CPD-E220/E215E/E220E
[CPD-E220]
SERVICE MANUAL
Equator Model
S. Hemisphere Model
N. Hemisphere Model
Chassis No. SCC-L35B-A
AEP[CMPDo-Ed21e5El]
Chassis No. SCC-L35D-A
AEP[CMPDo-Ed22e0El]
Chassis No. SCC-L35C-A
H1
CHASSIS
SPECIFICATIONS
CRT
0.24 mm aperture grille pitch (center)
17 inches measured diagonally
90-degree deflection
* Recommended horizontal and vertical timing condition
• Horizontal sync width should be more than 1.0 µsec.
• Horizontal blanking width should be more than 3.0 µsec.
• Vertical blanking width should be more than 500 µsec.
FD Trinitron
Viewable image size
Approx. 327 × 243 mm (w/h)
3
5
(14 /4 × 9 /8 inches)
Design and specifications are subject to change without notice.
16.0" viewing image
Resolution
Maximum
Horizontal: 1600 dots (E220/E220E)
1280 dots (E215E)
Vertical: 1200 lines (E220/E220E)
1024 lines (E215E)
Recommended
Horizontal: 1024 dots
Vertical: 768 lines
Standard image area
Deflection frequency*
Approx. 312 × 234 mm (w/h)
3
1
(12 /8 × 9 /4 inches)
Horizontal: 30 to 85 kHz (E220/E220E)
30 to 70 kHz (E215E)
Vertical: 48 to 120 Hz
AC input voltage/current 220 to 240 V, 50/60 Hz, 0.9 A
Power consumption
Dimensions
120 W
Approx. 404 × 413.5 × 419.5 mm (w/h/
3
5
d) (16 × 16 /8 × 16 /8 inches)
Approx. 20 kg (44 lb 1 oz)
DDC1/DDC2B/DDC2Bi
Mass
Plug and Play
TRINITRON® COLOR COMPUTER DISPLAY
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
POWER SAVING FUNCTION
This monitor meets the power-saving guidelines set by VESA,
*
“Sleep” and “deep sleep” are power saving modes defined by the
Environmental Protection Agency.
E
NERGY STAR, and NUTEK. If the monitor is connected to a
** When your computer is in a power saving mode, MONITOR IS IN
POWER SAVE MODE appears on the screen if you press any button
on the monitor. After a few seconds, the monitor enters the power
saving mode again.
computer or video graphics board that is DPMS (Display Power
Management Signaling) compliant, the monitor will automatically
reduce power consumption in three stages as shown below
.
Power mode Power consumption 1 (power)
indicator
normal
operation
≤ 120 W
≤ 15 W
≤ 15 W
green
1 standby
green and orange
alternate
2 suspend
(sleep)*
green and orange
alternate
3 active off** ≤ 3 W
(deep sleep)*
orange
power off
0 W
off
DIAGNOSIS
This monitor is equipped with a self-diagnosis function. If there is
a problem with your monitor or computer, the screen will go blank
and the 1 (power) indicator will either light up green or flash
orange. If the 1 (power) indicator is lit in orange, the computer is
in power saving mode. Try pressing any key on the keyboard.
If all four color bars appear (white, red, green, blue), the monitor
is working properly. Reconnect the video input cable and check
the condition of your computer.
If the color bars do not appear, there is a potential monitor failure.
Inform your authorized Sony dealer of the monitor’s condition.
MENU
RESET
If the 1 (power) indicator is flashing orange
Press the 1 (power) button twice to turn the monitor off
and then on.
1 (power) indicator
If the 1 (power) indicator lights up green, the monitor is working
properly.
If the 1 (power) indicator is green
If the 1 (power) indicator is still flashing, there is a potential
monitor failure. Count the number of seconds between orange
flashes of the 1 (power) indicator and inform your authorized
Sony dealer of the monitor’s condition. Be sure to note the model
name and serial number of your monitor. Also note the make and
model of your computer and video board.
1
2
3
Disconnect the video input cable or turn off the
connected computer.
Press the 1 (power) button twice to turn the monitor
off and then on.
Move the control button , for 2 seconds before the
monitor enters power saving mode.
MENU
– 3 –
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
TIMING SPECIFICATION
PRIMARY MODE
MODE AT PRODUCTION
RESOLUTION
CLOCK
MODE 1
640 X 480
25.175 MHz
MODE 2
800 X 600
56.250 MHz
MODE 3
832 X 624
57.283 MHz
MODE 4
1024 X 768
78.750 MHz
MODE 5
1024 X 768
94.500 MHz
MODE 6
720 X 400
28.322 MHz
MODE 7
640 X 480
36.000 MHz
MODE 8
1280 X 1024
135.000 MHz
— HORIZONTAL —
H-FREQ
31.469 kHz
usec
53.674 kHz
usec
49.725 kHz
usec
60.024 kHz
usec
68.677 kHz
usec
31.469 kHz
usec
43.269 kHz
usec
79.976 kHz
usec
H. TOTAL
H. BLK
31.778
6.356
18.631
4.409
20.111
5.586
16.660
3.657
14.561
3.725
31.777
6.355
23.111
5.333
12.504
3.022
H. FP
0.636
0.569
0.559
0.203
0.508
0.636
1.556
0.119
H. SYNC
H. BP
3.813
1.138
1.117
1.219
1.016
3.813
1.556
1.067
1.907
2.702
3.910
2.235
2.201
1.907
2.222
1.837
H. ACTIV
— VERTICAL —
V. FREQ(HZ)
25.422
14.222
14.524
13.003
10.836
25.422
17.778
9.481
59.940 Hz
85.061 Hz
74.550 Hz
75.030 Hz
84.997 Hz
70.087 Hz
85.008 Hz
75.025 Hz
lines
525
45
lines
631
31
lines
667
43
lines
800
32
lines
808
40
lines
449
49
lines
509
29
lines
1066
42
V. TOTAL
V. BLK
V. FP
10
1
1
1
1
12
1
1
V. SYNC
2
3
3
3
3
2
3
3
V. BP
33
27
39
28
36
35
25
38
V. ACTIV
480
600
624
768
768
400
480
1024
— SYNC —
INT(G)
NO
YES -/-
NO
NO
YES +/+
NO
NO
YES -/-
NO
NO
YES +/+
NO
NO
YES +/+
NO
NO
YES -/+
NO
NO
YES -/-
NO
NO
YES +/+
EXT(H/V)/POLARITY
EXT(CS)/POLARITY
INT/NON INT
NO
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
2000.8.28 VER.
– 4 –
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
TABLE OF CONTENTS
Section
Title
Page
1. GENERAL .................................................................. 1-1
2. DISASSEMBLY
2-1. Cabinet Removal ................................................. 2-1
2-2. A and D Boards Removal ................................... 2-1
2-3. Service Position .................................................... 2-2
2-4. Picture Tube Removal .......................................... 2-2
2-5. H Board Removal ................................................. 2-3
2-6. Harness Location .................................................. 2-4
3. SAFETY RELATED ADJUSTMENT............. 3-1
4. ADJUSTMENTS ...................................................... 4-1
5. DIAGRAMS
5-1. Block Diagrams ................................................... 5-1
5-2. Frame Schematic Diagram .................................. 5-5
5-3. Circuit Boards Location ...................................... 5-6
5-4. Schematic Diagrams and Printed Wiring Boards .. 5-7
(1) Schematic Diagram of H Board ......................... 5-8
(2) Schematic Diagram of A Board ......................... 5-9
(3) Schematic Diagrams of
D (a, b, c, d) Board .................................. 5-13
5-5. Semiconductors .................................................. 5-23
6. EXPLODED VIEWS
6-1. Chassis ................................................................. 6-1
6-2. Picture Tube ........................................................ 6-2
6-3. Packing Materials ................................................ 6-3
7. ELECTRICAL PARTS LIST ............................ 7-1
– 5 –
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
SECTION 2
DISASSEMBLY
2-1. CABINET REMOVAL
Push in the tip of a screwdriver
about 10mm to unlock the claw.
Cabinet
Cabinet
2
Two claws
Bezel assembly
Bezel assembly
3
Cabinet
1
Two screws
(+BVTP 4 x 16)
2-2. A AND D BOARDS REMOVAL
7
A board
CN309
CN307
CN304
GND
CN303
CN2
GND
CN310
CN302
CN301
GND
9
Three screws
(+BVTT 3 x 12)
CN903
CN602
Connector
(2P)
2
Cable stopper
1
Screw
(+BVTT 3 x 8 )
GND
10
Four screws
(+BVTT 3 x 8)
8
I/O cable assembly
12
D board
3
Cable cover
6
Cable holder
5
Cable
4
Screw
(+M 4 x 8)
2-1
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
2-3. SERVICE POSITION
A board
1
3
2
2-4. PICTURE TUBE REMOVAL
2
A board
GND
CN307
GND
9
Tention spring
3
Two screws
8
Degauss coil
(+BVTP 4 x 16)
10
Neck assembly
11
Deflection yoke
CN602
5
Chassis assembly
6
Four screws
(Hexagon)
CN2
CN903
Connector
(2P)
1
Anode cap
(See page 2-3.)
4
Two screws
(+BVTT 4 x 8)
12
Two degauss
coil holder
13
Two degauss
coil holder
Bezel assembly
Cussion
7
Picture tube
2-2
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
2-5. H BOARD REMOVAL
1
Screw
(+BVTP 4 x 16)
2
H bracket
3
Claw
Picture tube
4
H board
5
Menu button
Bezel assembly
Cussion
• REMOVAL OF ANODE-CAP
NOTE: Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon painted on the CRT, after
removing the anode.
• REMOVING PROCEDURES
c
b
a
Anode Button
1 Turn up one side of the rubber cap in 2 Using a thumb pull up the rubber cap 3 When one side of the rubber cap is
the direction indicated by the arrow A.
firmly in the direction indicated by the
arrow B.
separated from the anode button, the
anode-cap can be removed by turning
up the rubber cap and pulling up it in the
direction of the arrow C.
• HOW TO HANDLE AN ANODE-CAP
1 Don’t scratch the surface of anode-caps with sharp shaped
material!
2 Don’t press the rubber hardly not to damage inside of anode-
caps!
A material fitting called as shatter-hook terminal is built in the
rubber.
3 Don’t turn the foot of rubber over hardly!
The shatter-hook terminal will stick out or damage the rubber.
2-3
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
2-6. HARNESS LOCATION
Degauss coil
H board
Picture tube
CN2
CN1
D board
CN903
CN505
CN902
CN602
AC inlet
CN301
CN304
CN310
CN307
A board
2-4
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E215E/E220E
SECTION 3
SAFETY RELATED ADJUSTMENT
When replacing parts shown in the table below, the
following operational checks must be performed as a
safety precaution against X-ray emissions from the unit.
8) After adjusting the High Voltage within specification,
put the VR cover on VR501 as shown below and apply
sufficient amount of RTV around VR501.
Part Replaced ( ] )
b) HV Protector Circuit Check
HV Regulator
Circuit
D board IC502, T501 (FBT)
1) Confirm that the voltage between cathode of D517 an
GND is more than 27.5 VDC.
2) Using an external DC Power supply, apply the voltage
shown below between cathode of D517 on "D" and
GND, and confirm that the HV Hold-Down circuit
works. (Raster disappears) Apply DC Voltage: Less than
35.8 VDC.
HV HOLD
DOWN Circuit
D board D538, R521, T501 (FBT)
D board IC901, R949, T501 (FBT)
Beam Current
Protector Circuit
Allow the unit to warm up for one minute prior to checking
the following conditions:
Check Condition
• Input voltage
• Input signal
• Controls
: 120 ± 2 VAC
a) HV Regulator Check
: (fH = 69 kHz), White Cross Hatch
: CONT (max) & BRT (center)
: 179 ± 3.0 VDC
1) Input white cross hatch signal. (fH = 69 kHz)
2) CONT maximum and BRT center
3) Cut off Screen VR (G2).
• B+ Voltage
4) Input voltage: 120 ± 2 VAC
5) Confirm that the voltage is within the voltage range
c) Beam Protector Check (Software logic)
1) Using an external current source, apply < 1.55mA
between pin qa of FBT (T501) and GND, and confirm
that the raster fades out.
shown below.
Standard voltage: 26.9 KV ± 0.4 KV
6) When replacing components identified by ], make sure
to recheck the High Voltage.
7) Verify the High Voltage as shown above (26.9 KV ± 0.4
KV) is within specification. If not, set H. SIZE data at
minimum (-127) and then adjust VR501 on "D" Board.
Check Condition
• Input voltage
• Input signal
• Controls
: 120 ± 2 VAC
: (fH = 69 kHz), White Cross Hatch
: CONT (max) & BRT (center)
d) B+ Voltage Check
1) Input white cross hatch (fH = 69 kHz) signal.
2) CONT (max) & BRT (center)
3) Input voltage: 120 ± 2 VAC
Note: Use NF power supply or make sure that distortion
factor is 3% or less.
4) Confirm that the voltage is within the voltage range
shown below.
VR501
Standard voltage: 179 ± 3.0 VDC
3-1
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
#2 SECTION 4
ADJUSTMENTS
Connect the communication cable of the computer to the connector located on the monitor. Run the service software and then follow
the instruction.
I2C Interface Card
I2 C Interface Cable
HD15 Connector Adapter
Computer
as a Jig
Video Cable
• Landing Fine Adjustment
1. Put the set inside the Helmholtz coil.
2. Set TLH plate to zero position.
L/D control specification
3. Input the single green signal.
4. Demagnetize the CRT surface with the hand degausser , and
perform auto degaussing.
5. Attach the wobbling coil to the designated part of the CRT
± 5
± 5
± 5
± 7
± 7
± 7
± 5
± 5
± 5
(µm)
neck.
6. Attach the sensor of the landing adjustment unit on the CRT
surface.
Purity magnet position
10. If the corner landing is out of specification, put a disk mag-
net for the landing correction.
11. Perform auto degauss in case disk magnets are used.
12. Remove the sensor and wobbling coil.
7. Adjust the DY position and purity, and the DY tilt.
8. Fasten DY with screw.
Note: Torque 20 +-12kgcm
9. Adjust top and bottom pins by pitching DY up and down
with two wedges.
13. Fix purity magnet on DY with UL black tape.
Also leave the yaw of DY to physical center position with
Another two wedes.
a
“a” and “b” must be equal, and
“c” and “d” must be equal.
c
d
b
<How to drive in wedges>
4-1
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
• Convergence Specification
• Convergence Rough Adjustment
1. Enter the crosshatch signal.
2. Recheck focus and readjust when focus was worse.
3. Adjust roughly H. STAT and V. STAT convergence by 4
pole magnet.
B
MODE All mode
A
0.30 mm
0.35 mm
A
B
4. Adjust roughly HMC and VMC by 6 pole magnet.
• Convergence Adjustment
1. Open H and V Stat by 4 pole magnet.
2. Adjust 6 pole magnet perform HMC and VMC.
3. Adjust 4 pole magnet close both Stat of R.G.B just overlap
each other Horizontal and Vertical.
4. Adjust TLH for side MC by TLH magnet when R or B is in
the opposite direction.
5. Adjust XCV to correct Vertical cross MC.
6. Adjust XBV to correct Vertical bow MC.
7. Adjust TLV to corect Vertical tilt MC.
• White Balance Adjustment Specification
(1) 9300K (2) 6500K
x = 0.283 ± 0.01 x = 0.313 ± 0.01
y = 0.298 ± 0.01 y = 0.329 ± 0.01
(2) 5000K
x = 0.346 ± 0.01
y = 0.359 ± 0.01
8. Adjust YCH to correct top and bottom Horizontal cross MC.
9. Adjust YBH to correct top and bottom Horizontal bow MC.
10. Using permalloys to correct MC of the cornters.
11. Check convergence for whole screen. If necessary, perform
step from 3-9 and correct with permalloys.
• Vertical and Horizontal Position and Size
Specification
A
b
12. Paint lock 4 pole magnet, 6 poles magnets, XBV reactor
XCV corrector and TLH corrector handle.
MODE All mode
B
312 mm
234 mm
A
B
a
Purity Mg.
DY
TLH
6Pole Mg
XCV
YV
YCH
a
b
1.5 mm
1.5 mm
CRT
• Focus adjustment
Adjust the focus volume 1 and 2 for the optimum focus.
4Pole Mg
XBV
R
XCV
YCH
B
R
Focus 1
(V)
B
R
B
Focus 2
(H)
YBH
TLV
TLH
R
R
B
B
B
R
B
R
R
B
FBT
4-2
Download from Www.Somanuals.com. All Manuals Search And Download.
G 2
G 1
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
P C + 5 V ( N C )
7
6
5
4
3
2
1
S C L
S D A
P C D E T
V - I N
G N D
H - I N
7 P
C N 9 0 2
1 . 2 k V
1
1
1 . 2 k V
1 P
C N 3 0 9
1 P
C N 5 0 4
C S 2
C S 3
C S 0
C S 1
4
3
2
1
1
2
3
4
C S 2
C S 3
C S 0
C S 1
4 P
C N 3 0 4
4 P
C N 5 0 2
S C L / I
S D A / I
C L A M P
S C L / 9 I
S D A / I
1
2
3
4
5
6
7
8
9
8
C L A M P
7
G N D
G 1
G N D
G 1
V _ R T N
H _ R T N
G N D
6
5
V _ R T N
4
H _ R T N
3
G N D
S O G
2
1
S O G
A u t o - S i z e ( N C )
1 0
9 P
C N 3 0 2
1 0 P
C N 9 0 1
+ 8 1 V
G N D
+ 8 1 V
G N D
1
2
3
1
2
3
4
5
6
7
+ 1 2 V
+ 1 2 V
+ 6 . 3 V
A B L
+ 6 . 3 V
4
A B L
5
6
7
+ 5 V
G N D
+ 5 V
G N D
7 P
C N 6 0 3
7 P
C N 3 0 3
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
4
3
2
1
5
6
7
8
B
V O U T 1
G N D 1
R
V O U T 2
G N D 2
G
V O U T 3
V C C
G N D
G
R
V I N 3
V I N 2
V B B
V I N 1
B
3 6
3 5
3 4
3 3
3 2
3 1
3 0
2 9
2 8
2 7
2 6
2 5
2 4
2 3
2 2
2 1
2 0
1 9
1
2
3
4
5
6
7
8
9
1 0
1 1
1 2
1 3
1 4
1 5
1 6
1 7
1 8
2 0
1 9
1 8
1 7
1 6
1 5
1 4
1 3
1 2
1 1
1
2
3
4
5
6
7
8
9
1 0
4
3
2
1
5
6
7
8
Download from Www.Somanuals.com. All Manuals Search And Download.
V S Y N C / O
H S Y N C / O
1 5 . 2
1 6
1 5
1 4
1 3
1 2
1 1
1 0
9
8
7
6
5
4
3
2
1
1 7
1 8
1 9
2 0
2 1
2 2
2 3
2 4
2 5
2 6
2 7
2 8
2 9
3 0
3 1
3 2
1
2
3
4
T I L T
8
7
6
5
T E S T
B L K
C S 4
G R E E N / L E D
O R A N G E / L E D
0 . 7
4 2
4 1
4 0
3 9
3 8
3 7
3 6
3 5
3 4
3 3
3 2
3 1
3 0
2 9
2 8
2 7
2 6
2 5
2 4
2 3
2 2
1
2
3
4
5
6
7
8
9
1 0
1 1
1 2
1 3
1 4
1 5
1 6
1 7
1 8
1 9
2 0
2 1
4 . 9
T E S T
T I L T
A B L / P W M
B R I
H - C E N T E R / O
0 . 5
Download from Www.Somanuals.com. All Manuals Search And Download.
H - C E N T E R / O
A B L / P W M
B R I
B L K
H - D R I V E R
Download from Www.Somanuals.com. All Manuals Search And Download.
8
7
6
5
1
2
3
4
Download from Www.Somanuals.com. All Manuals Search And Download.
1 . 5 k
R 6 6 1
8
7
6
5
1
2
3
4
Download from Www.Somanuals.com. All Manuals Search And Download.
5-5. SEMICONDUCTORS
BH3863F
M52743BSP
RN1203
2SC4632LS-CB7
MAA3371X
BH3863F-E2
n
LETTER SIDE
n
1
TOP VIEW
36 pin DIP
ST72774
1
B
TOP VIEW
24 pin SOP
n
C
E
CATHODE
ANODE
E
C
B
1
TOP VIEW
LA78040
MTZJ-15A
MTZJ-5.1A
MTZJ-5.1B
RD15ES-B1
RD5.1ESB2
1SS119-25
BYV26C
UF05G
42 pin DIP
MCR100
MCR100-8RL
TDA4841
CATHODE
n
1
1SS119-25TD
TOP VIEW
1
32 pin DIP
7
CATHODE
GATE
CATHODE
ANODE
ANODE
BF420
LM2415T
2N3904
D2L40-TA
ER106
HSS82
HZ12
ANODE
HZ18-2
HZ5C1
HZ5C2
SEL4225R-D
E
C
B
E
B
C
MTZJ-T-73-15A
PS104R
DTC124ESA
2SC3400
RD27EB4
RGP02-18
SB140-6339
UF4007G23
UF5402G
UF5404G
UF5406
LM358N
2SA1221-L
M24C16BN6
UC3842A
C3843A
ANODE
CATHODE
24LC21/P
n
TLP621D4-Y-LF2
E
C
B
10E2
IN4002
E
C
B
1
4
3
TOP VIEW
IN4004
IN4148
8 pin DIP
2SA733-Q
2SA733TP-QP
2SA966-Y
2SB647A-C
2SC2655
2SC2655-Y
2SC945-P
IRFU110
IRFU110A
MCT7812CT
TA7805S
CATHODE
1
2
4
3
1
2
ANODE
G
D
S
D4SB60L
D4SB60L-F
IRF640
M35047
-
~
E
C
B
n
~
-
1
TOP VIEW
2SB649-C
~
~
2SB649A-B
2SC2688-LK
2SD669AVC
20 pin DIP
G
D
S
M51951BSL
EGP10D
LETTER SIDE
CATHODE
E
C
B
ANODE
5-23
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
SECTION 6
EXPLODED VIEWS
NOTE:
• Items with no part number and no • Items marked " * " are not stocked since
The components identified by mark
are critical for safety.
Replace only with part number specified.
¡
description are not stocked because they
are seldom required for routine service.
• The construction parts of an assembled
part are indicated with a collation number
in the remark column.
they are seldom required for routine
service. Some delay should be anticipated
when ordering these items.
Les composants identifiés par une
marque
¡
sont critiques pour la
6-1. CHASSIS
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
7-685-648-79
7-685-872-09
7-685-663-71
7-685-881-09
+BVTP 3X12
+BVTT 3X8
+BVTP 4X16
+BVTT 4X8
8418113010
8026114012
4
5
10
3
1
7
9
6
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO. DESCRIPTION
REMARK
1
* A-1272-229-A A BOARD, COMPLETE [E220, E220E]
S07C2U0242
* A-1272-279-A A BOARD, COMPLETE [E215E]
SOE2150244
* 4-060-151-01 STOPPER, CABLE
4-072-384-01 CABINET [E220E, E215E]
4-072-384-11 CABINET [E220]
6
6
* A-1348-021-A D BOARD, COMPLETE [E220E]
C07C2U0144
* A-1348-026-A D BOARD, COMPLETE [E220 for NH]
#1
#1 1
SM7C1J5144
* A-1348-036-A D BOARD, COMPLETE [E220 for EQ, SH]
* A-1348-037-A D BOARD, COMPLETE [E215E]
SOE2155144
#1
#1
6
6
3
4
#1 4
7
0 1-453-358-11 TRANSFORMER, FLYBACK 7050307C2U
5
* 4-079-241-01 LABEL, INFORMATION [E220E]
9
10
1-757-540-11 I/O CABLE ASSY
4-073-622-01 SPONGE
C7107C2U11
9011097C2V
* 4-079-241-11 LABEL, INFORMATION [E220]
9011097C1N
* 4-079-241-21 LABEL, INFORMATION [E215E]
#1
5
#1 5
6-1
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
6-2. PICTURE TUBE
7-685-663-71
7-685-881-09
+BVTP 4X16
+BVTT 4X8
8026114012
68
64
62
61
66
65
60
64
69
59
63
58
70
57
71
72
61
55
51
56
67
54
The components identified by mark
are critical for safety.
¡
Replace only with part number specified.
53
52
Les composants identifiés par une
marque
¡
sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO. DESCRIPTION
REMARK
58 0 8-451-435-12 DEFLECTION YOKE (Y17TKJ-M)
59 0 1-452-923-41 NECK ASSY
51
51
X-4038-291-1 BEZEL ASSY [E220E]
X-4038-292-1 BEZEL ASSY [E220]
X-4038-570-1 BEZEL ASSY [E215E]
52-54
GP7C2V7001
52-54
1Q010T7C1N
52-54
#1
60
61
62
4-060-166-01 SPACER, DEFRECTION YOKE
4-045-123-21 HOLDER, DEGAUS COIL
4-060-155-01 HOLDER, HV CABLE
#1 51
IR011TE215
63
64
4-060-603-01 SPRING, TENSION
4-072-413-01 BAND, DG COIL
52
53
4-072-387-01 BUTTON, POWER
3-653-339-01 SPRING, COMPRESSION
65 0 1-419-255-11 DEGAUSS COIL
54
55
56
4-042-353-11 EMBLEM (NO.7), SONY
* A-1304-219-A H BOARD, COMPLETE
4-384-096-01 SCREW (4X16), TAPPING, +P
8433144020
66
67
4-365-808-01 SCREW (5), TAPPING
X-4037-104-1 STAND ASSY
S07C2U0342
56
68
69
70
71
72
4-072-411-01 HOLDER, DGC
4-308-870-00 CLIP, LEAD WIRE
1-452-032-00 MAGNET, DISK; 10mmφ
1-452-094-00 MAGNET, ROTATABLE DISK; 15mmφ
4-051-736-21 PIECE A (90), CONV. CORRECT
#1
57 0 8-738-549-05 PICTURE TUBE (17TKB)
(FILM INTENSITY SOUTH) [E220 for EQ, SH]
57 0 8-738-558-05 PICTURE TUBE (17TKB)
(FILM INTENSITY UP) [E220 for NH, E220E, E215E]
6-2
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
6-3. PACKING MATERIALS
101 102
103
104
105
The components identified by mark
are critical for safety.
¡
Replace only with part number specified.
Les composants identifiés par une
marque
¡
sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO. DESCRIPTION
REMARK
#1 101 0 1-776-027-11 CORD SET, POWER [E220E, E215E]
104 * 4-072-418-01 CUSION (LOWER)
105 * 4-079-271-01 INDIVIDUAL CARTON [E220E]
102
4-079-242-11 MANUAL, INSTRUCTION [E220E]
9012097C2V
4-079-242-21 MANUAL, INSTRUCTION [E220]
9012097C1N
4-080-479-11 MANUAL, INSTRUCTION [E215E]
901209E215
9001097C2V
#1
#1
#1
102
105 * 4-079-570-01 INDIVIDUAL CARTON [E220]
9001097C1N
#1 102
105 * 4-080-496-01 INDIVIDUAL CARTON [E215E]
900109E215
103 * 4-072-417-01 CUSHION (UPPER)
6-3
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
SECTION 7
ELECTRICALPARTS LIST
(a)
NOTE:
• All variable and adjustable resistors have RESISTORS
characteristic curve B, unless otherwise • All resistors are in ohms
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
noted.
• F : nonflammable
Ne les remplacer que par une pièce
portant le numéro spécifié.
• Items marked " * " are not stocked since
they are seldom required for routine
service. Some delay should be anticipated
when ordering these items.
Les composants identifiés par une
marque
¡
sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
When indicating parts by reference
number, please include the board name.
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
A BOARD, COMPLETE
***************************
#4 C103 1-163-189-11 CERAMIC
#4 C104 1-163-189-11 CERAMIC
0.1µF
0.1µF
50V 7146104456
50V 7146104456
100V 5075104501
C106 1-135-383-11 METALIZED FILM 0.1µF
4-382-854-11 SCREW (M3X10), P, SW (+) (IC002)
<CAPACITOR>
#4 C107 1-136-165-11 METALIZED FILM 0.1µF
50V 5134104452
50V 7183330556
50V 5156100T50
50V 7146104456
50V 7146104456
#4 C201 1-135-791-11
33pF
10µF
0.1µF
0.1µF
C202 1-126-964-11 ELECT
#4 C203 1-163-189-11 CERAMIC
C001 1-126-964-11 ELECT
C002 1-126-934-11 ELECT
#4 C004 1-115-340-11 CERAMIC
C005 1-135-397-11 ELECT
10µF
50V 5156100T50
16V 5156221S16 #4 C204 1-163-189-11 CERAMIC
16V 7144224106
16V 515X470T16
50V 7146104456
220µF
0.22µF
47µF
C206 1-135-383-11 METALIZED FILM 0.1µF
#4 C207 1-136-165-11 METALIZED FILM 0.1µF
100V 5075104501
50V 5134104452
50V 7183330556
50V 5156100T50
50V 7146104456
#4 C006 1-163-189-11 CERAMIC
0.1µF
#4 C301 1-135-791-11
C302 1-126-964-11 ELECT
#4 C303 1-163-189-11 CERAMIC
33pF
10µF
0.1µF
#4 C008 1-136-165-11 METALIZED FILM 0.1µF
50V 5134104452
16V 5156470T16
50V 7146104456
100V 5156100T01
100V 5116104111
#4 C009 1-126-947-11 ELECT
#4 C010 1-163-189-11 CERAMIC
C011 1-128-582-11 ELECT
47µF
0.1µF
10µF
0.1µF
#4 C304 1-163-189-11 CERAMIC
0.1µF
50V 7146104456
100V 5075104501
50V 5134104452
#4 C012 1-130-777-11 PETP FILM
C306 1-135-383-11 METALIZED FILM 0.1µF
#4 C307 1-136-165-11 METALIZED FILM 0.1µF
#4 C013 1-163-189-11 CERAMIC
#4 C014 1-137-877-11 CERAMIC
C015 1-107-823-11 CERAMIC
C016 1-163-009-11 CERAMIC
#4 C017 1-130-777-11 PETP FILM
0.1µF
50V 7146104456
2KV 51011021C3
16V 7144474106
50V 7144102256
100V 5116104111
1000pF
0.47µF
0.001µF
0.1µF
<CONNECTOR>
CN301 1-564-510-81 PLUG, CONNECTOR 6P
CN302 1-564-510-81 PLUG, CONNECTOR 9P
CN303* 1-564-510-81 PLUG, CONNECTOR 7P
CN304* 1-564-507-11 PLUG, CONNECTOR 4P
4490600330
4490900330
4490700330
4490400330
#4 C019 1-130-777-11 PETP FILM
C022 1-163-131-00 CERAMIC
C023 1-135-393-11 ELECT
#4 C025 1-163-189-11 CERAMIC
#4 C026 1-164-161-91 CERAMIC
0.1µF
100V 5116104111
50V 7183391556
10V 5156101T10
50V 7146104456
50V 7144222156
390pF
100µF
0.1µF
CN307 1-695-915-11 TAB (CONTACT)
1P
2200pF
CN309 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN) 3340236016
CN310 1-695-915-11 TAB (CONTACT)
1P
1P
1P
C028 1-163-263-11 CERAMIC
C029 1-102-074-21 CERAMIC
C030 1-135-393-11 ELECT
330pF
0.001µF
100µF
1µF
50V 7183331556
50V 5101102152
10V 5156101T10
50V 5156109T50
50V 7144472156
CN311
CN312
Pending
Pending
C032 1-135-398-11 ELECT
#4 C033 1-163-017-11 CERAMIC
4700pF
<DIODE>
#4 C034 1-163-189-11 CERAMIC
C035 1-135-393-11 ELECT
#4 C037 1-115-340-11 CERAMIC
#4 C038 1-126-947-11 ELECT
#4 C039 1-104-665-91 ELECT
0.1µF
100µF
0.22µF
47µF
50V 7146104456
10V 5156101T10
16V 7144224106
16V 5156470T16
16V 5156101T16
D001 8-719-911-19 DIODE 1SS119-25
D002 8-719-070-90 DIODE 1N4148
D003 8-719-109-85 ZENER DIODE RD5.1ESB2
D004 8-719-911-19 DIODE 1SS119-25
D017 8-719-074-13 DIODE BYV26C
4120511900
412014148T
41205005C2
4120511900
413010426C
100µF
#4 C040 1-137-150-11 PETP FILM
0.01µF
33pF
4.7µF
0.1µF
0.01µF
100V 5116103511
50V 5121330552
35V 5162479T35
100V 5116104111
1.5KV5104103463
D101 8-719-070-90 DIODE 1N4148
D102 8-719-070-90 DIODE 1N4148
D103 8-719-970-82 DIODE HSS82
D104 8-719-970-82 DIODE HSS82
D105 8-719-970-82 DIODE HSS82
412014148T
412014148T
4130190820
4130190820
4130190820
C042
Pending
CERAMIC
C043 1-135-404-11 ELECT
#4 C044 1-130-777-11 PETP FILM
C045
Pending
CERAMIC
#4 C101 1-135-791-11
C102 1-126-964-11 ELECT
33pF
10µF
50V 7183330556
50V 5156100T50
D201 8-719-911-19 DIODE 1SS119-25
D202 8-719-911-19 DIODE 1SS119-25
4120511900
4120511900
7-1
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
Les composants identifiés par une
marque sont critiques pour la sécurité.
The components identified by mark
are critical for safety.
¡
¡
Ne les remplacer que par une pièce
portant le numéro spécifié.
Replace only with part number specified.
(a)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
D203 8-719-970-82 DIODE HSS82
D204 8-719-970-82 DIODE HSS82
D205 8-719-970-82 DIODE HSS82
4130190820
4130190820
4130190820
<RESISTOR>
R001 1-247-807-31 CARBON (SMALL) 100
R002 1-247-807-31 CARBON (SMALL) 100
R004 1-216-025-11 RES-CHIP
#4 R005 1-215-049-91 RES-CHIP
R006 1-216-073-91 RES-CHIP
1/4W 4050510155
1/4W 4050510155
1/10W 4010110152
1/10W 4010110252
1/10W 4010110352
D301 8-719-911-19 DIODE 1SS119-25
D302 8-719-911-19 DIODE 1SS119-25
D303 8-719-970-82 DIODE HSS82
D304 8-719-970-82 DIODE HSS82
D305 8-719-970-82 DIODE HSS82
4120511900
4120511900
4130190820
4130190820
4130190820
100
1K
10K
R007 1-216-025-11 RES-CHIP
#4 R008 1-216-660-11 RES, CHIP
#4 R009 1-215-049-91 RES-CHIP
R010 1-216-025-11 RES-CHIP
#4 R011 1-216-041-11 RES-CHIP
100
2.4K
1K
100
470
1/10W 4010110152
1/10W 4010124252
1/10W 4010110252
1/10W 4010110152
1/10W 4010147152
<FERRITE BEAD>
#4 FB001 1-414-793-21 BEAD, FERRITE 0.45µH
7099458250
FB002 1-469-611-11 INDUCTOR, FERRITE BEAD 2µH 4322209005
#4 R012 1-215-049-91 RES-CHIP
R013 1-216-065-11 RES-CHIP
R014 1-216-065-11 RES-CHIP
R015 1-247-816-11 CARBON (SMALL) 240
#4 R016 1-216-041-11 RES-CHIP 470
1K
1/10W 4010110252
1/10W 4010147252
1/10W 4010147252
1/4W 4050524155
1/10W 4010147152
#4 FB003 1-535-303-31 JUMP WIRE
#4 FB004 1-535-303-31 JUMP WIRE
#4 FB005 1-535-303-31 JUMP WIRE
5406100000
5406100000
5406100000
4.7K
4.7K
FB006 1-469-402-11 BEAD, FERRITE 3µH
#4 FB101 1-535-303-31 JUMP WIRE
#4 FB201 1-535-303-31 JUMP WIRE
#4 FB301 1-535-303-31 JUMP WIRE
4322309006
5406100000
5406100000
5406100000
R017 1-247-807-31 CARBON (SMALL) 100
1/4W 4050510155
1/10W 4010110152
1/10W 4010110152
1/4W 4257044421
1/10W 419A132422
R018 1-216-025-11 RES-CHIP
R019 1-216-025-11 RES-CHIP
100
100
R020
Pending
METAL FILM 4.42K
#4 R021 1-244-297-11 RES-CHIP
32.4K
<IC>
#4 R022 1-216-660-11 RES, CHIP
#4 R023 1-216-121-11 RES-CHIP
#4 R024 1-247-883-11 CARBON (SMALL) 150K
#4 R025 1-249-421-11 CARBON (SMALL) 2.2K
2.4K
1M
1/10W 4010124252
1/10W 4010110552
1/4W 4050515455
1/4W 4050522255
1/10W 4010147152
IC001 8-759-582-06 IC M52743BSP
IC002 8-759-569-64 IC BH3863F
4159527432
IC003
Pending
IC M35047-XXX
4159350470
4159358000
IC004 8-759-991-16 IC LM358N
#4 R026 1-216-041-11 RES-CHIP
470
#4 R027 1-215-049-91 RES-CHIP
#4 R028 1-215-049-91 RES-CHIP
R029 1-216-053-11 RES-CHIP
R030 1-216-073-91 RES-CHIP
1K
1K
1/10W 4010110252
1/10W 4010110252
1/10W 4010115252
1/10W 4010110352
1/4W 4160422655
<SOCKET, PICTURE TUBE>
1.5K
10K
J001 0 1-251-598-11 SOCKET, PICTURE TUBE
4570307Y11
#4 R031 1-244-274-11 METAL FILM 22M
<COIL>
#4 R032 1-215-049-91 RES-CHIP
#4 R033 1-216-105-11 RES-CHIP
1K
220K
10K
1/10W 4010110252
1/10W 4010122452
1/2W 4050210355
1/2W 4160222555
1/10W 4010110152
L001 1-469-400-11 INDUCTOR, MICRO 100µH
#4 L002 1-535-303-31 JUMP WIRE
L101 1-469-398-11 INDUCTOR, MICRO 0.1µH
#4 L102 1-419-618-11 INDUCTOR, MICRO 0.47µH
L201 1-469-398-11 INDUCTOR, MICRO 0.1µH
432B101006
5406100000
R034
Pending
#4 R035 1-244-273-11 METAL FILM 2.2M
432B108006 #4 R036 1-216-025-11 RES-CHIP
432B478006
432B108006 #4 R037 1-216-025-11 RES-CHIP
#4 R039 1-216-660-11 RES, CHIP
100
100
2.4K
100
3K
1/10W 4010110152
1/10W 4010124252
1/2W 4050210155
1/10W 4010130252
1/10W 4010110352
#4 L202 1-419-618-11 INDUCTOR, MICRO 0.47µH
L301 1-469-398-11 INDUCTOR, MICRO 0.1µH
#4 L302 1-419-618-11 INDUCTOR, MICRO 0.47µH
432B478006
R042
Pending
432B108006 #4 R046 1-216-662-11 RES-CHIP
432B478006
R049 1-216-073-91 RES-CHIP
10K
R050 1-216-065-11 RES-CHIP
R051 1-216-053-11 RES-CHIP
#4 R054 1-216-121-11 RES-CHIP
R101 1-216-022-11 RES-CHIP
#4 R103 1-215-049-91 RES-CHIP
4.7K
1.5K
1M
75
1K
1/10W 4010147252
1/10W 4010115252
1/10W 4010110552
1/10W 4010175002
1/10W 4010110252
<TRANSISTOR>
Q001 8-729-139-04 TRANSISTOR 2N3904
Q002 8-729-139-04 TRANSISTOR 2N3904
Q003 8-729-139-04 TRANSISTOR 2N3904
Q004 8-729-823-81 TRANSISTOR 2SC4632LS-CB7
#4 Q005 8-729-029-86 TRANSISTOR DTC124ESA
4111139040
4111139040
4111139040
4100246340
4116612030
#4 R104 1-249-393-11 CARBON (SMALL) 12
#4 R107 1-249-425-11 CARBON (SMALL) 4.7K
#4 R108 1-247-862-11 CARBON (SMALL) 20K
1/4W 4050512055
1/4W 4050547255
1/4W 4050520355
1/10W 4010147152
1/4W 4050510555
Q008 8-729-139-04 TRANSISTOR 2N3904
#4 Q101 8-729-048-20 TRANSISTOR BF420
#4 Q201 8-729-048-20 TRANSISTOR BF420
#4 Q301 8-729-048-20 TRANSISTOR BF420
4111139040
4114804200
4114804200
4114804200
#4 R109 1-216-041-11 RES-CHIP
470
R111 1-247-903-81 CARBON (SMALL) 1M
R112
R113 1-216-013-11 RES-CHIP
R115 Pending
Pending
300
33
1/2W 4050230155
1/10W 4010133052
1/2W 4050262055
1/10W 4010175002
1/10W 4010110252
62
75
1K
R201 1-216-022-11 RES-CHIP
#4 R203 1-215-049-91 RES-CHIP
7-2
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
(a)(d)
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
#4 C507 1-136-287-11 PETP FILM
C508 1-163-251-11 CERAMIC
0.0047µF
100pF
100V 5116472511
50V 7183101556
#4 R204 1-249-393-11 CARBON (SMALL) 12
#4 R207 1-249-425-11 CARBON (SMALL) 4.7K
#4 R208 1-247-862-11 CARBON (SMALL) 20K
#4 R209 1-249-413-11 CARBON (SMALL) 470
R211 1-247-903-81 CARBON (SMALL) 1M
1/4W 4050512055
1/4W 4050547255
1/4W 4050520355
1/4W 4050547155
1/4W 4050510555
C509
Pending
0.0033µF
1000µF
100pF
100pF
0.1µF
50V 5144332550
16V 5153102S25
50V 7183101556
50V 7183101556
50V 7146104456
#4 C510 1-107-914-11 ELECT
C512 1-163-251-11 CERAMIC
C513 1-163-251-11 CERAMIC
#4 C514 1-163-189-11 CERAMIC
R212
R213 1-216-013-11 RES-CHIP
R215 Pending
Pending
300
33
1/2W 4050230155
1/10W 4010133052
1/2W 4050210155
1/10W 4010175002
5406100000
100
75
C515 1-136-195-11 METALIZED FILM 0.022µF
C517 1-128-981-11 CERAMIC
#4 C518 1-137-876-11 CERAMIC
250V 5074223102
3KV 510H221193
1KV 5101152132
2KV 51904323A3
250V 5199244583
[E220/E220E]
R301 1-216-022-11 RES-CHIP
220pF
#4 R302 1-535-303-31 JUMP WIRE
1500pF
4300pF
0.24µF
C521
#4 C522
Pending
Pending
#4 R303 1-215-049-91 RES-CHIP
1K
1/10W 4010110252
1/4W 4050512055
1/4W 4050547255
1/4W 4050520355
1/4W 4050547155
FILM
FILM
#4 R304 1-249-393-11 CARBON (SMALL) 12
#4 R307 1-249-425-11 CARBON (SMALL) 4.7K
#4 R308 1-247-862-11 CARBON (SMALL) 20K
#4 R309 1-249-413-11 CARBON (SMALL) 470
#4 C522
Pending
0.33µF
250V 5199334583
[E215E]
C523 1-126-964-11 ELECT
#4 C524 1-117-660-21 PETP FILM
10µF
0.12µF
50V 5156100T50
250V 5198124583
[E220/E220E]
R311 1-247-903-81 CARBON (SMALL) 1M
1/4W 4050510555
1/2W 4050230155
1/10W 4010133052
1/2W 4050262055
R312
Pending
300
33
R313 1-216-013-11 RES-CHIP
#4 C524
Pending
PETP FILM
0.18µF
250V 5198184583
[E215E]
R315
Pending
62
#4 C525 1-117-659-21 PETP FILM
0.1µF
250V 5198104583
[E220/E220E]
<SPARK GAP>
#4 C525
#4 C526
Pending
Pending
PETP FILM
PETP FILM
0,24µF
0.33µF
4700pF
250V 5198244583
[E215E]
250V 5190334583
[E220/E220E]
50V 7144472156
[E220/E220E]
#4 SG001 1-135-791-11 SPARK GAP
7183330556
4700000003
4700000003
4700000003
SG101
SG201
SG301
Pending
Pending
Pending
SPARK GAP
SPARK GAP
SPARK GAP
#4 C528 1-163-017-11 CERAMIC
#4 C529 1-136-165-11 METALIZED FILM 0.1µF
50V 5134104452
****************************************************************************************** #4 C531 1-137-150-11 PETP FILM
0.01µF
100V 5116103511
100V 5074473101
50V 5156229T50
50V 7146104456
16V 5156101T16
#4 C532 1-137-962-11 METALIZED FILM 0.047µF
C533 1-126-961-11 ELECT
#4 C534 1-163-189-11 CERAMIC
#4 C535 1-104-665-91 ELECT
2.2µF
0.1µF
100µF
D BOARD, COMPLETE
***************************
1-500-644-11 INDUCTOR (D521, D623, D627)
1-506-108-41 PIN, CONNECTOR (TERMINAL PIN)
C536
Pending
1500pF
3900pF
68µF
0.1µF
4.7µF
1.6KV5192152573
1KV 5101392132
100V 5156680T01
50V 7146104456
50V 5156479T50
#4 C537 1-137-878-11 CERAMIC
C539 1-128-563-11 ELECT
(CN503, R530, R603, R614, R653)
1-533-223-11 HOLDER, FUSE (F601)
1-785-907-11 PLUG, CONNECTOR 1P
46905Y1101 #4 C540 1-163-189-11 CERAMIC
C541 1-135-395-11 ELECT
(R576, R583, R605, R653) 3340101525
4-382-854-01 SCREW (M3X8), P, SW (+)
C542 1-137-395-91 PETP FILM
0.022µF
1000pF
10µF
100V 5116223111
100V 5101102112
50V 5156100T50
50V 5101101152
50V 5077104505
(C409, IC605, IC607, Q503, Q506, Q508, #4 C543 1-137-873-11 CERAMIC
Q517, Q518, Q519, Q534, Q544, Q602) C545 1-126-964-11 ELECT
C546
C547
Pending
Pending
CERAMIC
100pF
<CAPACITOR>
METALIZED FILM 0.1µF
C401 1-137-395-91 METALIZED FILM 0.1µF
250V 5074104102
25V 5156471S25
100V 5116223111
25V 5153102S25 #4 C553 1-163-133-21
50V 5110224550
C548
C549
Pending
Pending
ELECT
ELECT
330µF
330µF
25V 5156331T25
25V 5156331T25
250V 5074103102
50V 7183471556
50V 5128471552
C402 1-128-528-51 ELECT
C403 1-137-395-91 PETP FILM
#4 C404 1-107-914-11 ELECT
#4 C405 1-130-499-11 PETP FILM
470µF
0.022µF
1000µF
0.22µF
C550 1-135-352-11 METALIZED FILM 0.01µF
470pF
470pF
C554
Pending
CERAMIC
#4 C406 1-136-298-11 PETP FILM
C408 1-126-951-11 ELECT
0.0033µF
470µF
100V 5116332111
35V 5156471S35 #4 C556 1-163-189-11 CERAMIC
100V 5116102111
50V 5077104505
50V 5077104505
#4 C555 1-136-165-11 METALIZED FILM 0.1µF
50V 5134104452
50V 7146104456
100V 5116333111
100V 5116222111
50V 7146104456
0.1µF
#4 C409 1-104-987-11 PE TEREPHTHALATE 0.001µF
#4 C558 1-137-352-11 PETP FILM
C559 1-136-684-51 PETP FILM
#4 C560 1-163-189-11 CERAMIC
0.0033µF
0.0022µF
0.1µF
C502
Pending
METALIZED FILM 0.1µF
C503
Pending
METALIZED FILM 0.1µF
#4 C504 1-137-150-11 PETP FILM
C505 Pending METALIZED FILM 0.1µF
#4 C506 1-137-150-11 PETP FILM 0.01µF
0.01µF
100V 5116472511
50V 5077104505
100V 5116103511
#4 C561 1-163-007-11
#4 C562 1-163-189-11 CERAMIC
#4 C563 1-104-661-91 ELECT
680pF
0.1µF
330µF
50V 7144681156
50V 7146104456
16V 5156331T16
7-3
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
Les composants identifiés par une
marque sont critiques pour la sécurité.
The components identified by mark
are critical for safety.
¡
¡
Ne les remplacer que par une pièce
portant le numéro spécifié.
Replace only with part number specified.
(d)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
#4 C564 1-126-947-11 ELECT
#4 C565 1-107-651-11 ELECT
47µF
4.7µF
25V 5156470T25
250V 5156479S03
C625 1-125-700-11 ELECT
C626 1-107-955-51 ELECT
220µF
100µF
100V 5156221S01
250V 515X101S03
C566
C567
#4 C568
Pending
Pending
Pending
1µF
0.01µF
1000pF
250V 5190105583
2KV 51041034C3
50V 7144102156
[E220/E220E]
50V 5156100T50
50V 7146104456
16V 5156470T16
#4 C628 1-107-914-11 ELECT
C630 1-128-528-51 ELECT
#4 C631 1-163-189-11 CERAMIC
C632 1-128-528-51 ELECT
#4 C633 1-107-914-11 ELECT
1000µF
470µF
0.1µF
470µF
1000µF
25V 5153102S25
25V 5156471S25
50V 7146104456
25V 5156471S25
25V 5153102S25
CERAMIC
CERAMIC
C570 1-126-964-11 ELECT
#4 C571 1-163-189-11 CERAMIC
#4 C572 1-126-947-11 ELECT
10µF
0.1µF
47µF
C634 1-107-884-81 ELECT
#4 C635 1-126-926-11 ELECT
C638 1-164-143-11 CERAMIC
1000µF
1000µF
1000pF
0.1µF
16V 5156102S16
10V 5156102S10
1KV 5101102132
250V 5067104425
50V 7146104456
#4 C573 1-135-404-11 ELECT
#4 C574 1-126-970-11 ELECT
#4 C575 1-163-031-91
#4 C576 1-163-189-11 CERAMIC
#4 C577 1-107-662-11 ELECT
4.7µF
330µF
0.01µF
0.1µF
22µF
35V 5162479T35
50V 5156331S50 #4 C6400 1-115-165-11 CAP, FILM
50V 7146103456
50V 7146104456
250V 5156220S03
#4 C643 1-163-189-11 CERAMIC
0.1µF
C645 1-126-935-91 ELECT
#4 C646 1-107-914-11 ELECT
C647 1-135-401-11 ELECT
#4 C6480 1-137-930-11 CERAMIC
#4 C6490 1-137-930-11 CERAMIC
470µF
1000µF
100µF
4700pF
4700pF
16V 5156471T16
25V 5153102S25
35V 5156101T35
400V 5061472440
400V 5061472440
#4 C580 1-130-499-11 PETP FILM
#4 C581 1-130-499-11 PETP FILM
#4 C582 1-128-564-91 ELECT
0.22µF
0.22µF
220µF
4.7µF
50V 5110224550
50V 5110224550
100V 5156221T01
100V 515X479T01
50V 7144471156
[E220/E220E]
C583
Pending
Pending
ELECT
#4 C584
CERAMIC
470pF
#4 C650
#4 C650
Pending
Pending
METALIZED FILM 0.022µF
630V 5074223106
[E220 [NH]/E220E]
630V 5074103106
[E215E]
25V 5153102S25
250V 5077224102
25V 5156220T25
160V 5156100T02
METALIZED FILM 0.01µF
#4 C584
C585
Pending
Pending
CERAMIC
CERAMIC
680pF
50V 7144681156
[E215E] #4 C651 1-107-914-11 ELECT
1000µF
1000pF
1µF
0.1µF
0.1µF
500V 5101102142
50V 5156109T50
50V 7146104456
50V 7146104456
#4 C652 1-137-972-11 METALIZED FILM 0.22µF
#4 C654 1-128-551-11 ELECT
#4 C655 1-107-636-11 ELECT
C589 1-135-398-11 ELECT
#4 C590 1-163-189-11 CERAMIC
#4 C591 1-163-189-11 CERAMIC
22µF
10µF
C902 1-126-961-11 ELECT
C903 1-126-961-11 ELECT
C904 1-126-961-11 ELECT
C905 1-126-961-11 ELECT
C906 1-126-961-11 ELECT
2.2µF
2.2µF
2.2µF
2.2µF
2.2µF
50V 5156229T50
50V 5156229T50
50V 5156229T50
50V 5156229T50
50V 5156229T50
#4 C592 1-135-404-11 ELECT
4.7µF
0.22µF
470pF
35V 5162479T35
50V 5113224150
50V 7144471156
[E220/E220E]
C593
Pending
Pending
PETP FILM
CERAMIC
#4 C594
#4 C594
Pending
CERAMIC
680pF
50V 7144681156
[E215E]
C907 1-126-964-11 ELECT
#4 C908 1-163-189-11 CERAMIC
#4 C909 1-163-133-21
#4 C910 1-163-189-11 CERAMIC
#4 C914 1-163-251-11 CERAMIC
10µF
50V 5156100T50
50V 7146104456
50V 7183471556
50V 7146104456
50V 7183101556
#4 C595 1-137-871-11 METALIZED FILM 0.1µF
400V 5074104104
0.1µF
470pF
0.1µF
100pF
#4 C598 1-163-189-11 CERAMIC
C599 1-126-969-11 ELECT
#4 C6010 1-113-511-11
0.1µF
50V 7146104456
50V 5156221T50
250V 5067474425
250V 5067474425
250V 5063471325
220µF
0.47µF
0.47µF
470pF
#4 C6020 1-113-511-11
#4 C915 1-102-973-21 CERAMIC
100pF
50V 5128101552
[E220/E220E]
C6030 1-135-380-11 CERAMIC
#4 C918 1-163-243-11
#4 C919 1-163-243-11
47pF
47pF
0.1µF
22pF
50V 7183470556
50V 7183470556
50V 7146104456
50V 7183220556
C6040 1-135-380-11 CERAMIC
C605 1-135-351-11 CERAMIC
C606 1-135-396-11 ELECT
470pF
4700pF
220µF
220µF
250V 5063471325
250V 5063472425
#4 C920 1-163-189-11 CERAMIC
450V 515P331S45 #4 C921 1-163-235-91
35V 5156221T35
#4 C607 1-126-949-11 ELECT
#4 C608 1-137-871-11 METALIZED FILM 0.1µF
400V 5074104104
#4 C922 1-163-235-91
C923 1-126-961-11 ELECT
#4 C924 1-135-395-11 ELECT
22pF
50V 7183220556
50V 5156229T50
50V 5156479T50
50V 7146104456
50V 7183101556
2.2µF
4.7µF
0.1µF
100pF
#4 C609
#4 C609
Pending
Pending
METALIZED FILM 0.33µF
METALIZED FILM 0.22µF
680pF
630V 5074334106
[E220/E220E] #4 C925 1-163-189-11 CERAMIC
630V 5074224106
[E215E]
50V 7144681156
100V 5116103511
#4 C926 1-163-251-11 CERAMIC
#4 C611 1-163-007-11
#4 C927 1-163-251-11 CERAMIC
100pF
50V 7183101556
#4 C612 1-137-150-11 PETP FILM
0.01µF
#4 C613 1-163-002-11
270pF
0.1µF
0.1µF
10µF
50V 7144271156
50V 7146104456
50V 7146104456
50V 5156100T50
50V 7146104456
<CONNECTOR>
#4 C614 1-163-189-11 CERAMIC
#4 C616 1-163-189-11 CERAMIC
C618 1-126-964-11 ELECT
#4 C619 1-163-189-11 CERAMIC
CN501
CN502
Pending
Pending
6P
4P
0.1µF
#4 CN503 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN) 3340236016
[E220E/E215E]
#4 C620 1-135-389-11 CERAMIC
100pF
0.22µF
100pF
1KV 510H101132
50V 5113224150
50V 7183101556
CN504
#4 CN505
Pending
1P
2P
C622
Pending
C488020185
#4 C623 1-163-251-11 CERAMIC
7-4
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
The components identified by mark
are critical for safety.
¡
Les composants identifiés par une
marque sont critiques pour la sécurité.
¡
Replace only with part number specified.
Ne les remplacer que par une pièce
portant le numéro spécifié.
(d)
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
#4 CN60101-251-227-11 AC SOCKET
#4 CN602 1-815-267-11 PIN, CONNECTOR 3P
4570707C00
4490301100
D615 8-719-077-80 DIODE UF5404G
D616 8-719-074-19 DIODE UF5402G
D617 8-719-074-25 DIODE PG104R
4130305404
4130305402
4130101041
CN603
CN901
Pending
Pending
7P
9P
#4 CN902 1-564-510-51 PLUG, CONNECTOR 7P
4490700330
4490400330
#4 D618 8-719-074-17 DIODE SR1003
D619 8-719-911-19 DIODE 1SS119-25
#4 D621 8-719-074-13 DIODE BYV26C
4120511900
413010426C
CN903* 1-564-507-11 PLUG, CONNECTOR 4P
[E220 [NH]/E220E/E215E]
4130305402
D622 8-719-074-19 DIODE UF5402G
#4 D623 8-719-048-23 DIODE UF5406
<DIODE>
4130305406
[E220 [NH]/E220E/ E215E]
D402 8-719-200-02 DIODE 10E2
4120104002
4120511900
D501 8-719-911-19 DIODE 1SS119-25
D502 8-719-110-39 ZENER DIODE RD15ES-B1
D503 8-719-052-86 DIODE D2L40-TA
D504 8-719-911-19 DIODE 1SS119-25
#4 D625 8-719-911-19 DIODE 1SS119-25
D626 8-719-911-19 DIODE 1SS119-25
#4 D627 8-719-048-23 DIODE UF5406
4120511900
4120511900
4130305406
4130152400
4120511900
[E220 [NH]/E220E/E215E]
4130305406
#4 D628 8-719-048-23 DIODE UF5406
D629 8-719-911-19 DIODE 1SS119-25
D506 8-719-911-19 DIODE 1SS119-25
D507 8-719-987-31 DIODE SB140-6339
4120511900
4130104140
413050Z470
4130101040
4120511900
4120511900
D508
Pending
DIODE 5TUZ47CTO-220NIS
D630 8-719-911-19 DIODE 1SS119-25
D631 8-719-077-80 DIODE UF5404G
4120511900
4130305404
#4 D509 8-719-083-88 DIODE PS104R
D510 8-719-911-19 DIODE 1SS119-25
D901 8-719-921-42 ZENER DIODE MTZJ-5.1A
D902 8-719-921-42 ZENER DIODE MTZJ-5.1A
D903 8-719-921-42 ZENER DIODE MTZJ-5.1A
41205005C1
41205005C1
41205005C1
#4 D511 8-719-083-88 DIODE PS104R
#4 D512 8-719-083-88 DIODE PS104R
D513 8-719-074-13 DIODE BYV26C
D514 8-719-074-25 DIODE PG104R
D515 8-719-074-13 DIODE BYV26C
4130101040
4130101040
413010426C
4130101041
413010426C
D904 8-719-921-42 ZENER DIODE MTZJ-5.1A
D905 8-719-921-42 ZENER DIODE MTZJ-5.1A
D906 8-719-921-42 ZENER DIODE MTZJ-5.1A
D908 8-719-911-19 DIODE 1SS119-25
41205005C1
41205005C1
41205005C1
4120511900
#4 D516 8-719-911-19 DIODE 1SS119-25
D517 8-719-911-19 DIODE 1SS119-25
D518 8-719-911-19 DIODE 1SS119-25
#4 D519 8-719-083-88 DIODE PS104R
D520 8-719-074-25 DIODE PG104R
4120511900
4120511900
4120511900
4130101040
4130101041
<FUSE>
F601 0 1-576-231-11 FUSE (H.B.C.) (4A/250V)
5268400052
D521
Pending
DIODE BYV26C-200
4130204270
4130101041
4120511900
4120511900
41205005C1
D522 8-719-074-25 DIODE PG104R
D523 8-719-911-19 DIODE 1SS119-25
D524 8-719-911-19 DIODE 1SS119-25
D525 8-719-921-42 ZENER DIODE MTZJ-5.1A
<FERRITE BEAD>
FB502 1-419-981-11 COIL, CHOKE 10.8µH
FB504 1-469-402-11 BEAD, FERRITE 3µH
FB507 1-412-911-11 BEAD, FERRITE 2.3µH
FB508 1-412-911-11 BEAD, FERRITE 2.3µH
FB604 1-469-611-11 BEAD, FERRITE 2µH
4323100103
4322309006
7099159250
7099159250
4322309504
D526 8-719-911-19 DIODE 1SS119-25
#4 D527 8-719-110-35 ZENER DIODE HZ12
#4 D528 8-729-074-16 DIODE RGP02-18
D530 8-719-911-19 DIODE 1SS119-25
D531 8-719-911-19 DIODE 1SS119-25
4120511900
4120501202
4130100218
4120511900
4120511900
FB605 1-469-611-11 BEAD, FERRITE 2µH
#4 FB606 1-469-611-11 BEAD, FERRITE 2µH
FB607 1-469-611-11 BEAD, FERRITE 2µH
FB608 1-469-611-11 BEAD, FERRITE 2µH
4322309504
4322309504
4322309504
4322309504
4322309504
#4 D532 8-729-077-81 ZENER DIODE Z10-160B
D533 8-719-911-19 DIODE 1SS119-25
D535 8-719-921-42 DIODE MTZJ-5.1A
D538 8-719-110-39 ZENER DIODE RD15ES-B1
D592 8-719-911-19 DIODE 1SS119-25
4120510160
4120511900
#4 FB609
Pending
BEAD, FERRITE 3µH
[E220 [NH]/E220E/E215E]
41205015AU
4120511900
#4 FB610
#4 FB611
Pending
Pending
BEAD, FERRITE 3µH
4322309504
[E220 [NH]/E220E/E215E]
4322309504
[E220 [NH]/E220E/E215E]
7065R10301
D6010 8-719-510-53 DIODE D4SB60L
D603 8-719-911-19 DIODE 1SS119-25
#4 D604 8-719-083-88 DIODE PS104R
D605 8-719-053-19 DIODE UF4007G23
D606 8-719-911-19 DIODE 1SS119-25
4130400600
4120511900
4130101040
413010426D
4120511900
BEAD, FERRITE 3µH
FB612 1-419-445-11 COIL, CHOKE 300µH
FB613 1-419-445-11 COIL, CHOKE 300µH
7065R10301
7099159250
#4 FB614
Pending
BEAD, FERRITE 1.5µH
[E220 [NH]/E220E/E215E]
#4 D607 8-719-154-15 ZENER DIODE RD27EB4
#4 D608 8-719-154-15 ZENER DIODE RD27EB4
D609 8-719-911-19 DIODE 1SS119-25
D610 8-719-911-19 DIODE 1SS119-25
D611 8-719-911-19 DIODE 1SS119-25
4120502705
4120502705
4120511900
4120511900
4120511900
FB620 1-469-611-11 BEAD, FERRITE 2µH
FB622 1-469-611-11 BEAD, FERRITE 2µH
FB624 1-469-611-11 BEAD, FERRITE 2µH
4322309504
4322309504
4322309504
D612 8-719-911-55 DIODE U05G
#4 D613 8-719-048-23 DIODE UF5406
4120104004
4130305406
7-5
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
(d)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
<IC>
#4 Q512 8-729-194-57 TRANSISTOR 2SC945-P
Q513 8-729-141-03 TRANSISTOR 2SA733-QP
#4 Q514 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q515 8-729-194-57 TRANSISTOR 2SC945-P
Q516 8-729-141-03 TRANSISTOR 2SA733-QP
411020945P
4110007330
411020945P
411020945P
4110007330
IC401 8-759-593-28 IC LA78040
4159817200
4159484100
4159384300
4159358000
4159384200
IC501
IC502
Pending
Pending
IC TDA4841
IC UC3843A
IC504 8-759-991-16 IC LM358N
IC601 8-759-582-09 IC UC3842A
Q517 8-729-306-92 TRANSISTOR 2SD669AVC
#4 Q518 8-729-304-92 TRANSISTOR 2SB649-C
Q519 8-729-119-80 TRANSISTOR 2SC2688-LK
#4 Q520 8-729-194-57 TRANSISTOR 2SC945-P
410030669A
410010649A
4100226880
411020945P
[E220/E220E]
4110007330
[E220/E220E]
IC602 8-749-016-36 IC TLP621D4-Y-LF2
IC603 8-759-466-12 IC TL431ACLP
IC604 8-729-051-32 TRANSISTOR MCR100-8RL
IC605 8-759-231-53 IC TA7805S
415943100A
4114510080
4159780501
4114501006
IC606 8-729-048-22 TRANSISTOR MCR100
#4 Q521 8-729-141-03 TRANSISTOR 2SA733-QP
#4 IC607 8-759-088-08 IC MCT7812CT
4159781201
4159727750
415924C160
4159519510
IC901
Pending
IC ST72774
Q522 8-729-048-61 TRANSISTOR 2SK2843LB2SONY 4101528430
IC902 8-759-650-44 IC M24C16BN6
IC903 8-759-605-05 IC M51951BSL
Q523 8-729-306-92 TRANSISTOR 2SD669AVC
Q524 8-729-906-93 TRANSISTOR IRF640
Q525 8-729-141-03 TRANSISTOR 2SA733-QP
#4 Q526 8-729-029-86 TRANSISTOR DTC124ESA
410030669A
4105906400
4110007330
4116612030
<COIL>
#4 Q527 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q528 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q529 8-729-194-57 TRANSISTOR 2SC945-P
Q530 8-729-119-80 TRANSISTOR 2SC2688-LK
Q531 8-729-051-31 TRANSISTOR KSP92
411020945P
411020945P
411020945P
4100226880
4112409200
#4 L501 1-412-550-11 INDUCTOR, MICRO 1.2mH
#4 L502 1-469-994-11 COIL, PEAKING 100µH
#4 L503 1-459-104-11 COIL, CHOKE 10mH
#4 L504 1-419-986-11 COIL, CHOKE 28µH
4323122003
4321101006
4323103003
4323280003
[E220/E220E]
4323255903
[E215E]
#4 L504
Pending
COIL, CHOKE 25.5µH
Q532 8-729-141-03 TRANSISTOR 2SA733-QP
Q533 8-729-141-03 TRANSISTOR 2SA733-QP
#4 Q534 8-729-194-57 TRANSISTOR 2SC945-P
Q535 8-729-029-86 TRANSISTOR DTC124ESA
Q536 8-729-906-93 TRANSISTOR IRF640
4110007330
4110007330
411020945P
4116612030
4105906400
#4 L505 1-419-568-11 COIL, LINEARITY
#4 L506 1-459-104-11 COIL, CHOKE 10mH
#4 L509 1-469-995-11 COIL, PEAKING 150µH
#4 L601 1-412-537-31 COIL, CHOKE 100µH
#4 L602 1-412-537-31 COIL, CHOKE 100µH
708S205R50
4323103003
4321151006
4323101303
4323101303
#4 Q537 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q538 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q539 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q540 8-729-194-57 TRANSISTOR 2SC945-P
411020945P
411020945P
411020945P
411020945P
4111167180
#4 L603 1-412-537-31 COIL, CHOKE 100µH
#4 L604 1-412-537-31 COIL, CHOKE 100µH
#4 L605 1-412-537-31 COIL, CHOKE 100µH
4323101303
4323101303
4323101303
7067C2U150
Q541
Pending
TRANSISTOR H2N6718L
#4 L606
Pending
COIL, CHOKE 15µH
Q542 8-729-122-12 TRANSISTOR 2SA1221-L
411010647A
4103200122
4103200127
4116612030
[E220/E220E]
4110007330
[E220 [NH]/E220E/E215E] #4 Q543 8-729-055-78 TRANSISTOR TIP122
#4 L607 1-410-645-31 INDUCTOR, MICRO 100µH
4326101005
#4 Q544 8-729-055-77 TRANSISTOR TIP127
#4 Q546 8-729-029-86 TRANSISTOR DTC124ESA
<FILTER>
Q601 8-729-141-03 TRANSISTOR 2SA733-QP
LF6010 1-433-798-11 TRANSFORMER, LINE FILTER
7065Y11133
Q602 8-729-040-92 TRANSISTOR 2SK2607
#4 Q603 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q604 8-729-029-86 TRANSISTOR DTC124ESA
Q607 8-729-200-36 TRANSISTOR 2SA966-Y
Q608 8-729-206-21 TRANSISTOR RN1203
4102207800
411020945P
4116612030
4110009660
4116612030
<TRANSISTOR>
Q401 8-729-194-57 TRANSISTOR 2SC945-P
411020945P
4107496340
4103801100
Q501
Pending
TRANSISTOR SFS9634
Q609
Pending
TRANSISTOR 2SB1065
4100110650
4116612030
4116612030
411020945P
4116612030
#4 Q502 8-729-042-34 TRANSISTOR IRFU110
#4 Q610 8-729-029-86 TRANSISTOR DTC124ESA
[E220/E220E] #4 Q611 8-729-029-86 TRANSISTOR DTC124ESA
411022655Y #4 Q615 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q502
Pending
TRANSISTOR 2SC2655-Y
[E215E]
4100255870
411020945P
411020945P
4105906400
Q616 8-729-029-86 TRANSISTOR DTC124ESA
Q503 8-729-052-42 TRANSISTOR 2SC5587
Q504 8-729-194-57 TRANSISTOR 2SC945-P
Q505 8-729-194-57 TRANSISTOR 2SC945-P
#4 Q506 8-729-906-93 TRANSISTOR IRF640
Q617 8-729-265-52 TRANSISTOR 2SC2655
Q618 8-729-141-03 TRANSISTOR 2SA733-QP
Q901 8-729-139-04 TRANSISTOR 2N3904
4100226550
4110007330
4111139040
4111139040
[E220/E220E]
[E220/E220E] #4 Q902 8-729-139-04 TRANSISTOR 2N3904
#4 Q508 8-729-194-57 TRANSISTOR 2SC945-P
411020945P
[E220/E220E]
Q510 8-729-141-03 TRANSISTOR 2SA733-QP
4110007330
4111167180
Q511
Pending
TRANSISTOR H2N6718L
7-6
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
The components identified by mark
are critical for safety.
¡
Les composants identifiés par une
marque sont critiques pour la sécurité.
¡
Replace only with part number specified.
Ne les remplacer que par une pièce
portant le numéro spécifié.
(d)
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
<RESISTOR>
#4 R540 1-260-364-51 CARBON (SMALL) 1M
#4 R543 1-242-979-11 METAL OXIDE 270
1/10W 419A118212 #4 R544 1-260-352-51 CARBON (SMALL) 100K
1/10W 419A118212 #4 R545 1-260-352-51 CARBON (SMALL) 100K
1/2W 4050133955
1/2W 4050110555
1W 4177127153
1/2W 4050110455
1/2W 4050110455
[E220/E220E]
#4 R401 1-227-370-11 RES-CHIP
#4 R402 1-227-370-11 RES-CHIP
#4 R403 1-260-298-51 CARBON (SMALL) 3.3
R404 Pending
1.82K
1.82K
METAL OXIDE FILM 0.75
1W 4171075856
1/4W 4050515955
#4 R547 1-249-425-11 CARBON (SMALL) 4.7K
1/4W 4050547255
[E220/E220E]
R406 1-243-478-11 CARBON (SMALL) 1.5
#4 R407 1-260-322-51 CARBON (SMALL) 330
1/2W 4050133155
1/2W 4050133254
1/10W 4010110202
1/4W 4257046811
1/4W 4257046811
#4 R549 1-216-073-91 RES-CHIP
10K
1/10W 4010110352
[E220/E220E]
1/10W 4010110202
1/10W 4010110402
1/10W 4010110402
1/8W 4010815052
R408
R409
Pending
Pending
CARBON (SMALL) 3.3K
RES-CHIP
10K
R551
R552
R553
Pending
Pending
Pending
RES-CHIP
RES-CHIP
RES-CHIP
10K
100K
100K
15
R411 1-242-988-11 METAL FILM 6.81K
R412 1-242-988-11 METAL FILM 6.81K
#4 R554 1-216-154-11 RES-CHIP
#4 R500 1-247-798-11 CARBON (SMALL) 43
1/4W 4050543055
1/10W 4010127352
1/10W 419A122122 #4 R556 1-216-073-91 RES-CHIP
1/10W 4010147252 R557 Pending
1/10W 419A173202 #4 R558 1-249-431-11 CARBON (SMALL) 15K
#4 R559 1-249-417-11 CARBON (SMALL) 1K
1/10W 4010128202
#4 R501 1-216-083-11 RES-CHIP
#4 R502 1-227-372-11 RES-CHIP
#4 R503 1-216-065-11 RES-CHIP
#4 R504 1-227-379-11 RES-CHIP
27K
#4 R555 1-247-807-31 CARBON (SMALL) 100
10K
METAL OXIDE 10
1/4W 4050510155
1/10W 4010110352
1W 4171010053
1/4W 4050515355
1/4W 4050510255
22.1K
4.7K
732
R505
Pending
RES-CHIP
2.8K
10K
10K
#4 R506 1-216-073-91 RES-CHIP
#4 R507 1-216-073-91 RES-CHIP
1/10W 4010110352
1/10W 4010110352
1/4W 4050512355
1/4W 4050536255
#4 R560 1-216-101-11 RES-CHIP
#4 R561 1-249-437-11 CARBON (SMALL) 47K
#4 R562 1-216-073-91 RES-CHIP 10K
#4 R563 1-249-437-11 CARBON (SMALL) 47K
#4 R565 1-215-049-91 RES-CHIP 1K
150K
1/10W 4010115452
1/4W 4050547355
1/10W 4010110352
1/4W 4050547355
1/10W 4010110252
#4 R508 1-249-430-11 CARBON (SMALL) 12K
#4 R509 1-247-844-11 CARBON (SMALL) 3.6K
#4 R510 1-216-025-11 RES-CHIP
#4 R511 1-216-025-11 RES-CHIP
#4 R512 1-216-198-11 RES-CHIP
#4 R513 1-216-025-11 RES-CHIP
100
100
1K
100
68K
1/10W 4010110152
1/10W 4010110152
1/8W 4010810252
1/10W 4010110152
1/10W 4010168302
#4 R566 1-249-429-11 CARBON (SMALL) 10K
#4 R567 1-216-073-91 RES-CHIP 10K
1/4W 4050510355
1/10W 4010110352
1/4W 4050510355
1/2W 4050168155
1/10W 4010122252
#4 R568 1-249-429-11 CARBON (SMALL) 10K
#4 R569 1-260-326-51 CARBON (SMALL) 680
R515
Pending
RES-CHIP
#4 R570 1-216-057-91 RES-CHIP
2.2K
#4 R516 1-247-846-11 CARBON (SMALL) 4.3K
1/4W 4050543255
1/10W 4010110352
1/10W 4010151452
2W 4172010156
1W 4171022856
#4 R517 1-216-073-91 RES-CHIP
#4 R518 1-218-769-11 RES-CHIP
10K
#4 R571 1-249-425-11 CARBON (SMALL) 4.7K
#4 R572 1-249-393-11 CARBON (SMALL) 10
#4 R573 1-247-868-91 CARBON (SMALL) 36K
1/4W 4050547255
1/4W 4050510055
1/4W 4050536355
1/10W 4010182352
1/10W 4010130252
510K
#4 R519 1-244-194-11 METAL OXIDE 100
R520
Pending
METAL OXIDE FILM 0.22
#4 R574 1-216-095-11 RES-CHIP
#4 R575 1-216-662-11 RES-CHIP
82K
3K
R521
Pending
METAL FILM 22.6K
1/4W 4257042262
1/10W 4010147252
[E220/E220E]
#4 R522 1-216-065-11 RES-CHIP
4.7K
R576 1-242-973-11 METAL OXIDE 30K
R577 Pending
#4 R578 1-249-417-11 CARBON (SMALL) 1K
3W 4177330355
1/4W 4050568055
1/4W 4050510255
1/10W 4010127252
1/10W 4010110152
[E220/E220E]
CARBON (SMALL) 68
#4 R522 1-216-041-11 RES-CHIP
470
1/10W 4010147152
[E215E] #4 R579 1-216-059-11 RES-CHIP
2.7K
100
#4 R523 1-216-073-91 RES-CHIP
#4 R524 1-216-071-11 RES-CHIP
#4 R525 1-243-482-11 CARBON (SMALL) 56
10K
8.2K
1/10W 4010110352
1/10W 4010182252
1/4W 4050556055
#4 R580 1-216-025-11 RES-CHIP
#4 R580 1-216-041-11 RES-CHIP
470
1/10W 4010147152
[E215E]
#4 R526 1-216-065-11 RES-CHIP
#4 R527 1-216-073-91 RES-CHIP
4.7K
10K
1/10W 4010147252
1/10W 4010110352
1/2W 4077B12155 #4 R582 1-249-422-11 CARBON (SMALL) 2.7K
1/4W 4050510255 #4 R583 1-244-277-11 METAL OXIDE 1.8
3W 417731895A #4 R584 1-249-089-11 RES-CHIP 47K
R581
Pending
CARBON (SMALL) 33K
1/4W 4050533355
1/4W 4050527255
3W 417731895A
1/10W 4010147352
R528
Pending
METAL FILM 120
#4 R529 1-249-417-11 CARBON (SMALL) 1K
#4 R530 1-244-277-11 METAL OXIDE 1.8
#4 R531 1-216-055-11 RES-CHIP
#4 R531 1-215-049-91 RES-CHIP
1.8K
1K
1/10W 4010118252
[E220/E220E]
1/10W 4010110252
#4 R585 1-249-401-11 CARBON (SMALL) 47
1/4W 4050547055
1/4W 4257041103
1/4W 4257041002
1/4W 4050510555
1/10W 4010156352
R586
R589
Pending
Pending
METAL FILM 110K
METAL FILM 10K
[E215E] #4 R590 1-247-903-81 CARBON (SMALL) 1M
#4 R532 1-260-312-51 CARBON (SMALL) 47
1/2W 4050147055
1W 4177113253
1W 4171010053
#4 R591 1-216-091-11 RES-CHIP
56K
R533
R534
Pending
Pending
METAL OXIDE 1.3K
METAL OXIDE 10
#4 R592 1-216-089-11 RES-CHIP
47K
1/10W 4010147352
1/10W 4010112452
1/10W 4010147252
1/10W 4010182302
1/2W 4050182055
R594
Pending
RES-CHIP
120K
4.7K
82K
#4 R535 1-249-417-11 CARBON (SMALL) 1K
#4 R536 1-216-069-11 RES-CHIP 6.8K
R537 Pending
1/4W 4050510255
1/10W 4010168252
1/4W 4050115355
1/10W 4010147252
1/10W 4010110352
#4 R595 1-216-065-11 RES-CHIP
R596
R597
Pending
Pending
CARBON (SMALL) 15K
CARBON (SMALL) 82
#4 R538 1-216-065-11 RES-CHIP
#4 R539 1-216-073-91 RES-CHIP
4.7K
10K
#4 R598 1-215-049-91 RES-CHIP
1K
1/10W 4010110252
[E220/E220E]
7-7
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
Les composants identifiés par une
marque sont critiques pour la sécurité.
The components identified by mark
are critical for safety.
¡
¡
Ne les remplacer que par une pièce
portant le numéro spécifié.
Replace only with part number specified.
(d)
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
DESCRIPTION
REMARK
#4 R599 1-227-370-11 RES-CHIP
1.82K
1/10W 419A118212 #4 R907 1-249-417-11 CARBON (SMALL) 1K
1/4W 4050510255
1/10W 4010110352
1/4W 4050510255
R6010 1-260-132-11 CARBON (SMALL) 560K
1/2W 4050156455
2W 4172030353
1W 4171015456
#4 R908 1-216-073-91 RES-CHIP
#4 R909 1-249-417-11 CARBON (SMALL) 1K
10K
R603
R605
Pending
Pending
METAL OXIDE 30K
METAL OXIDE FILM 150K
#4 R910 1-216-073-91 RES-CHIP
#4 R911 1-249-417-11 CARBON (SMALL) 1K
#4 R912 1-216-222-91 RES-CHIP
#4 R913 1-249-417-11 CARBON (SMALL) 1K
10K
1/10W 4010110352
1/4W 4050510255
1/8W 4010810352
1/4W 4050510255
1/4W 4257043329
#4 R609 1-249-422-11 CARBON (SMALL) 2.7K
#4 R610 1-216-001-11 RES-CHIP 10
#4 R611 1-249-396-11 CARBON (SMALL) 18
1/4W 4050527255
1/10W 4010110052
1/4W 4050518055
10K
#4 R612 1-227-377-11 RES-CHIP
4.99K
1/10W 419A149912 #4 R914 1-244-247-11 METAL FILM 33.2
1/4W 4172022855
#4 R614 1-216-361-11 METAL OXIDE 0.22
#4 R915 1-240-907-11 METAL FILM 30.1K
1/4W 4257043012
1/10W 4010110352
1/4W 4050547255
[E220/E220E]
#4 R615 1-244-176-11 METAL FILM 1.82K
#4 R616 1-244-179-11 METAL FILM 3.92K
1/4W 4257041821
1/4W 4257043921
1/10W 4010110352
1/10W 4010110352
1/10W 4010110252
#4 R918 1-216-073-91 RES-CHIP
10K
#4 R919 1-249-425-11 CARBON (SMALL) 4.7K
#4 R618 1-216-073-91 RES-CHIP
#4 R619 1-216-073-91 RES-CHIP
#4 R620 1-215-049-91 RES-CHIP
10K
10K
1K
#4 R920 1-216-073-91 RES-CHIP
#4 R921 1-215-049-91 RES-CHIP
10K
1K
1/10W 4010110352
[E220/E220E]
1/10W 4010110252
#4 R621 1-216-182-11 RES-CHIP
#4 R622 1-216-182-11 RES-CHIP
#4 R623 1-216-025-11 RES-CHIP
#4 R624 1-216-072-11 RES-CHIP
#4 R625 1-216-073-91 RES-CHIP
220
220
100
1.9K
10K
1/8W 4010822152
1/8W 4010822152
1/10W 4010110152
1/10W 4010191252
1/10W 4010110352
#4 R922 1-216-073-91 RES-CHIP
#4 R923 1-216-073-91 RES-CHIP
#4 R924 1-215-049-91 RES-CHIP
10K
10K
1K
1/10W 4010110352
1/10W 4010110352
1/10W 4010110252
1/4W 4050510355
1/10W 4010110152
#4 R925 1-249-429-11 CARBON (SMALL) 10K
#4 R926 1-216-025-11 RES-CHIP
100
#4 R626 1-216-077-11 RES-CHIP
15K
1/10W 4010115352
R627
Pending
RES-CHIP
4.12K
1/10W 419A141212 #4 R927 1-216-065-11 RES-CHIP
4.7K
10K
10K
10K
10K
1/10W 4010147252
1/10W 4010110352
1/8W 4010810352
1/8W 4010810352
1/8W 4010810352
#4 R628 1-247-802-11 CARBON (SMALL) 62
#4 R629 1-249-417-11 CARBON (SMALL) 1K
1/4W 4050562055
1/4W 4050510255
1/10W 4010139252
#4 R928 1-216-073-91 RES-CHIP
#4 R929 1-216-222-91 RES-CHIP
#4 R930 1-216-222-91 RES-CHIP
#4 R931 1-216-222-91 RES-CHIP
R630
Pending
RES-CHIP
3.9K
R631
R632
Pending
Pending
RES-CHIP
RES-CHIP
10K
10K
1/10W 4010110202
1/10W 4010110202
1/4W 4050510355
1/4W 4050547155
1/4W 4050522155
#4 R932 1-249-397-11 CARBON (SMALL) 22
#4 R933 1-249-397-11 CARBON (SMALL) 22
#4 R934 1-249-401-11 CARBON (SMALL) 47
1/4W 4050522055
1/4W 4050522055
1/4W 4050547055
1/8W 4010810352
1/10W 4010110552
#4 R640 1-249-429-11 CARBON (SMALL) 10K
#4 R641 1-249-413-11 CARBON (SMALL) 470
#4 R642 1-249-409-11 CARBON (SMALL) 220
#4 R935 1-216-222-91 RES-CHIP
#4 R936 1-216-121-11 RES-CHIP
10K
1M
R643
R644
Pending
Pending
RES-CHIP
RES-CHIP
115K
2.8K
1/10W 419A111532
1/10W 4010128202
1/2W 4050115155
1/10W 4010110352
1/4W 4050530155
#4 R937 1-216-017-11 RES-CHIP
#4 R938 1-216-222-91 RES-CHIP
#4 R939 1-216-222-91 RES-CHIP
#4 R940 1-216-073-91 RES-CHIP
#4 R941 1-216-174-11 RES-CHIP
47
1/10W 4010147052
1/8W 4010810352
1/8W 4010810352
1/10W 4010110352
1/8W 4010810152
#4 R648 1-260-089-11 CARBON (SMALL) 150
#4 R651 1-216-073-91 RES-CHIP 10K
10K
10K
10K
100
R652 1-243-480-11 CARBON (SMALL) 300
R653 1-215-888-11 METAL OXIDE 220
2W 4172022155
1/10W 4010116252
1/4W 4050510355
1/4W 4050510355
1/4W 4050510255
R655
Pending
RES-CHIP
1.6K
#4 R942 1-216-174-11 RES-CHIP
#4 R943 1-247-807-31 CARBON (SMALL) 100
100
1/8W 4010810152
1/4W 4050510155
1/8W 4010847152
1/10W 4010147052
1/8W 4010810152
#4 R656 1-249-429-11 CARBON (SMALL) 10K
#4 R658 1-249-429-11 CARBON (SMALL) 10K
#4 R659 1-249-417-11 CARBON (SMALL) 1K
R944
Pending
RES-CHIP
470
47
#4 R945 1-216-017-11 RES-CHIP
#4 R946 1-216-174-11 RES-CHIP
100
#4 R660 1-249-429-11 CARBON (SMALL) 10K
#4 R661 1-249-419-11 CARBON (SMALL) 1.5K
1/4W 4050510355
1/4W 4050515255
1/10W 4010110352
1/4W 4050515255
1/2W 4050110955
R948
R949
Pending
Pending
RES-CHIP
RES-CHIP
1.4
1/10W 4010114202
1/10W 4010151352
1/10W 4010151452
1/10W 4010128302
1/10W 4010147052
#4 R665 1-216-073-91 RES-CHIP
10K
51K
510K
28K
47
#4 R666 1-249-419-11 CARBON (SMALL) 1.5K
#4 R950 1-218-769-11 RES-CHIP
R951 Pending RES-CHIP
#4 R952 1-216-017-11 RES-CHIP
R669
R670
Pending
Pending
CARBON (SMALL)
1
CARBON (SMALL) 1.5M
1/4W 4050515555
1/10W 4010120552
1/10W 4010147352
1/4W 4257041073
1/8W 4010800052
#4 R672 1-216-128-11 RES-CHIP
#4 R673 1-216-089-11 RES-CHIP
2M
47K
R954
Pending
RES-CHIP
10K
1/10W 4010110202
1/4W 4050510355
1/10W 4010100052
[E215E]
#4 R955 1-249-429-11 CARBON (SMALL) 10K
#4 R959 RES-CHIP
#4 R675 1-244-185-11 METAL FILM 107K
0
R676
Pending
RES-CHIP
0
#4 R5001 1-244-194-11 METAL OXIDE 100
#4 R5003 1-249-429-11 CARBON (SMALL) 10K
2W 4172010156
1/4W 4050510355
#4 R677 1-216-121-11 RES-CHIP
R678 Pending
#4 R902 1-249-417-11 CARBON (SMALL) 1K
#4 R903 1-249-417-11 CARBON (SMALL) 1K
R904 1-247-807-31 CARBON (SMALL) 100
1M
1/10W 4010110552
1/4W 4050520555
1/4W 4050510255
1/4W 4050510255
1/4W 4050510155
CARBON (SMALL) 2M
#4 R5102 1-216-075-11 RES-CHIP
#4 R5103 1-216-073-91 RES-CHIP
120K
10K
1/10W 4010113352
1/10W 4010110352
1/2W 4050110355
1/4W 4050547155
1/4W 4050510355
#4 R5104 1-260-340-51 CARBON (SMALL) 10K
#4 R5106 1-249-413-11 CARBON (SMALL) 470
#4 R5107 1-249-429-11 CARBON (SMALL) 10K
#4 R905 1-249-417-11 CARBON (SMALL) 1K
#4 R906 1-249-417-11 CARBON (SMALL) 1K
1/4W 4050510255
1/4W 4050510255
7-8
Download from Www.Somanuals.com. All Manuals Search And Download.
CPD-E220/E220E/E215E
(d)(h)
REF.NO. PART NO. DESCRIPTION
REMARK
REF.NO. PART NO.
<VARIABLE RESISTOR>
VR5010 Pending
DESCRIPTION
REMARK
R5108
Pending
RES-CHIP
18K
1M
470
20K
6.8K
1/10W 4010118302
1/10W 4010110552
1/10W 4010147152
1/10W 4010120352
1/10W 4010168252
#4 R5109 1-216-121-11 RES-CHIP
#4 R5110 1-216-041-11 RES-CHIP
#4 R5111 1-216-684-11 RES-CHIP
#4 R5112 1-216-069-11 RES-CHIP
RES, ADJ, CERMET 50K (HV ADJ)
5.22E+11
<CRYSTAL>
R5113
R5114
Pending
Pending
RES-CHIP
RES-CHIP
51K
120K
1/10W 4010151352
1/10W 4010112452
1/2W 4050110455
1/2W 4050110455
1/4W 4050510155
X901 1-781-719-11 VIBRATOR, CRYSTAL (24MHz)
7152400010
#4 R5115 1-216-352-51 CARBON (SMALL) 100K
#4 R5116 1-216-352-51 CARBON (SMALL) 100K
R5117 1-247-807-31 CARBON (SMALL) 100
******************************************************************************************
#4 R5118 1-216-073-91 RES-CHIP
#4 R5119 1-249-425-11 CARBON (SMALL) 4.7K
#4 R5120 1-244-295-11 RES-CHIP 26.7K
#4 R5121 1-249-429-11 CARBON (SMALL) 10K
#4 R5122 1-244-299-11 RES-CHIP 60.4K
10K
1/10W 4010110352
1/4W 4050547255
1/10W 419A126722
1/4W 4050510355
1/10W 419A160422
H BOARD, COMPLETE
****************************
R5123
Pending
RES-CHIP
10K
1/10W 4010110202
1/4W 4050510155
1/4W 4050543155
1/10W 419A114712
1/2W 4050120055
<CAPACITOR>
R5124 1-247-807-31 CARBON (SMALL) 100
R5125
R5126
R5127
Pending
Pending
Pending
CARBON (SMALL) 430
C701 1-135-360-11 CERAMIC
C702 1-135-360-11 CERAMIC
1000pF
1000pF
7181102552
7181102552
RES-CHIP
1.47K
CARBON (SMALL) 20
R5128
Pending
CARBON (SMALL) 36
1/2W 4050136055
1/10W 4010110252
1/10W 4010110352
1/8W 4010882452
1/10W 4010147352
<LED>
#4 R5129 1-215-049-91 RES-CHIP
#4 R5130 1-216-073-91 RES-CHIP
#4 R5131 1-216-268-11 RES-CHIP
#4 R5132 1-216-089-11 RES-CHIP
1K
10K
820K
47K
#4 LED7011-517-965-11 DIODE LT5J62-23-D63 (POWER) 412065J620
<RESISTOR>
R5134
Pending
METAL OXIDE FILM 4.7
1W 4171247956
#4 R701 1-244-177-11 METAL FILM 2.15K
R702 Pending METAL FILM 10.2K
#4 R705 1-244-180-11 METAL FILM 6.19K
#4 R706 1-244-178-11 METAL FILM 3.83K
#4 R709 1-244-181-11 METAL FILM 17.4K
4257042151
4257041022
4257046191
4257043831
4257041742
<RELAY>
RY501 1-755-423-11 RELAY
#4 RY60101-775-031-11 RELAY
4420412016
4420612014
<SWITCH>
<SWITCH>
SW701 1-771-734-11 SWITCH, TACTILE (MENU)
4410606000
S602 1-771-757-11 SWITCH, POWER PUSH
4410204018
SW901 1-771-930-11 SWITCH, KEY BOARD (RESET)
4410604034
******************************************************************************************
<SPARK GAP>
SG501 1-519-422-21 GAP, SPARK
5106152204
<TRANSFORMER>
T501 0 1-453-358-11 TRANSFORMER, FLYBACK
#4 T502 1-435-846-11 TRANSFORMER, DRIVER
#4 T503 1-435-845-11
T504 1-435-844-11 TRANSFORMER, FOCUS
#4 T601 0 1-435-853-11 PFC X’FORMER
7050307C2U
7050207C2U
7050907C2U
7050507C2U
7051309R00
[E220 [NH]/E220E/E215E]
#4 T603 0 1-435-843-11 TRANSFORMER, POWER 7050107C2U
<THERMISTOR>
TH60101-803-533-11 THERMISTOR
TH60201-803-963-11 THERMISTOR
710501003B
7106070027
7-9
Download from Www.Somanuals.com. All Manuals Search And Download.
|