STAINLESS STEEL BUILT-IN GAS GRILL
MODEL #s: 740-0165 (LP) / 750-0165 (NG)
LOWE’S ITEM #s: 144510/157618
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated.
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE
Download from Www.Somanuals.com. All Manuals Search And Download.
SAFETY INSTRUCTIONS
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS
SAFETY SYMBOLS
WARNING
CAUTION
Hazardous or unsafe practices that
could result in severe personal injury or
death.
Hazardous or unsafe practices that
could result in minor personal injury.
COMMON CAUTIONS AND WARNINGS
INSECT WARNING
WARNING
Spiders and insects can nest inside the burners of
this and other grills, which could disrupt gas flow.
This dangerous condition could cause a fire
behind and beneath the valve panel, damaging the
grill and making it unsafe to operate.
Do not use the grill if gas odor is present. Contact
customer service at 1-800-554-5799.
Inspect the grill at least twice a year.
WARNING
Do not try lighting this appliance without first
reading the “LIGHTING INSTRUCTIONS” section
of this manual.
ELECTRICAL GROUNDING WARNING
The rotisserie motor should be plugged directly
into a properly grounded receptacle.
WARNING
If you smell gas:
Do not cut or remove the grounding prong from
this plug.
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your
gas supplier or your fire department.
Keep the rotisserie motor electric cord away from
the heated surfaces of the grill.
When not in use, remove and store the motor in a
dry location.
LP GAS CYLINDER WARNING
The LP Gas Cylinder must be fitted with an Overfill
Protection Device (OPD).
WARNING
Cylinder must be stored outdoors out of the
reach of children and must not be stored in a
building, garage or any other enclosed area.
For Your Safety:
1. Do not store spare LP-gas cylinders under or
near this appliance.
2. Never fill the cylinder beyond 80 percent
capacity.
3. If the information above is not followed exactly,
a fire resulting in death or serious injury could
occur.
1
Download from Www.Somanuals.com. All Manuals Search And Download.
SAFETY INSTRUCTIONS
CAUTION
WARNING
Before cleaning make sure the burners are
cool, and the gas supply and knobs are in the
“OFF” position.
Do not attempt to use damaged or obstructed
equipment. See your local LP gas dealer for
repair.
CAUTION
WARNING
Failure to ensure proper placement of the
burner over the valve assembly can cause a
fire to occur behind and beneath the valve
panel, thereby damaging the grill and making
it unsafe to operate.
Do not install this unit into combustible
enclosures. There should be a minimum
clearance of at least 24 in. from all sides to
combustible materials.
WARNING
WARNING
Do not use the grill until all connections have
been checked and do not leak.
Storage of an outdoor cooking gas
appliance indoor is permissible only if the
cylinder is disconnected and removed from
the outdoor cooking gas appliance.
Do not smoke while leak testing.
Never leak test with an open flame.
Model 750-0165 Natural gas Grill
WARNING
Always check for leaks after every LP tank
change.
WARNING
1. The outdoor cooking gas appliance and its
individual shutoff valve must be disconnected
from the gas supply piping system during any
pressure testing of that system at test pressure in
excess of ½ psi (3.5 kpa).
CAUTION
Burner adjustments should only be
performed after the burners have cooled.
2. The outdoor cooking gas appliance must be
isolated from the gas supply piping system by
closing its individual manual shutoff valve during
any pressure testing of the gas supply piping
system at test pressures equal to or less ½ psi
(3.5 kpa).
CAUTION
Do not leave the grill unattended while
cooking.
Model 740-0165 LP Gas Grill
CAUTION
Remove the warming rack when using the
rotisserie burner. High heat from the burner
may cause the warming rack to bend.
WARNING
1. Do not store spare LP gas cylinders
under or near this appliance.
2. Never fill the cylinder beyond 80 percent
capacity.
WARNING
While lighting, keep your face and body as far
from the grill as possible.
3. If the information above is not followed
exactly, a fire resulting in death or
serious injury could occur.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
SAFETY INSTRUCTIONS
WARNING
Do not try lighting this appliance without first reading
the “LIGHTING INSTRUCTIO
When using the grill, do not touch the grill rack,
burner grate or immediate surroundings as these
areas become extremely hot and could cause
burns. Use only dry potholders. Moist or damp
potholders on hot surfaces may cause steam burns.
Do not use a towel or bulky cloth in place of
potholders. Do not allow potholders to touch hot
portions of the grill rack.
Grease is flammable. Let hot grease cool before
attempting to handle it. Do not allow grease
deposits to collect in the grease tray at the bottom
of the grill’s firebox. Clean the grease tray often.
GRILL SPECIFICATIONS
Description
740-0165 and 750-0165
Cutout Width
38 3/4 in. (98.43 cm)
21 3/4 in. (55.25 cm)
10 7/8 in. (27.63 cm)
Cutout Depth
Cutout Height
Natural Gas: Standard residential 1/2 in. (1.3 cm) ID gas service
line. Natural gas hose/regulator assembly included with quick-
connect fitting for attachment to house natural gas line.
Gas Requirements
Liquid Propane: Supplied with hose/regulator assembly for
connection to standard 5 gal, 20 lb. liquid propane gas cylinder
with Type 1, QCC-1 connection.
4 Cast brass main burners. Infra-red rear rotisserie burner.
1 Sear burner.
Grill Burners
BTU Ratings
Main burners 52,000 BTU/Hr.
Rear burners 16,000 BTU/Hr.
Sear burners 23,000 BTU/Hr.
Total
91,000 BTU/Hr.
Approximate Shipping
Weight
196 lbs.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
ISLAND CONSTRUCTION
A minimum of 3 in.(7.62cm) 1 o-7()5i2f
to non-combustible material.
10 7/8 in.(27.63cm)
WARNING
5 in.(12.70cm)
Do not install this unit into combustible enclosures.
There should be a minimum clearance of at least
24 in.(60.96cm) from all sides to combustible
materials.
Island cutout dimensions for Jenn-Air 4 burner + 1 Sear Burner LP and NG built-in grills:
Width
Depth
Height
38 3/4 in. (98.43 cm)
21 3/4 in. (55.25cm)
10 7/8 in. (27.63 cm)
6
Download from Www.Somanuals.com. All Manuals Search And Download.
FRONT VIEW FOR BUILT-IN OPENING
8 in.(20.32cm)
6 in.(15.24cm)
38 1/4 in.(97.16cm)
400
300
500
700
200
15
10
50
0
25
30
350
0
200
0
0
600
¡
Cã
100
¡
Fã
3 in.(7.62cm)
1 7/8 in.(4.76cm)
The following are minimum dimensions necessary to install the 4 burner + 1 sear burner built-in grills:
Width of grill head: 38 1/4 in.
Depth for grill control panel: 10 7/8 in.
Combustion Gap below control panel: 1 7/8 in.
ƒ
ƒ
A minimum of 6 in. clearance is needed from the right side of the grill firebox to non-combustible
materials. The rotisserie motor is located on the left side of the grill firebox.
A minimum of 8 in. clearance is required between the grill lid and any surrounding material to
allow for proper functioning of the rotisserie motor.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
SIDE VIEW FOR BUILT-IN OPENING
A minimum of 7.875 in.(20.00cm) is
required between the back of the grill
and any non-combustible material.
A minimum of 24 in.(60.96cm)is
required between the back of the grill
and any combustible material.
26 3/8 in.(66.99cm)
24 3/4 in.(62.87cm)
To ensure proper combustion.1 7/8 in.(4.76cm)
space is needed between the bottom of the
qrease tray andthe island material.
The following are minimum clearances necessary around the Jenn-Air built-in 4 burner +1 sear burner grills:
Rear Clearance: 3 in. to non-combustible materials
24 in. to combustible materials
Combustion gap below control panel: 1 7/8 in.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
BATTERY INSTALLATION
1. To install the battery, remove the ignition button housing.
2. Insert the battery into the housing with the positive terminal facing outward.
3. Replace the ignition button housing after the battery has been installed (See the image
below).
9
Download from Www.Somanuals.com. All Manuals Search And Download.
LP GAS HOOK-UP
Only the pressure regulator and hose assembly
supplied with the grill should be used. Any
replacement pressure regulator and hose assembly
must be specified by the grill manufacturer.
LP GAS HOOK-UP
Make sure the black plastic grommets on the LP
cylinder valve are in place, and the hose does not
come into contact with the grease tray or grill head.
This is a liquid propane configured grill. Do not
attempt to use a natural gas supply.
LP GAS SUPPLY CYLINDER CONNECTION
Your grill is equipped with gas supply orifices for
use only with liquid propane gas. It is also equipped
with a high capacity hose/regulator assembly for
connection to a standard 20lb. LP cylinder (18-1/4
in. high, 12-1/4 in. diameter).
Total gas consumption (per hour) of 740-0165 grill
with all burners on “HI”:
Main burners
Rotisserie burner
Sear Burner
Total
52,000 BTU/Hr.
16,000 BTU/Hr.
23,000 BTU/Hr.
91,000 BTU/Hr.
To connect the L.P. gas supply cylinder:
1. The tank valve should be in the “OFF” position.
If not, turn the knob clockwise until it stops.
2. Make sure the tank valve has the proper type 1
connection external male threads per
ANSIZ21.81.
The installation of this appliance must conform with
local codes or, in the absence of local codes, to the
national fuel gas code, ANSI Z223.1. Installation in
Canada must be in accordance with the Standard
CAN/CG A-B149.2 (installation code for gas
burning appliances and equipment) and local
codes.
3. Make sure all burner valves are in the “OFF”
position.
4. Inspect the valve connections, the port and
regulator assembly. Look for damage or debris.
Remove debris, and inspect hose for damage.
5. When connecting the regulator assembly to the
tank valve, use your hand to tighten the nut
clockwise until it stops. Use of a wrench may
damage the quick coupling nut and result in a
hazardous condition.
6. Open the tank valve fully by turning the valve
counterclockwise.
7. Before lighting the grill, use a soap and water
solution to check all the connections for leaks.
LP GAS CYLINDER REQUIREMENTS
(20lb. Cylinder)
A dented or rusty LP gas cylinder may be
hazardous and should be checked by your LP
supplier. Never use a cylinder with a damaged
valve. The LP gas cylinder must be constructed and
marked in accordance with the specifications for LP
gas cylinders of the U.S. Department of
Transportation (DOT), or the National Standard of
Canada, CAN/CSA-B339, Cylinders, Spheres and
Tubes for Transportation of Dangerous Goods; and
Commission.
The 20lb. cylinder must be provided with a shut off
valve terminating in an LP gas supply cylinder valve
outlet specified, as applicable, for connection type
QCC1 is the standard for compressed gas cylinder
valve outlet and inlet connection ANSI/CGA-V-1.
The cylinder supply system must be arranged for
vapor withdrawal. The cylinder must include a collar
to protect the cylinder valve.
Manifold pressure: (operating): 10 in. water column
(W.C.), (non-operating): 11.2 in. water column
(W.C.).The LP gas cylinder must be fitted with an
Overfill Protection Device (OPD).
PROPANE REGULATOR HOOK-UP
1. Attach the regulator to the propane cylinder by turning the regulator handle clockwise.
2. Turn off the gas supply at the cylinder when the appliance is not in use.
g
11
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION OF NATURAL GAS REGULATOR
1. The Natural Gas regulator has been factory installed. Attach the PVC gas hose to the
regulator (see drawing below).
2. Adjust the brass elbow so that it is pointing down.
3. Connect the other end of the PVC gas hose to the house gas line using the
quick-connect fitting.
Maintain 1 3/4 in. gap
12
Download from Www.Somanuals.com. All Manuals Search And Download.
NATURAL GAS HOOK-UP XXXXXXXXXXXXXXXXXXXXXXXX
Only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement
pressure regulator and hose assembly must be specified by the grill manufacturer.
The installation of this appliance must conform with the local codes or, in the absence of local codes, to
the national fuel gas code, ANSI Z223.1.
Total gas consumption (per hour) of the 750-0165 grill with all burners on the “HI” setting:
Main burners
Rear burner
Sear burner
Total
52,000 BTU/Hr
16,000 BTU/Hr
23,000 BTU/Hr
91,000 BTU/Hr
13
Download from Www.Somanuals.com. All Manuals Search And Download.
LEAK TESTING XXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXX
GENERAL
Although all gas connections on the grill are leak
tested at the factory prior to shipment, a complete
gas tightness check must be performed at the
installation site. Periodically check the whole
system for leaks following the procedures listed
below.
Only those parts recommended by the
manufacturer should be used on the grill.
Substitutions will void the warranty.
GAS FLOW CHECK
Each grill burner is tested and adjusted at the
factory prior to shipment. However, variations in the
local gas supply may make it necessary to adjust
the burners.
If the smell of gas is detected at anytime you should
immediately check the entire system for leaks.
BEFORE TESTING
Flames should be blue and stable with no yellow
tips, excessive noise or lifting.
Make sure all packing materials have been
removed from the grill, including the burner tie-
down straps.
If any of these conditions exist, first check to see if
the burner is blocked by dirt, debris, spider webs,
etc.
WARNING
Do not use the grill until all connections have
been checked and do not leak.
It is handy to keep a spray bottle of soapy water
near the shut-off valve of the gas supply line. Spray
all the fittings. Bubbles indicate leaks.
Do not smoke while leak testing.
Never leak test with an open flame.
Disconnected liquid propane cylinders must have
threaded valve plugs tightly installed, and must not
be stored in a building, garage or any other
enclosed area.
Make a soap solution of one part liquid detergent
and one part water. You will need a spray bottle,
brush, or rag to apply the solution to the fittings.
WARNING
Storage of an outdoor cooking gas appliance
indoor is permissible only if the cylinder is
disconnected and removed from the outdoor
cooking gas appliance.
TO TEST
1. Turn off all control valves, and turn on the gas
supply.
2. Apply the soap solution to all pipe fittings, from
the natural gas regulator and supply valve or
from the LP cylinder up to and including the
pipe that connects to the burners. Soap bubbles
will appear where a leak is present.
The gas must be turned off at the supply cylinder
when the unit is not in use.
If the appliance is stored indoors, the cylinder must
be disconnected and removed from the appliance.
Cylinders must be stored outdoors in a well-
ventilated area out of the reach of children.
3. If a leak is present, immediately turn off the gas
supply and tighten the leaky fittings.
4. Turn the gas back on and recheck.
5. If gas continues to leak from any of the fittings,
turn off the gas supply, and contact customer
service at 1-800-554-5799.
WARNING
Cylinder must be stored outdoors out of the reach
of children and must not be stored in a building,
garage or any other enclosed area.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLER FINAL CHECK
‰
Specified clearance maintained 24 in. from
combustible materials.
‰
‰
‰
The hose and regulator are properly
connected.
‰
‰
All internal packaging has been removed.
All the burners are factory installed.
The unit has been tested and is free of
leaks.
The gas supply shut off valve has been
located.
Model 740-0165
WARNING
1. Do not store spare LP gas cylinders under or near this appliance.
2. Never fill the cylinder beyond 80 percent capacity.
3. If the information above is not followed exactly, a fire resulting in death or serious injury could
occur.
Model 750-0165
WARNING
1. The outdoor cooking gas appliance and its individual shutoff valve must be disconnected from the
gas supply piping system during any pressure testing of that system at test pressure in excess of ½
psi (3.5 kpa).
2. The outdoor cooking gas appliance must be isolated from the gas supply piping system by closing
its individual manual shutoff valve during any pressure testing of the gas supply piping system at
test pressures equal to or less ½ psi (3.5 kpa).
15
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATING INSTRUCTIONS
GENERAL USE OF THE GRILL AND ROTISSERIE
Each main burner is rated at 13,000 BTU/Hr. The
main grill burners encompass the entire cooking
area and are side ported to minimize blockage from
falling grease and debris. Above the burners are
stainless steel flame tamers. The igniter knobs are
located on the lower center portion of the valve
panel. Each rotary igniter is labeled on the control
panel.
The grill is designed to grill efficiently without the
use of lava rocks or briquettes of any kind. Heat is
radiated by the stainless steel flame tamers
positioned above each burner.
USING THE ROTISSERIE BURNER
Your grill is capable of performing back burner
rotisserie cooking.
USING THE GRILL
Light the rear burner as described in the lighting
instructions on page 18. Once lit, the rotisserie
burner will reach cooking temperature in about 1
minute.
Grilling requires high heat for searing and proper
browning. Most foods are cooked at a “HI” heat
setting for their entire cooking time. However, when
grilling large pieces of meat or poultry, it may be
necessary to turn the heat to a lower setting after
the initial browning. This method cooks the food
thoroughly without burning the outside.
The rotisserie motor is capable of turning up to a
12lb. cut of meat or poultry. The motor slides onto
the stainless steel motor mount.
Food cooked for a long time or basted with a sugar
based marinade may need a lower heat setting
near the end of its cooking time.
The rotisserie motor must be electrically grounded
in accordance with local codes or, in the absence of
local codes, with the National Electrical Code,
ANSI/NFPA 70.
To begin:
1. Make sure the grill has been leak tested and is
properly located.
WARNING
The rotisserie motor is equipped with a plug and
should be plugged directly into a properly grounded
receptacle.
2. Remove any remaining packing materials.
3. Light the grill burners using the instructions on
page 18.
Do not cut or remove the grounding prong from this
plug.
4. Turn the control knob(s) to “HI” setting and
preheat the grill for 15 minutes. The grill lid is to
be closed during the appliance preheat period.
Keep the rotisserie motor cord away from the
heated surfaces of the grill. When not in use
remove and store the motor in a dry location.
5. Place the food on the grill and cook to the
desired doneness. If necessary, adjust the heat
setting. The control knob may be set to any
position between “HI” and “LO”.
THE ROTISSERIE SKEWER
The skewer for the rotisserie should be
assembled into the motor assembly by placing
the pointed end into the motor, and then sliding
the grooved bushing into the slot at the opposite
side of the grill.
CAUTION
Do not leave the grill unattended while cooking.
The thumbscrew for the grooved bushing should
be inside the grill body.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
LOADING THE ROTISSERIE SKEWER
1. Screw the bushing into the skewer rod at the
opposite end from the point.
It is normal for the skewer to flex when larger cuts
of meat are being cooked. It may also be necessary
to remove the cooking grids for larger cuts of meat.
2. Slide and tighten the counter balance apparatus
onto the skewer rod approximately 2-4 in. from
the bushing.
If the meat scrapes on the cooking grids during any
part of the rotation, the cooking grids must be
removed.
3. Slide the first meat fork onto the skewer rod
prongs toward the food.
Adjust the counter balance weight to balance the
heavier side of the meat and avoid lopsided rotation
of the rotisserie motor.
4. Center the product to be cooked on the skewer,
and then push the meat forks firmly together.
NOTE
After its first use, the stainless steel adjacent to the
rotisserie burner will most likely turn dark blue. This
is a normal property of the non-rusting, type
stainless steel used on the grill.
5. Tighten the wing nuts.
6. It may also be necessary to wrap the food with
butcher’s string (never use nylon or plastic
string) to secure any loose portions.
CAUTION
Remove the warming rack when using the rotisserie
burner. High heat from the burner may cause the
warming rack to bend.
7. Once the food is secure, insert the skewer into
the motor.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
LIGHTING INSTRUCTIONS
BEFORE LIGHTING…
FLAME CHARACTERISTICS
Inspect the gas supply piping prior to turning the
gas “ON”. If there is evidence of cuts, wear, or
abrasion, it must be replaced prior to use.
Check for proper burner flame characteristics. Each
burner is adjusted prior to shipment. However,
variations in the local gas supply may make minor
adjustments necessary.
WARNING
Burner flames should be blue and stable with no
yellow tips, excessive noise, or lifting. If any of
these conditions exist, contact customer service.
Do not use the grill if gas odor is present. Contact
customer service at 1-800-554-5799.
Leak check the piping and regulator connections
with a soap and water solution before operating the
grill (see instructions on page 14).
Yellow flames indicate insufficient air. Noisy flames
or flames that lift away from the burner indicate too
much air. (See the “GAS FLOW CHECK” section on
page 14).
Only the pressure regulator supplied with the unit
should be used. Never substitute regulators. If a
replacement is necessary, contact customer service
for proper replacement 1-800-554-5799.
TO LIGHT THE ROTISSERIE BURNER
1. Open the lid and press the knob for about 5
seconds without turning it. This will allow time
for the gas to flow into the rear burner.
TO LIGHT THE GRILL BURNER
1. Make sure all knobs are in the “OFF” position,
and turn on the gas supply.
2. Press the knob for 5 seconds, and then turn the
knob to the “HI” setting.
2. The igniter is built into the valve. To ignite each
burner simply press and turn the control knobs
to the “HI” setting, you will hear the valve click
as it sends a spark to the pilot flame.
3. Press the igniter button to light the rotisserie
burner.
4. If the burner does not light, turn the control
knob to the “OFF” position.
3. If the burner does not light, wait 5 minutes for
any excess gas to dissipate and then retry.
5. If the igniter does not function, follow the
instruction for match lighting on Page 20.
WARNING
While lighting, keep your face and body as far from
the grill as possible.
Keep a spray bottle of soapy water near the gas
supply valve, and check the connections before
each use.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
LIGHTING ILLUSTRATIONS
1. Open the top cover or lid.
2. Push and turn the main, rotisserie or sear
burner control knobs to the “HI” setting. Push
the control knob until the burner ignites. The
burner should ignite within 4 seconds (if
burner does not ignite follow match lighting
instructions on Page20). After the burner is
lit, adjust the heat level as desired.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
TO MATCH LIGHT THE GRILL
If the burner will not light after several attempts using the control knobs, the burner may be lit
with a match.
1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any
accumulated gas to dissipate.
2. Insert a match into the lighting rod. Ignite the match and insert through the cooking grids to
the burner.
3. Press and turn the control knob to the “HI” setting, continue to press the knob until the
burner ignites. The burner should light immediately.
4. If the burner does not ignite within 4 seconds, turn the control knob to the “OFF” position.
Wait 5 minutes and try again.
CAUTION
When lighting, keep your face and body as far
from the grill as possible.
CAUTION
When using a match to light the grill make
sure to use the attached lighting rod.
Lighting Rod
Download from Www.Somanuals.com. All Manuals Search And Download.
2
CARE & MAINTENANCE
STAINLESS STEEL
GRILL BURNER REMOVAL/INSTALLATION
The grill burners are factory installed. To remove
the main burners for cleaning,
The grill is made from non-rusting and non-
magnetic stainless steel. There are many different
stainless steel cleaners available. Always use the
mildest cleaning procedure first, scrubbing in the
direction of the grain.
1. Locate the cotter pin at the rear of the burner on
the bottom side.
To touch up noticeable scratches in the stainless
steel, sand very lightly with dry 100 grit emery
paper in the direction of the grain.
2. Remove the cotter pin and lift the burner out of
the fire box.
3. To reinstall the main burners, insert the burner
over the valve assembly (See exploded view
and parts list on pages 23 and 25).
Grease specks can gather and bake onto the
surfaces of the stainless steel, giving the
appearance of rust. For removal, use an abrasive
pad with a stainless steel cleaner.
4. Insert the back of the burner into the hole at the
rear of the fire box and reinsert the cotter pin.
CAUTION
Before cleaning make sure the burners are
cool, and the gas supply and knobs are in
the “OFF” position.
CAUTION
Failure to ensure proper placement of the
burner over the valve assembly can cause a
fire to occur behind and beneath the valve
panel, thereby damaging the grill and making
it unsafe to operate.
GRILL RACK
The easiest way to clean the grill is immediately
after cooking is completed, and the flame has been
turned off.
GRILL BURNER CLEANING
1. Turn off the gas supply, and make sure all the
knobs are in the “OFF” position.
Wear a barbeque mitt to protect your hand from the
heat and steam.
2. Wait for the grill to cool.
Scrub the hot grill by dipping a bristle barbeque
brush in tap water. Cleaning will be more difficult if
the grill is allowed to cool.
3. Clean the exterior of the burner with a wire
brush. Use a metal scrapper for stubborn
stains.
GRILL BURNERS
Extreme care should be taken when moving a
burner as it must be correctly centered on the
orifice before any attempt is made to relight the grill.
Frequency of cleaning will depend on how often you
use the grill.
4. Clear clogged ports with a straightened paper
clip. Never use a wooden toothpick as it may
break off and clog the port.
5. If insects or other obstructions are blocking the
flow of gas through the burner, call customer
service at 1-800-554-5799.
GREASE TRAY CLEANING:
The grease tray should be emptied, wiped down
and washed after each use in a mild detergent and
warm water solution.
A small amount of sand or cat litter may be placed
in the bottom of grease tray to absorb excess
grease. Do not allow excess grease to accumulate
and overflow out of the grease tray.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
TROUBLESHOOTING
WHEN TO LOOK FOR SPIDERS
You should inspect the burners twice a year or
immediately after any of the following conditions
occur:
INSECT WARNING
Spiders and insects can nest in the burners of
this and other grills, which could disrupt gas
flow. This dangerous condition could cause a
fire behind and beneath the valve panel,
damaging the grill and making it unsafe to
operate.
1. The smell of gas in conjunction with the
burner flames appearing yellow.
2. The grill does not reach temperature.
3. The grill heats unevenly.
Inspect the grill at least twice a year.
4. The burners make popping noises.
BEFORE CALLING FOR SERVICE
If the grill does not function properly, use the checklist below before contacting your dealer for service. You may
save yourself the cost of a service call.
PROBLEMS
WHAT TO DO
Grill will not light when the control
knob is rotated.
•
•
•
Check to see if house NG valve is open.
Check to see if LP tank is empty.
Clean wire(s) and/or electrode with rubbing alcohol and a
clean swab.
•
•
Make sure the wire is connected to the electrode
assembly.
Check to see if other burners operate. If so, check the gas
orifice on the malfunctioning burner for an obstruction.
Burner flame is yellow or orange and
the gas odor is present.
•
Contact customer service at 1-800-554-5799.
Low heat with the knob on “HI”.
•
•
•
•
Check to see if the fuel hose is bent or kinked.
Make sure the grill area is clear of dust.
Check your gas supply and gas pressure.
If it is only one burner that appears low, make sure the
orifice or burner is clean.
22
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED VIEW MODEL 740-0165
01
02
03
04
05
19
06
07
18
20
37
21
22
23
24
08
25
26
27
09
10
11
12
13
14
28
29
30
15
16
32
17
33
34
31
35
36
23
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
MODEL 740-0165
REF#
1
DESCRIPTION
Q’TY
1
REF#
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
DESCRIPTION
Warming Rack
QTY
1
Main Lid
2
Heat Indicator
1
Cooking Grid
2
3
Name Plate
1
Cooking Grid With Hole
Flame Tamer
1
4
Heat Insulating Spacer
Main Lid Handle Assembly
Rotisserie Burner
Rotisserie Gas Collector
Left Side Flange
Main Bowl Assembly
Front Baffle
2
4
5
1
Main Burner
4
6
1
Rear Trim Piece
Rear Baffle
1
7
1
1
8
1
Clamp
1
9
1
Right Side Flange
Rotisserie Burner Gas Pipe
90 Degree Gas Hose Adapter
LP Regulator With Hose
Main Gas Pipe
1
10
11
12
13
14
15
16
17
18
19
1
1
Sear Burner Gas Valve
Smoke Baffle Cover
Manifold Retainer Bracket
Control Panel
1
1
1
1
6
1
1
Rotisserie Gas Valve
Main Gas Valve
Manifold
1
Knob With Set Screw
Smoke Tray
6
4
1
1
Grease Tray
1
Lighting Rod
1
Sear Burner
1
Rotisserie Heat Shield
1
Cooking Griddle
1
24
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED VIEW MODEL 750-0165
01
02
03
04
05
19
06
07
18
20
39
21
22
23
08
24
25
26
27
09
10
11
12
13
14
30
28
29
15
16
31
32
33
34
35
36
17
37
38
25
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
MODEL 750-0165
REF#
1
DESCRIPTION
Q’TY
1
REF#
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
DESCRIPTION
Cooking Grid
QTY
2
Main Lid
2
Heat Indicator
1
Cooking Grid With Hole
Flame Tamer
1
3
Name Plate
1
4
4
Heat Insulating Spacer
Main Lid Handle Assembly
Rotisserie Burner
Rotisserie Gas Collector
Left Side Flange
Main Bowl Assembly
Front Baffle
2
Main Burner
4
5
1
Rear Trim Piece
1
6
1
Rear Baffle
1
7
1
Right Side Flange
12’ PVC Hose Quick Connector
12’ PVC Hose
1
8
1
1
9
1
1
10
11
12
13
14
15
16
17
18
19
20
1
Rotisserie Gas Pipe
90 Degree Gas Hose Adaptor
NG Regulator
1
Sear Burner Gas Valve
Smoke Baffle Cover
Manifold Retainer Bracket
Control Panel
1
1
1
1
6
Gas Hose Adaptor
Main Gas Pipe
1
1
1
Knob With Set Screw
Smoke Tray
6
Rotisserie Gas Valve
Main Gas Valve
1
1
4
Grease Tray
1
Main Manifold
1
Sear Burner
1
Lighting Rod
1
Cooking Griddle
Warming Rack
1
Rotisserie Heat Shield
1
1
26
Download from Www.Somanuals.com. All Manuals Search And Download.
GRILLING HINTS
The preparation of meat, whether rare, medium, or
well done, is affected to a large degree by the
thickness of the cut.
To get the juiciest meat, add seasoning or salt after
the cooking is finished and turn the meat only once
(juices are lost when the meat is turned several
times). Turn the meat just after the juices begin to
bubble to the surface.
The cooking time is affected by meat type, size,
shape of the cut, the temperature of the meat when
cooking begins, and the degree of preparation
desired.
Trim excess fat from the meat before cooking.
To prevent steaks or chops from curling during
cooking, slit the fat around the edges at 2-inch
intervals.
It is recommended that meat be defrosted overnight
in a refrigerator as opposed to a microwave. This
generally yields a juicier cut of meat.
WARNING
Turn the meat with a spatula instead of tongs. The
spatula will keep the meat whole and trap in the
juices.
Do not leave the grill unattended while cooking.
GRILL COOKING CHART
WEIGHT OR
THICKNESS
FLAME
SIZE
APPROXIMATE
TIME
SPECIAL INSTRUCTIONS
AND TIPS
FOOD
VEGETABLES
Slice. Dot with butter or
Beets
Medium
Medium
12 to 20 minutes margarine. Wrap in heavy-duty
foil. Grill, turning occasionally.
Carrots
Grill, turning once. Brush
occasionally with melted butter
or margarine.
Turnips
Onion
1/2 inch slices
8 to 20 minutes
Wrap individually in heavy-
duty foil. Grill, rotating
occasionally.
Potatoes
Sweet
White
Whole
6 to 8 ounces
Medium
High
40 to 60 minutes
45 to 60 minutes
Dot with butter or margarine.
Wrap in heavy-duty foil. Grill,
turning occasionally.
Frozen
Asparagus
Broccoli
Medium
15 to 30 minutes
Brussels
Sprouts
Green beans
Peas
27
Download from Www.Somanuals.com. All Manuals Search And Download.
WEIGHT OR
THICKNESS
FLAME
SIZE
APPROXIMATE
TIME
SPEICAL INSTRUCTIONS
AND TIPS
FOOD
Place in aluminum foil pan.
French Fries
Medium
15 to 30 minutes Grill, stirring occasionally.
MEATS BEEF
Grill, turning once when juices
rise to the surface.
Do not leave hamburgers
unattended since a flare-up
Hamburgers
1/2 to 3/4 inch
Medium
High
10 to 18 minutes could occur quickly.
8 to 15 minutes
Tenderloin,
Porterhouse,
Rib eye
Remove excess fat from edge.
Slash remaining fat at 2-inch
Rare
1 inch
1-1/2 inch
1 inch
High
High
8 to 14 minutes intervals. Grill, turning once.
11 to 18 minutes
Medium
Well-done
Medium to 12 to 22 minutes
1-1/2 inch
1 inch
1-1/2 inches
High
Medium
Medium
16 to 27 minutes
18 to 30 minutes
16 to 35 minutes
Lamb
Chops & Steaks
Remove excess fat from edge.
Slash remaining fat at 2-inch
Rare
1 inch
1-1/2 inch
1 inch
High
High
10 to 15 minutes intervals. Grill, turning once.
14 to 18 minutes
Medium
Medium to 13 to 20 minutes
1-1/2 inch
High
18 to 25 minutes
Well-done
1 inch
Medium
17 to 30 minutes
Remove excess fat from edge.
Slash remaining fat at 2-inch
intervals. Grill, turning once.
Pork
Chops
Well-done
1 inch
1-1/2 inches
Medium
Medium
20 to 30 minutes Cook well done.
30 to 40 minutes
28
Download from Www.Somanuals.com. All Manuals Search And Download.
WEIGHT OR
THICKNESS
FLAME
SIZE
APPROXIMATE
TIME
SPEICAL INSTRUCTIONS
AND TIPS
FOOD
Grill, turning occasionally.
During last few minutes brush
with barbecue sauce, turn
Ribs
Pork
Medium
30 to 40 minutes several times.
Ham steaks
Remove excess fat from edge.
Slash remaining fat at 2-inch
intervals. Grill, turning once.
5 to 10 minutes Slit skin. Grill, turning once.
(precooked)
Hot dogs
POULTRY
1/2 inch slices
2 to 3 pounds
High
4 to 8 minutes
Medium
Place skin side up. Grill, turning
and brushing frequently
with melted butter, margarine, oil
1 to 1-1/2 hours or marinade.
Broiler/fryer
Low or
Halved or
Quartered
well-done
Breast
Medium
40 to 60 minutes
well-done
Medium
30 to 45 minutes
WEIGHT
OR
THICKNESS
SPECIAL
APPROXIMATE INSTRUCTIONS
FOOD
FLAME
SIZE
TIME
AND TIPS
FISH AND
SEAFOOD
Grill, turning once. Brush with
melted butter, margarine or oil to
keep moist.
Steaks
Halibut
3/4 to 1 inch
Medium to 8 to 15 minutes
High
Salmon
Swordfish
Whole
Grill, turning once. Brush with
Medium to 12 to 20 minutes melted butter, margarine or oil.
Catfish
4 to 8 ounces
Rainbow trout
High
29
Download from Www.Somanuals.com. All Manuals Search And Download.
GRILL RECIPES
BBQ SALMON
2 large salmon steaks
2 tbs. oil
Salt & pepper
2 oz. thin bacon slices
2 tbs. butter
1 tbs. lemon juice
Sprig of parsley
Lemon wedges
Half-hour before cooking, turn the burner 1tsp. Worcestershire sauce
to the grill on high. Drain seafood-
reserving marinade. On each of twelve
10” skewers, thread 2 shrimps and 2
scallops, alternating with pineapple
chunks. Place skewers on grill. Cook 7-
10 minutes, basting and turning often.
1tsp. Dry mustard
¼ tsp. Thyme, crushed
1 medium onion, sliced
1 pound flank steak, scoured
2 tbs. Butter, melted
Combine first 4 ingredients, add onion
and marinade flank steak with it.
Refrigerate at least 4 hours or
PORK CHOPS
4 pork chops
*You can substitute catfish, halibut or cod
for salmon.
Marinade
1 large onion
2 tbs. lemon juice or vinegar
2 tbs. oil
½ tsp. freshly ground black pepper.
1 tsp. sugar
½ tps. paprika
1 clover garlic
Peel, grate onion, and add rest of the
ingredients except the pork chops. Mix
well. Pour over chops and marinate
overnight. Remove steak and grill on
preheated BBQ grill. Grill 5 to 7
minutes on each side basting
frequently with the marinade. In the
meantime sauté onions from the
marinade in butter in a skillet on grill
side burner for 3 minutes. To serve,
slice steak diagonally into thin slices,
sprinkle onions over top. Garnish with
vegetable kabobs.
Preheat the BBQ
Brush the steaks with oil and season with
salt and pepper. Place on BBQ grill and
cook for 10 minutes, turning steaks over
halfway through cooking time.
Meanwhile fry the bacon in a pan on the
side burner. Drain on paper towels. Melt
the butter in a small saucepan taking care
not to discolor it. Arrange the fish and
bacon on serving plates. Pour the butter
over and sprinkle with lemon juice.
Garnish with parsley sprigs and lemon
wedges. Serve with boiled potatoes in
butter and sprinkled with parsley.
one hour in a cool place. Turn the BBQ VEGETABLE KABOBS
grill on high. Heat 10 minutes. BBQ
the chops brushing with the marinade
occasionally. Serve with mixed salad,
dressed with vinaigrette flavored with
fresh dill.
3 medium-size zucchini
12 cherry tomatoes
12 fresh mushrooms
Grated parmesan cheese
Parboil whole zucchini 5 minutes on
grill side burner or until just tender.
Drain and cut into ½ inch slices.
Thread zucchini, tomatoes and
mushrooms alternately on each of six
skewers. Brush with marinade made
of Italian dressing, Worcestershire
sauce, mustard and thyme. Grill 5 to 7
minutes turning and basting
BARBECUED POTATOES and
CHEESE
1 –1/2 cups shredded cheddar cheese
1 can (10-3/4 oz.) condensed cream of
mushroom soup
1/3 cup milk
2 tbs barbecue sauce
¼ tsp. oregano
¼ tsp. salt
1/8 tsp. pepper
4 cups thinly sliced potatoes (4
medium-sized potatoes)
BAKED CHILI CORN
6 medium ears corn, husked
3 tbs. butter or margarine, melted
Dash ground cumin
Dash ground coriander
About ½ hour before cooking, turn the grill
on for butter. Place each ear on a heavy-
duty foil. In a bowl, combine remaining
ingredients. Mix well. Brush 1-1/2 tsp.
butter mixture over each ear. Close foil
and fold up ends to seal. Place on grill.
Cook, turning packets occasionally 10 to
12 minutes or until cooked through.
occasionally. Sprinkle liberally with
Parmesan cheese.
FAJITAS
1-1/2 lb. flank steak or boned chicken
breasts
2 tbs. oil
½ cup lime juice
½ tsp. salt
½ tsp. celery salt
¼ tsp. garlic powder
½ tsp. pepper
¼ tsp. oregano
¼ tsp. cumin
Preheat grill. Combine cheese,
condensed soup, milk, BBQ
sauce, oregano, salt and pepper
in a large mixing bowl. Stir in
potatoes until well coated. Turn
into well-buttered 1-1/2 quart
rectangular baking dish. Cover
dish with aluminum foil. Bake
covered 25 minutes on medium
with the lid of your BBQ grill
closed. Remove foil and
TANGY SEAFOOD KABOBS
1 lb. Large shrimp, shelled & divined
¾ Lbs. Sea scallops
2/3 c. chili sauce
¼ c. cider vinegar
3 tbs. Chopped parsley
1 tbs. Vegetable oil
Flour tortillas
Lemon
1 tbs. Worcestershire sauce
½ tsp. Prepared horseradish
1 clove garlic, minced
1 20 oz. Can pineapple chunks in juice
drained.
In medium bowl, combine shrimp and
scallops. In small bowl, combine chili
sauce and next six ingredients. Pour over
seafood. Toss to coat. Cover, refrigerate
2 hours.
continue baking 15 minutes
longer or until potatoes are
tender. Let stand 5 minutes
before serving.
Pound flank steak to ¼ inch thickness or
flatten chicken breasts. Mix oil, limejuice and
seasonings in a zip lock bag. Add meat and
shake bag to coat the meat. Refrigerate
overnight or at least 6 to 8 hours. Wrap
tortillas in foil. Remove meat from marinade.
Cook on a pre-heated gas grill for 5 to 8
minutes on each side. While meat is cooking,
heat tortillas on grill. Slice meat across grain
BARBECUED LONDON BROIL
4 to 6 servings
¾ c. Italian dressing
30
Download from Www.Somanuals.com. All Manuals Search And Download.
in thin slices. Place on hot platter. Squeeze
lemon juice over. Wrap meat and any of
the following toppings in tortillas: chopped
tomatoes, guacamole, sour cream, and
taco sauce.
CHICKEN TANDOORI STYLE
8 large chicken thighs or drumsticks
1 c. plain nonfat yogurt
½ c. lemon juice
2 tsp. salt
½ tsp. cayenne
½ tsp. black pepper
½ tsp. crushed garlic
½ tsp. grated ginger
1 tbs. corn oil
Time: 1-1/2 hours to 2 hours
Bring pork to room temperature
before placing it on the
rotisserie spit rod. Place on the
rod and test for balance. Light
rotisseries burner. Turn control
knob to high. Use the above
basting sauce for rotisserie
baking
BEEF AND LAMB KABOBS
Serve 4
½ lb. boneless sirloin or beef cut into 1”
cubes
½ lb. boneless loin of lamb cut into 1”
cubes
2/3 c. water, divided
¼ c. chopped onion
2 tbs. soy sauce
¼ c. vegetable oil, divided
1 tbs. dark brown sugar
1 tbs. fresh lemon juice
2 cloves garlic, minced
¼ tsp. ground cumin
¼ tsp. ground coriander
¼ tsp. ground turmeric
1/8 tsp. ground red pepper
1/8 tsp. ground ginger
1 red pepper cut into chunks
1 large banana, cut into chunks
8 small mushrooms
Combine all the ingredients in a large
mixing bowl and marinate the chicken for
8 hours in the refrigerator. Drain the
chicken and spread on the spit running
the rod on the fleshier side of the bone.
TURKEY
12 lb. turkey
Beer basting sauce:
1 can beer
12 oz. water
1 stick butter
1 tsp. salt
1 tsp. pepper
½ tsp. garlic flakes
1 tsp. parsley
Bake using the rotisserie. Cook on
medium high heat for 40 minutes basting
occasionally with the remainder of the
marinade mixture. Serve with sliced
onions and lemon wedges.
Thaw the bird completely.
Wash inside out. Securely tie
the legs and wings before
placing the turkey on the
rotisserie spit rod. Light
SPARE RIBS
Marinade:
1 c. soy sauce
½ c. honey
1/3 c. smooth peanut butter
½ c. vinegar
½ c. dry sherry
rotisseries burner. Turn to high.
Combine all the ingredients for
basting sauce in a shallow pan.
Place it under the turkey 15 to
20 minutes. Cook for
approximately 3 hours. The
basting sauce combined with
turkey drippings makes
In blender, process 1/3 c. water, onion, soy 2 tsp. chopped garlic
sauce, 2 tsp. oil and the next 8 ingredients 2 tsp. sugar
until smooth. Pour over meat cubes and
marinate about 4 hours, turning
occasionally. Drain and reserve marinade.
On to four 12” skewers alternately thread
meat, pepper, banana and mushrooms.
Preheat grill. Brush the kabobs with oil.
Grill 7-8 minutes each side.
1 c. water
1 chicken bouillon cube
1 can beer for basting sauce
Marinade ribs for 3 hours. Use
marinade for basting by adding
beer to it. Place pan under the ribs
and baste frequently. To cook ribs
delicious gravy.
Bring marinade to boil on the side burner in select lean, meaty ribs and
a saucepan. Add remaining 1/3 c. water
and peanut butter. Stir to blend. Heat
through. If sauce gets too thick, add 1 tbs.
water. Serve sauce with kabobs.
accordion pleat them with your
spit. Slide four-prong meat hook
down the length of spit and
tighten. At the beginning of the
rack and to its center, penetrate
the second rib with the pointed
end of the spit and push it
EGGPLANT CAVIAR
1 large eggplant
2 tbs. olive oil
between the meat. Skip a couple
and continue the process until the
entire rack is accordion pleated.
Fasten the second meat hook into
the rack. Turn rotisserie burner on
high. Bake using the rotisserie for
50 minutes or until done.
2 tbs. wine vinegar
2 tbs. finely chopped onion
½ clove garlic, minced
1 medium tomato, chopped salt and
pepper
Roast eggplant on gas grill over medium
flame, turning occasionally until thoroughly PORK ROAST
cooked. This may take 30 minutes.
Remove from grill and cool for handling.
Strip off the skin and chop eggplant finely.
Add all the seasonings. Chill thoroughly
and serve on toast.
Apple cider vinegar basting sauce:
1 c. apple cider vinegar
6 oz. water
½ stick butter
Salt, pepper, parsley and garlic
seasoning
2 oz. lemon juice
10 lbs. pork roast
31
Download from Www.Somanuals.com. All Manuals Search And Download.
LIMITED WARRANTY
MODEL # 740-0165/750-0165
STAINLESS STEEL BUILD-IN OUTDOOR GAS GRILL
Nexgrill Industries, Inc. warrants to the original consumer/purchaser of each Jenn-Air Outdoor Gas Grill
that when subject to normal residential use, it is free from defects in workmanship and materials for the
periods specified below. This warranty excludes grills used in rental or commercial applications.
Component
Warranty Period:
Cast Brass Burners:
Lifetime
Lifetime
Lifetime
2 Year
Stainless Steel Flame Tamer:
Stainless Steel Cooking Grids:
Sear Burner:
Valves, Nature Gas Regulator and 12’ Gas Hose:
Igniter and related Parts:
1 Year
1 Year
All Stainless Steel Parts:
Lifetime
Our obligation under this warranty is limited to repair or replacement, at our option, of the product during
the warranty period. The extent of any liability of Nexgrill Industries, Inc. under this warranty is limited to
repair or replacement. This warranty does not cover normal wear of parts, discoloration of the stainless
steel parts, or damage resulting from any of the following: negligent use or misuse of the product,
improper use of the fuel/gas supply, use contrary to the operating instructions, or alteration by any person
other than our factory service center. The warranty period is not extended by such repair or replacement.
Product repair as provided under this warranty is your exclusive remedy. Nexgrill Industries, Inc. shall not
be liable for any incidental or consequential damages for breach of any express or implied warranties on
its products. Except to the extent prohibited by applicable law, any implied warranty of merchantability or
fitness for a particular purpose on this product is limited by the duration of the above warranty. Some
states do not allow the exclusion or limitation of incidental or consequential damages, or allow limitations
on how long an implied warranty lasts, so the above limitations or exclusions may not apply to you. This
warranty gives you specific legal rights, and you may have other rights, which vary from state to state.
WARRANTY CLAIM PROCEDURE
If you require service or parts for your grill, please contact our Warranty Service Center for factory direct
assistance. Our hours of operation are 7 AM to 6 PM PST Monday to Friday, 8 AM to 12 PM PST on
Saturday. Our telephone number is 1-800-554-5799, FAX number 1-800-598-8829. Please direct all
correspondence to: Nexgrill Industries, Inc. 280 Machlin Court, City of Industry, CA 91789, ATTN:
Warranty Service Center.
*Jenn-Air is a trademark of the Maytag Corporation and is used under license to Lowe’s Company Inc.
Printed In China
32
Download from Www.Somanuals.com. All Manuals Search And Download.
|