ST-RC
FLAT BENCH W/ RACK
Owner’s Manual
Questions?
Call Us Toll Free
Keys Fitness Helpline
1-888-340-0482
Model Name :ST-FBR
Manufactured Date :
PO # :
Model Name Decal Location
215-00091
08/06 Rev B
Download from Www.Somanuals.com. All Manuals Search And Download.
Safety Information
Please read all instructions carefully before using this product.
SAFETY TIPS
Consult with your physician before engaging in any vigorous exercise. Know your heart rate
and/or pulse as well as your physician-recommended heart rate training zone. Proper medical
clearance is recommended for anyone beginning an exercise program especially if you are 35
years of age or older or suffer from heart respiratory problems.
- Warm-up before any exercise program with 8 minutes of aerobic-like activity followed
by stretching from head to toe.
- Wear comfortable clothes that allow freedom of movement and are not tight or
restricting.
- Wear comfortable shoes made with good support and non-slip soles.
- Breath naturally, never holding your breath during an exercise.
- Perform exercises consistently with proper technique and pass through a full range of
motion.
- Increase resistance by adding heavier weights. Decrease resistance by using lighter
weights.
- Always use a spotter for safety.
- Avoid over-training. You should be able to carry on a conversation while exercising.
- After an exercise session. Cool down with slow stretching, cycling or walking.
EXERCISE DEFINITIONS:
Sets: A set is one complete routine of exercises. Complete 1-3 sets for each exercise.
Repetitions: (referred to as reps) Is the number of times you perform an exercise in a row.
We recommend beginning with 6 reps and increasing up to 12 reps as indicated below.
Novice: Start with one set of 8-12 reps. Once you can complete the entire set of 12 reps con-
secutively, progress to the intermediate level.
Intermediate: Complete 2 sets of 8-12 reps once you can complete two sets of 12 reps con-
secutively, progress to the advanced level.
Advanced: Complete 3 sets of 12 reps
DISCLAIMER:
Keys Fitness is not responsible for the misuse of any of its products or for any injury sustained
while using any Keys Fitness product. The consumer uses any or all of Keys Fitness Products at
their own risk.
BEFORE YOU BEGIN:
Before you begin assembly of your Keys Fitness product, please take a moment to review the
hardware and parts list on the following pages. Each part has been illustrated and numbered
for easy identification.
Check this list against the contents of your package to make sure you have all required parts.
If any parts are missing, please do not return this product to the store. Contact our service
department immediately at 1-888-340-0482 and we will rush you any parts you may require.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
Unpack all parts and place them in a clear area. Be sure to remove all packing material.
NOTE: Hand Tighten bolts and nylon nuts until machine is fully assembled.
STEP 1:
Attach Rear Upright (2) to
Rear Base Frame (1) using Bolt
(22), two Washers (28) and
Nylon Lock Nut (26).
Connect the Front Upright (4)
to the U Base Frame (5) using
two Bolts (22), four Washers
(28) and two Nylon Lock Nuts
(26).
STEP 2:
Attach Cross Frame (3) to Rear
Upright (2) and Front Upright
(4) using four Bolts (19), eight
Washers (27) and four Nylon
Lock Nuts (25).
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Parts List
ST-RC Parts List Rev A
Description
Ref #
Part #
Qty
1
1
1
1
1
2
1
2
1
2
2
2
2
4
2
3
1
2
4
2
2
2
2
4
4
8
8
16
4
1
1
1
2
3
4
5
6
7
8
9
223-00719 REAR BASE FRAME, M-RC
223-00720 REAR UPRIGHT, M-RC
223-00721 CROSS FRAME, M-RC
223-00722 FRONT UPRIGHT, M-RC
223-00723 U-BASE TUBE, M-RC
223-00724 PAD SUPPORT, M-RC
223-00725 SLIDING CARRIAGE, M-RC
228-00195 PAD, ST-45/ST-RC
210-00040 POP PIN, IRONMAN
10 228-00094 FOAM ROLLER, AOLIN
11 206-00333 GRIP, M-RC
12 206-00288 PLUG 25
13 206-00075 WHEEL M-DFIDL
14 206-00335 END CAP, M-RC
15 206-00327 PLASTIC SLEEVE, 63.5X88.9-50.8X76.2
16 202-00414 PLUG 50.8X76.2
17 206-00334 PLASTIC PAD, M-RC
18 202-00440 ROUND PLUG 25
19 202-00441 BOLT, M12X75
20 202-00437 BOLT M10*100
21 202-00418 BOLT, M10X90
22 202-00294 HEX BOLT, M10X70
23 202-00163 HEX BOLT M10*80, M-PR
24 202-00416 BOLT M8*25
25 202-00428 NYLON LOCKNUT M12
26 202-00427 NYLON LOCKNUT M10
27 202-00417 WASHER, 12
28 202-00420 WASHER 10
29 202-00421 WASHER 8
#
#
202-00633 BOLT PACK, ST-RC
215-00083 MANUAL ST-RC
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Exploded View
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty
KEYS FITNESS PRODUCTS, L.P.
STRENGTH TRAINER
WARRANTY
Keys Fitness Products L.P. warrants this product for a period of 90 days on parts and lifetime
on the frame from the original date of purchase. This warranty covers the product from defects
in materials and workmanship for the original purchaser. Using this product for commercial
purposes, products damaged by misuse, abuse, or from shipping, moving and storage will void
this warranty.
Replacement parts are available from Keys Fitness Products L.P.
To contact us for customer service or replacement parts, call 1-888-340-0482.
CUSTOMER SERVICE
If you have any questions regarding this or any Keys Fitness product, or if we may be of
assistance in any way, please do not hesitate to call our toll free number 1-888-340-0482.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Keys Fitness Products, L.P.
4009 Distribution Drive, Suite 250
Garland, Texas 75041
Customer Service: 1-888-340-0482
Download from Www.Somanuals.com. All Manuals Search And Download.
|