24” FOLDABLE WHEELCHAIR
67437
SEt up AnD OpERAtIng InStRuCtIOnS
®
Distributed exclusively by Harbor Freight tools .
3491 Mission Oaks Blvd., Camarillo, CA 93011
Read this material before using this product.
Failure to do so can result in serious injury.
SAVE tHIS mAnuAL.
©
®
Copyright 2009 by Harbor Freight Tools . All rights reserved. No portion of this manual or any artwork
contained herein may be reproduced in any shape or form without the express written consent of
Harbor Freight Tools. Diagrams within this manual may not be drawn proportionally. Due to continuing
improvements, actual product may differ slightly from the product described herein. Tools required for
assembly and service may not be included.
For technical questions or replacement parts, please call 1-800-444-3353.
Download from Www.Somanuals.com. All Manuals Search And Download.
be made by a qualified service
technician.
themselves and be careful not to
pinch fingers and hand in wheel
spokes.
4. Before riding, have a physician or
health care advisor train you in
safe use of Wheelchair.
12. use the Wheel Locks on both
Rear Wheels whenever entering or
exiting the Wheelchair.
5. Do not try a maneuver on your
own until you are sure it can be
done safely.
13. people with limited strength and
mobility will need assistance when
moving in and out of Wheelchair.
6. Do not lean forward out of the
Wheelchair further than the length 14. Stay alert, watch what you are
of the armrests. Doing so may
cause the Wheelchair to tip over.
Other guidelines to prevent tipping
include:
doing and use common sense
when operating Wheelchair. the
attendant should not push this
Wheel Chair while tired or under
the influence of drugs, alcohol or
medication. A moment of inattention
while operating Wheelchair may
result in serious personal injury.
a. Do not attempt to reach objects
by moving forward on the
Wheelchair seat.
b. Do not attempt to reach objects
by reaching between your knees.
15. Dress properly. Do not wear loose
clothing, jewelry or any items that
could get caught in the wheels
during use.
c. Do not lean over the top of the
backrest.
7. Do not attempt to stand on
Wheelchair or the Wheelchair’s
frame.
16. Keep proper footing and balance
at all times when pushing the
Wheelchair. Proper footing and
balance enables better control of
Wheelchair in unexpected situations.
8. Do not attempt to slow down or
stop a moving Wheelchair with the
Wheel Locks.
17. Keep children who are not patients
away from Wheelchair. Do not
allow children to ride in, on, or
push the Wheelchair without adult
supervision.
9. When transferring to or from
the Wheelchair, do not stand or
put weight on the footplates or
footrests. Doing so can cause the
Wheelchair to tip and lead to potential
injury
18. Consult health care advisor
before making any modification
to the Wheelchair. Unauthorized
modifications or use of unauthorized
parts may change the Wheelchair
10. Do not sit or transfer into
Wheelchair unless it is fully
unfolded.
11. When propelling the Wheelchair,
carefully use the wheel hand
rails. Do not grip the rear wheel
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 3
Download from Www.Somanuals.com. All Manuals Search And Download.
structure, leading to possible
climb high steps can lead to loss of
personal injury and property damage.
balance and potential tip over.
19. use extra care when using
Wheelchair on a wet, icy or oil-
slicked surface. Do not use
26. Do not use Wheelchair on stairs
without assistance. Doing so can
lead to loss of balance and a fall,
leading to potential serious injury.
Wheelchair in shower, pool or other
body of water. Dry Wheelchair as
soon as possible if it does get wet.
27. Be aware that regular and
intensive impact of dropping down
from a high curb or step can cause
damage to fasteners and lead to
potential Wheelchair damage.
20. Do not operate Wheelchair in sand,
loose soil or over rough terrain.
Doing so may damage wheels or
axles or loosen the fasteners.
28. Do not use Wheelchair on an
escalator, even with assistance.
Doing so will most likely lead to a fall
and potential serious injury.
21. When using Wheelchair outside
and at night, use reflective tape on
Wheelchair and on clothing. Be
sure to make eye-contact with drivers
and adhere to crosswalks. It may
be difficult for some drivers to spot
Wheelchair at certain intersections;
use extra caution during street use.
29. Install and use ramps at entry and
exit doors whenever possible.
Make sure no drop off points are at
bottom of ramps.
30. Do not use Wheelchair on slope
steeper than 9% (one foot in
elevation per every nine feet of
slope length.)
22. Do not use Wheelchair on busy
roads, streets or highways. Use
only on pedestrian walking areas.
23. Scan area well ahead of
Wheelchair during use. Avoid
obstacles when possible and make
sure floor areas at home and work
are level. Remove or cover threshold
strips between rooms.
31. go straight up and straight down
ramps; do angle or cut corners on
ramps. Stay in center of ramp and
do not change Wheelchair direction
or stop while on slope or ramp.
32. Do not use rear Wheel Locks to
slow down or stop Wheelchair
while on a slope or ramp.
24. Do not attempt to climb or descend
curbs or steps alone or without
assistance unless proficient
enough to make such maneuvers
on your own.
33. Verify that ramps at home
and work meet all local legal
requirements.
25. Do not attempt to climb a high
curb or step 4” or higher unless
you have assistance. Attempting to
34. Do not push or pull on stationary
objects (such as furniture or
doorjamb) to propel Wheelchair.
35. use assistance when moving into
vehicle until you are safely able
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 4
Download from Www.Somanuals.com. All Manuals Search And Download.
to transfer yourself without injury.
Lock rear wheels before transfer
and move Wheelchair as close as
possible to vehicle seat.
creates a “tip-point,” which can lead
to a fall.
44. Firmly grip a rear wheel or armrest
when reaching for something.
Doing so will help reduce the risk of a
fall.
36. Do not allow feet to catch in the
space between footrests during
transfer in and out of Wheelchair.
45. Verify both rear Rear Wheels are
locked before using Wheelchair. An
unlocked axle may come off during
use and potentially lead to a fall,
causing serious personal injury.
37. Keep footrests at least 2” off the
ground. If footrests are set lower,
they may get caught against objects
on floor.
38. Do not lift Wheelchair by armrest
pads or footrests. Lift Wheelchair
only by non-detachable parts of the
frame.
46. Verify push Handle grips do not
rotate or slip before use.
47. Do not modify or alter the Seat or
any other part of the Wheelchair.
39. Do not sit in Wheelchair while in a
moving vehicle. Sit in an approved
handicapped seating area and secure
yourself with proper seat belts and/or
vehicle restraints.
48. maintain labels and nameplates on
Wheelchair. These carry important
safety information. If unreadable or
missing, contact Harbor Freight Tools
for a replacement.
40. Do not transport Wheelchair in the
front seat of vehicle. It may shift
and interfere with the driver. Secure
wheelchair in proper location to avoid
rolling or shifting.
49. the warnings, precautions, and
instructions discussed in this
instruction manual cannot cover
all possible conditions and
situations that may occur. It must
be understood by the operator that
common sense and caution are
factors which cannot be built into this
product, but must be supplied by the
operator.
41. Do not reach or lean if you must
shift weight sideways or rise up
out of the Wheelchair. Always keep
your buttocks in contact with the
backrest.
42. Do not reach out for something
with both hands. Doing so will keep
you from catching yourself should the
chair tip.
SAVE tHESE
InStRuCtIOnS.
43. Do not lock the rear wheels when
reaching for an object. Doing so
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 5
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Swivel Footplates (2) so they are
horizontal.
SpECIFICAtIOnS
Weight Capacity
250 lb.
24”
5. To fold the Wheelchair, lock the Rear
Wheels and fold Footplates up.
Wheelchair Width
Weight
40 lb.
6. Pull up on the Seat and push
Armrest closer together, folding the
Wheelchair.
Solid Rubber Tires and
360° Swivel Casters
Wheels
Seat Width
20-1/4” x 16-5/8” Deep
Installing Foot Rests
unpACKIng
1. Slide the Footplates (2) to the side
(so that they are perpendicular to the
Wheelchair. See Figure 1, below.
When unpacking, make sure item
is intact and undamaged. If parts are
missing or broken, call Harbor Freight
Tools at 1-800-444-3353.
Figure 1
Foot Rest (1)
ASSEmBLY/OpERAtIOnS
InStRuCtIOnS
Tab
Read the EntIRE ImpORtAnt
SAFEtY InFORmAtIOn
Control
Handle
section at the beginning of this
manual including all text under
subheadings therein before set
up or use of this product.
Footplate (2)
For additional information
regarding the parts listed in the
following pages, refer to Assembly
Diagram near the end of manual.
2. Install the end of each Detachable
Footrest (1) onto the tab extending
from the Wheelchair Frame (9). See
Figure 1, above.
unfolding/Folding
1. Before unfolding Wheelchair, make
sure Rear Wheels (3) are in the
locked position.
3. Swivel the Footrest towards the
inside of the Wheel Chair until it locks
into place.
2. Hold the Armrests (10) and pull them
away from one another, unfolding the
Wheelchair.
4. Please note: When properly installed,
Footplate will be on the inside of the
Wheel Chair when locked into place.
3. As Wheelchair unfolds, press down
on Seat (6).
5. To remove, push the Control Handle
out and lift the Foot Rest off the
Wheelchair. See Figure 1, above.
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 6
Download from Www.Somanuals.com. All Manuals Search And Download.
Figure 3
Adjusting Foot Rests
Screws and
Washers
1. To adjust the Foot Rests, loosen but
don’t remove the bolt that secures the
lower section of each Foot Rest to
the upper half. See Figure 2, below.
Figure 2
Seat
Replacing Back pad
Upper Foot
Rest
1. Remove the eight screws and
washers that secure the Back Pad (7)
to the back of the Handles (8).
2. Remove upholstery from Wheelchair
and, using the screws and washers,
securely fasten the new back
Lower Foot
Rest
upholstery to the back of the Handles.
See Figure 4, below.
Bolt
Handles
Figure 4
Back Pad
(7)
2. Reposition lower section of Foot Rest
to desired height. Tighten bolt until
upper section is secured at spot.
3. nOtE: The Wheelchair may be used
without Foot Rests by persons able to
use their feet to self-propel chair.
Replacing Seat
Screws
1. Wheelchair uses ten screws and
washers to secure Seat (6) to frame.
Washers
Adjust and Replacing Front
2. To replace the Seat, remove the
screws and washers that secure the
Seat to the cross braces. See Figure
3, above. please note: Seat height
cannot be adjusted.
Wheels
1. Should the Casters need to be
adjusted, first tip back of Wheelchair
to floor.
3. Remove plate from Seat sleeve.
2. To tighten or loosen Casters, remove
the Dust Cover from the top of the
Caster Head tube and adjust Locknut
allowing for looser or tighter Caster
4. To install new Seat, insert plate into
sleeve and fasten Seat to cross bars
using ten screws and washers.
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 7
Download from Www.Somanuals.com. All Manuals Search And Download.
swing (Casters should swing down
to one side and immediately rest
after being held straight at the top of
the arc.) Too much swing indicates
Casters need to be tightened; not
enough swing means Casters should
be loosened. See Figure 5, below.
Figure 6
Dust
Cover
Yoke
Dust
Cover
Hex
Front
Caster (5)
Screw
Locknut
Figure 5
Caster
Headtube
Adjusting Rear Wheel Locks
1. WARnIng! Do not attempt to stop a
moving Wheelchair with Wheel Locks
(4). Wheel Locks are NOT brakes.
Washer
Yoke
2. To adjust Wheel Locks, disengage
lock and loosen bolt and locknut that
secure Rear Wheel (3) to frame.
Front
Caster (5)
3. Reposition Wheel Lock so that when
brake is engaged, lock shoe presses
down 1/8” onto Rear Wheel, holding
Wheelchair in place. See Figure 7.
3. Test Wheelchair for maneuverability.
Once both Casters are properly
readjusted, snap Dust Cover back
into place over Locknut.
Figure 7
4. To replace Casters, remove Hex
Screws, Washers, and Locknut
holding each Caster in place in the
Yoke.
Bolt and
Locknut
Wheel
Lock (4)
5. Set new Wheel in the Yoke and
fasten in place using Hex Screws,
Washers and Locknuts. See Figure
6, above.
Wheel
Lock Shoe
Tire
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 8
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Securely tighten the bolt and locknut,
securing the Wheel Lock to the
frame.
mAIntEnAnCE AnD
SERVICIng
Procedures not specifically
explained in this manual
must be performed only by a
qualified technician.
5. Repeat the above steps until BOTH
Wheel Locks engage the lock shoe
at least an 1/8” into the tire when the
Wheel Lock handle is pulled, and
HOLDS the occupied Wheelchair in
place when used.
tO pREVEnt
SERIOuS InjuRY
FROm WHEELCHAIR
FAILuRE:
6. If the 1/8” measurement cannot be
reached, contact a qualified service
technician.
Do not use damaged
equipment. If abnormal noise
or vibration occurs, have the
problem corrected before
further use.
Cleaning, maintenance, and
Lubrication
1. BEFORE EACH uSE, inspect the
general condition of the Wheelchair
Check for loose hardware,
misalignment or binding of moving
parts, cracked or broken parts, and
any other condition that may affect
its safe operation. DO nOt uSE A
DAmAgED WHEELCHAIR.
2. BEFORE EACH uSE, examine the
Wheel Locks for proper operation.
Make sure to adjust both Wheel
Locks evenly. DO nOt uSE A
WHEELCHAIR WItH DAmAgED
OR mALFunCtIOnIng WHEEL
LOCKS.
3. Keep the rubber Rear Wheels free
of oil grease, dirt and debris at all
times.
4. to clean: Wipe with clean, warm
water and a mild detergent. Then dry.
Do not use solvents.
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 9
Download from Www.Somanuals.com. All Manuals Search And Download.
5. WHEn StORIng, fold the
Wheelchair according to the
instructions detailed in this manual
and store in a safe, secure location
out of reach of children and non-
authorized users.
6.
WARnIng! All maintenance,
service or repairs must be
performed only by a qualified
service technician.
troubleshooting
problem
Wheel Lock not
possible Causes
Likely Solutions
Proper 1/8” distance between Wheel Adjustment to Wheel Lock required.
functioning properly. Lock Shoe and Tire cannot be
achieved.
Contact qualified service technician.
Wheel Chair is
turning too far to
right/left.
Front Wheel Casters not adjusted
properly.
Adjust Front Wheel Casters and Nut until
they swivel properly with equal free play.
Not enough support Back Pad is torn or damaged.
to occupant’s back.
Replace Back Pad
Wheelchair not
folding properly.
1. Footrests are not raised.
1. Raise the Footrests.
2. Seat is damaged or torn.
2. Replace Seat.
Follow all safety precautions whenever diagnosing or servicing the
Wheelchair.
pLEASE READ tHE FOLLOWIng CAREFuLLY
THe MANUFACTUReR AND/OR DISTRIBUTOR HAS PROvIDeD THe PARTS LIST AND ASSeMBLY
DIAgRAM IN THIS MANUAL AS A ReFeReNCe TOOL ONLY. NeITHeR THe MANUFACTUReR OR
DISTRIBUTOR MAKeS ANY RePReSeNTATION OR WARRANTY OF ANY KIND TO THe BUYeR THAT
He OR SHe IS qUALIFIeD TO MAKe ANY RePAIRS TO THe PRODUCT, OR THAT He OR SHe IS
qUALIFIeD TO RePLACe ANY PARTS OF THe PRODUCT. IN FACT, THe MANUFACTUReR AND/
OR DISTRIBUTOR exPReSSLY STATeS THAT ALL RePAIRS AND PARTS RePLACeMeNTS SHOULD
Be UNDeRTAKeN BY CeRTIFIeD AND LICeNSeD TeCHNICIANS, AND NOT BY THe BUYeR. THe
BUYeR ASSUMeS ALL RISK AND LIABILITY ARISINg OUT OF HIS OR HeR RePAIRS TO THe
ORIgINAL PRODUCT OR RePLACeMeNT PARTS THeReTO, OR ARISINg OUT OF HIS OR HeR
INSTALLATION OF RePLACeMeNT PARTS THeReTO.
Record product’s Serial number Here:
note: If product has no serial number, record month and year of purchase instead.
note: Some parts are listed and shown for illustration purposes only, and are not
available individually as replacement parts.
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 10
Download from Www.Somanuals.com. All Manuals Search And Download.
pARtS LISt AnD ASSEmBLY DIAgRAm
part
Description
Qty.
part
Description
Qty.
1
2
3
4
5
Detachable Footrest
2
2
2
2
2
6
7
8
9
Seat
1
1
2
1
2
Footplate
Back Pad
Handles
Frame
Rear Wheel
Wheel Lock
Front Casters
10 Armrest Pad
10
8
3
4
1
2
5
7
9
6
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 11
Download from Www.Somanuals.com. All Manuals Search And Download.
LImItED 1 YEAR WARRAntY
Harbor Freight Tools Co. makes every effort to assure that its products meet
high quality and durability standards, and warrants to the original purchaser that
this product is free from defects in materials and workmanship for the period of one
year from the date of purchase (90 days if used by a professional contractor or if
used as rental equipment). This warranty does not apply to damage due directly or
indirectly, to misuse, abuse, negligence or accidents, repairs or alterations outside
our facilities, normal wear and tear, or to lack of maintenance. We shall in no event be
liable for death, injuries to persons or property, or for incidental, contingent, special
or consequential damages arising from the use of our product. Some states do not
allow the exclusion or limitation of incidental or consequential damages, so the above
limitation of exclusion may not apply to you. THIS WARRANTY IS exPReSSLY IN
LIeU OF ALL OTHeR WARRANTIeS, exPReSS OR IMPLIeD, INCLUDINg THe
WARRANTIeS OF MeRCHANTABILITY AND FITNeSS.
To take advantage of this warranty, the product or part must be returned to us
with transportation charges prepaid. Proof of purchase date and an explanation of the
complaint must accompany the merchandise. If our inspection verifies the defect, we
will either repair or replace the product at our election or we may elect to refund the
purchase price if we cannot readily and quickly provide you with a replacement. We will
return repaired products at our expense, but if we determine there is no defect, or that
the defect resulted from causes not within the scope of our warranty, then you must
bear the cost of returning the product.
This warranty gives you specific legal rights and you may also have other rights
which vary from state to state.
3491 Mission Oaks Blvd. • PO Box 6009 • Camarillo, CA 93011 • (800) 444-3353
SKU 67437
For technical questions, please call 1-800-444-3353.
Page 12
Download from Www.Somanuals.com. All Manuals Search And Download.
|