Cooker with gas oven
and gas grill
Instructions for installation and use
K 642 G/G
K 642 GS/G
K 642R GS/G
K 643 G/G
K 6432 G/G
K 645 G/G
K 645R G/G
K 647 GS/G
K 647R G/G
Download from Www.Somanuals.com. All Manuals Search And Download.
Important safety warnings
To maintain the EFFICIENCY and SAFETY of this appliance, we recommend:
•
•
use only the MANUFACTURER Service
use only ORIGINAL Spare Parts
1
2
This owner's manual is for a class 1 appliance (installed
independently) or class 2 - sub-class 1 appliances (installed
between two cabinets).
request the use of original spare parts only. Failure to comply
with the above may compromise the safety of the appliance.
13 Remember if you are discarding any domestic appliance with
which children etc.may play, make it safe by removing the Mains
Cable from it, after first disconnecting the electricity supply.
Remove glass parts where possible, and consider sharp edges
etc. which may now be exposed.
Before using the appliance, read the instructions in this
owner’s manual carefully since you should find all the
instruction you require to ensure safe installation, use and
maintenance.
Always keep this owner’s manual close to hand since you
may need to refer to it in the future.
14 Oven gloves or similar protection should be used when moving
containers in or out of hot ovens and care should be be taken to
avoid contact with hot surfaces by exposed skin on wrists or
arms.
15 One of the commonest types of accident involving cooking
appliances is burns to babies and young children. These can
occur by:
3
When you have removed the packing, check that the appliance
is not damaged.If you have any doubts, do not use the appliance,
contact your nearest Ariston Service Centre. Never leave the
packing components (plastic bags, foamed polystyrene, nails,
etc.) within the reach of children since they are a source of
potential danger.
a) Touching hot parts
4
5
The appliance must be installed only by a qualified person in
compliance with the instructions provided. The manufacturer
declines all responsibility for improper installation which may
harm persons and animals and damage property.
b) Being splashed with hot liquids
c) By pulling projecting pan handles and tipping hot liquids
over themselves
16 Please remember that a small child’s skin is far more sensitive
and therefore easily burnt.You are, therefore, strongly advised
to keep babies and young children well clear of this appliance
during use and whilst it is cooling down after use.
17 Unstable or out of shape pans should not be used on the hob in
case they cause spillage of hot liquids by tipping over.
The electrical safety of this appliance can only be guaranteed if
the cooker is correctly and efficiently earthed, in compliance
with current regulations on electrical safety.Always ensure that
the earthing is efficient;if you have any doubts call in a qualified
electrician to check the system. The manufacturer declines all
responsibility for damage resulting from a system which has
not been earthed.
18 Pans must only be placed in the centre of the burners. Placing
pans off centre may cause cooking irregularites.
6
7
Before connecting the appliance to the mains, check that the
specifications indicated on the rating plate correspond to those
of the electrical mains system of your home.
19 Special care should be taken when using chip pans etc.in order
to avoid splashing or spillage of hot oil.They should not be used
unattended since overheated oil may boil over and could also
ignite.
20 Parts of this appliance, cooking surfaces, retain heat for
considerable periods after switching off.Care should, therefore,
be taken when touching these areas before they have completely
cooled down.
The cooker must be connected to the mains electrical supply
via a earthed 13 or 15 amp.socket outlet, meeting the electrical
current requirements detailed under “electrical Connection” in
the installation section later in this book.
8
9
The openings and slots used for ventilation and dispersion of
heat on the rear and below the control panel must never be
covered.
This appliance must be used for the purpose for which it was
expressly designed. Any other use (e.g. heating rooms) is
considered to be improper and consequently dangerous. The
manufacturer declines all responsibility for damage resulting
from improper and irresponsible use.
21 Remember to keep children away from the appliance when
you use the grill or oven, since these parts become very
hot.
22 Never use flammable liquids such as alcohol or gasoline, etc.
near the appliance when it is in use.
23 Wear oven gloves when placing coockware in the oven or
removing it.
10 A number of fundamental rules must be followed when using
24 Never use the oven as place to store flammable material.
electrical appliances.The following are of particular importance:
25 When using small electric appliances near the hob, keep the
supply cord away from the hot parts.
26 Make sure the knobs are in the“•”/”O”position when the appliance
is not in use.
•
•
•
do not touch the appliance when your hands or feet are wet
do not use the appliance barefooted
never allow the Mains Cable to be stretched, pulled or
damaged if the Cooker is moved for cleaning etc. Do not
use the cooker if the Mains Cable is damaged, consult a
qualified electrician.
27 Warning: open the door with care since if you are not careful
you may hurt yourself in the hinge area.
28 Gas units need a regular air replacement for a correct
functioning. Make sure that the requirements requested in
the“Positioning”paragraph are all observed in the owner’s
manual.
29 If the cooker is placed on a pedestal, take the necessary
precautions to prevent the same from sliding off the pedestal
itself.
•
do not allow the cooker to be used unsupervised by children
or persons unfamiliar with it.
11 Always switch off the electrical supply to the cooker and allow it
to cool down before carrying out any cleaning operations etc.
12 In the case of faults and/or faulty operation, switch off the
electricity supply to the cooker and do not tamper with it. For
repairs call only an authorised after-sales servicing centre and
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Thefollowinginstructionsshouldbereadbyaqualifiedtechnician
of the cooker the following precautions must be followed:
a) The cooker may be located in a kitchen, a kitonen/diner or
bed sitting room, but not in a bathroom or shower room.
b) The furniture units next to the cooker, that is higher than the
working boards, must be placed at least 110mm from the
edge of the board. Curtains must not be fitted immediately
behindthecookerorwithin110mm.ofthesidesofthecooker.
c) The hoods must be installed according to the requirements
in the hood handbook.
d) Wall cabinets may be fitted in line with the sides of the base
units, providing that the lower edge of the wall cabinet is a
minimum of 420 mm. above the worktop. The minimum
distance combustible material kitchen units can be fitted
directly above the worktop is 700 mm (Fig.A).
toensurethattheapplianceisinstalled, regulatedandtechnically
serviced correctly in compliance with current regulations.
Important: remember to unplug the appliance from the
mains before regulating the appliance or carrying out any
maintenance work.
Positioning
Important:thisunitmaybeinstalledandusedonlyinpermanently
ventilated rooms according to the British Standards Codes Of
Practice:B.S.6172/B.S.5440,Par.2andB.S.6891CurrentEditions.
The following requirements must be observed:
a) The cooker should not be installed in a bed sitting room with a
volume of less than 20m3. If it is installed in a room of volume
lessthan5m3 anairventofeffectiveareaof110cm2 isrequired,
if it is installed in a room of volume between 5m3 and 10m3 a
supplementaryairventareaof50cm2isrequired, ifthevolume
exceeds 11m3 no airvent is required.However, if the room has
a door or a window which opens directly to the outside no air
vent is required even when the volume is between 5m3 and
11m3.
e) The wall in contact with the back of the cooker must be of
flameproof material.
f) The cooker is fitted with a safety chain that must be attached to
a hook, secured to the wall behind the appliance.
Note: some models can have their gas connection inverted.
Itisimportanttomakesurethesafetychainisalwayssituated
on the side which corresponds to the hose holder (Fig. B).
b) During prolonged use of the appliance you may consider it
necessarytoopenawindowtotheoutsidetoimproveventilation.
c) If there are other fuel burning appliances in the same room,
B.S.5440 Part 2 Current Edition, should, be consulted to
determine the requisite air vent requirements.
HOOD
Min. 600mm.
Levelling your appliance (only on a few models)
Your cooker is supplied with feet for levelling the appliance. If
necessary, these feet can be screwed into the housings in the
corners of the cooker base.
Fig.A
Fig.B
Gas connection
The cooker should be connected to the gas-supply by a corgi
registeredinstaller.Duringinstallationofthisproductitisessential
tofitanapprovedgastaptoisolatethesupplyfromtheappliance
for the convenience of any subsequent removal or servicing.
Connection of the appliance to the gas mains or liquid gas must
be carried out according to the prescribed regulation in force,
and only after it is ascertained that it is adaptable to the type of
gas to be used. If not, follow the instructions indicated in the
paragraph headed“Adaptation to different gas types”.On some
models the gas supply can be connected on the left or on the
right,asnecessary;tochangetheconnection,reversetheposition
of the hose holder with that of the cap and replace the gasket
(supplied with the appliance). In the case of connection to liquid
gas, by tank, use pressure regulators that conform to the
regulation in force.The gas supply must be connected to the left
of the appliance. Be sure that the hose does not pass through
the rear of the cooker touching hot parts.
Mounting the legs (only on a few models)
Press-fitlegsaresuppliedwhichfitunderthebaseofyourcooker.
Installation of the cooker
HOT PARTS
Thecookerispreparedwithprotectiondegreeagainstexcessive
heating of type X, the appliance can therefore be installed next
to cabinets, provided the height does not exceed that of the hob.
If the cooker is placed touching walls or sides of neighbouring
cabinets, these must be capable of withstanding a temperature
rise of 50°C above room temperature. For a correct installation
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Important:makesurethesupplypressureconformswiththevalues
showninthetableentitled“Caracteristicsoftheburnersandnozzles”.
When the cooker is installed between cabinets (recessed),
the gas connection must be effected by an approved flexible
hose with bayonet fitting (BS 669 Current Edition). The gas
inlet for the cookers is a threaded G 1/2 gas female fitting.
the mains cable must be wired into a cooker output point with a
rating of 45 amp.In this case the cable is not supplied.
Disposing of the plug:
Ensure that before disposing of the plug itself, you make the pins
unusable so that it cannot be accidentally inserted into a socket.
Instructions for connecting cable to an alternative plug:
Important:thewiresinthemainsleadarecolouredinaccordance
with the following code:
Connecting the gas supply
To make the connection, a flexible hose should be used
corresponding to the current gas regulations which are:
Green &Yellow
Blue
Brown
- Earth
- Neutral
- Live
•
the hose must never be at any point in its lenght in contact with
the “hot”parts of the cooker;
•
•
the hose must never be longer than 1,5 metre;
the hose must not be subject to any tension or torsional stress
and it must not have any excessively narrow curves or
bottlenecks;
If the colours of the wires in the mains lead do not correspond with
thecolouredmarkingsidentifyingtheterminalsinyourplug,proceed
as follows:
Connect Green & Yellow wire to terminal marked “E” or
coloured Green or Green &Yellow.
or
•
•
thehosemustbeeasytoinspectalongitsentirelengthtocheck
its condition;
the hose must always be in good condition, never attempt to
repair.
Connect Brown wire to terminal marked“L”or coloured Red.
Connect Blue wire to terminal marked“N”or coloured Black.
If a 13 amp plug (BS 1363) is used it must be fitted with a 13 amp
fuse.A 15 amp plug must be protected by a 15 amp fuse, either in
the plug or adaptor or at the distribution board. If you are in any
doubtabouttheelectricalsupplytoyourmachine,consultaqualified
electrician before use.
Important:theinstallationmustcomplywithgassafety(installation
and use) regulations 1984. In all cases for the above, by low, a
qualified, corgi approved engineer must be called for installation.
Electrialconnection
Power supply voltage and frequency:230-240V a.c.50 Hz.
Note: the supply cable must be positioned so that it never reaches
atanypointatemperature50°Chigherthantheroomtemperature.
The cable must be routed away from the rear vents. Should you
require it, you may use a longer cable, however, you must ensure
that the cable supplied with the appliance is replaced by one of the
same specifications in accordance with current standards and
legislation.
Your appliance is supplied with a 13 amp fused plug that can be
plugged into a 13 amp socket for immediate use.Before using the
appliance please read the instructions below.
WARNING -THIS APPLIANCE MUST BE EARTHED.
THEFOLLOWINGOPERATIONSSHOULDBECARRIEDOUT
BY A QUALIFIED ELECTRICIAN.
How to connect an alternative plug:
The wires in this mains lead are coloured in accordance with the
followingcode:
BLUE
BROWN
“NEUTRAL”(“N”)
“LIVE”(“L”)
GREEN ANDYELLOW
“EARTH” (“E”)
GREEN &
YELLOW
13 amp fuse
BROWN
BLUE
CROSS-BAR
CORD GRIP
Replacing the fuse:
Whenreplacingafaultyfuse, a13ampASTAapprovedfusetoBS
1362shouldalwaysbeused,andthefusecoverre-fitted.Ifthefuse
coverislost,theplugmustnotbeuseduntilareplacementisobtained.
Disposing of the appliance
Whendisposingoftheappliancepleaseremovetheplugbycutting
the mains cable as close as possible to the plug body and dispose
of it as described above.
Replacement fuse covers:
If a replacement fuse cover is fitted, it must be of the correct colour
asindicatedbythecolouredmarkingorthecolourthatisembossed
in words on the base of the plug. Replacements can be obtained
directly from your nearest Service Depot.
Adapting the cooker to different types of gas
Inordertoadaptthecookertoadifferenttypeofgaswithrespect
to the gas for which it was produced (indicated on the label
attached to the lid), follow these steps:
a) replace the hose holder mounted on the appliance with that
supplied in the bag of “cooker accessories”.
Important: the hose holder for liquid gas is marked 8, the hose
holder for methane gas is marked 13. Always fit the sealing
gasket.
Removing the plug:
Ifyourappliancehasanon-rewireablemouldedplugandyoushould
wish to remove it to add a cable extension or to re-route the mains
cable through partitions, units etc., please ensure that either:
•
theplugisreplacedbyafused13ampre-wireableplugbearing
the BSI mark of approval.
b) Replacing the burner nozzles on the hob:
or:
•
•
remove the grids and slide the burners from their housings;
unscrew the nozzles using a 7 mm socket spanner, and
replace them with nozzles for the new type of gas (see table
1 “Burner and nozzle characteristics”).
•
the mains cable is wired directly into a 13 amp cable outlet,
controlled by a switch, (in compliance with BS 5733) which is
accessible without moving the appliance.
Please note: for appliances with a rating greater than 13 amp (eg:
electric hob, double ovens and freestanding electric cookers etc.)
•
replaceallthecomponentsbyrepeatingthestepsinreverse
order.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
V
c) Minimum regulation of the hob burners:
•
•
turn the tap to minimum;
Fig. C
Fig. D
remove the knob and adjust the regulation screw, which is
positioned in or next to the tap pin, until the flame is small but
steady.
N.B.: in the case of liquid gas, the regulation screw must be
screwed in to the bottom.
b) Minimum regulation of the gas oven burner with thermostat
(see fig.):
•
•
lighttheburnerasdescribedintheparagraph“theovenknob”
of the instruction booklet.
turn the knob to Max for about 10 minutes and then turn the
knob to the Min setting;
remove the knob;
regulate the screw positioned outside the thermostat pin
until the flame is small but steady.
•
check that the flame does not turn off when you turn the tap
quickly from high to low.
•
•
d) Regulating the primary air of the burners:
The primary air of the burners requires no regulation.
Adapting the gas oven to different types of gas
a) Replacing the oven burner nozzle:
•
•
N.B.: in the case of liquid gas, the regulation screw must
be screwed in to the bottom.
remove the warming drawer;
in the case of models without warming drawer, remove the
panel “P” as indicated in Fig. A. Open the door, release the
two top inserts by pressing them downwards, and then the
two bottom inserts by pressing them upwards.
remove the sliding protection “A”;
•
•
remove the two screws to dismount the protection “B”;(see
Fig. B);
•
•
remove the screw and then the oven burner“V”(see Fig.C).
Remove the oven door to facilitate this operation.
unscrew the oven burner nozzle using the special socket
spanner for the nozzles (see Fig. D), or better still a 7 mm
socket spanner, and replace it with a nozzle suited to the
new type of gas (see table 1).
•
check that the burner does not turn off when you turn the
knob from Max to Min and and when you open and close
the oven door quickly.
Adapting the gas grill to different types of gas
Replacing the nozzle of the grill burner:
•
remove the screw and then slide out the grill burner “V”
(see Fig. E);
•
unscrew the grill burner nozzle using the special socket
spanner for the nozzles (see Fig. F) or better still a 7 mm
socket spanner;replace the nozzle with a nozzle for the new
type of gas (see table 1).
A
B
Fig. A
Fig. B
V
I
Fig. E
Fig. F
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Important:when mounting the grill burner check that there is a
space of at least 4 mm between the security thermocouple (if
installed) and the burner.
Important
On completion of the operation, replace the old rating sticker
with one indicating the new type of gas used. This sticker is
available from our Service Centres.
Note
Should the pressure of the gas used be different (or vary) from
the recommended pressure, it is necessary to fit a suitable
pressure regulator onto the inlet pipe in compliance with current
National Regulations relative to“regulators for channelled gas”.
Raised border assembly (only on a few models)
To assemble the raised border correctly, please follow the
instructions below:
·
Unscrew the 4 screws and the 2 spacers on the rear
part of the worktop;
·
·
Place the raised border on the rear part of the worktop;
Screw the raised border onto the worktop using the
four screws you previously removed, ensuring that you
reposition the spacers on the outermost screws.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Burner and nozzle characteristics
Table 1
Liquid Gas
Natural Gas
Burner
Diameter
(mm)
Thermal Power
kW (p.c.s.*)
By-Pass Nozzle
Flow*
g/h
Nozzle
1/100
Flow*
l/h
1/100
1/100
Nominal
3.00
Reduced
0.7
(mm)
41
(mm)
86
***
**
(mm)
116
Fast
(Large)(R)
100
75
218
214
286
181
95
Semi Fast
(Medium)(S)
1.90
1.00
3.25
0.4
0.4
1.5
30
30
63
70
50
91
138
73
136
71
106
79
Auxiliary
(Small)(A)
55
Triple Crown
(TC)
130
236
232
133
309
Oven
Grill
-
-
3.02
2.50
1.0
-
49
-
85
80
219
182
216
179
132
122
288
227
Nominal (mbar)
Minimum (mbar)
Maximum (mbar)
28-30
20
35
37
25
45
20
17
25
Supply
Pressures
*
At 15°C and 1013 mbar- dry gas
**
***
Propane
Butane
Natural
P.C.S. = 50,37 MJ/Kg
P.C.S. = 49,47 MJ/Kg
P.C.S. = 37,78 MJ/m3
S
R
S
S
R
A
A
TC
K 642 G/G
K 642 GS/G
K 642R GS/G
K 643 G/G
K 6432 G/G
K 645 G/G
K 645R G/G
K 647 GS/G
K 647R G/G
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Technical characteristics
Mains frequency and voltage of the electric section and characteristics of the gas section
Model
Gas section
Electric section
Rated power
kW (1)
Class
II2H3+
II2H3+
Voltage
K 642 G/G
K 642 GS/G
K 642R GS/G
K 643 G/G
K 6432 G/G
K 645 G/G
10,82 (787 g/h - G30)
(773 g/h - G31)
230V~
230V~
50/60Hz
50/60Hz
K 645R G/G
K 647 GS/G
K 647R G/G
12,17 (885 g/h - G30)
(869 g/h - G31)
(1) The values in g/h refer to the capacities with liquid gas (Butane, Propane).
Inner dimensions of the oven:
Width: 40.7 cm
Depth: 41 cm
Height: 31 cm
Inner Volume of the Oven:
This appliance conforms with the following European
Economic Community directives:
50 lt
Innder dimensions of the plate plate warmer:
-
-
-
-
73/23/EEC of 19/02/73 (LowVoltage) and subsequent
modifications;
89/336/EEC of 03/05/89 (Electromagnetic
Compatibility) and subsequent modifications;
90/396/EEC of 29/06/90 (Gas) and subsequent
modifications;
Width: 43 cm
Depth: 43 cm
Height: 8 cm
Voltage and Frequency of Power Supply:
see data plate
93/68/EEC of 22/07/93 and subsequent modifications.
Burners:
adaptable for use with all the types of gas indicated on
the data plate
9
Download from Www.Somanuals.com. All Manuals Search And Download.
The cooker with gas oven
H
A
E
B
D
C
K
G
M
M
M
O
O
O
P
Q
P
L
L
L
N
N
N
F
A Tray for Catching Overflows
B Gas Burner
C Instantaneous Electronic Lighting Device (only a few
models)
K Oven Rack
L Electronic Lighting for Hob Burners (only a few mod-
els)
M Oven Control Knob
D Top Grate
E Control Panel
F Adjustable Feet or Legs
G Dripping Pan or Baking Sheet
H Flame Failure Device for Cooktop Burners (only a
few models)
N Control Knobs for Gas Burners on Hob
O Button for Oven and Rotisserie Light (only a few mod-
els)
P Timer Knob (only a few models)
Q Electronic timer (only a few models)
10
Download from Www.Somanuals.com. All Manuals Search And Download.
The different functions and uses of the oven
The various functions included in the cooker are selected
during the period between the time of production and
by operating the control devices located on the cooker
control panel.
installation of the appliance.
Attention: Only use the bottom shelf of the oven when
using the rotisserie to cook (where present). For all other
types of cooking, never use the bottom shelf and never
place anything on the bottom of the oven when it is in
operation because this could damage the enamel.Always
place your cookware (dishes, aluminium foil, etc. etc.) on
the grate provided with the appliance inserted especially
along the oven guides.
Control Knobs for the Gas Burners on the Hob
The position of the gas burner controlled by each one of
the knobs is shown by a symbol of a solid ring:•. To light
one of the burners, hold a lighted match or lighter near
the burner. Press down and turn the corresponding knob
in the counter-clockwise direction to the maximum
setting. Each burner can be operated at its maximum,
minimum or intermediate power. Shown on the knob are
The oven and grill knob (M)
This knob is used to select the different functions of the
oven and choose the right cooking temperature for the
food to be prepared in the oven among the temperatures
shown on the knob (from Min to Max).
the different symbols for off •(the knob is on this setting
when the symbol lines up with the reference mark on the
control panel), for maximum and minimum .
To obtain these settings, turn the knob counter-clockwise
with respect to the off position.To turn off the burner, turn
the knob clockwise until it stops (corresponding again with
To light the oven burner, hold a lighted match or lighter
near hole“F”and turn the oven knob counter anti clockwise
up to the Max position.
the •symbol).
Electronic Lighting of the Hob Burners (only a few
models)
Some models are equipped with instant electronic light-
ing of the gas burners located on the hob, which can be
identified by the presence of an igniter device (see detail
C).This device is activated by lighting pressing on the “L”
F
button, identified by the
symbol. To turn on a burner,
simply press the “L” button and then press while, at the
same time, pressing in and turning the control knob for
the burner in the anticlockwise direction until the burner
lights. To light the burner immediately, it is recom-
mended that the button be pressed first and then the
knob turned.
Caution: If the burner accidentally goes out, turn off
the burner using the knob and wait at least one minute
before relighting.
The models equipped with a safety device on oven
burner, the knob must be kept pressed in for about 6
seconds to activate the flame failure device. (For the
models provided with electronic lighting see the rela-
tive paragraph).
The cooking temperature is selected by matching the
desired temperature with the permanent reference on the
panel;the complete range of temperatures is shown below:
Min
•
150
•
180
•
220 Max
Models with Flame Failure Device (only a few models)
These models are identified by the presence of a flame
detection device (see detail H).
Important: Since the top burners are equipped with a
safety device, after lighting the burner keep the knob
pressed in for about 6 seconds to allow the gas to pass
until the safety thermocouple is heated.
130 140
160
200
250
The selected temperature is reached automatically and it
is kept constant by the knob-controlled thermostat.
To use the grill, turn the knob clockwise till to setting
, after holding a lighted match or a lighter close to
the grill burner.
Gas Cut Off (only a few models)
The models equipped with a safety device on grill
burner, the knob must be held pressed in for about 6
seconds in order to activate the flame failure device
(for the model provided with electronic lighting see
the relative paragraph). In this way the infrared ray comes
on for browning the food or cooking roast, chops,
sausages, roast-beef, etc.; for grill cooking, place a drip-
pan under the grill to catch the grease.
This cooker has a safety cut out feature which switches
off the burners when you close the cover. This device is
provided as a safety feature in case the cover is lowered
with the burners on. Always turn off the gas and allow the
burners to cool before closing the cover. Failure to follow
these instructions may cause the glass cover to shatter.
Keep the cover open when using the oven.
Oven and grill electronic lighting device (L) (only a
few models)
Some models are equipped with electronic lighting device
on oven and grill.
Attention: before using the oven and grill for the first time,
turn the oven on for approximately one half hour. Make
sure that the oven is empty, the thermostat on high, the
door open, and the room properly ventilated. The odor
which can be detected at times is due to the evaporation
off the substances used to protect the oven and the grill
To light the oven gas burner press in the botton marked
by the symbol , press deeply and turn the oven knob
11
Download from Www.Somanuals.com. All Manuals Search And Download.
clockwise, till to the position “Max”.
Oven light button (O)
It is necessary to hold pressed in the knob for about
6 seconds in order to activate the flame failure device.
To light on the grill burner press in the bottom marked
This is marked by the symbol
inside the oven so that you can control the cooking without
opening the door.
and switchs on the light
by the symbol , press deeply and turn the oven knob
Timer Knob (only a few models)
To use the timer, the ringer "S" must be wound up by turn-
counter clock wise till to the position
(grill).
It is necessary to hold pressed in the knob for about
6 seconds in order to activate the flame failure device.
In case of lack of electricity light the oven or grill manuall,
following the instruction of “the oven knob paragraph”.
ing the knob one full turn clockwise
; then turn it back
, to the desired time so that the number of minutes on
the knob matches the reference mark on the panel.
Attention
The rotisserie (only a few models)
Avoid the children touch the oven door because it is very
hot during the cooking.
When using the rotisserie act in this way:
a) fit supporting hook into the two holes in the lower side
of the grill protection (position A);
Practical advice for burner use
b) fit the spit into the hole in the centre of the back of the
oven, making sure that the fore clasping link of the spit
is correctly positioned on the supporting hook (position
B);
In order to get the maximum yield it is important to
remember the following:
·
Use appropriate cookware for each burner (see table)
so as to avoid flames overshooting the edges.
At boiling point turn the knob to minimum.
Use cookware with lids.
c) start up the rotisserie by pressing the botton "O".
·
·
·
Always use cookware with flat bottoms.
Burner
ø Cookware Diameter (cm)
Fast (R)
24 - 26
16 - 20
10 - 14
24 - 26
Semi Fast (S)
Auxiliary (A)
Triple Crown (TC)
N.B. On the models supplied with a reducer shelf,
remember that this should be used only for the auxiliary
burner when you use casserole dishes with a diameter
under 12 cm.
Electronic timer
Timer Feature
The electronic timer displays the time and the timer
function with countdown.
Press the
button to access this function. The symbol
Note: all the functions are operative approximately 7
seconds after they are stet.
" " will appear on the display.Each time you press button
, the time will increase by 10 seconds until 99 minutes
and 50 seconds. If you continue to press it, the time will
increase from minute to minute up to a maximum of 10
hours.
How to reset the clock
After the appliance has been connected to the power
supply, or when the power has gone out, the clock display
will automatically reset to 0:00 and begin to blink. 0 00
Use button
to go backwards.
After setting the desired time, start the countdown.When
the time has elapsed, the buzzer will sound, and it can be
interrupted by pressing any of the buttons.
•
Press the
button, and then use the
and
buttons to set the correct time. To move the time
forward quickly, keep the buttons pressed.
You can display the time by pressing button , and symbol
Whenever the time must be reset, follow this same
procedure.
" " indicates the timer function has been set. After
approximately 7 seconds, the display automatically goes
back to indicating the timer.
To cancel a previous setting
Press button
up until 0 • 00.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Cooking advice
The oven offers a wide range of alternatives which allow
I used more than one level and they are not all at
the same cooking point
you to cook any type of food in the best possible way.With
time you will learn to make the best use of this versatile
cooking appliance and the following directions are only a
guideline which may be varied according to your own per-
sonal experience.
Use a lower temperature setting. It is not necessary to
remove the food from all the racks at the same time.
Baking cakes
Cooking fish and meat
The oven should always be warm before putting in cakes
wait till the end of preheating (about 15 min.).Cake-baking
temperatures are normally around 160°C. Do not open
the oven door during the baking process as this could
cause the cake to sink.
Meat must weigh at least one Kg. to stop it becoming too
dry. When cooking white meat, fowl and fish use low
temperatures. (150°C-175°C). When red meat must be
superficially well-cooked but succulent inside, it is
advisable to start with a high temperature (200-220°C)
for a short time, and then to reduce it at a later point.
Generally speaking, the more meat there is, the lower the
temperature and the longer the cooking time should
be.Place the meat in the centre of the grid and put a spill-
tray underneath to catch grease drips. Insert the grid so
that it is in the middle of the oven. If more heat from below
is required, use the 1° bottom shelf. For tastier roasts,
wrap the meat with bacon rashers or dot the meat with
lard and place it in the upper part of the oven.When some
types of food are cooked in the ventilated oven (duck,
rabbit, large fowl) they become too dry; in these cases,
better results are obtained using the combined oven.
Beaten cake mixtures should not be too soft as this could
considerably lengthen cooking times. In general:
Pastry is too dry
Increase the temperature by 10°C and reduce the
cooking time.
Pastry dropped
Use less liquid or lower the temperature by 10°C.
Pastry is too dark on top
Place it on a lower rack, lower the temperature, and
increase the cooking time.
Cooked well on the inside but sticky on the
outside
Use less liquid, lower the tem perature, and increase
the cooking tim e.
The pastry sticks to the pan
Grease the pan well and sprinkle it with a dusting of
flour.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Cooker routine maintenance and cleaning
Before each operation, disconnect the cooker from
Replacing the oven lamp
the electricity.To assure the long life of the cooker, it must
be thoroughly cleaned frequently, keeping in mind that:
· Do not use steam equipment to clean the appliance.
· the enamelled parts and the self-cleaning panels are
washed with warm water without using any abrasive
powders or corrosive substances which could ruin
them;
·
·
·
Unplug the oven from the mains;
Remove the glass cover of the lamp-holder;
Remove the lamp and replace with a lamp resistant to
high temperatures (300°C) with the following
characteristics::
- Voltage 230V
- Wattage 25W
· the inside of the oven should be cleaned fairly often
while it is still warm using warm water and detergent,
followed by careful rinsing and drying;
- Type E14
· the flame spreaders should be washed frequently with
hot water and detergent taking care to eliminate any
scale;
· in cookers equipped with automatic lighting, the
terminal part of the electronic instant lighting devices
should be cleaned frequently and the gas outlet holes
of the flame spreaders should be checked to make
sure they are free of any obstructions;
· Stainless steel may become marked if it comes into
contact with very hard water or harsh detergents
(containing phosphorous) for long periods of time.After
cleaning, it is advisable to rinse thoroughly and dry. It
is also recommended to dry any water drops;
·
Replace the glass cover and reconnect the oven to
the mains.
Greasing theTaps
• On models with glass covers, the covers should be
cleaned with hot water; the use of rough cloths or
abrasives is to be avoided.
N.B: avoid closing the cover while the gas burners
are still warm. Remove any liquid from the lid before
opening it.
The taps may jam in time or they may become difficult to
turn. If so, the tap itself must be replaced.
N.B.:This operation must be performed by a technician
authorised by the manufacturer.
Important: periodically check the wear of the gas hose
and substitute it if there are any defects;we recommended
changing it every year.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Pratical advice for oven cooking
Food to be cooked
Wt.
(Kg)
Cooking position
of shelves from
bottom
Temperature
Pre-heating time
Cooking time
(°C)
(min)
(min.)
Pasta
Lasagne
Cannelloni
Pasta bakes
2.5
2.5
2.5
3
3
3
210
210
210
15
15
15
75-80
75-80
75-80
Meat
Veal
1.7
1.5
3.0
1.8
2.0
2.1
1.8
3
3
3
3
3
3
3
230
220
Max
230
230
230
230
15
15
15
15
15
15
15
85-90
110-115
95-100
120-125
105-110
100-110
90-95
Chicken
Turkey
Duck
Rabbit
Pork
Lamb
Fish
Mackerel
Dentex
Trout baked in paper
1.1
1.5
1.0
3
3
3
210-230
210-230
210-230
15
15
15
55-60
60-65
40-45
Pizza
Neapolitan
1.0
3
Max
15
30-35
Cake
Biscuits
Tarts
Chocolate cake
Raised Cakes
0.5
1.1
1.0
1.0
3
3
3
3
180
180
200
200
15
15
15
15
30-35
30-35
45-50
50-55
Grill cooking
Toasted sandwiches
Pork chops
n.° 4
1.5
1.1
4
4
4
10
30
35
Mackerel
Rotisserie
Veal on the spit
Chicken on the spit
1
2
2
2
80
90
NB: cooking times are approximate and may vary according to personal taste.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Merloni Elettrodomestici
Viale Aristide Merloni 47
60044 Fabriano
Italy
Tel +39 0732 6611
Fax +39 0732 662501
Download from Www.Somanuals.com. All Manuals Search And Download.
|