KITCHEN FAUCETS
Installation Instructions and Use & Care Guide
For questions about features, operation/performance, parts, accessories, or service, call: 1-800-422-1230 or visit our website at...
Model Series
KKFV01LP
Model Series
KKFV01SP
Model Series
KKFV01PP
READ AND SAVE THESE INSTRUCTIONS
FOR RESIDENTIAL USE ONLY
IMPORTANT:
Installer: Leave installation instructions with the homeowner.
Homeowner: Keep installation instructions for future reference.
8559765B
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Working from under the sink or countertop, reinstall the parts
onto the threaded shank of the faucet in the following order:
flat rubber washer, white triangular support, flat metal washer,
and threaded collar.
10. Move the faucet lever to the closed (forward) position and
open supply valves. Check connections for leaks.
11. Remove the aerator from the faucet and flush the hot and
cold lines until water is clear.
NOTE: The aerator is in the end of the faucet. To remove and
replace aerator, see “Aerator Assembly” in the “Faucet Care”
section.
A
B
12. Reinstall the aerator into the faucet and tighten with a
C
wrench.
D
Model KKFV01LP
1. Remove the threaded collar, flat metal washer, and flat rubber
A. Flat rubber washer
B. White triangular support
C. Flat metal washer
D. Threaded collar
washer from faucet.
NOTE: Do not remove the rubber O-ring from the bottom of
the faucet base.
4. Align the faucet and firmly hand-tighten the threaded collar to
keep the faucet base from turning when moving the control
lever. Make sure the control lever is pointed toward the right-
hand side of the sink.
A
B
C
5. Connect the sprayer hose to the water supply hose using the
check valve assembly and the fiber washers. Make sure the
check valve assembly is positioned so that the arrow is
pointing down, away from the faucet and toward the sprayer
head.
D
6. Place a fiber washer between the sprayer hose and the check
valve assembly and fasten them together. Then, place a fiber
washer between the check valve assembly and the supply
hose and fasten them together, as shown.
A. Rubber O-ring
B. Flat rubber washer
C. Flat metal washer
D. Threaded collar
2. Feed tubing through the hole in the sink or counter top and
then insert threaded shank into the hole. Make sure the
rubber O-ring in the channel at the bottom of the faucet base
is firmly in place.
A
B
C
3. Working from under the sink or countertop, reinstall the parts
onto the threaded shank of the faucet in the following order:
flat rubber washer, white triangular support, flat metal washer,
and threaded collar.
D
E
A
B
A. Supply hose (from faucet)
B. Fiber washer
D. Fiber washer
E. Sprayer hose
C
C. Check valve assembly
D
7. Connect the red-striped, braided hose to the hot water
supply valve. Connect the blue-striped, braided hose to the
cold water supply valve. Hold the hoses in place when
tightening the nut to keep the hoses from twisting.
A. Flat rubber washer
B. White triangular support
C. Flat metal washer
D. Threaded collar
8. Make sure the sprayer hose is fully inserted into the faucet
body.
4. Align the faucet and firmly hand-tighten the threaded collar to
keep the faucet base from turning when moving the operating
lever.
9. Working from under the sink, use the screws provided to
attach the weights onto the sprayer hose. Attach the weights
to the sprayer head side of the hose loop, just above the
bend in the hose, as shown.
5. Connect the red-striped, braided hose to the hot water
supply valve. Connect the blue-striped, braided hose to the
cold water supply valve. Hold the hoses in place when
tightening the nut to keep the hoses from twisting.
NOTE: The weights are for counterbalance only, not for
automatic retraction.
6. Move the faucet lever to the closed (forward) position and
open supply valves. Check connections for leaks.
7. Remove the aerator from the faucet and flush the hot and
cold lines until water is clear.
A
C
NOTE: The aerator is in the end of the faucet. To remove and
replace aerator, see “Aerator Assembly” in the “Faucet Care”
section.
B
8. Reinstall the aerator into the faucet and tighten with a
A. Weights
B. Sprayer hose
C. Water flow direction
wrench.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
FAUCET USE
FAUCET CARE
Operating the Faucet
Faucet Exterior
Clean the faucet using a clean cloth and warm water, or a very
diluted solution of mild dish detergent in warm water. Dry and
polish the faucet with a soft cloth.
All Models
Operate the faucet by moving the lever to the desired position.
NOTE: Do not use abrasive sponges, or anti-lime or acidic
cleansers such as scouring agents.
A
B
Aerator Assembly
D
C
Periodically, remove and clean the aerator under running water. If
the aerator is very dirty, soak it in household vinegar overnight.
Remove and Replace the Aerator
Model KKFV01PP
1. Turn off water supply to faucet.
A. Full hot
B. Full on
C. Full cold
D. Off
2. Remove the aerator assembly (threaded collar, screen, and
rubber washer). The spray button spring will also come out
with the aerator assembly.
Model KKFV01PP
3. Clean or soak only the aerator screen.
■
■
The flow of water can be a stream or spray. The default water
setting is stream.
4. Replace the spray button spring. Insert the small side into the
spray head around the slotted screw.
The spray assembly can be drawn out of the faucet
approximately 19" (48.26 cm).
5. Replace the aerator assembly, and fully tighten the threaded
collar with a wrench.
Water spray setting
Push the diverter button on top of the spray assembly.
Water stream setting
Turn off the faucet and then turn it back on. The spray assembly
automatically resets.
A
B
A
A. Spray button
B. Spray assembly
B
C
Model KKFV01SP
D
■
■
The flow of water can be a stream or spray. The default water
setting is stream.
A. Spray button spring
B. Rubber washer
C. Aerator screen
D. Threaded collar
The spray assembly can be drawn out of the faucet spout
approximately 12" (30.48 cm).
Water spray setting
Push the large diverter button on top of the spray assembly.
Water stream setting
Push the small diverter button located below the larger button, or
turn off the faucet and then turn it back on.
A
B
A. Spray button
B. Stream button
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Model KKFV01LP
1. Turn off water supply to faucet.
Model KKFV01SP
1. Turn off water supply to faucet.
2. Remove the aerator assembly (threaded collar, screen, and
2. Remove the aerator assembly (threaded collar, screen, and
rubber washer).
rubber washer).
3. Clean or soak only the aerator screen.
3. Clean or soak only the aerator screen.
4. Replace the aerator assembly, and fully tighten the threaded
4. Replace the aerator assembly, and fully tighten the threaded
collar with a wrench.
collar with a wrench.
A
B
C
A. Rubber washer
B. Aerator screen
C. Threaded collar
A
B
C
A. Rubber washer
B. Aerator screen
C. Threaded collar
TROUBLESHOOTING
Slow or no water flow
Faucet leaks around the lever
■
Is the faucet lever in the ON position? The lever control
pattern is triangular with OFF toward the front of the faucet.
See “Operating the Faucet.”
■
Is the retaining nut that holds the cartridge in place
loose? Remove the faucet lever, lever base assembly, and
cap to expose the cartridge retaining nut. Tighten retaining
nut.
■
■
■
■
■
Are the water supply valves fully open? Turn the water
valves ON.
Faucet lever is loose
Is the household main water supply turned OFF? Check
for water flow from a different faucet.
With the Allen wrench (supplied), tighten the setscrew in the lever.
Make sure the setscrew is flush with the lever so it does not stick
out.
Are the braided faucet hoses twisted? Untwist the hoses
and check for kinks.
Is the aerator blocked? Make sure the aerator is free of
debris that could plug the holes. See “Cleaning.”
Pull out or down sprayer head does not pull out to a
satisfactory distance or retract fully
(Models KKFV01PP and KKFV01SP only)
Does the faucet lever move normally? If the lever moves
too freely or seems stuck, the cartridge may need to be
replaced.
■
■
Are articles under the sink interfering with the hose?
Move the articles to provide clearance for the hose.
Faucet leaks or drips at the spout
Are the weights positioned correctly on the spray hose?
The two weights should be spaced approximately 1" apart on
the sprayer head side of the hose loop just above the bend.
See “Install the Faucet.”
It is normal for the faucet to drip up to 1 minute after turning off
the water.
■
Is the faucet lever in the OFF position? The lever control
pattern is triangular with OFF toward the front of the faucet.
See “Operating the Faucet.”
■
Is the faucet lever in the OFF position but continues to
leak from the spout? The cartridge and the cartridge seals
should be inspected for wear and replaced if necessary.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
REPLACEMENT PARTS LISTS
Model KKFV01LP
Model KKFV01SP
9
8
9
4
10
11
3
4
13
2
12
3
2
1
1
5
8
5
6
6
14
15
12
7
7
19
10
16
11
17
18
20
ITEM
DESCRIPTION
Lever base assembly
Spring
PART NUMBER
ITEM
DESCRIPTION
Lever base assembly
Spring
PART NUMBER
1
*
*
1
*
*
2
2
3
Lever - Stainless Steel
Lever - Chrome
Setscrew
W10198637
3
Lever - Stainless Steel
Lever - Chrome
Setscrew
W10198637
3
W10198638
3
W10198638
4
*
4
*
5
Cap
*
5
Cap
*
6
Retaining nut
Cartridge
*
6
Retaining nut
Cartridge
*
7
8211409
7
8211401
*
8
Spout assembly
Aerator set
*
8
Spout assembly
Short plastic insert
Screen washer
Sprayer - Stainless steel
Sprayer - Chrome
Aerator set
9
8211403
9
8211417
W10186588
8211402
8211416
8211403
*
10
11
12
Base
*
10
11
11
12
13
14
15
16
17
18
19
20
Mounting assembly
O-ring
8211411
*
* This part is not serviceable
Screw
O-ring
*
Base
*
Fiber washer
Check valve assembly
Weight
8211404
8211410
8211407
8211411
8211405
Mounting assembly
Hose
* This part is not serviceable
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Model KKFV01PP
ITEM
DESCRIPTION
Lever base assembly
Spring
PART NUMBER
4
3
2
1
*
*
2
1
3
Lever - Stainless steel
Lever - Chrome
Setscrew
W10198637
3
W10198638
5
6
4
*
21
15
5
Cap
*
6
Retaining nut
Cartridge
*
7
14
7
8211401
*
13
8
Body
12
8
9
9
O-ring
*
10
11
12
13
14
14
15
16
17
18
19
20
21
Base
Teflon® ring
*
*
Long plastic insert
Rubber washer
Sprayer - Stainless steel
Sprayer - Chrome
Aerator set
8211418
W10186587
8211408
8211415
8211403
8211410
8211404
8211405
8211407
8211411
W10200280
11
10
20
Check valve assembly
Fiber washer
Hose
17
16
Weight
19
Mounting assembly
Spray button spring
* This part is not serviceable
18
®Teflon is a registered trademark of E.I. Dupont de Nemours and
Company.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
KITCHENAID® FAUCETS WARRANTY
ONE YEAR LIMITED WARRANTY
For one year from the date of purchase, when this faucet is installed, operated and maintained according to instructions attached to or
furnished with the product, KitchenAid will replace the faucet with an equivalent faucet supplied by KitchenAid if this faucet is found to be
defective in materials or workmanship under conditions of normal use. This warranty extends to the original purchaser only.
SECOND THROUGH THIRD YEAR LIMITED WARRANTY ON STAINLESS STEEL FINISH
(residential installations only)
In the second through third year from the date of purchase, when this faucet is installed, operated and maintained according to instructions
attached to or furnished with the product, KitchenAid will replace the faucet with an equivalent faucet supplied by KitchenAid if the stainless
steel finish on this faucet is found to be defective in materials or workmanship under conditions of normal household use. This warranty
extends to the original purchaser only.
SECOND THROUGH FIFTH YEAR LIMITED WARRANTY ON CHROME FINISH
(residential installations only)
In the second through fifth year from the date of purchase, when this faucet is installed, operated and maintained according to instructions
attached to or furnished with the product, KitchenAid will replace the faucet with an equivalent faucet supplied by KitchenAid if the chrome
finish on this faucet is found to be defective in materials or workmanship under conditions of normal household use. This warranty extends
to the original purchaser only.
SECOND THROUGH TENTH YEAR LIMITED WARRANTY ON FAUCET CARTRIDGE
(residential installations only)
In the second through tenth year from the date of purchase, when this faucet is installed, operated and maintained according to instructions
attached to or furnished with the product, KitchenAid will replace the faucet cartridge with a faucet cartridge supplied by KitchenAid if the
faucet cartridge is found to be defective in materials or workmanship under conditions of normal household use. This warranty extends to the
original purchaser only.
ITEMS EXCLUDED FROM WARRANTY
KitchenAid WILL NOT Pay for:
1. Service calls to correct the installation of your faucet, to instruct you on how to use your faucet, or to repair or replace household
plumbing.
2. Limited warranty repairs after the first year when your faucet is used in other than normal, single-family household use.
3. Damage resulting from accident, alteration, unauthorized modification, misuse, abuse (such as heavy impact), fire, floods, acts of God,
improper installation or installation not in accordance with local plumbing codes, or use of products not approved by KitchenAid.
4. Damages resulting from improper care or maintenance.
5. Damages resulting from improper applications, such as exposure to corrosive chemicals, photographic solutions, etc.
6. Any unauthorized modifications made to the product after it leaves KitchenAid (or its suppliers) premises whether performed by a
contractor, service company, or you.
7. Any labor costs during the limited warranty periods.
8. Repair or replacement parts for units operated outside the United States.
9. Transportation and labor costs associated with removal or reinstallation of covered parts.
DISCLAIMER OF IMPLIED WARRANTIES
IMPLIED WARRANTIES, INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR IMPLIED WARRANTY OF FITNESS FOR A
PARTICULAR PURPOSE, ARE LIMITED TO ONE YEAR OR THE SHORTEST PERIOD ALLOWED BY LAW. Some states and provinces do not
allow limitations on the duration of implied warranties of merchantability or fitness, so this limitation may not apply to you. This warranty gives
you specific legal rights, and you also may have other rights that vary from state to state or province to province.
KITCHENAID SHALL NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES
Some states do not allow the exclusion or limitation of incidental or consequential damages, so this exclusion or limitation may not apply to
you. This warranty gives you specific legal rights, and you also may have other rights which may vary from state to state.
Outside the 50 United States, this warranty does not apply. Contact your authorized KitchenAid dealer to determine if another warranty
applies.
8/08
If you believe you have a warranty claim, contact KitchenAid through your Dealer, Plumbing Contractor, Home Center or E-tailer. Or call our
Customer eXperience Center at 1-800-422-1230 from anywhere in the U.S.A., or write:
KitchenAid Brand Home Appliances
Customer eXperience Center
553 Benson Road
Benton Harbor, MI 49022-2692
Please include a daytime phone number in your correspondence.
In the event of a warranty claim, the owner will be required to provide proof of purchase, model and serial number, finish, a copy of the
original invoice showing the seller and date the product was purchsed, and a complete description of the problem. KitchenAid reserves the
right to inspect any faucet reported to be defective prior to replacement of the faucet. All decisions are final.
Keep this book and your sales slip together for future
Dealer name____________________________________________________
reference. You must provide proof of purchase or installation
date for in-warranty service.
Address________________________________________________________
Phone number__________________________________________________
Model number __________________________________________________
Serial number __________________________________________________
Purchase date __________________________________________________
Write down the following information about your faucet to better
help you obtain assistance if you ever need it. You will need to
know your complete model number and serial number.
8559765B
9/08
Printed in U.S.A.
© 2008. All rights reserved.
® Registered Trademark/TM Trademark of KitchenAid, U.S.A.
Download from Www.Somanuals.com. All Manuals Search And Download.
|