ELECTRICAL
YOUR MUSTANG’S ELECTRICAL SYSTEM
Like most cars, your Mustang’s electrical system consists of a
“primary” and “secondary” system. The “primary” system is
everything related to the engine’s starting and ignition system.
The “secondary”system consists of all wiring for headlights,
tailights, and interior lights. Refer to the wiring diagram books
that we sell. Also, pick up a (Repro) Shop Manual . After
studying the schematics for some time, you’ll easily understand
how everything works. We have grouped this section by specific
areas (starting, charging, interior, headlights, tailights and
wiring looms), to help you find what you may need.
B1
A1
REPRODUCTION AUTOLITE BATTERIES
Autolite batteries are an excellent reproduction for your ‘65-’72
Mustang. Case is original type with proper lettering. Case also includes
original “tabs” for proper mounting on early batteries. Batteries include
state-of-the-art “guts” for easy starting. Group 24 only currently
available. Shipped dry (you will need to find a local source for
Electrolite). L10.75” W/Tab x W6.75” x H9”.
65-72 .. AUT-B101 ..............500 Cold cranking amps ... 99.00
65-72 .. AUT-B102 ..............650 Cold cranking amps . 129.95
Note: 12 volt negative ground means that your Mustang’s frame
and metal body is the negative side of the electrical system. The
wiring in your car carries the positive side to lights, etc.
AUTOLITE BATTERY COVER
Give your car the original look, with the use of any 24F60 flat top
maintenance free battery with the correct post location. Easy to install,
just follow the instructions.
A1 65-72 .. AUT-C101 ..............Cover & Tag ..................... 44.95
OPTIMA BATTERY
Optima is a sealed, zero-maintenance battery that last
longer, recharges faster, more dependable than any
battery on the market. It can’t even leak, so it can be
shipped UPS ready to go! L9.94” x W6.75” x H7.81”
B1 65-73 .. 800S .....................800 Cold cranking amps . 139.95
BATTERY CABLE BRACKETS & GROMMETS
C1 65-66 .. C5ZZ-14302KR ......Bracket with Grommets ...pr.9.95
65-66 .. STARTER GROMMET Grommet only................... 1.99
D1
MOTORCRAFT BATTERY CABLES
These cables give you the 60’s look with 90’s Performance.
65-68 .. 64-GRW ................Engine to firewall ............... 6.95
65-73 .. 7164 .....................Solenoid to Starter ........... 14.95
65-73 .. 7304 .....................Ground Cable ................. 16.95
65-73 .. 7364 .....................Battery to Solenoid........... 14.95
E1
C1
CONCOURS BATTERY CABLE SETS
Sets of Three Concours Quality, Style and Markings.
65-66 .. 64-BC-6.................I6................................... 49.95
D1 65-66 .. 64-BC-8.................V8.................................. 49.95
67-69 .. 67-BC-6.................I6................................... 49.95
67-69 .. 67-BC-8.................V8.................................. 49.95
70-71 .. 70-BC-6.................I6................................... 49.95
70-71 .. 70-BC-8.................V8.................................. 49.95
72-73 .. 72-BC-6.................I6................................... 49.95
72-73 .. 72-BC-8.................V8.................................. 49.95
DIAMONDBACK SHIELDED BATTERY CABLES
Braided alloy shielding gives you the great “Braided”
look and resists heat and abrasion. Heavy duty 4 gauge
cable with Solid brass terminals - 3 times more conductive
than lead.
65-73 .. 20142 ...................Solenoid to Starter ........... 13.95
65-73 .. 20038 ...................Ground Cable .................. 15.99
E1 65-73 .. 20012 ...................Battery to Solenoid........... 11.99
BATTERY POST TO FENDER SHIELD
66 ....... C6ZZ-10760AR ......Can be used on ‘65 ............ 2.95
BATTERY HINTS
When replacing the battery, wear safety goggles,
and make sure the ignition is in the “off” position.
Keep flame and sparks away. When picking up the
battery, avoid pressing on sides, as it may force
positive (+) and negative (-). On ‘64-’73 Mustangs, the positive cable is
mounted between the positive battery terminal and solenoid, and is
usually shorter. The negative cable goes from the battery (neg) to the
engine block (ground).
gas and/or acid from the top. Replace clean cable ends, before
installing your new battery. Be sure cables are properly oriented
Note: Most “dead” batteries that fail to start on a cold morning, many
times is actually because of dirty battery terminals and cable ends.
36
ELECTRICAL
STARTER SOLENOID
65-73 .. HDWR-266 ............Mounting screws ................ 1.00
M1 64-73 .. SW-3 .....................ALL ................................ 21.00
Solenoids with the concours markings and color.
64-65 .. C5AZ-11450AR ......All .................................. 34.95
66 ....... C6AZ-11450AR ......All .................................. 34.95
67-71 .. C7AZ-11450AR ......All .................................. 34.95
72-73 .. D2AF-11450AR......All .................................. 34.95
N2
N3
M1
N1
N4
CONCOURS VOLTAGE REGULATOR
65-73 .. HDWR-266 ............Mounting screws ................ 1.00
65-66 .. HDWR-436 ............Mounting screw protectors .. 1.00
N1 64 ....... C2AF-10505BR ......Gen ................................ 49.95
N1 64 ....... C4TF-10316DR ......Gen W/ AC ...................... 44.95
N2 65-67 .. C5AF-10316BR ......Black .............................. 44.95
N3 68-70 .. C8TF-10316AR ......Blue ............................... 44.95
P1
Q1
ELECTRONIC VOLTAGE REGULATOR
For state-of-the-art voltage for your early Mustang, this regulator will
do the job. Bolt in replacement. A must w/ 120 amp alternators.
65-73 .. HDWR-266 ............Mounting screws ................ 1.00
N4 65-73 .. GR-540-A...............All .................................. 44.95
ALTERNATOR TROUBLESHOOTING
The alternator is the one part that tells you when
it’s going bad. When the light on the dash (ALT)
comes on, or flickers, it usually means that one
REMANUFACTURED GENERATOR
Remanufactured, ask for current details on core.
P1 64 ....... 5855 .....................I6................................... 89.95
P1 64 ....... 5838 .....................V8.................................. 59.95
(or both) of the two diodes in the alternator has failed, and it’s time
for a new or rebuilt one. If you’re unsure, a local shop can run an
electrical test on the alternator, voltage regulator and battery.
Sometimes a low engine idle, and/or loose belt can make the “ALT”
light flicker. When an alternator fails it usually takes the voltage
regulator along with it. So it’s highly advisable to replace both. If you
drive your Mustang a lot, we recommend a state-of-art Motorcraft
Voltage Regulator No. GR-540-A (‘65-’73). For ‘67-70 Shelbys and
‘68 California Specials, a higher amp alternator is recommended for
those Cougar/T-Bird tailights. Use higher amp versions for air
conditioning, too. Concours Restorers should rebuild their
GENERATOR WIRE HARNESS
64 ....... 64-GEN-6 ..............I6................................... 59.95
64 ....... 64-GEN-8 ..............8Cyl ............................... 59.95
REMANUFACTURED ALTERNATOR
Remanufactured, ask for current details on core.
Q1 65-69 .. 66189 ...................I6, 60 Amp ..................... 69.95
Q1 65-68 .. 66190 ...................SB, FE, 60 Amp .............. 59.95
Q1 72-73 .. 66197 ...................250, 100 Amp .............. 149.95
Q1 72-73 .. 66198 ...................302, 100 Amp .............. 149.95
Q1 72-73 .. 66198 ...................351, 100 Amp .............. 149.95
Q1 65-73 .. ALT-101.................Terminal Covers ................. 4.95
alternators with our kit instead of a rebuilt/exchange.
ALTERNATOR - HI-PO PULLEY
Bolt-on HP! Factory on all 65’-68’ Shelby High rpm pulley
65-70 .. C5ZZ-10344AR ......Steel............................... 29.95
MUSTANG WIRING LOOMS AND HARNESSES
Rewiring your Mustang, using reproduced looms
and harnesses should not seem as difficult as at
ALTERNATOR - WIRING HARNESS (E5)
Alternator to Regulator. (1 of 3 under hood looms) Attaches to the
first impression.
back of alternator, plugs into main headlight harness and ground.
65 ....... 65-ALT-101............I6 W/ Lamps ................... 21.95
65 ....... 65-ALT-102............V8 W/ Lamps .................. 21.95
65 ....... 65-ALT-103............I6 W/ Gauges .................. 21.95
65 ....... 65-ALT-104............V8 W/ Gauges ................. 21.95
66 ....... 66-ALT-105............I6 All .............................. 19.95
66 ....... 66-ALT-106............V8 All ............................. 19.95
67-68 .. 67-ALT-107 ............I6 W/O Tach .................... 21.95
67-68 .. 67-ALT-108 ............V8 W/O Tach ................... 29.95
67-68 .. 67-ALT-110 ............BB W/ Tach ..................... 29.95
69 ....... 69-ALT-111............All W/O Tach ................... 24.95
69 ....... 69-ALT-112............All W/ Tach...................... 49.95
70 ....... 70-ALT-113............All W/O Tach ................... 29.95
70 ....... 70-ALT-114............All W/ Tach...................... 49.95
71 ....... 71-ALT-115............All W/O Instrument .......... 39.95
71 ....... 71-ALT-116............All W/ Instrument............. 39.95
72 ....... 72-ALT-117............All W/O Instrument .......... 39.95
72 ....... 72-ALT-118............All W/ Instrument............. 39.95
Your Mustang is basically made up of an under-dash harness with
two attached “looms.” These looms include the firewall to headlamp
and dash to taillight. From the firewall to headlamp loom is attached
the alternator to voltage regulator loom. Courtesy lights (roof)
come off the taillight loom. The under-dash harness includes many
plugs for the headlight, turn signal and wiper switches. The cigar
lighter, radio, courtesy lights, dash lights, tach, etc., also go through
the under-dash harness. If you’re thoroughly confused by now, get a
copy of the Wiring Diagrams Book.
If you are unsure about wiring your car, an auto electric shop can
install your looms for you. Don’t attempt wiring, splicing, etc., unless
you know what you’re doing, as an electrical fire can result from a
“mistake.”
38
ELECTRICAL
ALTERNATOR - BRACKETS
65-73...GY-934...................Adjusting Bracket .............. 43.00
65-73...GY-1014.................Mounting Bracket.............. 30.00
65-73...YS-30 .....................Mounting Spacer................. 7.00
65-69 .. M-10313-A302 ......Chrome Motorsport ....... pr.24.95
WIRE LOOM MOUNTING KIT
Includes all straps, anchors and clips need to install loom.
R1 64-66 .. C5ZZ-14000KR ......21piece kit ...................... 14.95
67 ....... C7ZZ-14000KR ......25 piece kit ..................... 19.95
68 ....... C8ZZ-14000KR ......24 piece kit ..................... 19.95
69 ....... C9ZZ-14000KR ......25 piece kit ..................... 24.95
R1
ENGINE GAUGE FEED (E2)
From firewall to engine components. On 64-66 it also plugs into heater
blower motor. (1 of 3 under hood wire looms)
65-73 .. O/P EXT .................Oil sending unit extension ... 9.95
65-73 .. HDWR-116 ............“J” wire clip for O/P EXT ..... 3.00
64 ....... 64-GF-101 .............I6................................... 34.95
64 ....... 64-GF-102 .............V8.................................. 34.95
65 ....... 65-GF-103 .............I6, w/lamps ..................... 29.95
65 ....... 65-GF-104 .............V8, w/lamps, 2 spd. heater 29.95
65 ....... 65-GF-104A ...........V8, w/lamps, 3 spd. heater 34.95
65 ....... 65-GF-105 .............I6, w/gauges.................... 34.95
65 ....... 65-GF-106 .............V8, w/gauges ................... 34.95
66 ....... 66-GF-107 .............I6................................... 34.95
66 ....... 66-GF-108 .............V8.................................. 34.95
67-68 .. 67-GF-109 .............I6................................... 21.95
67-68 .. 67-GF-110 .............SB, w/o tech.................... 21.95
67-68 .. 67-GF-111 .............SB, W/tech...................... 21.95
67-68 .. 67-GF-112 .............BB ................................. 21.95
68 ....... 68-GF-113 .............SB, w/AC ........................ 27.95
69-70 .. 69-GF-114 .............I6................................... 31.95
69-70 .. 69-GF-115 .............SB.................................. 24.95
69-70 .. 69-GF-116 .............BB ................................. 21.95
69 ....... 69-GF-119 .............Boss 302 ........................ 34.95
71-73 .. 71-GF-117 .............SB.................................. 21.95
71-73 .. 71-GF-118 .............BB ................................. 21.95
S2
S1
T1
FUSE - PARTS
65-68 .. FS-CL ....................Fuse Clips (10) ................ 10.95
65-73 .. 66421 ...................Fuse Kit w/o Instrument ... kit1.49
65-73 .. BP/SFE-4 ...............Instrument Fuse (5)............ 1.49
HEADLAMP
Incandescents are an OE replacement, Halogens give you 50% brighter
light with 25% longer range for better safety.
65-66 .. HDWR-223 ............Adjusting kit (one lamp) ...... 4.00
67-68 .. HDWR-412 ............“ ...................................... 4.00
69 ....... HDWR-413 ............“ ...................................... 5.50
70 ....... HDWR-414 ............“ ...................................... 4.00
71-73 .. HDWR-416 ............“ ...................................... 3.50
65-73 .. 6014 .....................Incandescent, (Exc. 69) ...... 4.95
T1 65-73...6014 SCRIPT..........Incandescent w/”FoMoCo” . 14.95
65-73 .. H6024...................Halogen, (Exc. 69) ........... 12.95
69 ....... 4000 .....................Incandescent, Low ............. 4.95
T1 69........4000 SCRIPT..........Incandescent, w/FoMoCo ... 14.95
69 ....... H5006...................Halogen, Low .................... 5.95
69 ....... 5001 .....................Incandescent, High ............ 4.95
T1 69........5001 SCRIPT..........Incandescent, w/”FoMoCo” 14.95
69 ....... H5001...................Halogen, High.................... 5.99
E1 - Heater Motor, ‘65-66 Part of E2
E2 - Engine Gauge Feed
E3 - Hood turn signial wiring
E4 - Headlamp loom wiring harness
E5 - Alternator wiring loom
E6 - Headlamp wiring extension ‘67-70
E7 - Firewall to solenoid N/A ‘67-70
HOW DO I KNOW IF MY HEADLIGHT SWITCH IS BAD?
If your headlights dim or flicker, or if your dash and/or
taillights flicker, then the switch is bad. Circuit
HEADLIGHT - DIMMER SWITCH AND CAP
breakers are in the switch, and after much use, can
S2 65-73 .. SW-263 .................Switch ............................ 10.95
S1 65-73 .. C5ZZ-13533AR ......Dimmer Cap ...................... 5.95
S1 65-73...C5ZZ-13533A .........Dimmer Cap....................... 9.00
fail. Remember to depress button on side of switch to remove
switch handle (pulls out).
39
ELECTRICAL
HEADLIGHT - SWITCH
U2 65-68 .. SW-441 .................All .................................. 31.00
U1 69 ....... SW-817 .................All .................................. 24.00
70 ....... SW-928 .................All .................................. 25.00
71-73 .. SW-1226 ...............All .................................. 29.00
DASH BEZEL AND KNOB KIT
Includes: Headlight switch knob and bezel,
wiper knob and bezel, ignition bezel, and a
cigarette lighter element and knob
assembly.
HEADLIGHT - SWITCH BEZEL
65-66 .. C4DZ-10852BR......All .................................. 11.95
67-68 .. C7ZZ-10852AR ......All .................................. 12.95
65-66 .......... C5ZZ-11661KR ......53.95
HEADLIGHT - KNOB & SHAFT
U3 65-66 .. C5ZZ-11661BR ......All .................................. 11.95
67-68 .. C7ZZ-11661BR ......All .................................. 16.95
HEADLIGHT LOOM WIRING HARNESS (E4)
Firewall to Headlamp/Regulator loom. (1 of 3 under hood looms)
All 1969-’70 Must reuse old firewall connector. See prior page for
loom kits.
U1
U2
65-66 .. HDWR-280 ............Fender apron grommet ....... 1.00
64 ....... 64-HL-101 .............W/ Lamps ....................... 64.95
65 ....... 65-HL-102 .............W/ Lamps ....................... 94.95
65 ....... 65-HL-103 .............W/ Gauges .................... 109.95
66 ....... 66-HL-104 .............W/ Gauges ...................... 94.95
67 ....... 67-HL-105 .............W/O Tach W/O GT .......... 149.95
67 ....... 67-HL-106 .............W/O Tach W/ GT ............ 159.95
67 ....... 67-HL-107 .............W/ Tach W/O GT ............ 174.95
67 ....... 67-HL-108 .............W/ Tach W/ GT .............. 184.95
68 ....... 68-HL-109 .............W/O Tach W/O GT .......... 164.95
68 ....... 68-HL-110 .............W/O Tach W/ GT ............ 184.95
68 ....... 68-HL-111 .............W/ Tach W/O GT ............ 189.95
68 ....... 68-HL-112 .............W/ Tach W/ GT .............. 209.95
69 ....... 69-HL-113 .............W/O Tach ...................... 209.95
69 ....... 69-HL-114 .............W/ Tach ........................ 219.95
70 ....... 70-HL-115 .............W/O Sport Lamp ............ 219.95
70 ....... 70-HL-116 .............W/ Sport Lamp .............. 239.95
U3
PARKING LAMP
INSTALLATION KIT
Includes: Mounting pads, lenses, gaskets,
bulbs and mounting hardware.
65-66 .......... C5ZZ-13211K ........16.95
HEADLIGHT WIRING EXTENSION (E6)
67-68 .. 67-HL-117 .................................................... 11.95
69 ....... 69-HL-118 .................................................... 17.95
70 ....... 70-HL-119 .................................................... 11.95
PARKING LAMP DELUXE KIT
Includes: Pair of parking lamp housings,
mounting pads, lenses, gaskets, bulbs and
mounting hardware.
PARKING LAMP - HOUSING W/PIG TAIL
65-66 .......... C5ZZ-1307/8K .......73.95
W1 65-66 .. C5ZZ-13206BR ......RH ................................. 27.95
W1 65-66... C5ZZ-13206B.........RH .................................. 50.00
W1 65-66 .. C5ZZ-13207BR ......LH.................................. 27.95
W1 65-66... C5ZZ-13207B.........LH .................................. 50.00
PARKING LAMP - ASSEMBLY W/ LENS & PIG TAIL
X1 67-68 .. C8ZZ-13200BR ......RH or LH ........................ 39.95
X1 67-68... C8ZZ-13200B.........RH or LH ......................... 79.00
W1
PARKING LAMP - LENS
W4 64 ....... C5ZZ-13208BR ......Clear .............................pr.7.95
W3 65-66 .. C5ZZ-13208AR ......Amber .............................. 6.95
W3 65-66... C5ZZ-13208C .........Amber ............................. 10.00
X2 67-68 .. C7ZZ-13208AR ......Clear ................................ 3.95
69........ D0ZZ-13208A.........Clear ............................... 25.00
69........ D0ZZ-13209A.........Clear ............................... 25.00
W2
W5
W3 W4
X1
PARKING LAMP - LENS GASKETS
W5 65-66 .. C5ZZ-13211AR ................................................. .95
X3 67-68 .. C7ZZ-13211AR ............................................ pr.1.95
69 ....... C9ZZ-13211AR ............................................ pr.2.95
71-73 .. D1ZZ-13211AR ............................................ pr.2.95
X2
X3
40
ELECTRICAL
PARKING LAMP - BULB
65-68 .. BP1157 .................Bulb ..............................pr.1.89
69-73 .. BP1157NA ............Bulb, Amber ...................pr.3.79
Y1
PARKING LAMP - HOUSING GASKET
65-66 .. HDWR-451 ............Nuts (4) ............................ 1.20
65-66 .. C5ZZ-13217C/DR ...LH & RH ........................... 6.95
Y2
HOOD TURN SIGNAL PARTS
67-68...C7ZZ-16B870A.......Grill, insert only ............ ea.20.00
67-68 .. C7ZZ-16720/1AR ...Grill assembly ........... set.109.95
67-68 .. HDWR-449 ............Nuts, for Grill (8) ............... 3.00
67-68 .. C7ZZ-13368AR ......Gaskets, for lens .............pr.2.95
69-70 .. 69H-101................Wiring ............................ 34.95
Z3
Z2
Z1
SIDE MARKER - ASSEMBLY
68 ....... C8ZZ-15A200PR ....Front ......................... pr.139.95
70........D0ZZ-15A201A.......Front, RH ......................... 75.00
70........D0ZZ-15A201B ......Front, LH ......................... 83.00
SIDE MARKER - LENS
TAIL LAMP BEZEL KIT
Includes: Bezels, lenses, gaskets and
mounting hardware.
65-66 .......... TK1-SP ..................44.95
68 ....... C8ZZ-15A215PR ....Front ...........................pr.34.95
Y2 E68 ......C8ZZ-13380A .........Rear, to be used w/bezel .... 26.00
L68 ......C8GY-13380A.........Rear, 1pc w/chrome trim ...... Call
Z2 69........C9ZZ-15A215C .......Front, Clear ...................... 12.00
Z3 69........C9ZZ-15A201C .......Rear, Red ......................... 14.00
SIDE MARKER - LENS GASKETS
69 ....... C9AZ-15447R ........FT & RR Lens to body (4) set2.95
70 ....... D0ZZ-15209R ........Rear, Lens ......................pr.1.95
70 ....... D0ZZ-15447AR ......Rear, Lamp to body .........pr.2.95
B1
SIDE MARKER - BULBS
68 ....... 1178A ...................Front, Amber ................. ea.2.69
69 ....... BP194A .................Front, Amber ..................pr.2.69
69-73 .. BP194 ...................Rear, Clear .....................pr.1.34
70 ....... BP97A ...................Front, Amber ..................pr.3.69
71-72 .. BP194 ...................Front, Clear ....................pr.1.34
A1
SIDE MARKER - BEZEL
Y1 E68 ......C8ZZ-13381A .........Rear ................................ 40.00
Z1 69........C9AZ-15A440A.......Front or Rear .................... 17.00
WHY WON’T MY TAILLIGHTS WORK?
Few things are as frustrating as taillights that
won’t work. After years of use, old Mustang
TAIL LIGHT - WIRE LOOM (A1)
Plugs into main under dash harness and turn signal harness and runs
taillights can “go dark.” Several things can hinder
taillights, brake and signal lights. Two circuits go to every tail lights:
brake/signal, and headlight/taillight. Both of these circuits go into
one bulb (LH, RH each) with two filaments (No. 1157). A common
ground wire or contact completes these circuits. The ground
contact, usually the bulb socket against the reflector housing,
(which is grounded to the car) can become corroded over the years
and should be cleaned up or replaced.
to tail lights, license plate light, back up lights, gas tank sending unit,
and panel lamps on FB.
64-66 .. 64-TL-101..............Cp, Cvt ........................... 79.95
65-66 .. 65-TL-102..............FB.................................. 89.95
67 ....... 67-TL-103..............All ................................ 119.95
68 ....... 68-TL-104..............Cp, Cvt ......................... 119.95
68 ....... 68-TL-105..............FB................................ 124.95
69 ....... 69-TL-106..............All ................................ 164.95
A bad headlight switch can prevent the taillight circuit to work. If
only one side works (taillight or signal or brake), then the turn signal
switch is usually at fault. Check the brake light switch is well.
Taillights that work, but are dim, are usually due to a bad ground
and/or taillight lenses that have darkened with age. Remember to do
a complete restoration of the entire system to obtain optimum
results. A voltmeter to measure amperage can be handy, too.
TAIL LIGHT - HOUSING
B1 65-66 .. C5ZZ-13434AR ......with pig tail ..................... 25.95
65-66 .. C4OZ-13A408AR ....Pig tail ............................ 16.95
65-66 .. C4OZ-13A408AL ....Pig tail ............................ 16.95
TAIL LIGHT - HOUSING TO BODY GASKET
65-66 .. C5ZZ-13420AR ............................................... 2.92
67-68 .. C7ZZ-13420AR ......................................... set16.95
69 ....... C9ZZ-13420AR ............................................pr.4.95
41
ELECTRICAL
TAIL LIGHT - TAIL LIGHT TO HOUSING GASKET
67-68 .. C7ZZ-13520AR ......Thick rubber ................ set34.95
69 ....... C9ZZ-13520AR ......Thick rubber .................pr.39.95
TAIL LAMP BEZEL KIT
Includes: Six bezels, pads and mounting
TAIL LIGHT - DOOR
65-66 .. C5ZZ-13489AR ......................................... ea.17.95
65-66 .. HDWR-369 ............SS Screws (8) .................... 4.00
67 ....... C7ZZ-13489AR ......................................... ea.13.95
68 ....... C8ZZ-13489AR ......................................... ea.14.95
68........ C5SZ-13489A .........GT/CS .......................... ea.84.00
hardware.
67 TK1-67 ...............................69.95
68 TK1-68 ...............................69.95
TAIL LIGHT - LENS
65-66 .. C5ZZ-13450BR ............................................... 6.95
65-66 .. C5ZZ-13450AR ......w/ ‘FoMoCo’ logo ............... 9.95
67-68... C7ZZ-13450A ................................................. 45.00
69........ C9ZZ-13450A ................................................. 68.00
TAIL LIGHT - LENS GASKET
65-66 .. C5ZZ-13461BR ............................................... 2.95
67-68 .. C5ZZ-13461AR ........................................... set4.95
67 ....... C7WY-13461AR .....Shelby ...........................pr.9.95
69 ....... C9ZZ-13461AR ............................................... 4.95
TAIL LIGHT - BULB
65-73 .. BP1157 .................Bulb .............................. pr.1.98
BRAKE LIGHT SWITCH
SW-24 Mounts on Master Cylinder - Others mount at Brake Pedal
64........ SW-24....................With Generator ................... 9.00
A2 65-66... SW-863..................With Alternator ................. 12.00
A2 67-70... SW-863..................With out Power Brakes ...... 12.00
A2 67-68... SW-862..................With Power Disc Brakes..... 11.00
A2 67-70... SW-864..................With Power Drum ............. 11.00
A2 71-73... SW-990..................With Power Brakes............ 12.00
HOW DO I KNOW MY BRAKE (STOP) LIGHT SWITCH IS
BAD?
If it isn’t a bad turn signal switch, the brake light
switch, mounted on the brake pedal (except ‘64-1/2),
can either produce a dim, delayed or no brake signal, when bad.
A good switch will produce brake lights at the slightest touch
of the brakes. Replacement is relatively easy, if you’re good at
lying on your back under the dash!
BRAKE SWITCH HARDWARE
64 ....... 64-PB ....................Switch extension wire ......... 9.95
A1 65-68... C5DZ-2B129A ........Washer / Spacer (Req.2) ..... 1.00
A3 65-73... C0AZ-7526B ..........Retainer Clip ...................... 2.00
A4 65-68... C5DZ-2474B ..........Bushing ............................. 4.00
A4 69-73... C9AZ-2474A...........Bushing ............................. 5.00
BRAKE WARNING LIGHT SWITCH
67-69... C8AZ-2B264A ................................................ 13.00
70-73... D0AZ-2B264A ................................................ 11.00
BACK UP INSTALLATION KIT
Includes: Mounting pads, lenses, gaskets,
bulbs and mounting hardware.
BACK UP LIGHT - HOUSING W/PIG TAIL
65-66 .. C5ZZ-15511AR ......RH ................................. 29.95
65-66... C5ZZ-15511A .........RH .................................. 71.00
65-66 .. C5ZZ-15512AR ......LH.................................. 29.95
65-66... C5ZZ-15512A .........LH .................................. 61.00
67-68 .. C7ZZ-15511BR ......RH ................................. 39.95
67-68... C7ZZ-15511B.........RH .................................. 72.00
67-68 .. C7ZZ-15512BR ......LH.................................. 39.95
67-68... C7ZZ-15512B.........LH .................................. 86.00
69-70... C9ZZ-15500E .........RH, Flat style ................... 89.00
69-70... C9ZZ-15500F .........LH, Flat style .................... 89.00
64-66 .......... C5ZZ-15510K ........19.95
BACK UP LAMP DELUXE KIT
Includes: Back up housing, pads, lenses,
gaskets, bulbs, and installation hardware.
64-66 .......... C5ZZ-15511/2K .....69.95
BACK UP LIGHT - HOUSING GASKET
65-66 .. C5ZZ-15533A/BR .........................................pr.4.95
67-70 .. C7ZZ-15533A ..............................................pr.4.95
BACK UP - LENS
65-70 .. HDWR-451 ............Nuts (4) ............................ 1.20
65-68 .. C5ZZ-15514AR ............................................... 4.95
69-70... C9ZZ-15514B................................................. 10.00
42
ELECTRICAL
BACK UP - LIGHT LENS GASKET
65-70 .. C5ZZ-15510AR ............................................ pr.1.95
KEY TO LINE LISTING:
Bold Print = Reproduction / OEM-Style
Replacement Parts
BACK UP - LIGHT BULB
65 ....... BP1141 .................Bulb, 1 contact ............... pr.2.09
66-73 .. 1142 .....................Bulb, 2 contact .............. ea.1.65
71-73 .. BP1156 .................Bulb, 1 contact ............... pr.1.49
Standard Print = Current Original Ford
Replacement Parts
BACK UP - LIGHT SWITCH
65-66... C5ZZ-15520C .........3 Spd .............................. 49.00
B1 65-66... C5ZZ-15520A .........4 Spd .............................. 57.00
67-68... SW-561..................4 Spd .............................. 54.00
70........ SW-1160................3 Spd .............................. 52.00
70-73... SW-943..................4 Spd .............................. 57.00
73........ SW-1052A..............Borg ................................ 20.00
C1
B1
LICENSE PLATE LAMP PARTS
C1 65-70 .. C5ZZ-13550AR ......Complete Assembly .......... 44.95
65-73... C4AZ-13564A.........Lamp Lens ......................... 7.00
65-73 .. C7AZ-13568AR ......Lens Gasket ........................ .99
65-67 .. BP1157 .................Bulb .............................. pr.1.89
68-73 .. BP97 .....................Bulb .............................. pr.1.59
D1
TURN SIGNAL - LEVER
D1 65-66 .. C5ZZ-13305AR ............................................... 9.95
D1 67-73 .. C7ZZ-13305AR ............................................... 9.95
D1 71-73... D3TZ-13305B ................................................ 13.00
TURN SIGNAL - CAM REPAIR KIT
Instead of replacing your whole turn signal switch for a broken or
faulty cam, use this kit. (Repo. & Not for tilt wheel.)
E1 64 ....... 642227 ........................................................ 10.95
E1 65-66 .. 652232 ........................................................ 10.95
E1 67-71 .. 672214 ........................................................ 10.95
TURN SIGNAL - FLASHER
65-70 .. SF-224 ........................................................... 7.00
71-73 .. SF-323 ........................................................... 7.00
F1
TURN SIGNAL - SWITCH
64........ C30Z-13341B ........Gen ................................. 52.00
F1 65-66 .. C50Z-13341BR ......Alt .................................. 34.95
65-66... C50Z-13341B ........Alt................................... 50.00
67........ C7ZZ-13341F .........W/ Fixed .......................... 75.00
68........ C8ZZ-13341A .........W/ Fixed .......................... 80.00
68-69... C8SZ-13341B.........W/ Tilt ........................... 100.00
69........ C9AZ-13341B ........W/ Fixed .......................... 77.00
70-72... D2AZ-13341C ........W/ Fixed .......................... 75.00
73........ D6AZ-13341A ........W/ Tilt ............................. 95.00
73........ D6AZ-13341B ........W/ Fixed .......................... 77.00
G1
G2
E1
EMERGENCY - SIGNAL FLASHER
HOW DO I KNOW MY TURN SIGNAL SWITCH IS BAD?
If you’ve eliminated the possibility of turn signal &
brake light bulb, pig tail, battery, or alternator etc.,
failure, then it probably is a bad switch. All four turn
65-73... SF-552-B.......................................................... 6.95
EMERGENCY - SIGNAL FLASHER SWITCH
G2 65-66... C6AZ-13A350D ......Switch w/mounting tab ...... 25.00
G1 65-66... C6AZ-13A350A.......Switch w/ tab & harness .... 30.00
67 ....... C7OZ-17513AR ......Knob .............................. 11.95
signals, the brake lights, license plate light, horn, as well as the
emergency flasher (after ‘67), go through this switch. Four
separate signals go through this switch, two front, two rear. You
will need to pull the steering wheel to replace this switch, and re-
wire the connector to the under dash harness. (See Shop
Manual). Do not over torque steering wheel after replacement,
as it can break the plastic cam.
43
ELECTRICAL
NEUTRAL (SAFETY) & BACK-UP SWITCH
H1 65-67... SW368...................W/ C-4 ............................ 29.95
67........ SW549...................W/ C-6 ............................ 47.95
67-69... SW877...................W/ C-4 & C-6 ................... 31.95
69-72... SW368...................W/ C-4 ............................ 29.95
69-73... SW903B ................W/ FMX ......................... 229.95
70-73... SW1615.................W/ C-4 ............................ 65.95
72-73... SW1148.................W/ C-6 ............................ 54.95
J1
H1
NEUTRAL SAFETY SWITCH WIRE LOOM
65-66... C5-7A248 ...................................................... 19.95
HOW DO I KNOW THE NEUTRAL SAFETY SWITCH
IS OUT?
UNDER DASH WIRING HARNESS
Main under dash harness. All new parts with fuse block and clips,
This switch, mounted on the side of the automatic
transmission, is intended to prevent your starting
in drive or reverse. If you turn the key and nothing happens - no
starter movement - then with the brake on, shift into neutral
and try. If it starts, the switch is out of adjustment, if not,
chances are it’s this switch (if the battery and starter and
solenoid are o.k.). This switch can be replaced without removing
the transmission.
lamp sockets and all molded plugs. ‘67’s tach loom sold seperately.
65 ....... 1440165WG3SG ....W/ Gauge ...................... 399.99
65 ....... 1440165WL2SM....W/ 2 Spd Heat, Lamps ... 399.99
65 ....... 1440165WL3SN ....W/ 3 Spd Heat, Lamps ... 399.99
66 ....... 1440166 ...............All ................................ 399.99
67 ....... 14401STDT ...........W/Tach ......................... 499.95
67 ....... 14401GTT .............GT W/Tach .................... 499.95
DASH INSTRUMENT REGULATOR
65-66... GR-508 .......................................................... 21.95
67-68... GR-510 .......................................................... 21.95
69-73... GR-512 .......................................................... 15.95
DOOR JAMB SWITCH
K3 65-66 .. C3AZ-13713AR ......Non-Tilt Steering Wheel ...... 6.95
K3 67-68 .. C60Z-13713AR ......Black, Non-Tilt ................... 6.95
K3 69-73 .. C8OZ-13713AR ......White, Non-Tilt .................. 6.95
K3 70-73 .. SW-1055 ...............W/Automatic seat latch..... 10.00
DOOR COURTESY LAMP & SPEAKER LOOM (DOOR)
64-65 .. 65-DP-101 .............w/o speakers ................... 21.95
66-70 .. 66-CR-105.............Speaker Cross Over Loom . 24.95
K4 66 ....... 66-DP-102 .............w/ speakers w/ 8-track ...... 31.95
67-68 .. 67-DP-103 .............w/speaker ....................... 31.95
69-70 .. 69-DP-104 .............w/speakers ...................... 49.95
RALLY-PAC
To add the “Grand Turismo” look, Ford added two gauges to the
steering column, Tachometer and a Clock. Our reproduction includes
an electronic Tach. and quartz clock. Authentic wrinkle finish. (1966
Type only, similar to ‘65 GT & Pony interior cars.
C6ZZ-10B960BR .................6000 RPM I6 ................ 469.95
C6ZZ-10B960AR .................6000 RPM V8 ............... 479.95
C6ZZ-10B960CR .................8000 RPM .................... 499.95
DOOR COURTESY LAMP (DOOR)
K1 65-66 .. C5ZZ-13789KR ......Pony Door light assy. ........ 34.95
K2 65-66 .. C5ZZ-13790AR ......Pony Door light gasket ........ 1.00
67-68 .. C9OZ-13790AR ......DLX Door light gasket ......... 2.00
K2
K1
K3
DOME LIGHT - BEZEL
L2 67-70 .. C0AF-13788AR ......CP.................................... 6.95
L2 67-70 .. C0AF-13788A ........CP.................................. 15.00
71 ....... D0AZ-13788A ............................................... 13.00
73 ....... D6UZ-13788A........W/ bulb .......................... 13.00
K4
DOME LIGHT - LENS & BULB
65-69 .. BP1003 .................Bulb, Step, Dome, Qtr .....pr.2.09
L1 67-70 .. C0AF-13783CR ............................................... 4.95
L1 67-70... C0AF-13783C................................................... 6.00
72-73 .. BP561 ...................Bulbs .............................pr.2.69
71........ C60Z-13783A................................................. 12.00
73........ D1AZ-13783B .................................................. 4.00
M1
L2
QUARTER TRIM LAMP
L1
65-70 .. BP1003 .................Bulbs .............................pr.2.09
M1 65-70 .. C4SZ-13776BR ......FB, Complete Assembly .... 49.95
65-70... C4SZ-13776B.........FB, Complete Assembly ..... 57.00
65-70 .. C1SZ-13783BR ......FB, Lens (round & white) .... 4.95
65-70... C1SZ-13783B.........FB, Lens ............................ 8.00
44
ELECTRICAL
CONSOLE - PARTS & LAMP
64 ....... BP1445 .................Bulb, Floor shift indicator.pr.1.49
Assembly includes: Die cast lamp, lens and pigtail.
KEY TO LINE LISTING:
Bold Print = Reproduction / OEM-Style Replacement Parts
Standard Print = Current Original Ford Replacement Parts
P1 65-66 .. PR-642233 ............Console Lamp Assembly ... 49.95
65-66 .. F29Z-13B712AR ....Dash to Console Wire Loom21.95
65-66 .. 64-CON-101 ..........Internal Console, W/o AC .. 14.95
65-66 .. 64-CON-102 ..........Internal Console, W/ AC .... 11.95
65-66 .. C5ZZ-13734AR ......Lens on console, rear .......... 3.95
65-70 .. BP1895 .................Bulb, Console glove box ...pr.1.39
65-73 .. BP1893 .................Bulb, Floor shift indicator.pr.1.79
Q1 67-68 .. C7ZZ-13783AR ......Lens on console, rear .......... 7.95
P1
Q1
GLOVE COMPARTMENT LAMP
R1 65-70 .. D1AZ-14413AR ......Switch w/bulb and pigtail .. 16.95
65-73 .. BP1895 .................Bulb ..............................pr.1.39
S1
S3
CIGAR LIGHTER PARTS
S2
S1 65-66 .. C5ZZ-15052KR ......Complete unit .................. 14.95
S2 65-70 .. C4AZ-15055BR ......Socket & Retainer .............. 6.95
S2 65-66...EOVY-15055A.........Socket & Retainer ............... 8.00
S3 65-69 .. C5ZZ-15052AR ......Knob ................................ 7.95
67-73 .. 1895BP .................Bulb ..............................pr.1.39
Q1
HORN RING / CAP
A12 64 ....... C5ZZ-13A805CR ....W/ Gen, w/ cap, std.......... 79.95
A12 65-66 .. C5ZZ-13A805BR ....W/ Alt, w/ cap, std ........... 89.95
A20 65-67...C7OZ-13A805E.......W/ woodgrain wheel .......... 60.00
A12 65-66 .. C5ZZ-13A800AR ....Cap only w/ woodgrain...... 79.95
A13 65-66...C5ZZ-13A806CR.....Collar for woodgrain cap .... 44.95
68-69...C9AZ-13A805B ......Ring only, 2 spoke wheel ... 65.00
HORN RING SPRING
A4 65-69...C0DZ-13A807B ......Std, w/o woodgrain wheel ... 6.00
A14 65-67...C5ZZ-13A807B.......w/ woodgrain wheel ............ 5.00
STEERING WHEEL TENSION SPRING
A11 65-66...C3DZ-3520A ..........Spring................................ 2.00
HORN RING INDEX RETAINER
A1 64 ....... C2DZ-13A809AR ....W/ Gen ............................. 4.95
A1 65-66 .. D2TZ-13A809BR ....W/ Alt ............................... 4.95
A1 67 ....... C7ZZ-13A809BR ....W/ Pins ............................. 4.95
HORN RING CONTACT KIT
Includes: Contact plate, spring plate, horn ring retainer pressure pad,
and screws. (A1, A2, A7, A13, A17)
65-66 .. C5ZZ-13A809KR ....Kit .................................. 12.95
Deluxe steering wheel. Includes: Plastic insulators and screws.
A16 65-67 .. C5ZZ-16A890/1MK.Kit .................................. 26.95
HORN BLOWING CONTACT AND SPRING ASSY.
A9 65-66...C5ZZ-13864B.........W/ Gen .............................. 5.00
A9 67-69...C5ZZ-13864A .........W/o Woodgrain Wheels........ 5.00
A10 65-69...C5AZ-13867A.........Lower shim, w/o woodgrain.. 4.00
HORN BRUSH & PAD
1965-66 STANDARD STEERING WHEEL
A18 64........C20Z-13A821A.......Brush, W/ Gen .................... 5.00
A19 64........13A822..................Pad, W/ Gen....................... 7.00
DELUXE WHEEL FOAM INSULATOR
A5 65-67 .. C5ZZ-13A816AR ....Foam ................................ 1.95
HORN RING CONTACT PLATE
A2 65-66...D1TZ-13A808A.......W/ Alt, std wheel .............. 11.00
HORN CAM / RING PLATE
A3 65-66...C5AZ-13A811A.......W/ Alt ................................ 4.00
HORN RING PRESSURE PAD (PIN W/SPRING)
A7 64-66...C0DZ-13A813A ......W/ Std wheel...................... 4.00
HORN ASSEMBLY
65-68 .. HDWR-268 ............Bolts and Nuts ................... 2.00
69-70 .. HDWR-198 ............Wire retainer ..................... 2.00
Original replacement, not original looking horns.
65-73...E3AZ-13832A.........Low Pitch......................... 32.00
65-73...E3AZ-13833A.........High Pitch ........................ 32.00
HORN BLOWING SWITCH ASSEMBLY
69........C9AZ-13A875C.......3 Spoke Wheel ................. 44.00
70-73...D1AZ-13A875A ......3 Spoke Wheel ................. 36.00
70-73...D2AZ-13A875A ......2 Spoke Wheel, Std .......... 36.00
1965-67 WOODGRAIN STEERING WHEEL
45
ELECTRICAL
“DEALER OPTION” GT FOG LAMP INSTALLATION KIT 1965-1967
Although included with the GT option, fog lamps were originally
available from the dealer separately. Our kits include: Fog lamp
housing, bars, wiring harness kit, switch, bulbs, instructions, under
dash wiring, wires to solenoid, ground wires, firewall grommets,
10 amp breaker and wiring diagram. *1966 requires GT Horse
and Corral. 1965-67 Grill brackets are recommended.
65 ....... C5ZZ-15199AR ......................299.95
*66....... C6ZZ-15199AR ......................299.95
67 ....... C7ZZ-15199AR ......................299.95
FOG LIGHT - HOUSING
G5 65-67 .. C5RZ-15200AR ......................................... ea.39.95
G5 68 ....... C8ZZ-15200AR ......................................... ea.39.95
G5
FOG LIGHT - BULB
G6 65-68 .. C5ZZ-15220BR ......Amber ............................... .Call
G6 65-68 .. C5ZZ-15220CR ......Clear .............................. 15.95
E8
G4
G8
FOG LIGHT - BARS
G4 65 ....... C5ZZ-8390AR ............................................ pr.89.95
G4 66 ....... C6ZZ-8390AR ............................................ pr.89.95
G4 67 ....... C7ZZ-8390AR ..........................................pr.129.95
G20
G2
FOG LIGHT - BAR GRILL MOUNTING BRACKETS
G3 66 ....... C6ZZ-8391AR ............................................ pr.19.95
G3 67 ....... C7ZZ-8391AR ............................................ pr.19.95
G3 68 ....... C8ZZ-8391AR ............................................ pr.24.95
G1
G7
FOG LIGHT - SWITCH
G20 65-67... B6TZ-9A389A.........Bezel ............................... 15.00
G1 65 ....... C5ZZ-15A214AR ....Factory GT only................ 39.95
G1 65-66 .. C6ZZ-15A214AR ........................................... 39.95
G1 67 ....... C7ZZ-15A214AR ........................................... 39.95
G1 68 ....... C8ZZ-15A214AR ........................................... 49.95
‘66
‘67
305522
Restoration
Guide
FOG LIGHT - WIRING HARNESS UNDER DASH
G3
G2 65 ....... 65-FG-UD ..................................................... 24.95
G2 66 ....... 66-FG-UD ..................................................... 24.95
G2 67 ....... 67-FG-UD ..................................................... 19.95
G2 68 ....... 68-FG-UD ..................................................... 19.95
FOG LIGHT TO FIREWALL FEED
G7 66 ....... 66-FG-FW ..................................................... 12.95
G7 67 ....... 67-FG-FW ..................................................... 19.95
G7 68 ....... 68-FG-FW ..................................................... 19.95
G7 67-68 .. C7ZZ-13461AR ............................................... 4.95
FOG LIGHT - GROUND WIRE
E8 66 ....... 66-FG-GR ....................................................pr.6.95
FOG LIGHT - CIRCUIT BREAKER
E9 65-68 .. 65-FG-CB........................................................ 9.95
FOG LIGHT - PIGTAIL
G8 65-67 .. 65-FG-PT ...................................................... 14.95
G8 68 ....... 68-FG-PT ...................................................... 14.95
46
|