Propane Catalytic
Heater
INSTRUCTIONS FOR USE
U.S. Patent 6,213,761
© 2005 The Coleman Company, Inc.
IMPORTANT
Model 5035
Propane Series
Read this manual carefully before assembling,
using or servicing this heater. Keep this manual for
future reference. If you have questions about
assembly, operation, servicing or repair of this
heater, please call Coleman at 1-800-835-3278
or TDD: 316-832-8707. In Canada call
1-800-387-6161.
CAN1-11.3-M79 Camp Heater
Download from Www.Somanuals.com. All Manuals Search And Download.
CALIFORNIA PROPOSITION 65:
General Safety Information
cont.
WARNING
WARNING: This fuel, and byproducts of
combustion of this fuel, contain chemicals known
to the state of California to cause cancer, birth
defects, or other reproductive harm.
We cannot foresee every use which may be made
of our products. Check with your local fire
safety authority if you have questions about
use.
DANGER
Failure to comply with the precautions and
instructions provided with this heater can result in
death, serious bodily injury and property loss or
damage from hazards of fire, explosion, burn
and/or asphyxiation.
Other standards govern the use of fuel gases and
heat producing products for specific uses.Your local
authorities can advise you about these.
WARNING
Only persons who can understand and follow the
instructions should use or service this heater.
• Never refill disposable cylinders.
• Use the preset regulator that came with the
catalytic heater. Do not attempt to adjust.
• BURN HAZARD
• Never leave catalytic heater unattended when
hot or in use.
DANGER
• Keep out of reach of children.
• EXPLOSION - FIRE HAZARD
CAUTION
• Never store propane near high heat, open flames,
WARNING
• SERVICE SAFETY
pilot lights, direct sunlight, other ignition sources or
where temperatures exceed 120 degrees F (49°C).
• Propane is heavier than air and can accumulate in low
places. If you smell gas, leave the area immediately.
• Never install or remove propane tank while catalytic
heater is lighted, near flame, pilot lights, other ignition
sources or while catalytic heater is hot to touch.
• During operation, this product can be a source of
ignition. Never use the catalytic heater in spaces that
contain or may contain volatile or airborne combustibles,
or products such as gasoline, solvents, paint thinner,
dust particles or unknown chemicals. Minimum
clearances from combustible materials: 24 inches.
• Provide adequate clearances around air openings
into the combustion chamber.
• Keep all connections and fittings clean. Inspect
propane cylinder and catalytic heater propane
connections for damage before attaching.
• During set up, check all connections and fittings
for leaks using soapy water. Never use a flame.
Bubbles indicate a leak. Check that the connection
is not cross-threaded and that it is tight. Perform
another leak check. If there is still a leak, remove
the cylinder and contact Coleman for service or
repairs.
• This product is fueled by propane gas. Propane
gas is invisible, odorless, and flammable. An
odorant is normally added to help detect leaks
and can be described as a “rotten egg” smell.
The odorant can fade over time so leaking gas is
not always detectable by smell alone.
• Propane gas is heavier than air and leaking
propane will sink to the lowest level possible. It
can ignite by ignition sources including matches,
lighters, sparks or open flames of any kind many
feet away from the original leak. Use only
propane gas set up for vapor withdrawal.
• Propane gas should be stored or used in
compliance with local ordinances and codes or with
ANSI/NFPA 58. Turn off propane when not in use.
• Use as a heating appliance only. Never alter in any
way or use with any device or part not specifically
designed and sold for this product.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
To Set Up
To Light
NOTE: Use 16.4 oz disposable propane cylinders
only. Do not connect to bulk propane systems. The
LP-gas cylinder(s) used with catalytic heaters must be
constructed and marked in accordance with the
specifications for LP-gas cylinders of the U.S.
Department of Transportation or Transport Canada,
CAN/CSA B339.
■ Turn HEATER VALVE
to OFF.
■ Firmly place cylinder
into support.
DANGER
■ Features identified are Burner, Heater Valve, Base,
and Ignition Button (Electronic Ignition only).
Propane tank is not included.
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can accumulate in low
places. If you smell gas, leave the area immediately.
• Always attach or detach propane source outdoors;
never while heater is lighted, near flame, pilot lights,
other ignition sources or while heater is hot to touch.
• This heater is red hot during use and can ignite
flammables too close to the burner. Keep flammables at
least 24 inches from the sides and 24 inches from the
top of the heater. Keep gasoline and other flammable
liquids and vapors well away from heater.
■ Attach CYLINDER to
HEATER outdoors.
Burner
■ Position HEATER as
shown on flat surface.
Ignition
Button
Heater
Valve
Support
■ Rotate four Support
Legs into operating
position.
WARNING
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean. Inspect propane
cylinder and heater propane connections for damage
before attaching.
• During set up, check all connections and fittings for leaks
using soapy water. Bubbles indicate a leak. Never use a flame.
• BURN HAZARD
Never leave heater unattended when hot or in use.
Keep out of reach of children.
•
•
4
Download from Www.Somanuals.com. All Manuals Search And Download.
■ NOTE: Observe heat
build up for a few minutes
to ensure heater is lit. If
heater fails to develop
substantial heat, turn
heater “OFF” and repeat
lighting procedure.
To Light
cont
To Store
cont
■ Make sure Heater is cool.
■ Take unit outdoors away from
any ignition sources. Remove
Cylinder from Heater.
■ Replace plastic cap on
cylinder.
■ Store propane cylinder
consistent with the instructions
and warnings on the cylinder.
Electronic Ignition
■ Hold heater with both
hands at a 45° angle,
pointing away from
yourself and others.
■ Turn valve to ON
position and repeatedly
push red ignition button
until heater ignites.
■ Heater will ignite with a
brief visible flame after
10-12 seconds.
■ Place Heater on a flat
surface.
To Turn Off
■ Turn FUEL VALVE to
OFF.
Things You Should Know
■ Allow HEATER to cool
for 10-15 minutes.
■ Heater is not adjustable.
1. This is a catalytic heater. Burning occurs within
the pad at a lower temperature than a normal
flame due to evenly distributed platinum. But, heat
guard and burner rim still get hot enough to burn
you. Be careful.
2. The catalytic process takes approximately 10
minutes to reach full heat output.
3. Do not use heater for cooking or warming items,
this can destroy combustion and catalyst. This
heater has a low burn temperature (no flame) but it
can still burn clothing, sleeping bags, etc., that
might fall on the burner surface.
Match Light
To Store
■ Hold match as shown.
■ Turn valve to ON
position.
■ Heater will ignite with a
brief visible flame after 10-
12 seconds.
4. To avoid damage to the catalyst, do not allow
head pad to come in contact with or around
silicone based hand creams, paints, etc.
5. Do not touch the gray ceramic fiber head pad or
poke a hole into it.
DANGER
■ Heater is not adjustable.
6. Do not attempt cleaning the head assembly.
• EXPLOSION - FIRE HAZARD
•
Never store propane near high heat, open flames,
pilot lights, direct sunlight, other ignition sources or
where temperatures exceed 120 degrees F (49°C).
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Things You Should Know
cont.
Replacement Parts List
No. Part No.
Description
7. For repair service call one of the numbers listed
below for location of your nearest Coleman Service
Center. If heater must be mailed to Service Center,
attach your name, address, and a description of
problem to product and and send to Service
Center either by UPS or Parcel Post insured with
shipping and insurance prepaid. Do not mail
propane cylinders. If necessary to write the
Service Center or factory, refer to your heater by
model number.
1
2
5035-5401
5035-1491
Support
Control Knob & screw
8. If not completely satisfied with performance of
this product, please call one of the numbers listed
below.
9. As with any new heating appliance, a small
amount of smoke may be seen during the initial
operation as a result of residual manufacturing oils
being heated. This is normal. Coleman suggests
the owner operate the heater for 30 minutes when
first purchased. This will also familiarize the owner
with all the features of the heater.
2
The Coleman Company, Inc.
3600 N. Hydraulic
Wichita, KS 67219 U.S.A.
1-800-835-3278
TDD: 316-832-8707
1
Sunbeam Corporation (Canada) Limited
5975 Falbourne Street
Mississauga, Ontario
Canada L5R 3V8
1 800 387-6161
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty
EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM
STATE TO STATE OR PROVINCE TO PROVINCE.
Limited Five Year Warranty
The Coleman Company, Inc. (“Coleman”) warrants that for a period of five years from the
date of original retail purchase, this product will be free from defects in material and
workmanship. Coleman, at its option, will repair or replace this product or any component of
the product found to be defective during the warranty period. Replacement will be made with
a new or remanufactured product or component. If the product is no longer available,
replacement may be made with a similar product of equal or greater value. This is your
exclusive warranty.
This warranty is valid for the original retail purchaser from the date of initial retail purchase
and is not transferable. Keep the original sales receipt. Proof of purchase is required to
obtain warranty performance. Coleman dealers, service centers, or retail stores selling
Coleman® products do not have the right to alter, modify or in any way change the terms
and conditions of this warranty.
How to Obtain Warranty Service
Take the product to an authorized Coleman service center.You can find the nearest
3278 or TDD 316-832-8707 in the United States or 1 800 387-6161 in Canada. If a service
center is not conveniently located, attach to the product a tag that includes your name,
address, daytime telephone number and description of the problem. Include a copy of the
original sales receipt. Carefully package the product and send either by UPS or Parcel Post
insured with shipping and insurance prepaid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
What This Warranty Does Not Cover
This warranty does not cover normal wear of parts, parts that are not genuine Coleman®
parts, or damage resulting from any of the following: negligent use or misuse of the product;
use on improper voltage or current; commercial use of the product; use contrary to the
operating instructions; disassembly, repair or alteration by anyone other than Coleman or an
authorized service center. Further, the warranty does not cover Acts of God, such as fire,
flood, hurricanes and tornadoes. Warranty void if damage to product results from the use of
a part other than a genuine Coleman® part.
Wichita, KS 67219
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
5975 Falbourne Street
Mississauga, Ontario
Canada L5R 3V8
COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT ARE CAUSED BY THE
USE OF UNAUTHORIZED PARTS OR SERVICE. COLEMAN SHALL NOT BE LIABLE
FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE BREACH
OF ANY EXPRESS OR IMPLIED WARRANTY OR CONDITIONS. EXCEPT TO THE
EXTENT PROHIBITED BY APPLICABLE LAW, ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN
DURATION TO THE DURATION OF THE ABOVE WARRANTY OR CONDITIONS. SOME
STATES, PROVINCES, OR JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR
LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES OR LIMITATIONS ON
HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE LIMITATIONS OR
The costs of transporting the product to Coleman or an authorized service center for
warranty service is the responsibility of the purchaser.
Do not mail products with fuel in tanks, or with disposable propane cylinders. Remove
glass globes from lanterns and wrap separately.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF PURCHASE.
If you have any questions regarding this warranty please call 1-800-835-3278 or TDD 316-
832-8707 in the United States or 1 800 387-6161 in Canada.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Notes:
8
Download from Www.Somanuals.com. All Manuals Search And Download.
|