3.25 CU. FT. REFRIGERATOR
INSTRUCTION MANUAL
Model No.: OSDR325B1
To ensure proper use of this appliance and your safety, please read the
following instructions completely before operating this appliance.
Download from Www.Somanuals.com. All Manuals Search And Download.
NAMES OF THE PARTS
MODEL NO.: OSDR325B1
(1) Door, Freezer Section
(2) Temperature Control Box
(3) Interior Light Switch
(4) Shelf, Refrigerator Section
(5) Door, Refrigerator Section
(6) Crisper
1
2
3
(7) Leveling Leg
5
4
6
7
: Never touch the interior of the Freezer Section or frozen foods in the
compartment with wet hands as this could result in frostbite.
WARNING
SPECIFICATIONS - MODEL NO.: OSDR325B1
PRODUCT DESCRIPTION
MODEL NO.
Oster 2 Door Refrigerator
OSDR325B1
3.25 Cu. Ft.
CAPACITY
Height
Depth
19.5”
Width
19.1”
UNIT DIMENSIONS
(inches)
33.9”
NET WEIGHT (lbs.)
57.5 (lbs.)
2
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY INSTRUCTIONS
To reduce the risk of ꢀre, electrical shock,
or injury when using your refrigerator,
follow these basic precautions:
WARNING
•
•
•
Read all instructions before using the refrigerator.
DANGER or WARNING: Risk of child entrapment.
To avoid the possibility of child entrapment, please take the following precautions
before throwing out the refrigerator.
-
-
Remove all doors from the unit.
Leave the shelves in place so that children may not easily climb inside.
•
•
Never allow children to operate, play with, or crawl inside the refrigerator.
Refrigerants: All refrigeration products contain refrigerants, which under the
guidelines of federal law must be removed before disposal of product. It is the
consumer’s responsibility to comply with federal and local regulations when
disposing of this product.
•
•
Never clean refrigerator parts with ꢁammable ꢁuids. The fumes can create a ꢀre
hazard or explosion.
Do not store or use gasoline or any other ꢁammable vapors and liquids in the vicinity
of this or any other refrigerator. The fumes can create a ꢀre hazard or an explosion.
-Save these instructions-
INSTALLATION INSTRUCTIONS
Before Using Your Refrigerator
•
•
Remove the exterior and interior packing.
Before connecting the refrigerator to the power source, let it stand upright for approximately 4
hours. This will reduce the possibility of a malfunction in the cooling system from improper
handling during transportation.
•
Clean the interior surface with lukewarm water using a soft cloth. (Cleaning Your Refrigerator on page 8)
Installing Your Refrigerator
•
•
This appliance is designed to be free standing only, and should not be recessed or built-in.
Place your refrigerator on a ꢁoor that is strong enough to support the refrigerator when it is fully
loaded.
•
•
Allow 5 inches of space between the back and sides of the refrigerator, which allows the proper
air ventilation. Adjust the feet to keep the refrigerator level.
Locate the refrigerator away from direct sunglight and sources of heat (stove, heater, radiator, etc.).
Direct sunlight may aꢂect the acrylic coating and heat sources may increase electrical consumption.
Ambient temperature below 50°F (10°C) or above 85°F (29.4°C) will hinder the performance of this
appliance. This unit is not designed for use in a garage or any other outside installation.
Avoid locating the refrigerator in moist areas.
Plug the refrigerator into dedicated, properly installed-grounded wall outlet. Do not under any
circumstances cut or remove the third (ground) prong from the power cord. Any questions
concerning power and/or grounding should be directed toward a certiꢀed electrician or an
authorized service center. This unit is not designed to be installed in an RV or used with an inverter.
After plugging the appliance into a wall outlet, turn the unit on and allow the unit to cool down for
2-3 hours under before placing food in the refrigerator or freezer compartment.
•
•
•
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical Connection
WARNING
Improper use of the grounded plug can result in the risk of electrical shock. If the power cord is
damaged, have it replaced by an authorized service center.
This refrigerator should be properly grounded for your safety. The power cord of this refrigerator is equipped
with a three-prong plug which mates with standard three-prong wall outlets to minimize the possibility of
electrical shock.
Do not, under any circumstances, cut or remove the third ground prong from the power cord supplied.
This refrigerator requires a standard 115/120 Volt A.C. ~/60Hz electrical outlet with three-prong ground.
This refrigerator is not designed to be used with an inverter.
The cord should be secured behind the refrigerator and not left exposed or dangling to prevent
accidental injury.
Never unplug the refrigerator by pulling the power cord. Always grip the plug ꢀrmly and pull straight
out from the receptacle.
Do not use an extension cord with this appliance. If the power cord is too short, have a qualiꢀed
electrician or service technician install an outlet near the appliance. Use of an extension cord can
negatively aꢂect the performance of the unit.
If any problems with the appliance persist, please contact our Customer Service Department to consult with
a representative at 877-856-0202 or visit our website to request warranty service at www.mcappliance.com.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATING YOUR REFRIGERATOR
Temperature Control
•
•
Your refrigerator has one control for
regulating the temperature. The
temperature control is located on the top
center of the refrigerator compartment.
The ꢀrst time you turn the unit on, adjust
the temperature control knob to “7” and
run for at least 2 hours before putting
TEMPERATURE
CONTROL
7 IS COLDEST
15W MAX
foods inside. This will ensure the cabinet is thoroughly chilled before food is put in.
•
•
The range of the refrigerator temperature control is from position “1” the warmest to “7” the
coldest. Adjust the temperature control to the setting that best suits your needs. The setting of “4”
should be appropriate for home or oꢃce refrigerator use.
Turning the temperature control knob to “0” position stops the cooling cycle but does not shut oꢂ
the power to the unit.
NOTE:
•
•
If the unit is unplugged, loses power; you must wait 3 to 5 minutes before restarting the
unit. If you attempt to restart before this time delay, the refrigerator will not start.
Large amounts of food will lower the cooling eꢃciency of the appliance.
Do not place the foods on the air outlet, and leave spaces for air ꢁow.
If you choose to change the thermostat setting, adjust the thermostat control by one
•
•
•
increment at a time. Allow several hours for temperature to stabilize between adjustments.
The Freezer Compartment
•
•
•
This compartment is designed for the long-term storage of frozen food.
The storage life of frozen foods varies and the recommended storage time should not be exceeded.
Place frozen food into the freezer as quickly as possible after purchase. If there are instructions on the
packet, carefully follow these instructions regarding storage times.
When To Defrost
This unit is not designed to defrost automatically. In order to prevent damage to the interior liner of
the unit from excessive frost build-up, please manually defrost the unit every 3 months or when the ice /
frost is approximately 1/4” thick inside the freezer compartment.
How To Defrost
Defrost the freezer compartment when the ice / frost are approximately 1/4” thick or every 3 months,
whichever comes ꢀrst. Set the thermostat dial to “0” to defrost. Remove all contents from the freezer
compartment. Leave the freezer door open to allow accumulated ice/frost to melt. Remove large
pieces of ice as needed. Do not use hot water or other electric heating devices to melt the
accumulated ice. After defrosting, remove accumulated ice / water and wipe the freezer compartment
dry with a soft cloth. In the event that the ice is not visibly present in the freezer compartment, please
allow the evaporator located behind the freezer wall to completely defrost for approximately 2 hours
before restarting the unit. Restart the unit per starting instructions.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
CHANGING THE REVERSIBLE DOOR
CAUTION: To avoid personal injury to yourself and/or property, we recommend someone assist you
during the door reversal process.
•
•
Remove the top hinge cover. (See Fig. 1)
Using Phillips Head Screwdriver, loosen and remove the
screws holding the top hinge in place.
•
•
Remove top hinge and carefully lift off the
freezer door.
Remove the screw hole plugs from the
opposite side and insert the plugs in the
screw hole openings of the just removed
Fig. 1
.
screws.
•
Open refrigerator door and unscrew two
screws from the center hinge bracket
while holding the open door in place.
(See Fig. 2)
•
•
Remove bracket and lift off refrigerator door.
While doors are removed unscrew the door
stoppers and re-insert on opposite side of
door. (See Fig. 3)
• Remove the screw hole plugs from the
opposite side and insert the plugs in the
screw hole openings of the just removed
screws.
•
Remove any loose items in the refrigerator
and carefully tilt refrigerator and lean against
wall. Remove both leveling legs and place
in a secure area.
• Loosen the screws holding the lower hinge
bracket to the refrigerator door and remove
screws and bracket. Remove leveling leg.
Fig. 2
•
Remove screws from the other side and
insert in the previously removed screw
holes. Remove leveling leg.
•
Remove door pin by turning counter clockwise
and re-insert to the underside of the bracket
and tighten.
• Align bracket and insert 2 remaining
screws into the holes provided. Tighten
all the way. Replace leveling legs and
place refrigerator in upright position.
Fig. 3
•
Replace washers and cap over pin. Align hole to
the refrigerator door with the door pin and gently
push down until firm.
•
Insert pin from center hinge bracket into
refrigerator door hole and align center hinge
bracket holes to the screw holes in the cabinet.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
•
•
•
Insert 2 screws and tighten.
Place washers on the center hinge bracket pin and align the freezer door holes and insert into pin.
Replace screws on the top hinge cover, align door and tighten screws.
Replace top hinge cover.
•
Door Axis
Hole Cover
Hole Plugs
Middle
Hinge
Hole Plugs
Screws
Bottom
Hinge
Tall Leg
Screws
Tall Leg
Short Leg
Fig. 4
LIGHT BULB REPLACEMENT
•
Switch off power to refrigerator.
Gently pull out the clear cover.
•
•
•
Replace
with same type light bulb rated at 10 watts.
Push the clear cover back into place.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE AND MAINTENANCE
Cleaning Your Refrigerator
•
•
•
•
Upon installation of your new appliance, it is recommended that it be cleaned thoroughly.
Turn oꢂ the refrigerator ꢀrst and then unplug the unit from the wall outlet.
Remove all food content.
Wash the inside with a damp warm cloth soaked in lukewarm water and baking soda solution.
The solution should be about 2 tablespoons of baking soda to a quart of water.
Be sure to keep the door gasket (seal) clean to keep the unit running eꢃciently.
The outside of the refrigerator should be cleaned with mild detergent and warm water.
Dry the interior and exterior with a soft cloth.
•
•
•
Vacation Time
•
•
•
•
•
•
•
Turn oꢂ the refrigerator ꢀrst and then unplug the unit from the wall outlet.
Remove all the food.
Clean the refrigerator.
Leave the door open slightly to avoid possible formation of condensation, mold, or odor.
Use extreme caution in the case of children. The unit should not be accessible to child’s play.
Short vacations: Leave the refrigerator operating during vacations of less than three weeks.
Long vacations: If the appliance will not be used for several months, remove all food and unplug
the power cord. Clean and dry the interior thoroughly. To prevent odor and mold growth, leave
the door open slightly: blocking it open if necessary or have the door removed.
Moving Your Refrigerator
•
•
•
•
•
Turn oꢂ the refrigerator ꢀrst and then unplug the unit from the wall outlet.
Remove all the food.
Securely tape down all loose items inside your refrigerator.
Tape the doors shut.
Be sure the refrigerator stays in the upright position during transportation.
Energy Saving Tips
•
The refrigerator should be located in the coolest area of the room, away from heat producing
appliances or heating ducts, and out of the direct sunlight.
•
Let hot foods cool to room temperature before placing them into the refrigerator. Overloading the
refrigerator forces the compressor to run longer. Foods that freeze too slowly may lose quality, or
spoil.
•
•
Be sure to wrap foods properly, and wipe containers dry before placing them in the refrigerator.
This cuts down on frost build-up inside the refrigerator.
Organize and label food to reduce door openings and extended searches. Remove as many
items as needed at one time, and close the door as soon as possible.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
TROUBLESHOOTING GUIDE
You can solve many common refrigerator problems easily, saving you the cost of a possible
service call. Try the suggestions below to see if you can solve the problem before calling for
service.
P R OB L E M
Refrigerator does not operate.
P OS S IB L E C AUS E
- Not plugged in.
- The circuit breaker tripped or a blown fuse.
- The room temperature is hotter than normal.
- A large amount of food has been added to the
refrigerator.
Compressor turns on and oꢂ frequently.
- The door is opened too often.
- The door is not closed completely.
- The temperature control is not set correctly.
- The door gasket does not seal properly.
- The refrigerator does not have the correct
clearances.
- The refrigerator has recently been disconnected
for a period of time. 4 hours are required for the
refrigerator to cool down completely.
- Temperature control is set too warm. Turn the
control to a cooler setting and allow several hours
for the temperature to stabilize.
Temperature inside the refrigerator is too warm.
- Door is kept open too long or is opened too
frequently. Warm air enters the refrigerator every
time the door is opened. Open the door less
often.
- The door is not closed completely.
- The door gasket does not seal properly.
- A large amount of warm or hot food might have
been stored recently. Wait until the refrigerator
has had a chance to reach its selected
temperature.
- The refrigerator has recently been disconnected
for a period of time. 4 hours are required for the
refrigerator to cool down completely.
- Temperature control is set too cold. Turn the
control to a warmer setting and allow several
hours for the temperature to stabilize.
- The exterior refrigerator walls can be as much as
30οF warmer than room temperature. This is
normal while the compressor works to transfer
heat from inside the refrigerator cabinet.
- Metal parts undergo expansion and contraction,
as in hot water pipes. This is normal. Sound will
level oꢂ or disappear as refrigerator continues to
run.
Temperature inside the refrigerator is too cold.
Temperature of external refrigerator surface is
warm.
Popping or cracking sound when compressor
comes on.
Bubbling or gurgling sound, like water boiling.
Vibrations.
- Refrigerant (used to cool refrigerator) is
circulating throughout the system. This is normal.
- Check to assure that the refrigerator is on a level
surface.
- Floor is uneven or weak. Refrigerator rocks on
the ꢁoor when it is moved slightly. Be sure ꢁoor
can adequately support refrigerator. Level the
9
Download from Www.Somanuals.com. All Manuals Search And Download.
refrigerator by putting wood or metal shims under
part of the refrigerator.
The refrigerator is touching the wall. Re-level the
refrigerator and move it from the wall.
See “Installation Instructions”.
- Weather is hot and humid, which increases
internal rate of frost build-up. This is normal.
- Door is slightly open.
Moisture forms on inside refrigerator walls.
- Door is kept open too long, or is opened too
frequently. Open the door less often.
- The door is not sealed properly.
- Door is slightly open, causing cold air from inside
the refrigerator to meet warm moist air from
outside.
Moisture forms on outside of refrigerator.
The door will not close properly.
- The refrigerator is not on a level surface.
- The gasket is dirty.
- The storage basket is out of position.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
REFRIGERATOR WARRANTY
Unless otherwise prohibited, MC Appliance Corporation warrants each new Refrigerator to be free from
defects in material and workmanship, and agrees to remedy any such defect or to furnish a new part(s), at
the company’s option, for any part(s) of the unit that has failed during the warranty period.
Parts and labor expenses are covered on this unit for a period of one year from the date of purchase. In
addition, MC Appliance Corporation warrants the compressor (parts only) to be free from defects in material
and workmanship for a period of 5 years. The consumer is responsible for all labor and transportation
expenses related to the diagnosis and replacement of the compressor after the initial one-year warranty
expires. A copy of the dated sales receipt or invoice is required to receive warranty service or a
refund.
This warranty covers appliances in use within the continental United States, Puerto Rico, and Hawaii.
The warranty does not cover the following:
Damages due to shipping damage or improper installation.
Damages due to misuse or abuse.
Content losses due to failure of the unit.
Inside components such as door panels, door shelves, racks, light bulbs, etc.
Punctures to the evaporator system due to improper defrosting of the unit.
Repairs performed by unauthorized service agents.
Service calls that do not involve defects in material and workmanship as instructions on
proper use of the product, door reversal, or improper installation.
Replacement or resetting of house fuses or circuit breakers.
Failure of this product if used for other than for its intended purpose.
Disposal costs for any failed unit not returned to our factory.
Any delivery costs incurred as the result of a unit that fails to perform as specified.
Expenses for travel and transportation for product service if your appliance is
located in a remote area where service by an authorized service technician is not available.
The removal and reinstallation of your appliance if it is installed in an inaccessible location or
is not installed in accordance with published installation instructions.
Liability under this warranty is limited to repair, replacement, or refund. If a replacement unit is not
available or the unit cannot be repaired, liability is limited to the actual purchase price paid by the
consumer.
This warranty is non-transferable.
This warranty applies only to the original purchase and does not extend to any subsequent
owner(s).
This warranty is in lieu of all warranties expressed or implied and no representative or person is authorized to
assume for us any other liability in connection with the sale of this product. Under no circumstances is the
consumer permitted to return this unit to the manufacturer without prior written consent from MC Appliance
Corporation.
Model
Parts
Labor
Compressor (Part Only)
Type of Service
OSDR325B1 One-Year
One-Year
Five-Years
Carry In
request warranty service or order parts.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
© 2012 Sunbeam Products, Inc. doing business as Jarden Consumer Solutions. All rights reserved.
Oster is a registered trademark of Sunbeam Products, Inc. used under license.
Distributed by MC Appliance Corporation, 777 Mark Street, Wood Dale, IL 60191
MCP042712
Download from Www.Somanuals.com. All Manuals Search And Download.
|