ꢀꢁꢂ 7)$% "%,4 3!.$%23
-/$%,3 'ꢃꢄꢄꢅꢆ 'ꢃꢇꢀꢈꢆ 'ꢃꢇꢁꢉ
).3425#4)/. -!.5!,
8DENG><=IꢀꢀB6Nꢀ'%%*ꢀ7Nꢀ<G>OOANꢀ>C9JHIG>6A!ꢀ>C8#ꢀ
7!2.).'ꢊ ./ 0/24)/. /& 4()3 -!.5!, -!9 "% 2%02/$5#%$ ). !.9 3(!0%
/2 &/2- 7)4(/54 4(% 72)44%. !002/6!, /& '2)::,9 ).$5342)!,ꢆ ).#ꢋ
ꢁ8G+.,&ꢀEG>CI:9ꢀ>CꢀI6>L6Cꢀ
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Page 46
Main Electrical panel and controls Diagram
2
1
24
3
22
22
23
33
7
9
26
15
19
27
28
20
21
29
30
38
31
8
4
11V2 (G0571 Only)
11V2 (G0539/G0446 220V/440V Only)
32
15-1
12V2 (G0539/G0446 220V Only)
12-1V2 (G0539/G0446 440V Only)
13V2
14 (G0539/G0571/G0446 220V Only)
14-1 (G0539/G0446 440V Only)
6
39 (G0571 Only)
5
10V2 (G0539/G0446 Only)
16V2 (G0571 Only)
16V2 (G0539/G0446 Only)
18V2 (G0571 Only)
18V2 (G0539/G0446 Only)
-2-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Page 13
4. remove the lr3d340 overload relay (figure
440v connection
8), and replace it with an lr3d325 (17-25A)
type, with the dial set to 18A.
(G0446/G0539)
to connect this machine to 440v three-phase,
you must purchase one lr3d076 overload relay
and one lr3d325 overload relay.
transformer
if you do not have three-phase power available to
the g0446/g0539 sander, you will have to install a
phase converter such as the grizzly h3741 phase
Converter.
when using a phase converter, the power from
the manufactured power leg (sometimes called
the wild wire) can fluctuate. Connect the manu-
factured power leg to the s terminal to prevent
damage to the transformer. the wire from the s
terminal can handle some fluctuation because it
goes directly to the motor. the power going to the
r and t terminals goes to the transformer and
must be consistent to prevent damage.
lr3d076
lr3d325
figure 8. overload relay.
5. remove the lr3d086 overload relay (figure
8), and replace it with an lr3d076 (1.6-2.5A)
type, with the dial set to 1.7A.
6. wire the sanding belt, conveyor belt, and
table elevation motors as shown on the
diagrams on the inside of each motor wire
cover.
to wire the Model G0446/G0539 to 440v:
1. Disconnect the sander from the power
source!
note: The circled references on the diagrams
represent labels on the wires. Also, Figure 9
below has been provided for your reference
and is current at the time of writing. However,
always use the diagram on the wire cover
that comes with your motor!
2. open the electrical box located on the back of
the machine.
3. remove the wire labeled “1” at the 220v
terminal of the control power transformer
(figure 7) and connect it to the 440v termi-
nal.
SANDING MOTOR
CONVEYOR MOTOR
W5
U2
U5
U1
W2
W5
W1
U5
U2
V5
V2
V6
W1
V2
V5
TABLE UP/DOWN MOTOR
W2
W5
W1
U2
U5
U1
V2
V5
W2
W6
TRANSFORMER
V1
U6
V1
V1
U1
0
440V
0
200V
220V
440V
440V
440V
figure 9. 440v motor wiring connection.
0
2
3
1
figure 7. the “1” wire should be connected to
the 440v terminal.
-3-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Some Content on Page 40
Wiring box Electrical Diagram (G0446/G0539)
-4-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Some Content on Page 42
Wiring box Electrical Diagram (G0571)
-5-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Page 41
Wiring box components (G0446/G0539)
Replaces Page 43
Wiring box components (G0571)
-6-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Page 44
General Electrical Diagram (G0446/G0539)
E
R
S
T
14
AM
A
15
OL1
M1
U1
V1
W1
R
S
T
U
V
CONVEYOR
BELT
MOTOR
MOTOR
W
F
U2
V2
W2
R
S
T
U
V
TABL E L I FTING
& LOWERING
W
U
V
R
S
T
W
OL3
M3
U
V
R
S
T
U
V
SANDING
BELT
MOTOR
W
R
S
W
FUSE
4A
1
0
440V
0V
220V 200V
2
2
WL
POWER SOURCE
AMP METER POWER
BRAKE
A
A
SOL
13
12
Emergency Brake
R
U
V
S
3
PC
EMERGENCY
BRAKE
5
A
a
b
LS1
Emergency Stop
A
6
LS2
LS3
LS4
PCR1
16
18
17
19
20
21
LS
LS
R
F
F
TABL E L I FTI NG
& L OWERING
PCR2
R
START
M1
7
STOP
STOP
M1
OL1
OL3
8
9
a
b
b
CONVEYOR BEL T
SANDING BELT
GL
START
M3
M3
10
11
a
GL
-7-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
Replaces Page 45
General Electrical Diagram (G0571)
E
R
S
14
AM
A
15
OL1
M1
U1
V1
CONVEYOR
BELT
R
U
MOTOR
S
S
V
V2
R
R
U3
U2
F
V2
U3
U2
V2
U3
U2
S
S
R
T ABLE L I F T I NG
& LOWERING
MOTOR
MOTOR
OL3
M3
U
V
SANDI NG
BELT
R
S
U
V
LT47
R
S
FUSE
4A
2
2
LT47
WL
POWER SOURCE
AMP METER
A
R
A
3
SOL
13
Emergency Brake
PC
12
BRAKE
U
V
S
EMERGENCY
BRAKE
5
LS1
A
a
b
Emergency Stop
A
6
LS2
LS3
LS4
PCR1
16
17
19
20
21
LS
LS
R
F
F
T ABL E L I F T I NG
PCR2
18
&
L OWERI NG
R
START
8
7
STOP
M1
OL1
OL3
9
a
b
b
M1
CONVEYOR BELT
SANDI NG BELT
GL
M3
START
10
STOP
11
a
M3
GL
-8-
g0446, g0539, g0571 (mfg. since 9/10)
Download from Www.Somanuals.com. All Manuals Search And Download.
7!2.).'
HdbZꢀYjhiꢀXgZViZYꢀWnꢀedlZgꢀhVcY^c\!ꢀhVl^c\!ꢀ\g^cY"
^c\!ꢀYg^aa^c\!ꢀVcYꢀdi]ZgꢀXdchigjXi^dcꢀVXi^k^i^ZhꢀXdciV^chꢀ
X]Zb^XVahꢀ `cdlcꢀ idꢀ i]Zꢀ HiViZꢀ d[ꢀ 8Va^[dgc^Vꢀ idꢀ XVjhZꢀ
XVcXZg!ꢀW^gi]ꢀYZ[ZXihꢀdgꢀdi]ZgꢀgZegdYjXi^kZꢀ]Vgb#ꢀHdbZꢀ
ZmVbeaZhꢀd[ꢀi]ZhZꢀX]Zb^XVahꢀVgZ/
ꢀ ™ꢀꢀAZVYꢀ[gdbꢀaZVY"WVhZYꢀeV^cih#
ꢀ ™ꢀꢀ8gnhiVaa^cZꢀh^a^XVꢀ[gdbꢀWg^X`h!ꢀXZbZci!ꢀVcYꢀdi]Zgꢀꢀ
ꢀꢀꢀꢀ ꢀꢀꢀbVhdcgnꢀegdYjXih#
ꢀ ™ꢀꢀ6ghZc^XꢀVcYꢀX]gdb^jbꢀ[gdbꢀX]Zb^XVaanꢀigZViZYꢀꢀꢀ
ꢀ ꢀꢀꢀajbWZg#
Ndjgꢀg^h`ꢀ[gdbꢀi]ZhZꢀZmedhjgZhꢀkVg^Zh!ꢀYZeZcY^c\ꢀdcꢀ
]dlꢀ d[iZcꢀ ndjꢀ Ydꢀ i]^hꢀ ineZꢀ d[ꢀ ldg`#ꢀ Idꢀ gZYjXZꢀ ndjgꢀ
ZmedhjgZꢀidꢀi]ZhZꢀX]Zb^XVah/ꢀldg`ꢀ^cꢀVꢀlZaaꢀkZci^aViZYꢀ
VgZV!ꢀVcYꢀldg`ꢀl^i]ꢀVeegdkZYꢀhV[ZinꢀZfj^ebZci!ꢀhjX]ꢀ
Vhꢀi]dhZꢀYjhiꢀbVh`hꢀi]ViꢀVgZꢀheZX^VaanꢀYZh^\cZYꢀidꢀ[^a"
iZgꢀdjiꢀb^XgdhXde^XꢀeVgi^XaZh#
Download from Www.Somanuals.com. All Manuals Search And Download.
4ABLE OF #ONTENTS
3%#4)/. ꢉꢊ ).42/$5#4)/. ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢀ
;dgZldgYꢀ#################################################################################################################################### (
8dciVXiꢀ>c[dꢀ################################################################################################################################ (
3%#4)/. ꢌꢊ -!#().% &%!452%3ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢄ
:miZgcVaꢀ;ZVijgZhꢀ####################################################################################################################### )
8dcigdaꢀEVcZaꢀ############################################################################################################################# )
6XXZhhꢀ9ddghꢀ############################################################################################################################# *
BVX]^cZꢀ9ViVꢀH]ZZiꢀꢂ<%))+$<%*(.ꢃꢀ######################################################################################## +
BVX]^cZꢀ9ViVꢀH]ZZiꢀꢂ<%*,&ꢃꢀ#################################################################################################### ,
3%#4)/. ꢀꢊ 3!&%49ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢍ
HV[Zinꢀ>chigjXi^dchꢀ[dgꢀBVX]^cZgnꢀ############################################################################################### -
6YY^i^dcVaꢀHV[Zinꢀ[dgꢀL^YZꢀ7ZaiꢀHVcYZghꢀ################################################################################## &%
3%#4)/. ꢄꢊ #)2#5)4 2%15)2%-%.43 ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢉꢉ
''%Kꢀꢄꢀ))%KꢀDeZgVi^dcꢀ########################################################################################################### &&
8dccZXi^dcꢀIneZꢀ###################################################################################################################### &&
<gdjcY^c\ꢀ################################################################################################################################# &'
:miZch^dcꢀ8dgYhꢀ####################################################################################################################### &'
))%Kꢀ8dccZXi^dcꢀꢂ<%))+$<%*(.ꢃꢀ############################################################################################ &(
3%#4)/. ꢇꢊ 3%4 50ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢉꢄ
JceVX`^c\ꢀ################################################################################################################################ &)
>ckZcidgnꢀ################################################################################################################################### &)
=VgYlVgZꢀ8]Vgiꢀ######################################################################################################################## &*
8aZVcꢀJeꢀ################################################################################################################################## &+
H^iZꢀ8dch^YZgVi^dchꢀ################################################################################################################## &+
7Z\^cc^c\ꢀ6hhZbWanꢀ################################################################################################################# &,
;addgꢀBdjci^c\ꢀ######################################################################################################################### &,
6^gꢀA^cZꢀ>chiVaaVi^dcꢀ################################################################################################################### &-
9jhiꢀ8daaZXi^dcꢀ######################################################################################################################### &-
HVcY^c\ꢀ7Zaiꢀ############################################################################################################################# &.
EgZhhjgZꢀGdaaZghꢀ####################################################################################################################### '%
HiVgiꢀJeꢀ#################################################################################################################################### '%
GZXdbbZcYZYꢀ6Y_jhibZcihꢀ#################################################################################################### '&
3%#4)/. ꢅꢊ /0%2!4)/.3 ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢌꢌ
DeZgVi^dcꢀHV[Zinꢀ###################################################################################################################### ''
8]ddh^c\ꢀHVcYeVeZgꢀ############################################################################################################### ''
IVWaZꢀBdkZbZciꢀ###################################################################################################################### '(
6Y_jhi^c\ꢀ;ZZYꢀGViZꢀ################################################################################################################# '(
6beꢀ9gVlꢀBZiZgꢀ###################################################################################################################### ')
HVcY^c\ꢀLdg`e^ZXZꢀ################################################################################################################## '*
EaViZcꢀ6Y_jhibZciꢀ#################################################################################################################### '*
3%#4)/. ꢁꢊ !##%33/2)%3ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢌꢅ
3%#4)/. ꢍꢊ -!).4%.!.#% ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢌꢁ
<ZcZgVaꢀ##################################################################################################################################### ',
HX]ZYjaZꢀ################################################################################################################################## ',
HVcY^c\ꢀ7Zaihꢀ########################################################################################################################### '-
6^gꢀHnhiZbꢀ################################################################################################################################ '-
9jhiꢀVcYꢀLViZgꢀIgVehꢀ############################################################################################################## '-
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢈꢊ 3%26)#% ꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋꢋ ꢌꢈ
IVWaZꢀ8Va^WgVi^dcꢀ###################################################################################################################### '.
7gV`ZꢀHZgk^XZꢀ########################################################################################################################### (%
;ZZYꢀ7ZaiꢀIZch^dcꢀ#################################################################################################################### (&
;ZZYꢀ7ZaiꢀIgVX`^c\ꢀ################################################################################################################### (&
DhX^aaVi^dcꢀI^b^c\ꢀꢀ#################################################################################################################### ('
DhX^aaVi^dcꢀHeZZYꢀ##################################################################################################################### ()
IVWaZꢀEVgVaaZa^hbꢀ###################################################################################################################### ()
EgZhhjgZꢀGdaaZghꢀ####################################################################################################################### (*
K"7Zaiꢀ6Y_jhibZciꢀ#################################################################################################################### (+
6^gꢀHnhiZbꢀ9^V\gVbꢀꢂ<%))+$<%*(.$<%*,&ꢃꢀ########################################################################### (,
BV^cꢀ:aZXig^XVaꢀEVcZaꢀVcYꢀ8dcigdahꢀ9^V\gVbꢀ########################################################################### )+
EVgihꢀA^hiꢀ################################################################################################################################## ),
HVcY^c\ꢀBdidgꢀ9^V\gVbꢀ########################################################################################################### )-
EVgihꢀA^hiꢀ################################################################################################################################## ).
IVWaZꢀA^[iꢀHnhiZbꢀ9^V\gVbꢀ####################################################################################################### *%
EVgihꢀA^hiꢀ################################################################################################################################## *&
8dckZndgꢀHnhiZbꢀ9^V\gVbꢀ###################################################################################################### *'
EVgihꢀA^hiꢀ################################################################################################################################## *(
JeeZgꢀGdaaZgꢀHnhiZbꢀ9^V\gVbꢀ################################################################################################# *)
EVgihꢀA^hiꢀ################################################################################################################################## **
7ZaiꢀDhX^aaVi^dcꢀHnhiZbꢀ9^V\gVbꢀ############################################################################################## *+
EVgihꢀA^hiꢀ################################################################################################################################## *,
;ZZY!ꢀ9gjb!ꢀVcYꢀEgZhhjgZꢀGdaaZgꢀ9^V\gVbꢀ############################################################################## *-
EVgihꢀA^hiꢀ################################################################################################################################## *.
8VW^cZiꢀ6hhZbWanꢀ9^V\gVbꢀ###################################################################################################### +%
EVgihꢀA^hiꢀ################################################################################################################################## +&
Iddaꢀ7dmꢀVcYꢀ6XXZhhdg^Zhꢀ9^V\gVbꢀ######################################################################################### +'
EVgihꢀA^hiꢀ################################################################################################################################## +(
IgdjWaZh]ddi^c\ꢀ######################################################################################################################## +)
LVggVcinꢀꢄꢀGZijgchꢀ################################################################################################################## ++
LVggVcinꢀ8VgYꢀ########################################################################################################################## +,
"'"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢉꢊ ).42/$5#4)/.
&OREWORD
#ONTACT )NFO
LZꢀVgZꢀegdjYꢀidꢀd[[Zgꢀi]ZꢀBdYZahꢀ<%*(.!ꢀ<%*,&!ꢀ
<%))+ꢀ (,ꢅꢀ L^YZꢀ 7Zaiꢀ HVcYZgh#ꢀ I]^hꢀ bVX]^cZꢀ
^hꢀeVgiꢀd[ꢀVꢀ\gdl^c\ꢀ<g^ooanꢀ[Vb^anꢀd[ꢀ[^cZꢀlddY"
ldg`^c\ꢀ bVX]^cZgn#ꢀ L]Zcꢀ jhZYꢀ VXXdgY^c\ꢀ idꢀ
i]Zꢀ \j^YZa^cZhꢀ hZiꢀ [dgi]ꢀ ^cꢀ i]^hꢀ bVcjVa!ꢀ ndjꢀ XVcꢀ
ZmeZXiꢀnZVghꢀd[ꢀigdjWaZ"[gZZ!ꢀZc_dnVWaZꢀdeZgVi^dcꢀ
VcYꢀ egdd[ꢀ d[ꢀ <g^ooan»hꢀ Xdbb^ibZciꢀ idꢀ XjhidbZgꢀ
hVi^h[VXi^dc#
>[ꢀndjꢀ]VkZꢀVcnꢀXdbbZcihꢀgZ\VgY^c\ꢀi]^hꢀbVcjVa!ꢀ
eaZVhZꢀlg^iZꢀidꢀjhꢀViꢀi]ZꢀVYYgZhhꢀWZadl/
<g^ooanꢀ>cYjhig^Va!ꢀ>cX#
8$DꢀIZX]c^XVaꢀ9dXjbZciVi^dcꢀBVcV\Zg
E#D#ꢀ7dmꢀ'%+.
7Zaa^c\]Vb!ꢀL6ꢀꢀ.-'',"'%+.
LZꢀVgZꢀeaZVhZYꢀidꢀegdk^YZꢀi]^hꢀbVcjVaꢀl^i]ꢀi]Zꢀ
BdYZahꢀ <%*(.!ꢀ <%*,&!ꢀ <%))+ꢀ (,ꢅꢀ L^YZꢀ 7Zaiꢀ
HVcYZgh#ꢀ >iꢀ lVhꢀ lg^iiZcꢀ idꢀ \j^YZꢀ ndjꢀ i]gdj\]ꢀ
VhhZbWan!ꢀgZk^ZlꢀhV[ZinꢀXdch^YZgVi^dch!ꢀVcYꢀXdkZgꢀ
\ZcZgVaꢀdeZgVi^c\ꢀegdXZYjgZh#ꢀꢀ
LZꢀhiVcYꢀWZ]^cYꢀdjgꢀbVX]^cZh#ꢀ>[ꢀndjꢀ]VkZꢀVcnꢀ
hZgk^XZꢀfjZhi^dchꢀdgꢀeVgihꢀgZfjZhih!ꢀeaZVhZꢀXVaaꢀdgꢀ
lg^iZꢀjhꢀViꢀi]ZꢀadXVi^dcꢀa^hiZYꢀWZadl#
<g^ooanꢀ>cYjhig^Va!ꢀ>cX#
&'%(ꢀAnXdb^c\ꢀBVaaꢀ8^gXaZ
BjcXn!ꢀE6ꢀꢀ&,,*+
E]dcZ/ꢀꢂ*,%ꢃꢀ*)+".++(
;Vm/ꢀꢂ-%%ꢃꢀ)(-"*.%&
I]Zꢀ heZX^[^XVi^dch!ꢀ YgVl^c\h!ꢀ VcYꢀ e]did\gVe]hꢀ
^aajhigViZYꢀ ^cꢀ i]^hꢀ bVcjVaꢀ gZegZhZciꢀ i]Zꢀ BdYZahꢀ
<%*(.!ꢀ <%*,&!ꢀ <%))+ꢀ (,ꢅꢀ L^YZꢀ 7Zaiꢀ HVcYZghꢀ
Vhꢀ hjeea^ZYꢀ l]Zcꢀ i]Zꢀ bVcjVaꢀ lVhꢀ egZeVgZY#ꢀ
;dgꢀ ndjgꢀ XdckZc^ZcXZ!ꢀ lZꢀ ValVnhꢀ `ZZeꢀ XjggZciꢀ
<g^ooanꢀbVcjVahꢀVkV^aVWaZꢀdcꢀdjgꢀlZWh^iZꢀVi WWWꢋ
GRIZZLYꢋCOM#ꢀ6cnꢀjeYViZhꢀidꢀndjgꢀbVX]^cZꢀl^aaꢀWZꢀ
gZ[aZXiZYꢀ ^cꢀ i]ZhZꢀ bVcjVahꢀ Vhꢀ hddcꢀ Vhꢀ i]Znꢀ VgZꢀ
XdbeaZiZ#ꢀ
:"BV^a/ꢀiZX]hjeedgi5\g^ooan#Xdb
LZWꢀH^iZ/ꢀ]iie/$$lll#\g^ooan#Xdb
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"("
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢌꢊ -!#().% &%!452%3
%XTERNAL &EATURES
#ONTROL 0ANEL
9
:
;
6
J
?
I
8
H
G
F
7
@
E
D
C
&IGURE ꢉꢋꢀ;gdciꢀK^Zl#
A
B
<
=
>
&IGURE ꢀꢋ 8dcigdaꢀEVcZa#
*ꢋ IVWaZꢀJeꢀ@Zn
+ꢋ HVcY^c\ꢀ7ZaiꢀHiVgiꢀ7jiidc
,ꢋ 8dckZndgꢀ7ZaiꢀHiVgiꢀ7jiidc
-ꢋ EdlZgꢀA^\]i
.ꢋ :bZg\ZcXnꢀHideꢀ7jiidc
/ꢋ ;ZZYꢀ7ZaiꢀHideꢀ7jiidc
0ꢋ HVcY^c\ꢀ7ZaiꢀHideꢀ7jiidc
1ꢋ IVWaZꢀ9dlcꢀ@Zn
2ꢋ IVWaZꢀHideꢀ@Zn
3ꢋ IVWaZꢀHiVgiꢀ@Zn
4ꢋ IVWaZꢀHZiꢀꢂ:ciZgꢃꢀ@Zn
5ꢋ IVWaZ"=Z^\]iꢀ9^\^iVaꢀGZVYdji
&IGURE ꢌꢋꢀGZVgꢀK^Zl#
!ꢋꢀ 8dcigdaꢀEVcZa
"ꢋꢀ IVWaZꢀ=Z^\]iꢀ=VcYl]ZZa
#ꢋꢀ :bZg\ZcXnꢀHideꢀ7Vg
$ꢋꢀ )ꢅꢀ9jhiꢀEdgiꢀꢂ(ꢃ
%ꢋꢀ 6beꢀꢂAdVYꢃꢀBZiZg
&ꢋꢀ 9^\^iVaꢀIVWaZꢀ=Z^\]iꢀ@ZnꢀEVY
'ꢋꢀ 8dckZndgꢀHeZZYꢀ8dcigda
(ꢋꢀ 6^gꢀEgZhhjgZꢀGZ\jaVidg
)ꢋꢀ BV^cꢀL^g^c\ꢀ7dm
")"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
!CCESS $OORS
:
?
6
7
;
>
9
=
8
<
@
&IGURE ꢄꢋꢀ>ch^YZꢀi]ZꢀaZ[iꢀVXXZhhꢀYddg#
&IGURE ꢇꢋꢀ>ch^YZꢀi]Zꢀg^\]iꢀVXXZhhꢀYddg#
!ꢋꢀ 7ZaiꢀIZch^dcꢀ@cdW
&ꢋꢀ JeeZgꢀGdaaZg
'ꢋꢀ 6^g[adlꢀ6Y_jhibZciꢀ@cdW
(ꢋꢀ HeZZYꢀ8dcigdaꢀ6Y_jhibZciꢀ@cdW
)ꢋꢀ 6^gꢀ;dg`ꢀVcYꢀ6^gꢀ?Zi
*ꢋꢀ 9^Ve]gV\bꢀKVakZꢀ6hhZbWan
+ꢋꢀ 8dckZndgꢀ<ZVgWdmꢀVcYꢀ8dcigda
"ꢋꢀ EaViZcꢀ6Y_jhibZciꢀAZkZg
#ꢋꢀ EaViZcꢀ6Y_jhibZciꢀAdX`ꢀAZkZg
$ꢋꢀ AdX`ꢀEdhiꢀGZaZVhZꢀAZkZg
%ꢋꢀ IgVX`^c\ꢀ6Y_jhibZciꢀ@cdW
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"*"
Download from Www.Somanuals.com. All Manuals Search And Download.
-!#().% $!4!
3(%%4
8jhidbZgꢀHZgk^XZꢀꢁ/ꢀꢂ*,%ꢃꢀ*)+".++(ꢀ™ꢀIdꢀDgYZgꢀ8Vaa/ꢀꢂ-%%ꢃꢀ*'("),,,ꢀ™ꢀ;Vmꢀꢁ/ꢀꢂ-%%ꢃꢀ)(-"*.%&
-/$%, 'ꢀꢁꢁꢂ ꢃ 'ꢀꢄꢅꢆ ꢅꢇꢈ 7)$%ꢉ"%,4 3!.$%23
9Zh^\cꢀIneZꢀ######################################################################################################;addgꢀBdYZa
/VERALL $IMENSIONSꢊ
ꢀ
L^Yi]ꢀ###############################################################################ꢂ<%*(./ꢀ*(ꢅꢃ!ꢀꢂ<%))+/ꢀ*+&¿'ꢅꢃꢀ
-ꢀꢈ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
=Z^\]iꢀL$9jhiꢀEdgihꢀ#####################################################ꢂ<%*(./ꢀ+.&¿'ꢅꢃ!ꢀꢂ<%))+/ꢀ,,&¿'ꢅꢃ
=Z^\]iꢀL$Dꢀ9jhiꢀEdgihꢀ####################################################ꢂ<%*(./ꢀ+)ꢅꢃ!ꢀꢂ<%))+/ꢀ,&&¿'ꢅꢃꢀꢀ
9Zei]ꢀ###############################################################################ꢂ<%*(./ꢀ).&¿'ꢅꢃ!ꢀꢂ<%))+/ꢀ*'ꢅꢃꢀ
8dckZndgꢀ=Z^\]iꢀViꢀAdlZhiꢀHZii^c\ꢀ##########################################################################('ꢆꢆ
CZiꢀLZ^\]iꢀ######################################################ꢂ<%*(./ꢀ'(%%ꢀaWh#ꢃ!ꢀꢂ<%))+/ꢀ'%.)ꢀaWh#ꢃ
;ddieg^ciꢀ#######################################################################################################&.ꢅꢀmꢀ*&&¿'
ꢅ
#APACITIESꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
BVm^bjbꢀ7dVgYꢀL^Yi]ꢀ####################################################ꢂ<%*(./ꢀ(+ꢅꢃ!ꢀꢂ<%))+/ꢀ(+&¿'ꢅꢃ
BVm^bjbꢀ7dVgYꢀI]^X`cZhhꢀ########################################################################################+ꢅ
B^c^bjbꢀ7dVgYꢀAZc\i]ꢀ########################################################ꢂ<%*(./ꢀ&)ꢅꢃ!ꢀꢂ<%))+/ꢀ.ꢅꢃꢀ
B^c^bjbꢀ7dVgYꢀI]^X`cZhhꢀ########################################################################################&¿-
ꢅ
7ZaiꢀHeZZYꢀ#################################################################################################### '+%%ꢀ;EB
8dckZndgꢀHeZZYꢀ######################################################################################### &*").ꢀ;EB
9jhiꢀEdgihꢀꢂ(ꢃꢀ#############################################################################################################)ꢆꢆ
3ANDING $RUM -OTORꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
IneZꢀ#####################################################################################################I:;8ꢀ>cYjXi^dc
=dghZedlZgꢀ#########################################################################################################&*ꢀ=E
KdaiV\Zꢀ$ꢀE]VhZꢀ$ꢀ8nXaZꢀ###########################################''%Kꢀ$ꢀ))%KꢀI]gZZ"E]VhZꢀ¿ꢀ+%ꢀ=O
6behꢀ############################################################################################################## (+ꢀ$ꢀ&-ꢀ6
GEBꢀ#############################################################################################################&,'*ꢀGEBꢀ
EdlZgꢀIgVch[Zgꢀidꢀ9gjbhꢀ########################################################################## Ig^eaZꢀK"7Zaiꢀ
#ONVEYOR &EED -OTORꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
IneZꢀ#####################################################################################################I:;8ꢀ>cYjXi^dc
=dghZedlZgꢀ###########################################################################################################&ꢀ=E
KdaiV\Zꢀ$ꢀE]VhZꢀ$ꢀ8nXaZꢀ###########################################''%Kꢀ$ꢀ))%KꢀI]gZZ"E]VhZꢀ¿ꢀ+%ꢀ=Oꢀ
6behꢀ############################################################################################################ (#)ꢀ$ꢀ&#,ꢀ6
GEBꢀ###################################################################################################################### &,'*
EdlZgꢀIgVch[Zgꢀ#################################################################################################### K"7Zai
4ABLE ,IFT -OTORꢊ
IneZꢀ#####################################################################################################I:;8ꢀ>cYjXi^dc
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
=dghZedlZgꢀ######################################################################################################## &¿)ꢀ=E
KdaiV\Zꢀ$ꢀE]VhZꢀ$ꢀ8nXaZꢀ###########################################''%Kꢀ$ꢀ))%KꢀI]gZZ"E]VhZꢀ¿ꢀ+%ꢀ=Oꢀ
6behꢀ############################################################################################################ &#'ꢀ$ꢀ%#+ꢀ6
GEBꢀ###################################################################################################################### &,'*
EdlZgꢀIgVch[Zgꢀ#################################################################################################### K"7Zai
'ENERAL #ONSTRUCTIONꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
8VW^cZiꢀ##################################################################################################################HiZZa
DeZgVi^c\ꢀ6^gꢀEgZhhjgZꢀ####################################################################################### ,*ꢀEH>
HVcY^c\ꢀ7ZaiꢀDhX^aaVi^dcꢀ############################################################################### 6Y_jhiVWaZ
HVcY^c\ꢀ7Zaiꢀ7gV`Zꢀ################################################################################ 6^gꢀ9^hXꢀ7gV`Z
8dcigdaꢀEVcZaꢀ####################################### Ejh]ꢀ7jiidcꢀ[dgꢀZVX]ꢀbdidg!ꢀeajhꢀadVYꢀhZchdg
HVcY^c\ꢀ7Zaiꢀ#################################################### ꢂ<%*(./ꢀ(+ꢅꢀmꢀ+%ꢅꢃ!ꢀꢂ<%))+/ꢀ(,ꢅꢀmꢀ,*ꢅꢃ
3PECIFICATIONSꢀ WHILE DEEMED ACCURATEꢀ ARE NOT GUARANTEEDꢁ
"+"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
-!#().% $!4!
3(%%4
8jhidbZgꢀHZgk^XZꢀꢁ/ꢀꢂ*,%ꢃꢀ*)+".++(ꢀ™ꢀIdꢀDgYZgꢀ8Vaa/ꢀꢂ-%%ꢃꢀ*'("),,,ꢀ™ꢀ;Vmꢀꢁ/ꢀꢂ-%%ꢃꢀ)(-"*.%&
-/$%, 'ꢀꢄꢇꢊ ꢅꢇꢈ 7)$%ꢉ"%,4 3!.$%2
9Zh^\cꢀIneZꢀ######################################################################################################;addgꢀBdYZa
/VERALL $IMENSIONSꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
L^Yi]ꢀꢀ#######################################################################################################################*(ꢅꢀ
=Z^\]iꢀL$9jhiꢀEdgihꢀ##############################################################################################+.&¿'ꢅꢀ
=Z^\]iꢀL$Dꢀ9jhiꢀEdgihꢀ#############################################################################################+)ꢅ
9Zei]ꢀ####################################################################################################################ꢀ).&¿'ꢅꢀꢀ
8dckZndgꢀ=Z^\]iꢀViꢀAdlZhiꢀHZii^c\ꢀ##########################################################################('ꢆꢆ
CZiꢀLZ^\]iꢀ##################################################################################################### '(%%ꢀaWh#
;ddieg^ciꢀ#######################################################################################################&.ꢅꢀmꢀ*&&¿'ꢅꢀ
#APACITIESꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
BVm^bjbꢀ7dVgYꢀL^Yi]ꢀ#############################################################################################(+ꢅ
BVm^bjbꢀ7dVgYꢀI]^X`cZhhꢀ########################################################################################+ꢅ
B^c^bjbꢀ7dVgYꢀAZc\i]ꢀ############################################################################################&)ꢅ
B^c^bjbꢀ7dVgYꢀI]^X`cZhhꢀ########################################################################################&¿-
ꢅ
7ZaiꢀHeZZYꢀ#################################################################################################### '+%%ꢀ;EB
8dckZndgꢀHeZZYꢀ######################################################################################### &*").ꢀ;EB
9jhiꢀEdgihꢀꢂ(ꢃꢀ#############################################################################################################)ꢆꢆ
3ANDING $RUM -OTORꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
IneZꢀ############################################################################I:;8ꢀ8VeVX^idgꢀHiVgiꢀ>cYjXi^dc
=dghZedlZgꢀ#########################################################################################################&%ꢀ=E
KdaiV\Zꢀ$ꢀE]VhZꢀ$ꢀ8nXaZꢀ#####################################################''%K$ꢀH^c\aZ"E]VhZꢀ¿ꢀ+%ꢀ=O
6behꢀ######################################################################################################################*%ꢀ6
GEBꢀ#############################################################################################################&,'*ꢀGEBꢀ
EdlZgꢀIgVch[Zgꢀidꢀ9gjbhꢀ########################################################################## Ig^eaZꢀK"7Zaiꢀ
#ONVEYOR &EED -OTORꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
IneZꢀ############################################################################I:;8ꢀ8VeVX^idgꢀHiVgiꢀ>cYjXi^dc
=dghZedlZgꢀ###########################################################################################################&ꢀ=E
KdaiV\Zꢀ$ꢀE]VhZꢀ$ꢀ8nXaZꢀ###################################################''%Kꢀ$ꢀH^c\aZ"E]VhZꢀ$ꢀ+%ꢀ=Oꢀꢀ
6behꢀ########################################################################################################################,ꢀ6
GEBꢀ###################################################################################################################### &,'*
EdlZgꢀIgVch[Zgꢀ#################################################################################################### K"7Zai
4ABLE ,IFT -OTORꢊ
IneZꢀ############################################################################I:;8ꢀ8VeVX^idgꢀHiVgiꢀ>cYjXi^dc
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
=dghZedlZgꢀ######################################################################################################## &¿(ꢀ=E
KdaiV\Zꢀ$ꢀE]VhZꢀ$ꢀ8nXaZꢀ################################################### ''%Kꢀ$ꢀH^c\aZ"E]VhZꢀ¿ꢀ+%ꢀ=Oꢀ
6behꢀ########################################################################################################################(ꢀ6
GEBꢀ###################################################################################################################### &,'*
EdlZgꢀIgVch[Zgꢀ#################################################################################################### K"7Zai
'ENERAL #ONSTRUCTIONꢊ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
8VW^cZiꢀ##################################################################################################################HiZZa
DeZgVi^c\ꢀ6^gꢀEgZhhjgZꢀ####################################################################################### ,*ꢀEH>
HVcY^c\ꢀ7ZaiꢀDhX^aaVi^dcꢀ############################################################################### 6Y_jhiVWaZ
HVcY^c\ꢀ7Zaiꢀ7gV`Zꢀ################################################################################ 6^gꢀ9^hXꢀ7gV`Z
8dcigdaꢀEVcZaꢀ####################################### Ejh]ꢀ7jiidcꢀ[dgꢀZVX]ꢀbdidg!ꢀeajhꢀadVYꢀhZchdg
HVcY^c\ꢀ7Zaiꢀ####################################################################################################(+ꢅꢀmꢀ+%ꢅ
3PECIFICATIONSꢀ WHILE DEEMED ACCURATEꢀ ARE NOT GUARANTEEDꢁ
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
","
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢀꢊ 3!&%49
&OR 9OUR /WN 3AFETYꢆ 2EAD )NSTRUCTION
-ANUAL "EFORE /PERATING THIS -ACHINE
4HE PURPOSE OF SAFETY SYMBOLS IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDOUS CONDITIONSꢋ 4HIS
MANUAL USES A SERIES OF SYMBOLS AND SIGNAL WORDS WHICH ARE INTENDED TO CONVEY THE LEVEL OF
IMPORTANCE OF THE SAFETY MESSAGESꢋ 4HE PROGRESSION OF SYMBOLS IS DESCRIBED BELOWꢋ 2EMEMBER
THAT SAFETY MESSAGES BY THEMSELVES DO NOT ELIMINATE DANGER AND ARE NOT A SUBSTITUTE FOR PROPER
ACCIDENT PREVENTION MEASURESꢋ
)NDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICHꢆ IF NOT AVOIDEDꢆ
7),, RESULT IN DEATH OR SERIOUS INJURYꢋ
)NDICATES A POTENTIALLY HAZARDOUS SITUATION WHICHꢆ IF NOT AVOIDEDꢆ
#/5,$ RESULT IN DEATH OR SERIOUS INJURYꢋ
)NDICATES A POTENTIALLY HAZARDOUS SITUATION WHICHꢆ IF NOT AVOIDEDꢆ
-!9 RESULT IN MINOR OR MODERATE INJURYꢋ )T MAY ALSO BE USED TO ALERT
AGAINST UNSAFE PRACTICESꢋ
4HIS SYMBOL IS USED TO ALERT THE USER TO USEFUL INFORMATION ABOUT
PROPER OPERATION OF THE MACHINEꢋ
./4)#%
3AFETY )NSTRUCTIONS FOR -ACHINERY
ꢉꢋ 2%!$ 4(2/5'( 4(% %.4)2% -!.5!,
"%&/2% 34!24).' -!#().%29ꢋ
BVX]^cZgnꢀegZhZcihꢀhZg^djhꢀ^c_jgnꢀ]VoVgYhꢀ
idꢀjcigV^cZYꢀjhZgh#ꢀ
ꢄꢋ !,7!93 53% (%!2).' 02/4%#4)/.
7(%. /0%2!4).' -!#().%29ꢋꢀ
BVX]^cZgnꢀ cd^hZꢀ XVcꢀ XVjhZꢀ eZgbVcZciꢀ
]ZVg^c\ꢀYVbV\Z#ꢀ
ꢇꢋ 7%!2 02/0%2 !00!2%,ꢋꢀ 9Dꢀ CDIꢀ
lZVgꢀaddhZꢀXadi]^c\!ꢀ\adkZh!ꢀcZX`i^Zh!ꢀg^c\h!ꢀ
dgꢀ_ZlZagnꢀl]^X]ꢀbVnꢀ\ZiꢀXVj\]iꢀ^cꢀbdk^c\ꢀ
eVgih#ꢀLZVgꢀegdiZXi^kZꢀ]V^gꢀXdkZg^c\ꢀidꢀXdc"
iV^cꢀadc\ꢀ]V^gꢀVcYꢀlZVgꢀcdc"ha^eꢀ[ddilZVg#
ꢌꢋ !,7!93 53% !.3) !002/6%$
3!&%49 ',!33%3 7(%. /0%2!4).'
-!#().%29ꢋ :kZgnYVnꢀ ZnZ\aVhhZhꢀ dcanꢀ
]VkZꢀ ^beVXiꢀ gZh^hiVciꢀ aZchZh!ꢀ i]Znꢀ VgZꢀ
CDIꢀhV[Zinꢀ\aVhhZh#
ꢅꢋ .%6%2 /0%2!4% -!#().%29 7(%.
4)2%$ꢆ /2 5.$%2 4(% ).&,5%.#% /&
$25'3 /2 !,#/(/,ꢋ 7ZꢀbZciVaanꢀVaZgiꢀ
ViꢀVaaꢀi^bZhꢀl]Zcꢀgjcc^c\ꢀbVX]^cZgn#
ꢀꢋ !,7!93 7%!2 !. !.3) !002/6%$
2%30)2!4/2 7(%. /0%2!4).'
-!#().%29 4(!4 02/$5#%3 $534ꢋꢀ
LddYꢀYjhiꢀ^hꢀVꢀXVgX^cd\ZcꢀVcYꢀXVcꢀXVjhZꢀ
XVcXZgꢀVcYꢀhZkZgZꢀgZhe^gVidgnꢀ^aacZhhZh#
"-"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
3AFETY )NSTRUCTIONS FOR -ACHINERY
ꢁꢋ /.,9 !,,/7 42!).%$ !.$ 02/0ꢐ
ꢉꢁꢋ 2%-/6% !$*534).' +%93 !.$
%2,9 350%26)3%$ 0%23/..%, 4/
/0%2!4% -!#().%29ꢋꢀ BV`Zꢀ hjgZꢀ
deZgVi^dcꢀ^chigjXi^dchꢀVgZꢀhV[ZꢀVcYꢀXaZVganꢀ
jcYZghiddY#
72%.#(%3ꢋꢀBV`ZꢀVꢀ]VW^iꢀd[ꢀX]ZX`^c\ꢀ[dgꢀ
`ZnhꢀVcYꢀVY_jhi^c\ꢀlgZcX]ZhꢀWZ[dgZꢀijgc"
^c\ꢀbVX]^cZgnꢀ/.#
ꢉꢍꢋ #(%#+ &/2 $!-!'%$ 0!243
"%&/2% 53).' -!#().%29ꢋꢀ 8]ZX`ꢀ
[dgꢀW^cY^c\ꢀVcYꢀVa^\cbZciꢀd[ꢀeVgih!ꢀWgd`Zcꢀ
eVgih!ꢀeVgiꢀbdjci^c\!ꢀaddhZꢀWdaih!ꢀVcYꢀVcnꢀ
di]Zgꢀ XdcY^i^dchꢀ i]Viꢀ bVnꢀ V[[ZXiꢀ bVX]^cZꢀ
deZgVi^dc#ꢀ GZeV^gꢀ dgꢀ gZeaVXZꢀ YVbV\ZYꢀ
eVgih#
ꢍꢋ +%%0 #(),$2%. !.$ 6)3)4/23 !7!9ꢋ
@ZZeꢀ Vaaꢀ X]^aYgZcꢀ VcYꢀ k^h^idghꢀ Vꢀ hV[Zꢀ Y^h"
iVcXZꢀ[gdbꢀi]Zꢀldg`ꢀVgZV#
ꢈꢋ -!+% 7/2+3(/0 #(),$ 02//&ꢋꢀJhZꢀ
eVYadX`h!ꢀ bVhiZgꢀ hl^iX]Zh!ꢀ VcYꢀ gZbdkZꢀ
hiVgiꢀhl^iX]ꢀ`Znh#
ꢉꢈꢋ 53% 2%#/--%.$%$ !##%33/2)%3ꢋꢀ
GZ[Zgꢀidꢀi]Zꢀ^chigjXi^dcꢀbVcjVaꢀ[dgꢀgZXdb"
bZcYZYꢀVXXZhhdg^Zh#ꢀI]ZꢀjhZꢀd[ꢀ^begdeZgꢀ
VXXZhhdg^ZhꢀbVnꢀXVjhZꢀg^h`ꢀd[ꢀ^c_jgn#
ꢉꢃꢋ .%6%2 ,%!6% 7(%. -!#().% )3
25..).'ꢋ IjgcꢀedlZgꢀ/&&ꢀVcYꢀVaadlꢀVaaꢀ
bdk^c\ꢀeVgihꢀidꢀXdbZꢀidꢀVꢀXdbeaZiZꢀhideꢀ
WZ[dgZꢀaZVk^c\ꢀbVX]^cZꢀjcViiZcYZY#
ꢌꢃꢋ $/ ./4 &/2#% -!#().%29ꢋꢀ Ldg`ꢀ Viꢀ
i]ZꢀheZZYꢀ[dgꢀl]^X]ꢀi]ZꢀbVX]^cZꢀdgꢀVXXZh"
hdgnꢀlVhꢀYZh^\cZY#
ꢉꢉꢋ $/ ./4 53% ). $!.'%2/53
%.6)2/.-%.43ꢋ 9Dꢀ CDIꢀ jhZꢀ bVX]^c"
Zgnꢀ^cꢀYVbe!ꢀlZiꢀadXVi^dch!ꢀdgꢀl]ZgZꢀVcnꢀ
[aVbbVWaZꢀdgꢀcdm^djhꢀ[jbZhꢀbVnꢀZm^hi#ꢀ
ꢌꢉꢋ 3%#52% 7/2+0)%#%ꢋꢀ JhZꢀ XaVbehꢀ dgꢀ
Vꢀk^hZꢀidꢀ]daYꢀi]Zꢀldg`e^ZXZꢀl]ZcꢀegVXi^"
XVa#ꢀ 6ꢀ hZXjgZYꢀ ldg`e^ZXZꢀ egdiZXihꢀ ndjgꢀ
]VcYhꢀVcYꢀ[gZZhꢀWdi]ꢀ]VcYhꢀidꢀdeZgViZꢀi]Zꢀ
bVX]^cZ#
ꢉꢌꢋ +%%0 7/2+ !2%! #,%!. !.$ 7%,,
,)4ꢋ 8ajiiZgꢀVcYꢀYVg`ꢀh]VYdlhꢀbVnꢀXVjhZꢀ
VXX^YZcih#
ꢌꢌꢋ $/ ./4 /6%22%!#(ꢋꢀ@ZZeꢀegdeZgꢀ[ddi"
ꢉꢀꢋ 53% ! '2/5.$%$ %84%.3)/. #/2$
2!4%$&/24(%-!#().%!-0%2!'%ꢋ
JcYZgh^oZYꢀXdgYhꢀdkZg]ZViꢀVcYꢀadhZꢀedlZg#ꢀ
GZeaVXZꢀ ZmiZch^dcꢀ XdgYhꢀ ^[ꢀ i]Znꢀ WZXdbZꢀ
YVbV\ZY#ꢀ 9Dꢀ CDIꢀ jhZꢀ ZmiZch^dcꢀ XdgYhꢀ
[dgꢀ''%KꢀbVX]^cZgn#ꢀ
^c\ꢀVcYꢀWVaVcXZꢀViꢀVaaꢀi^bZh#
ꢌꢀꢋ -!.9 -!#().%3 7),, %*%#4 4(%
7/2+0)%#%4/7!2$4(%/0%2!4/2ꢋ
@cdlꢀVcYꢀVkd^YꢀXdcY^i^dchꢀi]ViꢀXVjhZꢀi]Zꢀ
ldg`e^ZXZꢀidꢀꢅ`^X`WVX`#ꢅ
ꢉꢄꢋ !,7!93 $)3#/..%#4 &2/- 0/7%2
ꢌꢄꢋ !,7!93 ,/#+ -/"),% "!3%3
3/52#%
"%&/2%
3%26)#).'
ꢎ)& 53%$
"%&/2% /0%2!4).'
-!#().%29#ꢀBV`ZꢀhjgZꢀhl^iX]ꢀ^hꢀ^cꢀD;;
ꢀ
-!#().%29#
edh^i^dcꢀWZ[dgZꢀgZXdccZXi^c\#
ꢌꢇꢋ "% !7!2% 4(!4 #%24!). 7//$3
-!9 #!53% !. !,,%2')# 2%!#4)/.ꢀ
^cꢀ eZdeaZꢀ VcYꢀ Vc^bVah!ꢀ ZheZX^Vaanꢀ l]Zcꢀ
ZmedhZYꢀ idꢀ [^cZꢀ Yjhi#ꢀ BV`Zꢀ hjgZꢀ ndjꢀ
`cdlꢀl]ViꢀineZꢀd[ꢀlddYꢀYjhiꢀndjꢀl^aaꢀWZꢀ
ZmedhZYꢀidꢀVcYꢀValVnhꢀlZVgꢀVcꢀVeegdkZYꢀ
gZhe^gVidg#ꢀꢀ
ꢉꢇꢋ -!).4!). -!#().%29 7)4( #!2%ꢋꢀ
@ZZeꢀWaVYZhꢀh]VgeꢀVcYꢀXaZVcꢀ[dgꢀWZhiꢀVcYꢀ
hV[ZhiꢀeZg[dgbVcXZ#ꢀ;daadlꢀ^chigjXi^dchꢀ[dgꢀ
ajWg^XVi^c\ꢀVcYꢀX]Vc\^c\ꢀVXXZhhdg^Zh#
ꢉꢅꢋ -!+% 352% '5!2$3 !2% ). 0,!#%
!.$ 7/2+ #/22%#4,9 "%&/2%
53).' -!#().%29ꢋ
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"."
Download from Www.Somanuals.com. All Manuals Search And Download.
!DDITIONAL 3AFETY FOR 7IDE "ELT 3ANDERS
ꢉꢋꢀ ).&%%$ꢏ/54&%%$ !2%!ꢊꢀ L]Zcꢀ [ZZY^c\ꢀ
i]Zꢀldg`e^ZXZꢀ^cidꢀi]ZꢀbVX]^cZ!ꢀ`ZZeꢀXaZVgꢀ
d[ꢀ`^X`WVX`ꢀeVi]#
ꢉꢃꢋꢀ 5.!44%.$%$ -!#().%ꢊꢀ CZkZgꢀ aZVkZꢀ
i]ZꢀbVX]^cZꢀgjcc^c\ꢀjcViiZcYZY#
ꢉꢉꢋꢀ 3!.$0!0%2ꢊꢀGZeaVXZꢀhVcY^c\ꢀWZaiꢀl]Zcꢀ
ꢌꢋꢀ 7/2+0)%#% &%%$).'ꢊꢀ CZkZgꢀ [dgXZꢀ i]Zꢀ
ldg`e^ZXZꢀ ^cidꢀ i]Zꢀ hVcYZg!ꢀ VcYꢀ [ZZYꢀ dcanꢀ
dcZꢀldg`e^ZXZꢀViꢀVꢀi^bZ#ꢀꢀ
^iꢀWZXdbZhꢀldgcꢀdgꢀYVbV\ZY#
ꢉꢌꢋꢀ &/2%)'. -!4%2)!,ꢊ 6alVnhꢀ ^cheZXiꢀ
ldg`e^ZXZꢀ [dgꢀ cV^ah!ꢀ hiVeaZh!ꢀ `cdih!ꢀ VcYꢀ
di]Zgꢀ ^beZg[ZXi^dchꢀ i]Viꢀ XdjaYꢀ WZꢀ Y^h"
adY\ZYꢀVcYꢀi]gdlcꢀ[gdbꢀi]ZꢀbVX]^cZꢀYjg"
^c\ꢀhVcY^c\ꢀdeZgVi^dch#
ꢀꢋꢀ #,/4().'ꢊ GdaaꢀjeꢀdgꢀWjiidcꢀhaZZkZh!ꢀi^Zꢀ
VaaꢀaddhZꢀXadi]^c\ꢀdgꢀ]V^gꢀhdꢀ^iꢀl^aaꢀ`ZZeꢀXaZVgꢀ
d[ꢀZciVc\aZbZciꢀ]VoVgYh#ꢀꢀ
ꢄꢋꢀ .!22/7 7/2+0)%#%3ꢊꢀ CZkZgꢀ hVcYꢀ
ꢉꢀꢋꢀ $534 #/,,%#4)/.ꢊ CZkZg deZgViZꢀ i]Zꢀ
hVcYZgꢀ l^i]djiꢀ Vcꢀ VYZfjViZꢀ Yjhiꢀ XdaaZX"
i^dcꢀhnhiZbꢀ^cꢀeaVXZꢀVcYꢀgjcc^c\#
ldg`e^ZXZhꢀcVggdlZgꢀi]Vcꢀ&¿-ꢆꢆ#
ꢇꢋꢀ 4(). 7/2+0)%#%3ꢊꢀ CZkZgꢀ hVcYꢀ ldg`"
e^ZXZhꢀi]^ccZgꢀi]Vcꢀ&¿-ꢆꢆ#
ꢉꢄꢋ !,,%2')%3ꢊ 8ZgiV^cꢀ lddYhꢀ bVnꢀ XVjhZꢀ
VcꢀVaaZg\^XꢀgZVXi^dcꢀ^cꢀeZdeaZꢀVcYꢀVc^bVah!ꢀ
ZheZX^Vaanꢀ l]Zcꢀ ZmedhZYꢀ idꢀ [^cZꢀ Yjhi#ꢀ
BV`Zꢀ hjgZꢀ ndjꢀ `cdlꢀ l]Viꢀ ineZꢀ d[ꢀ lddYꢀ
Yjhiꢀ ndjꢀ l^aaꢀ WZꢀ ZmedhZYꢀ idꢀ VcYꢀ ValVnhꢀ
lZVgꢀVcꢀVeegdkZYꢀgZhe^gVidg#ꢀꢀ
ꢅꢋꢀ 3(/24 7/2+0)%#%3ꢊꢀCZkZgꢀhVcYꢀldg`"
e^ZXZhꢀh]dgiZgꢀi]Vcꢀ&)ꢆꢆ#
ꢁꢋꢀ (!.$3ꢊ CZkZgꢀ eaVXZꢀ ]VcYhꢀ cZVg!ꢀ dgꢀ ^cꢀ
XdciVXiꢀ l^i]!ꢀ hVcY^c\ꢀ Ygjbhꢀ dgꢀ XdckZndgꢀ
WZaiꢀYjg^c\ꢀdeZgVi^dc#
ꢉꢇꢋ !##%33 $//23ꢊ CZkZgꢀeZg[dgbꢀhVcY^c\ꢀ
deZgVi^dchꢀl]Zcꢀi]Zꢀh^YZꢀVXXZhhꢀYddghꢀVgZꢀ
deZc#ꢀ
ꢍꢋ -!).4%.!.#%ꢊ EZg[dgbꢀbVX]^cZꢀ^cheZX"
i^dchꢀVcYꢀbV^ciZcVcXZꢀhZgk^XZꢀViꢀi]ZꢀVeegd"
eg^ViZꢀi^bZꢀ^ciZgkVah#ꢀ
ꢉꢅꢋꢀ 5.$%234!.$ ).3425#4)/.3ꢊ CZkZgꢀ
VaadlꢀjchjeZgk^hZYꢀdgꢀjcigV^cZYꢀeZghdccZaꢀ
idꢀ deZgViZꢀ i]Zꢀ bVX]^cZ# BV`Zꢀ hjgZꢀ Vcnꢀ
^chigjXi^dchꢀndjꢀ\^kZꢀ^cꢀgZ\VgYhꢀidꢀbVX]^cZꢀ
deZgVi^dcꢀVgZꢀVeegdkZY!ꢀXdggZXi!ꢀhV[Z!ꢀVcYꢀ
XaZVganꢀjcYZghiddY#
"ꢈꢋꢀ 0/7%2 !.$ !)2 $)3#/..%#4ꢊꢀJcaZhhꢀ
heZX^[^XVaanꢀ hiViZYꢀ ^cꢀ i]Zꢀ bVcjVa!ꢀ ValVnhꢀ
Y^hXdccZXiꢀ i]Zꢀ edlZgꢀ hdjgXZꢀ [gdbꢀ i]Zꢀ
bVX]^cZꢀ l]Zcꢀ eZg[dgb^c\ꢀ bV^ciZcVcXZ!ꢀ
VY_jhibZcih!ꢀdgꢀVhhZbWan#ꢀ6alVnhꢀgZVYꢀVcYꢀ
[daadlꢀ heZX^[^Xꢀ hV[Zinꢀ ^chigjXi^dchꢀ [dgꢀ ZVX]ꢀ
hZXi^dc#
5NFAMILIARITY WITH THIS MANUAL COULD RESULT
IN SERIOUS PERSONAL INJURYꢋ 3PEND A SUFꢐ
FICIENT AMOUNT OF TIME BECOMING FAMILIAR
WITH THE CONTENTS OF THIS MANUALꢆ INCLUDING
ALL THE SAFETY WARNINGSꢋ
.O LIST OF SAFETY GUIDELINES CAN BE COMꢐ
PLETEꢋ /PERATING THIS MACHINERY MAY
REQUIRE ADDITIONAL SAFETY PRECAUTIONS SPEꢐ
CIFIC TO YOUR SHOP ENVIRONMENTꢋ &AILURE TO
USE REASONABLE CAUTION WHILE OPERATING
THIS MACHINE COULD RESULT IN SERIOUS PERꢐ
SONAL INJURYꢋ
"&%"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢄꢊ #)2#5)4
2%15)2%-%.43
DcanꢀXdccZXiꢀndjgꢀbVX]^cZꢀidꢀVꢀX^gXj^iꢀi]ViꢀbZZihꢀ
ꢌꢌꢃ6 ꢑ ꢄꢄꢃ6
/PERATION
i]Zꢀ gZfj^gZbZcihꢀ WZadl#ꢀ 6alVnhꢀ X]ZX`ꢀ idꢀ hZZꢀ ^[ꢀ
i]Zꢀ l^gZhꢀ VcYꢀ X^gXj^iꢀ WgZV`Zgꢀ ^cꢀ ndjgꢀ X^gXj^iꢀ VgZꢀ
XVeVWaZꢀ d[ꢀ ]VcYa^c\ꢀ i]Zꢀ VbeZgV\Zꢀ YgVlꢀ [gdbꢀ
ndjgꢀbVX]^cZ!ꢀVhꢀlZaaꢀVhꢀVcnꢀdi]ZgꢀbVX]^cZhꢀi]Viꢀ
XdjaYꢀWZꢀdeZgVi^c\ꢀdcꢀi]ZꢀhVbZꢀX^gXj^i#ꢀ>[ꢀndjꢀVgZꢀ
jchjgZ!ꢀXdchjaiꢀVꢀfjVa^[^ZYꢀZaZXig^X^Vc#ꢀ
#IRCUIT "REAKER ,IST
%LECTROCUTION OR FIRE COULD
<%*,&!ꢀ''%KꢀH^c\aZ"E]VhZꢀ######## +%ꢀ6be!ꢀ'ꢀEdaZ
<%*(.!ꢀ''%KꢀI]gZZ"E]VhZꢀ######## )%ꢀ6be!ꢀ(ꢀEdaZ
<%*(.!ꢀ))%KꢀI]gZZ"E]VhZꢀ######## '%ꢀ6be!ꢀ(ꢀEdaZ
<%))+!ꢀ''%KꢀI]gZZ"E]VhZꢀ######## )%ꢀ6be!ꢀ(ꢀEdaZ
<%))+!ꢀ))%KꢀI]gZZ"E]VhZꢀ######## '%ꢀ6be!ꢀ(ꢀEdaZ
RESULT IF THIS MACHINE IS
INCORRECTLY GROUNDED OR
THE POWER SUPPLY DOES
NOT COMPLY WITH LOCAL
AND STATE CODESꢋ #ONTACT
A QUALIFIED ELECTRICIAN FOR
SAFE WIRING PRACTICESꢒ
I]Zꢀ[daadl^c\ꢀa^hiꢀdjia^cZhꢀi]ZꢀZaZXig^XVaꢀe]VhZꢀVcYꢀ
kdaiV\Zꢀ gZfj^gZYꢀ idꢀ deZgViZꢀ i]Zꢀ kVg^djhꢀ hVcYZgꢀ
bdYZah!ꢀ Vhꢀ lZaaꢀ Vhꢀ i]Zꢀ VbeZgV\Zꢀ YgVlꢀ d[ꢀ i]Z^gꢀ
bdidgh/
#ONNECTION 4YPE
'ꢃꢇꢁꢉˆꢌꢌꢃ6ꢆ 3INGLEꢐ0HASE ^ꢅꢃ !MP
&%ꢀ=EꢀHVcY^c\ꢀBdidgꢀ############################*%ꢀ6beh
=VgYꢀl^gZꢀi]^hꢀbVX]^cZꢀidꢀndjgꢀedlZgꢀeVcZaꢀVcYꢀ
^chiVaaꢀ Vcꢀ ZaZXig^XVaꢀ Wdmꢀ l^i]ꢀ Vꢀ adX`^c\ꢀ h]ji"d[[ꢀ
aZkZgꢀꢂ&IGURE ꢅꢃ#
&ꢀ=Eꢀ;ZZYꢀBdidgꢀ#####################################,ꢀ6beh
&
¿(ꢀ=EꢀIVWaZꢀBdidgꢀ###################################(ꢀ6beh
'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈˆꢌꢌꢃ6ꢆ 4HREEꢐ0HASE ^ꢄꢃ !MP
&*ꢀ=EꢀHe^cYaZꢀBdidgꢀ#############################(+ꢀ6beh
&ꢀ=Eꢀ;ZZYꢀBdidgꢀ##################################(#)ꢀ6beh
&
¿)ꢀ=EꢀIVWaZꢀBdidgꢀ################################&#'ꢀ6beh
'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈˆꢄꢄꢃ6ꢆ 4HREEꢐ0HASE ^ꢌꢃ !MP
&*ꢀ=EꢀHe^cYaZꢀBdidgꢀ#############################&-ꢀ6beh
&ꢀ=Eꢀ;ZZYꢀBdidgꢀ##################################&#,ꢀ6beh
&
¿)ꢀ=EꢀIVWaZꢀBdidgꢀ################################%#+ꢀ6beh
&IGURE ꢅꢋꢀAdX`^c\ꢀH]ji"D[[ꢀAZkZg#
.OTEꢊꢀ>[ꢀndjꢀYdꢀcdiꢀ]VkZꢀi]gZZ"e]VhZꢀedlZgꢀVkV^a"
VWaZꢀidꢀi]Zꢀ<%))+$<%*(.ꢀhVcYZg!ꢀndjꢀl^aaꢀ]VkZꢀ
idꢀ^chiVaaꢀVꢀe]VhZꢀXdckZgiZgꢀhjX]ꢀVhꢀi]Zꢀ<g^ooanꢀ
=(,)&ꢀE]VhZꢀ8dckZgiZg#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"&&"
Download from Www.Somanuals.com. All Manuals Search And Download.
'ROUNDING
%XTENSION #ORDS
7ZXVjhZꢀ d[ꢀ i]Zꢀ ]^\]ꢀ VbeZgV\Zꢀ YgVlꢀ [gdbꢀ i]^hꢀ
bVX]^cZ!ꢀlZꢀYdꢀcdiꢀgZXdbbZcYꢀi]ZꢀjhZꢀd[ꢀZmiZc"
h^dcꢀ XdgYh#ꢀ Jh^c\ꢀ ZmiZch^dcꢀ XdgYꢀ l^aaꢀ ^cXgZVhZꢀ
i]Zꢀ]^\]ꢀVbeZgV\ZꢀZaZXigdXji^dcꢀVcYꢀ[^gZꢀ]VoVgY#ꢀ
>chiZVY!ꢀ edh^i^dcꢀ ndjgꢀ Zfj^ebZciꢀ cZVgꢀ ^chiVaaZYꢀ
l^g^c\ꢀidꢀZa^b^cViZꢀi]ZꢀcZZYꢀ[dgꢀZmiZch^dcꢀXdgYh#
%LECTROCUTION OR A FIRE
CAN RESULT IF THE SANDER IS
NOT GROUNDED CORRECTLYꢋ
-AKE SURE ALL ELECTRICAL
CIRCUITS ARE GROUNDEDꢋ
$/ ./4 USE THE MACHINE
IF IT IS NOT GROUNDEDꢋ
>cꢀi]ZꢀZkZciꢀd[ꢀVcꢀZaZXig^XVaꢀh]dgi!ꢀ\gdjcY^c\ꢀegd"
k^YZhꢀZaZXig^XꢀXjggZciꢀVꢀeVi]ꢀd[ꢀaZVhiꢀgZh^hiVcXZꢀidꢀ
gZYjXZꢀi]Zꢀg^h`ꢀd[ꢀZaZXig^XVaꢀh]dX`ꢀidꢀi]ZꢀdeZgV"
idg#ꢀ<gdjcYꢀi]ZꢀedlZgꢀXdgYꢀVcYꢀi]^hꢀbVX]^cZꢀ^cꢀ
VXXdgYVcXZꢀl^i]ꢀVaaꢀadXVaꢀXdYZhꢀVcYꢀdgY^cVcXZh#
DeZgVi^c\ꢀ i]^hꢀ bVX]^cZꢀ l]Zcꢀ ^iꢀ ^hꢀ cdiꢀ egdeZganꢀ
\gdjcYZYꢀXVcꢀgZhjaiꢀ^cꢀZaZXig^Xꢀh]dX`ꢀdgꢀZaZXigd"
Xji^dc#ꢀꢀ
"&'"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢄꢄꢃ6 #ONNECTION
ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈ
ꢄꢋꢀ GZbdkZꢀ i]Zꢀ AG(9"((**ꢀ dkZgadVYꢀ gZaVnꢀ
ꢂ&IGURE ꢍꢃ!ꢀVcYꢀgZeaVXZꢀ^iꢀl^i]ꢀVcꢀAG(9"((''ꢀ
ꢂ&,"'*6ꢃꢀineZ!ꢀl^i]ꢀi]ZꢀY^VaꢀhZiꢀidꢀ&-6#
Idꢀ XdccZXiꢀ i]^hꢀ bVX]^cZꢀ idꢀ ))%Kꢀ i]gZZ"e]VhZ!ꢀ
ndjꢀbjhiꢀejgX]VhZꢀdcZꢀAG(9"%,+ꢀdkZgadVYꢀgZaVnꢀ
VcYꢀdcZꢀAG(9"((''ꢀdkZgadVYꢀgZaVn#
>[ꢀndjꢀYdꢀcdiꢀ]VkZꢀi]gZZ"e]VhZꢀedlZgꢀVkV^aVWaZꢀidꢀ
i]Zꢀ<%))+$<%*(.ꢀhVcYZg!ꢀndjꢀl^aaꢀ]VkZꢀidꢀ^chiVaaꢀ
Vꢀ e]VhZꢀ XdckZgiZgꢀ hjX]ꢀ Vhꢀ i]Zꢀ <g^ooanꢀ =(,)&ꢀ
E]VhZꢀ8dckZgiZg#
L]Zcꢀ jh^c\ꢀ Vꢀ e]VhZꢀ XdckZgiZg!ꢀ i]Zꢀ edlZgꢀ [gdbꢀ
i]Zꢀ bVcj[VXijgZYꢀ edlZgꢀ aZ\ꢀ ꢂhdbZi^bZhꢀ XVaaZYꢀ
i]Zꢀ l^aYꢀ l^gZꢃꢀ XVcꢀ [ajXijViZ#ꢀ 8dccZXiꢀ i]Zꢀ bVcj"
[VXijgZYꢀ edlZgꢀ aZ\ꢀ idꢀ i]Zꢀ Hꢀ iZgb^cVaꢀ idꢀ egZkZciꢀ
YVbV\Zꢀidꢀi]ZꢀigVch[dgbZg#ꢀI]Zꢀl^gZꢀ[gdbꢀi]ZꢀHꢀ
iZgb^cVaꢀXVcꢀ]VcYaZꢀhdbZꢀ[ajXijVi^dcꢀWZXVjhZꢀ^iꢀ
\dZhꢀY^gZXianꢀidꢀi]Zꢀbdidg#ꢀI]ZꢀedlZgꢀ\d^c\ꢀidꢀi]Zꢀ
Gꢀ VcYꢀ Iꢀ iZgb^cVahꢀ \dZhꢀ idꢀ i]Zꢀ igVch[dgbZgꢀ VcYꢀ
bjhiꢀWZꢀXdch^hiZciꢀidꢀegZkZciꢀYVbV\Z#
AG(9"%,+
AG(9"((''
&IGURE ꢍꢋꢀDkZgadVYꢀgZaVn#
ꢇꢋꢀ GZbdkZꢀ i]Zꢀ AG(9"%-+ꢀ dkZgadVYꢀ gZaVnꢀ
ꢂ&IGURE ꢍꢃ!ꢀVcYꢀgZeaVXZꢀ^iꢀl^i]ꢀVcꢀAG(9"%,+ꢀ
ꢂ&#+"'#*6ꢃꢀineZ!ꢀl^i]ꢀi]ZꢀY^VaꢀhZiꢀidꢀ&#,6#
4O WIRE THE -ODEL 'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈ TO ꢄꢄꢃ6ꢊ
ꢉꢋꢀ $ISCONNECT THE SANDER FROM THE POWER
ꢅꢋꢀ L^gZꢀ i]Zꢀ hVcY^c\ꢀ WZai!ꢀ XdckZndgꢀ WZai!ꢀ VcYꢀ
iVWaZꢀ ZaZkVi^dcꢀ bdidghꢀ Vhꢀ h]dlcꢀ dcꢀ i]Zꢀ
Y^V\gVbhꢀ dcꢀ i]Zꢀ ^ch^YZꢀ d[ꢀ ZVX]ꢀ bdidgꢀ l^gZꢀ
XdkZg#ꢀ
SOURCEꢒ
ꢌꢋꢀ DeZcꢀi]ZꢀZaZXig^XVaꢀWdmꢀadXViZYꢀdcꢀi]ZꢀWVX`ꢀ
d[ꢀi]ZꢀbVX]^cZ#
.OTEꢊꢀ 4HE CIRCLED REFERENCES ON THE DIAꢂ
GRAMS REPRESENT LABELS ON THE WIRESꢁ !LSOꢀ
&IGURE ꢀ BELOW HAS BEEN PROVIDED FOR YOUR
REFERENCE AND IS CURRENT AT THE TIME OF WRITꢂ
INGꢁ (OWEVERꢀ ALWAYS USE THE DIAGRAM ON THE
WIRE COVER THAT COMES WITH YOUR MOTORꢃ
ꢀꢋꢀ GZbdkZꢀ i]Zꢀ l^gZꢀ aVWZaZYꢀ ¸&¹ꢀ Viꢀ i]Zꢀ ''%Kꢀ
iZgb^cVaꢀ d[ꢀ i]Zꢀ Xdcigdaꢀ edlZgꢀ igVch[dgbZgꢀ
ꢂ&IGURE ꢁꢃꢀVcYꢀXdccZXiꢀ^iꢀidꢀi]Zꢀ))%KꢀiZgb^"
cVa#ꢀ
ꢀꢁꢂꢃꢀꢄꢅꢆꢀꢇꢈꢃꢅ
ꢅꢅꢂꢃꢉꢁꢊꢋꢀꢃꢌꢈꢃ
ꢗ
ꢅꢆꢇꢅꢈꢅꢅꢉꢊꢘꢊꢋ
ꢑꢊꢅꢔꢎꢙꢊꢋꢅꢅꢉꢊꢘꢊꢋ
ꢒ
ꢍ
ꢕꢂ
ꢕꢁ
ꢕꢄ
ꢕꢁ
ꢖꢂ
ꢖꢁ
ꢖꢄ
ꢖꢁ
ꢖꢂ
ꢔꢁ
ꢔꢂ
ꢔꢃ
ꢕꢄ
ꢔꢂ
ꢔꢁ
ꢘ
ꢌꢍꢎꢅꢅꢖꢏꢐꢆꢊꢕꢅꢅꢅꢉꢊꢘꢊꢋ
ꢎ
ꢕꢂ
ꢕꢁ
ꢕꢄ
ꢖꢂ
ꢖꢁ
ꢖꢄ
ꢔꢂ
ꢔꢁ
ꢕꢂ
ꢕꢃ
ꢔꢄ
ꢖꢃ
ꢔꢄ
ꢔꢄ
ꢖꢄ
ꢏ
ꢑꢑꢀꢔ
ꢑꢑꢀꢔ
ꢑꢑꢀꢔ
&IGURE ꢁꢋ I]Zꢀ¸&¹ꢀl^gZꢀh]djaYꢀWZꢀXdccZXiZYꢀidꢀ
&IGURE ꢈꢋ ))%Kꢀbdidgꢀl^g^c\ꢀXdccZXi^dc#
i]Zꢀ))%KꢀiZgb^cVa#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"&("
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢇꢊ 3%4 50
5NPACKING
)NVENTORY
#RATE CONTENTSꢆꢀhZZꢀ&IGURE ꢉꢃꢋ
!ꢋ
"ꢋ
#ꢋ
$ꢋ
%ꢋ
&ꢋ
'ꢋ
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
HVcY^c\ꢀJc^iꢀꢂCdiꢀE^XijgZYꢃ
ꢂ(ꢃꢀ9jhiꢀEdgihꢀ)ꢅꢀ
HVcY^c\ꢀ7Zaiꢀ&%%ꢀ<g^iꢀ
HVcY^c\ꢀ7Zaiꢀ&-%ꢀ<g^iꢀ
ꢂ'ꢃꢀEaViZcꢀ<gVe]^iZꢀ;aVeꢀ
EaViZcꢀ;Zai
4HE
-ODEL
'ꢃꢄꢄꢅꢏ
'ꢃꢇꢀꢈꢏ'ꢃꢇꢁꢉ IS A HEAVY
MACHINE WEIGHING IN AT
ONE TONꢋ 0ERSONAL INJURY
CAN OCCUR IF THE MACHINE
IS MOVED WITHOUT APPROꢐ
PRIATE MACHINERYꢋ 5SE A
CRANE OR FORKLIFT WHEN
MOVING OR LIFTING THE
MACHINEꢋ
Iddaꢀ7dm
·E]^aa^ehꢀ=ZVYꢀHXgZlYg^kZgꢀꢁ'ꢀ
·HiVcYVgYꢀHXgZlYg^kZgꢀꢁ'ꢀ
·DeZc":cYꢀLgZcX]ꢀ-$&%bbꢀ
·DeZc":cYꢀLgZcX]ꢀ&'$&)bbꢀ
·DeZc":cYꢀLgZcX]ꢀ&,$&.bbꢀ
·BZig^Xꢀ=ZmꢀLgZcX]ꢀHZiꢀ&%ꢀEXh#ꢀ
·ꢂ'ꢃꢀ9ddgꢀ@Znh
·ꢂ'ꢃꢀ8ZgVb^XꢀA^b^iꢀHl^iX]ꢀGjWꢀGdYh
·ꢂ&ꢃꢀ;aZm^WaZꢀ<gZVhZꢀ<jcꢀ:miZch^dc
·ꢂ&ꢃꢀ<gVe]^iZꢀ=daYZgꢀ7Vg
ꢀ
ꢀ
ꢀ
ꢀ
I]Zꢀ BdYZaꢀ <%))+$<%*(.$<%*,&ꢀ lVhꢀ XVgZ[jaanꢀ
eVX`ZYꢀl]Zcꢀ^iꢀaZ[iꢀdjgꢀlVgZ]djhZ#ꢀ>[ꢀndjꢀY^hXdk"
Zgꢀi]ZꢀbVX]^cZꢀ^hꢀYVbV\ZYꢀV[iZgꢀndjꢀ]VkZꢀh^\cZYꢀ
[dgꢀ YZa^kZgn!ꢀ PLEASE IMMEDIATELY CALL #USTOMER
3ERVICE AT ꢄꢅꢆꢇ ꢅꢈꢉꢂꢊꢉꢉꢋꢀFOR ADVICEꢁ
ꢀ
HVkZꢀi]ZꢀXdciV^cZghꢀVcYꢀVaaꢀeVX`^c\ꢀbViZg^Vahꢀ[dgꢀ
edhh^WaZꢀ ^cheZXi^dcꢀ Wnꢀ i]Zꢀ XVgg^Zgꢀ dgꢀ ^ihꢀ V\Zci#ꢀ
/THERWISEꢀ FILING A FREIGHT CLAIM CAN BE DIFFICULTꢁ
8
L]ZcꢀndjꢀVgZꢀXdbeaZiZanꢀhVi^h[^ZYꢀl^i]ꢀi]ZꢀXdc"
Y^i^dcꢀd[ꢀndjgꢀh]^ebZci!ꢀndjꢀh]djaYꢀ^ckZcidgnꢀi]Zꢀ
XdciZcih#
9
./4)#%
<
! PARTS DIAGRAM AND PARTS LIST ARE LOCATED
NEAR THE END OF THE MANUALꢋ 5SE THE DIAGRAM
AND LIST TO IDENTIFY MISSING PARTS OR TO SUPꢐ
PLEMENT THE ASSEMBLY INSTRUCTIONS PROVIDED
IN THIS MANUALꢋ
7
:
;
&IGURE ꢉꢃꢋ EVgihꢀaVndji#
"&)"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
(ARDWARE #HART
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"&*"
Download from Www.Somanuals.com. All Manuals Search And Download.
#LEAN 5P
3ITE #ONSIDERATIONS
6cnꢀjceV^ciZYꢀhjg[VXZhꢀVgZꢀXdViZYꢀl^i]ꢀVꢀlVmnꢀ
d^aꢀ idꢀ egdiZXiꢀ i]Zbꢀ [gdbꢀ Xdggdh^dcꢀ Yjg^c\ꢀ h]^e"
bZci#ꢀGZbdkZꢀi]^hꢀegdiZXi^kZꢀXdVi^c\ꢀl^i]ꢀVꢀhda"
kZciꢀ XaZVcZgꢀ dgꢀ X^igjh"WVhZYꢀ YZ\gZVhZgꢀ hjX]ꢀVhꢀ
<g^ooan»hꢀ<,-.*ꢀ9Z\gZVhZg#ꢀIdꢀXaZVcꢀi]dgdj\]an!ꢀ
hdbZꢀeVgihꢀbVnꢀcZZYꢀidꢀWZꢀgZbdkZY#ꢀ&OR OPTIꢐ
MUM PERFORMANCE FROM YOUR MACHINEꢆ MAKE
SURE YOU CLEAN ALL MOVING PARTS OR SLIDING
CONTACT SURFACES THAT ARE COATEDꢋꢀ 6kd^Yꢀ X]ad"
g^cZ"WVhZYꢀhdakZcihꢀVhꢀi]ZnꢀbVnꢀYVbV\ZꢀeV^ciZYꢀ
hjg[VXZhꢀh]djaYꢀi]ZnꢀXdbZꢀ^cꢀXdciVXi#
&LOOR ,OAD
I]ZꢀBdYZaꢀ<%))+$<%*(.$<%*,&ꢀ^hꢀVꢀaVg\ZꢀadVYꢀ
^cꢀVꢀbZY^jbꢀ[ddieg^ci#ꢀBdhiꢀXdbbZgX^Vaꢀdgꢀ]dbZꢀ
h]deꢀ[addghꢀh]djaYꢀWZꢀhj[[^X^ZciꢀidꢀXVggnꢀi]ZꢀlZ^\]iꢀ
d[ꢀ i]Zꢀ bVX]^cZ#ꢀ >[ꢀ ndjꢀ fjZhi^dcꢀ i]Zꢀ higZc\i]ꢀ d[ꢀ
ndjgꢀ[addg!ꢀ]VkZꢀ^iꢀ^cheZXiZYꢀWnꢀVꢀWj^aY^c\ꢀXdYZꢀ
^cheZXidg#ꢀ
7ORKING #LEARANCE
Ldg`^c\ꢀ XaZVgVcXZhꢀ XVcꢀ WZꢀ i]dj\]iꢀ d[ꢀ Vhꢀ i]Zꢀ
Y^hiVcXZhꢀWZilZZcꢀbVX]^cZhꢀVcYꢀdWhiVXaZhꢀi]Viꢀ
Vaadlꢀ hV[Zꢀ deZgVi^dcꢀ d[ꢀ ZkZgnꢀ bVX]^cZꢀ l^i]"
djiꢀ a^b^iVi^dc#ꢀ 8dch^YZgꢀ Zm^hi^c\ꢀ VcYꢀ Vci^X^eViZYꢀ
bVX]^cZꢀcZZYh!ꢀh^oZꢀd[ꢀbViZg^VaꢀidꢀWZꢀegdXZhhZYꢀ
i]gdj\]ꢀ ZVX]ꢀ bVX]^cZ!ꢀ VcYꢀ heVXZꢀ [dgꢀ Vjm^a^Vgnꢀ
hiVcYhꢀVcY$dgꢀldg`ꢀiVWaZh#ꢀ6ahd!ꢀXdch^YZgꢀi]ZꢀgZa"
Vi^kZꢀedh^i^dcꢀd[ꢀZVX]ꢀbVX]^cZꢀidꢀdcZꢀVcdi]Zgꢀ[dgꢀ
Z[[^X^ZciꢀbViZg^Vaꢀ]VcYa^c\#ꢀ7ZꢀhjgZꢀidꢀVaadlꢀndjg"
hZa[ꢀhj[[^X^ZciꢀgddbꢀidꢀhV[ZanꢀgjcꢀndjgꢀbVX]^cZhꢀ^cꢀ
Vcnꢀ[dgZhZZVWaZꢀdeZgVi^dcꢀVcYꢀ`ZZeꢀYjhiꢀXdaaZX"
i^dcꢀ]dhZhꢀd[[ꢀi]Zꢀ[addgꢀVcYꢀdjiꢀd[ꢀi]ZꢀlVn#
'ASOLINE AND PETROLEUM
PRODUCTS HAVE LOW FLASH
POINTS AND COULD EXPLODE
IF USED TO CLEAN MACHINꢐ
ERYꢋ $/./4 USEGASOLINE
OR PETROLEUM PRODUCTS TO
CLEAN THE MACHINERYꢋ
,IGHTING
A^\]i^c\ꢀ h]djaYꢀ WZꢀ Wg^\]iꢀ Zcdj\]ꢀ idꢀ Za^b^cViZꢀ
h]VYdlhꢀ VcYꢀ egZkZciꢀ ZnZꢀ higV^c#ꢀ :aZXig^XVaꢀ X^g"
Xj^ihꢀ h]djaYꢀ WZꢀ YZY^XViZYꢀ dgꢀ aVg\Zꢀ Zcdj\]ꢀ idꢀ
]VcYaZꢀ XdbW^cZYꢀ bdidgꢀ Vbeꢀ adVYh#ꢀ 7Zꢀ hjgZꢀ idꢀ
dWhZgkZꢀadXVaꢀZaZXig^XVaꢀXdYZhꢀ[dgꢀegdeZgꢀ^chiVaaV"
i^dcꢀd[ꢀcZlꢀa^\]i^c\ꢀdgꢀX^gXj^ih#
,ACK OF VENTILATION WHILE
USING SOLVENTS COULD
CAUSE SERIOUS PERSONꢐ
AL HEALTH RISKSꢆ FIREꢆ OR
ENVIRONMENTAL HAZARDSꢋ
!LWAYS WORK IN A WELL
VENTILATED AREA TO PREꢐ
VENT THE ACCUMULATION
OF DANGEROUS FUMESꢋ
3UPPLY THE WORK AREA
WITH A CONSTANT SOURCE
OF FRESH AIRꢋ
5NSUPERVISEDCHILDRENAND
VISITORS ENTERING A SHOP
COULD SUFFER SERIOUS PERꢐ
SONAL INJURYꢋ %NSURE CHILD
AND VISITOR SAFETY BY KEEPꢐ
ING ALL ENTRANCES TO THE
SHOP LOCKED AT ALL TIMESꢋ
$/ ./4 ALLOW UNSUPERꢐ
VISED CHILDREN OR VISITORS
IN THE SHOP AT ANY TIMEꢋ
"&+"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
"EGINNING !SSEMBLY
&LOOR -OUNTING
I]^hꢀ hZXi^dcꢀ l^aaꢀ XdkZgꢀ i]Zꢀ WVh^Xꢀ VhhZbWanꢀ VcYꢀ
VY_jhibZciꢀ ^chigjXi^dchꢀ cZZYZYꢀ idꢀ WZ\^cꢀ deZgV"
i^dc#ꢀ 8dbeaZiZꢀ i]Zꢀ VhhZbWanꢀ ^cꢀ i]Zꢀ dgYZgꢀ egd"
k^YZYꢀ^cꢀi]^hꢀbVcjVaꢀVcYꢀi]ZcꢀgZVYꢀi]ZꢀgZbV^c^c\ꢀ
edgi^dcꢀd[ꢀi]ZꢀbVcjVaꢀWZ[dgZꢀViiZbei^c\ꢀVcnꢀineZꢀ
d[ꢀdeZgVi^dc#
4O MOUNT THE SANDER TO THE FLOORꢊ
I]ZꢀhVcYZgꢀcZZYhꢀidꢀWZꢀbdjciZYꢀ^cꢀVꢀaZkZaꢀadXV"
i^dcꢀl]ZgZꢀ^iꢀXVcꢀWZꢀZVh^anꢀhZgk^XZYꢀ[gdbꢀVaaꢀh^YZh#ꢀ
6ahd!ꢀ Xdch^YZgꢀ i]Zꢀ aVg\Zhiꢀ ldg`e^ZXZꢀ ndjꢀ b^\]iꢀ
cZZYꢀidꢀhVcYꢀWZ[dgZꢀYZX^Y^c\ꢀdcꢀVꢀ[^cVaꢀedh^i^dc#
9OUR SAFETY IS IMPORTANTꢒ 0LEASE FOLLOW THE
WARNINGS BELOW DURING THIS ENTIRE SECTIONꢊ
Bdjciꢀ i]Zꢀ hVcYZgꢀ idꢀ lddYZcꢀ [addghꢀ l^i]ꢀ &¿'ꢅꢀ aV\ꢀ
WdaihꢀVcYꢀlVh]Zgh#ꢀBdjciꢀi]ZꢀhVcYZgꢀidꢀXdcXgZiZꢀ
[addghꢀl^i]ꢀ&¿'ꢅꢀVcX]dg"hinaZꢀWdaihꢀYZh^\cZYꢀ[dgꢀXdc"
XgZiZꢀVeea^XVi^dch#ꢀ.OTEꢊꢀ"E SURE TO CAREFULLY FOLꢂ
LOW THE ANCHOR BOLT MANUFACTURERꢌS INSTRUCTIONSꢁ
,OOSE HAIR AND CLOTHꢐ
ING COULD GET CAUGHT IN
MACHINERY AND CAUSE
SERIOUS PERSONAL INJUꢐ
RYꢋ +EEP LOOSE CLOTHING
ROLLED UP AND LONG HAIR
TIED UP AND AWAY FROM
MACHINERYꢋ
$ISCONNECT POWER TO
THE MACHINE DURING THE
ENTIRE ASSEMBLY PROꢐ
CESSꢋ &AILURE TO DO THIS
MAY RESULT IN SERIOUS
PERSONAL INJURYꢋ
3HARP EDGES ON METAL
PARTS MAY CAUSE PERꢐ
SONAL INJURYꢋ %XAMINE THE
EDGES OF ALL METAL PARTS
BEFORE HANDLINGꢋ
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"&,"
Download from Www.Somanuals.com. All Manuals Search And Download.
!IR ,INE )NSTALLATION
$UST #OLLECTION
4O INSTALL THE AIR LINEꢊ
6cꢀ Z[[^X^Zciꢀ VcYꢀ XaZVcꢀ Yjhiꢀ XdaaZXi^dcꢀ hnhiZbꢀ ^hꢀ
ZhhZci^Vaꢀ idꢀ i]Zꢀ egdeZgꢀ [jcXi^dcꢀ d[ꢀ i]Zꢀ hVcYZg#ꢀ
:chjg^c\ꢀ Vꢀ ]ZVai]nꢀ ldg`ꢀ Zck^gdcbZciꢀ ^hꢀ Vahdꢀ
YZeZcYZciꢀ jedcꢀ XaZVc^c\ꢀ VcYꢀ bV^ciV^c^c\ꢀ ndjgꢀ
YjhiꢀXdaaZXi^dcꢀhnhiZb#ꢀ;dgꢀi]^hꢀbVX]^cZꢀlZꢀgZX"
dbbZcYꢀVꢀb^c^bjbꢀd[ꢀ&'%%ꢀ8;B#ꢀ
ꢉꢋꢀ 8dccZXiꢀi]Zꢀ]dhZꢀ[gdbꢀndjgꢀV^gꢀXdbegZhhdgꢀ
idꢀi]ZꢀV^gꢀ^caZiꢀꢂ&IGURE ꢉꢉꢃꢀdcꢀi]ZꢀgZ\jaVidg#
4O HOOK UP A DUST COLLECTION SYSTEMꢊ
GZ\jaVidgꢀ
@cdW
ꢉꢋ >chiVaaꢀ i]Zꢀ i]gZZꢀ )ꢅꢀ Yjhiꢀ edgihꢀ ꢂ&IGURE ꢉꢀꢃꢀ
idꢀi]Zꢀbdjci^c\ꢀadXVi^dchꢀdcꢀi]Zꢀideꢀd[ꢀi]Zꢀ
hVcY^c\ꢀ jc^iꢀ l^i]ꢀ i]Zꢀ hjeea^ZYꢀ B+"&#%ꢀ mꢀ &%ꢀ
E]^aa^ehꢀ]ZVYꢀhXgZlh#
6^gꢀDC$D;;ꢀ
=VcYaZ
ꢂDeZcꢀEdh^i^dcꢃ
6^gꢀ>caZi
&IGURE ꢉꢉꢋ 6^gꢀ^caZiꢀadXViZYꢀdcꢀgZ\jaVidg#
ꢌꢋꢀ BV`Zꢀ hjgZꢀ i]Zꢀ gZYꢀ ]VcYaZꢀ dcꢀ i]Zꢀ gZ\jaVidgꢀ
^hꢀ^cꢀi]ZꢀdeZcꢀedh^i^dcꢀꢂeVgVaaZaꢀl^i]ꢀi]ZꢀV^gꢀ
^caZiꢃ#
ꢀꢋꢀ A^[iꢀi]ZꢀgZ\jaVidgꢀ`cdWꢀꢂ&IGURES ꢉꢉ VcY ꢉꢌꢃꢀ
VcYꢀijgcꢀ^iꢀjci^aꢀi]ZꢀV^gꢀegZhhjgZꢀ\Vj\ZꢀgZVYhꢀ
,*ꢀ EH>#ꢀ .OTEꢊꢀ 4URN THE KNOB CLOCKWISE TO
INCREASE THE AIR PRESSURE AND COUNTERCLOCKꢂ
WISE TO LOWER THE AIR PRESSUREꢁ
&IGURE ꢉꢀꢋ )ꢅꢀYjhiꢀedgih#
ꢌꢋꢀ 8aVbeꢀi]gZZꢀ)ꢅꢀ]dhZhꢀ[gdbꢀndjgꢀYjhiꢀXdaaZX"
i^dcꢀhnhiZbꢀidꢀi]ZꢀYjhiꢀedgih#
ꢄꢋꢀ Ejh]ꢀi]ZꢀgZ\jaVidgꢀ`cdWꢀYdlcꢀjci^aꢀ^iꢀhcVeh#
&IGURE ꢉꢌꢋ GZ\jaVidgꢀ`cdW#
"&-"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢄꢋꢀ GZbdkZꢀi]ZꢀheVXZgꢀWadX`ꢀꢂ&IGURE ꢉꢇꢃ#ꢀ
3ANDING "ELT
ꢇꢋꢀ >chiVaaꢀi]ZꢀhVcY^c\ꢀWZaiꢀWnꢀhiVgi^c\ꢀ[^ghiꢀdcꢀi]Zꢀ
jeeZgꢀgdaaZg!ꢀVcYꢀi]Zcꢀi]ZꢀadlZgꢀgdaaZg#ꢀ
4O INSTALL THE SANDING BELTꢊ
.OTEꢊꢀ 4HE SANDING BELT MUST BE CENTERED
BETWEEN THE LIMIT SWITCHES AND THE EDGE OF
THE SANDING BELT MUST BE BETWEEN TONGS OF
THE OSCILLATION CONTROLLER AS SHOWN IN &IGURE
ꢁꢂꢁ $AMAGE TO THE SANDING BELT COULD OCCUR
IF THE SANDER IS TURNED /. BEFORE THE SANDING
BELT IS CORRECTLY POSITIONEDꢁ
ꢉꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
ꢌꢋ 9Z"VXi^kViZꢀi]ZꢀWZaiꢀiZch^dcꢀe^hidcꢀWnꢀijgc^c\ꢀ
i]ZꢀgdaaZgꢀiZch^dcꢀhl^iX]ꢀꢂ&IGURE ꢉꢄꢃ#
DhX^aaVi^dcꢀ8dcigdaaZg
ꢂ7VX`ꢃ
HVcY^c\ꢀ7Zai
ꢂ;gdciꢃ
A^b^iꢀHl^iX]Zh
&IGURE ꢉꢄꢋ GdaaZgꢀiZch^dcꢀhl^iX]#
&IGURE ꢉꢅꢋ HVcYZgꢀDjia^cZꢀꢂIdeꢀK^Zlꢃ#ꢀEgdeZgꢀ
ꢀꢋꢀ GZbdkZꢀi]ZꢀadX`ꢀedhiꢀgZaZVhZꢀaZkZgꢀꢂ&IGURE
ꢉꢇꢃꢀWnꢀijgc^c\ꢀ^iꢀXdjciZgXadX`l^hZꢀ&¿'ꢀijgcꢀVcYꢀ
ejaa^c\ꢀ^iꢀjeꢀVcYꢀdjiꢀd[ꢀi]Zꢀbdjci^c\ꢀ]daZ#
edh^i^dcꢀd[ꢀWZaiꢀWZilZZcꢀi]Zꢀa^b^iꢀhl^iX]Zh#
./4)#%
4HE DIRECTIONAL ARROW ON THE BACK OF THE
SANDING BELT MUST BE POINTING IN A COUNꢐ
TERCLOCKWISE DIRECTION DURING INSTALLATIONꢋ
&AILURE TO INSTALL THE SANDING BELT CORRECTLY
COULD RESULT IN DAMAGE TO THE SANDING BELT
OR THE SANDER ITSELFꢋ
ꢅꢋꢀ GZeaVXZꢀi]ZꢀheVXZgꢀWadX`ꢀVcYꢀi^\]iZcꢀYdlcꢀ
i]ZꢀadX`ꢀ]VcYaZꢀWdai#
HeVXZgꢀ
7adX`
ꢁꢋꢀ L^i]ꢀ ndjgꢀ ]VcYhꢀ XaZVgꢀ d[ꢀ Vaaꢀ bdk^c\ꢀ eVgih!ꢀ
iZch^dcꢀi]ZꢀWZaiꢀWnꢀijgc^c\ꢀi]ZꢀgdaaZgꢀiZch^dcꢀ
hl^iX]#
AdX`ꢀEdhiꢀGZaZVhZꢀAZkZg
&IGURE ꢉꢇꢋ 8dbedcZcihꢀjhZYꢀl]ZcꢀX]Vc\^c\ꢀVꢀ
hVcY^c\ꢀWZai#ꢀ
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"&."
Download from Www.Somanuals.com. All Manuals Search And Download.
0RESSURE 2OLLERS
3TART 5P
I]ZꢀegZhhjgZꢀgdaaZghꢀ]VkZꢀWZZcꢀhZiꢀViꢀi]Zꢀ[VXidgn!ꢀ
Wjiꢀ[dgꢀhV[Zin!ꢀndjꢀh]djaYꢀkZg^[nꢀi]Viꢀi]ZnꢀVgZꢀhZiꢀ
WZadlꢀi]ZꢀaZkZaꢀd[ꢀi]ZꢀhVcY^c\ꢀgdaaZg#
3ERIOUS PERSONAL INJURY COULD RESULT IF THE
MACHINE IS CONNECTED TO THE POWER SOURCE
DURING ASSEMBLY OR ADJUSTMENTꢋ 7AIT UNTIL
THE MACHINE IS TURNED OFFꢆ UNPLUGGEDꢆ AND ALL
WORKING PARTS HAVE COME TO A COMPLETE STOP
BEFORE YOU ATTEMPT TO ASSEMBLE OR ADJUST THE
MACHINEꢒ
)T IS ABSOLUTELY ESSENTIAL TO KEEP THE PRESꢐ
SURE ROLLERS SET BELOW THE LEVEL OF THE SANDꢐ
ING ROLLERꢋ )F THE PRESSURE ROLLERS ARE EVENꢆ
OR HIGHER THAN THE SANDING ROLLERꢆ THE WOOD
7),, BE PROPELLED FROM THE SANDER AT A HIGH
RATE OF SPEEDꢋ 4HIS SITUATION COULD CAUSE
SERIOUS PERSONAL INJURYꢋ
,OOSE HAIR AND CLOTHꢐ
ING COULD GET CAUGHT
IN MACHINERY CAUSING
SERIOUS PERSONAL INJUꢐ
RYꢋ +EEP LOOSE CLOTHING
ROLLED UP AND LONG HAIR
TIED UP AND AWAY FROM
MACHINERYꢋ
4O CHECK THE PRESSURE ROLLER HEIGHTꢊ
ꢉꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
ꢌꢋ EaVXZꢀ Vꢀ e^ZXZꢀ d[ꢀ hXgVeꢀ lddYꢀ d[ꢀ jc^[dgbꢀ
i]^X`cZhhꢀVXgdhhꢀi]ZꢀiVWaZꢀhdꢀ^iꢀheVchꢀWdi]ꢀ
i]Zꢀ[gdciꢀVcYꢀi]ZꢀgZVgꢀegZhhjgZꢀgdaaZghꢀViꢀi]Zꢀ
hVbZꢀi^bZ#
ꢀꢋ L^i]ꢀ i]Zꢀ V^gꢀ egZhhjgZꢀ XdccZXiZYꢀ VcYꢀ i]Zꢀ
hVcY^c\ꢀWZaiꢀ^chiVaaZYꢀVcYꢀiZch^dcZY!ꢀbVcj"
VaanꢀgV^hZꢀi]ZꢀiVWaZꢀVcYꢀkZg^[nꢀi]Viꢀi]ZꢀWdVgYꢀ
idjX]ZhꢀWdi]ꢀegZhhjgZꢀgdaaZghꢀWZ[dgZꢀ^iꢀidjX]"
Zhꢀi]ZꢀhVcY^c\ꢀWZai#ꢀ
0ROJECTILES THROWN FROM
THE MACHINE COULD CAUSE
SERIOUS EYE INJURYꢋ 7EAR
SAFETY GLASSES DURING
START UPꢋ
.OTEꢊꢀ)F THE BOARD DOES NOT TOUCH BOTH PRESꢂ
SURE ROLLERS BEFORE IT TOUCHES THE SANDING
BELTꢀ THEN THE PRESSURE ROLLERS MUST BE ADJUSTꢂ
ED BEFORE OPERATIONꢁ 3EE ꢍ0RESSURE 2OLLERSꢍ
ON 0AGE ꢃꢄ FOR 3TEPꢂBYꢂ3TEP INSTRUCTIONS ON
HOW TO DO THISꢁꢀ
"EFORE STARTING THE MACHINEꢊ
ꢉꢋꢀ GZVYꢀi]^hꢀbVcjVaꢀVcYꢀbV`ZꢀhjgZꢀ ndjꢀ iV`Zꢀ
Vaaꢀ hV[Zinꢀ egZXVji^dchꢀ WZ[dgZꢀ deZgVi^c\ꢀ i]^hꢀ
bVX]^cZ#
ꢌꢋꢀ BV`ZꢀhjgZꢀi]ZꢀbVX]^cZꢀ^hꢀXdccZXiZYꢀidꢀVcꢀ
V^gꢀ XdbegZhhdgꢀ VcYꢀ i]Zꢀ egZhhjgZꢀ \Vj\Zꢀ
gZVYhꢀ,*ꢀEH>#
ꢀꢋꢀ BV`ZꢀhjgZꢀVaaꢀiddahꢀdgꢀ[dgZ^\cꢀdW_ZXihꢀ ]VkZꢀ
WZZcꢀ gZbdkZYꢀ [gdbꢀ i]Zꢀ XdckZndgꢀ hjg[VXZ!ꢀ
ideꢀ d[ꢀ i]Zꢀ bVX]^cZ!ꢀ VcYꢀ i]Zꢀ ^ch^YZꢀ d[ꢀ i]Zꢀ
bVX]^cZ#
ꢄꢋꢀ BV`ZꢀhjgZꢀVaaꢀi]Zꢀl^g^c\ꢀ^hꢀXdggZXi#
"'%"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
4O START THE MACHINEꢊ
2ECOMMENDED
!DJUSTMENTS
ꢉꢋꢀ 7EAR SAFETY GLASSES AT ALL TIMES WHEN RUNꢐ
NING THE MACHINEꢒ
ꢌꢋꢀ 8dccZXiꢀi]ZꢀbVX]^cZꢀidꢀi]ZꢀedlZgꢀhdjgXZ#ꢀ
;dgꢀ ndjgꢀ XdckZc^ZcXZ!ꢀ i]Zꢀ VY_jhibZcihꢀ a^hiZYꢀ
WZadlꢀ ]VkZꢀ WZZcꢀ eZg[dgbZYꢀ Viꢀ i]Zꢀ [VXidgnꢀ VcYꢀ
gZfj^gZꢀcdꢀ[jgi]ZgꢀVY_jhibZci#ꢀ=dlZkZg!ꢀlZꢀgZX"
dbbZcYꢀi]ViꢀndjꢀkZg^[nꢀi]Viꢀi]ZꢀVY_jhibZcihꢀVgZꢀ
XdggZXiꢀVcYꢀidꢀndjgꢀhVi^h[VXi^dc#
ꢀꢋꢀ EgZhhꢀ i]Zꢀ I67A:ꢀ JEꢀ VcYꢀ I67A:ꢀ 9DLCꢀ
`Znh#ꢀ I]Zꢀ iVWaZꢀ h]djaYꢀ \dꢀ jeꢀ VcYꢀ Ydlcꢀ
hbddi]an#
.OTEꢊꢀ -AKE SURE THE TABLE MOVES IN THE
SAME DIRECTION AS THE BUTTON DESCRIPTIONꢁ
)F NOTꢀ THEN THE POWER NEEDS TO BE DISCONꢂ
NECTED AND ANY TWO POWER WIRES NEED TO BE
SWITCHED AT THE CIRCUIT BREAKER IN THE ELECTRIꢂ
CAL BOXꢁ )F USING A PHASE CONVERTERꢀ SWITCH
THE 2 AND 4 WIRESꢁ
2ECOMMENDED ADJUSTMENT CHECKLISTꢊ
·IVWaZꢀ8Va^WgVi^dc
·;ZZYꢀ7ZaiꢀIZch^dc
·;ZZYꢀ7ZaiꢀIgVX`^c\
·6^gꢀGZ\jaVidgꢀidꢀ,*ꢀEH>
·DhX^aaVi^dcꢀI^b^c\
ꢄꢋꢀ EgZhhꢀ i]Zꢀ ;::9ꢀ 7:AIꢀ HI6GIꢀ VcYꢀ ;::9ꢀ
7:AIꢀ HIDEꢀ Wjiidch#ꢀ I]Zꢀ [ZZYꢀ WZaiꢀ h]djaYꢀ
hiVgi!ꢀgjc!ꢀVcYꢀhideꢀhbddi]an#
ꢇꢋꢀ EgZhhꢀ i]Zꢀ H6C9>C<ꢀ 7:AIꢀ HI6GIꢀ VcYꢀ
H6C9>C<ꢀ7:AIꢀHIDE Wjiidch#ꢀI]ZꢀhVcY^c\ꢀ
WZaiꢀh]djaYꢀhiVgi!ꢀgjc!ꢀVcYꢀhideꢀhbddi]an#
·DhX^aaVi^dcꢀHeZZY
·EgZhhjgZꢀGdaaZgh
I]ZꢀbVX]^cZꢀh]djaYꢀgjcꢀhbddi]an!ꢀl^i]ꢀa^iiaZꢀdgꢀcdꢀ
k^WgVi^dcꢀ dgꢀ gjWW^c\ꢀ cd^hZh#ꢀ HigVc\Zꢀ dgꢀ jccVij"
gVaꢀcd^hZhꢀh]djaYꢀWZꢀ^ckZhi^\ViZYꢀVcYꢀXdggZXiZYꢀ
WZ[dgZꢀdeZgVi^c\ꢀi]ZꢀbVX]^cZꢀ[jgi]Zg#
·IVWaZꢀEVgVaaZa^hb
·K"7Zaiꢀ6Y_jhibZci
>[ꢀ i]Zꢀ bVX]^cZꢀ hZZbhꢀ idꢀ WZꢀ gjcc^c\ꢀ XdggZXian!ꢀ
aZiꢀ^iꢀgjcꢀ[dgꢀVꢀh]dgiꢀi^bZꢀidꢀZchjgZꢀi]Viꢀi]Zꢀbdk"
^c\ꢀeVgihꢀVgZꢀldg`^c\ꢀegdeZganꢀl^i]ꢀcdꢀZmXZhh^kZꢀ
k^WgVi^dc#ꢀ9DꢀCDIꢀdeZgViZꢀi]ZꢀbVX]^cZꢀ^[ꢀegdW"
aZbhꢀXVccdiꢀWZꢀXdggZXiZY#
>[ꢀndjꢀXVccdiꢀadXViZꢀi]ZꢀhdjgXZꢀd[ꢀjcjhjVaꢀcd^hZh!ꢀ
gZ[Zgꢀidꢀ4ROUBLESHOOTING!ꢀVcYꢀ[ZZaꢀ[gZZꢀidꢀXdc"
iVXiꢀdjgꢀIZX]c^XVaꢀHjeedgiꢀ9ZeVgibZciꢀViꢀꢂ*,%ꢃꢀ
*)+".++(#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"'&"
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢅꢊ /0%2!4)/.3
/PERATION 3AFETY
#HOOSING 3ANDPAPER
I]Zꢀ\g^iꢀndjꢀX]ddhZꢀl^aaꢀYZeZcYꢀdcꢀi]ZꢀineZꢀd[ꢀ
ldg`!ꢀi]ZꢀheZX^Zhꢀd[ꢀlddYꢀVcYꢀi]ZꢀhiV\Zꢀd[ꢀ[^c^h]"
^c\#ꢀ7Zadlꢀ^hꢀVꢀX]Vgiꢀi]Viꢀ\gdjehꢀVWgVh^kZhꢀ^cidꢀ
Y^[[ZgZciꢀXViZ\dg^ZhꢀVcYꢀh]dlhꢀl]^X]ꢀ\g^ihꢀ[Vaaꢀ^cidꢀ
ZVX]"dcZ#ꢀLZꢀgZXdbbZcYꢀjh^c\ꢀVajb^cjbꢀdm^YZꢀ
hVcY^c\ꢀWZaihꢀ[dgꢀi]ZꢀWZhiꢀgZhjaih#
9OUR SAFETY IS IMPORTANTꢒ 0LEASE FOLLOW THE
WARNINGS BELOW DURING THIS ENTIRE SECTIONꢊ
4O AVOID SERIOUS PERSONAL INJURYꢆ READ AND
BECOME FAMILIAR WITH THE ENTIRE INSTRUCTION
MANUAL BEFORE USING THIS WIDE BELT SANDERꢋ
'RIT
+%
4YPE
8dVghZ
BZY^jb
;^cZ
-%"&%%
&'%"&*%
$AMAGE TO YOUR EYESꢆ LUNGSꢆ AND EARS
COULD RESULT FROM FAILURE TO WEAR SAFETY
GLASSESꢆ A DUST MASKꢆ AND HEARING PROTECꢐ
TION WHILE SANDING WITH THIS MACHINEꢋ
I]Zꢀ\ZcZgVaꢀgjaZꢀd[ꢀi]jbWꢀ^hꢀidꢀhVcYꢀVꢀldg`e^ZXZꢀ
l^i]ꢀ egd\gZhh^kZanꢀ ]^\]Zgꢀ \g^iꢀ cjbWZgh!ꢀ l^i]ꢀ cdꢀ
dcZꢀ\g^iꢀ^cXgZVhZꢀd[ꢀbdgZꢀi]Vcꢀ*%0ꢀ]dlZkZg!ꢀi]Zꢀ
ineZꢀd[ꢀlddYꢀVcYꢀYZh^gZYꢀ[^c^h]ꢀl^aaꢀYZiZgb^cZꢀi]Zꢀ
WZhiꢀ\g^iꢀidꢀjhZ#
,OOSE HAIR AND CLOTHꢐ
ING COULD GET CAUGHT IN
MACHINERY AND CAUSE
SERIOUS PERSONAL INJUꢐ
RYꢋ +EEP LOOSE CLOTHING
ROLLED UP AND LONG HAIR
TIED UP AND AWAY FROM
MACHINERYꢋ
"''"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
4ABLE -OVEMENT
!DJUSTING &EED 2ATE
IVWaZꢀ]Z^\]iꢀXVcꢀWZꢀVY_jhiZYꢀbVcjVaanꢀdgꢀl^i]ꢀi]Zꢀ
Y^\^iVaꢀ`ZnꢀeVYꢀVcYꢀbdidg!ꢀhZZꢀ&IGURE ꢉꢁꢋ
I]Zꢀ Y^Vaꢀ ViiVX]ZYꢀ idꢀ i]Zꢀ h^YZꢀ d[ꢀ i]Zꢀ [ZZYꢀ WZaiꢀ
\ZVgꢀWdmꢀꢂ&IGURE ꢉꢍꢃꢀVY_jhihꢀi]Zꢀ[ZZYꢀgViZꢀd[ꢀi]Zꢀ
hVcYZg#ꢀ
-ANUAL 4ABLE -OVEMENT·Ijgcꢀi]Zꢀ]VcYl]ZZaꢀ
adXViZYꢀjcYZgꢀi]Zꢀ[gdciꢀd[ꢀi]Zꢀ^c[ZZYꢀiVWaZꢀ[dgꢀ
bVcjVaꢀiVWaZꢀedh^i^dc^c\#ꢀ
.OTEꢊꢀ.EVER ADJUST THE FEED RATE DIAL UNLESS THE
CONVEYOR BELT IS RUNNINGꢀ OTHERWISE YOU CAN DAMꢂ
AGE THE CONTROLꢁ
-OTORIZED 4ABLE -OVEMENT·EgZhhꢀi]ZꢀI67A:ꢀ
JE dgꢀ I67A:ꢀ 9DLCꢀ `Znꢀ dcXZꢀ [dgꢀ bdidg^oZYꢀ
iVWaZꢀedh^i^dc^c\ꢀ^cꢀ%#%%*ꢅꢀꢂ%#&bbꢃꢀ^cXgZbZcih#
#HANGING &EED 2ATE·Ijgcꢀ i]Zꢀ Y^Vaꢀ XadX`l^hZꢀ
idꢀYZXgZVhZꢀi]Zꢀ[ZZYꢀgViZꢀVcYꢀXdjciZgXadX`l^hZꢀ
idꢀ^cXgZVhZꢀ^i#ꢀI]Zꢀ[ZZYꢀgViZꢀ^hꢀkVg^VWaZꢀWZilZZcꢀ
&*").ꢀ;EB#
.UMERICAL +EY 0AD·:ciZghꢀ i]Zꢀ edh^i^dcꢀ d[ꢀ
hVcY^c\ꢀYZei]ꢀY^\^iVaan#
$ETERMINING )DEAL &EED 2ATES·Hd[ilddYhꢀine^"
XVaanꢀgZfj^gZꢀVꢀ[VhiZgꢀ[ZZYꢀgViZꢀi]Vcꢀ]VgYlddYh0ꢀ
]dlZkZg!ꢀi]ZgZꢀ^hꢀcdꢀYZ[^c^i^kZꢀgjaZꢀidꢀ[daadlꢀl]Zcꢀ
YZiZgb^c^c\ꢀi]ZꢀWZhiꢀ[ZZYꢀgViZ#ꢀ6hꢀVꢀ\ZcZgVaꢀgjaZ!ꢀ
ValVnhꢀhiVgiꢀl^i]ꢀi]ZꢀhadlZhiꢀ[ZZYꢀgViZꢀVcYꢀldg`ꢀ
ndjgꢀlVnꢀje#ꢀLZꢀValVnhꢀgZXdbbZcYꢀiZhi^c\ꢀi]Zꢀ
[ZZYꢀgViZꢀjh^c\ꢀhXgVeꢀlddYꢀh^b^aVgꢀidꢀndjgꢀldg`"
e^ZXZ#ꢀ 7Zꢀ hjgZꢀ idꢀ bdc^idgꢀ i]Zꢀ VbeZgV\Zꢀ bZiZgꢀ
l]ZcꢀVY_jhi^c\ꢀi]Zꢀ[ZZYꢀgViZ#ꢀ9ZXgZVhZꢀi]Zꢀ[ZZYꢀ
gViZꢀ^[ꢀi]ZꢀadVYꢀWZ\^chꢀidꢀhadlꢀi]ZꢀbdidgꢀGEB#ꢀ
-ETRIC OR 3TANDARD +EY·EgZhhꢀ VcYꢀ ]daYꢀ i]Zꢀ
H:IꢀWjiidcꢀ[dgꢀ(ꢀhZXdcYhꢀidꢀXVa^WgViZꢀY^heaVnꢀViꢀ
i]Zꢀ XjggZciꢀ WdVgYꢀ i]^X`cZhh0ꢀ dgꢀ egZhhꢀ VcYꢀ ]daYꢀ
`Znꢀ[dgꢀ&%ꢀhZXdcYhꢀidꢀid\\aZꢀi]ZꢀY^heaVnꢀWZilZZcꢀ
bZig^XꢀVcYꢀhiVcYVgYꢀbZVhjgZbZci#
4ABLE 3TART +EY·BdkZhꢀiVWaZꢀidꢀVꢀegZhZiꢀhVcY"
^c\ꢀYZei]#
4ABLE 3TOP +EY·HidehꢀiVWaZꢀbdkZbZciꢀ^bbZ"
Y^ViZan#
$IGITAL $ISPLAY·H]dlhꢀ [^cVaꢀ iVWaZꢀ hVcY^c\ꢀ
YZei]#
;ZZYꢀ
GViZꢀ9^Va
9^\^iVaꢀ9^heaVn
BZig^Xꢀdgꢀ
HiVcYVgYꢀ@Znꢀ
CjbZg^XVaꢀ
@ZnꢀEVY
IVWaZꢀ
HiVgi
IVWaZꢀ
JE
IVWaZꢀ
Hide
&IGURE ꢉꢍꢋ ;ZZYꢀgViZꢀY^Va#
IVWaZꢀ9dlc
&IGURE ꢉꢁ#ꢀ@Znhꢀ[dgꢀVY_jhi^c\ꢀi]ZꢀiVWaZꢀ]Z^\]i#ꢀ
./4)#%
4HE THICKNESS GAUGE IS PREꢐCALIBRATED FROM
THE FACTORYꢓ HOWEVERꢆ CORRECT CALIBRATION
SHOULD BE VERIFIEDꢋ
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"'("
Download from Www.Somanuals.com. All Manuals Search And Download.
!MP $RAW -ETER
I]ZꢀVbeZgV\ZꢀYgVlꢀbZiZgꢀꢂ&IGURE ꢉꢈꢃꢀ^hꢀadXViZYꢀ
VWdkZꢀi]ZꢀXdcigdaꢀeVcZa#ꢀJhZꢀi]ZꢀbZiZgꢀidꢀbdc^idgꢀ
i]Zꢀ VbeZgV\Zꢀ YgVlꢀ dcꢀ i]Zꢀ bVX]^cZꢀ l]^aZꢀ eZg"
[dgb^c\ꢀhVcY^c\ꢀdeZgVi^dch#ꢀ
6hꢀ Vꢀ \ZcZgVaꢀ gjaZ!ꢀ ValVnhꢀ hiVgiꢀ l^i]ꢀ Vꢀ hbVaaꢀ
adVYꢀVcYꢀldg`ꢀndjgꢀlVnꢀje#ꢀ9DꢀCDIꢀldg`ꢀndjgꢀ
bVX]^cZꢀ idꢀ ^ihꢀ bVm^bjbꢀ adVYꢀ l]ZgZꢀ ndjꢀ XVcꢀ
]ZVgꢀi]ZꢀbdidgꢀadhZꢀGEB0ꢀ^chiZVY!ꢀbV`Zꢀbjai^eaZꢀ
eVhhZhꢀdgꢀ^chiVaaꢀVꢀXdVghZgꢀ\g^iꢀeVeZg#ꢀ
6beꢀadVYꢀl^aaꢀWZꢀY^gZXianꢀV[[ZXiZYꢀWnꢀbVcnꢀ[VXidghꢀ
hjX]ꢀVhꢀ[ZZYꢀgViZ!ꢀYZei]ꢀd[ꢀXji!ꢀlddYꢀineZ!ꢀhVcY"
eVeZgꢀ\g^i!ꢀVcYꢀldg`e^ZXZꢀl^Yi]#ꢀ>[ꢀi]ZꢀVbeꢀadVYꢀ^hꢀ
^cꢀi]ZꢀgZYꢀadVYꢀgVc\Z!ꢀi]ZꢀbVX]^cZꢀ^hꢀdkZgadVYZYꢀ
VcYꢀbdidgꢀYVbV\Zꢀl^aaꢀdXXjg#ꢀ@ZZeꢀi]ZꢀVbeꢀadVYꢀ
^cꢀi]Zꢀ\gZZcꢀgVc\ZꢀYjg^c\ꢀdeZgVi^dc#
&IGURE ꢉꢈꢋ 6beZgV\ZꢀbZiZg#
./4)#%
$/ ./4 6/)$ 7!22!.49ꢒ +EEP THE AMP
DRAW WITHIN THE '2%%. LOAD RANGE SHOWN
ON THE !-0 ,/!$ #(!24ꢋ )F YOU OPERATE
THE SANDER IN THE 2%$ LOAD RANGEꢆ CAPACITOR
OR MOTOR FAILURE WILL OCCUR AND WILL NOT BE
COVERED UNDER WARRANTYꢋ
"')"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
3ANDING 7ORKPIECE
0LATEN !DJUSTMENT
Ine^XVaan!ꢀcdꢀbdgZꢀi]Vcꢀ%#*bbꢀꢂVeegdm#ꢀ&¿+)ꢅꢃꢀd[ꢀ
bViZg^Vaꢀ^hꢀgZbdkZYꢀYjg^c\ꢀZVX]ꢀeVhh#ꢀ6iiZbeihꢀ
idꢀgZbdkZꢀiddꢀbjX]ꢀbViZg^VaꢀXVcꢀXVjhZꢀ_Vbb^c\!ꢀ
lddYꢀWjgc^c\!ꢀgVe^YꢀeVeZgꢀlZVgꢀdgꢀiZVg^c\!ꢀeddgꢀ
[^c^h]!ꢀh]dgiꢀbdidgꢀa^[Z!ꢀVcYꢀWZaiꢀha^eeV\Z#ꢀ
NdjgꢀhVcYZgꢀ^hꢀZfj^eeZYꢀl^i]ꢀVcꢀVY_jhiVWaZꢀ[Zaiꢀ
eaViZcꢀVcYꢀ\gVe]^iZꢀha^eꢀ[dgꢀi]dhZꢀZmigVꢀhZch^i^kZꢀ
hVcY^c\ꢀ deZgVi^dch#ꢀ I]Zꢀ eaViZcꢀ edh^i^dcꢀ Vaadlhꢀ
[dgꢀ(ꢀWVh^XꢀineZhꢀd[ꢀhVcY^c\#ꢀI]ZhZꢀY^[[ZgZciꢀedh^"
i^dchꢀXVcꢀWZꢀVY_jhiZYꢀWnꢀgdiVi^c\ꢀi]Zꢀ]Z^\]iꢀaZkZgꢀ
h]dlcꢀ^cꢀ&IGURE ꢌꢃꢋ
4HE FOLLOWING IS THE CORRECT SANDING OPERATING
PROCEDUREꢊ
=Z^\]iꢀ
AZkZg
HXVaZꢀVcYꢀ
ꢉꢋꢀ Ijgcꢀ/.ꢀi]ZꢀYjhiꢀXdaaZXidg#
Ed^ciZg
AdX`ꢀ
ꢌꢋ 7EAR SAFETY GLASSESꢆ A DUST MASKꢆ AND
HEARING PROTECTIONꢒ
AZkZg
ꢀꢋ ꢀ Dcꢀi]Zꢀ^c^i^VaꢀeVhh!ꢀhZiꢀi]ZꢀiVWaZꢀidꢀVeegdm^"
bViZanꢀ&¿)ꢅꢀ\gZViZgꢀi]Vcꢀi]Zꢀi]^X`cZhhꢀd[ꢀi]Zꢀ
ldg`e^ZXZ#ꢀ
.OTEꢊꢀ 4HIS INITIAL PASS SETTING REDUCES THE
CHANCE OF OVERLOADING THE SANDER ON UNDEꢂ
TECTED HIGH POINTS ON THE WORKPIECEꢁ
&IGURE ꢌꢃꢋ EaViZcꢀ]Z^\]iꢀXdcigdah#
4HE THREE BASIC PLATEN POSITIONSꢊ
ꢄꢋꢀ 8dci^cjZꢀidꢀgV^hZꢀi]ZꢀiVWaZꢀ&¿&+ꢅꢀWZilZZcꢀZVX]ꢀ
hjXXZhh^kZꢀ eVhhꢀ jci^aꢀ i]Zꢀ hVcYZgꢀ WZ\^chꢀ idꢀ
hVcYꢀi]Zꢀldg`e^ZXZ#
0LATEN 5Pꢀ·ꢀI]ZꢀeaViZcꢀ^hꢀgV^hZYꢀVWdkZꢀi]ZꢀaZkZaꢀ
d[ꢀ i]Zꢀ hVcY^c\ꢀ gdaaZgh#ꢀ I]^hꢀ edh^i^dcꢀ Vaadlhꢀ i]Zꢀ
[gdciꢀgdaaZgꢀidꢀgZbdkZꢀaVg\ZꢀVbdjcihꢀd[ꢀbViZg^Vaꢀ
fj^X`an!ꢀWjiꢀaZVkZhꢀVꢀgdj\]ꢀ[^c^h]#ꢀI]ZꢀWZhiꢀWZaiꢀ
\g^iꢀ[dgꢀi]^hꢀedh^i^dcꢀ^hꢀꢁ&%%ꢀdgꢀXdVghZg#
./4)#%
)T MAY BE NECESSARY TO SEND WIDE STOCK
THROUGH THE SANDER TWO OR THREE TIMES
BETWEEN TABLE HEIGHT ADJUSTMENTSꢋ 4HIS
REDUCES THE LIKELIHOOD OF BURNING THE WOOD
IF THERE IS A HIGH SPOTꢋ
0LATEN %VENꢀ·ꢀI]ZꢀeaViZcꢀ^hꢀhZiꢀZkZcꢀl^i]ꢀi]Zꢀ
hVcY^c\ꢀgdaaZgh#ꢀI]ZꢀgdaaZghꢀldg`ꢀid\Zi]Zgꢀl^i]ꢀi]Zꢀ
eaViZcꢀidꢀegdYjXZꢀ^ciZgbZY^ViZ$[^cVaꢀ[^c^h]^c\#ꢀI]Zꢀ
WZhiꢀWZaiꢀ\g^iꢀ[dgꢀi]^hꢀedh^i^dcꢀ^hꢀꢁ&%%"ꢁ&-%#
0LATEN $OWNꢀ ·ꢀ I]Zꢀ eaViZcꢀ ^hꢀ adlZgZYꢀ WZadlꢀ
i]Zꢀ hVcY^c\ꢀ gdaaZgh#ꢀ I]Zꢀ bV_dg^inꢀ d[ꢀ i]Zꢀ ldg`ꢀ
^hꢀ VXXdbea^h]ZYꢀ Wnꢀ i]Zꢀ eaViZcꢀ egZhhjgZꢀ dcꢀ i]Zꢀ
ldg`e^ZXZ#ꢀ I]Zꢀ gZhjaiꢀ ^hꢀ Vꢀ hbddi]!ꢀ [aViꢀ [^c^h]#ꢀ
I]ZꢀWZhiꢀWZaiꢀ\g^iꢀ[dgꢀi]^hꢀedh^i^dcꢀ^hꢀꢁ&-%ꢀdgꢀ[^cZg#ꢀ
6kd^YꢀAdlZg^c\ꢀi]ZꢀeaViZcꢀbdgZꢀi]Vcꢀ'BBꢀWZadlꢀ
i]ZꢀhVcY^c\ꢀWZaiꢀgdaaZgh#ꢀ
.OTEꢊꢀI]ZꢀeaViZcꢀhXVaZꢀ^hꢀWgd`ZcꢀYdlcꢀ^cꢀb^aa^bZ"
iZgꢀ^cXgZbZcih#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"'*"
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢁꢊ !##%33/2)%3
(ꢀꢁꢄꢉ ꢀꢃ (0 2OTARY 0HASE #ONVERTER
(ꢌꢍꢄꢇ #LEANING 0ADS
6YYꢀ("e]VhZ!ꢀbjai^"bdidgꢀXVeVW^a^inꢀidꢀndjgꢀh^c"
\aZ"e]VhZꢀZaZXig^XVaꢀhjeeanꢀꢂ&IGURE ꢌꢌꢃ#ꢀDeZgViZꢀ
h^c\aZꢀdgꢀbjai^eaZꢀbdidgh!ꢀigVch[dgbZgh!ꢀVcYꢀgZh^h"
iVcXZꢀadVYhꢀViꢀ&%%ꢇꢀedlZgꢀVcYꢀ.*ꢇꢀZ[[^X^ZcXnꢀ
l]^aZꢀ hVk^c\ꢀ W^\ꢀ YdaaVghꢀ Viꢀ X]ZVeanꢀ bZiZgZY!ꢀ
h^c\aZ"e]VhZꢀ ZaZXig^XVaꢀ gViZh#ꢀ 8dbeaZiZꢀ hiZeꢀ Wnꢀ
hiZeꢀ ^chigjXi^dchꢀ VgZꢀ [jgc^h]ZYꢀ Vadc\ꢀ l^i]ꢀ Xdb"
eaZiZꢀ l^gZꢀ VcYꢀ [jh^c\ꢀ gZfj^gZbZcihꢀ [dgꢀ kVg^djhꢀ
bdidgꢀ adVYh#ꢀ :VX]ꢀ bdYZaꢀ deZgViZhꢀ jeꢀ idꢀ il^XZꢀ
^ihꢀ cVbZeaViZꢀ gVi^c\ꢀ ^cꢀ Vꢀ b^mZY"bdidgꢀ adVY#ꢀ Dcꢀ
]ZVk^anꢀadVYZYꢀdgꢀ]VgY"hiVgiꢀVeea^XVi^dch!ꢀhjX]ꢀVhꢀ
]^\]"heZZYꢀ\ZVgZY"]ZVYꢀaVi]ZhꢀVcYꢀV^gꢀXdcY^i^dc"
^c\ꢀXdbegZhhdgh!ꢀi]ZꢀcVbZeaViZꢀgVi^c\ꢀd[ꢀi]ZꢀXdc"
kZgiZgꢀndjꢀX]ddhZꢀh]djaYꢀWZꢀ'ꢀidꢀ(ꢀi^bZhꢀi]Zꢀ=Eꢀ
d[ꢀi]Zꢀbdhiꢀ]ZVk^anꢀadVYZYꢀbdidg#ꢀHZZꢀi]Zꢀ^cY^k^Y"
jVaꢀ("e]VhZꢀbVX]^cZꢀeV\Zhꢀ[dgꢀe]VhZꢀXdckZgiZgꢀ
gZXdbbZcYVi^dch#ꢀ ;dgꢀ Veea^XVi^dcꢀ Vhh^hiVcXZ!ꢀ
eaZVhZꢀ XVaaꢀ djgꢀ iZX]c^XVaꢀ hjeedgiꢀ Viꢀ ꢂ*,%ꢃꢀ *)+"
.++(#
8aZVc^c\ꢀeVYhꢀVgZꢀi]ZꢀeZg[ZXiꢀVXXZhhdgnꢀ[dgꢀl^YZꢀ
WZaiꢀ hVcYZghꢀ ꢂ&IGURE ꢌꢉꢃ#ꢀ H^beanꢀ hZiꢀ i]Zꢀ Xdc"
kZndgꢀ iVWaZꢀ idꢀ ]Z^\]iꢀ VcYꢀ [ZZYꢀ i]Zꢀ eVYꢀ i]gdj\]ꢀ
idꢀ¸jcadVY¹ꢀVꢀY^ginꢀhVcY^c\ꢀWZai#ꢀGZ\jaVgꢀXaZVc^c\ꢀ
\gZVianꢀ ^cXgZVhZhꢀ i]Zꢀ a^[ZheVcꢀ d[ꢀ hVcY^c\ꢀ WZaih#ꢀ
8]ZX`ꢀl^i]ꢀi]ZꢀXjggZciꢀ<g^ooanꢀXViVad\ꢀdgꢀWWWꢋ
GRIZZLYꢋCOMꢀ[dgꢀbdgZꢀYZiV^ah#
&IGURE ꢌꢉꢋꢀHVcY^c\ꢀWZaiꢀXaZVc^c\ꢀeVY#
ꢀꢁꢂ 7IDE X ꢅꢃꢂ ,ONG 3ANDING "ELTSꢊ
I]ZhZꢀ ZmXZaaZciꢀ ¸N¹ꢀ LZ^\]iꢀ edanZhiZgꢀ WVX`^c\ꢀ
VWgVh^kZꢀ WZaihꢀ VgZꢀ Y^gZXiꢀ gZeaVXZbZcihꢀ [dgꢀ ndjgꢀ
l^YZꢀWZaiꢀhVcYZg/
'ꢁꢈꢈꢍ !LUMINUM /XIDE
'ꢁꢈꢈꢈ !LUMINUM /XIDE
'ꢍꢃꢃꢃ !LUMINUM /XIDE
'ꢍꢃꢃꢉ !LUMINUM /XIDE
'ꢍꢃꢃꢌ !LUMINUM /XIDE
ꢅꢃ 'RIT
ꢍꢃ 'RIT
ꢉꢃꢃ 'RIT
ꢉꢌꢃ 'RIT
ꢉꢇꢃ 'RIT
&IGURE ꢌꢌꢋꢀGdiVgnꢀe]VhZꢀXdckZgiZg#
"'+"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢍꢊ -!).4%.!.#%
'ENERAL
3CHEDULE
9OUR SAFETY IS IMPORTANTꢒ 0LEASE FOLLOW THE
WARNINGS BELOW DURING THIS ENTIRE SECTIONꢊ
4HE FOLLOWING ITEMS SHOULD BE CHECKED EACH
TIME THE SANDER IS USEDꢋ
ꢀ
™ꢀ AddhZꢀbdjci^c\ꢀWdaih#
™ꢀ 9VbV\ZYꢀhVcY^c\ꢀWZai#
$ISCONNECT POWER TO THE
MACHINE WHEN PERFORMꢐ
ING MAINTENANCEꢆ ASSEMꢐ
BLY OR ADJUSTMENTSꢋ
&AILURE TO DO THIS MAY
RESULT IN SERIOUS PERSONꢐ
AL INJURYꢋ
™ꢀ LdgcꢀdgꢀYVbV\ZYꢀl^gZh#
™ꢀ LViZgꢀXdaaZXi^dcꢀXjehꢀ[^aaZYꢀl^i]ꢀlViZg#ꢀꢀ
™ꢀ 6cnꢀ di]Zgꢀ XdcY^i^dcꢀ i]Viꢀ XdjaYꢀ ]VbeZgꢀ i]Zꢀ
hV[ZꢀdeZgVi^dcꢀd[ꢀi]^hꢀbVX]^cZ#
™ꢀ 9jhiꢀigVe#
,OOSE HAIR AND CLOTHꢐ
ING COULD GET CAUGHT
IN MACHINERY CAUSING
SERIOUS PERSONAL INJUꢐ
RYꢋ +EEP LOOSE CLOTHING
ROLLED UP AND LONG HAIR
TIED UP AND AWAY FROM
MACHINERYꢋ
7EEKLY
<gZVhZꢀ i]Zꢀ \gZVhZꢀ [^ii^c\hꢀ adXViZYꢀ dcꢀ i]Zꢀ [ZZYꢀ
WZaiꢀgdaaZgꢀVmaZhꢀVcYꢀi]ZꢀhVcY^c\ꢀWZaiꢀgdaaZgꢀVmaZh#ꢀ
I]ZnꢀVgZꢀ^YZci^[^ZYꢀl^i]ꢀnZaadlꢀaVWZah#
-ONTHLY
6eeanꢀVꢀ\ZcZgdjhꢀVbdjciꢀd[ꢀ\gZVhZꢀidꢀi]ZꢀiVWaZꢀ
ZaZkVi^dcꢀhXgZlh#ꢀ7ZꢀhjgZꢀidꢀgZXdkZgꢀi]ZꢀVY_jhi"
bZciꢀhXgZlhꢀl^i]ꢀi]ZꢀYjhiꢀXdkZghꢀl]Zcꢀ[^c^h]ZY#
7EAR SAFETY GLASSES DURꢐ
ING THE ENTIRE MAINTEꢐ
NANCE PROCESSꢋ &AILURE
TO COMPLY MAY RESULT IN
SERIOUS PERSONAL INJURYꢋ
GZbdkZꢀi]ZꢀadlZgꢀh^YZꢀeVcZaꢀidꢀVXXZhhꢀi]ZꢀiVWaZꢀ
a^[i^c\ꢀbZX]Vc^hb#ꢀ6eeanꢀ\gZVhZꢀidꢀi]ZꢀX]V^cꢀVcYꢀ
\ZVghꢀVhhdX^ViZYꢀl^i]ꢀi]ZꢀiVWaZꢀa^[i^c\ꢀbZX]Vc^hb#ꢀ
7ZꢀXVgZ[jaꢀidꢀcdiꢀ\Ziꢀ\gZVhZꢀdcꢀi]ZꢀK"WZaih#ꢀI]^hꢀ
XdjaYꢀXVjhZꢀi]Zbꢀidꢀha^eꢀd[[ꢀd[ꢀi]ZꢀejaaZnh#
!FTER THE &IRST ꢉꢃꢃ (OURSꢀ
I]Zꢀd^aꢀ^ch^YZꢀi]Zꢀ\ZVgꢀgZYjXZgꢀh]djaYꢀWZꢀgZeaVXZYꢀ
V[iZgꢀi]Zꢀ[^ghiꢀ&%%ꢀldg`^c\ꢀ]djghꢀd[ꢀdeZgVi^dc#ꢀLZꢀ
gZXdbbZcYꢀ.%ꢀLi#ꢀ\ZVgꢀd^a#
%VERY ꢌꢇꢃꢃ (OURS
6[iZgꢀi]Zꢀ[^ghiꢀ\ZVgꢀgZYjXZgꢀd^aꢀX]Vc\Z!ꢀgZeaVXZꢀi]Zꢀ
d^aꢀV[iZgꢀZkZgnꢀ'*%%ꢀldg`^c\ꢀ]djghꢀd[ꢀdeZgVi^dc#ꢀ
LZꢀgZXdbbZcYꢀ.%ꢀLi#ꢀ\ZVgꢀd^a#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"',"
Download from Www.Somanuals.com. All Manuals Search And Download.
3ANDING "ELTS
$UST AND 7ATER
4RAPS
Ndjꢀ XVcꢀ \gZVianꢀ ^cXgZVhZꢀ i]Zꢀ a^[ZheVcꢀ d[ꢀ ndjgꢀ
hVcY^c\ꢀ WZaihꢀ ^[ꢀ ndjꢀ XaZVcꢀ i]Zbꢀ d[iZc#ꢀ 6hꢀ bZc"
i^dcZYꢀdcꢀ0AGE ꢌꢅ!ꢀXaZVc^c\ꢀeVYhꢀVgZꢀi]Zꢀ[VhiZhiꢀ
lVnꢀidꢀgZbdkZꢀhVlꢀYjhiꢀWj^aY"je#
I]ZgZꢀVgZꢀildꢀigVehꢀdcꢀi]ZꢀBdYZaꢀ<%))+$<%*(.$
<%*,&#ꢀDcZꢀ^hꢀViiVX]ZYꢀidꢀi]ZꢀWdiidbꢀd[ꢀi]ZꢀgZ\j"
aVidgꢀꢂ&IGURE ꢌꢀꢃꢀVcYꢀi]Zꢀdi]Zgꢀ^hꢀadXViZYꢀ^ch^YZꢀ
i]Zꢀ g^\]iꢀ VXXZhhꢀ Yddgꢀ ꢂ&IGURE ꢌꢄꢃ#ꢀ :beinꢀ i]Zꢀ
igVehꢀVhꢀi]Znꢀ[^aa#ꢀI]Zꢀ^ciZgcVaꢀl]^iZꢀ[^aiZghꢀh]djaYꢀ
WZꢀgZeaVXZYꢀnZVgan#
!IR 3YSTEM
I]ZꢀV^gꢀhnhiZbꢀ^hꢀYjgVWaZꢀVcYꢀgZa^VWaZ0ꢀ]dlZkZg!ꢀ
XdbedcZcihꢀYdꢀlZVgꢀl^i]ꢀV\Z#ꢀ>[ꢀndjꢀhjheZXiꢀi]Viꢀ
Vcꢀ^iZbꢀ^cꢀndjgꢀV^gꢀhnhiZbꢀbVnꢀWZꢀ]Vk^c\ꢀegdW"
aZbh!ꢀhZZꢀi]ZꢀV^gꢀa^cZꢀX^gXj^iꢀdcꢀ0AGE ꢌ#
GZ\jaVidgꢀLViZgꢀ
IgVe
™ꢀ 8VgZ[jaanꢀ^cheZXiꢀVaaꢀV^gꢀa^cZhꢀ[dgꢀXgVX`h!ꢀiZVghꢀ
dgꢀ]VgYZc^c\#ꢀGZeaVXZꢀ[Vjainꢀ]dhZh#
™ꢀ 8]ZX`ꢀi]ZꢀV^gꢀXdccZXi^dchꢀ[dgꢀaZV`h#ꢀ6ꢀhbVaaꢀ
Vbdjciꢀ d[ꢀ hdVenꢀ lViZgꢀ ^cꢀ Vꢀ fjZhi^dcVWaZꢀ
VgZVꢀl^aaꢀWjWWaZꢀ^[ꢀi]ZgZꢀ^hꢀVꢀaZV`#
9gV^cꢀKVakZ
&IGURE ꢌꢀꢋꢀEjh]ꢀadlZgꢀ
YgV^cꢀkVakZꢀidꢀZbeinꢀi]ZꢀgZ\jaVidgꢀlViZgꢀigVe#
™ꢀ BV`Zꢀ hjgZꢀ a^cZhꢀ VgZꢀ cdiꢀ Xad\\ZY#ꢀ GZbdkZꢀ
VꢀfjZhi^dcVWaZꢀa^cZꢀVcYꢀWadlꢀi]gdj\]ꢀ^iꢀVhꢀVꢀ
iZhi#
)F A COMPONENT IN THE AIR SYSTEM IS MALFUNCꢐ
TIONINGꢆ BLEED ALL AIR FROM THE SYSTEMꢆ AND FIX
THE PROBLEM BEFORE YOU RESUME SANDINGꢋ
9jhiꢀIgVe
&IGURE ꢌꢄꢋꢀJchXgZlꢀi]ZꢀXaZVgꢀXVc^hiZgꢀidꢀZbeinꢀ
i]ZꢀV^gꢀa^cZꢀYjhiꢀigVe#
"'-"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
3%#4)/. ꢈꢊ 3%26)#%
ꢁꢋ DWhZgkZꢀi]ZꢀY^\^iVaꢀY^heaVnꢀgZVY"dji!ꢀ^iꢀh]djaYꢀ
4ABLE #ALIBRATION
^cY^XViZꢀi]ZꢀVkZgV\Zꢀi]^X`cZhhꢀd[ꢀi]ZꢀhVcYZYꢀ
lddY#ꢀ
ꢀ·>[ꢀ ^iꢀ YdZh!ꢀ i]Zꢀ hVcYZgꢀ ^hꢀ egdeZganꢀ XVa^WgViZYꢀ
VcYꢀVXXjgViZꢀidꢀi]ZꢀcZVgZhiꢀ%#%%*ꢅ#
./4)#%
4HE DIGITAL THICKNESS GAUGE HAS BEEN CALIꢐ
BRATED AT THE FACTORY AND SHOULD REQUIRE NO
FURTHER ADJUSTMENTꢋ (OWEVERꢆ WE RECOMꢐ
MEND VERIFYING ITS ACCURACYꢋ
ꢀ·>[ꢀ^iꢀYdZhcꢆi!ꢀndjꢀbjhiꢀgZXVa^WgViZꢀi]ZꢀY^\^iVaꢀ
i]^X`cZhhꢀhXVaZ#ꢀ
4O RECALIBRATE THE DIGITAL THICKNESS SCALEꢊ
JhZꢀi]Zꢀ[^ghiꢀWdVgYꢀ[ZYꢀi]gdj\]ꢀi]ZꢀhVcYZgꢀidꢀiZhiꢀ
i]ZꢀVXXjgVXnꢀd[ꢀi]ZꢀY^\^iVaꢀi]^X`cZhhꢀ\Vj\Z#ꢀ
ꢉꢋꢀ L^i]djiꢀ bdk^c\ꢀ i]Zꢀ iVWaZꢀ ]Z^\]i!ꢀ ZciZgꢀ i]Zꢀ
cjbZg^XVaꢀbZVhjgZbZciꢀd[ꢀi]ZꢀVkZgV\Zꢀi]^X`"
cZhhꢀd[ꢀi]ZꢀhVcYZYꢀlddYꢀ^cidꢀi]ZꢀY^\^iVaꢀ`Znꢀ
eVYꢀdcꢀi]ZꢀXdcigdaꢀeVcZa#ꢀ
4O CALIBRATE THE DIGITAL THICKNESS SCALEꢊ
ꢉꢋꢀ Jh^c\ꢀVꢀegdeZganꢀhZi"jeꢀeaVcZg!ꢀeaVcZꢀVꢀWdVgYꢀ
.OTEꢊꢀI]ZꢀVkZgV\Zꢀi]^X`cZhhꢀd[ꢀi]ZꢀhVcYZYꢀ
lddYꢀh]djaYꢀcdlꢀWZꢀ[aVh]^c\ꢀdcꢀi]ZꢀY^\^iVaꢀ
gZVY"dji#
idꢀjc^[dgbꢀi]^X`cZhh#ꢀꢀꢀ
ꢌꢋ AdlZgꢀi]ZꢀhVcYZgꢀiVWaZꢀ[VgꢀZcdj\]ꢀidꢀeaVXZꢀ
i]ZꢀeaVcZYꢀWdVgYꢀjcYZgꢀi]ZꢀhVcYZgꢀgdaaZg#
ꢌꢋꢀ EgZhhꢀVcYꢀ]daYꢀi]Zꢀꢀ`Znꢀjci^aꢀi]ZꢀY^heaVnꢀ
hidehꢀ[aVh]^c\#ꢀI]ZꢀhVcYZgꢀ^hꢀcdlꢀXdggZXianꢀ
XVa^WgViZY#ꢀ
ꢀꢋꢀ BVcjVaanꢀgV^hZꢀi]ZꢀiVWaZꢀjci^aꢀi]ZꢀWdVgYꢀ_jhiꢀ
idjX]Zhꢀi]ZꢀhVcY^c\ꢀgdaaZg#ꢀ
ꢄꢋꢀ GZbdkZꢀ i]Zꢀ WdVgYꢀ l^i]djiꢀ X]Vc\^c\ꢀ i]Zꢀ
iVWaZꢀ ]Z^\]i#ꢀ I]^hꢀ ZchjgZhꢀ i]Zꢀ iVWaZꢀ l^aaꢀ WZꢀ
egdeZganꢀVY_jhiZYꢀ[dgꢀi]Zꢀ[^ghiꢀhVcY^c\ꢀeVhh#
ꢇꢋꢀ Gjcꢀ i]Zꢀ WdVgYꢀ i]gdj\]ꢀ i]Zꢀ hVcYZgꢀ hZkZgVaꢀ
i^bZhꢀ Viꢀ i]Zꢀ ^c^i^Vaꢀ ]Z^\]iꢀ hZii^c\#ꢀ BVcjVaanꢀ
gV^hZꢀ i]Zꢀ iVWaZꢀ %#%'%ꢅꢀ VcYꢀ eVhhꢀ i]Zꢀ WdVgYꢀ
i]gdj\]ꢀ i]Zꢀ hVcYZgꢀ hZkZgVaꢀ bdgZꢀ i^bZh#ꢀ
Bdc^idgꢀi]ZꢀVbeZgV\ZꢀbZiZgꢀVcYꢀi]ZꢀgZhjai"
^c\ꢀadVYꢀdcꢀi]ZꢀhVcYZg#
ꢅꢋꢀ BZVhjgZꢀ i]Zꢀ i]^X`cZhhꢀ Viꢀ kVg^djhꢀ ed^cihꢀ
VgdjcYꢀ i]Zꢀ WdVgYꢀ jh^c\ꢀ Vꢀ egZX^hZꢀ b^Xgdb"
ZiZgꢀdgꢀhZiꢀd[ꢀXVa^eZgh#ꢀ8dci^cjZꢀhVcY^c\ꢀi]Zꢀ
WdVgYꢀViꢀi]Viꢀ]Z^\]iꢀjci^aꢀi]ZꢀVkZgV\Zꢀi]^X`"
cZhhꢀbZVhjgZbZciꢀ^hꢀl^i]^cꢀ ¿"%#%%(ꢅ#ꢀꢀ
ꢀꢀ
.OTEꢊꢀ I]ZhZꢀ [^cVaꢀ eVhhZhꢀ h]djaYꢀ WZꢀ YdcZꢀ
l^i]djiꢀ VY_jhi^c\ꢀ i]Zꢀ iVWaZꢀ ]Z^\]i#ꢀ I]^hꢀ
ZchjgZhꢀ i]Zꢀ bdhiꢀ Xdch^hiZciꢀ VkZgV\Zꢀ i]^X`"
cZhh#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"'."
Download from Www.Somanuals.com. All Manuals Search And Download.
4O REPLACE THE BRAKE PADSꢊ
"RAKE 3ERVICE
ꢉꢋꢀ $ISCONNECT THE SANDER FROM THE POWER
SOURCE AND REMOVE AIR PRESSURE COMꢐ
PLETELYꢒ
4OOLS .EEDEDꢊ
1TY
&)bbꢀDeZcꢀ:cYꢀLgZcX]ꢀ################################## &
HbVaaꢀHcVeꢀG^c\ꢀEa^Zghꢀ##################################### &
+bbꢀ=ZmꢀLgZcX]ꢀ############################################## &
ꢁ'ꢀE]^aa^ehꢀHXgZlYg^kZgꢀꢀ##################################### &
ꢌꢋꢀ GZbdkZꢀ i]Zꢀ cjihꢀ [gdbꢀ i]Zꢀ ildꢀ bdjci^c\ꢀ
WdaihꢀVcYꢀi]ZꢀildꢀhcVeꢀg^c\hꢀdcꢀi]Zꢀbdjci^c\ꢀ
e^chꢀWZ]^cYꢀi]ZꢀWgVX`Zi#ꢀ
:kZcijVaanꢀi]ZꢀWgV`ZꢀeVYhꢀl^aaꢀlZVgꢀdji#ꢀ8]ZX`^c\ꢀ
VcYꢀgZeaVX^c\ꢀi]ZhZꢀ^hꢀVꢀh^beaZꢀegd_ZXiꢀi]ViꢀXVcꢀ
WZꢀYdcZꢀ^cꢀi]Zꢀh]de!ꢀl^i]ꢀi]ZꢀZmXZei^dcꢀd[ꢀ]Vk^c\ꢀ
i]ZꢀgdidgꢀgZhjg[VXZYꢀdcꢀVꢀaVi]Z#ꢀ
ꢀꢋꢀ Ejaaꢀ i]Zꢀ bdjci^c\ꢀ e^chꢀ djiꢀ d[ꢀ i]Zꢀ XVa^eZgꢀ
WgVX`Ziꢀ VcYꢀ gZbdkZꢀ i]Zꢀ V^gꢀ a^cZꢀ [gdbꢀ i]Zꢀ
XVa^eZg#ꢀI]ZꢀXVa^eZgꢀh]djaYꢀcdlꢀWZꢀVWaZꢀidꢀWZꢀ
gZbdkZY#
4O CHECK THE BRAKE PADSꢊ
ꢄꢋꢀ 9^hVhhZbWaZꢀ i]Zꢀ WgZV`ꢀ XVa^eZgꢀ VcYꢀ gZbdkZꢀ
i]ZꢀXVeꢀhXgZlhꢀhZXjg^c\ꢀi]ZꢀWgV`ZꢀeVYh#
ꢉꢋꢀ $ISCONNECT THE SANDER FROM THE POWER
SOURCE AND REMOVE AIR PRESSURE COMꢐ
PLETELYꢒ
ꢇꢋꢀ GZbdkZꢀi]ZꢀWgV`ZꢀgdidgꢀVcYꢀ]VkZꢀ^iꢀegd[Zh"
h^dcVaanꢀgZhjg[VXZYꢀViꢀVcꢀVjidbdi^kZꢀbVX]^cZꢀ
h]deꢀ^[ꢀ^iꢀ]Vhꢀ\dj\Zhꢀ^cꢀ^i#ꢀ>[ꢀk^h^WaZꢀXgVX`hꢀVgZꢀ
egZhZciꢀ^cꢀi]ZꢀWgV`Zꢀgdidg!ꢀgZeaVXZꢀ^iꢀl^i]ꢀVꢀ
cZlꢀdcZ#ꢀGZbdkZꢀd^aꢀVcYꢀY^giꢀ[gdbꢀi]Zꢀgdidgꢀ
l^i]ꢀVjidbdi^kZꢀWgV`ZꢀXaZVcZg#ꢀDcXZꢀXaZVc!ꢀ
dcanꢀ ]VcYaZꢀ i]Zꢀ gdidgꢀ l^i]ꢀ Vꢀ Ygnꢀ gV\ꢀ VcYꢀ
^chiVaaꢀZmVXianꢀi]ZꢀgZkZghZꢀd[ꢀgZbdkVa#
ꢌꢋꢀ GZbdkZꢀ i]Zꢀ [djgꢀ hXgZlhꢀ i]Viꢀ hZXjgZꢀ i]Zꢀ
VXXZhhꢀ eVcZaꢀ dcꢀ i]Zꢀ g^\]i"]VcYꢀ h^YZꢀ d[ꢀ i]Zꢀ
bVX]^cZ#
ꢀꢋꢀ I]ZꢀWgV`ZꢀXVa^eZgꢀ^hꢀadXViZYꢀjcYZgcZVi]ꢀi]Zꢀ
gdidgꢀ^cꢀ&IGURE ꢌꢇ!ꢀl]^X]ꢀ^hꢀViiVX]ZYꢀidꢀi]Zꢀ
bdidgꢀVgWdg#
ꢅꢋꢀ >chiVaaꢀ cZlꢀ WgV`Zꢀ eVYh!ꢀ bdjciꢀ i]Zꢀ XVa^eZgꢀ
VcYꢀgZXdccZXiꢀi]ZꢀV^gꢀa^cZ#ꢀ
ꢁꢋꢀ IZhiꢀi]ZꢀhV[Zinꢀh]jiYdlcꢀdeZgVi^dcꢀWnꢀgjc"
c^c\ꢀi]ZꢀhVcYZgꢀVcYꢀegZhh^c\ꢀi]ZꢀZbZg\ZcXnꢀ
hideꢀXdcigdah#
8Va^eZg
&IGURE ꢌꢇꢋꢀ9^hXꢀWgV`Z#
ꢄꢋꢀ I]ZꢀWgV`ZꢀeVYhꢀXdch^hiꢀd[ꢀVꢀbZiVaꢀeaViZꢀl^i]ꢀ
VꢀXdbedh^iZꢀeVY#ꢀL^i]ꢀVꢀ[^cZꢀgjaZg!ꢀbZVhjgZꢀ
i]Zꢀ i]^X`cZhhꢀ d[ꢀ i]Zꢀ Xdbedh^iZꢀ eVYꢀ dcan#ꢀ >[ꢀ
dcZꢀd[ꢀi]ZꢀeVYhꢀ^hꢀWZadlꢀ&¿-ꢅꢀꢂVeegdm#ꢀ(bbꢃ!ꢀ
gZeaVXZꢀWdi]#ꢀꢀ
"(%"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
&EED "ELT 4ENSION
&EED "ELT 4RACKING
4OOLS .EEDEDꢊ
1TY
4OOLS .EEDEDꢊ
1TY
'%bbꢀLgZcX]ꢀdgꢀHdX`Ziꢀ####################################&
+bbꢀ=ZmꢀLgZcX]ꢀ###############################################&
ꢁ'ꢀE]^aa^ehꢀHXgZlYg^kZgꢀ#######################################&
4O ADJUST THE FEED BELT TENSIONꢊ
./4)#%
!DJUST THE FEED BELT TENSION BEFORE ADJUSTING
THE FEED BELT TRACKINGꢋ
ꢉꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
ꢀꢀ
4O ADJUST THE FEED BELT TRACKINGꢊ
ꢌꢋꢀ ;^cYꢀi]ZꢀVY_jhibZciꢀedgihꢀ^cꢀi]ZꢀhV[Zinꢀ\jVgYꢀ
ꢂ&IGURE ꢌꢅꢃꢀ Viꢀ i]Zꢀ [gdciꢀ ZcYꢀ d[ꢀ i]Zꢀ [ZZYꢀ
iVWaZ#
ꢉꢋ Ijgcꢀi]Zꢀ[ZZYꢀWZaiꢀ/.#ꢀ
ꢌꢋ >[ꢀi]Zꢀ[ZZYꢀWZaiꢀ^hꢀigVX`^c\ꢀidꢀi]ZꢀRIGHTꢀh^YZꢀ
d[ꢀ i]Zꢀ iVWaZ!ꢀ ijgcꢀ i]Zꢀ RIGHTꢀ VY_jhibZciꢀ Wdaiꢀ
ꢂ&IGURE ꢌꢅꢃꢀXadX`l^hZ#
ꢀꢋꢀ Ijgcꢀ Wdi]ꢀ aZ[iꢀ VcYꢀ g^\]iꢀ VY_jhibZciꢀ Wdaihꢀ
ꢂ&IGURE ꢌꢅꢃꢀ XadX`l^hZꢀ ZfjVaanꢀ idꢀ ^cXgZVhZꢀ
iZch^dc#
ꢀꢋ >[ꢀi]Zꢀ[ZZYꢀWZaiꢀ^hꢀigVX`^c\ꢀidꢀi]ZꢀLEFTꢀh^YZꢀd[ꢀ
i]ZꢀiVWaZ!ꢀijgcꢀi]ZꢀLEFTꢀVY_jhibZciꢀWdaiꢀXadX`"
l^hZ#
HV[Zinꢀ<jVgY
6Y_jhibZciꢀEdgi
.OTEꢊꢀ4HE EDGE OF THE FEED BELT SHOULD JUST
TOUCH THE GUIDE WHEELS AS SHOWN IN &IGURE
ꢅꢆꢁ
6Y_jhibZciꢀ
7dai
6Y_jhibZciꢀ7dai
;ZZYꢀ7Zai
<j^YZꢀL]ZZa
&IGURE ꢌꢅꢋ ;ZZYꢀWZaiꢀiZch^dcꢀVY_jhibZciꢀWdaih#
.OTEꢊꢀHV[Zinꢀ\jVgYꢀgZbdkZYꢀ[dgꢀXaVg^in#
ꢄꢋꢀ L]ZcꢀiZch^dcZYꢀegdeZganꢀndjꢀh]djaYꢀcdiꢀWZꢀ
VWaZꢀidꢀa^[iꢀi]Zꢀ[ZZYꢀWZaiꢀd[[ꢀi]ZꢀiVWaZꢀhjg[VXZꢀ
dgꢀha^YZꢀ^iꢀWVX`ꢀVcYꢀ[dgi]#
&IGURE ꢌꢁꢋ <j^YZꢀl]ZZah#
$/./4SANDBOARDSWITHTHEGUARDREMOVEDꢋ
&AILURE TO FOLLOW THIS WARNING COULD RESULT IN
SERIOUS PERSONAL INJURYꢋ
ꢄꢋ Gjcꢀi]Zꢀ[ZZYꢀWZaiꢀ[dgꢀ("*ꢀb^cjiZhꢀVcYꢀgZX]ZX`ꢀ
i]ZꢀigVX`^c\#
ꢇꢋ >[ꢀ i]Zꢀ WZaiꢀ ^hꢀ hi^aaꢀ igVX`^c\ꢀ XdggZXian!ꢀ gZeaVXZꢀ
i]Zꢀ hV[Zinꢀ XdkZgꢀ gZbdkZYꢀ ^cꢀ i]Zꢀ egZk^djhꢀ
hjWhZXi^dc#ꢀ
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"(&"
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢀꢋꢀ 6cꢀ VYZfjViZꢀ higZVbꢀ d[ꢀ V^gꢀ i]gdj\]ꢀ i]Zꢀ V^gꢀ
[dg`ꢀꢀ\Veꢀꢂ&IGURE ꢌꢈꢃꢀ^hꢀZhhZci^Vaꢀ[dgꢀegdeZgꢀ
dhX^aaVi^dc#ꢀ >[ꢀ i]Zꢀ _Ziꢀ d[ꢀ V^gꢀ ^hꢀ lZV`ꢀ i]gdj\]ꢀ
i]Zꢀ \Ve!ꢀ i]Zꢀ WZaiꢀ l^aaꢀ igVX`ꢀ VlVnꢀ [gdbꢀ i]Zꢀ
XdcigdaaZgꢀ VcYꢀ ^cidꢀ i]Zꢀ a^b^iꢀ hl^iX]ꢀ dcꢀ i]Zꢀ
deedh^iZꢀZcYꢀd[ꢀi]ZꢀgdaaZg#ꢀI]Zꢀe^kdiꢀVXi^dcꢀd[ꢀ
i]ZꢀjeeZgꢀgdaaZg!ꢀVcYꢀi]ZꢀgZhjai^c\ꢀdhX^aaVi^dcꢀ
d[ꢀ i]Zꢀ WZai!ꢀ VgZꢀ YZeZcYZciꢀ jedcꢀ VYZfjViZꢀ
V^g[adlꢀi]gdj\]ꢀi]ZꢀV^gꢀ[dg`ꢀ\Ve#ꢀ
/SCILLATION 4IMING
./4)#%
4HE OSCILLATION ADJUSTMENTS HAVE BEEN PERꢐ
FORMED AT THE FACTORY AND SHOULD REQUIRE NO
FURTHER ATTENTIONꢋ (OWEVERꢆ WE RECOMMEND
VERIFYING THE SETTINGSꢋ
DhX^aaVi^dcꢀ8dcigdaaZgꢀ<Ve
L]Zcꢀ i]Zꢀ dhX^aaVi^dcꢀ ^hꢀ XdggZXianꢀ VY_jhiZY!ꢀ i]Zꢀ
hVcY^c\ꢀWZaiꢀdhX^aaViZhꢀidꢀi]ZꢀaZ[iꢀVcYꢀidꢀi]Zꢀg^\]iꢀ
Viꢀ i]Zꢀ hVbZꢀ heZZY#ꢀ >[ꢀ i]Zꢀ hVcY^c\ꢀ WZaiꢀ bV`Zhꢀ
XdciVXiꢀl^i]ꢀVꢀa^b^iꢀhl^iX]!ꢀVhꢀh]dlcꢀ^cꢀ&IGURE ꢌꢍ!ꢀ
i]ZꢀZbZg\ZcXnꢀWgV`^c\ꢀhnhiZbꢀl^aaꢀVXi^kViZꢀVcYꢀ
hideꢀi]ZꢀhVcYZgꢀ^bbZY^ViZan#
A^b^iꢀ
Hl^iX]Zh
6^gꢀ;dg`ꢀVcYꢀ6^gꢀ?Zi
&IGURE ꢌꢈꢋ DhX^aaVi^dcꢀXdbedcZcih#
4O SET THE CORRECT AMOUNT OF AIRFLOW THROUGH
THE AIR FORK GAPꢊ
HVcY^c\ꢀ7Zai
ꢉꢋꢀ GZbdkZꢀi]ZꢀhVcY^c\ꢀWZaiꢀVcYꢀijgcꢀi]ZꢀgdaaZgꢀ
HVcYZgꢀDjia^cZ
ꢂIdeꢀK^Zlꢃꢀ
iZch^dcꢀhl^iX]ꢀidꢀi]ZꢀiZch^dcZYꢀedh^i^dc#ꢀ
ꢌꢋꢀ AddhZcꢀi]ZꢀadX`ꢀcjiꢀdcꢀi]ZꢀV^g[adlꢀVY_jhibZciꢀ
`cdWꢀꢂ&IGURE ꢀꢃꢃ#
&IGURE ꢌꢍꢋ >begdeZgꢀdhX^aaVi^dc#
ꢀꢋꢀ Ijgcꢀi]ZꢀV^g[adlꢀVY_jhibZciꢀ`cdWꢀXadX`l^hZꢀ
jci^aꢀi]ZꢀV^g[adlꢀ^hꢀXdbeaZiZanꢀd[[ꢁ I]ZꢀjeeZgꢀ
gdaaZgꢀh]djaYꢀe^kdiꢀidꢀi]Zꢀg^\]i#
4O CHECK THE SANDING BELT OSCILLATIONꢊ
ꢉꢋ 7ZꢀhjgZꢀi]ZꢀhVcY^c\ꢀWZaiꢀ^hꢀegdeZganꢀ^chiVaaZYꢀ
VcYꢀi]ZꢀgdaaZgꢀiZch^dcꢀhl^iX]ꢀVcYꢀV^gꢀhjeeanꢀ^hꢀ
/.#ꢀ
ꢄꢋꢀ Hadlanꢀ ijgcꢀ i]Zꢀ V^g[adlꢀ VY_jhibZciꢀ `cdWꢀ
XdjciZgXadX`l^hZ!ꢀ VcYꢀ Xdci^cjZꢀ ijgc^c\ꢀ jeꢀ
i]ZꢀV^gꢀegZhhjgZꢀjci^aꢀi]ZꢀgdaaZgꢀe^kdihꢀidꢀi]Zꢀ
aZ[i#ꢀ
ꢌꢋ Ijgcꢀ/.ꢀi]ZꢀhVcY^c\ꢀWZai#ꢀ
ꢀ·>[ꢀ i]Zꢀ WZaiꢀ dhX^aaViZhꢀ l^i]djiꢀ XdciVXi^c\ꢀ i]Zꢀ
a^b^iꢀhl^iX]Zh!ꢀWjiꢀi]ZꢀdhX^aaVi^dcꢀi^bZꢀidꢀi]Zꢀ
aZ[iꢀVcYꢀg^\]iꢀVgZꢀ./4 ZfjVa!ꢀegdXZZYꢀidꢀ3TEP
ꢇꢆ 0AGE ꢀꢀ#ꢀ
ꢀ·>[ꢀi]ZꢀWZaiꢀigVX`hꢀVlVnꢀ[gdbꢀi]ZꢀV^gꢀ[dg`ꢀVcYꢀ
V^gꢀ_Zi!ꢀXdaa^Y^c\ꢀ^cidꢀi]Zꢀa^b^iꢀhl^iX]!ꢀXdci^cjZꢀ
l^i]ꢀ3TEP ꢀ#
"('"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢁꢋꢀ IZhiꢀ i]Zꢀ dhX^aaVi^dcꢀ Wnꢀ gjcc^c\ꢀ i]Zꢀ hVcYZg#ꢀ
BV`ZꢀcdiZꢀd[ꢀi]Zꢀi^bZꢀ^iꢀiV`Zhꢀ[dgꢀi]ZꢀWZaiꢀidꢀ
dhX^aaViZꢀ [gdbꢀ aZ[i"id"g^\]iꢀ VcYꢀ [gdbꢀ g^\]i"id"
ꢇꢋꢀ I^\]iZcꢀ i]Zꢀ adX`ꢀ cjiꢀ ꢂ&IGURE ꢀꢃꢃ idꢀ hZXjgZꢀ
i]ZꢀV^g[adlꢀVY_jhibZciꢀ`cdW#ꢀ
aZ[i#
ꢀ
ꢀ
ꢀ
L]ZcꢀXdggZXianꢀi^bZY!ꢀi]ZꢀdhX^aaVi^dcꢀh]djaYꢀ
iV`ZꢀVꢀh^b^aVgꢀVbdjciꢀd[ꢀi^bZꢀidꢀdhX^aaViZ#
AdX`ꢀCji
ˆ>[ꢀ i]Zꢀ dhX^aaVi^dcꢀ i^bZꢀ idꢀ i]Zꢀ RIGHTꢀ ^hꢀ 'ꢀ hZX"
dcYh!ꢀ Wjiꢀ i]Zꢀ dhX^aaVi^dcꢀ i^bZꢀ idꢀ i]Zꢀ LEFTꢀ ^hꢀ
adc\Zg!ꢀ addhZcꢀ i]Zꢀ dhX^aaVi^dcꢀ VY_jhibZciꢀ
`cdWꢀꢂ&IGURE ꢀꢉꢃ VcYꢀbdkZꢀ^iꢀidꢀi]ZꢀLEFTꢀjci^aꢀ
egdeZgꢀ igVX`^c\ꢀ ^hꢀ VX]^ZkZY#ꢀ I^\]iZcꢀ Ydlcꢀ
i]Zꢀ dhX^aaVi^dcꢀ VY_jhibZciꢀ `cdWꢀ l]Zcꢀ hVi^h"
[^ZY#
&IGURE ꢀꢃꢋ 6^g[adlꢀVY_jhibZciꢀ`cdW#
ꢅꢋꢀ GZhig^Xiꢀ i]Zꢀ V^g[adlꢀ VXgdhhꢀ i]Zꢀ V^gꢀ [dg`ꢀ \Veꢀ
l^i]ꢀ Vꢀ hXgVeꢀ e^ZXZꢀ d[ꢀ lddY#ꢀ Ndjꢀ h]djaYꢀ
cdi^XZꢀi]ZꢀgdaaZgꢀe^kdiꢀidꢀi]Zꢀg^\]i#ꢀL]Zcꢀi]Zꢀ
hi^X`ꢀ^hꢀgZbdkZY!ꢀi]ZꢀgdaaZgꢀh]djaYꢀe^kdiꢀWVX`ꢀ
idꢀi]ZꢀaZ[i#ꢀꢀ
&IGURE ꢀꢉꢋ DhX^aaVi^dcꢀVY_jhibZciꢀ`cdW#
ˆ>[ꢀi]ZꢀdhX^aaVi^dcꢀi^bZꢀidꢀi]ZꢀLEFTꢀ^hꢀ'ꢀhZXdcYh!ꢀ
Wjiꢀi]ZꢀdhX^aaVi^dcꢀi^bZꢀidꢀi]ZꢀRIGHTꢀ^hꢀadc\Zg!ꢀ
addhZcꢀ i]Zꢀ dhX^aaVi^dcꢀ VY_jhibZciꢀ `cdWꢀ VcYꢀ
bdkZꢀ ^iꢀ idꢀ i]Zꢀ RIGHTꢀ jci^aꢀ egdeZgꢀ igVX`^c\ꢀ
^hꢀ VX]^ZkZY#ꢀ I^\]iZcꢀ Ydlcꢀ i]Zꢀ dhX^aaVi^dcꢀ
VY_jhibZciꢀ`cdWꢀl]ZcꢀhVi^h[^ZY#
ꢍꢋꢀ 8dci^cjZꢀidꢀi]ZꢀcZmiꢀeV\ZꢀidꢀVY_jhiꢀi]ZꢀdhX^a"
aVi^dcꢀheZZY#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"(("
Download from Www.Somanuals.com. All Manuals Search And Download.
/SCILLATION 3PEED
4ABLE 0ARALLELISM
I]Zꢀ dhX^aaVi^dcꢀ heZZYꢀ d[ꢀ i]Zꢀ hVcY^c\ꢀ WZaiꢀ ^hꢀ
VY_jhiVWaZ#ꢀ9^[[ZgZciꢀdhX^aaVi^c\ꢀheZZYhꢀn^ZaYꢀY^["
[ZgZciꢀ hVcY^c\ꢀ gZhjaih#ꢀ LZꢀ gZXdbbZcYꢀ ign^c\ꢀ
kVg^djhꢀheZZYhꢀdcꢀVꢀhXgVeꢀe^ZXZꢀd[ꢀlddYꢀh^b^aVgꢀ
idꢀi]Zꢀ[^cVaꢀldg`e^ZXZ#ꢀ
./4)#%
4HE TABLE HAS BEEN ADJUSTED AT THE FACꢐ
TORY AND SHOULD REQUIRE NO FURTHER ATTENTIONꢋ
(OWEVERꢆ WE RECOMMEND VERIFYING ITS PARALꢐ
LELISM WITH THE SANDING ROLLERꢋ
4O ADJUST THE OSCILLATION SPEEDꢊ
I]Zꢀ XdgcZghꢀ d[ꢀ i]Zꢀ iVWaZꢀ XVcꢀ WZꢀ ^cYZeZcYZcianꢀ
VY_jhiZYꢀjeꢀdgꢀYdlc#ꢀ7nꢀY^hXdccZXi^c\ꢀi]ZꢀX]V^cꢀ
VcYꢀ ijgc^c\ꢀ i]Zꢀ eZgi^cZciꢀ iVWaZꢀ ZaZkVi^dcꢀ hXgZlꢀ
hegdX`Zi!ꢀ ꢂ&IGURE ꢀꢀꢃꢀ iVWaZꢀ eVgVaaZa^hbꢀ XVcꢀ WZꢀ
VX]^ZkZY#
ꢉꢋꢀ AddhZcꢀ i]Zꢀ adX`ꢀ cjiꢀ dcꢀ i]Zꢀ heZZYꢀ Xdcigdaꢀ
VY_jhibZciꢀ`cdWꢀꢂ&IGURE ꢀꢌꢃ#
AdX`ꢀCji
6Y_jhi^c\ꢀ i]Zꢀ iVWaZꢀ eVgVaaZa^hbꢀ XVcꢀ WZꢀ Vꢀ kZgnꢀ
iZY^djhꢀiVh`ꢀi]ViꢀiV`ZhꢀVꢀ\gZViꢀVbdjciꢀd[ꢀeVi^ZcXZ#ꢀ
9DꢀCDIꢀVY_jhiꢀi]ZꢀiVWaZꢀjcaZhhꢀndjꢀVgZꢀ]Vk^c\ꢀ
igdjWaZꢀ hVcY^c\ꢀ ndjgꢀ ldg`e^ZXZꢀ idꢀ Vꢀ jc^[dgbꢀ
i]^X`cZhh#ꢀ
>[ꢀ Vꢀ iVWaZꢀ VY_jhibZciꢀ ^hꢀ cZZYZY!ꢀ iV`Zꢀ egZX^hZꢀ
cdiZhꢀ dcꢀ i]Zꢀ edh^i^dc^c\ꢀ d[ꢀ i]Zꢀ iVWaZꢀ ZaZkVi^dcꢀ
hXgZlh#ꢀI]^hꢀl^aaꢀVaadlꢀi]Zꢀdg^\^cVaꢀhZii^c\ꢀidꢀWZꢀ
gZ"ZhiVWa^h]ZY#ꢀ
ꢀ
&IGURE ꢀꢌꢋ HeZZYꢀXdcigdaꢀVY_jhibZciꢀ`cdW#
ꢌꢋꢀ Ijgcꢀ i]Zꢀ `cdWꢀ XadX`l^hZꢀ idꢀ YZXgZVhZꢀ i]Zꢀ
dhX^aaVi^dcꢀ heZZYꢀ VcYꢀ XdjciZgXadX`l^hZꢀ idꢀ
^cXgZVhZꢀ^i#
:aZkVi^dcꢀHXgZl
HegdX`Zih
ꢀꢋꢀ I^\]iZcꢀ i]Zꢀ adX`ꢀ cjiꢀ addhZcZYꢀ ^cꢀ 3TEP ꢉꢀ idꢀ
hZXjgZꢀi]Zꢀ`cdW#ꢀꢀ
&IGURE ꢀꢀꢋꢀK^Zlꢀd[ꢀZaZkVi^dcꢀhXgZlꢀhegdX`Zih#
"()"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
4O ADJUST THE TABLE PARALLELISMꢊ
0RESSURE 2OLLERS
ꢉꢋ EVhhꢀ Vꢀ (,ꢅꢀ l^YZꢀ WdVgYꢀ i]gdj\]ꢀ i]Zꢀ hVcYZgꢀ
jci^aꢀi]ZꢀENTIRE hjg[VXZꢀd[ꢀi]ZꢀWdVgYꢀ^hꢀbV`"
^c\ꢀXdciVXiꢀl^i]ꢀi]ZꢀhVcY^c\ꢀWZai#
4O ADJUST THE PRESSURE ROLLERSꢊ
ꢉꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
ꢌꢋ BZVhjgZꢀi]Zꢀi]^X`cZhhꢀd[ꢀi]ZꢀWdVgYꢀViꢀkVg^"
djhꢀed^cihꢀVgdjcYꢀi]ZꢀZY\Z#ꢀ
ꢌꢋ EaVcZꢀꢂ'ꢃꢀ(+ꢅꢀadc\ꢀ'ꢀmꢀ)ꢆhꢀidꢀVꢀjc^[dgbꢀi]^X`"
cZhhZh#ꢀEaVXZꢀdcZꢀWdVgYꢀVadc\ꢀi]ZꢀaZc\i]ꢀd[ꢀ
i]Zꢀ[ZZYꢀWZaiꢀdcꢀi]Zꢀg^\]i"]VcYꢀh^YZꢀVcYꢀeaVXZꢀ
i]Zꢀdi]ZgꢀWdVgYꢀdcꢀi]ZꢀaZ[i"]VcYꢀh^YZ#ꢀ
ꢀꢋꢀ >[ꢀi]ZgZꢀ^hꢀVꢀkVg^Vi^dcꢀd[ꢀi]^X`cZhh!ꢀi]ZꢀiVWaZꢀ
XVcꢀWZꢀVY_jhiZYꢀVXXdgY^c\an#
ꢄꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
ꢀꢋ L^i]ꢀi]ZꢀhVcY^c\ꢀWZaiꢀiZch^dcZYꢀꢂ&IGURE ꢀꢇꢃ!ꢀ
bdkZꢀi]ZꢀhVcY^c\ꢀgdaaZghꢀVcYꢀbVcjVaanꢀgV^hZꢀ
i]Zꢀ iVWaZꢀ jci^aꢀ ndjꢀ _jhiꢀ ]ZVgꢀ i]Zꢀ hVcYeVeZgꢀ
bV`ZꢀXdciVXiꢀl^i]ꢀi]Zꢀhjg[VXZꢀd[ꢀi]ZꢀlddY#ꢀ
9DꢀCDIꢀXdci^cjZꢀidꢀgV^hZꢀi]ZꢀiVWaZꢀWZndcYꢀ
i]Viꢀed^ci#ꢀꢀ
ˆ;dgꢀb^cdgꢀVY_jhibZci!ꢀaddhZcꢀi]ZꢀiVWaZꢀꢀ
bdjci^c\ꢀWdaihꢀh]dlcꢀ^cꢀ&IGURE ꢀꢄꢀVcYꢀgdiViZꢀ
i]ZꢀZaZkVi^dcꢀhXgZlꢀ[aVc\Z#
ꢀ·;dgꢀbV_dgꢀVY_jhibZci!ꢀbVg`ꢀi]ZꢀX]V^cꢀadXV"
i^dcꢀdcꢀVaaꢀhegdX`Zih!ꢀgZbdkZꢀi]ZꢀX]V^cꢀ[gdbꢀ
i]Zꢀ hegdX`Ziꢀ idꢀ WZꢀ VY_jhiZY!ꢀ VcYꢀ ijgcꢀ i]Zꢀ
hegdX`ZiꢀXdjciZgXadX`l^hZꢀidꢀgV^hZꢀi]ZꢀiVWaZ#ꢀ
DcZꢀ fjVgiZgꢀ d[ꢀ Vꢀ ijgcꢀ gV^hZhꢀ dgꢀ adlZghꢀ Vcꢀ
ZaZkVi^dcꢀhXgZlꢀVeegdm^bViZanꢀ%#%'%ꢅ
:aZkVi^dcꢀ
HXgZlꢀ;aVc\Z
IVWaZꢀBdjci^c\
7dai
&IGURE ꢀꢇꢋ GdaaZgꢀiZch^dcꢀhl^iX]#
&IGURE ꢀꢄꢋ IVWaZꢀbdjci^c\ꢀWdaih#
ꢄꢋꢀ 8dccZXiꢀi]ZꢀhVcYZgꢀidꢀi]ZꢀedlZgꢀhdjgXZꢀVcYꢀ
bV`ZꢀcdiZꢀd[ꢀi]ZꢀgZVY^c\ꢀdcꢀi]ZꢀY^\^iVaꢀY^h"
eaVn#ꢀ I]Zcꢀ bVcjVaanꢀ adlZgꢀ i]Zꢀ iVWaZꢀ %#%'%ꢅꢀ
idꢀ%#%(%ꢅ#ꢀI]^hꢀ^hꢀ]dlꢀbjX]ꢀadlZgꢀi]Zꢀ^c[ZZYꢀ
egZhhjgZꢀgdaaZgꢀh]djaYꢀWZꢀhZiꢀl]ZcꢀXdbeVgZYꢀ
idꢀi]ZꢀhVcY^c\ꢀhjg[VXZꢀd[ꢀi]ZꢀhVcY^c\ꢀgdaaZg#ꢀ
./4)#%
7HEN ADJUSTING THE LEFT FRONT ELEVATION
SCREWꢆ MAKE THE SAME ADJUSTMENT TO THE
LEFT REAR ELEVATION SCREWꢋ 4HIS ENSURES THE
HEIGHT FROM THE FRONT TO THE BACK OF THE TABLE
REMAINS UNCHANGEDꢋ $O THE SAME WHEN
ADJUSTING THE RIGHT ELEVATION SCREWSꢋ
ꢇꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
ꢇꢋꢀ GZ^chiVaaꢀi]ZꢀX]V^c!ꢀi^\]iZcꢀi]ZꢀWdaih!ꢀVcYꢀiZhiꢀ
i]ZꢀbVX]^cZ#
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"(*"
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢅꢋꢀ AddhZcꢀ i]Zꢀ gdaaZgꢀ adX`ꢀ cjihꢀ ꢂ&IGURE ꢀꢅꢃꢀ dcꢀ
i]Zꢀ ^c[ZZYꢀ egZhhjgZꢀ gdaaZg#ꢀ Ijgcꢀ i]Zꢀ VY_jhi"
bZciꢀ cjihꢀ ꢂ&IGURE ꢀꢅꢃꢀ idꢀ adlZgꢀ i]Zꢀ egZh"
hjgZꢀgdaaZgꢀjci^aꢀ^iꢀ_jhiꢀidjX]Zhꢀi]ZꢀWdVgY#ꢀꢀ
.OTEꢊꢀ $/ ./4 CONTINUE TO LOWER THE ROLLER
BEYOND THAT POINTꢁ
6ꢐ"ELT !DJUSTMENT
4O ADJUST EITHER 6ꢐBELTꢊ
ꢉꢋ $ISCONNECT THE SANDER FROM THE POWER
SOURCEꢒ
GdaaZgꢀAdX`ꢀ
Cji
ꢌꢋ AddhZcꢀi]ZꢀadX`ꢀcjiꢀꢂ&IGURES ꢀꢁ ꢄ ꢀꢍꢃ#
K"7Zai
6Y_jhibZciꢀ
Cji
AdX`ꢀCji
6Y_jhibZciꢀ
Cji
&IGURE ꢀꢅꢋ EgZhhjgZꢀgdaaZgꢀeVgih#
ꢁꢋꢀ I^\]iZcꢀi]ZꢀgdaaZgꢀadX`ꢀcjihꢀVcYꢀgZX]ZX`ꢀndjgꢀ
hZii^c\h#
&IGURE ꢀꢁꢋ IVWaZꢀZaZkVi^dcꢀK"WZai#
ꢍꢋꢀ 8dccZXiꢀi]ZꢀhVcYZgꢀidꢀi]ZꢀedlZgꢀhdjgXZꢀVcYꢀ
bV`ZꢀcdiZꢀd[ꢀi]ZꢀgZVY^c\ꢀdcꢀi]ZꢀY^\^iVaꢀY^h"
eaVn#ꢀI]ZcꢀbVcjVaanꢀadlZgꢀi]ZꢀiVWaZꢀVcꢀVYY^"
i^dcVaꢀ%#%'ꢅꢀidꢀ%#%(ꢅ#ꢀI]^hꢀ^hꢀ]dlꢀbjX]ꢀadlZgꢀ
i]Zꢀ dji[ZZYꢀ egZhhjgZꢀ gdaaZgꢀ h]djaYꢀ WZꢀ hZiꢀ
l]Zcꢀ XdbeVgZYꢀ idꢀ i]Zꢀ ]Z^\]iꢀ d[ꢀ i]Zꢀ ^c[ZZYꢀ
gdaaZg#
K"7Zaih
AdX`ꢀCji
ꢈꢋꢀ AddhZcꢀ i]Zꢀ gdaaZgꢀ adX`ꢀ cjihꢀ dcꢀ i]Zꢀ dji[ZZYꢀ
egZhhjgZꢀgdaaZg#ꢀIjgcꢀi]ZꢀVY_jhibZciꢀWdaihꢀidꢀ
adlZgꢀi]ZꢀegZhhjgZꢀgdaaZgꢀjci^aꢀ^iꢀ_jhiꢀidjX]Zhꢀ
i]ZꢀWdVgY#ꢀ.OTEꢊꢀ$/ ./4 CONTINUE TO LOWER
THE ROLLER BEYOND THAT POINTꢁ
6Y_jhibZciꢀCji
ꢂ7ZadlꢀEaViZꢃ
ꢉꢃꢋꢀ I^\]iZcꢀi]ZꢀgdaaZgꢀadX`ꢀcjihꢀVcYꢀgZX]ZX`ꢀndjgꢀ
&IGURE ꢀꢍꢋ HVcY^c\ꢀYgjbꢀK"WZaih#
hZii^c\h#
(#ꢀ Ijgcꢀi]ZꢀVY_jhibZciꢀcjiꢀjeꢀdgꢀYdlcꢀjci^aꢀi]Zꢀ
K"WZaiꢀYZ[aZXihꢀ&ꢅꢀd[[ꢀd[ꢀXZciZgꢀl]Zcꢀejh]ZYꢀ
l^i]ꢀndjgꢀ[^c\Zg#ꢀ
.OTEꢊꢀ 6ARIABLES SUCH AS FEED RATEꢀ DEPTH OF
THE CUTꢀ AND THE TYPE OF SANDING BELT CAN PLAY
A BIG PART IN DETERMINING THE PROPER AMOUNT OF
DOWNWARD PRESSURE EXERTED BY THE ROLLERSꢁ 3OME
EXPERIMENTATION MAY BE NECESSARY TO ACHIEVE
THE DESIRED RESULTSꢁ (OWEVERꢀ UNDER NO CIRCUMꢂ
STANCES SHOULD THE PRESSURE ROLLERS BE SET EVENꢀ
OR HIGHER THANꢀ THE SANDING ROLLERꢁ
ꢄꢋ GZi^\]iZcꢀi]ZꢀadX`ꢀcji#
"(+"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
!IR 3YSTEM $IAGRAM ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈꢏ'ꢃꢇꢁꢉ
!ꢋ H]deꢀ8dbegZhhdg
)ꢋꢀ DhX^aaVi^dcꢀI^b^c\ꢀE^hidcꢀVcYꢀ9^Ve]gV\bꢀ6hhn#
*ꢋꢀ DhX^aaVi^dcꢀHeZZYꢀ8dcigdaꢀE^hidc
+ꢋꢀ 7ZaiꢀIZch^dcꢀ8dcigdaꢀE^hidc
,ꢋ 7ZaiꢀIZch^dcꢀ8dcigdaꢀHl^iX]
-ꢋꢀ :bZg\ZcXnꢀHideꢀ7jiidcꢀHl^iX]
.#ꢀ :bZg\ZcXnꢀHideꢀEjh]ꢀ7gV`ZꢀHl^iX]
/ꢋꢀ AZ[iꢀ7ZaiꢀA^b^iꢀHl^iX]
0ꢋ G^\]iꢀ7ZaiꢀA^b^iꢀHl^iX]
1ꢋ 7ZaiꢀIZch^dcꢀA^b^iꢀHl^iX]
2ꢋ :bZg\ZcXnꢀ7gV`Zꢀ8dciVXidg
"ꢋꢀ 6^gꢀEgZhhjgZꢀGZ\jaVidg
#ꢋꢀ :bZg\ZcXnꢀ7gV`ZꢀHdaZcd^Y
$ꢋꢀ :bZg\ZcXnꢀ7gV`Z
%ꢋꢀ 6^gꢀ9^hig^Wji^dcꢀBVc^[daY
&ꢋꢀ 6^g[adlꢀ6Y_jhibZciꢀ@cdWꢀ
ꢀ
ꢂDhX^aaVi^dcꢀI^b^c\ꢃ
'ꢋꢀ HeZZYꢀ8dcigdaꢀ6Y_jhibZciꢀ@cdW
ꢂDhX^aaVi^dcꢀHeZZYꢃ
(ꢋ DhX^aaVi^dcꢀ8dcigdaaZgꢀ6^gꢀ;dg`
ꢀ
*
+
)
6^gꢀA^cZ
1
,
:aZXig^XVaꢀL^gZ
(
0
/
'
&
%
#
2
$
"
!
;gdci
.
-
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"(,"
Download from Www.Somanuals.com. All Manuals Search And Download.
7IRING "OX %LECTRICAL $IAGRAM
ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈꢏ'ꢃꢇꢁꢉ
&*
&*
-
*
'
&)
&'
J( K( &+ &, &- &. &(
+
*
(
(
J&
&%
.
&&
K& J' K'
ꢂBD9:Aꢀ<%*,&ꢃꢀ
ꢂIDꢀ<%*,&ꢀBDIDGꢃꢀ
-
*
'
&)
&'
J( K( &+ &, &- &. &(
+
*
(
(
J&
&%
.
&&
K& J' K'
ꢂBD9:AHꢀ<%))+ꢀ6C9ꢀ<%*(.ꢃꢀ
ꢀꢀꢀꢀꢂIDꢀ<%))+ꢀ
<%*(.ꢀBDIDGꢃ
I67A:ꢀ
JE$9DLCꢀ
HL>I8=
ꢀꢀꢀꢀ9><>I6A
6BEꢀB:I:G
EDL:G
'
(
&
)
>C
¶
ꢂ=>ꢃ
>C
ꢂADꢃ
>C
.%
'+%K
&-
I67A:ꢀ
)
(
'
JE$9DLCꢀ
'
&
(
&*
&)
HL>I8=
&+
7ajZ
7aVX`
&(
H:CHDGH
&)
''
&* &+ &, &-
&'
&.
'% '&
7aVX`
7ajZ
,
9><>I6AꢀE6C:A
:B:G<:C8NꢀHIDE
H6;:INꢀHL>I8=
DK
*
6
&'K
'
(
&
.
&& &%
-
,
+
)
*
)
(
&
'
,
7
(
''
'&
M'
M&
&)
&(
H6C9>C<
7:AIꢀHI6GI
HL>I8=
H6C9>C<
7:AIꢀHIDE
HL>I8=
&)
&(
*
(
&
'
)
(
&%
''
'&
M'
7:AI
IG68@>C<
H6;:IN
HL>I8=:H
&)
&(
8DCK:NDG
7:AIꢀHI6GI
HL>I8=
8DCK:NDG
7:AIꢀHIDE
HL>I8=
&)
&(
M&
*
&
'
)
(
''
'&
M'
M&
&)
&(
EDL:G
A6BE
(
:B<ꢀHIDE
HL>I8=
&%
-
&&
.
+
*
(
'
"(-"
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
#ONTROL 0ANEL #OMPONENT ,OCATIONS
ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈꢏ'ꢃꢇꢁꢉ
9^\^iVaꢀ6beꢀ9gVlꢀ
BZiZg
9^\^iVaꢀEVcZa
HVcY^c\ꢀ7ZaiꢀHIDEꢀ
HVcY^c\ꢀ7Zaiꢀ
HI6GIꢀ7jiidc
7jiidc
8dckZndgꢀ7Zaiꢀ
8dckZndgꢀ7Zaiꢀ
HIDEꢀ7jiidc
HI6GIꢀ7jiidc
:bZg\ZcXnꢀHideꢀ
7jiidc
EdlZgꢀAVbe
<%))+$<%*(.$<%*,&ꢀ(,ꢅꢀL^YZꢀ7ZaiꢀHVcYZg
"(."
Download from Www.Somanuals.com. All Manuals Search And Download.
7IRING "OX %LECTRICAL $IAGRAM ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈ
ꢂ
ꢊ
ꢛ
ꢂ
ꢊ
ꢛ
ꢅꢋꢄꢛꢂꢋꢌꢉꢚꢋ ꢀꢂꢉꢛꢂꢇꢄꢊꢜꢋꢂꢁꢀꢂꢉ
ꢉꢉꢉꢉꢉꢉꢉꢉꢉꢉꢉꢉꢉꢉꢉꢓꢓꢗꢏꢉꢅꢗꢄꢄꢀꢅꢛꢍꢋꢄ
ꢔ
ꢐ
ꢇꢁꢚꢉꢁꢀꢛꢀꢂꢉꢅꢙꢂꢂꢀꢄꢛꢉꢊꢀꢄꢊꢋꢂ
ꢓ
ꢂ
ꢊ
ꢖ
ꢛ
ꢗ
ꢐ
ꢔ
ꢑ
ꢌꢐ
ꢌꢓ
ꢌꢔ
ꢐ
ꢔ
ꢑ
ꢌꢐ
ꢌꢓ
ꢌꢔ
ꢐꢔ ꢄꢋ ꢓꢐ ꢄꢅ
ꢇꢐ
ꢂ
ꢊ
ꢛ
ꢂ
ꢊ
ꢊꢇꢄꢎꢍꢄꢃꢉꢁꢋꢛꢋꢂ
ꢅꢋꢄꢛꢇꢅꢛꢋꢂ
ꢓ
ꢔ
ꢐꢐ
ꢐꢐ
ꢖ
ꢐꢑ
ꢐ
ꢔ
ꢑ
ꢐ
ꢔ
ꢑ
ꢌꢐ
ꢌꢓ
ꢌꢔ
ꢌꢐ
ꢌꢓ
ꢌꢔ
ꢐ
ꢔ
ꢑ
ꢌꢐ
ꢌꢓ
ꢌꢔ
ꢅꢋꢄꢏꢀ!ꢋꢂꢉ
ꢅꢋꢄꢛꢇꢅꢛꢋꢂ
ꢐꢔ ꢄꢋ ꢓꢐ ꢄꢅ
ꢐꢔ ꢄꢋ ꢓꢐ ꢄꢅ
ꢇꢐ
ꢇꢐ
ꢐꢔ ꢄꢋ ꢓꢐ ꢄꢅ
ꢇꢐ
ꢐꢒ
ꢗ
ꢓꢐ
ꢐꢒ
ꢄꢋ ꢓꢓ
ꢇꢓ
ꢄꢅ
ꢛꢔ
ꢓꢗ
ꢔ
ꢓ
ꢒ
ꢛꢆꢌꢉꢁꢛꢂꢉꢅꢋꢄꢛꢇꢅꢛꢋꢂ
ꢓ
ꢛꢆꢌꢉꢁꢛꢂꢉꢅꢋꢄꢛꢇꢅꢛꢋꢂ
ꢓ
ꢛꢐ
ꢛꢓ
ꢛꢔ
ꢔ
ꢓ
ꢒ
ꢛꢐ
ꢛꢓ
ꢐ
ꢉꢉꢉ
ꢋꢏꢀꢂꢌꢋꢇꢎꢉꢉ
ꢓ
ꢋꢏꢀꢂꢌꢋꢇꢎ
ꢂꢀꢌꢇ!ꢉꢉ
ꢐꢒ
ꢐꢒ
ꢄꢋ ꢓꢓ
ꢇꢓ
ꢄꢋ ꢓꢓ
ꢇꢓ
ꢄꢅ
ꢛꢔ
ꢄꢅ
ꢛꢔ
ꢐꢒ
ꢄꢋ ꢓꢓ
ꢇꢓ
ꢄꢅ
ꢛꢔ
ꢜꢙꢊꢀ ꢜꢙꢊꢀ
ꢓ
ꢒ
ꢓ
ꢒ
ꢛꢐ
ꢛꢓ
ꢛꢐ
ꢛꢓ
ꢂꢀꢌꢇ!
ꢓ
ꢒ
ꢛꢐ
ꢛꢓ
ꢕ
ꢙꢓ
ꢄꢋ
ꢖꢕ
ꢄꢅ
ꢐꢗ
ꢏꢓ
ꢖꢘ
ꢖꢑ
ꢖ
ꢐꢔ
ꢓ
ꢐꢖ
ꢐꢓ
ꢓ
ꢒ
ꢓ
ꢒ
ꢛꢐ
ꢛꢓ
ꢛꢔ
ꢛꢐ
ꢛꢓ
ꢛꢔ
ꢓ
ꢓ
ꢐꢘ
ꢓ
ꢏꢓ
ꢑ
ꢙꢐ
ꢏꢐ
ꢐ
ꢏ
ꢙ
ꢙꢓ
ꢛ
ꢀ
ꢊ
ꢂ
ꢙꢐ ꢏꢐ ꢐ ꢙꢓ ꢏꢓ ꢓ
ꢐ
ꢐꢘ ꢐꢕ ꢐꢖ ꢐꢔ
ꢖ
ꢔ
ꢓ
ꢐꢒ ꢐꢑ
ꢐꢓ ꢐꢐ ꢐꢗ
ꢕ
ꢑ
ꢑ
ꢔ
ꢐꢔ
ꢐꢓ
ꢀꢁꢀꢂꢃꢀꢄꢅ!
ꢆꢂꢇꢈꢀꢉꢊꢋꢌꢀꢄꢋꢍꢎꢉꢏꢇꢌꢏꢀ
ꢌꢔ
ꢌꢐ
ꢌꢓ
ꢃꢂꢋꢙꢄꢎ
ꢁꢁꢀꢕ
ꢅꢋꢄꢏꢀ!ꢋꢂꢉꢉꢁꢋꢛꢋꢂ
ꢊꢇꢄꢎꢍꢄꢃꢉꢉꢁꢋꢛꢋꢂ
ꢛꢇꢆꢌꢀꢉꢉꢙꢚꢝꢎꢋ ꢄꢉꢉꢁꢋꢛꢋꢂ
ꢙꢓ
ꢙꢑ
ꢙꢐ
ꢏꢓ
ꢏꢑ
ꢏꢐ
ꢓ
ꢑ
ꢐ
ꢙꢓ
ꢙꢑ
ꢙꢐ
ꢏꢓ
ꢏꢑ
ꢏꢐ
ꢓ
ꢑ
ꢐ
ꢙ
ꢏ
ꢓ
ꢙꢑ
ꢙꢐ
ꢙꢓ
ꢏꢑ
ꢏꢐ
ꢏꢓ
ꢑ
ꢐ
ꢓꢓꢗꢏ
ꢓꢓꢗꢏ
ꢓꢓꢗꢏ
ꢔꢔꢀꢕ
ꢅꢋꢄꢏꢀ!ꢋꢂꢉꢉꢁꢋꢛꢋꢂ
ꢛꢇꢆꢌꢀꢉꢉꢙꢚꢝꢎꢋ ꢄꢉꢉꢁꢋꢛꢋꢂ
ꢊꢇꢄꢎꢍꢄꢃꢉꢉꢁꢋꢛꢋꢂ
ꢓ
ꢑ
ꢐ
ꢙꢓ
ꢙꢑ
ꢙꢐ
ꢓ
ꢑ
ꢐ
ꢑ
ꢏꢓ
ꢏꢑ
ꢙꢓ
ꢙꢑ
ꢙꢐ
ꢙꢑ
ꢙꢓ
ꢏꢑ
ꢏꢓ
ꢏ
ꢏꢓ
ꢏꢑ
ꢓ
ꢏꢐ
ꢏꢐ
ꢙ
ꢏꢐ
ꢐ
ꢙꢐ
ꢒꢒꢗꢏ
ꢒꢒꢗꢏ
ꢒꢒꢗꢏ
")%"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
7IRING "OX #OMPONENTS ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈ
6beꢀBZiZgꢀ
8jggZciꢀHZchdg
8dcigdaꢀHnhiZbꢀ
HiZeYdlcꢀ
IgVch[dgbZg
HVcY^c\ꢀBdidgꢀ
8dciVXidg
:bZg\ZcXnꢀ7gV`Zꢀ
8dciVXidg
8dckZndgꢀBdidgꢀ
8dciVXidg
''%K$))%Kꢀ
I]gZZ"E]VhZꢀ
EdlZgꢀHjeeanꢀ
?jcXi^dcꢀ7adX`
JE$9DLCꢀIVWaZꢀBdidgꢀ
8dciVXidgh
8dckZndgꢀBdidgꢀ
DkZgadVYꢀGZaVnꢀ
Ildꢀ)ꢀ6beꢀ;jhZh
HVcY^c\ꢀBdidgꢀDkZgadVYꢀ
GZaVnꢀ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
")&"
Download from Www.Somanuals.com. All Manuals Search And Download.
7IRING "OX %LECTRICAL $IAGRAM ꢎ'ꢃꢇꢁꢉ
ꢎ
ꢏ
ꢎ
ꢏ
ꢅꢕꢙꢉꢕꢐꢆꢐꢎꢉꢉꢑꢎꢎꢐꢀꢆꢉꢏꢐꢀꢏꢁꢎ
ꢇ
ꢀ
ꢑꢌꢑ
ꢓ
ꢌꢓ
ꢑ
ꢓ
ꢌꢒ
ꢌ
ꢌꢒ
ꢌꢓ
ꢁꢑ
ꢀ
ꢎ
ꢇ
ꢀ
ꢎ
ꢒꢑ ꢂꢈ
ꢑꢓ ꢂꢅ
ꢑꢓ ꢂꢅ ꢒꢑ ꢂꢈ
ꢋ
ꢄ
ꢑꢑ
ꢘ
ꢄ
ꢇ
ꢂꢂ
ꢂ
ꢇ
ꢂ
ꢇ
ꢂ
ꢇ
ꢊ
ꢊꢄ
ꢊꢇ
ꢉꢁꢀ ꢐ"ꢁꢎꢉ
ꢉꢁꢀꢆꢅꢉꢆꢁꢎ
ꢊ
ꢊꢄ
ꢊꢇ
ꢅꢂ
ꢊ
ꢊꢄ
ꢊꢇ
ꢅꢂ
ꢂꢇ ꢀꢁ ꢄꢂ ꢀꢉ
ꢅꢂ
ꢂꢇ ꢀꢁ ꢄꢂ ꢀꢉ
ꢂꢇ ꢀꢁ ꢄꢂ ꢀꢉ
ꢏꢅꢀꢔꢘꢀꢓꢉꢕꢁꢆꢁꢎ
ꢉꢁꢀꢆꢅꢉꢆꢁꢎ
ꢂꢃ ꢀꢁ ꢄꢄ ꢀꢉ
ꢅꢄ
ꢓ
ꢒ ꢑ
ꢒ ꢗ
ꢐꢕꢓꢉꢖꢎꢅꢗꢐ
ꢄ
ꢃ
ꢈ
ꢆꢇ
ꢆꢂ
ꢆꢄ
ꢆꢖꢊꢉꢕꢆꢎꢉꢉꢁꢀꢆꢅꢉꢆꢁꢎ
ꢄ
ꢆꢖꢊꢉꢕꢆꢎꢉꢉꢁꢀꢆꢅꢉꢆꢁꢎ
ꢑꢔ ꢂꢅ
ꢒꢒ ꢂꢈ
ꢉꢉꢉ
ꢄ
ꢒ
ꢔ
ꢕ
ꢆꢓ
ꢆꢑ
ꢆꢒ
ꢂꢌ
ꢄ
ꢉꢁꢀꢆꢅꢉꢆꢁꢎ
ꢚꢑꢏꢐ ꢚꢑꢏꢐ
ꢑ
ꢂꢃ ꢀꢁ ꢄꢄ ꢀꢉ
ꢅꢄ
ꢙ
ꢑꢔ ꢂꢅ ꢒꢒ ꢂꢈ
ꢁꢒ
ꢑꢔ ꢀꢁ ꢒꢒ ꢂꢈ
ꢁꢒ
ꢁ ꢐꢎꢊꢁꢅꢔꢉꢉ
ꢎꢐꢊꢅ"
ꢄ
ꢃ
ꢈ
ꢆꢇ
ꢒ
ꢔ
ꢕ
ꢒ
ꢔ
ꢕ
ꢆꢂ
ꢆꢄ
ꢆꢑ
ꢆꢒ
ꢆꢓ
ꢆꢑ
ꢆꢒ
ꢆꢓ
ꢑ ꢔ
ꢑꢄ
ꢁ ꢐꢎꢊꢁꢅꢔ
ꢂꢅ
ꢂꢈ
ꢂ ꢋ
ꢑꢇ
ꢎꢐꢊꢅ"ꢉꢉ
ꢘꢚ ꢘꢙ
ꢘ
ꢘꢕ
ꢂꢅ
ꢂꢈ
ꢘꢕ
ꢒ
ꢑ ꢒ
ꢕ
ꢑꢄ
ꢆꢑ
ꢄ
ꢓ
ꢕ
ꢆꢓ
ꢔ
ꢆꢒ
ꢘ
ꢘꢙ ꢘꢚ
ꢄ
ꢂ ꢇ
ꢒ
ꢒ
ꢑ ꢘ
ꢑ ꢚ
ꢍꢓ
ꢒ
ꢔ
ꢕ
ꢆꢑ
ꢆꢒ
ꢆꢓ
ꢄ
ꢉꢑ
ꢑ ꢑ
ꢍꢑ
ꢂꢌ
ꢍ
ꢍ
ꢉ
ꢋ
ꢎ
ꢏ
ꢐ
ꢐꢕꢐꢎꢓꢐꢀꢉ"
ꢑꢂ ꢂ ꢑꢄ ꢄ ꢑꢇ ꢑ ꢕ ꢂ ꢒ
ꢂ ꢋ ꢂ ꢇ
ꢂ ꢂ ꢂ ꢌ
ꢂ ꢃ
ꢂ
ꢑ ꢙ
ꢂ ꢄ
ꢋ
ꢍ
ꢈ
ꢇ
ꢇ
ꢄ
ꢖꢎꢅꢗꢐꢉꢏꢁꢊꢐꢀꢁꢘꢔꢉ
ꢅꢊ ꢐ
ꢌꢑ
ꢌ ꢒ
ꢓꢎꢁꢑꢀꢔ
ꢂ ꢇ
ꢂ ꢄ
ꢁꢁꢀꢂ
ꢒꢒꢗꢉ
ꢒꢒꢗꢉ
ꢀꢁꢂꢃꢍꢂꢃꢉ
ꢄꢅꢆꢅꢇ
ꢇꢅꢆꢁꢆꢍꢅꢂ
ꢒ
ꢑ
ꢆꢁꢋꢌꢊꢉꢉꢍꢎꢏꢃꢅꢐꢂ
ꢄꢅꢆꢅꢇ
ꢒ
ꢓ
ꢑ
ꢒꢒꢗꢉ
ꢓ
!
ꢖ
#
ꢛ
ꢉꢒ
ꢍꢒ
ꢍꢓ
ꢕ
ꢒꢒꢗꢉ
ꢒꢒꢗꢉ
ꢈꢅꢂꢉꢊ ꢅꢇꢉ
ꢑ
ꢔ
ꢄꢅꢆꢅꢇ
ꢇꢅꢆꢁꢆꢍꢅꢂ
ꢔ
ꢑ
ꢕ
ꢔ
ꢑ
ꢄ
ꢇ
ꢕ
#
ꢛ
ꢒ
ꢓ
ꢒ
ꢓ
")'"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
7IRING "OX #OMPONENTS ꢎ'ꢃꢇꢁꢉ
6beꢀBZiZgꢀ
8jggZciꢀHZchdg
:bZg\ZcXnꢀ7gV`Zꢀ
HVcY^c\ꢀBdidgꢀ
8dciVXidg
8dciVXidg
8dckZndgꢀBdidgꢀ
8dciVXidg
Ildꢀ)ꢀ6beꢀ;jhZh
''%KꢀH^c\aZꢀ
JE$9DLCꢀIVWaZꢀBdidgꢀ
8dciVXidgh
8dckZndgꢀBdidgꢀ
E]VhZ"EdlZgꢀ
Hjeeanꢀ
DkZgadVYꢀGZaVnꢀ
?jcXi^dcꢀ7adX`
HVcY^c\ꢀBdidgꢀDkZgadVYꢀ
GZaVn
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
")("
Download from Www.Somanuals.com. All Manuals Search And Download.
'ENERAL %LECTRICAL $IAGRAM ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈ
ꢔ
ꢉ
ꢆ
ꢑ
ꢄꢎ
ꢁꢏ
ꢁ
ꢄꢓ
ꢇꢃꢄ
ꢄꢜ
ꢕꢄ
ꢜ ꢄ
ꢂꢄ
ꢇ
ꢀ
ꢑ
ꢍ
ꢉ
ꢆꢁꢚꢝꢙꢚꢐ
ꢗꢔꢃꢑ
ꢄꢅꢆꢅꢇ
ꢄꢅꢆꢅꢇ
ꢂ
ꢈ
ꢕꢅ
ꢜ ꢅ
ꢂꢅ
ꢉ
ꢆ
ꢑ
ꢕ
ꢜ
ꢑꢁꢗꢃ ꢔ ꢃ ꢙ ꢈꢑꢙꢚꢐ
ꢛ
ꢃꢇꢂꢔꢉꢙꢚꢐ
ꢂ
ꢕ
ꢜ
ꢉ
ꢆ
ꢑ
ꢂ
ꢇꢃ ꢀ
ꢏꢀ
ꢕ
ꢜ
ꢉ
ꢆ
ꢑ
ꢕ
ꢜ
ꢖꢇꢚꢜꢔ ꢇꢉ
ꢗꢔꢃꢑ
ꢏꢇꢑꢇꢉ
ꢂ
ꢉ
ꢆ
ꢂ
ꢚꢈꢗ
ꢎꢁ
ꢄ
ꢅ
ꢎꢎꢊꢜ ꢀꢍꢊꢜ
ꢊ
ꢎꢄꢓꢜ ꢅꢅꢊꢜ ꢅꢊꢊꢜ
ꢅ
ꢅ
ꢅ
ꢀ
ꢔ'$+%$(#- ꢗ+!&$
ꢂꢃ
ꢄꢅ
ꢒꢇꢂꢔꢉ ꢆꢇꢕꢉꢖꢔ
ꢗꢉꢁꢘꢔ
ꢁ
ꢁ
ꢆꢇꢃ
ꢄꢀ
ꢉ
ꢕ
ꢜ
ꢆ
ꢀ
ꢒꢖ
ꢔꢏꢔꢉꢐꢔꢚꢖ
ꢗꢉꢁꢘꢔ
ꢓ
ꢁ
!
"
ꢃꢆꢄ
ꢔ'$+%$(#- ꢆ,)*
ꢁ
ꢌ
ꢃꢆꢅ
ꢃꢆꢀ
ꢃꢆꢎ
ꢒꢖꢉꢄ
ꢄꢌ
ꢄꢍ
ꢄ
ꢅꢊ
ꢅꢄ
ꢃꢆ
ꢃꢆ
ꢉ
ꢈ
ꢈ
ꢑꢁꢗꢃ ꢔ ꢃ ꢙ ꢈꢑꢙ ꢚꢐ
ꢒꢖꢉꢅ
ꢄꢋ
ꢛ
ꢃ ꢇꢂꢔꢉꢙꢚꢐ
ꢉ
ꢆꢑꢁꢉꢑ
ꢏꢄ
ꢆꢑꢇꢒ
ꢆꢑꢇꢒ
ꢏꢄ
ꢇꢃꢄ
ꢇꢃꢀ
ꢍ
ꢋ
!
"
"
ꢆꢁꢚꢝꢙꢚꢐ ꢗꢔꢃꢑ
ꢐꢃ
ꢆꢑꢁꢉꢑ
ꢏꢀ
ꢏꢀ
ꢄꢊ
ꢄꢄ
!
ꢖꢇꢚꢜꢔ ꢇꢉ ꢗꢔꢃ ꢑ
ꢐꢃ
"))"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
'ENERAL %LECTRICAL $IAGRAM ꢎ'ꢃꢇꢁꢉ
:
G
H
&)
6B
6
&*
DA&
B&
J&
K&
H6C9> C<
7:AI
G
J
BDIDG
H
H
K
K'
G
G
J(
J'
;
K'
J(
J'
K'
J(
J'
H
H
G
I 67A : A > ; I > C<
ꢀ A DL:G>C<
BDIDG
BDIDG
DA(
B(
J
K
8DCK:NDG
7:AI
G
H
J
K
G
H
''%K
)6
'
&
'
(
'
LA
&'
EDL:G HDJG8:
7G6@:
6
6
(
HDA
&(
:bZg\ZcXn 7gV`Z
E8
G
J
K
H
:B:G<:C8N
7G6@:
*
AH&
6
V
W
:bZg\ZcXn Hide
6
+
AH'
AH(
AH)
E8G&
&+
&,
&.
'%
'&
AH
AH
G
;
;
I 67A : A > ; I > C<
E8G'
&-
ꢀ
A DL:G> C<
G
HI6GI
-
,
HIDE
HIDE
B&
DA&
DA(
.
V
W
W
B&
H6C9> C< 7:AI
<A
B(
HI6GI
&%
&&
V
B(
8DCK:NDG 7:AI
<A
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
")*"
Download from Www.Somanuals.com. All Manuals Search And Download.
-AIN %LECTRICAL 0ANEL AND #ONTROLS $IAGRAM
ꢁ
ꢀ
ꢁꢂ
ꢁꢁ
ꢁꢁ
ꢁ
ꢀꢈ
ꢇ
ꢁꢅ
ꢀꢃ
ꢁꢄ
ꢁꢀ
ꢁꢇ
ꢁꢆ
ꢁꢃ
ꢄ
ꢆ
ꢃ
ꢀ
ꢆ
ꢂ
ꢀꢀꢉꢊꢋꢄꢈꢇꢀꢉꢌꢍꢎꢏꢐ
ꢀꢀꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢁꢁꢄꢒꢑꢂꢂꢄꢒꢉꢌꢍꢎꢏꢐ
ꢀꢁꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢁꢁꢄꢒꢉꢌꢍꢎꢏꢐ
ꢀꢁꢉꢊꢋꢄꢈꢇꢀꢉꢁꢁꢄꢒꢉꢌꢍꢎꢏꢐ
ꢀꢁꢓꢀꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢂꢂꢄꢒꢉꢌꢍꢎꢏꢐ
ꢁ
ꢀꢈ
ꢀ
ꢀꢂꢉꢊꢋꢄꢈꢇꢀꢉꢁꢁꢄꢒꢉꢌꢍꢎꢏꢐ
ꢀꢂꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢁꢁꢄꢒꢉꢌꢍꢎꢏꢐ
ꢀꢂꢓꢀꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢂꢂꢄꢒꢉꢌꢍꢎꢏꢐ
ꢀꢄꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢌꢍꢎꢏꢐ
ꢅ
ꢀꢇ
ꢈ
ꢀꢅꢉꢊꢋꢄꢈꢇꢀꢉꢌꢍꢎꢏꢐ
ꢀꢅꢉꢊꢋꢄꢈ ꢃꢑꢋꢄꢂꢂꢅꢉꢌꢍꢎꢏꢐ
ꢀꢆ
")+"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂꢃꢄ ꢀ
ꢅꢆꢅꢇ#!ꢈꢇꢉꢆꢊꢇꢋꢌ#!ꢋꢆꢊꢍꢋ'
ꢁ
ꢐ
ꢐ
ꢒ
ꢄ
ꢀꢁꢂꢃꢄ
ꢀꢁꢒ ꢀ ꢐ
ꢀꢁꢂꢃꢄ
"ꢁ ꢑ
ꢀꢁꢂꢃꢄ
&ꢀꢐ
ꢁ
ꢐ
ꢄ
ꢇꢋꢌ#ꢉꢇ#ꢋ!ꢊꢆꢇ ꢎꢏꢀꢃꢐꢑꢒ
ꢍꢆꢋꢇꢖꢊꢗꢕꢀꢁꢒ ꢘ
ꢍꢆꢋꢇꢖꢊꢗꢕꢀꢁꢂꢃꢙꢕꢀꢚꢚꢐꢘ
ꢔꢆ ꢊꢔꢏꢊ"ꢇ!ꢊꢑꢚꢎꢛꢒꢊ'ꢊꢂꢀ
#ꢅ!ꢑꢈꢌꢉꢆꢊ ꢆꢉ#ꢅ
ꢓ
ꢂ
ꢚ
ꢁ
ꢐ
ꢒ
ꢄ
ꢃ
ꢀꢁꢂꢃꢄ ꢀꢓ ꢔꢈꢌꢕꢅ
ꢀꢁꢂꢃꢄ ꢀꢂ ꢏꢋꢋ!
ꢀꢁꢂꢃꢄ ꢀꢚ ꢍꢉ"ꢅꢊ ꢆꢉ#ꢅ
ꢌꢀꢁ
ꢆ&ꢀꢓ
ꢔꢅ'ꢊꢌ$#ꢊ ꢙꢚꢎꢓꢀ
ꢆꢋꢇꢖꢊ&ꢉ"ꢔꢅ!ꢊ ꢙꢚ
ꢃ
ꢜꢆꢉ#ꢊ&ꢉ"ꢔꢅ!ꢊ ꢙꢚ
ꢀꢁꢂꢃꢄ ꢀꢒ ꢇꢋꢌ#!ꢋꢆꢊ ꢉꢌꢅꢆ
ꢓꢀ
ꢓ
ꢆ&ꢀꢓ
"ꢀꢚ
ꢆꢋꢇꢖꢊ&ꢉ"ꢔꢅ!ꢊ ꢙꢚ
ꢔꢆ ꢊꢔꢏꢊ"ꢇ!ꢊ ꢙꢚꢎꢓꢀꢊ'ꢊ ꢙꢓ
"ꢀꢒꢑ
ꢔꢆ ꢊꢔꢏꢊ"ꢇ!ꢊꢑꢚꢎꢛꢒꢊ'ꢊꢄ
ꢀꢁꢂꢃꢀꢀꢃ
ꢀꢁꢂꢃꢀ ꢀ
ꢀꢁꢒ ꢀ
ꢇ$!!ꢅꢌ#ꢊ"ꢅꢌ"ꢋ!
ꢓꢓ
ꢓꢂ
ꢓꢚ
ꢓꢐ
ꢓꢒ
ꢓꢄ
ꢓꢃ
ꢂꢀ
ꢂ
ꢀꢁꢂꢃꢄ ꢓꢓ $ꢊꢇꢋꢌꢌꢅꢇ#ꢋ!ꢊ ꢙꢓ
ꢀꢁꢂꢃꢄ ꢓꢂ $ꢊꢇꢋꢌꢌꢅꢇ#ꢋ!ꢊꢂꢙꢚ
ꢀꢁꢂꢃꢄ ꢓꢚ ꢇꢉꢍꢆꢅꢊꢇꢋꢌꢌꢅꢇ#ꢋ!ꢊ ꢝ
ꢀꢁꢂꢃꢄ ꢓꢐꢉ ꢏꢈꢕꢈ#ꢉꢆꢊꢊꢉꢑ ꢊꢑꢅ#ꢅ!
ꢀꢁꢂꢃꢄ ꢓꢄꢎ "#ꢉ!#ꢊ"&ꢈ#ꢇꢔ
ꢀꢁꢂꢃꢄ ꢓꢄꢎꢓ "#ꢉ!#ꢊ"&ꢈ#ꢇꢔ
ꢀꢁꢂꢃꢄ ꢓꢃꢎ "#ꢋ ꢊ"&ꢈ#ꢇꢔ
ꢀ
#!ꢉꢌ"ꢜꢋ!ꢑꢅ!ꢊꢂ ꢔꢊꢗꢕꢀꢁꢂꢃꢙꢕꢀꢚꢚꢐꢘ
ꢇꢋꢌ#!ꢊꢆꢇ ꢎꢏꢁꢀꢊꢗꢕꢀꢁꢒ ꢘ
ꢇꢋꢌ#!ꢊ"&#ꢇꢔꢊꢆꢇ ꢎꢏꢚꢀ
ꢗꢕꢀꢁꢂꢃꢙꢕꢀꢚꢚꢐꢘ
ꢀꢁꢂꢃꢀ
ꢓ
ꢓ
ꢀꢁꢒ ꢀ ꢓ
ꢀꢁꢂꢃꢀ ꢓ
!ꢅꢆꢉ(ꢊꢆ!ꢂꢏꢎꢂꢂꢁꢃꢊꢗꢚꢄꢎꢐꢁꢉꢘꢊ
ꢗꢕꢀꢁꢒ ꢘ
!ꢅꢆꢉ(ꢊꢆ!ꢂꢏꢎꢂꢂꢁꢁꢊꢗꢂꢀꢎꢚꢀꢉꢘ
ꢗꢕꢀꢁꢂꢃꢙꢕꢀꢚꢚꢐꢘ
ꢀꢁꢂꢃꢄ ꢓꢃꢎꢓ "#ꢋ ꢊ"&ꢈ#ꢇꢔ
ꢀꢁꢂꢃꢄ ꢂ
ꢅꢑꢅ!ꢕꢅꢌꢇ(ꢊ"#ꢋ ꢊ"&ꢈ#ꢇꢔ
ꢂ
ꢚ
ꢚ
ꢀꢁꢂꢃꢀ ꢂ
ꢀꢁꢒ ꢄ
ꢀꢁꢂꢃꢄ
ꢜ$"ꢅꢊꢚꢉꢊ
ꢂꢓ
ꢂꢂ
ꢂꢄ
ꢀꢁꢂꢃꢄ ꢂꢓ &ꢈ!ꢅꢊꢇꢋꢆ$ꢑꢌ
ꢀꢁꢂꢃꢄ ꢂꢂ ꢇꢋꢑ $#ꢅ!
ꢀꢁꢂꢃꢄ ꢂꢀ ꢋ&ꢅ!ꢊꢈꢌꢏꢈꢇꢉ#ꢈꢋꢌꢊꢆꢈꢕꢔ#
ꢚ
ꢚ
ꢋ%ꢅ!ꢆꢏꢊ!ꢅꢆꢉ(ꢊꢆ!ꢂꢏꢎ ꢓꢐꢊꢗꢕꢀꢁꢒ ꢘ
ꢋ%ꢅ!ꢆꢋꢉꢏꢊ!ꢅꢆꢉ(ꢊꢆ!ꢂꢏꢎꢀꢄꢐꢊ
ꢗꢕꢀꢁꢂꢃꢙꢕꢀꢚꢚꢐꢘ
ꢄꢄꢃ6 #/.6%23)/. 0!243
ꢎ'ꢃꢄꢄꢅꢏ'ꢃꢇꢀꢈ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
!ꢅꢆꢉ(ꢊꢆ!ꢂꢏꢎꢂꢂꢓꢓꢊꢗ ꢒꢎꢓꢁꢉꢘ
ꢓꢎ
ꢀꢁꢂꢃꢀ ꢓꢎ
ꢚꢎ
ꢀꢁꢂꢃꢀ ꢚꢎ
!ꢅꢆꢉ(ꢊꢆ!ꢂꢏꢎꢀꢒꢐꢊꢗ ꢛꢐꢎꢓꢛꢁꢉꢘ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"),"
Download from Www.Somanuals.com. All Manuals Search And Download.
3ANDING -OTOR $IAGRAM
ꢀꢁ
ꢀꢁꢄ
ꢀꢁꢅ
ꢀꢁꢂ
ꢀꢆꢆ
ꢀꢁꢃ
ꢀꢈꢁ
ꢀꢁꢆ
ꢀꢇꢀ
ꢀꢈꢀ
ꢀꢇꢈ
ꢀꢈꢇ
ꢀꢁꢂꢃ
ꢀꢁꢂꢃꢏꢅꢆꢇꢁꢈꢉꢀꢅꢊꢋꢌꢍꢎ
ꢀꢁꢂꢃꢄꢅꢆꢇꢁꢈꢉꢀꢅꢊꢋꢌꢍꢎ
ꢀ ꢁ
ꢅꢀ ꢄ
ꢀꢈꢂ
ꢀꢈꢄ
ꢀꢄꢀ
ꢀꢈꢅ
ꢀꢈꢆ
ꢀꢏꢐ
ꢀꢏꢏ
ꢅꢀ ꢀ
ꢀꢀꢃ
ꢀꢁꢂꢃꢀ
ꢀꢁꢂꢃꢈ
ꢀꢁꢈ
ꢀꢁꢁ
ꢀꢀꢈ
ꢀꢀꢆ
ꢀꢀꢅ
ꢀꢁꢂ
ꢀꢈꢆ
ꢀꢇꢄ
ꢀꢇꢁ
ꢀꢀꢁ
ꢀꢇ
ꢀꢇꢆ
ꢀꢇꢅ
ꢀꢇꢆ
ꢀꢀꢂ
ꢀꢀ
ꢀꢀꢇ
ꢀꢇꢂ
ꢀꢀꢀ
")-"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀ
!ꢀꢁꢂꢃ ꢀ
!ꢀꢁꢂꢃ ꢀꢑ
!ꢀꢁꢂꢃ ꢀꢂ
!ꢉꢀꢖ
!ꢀꢁꢂꢃ ꢀꢁ
!ꢎ'ꢀꢒ
!ꢏꢑꢔ
!'ꢀ
!ꢀꢁꢒ ꢀꢃ
!ꢀꢁꢂꢃ ꢔꢂ
ꢄꢅꢆꢇꢈꢉꢊꢋꢌ"ꢅꢄꢊ
ꢄ $ "ꢋꢏꢅ#ꢊ
ꢄ $ "ꢋꢏꢅ#ꢊꢋꢇꢈꢉꢐꢊ
ꢇꢊ(ꢋꢉ%$ꢋ ꢗꢑꢓ ꢑ
ꢏꢅ#ꢊꢋꢅꢘꢙ%#$ꢄꢊꢉ$ꢋ" ꢘ
ꢎ ꢆꢕꢋ'ꢅ#ꢇꢊ"ꢋ ꢗꢑ
ꢇꢊ(ꢋꢏ ꢎ$ꢋꢂꢗꢍꢓ ꢖꢋ(ꢋ ꢋ ꢗꢔ
ꢌꢎꢅ$ꢋ'ꢅ#ꢇꢊ"ꢋ ꢗꢑ
ꢄ $ "ꢋ ꢀꢇ!ꢋ !ꢇꢋꢚꢐꢀꢁꢒ ꢛ
ꢄ $ "ꢋ ꢁꢇ!ꢋꢂ!ꢇꢋꢚꢐꢀꢁꢂꢃꢋꢜꢋꢐꢀꢔꢔꢖꢛ
'ꢈ"ꢈꢉꢐꢋꢏ (ꢋꢚꢐꢀꢁꢒ ꢛ
'ꢈ"ꢈꢉꢐꢋꢏ (ꢋꢚꢐꢀꢁꢂꢃꢋꢜꢋꢐꢀꢔꢔꢖꢛ
ꢍ
ꢃ
!ꢀꢁꢂꢃ
!&ꢅꢒ
!ꢀꢁꢂꢃ ꢑ
!'ꢀꢑ
!ꢏꢑ
!ꢀꢁꢂꢃ ꢑꢔ
!#ꢏꢀꢁ
!ꢀꢁꢂꢃ ꢑꢖ
!ꢀꢁꢂꢃ ꢑꢒ
!#ꢀꢔ
ꢍ
!%ꢎꢎꢊ)ꢋꢏ%#ꢇꢈꢉꢐ
&ꢓꢏꢊꢎ$ꢋꢅꢓꢒ ꢋꢔꢎꢒ ꢀ
ꢏ"ꢅꢕꢊꢋꢏ"ꢅꢆꢕꢊ$
ꢌꢎꢅ$ꢋ'ꢅ#ꢇꢊ"ꢋꢂꢗꢍ
ꢇꢊ(ꢋꢏ ꢎ$ꢋꢂꢗꢍꢓ ꢖꢋ(ꢋꢂꢗꢔ
ꢌꢎꢅ$ꢋꢇꢊꢅꢘꢋꢉ%$
ꢀꢑ
ꢀꢂ
ꢀꢔ
ꢀꢁ
ꢀꢖ
ꢀꢒ
ꢀꢍ
ꢀꢃ
ꢀꢃ
ꢑ
ꢑꢑ
ꢑꢂ
ꢑꢔ
ꢑꢁ
ꢑꢖ
ꢑꢒ
ꢑꢍ
ꢑꢃ
ꢂꢀ
ꢂ
ꢂꢑ
ꢂꢂ
ꢂꢔ
ꢂꢁ
ꢂꢖ
ꢂꢒ
ꢂꢍ
ꢔꢀ
ꢔ
ꢆꢅ!ꢋ#ꢆ"ꢊ'ꢋ ꢗꢔꢓꢑꢀꢋ(ꢋꢂꢗꢔ
ꢎꢈꢄꢈ$ꢋ#'ꢈ$ꢆꢇ
ꢎꢈꢄꢈ$ꢋ#'ꢈ$ꢆꢇꢋ!ꢎꢅ$ꢊ
!ꢇꢎ!ꢋꢇꢘꢋ#ꢆ"ꢋ ꢗꢔꢓꢑꢀꢋ(ꢋ ꢗꢑ
ꢌꢎꢅ$ꢋ'ꢅ#ꢇꢊ"ꢋ ꢗꢔ
ꢆꢅ!ꢋ#ꢆ"ꢊ'ꢋꢁꢗ ꢖꢓ ꢍꢋ(ꢋꢂꢗꢔ
ꢆ &ꢊ"
ꢌꢎꢅ$ꢋꢇꢘꢋ#ꢆ"ꢋꢄꢖꢓ ꢋ(ꢋꢑꢁ
ꢏ"ꢅꢕꢊꢋꢅ"ꢏ "
ꢎ ꢆꢕꢋ'ꢅ#ꢇꢊ"ꢋꢂꢗꢍ
ꢏ"ꢅꢕꢊꢋ!ꢈꢉ
ꢇꢊ(ꢋꢉ%$ꢋꢂꢗꢍꢓ ꢖ
ꢆꢅ!ꢋ#ꢆ"ꢊ'ꢋꢄꢁꢓꢝꢍꢋ(ꢋ ꢁ
ꢏ"ꢅꢕꢊꢋꢎꢈꢉꢈꢉꢐ
ꢆ ꢄ!ꢎꢊ$ꢊꢋꢏ"ꢅꢕꢊꢋꢅ##)ꢝꢋ
ꢏ"ꢅꢕꢊꢋ#!"ꢈꢉꢐ
ꢏ"ꢅꢕꢊꢋꢈꢉ#ꢈꢘꢊꢋ!ꢈꢊꢆꢊ
ꢎ ꢆꢕꢋ'ꢅ#ꢇꢊ"ꢋ ꢗꢔ
ꢀꢃꢓ !ꢀꢁꢒ ꢀꢃꢓ
ꢀꢃꢓ !ꢀꢁꢂꢃ ꢔꢂꢓ
ꢀꢃꢓꢑ !ꢀꢁꢒ ꢀꢃꢓꢑ #ꢝꢋꢆꢅ!ꢅꢆꢈ$ "ꢋꢚꢐꢀꢁꢒ ꢛ
ꢀꢃꢓꢂ !ꢀꢁꢒ ꢀꢃꢓꢂ "ꢝꢋꢆꢅ!ꢅꢆꢈ$ "ꢋꢚꢐꢀꢁꢒ ꢛ
ꢀꢃꢓꢔ !ꢀꢁꢒ ꢀꢃꢓꢔ ꢌꢅꢉꢋꢆ &ꢊ"ꢋꢚꢐꢀꢁꢒ ꢛ
ꢀꢃꢓꢔ !ꢀꢁꢂꢃ ꢔꢂꢓ
ꢀꢃꢓꢁ !ꢀꢁꢒ ꢀꢃꢓꢁ ꢌꢅꢉꢋꢚꢐꢀꢁꢒ ꢛ
ꢀꢃꢓꢁ !ꢀꢁꢂꢃ ꢔꢂꢓꢑ ꢌꢅꢉꢋꢚꢐꢀꢁꢂꢃꢋꢜꢋꢐꢀꢔꢔꢖꢛ
ꢀ
!'ꢀꢖ
!#ꢏꢀꢒ
!ꢀꢁꢂꢃ ꢂ
!ꢌꢇ ꢑꢄ
!ꢀꢁꢂꢃ ꢂꢂ
!ꢎ'ꢀꢔ
!ꢀꢁꢂꢃ ꢂꢁ
!ꢉꢀꢍ
!#ꢏ ꢀꢄ
!ꢀꢁꢂꢃ ꢂꢍ
!ꢀꢁꢂꢃ ꢔꢀ
!ꢀꢁꢂꢃ ꢔ
!ꢀꢁꢂꢃ ꢔꢑ
!ꢎ'ꢀꢑ
ꢌꢅꢉꢋꢆ &ꢊ"ꢋꢚꢐꢀꢁꢂꢃꢋꢜꢋꢐꢀꢔꢔꢖꢛ
!ꢀꢁꢂꢃ
!#ꢏꢀꢍ
!ꢎ'ꢀ
!ꢀꢁꢂꢃ
!ꢏꢀꢂ
ꢀ
ꢂ
ꢖ
!%ꢎꢎꢊ)
ꢆꢅ!ꢋ#ꢆ"ꢊ'ꢋꢁꢗ ꢖꢓ ꢍꢋ*ꢋ ꢋ ꢗꢑ
ꢎ ꢆꢕꢋ'ꢅ#ꢇꢊ"ꢋꢁꢗ ꢖ
ꢄ $ "ꢋꢕꢊ)
ꢇꢊ(ꢋꢏ ꢎ$ꢋꢁꢗ ꢖꢓ ꢍꢋ(ꢋ
ꢎ ꢆꢕꢋ'ꢅ#ꢇꢊ"ꢋꢁꢗ ꢖ
ꢏ"ꢅꢕꢊ
ꢑ
ꢂ
ꢔ
ꢁ
ꢖ
ꢔꢑ
ꢔꢔ
!ꢎ'ꢀ
!ꢀꢁꢂꢃ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
")."
Download from Www.Somanuals.com. All Manuals Search And Download.
4ABLE ,IFT 3YSTEM $IAGRAM
ꢀꢈꢆ
ꢀꢈꢀ
ꢀꢈꢃ
ꢀꢈꢅ
ꢀꢅꢂ
ꢀꢅꢊ
ꢀꢅꢀ
ꢀꢅꢆ
ꢀꢊꢄ
ꢀꢅꢈ
ꢀꢅꢁ
ꢀꢃꢀ
ꢀꢅꢃ
ꢀꢅ
ꢀꢅꢄ
ꢀꢃꢃ
ꢀꢃꢄ
ꢀꢃꢁ
ꢀꢃ
ꢀꢃꢂ
ꢀꢀꢀ
ꢀꢈꢄ
ꢀꢀꢀ
ꢀꢀꢅ
ꢀꢀꢃ
ꢀꢀꢄ
ꢀ ꢂꢇꢆ
ꢀꢃ
ꢀꢆꢁ
ꢀꢀꢁ
ꢀꢀꢈ
ꢀꢀ
ꢀꢁ
ꢀꢃꢄ
ꢀꢆꢆ
ꢀꢃꢅ
ꢀ ꢂꢇꢀ
ꢀꢁꢂ
ꢀꢊ
ꢀꢁꢃ
ꢀꢊꢅ
ꢀꢆꢂ
ꢀꢆꢃ
ꢀꢀꢊ
ꢀꢆꢈ
ꢀ ꢂꢉ
ꢀꢆꢅ
ꢀꢆꢀ
ꢀꢆꢃ
ꢀꢁꢆ
ꢀꢁꢃ
ꢀꢆꢁ
ꢉꢀꢁꢁꢉ
ꢀꢆꢄ
ꢀ ꢂꢇꢃ
ꢀꢃꢀ
ꢀꢃꢁ
ꢀꢃꢇ
ꢀꢁꢅ
ꢀꢃꢀ
ꢀ ꢃ
ꢀꢁꢈ
ꢀ ꢅ
ꢀ ꢈ
ꢀ ꢁ
ꢀꢁꢊ
ꢀꢃꢃ
ꢀꢃꢆ
ꢀ ꢂꢇꢄ
ꢀ
ꢀ ꢆ
ꢉꢀꢁꢂ
ꢀ ꢄ
ꢀ ꢁ
ꢀ ꢀ
"*%"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢅꢆ'ꢇꢈ$#ꢇꢅꢉ$"ꢊꢈꢋꢇ
ꢐꢉꢑ$ꢎꢈꢇꢈ$#
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
&ꢉ!ꢎꢇꢋꢆꢏ!
ꢒꢆꢏ!ꢊꢈꢋꢇꢐꢏ
ꢐꢏ ꢇ"ꢐ!ꢆ&ꢇꢁꢓꢌꢔ ꢀꢇ'ꢇꢂꢓꢕ
ꢅꢏꢈꢖꢇ&ꢅꢆꢆꢑ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢂꢓꢁꢘꢔꢁꢕꢇ'ꢇꢃꢓꢌ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢂꢓꢁꢘ
%ꢔꢒꢆꢑ#ꢇꢏꢔꢃꢍꢇꢌꢑꢃꢍꢀꢇꢙꢋꢀꢂꢃꢄꢓꢋꢀꢌꢌꢘꢚ
%ꢔꢒꢆꢑ#ꢇꢏꢔꢃꢘꢇꢌꢑꢃꢘꢀꢇꢙꢋꢀꢂꢍꢁꢚ
"ꢆ#ꢇ"ꢐ!ꢆ&ꢇꢁꢓꢌꢔ ꢀꢇ'ꢇꢁꢓ
ꢗꢆ(ꢇꢌꢇ'ꢇꢌꢇ'ꢇꢁꢘ
ꢀꢁ
ꢀ
ꢀꢂꢃꢄ ꢀꢁ
ꢀꢂꢃꢄ ꢀ
ꢂꢁꢁꢀꢍ
!ꢁ ꢎ
ꢑ&ꢀꢌ
ꢀꢂꢃꢄ ꢀꢘ
ꢀꢂꢃꢄ ꢀꢍ
ꢀꢂꢃꢄ ꢀꢕ
ꢒꢀꢍ
ꢀꢂꢃꢄ ꢁꢁ
ꢑ&ꢀꢁ
ꢒꢀꢍ
ꢑ&ꢀꢁ
ꢈꢀ
ꢌꢍ
ꢌꢄ
ꢂꢀ
ꢂꢁ
ꢂꢃ
ꢂꢌ
ꢂꢂ
ꢂꢂ
ꢂꢘ
ꢂꢍ
ꢂꢕ
ꢂꢕ
ꢂꢄ
ꢘꢀ
ꢘꢁ
ꢘ
ꢀꢂꢃꢄ ꢌꢍ
ꢀꢂꢃꢄ ꢌꢄ
"ꢒꢀꢁ
ꢀꢂꢃꢄ ꢂꢁ
ꢒꢀꢍ
ꢑ&ꢀꢁ
%ꢏꢃꢍ
%ꢏꢃꢘ
ꢀꢃ
ꢀꢌ
ꢀꢂ
ꢀꢘ
ꢀꢍ
ꢀꢕ
ꢀꢄ
ꢁꢁ
ꢁ
ꢁꢌ
ꢁꢂ
ꢁꢘ
ꢁꢕ
ꢀ
#ꢅ!$"#ꢇꢒꢆꢏ!ꢊꢈꢋꢇꢂꢁꢁꢀꢍ
ꢆ'#ꢇ!ꢆ#ꢏꢊꢈꢊꢈꢋꢇ!ꢊꢈꢋꢇꢃꢂꢎꢎ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢃꢓꢕ
" !ꢉꢐꢗꢆ#ꢇ&ꢅꢆꢆꢑ
ꢆꢑꢆ%ꢏ#ꢊꢉꢈꢇ"ꢑꢊꢖꢆ
ꢖ$"#ꢇꢒꢉꢉ#
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢂꢓꢁꢘꢔꢁꢕꢇ'ꢇꢃꢓꢌ
ꢐꢅꢏꢊꢈ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢂꢓꢁꢘ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢂꢓꢁꢘꢔꢁꢕꢇ'ꢇꢃꢓꢌ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢂꢓꢁꢘ
ꢅꢆ'ꢇꢈ$#ꢇꢂꢓꢁꢘꢔꢁꢕ
""ꢀꢍ
ꢗꢃꢍꢎ
ꢀꢂꢍꢁ ꢂꢕ
ꢀꢂꢃꢄ ꢂꢕ
ꢑ&ꢀ
ꢒꢕꢄ
ꢒꢃꢁ
$ꢑꢑꢆ(ꢇꢙꢋꢀꢂꢍꢁꢚ
$ꢑꢑꢆ(ꢇꢙꢋꢀꢂꢃꢄꢓꢋꢀꢌꢌꢘꢚ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢁꢓꢌ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢁꢓ ꢔꢁ ꢇ'ꢇꢌꢇꢁꢓ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢁꢓꢌꢔ ꢀꢇ'ꢇꢁ
ꢅꢆ'ꢇꢈ$#ꢇꢁꢓꢌꢔ ꢀ
ꢛꢑꢏ#ꢇ&ꢏ"ꢅꢆ!ꢇꢁꢓ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢁꢓ
ꢅꢆ'ꢇꢈ$#ꢇꢁꢓ ꢔꢁ
ꢏꢖꢜ$"#ꢎꢆꢈ#ꢇ!ꢉꢖ
ꢎꢉ#ꢉ!ꢇꢒꢏ"ꢆ
ꢈꢀꢕ
ꢅꢆ'ꢇꢈ$#ꢇꢃꢓꢕꢔꢁꢘ
" !ꢉꢐꢗꢆ#ꢇ&ꢅꢆꢆꢑ
&ꢅꢆꢆꢑꢇ!ꢉꢖ
ꢀꢂꢃꢄ
ꢀꢂꢃꢄ
&ꢀ
ꢀ
ꢁ
ꢈꢀꢂ
ꢁ
ꢘꢃ
ꢘꢌ
ꢘꢂ
ꢘꢘ
ꢘꢍ
ꢘꢕ
ꢘꢕ
&ꢀꢁ
ꢑ&ꢀꢍ
ꢈꢀꢘ
ꢀꢂꢃꢄ ꢘꢘ
ꢀꢂꢃꢄ ꢘꢍ
ꢀꢂꢃꢄ ꢘꢕ
ꢀꢂꢍꢁ ꢘꢕ
ꢛꢑꢏ#ꢇ&ꢏ"ꢅꢆ!ꢇꢃꢓꢕ
ꢒꢏꢑꢑꢇꢒꢆꢏ!ꢊꢈꢋꢇꢘꢀꢀꢃ))
" !ꢉꢐꢗꢆ#ꢇ"ꢅꢏꢛ#
"&ꢊ#ꢐꢅꢇ ꢑꢏ#ꢆ
ꢛꢑꢏ#ꢇ&ꢏ"ꢅꢆ!ꢇꢁꢓꢌ
ꢅꢑ ꢇꢅꢖꢇ"ꢐ!ꢇꢎꢃꢔꢝꢂꢇ'ꢇꢃꢂ
!ꢉ'ꢊꢎꢊ#(ꢇ"&ꢊ#ꢐꢅ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢁꢓ ꢔꢁ ꢇ'ꢇ ꢇꢁꢓ
$ꢑꢑꢆ(
ꢌ
ꢂ
ꢘ
ꢍ
ꢄ
ꢘꢀꢀꢃ
ꢀꢂꢃꢄ
ꢀꢂꢃꢄ
&ꢀꢘ
"ꢄꢍꢎ
ꢂ
ꢘ
ꢎꢉ#ꢉ!ꢇꢁꢓꢌꢅ ꢇꢃ ꢅꢇꢙꢋꢀꢂꢃꢄꢓꢋꢀꢌꢌꢘꢚ
ꢎꢉ#ꢉ!ꢇꢁꢓꢃꢅ ꢇꢁ ꢅꢇꢙꢋꢀꢂꢍꢁꢚ
ꢃꢀ
ꢃꢁ
ꢃ
ꢀꢂꢃꢄ ꢃꢀ
ꢒꢁꢄꢃ
ꢀꢂꢃꢄ ꢃ
ꢈꢀꢍꢎ
ꢀꢂꢃꢄ ꢃꢌ
ꢘꢀꢀ
"ꢒꢃꢁ
""ꢀꢍ
ꢀꢂꢃꢄ ꢃꢄ
ꢀꢂꢃꢄ ꢌꢁ
ꢘꢀꢀꢂ
ꢘꢕꢔꢁ ꢀꢂꢃꢄ ꢘꢕꢔꢁ ꢆꢑꢆꢐ#!ꢊꢐꢏꢑꢇꢒꢉ'ꢇꢇꢙꢋꢀꢂꢃꢄꢓꢋꢀꢌꢌꢘꢚꢇ
ꢘꢕꢔꢁ ꢀꢂꢍꢁ ꢘꢕꢔꢁ ꢆꢑꢆꢐ#!ꢊꢐꢏꢑꢇꢒꢉ'ꢇꢙꢋꢀꢂꢍꢁꢚ
ꢘꢕꢔ ꢀꢂꢃꢄ ꢘꢕꢔ
ꢘꢕꢔ ꢀꢂꢍꢁ ꢘꢕꢔ
ꢘꢕꢔꢃ ꢀꢂꢃꢄ ꢘꢕꢔꢃ ꢛꢏꢈꢇꢐꢉ%ꢆ!ꢇꢙꢋꢀꢂꢃꢄꢓꢋꢀꢌꢌꢘꢚ
ꢘꢕꢔꢃ ꢀꢂꢍꢁ ꢘꢕꢔꢃ ꢎꢉ#ꢉ!ꢇꢛꢏꢈꢇꢐꢉ%ꢆ!ꢇꢙꢋꢀꢂꢍꢁꢚ
ꢘꢕꢔꢌ ꢀꢂꢍꢁ ꢘꢕꢔꢌ ꢐꢏ ꢏꢐꢊ#ꢉ!ꢇꢙꢋꢀꢂꢍꢁꢚ
ꢛꢏꢈꢇꢙꢋꢀꢂꢃꢄꢓꢋꢀꢌꢌꢘꢚ
ꢛꢏꢈꢇꢙꢋꢀꢂꢍꢁꢚ
ꢃꢃ
ꢃꢌ
ꢃꢂ
ꢃꢍ
ꢃꢕ
ꢃꢄ
ꢌꢁ
ꢌ
ꢅꢆ'ꢇꢈ$#ꢇꢎꢃꢔꢝꢂ
ꢒꢆꢏ!ꢊꢈꢋꢇꢐꢏ
ꢒꢏꢑꢑꢇꢒꢆꢏ!ꢊꢈꢋꢇꢘꢀꢀ )
ꢐꢏ ꢇ"ꢐ!ꢆ&ꢇꢁꢀꢔ ꢌꢇ'ꢇꢂꢓꢕ
"ꢆ#ꢇ"ꢐ!ꢆ&ꢇꢁꢓꢌꢔ ꢀꢇ'ꢇꢁꢓ
ꢆꢑꢆ%ꢏ#ꢊꢉꢈꢇꢋꢆꢏ!ꢇꢒꢉ'
&ꢉ!ꢎꢇꢋꢆꢏ!
ꢒꢏꢑꢑꢇꢒꢆꢏ!ꢊꢈꢋꢇꢘꢀꢀꢂ)
ꢐꢏ ꢇ"ꢐ!ꢆ&ꢇꢁꢓꢌꢔ ꢀꢇ'ꢇꢃꢓꢌ
ꢒꢆꢏ!ꢊꢈꢋꢇꢐꢏ
ꢍꢀ
ꢍꢁ
ꢍ
ꢒꢁ
ꢑ&ꢀꢁ
&ꢀꢍ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢂꢓꢁꢘꢔꢁꢕꢇ'ꢇꢁꢇꢁꢓꢌ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢂꢓꢁꢘ
ꢛꢑꢏ#ꢇ&ꢏ"ꢅꢆ!ꢇꢂꢓꢁꢘ
ꢆꢑꢆ%ꢏ#ꢊꢉꢈꢇ"ꢐ!ꢆ&
&ꢅꢆꢆꢑꢇꢏꢖꢜ$"#ꢆ!ꢇ
" !ꢉꢐꢗꢆ#ꢇ&ꢅꢆꢆꢑ
ꢅꢆ'ꢇꢒꢉꢑ#ꢇꢃꢓꢕꢔꢁꢘꢇ'ꢇꢁ
ꢑꢉꢐꢗꢇ&ꢏ"ꢅꢆ!ꢇꢁꢓꢌ
ꢍꢃ
ꢍꢌ
ꢄꢀ
ꢄꢌ
ꢄꢘ
ꢀꢂꢃꢄ ꢍꢃ
ꢀꢂꢃꢄ ꢍꢌ
ꢀꢂꢃꢄ ꢄꢀ
ꢒꢁꢕ
ꢌꢃ
ꢌꢌ
ꢌꢂ
ꢌꢘ
"ꢒꢀꢂ
ꢀꢂꢃꢄ ꢌꢌ
ꢗꢁꢌ
ꢗꢆ(ꢇꢂꢓꢁꢘꢇ'ꢇꢂꢓꢁꢘꢇ'ꢇꢃꢓꢌ
ꢗꢆ(ꢇꢌꢇ'ꢇꢌꢇ'ꢇ ꢀ
ꢗꢌꢕꢎ
ꢑ&ꢀ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"*&"
Download from Www.Somanuals.com. All Manuals Search And Download.
#ONVEYOR 3YSTEM $IAGRAM
ꢀ
ꢂꢃꢄ
ꢂꢂꢅ
ꢀꢈ
ꢀꢈ ꢉꢆ
ꢂꢃꢃ
ꢊꢁꢄ ꢆ
ꢂꢃꢂ
ꢋꢌꢍꢎ
ꢂꢃꢆ
ꢂꢃꢉ
ꢂꢂꢃ
ꢂꢃꢈ
ꢂꢉꢇ
ꢂꢉꢈ
ꢂꢃꢇ
ꢂꢂꢄ
ꢂꢉꢉ
ꢂꢉ
ꢂꢂꢃ
ꢂꢂꢉ
ꢂꢅꢂ
ꢀꢁꢈ
ꢂꢂꢂ
ꢂꢂꢇ
ꢀꢈꢁ
ꢂꢂꢃ
ꢂꢂꢈ
ꢀꢆꢇ
ꢂꢂꢆ
ꢂꢂꢃ
ꢂꢂꢄ
ꢂꢃꢅ
ꢀꢁꢆ
ꢂꢂꢊ
ꢀꢁꢄ
ꢂꢃꢊ
ꢀꢈꢆ
ꢂꢂꢅ
ꢂꢉꢄ
ꢀꢁꢂ
ꢀꢁ
ꢂꢊ
ꢂꢊꢆ
ꢀꢁꢅ
ꢂꢊꢈ
ꢂꢊꢅ
ꢂꢊꢊ
ꢂꢊꢉ
ꢂꢊꢂ
ꢀꢁꢃ
ꢂꢊꢇ
ꢂꢊꢃ
ꢂꢅꢄ
"*'"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ
ꢀꢁ
ꢃꢁꢄꢀꢅꢀꢁꢂ
ꢃꢁꢄꢀꢅꢀꢁ
ꢃꢁꢄꢀꢅꢀꢁꢀ
ꢃꢁꢄꢀꢅꢀꢁꢒ
ꢃꢁꢄꢀꢅꢀꢁꢄ
ꢃꢁꢄꢀꢅꢀꢁꢓ
ꢃ!ꢂꢁ
ꢃ!ꢁꢒ
ꢃꢇꢅꢄ
ꢃꢁꢄꢀꢅꢀꢂꢁ
ꢃ ꢓꢁꢓ
ꢃ ꢂꢄꢋ
"ꢆꢇꢈꢉ
ꢕꢌꢖ$ꢉ'ꢌ ꢍꢇꢉꢈ"
ꢌ#"ꢗꢉꢉꢘꢍ ꢌꢈꢈꢉ
ꢗ ꢌꢖ"ꢍꢇ ꢆꢛꢉꢍꢕꢌ$ꢉ
ꢚꢖꢗꢉꢉꢘꢍ ꢌꢈꢈꢉ ꢍꢇ ꢆꢕꢛꢉ"
ꢈꢚꢋꢚ"ꢍ!%ꢚ"ꢕꢎ
ꢀ ꢊ
ꢀ ꢊ
ꢃꢁꢄꢀꢅꢀ ꢊ
ꢃꢁꢄꢊꢂꢀ ꢊ
ꢋꢌ"ꢌ ꢍꢂꢎꢃꢍꢂꢃꢎꢍꢏꢐꢁꢄꢀꢅꢑꢐꢁꢒꢒꢓꢔ
ꢋꢌ"ꢌ ꢍꢂꢎꢃꢍꢂꢃꢎꢍꢏꢐꢁꢄꢊꢂꢔ
ꢀꢁꢀ
ꢀꢁꢒ
ꢀꢁꢄ
ꢀꢁꢓ
ꢀꢁꢊ
ꢀꢁꢜ
ꢀꢁꢅ
ꢀꢂꢁ
ꢀꢂꢂ
ꢀꢂ
ꢀꢂꢀ
ꢀꢂꢒ
ꢀꢂꢄ
ꢀꢂꢓ
ꢀꢂꢊ
ꢀꢂꢜ
ꢀꢂꢅ
ꢀ ꢁ
ꢀ ꢂ
ꢀ
ꢀ ꢊꢙꢂ ꢃꢁꢄꢊꢂꢀ ꢊꢙꢂ ꢕꢆꢃꢆꢕꢚ"ꢌ ꢍꢏꢐꢁꢄꢊꢂꢔ
ꢀ ꢜ
ꢀ ꢅ
ꢀꢀꢁ
ꢀꢀꢂ
ꢀꢀ
ꢀꢀꢀ
ꢀꢀꢒ
ꢀꢀꢄ
ꢀꢀꢓ
ꢀꢀꢊ
ꢀꢀꢅ
ꢀꢒꢁ
ꢀꢒꢂ
ꢀꢒ
ꢀꢒꢀ
ꢀꢒꢒ
ꢀꢒꢄ
ꢀꢒꢓ
ꢀꢒꢊ
ꢀꢒꢅ
ꢃꢇꢀ ꢋ
ꢃꢇꢁꢊꢋ
ꢃꢈ%ꢁꢒꢋ
ꢃꢁꢄꢀꢅꢀꢀꢂ
ꢃꢛꢓꢓꢋ
ꢃꢇꢂꢜ
ꢃꢈ%ꢁꢒ
ꢃ%ꢁ
ꢎꢉ&ꢍꢇꢌꢈ"ꢍꢋꢂꢁꢙꢂꢝꢄꢍ(ꢍ ꢄ
ꢎꢉ&ꢍꢇꢌꢈ"ꢍꢋꢜꢙꢂꢝ ꢄꢍ&ꢍ ꢄ
ꢈꢌꢕꢛꢍ%ꢆ!ꢎꢉ ꢍꢜꢋꢋ
ꢃꢈ#ꢐ
ꢃꢎꢈꢃꢍꢎꢘꢍ!ꢕ ꢍꢂꢁꢙ ꢒꢍ(ꢍꢂꢍꢂꢑ
ꢃꢎꢈꢃꢍꢎꢘꢍ!ꢕ ꢍꢂꢑꢒꢙ ꢁꢍ&ꢍꢂꢑ
ꢎꢉ&ꢍꢇꢌꢈ"ꢍꢂꢑ ꢙꢂ ꢍ&ꢍꢀ
ꢚꢖꢗꢉꢉꢘꢍ ꢌꢈꢈꢉ ꢍ!ꢎꢆꢗ"
ꢇꢆꢈꢈꢍꢇꢉꢆ ꢚꢖꢐꢍꢓ ꢁꢓꢙ !
ꢉ&"ꢍ ꢉ"ꢆꢚꢖꢚꢖꢐꢍ ꢚꢖꢐꢍꢀꢁꢋꢋ
ꢕꢆꢃꢍ!ꢕ ꢉ%ꢍꢄꢑꢂꢓꢙꢂꢜꢍ&ꢍ
ꢃꢌ!ꢚ"ꢚꢌꢖꢚꢖꢐꢍ%ꢎꢉꢉꢈ
ꢚꢖꢗꢉꢉꢘꢍ ꢌꢈꢈꢉ ꢍꢇ ꢆꢕꢛꢉ"
ꢕꢆꢃꢍ!ꢕ ꢉ%ꢍꢀꢑꢜꢙꢂꢓꢍ&ꢍꢀꢑꢒ
ꢈꢌꢕꢛꢍ%ꢆ!ꢎꢉ ꢍꢄꢑꢂꢓ
ꢎꢉ&ꢍꢖ#"ꢍꢄꢑꢂꢓꢙꢂꢜ
ꢕꢆꢃꢍ!ꢕ ꢉ%ꢍꢂꢑꢒꢙ ꢁꢍ&ꢍꢂꢍꢂꢑ
ꢉꢈꢉ$ꢆ"ꢚꢌꢖꢍꢈꢚꢋꢚ"ꢉ
ꢚꢖꢗꢉꢉꢘꢍ ꢌꢈꢈꢉ
ꢎꢉ&ꢍꢇꢌꢈ"ꢍꢀꢑꢜꢙꢂꢓꢍ&ꢍꢂꢍꢂꢑꢒ
ꢇꢉꢆ ꢚꢖꢐꢍꢕꢆꢃꢍ
ꢛꢉ'ꢍꢊꢍ&ꢍꢊꢍ&ꢍꢄꢄ
ꢎꢉ&ꢍꢇꢌꢈ"ꢍꢀꢑꢜꢙꢂꢓꢍ&ꢍꢂ
ꢈꢌꢕꢛꢍ%ꢆ!ꢎꢉ ꢍꢀꢑꢜ
ꢗꢈꢆ"ꢍ%ꢆ!ꢎꢉ ꢍꢀꢑꢜ
ꢐꢉꢆ ꢇꢌ&ꢍꢃꢈꢆ"ꢉ
ꢇꢉꢆ ꢚꢖꢐꢍ#ꢕꢗ ꢁꢄ
ꢎꢉ&ꢍꢇꢌꢈ"ꢍꢀꢑꢜꢙꢂꢓꢍ&ꢍꢂꢍꢂꢑ
ꢕ#!ꢎꢚꢌꢖ
ꢃꢁꢄꢀꢅꢀꢀꢓ
ꢃꢁꢄꢀꢅꢀ ꢓ
ꢃꢇꢂꢓ
ꢃ!ꢇꢊꢁ
ꢃꢁꢄꢀꢅꢀꢂꢒ
ꢃꢁꢄꢀꢅꢀꢂꢄ
ꢃ!ꢇꢂꢓ
ꢃꢈ%ꢁꢂ
ꢃꢖꢁ
ꢃꢁꢄꢀꢅꢀꢒꢁ
ꢃꢁꢄꢀꢅꢀꢒꢂ
ꢃꢈ%ꢁꢓꢋ
ꢃꢁꢄꢀꢅꢀꢒꢀ
ꢃꢁꢄꢀꢅꢀꢒꢒ
ꢃꢁꢄꢀꢅꢀꢒꢄ
ꢃꢁꢄꢀꢅꢀꢒꢓ
ꢃꢁꢄꢀꢅꢀꢒꢊ
ꢃꢁꢄꢀꢅꢀꢒꢅ
ꢉꢘ#ꢕꢉ
ꢈꢌꢕꢛꢍ%ꢆ!ꢎꢉ ꢍꢂꢁꢋꢋ
!ꢃꢉꢉꢘꢍ#ꢖꢚ"ꢍꢇꢆ!ꢉꢍꢃꢈꢆ"ꢉ
ꢘ ꢚ$ꢉꢖꢍꢃ#ꢈꢈꢉ'
ꢘ ꢚ$ꢚꢖꢐꢍꢃ#ꢈꢈꢉ'
"ꢚꢋꢚꢖꢐꢍꢇꢉꢈ"
ꢃ!ꢇꢓ
ꢃꢁꢄꢀꢅꢀ ꢁ
ꢃꢁꢄꢀꢅꢀ ꢂ
ꢃꢇ ꢒ
ꢃꢁꢄꢀꢅꢀ ꢄ
ꢃꢁꢄꢀꢅꢀ ꢓ
!ꢃꢉꢉꢘꢍ#ꢖꢚ"ꢍꢕꢌ$ꢉ
!ꢃꢉꢕꢚꢆꢈꢍ!ꢕ ꢍꢋꢜꢙꢂꢝ ꢄꢍ&ꢍ ꢁ
ꢀ ꢄ
ꢀ ꢓ
ꢇꢉꢆ ꢚꢖꢐꢍ#ꢕꢗ ꢁꢄ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"*("
Download from Www.Somanuals.com. All Manuals Search And Download.
5PPER 2OLLER 3YSTEM $IAGRAM
)%+
)%*
)%)
)%(
)%'
)%(
)%.
)%-
)**
)%*
)%+
)*+
))'
)%&
)*(
)*'
)%)
)*,
)*-
)..
)++
)*&
)).
)%.
)%-
))-
)),
)&%
)&&
)*%
)*'
)'(
).-
).."(
).."*
)&'
)&)
)&,
)+.
)+-
)&(
).."-
))*
)+-
).."&
).."'
)+,
)..")
).."+
)..",
)'&
)+)
)+(
)&*
)&+
))(
))&
)',
)'+
))'
)(,
)((
)'*
)('
)&-
)+*
)&.
)+(
)+-
)(+
)(*
)'-
)'%
)'&
))'
)+,
)+-
)')
)('
)()
)(&
)((
)''
)'(
)()
ꢀ<%))+ꢁDcanꢂ
)''
"*)"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀ ꢁ
ꢀ ꢑ
ꢀ ꢃ
ꢀ ꢀ
ꢀ ꢂ
ꢀ ꢓ
ꢀ ꢕ
ꢀ ꢄ
ꢀꢁ
ꢀꢁꢁ
ꢀꢁꢑ
ꢀꢁꢃ
ꢀꢁꢀ
ꢀꢁꢂ
ꢀꢁꢓ
ꢀꢁꢌ
ꢀꢁꢕ
ꢀꢁꢄ
ꢀꢑ
ꢀꢑꢁ
ꢀꢑꢑ
ꢀꢑꢑ
ꢀꢑꢃ
ꢀꢑꢀ
ꢀꢑꢂ
ꢀꢑꢓ
ꢀꢑꢌ
ꢀꢑꢕ
ꢀꢃꢁ
ꢀꢃꢑ
ꢀꢃꢃ
ꢀꢃꢀ
ꢀꢃꢀ
ꢀꢃꢂ
ꢀꢃꢓ
" ꢂꢃꢄꢀ ꢁ
" ꢂꢃꢄꢀ ꢑ
" ꢂꢃꢄꢀ ꢃ
" ꢂꢃꢄꢀ ꢀ
" ꢂꢃꢄꢀ ꢂ
" ꢂꢃꢄꢀ ꢓ
"%ꢈꢁꢓ
'""ꢅ$ꢆ$!ꢇꢇꢅ$ꢆꢈ$ꢉꢊꢋꢅ&
'""ꢅ$ꢆ$!ꢇꢇꢅ$ꢆ
'""ꢅ$ꢆ$!ꢇꢇꢅ$ꢆꢈ$ꢉꢊꢋꢅ&
ꢈꢅꢉ$ꢍ ꢖꢆ'ꢊꢊꢑ ꢂ
%ꢅ&ꢆ%ꢊ$ꢅ)ꢆꢎꢓꢔꢁꢆ*ꢆꢓ
ꢗꢍꢇ&ꢅ$
ꢊꢉ"ꢆ%ꢊ$ꢅ)ꢆꢃꢒꢕꢔꢁꢓꢆ*ꢆꢃꢒꢀ
ꢇ!ꢊꢋꢆ)ꢉ%ꢏꢅ$ꢆꢃꢒꢕ
ꢀꢃꢌ
ꢀꢀꢁ
ꢀꢀꢑ
ꢀꢀꢃ
ꢀꢀꢂ
ꢀꢀꢌ
ꢀꢀꢕ
ꢀꢀꢄ
ꢀꢂ
ꢀꢂꢁ
ꢀꢂꢑ
ꢀꢂꢃ
ꢀꢂꢂ
ꢀꢂꢓ
ꢀꢂꢌ
ꢀꢂꢕ
ꢀꢓꢃ
ꢀꢓꢃ
ꢀꢓꢀ
ꢀꢓꢂ
ꢀꢓꢓ
ꢀꢓꢌ
ꢀꢓꢕ
ꢀꢓꢄ
ꢀꢄꢕ
ꢀꢄꢄ
" ꢂꢃꢄꢀꢃꢌ
" ꢂꢃꢄꢀꢀꢁ
"%ꢈ ꢌ
" ꢂꢃꢄꢀꢀꢃ
" ꢂꢃꢄꢀꢀꢂ
" ꢌ
"$ ꢂꢎ
" ꢑꢎ
" ꢂꢃꢄꢀꢂ
" ꢂꢃꢄꢀꢂꢁ
") ꢁ
"ꢇꢉ%&ꢍꢊꢆꢇꢍꢎꢍ&ꢆ%)ꢍ&ꢊꢏꢆ$!ꢐ
ꢉꢍ$ꢆꢊ+ꢇꢍ ꢐꢅ$
ꢊꢉ"ꢆ%ꢊ$ꢅ)ꢆꢂꢒꢁꢓꢔꢁꢕꢆ*ꢆꢃꢒꢀ
ꢈꢉ%ꢅ
ꢊꢉ"ꢆ%ꢊ$ꢅ)ꢆꢂꢒꢁꢓꢔꢁꢕꢆ-ꢆꢁꢆꢁꢒꢑ
ꢏꢅ*ꢆ '&ꢆꢁ ꢔꢑꢀ
ꢅ*&ꢆ$ꢅ&ꢉꢍ ꢍ ꢖꢆ$ꢍ ꢖꢆꢁꢂꢎꢎ
ꢏꢅ*ꢆ '&ꢆꢎꢁ ꢔꢁꢘꢂ
' ꢍ(ꢅ$%ꢉꢇꢆꢙ!ꢍ &ꢆꢗ!$ꢋ
ꢇ!ꢊꢋꢍ ꢖꢆꢊꢇꢅ(ꢍ%
ꢗꢇꢉ&ꢆ)ꢉ%ꢏꢅ$ꢆꢁꢒꢑ
ꢊꢉ"ꢆ%ꢊ$ꢅ)ꢆꢁꢒꢑꢔꢁꢑꢆ*ꢆꢃꢆꢁꢒꢑ
ꢗ$ꢉꢎꢅ
&$ꢍꢎꢎꢍ ꢖꢆ%ꢊ$ꢅ)
ꢅꢊꢊꢅ &$ꢍꢊꢆ$!ꢐ
"ꢇ) ꢀ
" ꢂꢃꢄꢀꢁ
" ꢂꢃꢄꢀꢁꢁ
"%ꢈꢃꢃ
&ꢏ$!&&ꢇꢅꢆ(ꢉꢇ(ꢅꢆ
&ꢏ$!&&ꢇꢅꢆ(ꢉꢇ(ꢅꢆꢈꢉ%ꢅ
ꢊꢉ"ꢆ%ꢊ$ꢅ)ꢆꢁ ꢔꢑꢀꢆ-ꢆꢃꢒꢀ
"ꢏꢇ"ꢆꢏꢐꢆ%ꢊ$ꢆꢎꢀꢔꢘꢌꢆ*ꢆꢑ
ꢉꢇ'ꢎꢍ 'ꢎꢆꢐꢍ%ꢊ
ꢉꢇ'ꢎꢍ 'ꢎꢆ"ꢇꢉ&ꢅ
"ꢇꢉ&ꢅ
"%ꢂꢑꢎ
"%ꢈꢌꢄ
" ꢂꢃꢄꢀꢁꢀ
" ꢂꢃꢄꢀꢁꢂ
" ꢂꢃꢄꢀꢁꢓ
" ꢌ
" ꢂꢃꢄꢀꢁꢕ
" ꢂꢃꢄꢀꢁꢄ
" ꢂꢃꢄꢀꢑ
"% ꢀ
" ꢂꢃꢄꢀꢑꢑ
" ꢀꢀꢓꢀꢑꢑ
"ꢇ) ꢌ
"ꢈꢂꢃ
" ꢁꢁ
" ꢂꢃꢄꢀꢑꢓ
" ꢂꢃꢄꢀꢑꢌ
" ꢂꢃꢄꢀꢑꢕ
" ꢂꢃꢄꢀꢃꢁ
" ꢂꢃꢄꢀꢃꢑ
" ꢂꢃꢄꢀꢃꢃ
" ꢀꢀꢓꢀꢃꢀ
" ꢂꢃꢄꢀꢃꢀ
" ꢂꢃꢄꢀꢃꢂ
" ꢂꢃꢄꢀꢃꢓ
" ꢂꢃꢄꢀꢂꢂ
" ꢂꢃꢄꢀꢂꢓ
" ꢂꢃꢄꢀꢂꢌ
" ꢂꢃꢄꢀꢂꢕ
" ꢀꢀꢓꢀꢓꢃ
" ꢂꢃꢄꢀꢓꢃ
"ꢈꢁꢕ
ꢏꢅ*ꢆ '&ꢆꢁ ꢔꢑꢀ
ꢅꢊꢊꢅ &$ꢍꢊ
!ꢍꢇꢆꢊꢉ"ꢆꢊ! ꢅꢊ&!$
%ꢏꢉꢗ&ꢆ!ꢗꢆ!ꢍꢇꢆꢊꢉ"
!ꢍꢇꢆꢊꢉ"
"ꢏꢇ"ꢆꢏꢐꢆ%ꢊ$ꢆꢁꢒꢀꢔꢑ ꢆ*ꢆꢁꢒꢑ
ꢗ$ꢉꢎꢅꢆ%ꢅꢉꢇꢚꢆꢛ$ꢜꢆꢛꢖ ꢂꢃꢄꢒꢖ ꢀꢀꢓꢜ
ꢗ$ꢉꢎꢅꢆ%ꢅꢉꢇꢚꢆꢛ$ꢜꢆꢛꢖ ꢀꢀꢓꢜ
ꢇ!ꢊꢋꢆ)ꢉ%ꢏꢅ$ꢆꢁꢒꢑ
ꢗ$ꢉꢎꢅꢆ%ꢅꢉꢇꢚꢆꢛꢇꢜꢆꢛꢖ ꢀꢀꢓꢜ
ꢗ$ꢉꢎꢅꢆ%ꢅꢉꢇꢚꢆꢛꢇꢜꢆꢛꢖ ꢂꢃꢄꢆꢝꢆꢖ ꢂꢌꢁꢜ
ꢏꢅ*ꢆꢈ!ꢇ&ꢆꢃꢒꢕꢔꢁꢓꢆ*ꢆꢁ
ꢇ!ꢊꢋꢆ)ꢉ%ꢏꢅ$ꢆꢃꢒꢕ
"ꢇ) ꢀ
" ꢂꢃꢄꢓꢁꢑꢕ "!)ꢅ$ꢆ!ꢗꢗꢆ"ꢇꢉ&ꢅ
"ꢈ ꢌ
"ꢇ) ꢁ
") ꢌ
" ꢓ
ꢏꢅ*ꢆꢈ!ꢇ&ꢆꢂꢒꢁꢓꢔꢁꢕꢆ*ꢆꢃꢒꢀ
ꢇ!ꢊꢋꢆ)ꢉ%ꢏꢅ$ꢆꢂꢒꢁꢓ
ꢗꢇꢉ&ꢆ)ꢉ%ꢏꢅ$ꢆꢂꢒꢁꢓ
ꢏꢅ*ꢆ '&ꢆꢁꢒꢑꢔꢁꢑ
ꢏꢅ*ꢆꢈ!ꢇ&ꢆꢁꢒꢑꢔꢁꢑꢆ*ꢆꢁ
ꢏꢅ*ꢆ '&ꢆꢃꢒꢕꢔꢑꢀ
ꢉꢍ$ꢆ !,,ꢇꢅꢆꢛꢗꢅꢎꢉꢇꢅꢜ
ꢉꢍ$ꢆꢊ+ꢇꢍ ꢐꢅ$ꢆꢈ$ꢉꢊꢋꢅ&
ꢉꢍ$ꢆ$ꢅꢊꢅꢍ(ꢅ$ꢆꢛꢎꢉꢇꢅꢜ
ꢇꢍꢎꢍ&ꢆ%)ꢍ&ꢊꢏꢆꢏ!ꢇꢐꢅ$
ꢇꢍꢎꢍ&ꢆ%)ꢍ&ꢊꢏꢆ&'ꢈꢅ
ꢇꢍꢎꢍ&ꢆ%)ꢍ&ꢊꢏꢆ)ꢒꢊꢅ$ꢉꢎꢍꢊꢆ&ꢍ"
%#'ꢉ$ꢅꢆꢗ$ꢉꢎꢅꢆꢛꢖ ꢀꢀꢓꢜ
%#'ꢉ$ꢅꢆꢗ$ꢉꢎꢅꢆꢛꢖ ꢂꢃꢄꢒꢖ ꢀꢀꢓꢜ
ꢏ!ꢇꢐꢅ$ꢆꢛꢇꢆ&+"ꢅꢜ
" ꢂꢃꢄꢀꢄꢄ
ꢐꢍꢉ"ꢏ$ꢉꢎꢆꢉ%%+
ꢀꢄꢄꢔꢁ " ꢂꢃꢄꢀꢄꢄꢔꢁ "'%ꢏ$!ꢐꢆꢊ!(ꢅ$
ꢀꢄꢄꢔꢑ " ꢂꢃꢄꢀꢄꢄꢔꢑ ꢊ!ꢎ"$ꢅ%%ꢍ! ꢆ%"$ꢍ ꢖ
ꢀꢄꢄꢔꢃ " ꢂꢃꢄꢀꢄꢄꢔꢃ "'%ꢏ$!ꢐ
ꢀꢄꢄꢔꢀ " ꢂꢃꢄꢀꢄꢄꢔꢀ ꢐꢍꢉ"ꢏ$ꢉꢎ
ꢀꢄꢄꢔꢂ " ꢂꢃꢄꢀꢄꢄꢔꢂ %"ꢅꢊꢍꢉꢇꢆ%ꢊ$ꢅ)
ꢀꢄꢄꢔꢓ "ꢄꢄꢕ ꢓꢃꢁꢂ "ꢇꢉ&ꢅ
ꢀꢄꢄꢔꢌ " ꢂꢃꢄꢀꢄꢄꢔꢌ $ꢅꢉ$ꢆꢏ!'%ꢍ ꢖ
ꢀꢄꢄꢔꢕ "%ꢈꢃꢃ
ꢊꢉ"ꢆ%ꢊ$ꢅ)ꢆꢁ ꢔꢑꢀꢆ-ꢆꢃꢒꢀ
ꢇꢍꢎꢍ&ꢆ%)ꢍ&ꢊꢏ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"**"
Download from Www.Somanuals.com. All Manuals Search And Download.
"ELT /SCILLATION 3YSTEM $IAGRAM
ꢂꢃꢄ
ꢂꢃꢇ
ꢂꢃꢉ
ꢂꢃꢆ
ꢂꢅꢄ
ꢂꢄ
ꢂꢅꢂ
ꢂꢃꢈ
ꢂꢃꢂ
ꢂꢄꢊ
ꢂꢃꢅ
ꢂꢆꢈ
ꢂꢅꢅ
ꢂꢅꢇ
ꢀꢁ
ꢂꢅꢊ
ꢂꢅꢆ
ꢂꢃꢊ
ꢂꢅꢈ
ꢂꢆꢅ
ꢂꢃ
ꢂꢄ
ꢂꢅꢃ
ꢂꢆꢂ
ꢂꢆꢉ
ꢂꢅꢊ
ꢂꢄꢈ
ꢂꢄꢃ
ꢂꢄꢉ
ꢂꢆꢄ
ꢂꢆꢆ
ꢂꢄꢆ
ꢂꢄꢅ
ꢂꢅ
ꢂꢄꢄ
ꢂꢄꢂ
ꢂꢅꢉ
ꢂꢄꢇ
ꢂꢆ
"*+"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ
ꢀꢁꢑ
ꢀꢁ
ꢃꢁꢀ ꢄꢀꢁꢂ
ꢃꢁꢀ ꢄꢀꢁꢑ
ꢃꢁꢀ ꢄꢀꢁ
ꢃꢁꢀ ꢄꢀꢁꢓ
ꢃꢁꢀ ꢄꢀꢁꢀ
ꢃꢁꢀ ꢄꢀꢁꢘ
ꢃꢇꢑꢑ
ꢃꢁꢀ ꢄꢀꢁꢗ
ꢃꢁꢀ ꢄꢀꢁꢄ
ꢃꢁꢀ ꢄꢀꢂꢁ
ꢃꢁꢀ ꢄꢀꢂꢂ
ꢃꢁꢀ ꢄꢀꢂꢑ
ꢃꢁꢀ ꢄꢀꢂ
ꢃꢁꢀ ꢄꢀꢂꢓ
ꢃꢁꢀ ꢄꢀꢂꢀ
ꢃꢁꢀ ꢄꢀꢂꢘ
ꢃꢁꢀ ꢄꢀꢂꢙ
ꢃꢁꢀ ꢄꢀꢂꢗ
ꢃꢅꢆꢇꢇ ꢅꢆꢈꢅꢆꢉ ꢊꢋꢌꢍꢅ
ꢃꢇꢒꢈꢉꢋ ꢉꢆ
ꢎꢅꢍꢏ$ꢆꢈꢐꢍꢏꢏꢆꢐꢌꢍꢅꢈ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢋꢒꢅꢈꢇ"ꢒꢌꢐꢕ
ꢀꢂꢄ
ꢀꢑꢁ
ꢀꢑꢂ
ꢀꢑꢑ
ꢀꢑ
ꢀꢑꢓ
ꢀꢑꢀ
ꢀꢑꢙ
ꢀꢑꢗ
ꢀꢑꢄ
ꢀ ꢂ
ꢀ ꢑ
ꢀ
ꢃꢁꢀ ꢄꢀꢂꢄ
ꢃꢁꢀ ꢄꢀꢑꢁ
ꢃꢁꢀ ꢄꢀꢑꢂ
ꢃꢁꢀ ꢄꢀꢑꢑ
ꢃꢁꢀ ꢄꢀꢑ
ꢃꢁꢀ ꢄꢀꢑꢓ
ꢃꢁꢀ ꢄꢀꢑꢀ
ꢃꢁꢀ ꢄꢀꢑꢙ
ꢃꢁꢀ ꢄꢀꢑꢗ
ꢃꢁꢀ ꢄꢀꢑꢄ
ꢃꢁꢀ ꢄꢀ ꢂ
ꢃꢁꢀ ꢄꢀ ꢑ
ꢃꢁꢀ ꢄꢀ
ꢎꢅꢍꢏ$ꢆꢈꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢋꢒꢅꢈꢇ"ꢒꢌꢐꢕꢈꢂꢖꢗ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢎ ꢔꢔꢆꢅꢈꢜꢎꢅꢍꢏ$ꢆꢝ
ꢃꢊꢋꢇꢌꢒꢐꢈꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢔꢊꢆ#ꢒꢎꢊꢆꢈꢕꢍꢇꢆ
ꢀꢁꢓ
ꢀꢁꢀ
ꢀꢁꢘ
ꢀꢁꢙ
ꢀꢁꢗ
ꢀꢁꢄ
ꢀꢂꢁ
ꢀꢂꢂ
ꢀꢂꢑ
ꢀꢂ
ꢀꢂꢓ
ꢀꢂꢀ
ꢀꢂꢘ
ꢀꢂꢙ
ꢀꢂꢗ
ꢆꢊꢎꢍ"
ꢃꢕꢊꢃꢈꢕꢚꢈꢇꢐꢅꢈꢂꢁꢛꢑꢓꢈ%ꢈꢀꢖꢗ
ꢇꢍꢊꢍꢏꢍꢒꢚꢈ!ꢋꢊ!ꢆ
ꢇꢍꢊꢆꢏꢍꢒꢚꢈ!ꢋꢊ!ꢆ
ꢌꢕꢅꢍꢌꢌꢊꢆꢈ!ꢋꢊ!ꢆ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢎꢅꢍꢏ$ꢆꢈꢆꢊꢎꢍ"
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢐꢍꢏꢏꢆꢐꢌꢍꢅ
ꢀ ꢀ
ꢀ ꢘ
ꢀ ꢙ
ꢀ ꢗ
ꢃꢁꢀ ꢄꢀ ꢀ
ꢃꢁꢀ ꢄꢀ ꢘ
ꢃꢁꢀ ꢄꢀ ꢙ
ꢃꢁꢀ ꢄꢀ ꢗ
ꢏꢆꢆꢚꢊꢆꢈ!ꢋꢊ!ꢆ
ꢃꢊꢋꢇꢌꢒꢐꢈꢐꢍꢏꢏꢆꢐꢌꢍꢅ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"*,"
Download from Www.Somanuals.com. All Manuals Search And Download.
&EEDꢀ $RUMꢀ AND 0RESSURE 2OLLER $IAGRAM
ꢀꢂꢄ
ꢀ ꢃ
ꢀ ꢅ
ꢀ ꢇ
ꢀ ꢂ
ꢉꢆꢇꢇꢀꢊꢋꢌꢍꢎ
ꢀ ꢈ
ꢀꢂꢀ
ꢀ ꢁ
ꢀ ꢀ
ꢀ
ꢀꢂꢃ
ꢀ ꢆ
ꢀ ꢅ
ꢀ ꢇ
ꢀꢂ
ꢀꢆꢇ
ꢀꢆꢅ
ꢀ ꢃ
ꢀꢂꢇ
ꢀ ꢄ
ꢀꢂꢅ
ꢀꢆꢀ
ꢀꢁꢃ
ꢀꢆꢃ
ꢀꢆ
ꢀ ꢁ
ꢀꢂꢂ
ꢀꢆꢈ
ꢀꢆꢁ
ꢀꢂꢁ
ꢀꢂꢆ
ꢀ ꢇ
ꢀꢁꢁ
ꢀ ꢆ
ꢀꢆꢂ
ꢀꢁꢅ
ꢀꢁꢂ
ꢀꢃꢄ
ꢀꢃꢇ
ꢀꢀꢀ
ꢀꢅꢁ
ꢀꢇ
ꢀꢁꢆ
ꢀꢆꢄ
ꢀꢃꢅ
ꢀꢇꢂ
ꢀꢅꢀ
ꢀꢅ
ꢀꢅꢆ
ꢀꢀꢀ
ꢀꢃꢃ
ꢀꢁ
ꢀꢁꢂ
ꢀꢅꢇ
ꢀꢅꢅ
ꢀꢅꢂ
ꢀꢁꢄ
ꢀꢇꢆ
ꢀꢇꢁ
ꢀꢅꢄ
ꢀꢅꢈ
ꢀꢃꢂ
ꢀꢃꢈ
ꢀꢃꢁ
ꢀꢃꢇ
ꢀꢇꢃ
ꢀꢅꢁ
ꢀꢇꢇ
ꢀꢇꢄ
ꢀꢇꢈ
ꢀꢇꢂ
ꢀꢇ
ꢀꢇꢀ
ꢀꢀꢅ
ꢀꢅꢃ
ꢀꢀꢄ
ꢀꢄꢆ
ꢀꢁꢅ
ꢀꢀꢁ
ꢀꢀꢀ
ꢀꢀꢅ
ꢀꢁꢇ
ꢀꢀꢇ
ꢀꢀꢅ
ꢀꢁꢆ
ꢀꢀꢃ
ꢀꢁꢈ
ꢀꢁꢁ
ꢀꢁꢀ
ꢀꢁꢂ
ꢀꢁꢄ
ꢀꢁ
"*-"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ
ꢀꢁ
ꢃꢁꢄꢅꢆꢀꢁꢂ
ꢃꢁꢄꢅꢆꢀꢁ
ꢃꢀꢁꢁꢅ
ꢃꢁꢄꢅꢆꢀꢁꢐ
ꢃ!!ꢁꢅ
ꢃ!ꢂꢂ
ꢃꢉꢁ
ꢃꢒꢂ
ꢃꢋ%ꢁꢂ
ꢃꢁꢄꢅꢆꢀꢂꢁ
ꢃꢁꢄꢅꢆꢀꢂꢂ
ꢃ!ꢒꢁꢄ
ꢃꢁꢄꢅꢆꢀꢂꢅ
ꢃꢁꢄꢅꢆꢀꢂꢄ
ꢃꢁꢄꢅꢆꢀꢂꢑ
ꢃ!ꢒꢁꢐ
ꢃꢁꢄꢅꢆꢀ ꢂ
ꢃꢁꢄꢅꢆꢀ
ꢃꢁꢄꢅꢆꢀ ꢅ
ꢃ!!ꢁꢘ
ꢃꢁꢄꢅꢆꢀ ꢄ
ꢃꢁꢄꢅꢆꢀ ꢘ
ꢃꢀ ꢁꢄꢎ
ꢃꢁꢄꢅꢆꢀꢅꢁ
ꢃꢁꢄꢅꢆꢀꢅꢂ
ꢃꢁꢄꢅꢆꢀꢅ
ꢃ!ꢁꢂ
ꢃꢇ!"ꢈꢉꢊ ꢈꢋꢋꢌ ꢊ!ꢍꢎꢏ"
ꢃꢇ!"ꢈꢉꢊ ꢈꢋꢋꢌ
ꢀꢐꢑ
ꢀꢐꢘ
ꢀꢐꢆ
ꢀꢄꢁ
ꢀꢄꢂ
ꢀꢄ
ꢀꢄꢅ
ꢀꢄꢐ
ꢀꢄꢄ
ꢀꢄꢀ
ꢀꢄꢑ
ꢀꢄꢘ
ꢀꢄꢆ
ꢀꢀꢁ
ꢀꢀꢂ
ꢀꢀ
ꢀꢀꢅ
ꢀꢀꢄ
ꢀꢀꢀ
ꢀꢀꢑ
ꢀꢑꢁ
ꢀꢑꢂ
ꢀꢑ
ꢀꢑꢅ
ꢀꢑꢐ
ꢀꢑꢄ
ꢀꢑꢀ
ꢀꢑꢑ
ꢀꢑꢘ
ꢀꢑꢆ
ꢀꢘꢁ
ꢀꢘꢂ
ꢀꢘ
ꢃꢁꢄꢅꢆꢀꢐꢑ
ꢃꢁꢄꢅꢆꢀꢐꢘ
ꢃꢁꢄꢅꢆꢀꢐꢆ
ꢃꢁꢄꢅꢆꢀꢄꢁ
ꢃꢁꢄꢅꢆꢀꢄꢂ
ꢃꢋ%ꢁꢑ
ꢒ ꢎꢓꢔꢌ"ꢊꢕꢏꢌꢖꢎꢋꢌꢗ
ꢃ ꢌ!!# ꢌꢊꢃꢋꢎ"ꢌ
ꢏꢌꢋ"
ꢙ ꢎꢃꢍꢇ"ꢌꢊꢃꢎꢚ
ꢃꢋ#ꢙꢊ ꢄꢊꢖꢖ
ꢀꢁꢅ
ꢀꢁꢐ
ꢀꢁꢄ
ꢀꢁꢀ
ꢀꢁꢑ
ꢀꢁꢘ
ꢀꢁꢆ
ꢀꢂꢁ
ꢀꢂꢂ
ꢀꢂ
ꢀꢂꢅ
ꢀꢂꢄ
ꢀꢂꢑ
ꢀꢂꢘ
ꢀ ꢂ
ꢀ
ꢀ ꢅ
ꢀ ꢐ
ꢀ ꢄ
ꢀ ꢘ
ꢀ ꢆ
ꢀꢅꢁ
ꢀꢅꢂ
ꢀꢅ
ꢀꢅꢅ
ꢀꢅꢐ
ꢀꢅꢄ
ꢀꢅꢀ
ꢀꢅꢑ
ꢀꢅꢘ
ꢀꢅꢆ
ꢀꢐꢁ
ꢀꢐꢂ
ꢀꢐ
ꢒꢎꢋꢋꢊꢒꢌꢎ ꢇꢉꢙꢊꢀꢁꢁꢂ((
!ꢍꢎꢏ"ꢊꢒꢌꢎ ꢇꢉꢙꢊꢓꢈꢋꢋꢎ
!ꢌ"ꢊ!ꢓ ꢌ%ꢊꢂꢛꢐꢜ ꢁꢊ&ꢊꢅꢛꢘ
ꢃꢍꢋꢃꢊꢍꢚꢊ!ꢓ ꢊꢄꢛꢂꢀꢜꢂꢘꢊ&ꢊꢂꢊꢂꢛꢐ
ꢍꢌ&ꢊꢉ#"ꢊꢄꢛꢂꢀꢜꢂꢘ
ꢍꢌ&ꢊꢒꢈꢋ"ꢊꢄꢛꢂꢀꢜꢂꢘꢊ&ꢊꢂꢊꢂꢛꢐ
ꢋꢈꢓꢔꢊ%ꢎ!ꢍꢌ ꢊꢄꢛꢂꢀ
ꢓꢈꢖꢃ ꢌ!!ꢇꢈꢉꢊ!ꢃ ꢇꢉꢙ
!ꢃꢌꢓꢇꢎꢋꢊꢃꢇꢉꢊꢂꢁꢖꢖ
ꢓꢎꢃꢊ!ꢓ ꢌ%ꢊꢂꢛꢐꢜ ꢁꢊ&ꢊꢅꢛꢐ
ꢃꢇ!"ꢈꢉꢊ!ꢇꢚꢌ ꢎꢇꢋ
ꢒꢌꢎ ꢇꢉꢙꢊꢊꢓꢎꢃ
ꢋꢈꢓꢔꢊ%ꢎ!ꢍꢌ ꢊꢂꢛ
ꢍꢌ&ꢊꢒꢈꢋ"ꢊꢂꢛ ꢜꢂ ꢊ&ꢊꢂꢊꢂꢛ
ꢃꢒꢐꢂ
ꢃꢁꢄꢅꢆꢄꢂꢁꢐ ꢒꢌꢎ ꢇꢉꢙꢊ#ꢓꢓ ꢁꢀ
ꢃꢁꢄꢅꢆꢀꢄꢄ
ꢃꢔꢂꢂ
ꢃꢋ%ꢁꢂ
ꢃ!ꢒꢂꢂ
ꢏꢎ!"ꢌꢉꢇꢉꢙꢊ"#ꢒꢌ
ꢔꢌ'ꢊꢄꢛꢂꢀꢊ&ꢊꢄꢛꢂꢀꢊ&ꢊꢂꢊꢅꢛꢂꢀ
ꢋꢈꢓꢔꢊ%ꢎ!ꢍꢌ ꢊꢄꢛꢂꢀ
ꢓꢎꢃꢊ!ꢓ ꢌ%ꢊꢄꢛꢂꢀꢜꢂꢘꢊ&ꢊꢂꢊꢂꢛꢐ
ꢃꢍꢋꢃꢊꢍꢚꢊ!ꢓ ꢊꢂꢛꢐꢜ ꢁꢊ&ꢊꢅꢛꢘ
ꢓꢈ$ꢌ ꢊꢈꢏꢊꢃ#ꢋꢋꢌ'
ꢃ#ꢋꢋꢌ'
ꢃ!ꢁꢑ
ꢃꢁꢄꢅꢆꢀꢀꢁ
ꢃꢁꢄꢅꢆꢀꢀꢂ
ꢃꢁꢄꢅꢆꢀꢀ
ꢃ!!ꢁ ꢖ
ꢍꢎꢉꢚꢋꢌ
ꢓꢎꢃꢊ!ꢓ ꢌ%ꢊꢂꢛꢐꢜ ꢁꢊ&ꢊꢂꢛ
ꢒꢌꢎ ꢇꢉꢙꢊꢍꢈ#!ꢇꢉꢙ
!ꢃꢌꢓꢇꢎꢋꢊ%ꢎ!ꢍꢌ
ꢍꢎꢉꢚꢋꢌ
!ꢌ"ꢊ!ꢓ ꢌ%ꢊꢄꢛꢂꢀꢜꢂꢘꢊ&ꢊꢂꢛ
ꢍꢎꢉꢚꢋꢌ
!ꢃꢎꢉꢉꢌ ꢊꢉ#"
ꢒꢎꢋꢋꢊꢒꢌꢎ ꢇꢉꢙꢊꢀ ꢁꢄꢜ !
ꢋꢌ$ꢌ ꢊ!ꢍꢎꢉꢔ
ꢒꢌꢎ ꢇꢉꢙꢊꢒ ꢎꢓꢔꢌ"ꢊꢃꢎꢚ
#ꢒꢒꢌ ꢊ ꢈꢋꢋꢌ
ꢃꢍꢋꢃꢊꢍꢚꢊ!ꢓ ꢊꢂꢁꢜ ꢐꢊ&ꢊꢂꢛ
!"ꢌꢌꢋꢊ ꢈꢋꢋꢌ ꢊ
ꢙ ꢌꢎ!ꢌꢊꢏꢇ""ꢇꢉꢙ
!ꢌ"ꢊ!ꢓ ꢌ%ꢊꢖꢀꢜꢂꢊ&ꢊꢀ
ꢃꢁꢄꢅꢆꢄ ꢁꢐ ꢒꢌꢎ ꢇꢉꢙꢊ#ꢓꢓ ꢁꢄ
ꢃꢁꢄꢅꢆꢀꢀꢀ
ꢃꢁꢄꢅꢆꢀꢀꢑ
ꢃꢁꢐꢐꢀꢀꢑꢁ
ꢃꢁꢐꢐꢀꢀꢑꢂ
ꢃꢁꢐꢐꢀꢀꢑ
ꢏꢇꢋ"ꢌ
ꢒꢌꢎ ꢇꢉꢙꢊꢍꢈ#!ꢇꢉꢙ
ꢎ&ꢋꢌꢊꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢌ ꢊꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢌ ꢊꢒ ꢎꢓꢔꢌ"ꢊꢊꢕꢙꢁꢐꢐꢀꢗ
ꢃꢁꢄꢅꢆꢄ ꢁꢐ ꢒꢌꢎ ꢇꢉꢙꢊ#ꢓꢓ ꢁꢄꢊꢊꢕꢙꢁꢐꢐꢀꢗ
ꢃ!!ꢁꢑ
ꢃ%ꢁꢐꢖ
ꢃꢁꢐꢐꢀꢀꢑꢀ
ꢃ ꢃꢂꢑꢖ
ꢃꢁꢐꢐꢀꢀꢑꢘ
ꢃꢉꢁ ꢖ
ꢃꢒꢂ
ꢃꢋ%ꢁꢂ
ꢃꢁꢐꢐꢀꢀꢘ
ꢃꢁꢐꢐꢀꢀꢘꢅ
ꢃꢁꢐꢐꢀꢀꢘꢐ
ꢃꢁꢐꢐꢀꢀꢘꢄ
ꢃꢁꢐꢐꢀꢀꢘꢀ
ꢃꢁꢄꢅꢆꢀꢘꢑ
ꢃꢁꢄꢅꢆꢀꢘꢘ
!ꢌ"ꢊ!ꢓ ꢌ%ꢊꢂꢛꢐꢜ ꢁꢊ&ꢊꢂꢛ
ꢏꢋꢎ"ꢊ%ꢎ!ꢍꢌ ꢊꢂꢁꢖꢖ
!"#ꢚꢊꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢊꢃꢇꢉꢊꢅꢝꢄꢊ&ꢊ ꢐ
ꢓꢈꢖꢃ ꢌ!!ꢇꢈꢉꢊ!ꢃ ꢇꢉꢙꢊꢊꢕꢙꢁꢐꢐꢀꢗ
ꢍꢌ&ꢊꢉ#"ꢊꢖꢂꢁꢜꢂꢝꢄ
ꢃꢁꢄꢅꢆꢀꢅꢐ
ꢃꢔꢅꢐꢖ
ꢃ!ꢒꢂꢀ
ꢔꢌ'ꢊꢄꢊ&ꢊꢄꢊ&ꢊ ꢁ
ꢓꢎꢃꢊ!ꢓ ꢌ%ꢊꢅꢛꢘꢜꢂꢀꢊ&ꢊꢅꢛꢐ
ꢏꢋꢎ"ꢊ%ꢎ!ꢍꢌ ꢊꢅꢛꢘ
ꢓꢈꢖꢃ ꢌ!!ꢇꢈꢉꢊ!ꢃ ꢇꢉꢙ
ꢏꢇ&ꢇꢉꢙꢊ!ꢍꢎꢏ"ꢊ
ꢃ%ꢁ
ꢍꢌ&ꢊꢒꢈꢋ"ꢊꢄꢛꢂꢀꢜꢂꢘꢊ&ꢊꢂꢊꢂꢛꢐꢊ
ꢋꢈꢓꢔꢊ%ꢎ!ꢍꢌ ꢊꢄꢛꢂꢀ
ꢃꢁꢄꢅꢆꢀꢅꢘ
ꢃꢁꢄꢅꢆꢀꢅꢆ
ꢃꢁꢄꢅꢆꢀꢐꢁ
ꢃ%ꢁꢑ
ꢃꢋꢎ"ꢌꢉꢊꢊꢕ ꢌꢎ ꢗꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢌ ꢊ"ꢈ%ꢌ ꢊꢕꢋꢏꢗꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢌ ꢊ"ꢈ%ꢌ ꢊꢕꢋ ꢗꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢌ ꢊ"ꢈ%ꢌ ꢊꢕ ꢗꢊꢕꢙꢁꢐꢐꢀꢗ
ꢈꢋꢋꢌ ꢊ"ꢈ%ꢌ ꢊꢕ ꢏꢗꢊꢕꢙꢁꢐꢐꢀꢗ
ꢃꢋꢎ"ꢌꢉꢊꢏ ꢈꢉ"ꢊꢕꢙꢁꢐꢐꢀꢗ
ꢃꢇ!"ꢈꢉꢊꢒ ꢎꢓꢔꢌ"
ꢍꢈ#!ꢇꢉꢙ
ꢀꢘꢅ
ꢀꢘꢐ
ꢀꢘꢄ
ꢀꢘꢀ
ꢀꢘꢑ
ꢀꢘꢘ
ꢏꢋꢎ"ꢊ%ꢎ!ꢍꢌ ꢊꢄꢛꢂꢀ
ꢍꢌ&ꢊꢒꢈꢋ"ꢊꢄꢛꢂꢀꢜꢂꢘꢊ&ꢊꢂ
ꢒ ꢎꢓꢔꢌ"ꢊꢕꢖꢎꢋꢌꢗ
"#ꢒꢌ
ꢃꢒꢁꢅ
ꢀꢐꢐ
ꢀꢐꢄ
ꢀꢐꢀ
ꢃꢁꢄꢅꢆꢀꢐꢐ
ꢃꢁꢄꢅꢆꢀꢐꢄ
ꢃꢁꢄꢅꢆꢀꢐꢀ
ꢒꢎ!ꢌ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"*."
Download from Www.Somanuals.com. All Manuals Search And Download.
#ABINET !SSEMBLY $IAGRAM
ꢂꢃꢇ
ꢂꢃꢅ
ꢂꢃꢄ
ꢂꢃꢆ
ꢂꢃꢈ
ꢂꢃꢉ
ꢂꢃꢂ
ꢂꢃ
ꢂꢈꢅ
ꢂꢈꢈ
ꢂꢈꢃ
ꢂꢃꢄ
ꢂꢃꢊ
"+%"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀ ꢁ ! ꢂꢂꢃꢀ ꢁ %!"ꢄꢅ"ꢆꢇꢈꢄꢉ &ꢈ"ꢄꢊꢋ ꢂꢂꢃꢌ
ꢀ ꢁ ! ꢐꢔꢕꢀ ꢁ %!"ꢄꢅ"ꢆꢇꢈꢄꢉ &ꢈ"ꢄꢊꢋ ꢐꢔꢕꢑꢋ ꢐꢀꢁꢌ
ꢀ ꢖ ! ꢐꢔꢕꢀ ꢖ ꢂꢗꢄꢘ%#$ꢄ! "$
ꢀ ꢀ !ꢍ ꢀ
ꢀ ꢓ !' ꢀ
ꢎꢈ(ꢄꢍ ꢏ$ꢄꢐꢑꢁꢃꢒꢁꢓꢄ(ꢄꢔꢑꢂ
ꢅꢏꢆ$ꢄ'ꢆ#ꢎꢈ"ꢄꢐꢑꢁꢃ
ꢀ ꢕ ! ꢂꢂꢃꢀ ꢕ "ꢙꢋꢎ$ꢄꢘ "ꢚꢄꢏ'"ꢄꢅ"ꢆꢇꢈꢄꢊꢋ ꢂꢂꢃꢌ
ꢀ ꢕ ! ꢐꢔꢕꢀ ꢕ "ꢛꢄꢘ "ꢚꢄꢏ'"ꢄꢅ"ꢆꢇꢈꢄꢊꢋ ꢐꢔꢕꢑꢋ ꢐꢀꢁꢌ
ꢀ ꢔ !#ꢁꢂꢇ
!ꢎꢏ!ꢄꢎꢘꢄ#ꢉ"ꢄꢇꢃꢒꢁꢄ(ꢄꢁꢖ
ꢀ ꢂ ! ꢂꢂꢃꢀ ꢂ ꢏꢈꢅ$ꢄꢘ "ꢄꢊꢋ ꢂꢂꢃꢌ
ꢀꢁ
!ꢅꢎ ꢔ
ꢅꢏꢆ$ꢄꢎꢘꢄ#ꢉ"ꢄꢁꢑꢂꢒꢖ ꢄ(ꢄꢁꢑꢖ
ꢀ ꢂ ! ꢐꢔꢕꢀ ꢂ ꢏꢈꢅ$ꢄꢘ "ꢚꢄꢊꢋ ꢐꢔꢕꢑꢋ ꢐꢀꢁꢌ
ꢀ ꢐ ! ꢂꢂꢃꢀ ꢐ "ꢙꢋꢎ$ꢄꢘ "ꢚꢄ%!"ꢄꢅ"ꢆꢇꢈꢄꢊꢋ ꢂꢂꢃꢌ
ꢀ ꢐ ! ꢐꢔꢕꢀ ꢐ "ꢙꢋꢎ$ꢄꢘ "ꢚꢄ%!!ꢈ"ꢄꢅ"ꢆꢇꢈꢄ
ꢀ ꢃ ! ꢐꢔꢕꢀ ꢃ ꢘ "ꢄꢏ ꢉꢝ
ꢀꢁꢁ ! ꢐꢔꢕꢀꢁꢁ ꢅ" ꢜ$ꢄ!ꢏꢆ$ꢈ
ꢀꢁꢖ ! ꢂꢂꢃꢀꢁꢖ ꢏꢈꢅ$ꢄꢘ "ꢚꢄꢏ'"ꢄꢅ"ꢆꢇꢈꢄꢊꢋ ꢂꢂꢃꢌ
ꢀꢁꢖ ! ꢐꢔꢕꢀꢁꢖ ꢘ "ꢚꢄꢏ'"ꢄꢅ"ꢆꢇꢈꢄꢊꢋ ꢐꢔꢕꢑꢋ ꢐꢀꢁꢌ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"+&"
Download from Www.Somanuals.com. All Manuals Search And Download.
4OOL "OX AND !CCESSORIES $IAGRAM
ꢀꢁꢀ
ꢀꢂꢊꢇꢇꢈꢉꢁꢄꢄꢊꢇꢋꢌꢍꢎꢏ
ꢀꢁꢃ
ꢀꢁꢂ
ꢀꢁꢄ
ꢀꢁꢅ
ꢀꢂꢅꢇꢈꢉꢁꢄꢄꢊꢇꢋꢌꢍꢎꢏ
ꢀꢁꢊ
ꢀꢂꢁ
ꢀꢁ
ꢀꢂꢂ
ꢀꢂꢃ
ꢀꢁꢆ
ꢀꢂꢀ
ꢀꢂꢆ
ꢀꢁꢐ
"+'"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
0ARTS ,IST
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ ꢃꢄꢀꢅꢆꢇ
ꢈꢁꢉꢊꢀꢋꢃꢅꢋꢌ
ꢀꢁꢂ
ꢀꢁꢑ
ꢀꢁ
ꢀꢁꢕ
ꢀꢁꢄ
ꢀꢁꢗ
ꢀꢁꢔ
ꢀꢁꢀ
ꢃꢁꢄ ꢅꢀꢁꢂ
ꢃꢁꢄ ꢅꢀꢁꢑ
ꢃꢁꢄ ꢅꢀꢁ
ꢃꢆꢇ"ꢈꢉꢊ ꢈꢋꢌ$ꢇꢆꢊ"ꢌꢌꢆ
ꢆꢐꢋꢐ"ꢊ!%ꢐ"ꢎꢒꢊ"#ꢓꢈ
"ꢌꢌꢆꢊꢓꢌ&
ꢀꢁꢅ
ꢀꢂꢁ
ꢀꢂꢂ
ꢀꢂꢑ
ꢀꢂ
ꢀꢂꢗ
ꢀꢂꢔ
ꢀꢂꢀ
ꢃꢁꢄ ꢅꢀꢁꢅ
ꢃ% ꢂꢔꢂꢅ
ꢃ% ꢂꢑꢂꢕ
ꢃ% ꢀꢂꢁ
ꢍꢆꢇ"ꢊ!ꢎ ꢈ%ꢏ ꢐ$ꢈ
% ꢈꢉꢎꢒꢊꢂꢔꢊ&ꢊꢂꢅ
% ꢈꢉꢎꢒꢊꢂꢑꢊ&ꢊꢂꢕ
% ꢈꢉꢎꢒꢊꢀꢊ&ꢊꢂꢁꢊ
ꢒꢈ&ꢊ% ꢈꢉꢎꢒꢊ!ꢈ"
!ꢇꢉꢏꢃꢇꢃꢈ ꢙꢊꢚꢂꢁꢁꢊꢛꢖꢁꢕꢕꢗꢜ
!ꢇꢉꢏꢃꢇꢃꢈ ꢙꢊꢚꢂꢀꢁꢊꢛꢖꢁꢕꢕꢗꢜ
ꢃꢒꢐꢆꢆꢐꢃ(!ꢊ!ꢎ ꢈ%ꢏ ꢐ$ꢈ
ꢃꢁꢄ ꢅꢁꢁꢁꢕ ꢍꢈꢆ"
ꢃꢁꢄ ꢅꢀꢁꢄ
ꢃꢁꢄ ꢅꢀꢁꢗ
ꢃꢁꢄ ꢅꢀꢁꢔ
ꢃꢁꢄ ꢅꢀꢁꢀ
ꢖ ꢇꢃꢒꢐ"ꢈꢊꢃꢇꢏ
ꢏꢌꢌ ꢊꢘꢈ'
!ꢇꢉꢏꢃꢇꢃꢈ ꢙꢊꢚꢂꢁꢁꢊꢛꢖꢁꢄ ꢅꢝꢖꢁꢄꢔꢂꢜ
!ꢇꢉꢏꢃꢇꢃꢈ ꢙꢊꢚꢂꢀꢁꢊꢛꢖꢁꢄ ꢅꢝꢖꢁꢄꢔꢂꢜ
ꢃꢁꢄ ꢅꢀꢂ
ꢃꢁꢕꢕꢗꢀꢂꢗ
ꢃꢁꢕꢕꢗꢀꢂꢔ
ꢃꢁꢄ ꢅꢀꢂꢀ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"+("
Download from Www.Somanuals.com. All Manuals Search And Download.
4ROUBLESHOOTING
39-04/-
0/33)",% #!53%
&#ꢀ AdlꢀkdaiV\Z#
#/22%#4)6% !#4)/.
Bdidgꢀl^aaꢀcdiꢀhiVgi#
&#ꢀ 8]ZX`ꢀedlZgꢀa^cZꢀ[dgꢀegdeZgꢀkdaiV\Z#
'#ꢀ DeZcꢀX^gXj^iꢀ^cꢀbdidgꢀdgꢀaddhZꢀXdc" '#ꢀ >cheZXiꢀ Vaaꢀ aZVYꢀ XdccZXi^dchꢀ dcꢀ bdidgꢀ [dgꢀ addhZꢀ dgꢀ deZcꢀ XdccZX"
cZXi^dch#
i^dch#
Bdidgꢀl^aaꢀcdiꢀhiVgi0ꢀ[jhZhꢀdgꢀ &#ꢀ H]dgiꢀX^gXj^iꢀ^cꢀa^cZꢀXdgYꢀdgꢀeaj\#
&#ꢀ >cheZXiꢀXdgYꢀdgꢀeaj\ꢀ[dgꢀYVbV\ZYꢀ^chjaVi^dcꢀVcYꢀh]dgiZYꢀl^gZh#
X^gXj^iꢀWgZV`ZghꢀWadl#
BdidgꢀdkZg]ZVih#
'#ꢀ H]dgiꢀX^gXj^iꢀ^cꢀbdidgꢀdgꢀaddhZꢀXdc" '#ꢀ >cheZXiꢀVaaꢀXdccZXi^dchꢀdcꢀbdidgꢀ[dgꢀaddhZꢀdgꢀh]dgiZYꢀiZgb^cVahꢀdgꢀ
cZXi^dch# ldgcꢀ^chjaVi^dc#
(#ꢀ >cXdggZXiꢀ [jhZhꢀ dgꢀ X^gXj^iꢀ WgZV`Zghꢀ (#ꢀ >chiVaaꢀXdggZXiꢀ[jhZhꢀdgꢀX^gXj^iꢀWgZV`Zgh#
^cꢀedlZgꢀa^cZ#
&#ꢀ BdidgꢀdkZgadVYZY#
&#ꢀ GZYjXZꢀadVYꢀdcꢀbdidg#
'#ꢀ 6^gꢀ X^gXjaVi^dcꢀ i]gdj\]ꢀ i]Zꢀ bdidgꢀ '#ꢀ 8aZVcꢀdjiꢀbdidgꢀidꢀegdk^YZꢀcdgbVaꢀV^gꢀX^gXjaVi^dc#
gZhig^XiZY#
Bdidgꢀ hiVaahꢀ ꢋgZhjai^c\ꢀ ^cꢀ &#ꢀ H]dgiꢀX^gXj^iꢀ^cꢀbdidgꢀdgꢀaddhZꢀXdc" &#ꢀ >cheZXiꢀXdccZXi^dchꢀdcꢀbdidgꢀ[dgꢀaddhZꢀdgꢀh]dgiZYꢀiZgb^cVahꢀdgꢀldgcꢀ
Wadlcꢀ [jhZhꢀ dgꢀ ig^eeZYꢀ X^g"
Xj^iꢌ#
cZXi^dch#
'#ꢀ AdlꢀkdaiV\Z#
^chjaVi^dc#
'ꢀ 8dggZXiꢀi]ZꢀadlꢀkdaiV\ZꢀXdcY^i^dch#
(#ꢀ >cXdggZXiꢀ [jhZhꢀ dgꢀ X^gXj^iꢀ WgZV`Zghꢀ (#ꢀ >chiVaaꢀXdggZXiꢀ[jhZhꢀdgꢀX^gXj^iꢀWgZV`Zgh#
^cꢀedlZgꢀa^cZ#
)#ꢀ BdidgꢀdkZgadVYZY#
)#ꢀ GZYjXZꢀadVYꢀdcꢀbdidg#
BVX]^cZꢀ hadlhꢀ l]Zcꢀ deZg" &#ꢀ ;ZZYꢀgViZꢀiddꢀ]^\]#
Vi^c\# '#ꢀ 9Zei]ꢀd[ꢀXjiꢀiddꢀ\gZVi#ꢀ
&#ꢀ ;ZZYꢀldg`e^ZXZꢀhadlZg#
'#ꢀ GZYjXZꢀYZei]ꢀd[ꢀXji#
AdjY!ꢀgZeZi^i^djhꢀcd^hZꢀXdb" &#ꢀ EjaaZnꢀhZiꢀhXgZlhꢀdgꢀ`ZnhꢀVgZꢀb^hh" &#ꢀ >cheZXiꢀ`ZnhꢀVcYꢀhZiꢀhXgZlh#ꢀGZeaVXZꢀdgꢀi^\]iZcꢀ^[ꢀcZXZhhVgn#
^c\ꢀ[gdbꢀbVX]^cZ
^c\ꢀdgꢀaddhZ#
'#ꢀ I^\]iZcꢀ[Vcꢀdgꢀh]^bꢀXdkZg#
'#ꢀ Bdidgꢀ[Vcꢀ^hꢀ]^ii^c\ꢀi]ZꢀXdkZg#
(#ꢀ K"WZaiꢀ^hꢀYZ[ZXi^kZ#
(#ꢀ GZeaVXZꢀK"WZai#ꢀHZZꢀ-AINTENANCE hZXi^dcꢀ
BVX]^cZꢀ ^hꢀ adjY!ꢀ dkZg]ZVihꢀ &#ꢀ :mXZhh^kZꢀYZei]ꢀd[ꢀXji#
dgꢀWd\hꢀYdlcꢀ^cꢀi]ZꢀXji# '#ꢀ 9jaaꢀdgꢀY^ginꢀhVcY^c\ꢀWZai#
&#ꢀ 9ZXgZVhZꢀYZei]ꢀd[ꢀXji#
'#ꢀ GZeaVXZꢀdgꢀXaZVcꢀhVcY^c\ꢀWZai#
GdjcYZYꢀldg`e^ZXZꢀZY\Zh#ꢀ &#ꢀ :mXZhh^kZꢀYZei]ꢀd[ꢀXji#
&#ꢀ GZYjXZꢀYZei]ꢀd[ꢀXji#
JcZkZcꢀ i]^X`cZhhꢀ [gdbꢀ aZ[iꢀ &#ꢀ ;ZZYꢀ iVWaZꢀ cdiꢀ eVgVaaZaꢀ idꢀ hVcY^c\ꢀ &#ꢀ 6Y_jhiꢀi]ZꢀiVWaZ#
idꢀg^\]iꢀd[ꢀWdVgY#
gdaaZg#
'#ꢀ ;ZZYꢀWZaiꢀ^hꢀldgc#ꢀ
'#ꢀ GZeaVXZꢀ[ZZYꢀWZai#
Ldg`e^ZXZꢀ ha^ehꢀ dcꢀ [ZZYꢀ &#ꢀ EgZhhjgZꢀgdaaZghꢀhZiꢀiddꢀ]^\]#
&#ꢀ AdlZgꢀegZhhjgZꢀgdaaZgh#
'#ꢀ 8aZVcꢀ[ZZYꢀWZai#
WZai#
'#ꢀ 9^ginꢀ[ZZYꢀWZai#
(#ꢀ ;ZZYꢀWZaiꢀ^hꢀldgc#
(#ꢀ GZeaVXZꢀ[ZZYꢀWZai#
HigV^\]iꢀhig^eꢀd[ꢀcdiX]Zhꢀdcꢀ &#ꢀ EgZhhjgZꢀ gdaaZghꢀ VgZꢀ Y^ginꢀ dgꢀ YVb" &#ꢀ 8aZVcꢀdgꢀgZeV^gꢀegZhhjgZꢀgdaaZgh#
ldg`e^ZXZ# V\ZY#
HcV`Zꢀ h]VeZYꢀ bVg`hꢀ dcꢀ &#ꢀ HVcY^c\ꢀWZaiꢀYVbV\ZYꢀdgꢀY^gin#
ldg`e^ZXZ#
&#ꢀ 8aZVcꢀdgꢀgZeaVXZꢀhVcY^c\ꢀWZai#
&OR YOUR SAFETYꢁ TURN SWITCH
OFF AND DISCONNECT THE
MACHINE FROM POWER SOURCE
BEFORE TROUBLESHOOTING THE
MACHINEꢀ 0LEASE REFER TO
3ECTION ꢄꢇ 3ET 5P TO MAKE
CORRECTIONSꢀ
"+)"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
4ROUBLESHOOTING
39-04/-
0/33)",% #!53%
#/22%#4)6% !#4)/.
A^cZhꢀVXgdhhꢀl^Yi]ꢀd[ꢀldg`" &#ꢀ HVcY^c\ꢀWZaiꢀhZVbꢀ^hꢀdeZcꢀdgꢀYVb" &#ꢀ GZeV^gꢀdgꢀgZeaVXZꢀhVcY^c\ꢀWZai#
e^ZXZ# V\ZY#
<adhhnꢀ hedihꢀ dgꢀ higZV`hꢀ dcꢀ &#ꢀ LdgcꢀhVcY^c\ꢀWZai#
&#ꢀ GZeaVXZꢀhVcY^c\ꢀWZai#
ldg`e^ZXZ#
'#ꢀ GZVgꢀegZhhjgZꢀgdaaZgꢀiddꢀadl#
'#ꢀ GV^hZꢀgZVgꢀegZhhjgZꢀgdaaZg#ꢀꢂ3EE WARNING IN 0RESSURE 2OLLER SECꢃ
TIONꢄ
HVcY^c\ꢀWZaiꢀXad\hꢀfj^X`an#
&#ꢀ HVcY^c\ꢀWZaiꢀ\g^iꢀiddꢀhbVaaꢀ[dgꢀeVg" &#ꢀ GZeaVXZꢀl^i]ꢀVꢀXdVghZgꢀ\g^iꢀhVcY^c\ꢀWZai#
i^XjaVgꢀ_dW#
'#ꢀ :mXZhh^kZꢀYZei]ꢀd[ꢀXji#
(#ꢀ LddYꢀ^hꢀiddꢀbd^hi#
'#ꢀ GZYjXZꢀYZei]ꢀd[ꢀXji#
(#ꢀ 6aadlꢀlddYꢀidꢀYgnꢀdji#
HVcY^c\ꢀ WZaiꢀ YdZhꢀ cdiꢀ iZc" &#ꢀ AdlꢀV^gꢀegZhhjgZ#
h^dcꢀ XdggZXian0ꢀ gdaaZghꢀ ha^eꢀ '#ꢀ 6^gꢀaZV`hꢀ^cꢀhnhiZb#
jcYZgꢀWZai#
&#ꢀ 6Y_jhiꢀV^gꢀegZhhjgZꢀidꢀ,*ꢀEH>ꢀViꢀeg^bVgnꢀgZ\jaVidg#
'#ꢀ >cheZXiꢀVaaꢀ]dhZhꢀVcYꢀXdccZXi^dchꢀ[dgꢀaZV`^c\ꢀV^g0ꢀjhZꢀlViZgꢀdcꢀhjh"
eZXiZYꢀVgZVꢀidꢀYZiZXiꢀWjWWaZh#
HVcY^c\ꢀWZaiꢀgjchꢀd[[ꢀidꢀdcZꢀ &#ꢀ 6^gꢀZnZꢀ[dg`ꢀXad\\ZY#
&#ꢀ 8aZVcꢀi]Zꢀ^ciV`Zꢀ]daZꢀdcꢀi]ZꢀV^gꢀZnZꢀ[dg`#
'#ꢀ DeZcꢀkVakZ#
h^YZ!ꢀhidee^c\ꢀi]ZꢀhVcYZg#
'#ꢀ DhX^aaVi^dcꢀgZijgcꢀkVakZꢀXadhZY#
(#ꢀ DhX^aaVi^dcꢀi^b^c\ꢀ^cXdggZXi#
(#ꢀ 6Y_jhiꢀdhX^aaVi^dcꢀi^b^c\#
HVcY^c\ꢀWZaiꢀl^aaꢀcdiꢀhiVgi
&#ꢀ HVcY^c\ꢀWZaiꢀ^hꢀcdiꢀiZch^dcZY#
'#ꢀ A^b^iꢀhl^iX]ZhꢀZc\V\ZY#
(#ꢀ :bZg\ZcXnꢀhideꢀeaViZꢀZc\V\ZY#
&#ꢀ IZch^dcꢀhVcY^c\ꢀWZai#
'#ꢀ 8ZciZgꢀhVcY^c\ꢀWZaiꢀhdꢀ^iꢀ^hꢀcdiꢀidjX]^c\ꢀi]Zꢀa^b^iꢀhl^iX]Zh#
(#ꢀ BV`ZꢀhjgZꢀZbZg\ZcXnꢀhideꢀhl^iX]ꢀ^hꢀgZaZVhZY#
ꢀ
Eddg!ꢀcdc"V\\gZhh^kZꢀhVcY" &#ꢀ LdgcꢀhVcY^c\ꢀWZai#
^c\ꢀgZhjaih#
&#ꢀ GZeaVXZꢀhVcY^c\ꢀWZaiꢀl^i]ꢀVꢀcZlꢀdcZ#
'#ꢀ HVcY^c\ꢀWZaiꢀadVYZYꢀl^i]ꢀhVlYjhi# '#ꢀ 8aZVcꢀhVcY^c\ꢀWZaiꢀidꢀjcadVYꢀhVlYjhi#
ꢀ
8dckZndgꢀ WZaiꢀ cdiꢀ igVX`^c\ꢀ &#ꢀ 8dckZndgꢀ gdaaZghꢀ bdkZYꢀ djiꢀ d[ꢀ &#ꢀ GZ"VY_jhiꢀXdckZndgꢀgdaaZgh#
^cꢀXZciZg#
VY_jhibZci#
8dckZndgꢀWZaiꢀha^ee^c\#
&#ꢀ 8dckZndgꢀ gdaaZghꢀ ]VkZꢀ ^cXdggZXiꢀ &#ꢀ 6Y_jhiꢀXdckZndgꢀgdaaZghꢀidꢀeaVXZꢀbdgZꢀiZch^dcꢀdcꢀ#
iZch^dc#
'#ꢀ 8dckZndgꢀgdaaZghꢀXdciVb^cViZYꢀl^i]ꢀ '#ꢀ 8aZVcꢀXdckZndgꢀgdaaZgh#
Y^giꢀdgꢀYjhi#ꢀ
:bZg\ZcXnꢀ WgV`Zꢀ hidehꢀ &#ꢀ 6^gꢀegZhhjgZꢀ^cXdggZXi#ꢀ
hadl# '#ꢀ 6^gꢀaZV`ꢀ^cꢀhnhiZb#
&#ꢀ 6Y_jhiꢀV^gꢀegZhhjgZꢀidꢀ,*ꢀEH>!ꢀ
'#ꢀ ;^cYꢀVcYꢀ[^mꢀV^gꢀaZV`h#
(#ꢀ 7gV`ZꢀgdidgꢀXdciVb^cViZYꢀl^i]ꢀd^a# (#ꢀ 8aZVcꢀWgV`Zꢀgdidgꢀl^i]ꢀVjidbdi^kZꢀWgV`ZꢀeVgihꢀXaZVcZg#
)#ꢀ 7gV`ZꢀeVYhꢀldgcꢀdji#
)#ꢀ GZeaVXZꢀWgV`ZꢀeVYh#
<g^cY^c\ꢀ cd^hZꢀ l]Zcꢀ WgV`" &#ꢀ 7gV`ZhꢀhZkZgZanꢀldgcꢀdji#ꢀ
^c\#
&#ꢀ GZeaVXZꢀWgV`ZꢀeVYh!ꢀ]VkZꢀgdidgꢀijgcZYꢀꢋedhh^WanꢀgZeaVXZYꢌ#
&OR YOUR SAFETYꢁ TURN SWITCH
OFF AND DISCONNECT THE
MACHINE FROM POWER SOURCE
BEFORE TROUBLESHOOTING THE
MACHINEꢀ 0LEASE REFER TO
3ECTION ꢄꢇ 3ET 5P TO MAKE
CORRECTIONSꢀ
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"+*"
Download from Www.Somanuals.com. All Manuals Search And Download.
7ARRANTY ꢆ 2ETURNS
<g^ooanꢀ>cYjhig^Va!ꢀ>cX#ꢀlVggVcihꢀZkZgnꢀegdYjXiꢀ^iꢀhZaahꢀ[dgꢀVꢀeZg^dYꢀd[ꢀꢅ YEARꢀidꢀi]Zꢀdg^\^cVaꢀejgX]VhZgꢀ[gdbꢀ
i]ZꢀYViZꢀd[ꢀejgX]VhZ#ꢀI]^hꢀlVggVcinꢀYdZhꢀcdiꢀVeeanꢀidꢀYZ[ZXihꢀYjZꢀY^gZXianꢀdgꢀ^cY^gZXianꢀidꢀb^hjhZ!ꢀVWjhZ!ꢀ
cZ\a^\ZcXZ!ꢀVXX^YZcih!ꢀgZeV^ghꢀdgꢀVaiZgVi^dchꢀdgꢀaVX`ꢀd[ꢀbV^ciZcVcXZ#ꢀI]^hꢀ^hꢀ<g^ooan»hꢀhdaZꢀlg^iiZcꢀlVggVcinꢀ
VcYꢀVcnꢀVcYꢀVaaꢀlVggVci^Zhꢀi]ViꢀbVnꢀWZꢀ^bea^ZYꢀWnꢀaVl!ꢀ^cXajY^c\ꢀVcnꢀbZgX]VciVW^a^inꢀdgꢀ[^icZhh!ꢀ[dgꢀVcnꢀeVg"
i^XjaVgꢀejgedhZ!ꢀVgZꢀ]ZgZWnꢀa^b^iZYꢀidꢀi]ZꢀYjgVi^dcꢀd[ꢀi]^hꢀlg^iiZcꢀlVggVcin#ꢀLZꢀYdꢀcdiꢀlVggVciꢀdgꢀgZegZhZciꢀ
i]Viꢀi]ZꢀbZgX]VcY^hZꢀXdbea^Zhꢀl^i]ꢀi]Zꢀegdk^h^dchꢀd[ꢀVcnꢀaVlꢀdgꢀVXihꢀjcaZhhꢀi]ZꢀbVcj[VXijgZgꢀhdꢀlVggVcih#ꢀ
>cꢀcdꢀZkZciꢀh]Vaaꢀ<g^ooan»hꢀa^VW^a^inꢀjcYZgꢀi]^hꢀlVggVcinꢀZmXZZYꢀi]ZꢀejgX]VhZꢀeg^XZꢀeV^Yꢀ[dgꢀi]ZꢀegdYjXiꢀVcYꢀ
VcnꢀaZ\VaꢀVXi^dchꢀWgdj\]iꢀV\V^chiꢀ<g^ooanꢀh]VaaꢀWZꢀig^ZYꢀ^cꢀi]ZꢀHiViZꢀd[ꢀLVh]^c\idc!ꢀ8djcinꢀd[ꢀL]ViXdb#
LZꢀh]Vaaꢀ^cꢀcdꢀZkZciꢀWZꢀa^VWaZꢀ[dgꢀYZVi]!ꢀ^c_jg^ZhꢀidꢀeZghdchꢀdgꢀegdeZginꢀdgꢀ[dgꢀ^cX^YZciVa!ꢀXdci^c\Zci!ꢀheZX^Va!ꢀ
dgꢀXdchZfjZci^VaꢀYVbV\ZhꢀVg^h^c\ꢀ[gdbꢀi]ZꢀjhZꢀd[ꢀdjgꢀegdYjXih#
IdꢀiV`ZꢀVYkVciV\Zꢀd[ꢀi]^hꢀlVggVcin!ꢀXdciVXiꢀjhꢀWnꢀbV^aꢀdgꢀe]dcZꢀVcYꢀ\^kZꢀjhꢀVaaꢀi]ZꢀYZiV^ah#ꢀLZꢀl^aaꢀi]Zcꢀ
^hhjZꢀndjꢀVꢀ¸GZijgcꢀCjbWZg!¹ꢀl]^X]ꢀbjhiꢀWZꢀXaZVganꢀedhiZYꢀdcꢀi]Zꢀdjih^YZꢀVhꢀlZaaꢀVhꢀi]Zꢀ^ch^YZꢀd[ꢀi]Zꢀ
XVgidc#ꢀLZꢀl^aaꢀcdiꢀVXXZeiꢀVcnꢀ^iZbꢀWVX`ꢀl^i]djiꢀi]^hꢀcjbWZg#ꢀEgdd[ꢀd[ꢀejgX]VhZꢀbjhiꢀVXXdbeVcnꢀi]Zꢀ
bZgX]VcY^hZ#ꢀ
I]ZꢀbVcj[VXijgZghꢀgZhZgkZꢀi]Zꢀg^\]iꢀidꢀX]Vc\ZꢀheZX^[^XVi^dchꢀViꢀVcnꢀi^bZꢀWZXVjhZꢀi]ZnꢀXdchiVcianꢀhig^kZꢀidꢀ
VX]^ZkZꢀWZiiZgꢀfjVa^inꢀZfj^ebZci#ꢀLZꢀbV`ZꢀZkZgnꢀZ[[dgiꢀidꢀZchjgZꢀi]ViꢀdjgꢀegdYjXihꢀbZZiꢀ]^\]ꢀfjVa^inꢀVcYꢀ
YjgVW^a^inꢀhiVcYVgYhꢀVcYꢀlZꢀ]deZꢀndjꢀcZkZgꢀcZZYꢀidꢀjhZꢀi]^hꢀlVggVcin#
EaZVhZꢀ[ZZaꢀ[gZZꢀidꢀlg^iZꢀdgꢀXVaaꢀjhꢀ^[ꢀndjꢀ]VkZꢀVcnꢀfjZhi^dchꢀVWdjiꢀi]ZꢀbVX]^cZꢀdgꢀi]ZꢀbVcjVa#ꢀ
I]Vc`ꢀndjꢀV\V^cꢀ[dgꢀndjgꢀWjh^cZhhꢀVcYꢀXdci^cjZYꢀhjeedgi#ꢀLZꢀ]deZꢀidꢀhZgkZꢀndjꢀV\V^cꢀhddc#
"++"
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
Download from Www.Somanuals.com. All Manuals Search And Download.
7!22!.49 #!2$
CVbZꢀTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTT ꢀ
HigZZiꢀTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTT
8^inꢀ TTTTTTTTTTTTTTTTTTTTTTT HiViZꢀTTTTTTTTTTTTTTTTTTTTTTTTT O^eꢀ TTTTTTTTTTTTTTTTTTTTT
E]dcZꢀꢍꢀTTTTTTTTTTTTTTTTTTTT :bV^aꢀ TTTTTTTTTTTTTTTTTTTTTTTT >ckd^XZꢀꢍꢀTTTTTTTTTTTTTTTTT
BdYZaꢀꢍꢀTTTTTTTTTTTTTTTTTTTT DgYZgꢀꢍꢀTTTTTTTTTTTTTTTTTTTTTTT HZg^VaꢀꢍꢀTTTTTTTTTTTTTTTTTT
4HE FOLLOWING INFORMATION IS GIVEN ON A VOLUNTARY BASISꢁ )T WILL BE USED FOR MARKETING PURPOSES TO HELP US DEVELOP
BETTER PRODUCTS AND SERVICESꢁ /F COURSEꢈ ALL INFORMATION IS STRICTLY CONFIDENTIALꢉ
ꢅꢀꢀ =dlꢀY^YꢀndjꢀaZVgcꢀVWdjiꢀjh4
ꢀ
ꢀTTTT 6YkZgi^hZbZciꢀ
ꢀ TTTT ;g^ZcYꢀ
ꢀ TTTT LZWh^iZꢀ
ꢀTTTT 8ViVad\
ꢀTTTT Di]Zg/
ꢀ
ꢀTTTT 8VgYꢀ9ZX`ꢀ
ꢇꢀꢀ L]^X]ꢀd[ꢀi]Zꢀ[daadl^c\ꢀbV\Vo^cZhꢀYdꢀndjꢀhjWhXg^WZꢀid4
TTTT 8VW^cZiꢀBV`Zg
TTTT ;Vb^anꢀ=VcYnbVc
TTTT =VcYꢀAdVYZg
TTTT EdejaVgꢀBZX]Vc^Xh
TTTT EdejaVgꢀHX^ZcXZ
TTTT EdejaVgꢀLddYldg`^c\
TTTT EgVXi^XVaꢀ=dbZdlcZg
TTTT EgZX^h^dcꢀH]ddiZg
TTTT Egd_ZXihꢀ^cꢀBZiVa
TTTT G8ꢀBdYZaZg
TTTT IdYVn»hꢀ=dbZdlcZg
TTTT LddY
TTTT LddYZcꢀ7dVi
TTTT LddYh]deꢀCZlh
TTTT LddYhb^i]
TTTT =VcYn
TTTT =dbZꢀH]deꢀBVX]^c^hi
TTTT ?djgcVaꢀd[ꢀA^\]iꢀ8dci#
TTTT A^kZꢀHiZVb
TTTT BdYZaꢀ6^geaVcZꢀCZlh
TTTT BdYZaiZX
TTTT LddYldg`
TTTT LddYldg`ZgꢀLZhi
TTTT LddYldg`Zg»hꢀ?djgcVa
TTTT Di]Zg/
TTTT G^ÄZ
TTTT H]deꢀCdiZh
TTTT DaYꢀ=djhZꢀ?djgcVa
TTTT H]di\jcꢀCZlh
ꢈꢀꢀ L]Viꢀ^hꢀndjgꢀVccjVaꢀ]djhZ]daYꢀ^cXdbZ4
ꢀ
ꢀTTTT ꢎ'%!%%%"ꢎ'.!%%%ꢀ
ꢀ TTTT ꢎ(%!%%%"ꢎ(.!%%%ꢀ
ꢀTTTT ꢎ)%!%%%"ꢎ).!%%%
ꢀTTTT ꢎ,%!%%%
ꢀ
ꢀTTTT ꢎ*%!%%%"ꢎ*.!%%%ꢀ
ꢀ TTTT ꢎ+%!%%%"ꢎ+.!%%%ꢀ
ꢉꢀꢀ L]Viꢀ^hꢀndjgꢀV\Zꢀ\gdje4
ꢀ
ꢀTTTT '%"'.ꢀ
ꢀ TTTT (%"(.ꢀ
ꢀ TTTT +%"+.ꢀ
ꢀTTTT )%").
ꢀTTTT ,%
ꢀ
ꢀTTTT *%"*.ꢀ
ꢊꢀꢀ =dlꢀadc\ꢀ]VkZꢀndjꢀWZZcꢀVꢀlddYldg`Zg$bZiValdg`Zg4
ꢀTTTT %"'ꢀNZVghꢀ ꢀTTTT '"-ꢀNZVghꢀ ꢀTTTT -"'%ꢀNZVghꢀꢀ
ꢀ
ꢀ TTTT'% ꢀNZVgh
ꢋꢀꢀ =dlꢀbVcnꢀd[ꢀndjgꢀbVX]^cZhꢀdgꢀiddahꢀVgZꢀ<g^ooan4
ꢀTTTT %"'ꢀ ꢀTTTT ("*ꢀ
ꢀ
ꢀTTTT +".ꢀ
ꢀ TTTT&%
ꢀTTTTTCd
ꢀTTTTTCd
ꢌꢀꢀ 9dꢀndjꢀi]^c`ꢀndjgꢀbVX]^cZꢀgZegZhZcihꢀVꢀ\ddYꢀkVajZ4ꢀ
ꢍꢀꢀ LdjaYꢀndjꢀgZXdbbZcYꢀ<g^ooanꢀ>cYjhig^VaꢀidꢀVꢀ[g^ZcY4ꢀ
ꢀTTTTTNZhꢀ
ꢀTTTTTNZhꢀ
ꢎꢀꢀ LdjaYꢀndjꢀVaadlꢀjhꢀidꢀjhZꢀndjgꢀcVbZꢀVhꢀVꢀgZ[ZgZcXZꢀ[dgꢀ<g^ooanꢀXjhidbZghꢀ^cꢀndjgꢀVgZV4
CdiZ/ꢀ7E NEVER USE NAMES MORE THAN ꢋ TIMESꢁꢀ ꢀTTTTTNZhꢀ ꢀTTTTTCd
ꢀ
ꢅꢏꢀꢀ 8dbbZcih/ ?????????????????????????????????????????????????????????????????????
?????????????????????????????????????????????????????????????????????????????????
?????????????????????????????????????????????????????????????????????????????????
<%))+$<%*(.$<%*,&ꢀ(,ꢁꢀL^YZꢀ7ZaiꢀHVcYZg
"+,"
?????????????????????????????????????????????????????????????????????????????????
Download from Www.Somanuals.com. All Manuals Search And Download.
;DA9ꢀ6ADC<ꢀ9DII:9ꢀA>C:
EaVXZ
HiVbe
=ZgZ
'2)::,9 ).$5342)!,ꢁ ).#ꢀ
0ꢀ/ꢀ "/8 ꢇꢏꢋꢎ
"%,,).'(!-ꢁ 7! ꢎꢍꢇꢇꢌꢃꢇꢏꢋꢎ
;DA9ꢀ6ADC<ꢀ9DII:9ꢀA>C:
HZcYꢀVꢀ<g^ooanꢀ8ViVad\ꢀidꢀVꢀ[g^ZcY/
CVbZTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTT
HigZZiTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTT
8^inTTTTTTTTTTTTTTHiViZTTTTTTO^eTTTTTT
I6E:ꢀ6ADC<ꢀ:9<:H""EA:6H:ꢀ9DꢀCDIꢀHI6EA:
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
"UY $IRECT AND 3AVE WITH 'RIZZLY® n 4RUSTEDꢁ 0ROVEN AND A 'REAT 6ALUEꢄ
6ISIT /UR 7EBSITE 4ODAY !ND $ISCOVER 7HY
'RIZZLY§ )S 4HE )NDUSTRY ,EADERꢀ
s 3#5/$%2).'
s 0%$74).ꢁꢂ(/523
s ꢀ-!,0374).%(/52
/2ꢀ
#L4DAY&OR!
&2%
&UR#TALOG
Download from Www.Somanuals.com. All Manuals Search And Download.
|