Operating Instructions
ꢀree Standing Gas Cooker
Contents
GB
Introduction, 2
GB
ꢀor Your Safety, 3
English, 1
Clock and Minute Minder Operation, 4-5
Hotplate, 6
Grill, 7
Main Oven, 8
Main Oven Cooking Charts, 9-10
Top Oven, 11
Top Oven Cooking Charts, 12-13
Care and Cleaning, 14
Something Wrong with your cooker?, 15
Installation Instructions, 16-18
If it still Won't Work, 21
Guarantee Information, 22
Service Information, 23
KD6G25SAIR
KD6G25SXIR
KD6G25SWIR
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢀor your Safety
Please read the precautions below before using
your cooker.
GB
ALWAYS . . .
NEVER . . .
ALWAYS make sure you understand the controls
before using the cooker.
NEVER
leave children unsupervised where the
cooker is installed as all surfaces will get
hot during and after use.
allow anyone to sit or stand on any part of
the cooker.
store items that children may attempt to
reach above the cooker.
heat up unopened food containers as
pressure can build up causing the container
to burst.
ALWAYS check that all controls on the cooker are
turned off after use.
NEVER
NEVER
NEVER
ALWAYS stand back when opening an oven door to
allow heat to disperse.
ALWAYS use dry, good quality oven gloves when
removing items from the ovens.
ALWAYS take care when removing items from the
top oven/grill when the main oven is on, as
the contents may be hot.
ALWAYS keep the oven and grill doors closed when
the cooker is not in use.
ALWAYS place pans centrally over the hotplate
burners and position them so that the
handles cannot accidentally be caught or
knocked or become heated by other
burners.
NEVER
NEVER
store chemicals, food stuffs, pressurised
containers in or on the cooker, or in cabinets
immediately above or next to the cooker.
fill a deep fat frying pan more than 1/3 full
of oil, and never use a lid. DO NOT LEAVE
UNATTENDED WHILE COOKING.
place flammable or plastic items on or near
the hotplate.
NEVER
NEVER
ALWAYS keep the cooker clean, as a build up of
grease or fat from cooking can cause a fire.
ALWAYS allow the cooker to cool before cleaning.
ALWAYS follow the basic principles of food handling
and hygiene to prevent the possibility of
bacterial growth.
use proprietary spillage collectors on the
hotplate.
NEVER
NEVER
use the cooker as a room heater.
dry clothes or place other times over or
near to the hotplate or oven/gril doors.
wear garments with long flowing sleeves
whilst cooking.
NEVER
ALWAYS keep ventilation slots clear of obstructions.
ALWAYS turn off the electricity supply before
cleaning or replacing an oven lamp.
ALWAYS refer servicing to CORGI registered
appliance service engineers.
NOTE: The use of a gas cooking appliance results
in the production of heat and moisture in the room in
which it is installed. Always ensure that the kitchen
is well ventilated; keep natural ventilation holes open
or install a mechanical ventilation device
(mechanical extractor hood).
In particular when using the grill or more than one
hotplate burner, open a window if a mechanical
ventilation device is not operating.
! The appliance should not be operated by people
(including children) with reduced physical, sensory
or mental capacities, by inexperienced individuals or
by anyone who is not familiar with the product.
These individuals should, at the very least, be
supervised by someone who assumes responsibility
for their safety or receive preliminary instructions
relating to the operation of the appliance.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Clock and Minute Minder
CLOCK OPERATION
GB
To Set Time of Day
Step 1
Step 2
Check that the electricity supply to the
cooker is turned on.
00.00
When switched on the display will show
0.00 flashing intermittently.
Step 3
Press the "
" button and
then press either the "+" or "-" buttons to
set the correct time of day.
12.00
Note: If the electricity supply has been off, the "+"
button must be pressed once before the "-" button, if
it is required to reduce the time of day.
THE TIME Oꢀ DAY IS NOW SET.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Clock and Minute Minder
MINUTE MINDER OPERATION
GB
00.20
To Set the Minute Minder
Step 1 Press the "+" button until the required time
is set. A "Bell" symbol will light up. During
setting the time adjusts in 10 second
intervals up to a maximum of 99mins
50secs.
It can also be adjusted by pressing the "-" button.
At the end of the set time, a bleeping sound will be
heard and the "Bell" will disappear.
13.23
The bleeper can be cancelled by pressing the "+"
button.
The minute minder can be cancelled before the
bleeper sounds by pressing the "+" and "-" buttons
together until 0.00 appears in the display window.
BLEEPER SOUND
To adjust the pitch of the bleeper, press the "-"
button while the bleeper is sounding.
!or example:-
(a) Press the "+" button and set 10 seconds.
(b) When the bleeper sounds, press and release the "-
" button, until preferred pitch is set.
(c) Press and release the "+" button to cancel the
bleeper.
NOTE: If the sound of the bleeper appears to be
different, it is most likely that the pitch of the
bleeper has been inadvertently adjusted.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Hotplate
The hotplate lid is fitted with a safety device which
cuts off the gas supply to the hotplate burners
unless the lid is fully open. Do not use the safety
device as a means of controlling the hotplate
burners.
If aluminium based pans are used, a silvery deposit
may appear on the top edge of the pan support
fingers. See 'Care and Cleaning' section for cleaning
information.
GB
SAꢀETY REQUIREMENTS ꢀOR DEEP ꢀAT ꢀRYING
1. Never fill chip pans more than one third full with oil
or fat.
2. Never leave oil or fat unattended during the heating
or cooling period.
3. Never heat fat or fry with a lid on the pan.
4. Always dry food thoroughly before frying, and lower
it slowly into the hot oil or fat. !rozen foods in
particular will cause frothing and spitting if added
too quickly.
The hotplate has one high speed burner, two normal
simmering burners and one small simmering burner
which will accommodate pans between 120mm (5")
and 260mm (10") diameter. Locate the pan support
trivet above one of the simmering burners if a very
small pan is being used.
All pans should be positioned centrally over the
burners.
TO USE THE HOTPLATE
5. Always keep the outside of the pan clean and free
from streaks of oil or fat.
1. Remove any items or spillage from the top of the
lid and then raise it to its fully open position.
2. Press in the ignition button and then push in and
turn the control knob fully anti-clockwise. Continue
to push in the control knob for a further 3 seconds
after the gas has lit to allow time for the safety
device to operate. If the burner extinguishes when
the control knob is released, repeat the procedure
ensuring the control knob is fully depressed and
allowing more time for the safety device to opera-
te.
HOW TO DEAL WITH A ꢀAT ꢀIRE
1. Do not move the pan.
2. Turn off the hotplate burners.
3. Smother the flames with a fire blanket or damp cloth
to extinguish the fire. Do not use water or a fire
extinguisher as the force of it may spread the
burning fat or oil over the edge of the pan.
4. Leave the pan for at least 60 minutes before moving
it.
3. Turn the control knob anti-clockwise to reduce the
heat input. Only turn the control knob between the
large flame symbol and the small flame symbol
when adjusting the setting.
4. To turn off, turn the control knob fully clockwise to
the symbol O.
DONOT use the hotplate unless all pan supports
are in position.
DONOT use mis-shapen pans which may be
unstable.
DONOT use round base woks directly on the pan
supports.
DONOT use the glass lid as a working surface.
Each burner is fitted with a spark ignitor for lighting
the gas. To ensure rapid lighting of the burners
every time they are used, the ignitors must be kept
clean and dry. Remove any food spillage or
cleaning materials from the ignitor using a small
nylon brush such as a tooth brush. Access to the
ignitor can be achieved by lifting off the loose burner
parts carefully when the burners are cool.
When the hotplate burner bodies and caps are
removed for cleaning, be careful not to drop any
food particles or cleaning materials into the burner
bases, to avoid the possibility of blocking the gas
jets.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Grill
CAUTION - ACCESSIBLE PARTS MAY BECOME
HOT WHEN THE GRILL IS USED.
5. Press the ignition button and then push in and turn
the control knob clockwise to the large flame symbol.
Continue to push in the control knob for a further 3
seconds after the gas has lit, to allow time for the
safety device to operate. If the burner extinguishes
when the control knob is released, repeat the proce-
dure ensuring the control knob is fully depressed and
allowing more time for the safety device to operate.
6. Slide the grill pan along the shelf towards the rear of
the grill compartment until it stops.
GB
YOUNG CHILDREN SHOULD BE KEPT AWAY.
The grill is fitted with a safety device that will cut off
the gas supply to the burner if the flame is
extinguished for any reason. Each time the grill is
used, the safety device has to be activated by
pushing and holding in the control knob for 3
seconds after the gas has lit.
A gentle flow of air will be blown from underneath the
control panel when the grill or top oven is in use. If
the fan fails to blow air when the grill is in use, you
should contact your service engineer immediately.
7. Turn the control knob anti-clockwise to reduce the heat
input. Only turn the control knob between the large
flame symbol and the small flame symbol when
adjusting the setting.
STANDARD GRILL PAN AND HANDLE
The grill pan handle is
8. To turn off, turn the control knob anti-clockwise to the
symbol O.
detachable from the pan and
should always be removed
while grilling to prevent the
handle from becoming hot. The
handle should be attached as
The grill cannot be used at the same time as the top
oven. If for any reason the grill burner has not lit
after 15 seconds, turn the control knob to the off
position, leave the grill door open and wait for at
least a minute before attempting to light the burner
again. An odour may be noticed when first using the
grill - this should cease after a short period of use.
follows :
A
1. Tilt the handle over the recess
(A).
2. Slide the handle towards the
centre of the pan (B).
DO NOT use the grill with the door closed.
DO NOT cover the grill pan or grid with aluminium
foil as this can hold fat, intensify the heat
and create a fire hazard.
3. Locate the handle over the
bracket (C) ensuring that it is
centralised and secure.
B
RELIGHTING THE BURNER
Both the grill pan and the oven
shelf can be stored in the grill
compartment if the shelf is
In the event of the burner flames being accidentally
extinguished, turn off the burner control and do not
attempt to re-ignite the burner for at least one minute.
Grilling can be started from cold but for best results
preheat for approximately two minutes. Most cooking
is done with the heat on full, but it may be desirable to
reduce it for thicker pieces of meat or for keeping food
warm. !or au gratin dishes eg. Macaroni Cheese and
meringue toppings eg. Baked Alaska, place the dish
on the floor of the grill compartment. The base of the
grill pan can be used for warming fruit garnishes on the
reduced setting.
placed in the lowest position.
The grill pan should always be
removed from the top oven when
baking and NEVER used as a
baking/roasting dish in either the
C
top oven or the main oven.
IMPORTANT (KD6G25M
(A)
KD6G25W): When using the
grill, the oven door must be left
open. Position the deflector (B)
between the control panel and
deflector (A), to prevent the
cooker knobs from overheating.
(B)
REMOVE HEAT SHIELD
ꢀROM SHELꢀ WHEN
GRILLING ꢀOR MAXIMUM
GRILLING AREA.
TO USE THE GRILL
1. !it the deflector (B) as above (KD6G25M KD6G25W).
2. Open the top oven/grill door and remove the grill pan.
3. Remove the heat shield from the rear of the shelf for
maximum grilling area.
NOTE: Strong detergents used in dishwashers may
damage the grill pan grid finish; clean in soapy water
as described in CARE AND CLEANING section.
4. Place the shelf in the appropriate position.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven
The main oven is fitted with a safety device that will
cut off the gas supply to the burner if the flame has
been extinguished for any reason. Each time the
main oven is used, the safety device has to be
activated by pushing and holding in the control knob
for 3 seconds after the gas has lit.
COLD START COOKING
GB
Anything requiring long slow cooking such as
casseroles and rich fruit cakes can be put into a
cold oven. Satisfactory results can also be obtained
with creamed mixture, rich pastries or yeast
mixtures, but for perfection we recommend
preheating the oven for about 15 minutes at the gas
mark you require for cooking.
The oven has different heat zones - the thermostat
settings refer to the temperature on the middle shelf
position; above this shelf it is hotter and below it is
cooler. Two shelves provide five possible cooking
levels enabling full use of the different temperatures
inside the oven.
ROASTING Oꢀ LARGE POULTRY
The maximum weight of poultry that can be
accommodated is 11.5kg (25 lbs) of suitable shape.
It is important to check that the bird DOES NOT
overhang the burner at the back of the oven.
Each shelf has a safety stop to prevent if from being
pulled out too far when attending to food. Shelves
are removed from the oven by pulling them out to
the stop and then lifting them at the front to
withdraw.
STORAGE AND RE-HEATING Oꢀ ꢀOOD
It is vitally important to strictly adhere to the basic
principles of food handling and hygiene to prevent
the possibility of bacterial growth.
The maximum size of baking tray that should be
used is 325mm x 350mm (13" x 14").
1. If food is to be frozen or not served immediately,
cool it in a clean container as quickly as possible.
2. Completely thaw frozen food in the refrigerator
before re-heating.
TO USE THE MAIN OVEN
1. Place the oven shelves in the appropriate positions
(refer to cooking charts).
2. Press in the ignition button and then push in and turn
the control knob fully anti-clockwise. Continue to push
in the control knob for a further 3 seconds after the
gas has lit to allow time for the safety device to ope-
rate. If the burner extinguishes when the control knob
is released, repeat the procedure ensuring the control
knob is fully depressed and allowing more time for
the safety device to operate.
3. Re-heat food thoroughly and quickly either on the
hotplate or in a hot oven, Mk. 6, and then serve
immediately.
4. Only re-heat food once.
'COOK CHILL' DISHES
These should always be placed in a pre-heated oven
ideally on the first or second shelf position. !ollow
the packet instructions for cooking time.
3. Turn the control knob clockwise to the required setting
(refer to cooking chart).
4. To turn off, turn the control knob fully clockwise the
the symbol O.
ALUMINIUM ꢀOIL
If using Aluminium !oil:
1. Remember that it is important to increase the
cooking time by one third.
If for any reason the oven burner has not lit after 15
seconds, turn the control knob to the O!! position.
Leave the main oven door open and wait for at least
1 minute before attempting to light the burner again.
Never place dishes over the burner.
2. Never allow the foil to touch the sides of the oven.
3. Never cover the oven interior with foil.
4. Never cover the oven shelves with foil.
An odour may be noticed when first using the oven -
this should cease after a short period of use.
RELIGHTING THE BURNER
In the event of the burner flames being accidentally
extinguished, turn off the burner control and do not
attempt to re-ignite the burner for at least one minute.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven Cooking Chart
The following times and setting are for guidance
only. You may wish to alter the setting to give a
result more to your satisfaction. When a different
setting to that shown below is given in a recipe, the
recipe instructions should be followed.
Allow 15 minutes preheat for best results.
GB
Always turn the thermostat knob to Mark 9 first,
before turning back to the required Gas Mark.
Shelf position 1 is the highest.
Gas
Mark
Shelf
Positions
!ood
Approx. Cooking Time and Comments
STARTERS
Patés and Terrines
FISH
3 or 4
4
1 ½ - 2 hrs
Oily !ish (whole)
4 or 5
3
3
25 mins - 1 hr, depending on recipe and size of fish.
25 - 30 mins.
White !ish (fillets & steaks) 4 or 5
MEAT AND POULTRY
Veal
Beef
5
4
4
25 mins per lb (450g) + 25 mins.
4 or 5
25 - 30 mins per lb (450g) + 25 mins.
40 mins per lb (450g) covered in foil + 40 mins per lb (450g)
uncovered.
Ham
5
4
Lamb
5
4
4
4
4
30 - 35 mins per lb (450g) + 30 mins.
40 mins per lb (450g) + 40 mins.
25 mins per lb (450g) + 25 mins.
25 mins per lb (450g) + 25 mins.
Pork
5
5
Chicken
Duckling & gosling
Turkey
5
4 or 5
4 or 5 15 - 20 mins per lb (450g) + 20 mins.
50 mins Removed bacon for last 15 mins. Add extra 15 mins if roasting
brace
Game birds
6
3
4
Casseroles
3 or 4 1 ½ - 6 hrs. (depending on type of meat)
PUDDINGS
Milk Puddings
Baked Custard
Baked sponges
Baked Apples
Meringue puddings
Apple Pie 1x9" (230 mm)
!ruit crumbles
3
3 or 4 2 ¼ - 2 ½ hrs stand dish on a baking tray and started with warm milk
3 or 4 45 mins in bain-marie
3
4
3
4
40 - 45 mins
3
1
30 - 45 mins depending on the size and type of apples
4 or 5 15 mins or until 'tinged' with brown
6
3
3
45 - 55 mins stand dish on a baking tray
35 - 45 mins
5 or 6
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven Cooking Chart
Gas
Mark
Shelf
Positions
GB
!ood
Approx. Cooking Time and Comments
CAKES, PASTRIES AND BISCUITS
Small cakes - 2 trays
- 1 tray
5
5
1 & 3 17 - 25 mins
2 or 3
"
only
Victoria sandwich 2x8" (205mm)
!atless sponge 2x7" (180mm) - 3 egg mix
Christmas cake
4
5
2
4
2
6
1 & 3 25 - 35 mins.
2
20 - 25 mins. 2 tins side by side
3 or 4 4 - 6½ hrs depending on recipe
Madeira cake 7"
3
3
1¼ - 1½ hrs.
3 - 3½ hrs.
Rich !ruit cake 9" (230mm)
Shortcrust pastry
2 or 3 15 mins - 1 hr depending on recipe
20 - 40 mins. depending on recipe
1 & 3 10 - 30 mins. depending on recipe
Rich Shortcrust
pastry - 1 tray
5
7
2
!laky & puff
pastry - 2 trays
!laky & puff
pastry - 2 trays
2 or 3
2
"
"
"
"
Choux pastry - éclairs
1 tray
6
7
35 - 40 mins
Scones - 2 trays
Scones - 1 trays
1 & 3 10 - 15 mins
2 or 3
4
"
Shortbread - 7"
(180mm) round
2
4
55 - 1hr depending on thickness
Biscuits - 2 trays
Biscuits - 1 trays
1 and 3 15 - 20 mins depending on recipe
2 or 3
"
"
"
"
YEAST MIXTURES
Bread
7 or 8
7 or 8
5
3 or 4 45 - 50 mins
3 or 4 15 - 20 mins
2 or 3 30 - 40 mins
Rolls
Chelsea buns
MISCELLANEOUS
Yorkshire Pudding - large
Yorkshire Pudding - individual
Soufflés
7
7
1 or 2 45 - 50 mins
1 or 2 25 - 30 mins
4
3
30 mins
2 - 5 hrs starting on shelf 4 until 'set' and then on the
Cook baseplate baseplate until dried out - turn when necessary.
Slow
4 &
Meringues
Baked Potatoes
4 or 5
3
1½ - 4 hrs until soft, depending on size
When baking with two trays or tins on two levels, the
top tray is removed first and the lower tray moved
up to the top position for a few minutes longer.
Soft Margarine - Use the oven settings
recommended by the margarine manufacturer and
not those indicated on the cooking chart.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Top Oven
The top oven can be used to cook small quantities
of food or used in conjunction with the main oven to
provide additional cooking space.
GUIDANCE ON USING THE TOP OVEN
1. Best results are obtained by pre-heating the oven
for about 15 minutes.
GB
The top oven is fitted with a safety device that will
cut off the gas supply to the burner if the flame is
extinguished for any reason. Each time the top oven
is used, the safety device has to be activated by
pushing and holding in the control knob for 3
seconds after the gas has lit.
2. !ood which is higher than or will rise above 125mm
(5") cannot be cooked in the top oven.
Never place dishes over the burner.
An odour may be noticed when first using the oven -
this should cease after a short period of use.
A gentle flow of air will be blown from underneath the
control panel when the grill or top oven is in use.
The shelf in the top oven has a heat shield fitted at
the rear. The shield can be removed for cleaning and
grilling, but should be replaced when using the oven
for best cooking results. It has a safety stop to
prevent it from being pulled out too far when
attending to food.
RELIGHTING THE BURNER
In the event of the burner flames being accidentally
extinguished, turn off the burner control and do not
attempt to re-ignite the burner for at least one
minute.
The shelf is removed from the
oven by pulling it out to the
stop and then lifting at the
front to withdraw.
The maximum size of baking
tray that should be used is
300mm x 350mm (12" x 14").
TO USE THE TOP OVEN
1. Check that the heat shield is fitted to the shelf.
2. Place the top oven shelf in the appropriate position
(refer to cooking chart).
3. Press in the ignition button and then push in and
turn the control knob fully anti-clockwise. Continue
to push in the control knob for a further 3 seconds
after the gas has lit to allow time for the safety
device to operate. If the burner extinguishes when
the control knob is released, repeat the procedure
ensuring the control knob is fully depressed and
allowing more time for the safety device to opera-
te.
4. Turn the control knob clockwise to the required
setting. (refer to cooking chart).
5. To turn off, turn the control knob clockwise to the
symbol O.
Always push the door firmly closed to ensure that
there is no loss of heat through the door seal.
If for any reason the oven burner has not lit after 15
seconds, turn the control knob to the O!! position.
Leave the top oven door open and wait for at least 1
minute before attempting to light the burner again.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Top Oven Cooking Chart
The following times and setting are for guidance
only. You may wish to alter the setting to give a
result more to your satisfaction. When a different
setting to that shown below is given in a recipe, the
recipe instructions should be followed.
Allow 15 minutes preheat for best results. Always
GB
turn the thermostat knob to Mark 8 first, before
turning back to the required Gas Mark.
Gas
Mark
Shelf
Positions
!ood
Approx. Cooking Time and Comments
STARTERS
Oily and white fish
MEAT AND POULTRY
Beef (medium)
5
2
20 - 30 mins.
4 or 5
5
3
3
25 - 30 mins per lb + 25 - 30 mins.
40 mins per lb + 40 mins
Ham (covered in foil)
Lamb
5
3
30 - 35 mins per lb + 30 mins.
Pork
5
5
5
4
3
3
3
3
3
3
40 mins per lb + 40 mins.
Chicken
25 mins per lb + 25 mins.
Duckling & Goose
Turkey
25 mins per lb + 25 mins.
15 - 20 mins per lb + 15 - 20 mins.
2 - 4 hrs. depending on meat used
Casseroles
VEGETABLES
Baked jacket potatoes
PUDDINGS
5
2
1 ½ hrs.
Milk Puddings (500ml/1pt)
3
3
2
2
1 ½ hrs.
Baked Custard
(500ml/1pt)
45 mins - 1 hr. in bain-marie of cold water
Baked Sponge Puddings
Baked Apples
4
3
2
2
30 - 45 mins
45 mins - 1 hr. depending on size
Meringue Topped
Puddings
1
2
25 mins until tinged with brown
Apple Tart (1x205 mm)/8")
!ruit Crumble
6
5
2
2
60 mins
45 - 50 mins
2. Do not allow the foil to touch the sides of the oven.
3. Do not cover the oven interior with foil.
4. Do not cover the oven shelves with foil.
If using aluminium foil:
1. Remember it is important to increase the cooking
time by one third.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Top Oven Cooking Chart
Gas
Mark
Shelf
Positions
GB
!ood
Approx. Cooking Time and Comments
CAKES, PASTRIES AND BISCUITS
Small Cakes (16 per tray)
Victoria sandwich (2x180mm / 7 ")
Swiss Roll (3 egg quantity)
Christmas cake (1 x 205mm / 8")
Madeira cake (1 x 180mm / 7")
Rich !ruit cake (1 x 180mm / 7")
Gingerbread
5
4
2
2
2
20 - 25 mins
25 - 30 mins.
10 - 12 mins.
6
2
2 or 3 4 - 5 hrs depending on recipe
1 hr.
2 or 3 2¼ - 2½ hrs.
4
2
2
3
2
2
2
2
2
2
2
2
1½ - 1¾ hrs.
Scones - 16 per tray
Shortbread (1 x 180mm / 7")
Biscuits
7
12 - 15 mins.
2
45 mins. - 1hr depending on thickness
15 - 25 mins.
4 - 6
6
Shortcrust Pastry
15 mins. - 1 hr. depending on recipe
20 - 30 mins.
Rich Short Crust
5
!laky/Puff Pastry
7
10 - 30 mins. depending on recipe
25 - 35 mins.
Choux Pastry
6
YEAST MIXTURES
Bread - rolls, plait
7
5
2 or 3 25 - 35 mins
Tea breads etc.
2
25 - 30 mins
MISCELLANEOUS
Yorkshire Pudding - small
Yorkshire Pudding - large
Meringues
7
7
1
2
2
2
20 - 25 mins
30 - 40 mins
2½ - 4 hrs turn when necessary.
Soft Margarine - Use the oven settings
recommended by the margarine manufacturer and
not those indicated on the cooking chart.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Cleaning
! Never use steam cleaners or pressure cleaners
on the appliance.
! To move the cooker forward, open the top oven/grill
door and with both hands positioned under the roof
of the compartment, lift and pull forward. Replace by
pushing the cooker backwards.
GB
! Clean the glass part of the oven door using a
sponge and a non-abrasive cleaning product, then
dry thoroughly with a soft cloth. Do not use rough
abrasive material or sharp metal scrapers as these
could scratch the surface and cause the glass to
crack.
! Check that the cooker is level. Take care not to
damage any floor coverings.
REPLACEMENT Oꢀ OVEN LIGHT BULB
CAUTION: DISCONNECT THE APPLIANCE ꢀROM
THE ELECTRICITY SUPPLY BEꢀORE
REPLACING THE LAMP TO AVOID THE
POSSIBILITY Oꢀ AN ELECTRIC SHOCK.
Light bulbs are not covered by the manufacturer's
guarantee.
! The accessories can be washed like averyday
crockery (even in your dishwasher).
! Switch off the electricity supply and allow to
cool before cleaning the cooker.
A new 25W, 300°C rated SES bulb can be obtained
from your cooker supplier or any major electrical
retailer.
! Clean the cooker regularly and wipe up spills
soon after they occur to prevent them from
becoming burnt on. Never use biological
washing powder, caustic cleaners, harsh
abrasives, scouring pads, steam cleaners,
aerosol cleaners or oven chemical cleaners of
any kind.
1. Remove the shelves from the oven.
2. Unscrew the lens using a thick cloth to protect your
fingers in the unlikely event of a lens fracture.
3. Unscrew bulb.
4. !it new bulb and refit lens.
! If it is necessary to remove the cooker for
cleaning, ensure that it is cool and beware that it
is heavy (approximately 70 kg 155 lbs).
COOKER FINISH
CLEANING METHOD
Cloth wrung out in warm soapy water. Stubborn stains can be
removed with a cream paste, liquid cleaner or by rubbing with fine
steel wool soap pads.
Vitreous Enamel
Door inner panels, pan supports, burner caps,
roasting dish, grill pan, main oven base, inside of
grill compartment.
Check that the cleaning agent is approved by the Vitreous Enamel
Association.
Paint
Side panels.
Wash with a cloth wrung out in warm soapy water only.
DO NOT USE ABRASIVES.
Aluminium
Hotplate burner bodies, lid rear trim.
Similar to paint cleaning above. Use a nylon brush to remove any
cleaning materials, water or dirt from the hotplate burner bodies.
Glass
As for enamel cleaning. Polish with a clean dry cloth or kitchen roll.
Chromium Plating
Oven shelves, grill pan grid, grill pan handle
support.
Wipe with a cloth wrung out in warm soapy water. A fine steel wool
soap pad e.g. Brillo, Ajax, or a chrome or stainless steel cleaner
may be used.
Plastic
Grill pan handle, control knobs.
Wipe with a cloth wrung out in warm soapy water.
Wipe with a cloth wrung out in warm soapy water. Polish with a
clean dry cloth or kitchen towel. !or stubborn stains, use a
proprietary stainless steel cleaner and follow the instructions on the
container.
Stainless Steel
Hotplate, control panel.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Something Wrong
with your Cooker
Before contacting your Service Centre or
Installer, check the problem guide below, there
may be nothing wrong with your cooker.
GB
PROBLEM
CHECK
Burner will not light:
If all burners fail to ignite:
Check that sparks appear at the burners; a clicking noise should
be heard.
If not;
Check that the electricity supply is turned on.
If the electricity supply has failed, all burners can be lit by a match.
If only one burner fails to ignite:
Hotplate burner:
Check that the burner is dry and that spillage of food or cleaning
fluid remains are not affecting the ignitor or burner ports.
Clean away any debris with a dry nylon brush such as an old
toothbrush. If a wire wool pad has been used for cleaning around
the burner ensure the ignitor is free from any stray strands. Any
water on the burner should be dried with a cloth or kitchen towel.
On the hotplate make sure that all the burner parts are correctly
seated.
Burner ports Ignitor
Slight odour or small amount of smoke when grill / This is normal and should cease after a short period.
oven used first time.
Oven cooks too fast or too slow.
Check that the gas mark and shelf positions are as recommended
in the Oven Cooking Charts. However, it may be necessary to
increase or decrease the recommended setting slightly to suit your
taste.
Oven lamp does not work.
The oven lamp is not covered by the guarantee. The part is easily
changed (see the section on oven lamp replacement).
A new lamp may be obtained from our Parts department, (see back
page).
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Prior to installation, ensure that the local distribution
conditions (nature of the gas and gas pressure) and
the adjustment conditions are compatible. The
adjustment conditions for this appliance are stated
on the data badge which is fitted on the back panel.
This appliance is not designed to be connected to a
combustion products evacuation device. It must be
installed and connected in accordance with current
installation regulations. particular attention should be
given to the relevant requirements regarding
ventilation.
LOCATION
GB
The cooker may be located in a kitchen, kitchen/
diner or a bed-sitting room, but not in a room
containing a bath or shower. The cooker must not be
installed in a bed-sitting room of less than 20m3.
When adjusted for use on Butane (G30) or Propane
(G31), the cooker must not be installed in a room or
internal space below ground level, e.g. in a
basement.
PROVISION ꢀOR VENTILATION
The room containing the cooker should have an air
supply in accordance with BS 5440: Part 2.
MODEL NUMBERS KD6G25SAIR,
D6G25SXIR, KD6G25SWIR
Category II2H3+ (GB)
The room must have an opening window or
equivalent; some rooms may also require a
permanent vent. If the room has a volume between 5
and 10m3, it will require an air vent of 50cm2
effective area unless it has a door which opens
directly to outside. If the room has a volume of less
than 5m3, it will require an air vent of 100cm2
effective area. If there are other fuel burning
appliances in the same room, BS 5440: Part 2
should be consulted to determine air vent
requirements.
These models are set to burn NATURAL GAS (G20)
at 20 mbar but can be converted for use on BUTANE
(G30) at 28-30mbar or PROPANE (G31) at 37mbar
with the use of the LPG conversion kit that can be
obtained free of charge, if you contact our Genuine
Parts and Accessories department (see Key
Contacts, back page).
GAS SAꢀETY (INSTALLATION & USE)
REGULATIONS
It is the law that all gas appliances are installed by
competent persons in accordance with the current
edition of the above regulations. It is in your interest
and that of safety to ensure compliance with the law.
In the UK, CORGI registered installers work to safe
standards of practice. The cooker must also be
installed in accordance with BS 6172. !ailure to
install the cooker correctly could invalidate the
warranty liability claims and could lead to
prosecution.
TECHNICAL DATA
Gas connection
Rp ½ (½" BSP female)
!ront left hotplate injector
None
Pressure test point
Gas rate adjustment
Aeration adjustment
Electrical connection
None
!lexible cord fitted with a
3 pin 13 amp plug
230/240V a.c. 50Hz.
13A fuse.
G30 at 28-30mbar
G31 at 37mbar
G20 at 20mbar
Burner
Heat Input
3.0 kW
2.0 kW
1.1 kW
2.8 kW
2.5 kW
1.9 kW
Injector
116
103
79
Heat Input
Injector
Hotplate
!ront Left
3.0 kW (220g/h)
86
70
50
85
72
65
Hotplate
Rear Left and Rear Right
2.0 kW (145g/h)
1.0 kW (70g/h)
2.8 kW (200g/h)
2.3 kW (165g/h)
1.9 kW (135g/h)
Hotplate
!ront Right
Grill
129
115
100
Main Oven
Top Oven
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
SPACE ꢀOR ꢀIXING
UNPACKING THE COOKER
Unpack the components from inside the grill and
oven.
GB
The cooker can be close fitted below hotplate level.
This requires a minimum distance of 600mm
between cupboard units of hotplate height.
When installing next to a tall cupboard, partition or
wall, for a minimum distance of 400mm above
hotplate level, allow a side clearance of at least
65mm.
Check that the following parts are present:
Grill pan and grid Top oven/grill shelf heat shield
Main oven shelves (2)
Pan supports
Enamelled
The diagram below illustrates the minimum
clearance between the cooker and adjacent walls,
cupboards etc.
burner caps (4)
Aluminium
burner bodies(4) Literature
Top oven/grill shelf (1)
The wall behind the cooker, 50mm below and
450mm above, and the width of the cooker, must be
a non-combustible material such as ceramic wall
tiles.
LEVELLING
!our skid feet are fitted which can be adjusted up or
down to level the cooker.
If the cooker is to be fitted close to a corner on the
left hand side, ensure that there is a clearance of at
least 50mm to allow the main oven door to open fully
for when removing oven shelves.
CONVERSION ꢀOR USE ON BUTANE
(G30) OR PROPANE (G31)
Each burner requires the injector to be replaced and
bypass screws adjusted or replaced as follows:
1. Remove the loose hotplate burner parts.
2. Using a 7mm socket, replace the hotplate injectors
as appropriate (see table on previous page).
3. Re-position the loose burner parts.
4. Remove the enamelled baffle at the front of the grill
(2 screws).
65 mm Min
5. Remove the screw on the right hand side of the
burner and gently slide the burner off the injector.
6. Using a 7mm socket, replace the grill injector as
appropriate (see table on previous page).
7. Re-assemble the burner and baffle.
8. Inside the top oven, remove the central screw
securing the burner retainer. Slide the retainer to
the right slightly and lift away.
9. Lift the burner assembly and place on the floor of
the oven to the right of the burner opening.
10.Using a 7mm socket, replace the oven injector as
appropriate (see table on previous page).
11.Re-assemble the oven burner and retainer.
12.Replace the main oven injector following the same
procedure as for the top oven.
600 mm Min
COOKER HOODS
13.Carefully pull off the control knobs.
If a cooker hood is to be installed, refer to the
cooker hood manufacturers' instructions regarding
fixing height.
14.Using a narrow flat bladed screwdriver rotate the
bypass screws fully clockwise. The main oven
thermostat bypass screw is located on the body of
the thermostat below the spindle, the top oven
thermostat bypass screw is located on the body of
the thermostat to the right of the spindle and the
hotplate tap bypass screws are located down the
centre of the spindle.
15.Re-assemble the control panel parts.
16.Secure the self-adhesive LPG conversion label over
the gas details on the data badge.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
STABILITY CHAIN
A hole in the gas inlet valve bracket can be used to
engage a stability chain.
GB
CONNECTING TO GAS SUPPLY
Connection to the cooker should be made with an
approved appliance flexible connection to BS 669. A
length of 0.9 to 1.25m is recommended. The length
of hose chosen should be such that when the cooker
is in situ, the hose does not touch the floor.
Those cookers converted to use on LPG should be
connected with a hose suitable for LPG and capable
of withstanding a pressure of 50 mbar.
An adaptor backplate should be fitted within the
shaded area shown, to allow the cooker to be
pushed fully to the wall and to ensure that the
flexible hose is only likely to come into contact with
areas at the rear of the cooker that do not exceed a
temperature rise of 70°C.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical Connection
WARNING - THIS APPLIANCE MUST BE EARTHED.
CONNECT TO A 230-240V A.C. SUPPLY ONLY.
As the colours of the wires in the mains lead of this
GB
appliance may not correspond with the coloured
markings identifying the terminals in your plug,
proceed as follows:
Connection to the electricity supply should be made
via a properly earthed, readily accessible wall
socket which is adjacent to but not directly above,
and not more than 1.25m away from the appliance
and capable of electrical isolation.
The wire which is coloured green and yellow must be
connected to the terminal in the plug which is
marked with the letter E or by the earth symbol
or coloured green or green and yellow.
The mains lead should be routed such that it cannot
touch hot parts of the cooker i.e. the back panel
above a height of 650mm from the floor.
The wire which is coloured blue must be connected
to the terminal which is marked with the N or
coloured black.
Should this plug not fit the socket outlet in your
home it should be cut off and replaced with a
suitable plug as outlined below.
The wire which is coloured brown must be connected
to the terminal which is marked with the letter L or
coloured red.
NOTE: The removed plug cannot be used for any
other appliance and should therefore be properly
disposed of and not left where children might find it
and plug it into a supply socket - with the obvious
consequent danger.
When wiring the plug, ensure that all strands of wire
are securely retained in each terminal. Do not forget
to tighten the mains lead clamp on the plug.
As the appliance must be earthed, do not use 2-pin
sockets outlets, if you are in doubt, consult a
qualified electrician.
Iꢀ THE ꢀITTED PLUG IS REMOVED
The flexible mains lead must be correctly connected
as below to a three pin plug of not less than 13 amp
capacity. If a B.S. 1363 fused plug is used, it must
be fitted with a fuse which is approved to B.S. 1362.
IMPORTANT: The wires in the mains lead fitted to
this appliance are coloured in accordance with the
following code:
Should the mains lead ever require replacement, it is
essential that this operation be carried out by a
qualified electrician and should only be replaced
with a flexible cord of the same size i.e. 1.0mm2
cross sectional area PVC cable, available from our
parts department (see Back Cover).
Iꢀ A MOULDED PLUG IS ꢀITTED
In the event of replacing a fuse in the plug supplied
an ASTA approved fuse to BS1362 must be fitted.
NOTE: The fuse cover must be refitted when
changing the fuse. In the event of losing the fuse
cover the plug must not be used until a replacement
fuse cover has been obtained and fitted. A new fuse
cover can be obtained from your local Electricity
Board. The colour of the correct replacement fuse
cover is that of the coloured marks or inserts in the
base of the plug.
Green &
Yellow to
Earth
Brown
to Live
Blue to
Neutral
3 Amp
Fuse
Cord
Clamp
GREEN AND YELLOW
BLUE
- EARTH
- NEUTRAL
- LIVE
Make sure that the cable does not become trapped
when pushing the cooker into position.
BROWN
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
INSTALLATION AND OPERATIONAL CHECKS
After installation, check for gas soundness. The
supply pressure can be checked at the front left
hotplate burner injector.
GB
!it the hotplate burner bodies and caps, pan
supports and shelf shield(s).
Referring to the instructions for use where
necessary,
1. Check that the hotplate burners ignite and cross-
light to all ports. Check for a steady flame on the
low setting.
2. Check that the grill burner ignites and cross-lights
to all ports and that the flames remain when the
control is released 3 seconds later, Check for a
steady flame on the low setting.
3. Check that with the main oven set to mark 9, the
burner ignites and that tha flames remain when the
control is released 3 seconds later. Leave the oven
full on with the door closed for 10 minutes, and
check that when the control is turned to mark 1 that
the flame reduces.
4. Check that with the top oven set to mark 8, the
burner ignites and that the flames remain when the
control is released 3 seconds later. Leave the oven
full on with the door closed for 10 minutes, and
check that when the control is turned to mark 1 that
the flame reduces.
5. Check the operation of the timer and oven light.
Instruct the user on operation of the cooker.
On those models adjusted for use with LPG, it is
normal for the oven and grill burners to burn with
yellow tips.
20
Download from Www.Somanuals.com. All Manuals Search And Download.
If it Still Won't Work
Contact the Service Office
(UK: 08709 066 066)
If something is still wrong with your appliance after
you have been through the 'Something Wrong' list:
1. Switch off and unplug the appliance from the mains.
2. Call your nearest Service Office or local importer.
Disposal of your product
GB
To minimise the risk of injury to children please
dispose of your product carefully and safely.
Remove all doors and lids. Remove the mains cable
(where fitted) by cutting off flush with the appliance
and always ensure that no plug is left in a condition
where it could be connected to the electricity
supply.
When you contact us we will want to know the
following:
To help the environment, Local Authority instructions
should be followed for the disposal of your product.
1. Your name, address and postcode.
2. Your telephone number.
3. Clear and concise details of the fault.
4. The Model number and the Serial number of your
appliance.
5. The date of purchase (please keep the receipt as
evidence will be required when an engineer calls)
enter the date here:
Disposal of old electrical appliances
The European Directive 2002/96/EC on Waste
Electrical and Electronic Equipment (WEEE),
requires that old household electrical appliances
must not be disposed of in the normal unsorted
municipal waste stream. Old appliances must be
collected separately in order to optimise the
recovery and recycling of the materials they contain
and reduce the impact on human health and the
environment.
.............................................................................
Please make sure you have all these details ready
when you call.
Spare Parts
Please remember your new appliance is a complex
piece of equipment.
'DIY' repairs or unqualified and untrained service
people may put you in danger, could damage the
appliance and might mean you lose cover under the
Parts Guarantee.
The crossed out "wheeled bin" symbol on the
product reminds you of your obligation, that when
you dispose of the appliance it must be separately
collected.
If you do experience a problem with the appliance
don't take risks, call in our Service Engineer. Our
Parts are designed exclusively to fit your appliance.
Do not use them for any other purpose as you may
create a safety hazard.
Consumers should contact their local authority or
retailer for information concerning the correct
disposal of their old appliance.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
GB
Guarantee
12 months Parts and Labour Guarantee
Your appliance has the benefit of our manufacturer's guarantee, which covers the cost of
breakdown repairs for twelve months from the date of purchase.
This gives you the reassurance that if, within that time, your appliance is proven to be
defective because of either workmanship or materials, we will, at our discretion, either repair
or replace the appliance at no cost to you.
The guarantee is subject to the following conditions:
- The appliance has been installed and operated correctly and in accordance with our
operating and maintenance instructions.
- The appliance is only used on the electricity or gas supply printed on the rating plate.
- The appliance has been used for normal domestic purposes only.
- The appliance has not been altered, serviced, maintained, dismantled or otherwise interfered
with by any person not authorised by us.
- Any repair work must be undertaken by us or our appointed agent.
- Any parts removed during repair work or any appliance that is replaced become our property.
- The appliance is used in the United Kingdom or Republic of Ireland.
The guarantee does not cover:
- Damage resulting from transportation, improper use, neglect or interference or as a result of
improper installation.
- Replacement of any consumable item or accessory. These include but are not limited to:
plugs, cables, batteries, light bulbs, fluorescent tubes and starters, covers and filters.
- Replacement of any removable parts made of glass or plastic.
THE GUARANTEE WILL NOT APPLY I! THE APPLIANCE HAS BEEN USED IN
COMMERCIAL OR NON-DOMESTIC PREMISES.
Extended Guarantees
We offer a selection of protection plans that enable you to fully cover yourself against the
expense of repair bills for the life of your policy. To find the ideal plan for you please call our
advice line on 08709 088 088 (ROI 01 230 0233)
ꢀree Helpdesk Service
We have a dedicated team who can provide free advice and assistance with your appliance
if you experience any technical difficulties within the first 90 days of ownership.
Simply call our Indesit Service Hotline on 08709 066 066 (ROI 0818 313 413) for telephone
assistance, or, where necessary, to arrange for an engineer to call.
22
Download from Www.Somanuals.com. All Manuals Search And Download.
GB
After Sales Service
No one is better placed to care for your Indesit appliance during the course of its working life
than us - the manufacturer.
Essential Contact Information
Indesit Service
We are the largest service team in the country offering you access to 400 skilled telephone
advisors and 1100 fully qualified engineers on call to ensure you receive fast, reliable, local
service.
UK: 08709 066 066
Republic of Ireland: 0818 313 413
Please note: Our advisors will require the following information:
Model number
Serial number
Parts & Accessories
We supply a full range of genuine replacement parts as well as accessory products that
protect and hygienically clean your appliance to keep it looking good and functioning
efficiently throughout its life.
UK: 08709 077 077
Republic of Ireland: 0818 313 413
As part of Indesit's continued commitment to helping the environment, Indesit reserves the
right to use quality, recycled components to keep down customer costs and minimise
material wastage.
Indesit Company UK Limited, Morley Way, Peterborough, PE2 9JB
Indesit Company, Unit 49 Airways Industrial Estate, Dublin 17
23
Download from Www.Somanuals.com. All Manuals Search And Download.
11/2007 - 195067140.01
XEROX BUSINESS SERVICES
GB
24
Download from Www.Somanuals.com. All Manuals Search And Download.
|