Operation, Maintenance and Installation Manual
KG 291 CA
Gas Cooktop
Download from Www.Somanuals.com. All Manuals Search And Download.
FOR YOUR SAFETY
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury or death.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
– Do not try to light any appliance.
– Do not touch any electrical switch;
do not use any phone in your building.
– Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
– If you cannot reach your gas supplier,
call the fire department.
Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
1. Important Information for Installation and Use
1. Do not allow the flame to extend beyond the
edge of the cooking utensil. This instruction is
based on safety considerations.
Note:
To avoid jeopardising the electrical safety of the
appliance, it is forbidden to use high-pressure or
steam jet cleaning devices.
2. Do not forget that the unit becomes hot when in
use. Common sense is important. Just because
the flame is out, it does not mean parts still
cannot be hot.
Note:
The name plate is attached to the bottom of the unit
and to the inside of the housing.
3. This appliance shall not be used for space
heating. This instruction is based on safety
considerations.
Only for installation in USA:
This installation must conform with local codes or, in
absence of local codes, with the National Fuel Gas
Code, ANSI Z 223.1 Current Issue.
4. Be sure to disconnect the electrical supply
before disassembly of the appliance.
5. Keep the appliance area clear and free from
combustible materials, gasoline and other
flammable vapors and liquids.
The installer must leave these instructions with the
appliance, and the consumer should keep them for
future reference. If an external electrical source is
utilized, the appliance must be electrically
grounded in accordance with local codes, with the
National Electrical Code ANSI/NFPA 70 Current
Issue.
6. Do not obstruct the flow of combustion and
ventilation air.
7. Cabinets installed above the gas cooktop must
have a minimum distance of 762 mm (30 ).
8. The gas pressure regulator supplied with the
appliance must be installed in line with the gas
pipe.
Only for installation in Canada:
In Canada, installation must be in accordance with
the CAN 1-B149.1 and .2 – Installation Codes for
Gas Burning Appliances and/or local codes. The
installer must leave these Instructions with the
appliance and the Consumer should retain them for
future reference.
9. The appliance and its individual shutoff valve
must be disconnected from the gas supply
piping system during any pressure testing of the
system at test pressures in excess of 3.5 kPa
(1/2 psig). The appliance must be isolated from
the gas supply piping system by closing its
individual manual shutoff valve during any
pressure testing of the gas supply piping system
at test pressures equal to or less than 3.5 kPa
(1/2 psig).
This appliance when installed, must be electrically
grounded in accordance with local codes or, in the
absence of local codes, with the current CSA
Standard C 22.1-Canadian Electrical Code, Part I.
For mobile Housing and Recreational Vehicle
installation must conform with the following:
CAN/CSA Z240 MH
10.Important:
When using a very large pot, keep a distance of
at least 50 mm (2") to avoid damaging any parts
in counter top wood, plastic or other non-heat-
resistant materials. Never leave oil or hot fat
unattended.
CAN/CSA Z240 RV
Installation Requirement For Gas Burning
Appliances And Equipment In Mobile Homes CSA
Standard C 22:1 - Canadian Electrical Code Part 1
and /or local Codes.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
2. General Safety Instructions
Read all instructions in this Operation and
Maintenance Manual carefully before using
your new GAGGENAU Cooktop. As the user, you
are responsible for maintenance and proper use in
the household.
• Do not store items of interest to children
above the cooktop or at the back of it. If
children should climb onto the appliance to reach
these items, they could be seriously injured.
• Never use any part of the cooktop for
storage. Flammable materials can catch fire and
plastic items may melt or ignite.
WARNING: These precautions will reduce the
risk of burns, electric shock, fire, and injury to
persons. Use extreme care when using this
cooktop as this appliance provides intense
heat and can increase the accident potential.
• When connecting electrical appliances near
the Cooktop, make sure that connecting cables do
not come into contact with hot cooking surfaces!
• If the cooktop is near a window, be certain the
curtains do not blow over or near the Cooktop
burners; they could catch on fire.
When using kitchen appliances, these basic
safety precautions must be followed:
• Insure proper installation and servicing.
Follow the installation instructions provided with
this product. Have the cooktop installed and
grounded by a qualified technician. Do not
operate the appliance if it is damaged.
• DO NOT USE WATER ON GREASE FIRES.
Turn appliance off and smother fire with baking
soda or use a dry chemical or foam-type
extinguisher.
• Never let clothing, pot holders, or other
flammable materials come in contact with or
close to any burner or burner grate until it has
cooled. Fabric may ignite and result in personal
injury.
• Have the installer show you where the gas
supply shut-off valve is located so that you
know how and where to turn off the gas to the
cooktop.
• If you smell gas, follow the instructions on
page 2. If the connections are not perfectly tight,
you can have a small leak and therefore a faint
gas smell. Finding a gas leak must be done by a
qualified service technician.
• Use only dry pot holders. Moist or damp pot
holders on hot surfaces may cause burns from
steam. Do not use a towel or other bulky cloth in
place of pot holders. Do not let pot holders touch
hot burner grates.
• Do not repair or replace any part of the
appliance unless specifically recommended in
this manual. All other servicing should be referred
to a qualified technician. Disconnect the
appliance from the power supply at the fuse point
and the gas supply during every maintenance
operation.
• For personal safety, wear proper apparel.
Loose fitting garments or hanging sleeves should
never be worn while using this appliance. Some
synthetic fabrics are highly flammable and should
not be worn while cooking.
• The appliance is designed for cooking food.
Based on safety considerations, never use the
Cooktop to warm or heat a room. Such use can
damage the Cooktop.
• Children should not be left alone or
unattended in an area where appliances are
in use. They should never be allowed to sit or
stand on any part of the appliance.
• When using the Cooktop: DO NOT TOUCH THE
BURNER GRATES OR THE IMMEDIATE
SURROUNDING AREAS. They become hot
enough to cause burns.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
• Never leave the cooktop unattended.
Boil-overs cause smoking and greasy spills that
may ignite.
• For proper lighting and performance of the
burners, keep the ports clean. It is necessary to
clean these when there is a boil over or when the
burner does not light even though the electronic
igniters click. See care and maintenance section.
• Only certain types of glass, heatproof glass-
ceramic, ceramic, earthenware or other
glazed utensils are suitable for cooktop use.
This type of utensil may break with sudden
temperature changes. Use only on low or medium
heat settings according to the utensil
• Clean the cooktop with caution. Avoid steam
burns; do not use a wet sponge or cloth to clean
the cooktop while it is hot. Some cleaners
produce noxious fumes if applied to a hot surface.
Follow directions provided by the cleaner
manufacturer.
manufacturer’s directions.
• Do not heat unopened food containers; a
buildup of pressure may cause the container to
burst.
• Be sure all cooktop controls are turned off
and the cooktop is cool before using any type of
aerosol cleaner on or around the cooktop. The
chemicals that produce the spraying action can, in
the presence of heat, ignite or cause metal parts
to corrode. Service should only be done by
authorized technicians. Technicians must
disconnect the power supply before servicing this
unit.
• During cooking, set the burner control so that
the flame heats only the bottom of the pan
and does not extend beyond the bottom of the
pan.
• Use caution to insure that drafts like those from
forced air vents or fans do not blow flammable
material toward the flames or push the flames so
that they extend beyond the edges of the pot.
• To avoid fire hazard, clean the ventilator
hood and filters above the cooktop frequently
so grease from cooking vapors does not
accumulate on them.
• Always use utensils that have flat bottoms,
large enough to cover the burner. The use of
undersized utensils can expose a portion of the
flame and may result in ignition of clothing.
• Install a smoke detector in or near the kitchen.
• No warranty claims can be lodged for any
damage resulting from failure to observe these
instructions. Technical modifications reserved.
• To minimize burns, ignition of flammable materials
and unintentional spills, position handles of
utensils inward so they do not extend over
adjacent work areas, cooking areas or the edge of • California Proposition 65 Warning: The
the cooktop.
burning of gas cooking fuel generates some by-
products which are on the list of substances which
are known by the State of California to cause
cancer or reproductive harm. California law
requires businesses to warn customers of
potential exposure to such substances. To
minimize exposure to these substances, always
operate this unit according to the instructions
contained in this booklet and provide good
ventilation to the room when cooking with gas.
• Hold the handle of the pan to prevent
movement of the utensil when stirring or turning
food.
• GREASE IS FLAMMABLE. Let hot grease cool
before attempting to handle it. Avoid letting
grease deposits collect. Clean after each use.
SAVE THESE INSTRUCTIONS
5
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Important Notes
For Your Safety
Operating for the First Time
You must not operate the appliance if it is damaged. Remove the packaging from the appliance and
dispose of it according to local regulations. Be
When connecting electrical appliances in the proxi-
careful to remove all accessories from the
mity of the appliance, make sure that connecting
packaging. Keep packaging elements and plastic
leads do not come into contact with hot cooking
bags away from children.
surfaces!
Check the appliance for transport damage before
As the user, you yourself are responsible for
installing it.
maintenance and proper use in the household.
The appliance must be installed and connected by
an authorised specialist before operation. The
Only ever operate the appliance under supervision.
installation must conform with all current regulations
of the gas supply companies and the regional
construction regulations.
Do not operate the appliance without pots and pans
placed on it. Make sure that all the burner parts are
correctly fitted.
Turn all control knobs to the OFF position before
connecting the appliance to the power supply.
Caution: The appliance heats up during operation.
Keep children away.
The serial number of the appliance can be found on
the quality control slip which is included with these
instructions. This quality control slip should be kept,
for guarantee reasons, together with your operating
and assembly instructions.
Do not clean the appliance with a steam cleaning
apparatus or with water pressure - risk of short-
circuits!
Isolate the appliance from the power during every
maintenance operation. To do this, remove the
power plug or switch off the corresponding
household fuse. Close the gas supply.
Read through these instructions attentively before
operating your appliance for the first time.
Thoroughly clean the appliance and accessories
before using them for the first time. This will
eliminate any 'newness' smells and soiling (see
chapter “Cleaning and care”).
Repairs must be carried out by authorised specia-
lists, thus ensuring electrical safety.
No warranty claims can be lodged for any damage
resulting from failure to observe these instructions.
Observe caution with oils and fats. They may
overheat and burn easily.
Foodstuffs that are prepared in fat and oil must only
be prepared under constant supervision!
Technical modifications reserved.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
To Use
The appliance is intended solely for use in the
household and must not be put to any other uses.
Pots with a diameter of less than 90 mm (3 1/2 ) or
more than 280 mm (11 ) / 320 mm (12 1/2 ) for
the large (WOK) burner should not be used.
When using large pots, pay attention to keeping to
a minimum distance of 50 mm (2 ) between the
cooking vessel and combustible surroundings.
A minimum distance of 50 mm (2 ) must be
observed between the control knob / control panel
and the pot or pan. The pot or pan should not touch
the control panel.
Use the appliance to prepare meals only. It must not
be used to heat up the room in which it is installed.
Use of a gas cooktop generates heat and
humidity in the room where it is installed. This is
why attention must be paid to good kitchen
ventilation.
The natural ventilation openings must be kept
unobstructed. Prolonged use of the appliance
with several or all rings may call for additional
ventilation such as opening a window or a door,
or stronger air extraction by an extractor hood.
Switch the burners to the low setting whenever you
remove pots or pans briefly. In this way, you reduce
the risk of burns when working next to open flames;
you also save gas and reduce pollution.
To guarantee good combustion, the room in
which the appliance is installed must have
a minimum volume of 1240 cft (35 m3) and must
possess a door that opens outdoors or a
window that can be opened.
Whenever the gas hob is fitted under an extractor
hood, always cover the rings with pots or pans.
Otherwise, parts of the extractor hood may become
damaged by the extreme heat development or
grease residues in the filter may ignite.
Ensure an adequate supply of air when using
an extractor hood operating in the extraction
mode!
Keep the ventilation openings at the back of the
appliance free at all times.
Only ever use the burners after placing pots
and pans on them. Do not heat up any empty
pots or pans.
The appliance cannot be used during a power
failure.
In the event of malfunctions, contact your specialist
dealer or Gaggenau USA on (800) 828-9165.
It is not permitted to use roasting pans, frying pans
or grill stones heated simultaneously by several
burners because the resulting heat build-up may
damage the appliance.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Features
Features of the Appliance
1 Pot grids
5
(3 parts, the left and right part are identical)
1
2 Large (Wok) burner 17,000 BTU (5.0 kW)
3 Large burner 14,500 BTU (4.2 kW)
4 Normal burner 7,000 BTU (2.1 kW)
5 Ventilation openings
4
3
4
2
3
Control Knob
6 Symbol for corresponding cooking position
7 Indicator light
6
7
8 Flame setting:
0
OFF
8
High setting of outer and inner flame ring
Low setting of outer flame ring
High setting of inner flame ring
Burner Parts
Outer flame ring off
High setting of inner flame ring
9
Outer flame ring off
Low setting of inner flame ring
10
11
9 Burner head cover
10 Burner ring
11 Burner head
12 Electrode for automatic ignition,
flame detection and flame control
12
8
Download from Www.Somanuals.com. All Manuals Search And Download.
5. Operating Principle
The gas hob features two normal burners,
two large burners and a Wok burner.
The appliance features one-hand operation, flame
detection and automatic re-ignition. The ignition is
activated when the control knob is turned.
Should the flame go out during operation, the
appliance will automatically re-ignite the burner.
Off
During a disturbance, the appliance will cut off the
gas supply as a safety measure, to prevent
unburned gas escaping.
The flame setting is infinitely variable between high
and low.
High
The total rated thermal load amounts to:
60,000 BTU (17.6 kW)
The specified rated load is defined by installation
of the fixed nozzles.
The gas hob is converted to a different gas
type by nozzle replacement (full and low-burning
nozzles) (see nozzle table on page 20).
Low
9
Download from Www.Somanuals.com. All Manuals Search And Download.
6. Operation
Only light a burner if all burner parts are dry, and
assembled correctly. Otherwise, malfunctions may
occur or the appliance may switch off.
Switching on
• Place a suitable pot or a pan on the corresponding
cooking position.
• Press down the control knob for the corresponding
cooking position and turn it to the required
position between the and symbols. The burner
ignites automatically.
• When using large pots or pans you should ignite
the burner in the low position.
• Every time the gas hob is switched on, the
electronics run an auto test. All electrodes fire
and the required burner ignites after a few
seconds. When switching on further burners, only
the corresponding electrode fires.
• When being switched on, a short sound may be
heard when the electronic of the gas hob opens
the gas supply valve. This is a normal condition.
The flame size can be set continuously between full
and low by slowly turning the control knob.
Indicator light
The indicator light next to the control knob comes
on, if the burner is switched on and the flame burns
correctly.
Should the flame go out during operation (e.g.
because of a draught), the appliance will
automatically re-ignite the burner.
Should the re-ignition be unsuccessful (e.g. burner
is soiled by spilled over food or liquid), all burners
are switched off, the indicator lights of the burners
that were switched on flash. Turn all control knobs
to the OFF position. The flashing indicator lights will
go out except for the affected burner. This indicator
will continue to flash for a few seconds. After the
10
Download from Www.Somanuals.com. All Manuals Search And Download.
appliance has cooled down sufficiently, check this
burner to see if all the burner parts have been
assembled correctly. Check if the burner or the
electrode has been soiled (see trouble shooting
guide on page 19).
Note: if a malfunction occurs on one burner, you
can continue using the remaining burners, however,
you must turn all control knobs to the off-position
first, before recommencing.
Switching off
Fully turn the control knob to the OFF position.
The electronics of the appliance switch the gas
supply off, if all control knobs are in the off position.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
7. Burner Settings Chart
Cooking
level
Cooking method
Examples
High
Boiling
Water
Searing
Heating
Boiling
Meat
Fat, liquids
Soup, sauce
Vegetables
Blanching
Roasting
Meat, fish, potatoes
Flour, onions
Almonds, breadcrumbs
Pancakes, egg dishes
Liquids
Dumplings, sausages, soup garnish,
meat stock, poached eggs
From
to
Browning
Roasting
Baking
Boiling in open pot
Simmering in open pot
Simmering
Boiling with closed lid
Steaming
Sweet sauces
From
to
Pasta, soup, sauces
Vegetables, potatoes, fish
Vegetables, fruit, fish
Goulash, rolled beef steaks, roasts,
vegetables
Stewing
Braising
Low
Thawing
Slow cooking
Reheating
Frozen foods
Rice, pulses
Soup, casserole, vegetables in a sauce
Switch to the high setting in order to reach the required temperature quickly. Then switch back to a lower
setting.
The output of the inner flame ring is the same on the normal, as well as the large burners.
The values given above must be looked upon as recommended values. The heat required depends not
only on the type and condition of the food, but also the size and contents of the pot.
Due to the high performance of the cooktop, fat and oil will heat up quickly. Never leave the cooktop
unattended, fat can ignite, food can burn.
Preferably use the rear cooking zones to prepare meals, that need longer to cook.
Preferably use the larger burners or the wok burner for brief cooking, deep fat frying and brief frying of
large quantities.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
8. Cookware Recommendations
Pots with a diameter of less than 90 mm (3 1/2 ) or
more than 280 mm (11 ) / 320 mm (12 1/2 ) for
the large (WOK) burner should not be used.
When using large pots, pay attention to keeping to
a minimum distance of 50 mm (2 ) between the
cooking vessel and combustible surroundings.
A minimum distance of 50 mm (2 ) must be
observed between the control knob / control panel
and the pot or pan. The pot or pan should not touch
the control panel.
KG 291
Recommended Minimum
pot diameter pot diameter
Normal Burner
Large Burner
7 3/4 - 9 1/2
3 1/2
3 1/2
6 1/4
9 1/2 - 11
Large Burner (Wok) 9 1/2 - 12 1/2
When buying pots, pay attention to the fact
that the manufacturer frequently specifies the top
pot diameter, which is generally larger than the
diameter of the base.
Observe the manufacturer’s specifications! Use
cooking utensils that the manufacturer states as
being “suitable for gas". Use pots with heat resistant
handles.
Use pots and pans with a thick base, because heat
distribution is particularly improved in the low
setting. Using the correct size of pots and pans for
the burner ensures improved cooking performance
and energy efficiency.
To ensure an even distribution of heat, center the
pot above the burner. The flames should be
covered by the pot base.
Place the pot or pan securely and level on the pot
grid. Turn the pan handle to the side, it should not
point to the front. In order to guarantee a secure
position on the pot grid, the pot base should be flat
and not warped or dented.
Placing a fitting lid on the pot will shorten cooking
times. Through a glass lid you can watch the
cooking progress without having to take the lid off.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
9. Wok Cookware Recommendations
The Wok and Accessories
Cooking in the Wok
You can fry, steam, deep fry, stew and cook normally.
(not included in the scope of delivery)
– The round-bottom wok is the ideal wok for your
gas cooktop.
Stir frying is the special cooking method for the
wok. Ingredients cut into small pieces are cooked
as briefly as possible under strong heat and
constant stirring. In the large, round pan everything
can be stirred and turned faster and with greater
ease than in a conventional frying pan. Thanks to
stirring, ingredients do not burn onto the pan.
Surplus oil drains off towards the middle. In next to
no time, you obtain delicious roasted foods, the
pores in meat close and fish becomes nices and
juicy. Vegetables stay crispy, and aromas and
healthy vitamins are retained.
– The wok looks like a hollow semisphere with a
long handle or wooden handle. It has a rounded
base and slanted sides. The thin steel passes the
heat swiftly to the inside, but soon cools down
again as soon as the flame is set to a lower
setting. Therefore, ingredients cannot overcook.
– The diameter is between 35 - 40 cm / 14 - 15 3/4”
for 4 persons.
– Make sure that a wok with a rounded base is
positioned safely on the pot grid.
Important: the cooking time is so short that all
ingredients should be ready for cooking before you
begin. The correct sequence is also important. First
place the ingredients with the longest cooking time
in the wok. For example, these are hard-fibred
vegetables such as carrots. Soft vegetables such as
mushrooms or sprouts are added later.
– Woks may consist of various materials. Cast-iron
woks are more stable and keep the heat longer.
– They have a round, high cover. Therefore, they
are also capable of steaming and stewing.
– The semicircular grid is hooked in on the edge of
the wok. On it, you can steam ingredients, you
can allow deep fried foods to drip or you can
keep browned foods warm.
Proceed as follows:
– Pour sufficient oil into the wok to coat the surface.
We advise you to use peanut or or soya oil.
– Use the chan (rounded spatula) or the wooden
pan reversing implement.
– Heat up the oil to just before the smoking point;
only then begin with stir frying.
– Use a ladle to remove foods.
– Cut the food into pieces of equal size, but not too
small, thus making sure they will not burn.
– Use the strainer to lift deep fried foods from the
fat or large pieces out of a sauce.
– If you are cooking larger quantities, work with
portions as otherwise not all of the food will reach
the hot base of the wok.
– You can use bamboo baskets for steaming.
– Meals that are ready ca be kept warm on a
minimal flame. Clean the wok after every use and
rub its inside with oil. This will prevent rusting.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
10. Cleaning and Care
burner assembly normal burner / large burner
burner assembly wok burner
burner head cover
burner ring
burner head
electrode
burner base
Keep the ventilation openings on the rear of the
appliance clean. Do not block the ventilation
openings.
Note: to avoid jeopardising the electrical safety of
the appliance, do not use high-pressure or steam
jet cleaning devices – risk of short circuits!
The burners (burner head cover, burner ring and
burner head) will change their color during
operation and become darker. This change in color
will not influence the use-value.
Caution, risk of burns! Before cleaning,
please wait until the cooktop has cooled.
Never switch on the cooktop while cleaning.
Please thoroughly clean the appliance before
operating it for the first time and after every use.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Do not use scouring agents, abrasives or chemically • Soak burnt-in remainders in a little water and
aggressive cleaners (for example oven cleaner)!
Do not use any nitro polishing agents for cleaning!
Do not use any abrasive sponges either.
detergent. This loosens even the most stubborn of
soiling. Do not use any abrasive agents and
abrasive sponges.
• Only use very little water to clean your cooktop.
Be careful that no water enters the burner base.
Before cleaning, please wait until the cooktop
has cooled.
• As the result of heat development, slight dis-
coloration can appear on the stainless steel
surface. Do not attempt to scrape away such
discoloration. This damages the surface.
Distribute stainless steel care agents uniformly
and thinly on the hob (not on the control panel!).
This will ensure an even surface and will keep
your hob in a good condition for a long period of
time.
• First lift one of the pot grids on the side with both
hands (be careful not to scratch the base). Then
remove the remaining two pot grids.
• Remove the burner head cover, the burner ring
and the burner head.
• Important! Only clean the burner parts when
cold!
• Make sure the burner parts are dry before
assembly. Only operate the appliance with all
parts dry. Damp burner parts will cause
malfunctions when igniting or unstable flames.
• When assembling the burner parts, make sure
that the burner ring and burner head are placed in
such a way that the locking lugs fit in the
corresponding recesses.
• Important! Fit the middle pot support first
(be careful to center it over the burner) and
then the pot supports on the side. The
rounded corners of the pot supports on the
side must face out to the side.
Part / Material
Suggested Cleaning Procedure
Important Reminders
Control Panel
(anodized
aluminum)
Use cloth with detergent and hot water. Do not use strongly alkaline cleaning
Remove greasy splashes with a
commercially available cleaner for
aluminum. Make sure the cleaning
agent will not scratch the surface.
agents. These cleaners may cause
permanent discoloration!
Control Knobs
(mat chromium
plated )
Use cloth with detergent and hot water. Do not clean in a dishwasher.
see next page
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Part / Material
Suggested Cleaning Procedure
Important Reminders
Pot Grid
(enamel on
cast iron)
Take pot grids off for cleaning.
Soak in sink. Clean with detergent
and brush.
Do not clean in a dishwasher.
Soak burnt-in remainders in sink.
Abrasive cleaners, used too vigorously or
too often can eventually mar the enamel.
Burner Head Cover, Remove coarse soiling with damp
Do not clean in a dishwasher.
Port openings must be kept free.
Be careful not to loose the small parts.
Burner Ring,
Burner Head
(brass)
cloth and detergent.
Use brass polish to keep the
original shiny surface.
Wok Burner Head
(enamel on
cast iron)
Clean with detergent and brush.
Do not clean in a dishwasher.
Electrode
Clean with brush, fine glass-paper
or scouring pad.
Soiled electrodes may cause malfunctions
when igniting or flame control disturbance.
Be careful when cleaning electrodes,
they are fragile, do not turn.
Caution: never switch on cooktop while
cleaning electrodes.
Base
Cloth with detergent and hot water.
Soak burnt-in remainders with a
little detergent solution.
After cleaning, polish dry with a
soft cloth to prevent water stains
forming on the surface.
To prevent marring the polished stainless
steel base, always polish in the direction
of the polish lines.
(stainless steel,
shot blasted,
brushed)
Light discolorations may form if the
natural oxidation is removed together
with the soiling. Put some commercially
available stainless steel polish on a cloth
and polish the whole cooktop after cleaning
to get an even stainless steel surface.
Never allow food stains or salt to remain
on stainless steel for any length of time.
Important: certain stainless steel cleaners
will scratch the surface. Chlorine or
chlorine compounds in some cleaners are
corrosive to stainless steel. Check
ingredients on label.
Bar keeper’s friend recommended.
Caution: no liquid should enter
the housing of the cooktop
through the burner base.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
11. Maintenance
The appliance must be disconnected from the
power and gas supply during all repair work.
In the event of malfunctions, check whether the gas
and electricity supplies are in proper working
order.
The cooktop cannot be used during a power failure.
If the cooktop is being used when the power failure
occurs, turn all of the burner control knobs to the
OFF position. The cooktop will not turn back on
after a power failure until all control knobs are first
turned OFF and then turned back on again.
Before calling the service engineer, check the
trouble-shooting guide on page 19 to see, if you can
rectify the problem yourself. If your appliance still
does not work, please contact your Gaggenau
dealer who will provide you with the address and
telephone number of your nearest manufacturer’s
authorized service agent or contact Gaggenau USA
on (800) 828-9165. Specify the appliance type (see
rating plate).
Repairs may only be carried out by authorised
technicians, in order to guarantee the safety of the
appliance.
Unauthorised tampering with the appliance will
invalidate any warranty claims.
Only use original spare parts.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
12. Trouble Shooting
Not every malfunction can be ascribed to a defect
of your cooktop. If your appliance does not function
properly, look for the fault in the list below.
If you are not successful in remedying the fault with
the aid of the list below, then contact your
Gaggenau after-sales service.
Fault
Remedy
The burner does not ignite, the indicator
light is flashing.
Is the burner correctly assembled?
Is the manual gas shut-off valve open?
Is the burner clean and dry?
Is the propane gas tank empty?
Is there an air pocket in the gas supply line after
changing the propane gas tank?
Turn all control knobs off and switch on again.
If necessary, inform after-sales service.
The burner does not ignite, the indicator
lights are off.
Check whether the domestic fuse has tripped.
The gas flame goes off during operation,
re-ignition is unsuccessful, all burners off,
the indicator lights of the switched on
burners are flashing.
Turn all control knobs off. The flashing indicator lights
go off, except for the indicator of the affected burner.
This indicator will continue to flash for a few seconds.
Wait until the appliance has cooled down sufficiently,
then check this burner, whether
...the burner head cover is fitted correctly.
...the burner is soiled by boiled over food.
...the electrode is soiled (food remains). Carefully
clean the electrode.
...the propane gas tank is empty.
...the burner cannot ignite because of a strong draught
(for example open window behind the cooktop).
After a power failure, the appliance does not re-ignite
automatically.
After prolonged operation, all burners switch Overheating protection. Turn all control knobs off and
off, the indicator lights flash. wait for the indicator lights to go off.
Appliance does not react when switched on. Turn all control knobs off and disconnect the appliance
from the power supply for a few seconds (switch off
fuse). If necessary, inform after-sales service.
The flame tips are yellow and not blue.
Check whether...
...the burners are clean and dry.
...the pot base or the pot grid are soiled.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
13. Technical Data / Settings Table
Technical data (gas)
Technical data (electrical)
Burners: Normal burner
Rated consumption
Voltage
15 W
Full burning
Low burning
Large burner
Full burning
Low burning
Wok burner
Full burning
Low burning
Total output
7,000 BTU (2.1 kW)
700 BTU (0.175 kW)
AC 120 V
60 Hz
Frequency
14,500 BTU (4.2 kW)
700 BTU (0.175 kW)
Technical modifications reserved.
17,000 BTU (5.0 kW)
1,000 BTU (0.3 kW)
60,000 BTU (17.6 kW)
Gas connection: R 1/2’’ union nut for R 1/2’’
bracket to DIN 1999, conical-cylindrical
Settings table
Countries
US
CA
US
CA
Gas family
Pressure
Natural gas
Propane gas / L.P.G.
10” W.C. (2.5 kPa)
6” W.C. (1.5 kPa)
Wok burner, full burning
1.70
0.59
2 / 3
1.10
0.41
0 / 6
Wok burner, low burning
Air gap adjustm. outer/inner [mm]
Large burner, full burning
1.48
0.49
1.03
0.34
Large burner, low burning
Air gap adjustm. outer/inner [mm]
0 / fixed
3 / fixed
Normal burner, full burning
Normal burner, low burning
Air gap adjustm. outer/inner [mm]
1.01
0.69
0.49
0.34
0 / fixed
3 / fixed
Total output (5 burners)
60,000 BTU (17.6 kW)
60,000 BTU (17.6 kW)
20
Download from Www.Somanuals.com. All Manuals Search And Download.
GAGGENAU HAUSGERÄTE GMBH
P.O. BOX 10 02 50 · 80076 MÜNCHEN
GERMANY
5551 McFADDEN AVENUE
HUNTINGTON BEACH, CA 92649
USA
Y (089) 45 90-03
Y (800) 828-9165 · FAX (714) 901-0979
FAX (089) 45 90-23 47
Download from Www.Somanuals.com. All Manuals Search And Download.
|