Instructions for Installation and Use
BS61 MK2
Note: Timer must be set to ‘Time of Day’ and ‘Manual’
before the oven can be used.
Note: Ensure that the oven is securely fixed to the
cabinet before use.
To the Installer
Before installation fill in the product details on the back cover of
this booklet. The information can be found on the rating plate.
To the User
You must read the instructions prior to installing and using the
appliance and then retain them for future reference.
Download from Www.Somanuals.com. All Manuals Search And Download.
INTRODUCTION
Your new cooker is guaranteed* and will give lasting service. This guarantee is only
applicable if the appliance has been installed in accordance with the
installation instructions detailed in this booklet.
To help make best use of your cooking equipment,
please read this booklet carefully.
The cooker is designed specifically for domestic use and responsibility will not be
accepted for use in any other installation.
Note: When the cooker is first used, an odour may be emitted - this will cease
after a short period of use
To help remove the 'new' smell, heat up the empty oven(s) to maximum for a minimum
of two to three hours keeping the oven doors closed. Ensure that the room is well
ventilated (e.g. open a window or use an extractor fan) and that persons who may be
sensitive to the odour avoid any fumes. It is suggested that any pets be removed from
the room until the smell has ceased.
This odour is due to any temporary finish on oven linings and elements and also any
moisture absorbed by the insulation.
* The guarantee is subject to the provisions that the appliance:
(a) Has been used solely in accordance with the Users Instruction Book.
(b) Has been properly connected to a suitable supply voltage as stated on
the rating plate attached to this equipment.
(c) Has not been subjected to misuse or accident or been modified or
repaired by any person other than the authorised employee or agent.
(d) Has been correctly installed.
DISPOSAL OF YOUR PRODUCT
To minimise the risk of injury to children please dispose of your product carefully and safely.
Remove all doors and lids (where fitted). Remove the mains cable (where fitted) by cutting
off flush with the appliance and always ensure that no plug is left in a condition where it
could be connected to the electricity supply.
To help the environment, Local Authority instructions should be followed for the disposal of
your product.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
FOR YOUR SAFETY
When used properly, your appliance is completely safe but as with any
electrical product there are certain precautions that must be observed.
PLEASE READ THE PRECAUTIONS BELOW BEFORE USING YOUR
APPLIANCE.
ALWAYS
Always make sure you remove all packaging and literature from inside the
oven/grill compartment before switching on for the first time.
Always make sure you understand the controls prior to using the appliance.
Always keep children away from the appliance when in use as the surfaces
will get extremely hot during and after cooking.
Always make sure all controls are turned off when you have finished cooking
and when not in use.
Always stand back when opening an oven door to allow any build up of steam
or heat to disperse.
Always use dry, good quality oven gloves when removing items from the
oven/grill.
G
G
G
G
G
G
Always take care to avoid heat/steam burns when operating the controls.
Always turn off the electricity supply at the wall switch before cleaning and
allow the appliance to cool.
Always make sure the shelves are in the correct position before switching on
the oven.
G
G
G
Always keep the oven/grill door closed when the appliance is not in use.
Always keep the appliance clean as a build up of grease or fat from cooking
can cause a fire.
Always follow the basic principles of food handling and hygiene to prevent
the possibility of bacterial growth.
G
G
G
Always keep ventilation slots clear of obstructions.
Always refer servicing to a qualified appliance service engineer.
Always during use the oven becomes hot. Care should be taken to avoid
touching heating elements in the oven.
G
G
G
SAFETY ADVICE
IN THE EVENT OF A CHIP PAN OR ANY OTHER PAN FIRE:
1. TURN OFF THE COOKER APPLIANCE AT THE WALL SWITCH.
2. COVER THE PAN WITH A FIRE BLANKET OR DAMP CLOTH, this will
smother the flames and extinguish the fire.
3. LEAVE THE PAN TO COOL FOR AT LEAST 60 MINUTES BEFORE
MOVING IT. Injuries are often caused by picking up a hot pan and rushing
outside with it.
NEVER USE A FIRE EXTINGUISHER TO PUT OUT A PAN FIRE as the
force of the extinguisher is likely to tip the pan over. Never use water to
extinguish oil or fat fires.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
FOR YOUR SAFETY
NEVER
Never leave children unsupervised where a cooking appliance is installed as
G
all cooking surfaces will be hot during and after use.
Never allow anyone to sit or stand on any part of the appliance.
Never store items above the appliance that children may attempt to reach.
Never remove the oven shelves whilst the oven is hot.
Never heat up unopened food containers as pressure can build up causing the
container to burst.
G
G
G
G
Never store chemicals, food stuffs or pressurised containers in or on the
appliance, or in cabinets immediately above or next to the appliance.
Never operate the grill with the door closed as this may cause the appliance
to overheat.
G
G
Never use the appliance as a room heater.
Never use the grill to warm plates.
Never dry any items on the oven doors.
Never install the appliance next to curtains or other soft furnishings.
Never allow children to play with the oven controls.
Never line the shelves, floor or sides of the oven or grill with aluminium
foil as overheating and damage may result.
G
G
G
G
G
G
5
Download from Www.Somanuals.com. All Manuals Search And Download.
FEATURES
Multi-function
Selector
24 Hour Digital
Electronic Clock
and Oven Timer
Oven
Temp
Dual
Grill
Multifunction
Selector
Dual
Grill
Oven
Temp
Oven
Indicator
Light
Oven
MULTIFUNCTION BS 61
Removable roof
Dual Grill Element
Stayclean Liners
Oven Light (15W)
Meat/Grill pan
with anti-splash
tray and roasting
rack
3 Oven Shelves
Door Switch
Oven Fan
Rating plate
Oven
Door
Inner Door Glass
Never line the shelves, floor or sides of the oven or grill with aluminium foil
as overheating and damage may result.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
THE CONTROLS
Multifunction
Selector
Dual
Grill
Oven
Temp
Oven
MULTIFUNCTION BS 61
Oven
Thermostat
Multifunction Grill Control
Selector
IMPORTANT
Before using your oven ALWAYS make sure that the timer has
been set to MANUAL operation. Unless this is done, the oven
cannot heat up. Before seeking assistance make sure this is
done (refer to oven timer operation).
To release any control knob simply press its centre.
MULTIFUNCTION SELECTOR
Rotate the control knob in either direction until the required function symbol appears
in the control window. Many of the functions will also require the oven thermostat or
grill control to be set before the appliance will heat up.
After use knobs can be returned to the storage position by pressing in the knob
centre.
OVEN THERMOSTAT
This is used in addition to the multifunction selector. This is used for the functions
(fan oven, fan grill and top and base heat).
Turn the control clockwise to set the oven thermostat to the required temperature.
If the timer is set correctly and the selector switch set to a suitable function an
indicator light will illuminate. This will remain on until the oven reaches the required
temperature. This light will then cycle on and off as the thermostat maintains control
of the oven temperature.
GRILL CONTROL
This is used in addition to the multifunction selector.
This is used for the functions (full grill and half grill).
Turn the control in either direction to the required setting. If the selector switch is set
to either full grill or half grill and the oven door is in its grilling position then the grill
will heat up. After use return all controls to “O” (Off) position.
COOLING FAN
A gentle flow of air will be detected coming from beneath the control panel when
the oven or grill is switched on.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
SELECTOR SWITCH FUNCTIONS
Off
With the selector in this position the oven will be off with the
exception of the clock display.
Oven
Light
In this position the control panel and oven will illuminate (this
applies to all positions other than off)
Fan
Oven
The oven fan and a rear element are controlled when this function is
selected.
Use the oven thermostat control to set the required temperature.
Top and
Base Heat
Top and base elements are controlled when this function is selected.
Use the oven thermostat control to set the required temperature.
Fan
Only
The oven fan will operate when this function is selected.
The oven thermostat control must be set in the off position.
Fan
Grill
The oven fan and grill element are controlled when this function is
selected.
Use the oven thermostat control to set the required temperature.
Oven door must be closed for fan grilling.
Full
Grill
The full width of the grill is controlled when this function is selected.
In addition use the grill control set to the required position.
Oven door must be open for grilling.
Half
Grill
The inner section of the grill element is controlled when this function
is selected.
In addition use the grill control set to the required position.
Oven door must be open for grilling.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
OVEN TIMER OPERATION
Note: Timer must be set to ‘Time of Day’ and ‘Manual’ before the oven
can be used.
AUTOMATIC COOKING
The Oven can be controlled by the Automatic Timer .
HINTS ON AUTOMATIC COOKING
1. Select foods which will require the same cooking time and temperature.
2. To ensure food does not cool down and require reheating, set the end time so
the food is ready when you require it.
3. Always ensure that meat and poultry is defrosted before placing in the oven.
4. Whenever possible, take food out of the refrigerator and keep it as cool as
possible.
5. If cooking food that requires frying before placing in the oven for automatic
cooking, keep the delay time to a minimum.
6. Never place hot or warm food in the oven for delay start cooking as it could
cause the oven to be warm and produce harmful bacteria in the food.
7. We advise that dishes containing left-over cooked poultry or meat, e.g.
Shepherd's Pie, should not be cooked automatically if there is to be a delay
period.
8. Ensure that delay start times are kept to a minimum to prevent bacterial
growth in food.
9. Wine or beer may ferment and cream may curdle during the delay period so
it is best to add these ingredients just before serving.
10. Foods which discolour should be protected by coating in fat or tossing in
water to which lemon juice has been added, prior to placing food in the oven.
11. Dishes containing liquid should not be filled too full to prevent boiling over.
12. Food should be well sealed (but not airtight) in a container to prevent the loss
of liquid during cooking. Aluminium foil gives a good seal.
13. Always ensure that food is piping hot and cooked thoroughly before serving.
14. Only reheat food once.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
KNOW YOUR TIMER
CLOCKFACE
The timer incorporates a 24 hour clock.
Ensure correct time of day is always set, before using your cooker.
PLEASE NOTE THAT THE DISPLAY WILL DIM BETWEEN 22.00
HOURS AND 06.00 HOURS TO PREVENT GLARE.
However, should you operate the timer during these hours the display will
return to normal brightness for a few seconds and then dim again.
SYMBOLS
will light up when you select a Minute Minder Period and will remain
lit for the period set. At the end of the Minute Minder Period, the timer
will emit an audible tone for 2 minutes, the
symbol will start to flash
and will continue to flash until the Minute Minder function is cancelled.
This “Cookpot” symbol will light up either:–
– When you press the Cook Period Button and set a length of time for
an Auto Cooking Programme. (It will go out again a few seconds after
you release the timer buttons).
Minute Cook End
Minder Period Time
Manual
– During the actual Cook Period.
“AUTO” will light up:–
– When the timer is first turned on it will flash. (It will go out when a
time of day is set.
A
U
T
O
– When an Auto Cooking Programme has been set.
The “Auto” symbol will flash at the end of an Auto Cooking programme
to indicate that the programme has finished.
Minute Cook End
Minder Period Time
Manual
(When the “Auto” symbol is flashing, to return the oven to Manual
operation, turn the oven controls off, ensure that the correct time
of day is set, and press the “Manual” button twice – The “Auto”
symbol will go out.
TIMER FUNCTION BUTTONS
Minute Minder
Button
Here you can set a time period of up to 23 hours 59 minutes, that will count
down. When it reaches zero, the timer will emit an audible tone.
For Example: If you set 20 minutes, the audible tone will occur 20 minutes
later.
AUTO COOKING PROGRAMME
Cook Period Button
Cook Period is the actual length of time for which, the timer will switch the
oven(s) on as part of an “Auto Cooking” programme.
(e.g. If you set 2 hours, the food will be cooked for 2 hours).
End Time Button
The time of day at which you want an “Auto Cooking” programme to end.
For Example: If you set a “Cook Period” for 2 hours, and “End Time” of
11:00. The timer will switch the oven(s) on at 9:00 and turn the oven(s) off at
11:00. You will hear a audible tone at 11:00, to indicate that the Auto
Cooking Programme has finished.
Notes:
– When setting an Auto Cooking programme you will need to set the oven
controls(s) to the required temperature(s) when you set the timer.
_ If an Auto Cooking programme has been set the oven(s) will only operate
during the pre-programmed time.
Manual Button
Needs to be pressed to cancel an Auto Cooking programme and return the
ovens(s) to Manual operation.
“+” and “–” Buttons
Used to adjust the various timer function settings.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
ELECTRONIC CLOCK & AUTOMATIC
OVEN TIMER OPERATION
SETTING THE TIME OF DAY
A
U
Step 1 Make sure all oven controls are turned Off.
T
O
Step 2 Check the electricity supply to the cooker is turned on.
Minute Cook End
Manual
Minder Period Time
Step 3 When switched on the display will show 0.00 and Auto symbol
will be flashing intermittently.
Step 4 Press & hold in both the “Minute Minder” & “Cook Period” button
together.
Step 5 With the “Minute Minder” & “Cook Period” buttons still held in,
Minute Cook End
Minder Period Time
press either the “+” or “–” buttons to set the correct time of day.
Manual
Step 6 Release all the buttons simultaneously.
THE TIME OF DAY IS NOW SET.
To change the time of day repeat Steps 4, 5 & 6 above.
Note: You cannot adjust the time of day if the timer has been set
for an Auto Cooking Programme.
Bell Symbol
SETTING THE MINUTE MINDER
Step 1 Ensure the time of day is set correctly.
Step 2 Press and hold the Minute Minder Button, a
symbol will light up.
Minute Cook End
Minder Period Time
Manual
Step 3 With the “Minute Minder” button held in, set the required Minute
Minder time using the “+” and “–” buttons.
Release all buttons and the timer display will revert back to the time of day.
Bell symbol will remain lit to signify that a Minute Minder period has been set.
At the end of the set time a bleeping sound will be heard, and the
symbol will flash for approximately 2 minutes.
After approximately 2 minutes the bleeping sound will stop and the
symbol will go out automatically.
Minute Cook End
Minder Period Time
Manual
Step 4 To cancel the bleeping sound within the two minutes press the
Minute Minder button.
Note 1 When the Minute Minder has been set, the time remaining can be
checked at any time by simply pressing the Minute Minder button.
Note 2 If necessary the Minute Minder can be cancelled before the tone sounds
by pressing and holding the Minute Minder button and then at the same
time pressing the “–” button until 0.00 appears in the display window.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
ELECTRONIC CLOCK & AUTOMATIC
OVEN TIMER OPERATION
AUTO COOKING PROGRAMMES
There are two Auto Cooking programmes that can be selected using your timer:–
(a) To set the timer to switch the oven(s) On and Off Automatically
(b) To set timer to switch on immediately and OFF automatically after a set cook period.
a) TO SET THE TIMER TO SWITCH THE OVEN(S) ON AND OFF AUTOMATICALLY
This allows you to cook at a specified time for a chosen period before the oven
switches off Automatically.
Step 1 Check that the correct time of day is set, if not follow instructions for setting the
time of day.
Step 2 Place food onto the correct shelf position in the oven and close the oven door(s).
Cooktop Symbol
Step 3 Press and hold in the Cook Period button.
The display will read 0.00 with the cookpot (
) symbol lit.
Step 4 With the Cook Period button still held in, set the required Cook
Minute Cook End
Minder Period Time
Period using the “+” and “–” buttons.
Manual
A
U
T
Release the buttons and the timer display will revert to the time of day
with the Auto symbol and Cookpot (
) symbol lit.
O
Step 5 Press and hold in the “End Time” button.
The display will read the earliest possible end time for the Cook
Period that you have set above.
A
U
T
O
The Auto symbol and Cookpot (
) symbol lit.
Minute Cook End
Minder Period Time
Manual
Step 6 With the End Time button still held in, use the “+” and “–”
buttons to set the “End Time” (i.e. The time you require the oven
to switch off).
Release all the buttons and the timer will revert back to the time of day.
The “Auto” symbol will remain lit to signify that an Auto Cooking
A
U
T
O
Programme has been set. The (
) symbol will go out.
Minute Cook End
Minder Period Time
Manual
Step 7 Turn the oven control(s) to the required temperature, and if
necessary select the appropriate oven function.
Note: If your appliance has two ovens: When the timer has been
set for one oven it is possible to use the other oven only during the
same Automatic programme.
At the end of the Automatic Cook Period the Auto Symbol will flash and
an intermittent bleeping sound will be heard.
The bleeping sound will continue for approximately 2 minutes unless
cancelled. The “Auto” symbol will continue to flash until the timer is
returned to Manual operation (see below).
Step 8 Press the Manual button to cancel the bleeping sound. (If 2
Minute Cook End
Minder Period Time
minutes has not elapsed).
Manual
Step 9 Turn the oven control(s) to the OFF position.
Step 10Press the manual button again to return the oven(s) to Manual
Operation. (The Auto symbol will go out)
12
Download from Www.Somanuals.com. All Manuals Search And Download.
ELECTRONIC CLOCK & AUTOMATIC
OVEN TIMER OPERATION
Note 1 When cooking automatically the Cook Period can be checked at any time
by simply pressing the Cook Period button.
Note 2 When cooking automatically the End Time can be checked at any time by
simply pressing the End Time button.
b) TO SET TIMER TO SWITCH ON IMMEDIATELY AND OFF AUTOMATICALLY
AFTER A SET COOK PERIOD
Step 1 Check that the correct time of day is set, if not follow instructions for setting the time
of day.
Step 2 Place food onto the correct shelf position in the oven and close the oven door(s).
Step 3 Turn the oven control(s) to the required temperature, and if necessary select the
appropriate oven function.
Cookpot Symbol
Step 4 Press & hold in the “Cook Period” button, the display will read
0.00 and the cookpot (
) symbol will light up.
With the Cook Period button still held set the required Cook Period
using the “+” and “–” buttons. Example: 1hr 30 minutes (as shown).
Minute Cook End
Minder Period Time
Manual
Note: Cook Period is the length of time the food requires to cook.
Step 5 Release all buttons.
A
U
T
The timer display will revert to the time of day with the Auto symbol lit &
Cookpot symbol remaining lit.
O
Note: Cookpot symbol disappears
At the end of the Cook Period the “Auto” symbol will flash and an
intermittent bleeping sound will be heard.
The bleeping sound will continue for approximately 2 minutes unless
cancelled. The “Auto” symbol will continue to flash until the timer is
returned to Manual operation (see below).
A
U
T
O
A
U
T
Step 6 Press the manual button to cancel the bleeping.
(If 2 minutes has not elapsed)
O
Minute Cook End
Manual
Minder Period Time
Step 7 Turn the oven control(s) to the OFF position.
A
Step 8 Press the “Manual” button again to return the cooker to Manual
operation. (The Auto symbol will go out).
Minute Cook End
Manual
Minder Period Time
13
Download from Www.Somanuals.com. All Manuals Search And Download.
ELECTRONIC CLOCK & AUTOMATIC
OVEN TIMER OPERATION
TO CANCEL AN AUTO COOKING PROGRAMME BEFORE
THE COOK PERIOD HAS FINISHED.
Step 1 Turn the oven control(s) to the OFF position.
Step 2 Press and hold in the “Cook Period” button.
Minute Cook End
Manual
Minder Period Time
Step 3 With the “Cook Period” button still held in, return the display to
0.00 by pressing the “–” button.
A
U
T
Step 4 Release the “Cook Period” and “–” buttons and the display will
O
revert to the time of day and the “Auto” symbol will flash.
Step 5 Press the “Manual” button to return the oven(s) to “Manual”
Minute Cook End
Minder Period Time
operation. The “Auto” symbol will go out.
Manual
Note 1
When cooking automatically the Cook Period can be checked at any time by
simply pressing the Cook Period button.
OTHER NOTES ON TIMER OPERATION
1. When cooking Automatically the Cook Period can be checked at any time simply by pressing
the Cook Period button.
2. When cooking Automatically the End Time can be checked at any time by simply pressing the
End Time button.
3. Having set a Cook Period and End Time an electronic device stores the information. The device
within the timer will switch the oven(s) on and off at the required times.
4. When setting an Auto Cooking Programme and a mistake is made, to clear:–
(a) Press and hold in the “Cook Period” button.
A
U
T
(b) With the Cook Period button still held in, return the display to
by pressing the “–”
O
button.
(c) Release the “Cook Period” & “–” buttons, and the display will revert to the time of day and
the “Auto” symbol will flash.
(d) Press & release the “Manual” button.
(e) Start the sequence again.
5. If at any time the display shows three flashing zero’s 0.00. It is likely that the electricity supply
to the oven has been interrupted. Reset the timer to the correct time of day.
Food in the oven may, therefore, not have been cooked, before serving check food is
thoroughly heated and completely cooked.
6. To set each function always press and hold the required function button and at the
same time press “+” or “–” buttons.
Note: Between the hours of 22.00 & 06.00 the display dims to prevent glare.
However, if you should operate a button during this period, the timer will return to
normal brightness for a few seconds and then dim again.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
GRILL PAN & HANDLE
The grill pan handle is detachable from the pan, to facilitate cleaning and storage.
The grill pan handle can be fixed as follows:
(d)
(a)
(c)
(b)
Step 1
Step 2
Step 3
Ste
Step 1 Remove screw & washers from the grill pan bracket (a).
Step 2 Tilt the handle over the recess (b).
Step 3 Slide it towards the centre of the pan (c).
Step 4 Locate the handle over the bracket (d).
For a fixed handle, replace screw & washers and ensure they are fully
tightened up. If a detachable handle is required, do not replace screw &
washers.
Note: If a fixed handle is required, the grill pan is unable to be stored in the oven
with the door closed and cannot be used as a meat pan.
GRILL PAN FOOD GRID AND ANTI-SPLASH TRAY
GRILL PAN
GRILL PAN
FOOD GRID
ANTI-SPLASH
TRAY
DOOR POSITION FOR GRILLING
Note:Do not grill with the grill/oven door
closed.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
GRILLING PROCEDURE
Multifunction
Selector
Dual
Grill
Oven
Temp
A
B
C
Oven
MULTIFUNCTION BS 61
Oven
Thermostat
Multifunction Grill Control
Selector
Note: DO NOT allow young children near to the appliance when the grill is in use as
the surfaces get extremely hot.
Step 1 Ensure oven timer is set to manual.
Ensure the oven shelf is in the correct position (see Guide to Grilling
Successfully).
Ensure door is in the grilling position (see grilling page)
Step 2 Turn knob (B) anti-clockwise to grill or half grill function
Step 3 Turn knob (C) clockwise to select the Grill Setting (1–6). (1=Low,
6=High).
NOTE: When using the grill, a gentle flow if air will be detected coming from
beneath the control panel.
The grill power can be adjusted during grilling, adjust as necessary.
It is advisable to pre-heat the grill on the MAX
(6) setting for 5 minutes.The grill pan,with grid should be used at shelf position 5 or
6 from the bottom,according to the thickness of the food. Position the grill pan directly
under the heating elements. For toasting leave the control set at 6, shelf position 6.
For thicker foods requiring longer cooking times turn the grill control down to a lower
setting after the initial sealing of both sides at 6. The thicker the food, the lower the setting
on the grill control. Food that only requires browning should be done on a lower shelf
position.
Do not store the grill pan handle on the grill pan grid when the rod shelf is in the top runner
position.
Do not line the grill pan with aluminium foil, as this increases the amount of fat spitting.
Ensure that the grill pan is cleaned after use. Excess fat build up in the bottom of the pan could
cause a fire hazard.
After use, always return both controls to their OFF (O) position.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Fan
Oven
USING THE OVEN FOR FAN COOKING
Since a circulaire fan oven heats up more quickly, and generally cooks food at a lower
temperature than a conventional oven, pre-heating is often unnecessary. For guides on
“pre-heating”, “cooking temperatures” and “cooking times”, see “Oven Temperature
Charts” later in book.
NOTE: Charts are a guide only, to suit personal taste and requirements, it may be
necessary to increase or decrease temperatures by 10˚C. It may also be necessary to
increase or decrease cooking times.
OVEN SHELF POSITIONING FOR FAN OVEN
Most foods will cook satisfactorily on any shelf position, due to even distribution of
heat in the oven, but the shelves must be evenly spaced.
Food or utensils should never be placed directly on the floor of the oven for
cooking as air circulation is restricted.
DO NOT allow young children near to the appliance when the oven is in use as the
surfaces get extremely hot.
OVEN UTENSILS
Do not use:
Meat pans larger than 375mm x 300mm (15” x 12”)
Baking Trays larger than 325mm x 250mm (13” x10”)
An additional oven shelf can be purchased from your oven supplier if a third one
is required for batch baking. Never use more than three shelves in the oven as air
circulation will be seriously restricted.
TEMPERATURE & TIME
If three shelves are in use to cook large quantities of food, it may be necessary to
preheat and/or increase the cooking times given in the temperature charts by a few
minutes, to allow for the loss of heat due to extra time taken to load the oven, and
the larger mass of food. Baking trays should have an even gap around the oven.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Fan
Oven
USING THE OVEN FOR FAN COOKING
FAN OVEN OPERATION
Multifunction
Selector
Dual
Grill
Oven
Temp
A
B
C
Oven
MULTIFUNCTION BS 61
Oven
Thermostat
Multifunction Grill Control
Selector
Step 1 Ensure oven timer is set to manual.
Ensure that the oven shelf is in the correct position.
Place food centrally on the shelf ensuring the oven door is fully closed.
Turn knob B clockwise to Fan Oven function.
Step 2 Turn knob (A) clockwise and select the required cooking temperature
(80˚C to 230˚C). The pilot light (G) will immediately come on, and remain
on until the oven reaches the required temperature. The light will then
automatically go off and on during cooking as the oven thermostat
maintains the correct temperature.
Step 3 After use turn both controls to their Off (O) position.
NOTE: At the end of a cooking period there may be a momentary puff of steam
when the door is opened. This will disperse in a few seconds and is a
perfectly normal characteristic of an oven with a good door seal.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
USING THE OVEN FOR OTHER
FUNCTIONS
“SLOW” SETTING
E
90
This is used for slow cooking, keeping food warm and warming plates for short
periods. Extra care should be taken when warming bone china, as it may be
damaged in a hot oven.
DO NOT place food or plates directly on the oven floor as this could damage both the
oven lining and the plates which are being warmed.
ADVANTAGES OF SLOW COOKING ARE:
The oven stays cleaner because there is less splashing.Timing of food is not as
critical, so there is less fear of overcooking. Inexpensive joints of meat are tenderised.
Fully loading the oven can be economical. Cooking times can be extended in some
cases by up to 2 hours. The kitchen stays cooler.
OPERATION:
1. Place the prepared food in the main oven and ensure the door is fully closed.
2. Turn knob B to Fan Oven function.
Turn knob A to
(slow cooking temperature).
E 90
STORAGE & RE-HEATING OF FOOD:
1. If food is to be frozen or not used immediately, place it in a clean container
and cool as soon as possible.
2. Always thaw frozen food completely in the refrigerator before re-heating.
3. Always reheat food thoroughly and ensure it is piping hot before serving.
4. Only re-heat food once.
POINTS TO CONSIDER WHEN PREPARING FOOD FOR SLOW COOKING
1. Make sure that the dishes to be used will fit into the oven ensuring enough room
for air to circulate.
2. All dishes cooked on the slow setting will require a minimum of 6 hours, however,
it they are cooked for 1-2 hours longer then deterioration in their appearance may
be noticed.
3. Never cook joints of meat over 2.7kg (6 lb) or poultry over 2.0kg (4lb 8oz).
We do not recommend that joints of meat or poultry are stuffed before cooking on
the slow setting.
4. To seal in the meat juices, always cook meat or poultry at 170oC for 30 minutes
before wrapping in foil and placing on a rack over a tin (to allow good air
circulation) before turning the control to the slow setting and cooking immediately.
5. Always ensure that joints of pork and poultry are thoroughly cooked by checking
with a meat thermometer before serving.
6. Always thaw frozen foods completely before cooking. We do not recommend
placing frozen food in the oven to cook.
7. Always bring soups, liquids and casseroles to the boil before placing in the oven.
8. Ensure that casserole dishes have a good seal (not airtight) and cover to the
top with foil to prevent loss of moisture.
9. Ensure that fruit and vegetables are cut into even sized small pieces to cook
properly.
10. Always adjust seasoning before serving.
11. If using dried red kidney beans it is important that the beans are soaked and then
boiled for a minimum of 10 minutes before using in any dish to destroy any toxins.
12. When cooking fish or egg dishes it may be necessary to check during cooking to
avoid overcooking.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
USING THE OVEN FOR OTHER
FUNCTIONS
FAN GRILLING
Fan grilling is a combination of heat from the grill element and the oven fan
circulating the hot air around the food.
Joints of meat and poultry will be browned as if they were cooked on a rotisserie or
spit but more economically as the door if left closed.
If required, fan grilling can be timed using the Oven Auto timer. Follow the timer
instructions on before selecting fan grill and the required temperature.
If Manual fan grilling is required always ensure the timer is set to Manual.
OPERATING INSTRUCTIONS
1.
2.
3.
4.
Open the oven door.
Select the correct shelf position.
Turn the selector switch B until Fan grill is seen in the window.
Turn the oven thermostat control A to the required temperature (see Fan Grilling
Roasting Chart)
5.
Position the meat pan centrally under the grill elements (if using the grill pan
always remove the grill pan handle).
6.
7.
8.
Close the oven door. Fan grilling will not begin until the door is fully closed.
After use always return both controls to the off position.
If the oven timer was used, reset to Manual.
20
Download from Www.Somanuals.com. All Manuals Search And Download.
USING THE OVEN FOR OTHER
FUNCTIONS
FAN GRILLING
As with the Circulaire oven fan cooking there is no need to pre-heat the oven – yet
another economy feature. Also you can cook more than one thing at a time – even
up to 4 small chickens.
TEMPERATURES
These will be similar to those used for the more traditional form of roasting but the
guide will give you an indication of which temperature to set the Thermostat. But
remember that because of the way the oven is heated this is a more economical way
of roasting.
GENERAL RECOMMENDATIONS
Most types of meat and poultry cooked by this method will have an all over
brownness and crispness on the outside. The only exceptions are very lean joints,
such as veal, which, because of its low fat content, is better cooked using
conventional heating.
1. Always place the pan on the shelf position recommended. (See Chart).
2. There is no need to preheat the oven before cooking and all fan grilling should be
carried out with the oven door closed, this saves energy. The cooking
temperatures and times are calculated from a cold oven.
3. After rinsing and drying meat, place on the food roasting support rack over the
pan supplied with the anti-splash trivet in position. It is important that the
anti-splash trivet is used, as it will stop the splashing of fat and help keep the
oven clean.
4. Position meat in oven as recommended in the roasting chart.
5. Fan grilling is ideally suited for cooking all types of poultry and larger joints of
meat (e.g. stuffed, rolled joints and legs of pork and lamb). Results will be as if
you had cooked the food on a rotisserie. If you use frozen meat or poultry it must
be completely defrosted before it is cooked.
6. When cooking a joint always grill it with the fat side uppermost in order to crisp it.
For bigger joints or where there is little bone, grill at the lower temperature given
in the table and cook for a longer time per kg.
7. When cooking any type of poultry, start grilling the underside uppermost and turn
breast uppermost about a third to halfway through the cooking period. If cooking
stuffed poultry allow slightly longer cooking time.
Pan trivet and
food support rack
21
Download from Www.Somanuals.com. All Manuals Search And Download.
FAN GRILLING ROASTING CHART
Shelf positions are counted from the base upwards ie: lowest shelf position is 1.
Total Cooking Time
(mins)
Type of Meat
or Poultry
Temp
oC
Weight
kg
Plus Extra
Time (mins)
Time
(min/kg)
Tips
PORK
Pork Chop - thick
170
160
25
30
Dependent on size Season. Grill on shelf
position 3. Turn over after
15 mins.
Gammon Steaks
Dependent on size Grill on shelf position 3
Turn after 15 mins.
Pork - any type of joint
1.0
1.5
160-170
150-170
140-150
140-150
140
60-70
60-70
65-75
65-75
70-75
45
45
50
50
50
105-120
130-150
180-230
220-240
-
Score fat with sharp knife
and rub on salt. Pork
should always be
thoroughly cooked. So
overcook rather than
undercook. Grill on shelf
position 1.
2.0
2.5
over 2.5
LAMB
Lamb chop - thick
170
25
Dependent on size Season. Grill on shelf
position 3. Turn over after
15 mins.
Lamb - any type of joint
1.0
1.5
160-170
160-170
150-160
150-160
150
30-40
35-40
35-45
40-45
45-50
45
45
50
50
50
78-88
90-110
120-140
150-170
-
Score fat. Season with
pepper and rosemary. If you
prefer the lamb pink
choose the shorter time
Grill on shelf position 1.
2.0
2.5
over 2.5
BEEF
Beef - joints which have
an outside layer of fat
eg. Rib, Rolled, Sirloin
1.0
1.5
170-180
170-180
160-170
160-170
160
40-50
40-50
40-50
45-50
45-50
30
20
20
20
30
40
30
30
30
30
30
30
60-70
80-90
100-110
140-150
-
Season. If joint preferred
rare grill for the shorter
time. If preferred well done
grill for the longer time.
Grill on shelf position 1.
Season and brush over with
melted butter to give nicely
browned skin. Grill on shelf
position 1.
2.0
2.5
over 2.5
1.0
CHICKEN
180
60
1.5
180
30
75
2.0
170
35
100
2.5
170
35
115
over 2.5
less than
1kg each
1.5
160-170
180
40
-
Chicken joints
DUCK
30
60
Shelf 1.
180
180
180
30
30
35
40
45
-
30
30
30
40
40
-
75
Dry thoroughly and lightly
2.0
2.5
90
115-130
-
salt. Grill on shelf position 1.
GOOSE
up to 4
4-5
170-190
160-170
170
Can be stuffed.
-
Grill on shelf position 1
Season and brush over with
melted butter to give nicely
browned skin. Grill on shelf
position 1
TURKEY
up to 5
6-8
150-165
165-175
150
-
-
GAME
Grouse
Any
Any
Any
170-180
170-180
170-180
30-50
40-50
40-50
-
-
-
-
-
-
Well hung meat will require
less cooking time. grill on
position 1.
Partridge
Pheasant
Beefburgers
Sausages
Bacon
450g(lb)
450g (lb)
450g (lb)
170
170
170
170
25mins per
450g (lb)
Shelf 3.
25mins per
450g (lb)
Shelf 3.
Prick sausages before cooking.
Shelf 3.
25mins per
450g (lb)
Roll up bacon before cooking.
4 pieces of steak, sausages, chops,
bacon, tomatoes & mushrooms.
Cook sausages, chops, bacon for
10 mins. add steak, cook for further
20 mins. Tomatoes & mushrooms
should be placed on trivet under
roasting rack for total cooktime.
Mixed Grill
30
22
Download from Www.Somanuals.com. All Manuals Search And Download.
USING THE OVEN FOR OTHER
FUNCTIONS
FAN ONLY
The oven has a fan only position, which can be used to assist defrosting by
circulating unheated air around the food.
Time to defrost will depend on type and size of the food and the room temperature.
OPERATING PROCEDURE
1. Turn the selector switch until the required fan only symbol is shown in the control
panel window.
2. The control panel illumination and oven light will remain on.
3. After use always return the control to the off position and close the oven door.
DO NOT turn the oven thermostat control on.
DO NOT defrost meat and poultry by warming the food through.
Foods ideally suited for fan defrosting (without heat) are those which are normally served
cold, e.g. cream/cream cakes, butter cream filled cakes, gateaux, cheese cakes, iced cakes,
quiches, pastries, biscuits, bread croissants, fruit and many delicate frozen foods.
If fish, meat and poultry are to be “fan only” defrosted then where possible the items should
be thin e.g. fish fillets, peeled shrimp, cubed or ground meat, sliced meat, thin chops, steaks
or liver.
The items should be placed so the maximum amount of surface area is exposed to the
circulating air and turned regularly to ensure even defrosting.
Fan defrosting without heating is only suitable for meat and poultry joints up to a maximum
weight of 1.8kg (4 lb).
It is important to wash both roast and cooking utensils before cooking immediately
after defrosting.
It is vitally important to strictly adhere to the basic principles of food handling and
hygiene to prevent the possibility of bacterial growth.
23
Download from Www.Somanuals.com. All Manuals Search And Download.
USING THE OVEN FOR OTHER
FUNCTIONS
TOP AND BASE HEAT
The oven is heated by elements at the top of the oven and underneath the floor of
the oven.
The oven door is fitted with a switch which will automatically turn off the elements
when the door is opened.
Food should not be placed on the floor of the oven.
OPERATING PROCEDURE
1. Ensure Oven Timer is set to Manual.
2. Position rod shelf as recommended in the chart for food being cooked.
3. Position food centrally under grill element.
4. Turn the selector switch B until top and base is shown in the window.
5. Turn the oven thermostat control A to the required temperature setting (see oven
temperature charts). The control panel illumination and oven light will remain
on. The oven indicator light will remain on until the oven reaches the set tem
perature. This light will then automatically cycle on and off during cooking as the
oven temperature is controlled.
6. After use always return both controls to the ‘O’ off position and close the oven
door.
24
Download from Www.Somanuals.com. All Manuals Search And Download.
TEMPERATURE CONVERSION SCALE
Main
Conventional
Oven
Main
Fan
Oven
Gas
Mark
oF
1
250
275
300
325
350
375
400
425
450
475
120
140
150
160
180
190
200
220
–
100
120
130
140
160
170
180
200
210
220
2
/
1
2
3
4
5
6
7
8
9
–
25
Download from Www.Somanuals.com. All Manuals Search And Download.
OVEN TEMPERATURE CHART
Note: If soft margarine is used for cake making, temperatures recommended by the
manufacturers should be followed. Temperatures recommended in this chart refer to
cakes made with block margarines or butter only.
When using more than two shelves for baking in the fan oven best results are achieved
if before placing the food in the oven, it is preheated to the required temperature.
Note:Where times are stated, they are approximate only.
26
Download from Www.Somanuals.com. All Manuals Search And Download.
OVEN TEMPERATURE CHART
It is not necessary to pre-heat the oven fan before roasting. Note: Where times are stated, they
are approximate only.
27
Download from Www.Somanuals.com. All Manuals Search And Download.
COOKING RESULTS NOT
SATISFACTORY
GRILL
Uneven cooking front to back
Fat splattering
Ensure that the grill pan is positioned centrally below
the grill element.
Ensure that the grill pan is not lined with foil.
Ensure that the grill setting is not too high.
Remember to use the anti splash tray.
BAKING GENERAL
Uneven rising of cakes
Sinking of cakes
Ensure that the oven shelves are level.
The following may cause cakes to sink:
1. Pre-heating of fan ovens – not always necessary.
2. Cooking at too high a temperature – reduce
standard temperatures by 25˚C for fan ovens.
3. Using normal creaming method with a soft
margarine. If using soft margarine, use an all in one
method instead of the traditional creaming of the
margarine and sugar. Remember when using a food
mixer or processor not to over-cream soft
margarine.
Over/undercooking
Refer to the cooking times and temperatures given in
the Oven Temperature Charts provided, however, it
may be necessary to increase or decrease
temperatures by 10˚C to suit personal taste.
l
4
Do not use utensils greater than 56mm (2⁄ '') in height
for roasting.
28
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE AND CLEANING
Warning: Before cleaning, please ensure that the electricity supply to the appliance is
switched off and the appliance is fully cold.
1. “STAYCLEAN” OVEN LINERS
(a) How "Stayclean" works.
The surfaces of the "Stayclean" oven liners are treated
with a special vitreous enamel which absorbs cooking
soils. At temperatures of 220°C (425°F) or above, the
special surface enables these soils to be slowly
destroyed.
The higher the temperature the more effective it is.
(b) Cleaning.
In most cases normal cooking operations at 220°C
(425°F) will permit this cleaning operation to proceed
during cooking. However if higher cooking tempera
tures are not used regularly, it may be necessary, in
order to prevent heavy soiling, to run the ovens without
shelves or meat pan, at a maximum setting for a
couple of hours.
MAIN OVEN SIDE LINERS
AND REAR PANEL
It should not normally be necessary to clean the
"Stayclean" panels with water. If the user feels it is
desirable to do so, wipe them over with a clean, soapy
cloth, followed by a wipe with a clean damp cloth.
DO NOT use biological washing powder, harsh
abrasives or chemical oven cleaners of any kind as
this could damage the “Stayclean” oven liners.
29
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE AND CLEANING
2. CLEANING THE OVEN
(a) Base of Main Oven.
REMOVABLE GRILL ROOF
PANEL (NOT ALL MODELS OR
MODELS FITTED WITH HIGH
SPEED GRILL)
Wipe out the oven with a damp soapy cloth. For more
stubborn stains on the base of the oven use a well
soaped fine steel wool soap pad.
(b) Grill/Meat Pan & Oven Shelves.
To prevent stains from being burnt on to the grill pan,
food support and rod shelf, always wash immediately
after use in hot soapy water.
Use a well soaped fine steel wool soap pad to remove
stubborn stains from the rod shelves, grill/meat pan
and the base of the oven.
OVEN
SHELVES
GRILL/
MEAT
PAN
MAIN
OVEN
BASE
DO NOT use aerosol cleaners on this oven as they
could adversely affect the fan motor unit, and cannot
be wiped off the fan blade.
(c) Removable Grill Roof Panel (not all models).
Pull grill roof panel out slowly, being careful not to
damage the elements. Clean using a damp soapy
cloth, if stubborn stains remain gently clean with a well
soaped fine steel wool soap pad and soapy water, and
then wipe over with a damp cloth.
(d) Solarplus Grill (not all models).
To clean the Solarplus grill, use a clean, damp, soapy
cloth and wipe over. If stubborn stains remain, gently
clean with a well soaped nylon scouring pad and wipe
over with a damp cloth.
DO NOT use metal cleaning utensils, wire wool or
proprietary oven cleaners on the grill element mesh.
30
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE AND CLEANING
3. CONTROL PANEL / TRIMS / INNER DOOR PANEL & GLASS
(a) Control Panel
Regularly wipe with a clean, damp cloth and
polish with a clean, dry cloth.
(b) Trims
It is advisable to clean the trims regularly to pre
vent any build up of soiling which may detract
from the appearance of the cooker. The recom
mended method of cleaning is to wipe over the
trims with a clean, soft cloth wrung out in hot
water, or mild non abrasive cleaner. (If in doubt
try the cleaner on a small area of trim which is
not noticeable in normal use), then after wiping
with a cloth wrung out in clear water, dry with a
clean, soft cloth.
OVEN
DOOR
(c) Inner Door Panels & Glass
Open the door fully. The glass panel may now
be washed. Stubborn stains can be removed by
using a well soaped, fine steel wool soap pad.
TRIMS
DO NOT use scouring pads, or abrasive powder, which
will scratch the glass.
THE OVEN LAMP
Warning: Before removing lamp lens, please ensure that
the electricity supply to the appliance is switched off and
the appliance is fully cold.
Open the oven door and remove the oven
shelves. Using a thick cloth, grip the lamp lens,
unscrew anti-clockwis and remove the lens.
Carefully unscrew the bulb anti-clockwise. Fit
replacement bulb (15W 300°C SES). Fit
replacement bulb and refit lens.
MAIN OVEN LAMP
5. HOW TO CLEAN THE LAMP LENS
Warning: Before cleaning lamp lens, please ensure that
the electricity supply to the appliance is switched off and
the appliance is fully cold.
Open the oven door and remove the oven
shelves. Using a thick cloth, grip the lamp lens,
unscrew anti-clockwise and remove. Clean with
a non-abrasive cleansing cream and refit lamp
lens.
DO NOT use scouring pads, or abrasive powder, which
will scratch the glass lens
MAIN OVEN LAMP
31
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE AND CLEANING
Take particular care not to damage the inner surface of the door inner
glass that is coated with a heat reflective layer. Do not use scouring pads,
or abrasive powder, which will scratch the glass. Ensure that the glass
panel is not subjected to any sharp mechanical blows.
Stubborn stains can be removed by using a fine steel wool pad. For slight soiling
the inner glass panel may be cleaned, while still warm, without removing it from
the door. After cleaning, rinse and dry with a soft cloth.
CLEANING THE DOORS
SIDE OPENING DOORS
Cleaning the door glass is the same as the drop down doors, except take
care to support the weight of the inner glass when removing and refitting.
DROP DOWN DOORS
Remove the door inner glass as follows.
1. Open the door fully and unscrew the two screws securing the glass panel so
that the securing brackets can be turned. There is no need to remove the screws
completely.
2. Turn the brackets so that the glass can be
removed and cleaned at the sink (Fig. 1.)
Fig. 1.
Glass
3. The inside of the outer door glass can now be cleaned while still fitted to the
cooker.
NEVER OPERATE THE COOKER WITHOUT THE INNER DOOR
GLASS IN POSITION.
Refit the door inner glass as follows.
1. NOTE: The inner door glass has a special reflective coating on one side.
Replace the door inner glass so that the statement: “IMPORTANT THIS FACE
TOWARDS THE OVEN” can be read from the inner side of the door.
2. Turn the two securing brackets back to their
original position to retain the glass and tighten
the screws. (Fig. 2.)
Fig. 2.
Glass
32
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION INSTRUCTIONS
IMPORTANT
This equipment is designed specifically for domestic purposes and Hotpoint
Limited cannot accept responsibility if used in any other type of installation.
This appliance must not be installed over any appliance that generates heat.
For your own safety, we recommend that your appliance is installed by a
competent person – such as one who is registered with NICEIC (National
Inspection Council for Electrical Installation Contracting). The cooker should be
installed in accordance with the latest Edition of the IEE Regulations.
1. GENERAL
WARNING: THIS APPLIANCE MUST BE EARTHED.
(a) The oven unit is designed for mounting at a safe level into an oven housing
which must be secured to the backing wall, or alternatively, in the case of the
single oven unit, under a worktop with or without a hob unit above.
(b) In an oven/hob arrangement where it is proposed to install the oven directly
below the hob. It is advisable that only slimline hobs are used which have the
following maximum depths.
Maximum hob depth
Kitchen Worktop thickness
(from worktop surface vertically down)
30mm
40mm
55mm
65mm
Worktop thickness + 25mm
40mm +
It is most important that the hob installation instructions are strictly observed.
33
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION INSTRUCTIONS
2. OVEN UNIT HOUSING CABINETS
(a) The oven unit housing cabinet dimensions must comply with Fig. 3 and Fig. 4.
(b) An air gap of 50mm minimum must be provided at the rear of any top or
bottom cupboards or shelves for ventilation.
(c) Do not obstruct the ventilation slots provided on the oven trim. This is found
adjacent to the bottom of the oven door.
(d) The air gap at the rear allows the warmed air to pass out of the cabinet. If
cabinets extend up to the ceiling, the warm air must be exhausted through
to the front. Fig. 1.
(e) If an oven unit is installed adjacent to a tall cabinet, steam escaping from the
oven when the door is opened could condense on, and perhaps stain the
adjacent surface. To prevent permanent staining, the adjacent surface should be
made of a material that is heat resisting and easy to clean. Adjacent tall cabinets
should not be deeper than the oven housing cabinet.
IMPORTANT
It is essential that the lower cupboard is constructed in the manner illustrated i.e.
having side, back and roof panels so joined as to provide no apertures which could
permit access to the oven unit when installed.
3. ELECTRICAL INSTALLATION
Mains Supply
A 15 amp Double Pole control switch with a minimum contact clearance of 3mm
must be fitted on or recessed in the wall adjacent to the oven housing cabinetry and
should be accessible after installation. If the oven is to be wired into a connector unit
this may be positioned behind the oven providing:–
i. The top of the connector unit is not more than 30cm above the base of the
oven recess – see Fig. 4.
ii. The depth of the connector unit does not reduce the depth of the oven
recess to less than 55cm.
We recommend that 4mm2 twin and earth PVC insulated cable is used to connect
the cooker to the control unit. This power supply cable must conform to BS 6004.
Alternatively the mains supply can be taken from a household 13 amp switched
fused spur. Having a minimum contact clearance of 3mm which must be fitted
adjacent to the oven housing cabinetry and accessible after installation. The oven
must be fitted with a 3 core cable having a minimum cross sectional area of 1.5mm2
and must conform to BS6500.
The oven must not be connected using a 3 pin 13 amp plug.
34
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION INSTRUCTIONS
Any spare cable must be coiled either behind the oven (not more than 30cm above
the base of the oven recess) or pushed into the air gap below the oven after
installation.
Where a hob is fitted adjacent to or above an oven a 30 amp or 45 amp double
pole switch with a minimum contact clearance of 3mm should be used to feed both
units via separate suitably rated cables.
Where a hob unit is fitted above the oven unit we recommend that 85oC High
Temperature PVC with insulated 3 core flexible cord to table 15 of BS 6141:1991
with a conductor size of 2.5mm2 must be used to connect the hob to the control
unit.
Where a hob unit is fitted adjacent to the oven unit, then 4mm2 twin and earth
cable to BS 6004 is recommended to connect the hob unit to the control unit.
In all cases adhere to routing details (see fig. 5).
Your cooker should have been checked to ensure that the voltage corresponds
with your supply voltage, this is stated on the rating plate which is located on the
oven front frame (lower).
CONDUIT BOX TO MAINS TERMINAL BLOCK
(a) The oven unit should be placed on the floor on its carton base in front of the
housing cabinet. The rear of the unit should be in line with the conduit box.
(b) Ensure there is sufficient cable for any future servicing.
(c) Remove the terminal cover. Prepare the cable, pass it through the cable entry
hole in the oven rear panel and fit to terminal block. Secure the cable clamp
and replace the terminal cover.
4. FINAL INSTALLATION
(a) Using a spirit level, check that the housing cabinet is level from side to side
and from front to back in its installed position.
(b) Correct any unevenness by placing spacers under the bottom of the cabinet.
Make sure that the cabinet rests firmly on the floor without rocking.
(c) Before the oven is fitted the cabinet must be firmly secured to the backing wall
for stability.
(d) The oven unit should now be lifted (this requires two people) into the cabinet
and pushed fully home.
(e) Finally the oven unit must be secured to the cabinet. Position the oven side
trims equally about the cabinet sides. This should give an overlap of approx.
1.5mm per side (see Fig. 2). Secure the oven unit to the cabinet, through the
side trims, by means of the four screws provided, two each side trim.
(f) Remove all packing material from the grill and oven interior.
LIST OF LOOSE ITEMS
4 x No.6 Pozi Head screws
35
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION INSTRUCTIONS
Ventilation Slot
if cabinet doesn't fit to ceiling
51 x 457mm minimum area
560mm
Ventilation Slot
if cabinet fits
to ceiling
51 x 457mm
minimum area
50mm
air
gap
Fig. 1
Viewed down through
cabinet
Oven
Fig. 2
Cabinet
50mm
air
gap
as above
Tall Cabinet
Side
Trim
Oven Door
When fitting a hob above an oven always
use these installation instructions
in conjunction with the hob instructions.
Use 2.5mm2 High Temp Cable. Refer to
Electrical Installation.
No. 6 x 15mm
(4 Supplied)
1.5mm
Fig. 3
Built
Under
578mm min
585mm max
3
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION INSTRUCTIONS
Fig. 4
Single Oven
in tall
Cabinet
Double Pole
585mm max
578mm if cooker
trim is to
Control Switch
6mm2 Cable if Hotplate
fitted
overlap
top edge
of shelf
Conduit Box
4mm2 Cable if hob fitted
adjacent to oven
*excluding pipes
and other
projections
4mm2 Cable
to Oven
Refer to Electrical Installation
Fig. 5
37
Download from Www.Somanuals.com. All Manuals Search And Download.
SOMETHING WRONG?
Before calling a Service Engineer, please check through the following lists.
THERE MAY BE NOTHING WRONG.
Problem
Check
Nothing works.
(a) Check
If you find :-
Display is blank.
Then it is likely that there is no electricity supply to your oven.
Check: (i) That the main cooker wall switch is turned on.
(ii) Check other appliances to see if you have a power
cut.
(iii) Check the main circuit breaker for the property.
(iv) With the selector switch (B) turned the oven
light does not illuminate.
Display shows 0.00 AUTO.
The power supply to your oven has possibly been interrupted, but
has now come back on again. Reset the timer to the correct time
of day and "Manual" operation using instructions given in the timer
section of the book.
Main Oven and Grill do not work
Check the following to ensure that the timer is in Manual Mode:
Check that the Auto Symbol is not lit up and is not flashing.
See timer section for instructions on how to return timer to
"Manual".
Operating the cooker under the following conditions may cause a
safety device to operate.
Main Oven and Grill do not work.
(a) Grilling with the door closed - always grill with the door open
to the correct position - see grilling.
(b) Grilling for an excessively long period at maximum setting -
see grilling guide.
(c) Grilling with inadequate ventilation in the cabinet - see
installation instructions.
Check that the selector switch (B) is set and that the
temperature control (A) is set to the correct temperature.
Oven does not work.
Grill does not work.
Check that you have selected :- "Grill" function on the "Oven/Grill
Select" knob (B) and a Grill setting on the Temperature Control
Knob (C) - see grilling page.
Grill keeps turning on and off.
When the Temperature control (C) is operating at less than "6", the
grill will cycle on and off, this is normal and is not a fault.
Can not set an “Auto Cook” pro-
gramme
Remember: "Cook Period" is the actual length of time for which,
the timer will switch the oven on as part of an "Auto Cooking" pro-
gramme.
Draught from beneath control
panel.
A gentle flow of air will be blown from beneath the control panel
when the appliance is used.
Timer buzzer/bleeper operates
continually
Buzzer/Bleeper should stop automatically after 2 minutes. If not,
press minute minder button to silence.
If you have been through the above list and there is still a problem; You should identify your
Service Agent using the list on the back page and contact your Local Service Office.
38
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
Key Contacts
Service
Hotpoint has the largest appliance manufacturer’s service team in
Europe, trained specialists directly employed by us to ensure your com-
plete
confidence.
Repair Service
UK: 08709 066 066
Republic of Ireland: 1850 302 220
You will be asked for the following information:-
Name, address and postcode.
Telephone number
Model / Serial number of the appliance
Clear and concise details of the query or fault
Place and Date of purchase
(Please keep the receipt as evidence will be required when the engineer calls).
Extended Warranty
To join: UK 08709 088 088
Republic of Ireland: 1850 502 220
Genuine Parts & Accessories
Mail Order Hotline
UK: 08709 077 077
Republic of Ireland: (01) 842 6836
For further product information 08701 506070
All Hotpoint Services are offered as an extra benefit and do not affect your statutory rights.
General Domestic Appliances Limited, Morley Way, Peterborough, PE2 9JB
PRINTED BY SIMLEX - FOUR ASHES, WOLVERHAMPTON.
April 2001 Part no. 482800159-05
Download from Www.Somanuals.com. All Manuals Search And Download.
|