English and Deutsch
Model
PSP
-I
PSP-IG
CONTENTS:
1
2
3
4
5
Diagram
Safety Instructions (english)
Operation Maintenance (english)
Maintenance cont. (english)
Safety Instructions (deutsch)
Operation Maintenance (deutsch)
Maintenance cont. (deutsch)
Control Panel Handle Assembly
motor Frame Assembly
Tank Assemblies
7
8
9
10
11
12
13
Brush Drive Assembly
Shoe Assembly
Plumbing Assemblies
14 WiringDiagram
98130
Rev.
1
Download from Www.Somanuals.com. All Manuals Search And Download.
DIAGRAM
DIA RAMM
A
G
50540
I
C
Switch Panel
B
A
C
\
A
-
BRUSH
A
-
BURSTE
DAUERBETRIEB PUMPE
SAUG
UBERLASTKNOPFES
TASTBETRIEB PUMPE
B
-
CONTINUOUSPUMP
B-
C
-
VACUUM
C
-
E
D
-
CIRCUIT BREAKER
D-
E
-
INTERMITTENT PUMP
E-
D
SPRING PLUNGER SEAL VALVE BODY
I
\
Coil
Washer
Plunger
Solenoid Valve Assembly
(for Cleaning purposes only)
1
PASSPORT
Download from Www.Somanuals.com. All Manuals Search And Download.
ENGLISH
wire that is coloured
nected to the that ismarked
must be con-
18.
21.
extra cautionwhen cleaningon
Do notusemachine as step.
IMPORTANT SAFETY
INSTRUCTIONS
letter
or coloured
is colouredBrownmustbe con
that is markedwith the
a
The wire
nected the
-
and repairs
be clone
When usingan
appliance.
mustalways be
by qualified personnel.
coloured Red.
the
he
CHEMICALS
equipment when changing
when
all
before
motor must
off. Equipment plugged
must be unplugged.
use or replacementof
or fines connections.
machine.
be
This machineis
CAUTION:
designed for
are deemed
WARNING:
.
isnot
dust
Care must be exercised in
use of all chemi-
22.
23.
cals. Chemicals are poisonous and can pose
risk Read and follow the manufacturer's
regarding dangers and correct us
a
-
the
-
mustnot beused if
has been
a
certain
WARNING:TO REDUCE
THE RISK OF FIRE,
ELECTRICAL SHOCK
OR INJURY:
connectors to
WARNING
:
connections me equipment.
guardand
beensured.
he
stability
CAUTION:
usedinthe
carpet cleaning
If
a
machine is alteredby unauthorized
tor
suitablefor usewith
Do notoperate
2. Use only as
manufacturers
persons,
is not responsiblefor
they aresusceptible chemical
deaningsubstances, suchas
and chlorinatedbleaches.
are not of the
in
manual.
damages or injuriesthat may occur.
from
hydrocarbon
These
Use
SAVE THESE
INSTRUCTIONS
3. Useindoors
Do
useoutdoors.
used for carpet
Do not expose to rain.
SUITABLECHEMICALS
4. Machinescancause
a
fire when operated
materials. Do
near
Alkalis
notoperate his machine near
fluids. dust. orvapors.
Cbrox Bleach'
INSPECTION
.
Do not pick up
or combustible
Carefully unpack andinspectyour
for
and
Hydroxides
Oxygen Bleaches
materials such as
or
where
shipping damage. Each unit
may be present.
thoroughly inspected before shipping, and any
damage the responsibility the who
should be immediately.
6.
not
that
or
Fabric Softener'
Vinegar
White Monday Bleach'
suchascigarettes. matches, or
hotashes.
ELECTRICAL
7. Do not handle heplug of machine wih
'Registered Trademark
This
operates on a standard 230 Volt
AC circuit Voltages below 220 or
240 Volts cause serious damage to
Wring diagram is mounted inside control
panel machine.
wet hands.
NON
Aldehydes
CHEMICALS
8.
notleave the machine
Unplugmachine from
use and before
in
Hydrocarbons
9. Turn off all controls beforeunplugging
machine.
Carbon
WARNING:
notunplugmachineby pulingon card.
Bleaches
ChlorinatedHydrocarbons
Make
are using the correct
onnameplate before
chine power card to
as
ma
To
grasp the plug, not
-
not usewith damaged
plug.
Methyls
12. the machineisnot
properly.
POWER SUPPLY CORDS
damaged.
outdoors. or droppedintowater,
Phenols
it
IMPORTANT
The wires inthe mainsteads are
cordance the
Green and
inac
-
to an Authorized
center.
cord
cord.
code:
13.
not carry by hecord,
a
-
-Yellow:
handle. dose
a
cord
FILLING THE PASSPORT
around sharp edges
1.
hedear dome fromupper tank.
Live
cord.Keep
cordaway fromheatedsurfaces.
wiresin
may not correspond with
markings identifying the
proceedas
of
2
upper
set aside.
from machineand
in your plug,
15. Do not
to beusedas
Close
3. Use
a
clean
to solution rank with
concentrate
attentionis necessarywhen usedby or
Add
a
The
is
useinhotwater
atthe
must beconnected to me terminal in the dug
notedon h econtainer.
16. Do
operate
with any
mat ismarked
he
by
openingsblocked. Keepopenings free of
symbol. or
or
hat may reduce
CAUTION:
7.
NOTUSE
EXCEEOS
TEMPERATURETHAT
F)
of lhe
away from
and
C.
Rev.
1
2
Download from Www.Somanuals.com. All Manuals Search And Download.
and
machine. Frayedor cracked hoses should
be repaired to eliminate vacuum
solution pressureloss. Because
electricalcable lieon wet carpet
cable must bewell insulated and
on your
NOTE: powderedsoap isused.
with
ACCESSORY TOOLS
The PASSPORTis easily adaptedfor use
the following
hot water before
tank.
,
A. Reinstall
tank anddome. Make
hoses are snug
times.
cable
Never operate
screws kept
If
with water
C.
cable insulation broken or bayed.
OPERATING THE
PASSPORT
or replaceit immediately.
chances with an
take
or shock
Turn solutionvalve to 'ACCESSORY
TOOL position
-
PROTECT FROM
FREEZING
WARNING
the IMPORTANT
TIONS before operating,
attention to care and use of
cord. Only operate if
condition.
(DIAGRAM
INSTRUC
-
2. Remove recovery
dome and
accessory tool in itsplace.
(white
vacuum hose from
from
If it
necessarylo store
power
cord is in
below
must protected
a methyl hydrate (window washer)
4"
C
the
with
3.Attach
tobrass quick
side of machine.
hose
accessory
fitting on left
NOTE: Vacuum
of surface
carpetand make sure it
beforecleaning.
NOTE: Do not use
system antifreeze.
or
4. Remove dome andrecovery
to power
5. Fill
p e r
tank with
cord. Make bopin power
Add
washer
tank.
to
Prom
end.
(DIAGRAMA.
)
6.
tank
dome.
2. Turn on pump
solutionsprays
2. Adjust brush height by
front of machine. Pointeron
indicates carpetheight.
knob
side
on vacuum and
switches only.
3.
unused portionof
from tank
LOW
CAUTION: Do not
Damageto carpel
on brushswitch.
HIGH
-
1
MAINTENANCE
INSTRUCTIONS
NOTE:
moveheightmay cause
Raise brushand
brushcircuit breaker to
reset
breaker.
WARNING
3. Turn
ING'
valve to 'CARPET CLEAN
-
1. Only
maintenancepersonnel
!%??
(DIAGRAM
to perform
followingrepairs.
Before makingany adjustments or repairs to
hemachine, disconnect power cord from
4. Plug power cord into grounded wall
a
2. Unplug(he machine
repairs.
C:
h evacuumswitchand brush
3.
to
lor proper
1.
unusedcleaningsolution.
Turn
switch.
connections.
2. Inspectandcleansolution
screen.
to
NOTE:
water
tank may cause water
enter thevacuum This
the vacuum motor and
breakerwill trip.
loam the
foam to
over
3. flush pumpingsystem
of deanhotwater.
1
2
BRUSH ASSEMBLY
1. Remove
guard, brush
guard
-
and bearing
each end of brush
4. Rinse
lank
dean water.
brush and
vacuum
Loosen (2)hex
motor
from motor pulley.
on studs and
and remove
5.
any lintor debris
shoe.
6.
intermittentpump
dispensecleaningsolution.
backwards. Release pump
to
6. Check spray
and deansolenoid
3. Remove brush assembly from
Replacebrush or bearings
required.
.
.
if required.
about
12 inches before the end each cleaning
pass. will solution
from carpet.
NOTE: Always store machine
'store' position.
brush in
4. When
proper tension.
brush, check belt
should be taught (Do
belt.
rearward
not
To
CAUTION:
PERIODIC MAINTENANCE
hex nuts, rotate
retightennuts.
While operating machine, check
foam in the tank.
excessive
to
1. Twice
a
awhite vinegar
quart vinegar to
If
of
foam is present, add
covecy
a
hotwater) oran
ACCESS CHASSIS
(mixedas
through
extractor.
This will help prevent build
residuein system.
-upof alkaline
7.Empty recovery tank when approximately
COMPONENTS
full.
1. Lilt offrecovery tank and set
2.
I
f
spray
becomeclogged,
2.
solution-drainhose
spray tips, wash them
vinegar and blow dry.
CAUTION
:
DOnot use me
tank to the
Remove (A) bolts holding
to
tank. unless it CLEAN. Sedimentin
NOTE: Donot use pins,
jets asthis will
etc. lo
Raise tank and pull
chassis. Remove pump
torn rank and tay aside
hose
hose
tank
hespray
damage
rendering
pump and dog
spray
3. spray jets continueto drip
is
turned off. the solenoidvalve
cleaning.
MAINTENANCE Instructions
5/2/94
PASSPOR
T-I
Download from Www.Somanuals.com. All Manuals Search And Download.
DEUTSCH
des
des Grilles
einem
au
Wartungsdienst
13. Nicht am Kabel ziehen, Kabelnichtals
nichtin der
E
RH
INWEISE
WARNUNG:
einklemmen oder
Ecken
Vor
an das
werden.
Gebrauch
und Kanten ziehen.
die auf
angegebene
14.
15.
mit der Maschine
und Kabelvon
das Kabel
werden.
vorhanden
Die
Maschine darf nicht
werden. Besondere
die
geboten, wenn
von
WARNUNG:
Maschine in der
sind
Vorsicht geboten
Gebrauchvon
sind
ein
Nicht
Maschine arbeitenwenn
Vor Gebrauch
Maschine
erhdhte
Sie den
von
die
WARNUNG:
17.
lose
anderen
Finger und
von
und
Maschine nicht
die
BesondereVorsicht beider
Die
sind fur den
gegen die
und
Gebrauch der
geeignet
die
einiger
19. Maschine
20. Die
FEUER; STROMSCHLAG
ODER
ZU
und
Personal
von
werden
nicht
bei
21.
Reinigen
Maschine, beirn
oder der
Funktion, der
von Teilen
ziehen.
1. Keine
eingebauten
Filter.
Alkali
Clorox Bleach'
22.
oder Ersatz
darf nichtvon
2. Benutrungnur
und rnit dern vorn
Zu
vorn Hersteller abgegebenen
werden.
3. Nicht irn
ff
23.
von
4.
Fabric
wenn sie in der
von brennbaren
und die
werden. Also kein
von brennbaren
in
Nahe
White Monday
Bleach'
und
an der
5. Keine brennbarenoder
wie
Maschine
Herstellen
des
aufsaugen und
nicht in
arbeiten.
daraus resultierende
aus.
6.
oder
Aldehyde
Clorox'
oder
aufsaugen.
SIE
7. Maschineund
nichtrnit
H
INW
8.
und
Sleeker
wird. Maschine
I
NSPE
0N
ziehen.
9.
Stecker
untersuchen.
und
werdenvordern
werden
nicht
am
DES PASSPORT
11
rnit
1.
Haube vorn
entfernen
oder Stecker
die Maschine nichteinwandfrei,
hat sie
2. Den oberen
entfernen und
vom Gerat
bei 230 Volt
Spannung
uber 240 Volt kann
Molorschaden
220
Freien
in
oder
Wasser
rnit
V
3. Den
aus einem
an der
Rev. 5/2/94
5
PASSPORT-?
Download from Www.Somanuals.com. All Manuals Search And Download.
6. Vom
Fasern
evil.
entfernen.
sauberen Eimer
fullen. Ein fur den Gebrauch in
vorgesetienes,
Wasser
VORSICHT:
der
im
7. Abgelagerte Fasern und
und von dern
achten. Wenn
inden
Beachlungder
dern
geben.
7. Der
wenn
warden,
VORSICHT:
WARTUNG
DARF
WASSERTEMPERATUR
1.
das
Essig
mil einer
UBER 50'
C
sein.
VORSICHT:
Essigauf ca.
4
Liter Wasser)oder einer
dann
Fallen
wenn
ANMERKUNO: Bei der
Seifenpulver diesesvor dem
von
des
(enlsprechend der
er SAUBER
in
Wasser
Dadurchwird die
in dern
von Alkali
-
werden.
verhindert.
und die
wodurch das
wird.
2
einer
der
Den
wieder
in
und die Kappe
Ole
entfernen.
in Essig
waschen und
Kappe
ANMERKUNG: Keine Nadeln.
Der PASSPORT
mil den
SW. SWF, SW/
Dies
die
BETRIEB DES PASSPORT
3.
die
WARNUNG:
der
das
WARNUNG:
Sie
dle
werden.
Answeisungen).
.
mileiner
belreiben.
bevor
Sie besonders
50
"
C
bnlreiben. und
den
4.
Kabel. Filler
des
und
in
Den
einwandfreiem
Absllnden
stellen.
2. Den
seiner
3. Den
Zerschlissene oder
I
Oen
und die Kabel-
repariertoder
Vakuurn
das
Man
werden,
oder
von der Kappeentfernenund an
den
das Netzkabelca.
vom Ende eine
A)
verhuten
Kabel
einem
gut
des
in
sein unddie
lest sitzen. Wenn die
oder
2. Die
derseite
durch den an der Vor
befindlichen Knopf
ander
der links am
bindungsfassung
befindlichen
Messing
Der
ist.
sie
repariert
so
4. Kappe und
5. Den
abnehmen.
die
an.
oder
werden. Sie
den
NIEDRIG
HOCH
Feuer und
des Herstellers
und Kappe
ca. 13 rnrn
ca. rnm oder
FROSTSCHUTZ
6.
Wlrd
die
4
ANMERKUNG:
kann den
durch
(Waschmittel
werden.
ANMERKUNG: Keine
7. Nur die
In
den
die
einstellen.
Urn
den
3. Den
REINIGUNG'Positionstellen.
(DIAGRAMM
T
A
G
E
4.
in den
WARTUNG
C:
5. Den Sauger
ANMERKUNG:
wird
-
2. Die
den
3. DenRest des
dem
aus
Schaurn
Vor
und
kann in den
Den Rest
aus dern
WARTUNG
6
Den
wird.
ausgelassen
ziehen.
2. Den
3.
WARNUNG:
genden Reparaturen
und reinigen.
die
voilkommnn vom Teppich
aufgesogenwird. den
vor dern Ende
o
nur
I.
milca.
Wasser
4
8
Liter
werden.
immar
4. Den
und
2. Vor
saubnrom Wasser spulen.
5.
der
3
die
sich
6
Rev.
PASSPORT-?!
Download from Www.Somanuals.com. All Manuals Search And Download.
ANTRIEBSMOTOR
des Motors
Den
BURSTENMONTAGE
die
Spannungseinstellung des Treibriernens
beachten.
und die an
der
entfernen.
2. (2)
am Motor
und den Motor nach
AUSBAU DES
herausdrehenund den
vom
VAKUUMMOTORS
Den
des
des
Die
entfernen.
llch
abnehmen.
und
Lager
der
2. Schallpult
Beim
Spannung
die
3. Den Vakuumschlauchvom
Er
sein
4. Die
die (2)
und
der Treibriemenspannungdie (2)
den Motor
und die
5. Die
der die
am Fahrgestell befestigt
und den Motor herausheben.
anziehen.
ZUZANG ZU DEN
der
die
entfernen. Die
abheben und
Abnutzung
1anoder nach750
werden. Nach
2.
entfernen.
der
entfernen.
und den
am Fahrgestell
der Pumpe vom
Austausch der
und
werden.
doch
3.
(4)
am Fahrgestell
4. Den
die
durch
werden.
entfernen und Behalter
nicht
lose genug
werden.
WARNUNG:
den unwahrscheinlichen Fall
sind die
Komponenten von einem
Schlauch umgeben. Die
genau wie
wieder
werden. Vorsicht: Schla uche
VORS
Beim Wiedereinsetzen der Schlauch
-
au dem
FEST ANZIEHEN. da
Ansaug
in den
des
Pumpenkopfes
P
ASSPORT-?
Rev.
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY
Rev.
1
8
PASSPORT-?
Download from Www.Somanuals.com. All Manuals Search And Download.
VAC
ASSEMBLY
LIST:
Rev.
1
9
Download from Www.Somanuals.com. All Manuals Search And Download.
TANK ASSEMBLIES
PARTS LIST:
31
32
14042
98130
1.63 ID
Manual, PSP IG
-
I
10
PASSPORT
-I
Download from Www.Somanuals.com. All Manuals Search And Download.
DRIVE ASSEMBLY
PARTS LIST
KEY
PART NO.
DESCRIPTION
03069
12005
Axle, Brush
Brush
,
24 70020
25 87025
26 41114
1/4
-
20
x
112 HHMS
Star
Housing, Brush
Nut, 10 32
Washer,
27
57030
-
5/2/94
11
Download from Www.Somanuals.com. All Manuals Search And Download.
VAC SHOE ASSEMBLY
16
PARTS
KEY
PART NO.
DESCRIPTION
I
Rev.
1
12
PASSPORT-?
Download from Www.Somanuals.com. All Manuals Search And Download.
PLUMBING ASSEMBLIES
PARTS LIST:
PUMP ASSEMBLY
PUMP REPAIR KIT47176
\
COVER 27057
41226
230V MOTOR 53017
5/2/94
PASSPOR
T-I
13
Download from Www.Somanuals.com. All Manuals Search And Download.
WIRING DIAGRAM
93218 230V
MOTOR
2
CIRCUIT BREAKER
14
Download from Www.Somanuals.com. All Manuals Search And Download.
15
PASSPORT-I
Download from Www.Somanuals.com. All Manuals Search And Download.
|