842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 1
OWNER’S MANUAL
SINGLE BURNER
PROPANE STOVE
WARNING
FAILURE TO FOLLOW ALL WARNINGS
RETAIN THIS MANUAL FOR
FUTURE REFERENCE.
AND INSTRUCTIONS IN THIS MANUAL
COULD LEAD TO PERSONAL INJURY,
INCLUDING DEATH.
™
Propane cylinder not included.
Download from Www.Somanuals.com. All Manuals Search And Download.
842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 3
WARNING
• Never place more than 15 pounds on stove.
• DO NOT operate stove within 36" from any combustible material including walls and
ceiling.
• DO NOT use on/in apartment complex balconies or patios, recreational vehicles, campers
or boats.
• Propane gas is extremely flammable, follow these instructions:
• DO NOT store or use gasoline or other liquids/aerosols with flammable vapors in the
vicinity of this appliance.
• Use only 16.4 oz. LP-gas cylinder(s) constructed and marked in accordance with the
specifications for LP-gas cylinders of the United States Department of Transportation
(DOT) or Transport Canada, CAN/CSA 339. DO NOT use fuel other than propane.
• Always attach or detach propane cylinder outdoors away from flame, pilot lights or
other sources of ignition and only when appliance is cool to touch.
• Read and follow all warnings and instructions on or accompanying propane cylinder.
• Always inspect appliance, propane cylinder and propane connections for damage, dirt
or debris before attaching propane cylinder. DO NOT use if either has been damaged or
modified.
• Follow directions in the "Gas Leak Testing" section on page 4 of this manual. Never test
for gas leaks with a lit match or open flame. DO NOT operate the stove with a gas leak.
• When transporting, not using, or storing stove always disconnect propane cylinder.
• Propane cylinder should remain upright to prevent liquid propane flare-up.
• DO NOT connect to a remote gas supply such as natural gas or a refillable propane
cylinder.
• In case of fire, turn gas "OFF" at burner control knob and use Type 'BC' fire extinguisher or
other appropriate means to extinguish flame.
• Keep hands, face and hair away from burner. Use matches or long-nosed lighter to light
the burner. DO NOT wear loose clothing or allow long hair to hang freely while lighting or
using stove.
• Always snap down legs to locked position, before installing propane cylinder. Use only on
a flat surface.
• DO NOT move stove while in use. Avoid touching hot surfaces.
• Only use replacement/accessory parts manufactured by The Brinkmann Corporation.
Repairs should be performed by The Brinkmann Corporation. For parts or repairs contact
The Brinkmann Corporation’s Customer Service Department at 1-800-527-0717.
• Properly dispose of all packaging materials.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 4
ASSEMBLY INSTRUCTIONS
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS
CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR STOVE.
Inspect contents of the box to ensure all parts are included and undamaged.
FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717.
(Proof of purchase will be required.)
Step 1
Extend legs to locked position.
Leg
Control Knob
Step 2
Make sure burner control knob is in "OFF"
position.
Step 3
Attach propane cylinder to stove fitting.
HAND TIGHTEN ONLY. Do not cross-thread
connections.
WARNING: Always extend legs to locked
position, before installing propane
cylinder. Use only on a flat surface.
Step 4
Follow "Gas Leak Testing" instructions on
page 4 of this manual.
Detach
Attach
3
Download from Www.Somanuals.com. All Manuals Search And Download.
842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 5
GAS LEAK TESTING
WARNING
• Gas leak testing must be performed outdoors in a well ventilated area every time cylinder is connected
to stove.
• Always keep unit away from open flames, sparks or lit cigarettes.
• Never use a flame to check for gas leaks.
• The control knob is used when lighting the burner and to adjust the flame.
• Never use a unit that has a gas leak. Contact The Brinkmann Corporation’s Customer Service
Department for replacement parts or repairs at 1-800-527-0717.
Step 1
Assemble stove per "Assembly Instructions" on
page 3 of this manual. Make sure burner control
knob is in "OFF" position.
Step 2
Prepare a soapy water solution (one part
dishwashing liquid to three parts water) to test
for gas leaks in the connection. Apply a generous
amount of the soapy mixture to the propane
cylinder and stove fitting (located underneath
stove).
Step 3
With the burner control knob in the "OFF"
position, check for bubbles where propane
canister attaches to stove fitting. If soapy
mixture starts bubbling, gas is leaking through
the connection. Disconnect the propane canister.
Retighten the connection that is leaking gas.
Repeat procedure with soapy mixture until gas
no longer leaks. NEVER USE A FLAME TO CHECK
FOR GAS LEAKS.
Watch for Bubbles
Step 4
Once all gas leaks have been sealed, WAIT AT
LEAST 5 MINUTES FOR GAS FUMES TO
DISSIPATE BEFORE LIGHTING THE BURNER.
Carefully follow "Operating Instructions" to light
the burner and properly operate this unit.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 6
OPERATING INSTRUCTIONS
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY.
WARNING
• DO NOT allow gasoline or other flammable vapors or liquids to come in contact with stove while
lighting or at any time during use of stove.
Step 1
Make sure "Gas Leak Testing" from page 4 was completed
Minimum clearance to
combustibles 36 inches from top
and side of stove burners
and the burner control knob is in the "OFF" position and
stove is on a flat surface away from combustible material.
36"
Step 2
36"
Using a match, hold the flame beside burner. Turn the
burner control knob SLOWLY counter-clockwise until the
burner lights.
WARNING: If the burner does not light within 5 seconds, turn
the burner control knob "OFF" immediately. Wait
at least 5 minutes until gas fumes have dissipated
before attempting to light burner again.
Perimeter of base of stove
Match
Step 3
Control Knob
Adjust burner flame as necessary by using burner control
knob. Turn stove "OFF" using burner control knob when
stove is not in use.
Step 4
Allow stove to cool completely, then follow instructions in
the "After-Use Safety" and "Proper Care & Maintenance"
sections of this manual.
ON / Larger Flame
NOTE: Observe flame height and
color when lit. Flame
Yellow
should have a blue center
and a slight yellow tip.
OFF
ON
Blue
Burner
OFF / Smaller Flame
5
Download from Www.Somanuals.com. All Manuals Search And Download.
842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 7
AFTER-USE SAFETY
• Always allow the stove to cool completely before handling.
• When disconnecting propane cylinder, a small amount of LP gas is released until cylinder is completely
removed. Cylinder contains a self-sealing valve.
• Always disconnect the propane cylinder from stove when not in use - Replace cap on the propane
cylinder.
• Store propane cylinder in a well ventilated area away from any heat source or open flame.
• Fold legs underneath stove body.
PROPER CARE & MAINTENANCE
• Wipe exposed parts of stove with damp cloth. Do not use abrasive materials.
• To protect your stove, the unit must be kept clean and covered at all times when not in use.
• Only use replacement/accessory parts manufactured by The Brinkmann Corporation. Repairs should be
performed by The Brinkmann Corporation. For parts or repairs, contact The Brinkmann Corporation’s
Customer Service Department at 1-800-527-0717.
• Cover and store stove in a protected area away from children and pets.
• After product has been stored and prior to reusing, verify that burner is free from leaves, insects, spider
webs, dirt, etc. as these items can obstruct the flow of combustion air.
• Prior to each use, visually check the burner flame for proper operation as described on page 5.
DO NOT use if burner/flame is not operating properly.
• This stove requires an unobstructed airflow to operate correctly.
• During use or storage, always keep the stove area clear and free of combustible materials, gasoline and
other flammable vapors and liquids.
NOTE: Due to the intense heat from burner, it is normal for discoloration to occur on stove during the first
few uses.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 8
©2003 The Brinkmann Corporation
Dallas, Texas 75244 U.S.A
1-YEAR LIMITED WARRANTY
For 1-year from date of purchase, The Brinkmann Corporation warrants the Single Burner Propane Stove against defects due to
workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to
the following guidelines:
•
This warranty does not cover stoves that have been altered or damaged due to: normal wear, abuse, improper
maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of
The Brinkmann Corporation.
•
•
•
This warranty does not cover surface scratching or heat damage to the finish, which is considered normal wear.
The Brinkmann Corporation may elect to repair or replace damaged units covered by the terms of this warranty.
This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales
receipt or invoice. To obtain replacement parts for your Single Burner Propane Stove under the terms of this warranty, please
call Customer Service Department at 1-800-527-0717 for a Return Authorization Number and further instructions. A receipt or
proof of purchase will be required. Units returned to Brinkmann (without propane cylinder) must include your name, address
and telephone number. Please make sure product is properly packed, postage prepaid and insured. The Brinkmann Corporation
will not be responsible for any products forwarded to us without prior authorization.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION
TO 1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED
WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE SINGLE
BURNER PROPANE STOVE TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER
ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY
SET OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL
DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
140-0010-O
11/03, 7/04, 9/04
Owner’s Manual for Models
842-0010-0, 842-0010-S
Download from Www.Somanuals.com. All Manuals Search And Download.
|