EPS Espresso Pod System
User’s Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
4.4. DISPENSING HOT WATER .............................................................18
4.5. DISPENSING STEAM .....................................................................19
4.5.1. Using steam to heat up a drink ................................................19
4.5.2. Using the steam to froth milk for Cappuccino. ...........................19
CHAPTER 5 – PRECAUTIONS WHEN USING THE MACHINE ..............21
5.1. PRECAUTIONS WHEN DISPENSING STEAM.....................................21
5.1.1. Refilling water in boiler............................................................21
CHAPTER 6 – CLEANING & MAINTENANCE........................................23
6.1. WATER & STEAM DRIP TRAYS.......................................................23
6.2. STEAM ARM .................................................................................23
6.3. POD HOLDER FILTER....................................................................23
6.4. CLEANING THE CHROMIUM-PLATED PARTS....................................23
6.5. CLEANING THE PAINTED SURFACES ..............................................24
6.6. CLEANING THE WATER RESERVOIR...............................................24
6.7. REPLACING THE POD ASSEMBLY RUBBER SEALING RING................24
6.8. DESCALING OF THE INTERNAL BOILER..........................................25
6.9. ANTI SCALE WATER FILTER ..........................................................25
CHAPTER 7 - TROUBLESHOOTING .....................................................26
7.1. PROBLEMS DESCRIPTION AND SOLUTIONS....................................26
7.2. FILLING THE BOILER ....................................................................27
CHAPTER 8 - TECHNICAL DATA.........................................................29
3 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
INTRODUCTION
Congratulations on choosing a Tonino
Lamborghini Espresso Pod Coffee Machine.
The design of the machine was personally
approved by Tonino Lamborghini towards the end
of 2005 and it includes some design features taken
from the early cars.
Each machine uses the highest quality
materials designed to make a delicious cup of
coffee time and time again.
This manual will guide you through setting up
the machine and how to use the machine to ensure
that it makes a perfect cup of coffee.
PLEASE CAREFULLY READ THIS MANUAL
BEFORE USE.
Please keep this manual in a safe place and
make that that any other person who uses this
machine reads the instructions for use.
4 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 1 - GENERAL INFORMATION
1.1. CONTENTS OF THE BOX
1) Coffee Machine
2) 2 Spare rubber seals
3) Cleaning cloth
4) Water reservoir cover plate
5) Coffee Drip tray cover
6) Coffee Drip tray
7) Users Manual on CD Rom
2
1
3
4
5
6
7
Fig. 1 - Contents of the box
Carefully remove the components from the
box and keep all the packaging in the box.
5 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
1.2. DESCRIPTION OF THE MACHINE
Fig. 2 shows the assembled machine and
highlights the important controls and buttons.
Cup Rest
Steam release
Water reservoir
On/Off Button
Coffee Button
Steam Switch
Temperature
Led Light
On/Off Led
Light
Steam / Water
dispenser
Pod holder filter
Drip tray
Coffee Group
Lever
Spout
Steam Drip tray
Drip tray cover
Fig. 2 – Description of parts
1.2.1. ANTI SCALE WATER FILTER (see Par. 6.9)
Fitted at the end of the longer water pipe that
sits in the plastic water reservoir. When fitted this
filter will prevent the build of scale inside the
machine and will ensure that the machine provides
you with trouble free use.
6 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
1.3. DESCRIPTION OF CONTROLS
On/ Off button: Push the button to turn the
machine on. The red LED light next to the button
will come on to indicate that the machine is on.
This LED will remain illuminated at all times when
the machine is on. Push the button again to switch
the machine off.
Hot water/ Coffee making button: Push the
button to start making a cup of coffee or to release
hot water through the spout (when there is no
coffee pod in the machine). Push the button again
to turn off the water supply.
Steam button: Push the button to prepare the
machine to make steam (boiler temperature rises
to 125°C). Push the button again to return to
coffee making (boiler temperture reduces to 95°C).
You cannot make coffee whilst the steam button is
depressed as the water temperature will be too
high. It takes a couple of minutes for the boiler to
reach the correct temperatute for steam. It takes a
couple of minutes for the temperature to drop back
down after you turn the steam button off again.
Temperature Led Light: This red LED light is
on the left hand side of the casing next to the
steam button.
1 Light on = Machine is in the process of
heating up and is not yet ready. The boiler
has not yet reached operating temperature.
2 Light off = Machine is ready to make coffee.
The
boiler
has
reached
operating
temperature.
Steam release knob: Ensure that the steam
arm is over the drip tray and slowly rotate the knob
anticlockwise for a few seconds to discharge any
residual water from the steam arm. Once the water
has been discharged turn the steam off again by
rotating the steam knob clockwise.
PLEASE NOTE: Do not use the steam supply for
longer than about 1 minute at any one time (see Par 5.1).
7 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
Gearlever handle: Located on right hand side
of machine to open and close the pod holder
assembly. Pull the lever towards you to lower the
pod holder assembly and the spout. This allows the
coffee pod to be placed on the holder. Push the
lever away from you to raise the assembly before
you make a cup of coffee. Push the lever until it
locks into position. You should encounter some
resistance as the lever locks. After you have made
a cup of coffee pull the lever towards you to allow
the pod to be taken out.
CAUTION: The pod holder will become hot
during use and care should be taken when putting
in and removing the pod to avoid getting scalded.
1.4. MARKING AND IDENTIFICATION OF THE PRODUCT
The nameplate is located on the underside of
the base and shows details of the model and the
voltage. Please check that the voltage supply
matches the voltage specified on the nameplate
before you start.
1.5. CONDITIONS OF GUARANTEE
The manufacturer provides a guarantees on
the machine according to the laws.
If during the guarantee period the machine
breaks down then it will be fixed and the broken
part replaced on the following conditions:
1 The fault is reported within the guarantee
period.
2 The problem is caused by a manufacturing
defect or faulty material.
3 The machine must be returned to the
retailer to allow the necessary repair work to
be done.
If your machine does not work properly
please look at Chapter 7 – Troubleshooting –
before contacting your retailer.
IMPORTANT: If you have to return the coffee
machine for repair please do not send back the
8 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
water reservoir cover plate, the drip tray cover or
the drip trays. The manufacturer and/or the retailer
will not accept responsibility for the damage or loss
of any of these items if they are returned with the
coffee machine. Please remember to empty the
plastic reservoir before you return the machine.
1.6 LIMITS OF THE GUARANTEE
The guarantee does not cover
1 Incorrect use of the machine which is
designed for household/domestic use.
2 Damage caused by using the machine
outside of the normal working environment.
3 Tampering with the mains cable.
4 Alterations made to the product.
5 Repairs not carried out by an authorized
service agent or centre.
6 Use of non-original spare parts or
accessories.
7 Inadequate or incorrect packing during
transportation.
IMPORTANT: Problems caused by the build of of
scale inside the machine are not covered by the
guarantee. You are advised to use either filtered
water or bottled (still) water to prevent such
problems occurring and to use a scale filter on
the water pipe. The scale filter should be
replaced every 3 months.
1.7 CERTIFICATIONS
The machine complies with the following
European standards:
Safety (Dir. 72/23/CEE)
EMC (Dir. 89/336/CEE)
EN IEC 60335-1
EN IEC 60335-2-15
EN IEC 55014-1
EN IEC 55014-2
EN IEC 61000-3-2
EN IEC 61000-3-3
EN 50366
Subpart A and B
Dir. 2002/95/CE
Dir. 2002/96/CE
EMF (Dir. 2004/40/EC)
Part 15 FCC Rulement
RoHs
Weee
9 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
1.8 SCRAPPING
This product complies with EU Directive
2002/96/EC.
The symbol on the product or on its
packaging indicates that this product may not be
treated as household waste. Instead it shall be
handed over to the appropriate collection point for
recycling of electrical and electronic equipments.
By ensuring this product is disposed of correctly,
you will help prevent potential damage to for the
environment and human health, which could be
caused by inappropriate waste handling of this
product. For more detailed information about
recycling of this product, please contact your local
council office, your household waste disposal
service or the shop where you purchased the
product.
10 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 2 – UNPACKING / INSTALLATION
Before using the machine please carefully read these instructions.
2.1. INSTALLATION
Carefully unpack the machine and check that
all the parts are present (see Par. 1.1) and
familiarise yourself with the controls (see Fig. 2).
2.2. POSITION OF THE MACHINE
Place the machine on a flat, even surface
close to a wall socket in a well-lit environment.
Ensure that the machine cannot be knocked over
or cause injury and is out of the reach of children.
Keep the machine away from sources of heat, very
hot surfaces and open flames. Leave at least 30cm
of space on either side of the machine so that you
can operate all the controls safely (such as the
steam arm).
2.3. CONNECTING TO THE ELECTRICITY SUPPLY
Before plugging the machine into the mains
supply please check that the voltage indicated on
the nameplate on the base of the machine matches
the local power supply.
ATTENTION: The machine is intended for
domestic use only. Please ensure that you
have a suitable, earthed power supply.
If the mains cable becomes damaged or
defective you must contact the retailer to
arrange for a suitable replacement. The
machine MUST NOT be used if the mains
cable is, or appears to be, damaged.
11 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 3 – IMPORTANT SAFETY NOTICES
3.1. GENERAL SAFETY
Please ensure that you read this manual and
the safety notices contained in it so that you are
aware of any potential danger.
The manufacturer cannot be held responsible
for damage/ injury to persons caused as a
result of not following the safety guidelines
and instructions in this manual.
If you are unable to resolve an issue after
studying Chapter 7 – Troubleshooting then please
contact your retailer for advice.
3.2. ELECTRICITY
Do not remove the metal machine
casing as it contains live parts that will
produce an electric shock to the user.
There are no user serviceable parts inside the
metal casing of the machine.
Do not immerse the machine in water.
The machine must be earthed.
If an extension lead is to be used please
ensure that it is of a suitable rating and that is
contains a ground/ earth cable (i.e 3 wires).
When filling the water reservoir be careful not
to spill water onto the casing of the machine. If
water does get onto the casing unplug the machine
from the electricity before wiping off the water.
Always check the voltage to make sure it
matches the voltage indicated on the nameplate of
the machine.
12 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
3.3. DANGER – HIGH TEMPERATURES
During normal operation some parts of the
machine will become extremely hot. To avoid the
risk of scalding please do not touch the following
parts when the machine is turned on as they will
be hot:
1 Coffee Spout
2 Steam Arm
3 The inside of the pod holder assembly
Take particular care when putting in or taking
out a coffee pod as the temperature of the metal
can approach 100°C.
3.4. GENERAL INFORMATIONS & IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety
precautions should always be followed to reduce
the risk of fire, electric shock, and/or injury to
persons, including the following:
- Read all instructions and information in
this instruction book and any other
literature included in this packaging
referring to this product before operating
or using this appliance.
- Do not touch hot surfaces. Use handles or
knobs.
- To protect against fire, electric shock and
personal injury do not immerse cord,
plugs, or appliance in water or other
liquid.
- Close supervision is necessary when any
appliance is used by or near children.
- Unplug from outlet when not in use and
before cleaning. Allow to cool before
putting on or taking off parts and before
cleaning the appliance.
13 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
- Do not operate any appliance with a
damaged cord or plug or in the event of
appliance faults or damages. Return
appliance to the nearest authorized
service centre for examination, repair or
adjustment.
- The use of accessory attachments is not
recommended
by
the
appliance
manufacturer and may result in fire,
electric shock or personal injury.
- Do not use outdoors.
- Do not let the cord hang over the edge of
a table or counter, or touch a hot surface.
- Do not place on or near to a hot gas or
electric burner, or in a heated oven.
- Always switch appliance "0ff", then plug
cord into the wall outlet. To disconnect,
switch "0ff" the machine, then remove
plug from wall outlet.
- Do not use appliance other than for
intended household use.
- Use extreme caution when using hot
steam.
14 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 4 – USING THE MACHINE
NOTE: We would advise that you rinse the
water container before it is used for the first
time and that you discard the first coffee
that you make when the machine is brand
new.
4.1. FILLING UP THE WATER RESERVOIR
Remove the silver water reservoir cover and
carefully take out the 2 water pipes. Fit a scale
filter (supplied with the machine) to the longer of
the two pipes. Now fill the reservoir with water.
The water must be at room temperature. If you
prefer you can remove the reservoir from the
machine before filling it up with water. Be careful
not to get the water pipes trapped when refitting
the reservoir into the machine. You should hold
the 2 pipes out of the way when installing the
reservoir. When you put the 2 pipes back int the
reservoir ensure that the pipe with the scale filter
fitted can reach the bottom of the reservoir. The
capacity of the reservoir is about 2 litres. Refit the
metal reservoir cover.
NOTE: It is recommended that you use
mineral water or filtered water in the machine to
avoid the build up of scale which can cause
damage to the boiler.
The scale filter should be replaced every 3
months.
DO NOT USE FIZZY OR SPARKLING WATER,
OR ANY OTHER LIQUID IN THE WATER
RESERVOIR
4.2. FILLING UP THE BOILER
When you turn the machine on for the first
time please carry out the following procedure to
refill the boiler:
1 Ensure that the two buttons on the right
15 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
hand side of the casing and the single
button on the left hand side are NOT
depressed. Push the buttons in with your
finger to ensure that they are not
depressed.
2 Plug in the mains cable to a suitable wall
socket. Turn on the wall socket.
3 Turn on the coffee machine by pressing in
the on/off button which is located on the
right hand side of the casing above the
water button.
4 Close the pod assembly by pushing the
gearlever away from you until it locks into
position.
5 Press in the water button and you will hear
the pump running. Wait until water starts to
come out of the spout (see also note
below).
6 Press the water button again to stop the
water flow.
7 The machine is now primed and ready for
use.
NOTE: If after a few seconds the pump is
running but no water appears at the spout, switch
off the machine and retry after a few minutes or
just open the steam release knob for a few instant
and retry.
ATTENTION: If you leave the machine turned
on without any water being present in the
boiler for a period of time it will cause
irreparable damage which is not covered by
the guarantee.
4.3. MAKING A CUP OF COFFEE
To make a cup of coffee with your Tonino
Lamborghini machine proceed as outlined below:
1. Before plugging the mains cable in ensure
that the two buttons on the right hand side
of the casing and the single button on the
left hand side are NOT depressed. Push the
buttons in with your finger to ensure that
they are not depressed.
2. Plug in the mains cable to a suitable wall
16 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
socket. Turn on the wall socket.
3. Now turn on the coffee machine by pressing
in the on/off button which is located on
the right hand side of the casing above the
water button. The on/off button has a circle
with the numeral ‘1’ inside the circle. Both
red LEDs will light up. The LED light on the
right hand side indicates that the machine is
‘on’ and remains lit all the time that the
machine is on. The LED light on the left
hand side indicates that the machine is
warming up and has not reached operating
temperature. The LED on the left hand side
will go off when the boiler has warmed up.
This usually takes a few minutes.
4. Pull the gearlever on the right hand side
towards you as far as it will travel to lower
the pod holder assembly and the spout.
Remove any used pod from the pod holder.
Remove a fresh coffee pod from its wrapper
and place it carefully onto the pod holder
above the spout. Ensure that the pod is
located centrally on the holder.
5. Close the pod holder assemblying by
pushing the lever away from you until you
feel some resistance. You now need to lock
the pod assembly by pushing the lever
further away from you until it will go no
further. Please ensure that you have locked
the pod holder assembly before you make a
cup of coffee.
6. Place a coffee cup on the machine under the
spout. It is recommended that you pre-heat
the coffee cup.
7. When the red LED light on the left hand side
of the machine has gone out this indicates
that the machine is ready to make coffee.
8. Press the water button (picture of cup and
saucer on it) which is located below the
on/off button on the right hand side of the
casing. The machine will now make a cup of
coffee.
9. Press the water button once more to stop
the flow of coffee from the spout. PLEASE
NOTE the machine does NOT stop
automatically and you must operate the
water button when you have made a cup of
17 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
coffee.
10.Remove the cup of coffee which is now
ready.
11.Pull the gearlever on the right hand side
towards you to release the pod assembly
and remove the used coffee pod.
Each coffee pod makes a single cup of coffee.
Once the machine has reached its normal
operating temperature the red LED light on the left
hand side of the machine will go out. After this you
can use the machine to make coffee. The LED light
may come back on again to indicate that the boiler
is re-heating but once you have made your first
cup you can continue to use the machine and do
not need to wait for the LED to go off if you are
using the water.
NOTE: Unwrap the pods just before using them to retain maximum freshness.
4.4. DISPENSING HOT WATER
The machine can be used to dispense hot
water for tea or other drinks. To dispense hot
water proceed as follows:
1 Turn on the machine and wait for the red
LED light on the left and side to go out to
indicate that the water in the boiler has
reached operating temperature (95°C)
2 Place the cup or container under the steam
arm.
3 Carefully open the steam release knob and
press the water button (NOT the steam
button)
4 When you have sufficient hot water press
the water button again to stop the water.
5 Fully close the steam release knob.
ATTENTION: When hot water is being
dispensed from the steam arm it will be very hot.
Avoid touching the metal arm and use the plastic
lug to move it around.
18 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
4.5. DISPENSING STEAM
The steam arm can also be used to froth milk
for capuccinos and to heat other drinks. Please see
next paragraph for details.
ATTENTION: Do not make steam for longer
than 30-60 seconds continuosly.
After steam production the boiler will re-fill
with water (See recommendation in Par.
5.1).
4.5.1. Using steam to heat up a drink
CAUTION: The steam arm WILL BE
EXTREMELY hot and you should move it by
using the plastic lug located half way down
the steam arm.
1 Push in the Steam button on the left hand
side of the machine
2 The red LED light next to the button will
come on
3 Wait until the red LED light goes off which
indicated that the water temperature in the
boiler has reached 125°C
4 Position the container under the steam arm.
5 Slowly open the steam release knob.
6 Close the steam release knob once the drink
has reached the desired temperature.
7 Push in the Steam button.
8 Wait for the steam arm to cool down before
cleaning it with a damp cloth (see par. 6.2)
ATTENTION: During the production of steam
the container that the liquid is in will become very
hot. It is therefore recommended that you use a
container with a handle so your hands do not touch
the side of the container. Metal containers should
be used where possible.
4.5.2. Using the steam to froth milk for Cappuccino.
Follow the steps below:
19 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
1. Follow the steps in Par. 4.3 to make
the coffee
2. Push in the Steam button on the left
hand side of the machine
3. The red LED light next to the button
will come on
4. Wait until the red LED light goes off
which indicated that the water
temperature in the boiler has reached
125°C
5. Fill 1/3 of the receptacle you want to
use to make cappuccino with milk as
the volume of the milk will expand.
6. Position the container under the steam
arm.
7. Immerse the steam nozzle into the
milk that you wish to froth and turn
the steam knob slowly anticlockwise.
Move the receptacle slowly up and
down to achieve uniform froth.
8. When you have sufficient froth turn the
steam knob fully clockwise to shut off
the steam supply.
9. Push in the Steam button.
10.Wait for the steam arm to cool down
before cleaning it with a damp cloth
(see par. 6.2).
After you push in the Steam Button to stop
generating steam there is a built in safety
device which will prevent the machine from
dispensing water until the boiler has refilled
and the temperature of the water has
dropped from 125 degrees back to 95
degrees. This is to prevent the machine from
burning the coffee whilst the temperature of
the water is too high (see par.5.1). Don’t
forget the Steam button depressed.
20 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 5 – PRECAUTIONS WHEN USING THE MACHINE
5.1. PRECAUTIONS WHEN DISPENSING STEAM
ATTENTION: In order to avoid damage to the
boiler please do not produce steam for
longer than 30-60 seconds without turning
off the steam release knob.
Always re-fill the boiler with water after
steam production (see par. 5.1.1.).
After producing steam, push the same button
again (so the button is no longer depressed).
NOTE: there is a built in safety device which
will prevent the machine from dispensing
water until the temperature of the water has
dropped from 125 degrees back to 95
degrees. This is to prevent the machine from
burning the coffee whilst the temperature of
the water remains too high.
5.1.1. Refilling water in boiler
After a prolonged use of dispensing steam it
may be necessary to refill the boiler with water.
To do this make sure the steam release knob
is fully closed and the steam button is off.
Wait 2-3 minutes to allow the temperature in
the boiler to drop from 125 to 95 degrees and then
push the water button which will start the pump
and this will re-fill the boiler.
NOTE: The water button will not work until
the temperature in the boiler has dropped after
dispensing steam.
NOTE: If you want to use the steam for long
periods of time then it is recommended that you
stop every max 60 seconds and refill the boiler
with water. This simple safeguard is necessary to
ensure that the boiler does not run dry.
21 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
The manufacturer will not be responsible for
damage caused as a result of not following the
guidelines above.
IMPORTANT: Do not forget that the machine
will not dispense water or make coffee when
the machine is in Steam mode. The
temperature in the boiler has to drop back
down to 95 degrees before the hot water will
resume.
22 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 6 – CLEANING & MAINTENANCE
In order to keep your machine in good working order we recommend that you
follow the procedures below. Always make sure that the machine is cold and
disconnected from the mains before carrying out these steps:
6.1. WATER & STEAM DRIP TRAYS
Empty the two plastic drip trays under the
drip tray grills. Wash the trays in water using a
mild detergent. We recommend this is done daily.
6.2. STEAM ARM
After using the steam function, wait for the
arm to cool down before cleaning the arm with a
damp cloth. Avoid using abrasive materials.
6.3. POD HOLDER FILTER
This is located on top of the pod holder above
where the spout enters the assembly. Very
carefully insert a flat screwdriver between the filter
and the body of the assembly being careful not to
damage the machine. Take the filter out and clean
it in water. To re-fit the filter place it back on top
of the pod holder making sure it is properly seated
and then slowly push the gearlever away from you
to lift up the pod holder assembly. Keep going until
the gearlever locks into position. You can now pull
the gearlever back. Check that the filter is properly
fitted.
NOTE: It is only necessary to clean the pod
holder filter periodically when you notice that the
coffee does not appear to be flowing freely or
when you notice a build up of residue on the filter.
You can clean the spout by pulling it out from
the pod holder assembly and rinsing it in water. To
re-fit put the spout back in the pod assembly push
it until the spout is fully engaged. Ensure that the
end of the spout is facing downwards.
6.4. CLEANING THE CHROMIUM-PLATED PARTS
Your Lamborghini coffee machine is supplied
23 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
with a Microfibre cloth for cleaning the external
chrome and polished steel surfaces. First clean the
parts with a damp sponge or wet cloth before
drying off with a soft cloth. Finally polish the parts
with the Microfibre cloth. The Microfibre cloth is
ideal for removing fingerprints. Do not use the
microfibre cloth on the black painted surfaces.
6.5. CLEANING THE PAINTED SURFACES
It is only necessary to use cold water and a
mild detergent to clean the sides of the coffee
machine.
However, please note:
1 When cleaning the machine keep the
machine out of direct sunlight and make
sure the temperature is below 30 degrees C.
2 Do not use steam from the machine to clean
the surfaces.
3 Use only mild detergents
4 Do not use abrasive materials that may
damage the paint
5 Clean a small section of the surface to start
with to ensure that there is no adverse
effect on the metal before cleaning the
whole machine.
6 After using a mild detergent always wash it
off with clean, cold water.
6.6. CLEANING THE WATER RESERVOIR
Periodically it is advisable to remove the
water reservoir from the machine and to wash it in
cold water. Do not use detergents to clean the
inside of the water reservoir. The water used in the
reservoir should be cold and ideally filtered or
bottled (still) water.
6.7. REPLACING THE POD ASSEMBLY RUBBER SEALING
RING
After making about 1000 cups of coffee it will
be necessary to replace the orange rubber sealing
ring above the pod holder assembly. Two spare
seals are supplied with the machine. (see par. 1.1).
To change the seal proceed as follows:
24 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
1 Turn the machine off and remove the mains
from the wall socket
2 Make sure the machine is cold
3 Using a small screwdriver carefully remove
the old ring.
4 Fit the new sealing ring centrally on the pod
holder (where the coffee pod normally sits)
5 Slowly close the pod holder assembly and
the new ring will be raised up and will fix
back in place. Make sure the ring is properly
fitted. If necessary, open and re-close the
pod holder assembly to push the ring fully
in.
6.8. DESCALING OF THE INTERNAL BOILER
Like all coffee machines the boiler and other
internal parts can suffer from a build up of scale
caused by limescale in the water. Hard water
areas are particularly prone to a build up of scale.
6.9. ANTI SCALE WATER FILTER
Your machine should be fitted with a anti
scale filter to reduce the build up of limescale in
the machine. The filter should be replaced at least
every 3 months.
25 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 7 - TROUBLESHOOTING
If you have a problem with your machine please look at the table below to see if
the issue is covered. If not, please contact the retailer who should be able to resolve
the issue.
7.1. PROBLEMS DESCRIPTION AND SOLUTIONS
Problem
Resolution
The machine will not switch on
Check that the machine is plugged into a
230-240 volt mains supply.
Pre-heat the coffee cup before use
The coffee is not hot enough
Coffee comes out very slowly from The pod holder filter may need cleaning
he spout
(see Par 6.3)
The spout may need to be cleaned out
(see Par 6.3)
The machine does not dispense
coffee through the spout.
Check that the pod assembly is properly
closed by pushing the gearlever as far
forward as you can. It should lock into
place.
If you have just finished using the steam
the boiler will need to cool down before
it can produce hot water for coffee.
Check that the steam button is not
pushed in. Again, allow the boiler to cool
down. This may take a few minutes.
If the problem persists contact the
retailer.
The pump can be heard working
Checking the level of the water in the
but the machine does not dispense reservoir and check that the water pipes
water.
are able to reach the bottom of the
reservoir.
Check that the water pipes are not
kinked.
Switch off the machine and retry after a
few minutes or just open the steam
release knob for a few instant and retry.
26 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
The boiler may need refilling (See Par.
7.2)
Also check the other answers given in
this table.
If the problem persists, contact your
retailer.
The machine does not dispense
water or steam
Check the previous point.
If you can hear the pump working
correctly then the boiler may require de-
scaling (after dispensing approx. 2,500
coffees depending on the hardness of
the water) In this case please contact
your retailer.
The pod holder leaks when
dispensing hot water to make
coffee.
The coffee in the pod may be too finely
ground or may be too big for the holder.
Alternatively, the coffee pod may not be
seated centrally in the coffee pod holder.
If you have already made a 1,000 cups
of coffee then the orange rubber sealing
ring may need to be replaced (see Par
6.7)
It takes a long time for the coffee The coffee pod may not be fresh. Try a
to come out and there is little
crema produced.
fresh coffee pod.
The boiler is scaled up and may require
descaling – Contact your retailer.
7.2. FILLING THE BOILER
After a long period of not using the machine
the boiler may need to be refilled. To do this
proceed as follows:
1 Fill the water reservoir and put the two
water pipes back in making sure that there
are no kinks in the pipes.
2 Close the pod holder assembly by pushing
the gearlever on the right hand side away
from you until it locks into position.
3 Connect the machine to an electric socket;
4 Turn on the machine and the red LED lights
will illuminate.
27 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
5 Straight away open up the steam release
knob and push the water button to activate
the pump.
6 When water starts coming out of the steam
arm close the steam release knob fully.
7 Now wait for water to start coming out of
the spout before pushing the water button
once more to stop the flow of water.
If the boiler is empty then this process can
take some time.
28 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 8 - TECHNICAL DATA
Technical data*
Nominal Voltage
Rated Power in Watts
230-240V - 50Hz
900W maximum
Average power consumption when
machine is in stand-by mode in Watts
Dimensions in mm. (HxLxD)
Weight in kilograms
<50W
335x250x330
11
Water reservoir capacity in litres
2.0
Environmental data
Operating Temperature
Relative humidity
10-40°C
30-90 %
*: The manufacturer reserves the right to
change the specification without prior notice.
29 – TONINO LAMBORGHINI EPS
Use and maintenance manual – Rev.01 - 07/2006
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
|