ASSEMBLED PRODUCTS® CORPORATION
IMPORTANT DOCUMENT - DELIVER TO MANAGER
Quality, Performance, Value
OWNER’S MANUAL
and TECHNICAL DOCUMENTATION
Model 280-3506
¨ Standard Basket
280-1930
(shown with basket bumper option 280-1928)
ADDITIONAL OPTIONS YOUR CART IS EQUIPPED WITH:
¨
¨
¨
Basket Bumpers (280-1928)
Keyswitch & 2 Keys (280-1652)
Second 35 AHR Battery (280-1664)
¨ Jumbo Basket
¨ Small Basket
280-1374
(shown with basket bumper option 280-1928)
Mart Cart® is a quality product line of Assembled Products® Corporation
115 E. Linden • Rogers, Arkansas 72756 USA • (479) 636-5776 • (479) 636-3245 fax
E
CONTROL BOX
Be Responsible! Recycle old battery or dispose of according to local or national codes.
See below, under DISPOSAL.
The master control box is located on top of the steering column. It contains
the RUN/STOP/HORN switch, and optional key switch. The cover can be
removed by removing the four bottom screws.
To Replace Battery: (Read precautions on batteries, under Charging
Instructions and Safety Precautions, to avoid any sparks)
1.
Turn off key switch (if equipped, or flip On/Off switch to “Off”
position). Disconnect charger cord from wall outlet, if plugged in.
PARTS LISTS AND SCHEMATICS
2. Reach under right rear of back cover and pull latch, then tilt chair
forward.
3. Remove rear cover.
4. Untie battery cover strap and remove battery cover.
CAUTION: Do not cross battery posts with metal object!
5. Remove old battery and place new battery.
6. Reinstall battery cover. It will only fit one way.
7. Secure battery cover strap.
8. Before reinstalling cover, check wheel condition, and general
condition of the chair.
9. Reinstall rear cover and tilt chair back.
10. Test cart for proper operation. Charge battery if necessary.
DISPOSAL
Please read before disposing your old battery.
Spent batteries must be treated as hazardous waste and disposed of in
accordance with local, state and federal guidelines. The BATTERY ACT
of 1996 applies to battery disposal and recycling. The life expectancy of
the Mart Cart is 7-10 years. The life expectancy of the battery can be 2
years or longer with recommended charging procedures. The disposal
of the Mart Cart can be administered by any local metal recycling
center. The recycling of the battery can be administered by any local
battery recycling center.
ADDITIONAL INFORMATION
OPTIONS FOR 280-3506 CART
SEAT SWITCH
BASKET BUMPERS 280-1928
The seat switch is located under seat. Pressure (weight) on the seat
Protective basket bumpers are located on the front two corners of the
closes the control circuit, and allows the cart to operate.
basket.
VARIABLE SPEED CONTROL
KEY SWITCH & 2 KEYS 280-1652
The cart’s speed is regulated by a potentiometer. This provides extremely
smooth acceleration from 0 to 2.2 MPH, and is located in the control box
on the steering column.
Key switch comes standard with two keys. Provides store with security of
Mart Cart.
SECOND 35 AMP HOUR BATTERY 280-1664
Twice the run time with second battery in parallel. Five (5) Year Warranty (on
batteries only).
CIRCUIT BREAKER
The circuit breaker is designed to protect your electrical system from
transient overloads or electrical shorts. Either could cause serious
damage without a circuit breaker to open the circuit. The circuit breaker
is a manual reset type. It requires manual resetting once it has been
tripped. It is located on the battery cover.
DUAL HAND BASKET TRAY 280-1386
Two mounted trays that securely hold the store’s provided hand baskets.
SMALL BASKET 280-1385
CHARGING
18”basket with 2,800 cubic inches of cargo space.
HOW IT WORKS: When the power supply cord is plugged into the
store’s electrical outlet the battery charger is energized. The charger
sends approximately 14.5 volts to the battery for charging. A third wire
(yellow) from the charger output inhibits the PWM until the power to the
charger is disconnected. The motor circuit is interrupted until charging is
complete. NOTE: The cart will not move under power when the battery
is being charged. If the cart moves while plugged in, check the power to
your outlet before calling for service.
Basket dimensions: 18”x 10.50”x 15”
JUMBO BASKET 280-1374
24”basket with 11,000 cubic inches of cargo space.
Basket dimensions: 24”x 26”x 15”
3
martcart.com • 1-800-548-3373
—
DECALS FOUND ON 3506 MART CART® ELECTRIC SHOPPING CART
—
Please call 1-800-548-3373 if your decals are missing or are needing replacement.
280-3007
280-1509
280-1307
200-1155 (front & back)
000-1183
280-1531
280-1624
4
martcart.com • 1-800-548-3373
Drawing shows the standard 3506 only.
See front cover for additional options
your cart may contain.
9
Serial #
Location
17
34
31
11
6
28
30
36
22
19
19a
15
20
8
7
35
12
18
33
24
29
16
27
32
2
4
25
1
10
3
14
21
13
26
23
Item Part No. Description
Item Part No. Description
1
2
280-1800 Main Frame
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
280-0031 Steering Wire Harness w/Connectors
280-1281 Floor Cover
000-1224 5/8”Bushing (2 on each wheel)
280-1268 8”Wheel, Poly-U
000-1075 5/8” “E”Type Retaining Ring
280-1261 Seat Mount Tube
280-1799 Fuse, 5 AMP Mini
260-1228 Circuit Breaker, 15 AMP
280-1888 Low-back Seat
3
280-1280 Rear Cover (select color option)
280-1279 Front Cover (select color option)
280-1935 Motor Controller
4
6
7
280-1269 Fork Assembly
8
280-1441 Bridge Cover
9
280-1346 Tire/Outer Shell
10
11
12
13
14
15
16
17
18
19
19a
280-1264 Basket Tube
280-1797 Charging Cord, coiled
see pg. 3 Control Box
200-1802 Basket
200-1236 Basket Mounting Clip (4)
280-1335 Grommet 5/8”
280-2012 Hub Motor/Wheel/Tire - Green
see pg. 3 Steering Column
280-1214 Battery, 12V, 35 Ahr
200-1279 Seat Switch
280-1274 Cord Cover Lid (see note)
280-1889 Tube, Rear Corner Support
280-1711 Spring Latch for Seat
280-1938 12 VDC Charger -10 AMP
280-1712 Main Wire Harness/Battery Cover Assy.
NOTE: #29 (wire guide) and #33 (wire harness) can be ordered as an
assembly part 280-1656
#31 (cord cover) & #34 (cord cover lid) can be ordered as an
assembly part 280-0004
280-1389 12V, Complete Assembly, Main Harness
and Hardware for 2nd Battery
5
martcart.com • 1-800-548-3373
Electrical Schematic - Model 280-3506
(Basic model)
6
martcart.com • 1-800-548-3373
7
martcart.com • 1-800-548-3373
115 E. Linden • Rogers, Arkansas 72756 USA
(479) 636-5776 • Fax: (479) 636-3245
International (001) 479-636-5776
800-548-3373
MC1-MODEL 3506-OM-180215-EN
Specifications are subject to change without notice.
Printed in the USA.
|