Built-In Wall Oven
27” (68.6 cm) models
Installation
Instructions
JCKS10, JCKP30, JCKP70, PCK916, PCK920
30” (76.2 cm) models
JCTP30, JCTP70, PCT916, PCT920
If you have questions, call 1.800.561.3344 or visit our website at:
• Proper installation is the responsibility
Before You Begin
of the installer and product failure due
to improper installation is NOT covered
under warranty.
• NOTE—This appliance must be properly
grounded.
Read these instructions carefully and completely.
• IMPORTANT—Save these
instructions for local inspector’s use.
• IMPORTANT—Observe all
• ATTENTION INSTALLER
governing codes and ordinances.
All electric wall ovens must be hard wired
(direct wired) into an approved junction
box. A plug and receptacle is NOT permitted
on these products.
• Note to Installer—Be sure to leave these
instructions with the consumer.
• Note to Consumer—Keep these
instructions for future reference.
Materials Needed
Parts Included
(Appearance will vary.)
Wire Nuts
Strain Relief Clamp
for 1/2” conduit
Junction
Box
Screws for Installation
(8-18 x .750 flat head
Phillips wood screws)
68.6 cm (27″)
Metal Bottom Trim
91 cm (36”) of String
Tools Needed
76.2 cm (30″)
Metal Bottom Trim
Assembly
WB07T10578 – Black
WB07T10579 – SS
Optional 68.6 cm (27″)
Metal Bottom Trim Assembly
(on some models or can be
purchased separately)
1/8” (3 mm) Drill Bit and
Electric or Hand Drill
Phillips
Screwdriver
31-10666-3
11-07 JR
1
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
Pre-Installation Checklist
Door removal is not a requirement for
Remove packaging materials. Check
behind hinges and under false bottom.
Remove labels on the outside of the
door, plastic on trims and panel, all
tape around the oven and any shipping
screws securing the oven to the
base pad.
installation of the product, but is an
added convenience. To remove the door:
Open the oven door as far as it will go.
Hinge
Push both hinge
locks down toward
the door frame,
to the unlocked
position. This may
require a flat blade
screwdriver.
Unlocked
Position
Hinge
Slot
Hinge
Arm
DO NOT LIFT THE DOOR
BY THE HANDLE!
Oven Racks
Place hands on both sides of
the door, and close the oven
door to the removal position,
which is most of the way
closed.
EASY INSTALLATION OF YOUR NEW
30" WALL OVEN
Before you begin-Read these instructions completely and carefully.
IMPORTANT- Save these instructions for local inspector’s use.
IMPORTANT- OBSERVE ALL GOVERNING CODES AND ORDIANCES.
Note to Installer- Be sure to leave these instructions with the consumer.
OWNER- Keep these instructions for future reference.
Note- This appliance must be properly grounded (if applicable).
FOR YOUR SAFETY
ELECTRICAL REQUIREMENTS
Before you begin-Read these
instructions completely and
carefully.
Before you begin-Read these
instructions completely and
carefully.
IMPORTANT- Save these
IMPORTANT- Save these
Literature
Pack
instructions for local inspector’s use.
IMPORTANT- OBSERVE ALL
GOVERNING CODES AND ORDIANCES.
Note to Installer- Be sure to leave
these instructions with the consumer.
OWNER- Keep these instructions
for future reference.
instructions for local inspector’s use.
IMPORTANT- OBSERVE ALL
GOVERNING CODES AND ORDIANCES.
Note to Installer- Be sure to leave
these instructions with the consumer.
OWNER- Keep these instructions
for future reference.
Note- This appliance must be
properly grounded (if applicable).
Before you begin-Read these
instructions completely and
carefully.
Note- This appliance must be
properly grounded (if applicable).
Before you begin-Read these
instructions completely and
carefully.
IMPORTANT- Save these
IMPORTANT- Save these
instructions for local inspector’s use.
IMPORTANT- OBSERVE ALL
GOVERNING CODES AND ORDIANCES.
Note to Installer- Be sure to leave
these instructions with the consumer.
OWNER- Keep these instructions
for future reference.
instructions for local inspector’s use.
IMPORTANT- OBSERVE ALL
GOVERNING CODES AND ORDIANCES.
Note to Installer- Be sure to leave
these instructions with the consumer.
OWNER- Keep these instructions
for future reference.
Note- This appliance must be
properly grounded (if applicable).
Note- This appliance must be
properly grounded (if applicable).
Open oven door and remove
literature pack and oven racks.
Lift door up and
out until the
hinge arms
Remove Installation Instructions
from literature pack and read them
carefully before you begin.
clear the slots.
Be sure to place all literature,
Hinge Clears Slot
Owner’s Manual, Installations, etc.
in a safe place for future reference.
NOTE: The oven door is very heavy.
Be sure you have a firm grip before lifting
the oven door off the hinges. Use caution
once the door is removed. Do not lay the
door on its handle. This could cause dents
or scratches.
Place the oven on a table or platform even
with the cutout opening. (Platform must
support 68 Kg [150 lbs.].)
Remove the bottom trim from the top
of the oven. It will be installed at the end
of the installation process. The trim is
wrapped separately and taped to the
top of the unit
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
A
Cutout for 27″ (68.6 cm) Single Built-In
Ovens only
For JCKP30, JCKP70, JCKS10, PCK916, PCK920 models only.
12.7 cm
Cabinet Width
68.6 cm (27”)
(5”) Max.
from the left
or right
Cabinet
Width
68.6 cm
(27”)
Recommended
Cutout Location
from Floor
side
Junction Box
Location
82.6 cm (32 1/2”)
Cutout Depth
59.7 cm
Cutout Width
63.5 cm
(25”) Min.
64.1 cm
(23 1/2”) Min.
Cutout Width
63.5 cm
(25”) Min.
(25 1/4”) Max.
Allow 2.5 cm (1”)
for overlap of oven
over side edges of
cutout
64.1 cm
55.9 cm (22”) Min.
above base rail
(25 1/4”) Max.
Cutout
Height
5 cm x 10 cm
(2” x 4”)
or equivalent
runners level
with bottom
of cutout
70.2 cm (27 5/8”) Min.
71.4 cm (28 1/8”) Max.
Cutout Height
70.2 cm
(27 5/8”) Min.
71.4 cm
(28 1/8”) Max.
50.8 cm
(20”)
Alternate
Junction Box
Location –
access from
adjacent
cabinet may
be required
Recommended
cutout location
from floor 82.6 cm
(32 1/2”)
Allow 2.5 cm
(1”) minimum
for overlap of
oven top and
bottom of cutout
NOTE: If the cabinet does not
have a front frame and the sides
are less than 1.9 cm (3/4”) thick,
shim both sides equally to
Allow a minimum
of 50.8 cm (20”) for
clearance to adjacent
corners, drawers, walls,
etc. when door is open
establish the cutout width.
5 cm x 10 cm (2” x 4”) or
equivalent runners level
with bottom of cutout
If the cabinet does not have a solid bottom,
two braces or runners must be installed
level with the bottom of the cutout to
support the weight of the oven. For single
ovens, the runners and braces must
support 68 kg (150 lbs.).
61 cm
(24”)
NOTE: If marks, blemishes or the
cutout opening are visible above the
installed oven, it may be necessary to
add wood shims under the runners and
front trim until the marks or opening
are covered.
45.7 cm (18”)
68.6 cm (27”)
These ovens are not approved
for stackable installation.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
A
Cutout for 30″ (76.2 cm) Single Built-In
Ovens only
For JCTP30, JCTP70, PCT916, PCT920 models only.
Cutout Width
72.4 cm
(28 1/2”) Min.
72.7 cm
24.1 cm
(9 1/2”)
Max.
Cabinet Width
76.2 cm (30”)
Recommended
Cutout Location
from Floor
(28 5/8”) Max.
82.6 cm (32 1/2”)
Cutout Depth
59.7 cm
Allow 1.75 cm
(11/16”)
for overlap
of oven over
side edges of
cutout
Junction Box
Location
(23 1/2”) Min.
Cutout Width
72.4 cm
(28 1/2”) Min.
Opening
between
inside walls
must be at
least 72.4 cm
(28 1/2”) wide
Cutout
Height
69.2 cm
(27 1/4”) Min.
69.4 cm
72.7 cm
(28 5/8”) Max.
55.9 cm (22”)
to Bottom of
Junction Box
Cutout Height
69.2 cm
(27 1/4”) Min.
(27 5/16”) Max.
69.4 cm
(27 5/16”) Max.
53.3 cm
(21”)
Allow 2.5 cm (1”)
for overlap of
oven top and
Recommended
cutout location
from floor
NOTE: If the cabinet does not
have a front frame and the sides
are less than 1.9 cm (3/4”) thick,
shim both sides equally to
Allow a minimum
of 53.3 cm (21”)
for clearance to
adjacent corners,
drawers, walls, etc.
when door is open
3.2 cm (11⁄4”)
82.6 cm (32 1/2”)
bottom of cutout
establish the cutout width.
Cabinet
Width
76.2 cm (30”)
5 cm x 10 cm
C
L
(2” x 4”) or
equivalent
runners level
with bottom
of cutout
If the cabinet does not have a solid bottom,
two braces or runners must be installed
level with the bottom of the cutout to
support the weight of the oven. For single
ovens, the runners and braces must
support 68 kg (150 lbs.).
Suitable
Bracing
to Support
Runners
54.9 cm
NOTE: If marks, blemishes or the
cutout opening are visible above the
installed oven, it may be necessary to
add wood shims under the runners and
front trim until the marks or opening
are covered.
(21 5/8”)
Over Centerline
of Cabinet
These ovens are not approved
for stackable installation.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
A
Cutout for 27″ (68.6 cm) Single Built-In Ovens only
Under Counter
For JCKP30, JCKP70, JCKS10, PCK916, PCK920 models only.
Electric cooktops may be
installed over this oven. See
cooktop installation instructions
for cutout size. See label on top
of oven for approved cooktop
models.
240V / 208V
Junction Box
Location (junction
box may be in
adjacent cabinet)
Electrical connections for
cooktop must be located in
an adjacent accessible
location to the right.
63.5 cm (25”)
19.7 cm (7 3/4”)
Max.
Top and/or side fillers
may be necessary
if unit is positioned
between existing
cabinets. Be sure
they are attached
securely, since they
will anchor the oven
in the cabinet.
63.5 cm
(25”) Min.
Allow 2.5 cm
(1”) overlap
top of oven,
2.5 cm (1”)
overlap side
edges of cutout
and 2.5 cm (1”)
overlap bottom
of cutout
64.1 cm
55.9 cm (22”)
Min. Above
Support
91.4 cm (36”)
Typical
Countertop
Height
(25 1/4”) Max.
70.2 cm
(27 5/8”) Min.
71.4 cm
(28 1/8”) Max.
Platform
61 cm (24”)
10.2 cm (4”)
Typical
Toekick
1.9 cm (3/4”)
Support Platform
Required
Must
match
toekick
height
MUST SUPPORT 68 Kg (150 LBS.)
NOTE: This oven is only approved to
be installed under the specific models
as labeled on this unit.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
A
Cutout for 30″ (76.2 cm) Single Built-In Ovens only
Under Counter
For JCTP30, JCTP70, PCT916, PCT920 models only.
Gas or electric cooktops may be installed over this
oven. See cooktop installation instructions for cutout
size. See label on top of oven for approved cooktop
models.
240V / 208V
Junction Box
Location (junction
box may be in
adjacent cabinet)
Gas and electrical connections
for gas cooktop must be located
in an adjacent accessible location
to the right.
63.5 cm (25”)
24.1 cm
(9 1/2”)
Max.
Top and/or side fillers
may be necessary
if unit is positioned
between existing
cabinets. Be sure
they are attached
securely, since they
will anchor the oven
in the cabinet.
72.4 cm
(28 1/2”) Min.
72.7 cm
Allow 2.5 cm
(1”) overlap
top of oven,
1.8 cm (11/16”)
overlap side
edges of cutout
and 3.2 cm (1 1/4”)
overlap bottom
of cutout
55.9 cm (22”)
Min. Above
Support
91.4 cm (36”)
Typical
Countertop
Height
(28 5/8”) Max.
69.2 cm
(27 1/4”) Min.
69.4 cm
(27 5/16”) Max.
Platform
61 cm (24”)
10.2 cm (4”)
Typical
Toekick
1.9 cm (3/4”)
Support Platform
Required
Must
match
toekick
height
MUST SUPPORT 68 Kg (150 LBS.)
NOTE: This oven is only approved to
be installed under the specific models
as labeled on this unit.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
A
Cutout for 30″ (76.2 cm) Single Built-In
Ovens only – Over a Warming Drawer
For JCTP30, JCTP70, PCT916, PCT920 models only.
Anti-Tip Block Against
Rear Wall Per Warming
Drawer Requirement
2” (5.1 cm) Min.
Per Warming
Drawer
Requirement
NOTE: Install the
oven only with
specific models
listed on the label
located on top of
the oven.
1” (2.5 cm) Min. Above Toekick or
Adjust to Oven Installation Height
• When installing a Warming Drawer below
a single oven, a separate 120V, 60 Hz,
properly grounded receptacle must
NOTE: Additional clearances between cutouts
may be required. Check to be sure the oven
supports above the Warming Drawer location
do not obstruct the required interior depth and
height.
be installed. Refer to installation instructions
packed with the Warming Drawer for specific
installation requirements.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
B
Electrical Connections
Turn off the circuit breaker or remove fuses
ATTENTION INSTALLER
All electric wall ovens must be hard wired
(direct wired) into an approved junction
box. A plug and receptacle is NOT permitted
on these products.
B1
B2
to the oven branch circuit.
With the oven supported on a table or
platform in front of the cabinet opening,
connect the flexible conduit to the electrical
junction box as shown below. Position the
conduit in such a manner that it will lie on
top of the oven in a natural loop when the
oven is installed. You will need to purchase
an appropriate strain relief clamp to
DO NOT shorten the flexible conduit.
The conduit strain relief clamp must be
securely attached to the junction box
and the flexible conduit must be securely
attached to the clamp. If the flexible
conduit will not fit within the clamp, do not
install the oven until a clamp of the proper
size is obtained.
complete the connection of the conduit
to the junction box.
Junction Box
Location
GROUND
WIRE
Conduit
NOTE TO ELECTRICIAN: The 3 power
leads supplied with this appliance are
CSA recognized for connection to heavier
gauge household wiring. The insulation
of these 3 leads is rated at temperatures
much higher than the temperature rating
of household wiring. The current carrying
capacity of the conductor is governed
by the wire gauge and the temperature
rating of the insulation around the wire.
BARE
GROUND
RED
WHITE
BLACK
Strain Relief Clamp
(not included)
must be used at
Junction Box
Place oven on a
support to assist in
connecting conduit
WARNING: Improper
connection of aluminum house
wiring to copper leads can
result in an electrical hazard or fire.
Use only connectors designed for
joining copper to aluminum and follow
the manufacturer’s recommended
procedure closely.
This oven is supplied with a 123 cm (48”)
B3
B4
long flexible conduit consisting of:
3 insulated conductors (copper)
1 bare ground conductor (copper)
Attach conductors to residence wiring as
shown by wiring diagram.
CONDUIT
FROM
OVEN
WHITE
(NEUTRAL)
CSA APPROVED
CONNECTOR
RED
BLACK
1
BARE
COPPER
1
TO BREAKER PANEL
#12-#10 AWG-COPPER
NMD90 WIRE. FUSE 20
AMP CIRCUIT BREAKERS
WHITE
RED
BLACK
GROUND
CSA APPROVED
JUNCTION BOX AND COVER
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
C
Securing the Oven in the Opening
Sliding the Oven Into the
Opening
Drilling the Pilot Holes and
Mounting the Oven
C1
C2
a. Loop (do not tie) a 91 cm (36”) string
around the conduit before the oven is slid
into place. This will keep the conduit from
falling behind the oven.
NOTE: Before drilling the pilot holes,
make sure the oven is pushed as far
back into the opening as it will go
and is centered.
a. Drill through the mounting holes (top and
bottom) of the side trim, for the #8 screws
provided.
Pull out on
string loop
while pushing
the oven into
the cabinet
The screws must
Mounting
Hole
be a minimum
Locations
of 6 mm (1/4”)
(Hole
Locations
from the front of
may vary)
b. Lift oven into cabinet cutout using the oven
opening as a grip. Carefully push against
oven front frame. Do not push against
outside edges.
the cutout.
c. As you slide the oven back, pull the string
so that the conduit will lie on top of the
oven in a natural loop.
WARNING: Mounting
screws must be used. Failure to
do so could result in the oven
falling out of the cabinet, causing
serious injury.
d. When you are sure the conduit is out of the
way, slide the oven 3/4 way back into the
opening. Remove the string by pulling on
one end of the loop.
b. Secure the oven to cabinet with screws
provided.
NOTE: If the cabinet is particle board, you
must use #8 x 19 mm (3/4”) particle board
screws. These may be purchased at any
hardware store.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
Installing the Metal
Bottom Trim
Preparing for the Bottom
Trim Installation
C4
C3
a. Place the bottom metal trim centered over
the pre-drilled mounting holes. Tape the
edges of the trim down to maintain the
alignment.
a. With oven installed, take the bottom trim
and center it on the bottom front edge of
the cabinet opening.
For 27″ (68.6 cm)
b. Using the trim
models with Lower
as a template,
mark the center
of each slot
(two total) where
the mounting holes
will be drilled.
Trim in Position,
Mark (2) Mounting
Hole Locations
here
b. Using two trim screws provided, secure
the bottom trim to the bottom edge of the
cabinet.
Side
Trim
Trim Screw Locations for
27″ (68.6 cm) models with
Lower Trim
Side
*
For 30″ (76.2 cm)
models with
Lower Trim in
Position, Mark
(2) Mounting
Hole Locations
here
c. Remove the trim.
* Remove
Lower Trim
Before
Pre-drilling
Mounting
Holes
Trim
d. Drill pilot holes into
the center of each
template mark.
Metal Lower Trim
Trim Screw Locations for
30″ (76.2 cm) models with
Lower Trim
IMPORTANT: If this unit is ever
removed from the cabinet or the oven
is ever pulled out for service, the trim
must be removed first or damage to
the trim will occur.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
D
Replacing the Oven Door
Open the oven door as far as it
D3
NOTE: The oven door is heavy. You
may need help lifting the door high
enough to slide it into the hinge slots.
Do not lift the door by the handle.
will open.
Push the hinge locks up against the
front frame of the oven cavity, to the
locked position.
D4
Hinge in
Locked Position
Lift the oven door by
D1
placing one hand on
each side. The door is
heavy, so you may need
help. Do not lift the door
by the handle.
Notch of Hinge
Securely Fitted
into Bottom of
Hinge Slot
Close the oven door.
D5
With the door at the same angle as
the removal position, which is most of
the way closed, seat the notch of the
hinge arm into the bottom edge of the
hinge slot. The notch of the hinge arm
must be fully seated into the bottom of
D2
the slot.
Hinge Arm
Bottom Edge
of Slot
Hinge Notch
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
Pre-Test Checklist
Remove all protective film, if present,
and any stickers.
Check that the bottom trim is installed
properly (see page 10).
Check to be sure that all wiring is
secure and not pinched or in contact
with moving parts.
Check to be sure the mounting screws
are installed and flush with the side trim
(see page 9).
Operation Checklist
Remove all items from the inside
of the oven.
NOTE TO ELECTRICIAN: The power
leads supplied with this appliance
are CSA recognized for connections
to larger gauge household wiring.
The insulation of these leads is
rated at temperatures much higher
than the temperature rating of
household wiring. The current
carrying capacity of a conductor
is governed by the wire gauge and
also the temperature rating of the
insulation around the wire.
Check that conduit is securely
connected to the junction box.
Turn on the power to the oven. (Refer
to your Owner’s Manual.) Verify that
the bake and broil units, and all
cooking functions operate properly.
Check that the circuit breaker is not
tripped nor the house fuse blown.
NOTE: ALUMINUM WIRING
See your Owner’s Manual for
troubleshooting list.
A. WARNING: IMPROPER
CONNECTION OF ALUMINUM
HOUSE WIRING TO THE COPPER
LEADS CAN RESULT IN AN
ELECTRICAL HAZARD OR FIRE.
B. Splice copper wires to aluminum
wiring using special connectors
designed and CSA approved for
joining copper to aluminum,
and follow the manufacturer’s
recommended connector
procedure closely.
NOTE: Wire used, location and
enclosure of splices, etc., must
conform to good wiring practice
and local codes.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Notes
14
Download from Www.Somanuals.com. All Manuals Search And Download.
1 4
N o t e s
Download from Www.Somanuals.com. All Manuals Search And Download.
1 3
e n v i g u e u r l o c a l e m e n t .
d e l ’ a r t e t a u c o d e d e l ’ é l e c t r i c i t é
d o i v e n t s e c o n f o r m e r a u x r è g l e s
e t l ’ i s o l a t i o n d e s é p i s s u r e s , e t c . ,
N O T E : L e f i l u t i l i s é , l ’ e m p l a c e m e n t
r e c o m m a n d é e p a r l e f a b r i c a n t .
m i n u t i e u s e m e n t l a p r o c é d u r e
c u i v r e à l ’ a l u m i n i u m , e t s u i v e z
C S A , c o n ç u s p o u r r a c c o r d e r d u
c o n n e c t e u r s s p é c i a u x a p p r o u v é s
c â b l a g e d ’ a l u m i n i u m à l ’ a i d e d e
R a c B c . o r d e z l e s f i l s d e c u i v r e a u
É L E C T R I Q U E O U D ’ I N C E N D I E .
P E U T E N T R A Î N E R U N R I S Q U E
D E S F I L S D E S O R T I E E N C U I V R E
R É S I D E N T I E L
A L U M E N I N I U M À
v o t r e M a n u e l d ’ u t i l i s
C o n s z l e g u i d e d
I N A P P R O P R I É D ’ U N C Â B L A G E
V L A E E R R A C C O R D E M E N T
T I S S E M E N T :
A .
g r i l l é .
d é c l e n c h é o u l e f u s
V é r i f q u e l e d i s j o
C Â B L A G N E O T D E ’ A : L U M I N I U M
a u t o u r d u f i l .
t e m p é r a t u r e n o m i n a l e d e l ’ i s o l a n t
e t G r i l ( B r o i l ) .
d é t e r m i n é e p a r l e c a l i b r e d u f i l e t l a
s u p p o r t é e p a r u n c o n d u c t e u r e s t
L a c a p a c i t é d e t r a n s p o r t d u c o u r a n t
q u e c e l l e s d u c â b l a g e r é s i d e n t i e l .
d e c e s f i l s s o n t b e a u c o u p p l u s é l e v é e s
t e m p é r a t u r e s n o m i n a l e s d e l ’ i s o l a n t
r é s i d e n t i e l d e c a l i b r e s u p é r i e u r
p o u r u n b r a n c h e m e n t à d u c â b l a g e
a v e c c e t a p p a r e i l s o n t a p p r o u v é s C S A
L e s f i l s é l e c t r i q u e s d e s o r t i e f o u r n i s
y c o m p r i s l e s m o d e
c u i s s o n f o n c t i o n n e n
V é r i f i e z q u e t o u t e s l
v o t r e M a n u e l d ’ u t i l i s
M e t t f o u r e n m a
. L e s
à l a b o î t e d e j o n c t i o
V é r i f q u e l e c o n d
.
d u f o u r
E n l e t o u s l e s a r t
’ É L E C T R I C I E N ’ U : S A G E D N E O L T L
L i s t e d e
d e l a g a r n i t u r e l a t é r a l e ( v o i r l a p a g e 9 ) .
e n p l a c e e t n e d é p a s s e n t p a s l a s u r f a c e
V é r i f q u e l e s v i s d e m o n t a g e s o n t b i e n
a v e c d e s p i è c e s e n
e t q u ’ i l n ’ e s t p a s c o i
V é r i f q u e t o u t l e c
b i e n m o n t é e ( v o i r l a . p a g e 1 0 ) .
V é r i f q u e l a g a r n i t u r e i n f é r i e u r e e s t
e t l e s é t i q u e t t e s c o l l
S ’ i l y e u , e n l e v e z
L i s t e d e
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
1 2
c h a r n i è r e
b r a s d e
E n c o c h e d u
d e l a f e n t e
B o r d i n f é r i e u r
c h a r n i è r e
B r a s d e
i n s é r é e d a n s l e
’ e n c o c h e d o i t ê l a t r c e h b a i r e n n i è r e . L
d a n s l e b o r d i n
l ’ e n c o c h e d u b r
p r è s à l a p o s i t i o
d ’ e n l è v e m e n t ,
D 2
E a i n t e n a n t
D 5
F e z l a p o r t e d u f o u r
.
b a s d e l a f e n t e
l a p o r t e p a r l a p
d ’ a i d e . N e s o u l
p o u r r i e z a v o i r b
l o u r d e d e s o r t e
c h a q u e c ô t é . L
i n s é r é e d a n s l e
c h a r n i è r e b i e n
E n c o c h e d e l a
, s a i s i s s d e u z f - o l a u r d e
D 1
v e r r o u i l l a g e
p o s i t i o n d e
C h a r n i è r e e n
P s o u l e v e r l
.
d u f o u r
v e r s l e h a u t c o n t r e l e p a n n e a u f r o n t a l
s o u l e v e z p
g l i s s e r d a n
p o s i t i o n d e v e r r o u i l l a g e e n p o u s s a n t
P D z l 4 e s v e r r o u s d e l a c h a r n i è r e e n
p o u r l a s o u
I I s e p e u t q
L a p o r t e N d O u T f E o u : r e s
a n g l e D m 3 a x i m u m .
O z l a p o r t e d u f o u r j u s q u ’ à s o n
R e m i
D
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
1 1
a u t r e r a i s o n .
l ’ e n c e i n t e p o u r u n e r é p a r a t i o n o u u n e
p r e m i e r l o r s q u e l ’ a p p a r e i l e s t r e t i r é d e
e n d o m m a g é e s i e l l e n ’ e s t p a s e n l e v é e e n
A N T : L a I M g P a r O n R i t T u r e r i s q u e d ’ ê t r e
q u ’ i n d i q u é .
m o n t a g e ( 2 ) t e l
d e s t r o u s d e
m o u l u r e d u b a s
p o ) a v e c m ( 3 0 d e 7 6 , 2
m o n t a g e
l ’ e m p l a c e m e n t
t r o u s d e
m a r q u e z
m o u l u r e p o u r l e s m o d è l e s
E m p l a c e m e n t s d e s v i s d e
p e r c e r l e s
d u b a s e n p l a c e ,
a v a n t d e
a v e c l a m o u l u r e
d e c h a q u e m
m o n t a g e d a n
P e r d c . e z d e s t
i n f é r i e u r e
p o )
c m ( 3 7 0 6 , 2
m o d è l e s d e
G a r n i t u r e i n f é r i e u r e m é t a l l i q u e
g a r n i t u r e
E * n l e v e z l a
P o u r l e s
*
E n l c e . v e z l a g
l a t é r a l e
G a r n i t u r e
s e r o n t p e r c é
l e s t r o u s d e
à l ’ e n d r o i t o ù
( d e u x a u t o t a
d e c h a q u e t r
m a r q u e z l e c
c o m m e g a b a
d e l a g a r n i t u
E n b v . o u s s e r v
d u b a s
p o ) a v e c m m ( o 2 6 u 7 8 l u , 6 r e
m o u l u r e p o u r l e s m o d è l e s d e
E m p l a c e m e n t s d e s v i s d e
l a t é r a l e
G a r n i t u r e
( 2 ) t e l q u ’ i n d i q u é .
t r o u s d e m o n t a g e
l ’ e m p l a c e m e n t d e s
m a r q u e z
d e l ’ e n c e i n t e .
d u b a s e n p l a c e ,
a v e c l a m o u l u r e
f i x e z l a g a r n i t u r e i n f é r i e u r e a u b o r d i n f é r i e u r
À l ’ b a . i d e d e s d e u x v i s d e g a r n i t u r e f o u r n i e s ,
p o )
c m ( 2 7 d e 6 8 , 6
P o u r l e s m o d è l e s
p o u r e n c o n s e r v e r l ’ a l i g n e m e n t .
f r o n t a l d e l ’ o
i n f é r i e u r e e t
U n a e . f o i s l e f o
b o r d s d e l a g a r n i t u r e a v e c d u r u b a n a d h é s i f
l e s t r o u s d e m o n t a g e p r é - p e r f o r é s . F i x e z l e s
C e a n . t r e z l a g a r n i t u r e i n f é r i e u r e m é t a l l i q u e s u r
d e l a g a r n i
i n f é r i e u r e m é t a l l i q u e
C 3
C 4
P r é p a r a t i o n
I n s t a l l a t i o n d e l a g a r n i t u r e
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
1 0
n ’ i m p o r t e q u e l l e q u i n c a i l l e r i e .
m a t é r i a u . O n p e u t s ’ e n p r o c u r e r d a n s
# 8 x 1 9 m m ( 3 / 4 p o ) c o n ç u e s p o u r c e
d e p a r t i c u l e s , v o u s d e v e z u t i l i s e r d e s v i s
S i l ’ e n c e N i n O t e T e E s : t e n p a n n e a u x
f o u r n i e s .
F i x b e . z l e f o u r à l ’ e n c e i n t e à l ’ a i d e d e s v i s
.
u n e e x t r é m
a u x t r o i s - q u
, p o f u o s u s r e z c e d e
U n d e . f o i s l e
s é v è r e s .
i r e T z s u r
v o i e d e c o n s é q u e n c e , d e s b l e s s u r e s
o c c a s i o n n e r l a c h u t e d e f o u r e t , p a r
s e c o n f o r m e r à c e t t e d i r e c t i v e p e u t
ê t r e u t i l i s é e s . L e d é f a u t d e
.
u n e b o u c l e
t i r e z s u r l a
o T u t c e . n f a i s a n
V D A E e R s v T i s I S d e S m E o n M t a E g e N d o T i v e : n t
N e p o u s s e z
p r é c a u t i o n
l ’ o u v e r t u r e
p o u r l e s o u
A g b r i . p p e z l e
.
d e l ’ o u v e r t u r e .
p e u t v a r i e r )
( 1 / 4 p o ) d u d e v a n t
d e s t r o u s
d ’ a u m o i n s 6 m m ’ e m ( L p l a c e m e n t
m o n t a g e
ê t r e à e
d e s t r o u s d e
L e s v i s d o i v e n t
E m p l a c e m e n t
l ’ e n c e i n t e
l e f o u r d a n s
e n p o u s s a n t
r e c e v o i r l e s v i s # 8 f o u r n i e s .
f i c e l l e t o u t
i r T e z s u r l a
( h a u t e t b a s ) d e l a g a r n i t u r e l a t é r a l e , p o u r
P e a r c . e z à t r a v e r s l e s t r o u s d e m o n t a g e
e t d e l e c e n r a q u a t e m e n t .
f o u r j u s q u ’ à l ’ e n d r o i t o ù i l d o i t a l l e r
g u i d a g e , a s s u r e z - v o u s d e p o u s s e r l e
.
d u f o u r
a i n s i d e f a i r
f a i r e g l i s s e r
9 1 c m ( 3 6 p
v a A n t d e p N e r O c T e E r l : e s t r o u s d e
u n e f i c e l l e d e ( n e p a s n o u e F r a ) a i r . e p a s s e
g u i d a g e e t m o n t a g e d u f o u r
l ’ o u v e r t u r e
C 1
C 2
P e r ç a g e d e s t r o u s d e
M i s e e n p l a
F i x a t i
C
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
9
C S A A P R L A
J U N C T I O N B
C O U V E R C L E A P P R O U V É S
C S A A P P R O
B O Î T E D E J O N C T I O N E T
D I S J O N C T E U R S
F U S I B L E 2 0
,
A M P
W A G .
N M D 9 0 , # 1 2 – # 1 0
A M P C I R C U I T B R E A K E R S
F I L D E M I S E À L A T E R R E
G R O U N D
F I L D E C U I V R E
N M D 9 0 W I R E . F U S E 2 0
D E D I S J O N C T E U R S
B L A C K
N O I R
# 1 2 - # 1 0 A W G - C O P P E R
R E D
R O U G E
A N N E A U V E R S L E P
W H I T
B L A N C
O B R E A K E R P A N E L
4 A W G
C O P P E R
N U
A R E
C U I V R E
4
L A C K
N O I R
r e c o m m a n
m i n u t i e u s e
1 4 A W G
D
R O U G E
C O N N E C T O R
C S A A P R L A
( n e u t r e )
O V
C
( N )
A P C P S R A O A U V P É P R O V E D
C O N N E C T E U R
D U F O U R
P R O V E N A N C E
C O N D U I T E N
B L A N C
H I T E
d u c u i v r e à
c o n n e c t e u
d ’ i n c e n d i e
d e c â b l a g e .
d e l a m a i s o n , t e l q u ’ i l l u s t r é d a n s l e s c h é m a
e n t r a î n e r u
B 4
R r d e z l e s c o n d u c t e u r s a u c â b l a g e
à d e s f i l s d
c â b l a g e r é s i d e n t
d é n u d é ( e n c u i v r e )
1 c o n d u c t e u r d e m i s e à l a t e r r e
3 c o n d u c t e u r s i s o l é s ( e n c u i v r e )
V L A E e R r a T c c I o S r d S e m E e M n t
d e 1 2 3 c m ( 4 8 p o ) c o m p o r t a n t :
B 3
C r e s t d o t é d ’ u n c o n d u i t f l e x i b l e
l ’ i s o l a n t
d u f i l e t
c o n d u c t
d e j o n c t i o n
f a c i l i t e r l a c o n n e x i o n d u c o n d u i t
u n s u p p o r t p o u r
P l a c e r l e f o u r s u r
d e t r a n s
d o i t ê t r e u t i l i s é e à l a b o î t e
a n t i - t r a c t i o n ( n o n i n c l u
U n e b a g u e
c e l l e s d u
c e s 3 f i l e
N O I R
t e m p é r a
B L A N C
R O U G E
. L e s
s u p é r i e ( u G r a u g e ) d e c a l i b r
u n b r a n c
T E R R E N U
F I L D E
a p p a r e i l
é l e c t r i q u
’ É L E C T R A I C V I I E S N À L
: L e s 3 f i l s
d ’ i n s t a l l
b a g u e d
a j u s t é à
à l a b a g u
l e c o n d u
f i x é e f e r
L a b a g u
N E P A S
C o n d u i t
T E R R E
M I S E À L A
F I L D E
b o î t e d e j o n c t i o n
E m p l a c e m e n t d e l a j o n c t i o n .
t e r m i n e r l a c o n n e x i o n d u c o n d u i t à l a b o î t e d e
u n e b a g u e a n t i - t r a c t i o n a p p r o p r i é e p o u r
o u s d e v e z v o u s p r o c c u e r e d r e r n i e r i n s t a l l é . V
a u t o r i s é
e t u n e p
u n e b o î t
ê t r e r a c c
o T u s l e s f o
b o u c l e n o r m a l e s u r l e d e s s u s d u f o u r u n e f o i s
A S
c o n d u i t d e m a n i è r e à c e q u ’ i l f a s s e u n e
j o n c t i o n , t e l q u ’ i l l u s t r é c i - d e s s o u s . P l a c e z l e
c o n n e c t e z l e c o n d u i t f l e x i b l e à l a b o î t e d e
B 2
f o e n f a c e d e l ’ o u v e r t u r e d e l ’ e n c e i n t e ,
L e f o u r r e p o s a n t s u r u n e t a b l e o u u n e p l a t e -
T E U R A : L L A ’ I L N S T
A V I S
l e s f u s B i b l e 1 s d u c i r c u i t t e r m i n a l d u f o u r
.
A N T À
M l e d i s j o n c t e u r h o r s c i r c u i t o u e n l e v e z
R a c c o
B
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
8
l ’ i n s t a l l a t i o
l a p r o f o n d
p o u r l e s d i r e c t i v e s d ’ i n s t a l l a t i o n s p é c i f i q u e s .
d ’ i n s t a l l a t i o n e m b a l l é e s a v e c l e t i r o i r c h a u f
e n c a s t r é s i m p l e . R e p o r t e z - v o u s a u x d i r e c t i v e s
l ’ i n s t a l l a t i o n d ’ u n t i r o i r c h a u f
f e - p l a t
f e - p l a t n e r é d u i s e n t p a s
l ’ e m p l a c e
A s s u r e z - v
s u p p l é m e
I l e s t p o N s s O i b T l E e q : u
f e - p l a t s o u s u n f o u r
H z , c , o 6 V r 0 r e c 1 t e 2 m 0 e n t m i s e à l a t e r r e , p o u r
P r é • v o y e z u n e p r i s e é l e c t r i q u e d i s t i n c t e d e
o u a j u s t e z e n f o n c t i o n d e l a h a u t e u r d ’ i n s t a l l a t i o n d u f o u r
p o ) a u c - d m e s ( 1 s u s d u c o u p - d e - p i e d D é g a g e m e n t m i n . d e 2 , 5
.
l e d e s s u s d u f o u r
t i r o i r c h a u f f e - p l a t
p o u r c h a q u e
S p é c i f i c a t i o n s
l ’ é t i q u e t t e a p p o s é e s u r
m o d è l e s p r é c i s é s s u r
u n i q u e m e n t a v e c l e s
I n : s t a l l e z N l e O f T o u E r
p o ) c m 5 ( 2 , 1
D é g a g e m e n t m i n .
:
c h a q u e t i r o i r c h a u f f e - p l a t
a r r i è r e s p é c i f i c a t i o n s p o u r
i n s t a l l é c o n t r e l e m u r
M o d u l e a n t i b a s c u l e m e n t
P o u r l e s m o d
d ’ u n t i r
p o u r u
s i m p l e
–
s e u l e ( m 7 6 o e , 2 p n c m t 0 )
O u v e r t
A
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
7
a p p o s é e s u r c e t a p p a r e i l .
p a r t i c u l i e r s m e n t i o n n é s s u r l ’ é t i q u e t t e
p o u r u n e i n s t a l l a t i o n s o u s l e s m o d è l e s
: C e f o N u r O e T s E t a p p r o u v é u n i q u e m e n t
L B )
K G ( 1 5 0
D O I T P O U V O I R S U P P O R T E R
c o u p - d e - p i e d
à c e l l e d u
d o i t c o r r e s p o n d r e
L a h a u t e u r
r e q u i s e
P l a t e f o r m e d e s u p p o r t
1 , 9 c m ( 3 / 4 p o )
c o u p - d e - p i e d
s t a n d a r d d u
H a u t e u r
1 0 , 2 c m ( 4 p o )
d u f o u r
6 1 c m ( 2 4 p o )
a u - d e s s o u s
p o ) ( 1 1 / 4
c m
e t d e 3 , 2
l ’ o u v e r t u r e
l e s c ô t é s d e
m a x .
m i n .
( 2 7 5 / 1 6 p o )
6 9 , 4 c m
( 2 7 1 / 4 p o )
6 9 , 2 c m
p o ) s 1 u / r ( 1 1 6
, d e f 1 o , u 8 r
a u - d e s s u s d u
p o ) c m ( 1 d e 2 , 5
c h e v a u c h e m e n t
c u i s i n e
à l ’ a r m o i r e .
s e r v i r à f i x e r l e f o u
, c a r f o e u l l r e s v o n t
s u p p o r t
c m
d u c o m p t o i r d e
H a u t e u r s t a n d a r d
9 1 , 4 c m ( 3 6 p o )
p l a t e f o r m e d e
a u - d e s s u s d e l a
( 2 2 p o ) m 5 i 5 n , 9 . c m
s o l i d e m e n t f i x é e s
v o u s q u ’ e l l e s s o i e
e x i s t a n t e s . A s s u r e
e n t r e d e u x a r m o i r
s i l e f o u r e s t i n s t a
ê t r e n é c e s s a i r e s
l a t é r a l e s p e u v e n t
s u p é r i e u r e s e t / o u
D e s g a r n i t u r e s
m a x .
( 2 8 5 / 8 p o )
7 2 , 7 c m
( 2 8 1 / 2 p o )
7 2 , 4 c m
L a i s s e z u n
m i n .
m a x .
a d j a c e n t a c c e s s i b l e .
( 9 1 / 2 p o )
à d r o i t e d a n s u n e n d r o i t
2 4 , 1 c m
a u g a z d o i v e n t ê t r e s i t u é e s
6 3 , 5 c m ( 2 5 p o )
a u g a z p o u r l a t a b l e d e c u i s s o n
L e s c o n n e x i o n s é l e c t r i q u e s e t
l ’ a r m o i r e a d j a c e n t e )
j o n c t i o n p e u t ê t r e d a n s
d e j o n c t i o n ( b o î t e d e
E m p l a c e m e n t d e l a b o î t e
2 4 0 V / 2 0 8 V
m o d è l e s d e
o V i r l ’ é t i q u e t t e
l a t a b l e d e c
o i r . l V e s i n s t r u c t i o n s d ’ i n s a t u a - l d l a e t s i o s n u s d e d
U n e t a b l e d e
C J T P 3 0 , J C T P 7 0 , P C T 9 P 1 o 6 u , r P l C e T s 9 m 2 0 o s d e è u l
( 7 6 o , 2 p c m 0 )
s t n a i l l é
a u d e s s
O u v e r t u
A
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
6
a p p o s é e s u r c e t a p p a r e i l .
p a r t i c u l i e r s m e n t i o n n é s s u r l ’ é t i q u e t t e
p o u r u n e i n s t a l l a t i o n s o u s l e s m o d è l e s
: C e f o N u r O e T s E t a p p r o u v é u n i q u e m e n t
L B )
K G ( 1 5 0
D O I T P O U V O I R S U P P O R T E R
c o u p - d e - p i e d
à c e l l e d u
d o i t c o r r e s p o n d r e
L a h a u t e u r
r e q u i s e
P l a t e f o r m e d e s u p p o r t
1 , 9 c m ( 3 / 4 p o )
c o u p - d e - p i e d
s t a n d a r d d u
H a u t e u r
1 0 , 2 c m ( 4 p o )
d u f o u r
a u - d e s s o u s
p o ( ) 1
6 1 c m ( 2 4 p o )
c m
e t d e 2 , 5
l ’ o u v e r t u r e
l e s c ô t é s d e
p o ( ) 1 s u r
m a x .
m i n .
( 2 8 1 / 8 p o )
7 1 , 4 c m
( 2 7 5 / 8 p o )
7 0 , 2 c m
c u i s i n e
à l ’ a r m o i r e .
s e r v i r à f i x e r l e f o u
, c a r f o e u l l r e s v o n t
s u p p o r t
c m
, d e f 2 o , u 5 r
d u c o m p t o i r d e
H a u t e u r s t a n d a r d
9 1 , 4 c m ( 3 6 p o )
p l a t e f o r m e d e
a u - d e s s u s d u
p o ) c m ( 1 d e 2 , 5
a u - d e s s u s d e l a
( 2 2 p o ) m 5 i 5 n , 9 . c m
s o l i d e m e n t f i x é e s
v o u s q u ’ e l l e s s o i e
e x i s t a n t e s . A s s u r e
e n t r e d e u x a r m o i r
s i l e f o u r e s t i n s t a
ê t r e n é c e s s a i r e s
l a t é r a l e s p e u v e n t
s u p é r i e u r e s e t / o u
D e s g a r n i t u r e s
c h e v a u c h e m e n t
L a i s s e z u n
m a x .
( 2 5 1 / 4 p o )
6 4 , 1 c m
m i n . ( 2 5 p o )
6 3 , 5 c m
m a x .
a c c e s s i b l e .
1 9 , 7 c m ( 7 3 / 4 p o )
6 3 , 5 c m ( 2 5 p o )
d a n s u n e n d r o i t a d j a c e n t
d o i v e n t ê t r e s i t u é e s à d r o i t e
p o u r l a t a b l e d e c u i s s o n
L e s c o n n e x i o n s é l e c t r i q u e s
l ’ a r m o i r e a d j a c e n t e )
j o n c t i o n p e u t ê t r e d a n s
d e j o n c t i o n ( b o î t e d e
E m p l a c e m e n t d e l a b o î t e
2 4 0 V / 2 0 8 V
t a b l e d e c u i s s o n a p p r o u v é s
d u f o u r p o u r c o n n a î t r e l e s m
o i r l ’ é t i q u e t t e l s ’ o u u r v l e r d t u e r s e s . u V s
d e c u i s s o n p o u r c o n n a î t r e l
l e s i n s t r u c t i o n s d ’ i n s t a l l a t i o
ê t r e i n s t a l l é e a u - d e s s u s d e
U n e t a b l e d e c u i s s o n é l e c t r
o i r . V
C J K P 3 0 , J C K P 7 0 , J C K P S o 1 u 0 , r P l e C s K m 9 1 o 6 d , P è C l
( 6 8 o , 6 p c m 7 )
s t n a i l l é
a u d e s s
O u v e r t u
A
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
5
p o u r u n m o n t a g e s u p e r p o s é .
d e l ’ o u v e r t u
j u s q u ’ à c e q
s o u s l e s r a i
n é c e s s a i r e
v i s i b l e s a u -
m a r q u e s o u
N O T E : S i l a
C e s f o u r s n e s o n t p a s a p p r o u v é s
l a l i g n e d e c e n t r e d e l ’ e n c e i n t e
c e n t r é e s u r ( 2 1 5 / 8 p o )
d e 5 4 , 9 c m
, i l p e u t ê t r e
O V E R C E N T E R L I N E
D i s t a n c e
R
T
5 "
B
l e s r a i l s
S
d e s u p p o r t e r
a d é q u a t a f i n
E n t r e t o i s e m e n t
l e c a s d ’ u
r a i l s d o i v
s o u t e n i r
n i v e a u d
d e u x e n t
S i l ’ e n c e
. C e s e n t r e t o i s e s o u
e
i n f é r i e u r
d u b o r
d
a u n i v e a u
é q u i v a l e n t s
o R u U N r a N i E l s R S
( 3 0 p o )
7 6 , 2 c m
l ’ e n c e i n t e
L a r g e u r d e
E Q U I V A L E N T
( 2 p o x 4 p o )
t i r o i r s , m u r s , e t c . )
a d j a c e n t s ( c o i n s ,
a u x é l é m e n t s
L
C
2 " x 4 " o r
5 c m x 1 0 c m
p o r t e p a r r a p p o r t
l ’ o u v e r t u r e d e l a
( 2 1 p o ) p o u r
m o i n s 5 3 , 3 c m
d é g a g e m e n t d ’ a u
P r é v o i r u n
d é t e r m i n e r l a l a r g e u r d e l ’ o u v e r t u r e .
8 2 , 6 c m ( 3 2 1 / 2 p o )
l e b o r d i n f é r i e u r d e l ’ o u v e r t u r e
s u p é r i e u r e e t 3 , 2 c m ( 1
f o u r p a r - d e s s u s l e b o r d
é p a i s s e u r d e c h o
e t 4 r
p ⁄ 1 o )
e n t u r
( 3 / 4 p o ) , p l a c e z é
r e c e
p o u r l e c h e v a u c h e m e n t d u
P r é v o i r 2 , 5 c m ( 1 p o ) a u m o i n s
d e s c ô t é s f a i t m c
D i s
d ’ u n p a n n e a u f r o n t a l e t s i l ’ é u
N O T E : S i l ’ e n c e i n t e n ’ e s t p a s d o t é e
( 2 1 p o )
5 3 , 3 c m
( 2 7 5 / 1 6 p o ) m a x .
6 9 , 4 c m
( 2 7 1 / 4 p o ) m i n .
6 9 , 2 c m
( 2 8 5 / 8 p o ) m a x .
7 2 , 7 c m
( 2 8 1 / 2 p o ) m i n .
7 2 , 4 c m
m a x .
( 2 7 5 / 1 6 p o )
6 9 , 4 c
( 2 7 1 / m i n .
6 9 , 2 c m
l ’ o u v e r t u r e
H a u t e u r d e
m u r s i n t é r i e u r s
b o î t e d e j o n c t i o n
l ’ o u v e r t u r e
l a r g e u r e n t r e l e s
( 2 8 1 / 2 p o ) d e
m o i n s 7 2 , 4 c m
o u v e r t u r e d ’ a u
P r é v o i r u n e
j u s q u ’ a u b a s d e l a
5 5 , 9 c m ( 2 2 p o )
D i s t a n c e d e
H a u t e
l ’ o u v e r t u r e
l e s c ô t é s d e
d u f o u r p a r - d e s s u s
c h e v a u c h e m e n t
1 / 1 ( 1 6 p o ) p o u r l e
P r é v o i r 1 , 7 5 c m
l ’ o u v e r t u r e
L a r g e u r d e
l ’ o u v e r t u r e
P r o f o n d e u r d e
d e j o n c t i o n
d e l a b o î t e
( 2 3 1 / 2 p o ) m i n .
5 9 , 7 c m
E m p l a c e m e n t
8 2 , 6 c m ( 3 2 1 / 2 p o ) e t l e p l a n c h e r
e n t r e l ’ o u v e r t u r e
r e c o m m a n d é e
7 2 , 7 c m ( 2 8 5 / 8 p o ) m a x .
7 2 , 4 c m ( 2 8 1 / 2 p o ) m i n .
L a r g e u r d e l ’ o u v e r t u r e
m a x .
( 9 1 / 2 p o )
2 4 , 1 c m
D i s t a n c e
l ’ e n c e i n t e
L a r g e u r d e
7 6 , 2 c m ( 3 0 p o )
s e u l e ( m 7 6 o e , 2 p n c m t 0 )
P s o i u m r l e s p m l o e
O u v e r
A
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
4
p o u r u n m o n t a g e s u p e r p o s é .
l ’ o u v e r t u r e s
j u s q u ’ à c e q u
s o u s l e s r a i l s
n é c e s s a i r e d
v i s i b l e s a u - d
m a r q u e s o u
N O T E : S i l a
C e s f o u r s n e s o n t p a s a p p r o u v é s
2 7 " 6 8 , 6 c m ( 2 7
4 5 , 7 c m ( 1 8
p o )
p o )
, i l p e u t ê t r e
( 2 4 p o )
2 4 "
6 1 c m
l e c a s d ’ u n
r a i l s d o i v e
s o u t e n i r l e
n i v e a u d u
d e u x e n t r e
S i l ’ e n c e i n
. C e s e n t r e t o i s e s o u
R u n n e r s
n i v e a u d u b o r
e
d i n f é r i e u r
E q u i v a l e n t
o u r a i l s é q u i v a l e n t s a u
" x 4 " o r
5 c m x 1 0 c m ( 2 p o x 4 p o )
d é t e r m i n e r l a l a r g e u r d e l ’ o u v e r t u r e .
l ’ o u v e r t u r e
( c o i n s , t i r o i r s ,
a u x é l é m e n t s
d e l a p o r t e p a
( 2 0 p o ) p o u r l ’
d ’ a u m o i n s 5 0
P r é v o i r u n d é
é p a i s s e u r d e c h a q u e c ô t é p
e t s u p é r i e u r d e
l e s b o r d s i n f é r i e u r
d u f o u r p a r - d e s s u s
c h e v a u c h e m e n t
m o i n s p o u r l e
( 1 p o ) a u
r e q u i s
( 3 / 4 p o ) , p l a c e z d e s c a l e
p e u t ê t r e
a d j a c e n t e
( 3 2
p l a
l ’ o
r e c
d e s c ô t é s f a i t m o i n s
l ’ a r m o i r e
d ’ u n p a n n e a u f
p a r t i r d e
N O T E : S i l ’ e n c
u n a c c è s à
P r é v o i r 2 , 5 c m
D i s
j o n c t i o n –
l a b o î t e d e
s e c o n d a i r e d e
E m p l a c e m e n t
( 2 0 p o )
5 0 , 8 c m
) m a p x o .
) m i p n o .
) m a p x o .
( 2 8 1 / 8
7 1 , 4 c m
( 2 7 5 / 8
7 0 , 2 c m
( 2 5 1 / 4
6 4 , 1 c m
l ’ o u v e r t u r e
H a u t e
e
i n f é r i e u r
7 1 , 4 c m ( 2 8 1 / 8 p o ) m a x .
7 0 , 2 c m ( 2 7 5 / 8 p o ) m i n .
d e l ’ o u v e r t u r e
d
a u n i v e a u d u b o
r a i l s é q u i v a l e n t
( 2 p o x 4 p o ) o u
5 c m x 1 0 c m
H a u t e u r
A u - d e s s u s d e s r a i l s
5 5 , 9 c m ( 2 2 p o ) m i n .
c ô t é s d e l ’ o u v e
d u f o u r p a r - d e s
p o u r l e c h e v a u
P r é v o i r 2 , 5 c m
) m i p n o . ( 2 5
l ’ o u v e r t u r e
L a r g e u r d e
6 3 , 5 c m
( 2 3 1 / 2
5 9 , 7 c m
( 2 5 1 / 4 p o ) m a x .
6 3 , 5 c m
( 2 5 p o ) m i n .
6 4 , 1 c m
l ’ o u v e r t u r e
L a r g e u r d e
) m i p n o .
l ’ o u v e r t u r e
P r o f o n d e u r d e
)
p o
8 2 , 6 c m ( 3 2 1 / 2
e t l e p l a n c h e r
e n t r e l ’ o u v e r t u r
r e c o m m a n d é e
D i s t a n c e
( 2 7 p o )
6 8 , 6 c m
d e j o n c t i o n
d e l a b o î t e
E m p l a c e m e n t
l ’ e n c e i n t e
L a r g e u r d e
d r o i t
g a u c h e o u
l ’ e n c e i n t e
L a r g e u r d e
d u c ô t é
à p a r t i r
( 5 p o ) m a x .
1 2 , 7 c m
)
p o
6 8 , 6 c m ( 2 7
s e u l e ( m 6 8 o e , 6 p n c m t 7 )
P s o i u m r l e s p m l o e d
O u v e r t
A
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
3
r u b a n a d h é s i f .
e t f i x é e d a n s l e h a u t d u f o u r p a r d u
L a g a r n i t u r e e s t e m b a l l é e s é p a r é m e n t
E l l e s e r a p o s é e à l a f i n d u m o n t a g e .
t e m p o r a i r e m e n t d a n s l e h a u t d u f o u r
E n l e l a g a r n i t u r e i n f é r i e u r e f i x é e
.
[ 1 5 0 l i v r e s ] d a n s l e c a s d ’ u n f o u r s i m p l e ) .
( l a p l a t e - f o r m e d o i t p o u v o i r s u p p o r t e r 6 8 k g
q u i a é t é p r a t i q u é e p o u r r e c e v o i r l e f o u r
p l a t e - f o r m e d e n i v e a u a v e c l ’ o u v e r t u r e
P l a c e f o u r s u r u n e t a b l e o u u n e
.
p o i g n é e . C e l a p o u r r a i t l a r a y e r o u l a b o s s e l e r
N e l a i s s e z j a m a i s l a p o r t e r e p o s e r s u r s a
S o y e z v i g i l a n t u n e f o i s l a p o r t e e n l e v é e .
s o u l e v e r p o u r l a s é p a r e r d e s c h a r n i è r e s .
A s s u r e z - v o u s d e b i e n l a t e n i r a v a n t d e l a
c o n s u l t a t i o n u l t é r i e u
N O T E : L a p o r t e d u f o u r e s t t r è s l o u r d e .
d o c u m e n t a t i o n d a n s
A s s u r e z - v o u s d e r a
C h a r n i è r e s o r t i e d e l a f e n t e
.
a t t e n t i v e m e n t a v a n t
p o c h e t t e à d o c u m e n
R e t i r e s d i r e c t i v e
s o r t e n t d e s f e n t e s .
b r a s d e s c h a r n i è r e s
j u s q u ’ à c e q u e l e s
t i r a n t v e r s l ’ e x t é r i e u r
S o u z l a p o r t e e n
d o c u m e n t a t i o n a i n s
O u v r a p o r t e d u f
p r è s à l a p o s i t i o n f e r m é e .
q u i c o r r e s p o n d à p e u
p r o p e r l y g r o u n d e d ( i f a p p l i c a b l e ) .
N o t e - T h i s a p p l i a n c e m u s t b e
f o r f u t u r e r e f e r e n c e .
O W N E R - K e e p t h e s e i n s t r u c t i o n s
t h e s e i n s t r u c t i o n s w i t h t h e c o n s u m e r .
N o t e t o I n s t a l l e r - B e s u r e t o l e a v e
G O V E R N I N G C O D E S A N D O R D I A N C E S .
I M P O R T A N T - O B S E R V E A L L
i n s t r u c t i o n s f o r l o c a l i n s p e c t o r ’ s u s e .
I M P O R T A N T - S a v e t h e s e
p r o p e r l y g r o u n d e d ( i f a p p l i c a b l e ) .
N o t e - T h i s a p p l i a n c e m u s t b e
f o r f u t u r e r e f e r e n c e .
O W N E R - K e e p t h e s e i n s t r u c t i o n s
t h e s e i n s t r u c t i o n s w i t h t h e c o n s u m e r .
N o t e t o I n s t a l l e r - B e s u r e t o l e a v e
G O V E R N I N G C O D E S A N D O R D I A N C E S .
I M P O R T A N T - O B S E R V E A L L
i n s t r u c t i o n s f o r l o c a l i n s p e c t o r ’ s u s e .
I M P O R T A N T - S a v e t h e s e
c a r e f u l l y .
i n s t r u c t i o n s c o m p l e t e l y a n d
B e f o r e y o u b e g i n - R e a d t h e s e
c a r e f u l l y .
i n s t r u c t i o n s c o m p l e t e l y a n d
B e f o r e y o u b e g i n - R e a d t h e s e
d o c u m e n t a t i o n
p r o p e r l y g r o u n d e d ( i f a p p l i c a b l e ) .
p r o p e r l y g r o u n d e d ( i f a p p l i c a b l e ) .
N o t e - T h i s a p p l i a n c e m u s t b e
N o t e - T h i s a p p l i a n c e m u s t b e
f o r f u t u r e r e f e r e n c e .
p o s i t i o n d ’ e n l è v e m e n t ,
f o r f u t u r e r e f e r e n c e .
O W N E R - K e e p t h e s e i n s t r u c t i o n s
O W N E R - K e e p t h e s e i n s t r u c t i o n s
t h e s e i n s t r u c t i o n s w i t h t h e c o n s u m e r .
t h e s e i n s t r u c t i o n s w i t h t h e c o n s u m e r .
N o t e t o I n s t a l l e r - B e s u r e t o l e a v e
N o t e t o I n s t a l l e r - B e s u r e t o l e a v e
G O V E R N I N G C O D E S A N D O R D I A N C E S .
G O V E R N I N G C O D E S A N D O R D I A N C E S .
I M P O R T A N T - O B S E R V E A L L
I M P O R T A N T - O B S E R V E A L L
i n s t r u c t i o n s f o r l o c a l i n s p e c t o r ’ s u s e .
i n s t r u c t i o n s f o r l o c a l i n s p e c t o r ’ s u s e .
P o c h e t t e à
I M P O R T A N T - S a v e t h e s e
I M P O R T A N T - S a v e t h e s e
c a r e f u l l y .
i n s t r u c t i o n s c o m p l e t e l y a n d
B e f o r e y o u b e g i n - R e a d t h e s e
c a r e f u l l y .
i n s t r u c t i o n s c o m p l e t e l y a n d
B e f o r e y o u b e g i n - R e a d t h e s e
l a p o r t e d u f o u r j u s q u ’ à l a
c ô t é d e l a p o r t e e t r e f e r m e z
P l a c o s m a i n s d e c h a q u e
E L E C T R I C A L R E Q U I R E M E N T S
F O R Y O U R S A F E T Y
N o t e - T h i s a p p l i a n c e m u s t b e p r o p e r l y g r o u n d e d ( i f a p p l i c a b l e ) .
O W N E R - K e e p t h e s e i n s t r u c t i o n s f o r f u t u r e r e f e r e n c e .
N o t e t o I n s t a l l e r - B e s u r e t o l e a v e t h e s e i n s t r u c t i o n s w i t h t h e c o n s u m e r .
I M P O R T A N T - O B S E R V E A L L G O V E R N I N G C O D E S A N D O R D I A N C E S .
I M P O R T A N T - S a v e t h e s e i n s t r u c t i o n s f o r l o c a l i n s p e c t o r ’ s u s e .
B e f o r e y o u b e g i n - R e a d t h e s e i n s t r u c t i o n s c o m p l e t e l y a n d c a r e f u l l y .
3 0 " W A L L O V E N
E A S Y I N N E W
G r i l l e f o u r
P O I G N A É P R E S ! A
P O R T A E S L A
N E S O U L E V E Z P
à l a m e p l a t e .
A r m
H i n g
B r a s d e l a
u t i l i s e z u n t o u r n e v i s
l a p o r t e . S ’ i l l e f a u t ,
v e r s l e c h â s s i s d e
e n l e s a b a i s s a n t
d é v e r r o u i l l a g e
c h a r n i è r e
c h a r n i è r e
d e l a
S
F e n t e
H
p o s i t i o n d e
c h a r n i è r e s e n
A m e l e s d e u x
d é v e r r o u i l l a g e
o s P i t i o n
p o s i t i o n d e
U n l o c
f i x e n t l e f o u r s u r s a
C h a r n i è r e e n
n g
E n l e v e z a u s s i l e s v i
a i n s i q u e l e r u b a n c
p l a s t i q u e s u r l e s g a
f a c e e x t é r i e u r e d e l a
f a u x f o n d . E n l e v e z l
V é r i f i e z d e r r i è r e l e s
E n l e t o u s l e s m a
.
m a x i m u m .
O u v a p o r t e j u s q u ’ à s o n a n g l e
s o i t p a s o b l i g a t o i r e . P o u r e n l e v e r l a p o r t e :
p o u r f a c i l i t e r l ’ i n s t a l l a t i o n , b i e n q u e c e l a n e
I I e s t p o s s i b l e d ’ e n l e v e r l a p o r t e d u f o u r
L i s t e d e
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
2
5 0 a m p è k r e W s
k W 8 à , 4 1 0 , k 4 W
k W 9 à , 7 1 2 , 0
4 0 a m p è r k e W s
3 0 a m p è r k e W s
k W 6 à , 3 8 , 3 k W
k W 4 à , 3 6 , 2 k W
k W 7 à , 3 9 , 6
k W 4 à , 9 7 , 2
2 0 a m p è r e s k W 4 ≤ , 1
k W 4 ≤ , 8
l e c i r c u V i t ( d é d i é ) e n k W 2 0 8
r e c o m m a n d é p n o o u m r i n a l e
2 4 0 V
n o m i n a l e e n
P u i s s a n c e
C a l i b r e
P u i s s a n c e
a p p r o u v é s p o u r c e t y p e d e c â b l a g e .
c o n n e c t e u r s c o r r e c t e m e n t m o n t é s e t
a l u m i n i u m , v o u s d e v e z u t i l i s e r d e s
S i v o u s v o u s b r a n c h e z à d u c â b l a g e e n
2 0 8 Y / 1 2 0 v o l t s o u 2 4 0 / 1 2 0 v o l t s , 6 0 h e r t z .
r e c o m m a
p o u r d é t e
p r o d u i t . S
a f i n d e d
p l a q u e s
d i s j o n c t e
a d é q u a t e
a p p r o p r i é
u n c o u r a
C e t a p p a
c o u r a n t m o n o p h a s é ( c . a . ) , t r i f i l a i r e ,
e u i l l e z c o n s u l t e r l a
p r é s e n t a n t l e s c a r a c t é r i s t i q u e s s u i v a n t e s :
o u V s d e v e z u t i l i s e r u n c i r c u i t é l e c t r i q u e
C 2 2 . 2 N o . O - M 9 1 , o u l a d e r n i è r e é d i t i o n .
f u s i b l e s q u i r é p o n d e n t à l a n o r m e C A N / C S A
f o u r d o i t ê t r e m u n i d ’ u n b r a n c h e m e n t e t d e
l ’ a b s e n c e d ’ u n c o d e d e l ’ é l e c t r i c i t é l o c a l , v o t r e
e x p o s e z à u n e s i t u a t i o n d a n g e r e u s e . E n
c o n f o r m é m e n t a u c o d e e n v i g u e u r
A l i m
, v o u s v o u s
r é g i o n . S i v o u s n e b r a n c h e z p a s v o t r e f o u r
l e s i n s t a l l a t i o n s é l e c t r i q u e s d a n s v o t r e
d ’ é l e c t r i c i t é , l e c o d e d e l ’ é l e c t r i c i t é r é g i s s a n t
b l e s s u r e s s
à c e t t e p r o c
V é r i f i e z , a u p r è s d e v o t r e c o m p a g n i e
. L e d é f a u b t r a d n e c s h e e c r o n
é l e c t r i q u e d u f o u
.
d ’ i s o l e m e n t d e v o t r e f o u r
o V u s d e v e z c o u p e r
V A E R T I S S E M
m o n t r e r l ’ e m p l a c e m e n t d e l ’ i n t e r r u p t e u r
m o n t a g e , d e m a n d e z à l ’ é l e c t r i c i e n d e v o u s
v o t r e f o u r p a r u n é l e c t r i c i e n q u a l i f i é .
A p r è s l e
l e c â b l a g e é l e c t r i q u e e t l e b r a n c h e m e n t d e
.
F ° ] ) p r o d u C ° i t e [ 2 p 0 a 0 r l e f o u r a t t e i n d r e 9
N o u s v o u s r e c o m m a n d o n s d e f a i r e r é a l i s e r
p e u v e n t s u
e t l e s r e v ê
A s • s u r e z - v o
l a p o r t e d u
, d e s e t e n i r s , u d r e s ’ a s s e d o e i r g r i m p e r
d e s b l e s s u
s i g n a l é t i q u e
d e l a p l a q u e
E m p l a c e m e n t
f o u r p e u t f
o T u t e p r e s s i o
b i e n f i x é e
t o u t e s é c u
A s • s u r e z - v o
.
i n f é r i e u r
c a d r e l a t é r a l o u s u r l e d e v a n t d u c a d r e
g a r n i t u r e l a t é r a l e d u f o u r
L a p l a q u e s i g n a l é t i q u e e s t s i t u é e s u r l a
d e s e r v i c e
p a r u n i n s t
A s • s u r e z - v o
, s u r l e d e v a n t d u
( s u i t e )
A l i m e n t a t i o n
P o u
A N T E S
C O
D i r e c t i v e s
Download from Www.Somanuals.com. All Manuals Search And Download.
1
1 - 0 7 J 1 R
3 1 - 1 0 6 6
p e u t ê t r e a c
( 2 7 p o ) ( s u r
m é t a l l i q u e o
M o n t a g e d e
d e 3 m m ( 1 / 8 p o )
o u m a n u e l l e e t m è c h e
P e r c e u s e é l e c t r i q u e
c r u c i f o r m e
o T u r n e v i s à p o i n t e
A c i e r i n o x y d a b l e W B 0 7 T 1 0 5
W B 0 7 T 1 0 5
7 6 , 2 c m ( 3 0 p o )
m é t a l l i q u e d e
g a r n i t u r e i n f é r i e u r e
M o n t a g e d e
O u t i l s r e q u i s
F i c e l l e d e 9 1 c m ( 3 6 p o )
6 8 , 6 c m ( 2 7 p o )
m é t a l l i q u e d e
G a r n i t u r e i n f é r i e u r e
c r u c i f o r m e
( v i s à b o i s à
i s V p o u r l ’ i n s t a
1 / 2 p o
p o u r c o n d u i t d e
B a g u e a n t i - t r a c t i o n
j o n c t i o n
B o î t e d e
S e r r e - f i l s
. )
’ a s ( L p e c t d
P i è c
M a t é r i e l r e q u i s
a u t o r i s é e s p o u r b r a n c h e r c e s p r o d u i t s .
e t u n e p r i s e d e c o u r a n t n e s o n t P
A S
d i r e c t i v e s
N o • t e a u c o
u n b o î t i e r d e j o n c t i o n h o m o l o g u é . U n e f i c h e
ê t r e r a c c o r d é s ( r a c c o r d e m e n t d i r e c t ) d a n s
.
c h e z l e c o
A s s u r e z - v
N o • t e à l ’ i n
o T u s l e s f o u r s m u r a u x e n c a s t r é s d o i v e n t
T E U R A : L L A ’ I L N S T
A N T À
V A I S • I M P O R T
.
l e s c o d e s
I M • P O R
R e — s p e c t e A z t N o u T s
a d é q u a t e m e n t .
d i r e c t i v e s
N O • T E — C e t a p p a r e i l d o i t ê t r e m i s à l a t e r r e
C o — n s e r v e A z c N e s T I M • P O R
n e s e r a i t p a s c o u v e r t p a r l a g a r a n t i e .
r é s u l t e r a i t d ’ u n e i n s t a l l a t i o n i n c o r r e c t e
U n d y s f o n c t i o n n e m e n t d u p r o d u i t q u i
d e p r o c é d e r à u n e i n s t a l l a t i o n a p p r o p r i é e .
I I • e s t d e l a r e s p o n s a b i l i t é d e l ’ i n s t a l l a t e u r
s u i v a n t e s
L i s e z c o m
v a A n t d
. e l e c t r o m e n a g e r s g e . c a n o t r e s
S i v o u
J C T P 3 0 , J C T P 7 0 , P C T 9 1 6 , P C T 9 2 0
m o d è l e s d e 3 0 p o ( 7 6 , 2 c m )
d ’ i n
D i r e
J C K S 1 0 , J C K P 3 0 , J C K P 7 0 , P C K 9 1 6 , P C K 9 2 0
2 7 p o ( 6 8 , 6 c m m o ) d è l e s d e
F o u r m u r a l e n c a s t r é d e
Download from Www.Somanuals.com. All Manuals Search And Download.
|