Care and Use Manual
Model PGR304
Model PGR364GL
Low Back Model LB36R
Model PGR484GG
Low Back Model LB48R
Thermador Professional® Range
FOR RESIDENTIAL USE ONLY
All Gas Models PGR30, PGR36, PGR48
LE MANUEL DE SOIN ET D’UTILISATION
EN ENGLAIS AVEC ADVERTISSEMENTS EN FRANÇAIS
© 2002 BSH Home Appliances Corp.
INTRODUCTION
INTRODUCTION
TABLE OF CONTENTS
The Thermador Professional® Ranges are free-standing
units available in a number of configurations. All models
feature a gas cooking surface with a professional size, Gas
convection, self-cleaning oven with broil capability.
Introduction ................................................... 1
Gas Type Verification.................................... 1
Care and Use Manual Conventions.............. 2
Section One: General Safety Instructions
GAS TYPE VERIFICATION
Verify the type of gas supplied to the location. Ensure that
the appliance is connected to the type of gas for which it
iscertified. Modelscomefromthefactorycertifiedforuse
with natural gas or with propane (LP) gas. Make certain
yourrangeandgastypearethesame. Refertotheproduct
rating label which can be located as indicated on Page 42.
Safety ............................................................................. 3 – 4
Precautions................................................................... 5 – 6
Section Two: Before You Begin
Before Using Your Range for the First Time.............. 7
Section Three: Description
Model & Parts Identification – PGR484GG .................... 8
Model & Parts Identification – PGR366 ........................... 9
Model & Parts Identification – PGR304 ......................... 10
Guide to Knob Identification and Location ................. 11
CAUTION:
Section Four: Using the Cooktop
!
▲
When connecting the unit to propane gas, make
certainthepropanegastankisequippedwithitsown
high-pressure regulator in addition to the pressure
regulator supplied with the range. The maximum
gaspressuretothisappliancemustnotexceed
14.0incheswatercolumn(34.9millibars)from
thepropanegastanktothepressureregulator.
Using the Cooktop................................................ 12 – 13
Flame Setting Guidelines................................................ 14
Proper Cookware ................................................. 15 – 16
Surface Burner Cooking Chart .......................... 17 – 18
Using the Grill . ...................................................... 19 – 21
Grill Cooking Chart .............................................. 22 – 23
About the Griddle ........................................................... 24
Griddle Cooking Chart .................................................. 24
Section Five: Using the Oven
Bake .................................................................................... 25
Convection•Bake ............................................................. 26
Setting Bake/Convection•Bake ..................................... 27
Other Uses of Bake ........................................................ 28
Baking Chart ..................................................................... 29
Broil .................................................................................... 30
Setting Broil and Convection Broil ............................. 31
Broiling and Roasting Chart .......................................... 32
IMPORTANT
All ranges must be installed with a backguard. The
PGR 304 comes with a low back. For all other
models, one of three available backguards must be
ordered separately and installed at the back of the
range. The three backguard choices include a Low
Back, High Back Shelf, or Island Trim. Before using
the range, insure that it is equipped with a proper
backguard. Refer to the Installation Instructions
accompanying this appliance for more information.
Section Six: Care and Maintenance
Self-Cleaning the Oven......................................... 33 – 34
Range Cleaning Chart........................................... 35 – 40
Section Seven: Before Calling For Service
Do-It-Yourself Maintenance.......................................... 41
Before Calling For Service............................................. 42
Data Rating Plate ............................................................. 42
Warranty ........................................................................... 43
Page 1
INTRODUCTION: CARE AND USE MANUAL
Introduction
This manual contains important Care and Use information for allThermador Professional® Ranges. When
using this manual, it is critical that you know the model number of your range, as some information will be
unique to each Range. The model number may be found on the rating plate located on the range as identified
on Page 42 of this manual. The charts on the following pages summarize the various range models and
identify the features of each range.
PGR Ranges, featuring a Gas Cooking Surface
with Self-Cleaning Gas Ovens with Gas Broiler.
All Gas PGR304 .......................All Gas, 30" wide Range with Four Gas
Cooktop Burners and self-cleaning Gas Oven
All Gas PGR364GD .................All Gas, 36" wide Range with Four
Gas Cooktop Burners, Griddle and self-cleaning Gas Oven
All Gas PGR364GL ..................All Gas, 36" wide Range with Four
Gas Cooktop Burners, Grill and self-cleaning Gas Oven
All Gas PGR366 .......................All Gas, 36" wide Range with Six Gas
Cooktop Burners and self-cleaning Gas Oven
All Gas PGR486GD .................All Gas, 48" wide Range with Six
Gas Cooktop Burners, Griddle, large self-cleaning Gas Oven
and one auxiliary oven.
All Gas PGR486GL ..................All Gas, 48" wide Range with Six
Gas Cooktop Burners, Grill, large self-cleaning Gas Oven
and one auxiliary oven.
All Gas PGR484GG .................All Gas, 48" wide Range with Four Gas
Cooktop Burners, Grill, Griddle, large self-cleaning Gas Oven
and one auxiliary oven.
Page 2
SECTION ONE: GENERAL SAFETY INSTRUCTIONS
SAFETY
GAS AND ELECTRICAL REQUIREMENTS AND GROUNDING INSTRUCTIONS
PLEASE READ CAREFULLY
FOR PERSONAL SAFETY,
CAUTION
Gas Models:
THIS APPLIANCE MUST
BE CONNECTED TO A
PROPERLY GROUNDED
AND POLARIZED ELEC-
TRICAL POWER SUPPLY.
PGR304
Accessiblepartsmaybecome
hot when the grill is in use.
Young children must be kept
away.
120 volts, 60 Hz.,
10 Amp electrical circuit required.
Gas Models:
PGR364GD, PGR364GL,
PGR366
120 volts, 60 Hz.,
SeeInstallationInstructionsforelectricalrequirementsandground-
ing instructions.
10 Amp electrical circuit required.
It is the personal responsibility and obligation of you, the user, to have this
appliance connected to the electrical power supply in accordance with the
National Electrical Code and/or applicable local codes and ordinances by a
qualified electrician.
Gas Models:
PGR486GD, PGR486GL,
PGR484GG
120 volts, 60 Hz.,
10 Amp electrical circuit required.
CAUTION - ALL MODELS
IN CASE OF AN ELECTRICAL FAILURE
IfforanyreasonagascontrolknobisturnedONandthereisnoelectrical
power to operate the electronic igniters on the cooktop burners, turn
OFF the gas control knob and wait 5 minutes for the gas to
dissipate before lighting the cooktop burner manually.
To light the cooktop burners manually, carefully hold a lighted match to
the burner ports and turn the gas control knob to HI. During a power
failure you can use the cooktop burners, but each must be lit with a
match.
DO NOT attempt to light the two left burners manually. These burners
are equipped with the ExtraLow® feature and cannot be lit manually.
Check your local building codes
TESTED IN ACCORDANCE
ALWAYS DISCONNECT THE
ELECTRICAL PLUG FROM THE
WALL RECEPTACLE BEFORE
SERVICING THIS UNIT.
for the proper method of installa-
WITH:
tion. In the absence of local codes,
• ANSI Z21.1-2000 for House-
this unit should be installed in ac-
hold Gas Appliances
cordance with the National Fuel
• UL858 14th Edition for House-
It is recommended that a dedicated
circuit servicing this appliance be
provided.
Gas Code No. Z223.1 Current
hold Gas Ranges
Issue and the National Electrical
• CAN/CSA-22.2 No. 61-M89 for
CodeANSI/NFPANo.70Current
Household Cooking Ranges
IssueortheCan-B149Installation
• CAN/CGA 1.1-M81 Domestic
The use of gas cooking appliances
results in the production of heat and
moisture.
Codes for Gas Burning Appliances
Gas Ranges
and C22.1 Canadian Electrical
Code Part 1.
SAVETHESE INSTRUCTIONS
Page 3
SECTION ONE: GENERAL SAFETY INSTRUCTIONS
PRECAUTIONS
SAFETY PRACTICESTOAVOID
PERSONAL INJURY
When properly cared for, your new
ThermadorPROFESSIONAL® Range
hasbeendesignedtobeasafe,reliable
appliance. However, use extreme
carewhenusingthisrestaurantcaliber
range as this type of appliance
providesintenseheatandcanincrease
the accident potential. When using
kitchen appliances, basic safety
precautions must be followed,
including the following:
Use only dry potholders: moist
or damp potholders on hot surfaces
may cause burns from steam. Do
not use a towel or other bulky cloth
in place of potholders. Do not let
potholders touch hot elements, hot
burners, or burner grates.
Do not repair or replace any
part of the appliance unless
specifically recommended in this
manual. Allotherservicingshouldbe
referred to a qualified technician.
Childrenshouldnotbeleftalone
or unattended in an area where
appliancesareinuse. Theyshould
never be allowed to sit or stand on
any part of the appliance.
Forpersonalsafety,wearproper
apparel. Loose fitting garments or
hangingsleevesshouldneverbeworn
while using this appliance. Some
syntheticfabricsarehighlyflammable
and should not be worn while
cooking.
CAUTION: Do not store items
of interest to children above the
range or at the back of it. If
children should climb onto the
appliance to reach these items, they
could be seriously injured.
Read this Care and Use Manual
carefully before using your new
range to reduce the risk of fire,
electrical shock,orinjurytopersons.
Do not use aluminum foil to line
anypartoftheovenorcooktop.
Use of a foil liner could result in a
shock or fire hazard, or the
obstructionoftheflowofcombustion
andventilationair. Foilisanexcellent
heatinsulatorandheatwillbetrapped
beneathit. Thiswillupsetthecooking
performance and can damage the
finish of the oven or the cooktop.
Insure proper installation and
servicing. Follow the installation
instructions provided with this
product. Have the range installed
andgroundedbyaqualifiedtechnician.
Never use any part of the
cooktop or oven for storage.
Flammable materials can catch
fire and plastic items may melt
or ignite.
Have the installer show you
where the gas supply shut-off
valve is located so that you know
how and where to turn off the gas to
the range.
Do not hang articles from any
part of the appliance or place
anything against the oven. Some
fabrics are quite flammable and may
catch on fire.
WARNING
If you smell gas, your installer has
notdoneaproperjobofcheckingfor
leaks. If the connections are not
perfectly tight, you can have a small
leak and therefore a faint gas smell.
Finding a gas leak is not a “do-it-
yourself”procedure. Someleakscan
onlybefoundwiththeburnercontrol
in the ON position and this must be
donebyaqualifiedservicetechnician.
See Inside Front Cover regarding gas
leaks.
!
TO REDUCE THE
RISK OF TIPPING
If the range is near a window, be
certain the curtains do not blow
over or near the cooktop
burners; they could catch on fire.
OF THE APPLI–
ANCE,ITMUSTBE
SECURED BY A
P R O P E R L Y
DO NOT USE WATER ON
GREASE FIRES. Turn appliance
off and smother fire with baking soda
or use a dry chemical or foam-type
extinguisher.
INSTALLEDANTI-
TIP DEVICE. VERIFY
THAT THE ANTI-TIP
DEVICEISENGAGEDPER
INSTALLATION
IN–
Never let clothing, potholders,
or other flammable materials
comeincontactwithortooclose
toanyelement,burnerorburner
grate until it has cooled. Fabric may
ignite and result in personal injury.
In the event a burner goes out and
gas escapes, open a window or a
door. Do not attempt to use the
cooktop until the gas has had time to
dissipate. Waitatleast5minutes
before using the range.
STRUCTIONS. (NOTE:
ANTI-TIP DEVICE IS
REQUIRED ON ALL 30"
AND 36" RANGES)
Page 4
SECTION ONE: GENERAL SAFETY INSTRUCTIONS
PRECAUTIONS
Usecautiontoinsurethatdrafts
like those from forced air vents
or fans do not blow flammable
material toward the flames or
push the flames so that they
extend beyond the edges of the
pot.
Warning: The appliance is for
cooking. Based on safety
considerations, never use the oven
orcooktoptowarmorheataroom.
Also, such use can damage the
cooktop or oven parts.
WARNING
After a spill or boil over, turn off
the burner and clean around the
burner and burner port. After
cleaning, check for proper
operation.
Cleanthecooktopwithcaution.
Avoid steam burns; do not use a wet
spongeorclothtocleanthecooktop
whileitishot. Somecleanersproduce
noxious fumes if applied to a hot
surface. Follow directions provided
by the cleaner manufacturer.
Whenusingthecooktop:DONOT
Always use utensils that have
flat bottoms, large enough to
cover the burner. The use of
undersized utensils could expose a
portionoftheflameandmayresultin
ignition of clothing.
TOUCH
THE
BURNER
GRATESORTHEIMMEDIATE
SURROUNDING AREA. Areas
adjacenttotheburnersmaybecome
hot enough to cause burns.
Never leave the cooktop
unattended when using high flame
settings. Boil overs cause smoking
and greasy spillovers that may ignite.
More importantly, if the burner
flames are smothered, unburned gas
willescapeintotheroom. SeeInside
Front Cover regarding gas leaks.
To minimize burns, ignition of
flammablematerialsandunintentional
spillovers, position handles of
utensils inward so they do not
extend over adjacent work areas,
cooking areas, or the edge of the
cooktop.
Be sure all cooktop controls are
turned off and the cooktop is cool
before using any type of aerosol
cleaner on or around the cooktop.
The chemical that produces the
sprayingactioncould,inthepresence
of heat, ignite or cause metal parts to
corrode.
Hold the handle of the pan to
prevent movement of the utensil
when stirring or turning food.
When using the oven: DO NOT
TOUCH THE INFRARED
BURNERS, THE INTERIOR
SUR–FACES OF THE OVEN
OR THE EXTERIOR AREA
I M M E D – I A T E L Y
SURROUNDING THE DOOR.
Interior oven surfaces become hot
enough to cause burns. The heat
deflector, which deflects heat away
from the cooktop and the trim on
the top and sides of the oven door,
will also be hot when the oven is in
use.
Onlycertaintypesofglass,heat-
proof glass-ceramic, ceramic,
earthenware, or other glazed
utensilsaresuitableforcooktop
use. This type of utensil may break
with sudden temperature changes.
Use only on low or medium heat
settings according to the utensil
manufacturer’s directions.
DO NOT use pots or pans on the
grill section.
Do not use the grill for cooking
excessively fatty meats or
products which promote flare-
ups.
The optional cutting board
accessory must be removed
before operating the griddle beneath
or burners adjacent to it.
Do not heat unopened food
containers; a buildup of pressure
may cause the container to burst.
GREASE IS FLAMMABLE. Let
hot grease cool before attempting to
handle it. Avoid letting grease
deposits collect. Clean after each
use.
During cooking, set the burner
control so that the flame heats
only the bottom of the pan and
does not extend beyond the
bottom of the pan.
Place oven racks in desired
position while oven is cool. If a
rack must be moved while the oven
is hot, do not let the potholders
contact the infrared burner.
For proper lighting and performance
of the burners, keep the igniter
ports clean. It is necessary to clean
these when there is a boil over or
when the burner does not light even
though the electronic igniters click.
See Page 38.
Usecarewhenopeningtheoven
door; let hot air or steam escape
before removing or replacing foods.
Avoid using high flame setting with a
panlargerthanthegrateorwith
onethatspansmorethanoneburner,
such as a griddle, for prolonged
periods of time. This can result in
poor combustion that generates
harmful by-products.
Before self-cleaning the oven,
remove the broiler pan, oven racks
and any other utensils, and excess
spillage.
Page 5
SECTION ONE: GENERAL SAFETY INSTRUCTIONS
PRECAUTIONS
Do not clean, rub, damage,
move or remove the door
gasket. It is essential for a good seal
during baking and while self-cleaning
the oven.
authorized Technicans. Techni-
cians must disconnect the power
supply before servicing this unit.
CaliforniaProposition65-Warning:
The burning of gas cooking fuel and
the elimination of soil during self-
cleaning generate some by-products
which are on the list of substances
which are known by the State of
California to cause cancer or
reproductive harm. California law
requires businesses to warn
customers of potential exposure to
such substances. To minimize
exposuretothesesubstances,always
operate this unit according to the
instructionscontainedinthisbooklet
and provide good ventilation to the
room when cooking with gas, during
and immediately after self-cleaning
the oven.
Listen to be sure the cooling
blower runs whenever the oven
controlsaresettobroilorself-clean.
If the fan does not operate, do not
use the oven. Call an authorized
service center for service.
Protecttheself-cleaningfeature.
Clean only those parts indicated in
this booklet. Do not use commercial
ovencleanersorovenlinerprotective
coatings of any kind in or around the
large self-cleaning oven.
Clean the ventilator hood and
filters above the range
frequently so grease from cooking
vaporsdoesnotaccumulateonthem.
DO NOT obstruct the flow of
combustion or ventilation air.
For safety reasons and to avoid
equipment damage, never sit, stand,
or lean on the oven door.
• In case of fire or when inten-
tionally “flaming” liquor or
other spirits on the cooktop,
follow hood manufacturer’s in-
structions.
Service should only be done by
BEFORE USING YOUR RANGE FOR THE FIRST TIME, CHECK THAT YOU HAVE THESE ITEMS:
DESCRIPTION
PGR
PGR
PGR
PGR
366
PGR
484 GG
PGR
486 GD
PGR
486 GL
304 364 GD 364 GL
Oven Racks Large Oven
Oven Racks 12-inch Oven
3
3
3
3
3
2
3
2
3
2
Two-Piece Broil Pan
Star Burner Caps
1
4
2
5
1
4
2
6
1
4
2
6
1
1
1
6
3
7
2‡
4
2
8
1
1
1
1
*
2‡
6
2‡
6
Burner Grates
3
3
Control Knobs
9
9
Cast Iron Grill Grate
Stainless Steel Radiant
Coated Titanium-Surface Griddle
Product Registration Card
Backguard
1
1
1
1
*
1
1
*
1
1
1
1
1
*
1
*
1
*
Installation Instructions
Use and Care Manual
1
1
1
1
1
1
1
1
1
1
1
1
*
Backguard must be ordered and shipped separately. It is not included with the range shipment. ‡The aluminum broil pan is
for the Secondary Oven; the porcelain & chrome broil pan is for the Main Oven.
Page 6
SECTION TWO: BEFORE YOU BEGIN
Before UsingYour Range for the FirstTime
Remove all packaging materials
and temporary labels from oven
and cooktop.
1. Check that you have the items listed on Page 6.
2. Record the Model and Serial number on Page
42. See "Data Rating Plate." These may be used
for any future contacts with your servicer or the
factory. Enter this information on the Product
Registration Card included with this product then
mail it to the indicated address.
3. Optional Accessories. Grill Cover, Chopping
Board, Griddle Cover and other accessories are
available from your Thermador Dealer. Contact the
Thermador Parts Department toll-free at 800/735-
4327 for more information.
4. Position the racks correctly in the oven.
CAUTION
The correct rack position depends on the recipe and the
cooking mode. The rack positions are numbered
from the bottom of the oven, like an elevator.
Rack position 3 is the most frequently used position.
Place rack(s) in the proper position before turning on the
oven.
Aluminum foil should never be used to cover
the oven racks or to line the oven. It may
cause damage to the oven. Do not remove
the infrared burner in the gas oven.
Insert the racks as follows:
a. Hold the rack with the back rail in the up position
BEFOREBAKINGORBROILING, theovenandbroiler
towards the rear of the oven. Slip it into the oven
should be turned on to burn off the manufacturing oils.
so the rack slides are between the rack and the
Turn the oven on to 450°F (230°C) for 20 to 30 minutes;
rack guides.
then turn the broiler to "Broil" for same length of time.
b. Tipthefrontoftherackupslightlyasitslidesinto
You may wish to turn on the ventilator above your range
the oven so that the safety stops clear the rack
during this time.
slides. The safety stops on the back of the rack
will keep it from sliding out of the oven when it
is pulled forward.
Please read Page 40 in Section 6: Care and Maintenance
before cleaning the oven racks.
Page 7
SECTION THREE: DESCRIPTION
Model and Parts Identification
Gas Model PGR484GG - Shown Has a grill, a griddle and four burners, two ExtraLow® and two standard.
Model PGR486GD – Has a griddle and six burners, two ExtraLow® and four standard.
Model PGR486GL – Has a grill and six burners, two ExtraLow® and four standard.
Key for PGR48 Models
1
1. 22" High Shelf Backguard,
12" Low Back, or Island Trim
(Backguard ordered separately)
2
2
3
8
2. Burner Grates & Burners
3. Grill
4
4. Griddle
5. Control Knobs, ExtraLow®
Burners (2)
7
5
6
6. Control Knobs, Standard
Burners (4)
7. Oven Controls
8. Oven Light Switch
9. Oven Door
11
9
10. Viewing Window
11. Auxiliary Oven
(2 racks included)
10
12. Kick Panel (Product Rating
Label Located Behind Kick
Panel)
12
13. Range Feet (4)
13
13
!
WARNING:
▲
To provide proper ventilation,
do NOT remove range feet.
15
Gas Oven Interior
14. Oven Interior Lights
15. Broil Element
16. Oven Thermostat
17. Rack Guides
16
17
14
14
18. Oven Rack
(3 included, not shown)
19. Bake Element (hidden)
20. Convection Fan Cover
20
19
Page 8
SECTION THREE: DESCRIPTION
Gas Model PGR366 - Shown
Model PGR364GD – Has a center griddle and four burners, two ExtraLow® and two standard.
Model PGR364GL – Has a center grill and four burners, two ExtraLow® and two standard.
Key for PGR Models
1
1. 22" High Shelf Backguard,
12" Low Back, or Island Trim
(Backguard ordered separately)
2. Burner Grates & Burners
3. Control Knobs, ExtraLow® Burners (2)
4. Control Knobs, Standard Burners (4)
5. Oven Controls
2
2
2
4
6. Oven Light Switch
5
3
4
7. Oven Door
6
8. Viewing Window
9. Kick Panel (Product Rating Label
Located Behind Kick Panel)
7
10. Range Feet (4)
8
!
WARNING:
▲
9
To provide proper ventilation,
do NOT remove range feet.
10
10
Gas Oven Interior,
Please see Page 8
Page 9
SECTION THREE: DESCRIPTION
Model and Parts Identification
Gas Model PGR304 - Shown
Key for PGR304 Models
1. 9" Low Back or Island Trim
(Island Trim ordered separately)
1
2. Burner Grates & Burners
3. Control Knobs, ExtraLow® Burners (2)
4. Control Knobs, Standard Burners (2)
5. Oven Controls
2
2
4
6. Oven Light Switch
7. Oven Door
8. Viewing Window
5
6
3
9. Kick Panel (Product Rating Label
Located Behind Kick Panel)
10. Range Feet (4)
7
8
!
WARNING:
▲
To provide proper ventilation,
do NOT remove range feet.
Gas Oven Interior,
Please see Page 8
9
10
10
Page 10
Guide to Knob Identification and Location
Locate each knob type by the
corresponding number on the
PGR30 MODEL
PGR304ZS
diagrams. Actual knobs are not
numbered.
1. Simmer Knob
6
1
2
OFF HI-LO-XLO
2. Standard Knob
PGR36 MODELS
PGR366ZS
OFF HI LO
3. Grill Knob
OFF-LITE-HI-LO
6
1
2
2
4. Griddle Knob
OFF 150 200 250 300
350 400 450 500
PGR364GDZS
5. Auxiliary Oven Knob
OFF 150 200 250 300
350 400 450 500
Broil
4
3
1
6
2
2
PGR364GLZS
6. Main Oven Knob
OFF 150 200 250 300
350 400 450 500
Broil Clean
6
1
PGR48 MODELS
PGR484GGZS
3
4
5
6
1
2
2
PGR484GDZS
5
4
6
1
2
PGR484GLZS
1
6
3
5
2
2
Page 11
SECTION FOUR: USING THE COOKTOP
USINGTHE COOKTOP
SEALED BURNERS
CONTROL KNOBS
BTU Output for Standard Burners
• HI is equivalentto15,000 BTU/HR.
• LO is equivalent to 2,100 BTU/HR.
The control knobs for two sealed gas
burners, one in front and one in the
rear, are located directly in front of
and below the pair of burners on the
control panel.
BTU Output for ExtraLow® Burners
• HI is equivalent to15,000 BTU/HR.
• LO is equivalent to3,000 BTU/HR.
• XLO is equivalent to370 BTU/HR.
Rear
ExtraLow® Burners
Burner
Setting
Indicator
Location
The controls for the two left burners,
front and rear, have flame settings
even lower than the standard LO
settings.
Sealed Star™ Burner Base
The cooktop features four or six gas
surface burners; each rated at 15,000
BTU/HR.The burners are sealed to
the stainless steel top frame to
prevent liquid spills from
accumulating below the top surface,
making it easier to clean.
On all models, the two left burners
have the exclusive ExtraLow‚ feature;
the remaining burners are standard.
Each burner has its own control
knob.
Front
Knob
Burner
Location
Bezel
Standard Burner
Control Knob
The icon above each control shows
whether the burner position is in the
front or in the rear. A solid star
indicates the location of the burner
controlled by that particular knob.
The drawing above shows the knob
controlling the rear burner.
ExtraLow
Range
ExtraLow® Burner
Control Knob
The drawing shows that the control
knob has an additional range between
the LO and XLO settings.When the
knob is set within this range, the
flame pulses off and on. By varying
the length of time the flame is off and
on, the heat is reduced even further
to cook delicate foods.For example,
these very low settings are suitable
for simmering and poaching, melting
chocolate and butter,holding cooked
foods at temperatures without
scorching or burning, etc.
OPERATION OFTHE
BURNERS
• Press in on the knob and turn it
counter-clockwise to the HI
setting.
• The igniter for the selected sealed
burner clicks and sparks.
• After flame ignition, the igniters
stop clicking.
• Rotate the knob to any flame
setting between HI and LO.
• The Blue Burner Signal Light,
between the burners, will light
when adjacent burners are lit.They
will remain on until the burner is
turned off.
Page 12
SECTION FOUR: USING THE COOKTOP
• To maintain a low or simmer heat,
ELECTRONIC
SINGLE POINT
IGNITION
Operation of the ExtraLow
Burners
• XLO, the very lowest setting, is
achieved by cycling the flame ON
for approximately 8 seconds and
OFF for 52 seconds of each
minute.
bring food to a rolling boil. Stir
well,then cover the pan and lower
the heat to a setting just below
LO.
Burner
• Check periodically to see if the
control knob should be turned to
another setting.
Base
• When the knob is set just below
the LO setting, the flame will cycle
ON for approximately 52 seconds
and OFF for 8 seconds of each
minute.
• If an over-size pan is used, the
simmer action may occur mainly
in the center of the pan. To
equalize the temperature
throughout the food,stir the food
around the outer edges of the pan
into the food in the center.
• To vary the amount of low heat
to suit the food and quantity, the
control can be set anywhere
within the LO and XLO range
marked on the knob.
• It is normal to stir food
occasionally while simmering.This
is especially important when
simmering for several hours,such
as for a homemade spaghetti sauce
or beans.
Bu
Ca
Star™ Burner
Components
Each burner has its own electronic
igniter that sparks when the burner
is turned on. Each burner should light
in 4 seconds or less. If a burner does
not light,check to see that the cap is
positioned correctly on the base.Do
not touch the burners when the
igniters are sparking. If a burner
fails to ignite,refer to the section on
Page 43, “Before Calling for Service.”
• When lowering the flame setting,
adjust it in small steps.
• If the setting is too low to hold a
simmer, bring the food back to a
boil before re-setting to a higher
heat.
ExtraLow Settings
• The
number
and
dash
• It is normal not to see simmer
bubbles immediately after the food
has been stirred.
designations, shown in the
drawing, are for reference only.
They do not actually appear
on the knob. The number
indicates the position of the flame
setting as represented on the
cooking chart, pages 17 and 18,
with #4 being hotter than #1.
• There may be bubbling when the
flame cycles ON and no bubbles
when the flame is OFF.Even when
the flame is OFF, there will be
steam and a slight quiver on the
liquid’s surface.
ExtraLowTechniques
• The type and quantity of food
affects which setting to use.
• The pan selected affects the
setting. Its size, type, material,and
whether a lid is used,all affect the
consistency of the cooking
temperature.
BURNER CAP
Page 13
SECTION FOUR: USING THE COOKTOP
AUTOMATIC RE-IGNITION
POWER FAILURE
FLAME HEIGHT
• In the event of a power failure,
only the standard burners and
grill can be manually lit. It is
necessary to light each one
individually.
• The correct flame height depends
on 1) size and material of pan
being used;2) food being cooked;
and 3) amount of liquid in the pan.
If any one or more burners or grill
blow out, the electronic igniter
automatically sparks to re-light the
flame. Do not touch the burners
when the igniters are sparking.
• Never extend the flame beyond
the base of the pan.
• If the cooktop is being used when
the power failure occurs, turn all
knobs to the OFF position.
IMPORTANT:
• Use a low or medium flame for
pan materials that conduct the
heat slowly, such as porcelain
coated steel or glass-ceramic.
• For proper combustion do not use
the cooktop without the burner
grates in place.
• The standard burners and grill can
be lighted by holding a match at
the ports and turning the control
knob to the HI position.Wait until
the flame is burning all around the
burner cap or U-shaped burner
before adjusting the flame to the
desired height.
• There is a slight sound associated
with gas combustion and ignition.
This is a normal condition.
FLAME DESCRIPTION
• On cooktops using propane gas
(LP), a slight “pop” sound may be
heard at the burner ports a few
seconds after the burner has been
turned off.
Dark Blue
S e c o n d a r y
Cone
• Neither ExtraLow burner can be
used during a power failure. Be
sure to turn them off.
Light Blue
• If either ExtraLow burner is on
when a power failure occurs,they
cannot be turned back on until
both knobs are first turned off.
Primary
Cone
• The griddle cannot be used during
a power failure.
• If you smell gas, refer to safety
precautions listed inside the front
cover.
Flame Color
• The burner flame color should be
blue with no yellow on the tips.It
is not uncommon to see orange
in the flame color; this indicates
the burning of airborne impurities
in the gas and will disappear with
use.
WARNING
In the event of a power failure,
all knobs are to be turned to the
OFF Position. Only the standard
burners and the grill can be lit
manually.
• With propane (LP) gas, slight
yellow tips on the primary cone
are normal.
• The flame should burn completely
around the burner cap.If it doesn’t,
check that the cap is positioned
correctly on the base and that the
ports are not blocked.
• The flame should be stable with
no excessive noise or fluttering.
Page 14
SECTION FOUR: USING THE COOKTOP
COOKWARE RECOMMENDATIONS
SAFETY PRECAUTIONS:
➤ Food packaged in aluminum foil should not
be placed directly on the burner grate.
Aluminum foil can melt during cooking.
➤ Do not let plastic, paper or cloth come in
contact with a hot burner grate.They may
melt or catch fire.
(51 mm)
➤ Never let a pan boil dry. This can damage
your pan and the cooking surface.
BASE DIAMETER
• Select the base diameter to match the diameter of the
flame.The diameter of the flame should be the same
size as the pan base or slightly smaller. Oversize or
under size pans sacrifice cooking performance.
A 5-1/2" (140 mm) base size is generally the smallest
recommended.
• For best cooking results,use professional quality pans
with metal handles.(Plastic handles can melt or blister,
if the flame extends up the side of the pan.) Professional
quality pans are found at restaurant supply stores and
gourmet specialty shops. All cookware should have
these characteristics: good heat conductivity, good
balance,correctly sized base diameter,a heavy,flat base,
and a proper fitting lid.
• Aluminum and copper are pan materials that conduct
the heat quickly and evenly.These metals are sometimes
attached to the base or in the core between stainless
steel.
FLAT BASE PAN
• A heavy, flat base is more apt to remain flat when
heated. Pan bases that are warped, dented, ridged or
too lightweight will heat unevenly. Heat and cool pans
gradually to avoid sudden temperature changes which
tend to distort cookware.Do not add cold water to a
hot pan.
BALANCED PAN
• Balance is important for stability and even cooking.
The handle must not be heavier than the pan and tilt it
unevenly. A pan must sit level on the grate without
rocking or wobbling.
COVERED PAN
• A properly fitting lid will shorten cooking time and
make it possible to use lower heat settings.
Page 15
SECTION FOUR: USING THE COOKTOP
SPECIALTY COOKWARE
CANNINGTIPS:
• A flat base pan is preferred to one with a concave,
convex or rippled base.
• When using two canners at the same time, use
staggered burners. Do not block air to the burners.A
flame needs the right amount of air for complete
combustion.
FLAT-BOTTOM WOK PAN
• Use a cover on a canner when bringing the contents
to a boil.
• Once the contents have reached a boil on HI, use the
lowest flame possible to maintain the boil or pressure.
• Canning produces a large amount of steam. Take
precautions to prevent burns.
ROUND-BOTTOM WOK
IN SUPPORT RING
COOKING CHART
SUGGESTIONS FOR USINGTHE CHART
Use the chart on Pages 17 and 18 as a guide.The settings
you use will vary depending on the pans selected and the
starting temperature of the food.
• Woks – Either flat based or round bottom woks with
the accessory ring can be used on models without a
built-in wok burner.Round bottom woks must be used
with a support ring. Place the “F” on the accessory
ring facing to the front.
On the chart,the“Finish Setting” has been separated for
the standard and ExtraLow burners.There may or may
not be a change between the two burner settings.
• Canners and Stock Pots – Select one with a base
diameter that extends no more than 2 inches (51mm)
beyond the grate.
The ExtraLow setting can be either a cooking or a holding
setting.
Standard SizeWater Bath Canner
21 to 22 quarts (19.95 to 20.9 liters),
Raise or lower the flame setting gradually.Allow time for
the pan and the food to adjust to the new setting.
with an 11 to 12 inch base (279 to 305 mm) and
a 9 to 11 inch depth (229 to 279 mm).
Standard Size Pressure Canner
8 to 22 quarts (7.6 to 20.9 liters)), with an
8 to 11 inch base (203 to 279 mm) and
a 6-1/2" to 12 inch depth (165 - 305 mm).
Page 16
SECTION FOUR: USING THE COOKTOP
SURFACE BURNER COOKING CHART
Food
Start Setting
Finish Setting
Standard Burners
Finish Setting
ExtraLow® Burners
BEVERAGES
Med. – heat milk,
cover
LO – finish heating
XLO – keep warm,
cover*
Cocoa
BREADS
Med. – preheat skillet
Med. Lo to Med. –
Same as Standard
French Toast, Pancakes,
Grilled Sandwiches
cook
BUTTER
4 to 3 – allow 5 to 10
Melting
XLO – to hold
minutes to melt
CEREALS
Cornmeal, Grits,
Oatmeal
HI – cover, bring
water to a boil, add
cereal
Med. Lo to Med. –
finish cooking
according to package
directions
XLO – to hold, cover*
CHOCOLATE
Use XLO
2 to XLO – allow 10
to 15 minutes to melt
XLO – to hold*
Melting
DESSERTS
Med. Lo to Med. –
Med. Lo to Med.
Same as Standard
Candy
cook following recipe
Pudding and Pie Filling
Mix
Lo to Med.
cook according to
package directions
Lo
Same as Standard
Pudding
Med. Lo – Bring milk
to a boil
Use XLO
Use XLO
3 to 2 – to cook
EGGS
HI – cover, bring
water to a boil, add
eggs, cover
XLO – cook 3 to 4
minutes for soft cooked;
or 15 to 20 minutes for
hard cooked
Cooked in Shell
Fried, Scrambled
Poached
Med. to Med. HI –
melt butter, add eggs
Lo to Med. Lo
finish cooking
XLO – to hold for a
short period*
HI – bring water to
the steaming point,
add eggs
4 to 3 - finish
cooking
Same as Standard
MEAT, FISH, POULTRY
HI – until meat starts
Med. Lo to Med.
Same as Standard
Bacon, Sausage Patties
to sizzle
finish cooking
Braising: Swiss Steak,
Pot Roast, Stew Meat
HI – melt fat, then
brown on Med. Hi to
HI, add liquid, cover,
Use XLO
3 to 2 –
simmer until tender
Quick Frying: Breakfast
Steaks
Med. Hi to HI –
preheat skillet
Med. Hi to HI –
fry quickly
Same as Standard
Same as Standard
Same as Standard
Frying: Chicken
HI – heat oil, then
brown on Med.
LO cover, finish
cooking
Deep Frying: Shrimp
HI – heat oil
Med. Hi to HI – to
maintain temperature
Pan Frying:Lamb Chops,
Thin Steaks, Hamburgers,
Link Sausage
HI – preheat skillet
Med. to Med. HI –
brown meat
4 to 3 – to hold, covered
3 to 2 – to hold, uncovered
Poaching: Chicken,
HI – Cover, bring
Use XLO
2 to 1 – to finish cooking
whole or pieces, Fish
liquids to a boil
Page 17
SECTION FOUR: USING THE COOKTOP
SURFACE BURNER COOKING CHART
Food
Start Setting
Finish Setting
Standard Burners
Finish Setting
ExtraLow® Burner
Simmering: Stewed
Chicken, Corned Beef,
Tongue, etc.
HI – cover,
bring liquid
to a boil
4 to 1 – simmer slowly
PASTAS
HI – bring water to a
boil, add pasta
Med. Hi to HI – to
maintain a rolling boil
Same as for Standard Burners
Same as for Standard Burners
Macaroni, Noodles,
Spaghetti
POPCORN (use a heavy,
HI – cover, heat until
Med. to Med. Hi –
flat bottom pan)
kernels start to pop
finish popping
PRESSURE COOKER
Med. Hi to HI – build
up pressure
Med. Lo to Med. –
maintain pressure
Same as for Standard Burners
Same as for Standard Burners
Meat
Vegetables
HI – build up pressure
Med. Lo to Med. –
maintain pressure
RICE
HI – cover, bring
water to a boil, add
rice, cover
4 to 2 – cook according
to package directions
XLO – to hold, cover
SAUCES
Med. Hi to HI – cook
meat/vegetables,
follow recipe
2 to XLO – simmer
(2 to 3 to thicken sauce,
uncovered).
Tomato Base
White,Cream,Bernaise,
Med. Lo – melt fat,
LO to Med. Lo –
XLO – to hold, cover*
follow recipe
finish cooking
Hollandaise
Lo to Med. Lo
XLO
XLO – Lowest setting
SOUPS, STOCK
HI – cover, bring
3 to 2 – simmer
liquid to a boil
XLO – to hold, cover*
VEGETABLES
HI – cover, bring
water and vegetables
to a boil
Med. Lo to Med. –
cook 10 to 30 minutes,
or until tender
XLO – to hold, cover
Fresh
Frozen
HI – cover, bring
water and vegetables
to a boil
Med. Lo to Med. –
cook according to
package directions
Same as for Standard Burners
Same as for Standard Burners
Same as for Standard Burners
Same as for Standard Burners
Deep Frying
In Pouch
Saute
HI – heat oil
Med. to Med. Hi –
maintain frying
temperature
HI – cover, bring
water and vegetables
to a boil
LO to Med. Lo –
cook according to
package directions
HI – heat oil or melt
butter, add vegetables
Med. Lo to Med. –
cook to desired
doneness
Stir Fry
HI – heat oil, add
Med. Hi to HI –
Same as for Standard Burners
vegetables
finish cooking
*We recommend that these foods be stirred occasionally.
Page 18
SECTION FOUR: USING THE COOKTOP
Using the Grill
A VENTILATING HOOD of adequate cubic-feet-per-minute capacity vented to the outside of the house is
recommended for installation ABOVE THE RANGE AND GRILL. For most kitchens with a wall mounted
hood, a certified hood is recommended. The hood must be installed according to installation instructions
furnished with the hood and local building code requirements.
THE GRILL
(Available on some models)
AUTOMATIC
REIGNITION
GRILL
The electronic igniter auto-
matically sparks the burner to
light. DO NOT TOUCH any
burner while the igniters are
sparking.
When cooking food on the grill you
will achieve the same flavor as meat
cooked on an outdoor barbecue.
This flavor is actually created by the
fatsandjuicesthatarebroughttothe
surface of the food and caramelized
by the intense heatfromthestainless
steel radiant.
BURNER EFFICIENCY
AND FLAME
CHARACTERISTICS
Control Knob
Most types of foods, steaks, chops,
patties, poultry pieces, etc., cook
somewhat faster on the gas grill with
its constant regulated heat than on
an ordinary charcoal grill.
CONTROL KNOB
The burner control has an infinite
number of heat settings, and there
are no fixed positions on the control
knob between HI and LO. To turn
the burner on, press the control
knob and rotate it counterclockwise
to the LITE position.
The burner flame should be blue in
color and stable with no yellow tips,
excessive noise or lifting. It should
burn completely along both sides of
the burner tube.
Your new Thermador Professional®
grill is equipped with an aluminized
steelU-shapedtubeburnertypicalof
thoseusedinrestaurants.Automatic
ignition is used to eliminate the
continuouspilotsfoundonrestaurant
grills. The grill burner is rated at
18,000 BTU/HR.
An improper gas-air mixture may
cause either a yellow tipped flame or
burner flutter. Have the flame
adjusted by a technician. Foreign
particles in the gas line may cause an
orange flame during initial use. This
will disappear with use.
Adjust the knob to the desired heat
setting.
If the flame is uneven, flutters, makes
excessive noise or lifts, check to see
if the BURNER ports are clogged. If
the ports are clogged, use a wire, a
straightened paper clip or needle to
clear the ports. If the condition
persists, contact a service agency for
adjustment.
NOTE: When used with pro-
pane gas, a slight pop or flash
may occur at the burner ports
a few seconds after the burner
has been turned off. This usu-
ally occurs after the burner has
been on awhile. This is normal.
Page 19
SECTION FOUR: USING THE COOKTOP
Disassembly/Assembly of the Grill
Follow the steps below to disassemble the compo-
nents in the grill box.
CAUTION:
A. Remove the grill grate, stainless steel radiant and
burner from the grill box.
•
•
Use extreme care when placing the grill
components into the grill compartment.
Avoid contacting the ceramic igniter which
could break preventing operation of the
grill.
B. Remove the rectangular drip pan inside the grill box
as shown below.
C. Install the heat deflector into slots of front panel of
grill box.
The grill must be assembled as shown. The
drip tray heat shields must be in place, and
the burner must be properly positioned
relativetothegassupply. Incorrectassembly
ofthegrillmayresultinunsafeorhazardous
conditions during operation.
D. Insert the end of the burner into the slots at the
back of the grill box. Insert the tab on front of the
burner into slot in the heat deflector.
E. The stainless steel radiant lies on two (2) studs on
each end of the grill can.
•
•
Do not leave the grill unattended while in
use.
F. Place the grill grate, with raised food containment
rail oriented towards the grill box rear.
Do not use charcoal briquettes or coals of
any kind.
G. To reassemble the grill, follow these instructions in
reverse order.
Exploded Views and Side View of Grill
Grill
Grate
tainless
teel Radian
U-shaped
burner
eat
eflector
l Box
Burner Placement in slots in back of grill
Page 20
SECTION FOUR: USING THE COOKTOP
USINGTHE GRILL
GRILLING SUGGESTIONS
COOKING ONTHE GRILL
◆ Trim any excess fat from the meat before cooking. Cut slits in
• The burner should light within
approximately 5 seconds.
the remaining fat around the edges at 2" (51 mm) intervals.
◆ Brush on basting sauce toward the end of cooking.
• Preheat grill for 10 to 15 minutes
minimum. The hot grill sears the
food, sealing in the juices. The
longer the preheat,the faster the
meat browns and the darker the
grill marks.
◆ Use a spatula or tongs instead of a fork to turn the meat. A fork
punctures the meat and lets the juices run out.
◆ Add seasoning or salt after grilling.
• Grilling requires high heat for
searing and proper browning.
Most foods are cooked at the
higher heat settings for most of
the cooking time.However,when
grilling large pieces of meat or
poultry, it may be necessary to
turn the heat to a lower setting
after the initial browning. This
cooks the food through without
burning the outside.
◆ The grill grate has side and rear rails designed to make it easier
to turn with a spatula.
◆ After the juices begin to bubble to the surface, turn the meat
only once.This helps keep the juices in the meat.
◆ Some pieces of meat and poultry cook faster than others.Move
those pieces to the cooler area of the grill until the rest have
finished.
◆ The doneness of meat is affected by the thickness of the cut.
• Foods cooked for a long time or
basted with a sugary marinade
many need a lower heat setting
near the end of the cooking time.
Chefs say it is impossible to have a rare doneness with a thin cut.
◆ Do not leave the grill unattended while cooking.
• After grilling and the food has
been removed, turn the knob to
HI and burn off any excess grease
which has accumulated on the
stainless steel radiant.
HANDLING EXCESSIVE FLARE-UPS
◆ The intense heat needed for grilling may also cause flare-ups due
to grease dripping on the stainless steel radiant.
• Use a brass wire brush,dipped in
hot water,to loosen food particles
from the grate.
◆ If flare-ups occur,use a long handled spatula to move the food to
another area of the grill.
◆ Should flare-ups become excessive, remove the food from the
• When the grill has cooled, clean
the drip tray, radiant, heat
deflector and compartment.Wipe
the U-shaped burner with a damp
cloth.
grill and turn off the burner.
◆ Excessive flames occur when cooking meat with extra fat, i.e.
30% ground beef, untrimmed steaks, lamb chops, etc.
◆ Be cautious when turning meat over.
◆ It is important that grilling be supervised at all times.
Page 21
SECTION FOUR: USING THE COOKTOP
GRILL COOKING CHART
Food
Weight or
Thickness
Control
Setting
Total Suggested Special Instructions
CookingTime
andTips
MEATS
Beef
Hamburgers
1/2 to 3/4 inch
(13 mm to 19 mm)
Medium
High
14 to 18 minutes
12 to 15 minutes
Grill, turning once when
Juices rise to the surface.
Do not leave hamburgers
unattended since a flare
up can occur quickly.
Steaks
Rib, Club,
Tenderloin,
Porterhouse,
T-Bone,
Sirloin
Rare
(140ºF)
1" (25 mm)
1-1/2" (38 mm)
High
High
10 to 14 minutes
13 to 18 minutes
Remove excess fat from
edge. Slash remaining fat
at 2-inch (51 mm) intervals.
Grill, turning once.
Medium
(160º F)
1" (25 mm)
1-1/2" (38 mm)
Medium to
High
14 to 22 minutes
18 to 27 minutes
Well-Done
(170º F)
1" (25 mm)
1-1/2" (38 mm)
Medium
Medium
22 to 32 minutes
27 to 37 minutes
Lamb
Chops &
Steaks
Rare
1" (25 mm)
1-1/2" (38 mm)
High
High
12 to 15 minutes
14 to 18 minutes
Remove excess fat from
edge. Slash remaining fat
at 2-inch (51 mm) intervals.
Grill, turning once.
(140ºF)
Medium
(160ºF)
1" (25 mm)
1-1/2" (38 mm)
Medium to
High
15 to 20 minutes
18 to 25 minutes
Well-Done
1" (25 mm)
Medium
20 to 30 minutes
(170ºF)
Chops
Pork
1/2" (13 mm)
1" (25 mm)
Medium
Medium
20 to 40 minutes
35 to 60 minutes
Remove excess fat from
edge. Slash remaining fat
at 2-inch (51 mm) intervals.
Grill, turning once.
Cook well done.
Ribs
Medium
45 to 60 minutes
Grill, turning occasionally.
During last few minutes
brush with barbecue sauce,
turn several times.
Chart continued, please see next page
Page 22
SECTION FOUR: USING THE COOKTOP
GRILL COOKING CHART
Food
Weight or
Thickness
Control
Setting
Total Suggested Special Instructions
CookingTime
andTips
MEATS
Pork
Ham Steaks
(precooked)
Remove excess fat from
edge. Slash remaining fat at
2-inch (51 mm) intervals.
Grill, turning once.
1/2 inch
High
4 to 8 minutes
5 to 10 minutes
Hot Dogs
Medium
Slit skin. Grill, turning once.
POULTRY
Chicken
Broiler/Flyer
Halved or
2 to 3 pounds
Low or
Medium
1 to 1-1/2 hours
40 to 60 minutes
Place skin side up. Grill,
turning 2 to 3 times.
Quartered
Breasts, bone-in
Medium
30 to 45 minutes
FISH AND
SEAFOOD
Steaks
Halibut,
Salmon,
Swordfish
Whole
3/4 to 1 inch
Medium to
High
8 to 15 minutes
20 to 30 minutes
Grill, turning once. Brush
with melted butter, margarine
or oil to keep moist.
Grill, turning once. Brush
with melted butter,
margarine or oil to
Catfish,
Rainbow
Trout
8 to 16 ounces
Medium to
High
moisten.
Page 23
SECTION FOUR: USING THE COOKTOP
ABOUTTHE GRIDDLE
(Available on some models)
The griddle plate should be washed with warm soapy
water then rinsed with clear water prior to use. The
griddle may be used without any butter,margarine or oil.
However,a very small amount may be used to flavor foods.
Any utensil, including metal ones may be used on the
griddle surface. Care should be taken so the surface is
not gouged when metal utensils are used.
DESCRIPTION
The built in griddle is made of restaurant quality aluminum
coated with titanium.This produces a surface with even
heat that is easy to clean.
The griddle has an aluminized steel tube burner that is lit
by a spark igniter.The griddle should light within 4 clicks
of the igniter.This eliminates the need for a continuous
burning pilot lighter.
lide back and lift
A maple chopping block is available as an accessory and
purchased separately.It is sized to fit on top of the surface
when the griddle is not being used.
•The burner is rated at 15,000 BTU / HR.
CONTROL KNOB
GRIDDLE
Griddle GreaseTray
GRIDDLE GREASETRAY
• Push the tray under the front edge of the griddle
overhang to catch grease or food residue.
• Use a metal spatula to scrape the grease and food
particles forward from the surface into the tray.
• Clean the tray after every use. When removing the
tray, use care when tipping it so that the contents do
not spill.
Cooking on the Griddle
Control Knob
1. Check that the grease tray is tucked under the griddle
plate overhang.
2. Turn the knob to the cooking temperature to preheat
the griddle.
• The griddle is electronically controlled with
temperatures marked on the knob from 150ºF to
500ºF.
3. Preheat 10 to 15 minutes.
• There are no fixed settings on the knob.
4. Add butter,margarine,oil or shortening for more flavor.
5. Add the food and cook.
• Press and turn the knob counter-clockwise to the
temperature setting.
PREPARINGTHE GRIDDLE
The griddle must be level or tilted slightly forward for
optimum performance. The griddle should have been
leveled during installation.If not,the griddle can be leveled
by removing the griddle plate and frame then adjusting
the leveling screws at the front and back of the griddle
opening.
GRIDDLE COOKING CHART
FOOD
SETTING
Bacon, Ham, Pork Chops 350ºF to 375ºF (177ºC to 190ºC)
Eggs
300ºF to 325ºF (150ºC to 160ºC)
350ºF to 375ºF (177ºC to 191ºC)
400ºF to 425ºF (205ºC to 219ºC)
350ºF to 375ºF (177ºC to 191ºC)
Pancakes, French Toast
Potatoes, Hash Brown
Sandwiches, Sausage
Page 24
SECTION FIVE: USING THE OVEN
Bake
RACK POSITIONS
TIPS FOR BAKE
PREHEATING THE OVEN
Many foods such as meat, poultry,
casseroles, or other long cooking
foods cook well without preheating
the oven. See your recipe for pre–
heatingrecommendation. Preheating
time depends on the temperature
setting and the number of racks in
the oven.
5
4
3
2
1
GETTING THE BEST
RESULTS
▲
▲
▲
Minimize opening the door:
Use a minute timer.
Usetheinteriorovenlights.
Choosetherightsizeutensil;use
the utensil recommended in the
recipe.
Store the broiler pans outside
the ovens. An extra pan without
food, affects the browning and
cooking.
The type of pan used affects the
browning:
•
•
Large Gas Main Oven
Bake Rack Positions
Rack positions in the oven are numbered like an elevator. Number one position
is the lowest rack and number five is at the top.
LARGE MAIN OVEN
One Rack Baking
•
The Bake Mode is best for baking on one rack with rack #3 used for most
baked items. If the item is tall such as an angel food cake rack #2 may be
used. Pies are best baked on rack #2 to make certain the bottom of the
crust is done without over browning the top. When large pieces of meat
or poultry such as a prime rib of beef or a turkey is roasted, rack #2 is the
preferred rack.
▲
•
•
For tender, golden brown
crusts, use light non-stick/
anodized or shiny metal
utensils.
For brown crisp crusts, use
dark non-stick/anodized or
dark, dull metal utensils or
glass bakeware. These may
require lowering the bake
temperature 25˚F.
Two Rack Baking
•
Racks #2 and #5 may be used when baking on two levels. Foods such as
cookies and biscuits work well using these two racks. Casserole dishes
may also be baked using these two racks.
Three Rack Baking
•
If three rack baking is desired, the Convection Bake mode should be used.
12 INCH AUXILIARY OVEN (PGR48 Models)
BAKEWARE
■
•
Baking on rack #3 will result in the best product. When additional height
is needed, rack #2 may be used. The use of rack #2 with pies will result
in a crisp bottom crust without over baking the top.
Type
▲
Metalbakeware(withorwithout
a non-stick finish), heat-proof
glass, glass-ceramic, pottery, or
other utensils suitable for the
oven.
Suitable cookie sheets have a
small lip on one side only.
Large oven will hold a full
commercial baking sheet (18" x
26").
•
If two rack baking is desired in this small oven, use racks #2 and #5. For
best results, stagger baking pans front to rear with the pan on rack #2
toward the rear and the pan on rack #5 toward the front.
■ Placement
▲
▲
▲
Allow at least 1" of space between the pans and the oven walls so heat can
circulate around each pan.
Stagger baking utensils so that one is not directly above another. Allow
1-1/2 inches above and below each pan.
▲
Page 25
SECTION FIVE: USING THE OVEN
Convection Bake
TIPS FOR CONVECTION BAKE
PREHEATING THE OVEN
RACK POSITIONS
LARGE MAIN OVEN
Many foods such as meat, poultry,
casseroles, or other long cooking
foods cook well without preheating
the oven. See your recipe for pre–
heatingrecommendation. Preheating
time depends on the temperature
setting and the number of racks in
the oven.
One Rack Baking
•When baking on one rack,best results are obtained in the bake mode
(see Bake).
•When roasting a turkey or a large piece of meat,convection bake may
be used. Rack #2 is the most appropriate rack.
Two Rack Baking
•Racks #2 and #5 are most appropriate when using the convection
bake mode. Pans should not be staggered but the baking pan on rack
#5 should be placed on rack #2 directly under the one on rack #5.
•This may be used for cakes,cookies,biscuits and other foods for which
two rack baking is desirable.
•When several casseroles , frozen pies or cakes are to be baked, use
racks #2 and #5.
•These two racks can also be used for a large oven meal.
HIGH ALTITUDE
BAKING
When baking at high altitudes, in
either BAKE or CONVECTION•
BAKE, recipes and baking times vary.
For accurate information, write the
Extension Service, Colorado State
University, Fort Collins, Colorado
80521. There may be a cost for the
bulletins. Specify the type of
information you want (example:
cakes, cookies, breads, etc.).
Three Rack Baking
•When several sheets of cookies are to be baked, bake them on racks
#1,#3,and #5. Place the baking sheets directly on top of each other on
the respective racks to allow air to flow around the baking sheets.
BAKEWARE
Type
CONDENSATION
It is normal for a certain amount of
moisturetoevaporatefromthefood
during any cooking process. The
amount depends on the moisture
content of the food. The moisture
will condense on any surface cooler
than the inside of the oven, such as
the control panel.
•
•
Aluminum bakeware gives the best browning results.
Cookie sheets should have low sides; use aluminum commercial
half-sheets or professional cooking utensils.
Placement
•
•
For better browning, utensils such as cookie sheets, jelly roll pans
and rectangular baking pans should be placed crosswise on the rack
with the shorter sides on the right and the left. This allows the air
to circulate freely.
When baking on more than one rack, pans should not be staggered.
CAUTION
■ WHEN USING THE
OVEN IN ANY MODE
Never use aluminum foil
to cover the oven racks
or to line the oven. It can
damage the oven and cause a
fire hazard if heat is trapped
under it.
Page 26
SECTION FIVE: USING THE OVEN
Setting Bake/Convection Bake
BAKE/CONVECTION BAKE
Thesecookingmodesareforbaking, roastingorwarming
using one, two or three racks.
OVEN CONTROL KNOBS
TO SET THE GAS OVEN
1. Select BAKE or CONVECTION•BAKE using the
Selector switch.
2. Set Temperature using the Oven Control Knob.
▲ The convection fan turns on six minutes after the oven is
turned on, if CONVECTION BAKE is selected.
▲ The OVEN and HEATING lights turn on.
▲ The HEATING light cycles off and on. The oven is
preheated when the HEATING light cycles off the first
time.
NOTE: When the oven is used for an
extendedperiodoftimeatahightemperature,
the cooling blower will turn on. This is
normal. Thiscoolingblowerwillalsooperate
during Broil and during the Self-Cleaning
cycle. Iftheblowerisnotrunningduring
these modes, do not use the oven. Call
a qualified appliance technician to repair the
unit.
▲ The OVEN ON light illuminates and remains on until the
OFF Selector switch is turned off or the oven control knob
is turned to the OFF position.
▲ The needle of the gauge in the center of the control panel
moves to the selected temperature. The gauge is for
reference only.
TO SET THE 12-INCH OVEN
OVEN CONTROL KNOBS
1. Select BAKE using Selector switch.
2. Set Temperature using the Oven Control Knob.
▲ The OVEN ON light turns on.
▲ The HEATING light turns on.
▲ The HEATING light cycles off and on. The oven is
preheated when the HEATING light cycles off the first
time.
▲ The OVEN ON light remains on until the Selector
switch is turned off.
Page 27
SECTION FIVE: USING THE OVEN
Other Uses of Bake
SLOW COOKING AND LOW TEMPERATURE USES OF THE OVEN
In addition to providing perfect
temperaturesforbakingandroasting,
FOOD SAFETY
the oven can be used at low oven
temperatures to keep hot, cooked
foods at serving temperature, to
dehydrate food and to warm plates.
The United States Department of Agriculture advises: DO
NOT hold foods at temperatures between 40˚F to 140˚F more than 2
hours. Cooking raw foods at below 275º F is not recommended.
Hot cooked foods can be kept at
serving temperatures. Set the oven
to bake and use the temperature
suggested on the chart.
Suggested Temperature Chart to Keep Food Hot
FOOD
OVEN TEMPERATURE ˚F
Foodsneedingtobekeptmoistmust
be covered with a lid or aluminum
foil.
Beef
Rare ............................................................................140˚ - 155˚F
Medium ......................................................................155˚ - 170˚F
Well done..................................................................170˚ - 180˚F
Bacon....................................................................................200˚ - 225˚F
Biscuits and Muffins (covered) .......................................170˚ - 185˚F
Casserole (covered) .........................................................170˚ - 200˚F
Fish and Seafood ................................................................170˚ - 200˚F
French Fried Foods ...........................................................200˚ - 225˚F
Gravy or Cream Sauces (covered) ...............................170˚ - 180˚F
Lamb and Veal Roasts ......................................................170˚ - 200˚F
Pancakes and Waffles (covered)....................................200˚ - 225˚F
Potatoes
Baked ...................................................................................... 200˚F
Mashed (covered)....................................................170˚ - 185˚F
Pies and Pastries ............................................................................ 170˚F
Pizza (covered)............................................................................... 225˚F
Pork .....................................................................................170˚ - 200˚F
Poultry (covered) ..............................................................170˚ - 200˚F
Vegetables (covered) ........................................................170˚ - 175˚F
OVEN CONTROL KNOBS
12" GAS OVEN
LARGE GAS MAIN OVEN
Page 28
SECTION FIVE: USING THE OVEN
Baking Chart
Control
Total
Special
Pan
Size
Temperature
Setting
Suggested
Cooking Time
Instructions
and Tips
Food
Cookies
12"x15"
375°
350°
350°
325°
325°
8 to 12 minutes
25 to 35 minutes
30 to 40 minutes
60 to 75 minutes
20 to 25 minutes
10 to 15 minutes
Follow recipe
instructions
Cookie Sheet
Layer Cakes
Sheet Cakes
8" or 9" Round
9"x13" Pan
Follow recipe
instructions
Follow recipe
instructions
Bundt™ Cakes 12 Cup
Follow recipe
instructions
Brownies
or Bar Cookies
9"x9" Pan
Follow recipe
instructions
Biscuits
12"x15"
Cookie Sheet
425° or
Follow recipe or
package directions
Package
Directions
Quick Bread
Muffins
8"x4" Loaf Pan
350°
55 to 70 minutes
14 to 19 minutes
Follow recipe or
package directions
12 cup Muffin Pan
425°
Follow recipe or
package directions
Fruit Pies
9" Diameter
9"x9" Pan
425°
400°
425°
400°
35 to 45 minutes
25 to 30 minutes
25 to 30 minutes
12 to 18 minutes
Follow recipe
instructions
Fruit Cobblers
Follow recipe
instructions
Yeast Bread,
Loaves
8"x4" Loaf Pan
9"x13" Pan
Follow recipe
instructions
Dinner Rolls
Follow recipe
instructions
Page 29
SECTION FIVE: USING THE OVEN
Broil
RACK POSITIONS
BROIL
Before turning on the oven, place the rack in the desired position. After
preheating the broiler, center the broil pan directly under the infrared
burners.
TIPS FOR BROIL
PREHEATING THE
BROILER
Gas Oven
#5 Usethisrackpositionwhenbroilingbeefsteaks, groundmeatpatties, ham
steak and lamb chops 1 inch or less in thickness. Also, use when top
browning foods.
It is recommended that you
preheatthebroilelementbefore
starting to cook. Preheat until the
dial reaches broil.
#4 Use this rack position when broiling meat 1-1/8 inches or more in
thickness, fish, poultry, pork chops, ham steaks 1 inch or more in
thickness.
GETTING THE
BEST RESULTS
#3 Use this rack when broiling chicken halves (remove skin).
UTENSILS
▲ Be sure to defrost food before
broiling.
▲ The chromeandporcelainenameltwo-piecebroilpanandgridisincluded
with the range. DO NOT cover the slotted grid (top) with aluminum foil.
▲ Doormaybeajarorclosedduring
▲ Usemetalorglass-ceramicbakewarewhentopbrowningcasseroles,main
broiling.
dishes, or bread.
▲ Steaks should be at least 1" thick
.
▲ DO NOT use heat-proof glass or pottery. This type of glassware cannot
if rare meat is desired.
withstand the intense heat of the broil element.
▲ The two-piece aluminum broiler pan is designed to be used in the 12"
▲ Turn foods over only once, after
half the total cooking time. It is
not necessary to turn very thin
foods (ham slices, fillets of fish,
etc.). Liver slices must be turned
over regardless of thickness.
Auxiliary Oven in the PGR48 Ranges.
BROILING USING A REGULAR MEAT THERMOMETER
For accurately determining the degree of doneness for a thick steak or chop
(at least 1-1/2 inches thick), use a regular meat thermometer. Insert the point
of the thermometer into the side of the meat to the center of the steak or
chop.
▲ Useaminutetimer. Setitforthe
minimumtimetocheckthefood.
For rare steaks, cook the first side to 90˚F. For medium or well done steaks,
cook the first side to 100˚F. Turn and cook the second side to desired internal
temperature.
▲ Center foods directly under the
infrared burners for best
browning.
Small Gas Oven (Models PGR48)
Foods may be broiled on racks #3, 4 or 5 depending upon the type and
thickness of the food. Rack #5 may be used for top browning of foods.
▲ To avoid burning chicken skin,
remove it before broiling.
NOTE:
It is impossible to use the oven and the broiler simultaneously.
When one is on, the other one cannot be turned on.
Page 30
SECTION FIVE: USING THE OVEN
Setting Broil for Gas Oven
BROIL - Gas Oven
Only the infrared burners heat in the BROIL mode.
NOTE: Successful broiling requires constant ex-
posure to high, intense heat .
Place rack in recommended position on Page 32. Before
placing food in the oven for broiling, preheat the broiler
element until the dial reaches “Broil.”
To Set the Oven to Broil
1. Place oven rack in desired position.
2. Set Selector Switch to Broil.
3. Set Oven Control Knob to BROIL setting.
4. The door may ajar or closed throughout broil cycle.
▲ Your Professional® Range comes with a large two-piece broil
pan. The slotted grid allows drippings to flow into the lower
pan,away from the intense heat of the broil burners,minimizing
spattering and smoking.
▲ The PGR48 Models have a small two-piece aluminum broiler
pan. It is to be used in the small auxiliary oven.
Oven Heating Light
This light turns on when the oven heats and cycles off
when the set temperature has been reached.The cycling
continues as long as a BROIL mode is set.
Page 31
SECTION FIVE: USING THE OVEN
Broiling and Roasting Chart
All meats are placed on the broiler pan included with the range.
Food Item
Rack
Number Mode
Oven
Control
Temperature
Setting
Approximate
Cooking
Time
Special
Instructions
and Tips
Beef
Ground Beef
5
5
Broil
Broil
Broil
15 to 20 minutes Broil until no
pink in center
Patties 1/2" thick
,
T-Bone Steak
Flank Steak
Broil
12 to 20 minutes Time depends on
rareness of steak
5
3
Broil
Bake
Broil
12 to 20 minutes Rare to Medium
rare is best
Eye of Round
Roast
325°
20 to 25 min/lb
20 to 25 min/lb
Small roasts take
more minutes per
pound
Pork
Loin Roast
5
Bake
325°
Cook until juices
are clear
Poultry
Boneless, Skinless
Chicken Breasts
4
4
Broil
Broil
Broil
Broil
20 to 25 minutes Cook until juices
are clear
Chicken Thighs
25 to 30 minutes Remove skin; Cook
until juices are clear
Half Chickens
Roast Chicken
3
3
Broil
Bake
Broil
30 to 45 minutes Remove skin;
Turn with tongs
350° min
75 to 90 min
Roast with breast
side down to keep
breast moist.
Turkey
2
Bake
325° min
20 to 25 min/lb
Roast Unstuffed
Page 32
SECTION SIX: CARE AND MAINTENANCE
Self-Cleaning the Oven
LOCK
LARGE GAS MAIN OVEN
When the CLEAN cycle starts, the LOCK light turns on, and the automatic
door lock cycle begins. Check the door when the LOCK light comes on to
confirm that it is locked. You can stop the clean cycle by selecting the OFF
position. Thelocklightwillturnoffonlyaftertheovenhascooledbelow550˚F,
and the automatic door lock has completed its cycle to the open position.
The self-cleaning mode of your new
rangefeaturespyrolyticself-cleaning.
When set to the CLEAN mode, the
ovenreachesahightemperaturethat
burns off the food soil.
Makecertainthattheovendoorislockedatthebeginningoftheself-
cleaning cycle.
When the oven is set for CLEAN,
only the cooktop burners (four or
six) may be used. The 12-inch oven
(ModelPGR48only),thegriddleand/
or the grill cannot be used.
BEFORE SELF CLEANING THE OVEN
✓
Remove all utensils.
✓ Be sure the light bulbs
and glass covers are in
place.
It is common to see smoke and/
or flames during the CLEAN
cycle, depending on the content and
amount of soil remaining in the oven.
If a flame persists, turn off the oven
and allow it to cool before opening
the door to wipe up the excessive
food soil.
✓
Remove Racks.
✓ Clean the oven front
frame and outer door
edges. Wipe up large
spillovers and grease.
✓ Turn on the ventilator
hoodabovetherangeand
leave it on until after the
oven has completed the
self-clean cycle.
Wipe out puddles of grease and any
loosesoilthatcanbeeasilyremoved.
At the end of the CLEAN cycle,
some gray ash or burned residue
may remain inside the oven. This is
a mineral deposit that does not burn
or melt. The amount of ash depends
on how heavily soiled the oven was
before it was cleaned. It is easily
removed, when the oven is cold,
using a damp paper towel, sponge, or
cloth.
Remove any soil that is outside the
door seal area. This appliance is
designed to clean the oven interior
and that portion of the door that is
inside the oven. The outer edges of
the door and the oven cavity are not
in the cleaning zone. Wipe this area
clean BEFORE SETTING THE
OVEN TO SELF-CLEAN.
NOTE: For the first Self-
Cleaning cycle, remove small
animals and birds from the
kitchen and surrounding
areas.Open a nearby window
for additional ventilation.
Wipe off any smoke residue that
remains on the front frame with
Formula 409® or Fantastik®. If stain
remains, use a mild liquid cleanser.
Theamountofsmokestainisdirectly
relatedtotheamountoffoodsoilleft
intheovenatthetimeofself-cleaning.
Clean the oven often.
Page 33
SECTION SIX: CARE AND MAINTENANCE
SELF CLEANING THE OVEN
To Set Self-Clean for the Large Main Self-Cleaning Oven
OVEN CONTROL KNOBS
1. Select CLEAN using the Selector switch.
2. Set Oven Control Knob to CLEAN.
▲ Cooling Blower turns on.
▲ OVEN ON light and HEATING light turn on.
▲ LOCK light turns on.
▲ The door closing process takes approximately 60 seconds to
complete, at which time the door becomes locked. Check to
make certain the door is locked.
AT THE END OF THE CLEAN CYCLE
The Clean cycle takes 4 to 5 hours to complete. The blower and the OVEN
ONlightandtheCLEANlightturnoffwhenthecycleisfinished. Donotturn
the selector switch or the oven control knob to the OFF position until the
LOCK light goes off.
1. Select OFF using the Selector Switch.
CAUTION
The interior of the oven will
still be at baking temperatures
whentheLOCK lightturnsoff
and the oven door can be
opened.
▲ The door latch will open automatically when the oven is below
550˚F and the automatic Door Lock completes its 60 second
cycle to the OPEN position.
2. Turn Oven Control Knob to OFF position.
CLEANING HINTS
1. The porcelain enamel finish is acid resistant, but not acid proof. Acidic
foods, such as citrus juices, tomatoes, rhubarb, vinegar, alcohol or milk,
should be wiped up and not allowed to bake onto the porcelain during the
next use.
2. Remove the oven racks. See Racks, on Range Cleaning Chart, Page 40.
3. The infrared burner in the oven does not require cleaning; the
elements burn themselves clean when the oven is in use.
4. Use caution when cleaning the the 12-inch auxiliary oven in the PGR48
range. Use hot sudsy water; rinse and dry thoroughly.
Page 34
SECTION SIX: CARE AND MAINTENANCE
RANGE CLEANING
CAUTION
BRAND NAMES
WHEN CLEANING THIS
Avoid cleaning any part of
the range while it's hot.
The use of brand names is intended
only to indicate a type of cleaner.
This does not constitute an
endorsement. The omission of any
brand name cleaner does not imply
its adequacy or inadequacy. Many
products are regional in distribution
andcanbefoundinthelocalmarkets.
RANGE:
1. Use the mildest cleaning procedure that
will do the job efficiently and effectively. Some cleaners of the same type
are harsher than others. Try on a small area first.
2. Always rub metal finishes in the direction of the polish lines for maximum
effectiveness and to avoid marring the surface.
3. Use only clean soft cloths, sponges, paper towels, fibrous brushes, plastic,
non-metal or steel wool soap pads for cleaning and scouring, as
recommended on the chart.
4. Any part of this appliance can be cleaned with hot sudsy water. When
rinsing is required, rinse thoroughly.
It is imperative that all products be
used in strict accordance with
instructions on the package.
The following chart gives directions
for cleaning this range:
5. Always wipe dry immediately to avoid water marks.
COOKTOP CLEANING CHART
Cooktop Part / Material
Suggested Cleaners
Important Reminders
• Acidic and sugar-laden spills
deteriorate the stainless steel.
Remove soil immediately.
Burner Base and Cap
and SpillTray/
Stainless Steel
• Hot sudsy water; rinse and dry
thoroughly.
Burner
Base
• Mild Abrasive Cleansers: Bon
Ami®,Ajax®, Comet®.
Liquid cleaners: Kleen King®.
• Do not scratch or gouge the
port openings of burner cap.
• Stiff nylon bristle tooth brush to
clean port openings.
• Reassemble as shown.Make sure
that the burner cap is seated on
the base.
B
C
Star™ Burner
Components
• Hot sudsy water; rinse and dry
immediately.
• Do not soak knobs.
Control Knobs/Plastic
Bezels/Chrome
Please see Guide to Knob
Identification and Location
on Page 11.
• Do not force knobs onto
wrong valve shaft.
Continued
➟
➟
Page 35
SECTION SIX: CARE AND MAINTENANCE
COOKTOP CLEANING CHART
Cooktop Part / Material
Suggested Cleaners
Important Reminders
• Stainless steel resists most
food stains and pit marks
providing the surface is kept
clean and protected.
Exterior Finish/Back Panel
Stainless Steel
• Nonabrasive Cleaners:Hot water
and detergent, ammonia, Fan-
tastic®, Formula 409®. Rinse and
dry immediately.
• Cleaner Polish: Stainless Steel
Magic® to protect the finish from
staining and pitting; enhances
appearance.
• Never allow food stains or salt
to remain on stainless steel for
any length of time.
• Rub lightly in the direction of
polish lines.
• Hard water spots: Household
vinegar.
• Chlorine
or
chlorine
• Mild Abrasive Cleaners: Siege
Stainless Steel and Aluminum
Cleaner, Kleen King® Stainless
Steel liquid cleaner.
compounds in some cleaners
are corrosive to stainless steel.
Check ingredients on label.
• Heat discoloration: Cameo®,
Barkeepers Friend®, Zud®.
Grates:/Porcelain Enamel on
Cast Iron
• Nonabrasive cleaners: Hot water
and detergent, Fantastic®,
Formula 409®. Rinse and dry
immediately.
• The grates are heavy; use care
when lifting. Place on a
protected surface.
• Blisters/ crazing/ chips are
common due to the extreme
temperatures on grate fingers
and rapid temperature
changes.
• Mild abrasive cleaners: Bon Ami®
and Soft Scrub®.
• Abrasive cleaners for stubborn
stains: soap-filled steel wool pad.
• Acidic and sugar-laden spills
deteriorate the enamel.
Remove soil immediately.
• Abrasive cleaners, used too
vigorously or too often can
eventually mar the enamel.
Griddle GreaseTray/
Titanium Coated Aluminum
• Clean the grease tray after each
use.
• Empty grease tray after each
use.
• May be placed in dishwasher.
• Remove tray after grease has
cooled. Be careful not to fill it
so full that tipping to remove
it spills the grease.
• Wash in detergent and hot water;
rinse and dry.
Slide back and lift
• Stubborn soil: Soft Scrub®
Page 36
SECTION SIX: CARE AND MAINTENANCE
COOKTOP CLEANING CHART, continued
Cooktop Part / Material
Suggested Cleaners
Important Reminders
• Never flood a hot griddle with
cold water. This can warp or
crack the aluminum plate.
• Remove drip tray and discard
grease into a grease resistant
container for disposal.Wash drip
tray in warm soapy water or
place in dishwasher. Wipe griddle
surface with warm soapy water
then rinse with warm water.
Wipe dry with a soft cloth.
Griddle/Titanium surfaced
• Do not clean any part of the
griddle in a self-cleaning oven.
• If food particles stick to the
griddle plate,remove with a mild
abrasive cleaner such as Soft
Scrub®.
Grill Box/Stainless Steel
• Non-abrasive Cleaners: Hot
water and detergent, ammonia,
Fantastic®, Formula 409®. Rinse
and dry immediately.
• Do not clean any part of the
grill assembly in a self-cleaning
oven.
Grill
• Abrasive cleaners, used too
vigorously or too often, will
eventually scratch the steel.
• Mild Abrasive Cleaners: Bon
Ami®, Soft Scrub®.
• Abrasive cleaners for stubborn
stains:soap-filled steel wool pad,
Kleen King® Stainless Steel liquid
cleaner.
• When disassembling, cleaning
and reassembling the grill,avoid
contact with the spark igniter.
Note: To reach the grill box, remove the grate, stainless steel
radiant, U-shaped burner, heat shield and drip pan.
Note: To disassemble or reassemble the grill box, see Page 20.
Electrode,
Spark
Grill Can
Assembly
Grease Catch Tray
Continued
➟
➟
Page 37
SECTION SIX: CARE AND MAINTENANCE
COOKTOP CLEANING CHART, continued
Cooktop Part / Material
Suggested Cleaners
Important Reminders
Grill Drip Pan / Stainless Steel
• Hot sudsy water; rinse and dry
thoroughly.
• Do not clean in a self-cleaning
oven.
• After grease removal, drip pan
may be put into dishwasher.
• While the grate is hot (but the
flame is off), dip a brass grill
brush in hot water and scrub
the grate. The steam created
from the hot water and the
abrasive action of the brush
helps loosen the hard to
remove soil.
Grill Grate/Porcelain
Enamel on Cast Iron
• The grate is heavy; use care
when lifting. Place on a
protected surface.
• Blisters, crazing and chips are
common due to the extreme
temperatures and rapid temp-
erature changes.
• Use a cotton swab dampened
with water, Formula 409® or
Fantastic®.
Igniters/Ceramic
• Do not use sharp tool to
scrape the igniter. It is fragile;
if it is damaged the grill cannot
be lit.
Surface SpillTrays/
Stainless Steel
• Hot sudsy water; rinse and dry
thoroughly.
• Acidic and sugar-laden spills
deteriorate the stainless steel.
Remove soil immediately.
• Formula 409® or Fantastic®.
Wipe spray off immediately or
apply to a paper towel first and
then wipe spill.
• Abrasive cleaners, used too
vigorously or too often, can
eventually mar the stainless
steel.
• Mild Abrasive Cleansers:
Cameo®, Zud®, Barkeepers
Friend®. Liquid cleaners: Kleen
King®, Siege Stainless Steel and
Aluminum Cleaner. Apply with
care.
• Hot sudsy water; rinse and dry
thoroughly.
• The over-spray from liquid
cleaners may leave an outline
shadow. If allowed to dry, it
may leave a permanent
outline.
Trim Strips
• Formula 409® or Fantastic®.
Wipe spray off immediately
or apply to a paper towel
first and then wipe soil.
(Located between stainless
steel spill trays; they join the
spill trays.)
Page 38
SECTION SIX: CARE AND MAINTENANCE
OVEN CLEANING CHART
Part/Material/Soil Condition
Cleaning Products/Directions
DO NOT CLEAN IN SELF-CLEANING OVEN
To loosen cooked on food, sprinkle empty hot grid with powdered laundry
detergent or squirt with liquid detergent and cover with wet paper towels. Allow
to stand.
OVEN
Broil Pan Grid
Chrome Plated
Hot sudsy water.
Aluminum (12" oven)
•
Wash, rinse thoroughly, and dry.
Cleaners: Soft Scrub®.
•
Apply with a damp sponge or cloth according to manufacturer’s directions.
Rinse and wipe dry.
Powdered Cleanser: Bon-ami®, Comet®, Ajax®.
•
Applywithadampspongeorclothaccordingtomanufacturer’sdirections. Rub
lightly, it may scratch the finish. Rinse thoroughly and wipe dry.
Soap-filled fiber or steel wool pads: S.O.S®, Brillo®.
•
Dampen pad, rub lightly, it may scratch the finish. Rinse thoroughly and wipe
dry.
Broil Pan Bottom
Porcelain Enamel
See instructions for Cavity porcelain enamel. See instructions, above for
broil pan grid.
Aluminum (12" oven)
Porcelain enamel is acid resistant, but not acid proof. Acid foods such as citrus
juices, tomatoes, rhubarb, vinegar, alcohol or milk, should be wiped up and not
allowed to bake onto the porcelain during the next use. Over a period of time, the
porcelain may craze (get fine hairlike lines).
Cavity
Porcelain Enamel on Steel
See Self-Cleaning instructions, Pages 33 and 34.
Large Main Oven
NOTE: Due to the high temperatures used for self-cleaning, the oven may develop
fine hairlike lines or surface roughness. This is a common condition and does
not affect either the cooking or the cleaning performance of the oven.
Hot sudsy water.
12" Oven
•
Wash, rinse thoroughly, and dry.
Mild Cleaners: Bon-ami®, ammonia, or ammonia and water, Soft Scrub®.
•
Apply to a damp sponge or cloth. Rub lightly. Rinse thoroughly. Dry.
If food has burned onto the oven and is difficult to remove, the spots can be
soaked with a cloth saturated with household ammonia. Close the door and
allow it to soak for an hour or two, or until the food soil can be easily removed
with a damp soapy cloth or mild abrasive. A solution of about 3 tablespoons
of household ammonia in a half cup of water may be placed in the warm oven
overnight. Thiswillloosenhardenedresidueandspillagesothatitmaybeeasily
wiped up. The ammonia solution may be added to warm water for a thorough
wiping of the oven.
Continued
➟
➟
Page 39
SECTION SIX: CARE AND MAINTENANCE
RANGE CLEANING CHART
Part/Material/Soil Condition
Cleaning Products/Directions
Front Frame
See Cooktop, Back Panel, Page 36.
Stainless Steel
Oven Racks
Racks may be cleaned in the oven during the clean cycle, however, they
will lose their shiny finish and change to a dark, metallic gray.
Chrome Plated
Hot sudsy water.
•
Wash, rinse thoroughly, and dry.
Cleaners: Soft Scrub®.
•
Applywithadampspongeorclothaccordingtomanufacturer’sdirections. Rinse
and wipe dry.
Powdered Cleanser: Bon-ami®, Comet®, Ajax®.
•
Apply with a damp sponge or cloth according to manufacturer’s directions. Rub
lightly. Rinse thoroughly and wipe dry.
Soap filled fiber or steel wool pads: S.O.S®, Brillo®.
Dampen pad, rinse thoroughly, and dry.
•
Harsh Cleaners: Easy Off ®Oven Cleaner, Dow® Oven Cleaner.
NOTE:Somecommercialovencleanerscausedarkeninganddiscoloration. Testthe
cleaner on a small part of the rack and check for discoloration before cleaning
the entire rack.
•
Apply a generous coating. Allow to stand for 10 to 15 minutes. Rinse thoroughly
and wipe dry.
If the racks do not slide easily after being cleaned, dampen a paper towel with a small
amount of cooking oil and rub it lightly over the side rails.
DOOR
Use care to keep cleaners and water away from the door vents. If water
or cleaners spill into the vents, water may streak the glass inside.
Exterior, Frame, Handle, Heat
Deflector
See Cooktop, Back Panel, Stainless Steel, Page 36.
Stainless Steel
Interior
See Oven Cavity, Page 39.
Porcelain Enamel
Seal
General Kitchen Cleaners: Formula 409®, Fantastik®.
Door Gasket
•
Spray on and blot dry with a cloth. Do not rub. Do not move, remove or damage
mesh.
Page 40
SECTION SIX: CARE AND MAINTENANCE
DO-IT-YOURSELF MAINTENANCE
OVEN LIGHT BULB REPLACEMENT
!
Replace only with a 5-watt, halogen appliance light bulb. DO NOT USE a
standard household light bulb in any oven.
CAUTION:
Before replacing the light bulb,
be certain the Oven Light
Switch is in the off position.
Let bulb and cover cool com-
pletely before touching. If the
lightbulbglasscomesloose
from the base, turn the
power to the oven OFF at
the circuit breaker panel,
before attempting to re-
move the bulb base from
the socket.
TO REPLACE THE LIGHT BULB:
1. Turn oven light switch to the off position. Let bulb and cover cool
completely.
2. Remove the light cover.
3. Remove the burned-out bulb. Replace it with a 5-watt halogen
appliance light bulb only. Don't touch bulb with greasy fingers.
Follow bulb manufacturer's instructions.
4. Replace cover. Turn circuit back on, if need be. (See Caution.)
POWER FAILURE
way around the burner cap before adjusting the flame to
the desired height.
In the event of a power failure, only the standard burners
can be lighted manually. It is necessary to light each
standard burner individually.
ThetwoExtraLow® burnersonthefarleftside, cannotbe
used during a power failure. Be sure to turn them OFF
ifapowerfailureoccurs, astheywillnotturnbackonuntil
bothcontrolknobsareturnedOFFandthenturnedback
on again. See “What to do if you Smell Gas”, inside front
cover.
If the cooktop is being used when the power failure
occurs, turn all of the burner control knobs to the OFF
position. Then, the standard burners can be lighted by
holding a match at the ports and turning the control knob
to the HI position. Wait until the flame is burning all the
If you have low gas pressure, contact your gas company.
INTERMITTENT OR CONSTANT IGNITER SPARKING
Intermittent or constant sparking of the sealed gas surface burners can result from a number of preventable
conditions. Eliminate these conditions as indicated in the chart.
SYMPTOM
CAUSE
REMEDY
Intermittent sparking
• Improper fit of burner cap onto
burner base.
•
Align burner cap properly
on burner base.
• Ceramic igniter is wet or dirty.
• Burner ports are clogged.
•
•
Carefully dry or clean igniter.
Clean ports on flame spreader
with a wire, a needle or
straightened paper clip.
Constant Sparking
• Range is not properly grounded.
•
•
Refer to Installation Instructions.
Have a qualified electrician
ground the range properly.
• Electrical power supply is
incorrectly polarized.
Refer to Installation Instructions.
Have a qualified electrician
ground the range properly.
Page 41
SECTION SEVEN: BEFORE CALLING FOR SERVICE
BEFORE CALLING FOR SERVICE
Before calling for Service, check the following to avoid unnecessary
service charges.
SERVICE INFORMATION
For handy reference, copy the infor-
mation below from the data rating
plate. Keep your invoice for War-
ranty validation.
Be sure to check these items first:
Is there a power outage in the area?
Model Number
Is the household fuse blown or the circuit breaker tripped?
Is the range disconnected from the electrical supply?
Serial Number
IF THE BURNERS DO NOT IGNITE
Date of Purchase
•
•
•
•
Are the burner caps properly aligned and seated in the burner base?
Are the burner ports clogged?
Dealer’s Name
Dealer’s Phone Number
Service Center's Name
Service Center’s Phone Number
Is a fuse blown or is the circuit breaker tripped?
Is the manual shut-off valve closed, preventing the flow of gas?
DATA RATING PLATE
The data rating plate shows the model and serial number of your range. It is
located behind the toe kick at the bottom of the range. To access the rating
plate, remove the two toe kick attachment screws, then carefully remove the
toe kick panel.
Also, enter this information on
the Product Registration Form in-
cluded with this product, then mail it
to the indicated address.
For all models, the data rating plate is found on the component tray behind the
toe kick panel.
!
CAUTION:
Before removing the toe kick panel, disconnect the range from the
electrical power supply. Reinstall the toe kick panel before reconnecting
the range to the power supply and operating the range.
PGR Data Rating Plate Location
Page 42
WARRANTY
4. Repairs due to other than normal home use.
5. Service labor during limited warranty period.
FULL ONEYEARWARRANTY
Covers one year from the date of installation or date of
occupancy for a new previously unoccupied dwelling,
Save your dated receipt or other evidence of the
installation/occupancy date.
6. Travelfeesandassociatedchargesincurredwhenthe
product is installed in a location with limited or
restricted access, (i.e., airplane flights, ferry charges,
isolated geographic regions).
Thermador® Will Pay For:
All repair labor and replacement parts found to be
defective due to materials and workmanship.
Warranty applies to appliances used in residential
application: it does not cover their use in commercial
installations.
ServicemustbeprovidedbyaFactoryAuthorizedService
Agency during normal working hours.
This warranty is for products purchased and retained in
the 50 states of the U.S.A., the District of Columbia and
Canada. Should the appliance be sold by the original
purchaser during the warranty period, the new owner
continues to be protected until the expiration date of the
original purchaser’s warranty period.
ForaServiceAgencynearestyou,pleasecall800/735-4328.
THERMADOR® WILL NOT PAY FOR:
1. Servicebyanunauthorizedagency.Damageorrepairs
due to service by an unauthorized agency or use of
unauthorized parts.
The warranty applies even if you should move.
THERMADOR DOES NOT ASSUME ANY
2. Service visits to:
RESPONSIBILITY
FOR
INCIDENTAL
OR
•
•
Teach you how to use the appliance.
CONSEQUENTIAL DAMAGES. Some states do not
allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or
exclusion may not apply to you. This warranty gives you
specific legal rights and you may also have other rights
which may vary from state to state or province to
province.
Correct the installation. You are responsible for
providing electrical wiring and other connecting
facilities.
•
Reset circuit breakers or replace home fuses.
3. Damage caused from accident, alteration, misuse,
abuse, improper installation or installation not in
accordance with local electrical codes or plumbing
codes, or improper storage of the appliance.
Page 43
Notes
Notes
Specifications are for planning purposes only. Refer to installation instructions and consult your countertop supplier
prior to making counter opening. Consult with a heating and ventilating engineer for your specific ventilation
requirements. For the most detailed information, refer to installation instructions accompanying product or write
Thermador indicating model number.
We reserve the right to change specifications or design without notice. Some models are certified for use in Canada.
Thermador is not responsible for products which are transported from the United States for use in Canada. Check
with your local Canadian distributor or dealer.
For the most up to date critical installation dimensions by fax, use your fax handset and call 702/833-3600. Use code
#8030.
A P P R O V E D
®
5551 McFadden Avenue, Huntington Beach, CA 92649 • 800/735-4328
ECO16588 • 5040008373 • © 2002 BSH Home Appliances Corp. • Litho in U.S.A. 10/02
|