HRVCCLHA, HRVCCSVU, HRVCCLVU
HRVCCSVB, HRVCCSHB
Heat Recovery Ventilator
Owner’s Manual
HRVCCSVU Compact Unit
HRVCCLHA Conventional Unit
HRVCCLVU High Efficiency Unit
HRVCCSVB Unit (Top Port
HRVCCSHB Unit (Side Port)
A09702
Fig. 1 -- Heat Recovery Ventilators
NOTE TO EQUIPMENT OWNER:
For your convenience, please record the model and serial numbers of your new equipment in the spaces
provided. This information, along with the installation data and dealer contact information will be helpful
should your system require maintenance or service.
HEAT RECOVERY VENTILATOR
INSTALLATION INFORMATION:
Model # _____________________________________
Serial # ______________________________________
Date Installed ________________________________
DEALERSHIP CONTACT INFORMATION:
Company Name_______________________________
Address______________________________________
_____________________________________________
Phone Number _______________________________
Technician Name _____________________________
_____________________________________________
ACCESSORIES (List type and model #)
_____________________________________________
_____________________________________________
_____________________________________________
_____________________________________________
NOTE TO INSTALLER:
This manual must be left with the equipment owner.
Download from Www.Somanuals.com. All Manuals Search And Download.
5. Examine the condensate drain pan to ensure drains are func-
tioning properly. Gently clean tray with mild soapy water.
(See Fig. 3 and 4).
!
CAUTION
CUT HAZARD
BEFORE YOU REQUEST A SERVICE
CALL
Failure to follow this caution may result in personal injury.
Although special care has been taken to minimize sharp edges
in the construction of your unit, be extremely careful when
handling parts or reaching into the unit. Wear appropriate
protective clothing and gloves when working on this unit.
S Check the main power disconnect switch. Verify that the circuit
breakers are ON or that fuses have not blown. If you must reset
breakers or replace fuses, do so only once. Contact your servicing
dealer for assistance if the breakers trip or the fuses blow a second
time.
PERFORMING ROUTINE MAINTENANCE
1. The motors are factory lubricated. Lubricating the bearings
is not recommended.
2. The heat recovery coremust be handled with care. To ensure
maximum efficiency of the plastic partitions wash core once
a year following the season of most intense use.
S Check for sufficient airflow. Check air filters for accumulations of
large particles. Check for blocked exhaust--air grilles or ductwork.
Keep grilles and duct work open and unobstructed.
S If the condensate fails to drain properly, check the grommet and
drain tube for obstructions. Make sure that the condensate drain
tube has a slight slope and is not kinked.
Allowthe heat recovery core to soak for 3 hours in a
solution ofwarmwater and mild soap. Rinse under a stream
ofwarm water. Hot water and strong detergent should NOT
be used,as it will damage the heat recovery core.
Ifyour HRVstill failsto operateproperly, contactyour servicingdeal-
er. Give him your model and serialnumber. Withthis information,the
dealer will be able to correct any problems.
3. A dirty air filter will cause excessive strain on the blower
motor. The filters in your HRV are washable and should be
cleaned every 3months.Use a vacuumcleaner to remove the
heaviest portion of accumulated dust, then wash in warm
water.
Table 1 – Recommended Humidity Levels
OUTSIDE
TEMPERATURE
50°F / 10°C
D O U B L E --- PA N E
T R I P L E --- PA N E
WINDOWS
65%
The Air Exchange Indicator light on the auto control will
indicate when filters should be cleaned. The light will flash
on and off until the door is opened to service the unit.
WINDOWS
55%
32°F / 0°C
45%
55%
4. Regularly check the screen on the exterior intake hood and
clean as necessary.
14°F / --- 1 0 °C
--- 4 °F / --- 2 0 °C
--- 2 2 °F / --- 3 0 °C
35%
30%
25%
45%
45%
35%
FRESH AIR
TO BUILDING
FRESH AIR
FROM OUTSIDE
STALE AIR
FROM BUILDING
STALE AIR
TO OUTSIDE
A92382
Fig. 3 -- Vertical Application
3
Download from Www.Somanuals.com. All Manuals Search And Download.
DOOR IS
DETACHABLE
ENERGY RECOVERY
CORE CAN BE REMOVED
BY PULLING STRAIGHT OUT
FILTERS ARE
REMOVABLE BY
PULLING STRAIGHT
OUT
BRIEF CASE
TYPE LATCH
A99300
Fig. 4 -- Horizontal Application
C a t a l o g N o : O M H R V --- 0 3 C A
Copyright 2010 Carrier Corp. S 7310 W. Morris St. S Indianapolis, IN 46231
Printed in U.S.A.
Edition Date: 01/10
Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations.
Replaces: OMHRV---2
4
Download from Www.Somanuals.com. All Manuals Search And Download.
|