INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 1
®
WARNING
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS
MANUAL TO AVOID PERSONAL
INJURY OR PROPERTY DAMAGE.
WARNING
TO PREVENT DAMAGE TO
EYESIGHT, NEVER LOOK INTO
SPOTLIGHT WHEN LIGHT IS ON. DO
NOT SHINE LIGHT INTO THE FACE
OF SOMEONE ELSE.
LE
B
A
E
G
R
A
H
C
E
R
2,000,000
ER
CANDLEPOW
SPOTLIGHT OWNER’S MANUAL
OPERATING INSTRUCTIONS
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 3
OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
Inspect contents of the box to ensure all parts are included and undamaged.
Part List:
1
Q-Beam Max Million II
Rechargeable Spotlight
1
X
A
M
II
N
IO
L
IL
M
RECHARGEABLE
Rechargeable Battery
(Extra Battery with
Model 800-2655-1)
2
2,000,000
CANDLEPOWER
3
2
12-volt DC Charger/Adapter
120-volt AC Charger
Owner’s Manual
3
4
4
To Operate
IMPORTANT:
Unlock and turn spotlight OFF before charging
Step 1: Follow charging instructions on page 3 of this manual and allow
from AC or DC outlet. The battery cannot charge if
the spotlight is ON. Leaving spotlight ON during
charging may cause damage to battery and AC
charger.
12-volt DC charger/adapter operates from a
cigarette lighter receptacle for charging battery in
spotlight or continuous corded operation with or
without battery.
battery to fully charge.
Step 2: Depress trigger switch in handle to turn spotlight ON. Release
trigger switch to turn spotlight OFF.
Step 3: To lock trigger switch to ON, depress trigger switch and slide
down lock button on side of handle. To unlock and turn spotlight
OFF, depress trigger and slide lock button up.
NOTE:
To prevent car battery from completely
discharging, it is recommended that car
engine remain running while in use.
WARNING:
Never place spotlight face down when light is on or is still
hot from recent use. Doing so could burn/ignite surfaces
such as seats, carpeting, etc. and cause major property
damage. Always turn spotlight off when not in use.
•
•
The life expectancy of the battery is approximately 500 cycles, at
which time a replacement battery is recommended. A replacement
battery may be purchased from The Brinkmann Corporation Customer
Service Department by calling 800-468-5252.
Lock Button
Do not allow battery to completely discharge. A dim light indicates a
low battery. Turn OFF and UNLOCK spotlight and recharge battery as
soon as possible.
Trigger
Switch
2
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 4
THE BATTERY CAN BE CHARGED INSIDE OR OUTSIDE OF SPOTLIGHT.
To Charge
To Charge Battery Inside of Spotlight:
Step 1: Make sure the trigger switch is not locked ON.
Step 2: Plug the AC charger directly into back of battery or DC
charger/adapter into bottom of spotlight handle.
Note: L.E.D. Indicator light will turn on when battery is charging
E
I
I
L
N
B
A
AX
E
0
R
G
0
E
M
R
,0
W
from AC charger only.
0
A
O
ILLIO
0
P
H
E
,0
L
C
M
2
D
E
N
R
A
C
Step 3: For DC Charger/Adapter - Battery charges only while vehicle
engine is running.
For AC Charger - Allow battery to fully charge. L.E.D. indicator on
battery will automatically turn off when battery is fully charged.
See chart for recommended charge times.
Charge Times
L.E.D. Indicator Light
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
20
DC Charge
AC Charge
10
4
6
8
10
CHARGE TIME (Hours)
WARNING: A damaged battery can leak acid. Avoid contact with eyes and
skin. If contact occurs, flush immediately with large amounts of
water. DO NOT ingest. If contact with eyes or ingestion occurs,
consult physician immediately.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every
2 months to ensure battery does not completely lose
charge. A completely discharged battery may not
recharge properly.
Contains lead-acid (Pb)
batteries. Batteries must
be recycled or disposed of
properly.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 5
To Charge Battery Outside of Spotlight:
Step 1: Remove battery from back of spotlight by pressing on the
Battery
quick-release tabs.
Step 2: Plug the AC charger into battery as illustrated.
Note: L.E.D. Indicator light will turn on when battery is
M
A
X
M
RE
IL
LI
O
N
charging from AC charger only.
II
CH
2,0
AR
GE
AB
LE
00
,00
0
CA
ND
LE
PO
W
ER
Step 3: For AC Charger - Allow battery to fully charge. L.E.D.
indicator on battery will automatically turn off when battery is
fully charged.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every
2 months to ensure battery does not completely lose
charge. A completely discharged battery may not
recharge properly.
L.E.D. Indicator Light
WARNING: A damaged battery can leak acid. Avoid contact with eyes
and skin. If contact occurs, flush immediately with large
amounts of water. DO NOT ingest. If contact with eyes or
ingestion occurs, consult physician immediately.
Step 4: Place charged battery inside light so that metal contacts on
battery and light are making contact.
Note: Press battery firmly until fully inserted and locked
with quick-release tabs.
For extended lighting requirements, we recommend purchasing an
additional battery as a back-up. Additional/replacement batteries may
be purchased from The Brinkmann Corporation Customer Service
Department by calling 800-468-5252.
Only use Brinkmann’s 12V75W halogen bulb that is designed for the
Q-Beam Max Million II Rechargeable spotlight as a replacement. Use
of any other bulb may result in poor performance and may damage
your spotlight.
To Replace Bulb
Rear
Reflector
Housing
IMPORTANT: Do not touch the glass part of bulb with fingers as natural
oils affect the life and performance of bulb. Handle bulb by
metal end only.
Step 1: Disconnect spotlight from power source.
MA
X
MI
REC
LL
ION
BLE
0
II
HAR
0,00
GEA
2,00
CAN
DLEP
OWE
R
Step 2: Remove battery from spotlight.
Step 3: Remove the two screws from top and bottom of front housing.
Step 4: Lay the spotlight face (lens) down on a flat surface.
Glass Lens
Front
Housing
4
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 6
Step 5: Holding the front housing secure, slowly lift the rear housing off.
Step 6: Pull reflector away from rear housing being careful not to pull
wire connections inside. Do not touch the inside of reflector.
NOTE:
The glass lens is not attached to front housing. Use care when
disassembling to avoid breaking lens.
Step 7: Pinch the ends of the wire retainer together and lift up as
illustrated.
Step 8: Pull bulb straight out from the reflector mounting plate.
Step 9: Disconnect bulb wire from connector by holding the connector
Connector
firmly with fingers then pulling bulb wire straight out.
Step 10: To install new bulb, grasp the bulb from the metal end (DO NOT
TOUCH THE GLASS PART) and insert into the reflector mounting
plate. Align the slots in the bulb base with those in the reflector
mounting plate.
RECHARGEABLE
2,0
00
,00
0
CA
ND
LEP
OW
ER
Step 11: Replace wire retainer by pinching ends together while pressing
down. Push ends apart so they catch on the reflector mounting
plate.
Step 12: Reconnect the bulb wire to the connector as illustrated.
Step 13: To reassemble, place the front housing face (lens) down on a
flat surface. Set the reflector into the rear housing. Insert the
rear housing into the font housing of the spotlight.
Connector
Step 14: Replace the two screws that were removed in Step 3. Do not
over tighten screws.
HARGEABLE
Replacement bulbs may be purchased from The Brinkmann Corporation
Customer Service Department by calling 800-468-5252.
2,0
00
,00
0
AN
DL
EP
OW
ER
5
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 7
To Replace Cigarette
Lighter Plug Fuse
Lighter Plug
Step 1: Disconnect spot/flood light from power source.
Step 2: Unscrew cap of lighter plug and pull straight away from fuse.
Step 3: Pull fuse holder and fuse out of lighter plug. Observe to see if
fuse is burned out.
Lighter Cap
NOTE:
Use a 8A fuse only. Fuse is burned out when fuse element is
missing or broken inside glass tube. Replace with new 8A fuse
if fuse element is missing or broken.
Step 4: Pull fuse out of fuse holder. Insert new fuse into holder.
Step 5: Insert fuse holder and fuse into lighter plug.
Step 6: Screw cap onto lighter plug.
Lighter Cap
Fuse
Fuse Holder
Lighter Plug
Lighter Plug
Lighter Cap
Lighter Cap
To Prevent Damage to Spotlight and Battery:
Charging Tips
•
Do not attempt to use spotlight while charging directly from AC outlet.
Doing so may cause damage to battery and AC charger.
•
12-volt DC charger/adapter operates from a cigarette lighter
receptacle for charging battery in spotlight only while vehicle engine
is running or continuous corded operation with or without battery.
Charge Times
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
•
•
•
Do not attempt to charge battery pack using both AC an DC chargers
at the same time.
20
DC Charge
Only use charging devices that are provided with the Q-Beam Max
Million II Rechargeable Spotlight or its replacements.
For DC Charger/Adapter - Battery charges only while vehicle engine is
running.
For AC Charger - Allow battery to fully charge. L.E.D. indicator on
battery will automatically turn off when battery is fully charged.
See chart for recommended charge times.
AC Charge
10
•
•
Do not allow battery to completely discharge. A dim light indicates a low
battery. Recharge battery as soon as possible after each use.
4
6
8
10
Always keep the battery fully charged when not in use.
CHARGE TIME (Hours)
6
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2655-2_MM2_10-05.qxd 10/14/05 10:48 AM Page 8
©2002 The Brinkmann Corporation
Dallas, Texas 75244 U.S.A
1-YEAR LIMITED WARRANTY
For 1-year from date of purchase, The Brinkmann Corporation warrants the Max Million Million II Rechargeable Light against defects
due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to
the following guidelines:
•
•
This warranty does not extend to the bulb or battery.
This warranty does not cover rechargeable lights that have been altered or damaged due to: normal wear, abuse, improper
maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of
The Brinkmann Corporation.
•
•
This warranty does not cover surface scratches or weathering as this is considered normal wear.
Warranty service is limited to repair or replacement of rechargeable lights which prove defective under normal use and which
upon examination shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms the defect and approves the
claim, Brinkmann will elect to repair or replace the rechargeable light as covered by the terms of this warranty.
•
This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales
receipt or invoice. To obtain repair or replacement of your Max Million II Rechargeable Light under the terms of this warranty, please
call Customer Service Department at 800-527-0717 for a Return Authorization Number and further instructions. A receipt will be
required. Rechargeable lights returned to Brinkmann must include your name, address and telephone number. Please make sure the
light is properly packed, postage prepaid, and insured. A Return Authorization Number must be clearly marked on the outside of the
box. Brinkmann cannot be responsible for any rechargeable lights forwarded to us without a Return Authorization Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO
1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY
LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE MAX MILLION II
RECHARGEABLE LIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER
ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY SET
OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO
THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND
YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
140-2655-0
Owner’s Manual for Model
800-2655-2 & 800-2655-1
5/02, 7/02, 8/03,
6/04, 10/05
Download from Www.Somanuals.com. All Manuals Search And Download.
|