NOTE:
Please read all instructions
carefully before using this
product
Dumbbell Rack
Safety Notice
Hardware Identifier
Assembly Instruction
Parts List
IVK-402
Warranty
Ordering Parts
Model
IVK-402
Retain This
Manual for
Reference
09-20-05
OWNER'S
MANUAL
IMPEX INC.
14777 DON JULIAN RD., CITY OF INDUSTRY, CA 91746
Tel: (800) 999-8899 Fax: (626) 961-9966
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY NOTICE
PRECAUTIONS
This exercise equipment is built for optimum safety. However, certain precautions
apply whenever you operate a piece of exercise equipment. Be sure to read the
entire manual before you assemble or operate your equipment. In particular, note
the following safety precautions:
1. Keep children and pets away from the equipment at all times. DO NOT
leave children unattended in the same room with the equipment.
2. If the user experiences dizziness, nausea, chest pain, or any other abnormal
symptoms, STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
3. Position the equipment on a clear, leveled surface. DO NOT use the equipment
near water or outdoors.
4. Always wear appropriate workout clothing when exercising. DO NOT wear
robes or other clothing that could become caught in the equipment. Running
or aerobic shoes are also required when exercising.
5. Use the equipment only for its intended use as described in this manual. DO
NOT use attachments not recommended by the manufacturer.
6. Do not place any sharp object around the equipment.
7. Disabled person should not use the equipment without a qualified person or
physician in attendance.
8. Before using the equipment to exercise, always do stretching exercises to
properly warm up.
9. Never operate the equipment if the equipment is not functioning properly.
10. The Dumbbell Rack can be cleaned using a damp cloth and mild non-abrasive
detergent. DO NOT use solvents.
11. Maximum weight capacity 400 lbs.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT
YOUR PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS
OVER THE AGE OF 35 OR PERSONS WITH PRE-EXISTING HEALTH
PROBLEMS. READ ALL INSTRUCTIONS BEFORE USING ANY FITNESS
EQUIPMENT. IMPEX INC. ASSUMES NO RESPONSIBILITY FOR PERSONAL
INJURY OR PROPERTY DAMAGE SUSTAINED BY OR THROUGH THE USE OF
THIS PRODUCT.
SAVE THESE INSTRUCTIONS.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING LABEL REPLACEMENT
The Warning Label shown here has been placed on the Cross Brace. If the label is missing or illegible, please
call customer service at 1-800-999-8899 for replacement. Apply the label in location shown.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
HARDWARE PACK
4
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTION
Tools Required Assembling the Machine: Adjustable Wrench and Allen Wrench
NOTE: It is strongly recommended two or more people assembling this equipment
to avoid possible injury.
STEP 1 (See Diagram 1)
A.) Place the Cross Brace (#1) in between the Left & Right Upright Beams (#2 & #3).
B.) Secure each end with three M10 x 3” Allen Bolts (#15), two Brackets (#5), six Ø ¾”
Washers (#14), and three M10 Aircraft Nuts (#13). Do not tighten the Nuts and Bolts
yet.
DIAGRAM 1
5
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 2 (See Diagram 2)
A.) Attach one Floor Stabilizer (#4) in between the two Brackets (#5) to the Right Upright
Beam (#3).
B.) Secure it with one M10 x 3” Allen Bolt (#15), two Ø ¾” Washers (#14), and one M10
Aircraft Nut (#13). Repeat the same procedure to install the other side.
C.) Place the Upper Dumbbell Rack (#7) onto the top dumbbell support on the Left & Right
Upright Beams. Secure each end with two M10 x 3” Allen Bolts (#15), four Ø ¾”
Washers (#14), and two M10 Aircraft Nuts (#13). Do NOT tighten the Nuts and Bolts
yet.
DIAGRAM 2
6
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 3 (See Diagram 3)
A.) Place the Lower Dumbbell Rack (#6) onto the second level of dumbbell support on the
Right and Left Upright Beams.
B.) Secure each end with two M10 x 3” Allen Bolts (#15), four Ø ¾” Washers (#14), and two
M10 Aircraft Nuts (#13). Repeat the same procedure to install the other Lower Dumbbell
Rack.
C.) Cover all ends of Upper and Lower Dumbbell Racks with six Dumbbell Rack End Caps
(#12). Secure each End Cap with two ½” Philips Screws (#16).
DIAGRAM 3
7
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 4 (See Diagram 4)
A.) Plug four Base End Caps (#10) onto the base of Upright Beams (#2 & #3) and Floor
Stabilizers (#4).
B.) Slide the Training Book (#9) onto the Book Rack (#8). Attach the Rack to the back of the
Upright Beams.
C.) Securely tighten all Nuts and Bolts previously installed.
DIAGRAM 4
8
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED DIAGRAM
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Parts list
KEY NO. DESCRIPTION
Q’ty
1
Cross Brace
1
2
3
4
Left Upright Beam
Right Upright Beam
Floor Stabilizer
1
1
2
5
Bracket
4
6
7
8
Lower Dumbbell Rack
Upper Dumbbell Rack
Book Rack
2
1
1
9
Training Book
1
10
11
12
13
14
15
16
Base End Cap
4
6
6
20
40
20
12
2” x 2 ¾” End Cap
Dumbbell Rack End Cap
M10 Aircraft Nut
Ø ¾” Washer
M10 x 3” Allen Bolt
½” Philips Screw
10
Download from Www.Somanuals.com. All Manuals Search And Download.
IVANKO
By IMPEX INC.
LIMITED WARRANTY
IMPEX Inc. ("IMPEX") warrants this product to be free from defects in workmanship and material,
under normal use and service conditions, for a period of 2 YEARS from the date of purchase. This
warranty extends only to the original purchaser. IMPEX's obligation under this Warranty is limited
to replacing or repairing, at IMPEX's option.
All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling
IMPEX Customer Service Department at 1-800-999-8899. All freights on products returned to
IMPEX must be prepaid by the customer. This warranty does not extend to any product or
damage to a product caused by or attributable to freight damage, abuse, misuse, improper or
abnormal usage or repairs not provided by an IMPEX authorized service center or for products
used for heavy commercial or rental purposes. No other warranty beyond that specifically set
forth above is authorized by IMPEX.
IMPEX is not responsible or liable for indirect, special or consequential damages arising out of or
in connection with the use or performance of the product or other damages with respect to any
economic loss, loss of property, loss of revenues or profits, loss of enjoyments or use, costs of
removal, installation or other consequential damages or whatsoever natures. Some states do not
allow the exclusion or limitation of incidental or consequential damages. Accordingly, the above
limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied
warranties of merchantability or fitness for a particular purpose is limited in its scope and duration
to the terms set forth herein. Some states do not allow limitations on how long an implied
warranty lasts. Accordingly, the above limitation may not apply to you.
This warranty gives you specific legal right. You may also have other rights which vary from state
to state. Register on-line at www.impex-fitness.com
IMPEX INC.
14777 Don Julian Rd.,
City of Industry, CA 91746
ORDERING REPLACEMENT PARTS
Replacement parts can be ordered by calling our Customer Service Department toll-free at 1-800-
999-8899 during our regular business hours: Monday through Friday, 9 am until 5 pm Pacific
standard time.
When ordering replacement parts, always give the following information.
1.
2.
3.
4.
Model
Description of Part
Part Number
Date of Purchase
11
Download from Www.Somanuals.com. All Manuals Search And Download.
|