Ranger Communications Inc.
RCI−6300F HP
RCI−6300F TB
10 Meter Amateur Radio
Ranger
Service Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP
RCI-6300F TB
CHAPTER 1
SPECIFICATIONS
1.0 GENERAL
Model
RCI-6300F HP / RCI-6300F TB
Frequency Range
28.245 - 29.655MHz.
Emission Modes
AM/FM (A3/F3)
Frequency Control
Phase Lock Loop (PLL) synthesizer.
Frequency Tolerance
Frequency Stability
Operating Temperature Range
Microphone
± 0.005 %.
± 0.001 %.
-20°C to +50°C.
Dynamic PTT, 500 Ω
13.8V DC nominal ±15%.
RCI-6300F HP < 5A; RCI-6300F TB < 15A.
≤ 0.25A.
Input Voltage
Current Drain: Transmit (AM full mod.)
Current Drain: Receiver (Squelched)
(Max. audio output)
Antenna Connector
Dimensions (RCI-6300F HP)
Dimensions (RCI-6300F TB)
Weight
< 0.5A.
UHF, SO239.
2-3/8”(H) x 7-7/8”(W) x 10-3/4”(D).
3-7/8”(H) x 7-7/8”(W) x 9-1/4”(D).
5 lb. (RCI-6300F HP) ; 7lb 6oz (RCI-6300F TB)
1.1 TRANSMITTER
RF Power Output (AM/FM)
(DC Carrier Power)
RF Transmit Modes
AM Modulation
10 W (RCI-6300F HP)
50W (RCI-6300F TB)
AM/FM.
High and low level Class B, Amplitude Modulation.
Spurious Emissions
Audio Frequency Response
Antenna Impedance
Output Indicators
-50 dB.
300 to 2500 Hz
50 Ohms.
Meter shows relative RF output power, receive signal
and SWR. Transmit LED glows red when transmitter
is in operation.
1.2 RECEIVER
Sensitivity For 10dB S/N (AM)
Sensitivity For 12dB S/N (FM)
IF Frequency
< 0.5 µV.
< 0.25 µV.
AM: 10.695 MHz 1st IF, 455 KHz 2nd IF.
> 50 dB.
Image Rejection
Adjacent Channel Selectivity
RF Gain Control
Automatic Gain Control (AGC) Figure Of Merit
Squelch
> -55 dB.
45 dB adjustable for optimum signal reception.
100 mV for 10 dB Change in Audio Output.
Adjustable; threshold less than 0.5 µV.
RF type.
Noise Blanker
Audio Output Power
2.5W @ 10% THD.
Audio Frequency Response
Built-in Speaker
300 to 2500 Hz.
8 Ohms, 4 Watts.
External Speaker (Not Supplied)
8 Ohms; 4 Watts.
(SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE)
RCI-6300F HP
CHAPTER 2
- 2 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F TB
OPERATION
Figure 2-1 Front Panel
2.0 INTRODUCTION
This section explains the basic operating procedures for the RANGER RCI-6300F HP / RCI-6300F TB
mobile transceiver.
2.1 CONTROL AND CONNECTIONS
2.1.1 FRONT PANEL
Refer to the above Figure 2-1 for the location of the following controls.
1. ON/OFF VOLUME CONTROL
This knob controls the volume and the power to the radio. To turn the radio on, rotate the knob
clockwise. Turning the knob further will increase the volume of the receiver.
2. SQUELCH CONTROL
This switch is used to eliminate background noise being heard through the receiver which can be
disturbing when no transmissions are being received. To use this feature, turn the switch fully
counterclockwise and then turn clockwise slowly until the background noise is just eliminated. Further
clockwise rotation will increase the threshold level which a signal must overcome in order to be heard.
Only strong signals will be heard at a maximum clockwise setting.
3. MIC GAIN CONTROL
- 3 -
Download from Www.Somanuals.com. All Manuals Search And Download.
Adjusts the microphone gain in the transmit and PA modes. This controls the gain to the extent that full
talk power is available several inches away from the microphone. In the Public Address (PA) mode, the
control functions as the volume control.
4. RF GAIN CONTROL
This control is used to reduce the gain of the RF amplifier under strong signal conditions.
5. MODE SWITCH
This control allows you to select one of the following operating modes: PA/FM/AM.
In the PA position, the radio acts as a public address amplifier. Your voice will come out of the speaker
that is plugged into the PA. SP. jack on the rear panel. The radio does not operate when you are in the
PA mode. In the FM/AM position, the PA function is disabled and the unit will transmit and receive on
the speaker that is connected to the radio.
6. FR. POOL SELECTOR
This switch is used to select the frequency range of operation (1 - 6).
7. ECHO SWITCH
This control is used for echo effect.
8. TIME CONTROL
This time control is used to control the intervals of the echo sound.
9. TALKBACK CONTROL
Adjust this knob for desired volume of Talkback. This is used to monitor your own voice. For example,
you could use this feature to compare different microphones.
10. RF POWER CONTROL
This control allows the user to adjust RF power output.
11. CHANNEL SELECTOR
This control is used to select a desired transmit and receive channel.
12. FRONT PANEL METER
The Front Panel Meter allows the user to monitor signal strength, RF output power and SWR level.
13. TX/RX LED
The red LED indicates the unit is in the transmit mode. The green LED indicates the unit is in the
receive mode.
14. FREQUENCY COUNTER
This display indicates the frequency of operation.
15. DIM/BRT SWITCH
This switch controls the level of brightness for the meter lamp, frequency display and the channel
display. Press this switch (DIM) for the meter lamp, frequency display and the channel display to be
dimly lighted. Depress this switch (BRT) for brighter effects.
16. HI/LO SWITCH
This switch selects received audio tone quality. In LO position, bass is increased and in HI position,
treble is increased.
- 4 -
Download from Www.Somanuals.com. All Manuals Search And Download.
17. S-RF/SWR SWITCH
This is a two-function switch. In the S-RF position, the meter will indicate the strength of the signal
being received, as well as the relative RF output of transmission. To use the meter to measure the
standing wave ratio, turn the switch to the SWR position. The SWR function is self-calibrating.
18. NB/ANL/OFF SWITCH
In the NB/ANL position, the RF Noise Blanker and the Automatic Noise Limiter in the audio circuits
are also activated. The Noise Blanker is very effective in eliminating repetitive impulse noise such as
ignition interference.
19. R.B./OFF SWITCH
In the Roger Beep position, the radio transmits an audio tone at the end of your transmission to indicate
that transmission has ended. As a courtesy to others, use the Roger Beep only when necessary.
20. +10KHz/OFF SWITCH
When the switch is pressed the frequency is shifted 10KHz up.
21. CHANNEL DISPLAY
The channel display indicates the current selected channel.
2.1.2 REAR PANEL
Figure 2-2 represents the location of the following connections:
- 5 -
Download from Www.Somanuals.com. All Manuals Search And Download.
Figure 2-2 Rear Panel
1. ANTENNA
This jack accepts 50 ohms coaxial cable with a PL- 259 type plug.
2. POWER
This connector accepts 13.8V DC power cable with built-in fuse. The power cord provided with the
radio has a black and red wire. The black goes to negative and the red goes to positive.
3. PA. SP.
This jack is for PA operation. Before operating, you must first connect a PA speaker (8 ohms, 4W) to
this jack.
4. EXT. SP.
This jack accepts 4 to 8 ohms, 4 watts external speaker. When the external speaker is connected to this
jack, the built-in speaker will be disabled.
2.1.3 FREQUENCY CHART
FR. POOL
CHANNEL 1 (MHz)
2 (MHz)
3 (MHz)
4 (MHz)
5 (MHz)
6 (MHz)
- 6 -
Download from Www.Somanuals.com. All Manuals Search And Download.
1
2
3
4
5
6
7
8
28.245
28.255
28.265
28.285
28.295
28.305
28.315
28.335
28.345
28.355
28.365
28.385
28.395
28.405
28.415
28.435
28.445
28.455
28.465
28.485
28.495
28.505
28.535
28.515
28.525
28.545
28.555
28.565
28.575
28.585
28.595
28.605
28.615
28.625
28.635
28.645
28.655
28.665
28.675
28.685
28.695
28.705
28.715
28.735
28.745
28.755
28.765
28.785
28.795
28.805
28.815
28.835
28.845
28.855
28.865
28.885
28.895
28.905
28.915
28.935
28.945
28.955
28.985
28.965
28.975
28.995
29.005
29.015
29.025
29.035
29.045
29.055
29.065
29.075
29.085
29.095
29.105
29.115
29.125
29.135
29.145
29.155
29.165
29.185
29.195
29.205
29.215
29.235
29.245
29.255
29.265
29.285
29.295
29.305
29.315
29.335
29.345
29.355
29.365
29.385
29.395
29.405
29.435
29.415
29.425
29.445
29.455
29.465
29.475
29.485
29.495
29.505
29.515
29.525
29.535
29.545
29.555
29.565
29.575
29.585
28.315
28.325
28.335
28.355
28.365
28.375
28.385
28.405
28.415
28.425
28.435
28.455
28.465
28.475
28.485
28.505
28.515
28.525
28.535
28.555
28.565
28.575
28.605
28.585
28.595
28.615
28.625
28.635
28.645
28.655
28.665
28.675
28.685
28.695
28.705
28.715
28.725
28.735
28.745
28.755
28.765
28.775
28.785
28.805
28.815
28.825
28.835
28.855
28.865
28.875
28.885
28.905
28.915
28.925
28.935
28.955
28.965
28.975
28.985
29.005
29.015
29.025
29.005
29.035
29.045
29.065
29.075
29.085
29.095
29.105
29.115
29.125
29.135
29.145
29.155
29.165
29.175
29.185
29.195
29.205
29.215
29.225
29.235
29.255
29.265
29.275
29.285
29.305
29.315
29.325
29.335
29.355
29.365
29.375
29.385
29.405
29.415
29.425
29.435
29.445
29.465
29.475
29.505
29.485
29.495
29.495
29.515
29.525
29.535
29.545
29.555
29.565
29.575
29.585
29.595
29.605
29.625
29.635
29.645
29.655
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
2.2 MICROPHONE
The receiver and transmitter are controlled by the push-to-talk switch on the microphone. Press the
switch and the transmitter is activated, release switch to receive. When transmitting, hold the
microphone two inches from the mouth and speak clearly in a normal voice. The radio comes complete
with low impedance (500 ohm) dynamic microphone.
- 7 -
Download from Www.Somanuals.com. All Manuals Search And Download.
2.3 OPERATION
2.3.1 PROCEDURE TO RECEIVE
1. Be sure that power source, microphone and antenna are connected to the proper connectors before
going to the next step.
2. Turn unit on by turning VOL knob clockwise on transceiver.
3. Set the VOL to a comfortable listening level.
4. Set the MODE switch to the desired mode.
5. Listen to the background noise from the speaker. Turn the SQ knob slowly clockwise until the noise
just disappears. The SQ is now properly adjusted. The receiver will remain quiet until a signal is
actually received. Do not advance the control too far or some of weaker signals will not be heard.
6. Set the CHANNEL selector switch to the desired channel.
7. Set the RF GAIN control fully clockwise for maximum RF gain.
2.3.2 PROCEDURE TO TRANSMIT
1. Select the desired channel of transmission
2. Set the MIC GAIN control fully clockwise.
3. If the channel is clear, press the push-to-talk switch on the microphone and speak in a normal voice.
2.4 ALTERNATE MICROPHONES AND INSTALLATION
For best results, the user should select a low impedance dynamic type microphone or a transistorized
microphone. Transistorized type microphones have a low output impedance characteristic. The
microphones must be provided with a four-lead cable. The audio conductor and its shielded lead
comprise two of the leads. The third lead is for transmit control and the fourth is for receiving control.
The microphone should provide the functions shown in schematic below (Figure 2-3).
- 8 -
Download from Www.Somanuals.com. All Manuals Search And Download.
4 WIRE MIC CABLE
Pin Number Mic Cable Lead
1
2
3
4
Audio Shield
Audio Lead
Transmit Control
Receive Control
Figure 2-3 Your Transceiver Microphone Schematic
Figure 2-4 Microphone plug pin numbers viewed from rear of pin receptacle.
CHAPTER 3
RCI-6300F HP
RCI-6300F TB
CIRCUIT
DESCRIPTION
3.0 INTRODUCTION
This section explains the technical theory of operation for the RCI-6300F HP / RCI-6300F TB mobile
transceiver.
- 9 -
Download from Www.Somanuals.com. All Manuals Search And Download.
3.1 PLL CIRCUIT
The Phase Lock Loop (PLL) circuit is responsible for developing the receiver’s first local oscillator
signal and the transmitter’s exciter signal. The PLL circuit consists primarily of IC2, IC3, IC4, IC5
Q25, Q27, Q28, Q29 and Q61. The PLL circuit is programmed by the rotary channel switch GPS-0501.
The switch communicates the correct binary data information to the programmable divider inside of
IC3. IC3 then controls the VCO (Voltage Controlled Oscillator), consisting of VCO to oscillate on the
correct frequency. This signal is fed either into the receiver’s first mixer (for receive operation) or the
transmitter’s mixer (for transmit operation).
3.2 RECEIVER CIRCUIT
The incoming RF signal comes into the radio via the antenna and into the front-end pre-amp, Q17. The
RF signal is fed into the mixer circuit Q18 & Q19 and then into the IF section of the receiver
(depending on the mode of operation). The signals is then detected by either the AM detector or FM
detector and then fed to the audio amplifier section of the receiver and finally out to the speaker.
3.3 TRANSMITTER MODULATION CIRCUIT
(i) The transmitter modulation circuit modulates the low-level RF signal from the PLL exciter circuit
with the user’s audio voice signal from the microphone. The audio from the microphone is then
amplified and fed into the transmit amplifier circuit.
(ii) If the transceiver is in the AM mode, the AF power amplifier modulates the last RF amplifier which
produces a true amplitude modulated RF signal.
3.4 TRANSMITTER AMPLIFIER CIRCUIT
The transmitter takes the basic exciter signal from the TX mixer and amplifies it through a series of
amplifiers consisting of Q50, Q51, Q49, Q47, Q48 and EPA010010A (only for RCI-6300F TB) where
it is sent out to the antenna connector.
- 10 -
Download from Www.Somanuals.com. All Manuals Search And Download.
- 11 -
Download from Www.Somanuals.com. All Manuals Search And Download.
- 12 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP / RCI-6300F TB FREQUENCY COUNTER CIRCUIT DIAGRAM
- 13 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP / RCI-6300F TB ECHO BOARD (EB-99) CIRCUIT DIAGRAM
- 14 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP
RCI-6300F TB
CHAPTER 4
ALIGNMENT
4.0 REQUIRED TEST EQUIPMENT
! DC Power Supply (13.8VDC, 20A)
" RF Wattmeter (25~60 MHz, 100W)
# Multimeter (Digital)
$ Automatic Modulation Meter
% Audio Signal Generator
& Frequency Counter (100 MHz)
' RF Signal Generator (100 MHz)
( Automatic Distortion Meter
) Oscilloscope (50 MHz)
* Sinad Meter
4.1 ALIGNMENT PROCEDURES
This transceiver has been aligned at the factory and does not require any adjustments at installation.
The required test equipment listed are used for the test setup or alignment shown in Figure 4-1
Transmitter Test Setup and Figure 4-2 Receiver Test Setup. These test setup are used in part or total
during the following adjustments and refer to Figure 4-3 for adjustment location.
4.1.1 PLL ALIGNMENT
ITEM
U.U.T. SETTING
ADJUST
POINT
MEASUREMENT
VCO Voltage
Disconnect the “short PCB” from TP7, TP8
and TP9.
Set radio to Fr Pool 6, CH 40 AM RX mode.
Set the +10KHz switch to OFF position.
Connect Multimeter to TP2.
L14
L15
6.5 VDC ± 0.1
Maximum Output
and Balance. (CH 1
& CH 40)
Connect Oscilloscope to TP3.
AM Frequency Set radio to Fr Pool 1, CH 1 AM RX mode.
Set radio to Pool 6, CH 40 AM RX mode.
L20
L17
17.5500 MHz + 20Hz
18.9600 MHz + 20Hz
Connect Frequency Counter to TP3.
TX Frequency Set radio to Fr Pool 1, CH 1 AM TX mode.
Connect Frequency Counter to TP3.
VR7
L23
17.5500 MHz + 20Hz
10.6950 MHz + 20Hz
AM OSC
Set radio to Fr Pool 1, CH 1 AM TX mode.
Connect Frequency Counter to TP5.
4.1.2 TRANSMITTER ALIGNMENT
- 15 -
Download from Www.Somanuals.com. All Manuals Search And Download.
ITEM
U.U.T. SETTING
ADJUST
POINT
MEASUREMENT
TX Power
Set radio to Fr Pool 2, CH 19 AM TX mode. L40,L42,L43, Power MAX.
Connect “short PCB” to TP7, TP8 and TP9.
Connect RF Power Meter to antenna jack.
Set RF Power Fully Clockwise.
L44
Spurious emission
Min.
L40,L42
Balance Power
between CH 1 and
CH 40.
AM TX Power Set radio to Fr Pool 2, CH 19 AM TX mode.
Modulation off.
VR14
10W (RCI-6300F HP)
50W (RCI-6300F TB)
RF Power
Meter
Set radio to Fr Pool 2, CH 19 AM TX mode. VR9
Set SWR/S-RF switch to S/RF position.
Modulation off.
Adjust RF Power
meter needle until it is
in-between the green
and red bar on PWR
scale.
AM
Modulation
Set radio to Fr Pool 2, CH 19 AM TX mode. VR16
Set Mic Gain Fully Clockwise.
90%
AF signal 30 mV, 1 KHz to microphone.
FM Deviation Set radio to Fr Pool 2, CH 19 FM TX mode.
Set Mic Gain Fully Clockwise.
VR5
4KHz
AF signal 30 mV, 1 KHz to microphone.
Frequency
Set radio to Fr Pool 2, CH 19 AM RX mode. VC1 on
Display should be
28.9150
Counter Adjust Set DIM/BRT switch to BRT position.
frequency
counter
4.1.3 RECEIVER ALIGNMENT
ITEM
U.U.T. SETTING
ADJUST MEASUREMENT
- 16 -
Download from Www.Somanuals.com. All Manuals Search And Download.
POINT
AM Sensitivity Set radio to Fr Pool 2, CH 19 AM RX mode. L2,3,5,6,7,8, Audio output > 2V
Set RF Gain Fully Clockwise.
9,10
S/N > 10 dB.
Set SQ Fully Counter Clockwise.
Set VOL Control at 2 o’clock.
Set NB-ANL/OFF switch to OFF position.
Connect RF SG to antenna jack
Frequency 28.915 MHz, 1uV. Mod 30%.
Set radio to Pool 6, CH 40 AM mode.
RF SG setting 29.655 MHz.
L5,L6
L5,L6
For Balance between
CH 1 and CH 40.
Set radio to Pool 1, CH 1 AM mode.
RF SG setting 28.245 MHz.
FM Sensitivity Set radio to Fr Pool 2, CH 19 FM RX mode.
Set MODE switch to FM mode.
L4
L1
Audio output Max
S/N > 20 dB.
RF SG setting 28.915 MHz, 0.5uV. Mod
3KHz.
NB Adjust
Set radio to Fr Pool 2, CH 19 AM RX mode
RF SG setting 28.915 MHz, 100uV. Mod off.
Set NB-ANL/OFF switch to NB/ANL
position.
DC voltage to max.
( >2.0V )
Connect Voltmeter to TP1.
AM Squelch
Set radio to Fr Pool 2, CH 19 AM RX mode. VR4 Slowly Adjust very slowly
Set SQ control fully clockwise.
RF SG setting 28.915 MHz, 1 mV. Mod 30%.
until squelch just
open
AM S/RF Meter Set radio to Fr Pool 2, CH 19 AM RX mode. VR1
Set SWR/S-RF switch to S/RF position.
RF SG setting 28.915 MHz, 100uV. Mod
30%.
Meter needle to S9
on the S scale
Figure 4-1 Transmitter test setup
- 17 -
Download from Www.Somanuals.com. All Manuals Search And Download.
Figure 4-2 Receiver test setup
- 18 -
Download from Www.Somanuals.com. All Manuals Search And Download.
Figure 4-3 Main PCB Adjustment Location
- 19 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP
RCI-6300F TB
CHAPTER 5
MAINTENANCE
5.0 PRECAUTIONS
The inherent quality of the solid-state components used in this transceiver will provide many years of
continuous use. Taking the following precautions will prevent damage to the transceiver.
(i) Never key the transmitter unless an antenna or suitable dummy load is connected to the antenna
receptacle.
(ii) Ensure that the input voltage does not exceed 16 VDC or fall below 11 VDC.
(iii) During alignment, do not transmit for more than 10 seconds at a time. Transmitting over long
periods can cause heat built-up and cause transmitter damage.
5.1 PERIODIC INSPECTION
This unit is aligned at the factory to deliver maximum performance. However, continued performance
cannot be expected without periodic inspection and maintenance. Important points to be checked
regularly are as follows;
Check Item
Whip
Action
antenna If cracked or broken, replace it.
(option)
Coaxial cable
If sheath is cracked, seal with
vinyl tape. If immersed with
water, install new coaxial cable.
Coaxial & power If loosened, reconnect. If
plug connections corroded, clean contacts.
Battery connection If corroded, clean power
terminals.
Ground terminal
If corroded, clean terminal.
5.2 FUSE REPLACEMENT
To protect the equipment from serious damage, a fuse is provided on the power supply lines. The fuse
protect against overvoltage / reverse polarity and internal fault of the equipment. If the fuse has blown,
first find out the cause of the trouble before replacing it. A fuse rated for more than the transceiver
requirement should not be used, since it may permanently damage the equipment. Damage due to
overfusing is not covered by the warranty.
CHAPTER 6
RCI-6300F HP
DIAGRAMS &
- 20 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F TB
PARTS LIST
6.0 GENERAL
Information on most electrical and mechanical parts is included in the parts list. The reference
designators are in alphanumeric order.
6.1 ORDERING REPLACEMENT PARTS
Parts orders should be referred to the Parts Department at:
• Ranger Communications, Inc.
3377 Carmel Mountain Road
San Diego, CA 92121
Tel: 858-259-0287
Fax: 858-259-0437
- 21 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP / RCI-6300F TB ROTARY SW P.C.B
ITEM REFERENCE NUMBER
RANGER PART
DESCRIPTION
NUMBER
EPT690020Z
RCY010004Z
1
2
ROTARY SW P.C.B
0 OHM 0.1W
R300-R310,D325,
D331,D336
R312-R325
R327
3
4
5
6
7
8
9
10
RCY011024Z
RCY012224Z
RCY014724Z
EDSS00355Y
TY2SC2712G
EX07N48223
EX07N48209
EWRT32000S
1K OHM 0.1W
2.2K OHM 0.1W
4.7K OHM 0.1W
DIODE 1SS355
R326
D340
Q304
TR 2SC2712GR
PCB CONN/S 2PIN
PCB CONN/S 10PIN
ROTARY SW
J303-J305
J301
S301
REMARK:
LEFT: COMPONENT SIDE (BLUE)
RIGHT: COPPER SIDE (BLUE)
- 22 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP ANT P.C.B
ITEM REFERENCE NUMBER
RANGER PART
NUMBER
DESCRIPTION
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
EPT360042Z
RCY010004Z
RCY014714Z
RCY011014Z
RCY013314Z
RCY011024Z
RCY012224Z
RCY014724Z
RCY011034Z
RCY012234Z
CK1059AB1A
CK1030AB1A
CK2104AB7R
CK1103AB7L
TY2SC2712G
EDSS00355Y
EDHM0198SY
EDMA0028TY
ECRFZ10053
RE10300009
WX01070715
ANT P.C.B
0 OHM 0.1W
R9
R1
R3,R4
R2
R5,R11
R10
R12
R7
C5
C7
C6
C3,C4
C1,C2
Q1
D3
D1,D2
D4
470 OHM 0.1W
100 OHM 0.1W
330 OHM 0.1W
1K OHM 0.1W
2.2K OHM 0.1W
4.7K OHM 0.1W
10K OHM 0.1W
22K OHM 0.1W
0.5PF 50WV
3PF 50WV
0.1uF 25WV
0.001uF 50WV
TR 2SC2712GR
DIODE 1SS355
DIODE HSM198S
DIODE MA28T
RF COIL C3RH0610
S/F/R 10K OHM
JUMPER WIRE
L1
VR1
JP1
REMARK:
COPPER SIDE (BLUE)
- 23 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F TB POWER P.C.B
ITEM REFERENCE NUMBER
RANGER PART
NUMBER
DESCRIPTION
1
EPA010010A
RCU141094Z
RCU141004Z
RCP141034Z
RCM141024A
RCP121034Z
RCP202204Z
RE10200046
RCP141024Z
POWER P.C.B
1 OHM 1/4W
2
3
4
5
6
7
8
9
R904
R905,R906
R909
10 OHM 1/4W
10K OHM 1/4W
1K OHM 1/4W
10K OHM 1/2W
22 OHM 2W
R902
R911
R903
R901,R909(R910)
BETWEEN C901 &
GROUND
T901,T902
S/F/R 1K OHM
1K OHM 1/4W
10
RFP202214Z
220 OHM 2W
ITEM REFERENCE NUMBER
RANGER PART
DESCRIPTION
- 24 -
Download from Www.Somanuals.com. All Manuals Search And Download.
NUMBER
RCY011014Z
CC0501015A
CC0500591A
CC0501037L
11
12
13
14
COPPER SIDE
C901
100 OHM 0.1W
100PF 50WV
0.5PF 50WV
0.01uF 50WV
C943
C906,C926,C932,
C937,TERMINALx2
C905,C920,C921,C923x2,
C924x2,C925,C935,C939,
C941,T901-902x2,
C927-C931,C933,C940
C918
15
CC0501047L
0.1uF 50WV
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
CD3006804Z
CD3001514Z
CD5001018Z
CD3001814Z
CD5005614Z
CD5008214Z
CD1001024Z
CX0071037Z
CE0162277Z
CE0352277Z
T2SD02531Z
T2SC02290Z
ED1N04148Z
ED1N04001Z
ECSPG18069
ECBAD18553
ECCHK16098
ECRFZ10096
ECRFZ10097
EX07N41226
EX05N40825
GZZZ50062Z
GZZZ50011Z
68PF 300WV
150PF 300WV
100PF 500WV
180PF 300WV
560PF 500WV
820PF 500WV
0.001uF 100WV
HV DISC/ C 0.01µF
220uF 16WV
220uF 35WV
TR 2SD2531
TR 2SC2290
DIODE 1N4148
DIODE 1N4001
SPRING COIL
BEAD COIL
CHOKE COIL
RF COIL
C916
C917
C908,C910,C936
C945
C909
C904
C919
C922
C938
TR903
TR901,TR902
D903,D904
D901,D902
L903,L904
L901
L902
T901
T902
RF COIL
PCB CONN/S 2PIN
RELAY
J901,J902
RL901
J903,J904
J905,J906
V TYPE JACK
C PIN
REMARK:
TOP: COMPONENT SIDE (WHITE)
BOTTOM: COPPER SIDE (WHITE)
- 25 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP / RCI-6300F TB BAND SWITCH P.C.B
ITEM REFERENCE NUMBER
RANGER PART
NUMBER
DESCRIPTION
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
EPT630030Z
RCP164704Z
RCP161024Z
ED1N04148Z
T2SC00945P
EX07N48223
EX07N48350
EX07N48490
EX07N48224
EX07W48824
EX07W48826
EX07W48827
WX01070705
WX01070710
RV10203524
RV20303560
RV50303522
EWRT32084S
EWRT32094S
BAND SWITCH P.C.B
47 OHM 1/16W
R1
R2,R3
D1
Q1
1K OHM 1/16W
DIODE 1N4148
TR 2SC945P
J1,J2,J12-J14
PCB CONN/S 2PIN
PCB CONN/S 3PIN
PCB CONN/S 4PIN
PCB CONN/S 7PIN
PCB CONN/S 3PIN
PCB CONN/S 5PIN
PCB CONN/S 6PIN
JUMPER WIRE
J7,J10
J6
J9
J11
J3
J4
JP3
JP1
MIC/RF
JUMPER WIRE
VR 1KB/1KA
VR 20KB/5KB
TALK BACK/RF PWR
VOL/SQ,ECHO/TIME
MODE
VR 50KB/50KA W/SW
ROTARY SW 3N
ROTARY SW 6N
BAND
REMARK:
COPPER SIDE (WHITE)
- 26 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP / RCI-6300F TB MIC P.C.B
ITEM REFERENCE NUMBER RANGER PART
NUMBER
DESCRIPTION
REMARK
1
2
3
4
5
6
7
8
EPT690050Z
CC0501027L
CC0501027L
CC0501037L
ECCHK16001
ECBAD18526
EX06N41020
EX07N48903
MIC P.C.B
0.001uF 50WV
0.001uF 50WV
0.01uF 50WV
C502-C504
C501
C505,C506
L501
RCI-6300F HP
CHOKE COIL 5.6uH
BEAD COIL
MIC JACK
WIRE CONN/H 3PIN
L502
1-4
MIC/GND/PTT
REMARK:
COPPER SIDE (BLUE)
- 27 -
Download from Www.Somanuals.com. All Manuals Search And Download.
- 28 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP / RCI-6300F TB COUNTER P.C.B
ITEM REFERENCE NUMBER
RANGER PART
DESCRIPTION
NUMBER
1
2
3
4
5
6
7
8
9
10
11
12
13
14
EPT900040Z
RCY010004Z
RCY011014Z
RCY013314Z
RCY014714Z
RCY012224Z
RCY014724Z
RCY011034Z
RCY012234Z
RCY013334Z
RCY014734Z
CK1150AB4A
CK1330AB4A
CK2104AB7R
COUNTER P.C.B
0 OHM 0.1W
R40
R19-R39
R6
R9
R4,R5
R7
R3,R10,R12
R13-R18
R11
R41,R42
100 OHM 0.1W
330 OHM 0.1W
470 OHM 0.1W
2.2K OHM 0.1W
4.7K OHM 0.1W
10K OHM 0.1W
22K OHM 0.1W
33K OHM 0.1W
47K OHM 0.1W
15PF 50WV
C15
C14
33PF 50WV
0.1uF 25WV
C2,C6,C8,C10,C11,C12,
C17,C19,C21,C29,C31,
C32,C33,C35,C36,C28
15
C5,C7,C16,C20,C22,
CK1103AB6U
0.01uF 50WV
C25,C38,C40
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
C13
CK1102AB7L
CK5105AA7R
YNRG0GX3SP
YNTA04073B
YNR006250F
YNT011650U
TY25C2714Z
TY2SC2712G
EDSS00355Y
YCCHK16259
CV038200AY
CEM161077A
EYCAP04500
CE0161087Z
EX07N48927
EX07N48223
EX07N48224
0.001uF 50WV
1uF 16WV
C9,C18,C27,C30,C34
U3
U2
U4,U5,U6
U1
Q3
Q1,Q2
D2,D3
L1
VC1
C1,C3
X1
IC LC7232N 18PIN
IC TC4093BFN 14PIN
IC BA6250F 16PIN
IC TK11650U 3PIN
TR 2SC2714
TR 2SC2712GR
DIODE 1SS355
CHOKE COIL 1000UH
TRIMMER/C 20PF
100UF 16WV
CRYSTAL 4.500MHz
1000UF 16WV
PCB CONN/S 12PIN
PCB CONN/S 2PIN
PCB CONN/S 7PIN
C37
COUNTER PCB x2
CN1
CN2
REMARK:
TOP: COMPONENT SIDE (BLUE)
BOTTOM: COPPER SIDE (BLUE)
- 29 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP / RCI-6300F TB LED DISPLAY P.C.B
ITEM REFERENCE NUMBER
RANGER PART
DESCRIPTION
NUMBER
EPT900022Z
EX03N40003
EX03N40476
EX01N40004
EWPS33033X
1
LED DISPLAY P.C.B
LED DISPLAY
LED DISPLAY
LED
2
3
4
5
DISPLAY PCB
1,2,3,4,5,6
TX/RX
ON,NB/ANL,R.B,S/RF,
SWR,+10K
PUSH SW.
6
7
DISPLAY PCB
TOJ10,+10K,S/RF,
M-M+
EX07N48928
EX07N48223
PCB CONN/S 12PIN
PCB CONN/S 2PIN
8
9
10
TOJ2,TOJ6
RX/G/TX
EX07N48350
EX07N48947
EX07W48824
PCB CONN/S 3PIN
PCB CONN/S 3PIN
PCB CONN/S 4PIN
TOJ13
REMARK:
TOP: COMPONENT SIDE (BLUE)
BOTTOM: COPPER SIDE (BLUE)
- 30 -
Download from Www.Somanuals.com. All Manuals Search And Download.
- 31 -
Download from Www.Somanuals.com. All Manuals Search And Download.
PART LIST:
RCI-6300F HP / RCI-6300F TB ECHO P.C.B (EB-99)
ITEM REFERENCE NUMBER
RANGER PART
DESCRIPTION
NUMBER
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
EPT0SSB50F
RCY011014Z
RCY014714Z
RCY011024Z
RCY012224Z
RCY014724Z
RCY011034Z
RCY012234Z
RCY013334Z
RCY014734Z
RCY011044Z
CK1331AB5A
CK1561AB5A
CK1102AB7L
CK2103AB7R
CK2104AB7R
ECHO P.C.B
10 OHM 0.1W
470 OHM 0.1W
1K OHM 0.1W
2.2K OHM 0.1W
4.7K OHM 0.1W
10K OHM 0.1W
22K OHM 0.1W
33K OHM 0.1W
47K OHM 0.1W
100K OHM 0.1W
330PF 50WV
R3,R16
R28
R27
R7
R17,R29
R1,R23,R24,R30,R26
R18
R2,R5,R6,R13,R15,R22
R14,R20,R4
R21
C26
C5
C12,C14
560PF 50WV
0.001uF 50WV
0.01uf 25WV
C4,C11,C23,C34
C2,C3,C10,C16,C28,C29,
0.1Uf 25WV
C30,C32,C33,C36,C37,
C38,C39,C40,C18,C35
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
C6,C31,C20,C22
CK510AB7R
CK1152AB7R
CK1472AB6U
CK5105ZZ7R
CK5225AA7R
YNJR04558M
YNES56033S
TY2SC2712G
EDSS00355Y
EDZD05569Y
CE0164767Z
EX07N41216
EX07N41227
EX07N48223
EX07N48331
1uF 16WV
0.0015uF 50WV
.0047uF 50WV
1uF 16WV
2.2uF 16WV
C13
C19
C25
C1
IC1
IC2
IC NJM4558M 8PIN
IC ES56033S 16PIN
TR 2SC2712GR
DIODE 1SS355
ZENER DIODE 5.6V
47uF 16WV
PCB CONN/S 3PIN
PCB CONN/S 3PIN
PCB CONN/S 2PIN
PCB CONN/S 6PIN
Q1,Q3
D1,D2,D4,D5,D6
D3
C27
J3
J2
J1
J6
REMARK:
TOP: COMPONENT SIDE (WHITE)
BOTTOM: COPPER SIDE (BLUE)
- 32 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP / RCI-6300F TB MAIN PCB.
REMARK:
COPPER SIDE (WHITE)
- 33 -
Download from Www.Somanuals.com. All Manuals Search And Download.
C195
C24,287
C8
C4,53
C137
C56,222
C28
C31,136
C11,14
C23
C197
C225
CC0501804L
CC0503304L
CC0508204L
CC0501015L
CC0501515L
CC0501815L
CC0502215L
CC0502715L
CC0503315L
CC0505615L
CC0500101A
CC0500201A
CC0500301A
CC0500501A
CC0501504A
CC0501804A
CC0502704A
CC0504704A
CC0506804A
CC0508204A
CC0501515A
CC0501815A
CC0503904D
CC0501015G
CC0501815G
CC0506804G
CC0501215G
CC0502215G
CC0502715G
CC0503915G
CC0504715G
CD3005614Z
CC0501027L
18PF 50WV
33PF 50WV
82PF 50WV
100PF 50WV
150PF 50WV
180PF 50WV
220PF 50WV
270PF 50WV
330PF 50WV
560PF 50WV
1PF 50WV
PART LIST
RCI-6300F HP MAIN PCB
REFERENCE
NUMBER
RANGER
PART NO.
EPT690010Z
RCP164794Z
RCP161504Z
RCP162204Z
RCP164704Z
DESCRIPTION
MAIN P.C.B
4.7 Ω 1/16W
15 Ω 1/16W
22 Ω 1/16W
47 Ω 1/16W
R246
R267
R241,242
R133,213,253,282,
VR10,VR11
R130,215,220
R11
R3,5,8,30,33,76,81,
259,260,263,JP237
R32,249
2PF 50WV
3PF 50WV
5PF 50WV
C286
RCP165604Z
RCP166804Z
RCP161014Z
56 Ω 1/16W
68 Ω 1/16W
100 Ω 1/16W
C61,62,90,226,218
C89
C43
C84
C202
C88,116,117
C192
C194
C196,295
C139
C281
C282
C124
C123
C220
C86
C85,201,203
C209,210
C199
C7,47,50,74,95,99,
100,110,118,120,174,
183,244,246,245,
C161
15PF 50WV
18PF 50WV
17PF 50WV
47PF 50WV
68PF 50WV
82PF 50WV
150PF 50WV
180PF 50WV
39PF 50WV
100PF 50WV
180PF 50WV
68PF 50WV
120PF 50WV
220PF 50WV
270PF 50WV
390PF 50WV
470PF 50WV
560P 300WV
0.001UF
RCP161514Z
RCP161814Z
RCP162214Z
RCP162714Z
150 Ω 1/16W
180 Ω 1/16W
220 Ω 1/16W
270 Ω 1/16W
330 Ω 1/16W
R23
R140,163,177
R31
R6,10,16,24,248,254, RCP163314Z
300
R141,188,268,293
R258,266
R4,50,209
R74
R36,62,64,67,72,115, RCP161024Z
116,118,123,136-138,
143,144,160,164,179,
186,189,205,214,232,
261,291,292,295,303,
206,237
RCP164714Z
RCP165614Z
RCP166814Z
RCP168214Z
470 Ω 1/16W
560 Ω 1/16W
680 Ω 1/16W
820 Ω 1/16W
1KΩ 1/16W
R192
RCP161224Z
1.2KΩ 1/16W
1.5KΩ 1/16W
50WV
R132,207,233,247,255 RCP161524Z
,273,79,80
CC0501537L
CC0501047L
0.015UF
50WV
0.1UF 50WV
R226
RCP161824Z
1.8KΩ 1/16W
2.2KΩ 1/16W
R20,27,71,73,75,134, RCP162224Z
162,122,283
R9,25,28
R18,22,58,66,128,129 RCP163324Z
,191,219,274,277
R52,57
R26,35,131,165,190,
195,196
R264,265
R14,40,41,82,127,148 RCP166824Z
,297
C81,83,111,113,126,
173,193,206,207,211-
213,228,234,236,249,
250,256,259,268,272,
280,288,292,296
(COPPER SIDE),C270,
C177,R302
C5,18,20,48,65,87,92 CC0504737L
,96,102,105,106,151,
160,233,251-253,257,
258,260-263,240
C32,42,45,46,221,162 CC0504727L
,163
RCP162724Z
2.7KΩ 1/16W
3.3KΩ 1/16W
RCP163924Z
RCP164724Z
3.9KΩ 1/16W
4.7KΩ 1/16W
0.047uF
50WV
RCP165624Z
5.6KΩ 1/16W
6.8KΩ 1/16W
R275
RCP168224Z
RCP161034Z
8.2KΩ 1/16W
10KΩ 1/16W
0.0047UF
50WV
0.022UF
50WV
0.01UF
100WV
0.01UF 50WV
R1,13,17,37,38,65,
142,145,159,161,168,
175,181,202,216,227-
231,272,276,294,296,
262,68
R178
C155
CC0502237L
CC1001037L
CC0501037L
C200
RCP161234Z
RCP161534Z
RCP162234Z
RCP162734Z
RCP163334Z
RCP163934Z
12KΩ 1/16W
15KΩ 1/16W
22KΩ 1/16W
27KΩ 1/16W
33KΩ 1/16W
39KΩ 1/16W
47KΩ 1/16W
C2,3,6,9,15-17,19,
25,51,57,58,60,109,
114,121,138,188,189,
205,216,217,219,223,
229,230,232,247,254,
255,265,267,269,271,
277,278,285,184
C154
R180
R187,208
R121
R2
R46
R7,29,61,63,126,185, RCP164734Z
218,234,235,236,224,
222.
CT0162246Z
CT0164746Z
0.22UF 16WV
T/C0.47UF
16WV
2.2UF 16WV
1UF 16WV
0.1UF 50WV
0.001UF
50WV
0.01UF 50WV
0.022UF
50WV
0.0047UF
50WV
C97
R21,85,105,107
RCP166834Z
RCP168234Z
RCP161044Z
68KΩ 1/16W
82KΩ 1/16W
100KΩ
R45
C98
C112
C40,178,171,235
C26,27,237
CT0162256Z
CT0161056Z
CM0501045Z
CM0501025Z
R12,42-44,51,53,77,
78,104,108,112,182,
184,225,256,257,278,
1/16W
221
R47,59,117,135,139,
RCP162244Z
220KΩ 1/16W
C29,78,185,41
C39
CM0501035Z
CM0502235Z
194
R49,55,176
R15,34,111,183
R48
RCP162744Z
RCP164744Z
RCP168244Z
RCP161054Z
RCP161554Z
RCP161064Z
RCP142204Z
RCP121514Z
RCP121034Z
CC0501004L
270KΩ 1/16W
470KΩ 1/16W
820KΩ 1/16W
1MΩ 1/16W
1.5MΩ 1/16W
10MΩ 1/16W
22 Ω 1/4W
150 Ω 1/2W
10KΩ 1/2W
10PF 50WV
C176
CM0504725Z
R106
R193
R124
JP264
C34
C12,30,101
CM0504735Z
CM0502225Z
.047UF 50WV
.0022UF
50WV
0.47UF 50WV
1UF 50WV
C10
CE0504747Z
CE0501057Z
R243,244
R239
C1,49,108,119,122,
279,147
C224
C67,75,153,157,170,
186,187,198
C159,214,148
C38,103,182
CE0502257Z
CE0504757Z
2.2UF 50WV
4.7UF 50WV
10UF 25WV
CC0501504L
15PF 50WV
C13,21,22,44,82,115, CE0251067Z
- 34 -
Download from Www.Somanuals.com. All Manuals Search And Download.
158,275,276
C80,181
C37,175
C107,156,238,293
C152,179
C91
C243,248
C35
FL1
L13,39,41
VR16
VR14,18
VR1,5
VR9
VR4
RA1
RA2
RA3
C165-R223
C167-R223
J29
JP1-3,4,7,9,23,24-26 WX01060605
,32,33,38,39,50,54-
57,59,61,62,63,65,66
,71,72,79,80,82,85,
86,87,93,100,105,106
,114,115,118-122,124
-126,190,135,138-140
,144,145,152,153,156
,157,159,160,128,165
,166,168,170,172,174
,175,177-179,181,184
,188,91,190
JP200-202,204,205,
209-211,212,214,217,
219,220,224,226,231-
233,235,236,238,239,
242,243,245,250,252,
253,255-260,262,263,
265,271-273,276,278-
280,285,267x2,R245,
R305,R89,C142,C291,
D26,D46,D50,D95,D49-
L46,TP8,C133
R19,119
ECBAD18526
RE10200041
RE50200042
RE10300031
RE10400043
RE50400087
RCS0870014
RCS0970015
RCS0670025
WL0007009Z
WL0207009Z
WX01070703
BEAD COIL
S/F/R 1K
S/F/R 5K
S/F/R 10K
S/F/R 100K
S/F/R 500K
R/ARRAY
R/ARRAY
R/ARRAY
LEAD WIRE
LEAD WIRE
J/W 7x3x7
J/W 6x5x6
CE0252267Z
CE0254767Z
CE0161077Z
CE0163377Z
CE0104777Z
CE0251087Z
CEM254767Z
EFCFW455HT
22UF 25WV
47UF 25WV
100UF 16WV
330UF 16WV
470UF 10WV
1000UF 25WV
47UF 25WV
C/FILTER
455HT
C/FILTER
10.7MX RED
CRYSTAL
10.240MHZ
CRYSTAL
15.360MHZ
CRYSTAL
12.660MHZ
CRYSTAL
10.6975MHZ
NJM324D
MC145106
MC14008BCP
NJM4558D
TDA6130
FL2
X1
X2
X3
X4
EFCFE107MX
EYCAB10240
EYCAA15360
EYBAA12660
EYBAE10697
IC1
IC3
IC4,5
IC7
IC9
VCO
Q8,17
Q51
Q52
Q26,36
Q24,43
Q30,33,62
Q1,2,9,10-12,25,27,
28,29,46,61
Q60
Q3-5,7,14,16,31,35,
39,42,44,53,57,58,40
Q6,38
ENJR00324D
ENMC45106P
ENMC14008B
ENJR04558D
ENSM06130Z
ENRG0IC090
T2SC01674L
T2SC02538Z
T2SC01906Z
TDTC0124ES
TDTC0114ES
T2SA01282E
T2SC01675L
WX01070705
J/W 7x5x7
IC090 10PIN
2SC1674L
2SC2538
2SC1906
DTC124ES
DTC114S
2SA1282AE
2SC1675
TDTA0124ES
T2SC00945P
DTA124ES
2SC945P
WX01070706
WX01070708
WX01060610
J/W 7x6x7
J/W 7x8x7
J/W 6x10x6
D25
T2SA00733P
T2SA01869Z
FM0J00310Z
ED1N04148Z
2SA733P
2SA1869
F.E.T J310
DIODE
JP6,11,12,16-19,34-
37,40-49,51-53,58,60
,67,70,88,96,101-104
,107-109,116,117,127
,129,133,136,137,143
,147,148,151,161,167
,169,176,131,132,111
,130
JP215,218,222,223,
225,227,228,230,234,
241,244,246-249,251,
254,261,266,277,286,
287,240,IC6,C128-L45
,L36
Q55
Q18,19
D3,5,7-10,13,14,20-
23,27,33,34,35,37,
40,53,60-65,69,75-
82,84,85,88-91,97,
102,106,107,111-141,
143,144,147,149,150,
JP191
D1,2,11,12,30,31
D110
D109
1N4148
WX01070710
J/W 7x10x7
ED1N00060P
ED1N04003Z
ED1N04007Z
EDSS00053Z
1N60P
1N4003
1N4007
ISS53
D16,17
JP75-78,81,193
JP99
FL3
TP7-TP8,TP8-TP9
J7x2,10,17,22,Q41
J2,3,6,11,18
J21
J5,20
J13
J14
J1
J28
J12
J16
J4
J28
TP2,3,5
EXT SP,CW/PA
DC SOCKETx2
IC8
WX01070712
WX01070713
WX01070715
WX01070718
EX07N48223
EX07N48350
EX07N48490
EX07N48222
EX07N48331
EX07N48224
EX07N48543
EX07N48244
EX07N41227
EX07N41330
EX07N49140
EX07N48151
EX07N48612
EX06N41045
CC0501037L
ENTA07222A
T2SB00754Y
T2SC02166C
T2SC02312C
T2SA01869Z
EDLT6A400Z
J/W 7x12x7
J/W 7x13x7
J/W 7x15x7
J/W 7x18x7
P/C/S 3P
P/C/S 3P
P/C/S 4P
P/C/S 5P
P/C/S 6P
P/C/S 7P
P/C/S 9P
P/C/S 3P
P/C/S 3P
P/C/S 2P
P/C/S 2P
P/C/H
P/C/S 1PIN
EAR JACK
0.01uF 50WV
IC TA7222AP
TR 2SB754Y
TR 2SC2166C
TR 2SC2312C
TR 2SA1869
DIODE
D59,72
D71,145
D18,19,42,99,100,
146,148
D70
D73
L2,3
L6
L17,20
L23
L1
EDMA00027W
EDMA00027T
EDSV00251Z
MA27W-A
MA27T-A
SVC-251SPA
EDZD05519Z
EDZD05759Z
ECIFT12002
ECIFT12290
ECIFT12012
ECIFT12016
ECIFT12252
ECIFT12255
ECIFT12256
ECIFT12258
ECIFT12262
ECIFT12558
ECIFT12253
ECIFT12440
ECIFT12492
ECIFT12526
ECCHK16000
ECCHK16004
ECCHK16070
ECCHK16176
ECCHK16246
ECSPG18003
ECSPG18077
ECSPG18075
ECSPG18365
ECSPG18001
ECRFZ10048
5.1V 0.5W
7.5V 0.5W
I.FT
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
CHOKE COIL
CHOKE COIL
CHOKE COIL
CHOKE COIL
CHOKE COIL
SPRING COIL
SPRING COIL
SPRING COIL
SPRING COIL
SPRING COIL
RF COIL
L44
L9,10
L15,43
L40
L14
L5
L7,42
L8
L4
L503,504
T1
L34,37,33
L47
L16
L28
L30
L29
L31
L35
L38
Q54
Q49
Q47,48
Q37
DC SOCKET
LT6A400
- 35 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP MISC. PARTS
REFERENCE
RANGER
DESCRIPTION
NUMBER
PART NO.
-
-
-
MM7878041B
MT3001021X
MT3600050X
HEAT SINK
SET CHASSIS
DC SOCKET
HOLDER
2SB754Y
XZZZ90020Z
XZZZ90003Z
XZZZ90358Z
INSULATING
PLATE
INSULATING
PLATE
INSULATING
PLATE
Q47,48,49
Q47,48,49
IC8
DC(2)
Q37
Q47,48,49
IC8
Q54
LZZZ61008Z
JS053006MN
JS052006MN
JS052012MN
JS013006MV
JS052010MN
JS013008TN
XZZZ90098Z
IC SHIELD B
SET SCREW
SET SCREW
SET SCREW
SET SCREW
SET SCREW
SET SCREW
SOLDER
HEAT SINK
ANT JACK(1),MIC
JACK(1)
PLATE
-
-
-
-
-
-
ES300835SQ
PT9000060K
PT9000020E
PT9000040E
PT9000050E
PT3600080A
SPEAKER
FRONT PANEL
CH KNOB
INNER KNOB
OUTER KNOB
SIGNAL
METER
HOLDER
BAND KNOB
COUNT
-
-
PT9000070E
PT2100031C
WINDOW
DISPLAY
WINDOW
-
PT2100041C
-
-
PT7001070C
MT9000010X
PUSH KEY
FRONT
CHASSIS
CHANNEL
BRACKET
TOP HOUSING
BOTTOM
-
MT3600040S
-
-
MT3600061X
MT36000710
HOUSING
HANDLER
FOAM
FOAM
SPONGE
CLAMP
SOLDER
-
-
-
-
-
-
MT3600030S
XZZZ90004Z
XZZZ90005Z
XZZZ90367A
GZZZ50000Z
XZZZ90098Z
PLATE
FOAM
INSULATING
PLATE
-
-
XZZZ90021Z
XZZZ90064Z
COUNTER
XZZZ90363Z
PVC STAND
OFF
COUNTER
JS013016WH
JS033008MN
JS052004MN
SET SCREW
SET SCREW
SET SCREW
FRONT PANEL(4)
TONE(2),CH9(2),
WB/ANL(2)
SWR SW(2)
CH BKT(2),
CHASSIS(12)
SPK(4)
JS052605MN
JS053006MN
SET SCREW
SET SCREW
JS053008MN
JS053006TN
JN263035ZS
SET SCREW
SET SCREW
NUT WITH
WASHER
MAIN PCB(5)
SPK(4)
-
HZZZ76005Z
SSEBRIH K
905
- 36 -
Download from Www.Somanuals.com. All Manuals Search And Download.
R106
R193
R124
JP264
R244
R239
RCP161054Z
RCP161554Z
RCP161064Z
RCP142204Z
RCP121514Z
RCP121034Z
CC0501004L
1MΩ 1/16W
1.5MΩ 1/16W
10MΩ 1/16W
22 Ω 1/4W
150 Ω 1/2W
10KΩ 1/2W
10PF 50WV
C1,49,108,119,122,
279,147
C224
C195
C24,287
C8
C4,53
C137
C56,222
C28
C31,136
C11,14
C23
C197
C225,52
C61,62,90,226,218
C89
C43
C84
C202
C88,116,117
C192,8
C194
C196,295
C139
C281
C282
C124
C123
C220
C86
C85,201,203
C209,210
C199
CC0501504L
CC0501804L
CC0503304L
CC0508204L
CC0501015L
CC0501515L
CC0501815L
CC0502215L
CC0502715L
CC0503315L
CC0505615L
CC0500101A
CC0500201A
CC0500501A
CC0501504A
CC0501804A
CC0502704A
CC0504704A
CC0506804A
CC0508204A
CC0501515A
CC0501815A
CC0503904D
CC0501015G
CC0501815G
CC0506804G
CC0501215G
CC0502215G
CC0502715G
CC0503915G
CC0504715G
CD3005614Z
CC0501027L
15PF 50WV
18PF 50WV
33PF 50WV
82PF 50WV
100PF 50WV
150PF 50WV
180PF 50WV
220PF 50WV
270PF 50WV
330PF 50WV
560PF 50WV
1PF 50WV
PART LIST
RCI-6300F TB MAIN PCB
REFERENCE
NUMBER
RANGER
PART NO.
DESCRIPTION
EPT690010Z
RCP164794Z
RCP161504Z
RCP162204Z
RCP163304Z
RCP164704Z
RCP165604Z
RCP166804Z
RCP161014Z
MAIN P.C.B
4.7 Ω 1/16W
15 Ω 1/16W
22 Ω 1/16W
33 Ω 1/16W
47 Ω 1/16W
56 Ω 1/16W
68 Ω 1/16W
100 Ω 1/16W
R246
R267
R241,VR10
J3(2-4P)
R133,213,253,282
R130,215,220,249
R11
R3,5,8,30,33,76,81,
259,260,263,JP237
R32
R23
R140,163,177
R31
2PF 50WV
5PF 50WV
15PF 50WV
18PF 50WV
17PF 50WV
47PF 50WV
68PF 50WV
82PF 50WV
150PF 50WV
180PF 50WV
39PF 50WV
100PF 50WV
180PF 50WV
68PF 50WV
120PF 50WV
220PF 50WV
270PF 50WV
390PF 50WV
470PF 50WV
560P 300WV
0.001UF
RCP161514Z
RCP161814Z
RCP162214Z
RCP162714Z
150 Ω 1/16W
180 Ω 1/16W
220 Ω 1/16W
270 Ω 1/16W
330 Ω 1/16W
R6,10,16,24,248,254, RCP163314Z
300
R141,188,268,293
R258,266
R4,50,209
R74
R36,62,64,67,72,115, RCP161024Z
116,118,123,136-138,
143,144,160,164,179,
186,189,205,214,232,
261,291,292,295,303,
206,L5
RCP164714Z
RCP165614Z
RCP166814Z
RCP168214Z
470 Ω 1/16W
560 Ω 1/16W
680 Ω 1/16W
820 Ω 1/16W
1KΩ 1/16W
C7,47,50,74,95,99,
100,110,118,120,174,
183,244,246,245
C161
50WV
R192
RCP161224Z
1.2KΩ 1/16W
1.5KΩ 1/16W
R132,207,233,247,255 RCP161524Z
,273,79,80
CC0501537L
CC0501047L
0.015UF
50WV
0.1UF 50WV
R226
L7
RCP161824Z
RCP162024Z
1.8KΩ 1/16W
2KΩ 1/16W
2.2KΩ 1/16W
C81,83,111,113,126,
173,193,206,207,211,
213,228,234,236,249,
250,256,259,268,272,
280,288,292,296
R20,27,71,73,75,134, RCP162224Z
162,122,283
R9,25,28
R18,22,58,66,128,129 RCP163324Z
,191,219,274,277
RCP162724Z
2.7KΩ 1/16W
3.3KΩ 1/16W
(COPPER SIDE),C270,
C177,R302
R52,57
R26,35,131,165,190,
195,196
R264,265
R14,40,41,82,127,148 RCP166824Z
,297,70
RCP163924Z
RCP164724Z
3.9KΩ 1/16W
4.7KΩ 1/16W
C5,18,20,48,65,87,92 CC0504737L
,96,102,105,106,151,
160,233,251-253,257,
258,260-263,240
C32,42,45,46,221,162 CC0504727L
,163
0.047uF
50WV
RCP165624Z
5.6KΩ 1/16W
6.8KΩ 1/16W
0.0047UF
50WV
0.022UF
50WV
0.01UF
100WV
R275
RCP168224Z
RCP161034Z
8.2KΩ 1/16W
10KΩ 1/16W
C155
CC0502237L
R1,13,17,37,38,65,
142,145,159,161,168,
175,181,202,216,227-
C200
CC1001037L
231,272,276,294,296,
262,68
R178
R180
R187,208
R121
C2,3,6,9,15-17,19,25 CC0501037L
,51,57,58,60,109,114
,121,138,188,189,205
,216,217,219,223,229
,230,232,247,254,255
,265,267,269,271,277
,278,285,184
0.01UF 50WV
RCP161234Z
RCP161534Z
RCP162234Z
RCP162734Z
RCP163334Z
RCP163934Z
12KΩ 1/16W
15KΩ 1/16W
22KΩ 1/16W
27KΩ 1/16W
33KΩ 1/16W
39KΩ 1/16W
47KΩ 1/16W
R2
R46
C154
C97
C98
C112
C40,178,171,235
C26,27,237,39
CT0162246Z
CT0164746Z
CT0162256Z
CT0161056Z
CM0501045Z
CM0501025Z
0.22UF 16WV
0.47UF 16WV
2.2UF 16WV
1UF 16WV
0.1UF 50WV
0.001UF
50WV
0.01UF 50WV
0.022UF
50WV
0.0047UF
50WV
.047UF 50WV
.0022UF
R7,29,61,63,126,185, RCP164734Z
218,234,235,236,224,
222.
R21,85,105,107
R45
R12,42-4,51,53,77,78
,104,108,112,182,184
,225,256,257,278,221
R47,59,117,135,139,
194
RCP166834Z
RCP168234Z
68KΩ 1/16W
82KΩ 1/16W
C29,185
C41
CM0501035Z
CM0502235Z
RCP162244Z
220KΩ 1/16W
C176
CM0504725Z
R49,55,176
R15,34,111,183
R48
RCP162744Z
RCP164744Z
RCP168244Z
270KΩ 1/16W
470KΩ 1/16W
820KΩ 1/16W
C34
C12,30,101
CM0504735Z
CM0502225Z
- 37 -
Download from Www.Somanuals.com. All Manuals Search And Download.
50WV
L47
L16
L28
L30
L29
L31
L35
L38
L13,39,41
VR16,18
VR14
VR1,5
VR9
VR4
RA2
RA1
RA3
R201-R223
R223-R198
JP1-3,4,7,9,23,24-26 WX01060605
,32,33,38,39,50,54-
57,59,61,62,63,65,66
,71,72,79,80,82,85,
86,87,93,100,105,106
,114,115,118-122,124
-126,190,135,138-140
,144,145,152,153,156
,157,159,160,128,165
,166,168,170,172,174
,175,177-179,181,184
,188,125
JP200-202,204,205,
209,211,212,214,217,
219,220,224,226,231-
233,235,236,238,239,
242,243,245,250,252,
253,255-260,262,263,
265,271-273,276,278-
280,285,267x2,R119,
R305,R89,R19,C142,
C291,C128,C129,D26,
D46,D50,D49-L46,TP8,
C133,D95
ECCHK16176
ECCHK16246
ECSPG18003
ECSPG18077
ECSPG18075
ECSPG18365
ECSPG18001
ECRFZ10048
ECBAD18526
RE10200041
RE50200042
RE10300031
RE10400043
RE50400087
RCS0870014
RCS0970015
RCS0670025
WL0007009Z
WL0207009Z
CHOKE COIL
CHOKE COIL
SPRING COIL
SPRING COIL
SPRING COIL
SPRING COIL
SPRING COIL
RF COIL
BEAD COIL
S/F/R 1K
S/F/R 5K
S/F/R 10K
S/F/R 100K
S/F/R 500K
R/ARRAY
C78
C10
CM0502245Z
CE0504747Z
CE0501057Z
.22UF 50WV
0.47UF 50WV
1UF 50WV
C67,75,153,157,170,
186,187,198
C159,214,148
C38,103,182
C13,21,22,44,82,115, CE0251067Z
158,275,276
C80,181
C37,175
C107,156,238,293
C152,179
C91
C243,248
C35
CE0502257Z
CE0504757Z
2.2UF 50WV
4.7UF 50WV
10UF 25WV
CE0252267Z
CE0254767Z
CE0161077Z
CE0163377Z
CE0104777Z
CE0251087Z
CEM254767Z
EFCFW455HT
22UF 25WV
47UF 25WV
100UF 16WV
330UF 16WV
470UF 10WV
1000UF 25WV
47UF 25WV
C/FILTER
455HT
C/FILTER
10.7MX RED
CRYSTAL
10.240MHZ
CRYSTAL
15.360MHZ
CRYSTAL
12.660MHZ
CRYSTAL
10.6975MHZ
I.C.NJM324D
MC145106
MC14008BCP
NJM4558D
TDA6130
IC090 10PIN
2SC1674L
2SC2538
R/ARRAY
R/ARRAY
LEAD WIRE
LEAD WIRE
J/W 6x5x6
FL1
FL2
X1
X2
X3
X4
EFCFE107MX
EYCAB10240
EYCAA15360
EYBAA12660
EYBAE10697
IC1
IC3
IC4,5
IC7
IC9
VCO
Q8,17
Q51
Q52
Q26,36
Q24,43
Q30,33,62
Q1,2,9,10-12,25,27,
28,29,46,61
Q60
Q3-5,7,14,16,31,35,
39,42,44,53,57,58,40
Q6,38
ENJR00324D
ENMC45106P
ENMC14008B
ENJR04558D
ENSM06130Z
ENRG0IC090
T2SC01674L
T2SC02538Z
T2SC01906Z
TDTC0124ES
TDTC0114ES
T2SA01282E
T2SC01675L
WX01070705
J/W 7x5x7
2SC1906
DTC124ES
DTC114S
2SA1282AE
2SC1675
TDTA0124ES
T2SC00945P
DTA124ES
2SC945P
R19,119
D25
WX01070706
WX01070708
WX01060610
J/W 7x6x7
J/W 7x8x7
J/W 6x10x6
T2SA00733P
T2SA01869Z
FM0J00310Z
ED1N04148Z
2SA733P
2SA1869
F.E.T J310
DIODE
JP6,11,12,16-19,34-
37,40-49,51-3,58,60,
67,70,88,96,101-104,
107-109,116,117,127,
129,133,136,137,143,
147,148,151,161,167,
169,176,131,132,240
JP215,218,222,223,
225,227,228,230,234,
241,244,246-249,251,
254,261,266,277,286,
287,IC6,L36
JP75-78,81
JP99
FL3
TP7-TP8,TP8-TP9
J7x2,10,17,22,Q41
J2,3,6,11,18
J21
J5,20
J13,7
J14
J1
J28
J12
J16
J28
TP2,3,5
IC8
Q54
Q49
Q47
Q37
Q55
Q18,19
D3,5,7-10,13,14,20-
23,27,33,34,35,37,40
,53,60-65,69,75-82,
84,85,88-90,97,102,
106,107,111-141,143,
144,147,149,150,
JP191
D1,2,11,12,30,31
D110
D109
1N4148
WX01070710
J/W 7x10x7
ED1N00060P
ED1N04003Z
ED1N04007Z
EDSS00053Z
1N60P
1N4003
1N4007
ISS53
WX01070712
WX01070713
WX01070715
WX01070718
EX07N48223
EX07N48350
EX07N48490
EX07N48222
EX07N48331
EX07N48224
EX07N48543
EX07N48244
EX07N41227
EX07N41330
EX07N48151
EX07N48612
ENTA07222A
T2SB00754Y
T2SC02166C
T2SC01969C
T2SA01869Z
J/W 7x12x7
J/W 7x13x7
J/W 7x15x7
J/W 7x18x7
P/C/S 3P
P/C/S 3P
P/C/S 4P
P/C/S 5P
P/C/S 6P
P/C/S 7P
P/C/S 9P
P/C/S 3P
P/C/S 3P
P/C/S 2P
P/C/H
P/C/S 1PIN
IC TA7222AP
TR 2SB754Y
TR 2SC2166C
TR 2SC1969C
TR 2SA1869
D16,17
D59,72
D71,145
EDMA00027W
EDMA00027T
MA27W-A
MA27T-A
SVC-251SPA
D18,19,42,99,100,146 EDSV00251Z
,148
D70
D73
L2,3
L6
L17,20
L23
L1
EDZD05519Z
EDZD05759Z
ECIFT12002
ECIFT12290
ECIFT12012
ECIFT12016
ECIFT12252
ECIFT12255
ECIFT12256
ECIFT12258
ECIFT12262
ECIFT12558
ECIFT12253
ECIFT12440
ECIFT12492
ECIFT12526
ECCHK16000
ECCHK16004
ECCHK16070
5.1V 0.5W
7.5V 0.5W
I.FT
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
I.F.T
L44
L9,10
L15,43
L40
L14
L5
L7,42
L8
L4
L503,504
T1
L37,33
CHOKE COIL
CHOKE COIL
CHOKE COIL
- 38 -
Download from Www.Somanuals.com. All Manuals Search And Download.
Q47,49
IC8
JS052012MN
JS013006MV
JS052010MN
JN242012ZS
SET SCREW
SET SCREW
SET SCREW
NUT
-
Q47,49
RCI-6300F TB MISC. PARTS
REFERENCE
RANGER
DESCRIPTION
NUMBER
PART NO.
-
-
-
-
-
-
PT9000060K
PT9000020E
PT9000070E
PT9000040E
PT9000050E
PT2100041C
FRONT PANEL
CH KNOB
BAND KNOB
INNER KNOB
OUTER KNOB
DISPLAY
WINDOW
-
PT3600080A
SIGNAL
METER
HOLDER
COUNT
-
PT2100031C
WINDOW
PUSH KEY
FRONT
-
-
PT7001070C
MT9000010X
CHASSIS
CHANNEL
BRACKET
TOP HOUSING
BOTTOM
-
MT3600040S
-
-
MT3600061X
MT3600071N
HOUSING
HANDLER
FOAM
CLAMP
SHIELD
-
-
-
-
MT3600030S
XZZZ90004Z
GZZZ50000Z
LZZZ60001Z
CLOTH
SOLDER
-
XZZZ90098Z
PLATE
FOAM
INSULATING
PLATE
-
-
XZZZ90021Z
XZZZ90064Z
-
BA0112010P
XZZZ90363Z
MIC PLATE
PVC STAND
OFF
SET SCREW
SET SCREW
SET SCREW
COUNTER
COUNTER
JS013016WH
JS033008MN
JS053006MN
FRONT PANEL(4)
CH BKT(2),
CHASSIS(12)
SPK(4)
MAIN PCB(5)
SPK(4)
JS053008MN
JS053006TN
JN263035ZS
XZZZ90008Z
XZZZ90007Z
SET SCREW
SET SCREW
NUT
MIC STOPPER
MOUNTING
SCREW
-
-
-
-
-
JS015010WH
JS013509TH
JW315510CN
SET SCREW
SET SCREW
OUT-TOOTH
WASHER
-
-
XZZZ90188Z
HZZZ76005Z
FIBER
WASHER
SSSEBRIH K
905
-
MT3600200X
XZZZ90020Z
SET CHASSIS
INSULATING
PLATE
2SB754Y
Q47,49
Q47,49
XZZZ90003Z
XZZZ90358Z
INSULATING
PLATE
INSULATING
PLATE
IC8
Q37
LZZZ61008Z
JS052006MN
IC SHIELD B
SET SCREW
- 39 -
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP SCHEMATIC DIAGRAM
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F TURBO SCHEMATIC DIAGRAM
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F HP EXPLODE DRAWING
Download from Www.Somanuals.com. All Manuals Search And Download.
RCI-6300F TURBO EXPLODE DRAWING
Download from Www.Somanuals.com. All Manuals Search And Download.
AT6300040A
COPYRIGHT 1999, RANGER COMMUNICATIONS INC.
Download from Www.Somanuals.com. All Manuals Search And Download.
|