LAWN SWEEPER
Model LS340
Starting Serial No. 1001
Owner/Operator's Manual
& Illustrated Parts List
CAUTION
Avoid injuries. Read and understand Operator’s manual
before operating tractor or equipment.
It contains instructions for safe operation.
Form # 09-164
Download from Www.Somanuals.com. All Manuals Search And Download.
TABLE OF CONTENTS
INTRODUCTION
SECTION 1
page
Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
SAFETY
SECTION 2
General Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Operator Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
OPERATION
SECTION 4
Operating Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
SERVICE
SECTION 5
Service Schedule . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
PARTS
SECTION 6
Parts List and Illustrations Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Warranty
12
Form #09-164 reprint 2/96
1
Download from Www.Somanuals.com. All Manuals Search And Download.
INTRODUCTION
section 1.1
Description
The Steiner Lawn Sweeper is designed to give a “clean sweep” in your lawn sweeping operations.
The unit is ground-driven so it can be pulled by any lawn and garden tractor. It can be used to trail behind
with offset hitch while mowing, or regular hitch to clean-up after you've finished mowing. The packing action
allows you to put much more material into the unit before it is necessary to unload.
There is a transport position for the sweeper and clutch levers on each wheel to disengage the wheel
clutches.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
INTRODUCTION
section 1.2
Specifications
Overall width _ _ _ _ _ _ _ _ _ _ _ _ _ _ 62"
Overall height _ _ _ _ _ _ _ _ _ _ _ _ _ _ 52"
Overall length to hitch_ _ _ _ _ _ _ _ _ _ _ 66"
Width of pick up _ _ _ _ _ _ _ _ _ _ _ _ _ 40"
Brush _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 3 paddle, staggered
Depth wheels _ _ _ _ _ _ _ _ _ _ _ _ _ _ Semi-pneumatic
Hitch _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ Right, left or center pull adjustment
Carrying capacity _ _ _ _ _ _ _ _ _ _ _ _ 24 cu. ft.
Weight _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 530 lb.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
SAFETY
section 2.1
BE ALERT!
ATTENTION: This symbol identifies potential health and safety hazards. It marks safety
precautions.
ATTENTION: Your safety is involved.
GENERAL SAFETY
4. Do not leave equipment unattended. STOP
the engine and remove the key.
1. Read and understand the owner's manual,
before attempting to operate this machine.
5. Do not allow minors or the inexperienced to
operate this machine.
2. Operate all controls from the operator's
seat. NO RIDERS.
6. Keep people and pets a safe distance away
from machine using power driven attachments. Injury
could result from flying debris.
3. Keep all shields in place and safety switches
adjusted properly.
OPERATING SAFETY
1. Remove large objects or debris from the path
of the lawn sweeper..
3. Disengage clutches and raise broom to
transport position before transporting at high speed.
2. Before leaving the tractor seat to clear
blockage, service or make adjustments:
1. Set PARKING brake.
2. Stop Engine.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION
section 4.1
Operating Instructions
›
›
›
1. Determine hitch position for offset or straight pull position.
2. Transport to clean-up site with the clutches disengaged and sweeper in transport position.
3. Lower the sweeper housing and adjust sweeper height on right side of sweeper housing by
choosing the pin location to regulate gauge wheel height. NOTE: Operation is best when the
sweeper is approximately 1/2" below the tips of the grass, but does not “scrub” the lawn.
›
›
›
4. Adjust the float springs allowing the sweeper to “float” over rough areas or high spots in the lawn.
5. Engage clutches on both wheels by rotating the lever approximately 180 deg.
6. When sweeping leaves - the best results are obtained by sweeping several times during the leaf
fall rather than waiting until there is a large accumulation. A large accumulation will require several
passes to make a clean sweep. MAXIMUM SPEED IS 10 M.P.H.
›
›
7. Open rear door to unload.
8. To transport - Always disengage wheel clutches and raise sweeper housing. DO NOT TRAVEL AT
HIGH SPEEDS WITH CLUTCHES ENGAGED! MAXIMUM SPEED IS 10 M.P.H. NOTE: to disengage
both wheels rotate each lever approximately 180 deg. You can feel a high spot when it is
disengaged.
CAUTION
Do not travel at high speeds with clutches
engaged. MAXIMUM SPEED IS 10 M.P.H.
Disengage clutches for transport.
MAXIMUM SPEED IS 10 M.P.H.
09-164
5
7/89
Download from Www.Somanuals.com. All Manuals Search And Download.
SERVICE
Section 5.1
Maintenance
Daily
Visually check chain drive - it should not run “dry”.
Lube with chain lube or 30W oil
Weekly or 50 Hours
Grease all bearings and wheels.
Check tire pressure (12 lbs.)
rev 6/00
6
09-164
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS
Section 6.1
Parts Index
GROUP
FIGURE
PAGE
Main Parts. . . . . . . . . . . . . . . . . Fig. 1 . . . . . . . . . . . . . . . . . . . . . . . 8
Brush Parts . . . . . . . . . . . . . . . . Fig. 2 . . . . . . . . . . . . . . . . . . . . . . . 10
7
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS
section 6.2
Main Parts
Figure 1
rev 6/00
8
09-164
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS
section 6.3
Parts List for Figure 1
Description
Ref
Part no.
Quantity
1
2
3
4
5
6
62-602
60-187
42-205
02-CP0406
41-010
40-114
40-115
83-407016
41-013
86-020
86-021
85-K0410
86-043
50-030
53-089
50-101
55-IB-1
29-053
95-16
Main Frame
Door
Hinge Rod
Cotter Pin, 1/8 x 3/4
Spring, 5"
Latch, Right
Latch, Left
Sprocket
Spring
Clutch Pawl, Right
Clutch Pawl, Left
Key, 1/4 x 1-1/4
Clutch
1
1
1
2
2
1
1
1
2
1
1
3
2
2
1
1
1
2
7
2
12
6
8
2
8
1
1
4
1
4
2
4
4
12
8
6
4
4
4
2
2
2
7
8
9
10
11
12
Wheel & Tire Assembly
Tire, 16 x 7.50 x 8, Turfsaver
Rim
Bearing
*
Grease Fitting, 1/4-28 long
Flat Washer, 1" SAE
Cotter Pin
13
14
15
16
17
18
19
20
21
22
23
24
25
*
27
28
29
30
31
32
33
34
35
36
02-CP0612
92-05
90-0528
92-06
Nut, 5/16
Bolt, 5/16 x 3-1/2
Nut, 3/8
Bearing
Bolt, 3/8 x 1-1/4
Bottom Pan
Packer Rotor
Bolt, 1/2 x 1-1/4
Hitch
Nut, 1/2
Hub, Clutch Drive
Decal, Steiner Large
Lock Washer, 1/2
Flat Washer, 3/8 USS
Lock Washer, 3/8
Lock Washer, 5/16
Set Collar, 3/8 ( After Serial #1097)
Flange Bolt, 5/16 x 1 (After Serial #1097)
Flange Nut, 5/16 (After Serial #1097)
Stop, Adjustable Latch (After Serial #1097)
Locknut, Stover 3/8
Bolt, 3/8 x 1
55-FB22016
90-0610
60-188
80-124
90-0810
62-357
92-08
86-044
00-001
96-08
94-06
96-06
96-05
85-SC06
99-K02
99-E12
64-535
99-A06
90-0608
* Not Illustrated
09-164
9
rev 6/01
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS
section 6.4
Brush Parts
Figure 2
rev 6/00
10
Download from Www.Somanuals.com. All Manuals Search And Download.
09-164
PARTS
section 6.5
Parts List for Figure 2
Description
Ref
Part no.
Quantity
1
2
3
4
5
6
7
62-385
92-08
92-06
42-209
41-010
95-10
53-104
55-G527
55-107
53-186
55-112
53-187
90-0640
94-06
40-227
56-RC40-59
81-056
81-076
85-K0410
90-0816
83-H401216
83-4017E08
55-FB23016
79-017
Housing, Brush
Nut, 1/2
Nut, 3/8
Adjuster, Spring Tension
Spring, 5"
Flat Washer, 5/8 SAE
Wheel, 10.25 x 3.25 Caster (Serial No. 1001 - 1559)
Ball Bearing for 53-104
Bearing, 5/8 ID x 1-3/8 OD (Optional, Heavy Duty)
Wheel, 10.25 x 3.25 Caster (Serial No. 1560 - )
Bearing, Roller 5/8 ID X 1-3/8
Retainer, Flanged For 53-186
Bolt, 3/8 x 5
Flat Washer, 3/8 USS
Idler Arm
Chain, Drive #40, 59" long
Connector Link, #40 Chain
Half Link, #40 Chain
Key, 1/4 X 1-1/4
Bolt, 1/2 x 2
Sprocket
Idler Sprocket
Flange Bearing, 2 Bolt, 1"
Brush, Strip
Rotor, Brush
1
3
8
2
3
12
2
2
2
2
1
2
2
2
1
1
1
1
1
1
1
1
2
6
1
1
1
1
1
1
1
2
6
1
2
2
2
2
4
2
4
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
80-125
99-A04
90-0412
02-PP0420
42-207
Locknut, Stover 1/4
Bolt, 1/4 X 1-1/2
Presto Pin, 1/8 x 2-9/16
Transport Handle
Height Adjuster
Presto Pin, 3/32 x 2-5/16
Set Collar, 1"
Flat Washer, 1/2 SAE
Bolt, 1/2 X 2-1/2
Lock Washer, 1/2
42-206
02-PP0318
85-SC16
95-08
90-0820
96-08
90-0810
99-A08
50-062
90-06010
99-E13
96-06
Bolt, 1/2 x 1-1/4
Locknut, Stover 1/2
Shaft, Wheel
Bolt, 3/8 X 1-1/4
Flange Nut, 3/8
Lock Washer, 3/8
09-164
11
Download from Www.Somanuals.com. All Manuals Search And Download.
rev 2/01
Download from Www.Somanuals.com. All Manuals Search And Download.
|