MWDF-1130#66237 10/25/01 2:36PM Page1SallyMercury:65946Metalwarebooks:66237:
Electric Deep Fryer
with 1500 watts and
cool touch exterior
Deep Fryer
Use/Care and Recipe Guide
Model DF-1130
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page3SallyMercury:65946Metalwarebooks:66237:
I M P O R T A N T S A F E G U A R D S
When using electrical appliances, basic safety precautions should always be followed including the following:
1. READ ALL INSTRUCTIONS BEFORE USING APPLIANCE.
2. DO NOT USE WITH AN EXTENSION CORD. Use of this 1500-WATT fryer on the same circuit or fuse with other
electrical products or appliances may trip a 15-amp circuit breaker or blow a 15-amp fuse. NEVER replace the
fuse with one rated higher than the capacity of the circuit. Doing so could result in an
electrical fire.
3. Hot oil can cause very serious burns. The appliance is hot during operation and retains heat for some time after
being switched off. Do not touch hot surfaces such as oil reservoir and metal surface.
4. To protect against electrical shock, do not immerse the Main Body or the Breakaway Cord™ in water
or other liquids
5. This appliance is not for use by children. Close supervision is necessary when any appliance is used near children.
6. Do not operate unattended, and never leave the appliance unattended when connected to the power outlet.
7. Always attach Breakaway Cord™ to appliance first, then plug cord in wall outlet. To disconnect, turn the
switch to OFF, then remove plug from wall outlet.
8. Unplug the appliance from power outlet after use, and before filling and emptying. Detach Breakaway Cord™
from appliance before cleaning.
9. Do not operate any appliance with damaged cord or plug or after the appliance malfunctions or has been
damaged in any manner. Return appliance to NESCO Factory Service Department for examination, repair or
adjustment.
10. Only use accessory attachments recommended by the manufacturer.
11. Do not use outdoors.
12. Do not let the cord hang over the edge of a table or counter, or touch hot surfaces.
13. Do not place on or near a hot gas or electric burner or in a heated oven.
14. DO NOT MOVE THE DEEP FRYER WHEN OIL IS HOT OR DURING COOKING. ALLOW OIL TO COOL BEFORE
MOVING THIS APPLIANCE.
15. Do not use the appliance for other than intended use, as described in this manual.
16. Always keep lid closed while deep fryer is frying foods. Use Basket Handle to raise and lower Basket. BEWARE OF
STEAM WHEN OPENING LID.
17. Wet food should be dried first with paper towels. Remove loose ice from frozen food. Close the lid when frying.
Beware of oil spattering when food is put into the oil.
18. Never obstruct the air outlet vent on top of the lid with any objects and beware of the hot steam coming from the
air outlet vent.
19. Keep appliance at least 4 inches away from walls or other objects during operation. Do not place any objects on
top of appliance while it is operating.
20. Be sure oil reservoir is filled with oil to at least the ‘MIN’ (minimum) oil marking level. Do not fill above ‘MAX’
(maximum). Do not operate appliance without oil or with an insufficient amount of oil. Never pour oil into
heated reservoir.
21. Do not operate this appliance if the lid and the reservoir are not COMPLETELY DRY. Refer to the Cleaning
Instructions for the best draining position of the lid.
CAUTION: To prevent damage to countertop or tabletop finish, place non-flammable, non-
burnable, heat resistant coaster or placemat between the appliance and the countertop or
tabletop surface. Never place on carpet, furniture, or other combustible materials.
S A V E T H E S E I N S T R U C T I O N S
THIS APPLIANCE IS FOR HOUSEHOLD USE ONLY
DF-1130 Deep Fryer
3
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page4SallyMercury:65946Metalwarebooks:66237:
S A V E T H E S E I N S T R U C T I O N S
THIS APPLIANCE IS FOR HOUSEHOLD USE ONLY
Short Cord Instructions
CAUTION: A short power supply cord is provided to reduce the risk of personal injury resulting from becoming
entangled in or tripping over a long cord.
Breakaway Cord™ and Polarized Plug
This appliance features a patented Breakaway Cord™ and polarized plug (one blade is wider than the other). The
Breakaway Cord™ is designed to quickly disconnect from the appliance when a pulling force is applied. To reduce
the risk of electric shock, a polarized plug is featured. This plug is intended to fit into a polarized outlet only. If the
plug does not fit into the outlet, reverse the plug. If it still does not fit, contact a qualified electrician.
Do not attempt to modify the plug.
Electric Power
If the electrical circuit is overloaded with other appliances, your appliance may not operate. It should be
operated on a separate electrical circuit from other appliances. If you are not sure of the reason of
overloading or cannot find a separate circuit, contact a qualified electrician.
Get To Know Your Nesco DF 130 Deep Fryer :
Item Description
1
2
3
4
5
6
7
8
9
Main body
Oil reservoir
Lid
Red indicator light
Green indicator light
Temperature control knob
Lid button
Connector box
Air outlet vent / filter
10 Connector
11 Embedded heating element
12 Patented Breakaway Cord™
12
DF-1130 Deep Fryer
4
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page5SallyMercury:65946Metalwarebooks:66237:
Directions For Use:
1. This appliance is designed for household and indoor use only. It is not intended for commercial use.
2. Before fryer is used the first time, remove all packaging materials and follow cleaning instructions in this book.
3. Open Lid by pressing one of the Lid Buttons on front of unit.
4. Remove basket by pushing handle button and lifting up on handle.
5. Pour good quality vegetable, corn, canola, soybean, or peanut oil into the reservoir until it reaches between the
‘MIN’ and ‘MAX’ marks inside reservoir (approximately 2 to 2-1/2 quarts). DO NOT OVER OR UNDER FILL.
6. Close lid of fryer.
7. Attach Breakaway Cord™ to appliance, then plug into standard 120V AC electrical outlet.
8. Rotate Temperature Control Knob to set the desired temperature. The red light will turn on and oil will heat.
When set temperature is reached the red light will turn off and your fryer is ready for cooking. If the red light
turns back on, oil temperature has dropped and is being reheated back up to desired temperature.
9. Open lid and place food, which should be as dry as possible, into basket.
10. Lower basket gently into oil (BEWARE OF OIL SPLATTERING) and close lid.
11. When cooking is finished OPEN LID CAREFULLY TO AVOID ESCAPING STEAM and raise basket onto hook to
allow food to drain for 10-20 seconds before serving. NOTE: To maintain oil quality, do not add salt or spices to
the food until after it has been removed from the fryer.
12. When cooking is finished, shut down fryer by rotating temperature control knob to position ‘O’ and press Main
Switch OFF. Unplug the Breakaway Cord™ from the wall outlet before detaching from the appliance.
Cleaning Instructions
1. Always unplug appliance, detach the Breakaway Cord™ and let the oil cool down to room temperature
before cleaning.
2. Open lid by pressing one of two release buttons on front of unit. Remove lid by pulling upwards while it is open.
3. Lift out basket.
4. Carefully lift Oil Reservoir out by holding the edges and pour oil into suitable container.
5. The Oil Reservoir is fully immerseable but must only be washed by hand. Basket and Lid are dishwasher safe.
6. Never immerse Body of fryer into water or other liquids. Clean Body with a damp cloth, containing mild soap
solution or plain water.
7. Ensure that Lid and Oil Reservoir are completely dry after
washing and before use. See diagram for the best
draining position of Lid.
8. After cleaning, reassemble the Oil Reservoir, Basket, and
Lid to the fryer. Make sure the Oil Reservoir seats properly
into the body or the fryer will not operate.
DF-1130 Deep Fryer
5
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page6SallyMercury:65946Metalwarebooks:66237:
Helpful Hints
• When cooking foods dipped in fresh batter, lower basket first. Using tongs, add food directly to oil. Use basket to
lift out food when finished cooking.
• Fill the basket no more than half full for best results. This helps maintain the oil temperature for better cooking
results.
• Sort or cut food into uniform pieces. All the food will then be cooked in the same amount of time.
• To reduce splattering, remove excess moisture or ice from the food.
• Store oil in the oil reservoir for only a limited time. When oil has cooled to room temperature, pour into a
suitable container with lid and refrigerate.
• For best results, change oil in fryer after a maximum of ten uses.
Troubleshooting
PROBLEM
CAUSE
SOLUTION
Fryer not operating
Oil Reservoir not seated
Not plugged in
Reinsert Oil Reservoir
Insert plug into outlet
Outlet not energized
Check fuses or circuit breaker
Oil spills out
Oil Reservoir over filled
Too much water in food
Food batches too large
Remove excess oil
Dry food with toweling
Use less food per basket
Food greasy or not crisp
Unpleasant smell
Food batches too large
Oil temperature too low
Using wrong type of oil
Use less food per basket
Increase temperature
Use good vegetable oil
Oil not fresh
Replace oil
DF-1130 Deep Fryer
6
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page7SallyMercury:65946Metalwarebooks:66237:
Deep Frying Chart—1500 WATTS
BREADED FROZEN
ITEM
WEIGHT / SIZE
10 oz.
SUGGESTED TIME/TEMP.
1-1/2 – 2 minutes / 350° F.
2 – 4 minutes / 375° F.
3 minutes / 350° F.
Chicken Nuggets
Chicken Strips
Fantail Shrimp
Jalapeno Poppers
Egg Rolls
15 oz.
13 oz.
8 oz.
4-1/2 minutes / 350° F.
8 – 9 minutes / 350° F.
3 – 5 minutes / 375° F.
1-1/2 – 2 minutes / 375° F.
2 oz.
French Fries (regular cut)
Onion Rings
16 oz.
8 oz.
FRESH OR FROZEN PRE-COOKED
ITEM
WEIGHT / SIZE
SUGGESTED TIME/TEMP.
3 minutes / 350° F.
Shrimp
Large
FRESH OR FROZEN THAWED
ITEM
WEIGHT / SIZE
SUGGESTED TIME/TEMP.
1 minute / 350° F.
Shrimp
Large
Beef Tips
Egg Rolls
Cornish Hen
2-inch diameter, 1 lb.
4 minutes / 350° F.
6 minutes / 350° F.
15 minutes / 350° F.
4
1 lb.
FRESH REFRIGERATED TEMP.
ITEM
WEIGHT / SIZE
SUGGESTED TIME/TEMP.
8 – 10 minutes / 375° F.
15 minutes / 350° F.
10 minutes / 350° F.
4 minutes / 350° F.
Boneless Chicken Breast
Bone-in Chicken Thigh
Chicken Drumstick
Beef Tips
1/2 lb.
3/4 lb.
2 lbs.
2-inch diameter, 1 lb.
Cornish Hen
1 lb.
1 lb.
15 minutes / 350° F.
15 minutes / 350° F.
Turkey Breast (boned)
DF-1130 Deep Fryer
7
Download from Www.Somanuals.com. All Manuals Search And Download.
R E C I P E S
Stuffed Turkey Breast
1 (2 lb.) turkey breast (bone-in)
1/2 red bell pepper, strips
1 onion
1/2 cup Italian herb bread crumbs
salt
Debone breast and strip out tendon of the tenderloin.
Lay open and score internal meat to spread breast out flat.
Place 2-3 red pepper strips and onion strip in center and roll up.
Tie roast together with baking string.
DF-1130 Deep Fryer
8
MWDF-1130#66237 10/25/01 2:36PM Page9SallyMercury:65946Metalwarebooks:66237:
Cheese Puff Appetizers
1 small package puff pastry sheets
1 head bok choy leaves
6 mini Babybel cheeses
1/2 cup butter, melted
Wrap each mini Babybel cheese in bok choy leaf by folding and rolling.
Place one wrapped cheese on buttered pastry sheet. Roll up, folding sides in.
Roll up on two more buttered sheets.
Fry 3-4 minutes until golden brown.
MAKES:
6
Prep. Time: 15 minutes
Fry Time: 3-4 minutes
Fry Temp: 375° F.
Beef and Bean Enchilada
1 lb. beef tips, diced 1/2-inch
1 (8-oz.) can refried beans
1 cup salsa
6 (6-inch) flour tortillas
1 (8-oz.) can green salsa or enchilada sauce
1 cup cheddar cheese, shredded
Fry beef tips until just brown (approximately 1 minute on 350° F.). Remove and dry on paper towel.
Mix beans and salsa in medium microwavable bowl and microwave for 2 minutes.
Add beef tips to beans and mix.
Warm tortillas in microwave for 1 minute.
Remove 1 tortilla at a time, placing 1/2 cup bean mixture in center of tortilla, then rolling it up.
Place fold side down on baking pan.
Repeat process using six tortillas. Cover with green sauce and cheese before broiling until cheese is melted and edges
of tortilla are browned, approximately 5 minutes.
SERVES:
4-6
OPTIONAL: Make sopapillas with remaining tortillas. Mix 1 tsp. cinnamon with 1/2 cup sugar in a large, zipped
plastic bag. Cut tortillas in quarters and fry each batch for 1 minute, until puffy pillows form. Remove
from fryer and shake in sugar bag. Serve hot with honey.
TIP:
Warm tortillas by folding up in a slightly damp, clean kitchen cloth before microwaving.
Prep. Time: 5 minutes
Fry Time: 1 minute
Fry Temp: 350° F.
DF-1130 Deep Fryer
9
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page10SallyMercury:65946Metalwarebooks:66237:
Portabella Mushrooms
6 whole portabella mushrooms
2 eggs, beaten
1 cup Italian style bread crumbs
1 tsp. seasoned salt
1/2 cup cheddar cheese
Beat eggs in a shallow bowl. Use a plate for the bread crumbs and salt mixture.
Remove stems from mushrooms and place each whole mushroom in egg,
allowing to sit several minutes on each side.
Put mushrooms on plate of crumbs, covering completely with the crumbs.
Fry at 350° F. for 2 minutes until slightly soft and golden brown.
Sprinkle cheese on “gill” side of mushrooms and allow to melt.
SERVES:
TIP:
4
Any cheese or mix of cheese is nice on mushrooms, especially grated parmesan.
Prep. Time: 5 minutes
Fry Time: 2-4 minutes
Fry Temp: 350° F.
Shrimp Egg Rolls
1 cup red bell pepper, diced
2 green onions, diced
24 shrimp, precooked, medium size, and chopped
1 cup bok choy, shredded
1/4 cup sweet and sour sauce
1 Tbs. soy sauce
1 tsp. peanut oil
1 tsp. corn starch
1 Tbs. ginger, peeled and grated
10 egg roll skins
Mix all ingredients (except egg roll skins) together in a medium bowl.
Roll up egg rolls by placing 2 heaping tablespoons of ingredients diagonally across the skin.
With the corner closest to you, lift and roll it around ingredients while tucking in both corners
from sides as you roll.
Using 1 beaten egg or a little water, brush last corner (away from you) and finish rolling.
This seals the egg roll. Repeat process until all ingredients are used.
Fry five rolls at a time on 350° F. for 6 minutes, until golden brown
SERVES:
5-6
OPTIONAL: Egg roll skins typically come in packages of 20. Just double the recipe if using entire package.
TIP:
Egg rolls can be frozen before frying. Place on waxed paper baking sheet and cover with plastic to
freeze. Once frozen, put in freezer storage bag. Fry from frozen state approximately 8 minutes.
Prep Time: 10 minutes
Fry Time: 12 minutes total
Fry Temp: 350° F.
DF-1130 Deep Fryer
10
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page11SallyMercury:65946Metalwarebooks:66237:
O N E Y E A R L I M I T E D W A R R A N T Y
This appliance is warranted for one year from date of original purchase against defects in material and workmanship.
This warranty does not cover transportation damage, misuse, accident or similar incident. This warranty gives you
specific legal rights and you may have other rights, which vary, from state to state.
Your new NESCO® Deep Fryer comes equipped with numerous safety features. Any attempt to interfere with the
operation of these safety features makes this warranty null and void. In the event we receive a Deep Fryer for service
that has been tampered with, we reserve the right to restore it to its original state and charge for the repair.
Defective products may be returned, postage prepaid, with a description of the defect to: The Metal Ware Corporation,
1700 Monroe Street, Two Rivers, Wisconsin 54241 for no charge repair or replacement at our option.
Service and genuine NESCO® replacement parts may be obtained from the NESCO® FACTORY SERVICE DEPARTMENT.
For service in warranty, follow instructions set forth in warranty. When ordering new parts, make sure that you always
mention the model number of the product, which is found on the back of the Unit.
About Your Warranty and Service Satisfaction
One simple step sets you on the road to complete customer satisfaction:
Mail in your warranty card and file your NESCO® Deep Fryer’s Exclusive registration number now!
Your serial number and Deep Fryer Model are located on the bottom of the Control Box.
We enter this number into our database. It registers your warranty and identifies your Deep Fryer specifically by its
individual code. Should you call our 800 toll free line, your registration number helps us identify your appliance and
speeds up our assistance to you.
Five Easy Steps to Satisfaction
Should you have a problem with your NESCO® Deep Fryer, please refer to these steps for assistance:
1. Call us on our toll free number, 1-800-288-4545 and tell us about your problem.
2. If we instruct you to send us all or part of your appliance for repair or replacement, the Customer Satisfaction
representative will give you an authorization number (this number notifies our receiving department to expedite
your repair). Pack your unit carefully in a sturdy carton to prevent damage because any damage caused by
shipping is not covered by the warranty.
3. Print your name, address and authorization number on the carton.
4. Write a letter explaining the problem. Include the following: Your name, address, telephone number and a copy
of the original bill of sale.
5. Attach the sealed envelope containing the letter inside the carton. Insure the package for the value of the NESCO®
Deep Fryer and ship prepaid to:
The Metal Ware Corporation
1700 Monroe Street
Two Rivers, WI 54241
DF-1130 Deep Fryer
11
Download from Www.Somanuals.com. All Manuals Search And Download.
MWDF-1130#66237 10/25/01 2:36PM Page12SallyMercury:65946Metalwarebooks:66237:
1-800-288-4545
© 2001, The Metal Ware Corporation
66237
Download from Www.Somanuals.com. All Manuals Search And Download.
|