ST IG A
PARK
VILLA
READY
8211-0209-13
Download from Www.Somanuals.com. All Manuals Search And Download.
EN
ENGLISH
•
•
Be careful when driving on slopes. No sudden
starting or stopping when moving up or down a
slope.
Release the clutch pedal slowly. Always drive
with the gear engaged, and do not disengage
when driving down slopes.
Never cut across a slope. Move from the top
down, and from the bottom to the top.
Use low acceleration when engaging the drive,
especially in long grass. Reduce the speed on
slopes and when making sharp turns to prevent
the machine from tipping over or you losing
control of the machine.
•
•
Only use accessories that are approved by the
machine’s manufacturer.
The machine may not be used without
accessories/tools being installed in the
machine’s tool mounts. Driving without
accessories can have a negative effect on the
stability of the machine.
Take care when using grass collectors and other
accessories. These can alter the machine’s
stability. Particularly on slopes.
Disengage the drive to the accessories, shut off
the engine and disconnect the spark plug cable
or remove the starter key:
•
•
•
•
•
•
Watch out for holes in the ground and other
hidden dangers.
Do not drive too near ditches or high edges.
The machine can turn over if a wheel drives
over the edge or the edge breaks.
Take care when towing and when using heavy
equipment.
a. Only use an approved towing device.
b. Limit the load so that it can be controlled
safely.
c. Do not make any sudden turns. Take care
when reversing.
d. Use wheel weights or front weight when
recommended in the user instructions.
Look out for traffic at crossings or when driving
near roads.
Stop the blade(s) when crossing a surface other
than grass during mowing.
When using any of the accessories, never direct
the discharge at somebody standing beside it,
and do not allow anyone to stand near the
machine when it is running.
Never operate the machine with insufficient
protection or without the safety devices in
place.
Existing safety devices may not be
disconnected or disengaged. Check that the
safety devices work each time before using the
machine.
Do not alter the engine’s regulator setting and do
not race the engine. The danger of personal injury
increases when the engine is run at high revs.
Do not touch engine components which become
warm during use. Risk of burn injuries.
Do not leave the driving seat without:
a. Disengaging the power take-off and lowering
the accessories.
a. To remove sticks and rubbish or when the
discharge has become clogged.
b. To check, clean or service the machine.
c. To check whether damage has occurred and
to carry out any repairs before starting and
using the machine again after a collision with a
foreign object.
d. To check the machine if it begins to vibrate
excessively. (Check immediately).
Disengage the drive to accessories during
transport or when the machine is not in use.
Shut off the engine and disconnect the drive to
the accessories:
a. Before filling with petrol.
b. Before removing the grass collector.
c. Before adjusting the height setting, assuming
this cannot be done from the driver’s position.
Reduce the acceleration when the engine is to
be stopped, and if the engine is equipped with a
fuel shut-off valve, this should be switched off
when the work is finished.
Take care with multiple blade decks as one
rotating blade can cause other blades to rotate.
The machine, equipped with original
•
•
•
•
•
•
•
•
•
•
•
accessories, must not be driven in any direction
on slopes with a gradient greater than 10º.
•
The cutting deck’s original blade(s) may not be
replaced with non-original devices intended for
e.g. moss scarification. If such devices are used,
the guarantee will cease to be valid. There is
also a risk of serious injury or damage to people
or property.
•
•
Take care when unloading and loading the
machine onto a trailer or lorry.
•
•
1.4 MAINTENANCE AND STORAGE
Tighten all nuts and screws so that the machine
is in safe working condition.
At regular intervals check that the cutting
deck’s blade screw(s) are properly tightened.
Regularly check the operation of the brakes. It
•
•
•
b. Putting the gear in neutral and activating the
parking brake.
c. Stopping the engine and removing the key.
24
Download from Www.Somanuals.com. All Manuals Search And Download.
EN
ENGLISH
is important to maintain and repair the brakes if
necessary.
Never store the machine with petrol in the tank
in buildings where the fumes can come into
contact with open flames or sparks.
2 STORAGE
Empty the petrol tank. Start the engine and let it
run until it stops.
•
Replace the oil while the engine is still warm.
•
•
Allow the engine to cool before placing the
machine in a store.
To reduce the risk of fire, keep the engine,
silencer, battery and petrol tank free from grass,
leaves and surplus oil.
Check frequently whether there is any wear or
damage to the grass collector.
For the sake of safety, replace worn or damaged
parts.
Always use genuine spare parts. Non-genuine
spare parts can entail a risk of injury, even if
they fit the machine.
Replace damaged warning and instruction
stickers.
If there is no mechanical lock for the transport
position, the cutting deck must be lowered
when parked, stored or when the machine is left
unsupervised.
If the petrol tank is to be emptied, this must take
place outdoors.
Unscrew the spark plug and pour a tablespoonful
of oil into the cylinder. Rotate the engine a few
turns to that the oil is distributed in the cylinder.
Install the spark plug.
Clean the entire machine. It is particularly
important to clean under the cutting deck. Touch
up paint damage to prevent rust.
Store the machine indoors in a dry place.
Machines with an electric starter:
Remove the battery. Store it well charged in a cool
place (between 0°C and +15°C).
At the correct storage temperature, the battery
should be maintenance-charged every four
months.
•
•
•
•
•
The battery acid is extremely corrosive
and can cause injuries and damage to
skin and clothing. Always use rubber
gloves and glasses (goggles) to protect
your eyes. Avoid inhaling any acid
vapour.
•
Do not incline the battery too much so
that the battery acid can run out onto
hands or clothing. If this should
•
•
Store the machine so that children cannot get to it.
The battery contains acid. In the event of
mechanical damage or overcharging, acid can
leak out.
happen, rinse with plenty of water.
•
•
Never overcharge the battery. Overcharging can
cause the battery to explode, throwing the acid
in all directions.
If acid comes into contact with the eyes or skin,
this can cause serious injuries. If any part of the
body has come into contact with acid, rinse
immediately with copious amounts of water and
seek medical assistance as soon as possible.
Fumes from acid that are inhaled cause damage
to mucous membranes and other internal
organs. Seek medical assistance if acid fumes
have been inhaled.
Acid causes serious damage to tools, clothes
and other material. Rinse away spilled acid
immediately with water.
Do not short circuit the battery’s terminals.
Sparks occur which can result in fire. Do not
wear metal jewellery which can come into
contact with the battery terminals.
In the event of damage to the battery casing,
cover, terminals or interference to the strip
covering the valves, the battery should be
replaced.
3 SERVICE
Authorised service workshops carry out repairs
and guarantee service. They use original spare
parts.
STIGA original spare parts and accessories are
designed specifically for STIGA machines.
Please note that ‘non-original’ spare parts and
accessories have not been checked or approved
by STIGA.
•
The use of such parts and accessories
can affect the function and safety of the
machine. STIGA accepts no
responsibility for damage or injuries
caused by such products.
•
•
Original spare parts are supplied by service
workshops and by many dealers.
A list of these can be found on STIGA’s Internet
We recommend that the machine be handed in to
an authorised service workshop for service,
maintenance and checking of the safety devices
once a year.
•
25
Download from Www.Somanuals.com. All Manuals Search And Download.
EN
ENGLISH
As soon as possible after acquiring the machine,
the above number should be written in on the last
page of this publication.
4 PURCHASE TERMS
A full guarantee is issued against manufacturing
and material defects. The user must carefully fol-
low the instructions given in the enclosed docu-
mentation.
6 ENVIRONMENT
Guarantee period
For environmental reasons, we recommend that
particular attention is given to the following
points:
For consumer use: two years from purchase date.
For professional use: 300 hours or three months,
whichever comes first.
•
Always use Alkylate petrol (“Environmental
petrol“).
For Stiga Park and Stiga Villa, it is possible to have
a one year extension to the guarantee if the condi-
tions in the service book are satisfied.
For batteries: six months from the purchase date.
Exceptions
The guarantee does not cover damage due to:
•
Always use a funnel and/or a petrol can with
overfill protection to avoid spillage when filling
with petrol.
•
•
Do not fill the petrol tank right to the top.
Do not fill too much engine and/or transmission
oil (see user instructions for the correct
amount).
-
neglect of the user to acquaint himself with ac-
companying documentation
-
-
-
-
carelessness
incorrect and non-permitted use or assembly
the use of non-genuine spare parts
the use of accessories not supplied or approved
by Stiga
•
•
•
Collect up all oil during oil changes. Do not
spill any. Hand in the oil to a recycling station.
Do not discard replaced oil filters with normal
rubbish. Hand them in to a recycling station.
Do not discard replaced lead batteries with
normal rubbish. Hand in to a battery collection
point for recycling.
Neither does the guarantee cover:
-
wearing components such as blades, belts,
wheels and cables
•
•
Replace the silencer if it is broken. Always use
original spare parts when carrying out repairs.
If the machine was originally equipped with a
catalytic converter and this is broken, a new
catalytic converter must be installed after
removing the old one.
Always get a specialist to adjust the carburettor
if necessary.
Clean the air filter according to the instructions
given (see user instructions).
-
-
normal wear
engine and transmission. These are covered by
the appropriate manufacturer’s guarantees with
separate terms and conditions.
The purchaser is covered by each country’s
national laws. The rights to which the purchaser is
entitled with the support of these laws are not
restricted by this guarantee.
•
•
5 PRODUCT IDENTITY
The identity of the product is determined by two
7 INSURE YOUR RIDE-ON
LAWNMOWER
Check the insurance for your new ride-on
lawnmower. Contact your insurance company.
parts:
1. The machine’s item and serial numbers:
You ought to have fully comprehensive insurance
for traffic, fire, damage and theft.
2. The engine’s model, type and serial numbers:
Use these identification terms during all contact
with service workshops and when purchasing
spare parts.
GGP reserves the right to make alterations to the
product without prior notification.
26
Download from Www.Somanuals.com. All Manuals Search And Download.
ANSI B71.1-2003
17. Always wear eye protection when operating
the machine.
1 IMPORTANT
18. Data indicates operators 60 years and above are
involved in a large percentage of riding mower-
related injuries. These operators should
evaluate their ability to operate the riding
mower safely enough to protect themselves
and others from serious injury.
Safe Practice for Ride-On Mowers
(ANSI B71.1 - 2003)
This cutting machine is capable of amputating
hands and feet and throwing objects. Failure to
observe the following safety instructions could
result in serious injury or death.
19. Follow the manufacturer´s recommendation
for wheel weights or counterweights.
1.1 General operation
1. Read, understand, and follow all instructions
on the machine and the manual(s) before
starting.
2. Do not put hands or feet near the rotationg parts
or under the machine. Keep clear of the
discharge opening at all times.
3. Only allow responsible adults, who are familiar
with the instructions, to operate this machine.
4. Clear the area of objects such as rocks, wire,
toys, etc., wich could be thrown by the
blade(s).
1.2 Slope operation
Slopes are a major factor related to loss of control
and tip-over accidents, wich can result in severe
injury or death. Operation on all slopes requires
extra caution. If you cannot back up the slope or if
you feel uneasy on it, do not mow it.
1. Mow up and down slopes, not across.
2. Watch for holes, ruts, bumps, rocks, or other
hidden objects. Uneven terrain could overturn
the machine. Tall grass can hide obstacles.
3. Choose a low ground speed so you will not
have to stop or shift while on a slope.
4. Do not mow on wet grass. Tires may lose
traction.
5. Always keep the machine in gear when going
down slopes. Do not shift to neutral and coast
downhill.
6. Avoid starting, stopping, or turning an a slope.
If the tires lose traction, disengage the blade(s)
and proceed slowly straight down the slope.
7. Keep all movement on slopes slow and
gradual. Do not make sudden changes in speed
or direction, wich could cause the machine to
roll over.
8. Use extra care while operating machine with
grass catchers or other attachments; they can
affect the stability of the machine. Do not use
on steep slopes.
9. Do not try to stabilize the machine by putting
your foot in the ground.
5. Be sure the area is clear of bystanders before
operating. Stop the machine if anyone enters
the area.
6. Never carry passengers.
7. Do not mow in reverse unless absolutely
necessary. Always look down and behind
before and while backing.
8. Never direct discharge material toward anyone.
Avoid discharging material against a wall or
obstruction. Material may rocochet back
toward the operator. Stop the blade(s) when
crossing gravel surfaces.
9. Do not operate machine without the entire
grass catcher, discharge guard, or other safety
devices in place and working.
10. Slow down before turning.
11. Never leave a running machine unattended.
Always turn off blade(s), set parking brake,
stop engine and remove key before
dismounting.
12. Disengage blade(s) when not mowing. Shut off
engine and wait for all parts to come to a
complete stop before cleaning the machine,
removing the grass catcher, or unclogging the
discharge guard.
13. Operate machine only in daylight or good
artificial light.
14. Do not operate machine while under the
influence of alcohol or drugs.
10. Do not mow near drop-offs, ditches or
embankments. The machine could suddenly
roll over if a wheel goes over the edge or if the
edge caves in.
1.3 Children
Tragic accidents can occur if the operator is not
alert to the presence of children. Children are often
attracted to the machine and mowing activity.
Never assume that children will remain where you
last saw them.
15. Watch for traffic when operating near or
crossing roadways.
16. Use extra care when loading or unloading the
machine into a trailer or truck.
1. Keep children out of the mowing area and in
the watchful care of a responsible adult other
than the operator.
2. Be alert and turn machine off if a child enters
the area.
74
Download from Www.Somanuals.com. All Manuals Search And Download.
ANSI B71.1-2003
3. Before and while backing, look behind and
9. If fuel is spilled on clothing, change clothing
immediately.
down for small children.
4. Never carry children, even with the blade(s)
shut off. They may fall off and be seriously
injured or interfere with safe machine
operation. Children who have been given rides
in the past may suddenly appear in the mowing
area for another ride and be run over or backed
over by the machine.
10. Never overfill fuel tank. Replace gas cap and
tighten securely.
1.5.2 General service
1. Never operate machine in closed area.
2. Keep all nuts and bolts tight to be sure the
equipment is in safe working condition.
5. Never allow children to operate the machine.
3. Never tamper with safety devices. Check their
proper operation regularly.
4. Keep machine free of grass, leaves, or other
debris build-up. Clean up oil or fuel spillage
and remove any fuel-soaked debris. Allow
machine to cool before storing.
5. If you strike a foreign object, stop and inspect
the machine. Repair, if necessary, before
restarting.
6. Use extreme care when approaching blind
corners, shrubs, trees, or other objects that may
block your view of a child.
1.4 Towing
1. Tow only with a machine that has a hitch
designed for towing. Do not attach towed
equipment except at hitch point.
2. Follow the manufacturer´s recommendation
for weight limits for towed equipment and
towing on slopes.
3. Never allow children or others in or on towed
equipment.
4. On slopes, the weight of the towed equipment
may cause loss of traction and loss of control.
5. Travel slowly and allow extra distance to stop.
6. Never make any adjustments or repairs with
the engine running.
7. Check grass catcher components and the
discharge guard frequently and replace with
manufacturer´s recommended parts, when
necessary.
8. Mover blades are sharp. Wrap the blade or
wear gloves, and use extra caution when
servicing them.
9. Check brake operation frequently. Adjust and
service as required.
1.5 Service
1.5.1 Safe handling of gasoline
To avoid personal injury or property damage, use
extreme care in handling gasoline. Gasoline is
extremely flammable and the vapors are explosive.
10. Maintain or replace safety and instruction
labels, as necessary.
1. Extinguish all cigarettes, cigars, pipes, and
other sources of ignition.
2. Use only an approved gasoline container.
3. Never remove gas cap or add fuel with the
engine running. Allow engine to cool before
refueling.
4. Never fuel the machine indoors.
5. Never store the machine or fuel container
where there is an open flame, spark, or pilot
light such as on a water heater or other
appliances.
6. Never fill containers inside a vehicle or on a
truck or trailer bed with a plastic liner. Always
place containers on the ground away from your
vehicle before filling.
7. Remove gas-powered equipment from the
truck or trailer and refuel it on the ground. If
this is not possible, then refuel such equipment
with a portable container, rather than from a
gasoline dispenser nozzle.
8. Keep the nozzle in contact with the rim of the
fuel tank or container opening at all times until
the fueling is complete. Do not use a nozzle
lock-open device.
75
Download from Www.Somanuals.com. All Manuals Search And Download.
w ww.st iga.co m
Box 1006 SE-573 28 TRANÅS
GGP Sweden AB
·
·
Download from Www.Somanuals.com. All Manuals Search And Download.
|