®
GARDENA
5000 S
Art. 1778
D
Gebrauchsanweisung
Tauchpumpe
GB Operating Instructions
Submersible Pump
F
Mode d’emploi
Pompe d’évacuation pour eaux claires
NL Gebruiksaanwijzing
Dompelpomp
S
I
Bruksanvisning
Dränkbar pump
Istruzioni per l’uso
Pompa sommersa
E
P
Manual de instrucciones
Bomba sumergible
Instruções de utilização
Bomba submersível
DK Brugsanvisning
Dykpumpe
Download from Www.Somanuals.com. All Manuals Search And Download.
G
G
Connecting the hose:
The universal fitting
in the previous table.
allows you to connect all the hoses listed
7
Avoid running of the pump for more than 10 min. against closed
delivery side of the pump.
1. Cut off nipples of the universal fitting , which are not needed,
7
Sand and other abrasive substances cause increased wear and
reduce the pump’s output.
to match the hose connection.
2. Screw the universal fitting
onto the pump.
7
Take care that the pump is located where the inlet openings at
the suction base are obstructed neither completely nor partly.
3. Connect the hose to the universal fitting
.
7
We recommend that you secure 38 mm (1 1/2”) and 25 mm (1”)
hoses additionally with a GARDENA Hose Clip Art. No. 1591.
Stand the pump on a brick if using in a pond.
Thermal motor protector
The pump is automatically switched off on overheating by
the built-in thermal motor protector. After having cooled down,
the motor automatically switches on again (see 6. Trouble
Shooting).
Only for 13 mm (1/2”) hose:
The universal fitting
can also be equipped with a GARDENA
7
7
Regulator Valve Art. No. 977 so that the contents of the out-
let line do not flow back through the pump after pumping.
The Regulator Valve can be ordered from GARDENA Service.
Automatic deaerating
valve
The automatic deaerating valve eliminates any air pockets in
the pump. If the water level drops below the vent valve, some
water flows penetrates outside through the vent valve
This is not a defect of your pump, but serves to deaerate the
pump.
.
4
4. Operation
To ensure that the pump draws the water out, the water to be
drained must be at least 45 mm deep.
The float switch
turns the pump on automatically when the
Automatic operation:
5
4
water level exceeds the cut-in height and the water is pumped out.
The float switch turns the pump off again as soon as the water
level falls below the cut-out height.
5
1
3
2
1. Stand the pump on a firm surface – or –
use a rope attached to the carrying handle
pump in a well or shaft.
to immerse the
2
3. Initial Operation
During automatic operation, ensure that the float switch
can move freely.
5
13 mm (1/2”)
15 mm (5/8”)
19 mm (3/4”)
Hose diameter
25 mm (1”)
38 mm (1 1/2”)
2. Plug the power cable
into a mains socket.
1
Adjusting the Cut-in and Cut-out Height:
The maximum cut-in height and minimum cut-out height (see
8. Technical Data) can be adjusted.
4
5
7
a
b
v Push the cable of the float switch
into the float switch lock
.
5
3
6
Do not select a cable length that is too long or short to ensure
that the float switch can turn on and off properly.
7
•
The shorter the length of cable between the float switch
5
and the float switch lock , the lower the cut-in height and the
3
higher the cut-out height.
Hose connection
of universal fitting
5
1
7
The pump remains in constant operation because the float switch
is bypassed.
Manual
operation:
Hose connection
Cut off topmost
Do not cut off
any nipples.
Cut off top two
1. Stand the pump on a firm surface – or –
nipple at
.
a
nipples at
.
b
use a rope attached to the carrying handle
pump in a well or shaft.
to immerse the
2
The following connection kits are required for 13 mm to 19 mm
connections:
13 mm (1/2”): GARDENA Pump Connection Set, Art. No. 1750
15 mm (5/8 ”): GARDENA Tap Connector, Art. No. 902, and
Standard Hose Connector, Art. No. 916
2. Plug the power cable
into a mains socket.
1
2
3. Fix float switch
at the bottom).
vertically above the pump (with the cable
5
As long as the float switch is positioned vertically above the
pump, the pump will operate regardless of the water level.
19 mm (3/4”): GARDENA Pump Connection Set, Art. No. 1752
Best results in delivery capacity are achieved when using 38 mm
(1 1/2”) hoses.
The residual water height of approx. 5 mm is only reached
during manual operation since the float switch turns off the
pump during automatic operation before this water level is
reached.
12
13
Download from Www.Somanuals.com. All Manuals Search And Download.
G
G
5. Cleaning
Attention!
Repairs on electrical parts should only be done by our
GARDENA Service Centres.
The pumps are virtually maintenance-free.
If you have any problems with your Pump, please contact our Service.
After having pumped chlorinated swimming pool water or other
liquids leaving residues, the pump should be rinsed with clear
water.
Flushing the Pump:
7. Storage
A Warning! Electric shock!
Risk of injury due to electric shock.
V Disconnect the pump from the mains before clean-
ing the suction base and turbine.
Cleaning the suction
base and turbine:
Store the pump away from frost before the first frost sets in.
Frost-free storage
9
6
8
1. Unscrew the 3 Phillips screws
off the pump.
and pull the suction base
8
6
8. Technical Data
2. Clean the suction base
and the turbine
.
9
6
Type
5000 S (Art. No. 1778)
3. Reinstall the suction base
and screw in the Phillips screws
.
8
6
Rated power
200 W
5,000 l/h
0.5 bar
5 m
For safety reasons a damaged turbine
changed by the GARDENA Service Centre.
can only be ex-
9
Max. delivery capacity
Max. pressure
Max. delivery height
Max. submersion depth
Flat suction down to approx.
6. Trouble-Shooting
9 m
Problem
Probable cause
Remedy
5 mm
Contaminated water with
particle size of max.
Pump is running,
but doesn’t deliver.
Air cannot escape, since
pressure line is closed.
v Open pressure line
5 mm
(e.g. kinked pressure pipe).
Power cable
10 m H05 RNF
Air locks in the suction base.
v Wait for max. 60 seconds
until the pump deaerates
automatically over the vent
valve. If necessary, switch
off and start it again.
Pump connection
38 mm (1 1/2”) / 25 mm (1”) graduated nipple,
option GARDENA Water hose Plug-in-system
Min. water level for operation
Weight approx.
45 mm
4.0 kg
35°C
Turbine clogged.
v Disconnect plug and clean
turbine (see 5. Cleaning).
Max. media temperature
Mains voltage /
mains frequency
When starting the pump,
water height falls below the
min. water level.
v Submerge pump deeper.
230 V / 50 Hz
380 mm
Min.cut-in height
Pump doesn’t start or
suddenly stops during
operation.
Thermal overload switch has
switched the pump off due
to overheating.
v Disconnect plug and clean
Min./max. cut-out height
100 mm / 140 mm
46 dB(A)
turbine (see 5. Cleaning).
1)
Noise level LWA
Observe max. media temper-
ature of 35°C.
1) Measuring method according to EN 60335-1
No power.
v Check fuses and electric
connections.
The cut-in and cut-out height varies.
Cut-in / Cut-out height
Dirt particles are jammed
in the suction base.
v Disconnect plug and clean
suction base (see 5. Clean-
ing).
The residual water depth (draining in the flat position down
to approx. 5 mm) is only reached during manual operation
(see 4. Operation).
Pump runs, but output
suddenly decreases.
Suction base is clogged.
v Disconnect plug and clean
suction base (see 5. Clean-
ing).
The GARDENA Submersible Pump is manufactured in accordance
with the current electrical safety regulations of the Appliance
Safety Law (GSG) and inspected by the TÜV (German institution
for technical surveillance).
Safety and
Approval
14
15
Download from Www.Somanuals.com. All Manuals Search And Download.
G
G
Performance characteristics
EU Certificate of Conformity
The undersigned
m
5
bar
0.5
GARDENA Kress + Kastner GmbH · Hans-Lorenser-Str. 40 · D-89079 Ulm
4
3
2
1
0
0.4
0.3
0.2
0.1
hereby certifies that, when leaving our factory, the unit indicated below is in accordance with the
harmonised EU guidelines, EU standards of safety and product specific standards.
This certificate becomes void if the unit is modified without our approval.
Description of the units:
Types:
Submersible Pump
5000 S
Art. No.:
1778
EU directives:
Machinery Directive 98/37/EC
Electromagnetic Compatibility 89/336/EC
Low Voltage Directive 73/23/EC
Directive 93/68/EC
0
1000
2000
3000
4000
5000
l/h
Harmonised
European standards:
9. Service
EN 292-1
EN 292-2
EN 60335-1
EN 60335-2-41
Ulm, 29.05.2001
GARDENA guarantees this product for 2 years (from date of
purchase). This guarantee covers all serious defects of the unit
that can be proved to be material or manufacturing faults. Under
warranty we will either replace the unit or repair it free of charge
if the following conditions apply:
Warranty
Year of CE marking:
2002
Thomas Heinl
Technical Dept. Manager
• The unit must have been handled properly and in keeping
with the requirements of the operating instructions.
• Neither the purchaser or a non-authorised third party have
attempted to repair the unit.
The turbine is a wearing part and is not covered by the guar-antee.
This manufacturer’s guarantee does not affect the user’s existing
warranty claims against the dealer/seller.
If you have any problems with your pump, please contact our
Customer Service or return the defective unit together with
a short description of the problem directly to one of the
GARDENA Service Centres listed on the back of this leaflet.
We expressly point out that, in accordance with the product
liability law, we are not liable for any damage caused by our units
if it is due to improper repair or if parts exchanged are not original
GARDENA parts or parts approved by us, and, if the repairs were
not carried out by a GARDENA Service Centre or an authorised
specialist. The same applies to spare parts and accessories.
Product Liability
16
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Deutschland
GARDENA Kress + Kastner GmbH
GARDENA Service
Hans-Lorenser-Straße 40
D-89079 Ulm
Produktfragen: (0731) 490-123
Reparaturen: (0731) 490-290
Finland
Norway
Habitec Oy
GARDENA Norge A/S
Postboks 214
2013 Skjetten
Martinkyläntie 52
01720 Vantaa
France
Poland
GARDENA France
Service Après-Vente
BP 50080
GARDENA Polska Sp. z o.o.
Szymanów 9 d
Argentina
05-532 Baniocha
Argensem S.A.
95948 ROISSY CDG Cedex
Portugal
Venezuela 1075
Great Britain
MARKT (Portugal), Lda.
Recta da Granja do Marquês
Edif. GARDENA
(1618) El Talar - Buenos Aires
GARDENA UK Ltd.
27-28 Brenkley Way
Blezard Business Park
Seaton Burn
Australia
NYLEX Corporation Ltd.
25-29 Nepean Highway
P.O. Box 68
Algueirão
2725-596 Mem Martins
Newcastle upon Tyne
NE13 6DS
Russia / Россия
АО АМИДА ТТЦ
Mentone, Victoria 3194
Austria
Greece
ул. Моcфилмовcкая 66
117330 Моcква
GARDENA Österreich Ges. m.b.H.
Stettnerweg 11-15
2100 Korneuburg
Agrokip G. Psomadopoulos & Co.
20, Lykourgou str.
Kallithea - Athens
Singapore
Variware
Holland Road Shopping Centre
227-A 1st Fl., Unit 29
Holland Avenue
Singapore 1027
Belgium
Hungary
MARKT (Belgium) NV/SA
Sterrebeekstraat 163
1930 Zaventem
GARDENA Magyarország Kft.
Késmárk utca 22
1158 Budapest
Brazil
Iceland
Heimilistaeki hf
Saetun 8
P.O. Box 5340
125 Reykjavik
Slowenia / Croatia
Silk d.o.o. Trgovina
Brodišče 15
M. Cassab
Av. das Nações Unidas, 20.882
Santo Amaro, CEP 04795-000
São Paulo - S.P.
1236 Trzin
South Africa
Bulgaria / България
ДЕНЕКС ООД
Бул. ”Г.М.Димитров” 16 ет.4
София 1797
Republic of Ireland
Michael McLoughlin & Sons
Hardware Limited
Long Mile Road
GARDENA South Africa (Pty.) Ltd.
P.O. Box 11534
Vorna Valley 1686
Spain
Dublin 12
Canada
ANMI Andreu y Miriam S.A.
Calle Pere IV, 111
08018 Barcelona
GARDENA Canada Ltd.
100, Summerlea Road
Brampton, Ontario
Canada L6T 4X3
Italy
GARDENA Italia S.r.l.
Via Donizetti 22
20020 Lainate (Mi)
Sweden
GARDENA Svenska AB
Box 9003
Chile
Japan
Antonio Martinic Y CIA. LTDA.
Gilberto Fuenzalida 185 Loc.
Las Condes - Santiago de Chile
KAKUDAI Mfg. Co. Ltd.
1-4-4, Itachibori Nishi-ku
Osaka 550
20039 Malmö
Switzerland
GARDENA Kress + Kastner AG
Bitziberg 1
Costa Rica
Luxembourg
Magasins Jules Neuberg
Grand Rue 30
Case Postale No. 12
Luxembourg 2010
Compania Exim
Euroiberoamericana S.A.
350 Sur del Automercado
Los Yoses
8184 Bachenbülach
Ukraine / Украина
АОЗТ АЛЬЦЕСТ
ул. Гайдара 50
г. Киев 01033
San Pedro
Netherlands
Cyprus
GARDENA Nederland B.V.
Postbus 50176
Turkey
FARMOKIPIKI LTD
P.O. Box 7098
74, Digeni Akrita Ave.
1641 Nicosia
Dost Diþ Ticaret Mümessillik A.Þ.
Yeþilbaðlar Mah. Baþkent
Cad. No. 26
1305 AD ALMERE
Neth. Antilles
Jonka Enterprises N.V.
Sta. Rosa Weg 196
P.O. Box 8200
Pendik - Ýstanbul
Czech Republic
GARDENA spol. s.r.o.
Шнpskб 20a, и.p. 1153
62700 Brno
USA
GARDENA
3085 Shawnee Drive
Winchester, VA 22604
Curaçao
New Zealand
NYLEX New Zealand Limited
Private Bag 94001
South Auckland Mail Centre
10 Offenhauser Drive
East Tamaki, Manukau
Denmark
GARDENA Danmark A/S
Naverland 8
1778-20.960.01/0021
GARDENA Kress + Kastner GmbH
©
2600 Glostrup
Postfach 27 47, D-89070 Ulm
http://www.gardena.com
Download from Www.Somanuals.com. All Manuals Search And Download.
|