PARTS AND OPERATION MANUAL
MULTIQUIP
Model GA-6RZ2
A.C. GENERATOR
Revision #3 (03/09/05)
MULTIQUIPINC.
18910 WILMINGTON AVE.
PARTS DEPARTMENT:
800-427-1244
CARSON, CALIFORNIA 90746 FAX: 800-672-7877
310-537-3700
800-421-1244
SERVICE DEPARTMENT/TECHNICAL ASSISTANCE:
800-478-1244
FAX:310-537-3927
FAX:310-631-5032
E-mail:mq@multiquip.com • www:multiquip.com
Atlanta • Boise • Dallas • Houston • Newark
Montreal, Canada • Manchester, UK
Rio De Janiero, Brazil • Guadalajara, Mexico
Download from Www.Somanuals.com. All Manuals Search And Download.
HERE'S HOW TO GET HELP
PLEASE HAVE THE MODEL AND SERIAL NUMBER
ON-HAND WHEN CALLING
PARTS DEPARTMENT
800-427-1244 or 310-537-3700
FAX: 800-672-7877 or 310-637-3284
SERVICE DEPARTMENT/TECHNICAL ASSISTANCE
800-478-1244 or 310-537-3700
FAX: 310- 537-4259
WARRANTY DEPARTMENT
888-661-4279, or 310-661-4279
FAX: 310- 537-1173
MAIN
800-421-1244 or 310-537-3700
FAX: 310-537-3927
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 3
Download from Www.Somanuals.com. All Manuals Search And Download.
TABLE OF CONTENTS
Here's How To Get Help ............................................ 3
Table Of Contents ..................................................... 4
Parts Ordering Procedures ....................................... 5
Rules For Safe Operation ......................................... 6
Operation and Safety Decals .................................... 6
Specifications ............................................................ 8
General Information .................................................. 9
ROBIN EH-34DS Engine
Crankcase Assembly .........................................34-35
Crankshaft & Piston Assembly ...........................36-37
Intake Exhaust Assembly...................................38-39
Governor Assembly ...........................................40-41
Cooling & Starting Assembly .............................42-43
Carburetor Assembly .........................................44-45
Coil Assembly And Spark Plug...........................46-47
Starter Assembly And Magnetic Switch .............48-49
Oil Level Sensor & Solenoid Assembly ..............50-51
Multiquip GA-6RZ2— AC
Generator
Terms and Conditions Of Sale — Parts .................. 52
Controls and Indicators ........................................... 10
Installation ............................................................... 11
Pre-Setup ........................................................... 12-13
Instrumentation ....................................................... 14
Load Application ..................................................... 15
Operating Instructions............................................. 16
Maintenance ........................................................... 17
Preparation For Long Term Storage ....................... 18
Wiring Diagram ....................................................... 19
Troubleshooting (Engine)................................... 20-21
Troubleshooting (Generator) ............................. 22-23
Explanation Of Codes In Remarks Column ............ 24
Suggested Spare Parts ........................................... 25
Generator Assembly .......................................... 26-27
Control Box Assembly ........................................ 28-29
Pipe Frame Assembly ........................................ 30-31
Name Plate And Decals ..................................... 32-33
NOTE
Specification and part number
are subject to change without
notice.
PAGE 4 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS ORDERING PROCEDURES
■ Dealer account number
■ Dealer name and address
■ Shipping address (if different than billing address)
■ Return fax number
■ Applicable model number
■ Quantity, part number and description of each part
■ Specify preferred method of shipment:
UPS Ground
•
UPS Second Day or Third Day*
•
UPS Next Day*
•
Federal Express Priority One (please provide us with your Federal
Express account number)*
•
Airborne Express*
•
Truck or parcel post
•
*Normally shipped the same day the order is received, if prior to 2PM west coast time.
Earn Extra Discounts when
you order by FAX!
All parts orders which include complete part numbers
and are received by fax qualify for the following extra
discounts:
Number of
line items ordered
Additional Discount
1-9 items
3%
10+ items**
5%
Get special freight allowances
when you order 10 or more
line items via FAX!**
Now! Direct TOLL-FREE access
to our Parts Department!
■
UPS Ground Service at no charge for freight
■
PS Third Day Service at one-half of actual freight cost
Toll-free nationwide:
800-421-1244
No other allowances on freight shipped by any other carrier.
**Common nuts, bolts and washers (all items under $1.00 list price)
do not count towards the 10+ line items.
Toll-free FAX:
800/6-PARTS-7 • 800-672-7877
*DISCOUNTS ARE SUBJECT TO CHANGE*
Fax order discount and UPS special programs revised June 1, 1995
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 5
Download from Www.Somanuals.com. All Manuals Search And Download.
RULES FOR SAFE OPERATION
■
Provide adequate ventilation when operating the generator.
DO NOT operate the generator in any enclosed or narrow
space. The generator's gasoline engine gives off DEADLY
carbon monoxide gas.
CAUTION:
Failure to follow instructions in this manual
may lead to serious injury or even death!This
equipment is to be operated by trained and
qualified personnel only! This equipment is
for industrial use only.
■
■
■
■
NEVER operate the generator in an explosive atmosphere or
near combustible materials. An explosion or fire could result
causing severe bodily harm or even death.
The following safety guidelines should always be used when
operating the GA-6HZRGenerator:
Always make sure that the generator is secure on level ground
so that it cannot slide or shift around, endangering workers.
Also keep the immediate area free of bystanders.
GENERAL SAFETY
■
■
■
DO NOT operate or service this equipment before reading
When using a concrete vibrator or a similar device that is
immersed in a water based solution, make sure the device is
equipped with short circuit protection.
this entire manual.
This equipment should not be operated by persons under 18
years of age.
Always use rubber boots and gloves when operating a
concrete vibrator or similar device.
NEVER operate this equipment without proper protective
clothing, shatterproof glasses, steel-toed boots and other
protective devices required by the job.
■
■
Use adequate size connecting cable for extension.
■
This generator is a source of potentially LETHAL high voltage.
Never permit unqualified personnel-especially children to
operate the generator.
Maintain electrical cords in good condition and frequently
replace the entire cable of the concrete vibrator with a new
one.
■
■
Always refuel in a well-ventilated area, away from sparks and
open flames.
■
HighTemperatures – Allow the machine and engine to cool
before adding fuel or performing service and maintenance
functions. Contact with hot components can cause serious
burns.
Always use extreme caution when working with flammable
liquids. When refueling, stop the engine and allow it to cool.
DO NOT smoke around or near the machine. Fire or explosion
could result from fuel vapors, or if fuel is spilled on a hot
engine.
Emergencies
■
Always know the location of the nearest fire extinguisher
and first aid kit. Know the location of the nearest telephone.
Also know the phone numbers of the nearest ambulance,
doctor and fire department. This information will be
invaluable in the case of an emergency.
■
■
This generator is equipped with a ground terminal for your
protection. Always complete the grounding path from the
generator to an external grounding source.
NEVER operate this generator, or handle any electrical
equipment while standing in water, while bare foot, while
hands are wet, or in the rain. Electrical shock could occur
causing severe bodily harm or even death.
Maintenance Safety
■
NEVER lubricate components or attempt service on a running
machine.
■
Always allow the machine a proper amount of time to cool
before servicing.
■
■
Keep electrical cords in good condition. Worn, bare or frayed
wiring can cause electrical shock, leading to bodily harm or
even death.
■
■
Keep the machinery in proper running condition.
Fix damage to the machine immediately and always replace
broken parts.
This generator requires an adequate free flow of cooling air.
Never operate the generator in any enclosed or narrow area
where free flow of the air is restricted. If the air flow is restricted
it will cause serious damage to the generator and may cause
injury to people.
■
■
■
Dispose of hazardous waste properly.Examples of potentially
hazardous waste are used motor oil, fuel and fuel filters.
DO NOT use food or plastic containers to dispose of
hazardous waste.
■
NEVER touch the hot exhaust manifold, muffler or cylinder.
Allow these parts to cool before servicing generator.
DO NOT pour waste, oil or fuel directly onto the ground,
down a drain or into any water source
PAGE 6 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION AND SAFETY DECALS
Machine Safety Decals
The GA-6RZ2 portable generator is equipped with a number of safety decals.These decals are provided for operator safety and
maintenance information.The illustration below shows these decals as they appear on the machine. Should any of these decals
become unreadable, replacements can be obtained from your dealer.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 7
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— SPECIFICATIONS
Table 1. Specifications
MODEL
GA-6RZ2
Type
2-pole, Brushless Type Revolving Field
Max. Output
Rated Output (continuous)
Rated Voltage
Rated Current
Phase
5500 Watts
5000 Watts
120/240 V
21 Amps
60 Cycle Generator
Single Phase (4-wire)
60 Hz
Frequency
Rated Speed
Power Factor
Model
3600 RPM
100%
ROBIN EH-34DS
Air-cooled 4 stroke OVH 90 V- Twin
horizontal shaft gasoline engine
Type
Bore X Stroke
Displacement
Max Output
1-3.31 in. X 2.40 in.
20.62 cc
11 H.P./3600 R.P.M.
Approx. 5 U.S. Gallons
Unleaded Automobile Gasoline
2-17/32 pints
Engine
Fuel Tank Capacity
Fuel
Lube Oil Capacity
Speed Control Method
Starting Method
Centrifugal Fly-weight Type
Recoil/Electric Start
630 X 625 X 480 mm
203 lbs (92 Kg.)
Dimension (LXWXH)
Dry Net Weight
Effects of Altitude and Heat
The maximum output of the engine listed above is applicable to supplying electrical power for continuous service at ambient
conditions in accordance with SAE Test cord J607. The above ambient conditions are at standard sea level, with a barometric
reading of 29.92 inches and a temperature of 60 degrees fahrenheit.
Generally, the engine output power will decrease 3 1/2% for each 1000 feet of altitude above sea level, and 1% for each 10° F
fahrenheit above the standard temperature of 60° F
PAGE 8 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— GENERAL INFORMATION
Excitation System
WARNING:
All GA-series generators use a magnet attached to a flywheel
to produce AC voltage from a lamp coil beneath the flywheel.
As the magnet passes the coil it produces approximately
19-22 AC volts.
Before connecting this generator to
any building’s electrical system, a
licensed electrician must install an
isolation (transfer) switch.
This voltage (19-22 VAC) is then sent to the control box that
contains three rectifying diodes:
Serious injury or death may result
without this transfer switch.
z
z
z
Excitation (diode 1)
Battery (diode 2)
Slow Down (diode 3)
GA-6RZ2 FAMILIARIZATION
Generator
The AC voltage will pass through the excitation diode that
converts the voltage to DC power.
The Multiquip Model GA-6RZ2 generator has been designed
as a portable lightweight power source for 60 Hz (single-
phase) vibrators, lighting facilities, power tools, submersible
pumps and other industrial and construction machinery.
This DC power is then sent to the excitation windings housed
within the main windings commonly called the "stator".
This generator is powered by a ROBIN gasoline engine. The
alternator, a brushless revolving-field type, is permanently
aligned to the engine through rigid coupling.
This voltage is then transferred into the rotor through
induction.The rotor contains two diodes within it which rectify
the DC voltage and send it out through the main windings,
as AC voltage.
The generator is mounted on rubber vibration isolators that
have a steel base backplate which is attached to the
protective steel pipe carrying frame.The protective carrying
frame is made of steel tubing and fully wraps around the
generator to protect against damage.
Engine
The four-cycle air-cooled ROBIN gasoline engine is designed
to meet every performance requirement of this generator.
Reference Table 1, page 8 for engine specifications.
This portable generator is supplied with a electrical control
box. To reduce vibration caused by the engine, the control
box is also placed on rubber isolators.
Figure 1 (page 10) shows the basic controls and indicators
for the GA-6RZ2 generator.
Control Box
The control box has the following: (all outputs are 60 Hz,
single phase)
NOTE
z
z
z
z
z
z
z
z
One 120V output receptacle.
One 240V output receptacle.
One 120V output receptacle (GFI protected).
One main 21 amp circuit breaker.
AC Voltmeter
In keeping with Multiquip's policy of
constantly improving its products, the
specifications quoted herein are subject
to change without prior notice.
Idle Control Switch
Full Power Switch
Operation Switch
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 9
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2 — CONTROLS AND INDICATORS
Figure 1. Controls and Indicators
PAGE 10 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— INSTALLATION
Outdoor Installation
Install the generator in a location where it will not be exposed to Exhaust gases from gasoline engines are extremely
Indoor Installation
rain or sunshine. Make sure that the generator is on secure level
ground so that it cannot slide or shift around. Also install the
generator in a manner so that the exhaust will not be discharged
in the direction of nearby homes.
poisonous. Whenever an engine is installed indoors the
exhaust fumes must be vented to the outside. The engine
should be installed at least two feet from any outside wall.
Using an exhaust pipe which is too long or too small can
cause excessive back pressure which will cause the engine
to heat excessively and possibly burn the valves.
The installation site must be relatively free from moisture and
dust. All electrical equipment should be protected from excessive
moisture.Failure to do will result in deterioration of the insulation
and will result in short circuits and grounding.
Eliminate the danger of deadly carbon monoxide gas.
Remember that exhaust fumes from any gasoline engine
are very poisonous if discharged in a closed room, but
harmless if allowed to mix with the outside air.If the generator
is installed indoors, you must make provisions for venting
the engine exhaust to the outside of the building.
Foreign materials such as dust, sand, lint and abrasive materials
have a tendency to cause excessive wear, not only to the engine
parts, but also to the alternator parts.
CAUTION :
CAUTION :
An electric shock is apt to happen when
vibrators are used. Pay close attention to
handling when operating vibrators and
always use rubber boots and gloves to
insulate the body from a short circuit.
Pay close attention to ventilation when
operating the generator inside confined
areas. The engine exhaust contains
noxious elements.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 11
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— PRE-SETUP
General Inspection Prior to Operation
Circuit Breaker
This generator has been thoroughly inspected and accepted To protect the generator from an overload, a 2-pole 21 amp
prior to shipment from the factory.However, be sure to check circuit breaker is provided on the control box. Make sure to
for damaged parts or components, or loose nuts and bolts, switch this circuit breaker to the "OFF" position prior to
which could have occurred in transit.
starting the engine.
Ground
Extension Cable
When electric power is to be provided to various tools or loads at
some distance from the generator, extension cords are normally
used. Cables should be sized to allow for distance in length and
amperage so that the voltage drop between the generator and
point of use (load) is held to a minimum. Use the cable selection
chart (Table 2 ) as a guide for selecting proper cable size.
The nut and ground terminal on the generator should always
be used to connect the generator to a suitable ground. The
ground path should be of #8 size wire.
Connect the terminal of the ground wire between the lock
washer and the nut and tighten the nut fully. Connect their
end of the wire to a suitable ground.
Table 2. Cable Selection (60 Hz, single phase operation)
Load In Watts
At 120 At 240
Maximum Allowable Cable Length
Current
in
Amperes
#10 Wire
#12 Wire
#14 Wire
#16 Wire
Volts
Volts
2.5
5
300
600
1000 ft.
500 ft.
350 ft.
250 ft.
150 ft.
125 ft.
600 ft.
300 ft.
200 ft.
150 ft.
100 ft.
75 ft.
375 ft.
200 ft.
125 ft.
100 ft.
65 ft.
250 ft.
125 ft.
100 ft.
600
1200
1800
2400
3600
4800
7.5
10
15
20
900
1200
1800
2400
50 ft.
CAUTION: Equipment damage can result from low voltage.
PAGE 12 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— PRE-SETUP
Fuel
Lubrication Oil
Close the fuel cock before filling the tank. Fill the fuel tank
with clean and fresh unleaded gasoline. Do not fill the tank
beyond capacity.
Fill the engine crankcase with lubricating oil through the filler
hole, but do not overfill. Make sure the generator is level.
With the dipstick inserted all the way, but without being screw
into the filler hole, verify that the oil level is maintained
between the two notches on the dipstick.
Pay attention to the fuel tank capacity when replenishing
fuel. Refer to the fuel tank capacity listed on page 8
Specification Table1.
The oil listed in Table 3 is recommended to ensure better
engine performance. Use class SC or higher grade motor
oil.
The fuel tank cap must be closed tightly after filling.
Handle fuel in a safety container. If the container does not have
a spout, use a funnel.
NOTE
This ROBIN engine is equipped with a low oil
shutdown capability. A built in sensor will
automatically turn off the engine should the oil level
fall below a safe operating condition. Make sure
the generator is placed on level ground. Placing
the generator on level ground will ensure that the
low oil sensor will function properly.
CAUTION :
Never fill the fuel tank while the engine is
running or in the dark. Gasoline spillage
on a hot engine can cause a fire or
explosion. If gasoline spillage occurs, wipe
up the spilled gasoline completely to
prevent fire hazards.
Table 3. Recommended Motor Oil
Temperature
Range
Type Oil
SAE 30
104° F ~ 23° F
(40° C ~ -5°C)
23° F ~ 5° F
(-5° C ~ -15°C)
SAE 20 or SAE 10W-30
SAE 10W or SAE 10W-30
Below 5° C (-15°)
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 13
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— INSTRUMENTATION
Start Switch
CAUTION :
Push this switch to start the engine (electric start only). If a
recoil starter is used, pull the starter rope to start the engine.
Make sure the operation switch is in the ON position (up),
otherwise engine will not start.
When using a combination of dual
receptacles, total load should not exceed
the rated capacity of the generating.
Full Power Switch
Power Outlets
The unit is provided with a full power switch. Figures 2 and
3 show simplified wiring diagrams of the dual voltage system.
The generator has the following 120/240 volt 60 Hz (single-
phase) receptacles.
When the full power switch is in the 120 volt (up) position,
you can take up full rated power of the generator at 120
volts from the single duplex receptacle, single locking type
120 volt receptacle, or a combination of these receptacles
as long as the total load does not exceed the generating set
capacity.
z
Single Phase
One Duplex NEMA (GFCI) 5-20R (120V, 20 Amp)
One Twist Lock NEMA L5-30R (120V, 30 Amp)
One Twist Lock NEMA L6-20R (240V, 20 Amp)
Main Circuit Breaker (2-Pole 120/240V 60 Hz)
This 2-pole 21 amp breaker protects the generator from short
circuiting or overloading from the 120/240V 60 Hz single
phase load.
Idle Control Switch
This unit is provided with an automatic idle control for noise
suppression and reduced fuel consumption. The automatic
idle control automatically engages under a no-load condition.
With the automatic idle control switched “ON”, the engine
revolutions will automatically drop to about 2500 rpm (low-
speed operation) within 3 seconds after the load stops.When
the operation is resumed, the engine speed is automatically
increased to about 3600 rpm (high-speed operation) as soon
as the load is connected.
Figure 2. 120 V Simplified Diagram (Switch Up)
NOTE
When the full power switch is in the 120 volt
position, the locking type 240 volt receptacle
cannot be used.
When the full power switch is in the 240 volt (down) position,
you can take up to half of the rated power of the generating
set at 120 volts from the duplex receptacle and up to half of
the rated power of the set at 120 volts from the locking type
120 volt receptacle; or full rated power of the set at 240
volts from the locking type 240 volt receptacle.
Fuel Gauge
The fuel gauge is located on the fuel tank and allows easy
monitoring of the fuel level.
ACVoltmeter
This voltmeter indicates (with a mark) the rated 60 Hz, single
phase output voltage. In addition the voltmeter can also be
used as a diagnostic tool.
If the voltmeter indicator (needle) is below the rated voltage,
engine problems may exist (low/high RPM's). To prevent
damage to the generator or power tools turn the generator
OFF and consult your authorized Multiquip service dealer.
Operation Switch
Figure 3. 120/240V Simplified Diagram (Sw Dn.)
This switch must be in the ON position (up) for normal
operation.
PAGE 14 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— LOAD APPLICATION
Single Phase Load
CAUTION:
Motors and motor-driven equipment draw
much greater current for starting than
during operation.
Always be sure to check the nameplate on the generator
and equipment to insure the wattage, amperage and
frequency requirements are satisfactorily supplied by the
generator for operating the equipment.
Generally, the wattage listed on the nameplate of the
equipment is its rated output. Equipment may require 130—
150% more wattage than the rating on the nameplate, as
the wattage is influenced by the efficiency, power factor and
starting system of the equipment.
An inadequate size connecting cable which cannot carry
the required load can cause a voltage drop which can burn
out the appliance or tool and overheat the cable.
The idle control is operated at minimum load capacity of
100W. If the load capacity is less than 100W, throw the idle
control switch to the OFF position.
NOTE
If wattage is not given on the equipment's
name plate, approximate wattage may be
determined by multiplying nameplate
voltage by the nameplate amperage.
WATTS = VOLTAGE x AMPERAGE
To determine the running wattage for your load, multiply the
running wattage as indicated by steps 1, 2, and 3 below:
1. INCANDESCENT LOADS
Lights, heaters and similar appliances.
Total the running wattage and multiply by 1.
Example:
29 light bulbs @ 100W each = 2.9 KW
use a 3 KW generator.
2. SMALL MOTORS
Drills and other small power tools.
Total the running wattage and multiply by 2.
Example:
A 1 inch drill runs at 1 KW
use a 2 KW generator.
3. LARGE MOTORS
Submersible pumps, table saws etc.
Total the running wattage and multiply by 3.
Example:
A conveyor belt runs at 8 KW
use a 24 KW generator.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 15
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— OPERATING INSTRUCTIONS
Warm up
Before Starting
1. When the engine starts, open the choke slowly.
1. Be sure to disconnect the electrical load and switch the
main circuit breaker to the “OFF”position prior to starting
the engine.
2. Run the engine at low speed for 3 minutes without load
until the engine warms up.
2. Never start the engine with the main circuit breaker “ON”.
3. Turn the idle control switch to the "OFF" (down) position
and check the voltage by referring to the voltmeter on
the control box.
3. Check the lubricating oil level prior to starting the engine.
Make sure the generator is level. The oil level must be
maintained between two notches on the dipstick.
CAUTION:
4. When there is not enough lubricating oil, fill the crankcase
with high grade motor oil. Use a high quality detergent
oil classified SC, SD or SE. (See Table 3 on page 13)
DO NOT change the engine speed control
lever which has been set at the factory prior
to shipping.
CAUTION:
1. Check the generator for abnormal noise and smells.Then
connect the load to the receptacles of the generator.
z
NEVER start the engine when the oil level
is below the lower mark on the dipstick.
2. Switch the main circuit breaker to the “ON” position and
turn the idle control switch to the “ON” (down) position
for normal (load) engine operation.
z
Check the fuel level on the fuel gauge.
When fuel is low, fill the fuel tank with
clean fresh unleaded automotive gasoline.
Operation
z
If gasoline spillage occurs, completely
wipe up the spilled gasoline.
Check the voltage by referring to the voltmeter on the control
box. When the voltmeter indicates 120 volts, 120 volts from
the 120V receptacles and 240 volts from the 240V receptacle
can be obtained at the same time. Refer to Figure 1, Controls
and Indicators, item 10 on page 10.
Starting
1. Open the fuel cock located below the fuel tank.The fuel
starts to flow when the fuel cock lever is turned
downward.
2. Place the idle control switch in the “ON” (up) position.
Stopping the Engine
3. Close the choke. Adjust the opening of the choke valve
according to operating conditions. When the engine is
warm or the air temperature is high, close the choke
valve halfway or open it all the way.
CAUTION:
NEVER stop the engine suddenly while
running at high speeds.
4. Confirm that the main circuit breaker on the generator
control box is “OFF”.
5. Set the operation switch to the “ON” position and grasp
the starting rope and slowly pull it out. The resistance
becomes hardest at a certain position, corresponding
to the compression point. Rewind the rope a little from
that point and pull out sharply.
1. Remove the load from the generator. Place the circuit
breaker in the “OFF” position. Refer to Figure 1, item 11
on page 10. Run the engine (no-load) with the idle control
switch set to the ON position for three to five minutes,
then stop the engine.
6. If the engine fails to start, repeat the procedure.
2. Turn the START/STOP switch to the “STOP” position.
3. Close the fuel cock.
CAUTION:z
DO NOT pull the starter rope all the way
to the end.
z
DO NOT release the starter rope after
pulling. Allow it to rewind as soon as
possible.
PAGE 16 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— MAINTENANCE
Service Daily
General Inspection
If engine is operating in very dusty and dry grass conditions.
A clogged air cleaner will result in high fuel consumption,
loss of power and excessive carbon buildup in the
combustion chamber.
At least daily or prior to each use, the generating set should
be cleaned and inspected for deficiencies. Check for loose,
missing or damaged nuts, bolts or other fasteners. Also check
for fuel or oil leaks.
Cleaning the Fuel Strainer
Engine Side (Refer to the Engine Instruction Manual)
Clean the fuel strainer if it contains dust or water. Remove
dust or water in the strainer cap and wash it in gasoline.
Securely fasten the fuel strainer cap so that fuel will not
leak. Check the fuel strainer every 200 hours of operation or
once a month.
Check Oil Level
Check the crankcase oil level prior to each use, or when the
fuel tank is filled. Make sure the generating set is level.The
oil level must be between the two notches on the dipstick.
Changing Oil
Spark Plug
Change oil after the first 20 hours of operation. Drain and
refill the engine crankcase every 50 operating hours or once
a week thereafter.Drain crankcase oil into a suitable container
while engine is still warm.Replace the drain plug tightly.Add
oil through the filler hole.
Remove carbon build-up on the spark plug (Figure 4) with a
wire brush. Set the spark plug gap to 0.6—0.7mm (0.024-
0.028 inch).Tighten with a spark plug socket wrench. Clean
the spark plug every 50 operating hours or once a week.
Air Cleaner
Every 50 hours: Remove air cleaner element (std. or heavy
duty types), and wash in kerosene or liquid detergent and
hot water. Wrap foam element in a cloth and squeeze dry.
Wipe heavy duty paper element dry with toweling. Saturate
element with kerosene; squeeze excess from foam element.
Wipe excess from heavy duty paper element.
Figure 4. Spark Plug Gap
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 17
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— PREPARATION FOR LONG -TERM STORAGE
Generator Storage
For storage of the generating set for over 30 days, the
following is required:
z
z
Drain the fuel tank completely.
Run the engine until the gasoline in the carburetor is
completely consumed.
z
z
z
z
Completely drain the oil from the crankcase and refill
with fresh oil.
Remove the spark plug, pour 2 or 3 cc of SAE 30 oil
into the cylinder and crank slowly to distribute the oil.
Slowly rotate the engine a few times with the starter
Rope and install a new plug.
Pull out the starter rope slowly and stop at the
compression point.
z
z
Clean all external parts of the generating set with a cloth.
Cover the generating set and store in a clean, dry place.
PAGE 18 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2—WIRING DIAGRAM
GENERATOR
ENGINE
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 19
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2—TROUBLESHOOTING (ENGINE)
diagnosis based on the Engine Troubleshooting (Table 4)
information shown below and on the proceeding page. If the
problem cannot be remedied, please leave the unit just as it
is and consult our company's business office or service
plant.
Practically all breakdowns can be prevented by proper
handling and maintenance inspections, but in the event of a
breakdown, please take a remedial action following the
TABLE 4. ENGINE TROUBLESHOOTING
SYMPTOM
POSSIBLE PROBLEM
SOLUTION
Inspect carburetor to see if fuel
is reaching it?
Check fuel line
No Fuel?
Add Fuel
Water in fuel tank?
Fuel filter clogged?
Stuck carburetor?
Spark plug is red?
Flush or replace fuel tank.
Replace fuel filter
Check float mechanism.
Poor starting
Spark plug is fouled. Check tranistor ignition unit.
Insufficient compression, injected air leaking. Carburetor jets are
clogged (overflow).
Spark plug is blue-white?
No spark present at tip of spark
plug?
Tranistor ignition unit broken, high voltage cord cracked or broken.
Start/Stop switch broken. Replace spark plug if fouled.
No oil?
Add oil as required.
Oil pressure alarm lamp blinks
upon starting?
Check Automatic shutdown circuit "oil sensor".
Replace cylinder and piston and if necessary axel joint.
Tighten cylinder head connecting bolts.
Engine will not turn over?
Cylinder head connecting bolts
loose?
Cylinder head gasket damaged?
Malfunction of valve seat?
Spark plug is loose?
Replace cylinder head gasket.
Re-seat valves.
Insufficient power output "no
compression"
Replace spark plug.
Replace piston rings.
Worn piston rings?
Malfunction in air-cleaner system,
air filter clogged?
Clean or replace air filter.
Air leaking in from interface
between carburetor and cylinder
head?
Tighten bolts between carburetor and cylinder head. Replace
cylinder head gasket.
Insufficient power output
"compression"
Clean or replace fuel filter.
Clean or replace carburetor.
Check carburetor float.
Malfunction in fuel system?
PAGE 20 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2—TROUBLESHOOTING (ENGINE)
TABLE 4. ENGINE TROUBLESHOOTING (CONTINUED)
SYMPTOM
POSSIBLE PROBLEM
Malfunction in cooling fan?
Air in-take filter clogged?
SOLUTION
Check or replace cooling fan.
Insufficient power output
"compression" and overheats
Clean or replace air in-take filter.
Over accumulation of exhaust
products?
Clean and check valves.
Check muffler, replace if necessary.
Burns to much fuel
Wrong spark plug?
Replace spark plug with manufactures suggested type spark plug.
Lubricating oil is wrong viscosity? Replace lubricating oil with correct viscosity.
Exhaust color is continiously
"WHITE"
Worn rings?
Replace rings
Air cleanner clogged?
Clean or replace air cleaner.
Adjust choke valve to the correct position.
Choke valve has not been set to
the correct position?
Exhaust color is continiously
"BLACK"
Carburetor defective, seal on
carburetor broken?
Replace carburetor or seal.
Adjust carburetor.
Poor carburetor adjustment
"engine runs too rich?
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 21
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2—TROUBLESHOOTING (GENERATOR)
diagnosis based on the GeneratorTroubleshooting (Table 5)
information shown below and on the preceding page. If the
problem cannot be remedied, please leave the unit just as it
is and consult our company's business office or service
plant.
Practically all generator breakdowns can be prevented by
proper handling and maintenance inspections, but in the event
of a breakdown, please take a remedial action following the
TABLE 5. GENERATOR TROUBLESHOOTING
SYMPTOM
Low voltage
POSSIBLE PROBLEM
Engine speed too low?
SOLUTION
Raise engine speed to rated RPM.
AC voltmeter not working?
Replace AC voltmeter.
Control box internal wiring
malfunction?
Check control box wiring.
Defective ignition coil?
Check red and green ignition wires. Replace ignition wires if
necessary.
Low voltage. Engine speed
normal 3650 RPM (unloaded),
2500 RPM (idle)
Rotor winding malfunction?
Stator winding malfunction?
Leakage breaker malfunction?
Full power switch malfunction?
Engine speed too high?
Check or replace rotor.
Check or replace stator.
Check or replace CB1.
Check full power switch and full power switch circuit.
Lower engine speed to rated RPM.
Check control box wiring.
Voltage output too high.
Voltage output too high. Engine
speed normal 3650 RPM
(unloaded), 2500 RPM (idle)
Control box internal wiring
malfunction
Circuit breaker will not turn on
"NO LOAD"
Defective circuit breaker?
Replace circuit breaker.
Overload?
Reduce load or replace breaker.
Check load circuit for short.
Check solenoid.
Circuit breaker will turn on
"LOADED" but trips immediately.
Load circuit is shorted?
Stuck solenoid?
Does not accelerate from low to
high "NO LOAD"
Bad Idle control switch?
Idle control switch malfunction?
Check or replace idle control switch.
Check or replace idle control switch.
Does not accelerate from low to
high "LOAD ACTIVE"
Idle control device malfunction?
Check or replace idle control device.
Check control box wiring.
Control box interal wiring
defective?
PAGE 22 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2—TROUBLESHOOTING (GENERATOR)
TABLE 5. GENERATOR TROUBLESHOOTING (CONTINUED)
SYMPTOM
POSSIBLE PROBLEM
Defective rotor windings?
Defective solenoid?
SOLUTION
Check or replace rotor.
Check or replace solenoid.
Does not decelerate no
"VOLTAGE OUTPUT".
Defective idle control device?
Defective solenoid?
Check or replace idle control device.
Check or replace idle control device.
Does not decelerate but has
"VOLTAGE OUTPUT".
Control box wiring malfunction?
Check control box wiring, replace any defective components.
Defective solenoid?
Check or replace solenoid.
Idle control device malfunction?
Check or replace idle control device.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 23
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— EXPLANATION OF CODE IN REMARKS COLUMN
How to read the marks and remarks used in this parts
book.
Items Found In the “Remarks” Column
Serial Numbers-Where indicated, this indicates a serial
number range (inclusive) where a particular part is used.
Model Number-Where indicated, this shows that the
corresponding part is utilized only with this specific model
number or model number variant.
Items Found In the “Items Number”Column
All parts with same symbol in the number column, , #,
, belong to the same assembly or kit.
+, %, or
*
■
NOTE
If more than one of the same reference number is
listed, the last one listed indicates newest (or latest)
part available.
NOTE
The contents of this catalog are
subject to change without notice.
PAGE 24 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— SUGGESTED SPARE PARTS
GA-6RZ2 WITH ROBIN
EH-34DS ENGINE
1 to 5 Units
5 to 10 Units
Qty.
P/N........................ Description
Qty.
P/N........................ Description
1 ............ 0601804819 .......... CIRCUIT BREAKER
2 ............ 0601804819 .......... CIRCUIT BREAKER
2 ............ 0601812597 .......... RECEPTACLE, GFCI
2 ............ 0601811031 .......... RECEPTACLE, 125V, 30A
2 ............ 0601811032 .......... RECEPTACLE, 250V, 20A
6 ............ 0601823204 .......... RECTIFIER
1 ............ 0601812597 .......... RECEPTACLE, GFCI
1 ............ 0601811031 .......... RECEPTACLE, 125V, 30A
1 ............ 0601811032 .......... RECEPTACLE, 250V, 20A
3 ............ 0601823204 .......... RECTIFIER
2 ............ 0642009000 .......... STRAINER, FUEL
2 ............ 0810107103 .......... FILTER, FUEL
1 ............ 0810106004 .......... CAP, FUEL TANK
5 ............ 2462360107 .......... ELEMENT, AIR CLEANER
5 ............ 0650140100 .......... SPARK PLUG
4 ............ 0642009000 .......... STRAINER, FUEL
4 ............ 0810107103 .......... FILTER, FUEL
3 ............ 0810106004 .......... CAP, FUEL TANK
2 ............ 3015419004 .......... SUSPENSION RUBBER
4 ............ 7855419014 .......... SUSPENSION RUBBER
10 .......... 2462360107 .......... ELEMENT, AIR CLEANER
10 .......... 0650140100 .......... SPARK PLUG
1 ............ 0601823853 .......... SLOW DOWN UNIT
1 ............ 0601800258 .......... ACVOLMETER
2 ............ 0601830737 .......... FULL POWER SWITCH
2 ............ 0601830727 .......... IDLE CONTROL SWITCH
1 ............ 0602123555 .......... OIL ALARM LAMP
1 ............ KS31101301 ......... OIL LEVEL SENSOR ASSY.
1 ............ 2467820121 .......... IGNITION COIL
1 ............ 2476231500 .......... CARBURETOR ASSY.
1 ............ 06022100102 ........ STARTER SWITCH
NOTE
Part numbers on this Suggested
Spare Parts List may supercede/
replace the P/N shown in the text
pages of this book.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 25
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— GENERATOR ASSY.
GENERATOR ASS’Y
PAGE 26 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— GENERATOR ASSY.
GENERATOR ASS’Y
NO
1
PART NO
PART NAME
QTY.
REMARKS
7901000503
7901002403
0601823207
0601822638
0071706304
7871017004
0801086104
0040010000
7901341503
7901315202
7871315102
7875021513
7871331003
7871344204
0040008000
031108160
7871329514
0601851760
011008020
ROTOR ASSY. ........................... 1 ..........INCLUDES ITEMS W/
*
1-1
1-2
FIELD COIL .................................1..........REPLACES 7871080003
RECTIFIER ..................................2..........D3SB60,S
*
*
*
SURGE ABSORBER ...................2..........TNR15G431K
BEARING .....................................1..........6304 2RUNYCM
1-3
2
SET BOLT, ROTOR
SET WASHER, BEARING
SPRING WASHER
ARMATURE ASSY.
END BRACKET
1
1
1
1
1
3
4
5
6
7
END BRACKET ...........................1..........REPLACES 7871315022
8
GUIDE PANEL, AIR
COVER
SET BOLT, STATOR
SPRING WASHER
1
1
4
4
9
10
11
12
13
14
15
PLAIN WASHER ..........................4..........REPLACES 0041208000
GROMMET
CAP
1
1
HEX. HEAD BOLT........................4..........REPLACES 0017108020
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 27
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— CONTROL BOX ASSY.
CONTROL BOX ASSY.
PAGE 28 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— CONTROL BOX ASSY.
CONTROL BOX ASSY.
NO
1
PART NO
PART NAME
QTY.
REMARKS
7901810303
0601850102
0805088004
0805088304
011206020
0601823204
0027103020
0601823853
0027104010
0030004000
7911820413
55885
0601800258
0601804819
4341817004
0021004010
0601812597
0610811031
0601811032
0021004010
0030004000
0601830737
0601815109
0601830727
0601810635
0663000010
0660000040
0601802137
2463170101
CONTROL BOX
1
1
2
2
2
GROMMET
3
RUBBER CUSHION
COLLAR
4
5
HEX. HEAD BOLT....................... 2 ..........REPLACES 0017106020
RECTIFIER ..................................3..........S5VB60
6
7
MACHINE SCREW
3
8
SLOW DOWN UNIT ....................1..........ND-80
MACHINE SCREW
HEX. NUT.....................................2..........REPLACES 0038404000
9
2
10
11
12
13
14
15
16
17
18
19
CONTROL PANEL
1
HEX. HEAD BOLT........................4..........REPLACES 0017105010
AC VOLTMETER ........................1..........0~120V, 0~240V
CIRCUIT BREAKER ....................1..........KM-2 21A
BRACKET, CIRCUIT BREAKER 1
MACHINE SCREW ......................2..........REPLACES 0027504010
RECEPTACLE .............................1..........5-20RLF, GF-5352
RECEPTACLE .............................1..........L5-30R, 125V 30A
RECEPTACLE .............................1..........L6-20R, 250V 20A
MACHINE SCREW ......................6..........REPLACES 0027504010
HEX. NUT.....................................6..........REPLACES 0038404000
FULL POWER SWITCH .............1..........ET330D12
20
21
22
23
24
25
26
0
GROUNDING TERMINAL
IDLE CONTROL SWITCH ..........1..........ET115A12
1
OIL ALARM LAMP ...................... 1 ..........REPLACES 0602123555
STARTER SWITCH.................... 1 ..........REPLACES 0602100102
OPERATION SWITCH ............... 1 ..........REPLACES 0601830791
FUSE ...........................................1..........10A
CAMSHAFT CP
1
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 29
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— PIPE FRAME ASSY.
PIPE FRAME ASSY.
PAGE 30 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2— PIPE FRAME ASSY.
PIPE FRAME ASSY.
NO
1
PART NO
PART NAME
QTY.
REMARKS
7905412102
7905414104
0017106016
7905442103
3015419004
0023808000
1665419004
020108060
011208030
0023808000
0017108040
0023808000
7905456014
0017106016
7915455003
7915455103
0017106016
7905512102
0810107103
0810106004
0602125031
7855525514
7855525604
011208030
0642009000
0521070042
PIPE FRAME
1
1
4
1
1
2
BRACKET
3
HEX. HEAD BOLT
BASE
4
5
RUBBER SUSPENSION
6
HEX. NUT.....................................2..........REPLACES 0038408000
RUBBER SUSPENSION .............2..........REPLACES 7855419014
HEX. NUT.....................................4..........REPLACES 0207008000
HEX. HEAD BOLT........................2..........REPLACES 0017108030
HEX. NUT.....................................2..........REPLACES 0038408000
7
8
9
10
HEX. HEAD BOLT
2
HEX. NUT....................................2..........REPLACES 0038408000
11
12
13
14
15
16
17
18
19
20
21
22
23
STOPPER
1
2
1
1
1
1
1
1
1
4
4
HEX. HEAD BOLT
COVER
COVER
HEX. HEAD BOLT
FUEL TANK
FUEL FILTER
CAP
FUEL GAUGE
RUBBER CUSHION
COLLAR
HEX. HEAD BOLT........................4..........REPLACES 0017108030
FUEL STRAINER ........................1..........INCLUDES ITEMS W/#, REPLACES 0605510025
JOINT...........................................1..........REPLACES 0605512561
23-1# 0642000220
23-2# 0642000230
23-3# 0642001910
SCREEN
1
1
1
1
RUBBER PACKING
CUP
24
25
26
27
28
29
30
31
0162212024
080508100
7905458103
0805082204
0037806000
952404470
0040006000
D1343200604
BATTERY
BATTERY SHEET ........................1..........REPLACES 1702202104
BATTERY BAND
BATTERY BOLT
WING NUT
1
2
2
SPRING WASHER ......................2..........REPLACES 0041206000
PLAIN WASHER
CAP
2
1
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 31
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2 — NAME PLATE AND DECALS
NAME PLATE AND DECALS
PAGE 32 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
GA-6RZ2 — NAME PLATE AND DECALS
NAME PLATE AND DECALS
NO
PART NO
PART NAME
DECAL : GROUND
QTY. REMARKS
1
0800628504
1980680004
7900638104
7900501002
7900631402
920203290
0820610404
7900636004
8700611804
8700611904
1
1
1
1
1
1
1
1
1
1
S-1123
S-3704
S-4606
N-5667A
S-5179
NPA-329
*
2
DECAL : FUEL COCK
DECAL : OPERATING INSTRUCTIONS
DECAL : MQ GA-6RZ2
DECAL : MQ 6000
*
3
*
4
*
5
*
6
DECAL : CAUTION
DECAL : WARNING
*
7
*
8
DECAL : OPERATE AT 3600 RPM ONLY
DECAL : WARNING
S-4461
S-4984
S-4985
*
9
*
10
DECAL : DANGER
*
11
PLATE, SERIAL NO. .................................... 1 ..... CONTACT MQ SERVICE DEPT. W/MODEL & S/N
DCLGA6RZ2
KIT, DECAL .................................................. 1 ..... INCLUDES ITEMS W/
*
SEE DECAL ILLUSTRATIONS ON PAGE 7.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 33
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — CRANKCASE ASSY.
CRANKCASE ASSY.
ROBINGX240K1 ENGINE — CYLINDER HEAD
PAGE 34 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — CRANKCASE ASSY.
CRANKCASE ASSY.
NO
10
PART NO
PART NAME
QTY.
REMARKS
2471010221
2461420203
0440350090
040006207
0600150010
0310060020
0105080430
0401140030
0211140020
2461100141
0440350090
040006207
0600150010
2464500101
2054190103
2246360107
0213200010
CRANKCASE CP.........................1..........INCLUDES ITEMS W/
VALVE GUIDE ..............................2..........OVER SIZE
OIL SEAL .....................................1..........35X48X8
*
20+
30
*
40
BALL BEARING ...........................1..........BB6207C3 REPLACES 0600350010
BALL BEARING ...........................1..........BB6202C3
*
45
*
50
DOWEL PIN
STUD
2
2
2
2
*
60+
80
PLUG
90
GASKET
210
220#
230#
240#
250
260
270
280
MAIN BEARING COVER .............1..........INCLUDES ITEMS W/#
OIL SEAL .....................................1..........35X48X8
BALL BEARING ...........................1..........BB6207C3 REPLACES 0600350010
BALL BEARING ...........................1..........BB6202C3
GOVENOR GEAR CP
GOVERNOR SLEEVE
1
1
OIL GAUGE .................................1..........REPLACES 2246360103
GASKET
1
1
7
290% 2461510103
GASKET, BEARING COVER
BOLT AND WASHER ASSY.
300
610
0011308400
2471300301
CYLINDER HEAD CP..................1..........INCLUDES ITEMS W/+ REPLACES 2471300131
620% 2471500113
GASKET, HEAD
1
4
1
1
2
4
1
1
1
1
1
1
2
630
680
0110100040
2461550102
FLANGE BOLT
ROCKER COVER UN
GASKET, ROCKER COV
DOWEL PIN
690% 2461600203
700
710
720
810
820
830
840
850
860
960
0310060020
0110060020
0110100020
2461430101
2461440101
2461600603
2461600703
2461080103
0110060030
2479900207
FLANGE BOLT
FLANGE BOLT
BREATHER COVER CP
BREATHER PLATE CP
GASKET, BREATHER COVER
GASKET, BREATHERPLATE
RUBBER PIPE
FLANGE BOLT
GASKET SET ..............................1..........INCLUDES ITEMS W/% REPLACES 2479900107
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 35
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — CRANKSHAFT & PISTON ASSY.
CRANKSHAFT& PISTON ASSY.
PAGE 36 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — CRANKSHAFT & PISTON ASSY.
CRANKSHAFT & PISTON ASSY.
NO
10
40
PART NO
PART NAME
CRANKSHAFT CP
QTY.
1
REMARKS
2462070201
0230350160
0230350170
0230350180
0021818000
0032018000
0031018000
0053205401
2462410223
2462250100
2462300103
2462310113
2462330103
2472340113
2472340213
2472340313
2472350117
2472350217
2472350317
0565210020
SPACER.......................................1..........SELECTIVE ASSY T=0.6
SPACER.......................................1..........SELECTIVE ASSY T=0.8
SPACER.......................................1..........SELECTIVE ASSY T=1.0
50
NUT
1
1
1
1
1
60
SPRING WASHER
WASHER
65
70
WOODRUFF KEY
BALANCER SHAFT
220
310
320
330
350
360
CONNECTING ROD ASSY. ........1..........INCLUDES ITEMS W/
*
CONNECTING ROD BOLT
OIL SCRAPER
2
1
1
*
*
PISTON PIN
PISTON........................................1........... STD.
PISTON........................................1........... OVER SIZE 0.25MM
PISTON........................................1........... OVER SIZE 0.50MM
PISTON RING SET .....................1........... STD.
370
380
PISTON RING SET .....................1........... OVER SIZE 0.25MM
PISTON RING SET .....................1........... OVER SIZE 0.50MM
CLIP
2
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 37
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — INTAKE EXHAUST ASSY.
INTAKE EXHAUST ASSY.
PAGE 38 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — INTAKE EXHAUST ASSY.
INTAKE EXHAUST ASSY.
NO
10
PART NO
PART NAME
QTY.
REMARKS
2463170101
2463330103
2463360103
2463580103
2463371103
0200200010
2463341103
2463350103
0051904100
2463620101
0230220050
0230220060
0230220070
2463670103
2393500103
2463530111
2463610110
0149080021
0170080090
2463612003
2463010121
2463420121
2463520103
0180080010
0110060050
0011108160
2463400101
0105080360
2463300101
0105060230
2543260210
2343600308
2463260707
2463290103
2463600113
0011308300
2343590203
001606120
0023706000
0732000150
CAMSHAFT CP ......................... 1 ...........INCLUDES ITEMS W/#
50
TAPPET
2
2
2
2
2
60
VALVE SPRING
COLLET, VALVE
SPRING RETAINER
WASHER
70
71
75
80
INTAKE VALVE ........................... 1 ...........REPLACES 2463340103
90
EXHAUST VALVE
SPRING PIN
RELEASE LEVER CP
1
1
1
100#
110
120
SPACER..................................... 1 ...........SELECTIVE ASSY T=0.6
SPACER..................................... 1 ...........SELECTIVE ASSY T=0.7
SPACER..................................... 1 ...........SELECTIVE ASSY T=0.8
130
200
210
220
230+
240+
250
310
320
340
350
360
365
400
RETURN SPRING
ROCKER SHAFT
PUSH ROD CP
1
1
2
ROCKER ARM ASSY................. 2 ...........INCLUDES ITEMS W/+
ADJUSTING SCREW
NUT
2
2
SPACER, ROCKER SHAFT ...... 1 ........... REPLACES 2463612013
MUFFLER CP
1
1
2
4
MUFFLER COVER CP
GASKET, MUFFLER
FLANGE NUT
FLANGE BOLT .......................... 3 ......... REPLACES 0110060010
BOLT AND WASHER ASSY.
EXHAUST PIPE CP ................... 1 ...........INCLUDES ITEMS W/
STUD
INTAKE PIPE CP ....................... 1 ...........INCLUDES ITEMS W/%
STUD
1
■
■
410
500
2
505%
510
1
AIR CLEANER ASSY. ................ 1 ...........INCLUDES ITEMS W/
*
510- 2
520
PACKING
1
1
1
1
3
2
*
ELEMENT SET
*
540
INSULATOR
550
555
560
580
590
900
GASKET, IN. PIPE
BOLT AND WASHER ASSY.
GASKET 2, INSULATOR
BOLT AND WASHER ASSY. ..... 1 ...........REPLACES 0011006120
FLANGE NUT............................ 2 ...........REPLACES 0023806000
LABEL, SHUTTER
1
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 39
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — GOVERNOR ASSY.
GOVERNOR ASSY.
PAGE 40 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — GOVERNOR ASSY.
GOVERNOR ASSY.
NO
10
PART NO
PART NAME
QTY.
1
REMARKS
2464230401
2464220113
2344270301
2464280113
0031300600
0011406250
0186060020
2464250123
0110060050
2464330111
0043105350
0022705000
0011008160
GOVERNOR LEVER CP
GOVERNOR SHAFT
GOVERNOR ROD CP
ROD SPRING
20
1
30
1
40
1
50
CLIP
2
60
BOLT AND WASHER ASSY.
NUT
1
70
1
80
GOVERNOR SPRING
1
270
320
360
370
385
FLANGE BOLT ............................1.......... REPLACES 0110060010
SPEED CONTROL CP
SCREW, PANHEAD
NUT
1
1
1
1
BOLT & WASHER ASSY.
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 41
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — COOLING & RECOIL STARTER ASSY.
COOLING & RECOIL STARTER ASSY.
PAGE 42 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — COOLING & RECOILSTARTER ASSY.
COOLING & RECOIL STARTER ASSY.
NO
PART NO
PART NAME
QTY.
REMARKS
10
2465120301
2479170303
0732003900
2479520103
0110060050
2465270112
0110060050
0016510160
2465020120
2465011508
2465012008
2355011008
2065010108
2465012508
2465013008
2275013508
2465014708
2465016008
2275015208
0110060502
0016508120
0732004350
BLOWER HOUSING CP
LABEL, TRADE MARK
LABEL, WARNING
LABEL, EMISSON CONT
1
1
1
1
20
27
31
40
FLANGE BELT .......................... 4 ...........REPLACES 0110060010
CYLINDER BAFFLE UN
FLANGE BOLT .......................... 2 ...........REPLACES 0110060010
BOLT
60
1
80
110
210
210-1
210-2
210-3
210-4
210-5
210-6
210-7
2
RECOIL STARTER ASSY. ......... 1 ...........INCLUDES ITEMS W/
*
SPIRAL SPRING
REEL
STARTER ROPE
1
1
1
*
*
*
*
*
*
*
STARTER KNOB ....................... 1 ...........REPLACES 2365010108
RATCHET
2
1
2
1
1
1
FRICTION SPRING
RETURN SPRING
STARTER PULLY
RATCHET GUIDE
SET SCREW
210-11
210-35
210-49
220
230
240
*
*
*
FLANGE BOLT .......................... 4 ...........REPLACES 0110060010
BOLT
LABEL, OHV MARK
3
1
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 43
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — CARBURETOR ASSY.
CARBURETOR ASSY.
PAGE 44 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — CARBURETOR ASSY.
CARBURETOR ASSY.
NO
PART NO
PART NAME
QTY.
REMARKS
50
0642009000
0851060000
0561110020
0521070042
2476231500
2136253508
2096235108
2346252508
2376245108
2476242008
2466243608
2096244508
2346252008
2396256008
2466253108
2246254408
2266255008
2246231208
2146251508
2246255208
2076234508
2066254008
2346250608
2466244108
2466242508
2466240208
2246256908
1066239208
2466243508
2096244508
1566235108
2476255008
2366268008
2466255108
FUEL STRAINER ASSY. ........... 1 ...........SEE PAGE 30 FOR COMPONENT BREAKDOWN
80
RUBBER PIPE
HOSE CLAMP
BANJO
1
2
1
90
95
210
210-1
CARBURETOR ASSY............... 1 ...........INCLUDES ITEMS W/
*
THROTTLE VALVE
SCREW
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
*
210- 2
210- 3
210- 4
210- 5
210- 6
210- 7
210- 8
210- 9
*
*
*
*
*
*
*
*
CHOKE VALVE
SCREW
PILOT JET
PILOT SCREW
SPRING
LEVER ASSY., CHOKE
RING
210-11
210-12
210-13
210-14
210-15
210-16
210-17
210-18
210-19
210-20
210-21
210-22
210-24
210-32
210-40
210-41
210-60
210-61
210-62
THROTLE SHAFT, A
BOLT
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
RING
NEEDLE VALVE ASSY.
PIN
FLOAT CHAMBER BODY
INSERT WASHER
CHAMBER PACKING
FLOT ASSY.
MAIN NOZZLE
GUIDE HOLDER
MAIN JET
CLIP
SEAL
ADJUST SCREW
SPRING
PACKING
CAP, CHOKE
SEAL
210-119
CAP
*
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 45
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — COIL ASSY. AND SPARK PLUG
COIL ASSY. AND SPARK PLUG
PAGE 46 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — COIL ASSY. AND SPARK PLUG
COIL ASSY. AND SPARK PLUG
NO
10
PART NO
PART NAME
FLYWHEEL CP
IGNITION COIL CP
CHARGE COIL CP
RING GEAR
QTY.
1
REMARKS
2467720401
2467820121
2467920301
2467100203
0011406300
0043506200
2467310301
2267550103
0650140100
0655000051
2467550201
11
1
12
1
20
1
30
BOLT AND WASHER ASSY.
SCREW AND WASHER ASSY.
WIRE 3 CP
2
35
4
50
1
80
GROMMET
1
100
110
230
SPARK PLUG ..............................1..........B-6ES
SPARK PLUG CAP
CLAMP CP
1
1
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 47
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — STARTER ASSY. & MAGNETIC SWITCH
STARTER ASSY. & MAGNETIC SWITCH
PAGE 48 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — STARTER ASSY. & MAGNETIC SWITCH
STARTER ASSY. & MAGNETIC SWITCH
NO
120
PART NO
PART NAME
QTY.
REMARKS
2467050100
2357056008
2357053508
2357054508
2357053008
2357055008
2467052108
2467057108
2467050008
2357054008
2467050508
2357057508
2357055508
2357056508
2357056608
1137051008
2147056008
2467058008
0022706000
0032006000
2147900701
0031008000
0032008000
2467600901
0110060010
2147310111
0661000010
0566000250
0732004480
2147850103
0032006000
0022706000
0032005000
0021705000
STARTING MOTOR ASSY. .........1..........INCLUDES ITEMS W/
*
120-1
120-2
120-3
120-4
120-6
120-7
120-8
120-9
YOKE ASSY.
BRUSH, +
1
1
2
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
2
2
2
1
2
1
1
2
1
2
2
2
2
2
*
*
*
*
*
*
*
*
SPRING, BRUSH
HOLDER ASSY, BRUSH
ARMATURE ASSY.
PINION ASSY.
STOPPER SET PINION
COVER ASSY. FRONT
BRUSH, -
120-10
120-11
120-17
120-23
120-40
120-41
120-42
120-43
120-52
121
COVER ASSY. REAR
THROUGH BOLT
WASHER KIT
M BUSH, 1
M BUSH, 2
CASE METAL
FRONT METAL
O RING
NUT
122
SPRING WASHER
BOLT CP, STARTER
WASHER
130
140
150
SPRING WASHER
BRACKET, MAG.S. CP
FLANGE BOLT
WIRE 1 CP
MAGNETIC SWITCH
CLAMP
LABEL, BATTERY
WIRE CASING
SPRING WASHER
NUT
SPRING WASHER
NUT
210
220
340
360
370
380
390
460
470
480
490
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 49
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — OIL LEVEL SENSOR & SOLENOID ASSY.
OIL LEVEL SENSOR & SOLENOID ASSY.
PAGE 50 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
ROBIN EH-34 ENGINE — OIL LEVEL SENSOR & SOLENOID ASSY.
OIL LEVEL SENSOR & SOLENOID ASSY.
NO
PART NO
PART NAME
CLAMP CP
QTY.
1
REMARKS
230
240
370
400
700
730
760
850
850-1
850-2
860
865
870
880
2467550201
0043106080
0566000250
0566000260
KS31101301
2467600501
2467311801
2277550100
SCREW, PANHEAD
CLAMP CP
1
1
CLAMP
3
OIL LEVEL SENSOR ASSY.
BRACKET, SOLENOID, 1 CP
WIRE 18 CP
1
1
1
SOLENOID ASSY. .......................1..........INCLUDES ITEMS W/
NUT, HEX.....................................1..........CANNOT BE PURCHASED SEPERATELY
WASHER, LOCK .........................1..........CANNOT BE PURCHASED SEPERATELY
BRACKET, SOLENOID, 2 CP
SPRING, SOLENOID
BOLT AND WASHER ASSY.
BOLT AND WASHER ASSY.
*
*
*
2467600701
2347820203
0011106100
0011310200
1
1
2
1
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 51
Download from Www.Somanuals.com. All Manuals Search And Download.
Effective: July 1, 2000
TERMS AND CONDITIONS OF SALE — PARTS
PAYMENT TERMS
4. Freight is at the sender’s expense. All PRICINGANDREBATES
partsmustbereturnedfreightprepaidto
Multiquip’sdesignatedreceivingpoint.
Terms of payment for parts are net 10 days.
Prices are subject to change without prior
notice.Pricechangesareeffectiveonaspecific
5. Parts must be in new and resalable dateandallordersreceivedonorafterthatdate
condition,intheoriginalMultiquippackage willbebilledattherevisedprice. Rebatesfor
(ifany),andwithMuiltiquippartnumbers price declines and added charges for price
FREIGHTPOLICY
All parts orders will be shipped collect or
prepaidwiththechargesaddedtotheinvoice.
All shipments are F.O.B. point of origin.
Multiquip’sresponsibilityceaseswhenasigned
manifesthasbeenobtainedfromthecarrier,
andanyclaimforshortageordamagemustbe
settledbetweentheconsigneeandthecarrier.
clearlymarked.
increaseswillnotbemadeforstockonhandat
thetimeofanypricechange.
6. Thefollowingitemsarenotreturnable:
Multiquip reserves the right to quote and sell
directtoGovernmentagencies,andtoOriginal
Equipment Manufacturer accounts who use
our products as integral parts of their own
products.
a. Obsolete parts. (If an item is listed
inthepartspricebookasbeing
replaced by another item, it is
obsolete.)
b. Any parts with a limited shelf life
(such as gaskets, seals, “O” rings,
andotherrubberparts)thatwere
purchasedmorethansixmonths
priortothereturndate.
MINIMUMORDER
SPECIALEXPEDITINGSERVICE
TheminimumchargeforordersfromMultiquip
is $15.00 net. Customers will be asked for
instructionsregardinghandlingofordersnot
meetingthisrequirement.
A$20.00to$50.00surchargewillbeaddedto
theinvoiceforspecialhandlingincludingbus
c. Anylineitemwithanextendeddealer shipments, insured parcel post or in cases
netpriceoflessthan$5.00.
where Multiquip must personally deliver the
partstothecarrier.
d. Special order items.
RETURNEDGOODSPOLICY
e. Electricalcomponents.
Returnshipmentswillbeacceptedandcredit
will be allowed, subject to the following
provisions:
LIMITATIONSOFSELLER’SLIABILITY
f.
Paint,chemicals,andlubricants.
Multiquip shall not be liable here under for
damagesinexcessofthepurchasepriceofthe
itemwithrespecttowhichdamagesareclaimed,
andinnoeventshallMultiquipbeliableforloss
of profit or good will or for any other special,
consequentialorincidentaldamages.
g. Decalsandpaperproducts.
h. Itemspurchasedinkits.
1. AReturnedMaterialAuthorizationmust
beapprovedbyMultiquippriortoshipment.
7. Thesenderwillbenotifiedofanymaterial
receivedthatisnotacceptable.
2. ToobtainaReturnMaterialAuthorization,
alistmustbeprovidedtoMultiquipParts
Sales that defines item numbers,
quantities,anddescriptionsoftheitemsto
bereturned.
8. Such material will be held for 5 working
days from notification, pending
instructions. If a reply is not received
within5days,thematerialwillbereturned
tothesenderathisexpense.
LIMITATIONOFWARRANTIES
a. Thepartsnumbersanddescriptions
mustmatchthecurrentpartsprice
list.
Nowarranties,expressorimplied,aremadein
connection with the sale of parts or trade
accessories nor as to any engine not
manufacturedbyMultiquip.Suchwarranties
made in connection with the sale of new,
complete units are made exclusively by a
statement of warranty packaged with such
units, and Multiquip neither assumes not
authorizes any person to assume for it any
other obligation or liability whatever in
connectionwiththesaleofitsproducts.Apart
fromsuchwrittenstatementofwarranty,there
arenowarranties,express,impliedorstatutory,
which extend beyond the description of the
productsonthefacehereof.
9. Creditonreturnedpartswillbeissuedat
dealer net price at time of the original
purchase,lessa15%restockingcharge.
b. The list must be typed or computer
generated.
10. In cases where an item is accepted for
which the original purchase document
can not be determined, the price will be
basedonthelistpricethatwaseffective
twelvemonthspriortotheRMAdate.
c. Thelistmuststatethereason(s)for
thereturn.
d. The list must reference the sales
order(s)orinvoice(s)underwhich
theitemswereoriginallypurchased.
11. Credit issued will be applied to future
purchasesonly.
e. Thelistmustincludethenameand
phonenumberoftheperson
requestingtheRMA.
3. A copy of the Return Material
Authorizationmustaccompanythereturn
shipment.
PAGE 52 — GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05)
Download from Www.Somanuals.com. All Manuals Search And Download.
NOTE PAGE
GA-6RZ2 A.C. GENERATOR — PARTS & OPERATION MANUAL — REV. #3 (03/09/05) — PAGE 53
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS AND OPERATION MANUAL
HERE'S HOW TO GET HELP
PLEASE HAVE THE MODEL AND SERIAL NUMBER
ON-HANDWHEN CALLING
PARTS DEPARTMENT
800/427-1244
FAX: 800/672-7877
SERVICE DEPARTMENT
800/478-1244
FAX: (310) 537-4259
WARRANTY DEPARTMENT
800/421-1244, EXT. 279
FAX: (310) 537-1173
MAIN
800/421-1244
FAX: (310) 537-3927
Manufactured for MULTIQUIP INC.
by
DENYO MANUFACTURING CO., JAPAN
MULTIQUIP INC.
POST OFFICE BOX 6254
CARSON, CA 90749
310-537-3700 • 800-421-1244
FAX:310-537-3927
WWW:multiquip.com
Atlanta • Boise • Dallas • Houston • Newark
Quebec, Canada • Manchester, UK • Rio De Janiero, BR • Guadalajara, MX
Download from Www.Somanuals.com. All Manuals Search And Download.
|
Miller Electric Welder Spoolmate 250 User Manual
Milwaukee Router 5626 68 User Manual
Multi Tech Systems Network Router GPRS MTMMC G User Manual
NETGEAR Network Router DG834GFS User Manual
Nikon Camcorder iMacTM User Manual
Olympus Camera Lens 261011 User Manual
Panasonic Camera Lens H NS043 User Manual
Panasonic Power Supply EZAEG2A User Manual
Paradyne Modem DSL Modem User Manual
Patriot Products TV Antenna MI 49224 User Manual