®
700,000 CANDLEPOWER
12-VOLT SPOTLIGHT
WARNING
READ AND FOLLOW ALL WARNINGS AND
INSTRUCTIONS IN THIS MANUAL TO AVOID
PERSONAL INJURY OR PROPERTY DAMAGE.
OWNER’S MANUAL &
OPERATING INSTRUCTIONS
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY WARNINGS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS
IN THE OWNER’S MANUAL BEFORE OPERATING SPOTLIGHT.
WARNING
•
Never place spotlight lens (face) down when light is on or if it was recently on. Doing so could burn/ignite
surfaces such as seats, carpeting, etc. and cause serious property damage. Always turn spotlight OFF and
unplug from source when not in use.
•
•
To prevent serious damage to eyesight, never look into spotlight when light is on. Do not shine light into the
face of someone else.
Do not touch lens of spotlight when light is on or if it was recently on. The lens will be hot and could cause
serious burns.
•
•
•
•
•
•
Keep battery clips or cigarette lighter plug dry and out of water at all times.
Do not place spotlight in water. Keep all components dry and out of water at all times.
Do not allow children to handle or operate this spotlight.
Do not use this product for other than its intended use.
Do not operate in close proximity of combustible or flammable materials.
Do not attempt to operate spotlight if cord, plug, bulb or any part of the spotlight is damaged or corroded.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SPOTLIGHT.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL
COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
•
•
•
•
•
Never attempt to wipe or clean the inner reflective surface of the
reflector. Touching or wiping the surface will damage it permanently.
Tips to Avoid Damage to
Your Q-Beam Spotlight
The lens is made of optical-quality, tempered glass. As with all glass,
avoid dropping or sharp impact on spotlight.
Do not allow the hot lens to come in contact with water or materials
subject to heat damage.
This spotlight is weather resistant. It is not waterproof. Do not use the
spotlight under water or store outdoors for extended periods.
Only use a Brinkmann 12-volt, halogen bulb that is designed for your
Q-Beam spotlight. Use of any other bulb may result in poor
performance and may damage your spotlight.
•
After months of use, cigarette lighters can build up corrosion that may
prevent your Q-Beam spotlight from making good contact. It may be
necessary to clean the inside of your cigarette lighter receptacle with a
fine emery cloth. Before cleaning receptacle, remove the fuse to prevent it
from shorting out.
1
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
Step 1: To activate spotlight, plug the cigarette lighter adapter
into a cigarette lighter receptacle.
Step 2: Depress trigger switch in handle to turn spotlight ON.
Release trigger switch to turn spotlight OFF.
WARNING: Never place spotlight lens face down when light is
on or if it was recently on. Doing so could
burn/ignite surfaces such as seats, carpeting, etc.
and cause serious property damage. Always turn
spotlight off and unplug from power source when
not in use.
Step 3: To lock trigger switch to ON, depress trigger switch and
slide locking button on back of handle to LOCK. To
unlock and turn spotlight OFF, slide locking button back
to UNLOCK.
Locking
ON/OFF
Button
NOTE: The locking button can also be used to lock spotlight in
the OFF position to prevent accidental activation.
Only use a Brinkmann halogen bulb that is designed for the
Q-Beam 700,000 CP spotlight as a replacement. Use of any other
bulb may result in poor performance and may damage your
spotlight.
To Replace Bulb
Rear
Housing
IMPORTANT: Do not touch the glass part of bulb with fingers as
natural oils affect the life and performance of bulb.
Handle bulb by metal end only.
Step 1: Disconnect spotlight from power source.
Step 2: Remove the two screws from top and bottom of front
housing (see Figure 1).
Step 3: Holding the front housing securely, slowly remove the
rear housing, being careful not to pull wire connections
inside.
Front
Housing
FIGURE 1
2
Download from Www.Somanuals.com. All Manuals Search And Download.
Connector
FIGURE 2
Step 4: Disconnect bulb wire from connector by holding the
connector firmly with fingers then pulling bulb wire
straight out as shown in Figure 2.
Step 5: Squeeze the wire retainer together and lift up as
illustrated in Figure 3.
Step 6: Pull bulb straight out from the reflector mounting plate.
Step 7: To install new bulb, grasp the bulb from the metal end
(DO NOT TOUCH THE GLASS PART) and insert into the
reflector mounting plate. Align the slots in the bulb base
with those in the reflector mounting plate.
Step 8: Replace wire retainer by squeezing ends together while
pressing down. Release ends so that they catch on the
reflector mounting plate.
FIGURE 3
Step 9: Reconnect the bulb wire to the connector as illustrated
in Figure 4.
Step 10: To reassemble spotlight, align screw holes in the rear
and front housings, then insert the rear housing into the
front housing of the spotlight.
Step 11: Replace the two screws that were removed in Step 2. Do
not overtighten screws.
Replacement bulbs and accessories may be purchased from
The Brinkmann Corporation Consumer Sales Department by
calling 1-800-468-5252.
Connector
FIGURE 4
3
Download from Www.Somanuals.com. All Manuals Search And Download.
ACCESSORIES
Rechargeable Battery Pack
With Carrying Case
12-volt rechargeable battery pack
adds total mobility to your Q-Beam.
Includes cigarette lighter receptacle,
120-volt charging transformer and a
heavy-duty, woven nylon carrying
case with shoulder strap.
Model 802-1724-1 Black
Model 802-1725-1 Green Camo
Pigtail Adapters
Pigtail adapter with battery terminal
clips allow Q-Beam spotlights with
cigarette lighter plug to operate
directly from a 12-volt battery.
(2Ft. Cord) Model 802-1704-0
(10Ft. Cord) Model 802-1705-0
Lighter Plug Extension Cord
Features a 15-ft. cord with a cigarette
lighter plug and receptacle.
Model 802-1706-0
4
Download from Www.Somanuals.com. All Manuals Search And Download.
ACCESSORIES
Snap-On Lens Filter
Filter lens easily snaps-on to Q-Beam
spotlight for color and visual effect.
Model 802-1703-1 Amber
Model 802-1703-2 Red
Model 802-1703-3 Blue
Model 802-1703-4 Assortment Pack
(1 Amber, 1 Red, 1 Blue)
Replacement Bulb
12-volt, halogen bulb is an original
replacement for 700,000 CP spotlight.
Model 802-1745-0
Look for these accessories at your local retailer where Q-Beams
are sold, or order direct by calling 1-800-468-5252
5
Download from Www.Somanuals.com. All Manuals Search And Download.
1-YEAR LIMITED WARRANTY
For 1-year from date of purchase, The Brinkmann Corporation warrants the Q-Beam 700,000 CP Spotlight against
defects due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under
this warranty are limited to the following guidelines:
•
•
This warranty does not extend to the bulb.
This warranty does not cover spotlights that have been altered or damaged due to: normal wear, abuse,
improper maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an
authorized employee of The Brinkmann Corporation.
•
•
This warranty does not cover surface scratches or weathering as this is considered normal wear.
Warranty service is limited to repair or replacement of spotlights which prove defective under normal use and
which upon examination shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms
the defect and approves the claim, Brinkmann will elect to repair or replace the rechargeable light as covered
by the terms of this warranty.
•
This warranty extends to the original purchaser only and is not transferable or assignable to subsequent
purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you
retain your sales receipt or invoice. To obtain repair or replacement of your Q-Beam 700,000 CP Spotlight under
the terms of this warranty, please call Customer Service Department at 1-800-527-0717 for a Return Authorization
Number and further instructions. A receipt or proof of purchase will be required. A Return Authorization
Number must be clearly marked on the outside of the box. Spotlights returned to Brinkmann must include your
name, address and telephone number. Please make sure the light is properly packed, postage prepaid, and
insured. Brinkmann will not be responsible for any spotlights forwarded to us without a Return Authorization
Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED
IN DURATION TO 1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON
HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF
THE Q-BEAM 700,000 CP SPOTLIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS
EXCLUDED. CUSTOMER ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE
LIMITATIONS CONTAINED IN THE WARRANTY SET OUT ABOVE. SOME STATES DO NOT ALLOW THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR
EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY
ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
140-2700-0
7/01
Download from Www.Somanuals.com. All Manuals Search And Download.
|