Insulated
Banquet Cabinet
FL-2257
Rev. 4 (4/07)
Page 1 of 4
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Models: EB-150 Banquet Warming Cabinet
ELECTRICAL SPECIFICATIONS:
Model No.
Volts
Watts
Amps
Hertz
Phase
NEMA
EB-150
120
1500
12.5
60
1
5-15P
5-20P
6-15P
6-15P
*EB-150-CAN
EB-150-208
EB-150-240
120
208
240
1500
1500
1500
12.5
7.3
60
60
60
1
1
1
6.3
Models are designed for AC Service.
*For Canadian use.
HOW TO INSTALL UNIT:
TO TURN OFF UNIT:
1. Remove all packing material from inside the
cabinet and clean cabinet thoroughly.
2. Install all channels and shelves before the unit is
put into operation.
Push the POWER switch to “OFF”.
The yellow light will go out.
3. Plug the power cord into the proper wall outlet.
HOW TO START UNIT:
1. Turn the POWER switch “ON”. The yellow light
will turn on.
2. Turn the thermostat to no. 10.
3. Preheat (assuming a “cold” cabinet of 75°F/25°C):
To 150°F/65°C takes about 30 mins.
To 175°F/79°C takes about 45 mins.
To 190°F/88°C takes about 1 hour.
4. Put food into the cabinet.
5. Turn the thermostat to the required temperature.
Switch
w/Light
Thermometer
Thermostat
NOTE: No. 8 is about 180°F/82°C
No. 6 is about 155°F/69°C
Proper food holding temperature is 140°F / 60°C or
higher.
Download from Www.Somanuals.com. All Manuals Search And Download.
Insulated
Banquet Cabinet
FL-2257
Rev. 4 (4/07)
Page 3 of 4
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Models: EB-150 Banquet Warming Cabinet
TROUBLE-SHOOTING CHART:
FAILURE:
1. Yellow light at switch does NOT light.
POSSIBLE CAUSE:
1a. Circuit breaker/fuse to wall outlet is blown
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF.”
2. Unit does not heat.
2a. Thermostat set too low or is “OFF.”
2b. Switch is “OFF.”
3. Unit gets too hot or won’t shut off.
3a. Defective electrical parts.
UNPLUG UNIT FROM WALL OUTLET
4. Blower does not work or makes noise.
5. Excess moisture in cabinet.
4a. Defective blower
5a. Open vent
5b. “Slack out” foods from oven or fryer for 5 minutes
before putting in hot cabinet.
If cause is none of the above, refer to our list of Authorized Service Centers, FL-1400
REPLACEMENT PARTS:
DESCRIPTION
Power Unit
120 VOLT
1254-047
208 VOLT
1254-048
240 VOLT
1254-049
Blower Kit
0769-005-K
0811-244
0769-006-K1
0811-245
0769-006-K1
0811-246
Heater Kit
Thermostat Kit
Thermometer Kit
Power Cord
0848-062-K
5238-030-K
0810-029-02
0808-113-K
0848-062-K
5238-030-K
0810-039-03
0808-113-01-K
0848-062-K
5238-030-K
0810-039-03
0808-113-01-K
Power Switch
CABINET PARTS:
Door Latch
1006-143-K
1006-151-K
0519-084
Door Strike
Door Hinge
Door Gasket Kit
Door Assembly Complete
Wire Grid
0861-243
1221-529
1170-205
Push Handle
1072-117-K
EB-150-CAN: (120V for Canada)
Power Unit
1254-050
Power Cord
0810-029-03
Download from Www.Somanuals.com. All Manuals Search And Download.
Insulated
Banquet Cabinet
FL-2257
Rev. 4 (4/07)
Page 4 of 4
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Models: EB-150 Banquet Warming Cabinet
Download from Www.Somanuals.com. All Manuals Search And Download.
|