10
Invac are® Auriga & Auriga
Scooter
User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Invacare® AS
Grensesvingen 9
0603 Oslo
Norge
ꢀ (Kundeservice):
Fax (Kundeservice):
Invacare® B.V.
Celsiusstraat 46
NL-6716 BZ Ede
The Netherlands
ꢀ :
+47 - 22 57 95 10
+47 - 22 57 95 01
+31 - (0) 318 - 69 57 57
+31 - (0) 318 - 69 57 58
Fax:
Invacare® PORTUGAL Lda
Rua Senhora de Campanhã, 105
4369-001 Porto
PORTUGAL
ꢀ :
Invacare® AB
Fagerstagatan 9
163 91 Spånga
Sverige
ꢀ (Kundtjänst):
Fax (Kundtjänst):
+351-225105946
+351-225105739
+46 - (0) 8 761 70 90
+46 - (0) 8 761 81 08
Fax:
Service
Invacare
JÄRFÄLLA
ꢀ:
+46 - (0) 8 – 621 08 44
+46 - (0) 8 – 621 08 45
Fax:
MÖLNDAL
ꢀ:
Fax:
+46 - (0) 31 – 86 36 00
+46 - (0) 31 – 86 36 06
Invacare® n.v.
Autobaan 14
8210 Loppem (Brugge)
BELGIUM
ꢀ:
Fax:
LANDSKRONA
ꢀ:
Fax:
+32 (50) 831010
+32 (50) 831011
+46 - (0) 418 – 285 40
+46 - (0) 418 – 180 89
OSKARSHAMN
ꢀ:
Fax:
+46 - (0) 491 – 101 40
+46 - (0) 491 – 101 80
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Table of Contents
Chapter
Page
1
2
Introduction
7
1.1
Important symbols in this manual...........................................................................................9
1.2
Type Classification and Area of Use .....................................................................................10
Safety Notes
11
2.1
2.2
2.3
2.4
General Safety Notes ..............................................................................................................11
Safety information with regard to care and maintenance...................................................14
Safety Information on Electromagnetic Interference...........................................................15
Safety Information on Driving and Freewheel Mode............................................................16
3
4
Key features
Driving
18
19
4.1
4.2
4.3
4.4
Before driving for the first time..............................................................................................19
Taking Obstacles.....................................................................................................................20
Driving up and down gradients..............................................................................................21
Parking and stationary............................................................................................................22
4.4.1 Activating and de-activating the parking brake (option) ...............................................22
5
6
Pushing the scooter by hand
23
5.1
Disengaging Motors................................................................................................................23
The Control Panel
24
6.1
Control Panel layout................................................................................................................24
6.1.1 Seat Lifter Button..........................................................................................................25
4
Download from Www.Somanuals.com. All Manuals Search And Download.
6.1.2 Status display ...............................................................................................................25
6.1.3 Battery charge display ..................................................................................................26
Driving the Scooter .................................................................................................................27
Diagnostics and Trouble Shooting........................................................................................28
6.3.1 Diagnosing Faults.........................................................................................................29
Error Codes and Diagnostic Codes.......................................................................................30
6.2
6.3
6.4
7
8
Adjustment Options
33
7.1
7.2
7.3
7.4
7.5
Adjusting the angle of the backrest ......................................................................................33
Adjusting the position of the seat from front to back .........................................................34
Adjusting the width of the armrests......................................................................................35
Releasing the seat so that it may rotated and/or removed .................................................36
Adjusting the height of the seat.............................................................................................37
Electrical System
39
8.1
Electronics Protection System ..............................................................................................39
8.1.1 The main fuse...............................................................................................................40
Batteries ...................................................................................................................................40
8.2.1 What you need to know about batteries .......................................................................40
8.2.2 Charging the batteries ..................................................................................................42
8.2.3 Removing and fitting batteries......................................................................................45
8.2
8.2.3.1
8.2.3.2
Removing the batteries............................................................................................46
How to handle damaged batteries correctly............................................................47
9
Care and maintenance
48
50
10 Repair Instructions
10.1
Repairing a flat tyre.................................................................................................................50
10.1.1 Repairing a flat tyre (pneumatic tyres type 260 x 85)...................................................51
10.1.1.1 Removing a rear wheel............................................................................................51
10.1.1.2 Removing a front wheel (4-Wheel Version).............................................................52
5
Download from Www.Somanuals.com. All Manuals Search And Download.
10.1.1.3 Removing a front wheel (3-Wheel Version).............................................................53
10.1.1.4 Repairing the flat tyre ..............................................................................................54
11 Dismantling the scooter for transport
56
11.1
Removing the seat...................................................................................................................56
11.2
Removing the batteries and the Drive Unit...........................................................................57
11.2.1 Removing the batteries.................................................................................................57
11.2.2 Removing the Drive Unit...............................................................................................58
12 Technical Specifications
13 Inspections Performed
59
62
6
Download from Www.Somanuals.com. All Manuals Search And Download.
1
Introduction
Dear user,
First we would like to thank you for purchasing our product! We hope you will enjoy your new
Scooter.
This manual contains important hints and information on:
•
•
•
Safety
Operation
Care and maintenance.
Please take care to read the operating manual thoroughly before starting out on your first
journey.
This product has been designed to fit the needs of different types of users with different
requirements.
The decision whether the model is suitable for the user may only be taken by medical specialists
with appropriate aptitude.
Invacare® or their statutory representatives can accept no liability in cases in which the mobility
product has not been adapted to suit the user's handicaps.
Some maintenance and settings can be carried out by the user. Certain adjustments do however
require technical training and may only be carried out by your Invacare® specialist dealer.
Damages and errors caused by nonobservance of the operating manual or as a result of incorrect
maintenance are excluded from all guarantees.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
This manual contains copyrighted information. It may not be reproduced or copied in whole or in
part without the prior written consent of Invacare® or its authorised representative. It may also
contain information that pertains to models sold only in certain countries. In this case the
information will be clearly marked as pertaining to a particular country-specific version. We reserve
the right to make any alterations on the grounds of technical improvements.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
1.1
Important symbols in this manual
WARNING!
This symbol warns you of danger!
•
Always follow the instructions to avoid injury to the user or damage to the product!
EXPLOSION HAZARD!
This symbol warns you of an explosion hazard, which can be caused by excessive tyre
pressure in a pneumatic tyre!
•
Always follow the instructions to avoid injury to the user or damage to the product!
BURN HAZARD!
This symbol warns you of burns due to acid or other substances!
•
Always follow the instructions to avoid injury to the user or damage to the product!
NOTE:
This symbol identifies general information which is intended to simplify working with your product
and which refers to special functions.
Requirements:
•
This symbol identifies a list of various tools, components and items which you will need in
order to carry out certain work.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
1.2
Type Classification and Area of Use
This vehicle has been classified as a mobility product in class C (for outdoor use). It has been
successfully tested for its safety according to German and international standards. When equipped
with an appropriate lighting system, the vehicle is suitable to be driven on public roads.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
2
Safety Notes
•
READ WELL BEFORE OPERATION!
2.1
General Safety Notes
Danger of injury if this scooter is used in any other way than the purpose described in this
manual!
•
Adhere strictly to the instructions in this user manual!
Danger of injury if the scooter is driven when your ability to drive is impaired by
medication or alcohol!
•
Never drive any vehicle under the influence of medication or alcohol!
Danger of damage or injury if the scooter is accidentally set into motion!
•
•
Switch the power system off before you get in, get out or handle awkward objects!
Be aware that there are only the motor brakes to stop your scooter. When the motors are
disengaged, these brakes are automatically deactivated. For this reason, freewheel operation
is only recommended on flat surfaces, never on gradients. Never leave your vehicle on a
gradient with its motors disengaged. Always re-engage the motors immediately after pushing
the vehicle.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Danger of injury if the On/Off Button is pressed while the vehicle is in motion, due to it
coming to an abrupt, sharp stop!
•
If you have to brake in an emergency, simply release the drive lever, which will bring you to a
halt! Only switch the vehicle off while in motion as a last resort!
Danger of injury if the scooter is transported in another vehicle with the occupant seated
in it!
•
Never transport the scooter with the occupant seated in it!
Danger of injury if maximum permissible load is exceeded!
Do not exceed the maximum permissible load (see technical specifications)!
Danger of injury when lifting heavy components!
•
•
When maintaining, servicing or lifting any part of your scooter, take into account the weight of
the individual components, especially the batteries! Be sure at all times to adopt the correct
lifting posture and ask for assistance if necessary!
Danger of injury if you fall off the scooter!
•
If restraining systems are installed (such as seat belts), use them each time you drive the
scooter.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Danger of injury by moving parts!
•
Make sure that no injury is incurred by moving parts of the scooter, like wheels or a Seat Lifter,
especially when children are around!
Danger of fire or breaking down due to electric devices being connected!
•
Do not connect any electric devices to your vehicle that are not expressly certified by
Invacare® for this purpose! Have all electrical installations done by your authorised Invacare®
Dealer!
Danger of technical failure and injury if unauthorized spare parts and components are
used!
•
Only use original Invacare® spare parts, which have been approved for use with this vehicle!
13
Download from Www.Somanuals.com. All Manuals Search And Download.
2.2
Safety information with regard to care and maintenance
Danger of accident and loss of guarantee if maintenance is insufficient!
•
•
•
For reasons of safety and in order to avoid accidents which result from unnoticed wear, it is
important that this electric vehicle undergoes an inspection once every year under normal
operating conditions (see inspection plan contained in service instructions)!
Under difficult operating conditions such as daily travel on steep slopes, or in the case of use
in medical care cases with frequently changing wheelchair users, it would be expedient to
carry out intermediate checks on the brakes, accessories and running gear!
If the vehicle is to be operated on public roads, the vehicle driver is responsible for ensuring
that the vehicle is in an operationally reliable condition! Inadequate or neglected care and
maintenance of the vehicle will result in a limitation of the manufacturer's liability!
14
Download from Www.Somanuals.com. All Manuals Search And Download.
2.3
Safety Information on Electromagnetic Interference
This electric vehicle was successfully tested in accordance with International standards as to its
compliance with Electromagnetic Interference (EMI) Regulations. However, electromagnetic fields,
such as those generated by radio and television transmitters, and cellular phones, can influence
the functions of electric vehicles. Also, the electronics used in our vehicles can generate a low level
of electromagnetic interference, which however will remain within the tolerance permitted by law.
For these reasons we ask you to please observe the following precautions:
WARNING: Danger of malfunction due to electromagnetic interference!
•
Do not switch on or operate portable transceivers or communication devices (such as radio
transceivers or cellular phones) when the vehicle is switched on!
•
•
Avoid getting near strong radio and television transmitters!
In case the vehicle should be set in motion unintentionally or the brakes are released, switch
it off immediately!
•
Adding electrical accessories and other components or modifying the vehicle in any way can
make it susceptible to electromagnetic interference. Keep in mind that there is no sure way to
determine the effect such modifications will have on the overall immunity of the electronic
system!
•
Report all occurrences of unintentional movement of the vehicle, or release of the electric
brakes to the manufacturer!
15
Download from Www.Somanuals.com. All Manuals Search And Download.
2.4
Safety Information on Driving and Freewheel Mode
Danger of injury if the vehicle tips over!
•
Only ever negotiate gradients of up to the maximum defined in the Technical Specifications
and only with the backrest in an upright position, and the seat lifter in the lowest position (if
installed)!
•
•
Only ever drive downhill at a maximum of 2/3rds of the top speed! Avoid abrupt braking or
accelerating on gradients!
If at all possible, avoid driving on slippery surfaces (such as snow, gravel, ice etc.) where there
is a danger of you losing control over the vehicle, especially on a gradient! If driving on such a
surface is inevitable, then always drive slowly and with the utmost caution!
•
•
•
Never attempt to overcome an obstacle when on an uphill or downhill gradient!
Never attempt to drive up or down a flight of steps!
Always approach obstacles straight on! Ensure that the front wheels and rear wheels move
over the obstacle in one stroke, do not stop halfway! Do not exceed the maximum obstacle
height (see Technical Specifications)!
•
Avoid shifting your centre of gravity as well as abrupt changes of direction when the vehicle is
in motion!
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Danger of injury if the vehicle tips over! (Continued)
•
•
•
Never use the vehicle to transport more than one person!
Do not exceed the maximum permissible load!
When loading the vehicle, always distribute the weight evenly! Always try to keep the centre of
gravity of the vehicle in the middle, and as close to the ground as possible!
•
Note that the vehicle will brake or accelerate if you change the Driving Speed while it is in
motion!
Danger of injury if you collide with an obstacle when driving through narrow passages
such as doorways and entrances!
•
Drive through narrow passages in the lowest Driving Speed and with due caution!
17
Download from Www.Somanuals.com. All Manuals Search And Download.
3
Key features
1) De-clutching lever
2) Release lever for swivelling and
removing seat (under the seat on
the right)
3) Release lever for seat sliding rail
adjustment (under the seat on the
right in the front)
4) Primary Charging Socket
5) Key switch (ON/OFF)
6) Throttle
7) Control panel
8) Lever for adjusting the angle of the
steering column
9) Handbrake / parking brake (if
installed)
18
Download from Www.Somanuals.com. All Manuals Search And Download.
4
Driving
4.1
Before driving for the first time...
Before you take your first trip, you should familiarise yourself well with the operation of the vehicle
and with all operating elements. Take your time to test all functions and driving modes.
NOTE:
If installed, use the restraining systems (seat belts) each time you use the vehicle.
Sitting Comfortably = Driving Safely
Before each trip, make sure that:
•
•
•
You are within easy reach of all operating controls.
The battery charge is sufficient for the distance intended to be covered.
The seatbelt is in perfect order.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
4.2
Taking Obstacles
Your Invacare® Auriga/Auriga10 can overcome obstacles and kerbs of up to 8 cm.
CAUTION: Danger of Tipping Over!
•
•
Never approach obstacles at an angle!
Put your backrest into an upright position before climbing an obstacle!
Driving up over an obstacle
Correct
•
Approach the kerb or obstacle slowly head-on. Shortly
before the front wheels touch the obstacle, increase the
speed and reduce only after the rear wheels have also
climbed the obstacle.
Driving down off of an obstacle
•
Approach the kerb or obstacle slowly head-on. Before the
front wheels touch the obstacle, reduce speed and keep it
until also the rear wheels have come down off of the
obstacle.
Incorrect
20
Download from Www.Somanuals.com. All Manuals Search And Download.
4.3
Driving up and down gradients
The Invacare® Auriga/Auriga10 can safely climb the following gradients:
•
•
•
4-Wheel Version (up to 150 kg payload):
3-Wheel Version (up to 120 kg payload):
3-Wheel Version (up to 150 kg payload):
12°
12°
10°
WARNING: Danger of tipping over!
•
•
Only ever drive downhill at a maximum of 2/3rds of the top speed!
Always return the backrest of your seat to an upright position before ascending slopes! We
recommend that you lean the backrest slightly to the rear before descending slopes!
•
Never attempt to ascend or descend a slope on slippery surfaces or where there is a danger
of skidding (such as wet pavement, ice etc)!
•
•
Avoid trying to get out of the vehicle on an incline or a gradient!
Always drive in a straight direction along the road or path you are travelling on, rather than
attempting to zigzag!
•
Never attempt to turn around on an incline or a slope!
21
Download from Www.Somanuals.com. All Manuals Search And Download.
4.4
Parking and stationary
When parking your vehicle or if your vehicle is stationary for a prolonged period:
•
•
Switch the vehicle's power system off (key switch).
Activate the parking brake (if available).
4.4.1 Activating and de-activating the parking brake (option)
Activating the brake
•
•
Pull brake lever (1) and hold it.
While holding the brake lever, press the
latching pin (2) down. The brake lever is
latched in place.
Releasing the brake
•
Pull the brake lever briefly and let it go. The
latching pin pops up. The brake lever is
released.
22
Download from Www.Somanuals.com. All Manuals Search And Download.
5
Pushing the scooter by hand
The motors of the scooter are equipped with automatic brakes, preventing the scooter from rolling
away out of control when the power supply is switched off. When pushing the scooter, the magnetic
brakes must be disengaged.
5.1
Disengaging Motors
Danger of the vehicle running away!
•
When the motors are disengaged (for push operation), the electromagnetic motor brakes are
deactivated! When the vehicle is parked, the levers for engaging and disengaging the motors
must without fail be locked firmly into the "DRIVE" position (electromagnetic motor brakes
activated)!
The lever for engaging and disengaging the motor is
located on the right at the rear of the scooter.
Disengaging the motor
•
Make sure the power supply is switched off (key
switch).
•
Push lever (1) forwards.
Engaging the motor
Pull lever backwards.
•
23
Download from Www.Somanuals.com. All Manuals Search And Download.
6
The Control Panel
6.1
Control Panel layout
1) Seat Lifter button (if
installed)
2) Battery charge indicator
3) Hazard flashers
4) Horn
5) Right turn signal
6) Driving speed adjustment
7) Throttle lever
8) Plug for external charger
9) Reduced Speed Mode
10) Left turn signal
11) Lights
24
Download from Www.Somanuals.com. All Manuals Search And Download.
6.1.1 Seat Lifter Button
•
•
•
Press the button to activate the Seat Lifter (if installed). The LED above the button lights up.
Raise or lower the seat using the throttle lever.
Press the button once again to de-activate the Seat Lifter. The throttle lever reverts back to
driving mode.
NOTE
If the Seat Lifter is not lowered entirely, then the speed of the scooter is automatically reduced to
lower the risk of tipping over. This is indicated by the LED just above the "Reduced Speed Mode"
button flashing. Lower the Lifter completely to restore speed to it's normal level. The LED will go
out.
6.1.2 Status display
NOTE
The leftmost diode of the battery charge display serves as an error message display (status
display). For an explanation of the Error Codes please see chapter "Error Codes and Diagnostic
Codes" on page "30".
25
Download from Www.Somanuals.com. All Manuals Search And Download.
6.1.3 Battery charge display
•
•
•
All diodes lit: full driving range
Only red and yellow diodes lit: decreased drive range. Charge batteries at end of journey.
Only red diodes lit / flashing: battery reserve = very low drive range!
Charge batteries immediately!
NOTE
Total discharge protection: After a certain drive time on reserve battery power the electronics
switches off the drive automatically and the scooter will be immobile.
26
Download from Www.Somanuals.com. All Manuals Search And Download.
6.2
Driving the Scooter
•
Switch on the power supply (key switch). The displays on the Control Panel light up. The
scooter is ready to drive.
NOTE
If the scooter does not respond after switching on, check the status display (see chapter "Status
display" on page 25 and chapter "Diagnostics and Trouble Shooting" on page 28).
•
Set the driving speed with the speed adjustment knob.
•
•
Gently pull the right driving lever towards you to drive forwards.
Gently pull the left driving lever towards you to drive backwards.
NOTE
The controller is programmed with standard values ex-works. Your Invacare® Dealer can
program it to fit your requirements.
NOTE:
To brake quickly, simply let go of the driving lever. It will automatically return to the middle
position. The scooter will brake.
27
Download from Www.Somanuals.com. All Manuals Search And Download.
6.3
Diagnostics and Trouble Shooting
The electronics system provides diagnostics information to assist technicians to diagnose and
correct faults within the scooter system. The existence of a fault will cause the status light to flash
in bursts, separated by a pause. The nature of the fault is indicated by the number of flashes in
each burst, also referred to as the Flash Code.
Depending on the severity of the fault and impact on user safety, the electronic system will react
differently. It may…
•
•
Simply display the Flash Code as a warning and allow normal driving and operation.
Display the Flash Code, stop the scooter and prevent driving until the electronic system
has been turned off and then back on again.
•
Display the Flash Code, stop the scooter and prevent driving until the fault has been fixed.
For detailed descriptions of what each Flash Code means, and the probable cause and remedy,
see Section "Error Codes and Diagnostic Codes" on page 30.
28
Download from Www.Somanuals.com. All Manuals Search And Download.
6.3.1 Diagnosing Faults
Use the following troubleshooting guide if the scooter fails to operate.
NOTE
Turn the key switch on before beginning any diagnostics.
If the Status Light is OFF
Check that the key switch is turned ON.
Check that all cables are connected correctly.
If only the leftmost diode of the battery charge display is PERMANENTLY ON
Contact your authorised Invacare® Dealer
If the leftmost diode of the battery charge display is FLASHING
Count the number of flashes and refer to the next section.
29
Download from Www.Somanuals.com. All Manuals Search And Download.
6.4
Error Codes and Diagnostic Codes
Number of
flashes
1
Fault
Impact on
Scooter
Notes
Battery needs Will drive
charging
Battery voltage Drive inhibited
too low
•
•
•
Battery charge is running low. Recharge
the batteries as soon as possible.
Battery charge is empty. Recharge the
batteries.
If the scooter is left off for a few minutes,
battery charge may recover sufficiently to
allow driving for a short period of time.
You should only ever do this in an
emergency, as this deep-discharges the
batteries!
2
Lifter raised
Driving speed
reduced
•
•
•
Lower lifter completely.
3
Battery voltage Drive inhibited
too high
Battery charge is too high. If a charger is
plugged in, unplug it.
The electronic system charges the
batteries when travelling down slopes or
decelerating. Excessive charging in this
manner may cause this fault. Turn the
scooter power off and then back on
again. Turn on the lighting system to use
power.
30
Download from Www.Somanuals.com. All Manuals Search And Download.
Number of
flashes
4
Fault
Impact on
Scooter
Drive inhibited
Notes
Current Limit
Time Out
•
•
The scooter has drawn too much current
for too long, possibly because the motor
has been over-worked, jammed or
stalled. Turn the scooter power off, leave
it off for a few minutes, and then turn the
power back on again.
The controller has detected a short-
circuited motor. Check the cable harness
for short and check the motor: Contact
your authorised Invacare® Dealer.
Check that the declutching lever is in the
engaged position.
The park brake coil or wiring is faulty.
Check the park brake and wiring for open
or short circuits. Contact your authorised
Invacare® Dealer.
Throttle is not in neutral position when
turning key switch on. Return throttle to
neutral, turn power off, and back on
again.
5
6
Brake Fault
Drive inhibited
•
•
Out Of Neutral Drive inhibited
At Power Up
•
•
•
•
Throttle may need to be re-calibrated.
Contact your authorised Invacare®
Dealer.
The throttle or its wiring may be faulty or
incorrectly set up. Contact your
authorised Invacare® Dealer.
7
8
Speed Pot
Error
Drive inhibited
Drive inhibited
Motor Volts
Error
The motor or its wiring is faulty. Contact
your authorised Invacare® Dealer.
31
Download from Www.Somanuals.com. All Manuals Search And Download.
Number of
flashes
9
Fault
Impact on
Scooter
Notes
Other Internal Drive inhibited
Errors
•
Contact your authorised Invacare®
Dealer.
32
Download from Www.Somanuals.com. All Manuals Search And Download.
7
Adjustment Options
7.1
Adjusting the angle of the backrest
The backrest is held in place by a metal plate on each side. Each plate has 4 holes that are used to
set the backrest to different angles. This is done by selecting different combinations of holes.
Requirements:
•
Allen key, 4 mm
•
Spanner, 10 mm
•
Remove the screws on both sides of the seat that hold the
backrest (1), using the spanner and Allen key.
•
•
Adjust the backrest to the desired angle.
Reposition the screws and tighten.
33
Download from Www.Somanuals.com. All Manuals Search And Download.
7.2
Adjusting the position of the seat from front to back
The lever for adjusting the seat back and forth is
located under the seat in the front on the right
side.
•
•
Pull the lever (1) to release the seat.
Slide the seat forward or backward to the
desired position.
•
Release the lever to lock the seat in place.
34
Download from Www.Somanuals.com. All Manuals Search And Download.
7.3
Adjusting the width of the armrests
The knobs to release the armrests are located in the back, under the seat (1).
•
•
•
Turn the knobs to release the armrests.
Adjust the armrests to the desired width.
Retighten the knobs.
35
Download from Www.Somanuals.com. All Manuals Search And Download.
7.4
Releasing the seat so that it may rotated and/or removed
The seat can be rotated to the side to ease getting
on and off of the scooter. In this position, the seat
can also be removed.
The lever for releasing the seat so that it can be
rotated is located under the seat on the right (1).
•
•
•
Push the lever forward to release the seat.
Rotate the seat to the side.
If desired, firmly grip the seat by the backrest
and the front edge and pull upwards to
remove it.
36
Download from Www.Somanuals.com. All Manuals Search And Download.
7.5
Adjusting the height of the seat
The height of the seat can be adjusted to 43, 45, 47, or 49 cm.
Requirements:
•
2 Spanners, 17 mm
•
Remove the seat
•
Remove the cover from the battery and motor
compartment.
•
Remove the bolt that hold the seat post, using the two
spanners.
37
Download from Www.Somanuals.com. All Manuals Search And Download.
NOTE
Do not use the uppermost hole. In this position the seat is too low, and does not have enough
clearance above the cowling.
•
Adjust the seat height.
•
Reposition the bolt and tighten.
38
Download from Www.Somanuals.com. All Manuals Search And Download.
8
Electrical System
8.1
Electronics Protection System
The vehicle's electronics are equipped with an overload-protection system.
If the motors are put under considerable strain for a longer period of time (for example, when
driving up a steep hill) and especially when the ambient temperature is high, then the electronic
system could overheat. In this case the vehicle's power is reduced gradually until it finally comes to
a halt. The Status Display shows a corresponding error code. By switching the power supply off
and back on again, the error code is cancelled and the electronics are switched back on. It will take
approximately five minutes until the electronics have cooled down enough for the motors to restore
full power again.
When the motors are stalled by an insurmountable obstacle, such as a high kerb, and the vehicle
driver allows the motors to strain against this hindrance for more than 20 seconds without moving,
then the electronics will automatically switch off to prevent the motors from being damaged. The
Status Display shows a corresponding error code. By switching off and back on again, the error
code is cancelled and the electronics are switched back on.
39
Download from Www.Somanuals.com. All Manuals Search And Download.
8.1.1 The main fuse
The entire electric system is protected against overload by two master fuses. The master fuses are
mounted on the positive battery cables.
NOTE
A defective main fuse may be replaced only after checking the entire electric system. An
Invacare® specialised dealer must perform the replacement.
8.2
Batteries
8.2.1 What you need to know about batteries
Power is supplied by two 12V gel batteries. The batteries are maintenance-free and only need
regular charging.
New batteries should always be fully charged once before their first use. New batteries will be at
their full capacity after having run through approx. 10 - 20 charging cycles. How fast the batteries
will be discharged will depend on many circumstances, such as ambient temperature, condition of
the surface of the road, tyre pressure, weight of the driver, way of driving and utilisation of lighting,
etc.
40
Download from Www.Somanuals.com. All Manuals Search And Download.
NOTE
Gel batteries are not hazardous goods. This classification is based on the German GGVS
Hazardous Goods Road Transport Ordinances, and the IATA/DGR Hazardous Goods Rail
Transport / Air Transport Ordinances. Gel batteries may be transported without restrictions,
whether by road, rail or by air. Individual transport companies have, however, guidelines which can
possibly restrict or forbid certain transport procedures. Please ask the transport company regarding
each individual case.
Pay attention to the Battery Charge Indicator! Make sure to charge the batteries when the Battery
Charge Indicator shows that battery charge is low. We recommend charging the batteries after
each trip, as well as each night over night. Depending on the level of discharge, it can take up to 12
hours until the batteries are fully charged again.
Protect your charger from sources of heat such as heaters and direct sunlight. If the battery
charger overheats, charging current will be reduced and the charging process delayed.
To avoid damaging the batteries, never allow them to be fully discharged. Do not drive on heavily
discharged batteries if it is not absolutely necessary, as this will strain the batteries unduly and
shorten their life expectancy.
In case your vehicle is not used for a longer period of time, then the batteries must be charged at
least once a month to maintain a full charge. Alternatively, the vehicle can stay connected to the
charger. The batteries cannot be overcharged with the specified charger.
Please use only charging devices in Class 2. This class of chargers may be left unattended during
charging. All charging devices which are supplied by Invacare® and comply with these
requirements.
41
Download from Www.Somanuals.com. All Manuals Search And Download.
8.2.2 Charging the batteries
•
Make sure you read and understand the battery charger's User's Manual, if supplied, as well as
the safety notes on the front and rear panels of the charger!
WARNING:
Danger of explosion and destruction of batteries if the wrong battery charger is used!
•
Only ever use the battery charger supplied with your vehicle, or a charger that has been
approved by Invacare®!
Danger of electric shock and damage to the battery charger if it is allowed to get wet!
•
•
Protect the battery charger from water!
Always charge in a dry environment!
Danger of short circuit and electric shock if the battery charger has been damaged!
Do not use the battery charger if it has been dropped or damaged!
•
Danger of fire and electric shock if a damaged extension cable is used!
•
Only ever use an extension cable if it is absolutely necessary! In case you must use one,
make sure it is in good condition!
Note
The Invacare® Auriga/Auriga10 can be charged using an internal or an external charger.
Although it is not inherently dangerous to use both simultaneously, we recommend using only
one at a time.
42
Download from Www.Somanuals.com. All Manuals Search And Download.
The Invacare® Auriga/Auriga10 is equipped with an integrated charger. The socket for this charger
is located on the front of the Battery and Motor Compartment Cover (1). To charge the scooter, you
only need to connect it to a mains power supply using the cable supplied with the scooter.
Connecting the scooter to a mains power
supply
•
•
First connect the cable to the scooter.
Then connect the cable to the mains power
supply and switch on.
Disconnecting the scooter from the mains
power supply
•
First disconnect the cable from the mains
power supply.
•
Then disconnect the cable from the scooter.
How can I tell when the batteries are fully charged?
Look through the slot for the de-clutching lever (2) down into the motor and battery compartment.
You will see a green LED. This is the charger LED.
LED ACTIVITY
LED lights contantly
LED dims and flickers
CHARGING PHASE
Start
90% Finished
LED go out / flickers for a few seconds / Finished
goes out again
43
Download from Www.Somanuals.com. All Manuals Search And Download.
The Invacare® Auriga/Auriga10 can also be charged using an external charger. The charging
socket is on rear edge of the Control Panel (1).
Connecting the charger
•
•
•
Switch off the Scooter.
Connect the battery charger to the Scooter.
Connect the battery charger to the mains.
Disconnecting the charger
•
First disconnect the battery charger from the
mains power supply.
•
Then disconnect the battery charger from the
scooter.
44
Download from Www.Somanuals.com. All Manuals Search And Download.
8.2.3 Removing and fitting batteries
WARNING:
Danger of injury if the batteries are not handled correctly during assembly and
maintenance work!
•
•
•
•
New batteries should be installed by authorised technicians!
Observe the warnings on the batteries!
Take into account the heavy weight of the batteries!
Only ever use the battery type defined in the technical specifications!
Danger of fire and burns if battery terminals are short-circuited!
DO NOT short-circuit battery terminals with a tool!
•
WARNING:
Corrosion and burns from acid leakage if batteries are damaged!
•
Remove clothes that have been soiled by acid immediately!
After contact with skin:
Immediately wash affected area with lots of water!
After contact with eyes:
•
•
Immediately rinse eyes under running water for several minutes; consult a physician!
45
Download from Www.Somanuals.com. All Manuals Search And Download.
8.2.3.1 Removing the batteries
Requirements:
•
Wrench 11 mm
•
Remove the seat.
•
•
•
Remove the battery and motor compartment cover.
Disconnect the main cable harness.
Open the belts that hold the batteries in place (1).
•
•
•
Loosen battery clamp of the blue cable at the negative pole
of the battery with the wrench and remove cable.
Loosen the battery clamp of the red cable at the positive
pole of the battery with the wrench and remove cable.
Repeat procedure on the other side.
NOTE
Fitting of new batteries is done in reverse order.
46
Download from Www.Somanuals.com. All Manuals Search And Download.
8.2.3.2 How to handle damaged batteries correctly
WARNING:
Corrosion and burns from acid leakage if batteries are damaged!
•
Remove clothes that have been soiled by acid immediately!
After contact with skin:
Immediately wash affected area with lots of water!
After contact with eyes:
Immediately rinse eyes under running water for several minutes; consult a physician!
•
•
Requirements:
•
•
•
Safety goggles
Acid-resistant gloves
Acid-resistant receptacle for transportation
•
Always wear appropriate safety clothing when handling damaged batteries.
Place damaged batteries in an acid-resistant receptacle immediately after removing them.
Only ever transport damaged batteries in an appropriate acid-resistant receptacle.
Wash all objects that have come into contact with acid with lots of water.
•
•
•
Disposing of dead or damaged batteries correctly
Dead or damaged batteries can be given back to your dealer or directly to Invacare®.
47
Download from Www.Somanuals.com. All Manuals Search And Download.
9
Care and maintenance
NOTE:
Have your vehicle checked once a year by an authorised Invacare® dealer in order to maintain
it's driving safety and roadworthiness.
Cleaning the vehicle
When cleaning the vehicle, pay attention to the following points:
•
•
•
•
Only use a damp cloth and gentle detergent.
Do not use any abrasive or scouring liquids.
Do not subject the electronic components to any direct contact with water.
Do not use high-pressure cleaning devices.
48
Download from Www.Somanuals.com. All Manuals Search And Download.
Maintenance Jobs
Seat and backrest padding:
Check for perfect condition.
Tyres:
Have tyres checked for specified air pressure (2,5 bar).
Front wheels
•
•
•
•
Front wheels must spin smoothly.
If wheels wobble or do not spin easily, adjust steering pivot pin or front
wheel bearing.
Rear wheels:
•
•
Test wheel for firm seat on the axle drive shaft.
Rear wheels must spin without wobbling
Electronics / Electrical System:
•
Check all plug connections for condition and firm connection.
Before every trip
Before each trip
•
•
•
Have batteries been fully charged before the daily operation?
Are all holders, screws firmly fixed, tight and safe?
Are all electric bulbs of the lighting system (if applicable) in working
order?
Cleaning:
Clean all parts carefully.
When necessary
•
Once a year you should have your vehicle inspected and serviced by your authorised
dealer. A complete checklist of necessary maintenance work can be found in the Service
Manual, which can be obtained from Invacare®.
49
Download from Www.Somanuals.com. All Manuals Search And Download.
10 Repair Instructions
The following are instructions on repairs that can be performed by the user. For the specifications
of spare parts please see "Technical Specifications" on page 59, or consult the Service Manual,
available from Invacare®. In case you require assistance, please contact your Invacare® Dealer.
10.1 Repairing a flat tyre
WARNING: Danger of damage or injury if the vehicle is accidentally set into motion during
repairs!
•
•
•
Switch the power off (ON/OFF Button)!
Engage the motors!
Secure the vehicle against rolling away by placing wedges under the wheels!
50
Download from Www.Somanuals.com. All Manuals Search And Download.
10.1.1 Repairing a flat tyre (pneumatic tyres type 260 x 85)
10.1.1.1 Removing a rear wheel
Requirements:
•
Spanner 19 mm
•
Rubber hammer
•
Jack the vehicle up and place a block of wood underneath it
to prop it up.
•
•
Remove the nut that secures the wheel (1) using the 19 mm
spanner.
Remove the wheel, using the rubber hammer to coax it off of
the axle by gently hitting it on the rear side.
Having trouble removing the wheel?
You might need to use a special tool. Please ask your authorized Invacare® Dealer for
assistance.
Re-assembly
Re-assembly is done in reverse order. Make sure that the wheel is put back on the same side it
was on, and that it runs in the same direction it did before it was removed.
51
Download from Www.Somanuals.com. All Manuals Search And Download.
10.1.1.2 Removing a front wheel (4-Wheel Version)
Requirements:
•
Allen key 6 mm
•
Rubber hammer
•
Jack the vehicle up and place a block of wood underneath it
to prop it up.
•
•
Remove the nut that secures the wheel (1) using the 6 mm
Allen key.
Remove the wheel, using the rubber hammer to coax it off of
the axle by gently hitting it on the rear side.
Re-assembly
Re-assembly is done in reverse order. Make sure that the wheel is put back on the same side it
was on, and that it runs in the same direction it did before it was removed.
52
Download from Www.Somanuals.com. All Manuals Search And Download.
10.1.1.3 Removing a front wheel (3-Wheel Version)
Requirements:
•
2 Spanners, 17 mm
•
Tilt the scooter over on it's side.
•
Remove the bolts that hold the wheel (1) using the two
spanners, then remove the wheel from the fork.
Re-assembly
Re-assembly is done in reverse order. Make sure that the wheel runs in the same direction it did
before it was removed.
53
Download from Www.Somanuals.com. All Manuals Search And Download.
10.1.1.4 Repairing the flat tyre
Requirements (General)
•
•
•
Repair kit for inner tubes or an new inner tube.
Talcum powder
Socket spanner, 13 mm
Requirements (3-Wheel Version - front wheel):
•
Allen key, 6 mm
•
Remove the valve cap.
•
Let the air out of the tyre by pressing the pin in the
centre of the valve in.
•
Remove the 4 nuts (1) from the rear of the wheel
using the 13 mm spanner (3-Wheel Version - front
wheel: counter the bolts from the other side using
the 6 mm Allen key).
•
•
Remove the rim halves from the tyre and take out
the inner tube.
Repair the inner tube and re-fit, or replace it with a
new one.
54
Download from Www.Somanuals.com. All Manuals Search And Download.
Did the old inner tube get wet during repair?
In case the old inner tube is to be repaired and used again, and it gets wet during repair, then it
is easier to re-fit it if you powder it lightly with talcum powder.
•
Place the rim halves in the tyre from the outside.
Pump up the tyre a little.
•
•
•
•
•
•
•
Re-position the screws and nuts that hold the rim together and tighten them firmly.
Check to make sure that the tyre is squarely in place on the rim.
Pump up the tyre to the recommended tyre pressure (2.5 bar, or 40 psi).
Check to make sure that the tyre is still squarely and snugly in place on the rim.
Screw the valve cap back on.
Refit the wheel.
55
Download from Www.Somanuals.com. All Manuals Search And Download.
11 Dismantling the scooter for transport
To dismantle the scooter for transport, proceed as follows:
•
•
•
Remove the seat
Remove the batteries
Remove the drive unit
The scooter is re-assembled in reverse order.
11.1 Removing the seat
The lever for releasing the seat so that it can be
rotated and removed is located under the seat on
the right (1).
•
•
•
Push the lever forward to release the seat.
Rotate the seat to the side.
Firmly grip the seat by the backrest and the
front edge and pull upwards to remove it.
56
Download from Www.Somanuals.com. All Manuals Search And Download.
11.2 Removing the batteries and the Drive Unit
•
After removing the seat, proceed to remove the cover from the battery and motor compartment
Cover. It is held in place with Velcro strips, so you only need to pull it upwards to remove it.
11.2.1 Removing the batteries
For instructions on how to remove the batteries see chapter "Removing and fitting batteries" on
page 45.
57
Download from Www.Somanuals.com. All Manuals Search And Download.
11.2.2 Removing the Drive Unit
WARNING: Danger of injury by moving parts!
•
The release lever for the drive unit is under tension! When releasing the drive unit be very
careful not to get your hands or feet caught underneath the chassis of the scooter, or in
between any moving parts!
To release the drive unit, first you need to remove the securing
pin that prevents the release lever from opening accidentally.
•
•
Remove the pin (1) that secures the latching mechanism.
Release the drive Unit by pressing the Release Lever (2)
forward and downward.
58
Download from Www.Somanuals.com. All Manuals Search And Download.
12 Technical Specifications
3-Wheel Version
4-Wheel Version
Electrical
System
Motor (6 km/h)
Motor (10 km/h)
Batteries
•
•
•
•
•
230 W
295 W
Standard: 2 x 30 AH
Option: 2 x 40 AH
30A
•
•
•
•
•
230 W
295 W
Standard: 2 x 30 AH
Option: 2 x 40 AH
30A
Main battery fuse
(6 km/h)
Main battery fuse
(10 km/h)
Charger
•
•
60 A
•
60 A
On board, Input 230V AC, Output • On board, Input 230V AC, Output 3
3 A, 24V DC for 40 Ah batteries
(external battery charger plug also
available on rear of control panel)
A, 24V DC for 40 Ah batteries
(external battery charger plug also
available on rear of control panel)
Weight
Empty weight
(including 30 Ah
batteries)
•
88 kg*
•
94 kg*
Weight of
•
•
21.4 kg
150 kg
•
•
25 kg
heaviest part
Maximum load
(payload)
150 kg
59
Download from Www.Somanuals.com. All Manuals Search And Download.
3-Wheel Version
4-Wheel Version
Dimensions
Height
Width
Length (w/o bumpers and
anti-tippers)
•
•
•
120 cm*
61 cm*
120 cm*
•
•
•
120 cm*
61 cm*
122 cm*
Seat height (measured
from the chassis, manually
adjustable)
•
43, 45, 47, 49 cm*
•
43, 45, 47, 49 cm*
Backrest height (w/o
headrest)
Backrest height (with
headrest)
Backrest angle (manually
adjustable)
•
•
•
44 cm*
•
•
•
44 cm*
63 cm*
63 cm*
0°, 10°, 15°, 30°
0°, 10°, 15°, 30°
Seat width
Seat depth
Armrest height
Tyres
•
•
•
44-55 cm*
44 cm*
23-29 cm*
•
•
•
44-55 cm*
44 cm*
23-29 cm*
Tyre pressure if fitted with
pneumatic tyres
•
2.5 bar (40 psi)
•
2.5 bar (40 psi)
60
Download from Www.Somanuals.com. All Manuals Search And Download.
3-Wheel Version
4-Wheel Version
Driving attributes
Speed (6 km/h)
Speed (10 km/h)
•
•
•
6.4 km/h (4 mph)
10 km/h (6,2 mph)
up to 120 kg load: 12°
(21%)
•
•
•
6.4 km/h (4 mph)
10 km/h (6,2 mph)
12° (21%)
Safe climbing capability
•
up to 150 kg load: 10°
(17%)
Maximum obstacle height
Minimum turning radius
Range according to ISO
7176 **
•
•
8 cm
120 cm
•
•
8 cm
150 cm
6 km/h version with 30 Ah
batteries:
6 km/h version with 40 Ah
batteries:
10 km/h version with 30
Ah batteries:
10 km/h version with 40
Ah batteries:
•
•
•
•
32 km (20 miles)
40 km (25 miles)
24 km (15 miles)
32 km (20 miles)
•
•
•
•
32 km (20 miles)
40 km (25 miles)
24 km (15 miles)
32 km (20 miles)
* Approximately.
** Note: The scooter's range depends strongly on various factors, such battery charge, ambient temperature, local topography, road conditions, tyre pressure, driver's
weight, driving habits and the usage the batteries for lighting, actuators, and so on.
61
Download from Www.Somanuals.com. All Manuals Search And Download.
13 Inspections Performed
It is confirmed by stamp and signature that all jobs listed in the inspection schedule of the Service
and Repair Instructions have been properly performed. The list of the inspection jobs to be
performed can be found in the Service Manual which is available through Invacare®.
Delivery Inspection
1st Annual Inspection
Stamp of authorised Dealer / Date / Signature
2nd Annual Inspection
Stamp of authorised Dealer / Date / Signature
3rd Annual Inspection
Stamp of authorised Dealer / Date / Signature
4th Annual Inspection
Stamp of authorised Dealer / Date / Signature
5th Annual Inspection
Stamp of authorised Dealer / Date / Signature
Stamp of authorised Dealer / Date / Signature
62
Download from Www.Somanuals.com. All Manuals Search And Download.
63
Download from Www.Somanuals.com. All Manuals Search And Download.
|