®
GARDENA
5000/3 SGP
Art. 1471
D
Gebrauchsanweisung
Duo-Pumpe
GB Operating Instructions
Dual Pump
F
Mode d’emploi
Pompe universelle
NL Gebruiksaanwijzing
Duopomp
S
I
Bruksanvisning
Universalpump
Istruzioni per l’uso
Pompa Duo
E
P
Manual de instrucciones
Bomba dúo
Instruções de utilização
Bomba dupla
DK Brugsanvisning
Universalpumpe
Download from Www.Somanuals.com. All Manuals Search And Download.
G
G
For safety reasons we recommend that you always operate
the Dual Pump via a residual-current device (DIN VDE 0100-702
and 0100-738).
Minimum flow rate
The minimum flow rate is 80 l/h (= 1.3 l/min).
Watering accessories with lower rate must not be operated.
Hot water –
risk of scalding
If the pump is operated for prolonged periods of time (> 5 min)
with the delivery side closed, the water in the pump may heat up
so that there is a risk of scalding yourself with hot water.
v Please contact your electrician.
In Austria, according to ÖVE B/EN 60 555 part 1 to 3, pumps
which are used in swimming pools and garden ponds, and
equipped with firm power cable should be fed via an ÖVE
approved isolating transformer – rated voltage must not exceed
230 V.
In Austria
v The pump should not run against the closed delivery side for
more than 5 minutes.
v If liquid fails to flow, switch off the pump immediately.
In Switzerland mobile appliances which are used outdoors,
must be connected via a residual-current device.
In Switzerland
Mains power
3. Initial Operation
According to DIN VDE (German Electrical Engineers’ Associa-
tion) 0620, mains power cables must not have a smaller cross-
section than the rubber-sheathed cables of the designation
H07 RNF. The cable length must be at least 10 m.
Connecting a filter or
hose to the inlet side:
1. When setting up the pump for use underwater, screw the
filter
onto the connection
at the inlet side of the pump.
1
2
– or –
When setting up the pump for use out of water, connect a
vacuum-resistant suction hose with filter to the connec-
Data indicated on the type plate must match technical data of
the mains supply.
v Take care that the electrical connections are made within
dry area, protected from flooding.
Protect plug and power cable from heat, oil and sharp edges.
2
3
tion
at the inlet side of the pump and screw on so that the
2
connection is air-tight.
2. When setting up the pump for use out of water with suction
heights over 4 m, the suction hose should also be secured (fas-
tened to a wooden peg for example).
1
v Don’t use the power cable for plugging off.
The power cable must not be used for mounting or relocating
the pump. For submerging or lifting/securing the pump, fix a
rope (available from GARDENA Service) to the pump’s carrying
handle.
The pump is relieved of the weight of the suction hose.
3
2
Don’t use any hose connection system fittings on the suction
side! A vacuum-resistant suction hose must be used
Extension cables must meet the requirements of DIN VDE
0620.
•
e.g. GARDENA Suction Unit, art. no. 1411.
In order to reduce the suction time, it is advisable to use a suction
hose with backflow preventer avoiding automatic draining of the
suction hose when the pump is stopped.
Visual check
v Before operating the pump, first make a visual check, if there
is any damage of the pump (esp. regarding power cable and
plug).
v Observe the minimum water level and the max. delivery
height (see 9. Technical Data).
A damaged pump must not be used.
Both pump connectors
are equipped with a 33.3 mm (G1”)
Connection hose
to delivery side:
4
thread to which 13 mm (1/2”), 19 mm (3/4”) and 16 mm (5/8”)
hoses can be connected by using GARDENA hose connection
system fittings.
v In case of damage, please have the pump checked by our
Best results regarding the delivery capacity of the pump are
achieved when connecting 19 mm (3/4”) hoses in conjunction
with e.g.
GARDENA Service Centre.
4
v Clear the outlet line before use.
Note on use
Dry-Running
• GARDENA Pump Connection Set, art. no. 1752,
or when using 25 mm (1”) hoses with fittings available from your
sanitary dealer.
When setting up the pump for use out of water
In order to avoid dry-running of the pump, take care that the
end of the suction hose is always submerged into the liquid.
5
v Connect the pressure hose
to the connector
on the
5
4
v Before each operation, fill the pump to overflowing with
delivery side.
approx. 2 l of the liquid to be pumped!
Only when setting up the pump for use out of water:
Sand and other abrasive substances in the liquid cause in-
creased wear and reduce the pump’s output.
Liquid fails to flow
Filling
the pump:
V Before each operation, fill the pump to overflowing
with approx. 2 l of the liquid to be pumped !
6
7
A
v Use a Pump Preliminary Filter if the water contains sand
(Art. No. 1730/ 1731).
The pump should not run against the closed delivery side
for more than 5 minutes.
1. Unscrew the screw fitting of the filler cap by hand.
6
7
2. Fill the pump via the filler cap
2 l of the liquid to be pumped.
to overflowing with approx.
7
v
If liquid fails to flow, switch off the pump immediately.
3. Tighten the screw fitting
use pliers).
of the filler cap
by hand (do not
6
7
12
13
Download from Www.Somanuals.com. All Manuals Search And Download.
G
G
Problem
Probable cause
Remedy
4. Operation
Pump runs, but the suction
action doesn’t take place.
Air cannot escape, since
delivery side is closed
or remaining water is in the
pressure hose.
v Open all possible shut-off
devices (e.g. spray nozzle)
in the pressure line, or drain
the pressure hose or dis-
connect it during the suction
action.
When setting up the pump for use in water:
v Plug the mains plug of the pump into a 230 V / 50 Hz alternat-
Starting the pump:
ing current socket. The pump starts.
When setting up the pump for use out of water
Pumping liquid:
1. Fill the pump to overflowing with approx. 2 l of the liquid
to be pumped (see “3. Initial Operation”, “Filling the pump” ).
Pump runs when out of water
but does not start pumping
when in water
You didn’t fill the pump with
any liquid before operation.
v Fill in liquid (see point
“3. Initial Operation”).
2. Open all possible shut-off devices in the pressure line
(watering accessories, Water Stop, etc.).
The liquid escapes over
the hose which is connected
to the delivery side during
the suction action.
1. Fill up the pump again (see
point 3. Initial Operation).
2. When starting operation
hold the pressure hose
3. Drain remaining water in pressure hose so that air can escape
during the suction process.
5
1m
approx. 1 m vertically above
the pump, until the suction
action has taken place.
4. Plug the mains plug of the pump into a 230 V / 50 Hz alternat-
ing current socket. The pump starts.
5. Hold the hose
at the delivery side approx. 1 m vertically
5
above the pump until the pump begins to pump.
Leaky or damaged suction
hose.
v Seal the connections or
check suction hose for
damages.
v If the pump has still not started pumping after 7 minutes,
unplug the mains plug (see 6. Trouble Shooting).
Absolutely vacuum-resistant
connection is achieved by using
GARDENA Suction Hoses
(see point “8. Accessories”).
When using the pump for pressure intensification, the max. per-
missible internal pressure of 6 bar (on the delivery side) must
not be exceeded. The to be increased delivery pressure and the
pump pressure sum up.
Leaky screw fitting at the filler
v Tighten the screw fitting
•
Example: pressure at the water tap 1.5 bar, max. pressure of
the GARDENA Dual Pump 5000/3 SGP = 3.3 bar, total pres-
sure = 4.8 bar.
cap
.
7
(do not use pliers).
Air cannot escape, since
delivery side is closed
or remaining water is in the
pressure hose.
v Open all possible shut-off
devices (e.g. spray nozzle)
in the pressure line, or drain
the pressure hose or dis-
connect it during the suction
action.
5. Maintenance
The GARDENA Dual Pump is virtually maintenance-free.
The waiting time wasn’t
observed.
v Switch on the pump and
wait max. 7 min.
6. Trouble-Shooting
Suction filter or backflow
preventer in the suction hose
clogged.
v Clean the filter or the back-
flow preventer.
If the impeller blocks or clogs you can remove the dirt to free
the impeller.
Freeing the impeller:
Too high suction height.
v Reduce suction height.
1. Unscrew the screw plug
a screwdriver.
using
8
In case of any other difficulties concerning the suction action,
use GARDENA Suction Hoses with Backflow Preventer (see point
“8. Accessories”) and fill in the liquid to be pumped over the filler
2. You can now turn the impeller
shaft in the casing using a
9
9
screwdriver.
This will free the blocked or clogged
impeller.
cap
before operation.
7
The specified maximum
self-priming height is not
Pump is not filled and suction
hose is not held upwards.
1. Fill the pump using the filler
neck until it overflows.
3. Replace the screw plug
a screwdriver.
using
8
8
2. Hold the suction hose up-
wards during the self-prim
ing phase so that the liquid
you are going to pump
cannot flow out of the pump
via the suction hose.
14
15
Download from Www.Somanuals.com. All Manuals Search And Download.
G
G
Problem
Probable cause
Remedy
9. Technical Data
Pump motor runs, but
Suction filter at the suction
hose is sucked free.
v Reduce flow rate on the
delivery side with a regula-
tor valve, e.g. GARDENA
art. no. (2)977.
delivery capacity or pres-
sure suddenly decreases.
5000/3 SGP (Art. 1471)
Rated power
750 W
5,200 l/h
3.3 bar
33 m
Max. delivery capacity
Max. pressure
Suction filter or backflow
preventer clogged.
v Clean filter or back-flow
preventer.
Max. delivery head
Impeller blocked.
No power.
v Free the impeller.
Max. self-priming
suction height
Pump motor doesn’t start
or suddenly stops.
v Check fuses and electric
8 m
connections.
Perm. internal pressure
(delivery side)
Thermal overload switch
has cut out the pump due
to overheating/overloading.
v Free the impeller and open
6 bar
the pressure side.
Voltage
230 V AC
50 Hz
Frequency
Weight
Impeller clogged.
v Send the pump to one of our
GARDENA Service Centres.
7.8 kg
Electric failure.
v Send the pump to one of our
1)
Noise level LWA
66 dB(A)
GARDENA Service Centres.
1) Measuring method according to Directive 2000/14/EC
Attention!
Repairs on electrical parts should only be done by our
GARDENA Service Centres.
Performance characteristics
m
bar
4
If you have any problems with your pump, please contact our Service.
40
30
20
10
0
3
2
1
7. Storage
Wintering/Storage:
Empty your Dual Pump before the first frost sets in.
1. Hold the pump diagonally and drain the water from the pump
out of the inlet side.
2. Store your Dual Pump in a place that is protected from frost.
0
1000
2000
3000
4000
5000
6000 l/h
8. Accessories
GARDENA Suction Hoses
Kink- and vacuum-resistant, sold by the metre with 19 mm (3/4”)
or 25 mm (1”) diameter without fittings or in fixed length, complete
with fittings.
10. Service
GARDENA
Suction Hose Fittings
Warranty
GARDENA guarantees this product for 2 years (from date of
purchase). This guarantee covers all serious defects of the unit
that can be proved to be material or manufacturing faults. Under
warranty we will either replace the unit or repair it free of charge
if the following conditions apply:
• Art. no. 1723/ 1724
GARDENA Suction Filter
with Backflow Preventer
To equip suction hoses
sold by the metre.
• Art. no. 1726/ 1727/ 1728
• Art. no. 1730/1731
GARDENA
Pump Preliminary Filter
Recommended for pumping
sandy liquids.
• The unit must have been handled properly and in keeping with
the requirements of the operating instructions.
GARDENA Electronic
Manometric Switch
Automatically cuts in and out
the pump depending on the
current operating pressure.
With dry-running safety.
• Neither the purchaser or a non-authorised third party have
attempted to repair the unit.
The impeller is a wearing part and is not covered by the guarantee.
• Art. no. 1739
• Art. no. 1741
This manufacturer’s guarantee does not affect the user’s existing
warranty claims against the dealer/seller.
GARDENA
Dry-Running Safety
Prevents the pump from dama-
ges in case of missing liquid.
16
17
Download from Www.Somanuals.com. All Manuals Search And Download.
G
If a fault occurs with your Dual Pump, please return the faulty
unit together with a copy of the receipt and a description of
the fault, with postage paid to one of the GARDENA Service
Centres listed on the back of these operating instructions.
Product Liability
We expressly point out that, in accordance with the product
liability law, we are not liable for any damage caused by our
units if it is due to improper repair or if parts exchanged are not
original GARDENA parts or parts approved by us, and, if the
repairs were not carried out by a GARDENA Service Centre or
an authorised specialist. The same applies to spare parts and
accessories.
EU Certificate of Conformity
The undersigned GARDENA Kress + Kastner GmbH · Hans-Lorenser-Str. 40 · D-89079 Ulm
hereby certifies that, when leaving our factory, the unit indicated below is in accordance with the
harmonised EU guidelines, EU standards of safety and product specific standards.
This certificate becomes void if the unit is modified without our approval.
Description of the unit:
Type:
Art. No.:
Dual Pump
5000/3 SGP
1471
EU directives:
Machinery Directive 98/37/EC
Electromagnetic Compatibility 89/336/EC
Low Voltage Directive 73/23/EC
Directive 93/68/EC
Directive 2000/14/EC
Harmonised
European standards:
EN 292-1
EN 292-2
EN 60335-1
EN 60335-2-41
Noise level:
measured
guaranteed 69 dB(A)
66 dB(A)
Year of CE marking:
2002
Ulm, 09.07.2002
Thomas Heinl
Technical Dept. Manager
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Deutschland
GARDENA Kress + Kastner GmbH
GARDENA Service
Hans-Lorenser-Straße 40
D-89079 Ulm
Produktfragen: (0731) 490-123
Reparaturen: (0731) 490-290
Finland
Norway
Habitec Oy
GARDENA Norge A/S
Postboks 214
2013 Skjetten
Martinkyläntie 52
01720 Vantaa
France
Poland
GARDENA France
Service Après-Vente
BP 50080
GARDENA Polska Sp. z o.o.
Szymanów 9 d
Argentina
05-532 Baniocha
Argensem S.A.
95948 ROISSY CDG Cedex
Portugal
Venezuela 1075
Great Britain
MARKT (Portugal), Lda.
Recta da Granja do Marquês
Edif. GARDENA
(1618) El Talar - Buenos Aires
GARDENA UK Ltd.
27-28 Brenkley Way
Blezard Business Park
Seaton Burn
Australia
NYLEX Consumer Division
76-88 Mills Road
P.O. Box 722
Algueirão
2725-596 Mem Martins
Newcastle upon Tyne NE13 6DS
Russia / Россия
АО АМИДА ТТЦ
ул. Моcфилмовcкая 66
117330 Моcква
Braeside 3195
Melbourne, Victoria
Greece
Agrokip G. Psomadopoulos & Co.
33a, Ifestou str.
Koropi 194 00
Austria
GARDENA Österreich Ges. m.b.H.
Stettnerweg 11-15
2100 Korneuburg
Singapore
Variware
Holland Road Shopping Centre
227-A 1st Fl., Unit 29
Holland Avenue
Singapore 1027
Athens
Hungary
Belgium
GARDENA Magyarország Kft.
Késmárk utca 22
1158 Budapest
MARKT (Belgium) NV/SA
Sterrebeekstraat 163
1930 Zaventem
Iceland
Heimilistaeki hf
Saetun 8
P.O. Box 5340
125 Reykjavik
Slowenia / Croatia
Silk d.o.o. Trgovina
Brodišče 15
Brazil
M. Cassab
Av. das Nações Unidas, 20.882
Santo Amaro, CEP 04795-000
São Paulo - S.P.
1236 Trzin
South Africa
Republic of Ireland
Michael McLoughlin & Sons
Hardware Limited
Long Mile Road
GARDENA South Africa (Pty.) Ltd.
P.O. Box 11534
Bulgaria / България
ДЕНЕКС ООД
Бул. ”Г.М.Димитров” 16 ет.4
София 1797
Vorna Valley 1686
Spain
Dublin 12
ANMI Andreu y Miriam S.A.
Calle Pere IV, 111
08018 Barcelona
Canada
Italy
GARDENA Canada Ltd.
100, Summerlea Road
Brampton, Ontario
Canada L6T 4X3
GARDENA Italia S.r.l.
Via Donizetti 22
20020 Lainate (Mi)
Sweden
GARDENA Svenska AB
Box 9003
Japan
Chile
KAKUDAI Mfg. Co. Ltd.
1-4-4, Itachibori Nishi-ku
Osaka 550
20039 Malmö
Antonio Martinic Y CIA. LTDA.
Gilberto Fuenzalida 185 Loc.
Las Condes - Santiago de Chile
Switzerland
GARDENA Kress + Kastner AG
Bitziberg 1
Luxembourg
Magasins Jules Neuberg
Grand Rue 30
Case Postale No. 12
Luxembourg 2010
Costa Rica
8184 Bachenbülach
Compania Exim
Euroiberoamericana S.A.
350 Sur del Automercado
Los Yoses
Ukraine / Украина
АОЗТ АЛЬЦЕСТ
ул. Гайдара 50
г. Киев 01033
Netherlands
San Pedro
GARDENA Nederland B.V.
Postbus 50176
Turkey
Cyprus
Dost Diþ Ticaret Mümessillik A.Þ.
Yeþilbaðlar Mah. Baþkent
Cad. No. 26
FARMOKIPIKI LTD
P.O. Box 7098
74, Digeni Akrita Ave.
1641 Nicosia
1305 AD ALMERE
Neth. Antilles
Jonka Enterprises N.V.
Sta. Rosa Weg 196
P.O. Box 8200
Pendik - Ýstanbul
USA
GARDENA
3085 Shawnee Drive
Winchester, VA 22604
Czech Republic
GARDENA spol. s.r.o.
Шнpskб 20a, и.p. 1153
62700 Brno
Curaçao
New Zealand
NYLEX New Zealand Limited
Private Bag 94001
South Auckland Mail Centre
10 Offenhauser Drive
East Tamaki, Manukau
Denmark
1471-20.960.02/0021
GARDENA Danmark A/S
Naverland 8
GARDENA Kress + Kastner GmbH
©
Postfach 27 47, D-89070 Ulm
http://www.gardena.com
2600 Glostrup
Download from Www.Somanuals.com. All Manuals Search And Download.
|