FW222 integrated under
counter larder fridge
Manual for Installation, Use and Maintenance
Customer Care Department • The
Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
FW222 Fridge Freezer Manual.indd
1
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Important
Never store inflammable or explosive items and strong corrosive acids or alkalis in the appliance.
This is a household appliance, which is produced in accordance with the national standard. It is intended for food storage
only, not for storage of blood, medicine and biological products.
To prevent risk of fire, keep the appliance away from petrol or any other inflammables.
To prevent risk of electromagnetic interference or other accidents, do not place a microwave oven on top of the
refrigerator or use any electric appliance inside the refrigerator.
Do not allow children to play with or near the appliance.
The internal surface of freezer compartment is very cold when the appliance is running. Do not touch the surface
especially with wet hands.
Do not splash water onto the appliance. Keep it away from places of high humidity that may have adverse effect on the
electric insulation performance.
Please remove the door, door seal and shelves before disposal of the old appliance and put them away in a safe place to
prevent children from being entrapped.
Before first use
You must allow the fridge to settle for at least twenty four hours prior to switching the power on.
It is recommended that you clean the interior of the appliance prior to first use, using a solution of bicarbonate of soda
and warm water and then thoroughly drying the interior.
The fridge may have an odour to it at first use. This will disappear as the appliance cools.
Please note:
The appliance will work continuously until it comes down to the correct temperature.
If the appliance is switched off, you should allow five minutes before switching it on again to prevent unnecessary damage
to the compressor.
Setting the temperature
You must allow the fridge to settle for at least twenty four hours prior to switching the power on.
To adjust the temperature turn the thermostat control knob clockwise (from off) to the required level. The temperature
becomes colder the higher the number on the control.
FW222 Fridge Freezer Manual.indd
3
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Use
Fridge
•
•
Never put liquids in the refrigerator uncovered.
Never put hot foods in the refrigerator. Warm food should be allowed to cool to room temperature before being
put into the refrigerator.
•
Nothing should rest against the rear wall of the refrigerator, as this will cause frost and possible condensation
problems which will be difficult to remove.
•
•
Make sure food is clean and any extra water is wiped away before putting into the fridge.
Wrap or cover food before putting into the fridge. This will help prevent the loss of moisture, keep food fresh and
avoid unpleasant odours.
•
Sort foods prior to storing. Any foods to be used soon should be stored at the front of the shelf to prevent
deterioration caused by the door being open for prolonged periods.
•
•
•
Do not overfill the fridge. There should be sufficient space between the foods to allow the cool air to circulate.
Thawing frozen foods in the fridge compartment will help to keep the temperature low and save energy.
Only open the door for as long as is necessary. Leaving the door open for long periods will affect the temperature
inside the appliance and waste energy.
•
Ensure all compartments are fully closed after use.
FW222 Fridge Freezer Manual.indd
4
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and cleaning
Always disconnect the appliance from the power supply before any cleaning or maintenance.
The fridge sections should be cleaned using a solution of bicarbonate of soda and lukewarm water. Do not use abrasive
products or detergents. After washing, rinse and dry thoroughly.
Clean the shelves and balconies separately by hand with soap and water. Do not put them in the dishwasher.
The water drain hole at the back of the fridge compartment and the evaporating tray should be clened periodically to
prevent the defrosted water from collecting inside the fridge compartment. The drain plug can be used to clean the
drain hole.
Once cleaning is complete, then reconnect the power.
•
•
Keep the door gasket clean. If damaged, the gasket should be replaced.
If the appliance is not used for prolonged periods of time, unplug and clean the appliance. The door should be left
slightly open to prevent the formation of mildew and smell.
Defrosting the fridge
The fridge is self-defrosting. Any water created will run out of the fridge through the channel at the back of the fridge.
It is important to keep the channel clear at all times. The defrosted water is collected in the evaporating tray at the back of
the appliance.
fig. 1
Changing the light bulb
Disconnect the appliance from the power.
•
•
•
Carefully remove the light cover by pushing in the lever at the back of the cover, and then pulling the cover down..
Unscrew the light bulb to remove it and replace with a new bulb (not more than 15W).
Replace the light cover and reconnect the power after five minutes’ delay as explained on page 3.
FW222 Fridge Freezer Manual.indd
5
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting
If you have any problems with your appliance, you should check the troubleshooting prior to calling CDA Customer Care
to prevent unnecessary service calls and potential cost.
If the appliance is not working
•
•
•
•
•
Check there is power to the appliance:
The house fuses are intact and the fuse in the plug has not blown.
The thermostat is not set to 0 (off position).
The plug socket is functioning fine. To check this, plug another electrical appliance in to see if the socket is working.
The temperature of the room is adequate (10oC or above).
The appliance is working, but not very well
•
•
•
•
•
•
The appliance is not overloaded.
The thermostat is set to an appropriate temperature.
The door is closing properly.
The cooling system at the rear of the appliance is clean and free of dust, and not touching the rear wall.
There is enough ventilation at the side and rear walls.
The temperature of the room is adequate (10oC or above).
The appliance is noisy
•
•
•
The appliance is level and stable.
The side and rear walls are clear, and there is nothing resting on the appliance.
The cooling gas in the refrigerator will make a slight bubbling noise, even when the compressor is not running.
There is water in the lower part of the refrigerator compartment
The drain hole in the channel at the back of the compartment is clear.
•
FW222 Fridge Freezer Manual.indd
6
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
This appliance must never be installed close to heat sources i.e. heating elements, radiators, cookers or in
damp places.
The appliance should be mounted on a piece of wood (for example a section of worktop or kitchen carcass)
if a raised floor is to be fitted, if the kitchen floor is to be tiled after installation, or if the installation height
of the appliance is greater than 850 mm.
Contents and Tools Required
Fig. 2 - Installation kit contents
2
1
1. Wood screw (17 pcs)
3
2. Decor door fixing bracket
4
3. Decor door base fixings (2 pcs)
6
5
4. Decorative cover
5. Screw
KIT
6. Top bracket
fig. 2
Fig. 3 - Tools required
7. Spirit level
7
8
8. Spanner
9. Setsquare
10. Flathead screwdriver
10
10
9
9
fig. 3
FW222 Fridge Freezer Manual.indd
7
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 4 - Dimensions of the appliance
600
min
550
548
595
820-
890
819-
889
100- 170
min 25
fig. 4
Fig. 5 - Fitting the worktop bracket
5
Remove the screw (5) on the top of the appliance, locate the top
bracket(6) and fix the bracket with screw(5).
6
fig. 5
Fig.6 - Fitting the spacer piece
Take out the spacer piece (11) located on the side panel and remove
the protective tape. Stick the spacer piece on the opposite side to
the door hinges of the appliance.
11
11
fig. 6
FW222 Fridge Freezer Manual.indd
8
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 7 - Adjusting the appliance height
The height of the appliance can be adjusted by the help of
adjustable feet to fit the furniture height. Use a spirit level to
ensure the appliance is level.
7
7
8
fig. 7
Fig. 8 - Aligning the appliance
Slide the appliance into the kitchen unit and align the hinge surface
with front surface of the kitchen unit.
9
fig. 8
Fig. 9 - Fixing the appliance
1
Screw the hinges and metal bracket to the kitchen unit using
screws (1)
1
fig. 9
FW222 Fridge Freezer Manual.indd
9
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 10 -
Fitting the decor door bracket
C
Unscrew and remove the nuts and washers from the appliance door.
Place fixing bracket on the appliance door by inserting the holes to
adjustment bolts.
B
Dimension B= Measure from the underside surface of kitchen unit
to the bottom of fixing bracket.
fig. 10
Dimension C= Measure from the underside surface of kitchen unit
to the top of next unit door.
Fig. 11 - Fitting the decor door bracket
Substract C from B and put the fixing bracket (2) in place using
this measurement for vertical position and place to the centre for
horizontal position. Secure the fixing bracket (2) using screws(1).
1
B-C
2
fig. 11
Fig. 12 - Fitting the decor door
Place the decor door onto the appliance door by inserting
adjustment bolts into the slots on the fixing bracket. Locate the
washers and screw the nuts onto the adjustment bolts.
fig. 12
FW222 Fridge Freezer Manual.indd 10
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 13 - Aligning the decor door
Close the door and check the alignment with the other unit doors.
Adjust the decor door by screwing or unscrewing the adjustment
bolts for vertical adjustment and by the help of the slots on the
fixing bracket for other directions. Lock the screws into place as
shown in 10.2.
10
8
fig. 13
Fig. 14 - Fitting the decor door base fixings
With the appliance door open, remove the screws at the bottom
of the appliance door. Locate the decor door base fixings (3) and
screw the fixings to the appliance door and the decor door.
3
1
fig. 14
Fig. 15 - Fitting the decorative cover
Fit the decorative cover (4) on the decor door fixing bracket.
4
fig. 15
FW222 Fridge Freezer Manual.indd 11
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 16 - Fitting the plinth
Fit the plinth section, providing minimum 25 mm gap between the
cabinet door and fix it.
Never cover over the ventilation slots.
Once installed the plinth must not block the
ventilation slots in the appliance.
This may require cutting the plinth down. Failure
to ensure adequate ventilation may invalidate the
warranty.
25mm
min
fig. 16
FW222 Fridge Freezer Manual.indd 12
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Reversing the door
It is possible to reverse the door on this appliance, if required.
To do so, follow the steps below:
1. Open the door.
2. Loosen the hinge fixing screws (1) and remove the door.
3. Remove the door fixing screws (2).
4. Remove the cover caps (3).
5. Relocate the hinges as shown.
6. Refit the door to the hinges.
Do not turn the door upside down
7. Insert the cover caps (3) on the opposite side in the exposed
holes.
fig. 17
FW222 Fridge Freezer Manual.indd 13
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical information
Warning! This appliance must be earthed.
The mains lead of this appliance has been fitted with a BS 1363A 13 amp fused plug. To change a fuse in this type of plug,
follow the steps below:
1. Remove the fuse cover and fuse.
2. Fit replacement 13A fuse, ASTA approved to BS 1362 type, into the fuse cover.
3. Replace fuse cover.
Important: Do not use the appliance without the fuse cover in position.
How to connect an alternative plug
If the fitted plug is not suitable for your socket outlet, then it should be cut off and disposed of safely to prevent the risk of
electric shock. A suitable alternative plug of at least 13 Amp rating to BS 1363 should be used.
As the colours of the wires in the mains lead of this appliance may not correspond with the
coloured markings identifying the terminals in your plug, proceed as follows:-
•
•
•
The wire which is coloured GREEN and YELLOW must be connected to the terminal which is marked with letter (E) or
by the Earth symbol or coloured GREEN and YELLOW.
The wire which is coloured BLUE must be connected to the terminal which is marked with the letter (N), or
coloured BLACK.
The wire which is coloured BROWN must be connected to the terminal which is marked with the letter (L) or
coloured RED.
If in doubt regarding the electrical connection of this appliance, consult a qualified electrician. Do not shorten the
supply cable, the appliance may require removing for servicing.
N.B. Ensure that the plug socket is situated in an easily accessible place.
FW222 Fridge Freezer Manual.indd 14
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
FW222 Fridge Freezer Manual.indd 15
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
To contact our Customer Care Department, or for Service,
please contact us on the details below.
Customer Care Department • The
Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
FW222 Fridge Freezer Manual.indd 16
11/02/2011 16:38
Download from Www.Somanuals.com. All Manuals Search And Download.
|