Alero GP52 Foldable Power Wheelchair
Owner’s Manual
401 Bridge Street · Old Forge, PA 18518
Phone: 800-624-6374 · Fax: 800-628-5165
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
TABLE OF CONTENTS
INTRODUCTION…………………………………………………………..........
SAFETY…………………………………………………………………………...
EMI/RFI…………………………………………………………………………...
SPECIFICATIONS……………………………………………………………….
4
5
8
9
UNPACKING……………………………………………………………………... 10
ASSEMBLY………………………………………………………………………. 11
SPECIAL FEATURES…………………………………………………………... 14
Brake Release Levers………………………………………………………….. 14
Wheel Locks…………………………………………………………………… 14
Armrest………………………………………………………………………… 15
Swing-Away Footrest………………………………………………………….. 16
Joystick Controller……………………………………………………………... 17
Folding Your Alero……………………………………………………………. 18
GENERAL OPERATION……………………………………………………….. 20
Charging Your Batteries……………………………………………………….. 20
Driving Your Alero……………………………………………………………. 21
Curbs and Other Small Obstacles………………………………………............ 22
Slopes and Ramps………………………………………………………............ 22
MAINTENANCE…………………………………………………………............ 24
Regular Maintenance…………………………………………………………... 24
Annual Maintenance………………………………………………………........ 24
DIAGNOSTICS………………………………………………………………....... 25
WARRANTY………………………………………………………………........... 26
REGISTRATION…………………………………………………………............ 28
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
INTRODUCTION
Congratulations on the purchase of your new Golden Technologies Alero power wheelchair!
The Alero combines cutting edge technology with attractive designs that are also highly
functional in today’s world. Every component of your Alero is produced using extensive
research and evaluation to ensure durability, reliability and efficiency to surpass industry
standards.
We at Golden Technologies know that you have chosen a power wheelchair that will give you
years of dependable operation and will also enhance the quality of your life by providing you
with the mobility to experience a more active daily lifestyle.
Please read, understand and follow all of the instructions and suggestions in this manual before
you operate your Alero for the first time. The safe use of your new power wheelchair is very
important and starts with you. Your new Alero is user-friendly and designed for maximum
maneuverability in even the tightest spaces.
If you feel uncomfortable with your new power wheelchair or do not understand the instructions
presented in this owner’s manual, or if, for any reason, you do not feel capable of performing
the activities necessary to assemble, disassemble, operate, or maintain your Alero, please
contact the home health care dealer you purchased this power wheelchair from or contact
Golden Technologies technical support services at 800-624-6374.
Golden Technologies, Inc. cannot be held responsible for personal injury or property damage
resulting from the unsafe or the improper use of any of our broad range of health and personal
mobility products.
Please fill out and mail the enclosed warranty registration card. We at Golden Technologies,
Inc. would appreciate hearing about your experience with your new Alero power wheelchair!
Please mail your warranty registration card to:
Golden Technologies, Inc.
Warranty Registration Office
401 Bridge Street
Old Forge, PA 18518
Phone: 570-451-7477
Fax: 570-451-7494
Stop by our website 24 hours a day!!!
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SAFETY
Safety is the most important consideration when using your Alero power wheelchair. Golden
Technologies has taken every consideration to provide you with a safe and reliable power
wheelchair. It is your responsibility to read and understand these safety instructions before
attempting to assemble or operate your power wheelchair. Failure to do so may result in
personal injury or may cause property damage.
Your Alero is a battery-operated power wheelchair. Please exercise caution and consideration when
you are operating it. Driving your Alero carefully and thoughtfully will help ensure your personal
safety and the safety of other people.
Please note, throughout this manual you will see the following warning symbol:
WARNING!
Please pay particular attention to these warnings. Doing so will help make riding your Alero a safe
and pleasurable experience.
Operating Safety
Adjustment to performance parameters should only be made by healthcare professionals or
people fully knowledgeable with this process and the driver’s capabilities. Improper settings
may cause injury to the driver, bystanders, damage to the power wheelchair or to surrounding
property.
Once the power wheelchair has been set-up, test the power wheelchair’s performance to be sure
they match the specifications entered during the set-up procedure. Should the power wheelchair
not perform to specifications, turn the power off immediately and enter the specifications again.
Repeat this process until the power wheelchair performs to desired specifications.
ALWAYS make sure the power is off when transferring in or out of your power wheelchair.
ALWAYS engage the wheel locks before entering or exiting your power wheelchair. The
wheel locks are designed to prevent the power wheelchair from moving. It is also preferable to
ensure the front casters are in the forward position before transferring. With the casters in the
forward position, the wheelbase of the power wheelchair is at its greatest, thereby offering more
stability.
When transferring in or out of your power wheelchair, ALWAYS keep the distance between the
two transfer points to a minimum.
When transferring in or out of your power wheelchair, NEVER stand on the footplates.
Depending on the style of footplate, either swing them away or fold them up before transferring.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SAFETY (cont.)
Operating Safety (cont.)
When turning, ALWAYS shift your weight in the direction you are turning. NEVER shift your
weight in the opposite direction of the turn. Doing so may cause your power wheelchair to tip
over.
To maintain lateral stability, NEVER reach further than the length of your arm.
NEVER lean out of the chair as this may cause instability.
Please practice bending, reaching and transferring activities in the presence of a qualified
healthcare professional to establish your particular safety limits before using your power
wheelchair for the first time.
NEVER engage or disengage the brake release levers with the power on.
NEVER sit on your power wheelchair when the brake release levers are disengaged.
NEVER use an escalator to move your power wheelchair between floors. Serious bodily injury
may occur.
NEVER attempt to lift your power wheelchair by any of the removable parts. Doing so may
result in injury to the people lifting the unit or damage to the power wheelchair.
ALWAYS remain properly seated when operating your power wheelchair.
DO NOT carry passengers under any circumstances
DO NOT operate your power wheelchair on roads, streets or highways.
ALWAYS reduce the speed of your power wheelchair when making turns.
DO NOT attempt to stop your power wheelchair using your wheel locks. Wheel locks are not
brakes!
DO NOT attempt to drive your power wheelchair up or down an incline more than 60.
ALWAYS ask for assistance when going up or down inclines of this nature.
ALWAYS drive up or down inclines on a 90o angle. Driving up or down an incline at angles
less than 90o may increase tipping and may cause bodily injury or property damage.
DO NOT back your power wheelchair down an incline or across uneven surfaces.
ALWAYS lower your speed while driving down inclines to avoid sudden stops or hard braking.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SAFETY (cont.)
Operating Safety (cont.)
DO NOT attempt to drive over curbs or obstacles greater than 1 ½ inches as this may cause
your power wheelchair to tip over or cause damage to your power wheelchair.
DO NOT back down a curb or step.
NEVER operate your power wheelchair without the provided anti-tippers. Failing to do so may
increase your chances of tipping over while operating your power wheelchair.
NEVER sit in your power wheelchair while it is being transported.
DO NOT leave your power wheelchair out in adverse weather such as rain or snow.
DO NOT leave your power wheelchair in a damp area (such as a shower or bathroom) for any
extended period of time. Excessive exposure to dampness may cause your power wheelchair to
malfunction.
DO NOT cut or remove the grounding prong on the plug used with any Golden Technologies
product. Always use a three prong receptacle or extension cord. Use of a two prong outlet or
extension cord may result in electrical shock or fire.
ALWAYS use the appropriate size batteries for your power wheelchair.
NEVER try to fit larger batteries into the battery cases provided. Forcing a larger battery into
the cases may cause damage to the battery, the battery case or may create a fire hazard.
NEVER attempt to charge the batteries and operate your power wheelchair at the same time.
DO NOT attempt to charge the batteries if your power wheelchair has been or is being exposed
to moisture.
DO NOT charge the batteries while sitting in the wheelchair.
NEVER charge a frozen battery.
ALWAYS make sure the charger is disconnected before attempting to operate your power
wheelchair.
NEVER modify your power wheelchair in any way that is not authorized by Golden
Technologies.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
EMI / RFI
The rapid development of electronics, especially in the area of communications, has saturated
our environment with electromagnetic (radio) waves that are emitted by television transmitters,
cellular phones, citizen’s band radios (CBs) amateur radios (HAM radios), wireless computers
links, microwave transmitters, paging transmitters, etc. These electromagnetic (EM) waves are
invisible and increase in strength the closer one gets to the source of transmission. When these
energy waves act upon electrical devices and cause them to malfunction or to function in an
erratic or uncontrolled manner, they are referred to as Electromagnetic Interference (EMI) or
Radio Frequency Interference (RFI).
EMI / RFI AND YOUR ALERO
All electrically powered vehicles, including power wheelchairs are susceptible to EMI / RFI.
This interference could result in abnormal or unintended movement of your Golden
Technologies Alero.
The FDA has determined that each make and model of power wheelchair can resist EMI /RFI
to a certain level. The higher the level of resistance, the greater the degree of protection from
EMI / RFI – measured in volts per meter (V/M). The FDA has also determined that current
technology is capable of providing 20 V/M of resistance to EMI/RFI, which would provide
useful protection against common sources of interference. The resistance level of the Golden
Technologies Alero is unknown.
EMI / RFI RECOMMENDATIONS
• Do not turn on or use hand-held personal electronic communication devices such as
cellular phones, walkie-talkies, or CB radios while your power wheelchair is turned on.
• Be aware of any nearby transmitters (radio, television, microwave, etc.) on your
intended route and avoid operation of your power wheelchair close to any of those
transmitters.
• Be aware that adding accessories or components or modifying your power wheelchair
may make it more susceptible to EMI / RFI.
• If unintended movement or brake release occurs, turn your power wheelchair off and
remove the key as soon as it is safe to do so.
• Report all incidents of unintended movement or brake failure to Golden Technologies.
IF UNINTENDED OR UNCONTROLLABLE MOTION OCCURS
OR IF UNINTENDED BRAKE RELEASE OCCURS TURN OFF
YOUR POWER WHEELCHAIR AS SOON AS IT IS SAFE TO DO
WARNING!
SO.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIFICATIONS
Model
Alero – GP52SS
Seat Dimensions
18” standard; also available in 16” and
20” widths
Seat Width
Seat Depth
Seat Height
16”
Front – 20” ; Rear – 19 3/8”
Overall Dimensions
47” for 16” and 18” models, 49” for 20”
model
24.5” for 16” model, 26.5” for 18”
model and 28.5 for 20” model
Length
Width
Height
39”
Weight
Base – including controller, footrests and
86 lbs
anti- tippers
Batteries – with cases (2)
50 lbs
Battery Type
(2) U1
250 lbs
3.7 mph
20 miles
29.5”
Load Capacity
Maximum Speed
Range
Turning Radius
Wheel Sizes
Rear Drive Wheels
Front Caster Wheels
Anti-Tip Wheels
Maximum Obstacle Height
Maximum Safe Incline
Controller
12.5” foam filled
8” foam filled
1.5” solid
1.5” (in upright seat position)
6 degrees
PG VSI 50 amp
Charger
Off-board, Portable
Rear Wheel, 24V DC Motors
Drive Train
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
UNPACKING
After removing your Alero GP52SS power wheelchair from the carton, please make sure you
have been supplied the following main parts as standard specification:
1. Main Frame – The main frame has the following parts attached:
• Motors/Gearboxes
• Front Casters
• Rear Drive Wheels
• Foldable Battery Tray
• Lap Positioning Belt
• Foldable Back with Cane Handle Grips
• Battery Charger pouch
2. Foot Rigging with swing-away footrest
3. Battery Boxes with U1 Batteries – two pieces
4. Battery Charger – off board
5. Controller – PG VSI 50 amp
6. Rear Anti-Tip Wheels – two pieces
7. Seat Cushion
8. Calf Strap
Fig. 1
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
ASSEMBLY
Your Golden Alero is a fully foldable power wheelchair. It has been designed to be assembled
with minimal effort or difficulty. Should you not understand the procedures outlined below or
have difficulty assembling your Alero, please contact your Golden Authorized Dealer for
assistance.
1. Unfold your Alero by holding the two arm rests with your hands and pushing outwards
to extend frame. (Fig. 2)
2. Push down on seat rails to ensure the seat opens fully and locks into the receivers on the
wheelchair side frames. (Fig. 3)
Fig. 2
Fig. 3
3. Raise the folding back and lock it into position. (Fig. 4)
4. Attach the bottom of the backrest under the bottom of the seat using the Velcro®
provided.
5. Slide the Power Control / Joystick arm into the mounting bracket under the armrest and
tighten it. The cable should run on the outside of the clothing guard. (Fig. 5)
Fig. 4
Fig. 5
Note: The Joystick Controller can be mounted on either side of your power wheelchair. We
suggest you contact the Golden Authorized Dealer you purchased your Alero from
should you wish to change it.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
ASSEMBLY (cont.)
6. Connect the motor cables underneath the seat to the motor connectors on the cable
coming from the joystick controller. The motor connectors and cables are marked left
and right. Plug in the left to the left and the right to the right.
NEVER plug the right motor connector into the left motor and
NEVER plug the left motor connector into the right motor. Doing so
may cause your power wheelchair to operate in an abnormal fashion.
WARNING!
This may cause bodily injury or property damage.
7. Insert the battery box with the red and black connectors into the battery tray so the
connectors face the arm with the Joystick Controller. (Fig. 6)
Please note: The battery tray is designed to fold and unfold with the unit. On some
units, the tray may be stiffer than others and may require you to push down on the
middle of the tray to fully open the tray it and fit the battery boxes inside.
8. Connect power connection from the battery box, (black connector) to the black
connector on the joystick controller. (Fig. 7) Slide battery box forward.
Fig. 7
Fig. 6
9. Place the second battery box behind the first battery box and connect the red battery
connectors. (Fig. 8) Ensure all connections are secure.
10. Slide anti-tips into sockets on rear of chair and lock into position. (Fig. 9)
Fig. 9
Fig. 8
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
ASSEMBLY (cont.)
11. Next, install the swing-away footrests. Taking one of the footrest, align the holes of the
hinge plate over the pivot hinge pins on the seat frame above the caster wheels. Note
you will need to face the locking mechanism forward of the seat post and swivel the
footrest inward until it locks in place. Repeat with other footrest. (Fig. 10)
12. Fasten calf strap to the swing-away footrest tubes above the foot plates by using the
Velcro® provided. (Fig. 11)
Hinge
Pins
Locking
Mechanism
Fig. 11
Fig. 10
13. Position seat cushion on seat.
14. Press power button on joystick controller. The LED’s should light indicating the power
is now on.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIAL FEATURES
Brake Release Levers
For your convenience, your Alero is equipped with two brake release levers. The brake release
lever can be located on the rear of each motor. (Fig. 12) These levers allow you to disengage
the drive motors and maneuver the power wheelchair manually.
DO NOT USE YOUR ALERO WHILE THE DRIVE MOTORS ARE
DISENGAGED UNLESS YOU ARE IN THE PRESENCE OF AN
ATTENDANT!
WARNING!
DO NOT DISENGAGE THE DRIVE MOTORS WHEN YOUR
ALERO IS ON AN INCLINE. DOING SO MAY CAUSE THE
POWER WHEELCHAIR TO ROLL ON ITS OWN AND MAY
WARNING!
RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
1. To ENGAGE the brakes on the motors, turn the brake release lever rearward. (Fig. 12)
2. To DISENGAGE the brakes on the motors, turn the brake release lever outward. (Fig.
13)
Fig. 12
Fig. 13
Wheel Locks
Wheel locks are fitted to both drive wheels. The wheel lock levers are located just in front of
the drive wheels. (Fig. 14) Wheel locks should be engaged whenever you transfer in or out of
your Alero and/or when the wheelchair is stationary.
NEVER ENGAGE YOUR WHEEL LOCKS WHILE OPERATING
YOUR ALERO. YOUR ALERO IS EQUIPPED WITH A BRAKING
SYSTEM AND THE WHEEL LOCKS ARE NOT TO BE USED AS A
WARNING!
SUBSTITUTE FOR THESE BRAKES.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIAL FEATURES (cont.)
Wheel Locks (cont.)
1. To ENGAGE your wheel locks, push the hand lever forward as shown below. (Fig. 14)
2. To DISENGAGE your wheel locks, push the hand lever rearward as shown below.
(Fig. 15)
Fig. 14
Fig. 15
Please note: Wheel Locks can be adjusted as tire wear increases. To adjust your wheel
locks, loosen the frame mounting clamp and slide the wheel lock upward. Retighten the
frame mounting clamp while the wheel lock engages to the correct position. Please contact
your Golden Authorized Dealer should you need assistance.
Armrest
Your Alero is equipped with a height adjustable armrest with a clothing guard. Adjustment of
the armrest is facilitated by the use of a lock pin. Simply pull the lock pin and adjust the arm
accordingly. (Fig. 16) Release the lock pin making sure the pin engages into one of the height
adjustment holes on the arm’s frame.
The Joystick Controller length can be adjusted for more comfort. Loosen the thumb screw
under the arm and adjust the length accordingly. Once a comfortable length has been achieved,
retighten the thumb screw. (Fig. 17)
Fig. 17
Fig. 16
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIAL FEATURES (cont.)
Armrest (cont.)
The arms of your Alero can also be flipped back to aid in transferring in or out of your power
wheelchair. To flip back the arm, disengage the lock by pressing on the locking lever and lift
the arm up and back. (Fig. 18 & Fig. 19)
Fig. 18
Fig. 19
NEVER DRIVE YOUR ALERO WHILE THE ARMS ARE FLIPPED
UP AND/OR BACK . DOING SO MAY CAUSE BODILY INJURY
OR PROPERTY DAMGE.
WARNING!
Swing-Away Footrest
Your Alero comes standard with swing-away footrest. These footrests are designed to swing
away for easier transfers in and out of your power wheelchair and are detachable for
transporting or storing your Alero. The foot plates on these footrests are also height adjustable
giving you a more comfortable riding experience.
1. To swing your footrests to the side of your chair, remove calf strap, then disengage the
locking mechanism on the inside of the footrest extension tube and swing to towards the
outside of your power wheelchair. (Fig. 20)
2. To detach your footrest, swing footrest to outside of your power wheelchair and lift
upwards.
3. To adjust the height of your foot plates, loosen the bolt on the bottom of the foot plate
and slide the extension tube and foot plate up or down until you meet the desired height.
(Fig. 21)
Extension Tube
Bolt
Fig. 21
Fig. 20
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIAL FEATURES (cont.)
Footrest (cont.)
DO NOT STAND ON THE FOOT PLATES OF YOUR ALERO.
WARNING!
NEVER LIFT YOUR ALERO BY THE FOOTRESTS OR ANY
OTHER DETACHABLE PART OR ACCESSORY. FAILURE TO
DO SO MAY RESULT IN BODILY INJURY OR PROPERTY
DAMAGE.
WARNING!
Joystick Controller
Your Alero is equipped with a joystick controller using proportional drive control. This means
the further you push the joystick from the neutral position, the faster you will go. However, the
top speed you can go is limited by the speed control buttons and the programmed settings of
the unit.
Your joystick controller has the following features associated with it:
Use this button to turn your power wheelchair on or off.
Press once for on. Press again for off. Do not use this
button to stop your wheelchair except in the case of an
emergency.
Power Button
Pushing this button decreases the speed of your Alero.
The lights on the speed gauge will decrease with each
time you press it signifying
Decrease Speed
Increase Speed
Pushing this button decreases the speed of your Alero.
The lights on the speed gauge will decrease with each
time you press it signifying
Push this button to operate the horn.
Horn
This is a 10 segment display which
indicates your power is on and gives the
state of the charged battery. The more
segments that are lit, the stronger the
battery charge.
Battery Gauge
This is a 5 segment display which
indicates the maximum speed setting
Maximum Speed Indicator
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIAL FEATURES (cont.)
Joystick Controller (cont.)
This controls the direction your
wheelchair will move. Gently push the
joystick in the direction you would like
to travel. The further you push from
center or neutral, the faster the
wheelchair will move. Releasing the
joystick stops the wheelchair and
automatically applies the brakes.
Joystick
Tires
Your Alero has been fitted with flat free tires. It will not be necessary to check tire pressure.
You will need to check tire tread for wear.
Folding Your Alero
Your Alero is a fully foldable power wheelchair. This feature will help save space when
transporting or storing your Alero. Please follow the procedures below to fold your Alero:
1. Disconnect and remove both batteries.
2. Fold up the footplates on both swing-away footrests.
3. Unlock the footrest and swing them to the side.
4. Remove each footrest and place them clear of the Alero.
5. Remove seat cushion and set aside.
6. Take hold of the strap in the middle of the seat upholstery. (Fig. 22) Depending on
your strength capabilities you may want to use two hands.
7. Pull up on the seat upholstery. (Fig. 23)
8. Remove battery charger from its storage pouch on the rear of the seat.
Fig. 23
Fig. 22
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
SPECIAL FEATURES (cont.)
Folding Your Alero (cont.)
9. Release the lock on the seat back and fold down. (Fig. 24)
Fig. 24
The Alero power chair folds easily for storage and transportation.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
GENERAL OPERATION
Before operating your Alero for the first time, we advise you to fully charge your batteries.
Most batteries are not fully charged when shipped from the manufacturer. While in storage,
batteries can lose some of their charge. Charging your batteries will ensure you get peak
performance from your Alero from the very first time you use it.
Charging Your Batteries
The battery charger is an automatic current limiting device. It is designed to shut itself down
when the batteries are fully charged. It is advisable to charge your batteries for a minimum of
10 hours per night to ensure a full return to the batteries storage capacity.
ALWAYS MAKE SURE THE POWER IS OFF BEFORE
ATTEMPTING TO CHARGE YOUR ALERO.
WARNING!
DO NOT PLACE YOUR ALERO NEAR RADIATORS OR OPEN
FIREPLACES WHILE CHARGING.
WARNING!
DO NOT SMOKE OR PERMIT OPEN FLAMES IN THE
IMMEDIATE AREA WHILE CHARGING.
WARNING!
NEVER USE BATTERIES OTHER THAN THE RECOMMENDED
TYPE FOR YOUR CHAIR.
WARNING!
NEVER USE A CHARGER OTHER THAN THE ONE SUPPLIED
BY GOLDEN TECHNOLOGIES.
WARNING!
1. Position your power wheelchair next to a standard wall outlet.
2. Make sure power is off. (there will be no lights lit on controller)
3. Remove battery charger and charger cord from storage pouch on the rear of the seat
back. (Fig. 25)
4. Make sure charger is set to off position by pushing “O” side of power button. (Fig. 26)
Charger
Pouch
On/Off
Fig. 26
Fig. 25
20
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
GENERAL OPERATION (cont.)
Charging Your Alero (cont.)
5. Push receiver end of charger cord into charger. (Fig. 27)
6. Push plug end of the charger cord into a standard wall outlet.
7. Align prongs of charging plug on charger with the holes in the charging socket on front
of your Joystick controller and insert charging plug. (Fig. 28)
Fig. 28
Fig. 27
8. Make sure all connections are secure.
9. Turn on the charger by pushing the “I” side of the power button. (Fig. 26) The fan
inside the charger should run and the LED’s will turn Red/Yellow.
10. The LED’s will turn Red/Green, when charging has been completed.
Driving Your Alero
If operating for the first time, please practice driving your Alero in an open area. All power
wheelchairs react differently and it is best getting used to how your wheelchair’s responds in an
area free of obstacles. Practice in an open area until you are comfortable operating your Alero.
Then practice moving around obstacles. If you are uncomfortable or not happy with the
response of your Alero, ask your Golden Authorized Dealer to adjust the programming to a
level at which you are comfortable.
Before sitting in your Alero, please make sure:
9 the power to your Alero is switched off.
9 the wheel locks are in the engaged position. (Fig. 14)
9 the brake release levers are in the engaged position. (Fig. 12)
9 the battery charger is disconnected.
9 you swing your footrest to the side of the chair.
1. Carefully transfer into your Alero making sure not to hit the power button.
2. After transferring, make sure you are comfortably positioned and the armrests and
swing-away footrests have been adjusted to suit your needs.
3. Position the joystick controller so it is easy to reach. This will help to eliminate muscle
fatigue during driving.
4. The lap positioning belt should be adjusted and fastened before you start to operate your
Alero.
Note: Golden Technologies strongly suggests to ALWAYS wear your lap positioning
belt. The lap positioning belt is a positioning belt only. It is not designed for
use as a safety device.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
GENERAL OPERATION (cont.)
Driving Your Alero (cont.)
5. Turn power on by pushing the power button once.
6. Set the speed control of your power wheelchair to slow.
7. Release the wheel locks.
8. Push the joystick gently forward, applying a steady even pressure. The further you
push the joystick the faster the power wheelchair will go. To STOP, release the
joystick so as to return it to the neutral or vertical position.
9. Directional control is achieved by gently moving the joystick in the direction you want
to go. Push to the right to go right; push left to go left; and pull back to go in reverse.
NEVER DRIVE AT A SPEED GREATER THAN YOUR ABILITY
TO SAFELY CONTROL YOUR POWER WHEELCHAIR.
REMEMBER THAT WET OR LOOSE SURFACES NEED
WARNING!
WARNING!
GREATER CARE AND CONTROL.
AVOID JERKY STOP / START MOTIONS. THIS MAY RESULT IN
INCREASED BATTERY WEAR, TIRE WEAR AND THE RAPID
WEARING OF THE MOTOR / GEARBOX.
Curbs and Other Small Obstacles
Golden Technologies strongly advises against climbing curbs
or any obstacle over 1½ inches in height. Failure to adhere to
this advice will increase your chances of tipping and may
cause bodily injury or property damage.
WARNING!
At times, you will be faced with situations requiring you to climb or descend a curb or traverse
over a small obstacle. In order to achieve this safely, approach the curb or obstacle head on
making sure both front casters go over the curb or obstacle at the same time.
Never traverse a curb or an obstacle at an angle. Failure to
adhere to this advice will increase your chances of tipping and
may cause bodily injury or property damage.
WARNING!
Slopes or Ramps
Never traverse a slope or ramp greater than 6o. Failure to
adhere to this advice will increase your chances of tipping and
may cause bodily injury or property damage.
WARNING!
When operating you Alero on slopes or ramps, it is recommended the user:
1. Visually inspect the angle of the slope or ramp is less than 6 degrees.
2. Makes sure the slope or ramp is wide enough to allow the tires of your wheelchair to
pass freely along the ramp.
22
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
GENERAL OPERATION (cont.)
Slopes or Ramps (cont.)
3. Makes sure the ramp is free of any debris or obstacles that may interfere with the safe
passage of your power wheelchair.
If the slope or ramp meets the above conditions, it is recommended the user approaches the
ramp at a reduced speed and head on. Once on the slope or ramp, the user should maintain a
constant but safe speed over the entire length of the slope or ramp. If the ramp does not meet
the above conditions, the user should ask for help from an assistant or find a safer, but alternate
route.
23
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
MAINTENANCE
Your Alero needs some basic attention to ensure it provides reliable service. We recommend
your power wheelchair is checked regularly for maintenance requirements and also receives a
thorough annual check up by your Golden Authorized Dealer.
Regular Maintenance
1. Make sure power is off before performing any maintenance.
2. Check the joystick to make sure it is not bent or damaged and that it returns to center
when you release it. See a Golden Authorized Dealer if there is any problem.
3. Check the rubber boot around the base of the joystick for damage. Visually inspect the
boot. Do not handle or try to repair it. See a Golden Authorized Dealer if there is any
problem.
4. Keep the upholstery and frame clean by wiping with a soft cloth, particularly after
driving through wet, sandy or muddy conditions.
Do not use harsh abrasive materials when cleaning, Do not
apply liquid cleaners or solvents directly to the control box,
battery charger or any electrical connections.
WARNING!
5. Keep wheels free from lint, hair, sand or carpet fibers.
6. Check motor connectors, joystick connectors and battery connectors for a tight fit and
that they are secured properly. Make sure there are no frayed or cut wires. See a
Golden Authorized Dealer if there is any problem.
7. Tighten the controller adjustment arm.
8. Charge your batteries regularly. Make sure the terminals are free of corrosion.
Remember to always wear gloves when handling any battery.
9. Lightly oil axle pin, wheel axles and bearings once every three months.
10. Check tires for abnormal wear and tear.
Annual Maintenance
1. Check the controller programmer for the user’s needs.
2. Check the wheelchair frame.
3. Check the upholstery for wear.
4. Check the tires for abnormal wear and tear.
5. Check the batteries and terminals.
6. Check all connectors for secure fits.
7. Check all cables for frayed, cut or exposed wires.
8. Check the joystick to make sure it is not bent or damaged and that it returns to center
when you release it.
9. Check the rubber boot around the base of the joystick for damage. Visually inspect the
boot.
24
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero GP52SS Owner’s Manual
Revised 0807
DIAGNOSTICS
The PG VSI controller on your Alero will provide you with information should a
malfunction happen with your power chair. The LED lights on the controller will flash in a
certain sequence to inform you of a malfunction. If more than one fault exists, then the
fault having the highest priority is indicated. All faults disable the controller and require
the controller to be turned off then on again if the source of the fault is removed.
The batteries need charging or there is a bad connection to the
batteries. Check the connection to the batteries. If the
connections are good, charge the batteries.
One Bar
The left side motor has a bad connection. Check the
connections to the left side motor. If the connections are good,
call your Golden Authorized Dealer for service.
Two Bars
The left side motor has a short circuit to a battery connection.
Call your Golden Authorized Dealer for service.
Three Bars
The right side motor has a bad connection. Check the
connections to the right side motor. If the connections are
good, call your Golden Authorized Dealer for service.
Four Bars
The right side motor has a short circuit to a battery connection.
Call your Golden Authorized Dealer for service.
Five Bars
The wheelchair is being prevented from driving by an external
signal. The exact cause will depend on the type of wheelchair
you have; one possibility is the battery charger is connected
Six Bars
A joystick fault is indicated. Make sure the joystick is in the
center position before switching on the control system.
Seven Bars
A control system fault is indicated. Make sure all connections
are secure.
Eight Bars
The parking brakes have a bad connection. Check the parking
brake and motor connections. Make sure the control system
connections are secure.
Nine Bars
An excessive voltage has been applied to the control system.
This is usually caused by a poor battery connection. Check
battery connections.
Ten Bars
Note: If you detect there are problems with the motors, the battery charger, the
controller or damage to the power wheelchair frame, it is highly recommended
you contact your local Authorized Golden Dealer.
25
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero
GP52SS
GOLDEN TECHNOLOGIES
CONSUMER LIMITED WARRANTY
ALERO
The following is granted only to the INITIAL CONSUMER who has purchased
our product and COMMENCES on the Date of Purchase by the Consumer from
the Merchant. The Consumer must have a warranty registration card filed with
Golden Technologies to receive service.
Three-Year Limited Warranty:
For the period of three years, in the event if defective materials or workmanship,
Golden Technologies will repair or replace at our option any of the following
structural frame components found to be defective by an authorized Golden
Technologies representative:
♦ Side Chair Frame
One-Year Limited Warranty:
For the period of one year, in the event if defective materials or workmanship, Golden
Technologies will repair or replace at our option any of the following structural frame
components found to be defective by an authorized Golden Technologies
representative:
♦ Cross Braces
♦ Armrests
♦ Backrest Canes
♦ Wheel Locks
♦ Foot Riggings
For the period of one year, in the event if defective materials or workmanship, Golden
Technologies will repair or replace at our option any of the following drive train
components found to be defective by an authorized Golden Technologies
representative:
♦ Motor/Gearbox Assembly
♦ Brake Assembly (electrical function only)
Note: An increase in operating noise of the motor/gearbox DOES NOT constitute
a defect. With normal wear and tear, operating noise is expected to
increase.
For the period of one year, in the event if defective materials or workmanship, Golden
Technologies will repair or replace at our option any of the following electronic
assemblies found to be defective by an authorized Golden Technologies representative:
♦ Battery Charger
♦ Electronic Controller
♦ Wire Harness (es)
Note: While charging batteries, it is normal for the battery charger to heat up.
Heat coming from the battery charger DOES NOT constitute a defect.
For the period of one year, in the event if defective materials or workmanship, Golden
Technologies will repair or replace at our option any of the following parts found to be
defective by an authorized Golden Technologies representative:
♦ Bearings
♦ Bushings
♦ Rubber Components
♦ Plastic Components
(excludes battery
cases)
(excludes tires)
26
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero
GP52SS
GOLDEN TECHNOLOGIES
CONSUMER LIMITED WARRANTY
ALERO
Warranty Exclusions:
Golden Technologies does not provide warranty on any of the following items which
may require replacement due to the normal wear and tear of day to day usage.
♦ Tires and Tubes
♦ Bulbs/Fuses
♦ Motor Brushes
♦ Upholstery
♦ Brake Pads
This warranty also excludes the following:
♦ Batteries (Please consult the battery manufacturer for any implied warranty)
♦ Damage caused by:
¾ Battery fluid spillage or leakage;
¾ Abuse, misuse, accident or negligence;
¾ Improper operation, maintenance or storage;
¾ Commercial use or use other than normal
¾ Repairs and/or modifications made to any part without the specific
consent of Golden Technologies;
¾ Exceeding the specified weight capacity of the unit;
¾ Accessories other than those supplied or approved by Golden
Technologies;
¾ Failure to adhere to product instructions;
¾ Acts of God, such as lightning strikes, earthquakes, etc…..
¾ Circumstances beyond the control of Golden Technologies.
♦ ANY PARTS ALTERED OR REPAIRED BY UNAUTHORIZED
PERSONS.
Warranty Service:
Warranty Service must be performed by an authorized Golden Technologies
representative. Golden Technologies reserves the right to replace warranted part(s)
at our discretion. All labor charges, service calls, transportation costs or any other
charge(s) associated with the installation of any warranted part(s) are the sole
responsibility of the consumer. Consumers are not to return any item(s) to Golden
Technologies without prior written authorization. Any damages incurred while
warranted part(s) are in transport are the sole responsibility of the consumer.
There is no other express warranty.
Implied warranties, including those of merchantability and fitness for a particular
purpose are excluded. Liabilities for consequential damages are excluded.
This warranty gives you specific rights and you may also have other rights which
may vary from state to state.
27
Download from Www.Somanuals.com. All Manuals Search And Download.
Golden Alero
GP52SS
Golden Technologies
Product Registration Form
Alero
Please fill out this product registration form. Failure to do so could
result in significant delays should service be required.
Owner Information:
Name: ___________________________________________________
Address: ___________________________________________________
City: __________________ State: _____ Zip Code: ___________
Product Information:
Serial Number: ____________________________________________
Purchased From: ____________________________________________
City: ________________________ State: _____________
Date Purchased: _________________
Mail Completed Form To:
Golden Technologies
401 Bridge Street
Old Forge, PA 18518
28
Download from Www.Somanuals.com. All Manuals Search And Download.
|