AUTOMATIC DRUM
WASHING MACHINE
HM500X HM500TX
HM600X HM600TX
INSTRUCTIONS FOR
INSTALLATION AND
OPERATION
0020504797
Download from Www.Somanuals.com. All Manuals Search And Download.
FUNCTION INTRODUCTION.....................................................3-5
INSTALLATION...........................................................................6-8
CLOSE UP................................................................................9-11
USINGINSTRUCTIONS..........................................................12-16
MAINTENANCE...........................................................................17
SOLUTION TO PROBLEMS................................................18-19
ATTACHEDCHART:
GUIDE FORSELECTINGPROGRAMME...........................20-21
WARNING....................................................................................22
2
Download from Www.Somanuals.com. All Manuals Search And Download.
FUNCTION INTRODUCTION
FUNCTION COMPARING TABLE
MODE
HM600X
HM500X
HM500TX
HM600TX
5kg
FUNCTION
Washing capacity
5kg
5kg
5kg
16
16
16
16
Programmes
Cotton
Synthetic
Wool
Thermostat ajustable(0-90 C)
Cold wash button
Economic wash button
No soak
600r/min
500r/min
600r/min
500r/min
Spin speed
Power switch
ON/OFF
Rinse
Plustic tub
Door-locking device
Power
330W
650W
63Kg
330W
650W
63Kg
330W
650W
63Kg
330W
650W
63Kg
Power(Wash)
Power(Spin)
Weight
850X520X595mm
HXDXW
3
Download from Www.Somanuals.com. All Manuals Search And Download.
FUNCTION INTRODUCTION
Characteristics of HM600X HM500X
EuropeanandAsiaAesthetic design, elegantandbeautiful.
Threetypesofwash:rinse, beat andraineffect.
Changeablewashingfunction:cold washandhotwash,Nosoak
Threetypesoflaundry:cotton, syntheticandwool, with16cycles.
Alargewashingcapacity:5 kg.
Stainlesssteeldrum;paintedcabinetwiththreelayersof
cataphresis, phosphorusandpaint.
Rinsewithanti-creasesystem, carefor clothes.
Superanti-shockdesign.
Self-lockdeviceforthedoor.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
FUNCTION INTRODUCTION
Characteristics of HM600TX HM500TX
EuropeanandAsiaAesthetic design, elegantandbeautiful.
Threetypesofwash:rinse, beat andraineffect.
Changeablewashingfunction:cold washandhotwash,Nosoak
Threetypesoflaundry:cotton, syntheticandwool, with16cycles.
Alargewashingcapacity:5 kg.
Stainlesssteeldrum;paintedcabinetwiththreelayersof
cataphresis, phosphorusandpaint.
Rinsewithanti-creasesystem, carefor clothes.
Superanti-shockdesign.
Self-lockdeviceforthedoor.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Unpacking
levelling and
positioning
Remove the package and check that the machine is
undamaged.
If you have any doubts, do not use the machine and call on a
qualified technician. Keep all packing parts (plastic bag,
foam rubber, screws etc.) out of the reach of children since
theycouldbedangerous.
Important: The inside of the washing machine which
consists of a floating unit, is fixed with screws at the back of
the cabinet (Fig.1) during transport. Before starting the
machine remember to release the floating unit by removing
the above screws . To prevent water spray from entering the
machine, remember to close the holes left open by the
screws with the plastic caps provided in the packet
containing the owner's manual. And rescrew the holes
where the iron piece is taken down with the former two
screws.Attention:keep the packing screws and plastic caps
in a safe place for later use. It is important for the machine to
be perfectly level (the angle of inclination on the work surface
must not be more than 2 degrees). For this reason the
machine is fitted with adjustable feet used for levelling the
machine before use (Fig.2). In the case of flooring with
carpeting, remember to check that the ventilation in the
support area is not plugged.
Fig.2
Fig.1
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Connect the plug to a socket provided with efficient earthing.
Electric
connection
Or use the spare earthing wire supplied together with the
machine and the earthing terminal located on the left-upper
corner of the back of your machine (Warning: this appliance
must be earthed as a safety measure according to the law).
Make sure that the voltage and frequency available
correspond with the values stated on the data plate located at
the back of the machine and that the electric system is
dimensioned to withstand the maximum current shown on the
data plate. If the socket the machine is connected to does not
correspond with the plug, replace the plug with a suitable one
and avoid using adaptors or shunts since they could cause
overheating and burn out.The spare eathing wire is
absolutely not allowed to be connected
pipe,heating pipe or other kinds of pipes.
to water
Connection
of tap and
Loading
Hose
Connect the inlet hose to a cold water tap with a 3/4 gas
threaded opening, and fit the filter and the rubber gasket
supplied with the washing machine. Check that it is tightly
screwedtothetap(Fig. 3).
Fig. 3
If the water piping is new or has not been used for a long time,
before making the connection, let the water run until it is clear
andfreefromimpurities.
This step is necessary to ensure that the incoming water
doesnotclogandpossiblydamagethemachine.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Connection of
the Drain Hose
Connect the drain hose to a drain duct (with internal
diameter of at least 4 cm.) or place it for drainage into
a sink or a tub, ensuring that there are no kinks or
bends. The free end must be at a height of between
80 and 100 cm. Should it be necessary to fix the end
of the hose at a height of less than 80 cm from the
floor, the hose must be fixed in the appropriate hook
on the upper part of the back panel (Fig.4) or use the
suppliedsupporttofixthedrainhose.(Fig.5)
Fig.5
Fig.4
Insert stainless steel screen washers into end of each
supply hose and attach that end of supply hose to
your 3/4" water tap spigot.Be sure that you match up
cold water to "C" .Note:Home Centers also have"Y"
connectors and "Couplings" which enable you to
connect the machine to your sinks faucet.
Connecting
WaterSupply
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Close up
G
D
I
C
F
H
A
1
16
2
15
14
3
4
13
12
11
5
10
6
9
7
8
G
D
C
I
F
H
A
1
16
2
15
14
3
4
13
12
11
5
10
6
9
7
8
G
D
I
C
E
H
A
B
1
16
2
15
14
3
4
13
MAX
30
12
11
80
40
5
70
50
60
10
6
9
7
8
G
D
I
C
E
H
A
B
1
16
2
15
14
3
4
13
MAX
30
12
11
80
40
5
70
50
60
10
6
9
7
8
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Close up
A Programme selector Knob.
By turning this dial (clockwise only) you can
select from sixteen wash programmes the one
mostsuitedforyourwashing.
1~7 cotton cycle
1
16
2
15
14
3
4
13
12
11
5
10
6
9
7
8
8~12 synthetic cycle
13~16 wool cycle
B Programme selector Knob.
With this dial you can set the wash temperature
that you desire. For synthetic and wool, the
30
MAX
ther mostat works below 60
respectively.
and 40
80
40
70
50
60
When the dial is located at
is available
a cold wash
C Power Light
This light indicates whether the electricity is on or
off. The light comes on when button D is pressed
andgoesoffwhenbuttonDisnotpressed.
D ON/OFFButton
ON/OFF button. Supplies electrical power to the
machine.
E EconomicWashButton.
It reduces water and power consumption when
rinsingifthemachinedoesnothaveafullload.
(Lessthan3kg)
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Close up
F Cold wash button.
Press it you get a cold wash.
Release it you get a heating wash.
For cotton,water can be heated to 80 C.
For synthetic,to 60 C and for wool,to 40 C
G DetergentDispenser.
The detergent dispenser is divided into 4 compart-
ments marked 1,2,A,C:(See Fig.8)
1 Pre-wash detergent
2 Wash detergent
A Softeners, conditioners, perfumes
C Bleach
Fig.8
H Door Lock Light
Remember that only when the washer doesn't
work,we can open the door. After the washing
program finish,after 3 minutes, when the self-lock
meter turn off, we can open the door.
I No Soak Button
For the synthetics cycle and the wool cycle, push the
button down, the anticrease funtion will be skiped and
automatically enter into the next step;Release the
button, the anti-crease funtion will work again.
Download from Www.Somanuals.co1m1. All Manuals Search And Download.
Using instructions:Your machine
offers the best results when...
In order to get the excellent results that you would expect
The weight
is right
from your washing machine, it is important to load the washer
correctly. You should therefore choose the quantity of each
typeoffabricthatyouwanttowash. Thistablewillhelp:
Colour fast fabrics
Delicate fabrics
Woollens
maximum load 5 kgs/11lbs
maximum load 2 kgs/2.5 lbs
maximum load 1 kg/2.2 lbs
maximum load 2.5 kgs/5.5 lbs
Mixed fabrics
Divide the laundry by fabric and degree of soiling loaded
makingtheloadsasuniformaspossible.
Pullthehandleout toopenthedoor.
Laundry has
been loaded
correctly
Place the laundry in the machine remembering to arrange
uniformly.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Using instructions:Your machine
offers the best results when...
The correct
A perfect wash depends above all on choosing the most
programme has suitable programme. We would therefore advise you to
been chosen
divide up your washing into separate loads of more or
less the same types of fabric. This will make it easier to
selectthebestprogramme.
Hints on choosing the programme are shown in the table
onpagesofthismanual.
Onceyouhaveselectedaprogramme, justturndial
A clockwise until the chosen programme lines up with
theindicatorlineonthefaciapanel.
Anti-crease
When your machine is washing synthetic fabrics or
woollens, the wash cycle stops before the last spin cycle,
with the laundry soaked in water in order to prevent the
formation of creases due to spinning. Complete the
wash cycle with a spin cycle or simply drain the water
fromthewashingmachinewithoutspinning.
For the spin cycle, turn the selector knob Aclockwise by
onestep.
To drain, set the selector knob Aon drain programme in
both cases, before turning the knob A remember to
switchOFFtheON/OFFbuttonD.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Using instructions:Your machine
offers the best results when...
The detergent
has been put
in properly
The 4 compartments marked 1, 2, Aand C (Fig.9) should
beusedasfollows:
1Pre-washdetergent
2Washdetergent
A Conditioner,starch, scents
C Bleach
Fig.9
Remember that it is important to use the right amount of
soap powder or liquid for the type of laundry you are washing;
the amount of detergent you use depends on a number of
factors:
Water hardness; if the water in your area has a
high calcium content, we recommend using a
anti-limestone additive.
degree of dirtiness; increase the amount of
soap powder used in the case of heavily soiled
laundry.
laundry load; the smaller the load the less soap
powder you will need to use.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Using instructions:Your machine
offers the best results when...
Thefollowingtablewillguideyou:
Compart.1 Compart.2
prewash
Laundry
Compart.A Compart.C
wash
Normally 1/2 measuring 1 and 1/2
Softeners
Bleach
soiled
cup
measuring (see note 'A') (see note 'C')
cups
When using concentrated detergents, remember to keep to the
manufacturer's instructions using only the measuring cups
suppliedwiththepacket.
Use more detergent in the case of very hard water ( more than
21.F), but remember to maintain the proportion between the
prewashandwashcycles.
Liquiddetergent
The liquid detergents currently available on the market may be
used with the washing machine. Use compartment 2 for very
dense liquid detergents. Follow the manufacturer's
instructions when using liquid detergents sold with the ball
detergent dispenser. Place the ball dispenser in the tub of
washing machine together with the laundry.
The prewash cycle may not be used with liquid detergents.
Note "A"
For soft and fluffy laundry always a softener in the final rinsing
cycle.
Note "C"
Bleach is ideal for removing stains (e.g.tea, coffee, fruit, red
wine ) on resistant fabrics like cotton, hemp and linen provided
the wash care label indicates that the garment may be
bleached.
Place the bleach in compartment C before you start the
machine without exceeding the maximum level. your machine
will load the bleach automatically when necessary .when
necessary.
Never place bleach in the other compartments.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Using instructions:Your machine
offers the best results when...
You can now start washing. We would advise you, especially
The cycle is
started
the first few times, to check that the programme that you
have set is really the one you want and that the fabric
selectioniscorrect.
If you want to start the cycle immediately, press the ON/OFF
buttonD.
At the end of the chosen cycie, the machine will stop
automatically.
The wash is
finished
Press the ON/OFF button D to switch off the power (light C
willturnoff).
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Maintenance: five simple
precautions for this machine
Your machine is designed to last without complicated
maintenance.
All the same, we would ask you to take care of a few small
matters. If you follow these four simple rules, we are sure
that the washing machine will stay as your faithful friend
andhelperforalong, longtime.
1. Ensure that your machine was installed according to the
installation manual that comes with this booklet.
2. Avoid at all costs using solvents either to clean the
machine, or to do the wash. when clean the machine, cut
offthepower.
3. Clean the detergent dispenser every so often. This is
very simple and should be done with water. Your
machine has an extractable dispenser to make it even
easier. Just pull it upwards and out.
4. If it is long time no use, you'd better cut off the power,
switch off the tap, and open the door to avoid unpleasant
smell.
5. Your washer is equipped with a self-cleaning pump. It is
therefore not necessary to carry out cleaning and
maintenanceoperations.
Open the cover of the filter, loosen the knob in counter-
clockwise rotation, then take out the filter and clean it with
water, everymonth.(seeFig.8)
Fig.8
Note: Reassembly the filter carefully after cleaning,
ensuring it is fit perfectly and no water can come out.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Solution to Problems
Even though your washing machine has been carefully
designed and constructed, something could still go a miss
with your machine. Before rushing to phone one of our
service centres, however, please check that the operations
listed below have been carried out. In many cases you will
save time, money and bother. Our statistics show that many
of the calls received by our service centres could have been
avoidedwithjustalittlemoreattention.
Checkthat:
The washing
machine
won't start
theplugispushedrightintothemainssocket;
thedoorisclosedtightly:
the "ON/OFF"buttonhasbeenpressed.
Checkthat:
thetapisopenandproperlyconnectedtotheinlet
The washing
machine won't
fill with water
pipe;
theinletpipeisnotbent.
The machine
fills and drains
continuously
Checkthat:
thedrainpipeisplacedatleast80cm/32inches
above ground level.
The machine
will not drain
drain the water
Check that:
the drain pipe is not blocked;
the drain pipe is not connected at a height more than
1 metre/40 inches above ground level.
There is too
much foam in
the tub
Check that:
the detergent being used is meant for automatic
machines and not for washing by hand;
that the amount used is that shown in this manual
and not more.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Solution to Problems
Check that:
The machine
vibrates too
much when
spinning
the transit bolts have been removed (see
installation manual);
themachineislevel;
thewashingloadisaccordingtotheinstructions
given in this booklet.
Check that:
thereisasuddenpowerfailureorwaterstop.
themachineisinthenormalstateofrinse.
The machine
stops operating
before finishing
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Guide for selecting programme
20
Download from Www.Somanuals.com. All Manuals Search And Download.
Warning:
1. If the supply card is damaged, it must be replaced by a special
card or assembly available from the manufacturer or it is service
agent.
2. It a stationray appliance is provided with a supply card and a plug,
the instructions shall state that the appliance must be positioned
so that the plug is accessible.
Note: this requirement dose not apply if the appliance incorporates
other means for disconnection from the supply.
3. For washing machines with ventilation openings in the base, that a
carpet must not obstruct the openings.
4. The instructions shall state that the appliance is to be connected
to the water mains using new hose-sets and that old hose-sets
should not be reused.
Note: this instructions is not required if the hoses are permanentiy
attached to the appliance.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
WIRING CIRCUIT (HM600TX HM500TX)
TH40
I1=ON/OFF
I2=ECONOMIC WASH
I3=NO SOAK
L Line
P2 2- level pressure switch
MT Timer motor
N Neutrol
SL Line LED
RR Heating element
PS Drain pump
SO Door lock
MR Thermol lock
EVF Cold water electrovolve
P1 1- level pressure switch
TH40 40 C thermostat
22
Download from Www.Somanuals.com. All Manuals Search And Download.
WIRING CIRCUIT (HM600X HM500X)
I1=ON/OFF
I2=COLD WASH
I3=NO SOAK
L Line
P2 2-level pressure switch
MT Timer motor
N Neutrol
SL Line LED
SO Door lock LED
MR Thermol lock
RR Heating element
PS Drain pump
TH40 40 C thermostat
TH80 80 C thermostat
EVF Cold water electrovolve
P1 1-level pressure switch
Download from Www.Somanuals.com. All Manuals Search And Download.
|