TM
Butane/Propane Stove
Instructions for use
© 2005 The Coleman Company, Inc.
3001 Series
ANSI Z21.72b - CSA 11.2b (2002)
Camp Stove
®
IMPORTANT
Read this manual carefully before assembling, using or servicing these stoves. Keep
this manual for future reference. If you have questions about assembly, operation,
servicing or repair of these stoves, please call Coleman at 1-800-835-3278 or TDD:
316-832-8707. In Canada call 1-800-387-6161.
The Coleman Company, Inc. • 3600 N. Hydraulic • Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 316-832-8707
© 2005 The Coleman Company, Inc. All rights reserved. Coleman®,
and PEAK 1® are registered trademarks and
is a trademark of The Coleman Company, Inc.
3001-050 (11/14/05)
ME
f.d07.1829
Download from Www.Somanuals.com. All Manuals Search And Do
E
w
n
A
loRe
a
WARNING
WARNING
• This product is fueled by LPG. LPG is invisible,
odorless, and flammable. An odorant is
normally added to help detect leaks and can
be described as a ”rotten egg” smell. The
odorant can fade over time so leaking gas is
not always detectable by smell alone.
• BURN HAZARD
• Never leave stove unattended when hot
or in use.
• Keep out of reach of children.
• LPG is heavier than air and leaking LPG will
sink to the lowest level possible. It can ignite by
ignition sources including matches, lighters,
sparks or open flames of any kind many feet
away from the original leak. Use only LPG set
up for vapor withdrawal.
DANGER
• LPG should be stored or used in compliance with
local ordinances and codes or with ANSI/NFPA
58. Turn off LPG when not in use.
• CARBON MONOXIDE HAZARD
• This stove is a combustion appliance. All
combustion appliances produce carbon
monoxide (CO) during the combustion
process. This product is designed to produce
extremely minute, non-hazardous amounts of
CO if used and maintained in accordance with
all warnings and instructions. Do not block air
flow into or out of the stove.
• Carbon Monoxide (CO) poisoning produces
flu-like symptoms, watery eyes, headaches,
dizziness, fatigue and possibly death. You
can’t see it and you can’t smell it. It’s an
invisible killer. If these symptoms are present
during operation of this product get fresh
air immediately!
DANGER
• EXPLOSION - FIRE HAZARD
• Never store LPG (liquefied petroleum gas) near
high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where
temperatures exceed 120 degrees F (49°C).
• LPG is heavier than air and can accumulate in
low places. If you smell gas, leave the
area immediately.
• Never install or remove LPG cylinder while
outdoor stove is lighted, near flame, pilot lights,
other ignition sources or while outdoor stove is
hot to touch.
• During lighting and operation, this product can
be a source of ignition. Never use the stove in
spaces that contain or may contain volatile or
airborne combustibles, or products such as
gasoline, solvents, paint thinner, dust particles
or unknown chemicals. Minimum clearances
from combustible materials: 24 inches from the
sides and 48 inches from the top.
• For outdoor use only.
• Never use inside house, camper, tent,
vehicle or other unventilated or enclosed
areas. This stove consumes air (oxygen).
Do not use in unventilated or enclosed
areas to avoid endangering your life.
CAUTION
• SERVICE SAFETY
• Provide adequate clearances around air
openings into the combustion chamber.
• Use only LPG set up for vapor withdrawal.
• Keep all connections and fittings clean.
Always inspect gas cartridge, stove
connections and “O” ring seal for damage, dirt
and debris before attaching cartridge (Fig. 1).
Replace if damaged or worn. Never use stove
with damaged or worn seals.
WARNING
Not for home or recreational vehicle use.
• During set up, CHECK FOR LEAKS in one or
more ways: Apply soapy water to connections.
Bubbles indicate a leak. Listen for hiss of
escaping gas. Feel for extreme cold. Smell for
rotten egg odor. Never use a flame. Check
that the connection is not cross-threaded and
that it is tight. Perform another leak check. If
there is still a leak, remove the cylinder and
contact Coleman for service or repairs.
• Use as a cooking appliance only. Never alter
in any way or use with any device or part not
expressly approved by Coleman.
We cannot foresee every use which may be
made of our products.
Check with your local fire safety authority if
you have questions about use.
Other standards govern the use of fuel gases
and heat producing products for specific uses.
Your local authorities can advise you
about these.
• Never refill disposable cylinders.
• Use only Coleman® accessories or parts.
During stove set-up, check all fittings for
leaks using soapy water. Never use a flame.
• Never use as a space heater.
• Clean stove frequently to avoid grease
accumulation and possible grease fires.
English-2
Download from Www.Somanuals.com. All Manuals Search And Download.
■ Screw LPG cylinder into stove. Take care not to
cross thread. HAND TIGHTEN only. (Fig. 3)
“O” Ring
Fig. 1
Technical
Characteristics
Input: 10,000 BTU/H
Category: Unregulated LPG
Fuel: 7 3/4 oz. disposable
butane/propane mix cylinders
To Set Up
Fig. 3
DANGER
■ Set pan supports to desired position. (Fig. 4, 5,
and 6)
• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper, tent, vehicle
or other unventilated or enclosed areas. This
stove consumes air (oxygen). Do not use in
unventilated or enclosed areas to avoid
endangering your life.
■ NOTE: Use Coleman® 7 3/4 oz. disposable
butane/propane mix cylinder only. Do not connect
to bulk LPG systems. The LP-gas cylinder(s)
used with stoves must be constructed and
marked in accordance with the specifications for
LP-gas cylinders of the U.S. Department of
Transportation or Transport Canada, CAN/CSA
B339.
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean.
Inspect LPG cylinder and stove LPG connec-
tions for damage before attaching.
• During set up, check all connections and
fittings for leaks using soapy water. Bubbles
indicate a leak. Never use a flame.
Fig. 4
■ Take stove outdoors away from ignition sources.
■ Turn fuel valve off. (Fig. 2)
Fig. 2
Fig. 5
English-3
Download from Www.Somanuals.com. All Manuals Search And Download.
Match Light:
■ Set on sturdy, flat surface. For outdoor use only.
■ Hold lighted match at burner and open FUEL
VALVE. (Fig. 7)
Fig. 6
Leak Check
Fig. 7
WARNING
■ Adjust flame to desired heat with FUEL VALVE.
(Fig. 8)
■ Flame should be blue with hint of yellow on tips.
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until connection
has been leak tested and does not leak.
• CHECK FOR LEAKS in one or more ways:
Apply soapy water to connections. Look for
bubbles. Listen for hiss of escaping gas. Feel for
extreme cold. Smell for rotten egg odor. Never
use a flame. Do not use if leaking.
To Light
DANGER
Fig. 8
To Turn Off
• EXPLOSION - FIRE HAZARD
• LPG is heavier than air and can accumulate in
low places. If you smell gas, leave the
area immediately.
■ Turn FUEL VALVE “off”. (Fig. 9)
• Always attach or detach LPG source
outdoors; never while stove is lighted, near
flame, pilot lights, other ignition sources or
while stove is hot to touch.
• This stove is very hot during use and can
ignite flammables too close to the burners.
Keep flammables at least 24 inches from the
sides and 48 inches from the top of the stove.
Keep gasoline and other flammable liquids
and vapors well away from stove.
• The stove must not be exposed to flammable
vapors or liquids during lighting.
WARNING
• BURN HAZARD
• Never leave stove unattended when hot
or in use.
Fig. 9
• Keep out of reach of children.
English-4
Download from Www.Somanuals.com. All Manuals Search And Download.
To Clean
To Store
DANGER
■ Make sure stove is cool.
■ Move stove away from flame (including pilot
lights) and other ignition sources.
■ Remove LPG cylinder from stove. (Fig. 10)
• EXPLOSION - FIRE HAZARD
• Never store LPG near high heat, open flames,
pilot lights, direct sunlight, other ignition
sources or where temperatures exceed 120
degrees F (49°C).
• The cylinder must be disconnected when the
stove is in storage.
Things You Should Know
1. It is unsafe and illegal in some places to store or
use LPG cylinders of greater than 1.14 kg (2.5
lbs) water capacity (approximately 1 lb. LPG) in
occupied enclosures.
2. The usual storage areas for camping and picnic
equipment are the basement, attic, or garage.
To avoid the accumulation of dust, cobwebs,
etc., that is common in these areas, place your
stove in a plastic bag and seal it with a rubber
band.
3. If your stove burns with a yellow smokey flame,
pull to remove the burner, and check the burner
and air tube for spider webs (Fig. 11).
Fig. 10
4. For repair service call one of the numbers listed below
for location of your nearest Coleman Service Center.
If stove must be mailed to Service Center, attach to
the product a tag that includes your name, address,
daytime telephone number and a description of
problem. Do NOT send LPG cylinder. Carefully
package the product and send either by courier or
insured mail with shipping and insurance prepaid to:
• MAINTENANCE DURING EACH USE
• Keep stove area clear and free from
combustible materials, gasoline and other
flammable vapors and liquids.
• Do not obstruct the flow of combustion and
ventilation air.
• A good flame should be blue with minimal
yellow tip. Some yellow tips on flames are
acceptable as long as no carbon or soot
deposits appear.
• Wipe clean with soft cloth and mild dish
detergent. Do not use abrasives.
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic • Wichita, KS 67219
1-800-835-3278 • TDD: 316-832-8707
5. If not completely satisfied with the performance
of this product, please call one of the numbers
listed above.
Check for spiderwebs
Fig. 11
English-5
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty
Limited Five Year Warranty
The Coleman Company, Inc. (“Coleman”) warrants that for a
period of five years from the date of original retail purchase,
this product will be free from defects in material and
workmanship. Coleman, at its option, will repair or replace this
product or any component of the product found to be defective
during the warranty period. Replacement will be made with a
new or remanufactured product or component. If the product is
no longer available, replacement may be made with a similar
product of equal or greater value. This is your exclusive
warranty.
This warranty is valid for the original retail purchaser from
the date of initial retail purchase and is not transferable. Keep
the original sales receipt. Proof of purchase is required to
obtain warranty performance. Coleman dealers, service
centers, or retail stores selling Coleman® products do not have
the right to alter, modify or in any way change the terms and
conditions of this warranty.
What This Warranty Does Not Cover
This warranty does not cover normal wear of parts, parts that
are not genuine Coleman® parts, or damage resulting from
any of the following: negligent use or misuse of the product;
use on improper voltage or current; commercial use of the
product; use contrary to the operating instructions;
disassembly, repair or alteration by anyone other than Coleman
or an authorized service center. Further, the warranty does not
cover Acts of God, such as fire, flood, hurricanes and
tornadoes. Warranty void if damage to product results from the
use of a part other than a genuine Coleman® part.
COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT
ARE CAUSED BY THE USE OF UNAUTHORIZED PARTS OR
SERVICE. COLEMAN SHALL NOT BE LIABLE FOR ANY
INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY
THE BREACH OF ANY EXPRESS OR IMPLIED WARRANTY
OR CONDITIONS. EXCEPT TO THE EXTENT PROHIBITED
BY APPLICABLE LAW, ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE IS LIMITED IN DURATION TO THE DURATION OF
THE ABOVE WARRANTY OR CONDITIONS. SOME STATES,
PROVINCES, OR JURISDICTIONS DO NOT ALLOW THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW
LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS,
AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY
FROM STATE TO STATE OR PROVINCE TO PROVINCE.
How to Obtain Warranty Service
Take the product to an authorized Coleman service center.
You can find the nearest authorized Coleman service center by
316-832-8707 in the United States. If a service center is not
conveniently located, attach to the product a tag that includes
your name, address, daytime telephone number and
description of the problem. Include a copy of the original sales
receipt. Carefully package the product and send either by
courier or insured mail with shipping and insurance
prepaid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
The costs of transporting the product to Coleman or an
authorized service center for warranty service is the
responsibility of the purchaser.
Do not mail products with fuel in tanks, or with disposable
LPG cylinders. Remove glass globes from lanterns and wrap
separately.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF
PURCHASE.
If you have any questions regarding this warranty please call
1-800-835-3278 or TDD 316-832-8707 in the United States.
English-6
Download from Www.Somanuals.com. All Manuals Search And Download.
Notes:
English-7
Download from Www.Somanuals.com. All Manuals Search And Download.
|