GB
User manual
Tumble Dryer
2
ZDE 47100W
Download from Www.Somanuals.com. All Manuals Search And Download.
• The final part of a tumble dryer cycle occurs without
heat (cool down cycle) to ensure that the items are left
at a temperature that ensures that items will not be
damaged.
• Ensure youhaveadequate ventilationintheinstallation
room to avoid the back flow of gases into the room
from appliances burning other fuels, including open
fires.
• Do not dry unwashed items in the tumble dryer.
• Do not overload the appliance. See the relevant section
in the user manual.
• Clothes which are dripping wet should not be placed
in the dryer.
• Garments which have been in contact with volatile pe-
troleum products should not be machine dried. If vol-
atile cleaning fluids are used, care should be taken to
ensure that the fluid is removed from the garment be-
fore placing in the machine.
• Never pull the power supply cable to remove the plug
from the socket; always take hold of the plug itself.
• Never use the tumble dryer if the power supply cable,
the control panel, the working surface or the base are
damaged so that the inside of the tumble dryer is ac-
cessible.
Installation
• This appliance is heavy. Care should be taken when
moving it.
• When unpacking the appliance, check that it is not
damaged. If in doubt, do not use it and contact the
Service Centre.
• All packing and transit bolts must be removed before
use. Serious damage can occur to the product and to
property if this is not adhered to. See relevant section
in the user manual.
• Fabric softeners, or similar products should be used
as specified by the fabric softener instructions.
• Caution-hotsurface :Donottouchthedoorlightcover
surface when the light is switched on.
• Any electrical work required to install this appliance
should be carried out by a qualified electrician or com-
petent person.
• Care must be taken to ensure that the appliance does
not stand on the electrical supply cable.
• If the machine is situated on a carpeted floor, please
adjust the feet in order to allow air to circulate freely.
• After having installed the appliance, check that it is not
pressing or standing on its electrical supply cable or/
and inlet hose.
1)
•
Hot surface: Do not touch the back of the appliance
while it is operating!
Child safety
• This machine is not intended for use by young children
or infirm persons without supervision.
• Children often do not recognise the hazards associated
with electrical appliances. Children should be super-
vised to ensure that they do not play with the appliance.
• The packaging components (e.g. plastic film, poly-
styrene) can be dangerous to children - danger of suf-
focation! Keep them out of children’s reach.
• Keep all detergents in a safe place out of children’s
reach.
• If the tumble dryer is placed on top of a washing ma-
chine, it is compulsory to use the stacking kit (optional
accessory).
Use
• This appliance is designed for domestic use. It must
not be used for purposes other than those for which it
was designed.
• Only wash fabrics which are designed to be machine
dried. Follow the instructions on each garment label.
• Make sure that children or pets do not climb into the
drum.
1) Only dryers equipped with internal drum light.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Product description
1
2
3
4
7
6
5
1
2
3
4
Control panel
Door
Fluff filter
Rating plate
5
6
7
Adjustable feet
Sideways vent outlets / back vent outlet
Ring nut
Control Panel
1
2
3
4
1
2
Function buttons
Programme knob and OFF switch
4
Download from Www.Somanuals.com. All Manuals Search And Download.
3
Function lights from up to down:
DRYING , COOLING , END/ANTICREASE, FILTER
4
START PAUSE button
Before first use
In order to remove any residues which may have been
damp cloth or carry out a brief drying cycle (ca. 30 min.)
produced during production, wipe the dryer drum with a with damp cloths in the machine.
Sorting and preparing laundry
• Turn items with double-layered fabrics inside out (e.g.
with cotton-lined anoraks, the cotton layer should be
outermost). These fabrics will then dry better.
Sorting laundry
• Sort by fabric type:
– Cotton/linen for programmes in COTTONS pro-
gramme group.
– Mixtures and synthetics for programmes in SYN-
THETICS programme group.
Important! Do not overload the appliance. Observe max.
loading volume of 7 kg.
Laundry weights
• Sort by care label: The care labels mean:
Type of laundry
Bathrobe
Weight
1200 g
100 g
700 g
500 g
200 g
250 g
200 g
100 g
200 g
100 g
600 g
200 g
500 g
100 g
100 g
Drying in the tumble dryer possible in prin-
ciple
Napkin
Drying at normal temperature
Quilt cover
Sheet
Drying at reduced temperature (press DELI-
CATE button!)
Pillow case
Tablecloth
Drying in the tumble dryer not possible
Important! Do not place in the appliance any wet laundry
which is not specified on the care label as being suitable
for tumble-drying.
This appliance can be used for all wet laundry items which
are labelled as suitable for tumble-drying.
• Do not dry new, coloured textiles together with light-
coloured laundry items. Textile colours may bleed.
• Do not dry cotton jersey and knitwear with the EXTRA
DRY programme. Items may shrink!
• Wool and wool-like textiles can be dried using the
WOOL CARE programme.
Preparing laundry
• To avoid laundry becoming tangled: close zips, button
up duvet covers and tie loose ties or ribbons (e.g. of
aprons).
Towelling towel
Tea cloth
Night dress
Ladies' briefs
Man's work shirt
Man's work shirt
Man's pyjamas
Blouse
Men's under-
pants
• Empty pockets. Remove metal items (paper clips, safe-
ty pins, etc).
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Programme chart
Time in mi-
nutes
Programmes
Application/properties
(about)
Thorough drying of thick or multi- layered fabrics, e.g.
terry towelling items, bathrobes.
1)
COTTON EXTRA DRY
7 kg
7 kg
7 kg
7 kg
7 kg
A
COTTON STRONG
DRY
Thorough drying of thick or multi- layered fabrics, e.g.
terry towelling items, bathrobes.
135
COTTON CUPBOARD
Thorough drying of fabrics of even thicknesses, e.g.
terry towelling items, knitwear, towels.
1)
A
2)
DRY
For thin textiles which are still to be ironed, e.g. knitted
items, cotton shirts.
2)
105
95
COTTON DAMP
For thin fabrics which are also to be ironed, e.g. knit-
wear, cotton shirts.
2)
COTTON IRON DRY
SYNTHETICS EXTRA
DRY
Thorough drying of thick or multi-layered fabrics, e.g.
pullovers, bedding, table linen.
1)
3 kg
A
For thin fabrics which are not ironed, e.g. easy care
3 kg shirts, table linen, baby clothes, socks, lingerie with
bones or wires.
SYNTHETICS CUP-
BOARD DRY
1)
A
2)
SYNTHETICS IRON
DRY
For thin fabrics which are also to be ironed, e.g. knit-
wear, cotton shirts.
25
3 kg
Special programme with anti-crease mechanism for
easycare textiles suchshirts andblouses;for minimum
ironing effort. The result depends on the type and qual-
1 kg ity of textiles. (The loading volume corresponds to ap-
prox. 5 to 7 shirts.) Recommendation: Place textiles in
the dryer straight after spinning. Once dried, immedi-
ately remove textiles and place on clothes hanger.
1)
SPECIAL EASY IRON
A
WOOL CARE is special programme for briefly treating
woollens with warm air after they have been dried nat-
urally, worn or stored for long periods. Wool fibres are
SPECIAL WOOL
CARE
1)
1 kg
A
aligned and the wool becomes soft and snugly.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Time in mi-
nutes
Programmes
Application/properties
(about)
For refreshing or gently cleaning textiles with com-
mercially available dry cleaning products.
1)
SPECIAL REFRESH
SPECIAL COOLING
1 kg
7 kg
A
Special programme, lasting around 10 minutes, for re-
freshing or gently cleaning textiles with commercially
available dry cleaning sets. (Only use those products
which are declared as suitable for the drier by the man-
ufacturer; please observe the manufacturer’s instruc-
tions for use.)
1)
A
For leisure clothing, such as jeans, sweat-shirts, etc.,
7 kg of different material thicknesses (e.g. at the neck, cuffs
and seams).
JEANS
125
1) Automatic
2) In accordance with IEC61121
Daily use
Switching machine on
Turn the programme selector to any programme. The ma-
chine has been switched on.
Door opening and laundry loading
1. Open loading door:
Push against the loading door (push point)
2. Load your laundry (do not force it in).
Caution! Do not jam laundry in between the loading
door and rubber seal.
3. Close loading door securely. Lock must audibly lock.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
The programme phase is shown by appropriate lights;
light 5- DRYING , light 6- COOLING, light7- END/ANTI-
CREASE .
Selecting the programme
Use the programme selector to set the programme you
require.
Changing programme
To change a programme which has been selected by mis-
take once the programme has started, first turn the pro-
gramme selector to OFF position. The programme is
cancelled.
The programme can no longer be changed directly
once the programme has started. If nevertheless
there is an attempt to change the programme on the pro-
gramme knob or if an function button is pressed, led
START PAUSE starts flashing temporarily in yellow. The
dryingprogrammeisnothoweveraffectedbythis(laundry
protection).
Selecting additional functions
You can choose from the additional functions (only with
time programmes ) :
Drying cycle complete / removing laundry
7
6
5
4
Once the drying cycle is complete, the lights END/ANTI-
CREASE and FILTER (light 4) are on. If the buzzer function
is active, an acoustic signal will sounds intermittently for
about one minute.
The drying cycles are automatically followed by an
anti-crease phase which lasts around 30 minutes.
Thedrumrotatesatintervalsduringthisphase. Thiskeeps
the laundry loose and free of creases. The laundry can be
removed at any time during the anti-crease phase. (The
laundry should be taken out towards the end of the anti-
crease phase at the latest to prevent creases from form-
ing.)
1
2
3
button 1 -DELICATE
button 2 -TEXTILE
DELICATE
Pressing this button allows drying to be performed at a
lower temperature, for delicate items. The corresponding
pilot light comes on. This option can also be used for time
controlled drying.
1. Open door.
2. Remove laundry.
3. Remove filter after clothes has been removed. Clean
the filter.
TEXTILE
Press the Textile button repeatedly, to select the desired
option. The relevant light will light up. You can select 2
different options: COTTON cycle: to be used for cotton,
and SYNTHETICS : to be used for synthetic or delicate
items.
Warning! Before You place the filter, please check
it there is nothing inside the filter seat.
4. Turn the programme selector to OFF .
Important! Clean the filter after each drying cycle.
5. Close the door.
Starting the programme
Press the START PAUSE button. The programme is star-
ted.
Cleaning and maintenance
Warning! The tumble dryer is not to be used if
industrial chemicals have been used for cleaning!
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Warning! Before You place the filter, please check
it there is nothing inside the filter seat.
4. The filter can be positioned only to one side. If po-
sition is wrong, the filter overhangs.
Cleaning fluff filter
The filter collect all the fluff which accumulates during
drying. To ensure that the dryer works perfectly, the fluff
filter must be cleaned after every drying cycle.
The warning light FILTER , is on to remind you this op-
eration.
If the filter will not snap into place, the loading door
cannot be closed.
Caution! Never operate the dryer without fluff filter
or with damaged or blocked fluff filter.
Cleaning the door
Clean periodically the interior part of the door to remove
any fluff. Accurate cleaning ensures correct drying.
1. Open loading door
and remove laun-
dry.
Cleaning the drum
2. Remove the filter
which is built into
the lower part of the
loading aperture.
Caution! Do not use abrasives or steel wool to clean
the drum.
Lime in the water or cleaning agents may form a
barely visible lining on the inside of the drum. The
degree to which the laundry has been dried is then no
longer detected reliably. The laundry is damper than ex-
pected when removed from the dryer.
Use a standard domestic cleaner (e.g. vinegar-based
cleaner) to wipe down the inside of the drum and drum
ribs.
3. Open the filter
pressing the but-
ton, among two
slots on fingers.
Clean the filter us-
ing dump hand or
cloth. After a period
Clean operating screen and housing
of time, a patina
due to detergent
residue on laundry forms on the filters. When this
occurs, clean the filter with warm water using a brush.
Close the filter and do not forget to put it back.
Caution! Do not use furniture cleaners or
aggressive cleaning agents to clean the machine.
Use a damp cloth to wipe down the operating screen and
housing.
What to do if ...
Problem
Possible cause
Remedy
Mains plug is not plugged in or fuse Plug in at mains socket. Check fuse
is not working correctly.
Loading door is open.
in fuse box (domestic installation).
Close loading door.
Dryer does not work.
Have you pressed the START PAUSE Press the START PAUSE button
button?
again.
Select a different programme the next
time you dry (see “Programme chart”
chapter).
Wrong programme selected.
Fluff filter clogged.
Clean fluff filter.
Drying results unsatisfactory.
Observe recommended loading vol-
umes.
Overloading of laundry.
Ventilation slots covered up.
Uncover ventilation slots.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Problem
Possible cause
Residue on inside surface of drum or Clean inside surface of drum and
drum ribs. drum ribs.
Remedy
Conductance of water at installation Re-programme standard setting for
site differs from standard setting of degree of drying (see ‘Programming
machine.
options’ chapter).
Loading door does not close.
Filter not in place.
Install filter into place.
Not enough washingloadedorwash- Select time programme or higher
Drying cycle ends shortly after pro-
gramme starts.
ing loaded is too dry for selected
programme.
drying level (e.g. EXTRA instead of
CUPBOARD ).
Filter clogged.
Clean filter.
Drying cycle lasts an unusually long
time. Note: After around 5 hours the Load volume too big.
Reduce load volume.
Laundry must be adequately spun.
drying cycle ends automatically.
Laundry insufficiently spun.
Machine settings
2. Press simultaneously theDELICATE and TEXTILE
buttons and hold down for approx. 5 seconds.
3. The buzzer is by default always off.
BUZZER SIGNAL permanent on/off
1. Turn the programme selector to any programme.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Technical data
Height x width x depth
Drum volume
85 x 60 x 58 cm
108 l
Depth with loading door open
Height can be adjusted by
Weight when empty
109 cm
1.5 cm
approx. 32.5kg
max. 7 kg
230-240 V
13 A
1)
Loading volume (depends on programme)
Voltage
Required fuse
Total power
2200 W
C
Energy efficiency class
Energy consumption (7 kg of cotton, pre-drained at 1000
rpm)
3.9 kWh
2)
Average annual energy consumption
Use
262.6kWh
Domestic
Permissible ambient temperature
+ 5°C to + 35°C
Consumption values
The consumption values have been established under standard conditions. They may deviate when the machine is
operated in domestic circumstances.
Programme
Energy consumption in kWh / average drying time in min.
3.9 / 115 (7kg load pre-drained at 1000 rpm)
3 / 85 (7 kg load pre-drained at 1000 rpm)
2)
COTTON CUPBOARD
2)
COTTON IRON
2)
1.18 / 35 (3 kg load pre-drained at 1200 rpm)
SYNTHETICS CUPBOARD
1) Different loading volume data may be needed in some countries as a result of different measuring methods.
2) in accordance with EN 61121
Installation
• Once in its permanent operating position, check that
the dryer is absolutely level with the aid of a spirit level.
If it is not, raise or lower the feet until it is.
Appliance positioning
• It is recommended that, for your convenience, the ma-
chine is positioned close to your washing machine.
• The feet must never be removed. Do not restrict the
floor clearance through deeppile carpets, strips of
wood or similar. This might cause heat built-up which
would interfere with the operation of the appliance.
• The tumble dryer must be installed in a clean place,
where dirt does not build up.
• Air must be able to circulate freely all round the appli-
ance. Do not obstruct the front ventilation grille or the
air intake grilles at the back of the machine.
• To keep vibration and noise to a minimum when the
dryer is in use, it should be placed on a firm, level
surface.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Important! The hot air emitted by the tumble dryer can
reach temperatures of up to 60°C. The appliance must
therefore not be installed on floors which are not resistant
to high temperatures.
When operating the tumble dryer, the room temperature
must not be lower than +5°C and higher than +35°C, as
it may affect the performance of the appliance.
Warning! Should the appliance be moved, it must
be transported vertically.
If the hose is long and the
room temperature low, the
moisture might condense to
water inside the hose. This
is an unavoidable natural
phenomenon. To prevent
this water from Iying in the
hose or flowing backinto the
tumble dryer, it is advisable
Warning! The appliance must not be installed
behind the lockable door, a sliding door or a door
with a hinge on the opposite side to that of the appliance.
Removing transport safety packaging
Caution! Before use all parts of the transport
packaging must be removed.
to drill a small hole (via. 3 mm) in the lowest point of the
hose and to place a small container below it. (See picture,
point B).
Once connected to the dryer, run the vent hose to the
desired outlet point, ensuring that the run’s overall length
is less than 2 m, and that it contains no more than two
bends. As to the outlet itself, if you have decided on a
fixed wall/window grille, a good local builder’s merchant
should be able to supply you with the necessary fittings
and installation advice.
1. Open loading door.
2. Pull off adhesive strips polystyrene padding from
3. Remove foil hose and
from inside machine on
top of drum.
the machine.
Warning!
It is important not to connect
the vent hose to, for
example, a cooker hood, or
a chimney or flue pipe
designed to carry the
exhaust from a fuel burning
appliance.
Fitting the vent hose
To simplify the installation, there is a choice of vent out-
lets: one at the back, the others in the left and right-hand
side. Connect the hose to whichever is the more conven-
ient by pulling the ring nut (A) from the vent outlet at the
back, screwing it on to the hose and pushing it firmly back
into place. The unused vents should now be sealed with Note that to avoid conden-
the special snap covers provided.
sation problems, it is essential that the dryer be fitted with
the flexible hose to carry its “exhaust” at least beyond the
kitchen units; preferable outside the kitchen. In order to
prevent the appliance from overheating, it is important
that the steam exhaust is unobstructed. Therefore, in case
of a permanent hose fitted to an exterior wall or ceiling, it
must be ensured an exhaust capacity of at least 150 m3/
h. If the dryer is fitted next to kitchen units, make sure that
the vent hose is not squashed. If the hose is partially
squashed, drying efficiency will be reduced, resulting in
12
Download from Www.Somanuals.com. All Manuals Search And Download.
longer drying times and higher energy consumption. If
The wire coloured green and yellow must be connected
the hose is completely squashed, the safety cut-outs with to the terminal marked with the letter «E» or by the earth
which the machine is fitted may operate. When operating
the tumble dryer, the room temperature must not be lower
than +5°C and higher than +35°C, as it may affect the
performance of the appliance.
symbol
or coloured green and yellow.
The wire coloured blue must be connected to the terminal
«N» or coloured black.
The wire coloured brown must be connected to the ter-
minal marked «L» or coloured red.
Upon completion there must be no cut, or stray strands
of wire present and the cord clamp must be secure over
the outer sheath.
Electrical connection
Details on mains voltage, type of current and the fuses
required should be taken from the rating plate. The rating
plate is fitted near the loading aperture (see “Product de-
scription” chapter).
Connect the machine to an earthed socket, in accordance
with current wiring regulations.
Warning! A cut off plug inserted into a 13 amp
socket is a serious safety (shock) hazard.
Ensure that the cut off plug is disposed of safely.
Warning! The manufacturer declines any
responsibility for damage or injury through failure
to comply with the above safety precautions.
Should the appliance power supply cable need to be
replaced, this must be carried out by our Service Centre.
Warning! The plug must be accessible after
installing the machine.
Permanent connection
In the case of permanent connection it is necessary that
you install a double pole switch between the appliance
and the electricity supply (mains), with a minimum gap
of 3 mm between the switch contacts and of a type suitable
for the required load in compliance with the current elec-
trical regulations.
The appliance is supplied with a 13 amp plug fitted. In the
event of having to change the fuse in the plug supplied,
a 13 amp ASTA approved BS 1363/A fuse must be used.
4
The switch must not break the yellow and green earth
cable at any point.
Door reversal
To make it easier to load or unload the laundry, the door
can be reversed. The door must only be reversed by an
authorised service engineer. Please contact your local
Service Force Centre. The engineer will carry out the door
reversal at your cost.
3
Special accessories
Stacking kit
A special stacking kit is
available through your deal-
er, to enable the mounting of
the dyer on top of a front
loading washing machine
with cover’s depth between
48and60cm.Readcarefully
the instructions supplied
with the kit.
1
2
The wires in the mains lead are coloured in accordance
with the following code:
1
2
3
4
Blue - Neutral
cord clamp
Brown - Live
Green and Yellow - Earth
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Environment
Warning! When disposing of old appliances,
removethemainscableanddisposeoftogetherwith
the plug. Remove the door hook and ensure it is no longer
lockable to prevent young children being trapped inside.
The symbol
on the product or on its packaging
indicates that this product may not be treated as
household waste. Instead it should be taken to the
appropriate collection point for the recycling of electrical
and electronic equipment. By ensuring this product is
disposed of correctly, you will help prevent potential
negative consequences for the environment and human
health, which could otherwise be caused by inappropriate
waste handling of this product. For more detailed
information about recycling of this product, please
contactyourlocalcouncil, yourhouseholdwastedisposal
service or the shop where you purchased the product.
Environmental tips
• In the dryer, laundry becomes fluffy and soft. Fabric
softeners are not therefore needed when washing.
• Your dryer will function most economically if you:
– always keep the ventilation slots on the base of the
dryer unobstructed;
– use the loading volumes specified in the pro-
gramme overview;
– clean the filter after each drying cycle;
– spin the laundry well before drying. Example: Con-
sumption data – depending on spinning speed –
for 7 kg of laundry, dried using the COTTONS CUP-
BOARD programme.
Packaging material
The packaging materials are environmentally friendly and
can be recycled. The plastic components are identified by
markings, e.g. >PE<, >PS<, etc. Please dispose of the
packaging materials in the appropriate container at the
community waste disposal facilities.
Pre-draining
Drying cycle
Residual dampness
Revolutions per minute
in litres
Energy in kWh
as a %
60
1000
1400
4.20
3.64
3,9
3,7
52
Service
In the event of technical faults, please first check whether So that you have the necessary reference numbers from
you can remedy the problem yourself with the help of the your appliance at hand,
operating instructions (Chapter “What to do if…”).
If you were not able to remedy the problem yourself,
please contact your local service centre.
In order to be able to assist you quickly, we require the
following information:
– Model description
– Product number (PNC)
– Serial number (S No.) (for numbers, see rating plate)
– Type of fault
– Any error messages displayed by the appliance
we recommend that you write them in here:
Model description:
PNC:
.................................................................................
.................................................................................
14
Download from Www.Somanuals.com. All Manuals Search And Download.
S No.:
.................................................................................
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
|