FW282 integrated under
counter freezer
Manual for Installation, Use and Maintenance
Customer Care Department • The
Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
Download from Www.Somanuals.com. All Manuals Search And Download.
Important
Never store inflammable or explosive items and strong corrosive acids or alkalis in the appliance.
This is a household appliance, which is produced in accordance with the national standard. It is intended for food storage only,
not for storage of blood, medicine and biological products.
To prevent risk of fire, keep the appliance away from petrol or any other inflammables.
To prevent risk of electromagnetic interference or other accidents, do not place a microwave oven on top of the refrigerator
or use any electric appliance inside the refrigerator.
Do not allow children to play with or near the appliance.
The internal surface of freezer compartment is very cold when the appliance is running. Do not touch the surface especially
with wet hands.
Do not splash water onto the appliance. Keep it away from places of high humidity that may have adverse effect on the
electric insulation performance.
Please remove the door, door seal and shelves before disposal of the old appliance and put them away in a safe place to
prevent children from being entrapped.
Before first use
You must allow the freezer to settle for at least twenty four hours prior to switching the power on.
It is recommended that you clean the interior of the appliance prior to first use, using a solution of bicarbonate of soda and
warm water and then thoroughly drying the interior.
The freezer may have an odour to it at first use. This will disappear as the appliance cools.
Please note:
The appliance will work continuously until it comes down to the correct temperature.
If the appliance is switched off, you should allow five minutes before switching it on again to prevent unnecessary damage
to the compressor.
Download from Www.Somanuals.com. All Manuals Search And Download.
Use
Freezer
•
•
•
The freezer compartments are designed to store only frozen food.
Never put hot or warm foods in the freezer, allow them to cool fully before putting them into the freezer.
Follow the instructions on the food packaging for storage of frozen food. If no information is provided, foods
should not be stored for more than three months after the purchase date.
•
Store food in small packages (ideally less than 2.5kg). This reduces the freezing time and improves the quality of the
food after thawing.
•
•
•
Wrap food before putting into the freezer. To stop the wrapping sticking together, ensure it is dry.
Label the food before freezing with information including type of food and dates of storage and expiry.
Once food is thawed, it must not be refrozen unless it has been completely cooked. Only defrost as much food as is
required to prevent wastage.
•
•
Bottled or canned drinks should not be stored in the freezer compartment as they could explode.
Only open the door for as long as is necessary. Leaving the door open for long periods will affect the temperature
inside the appliance and waste energy.
•
Ensure all compartments are fully closed after use.
Download from Www.Somanuals.com. All Manuals Search And Download.
Control panel
A
B
C
!
2
1
D
3
0
SF
4
5
fig. 1
A. Orange Compressor light
This light is illuminated when the compressor is running (for example, when Super Freeze is switched on)
B. Green Power light
This light is illuminated when the power supply to the appliance is on.
C. Red Over Temperature Light
This light is illuminated when the interior temperature is too warm.
D. Thermostat dial
The thermostat can be set between 0 (least cold) and 5 (coldest)
Super Freeze function
Your freezer is equipped with a super freeze function, which runs the compressor continuously. Super freeze should be used
when introducing large amounts of fresh food into the freezer.
To switch the super freeze function on, turn the thermostat dial fully clockwise to SF. When the super freeze function is no
longer required, turn the thermostat dial back to the required setting.
Download from Www.Somanuals.com. All Manuals Search And Download.
Defrosting the freezer
Do not use heaters or defrosting sprays in this appliance.
• Never use any metallic or sharp objects to remove the ice as this could damage the lining.
• The freezer compartment should be defrosted regularly to ensure the most efficient running of the freezer.
• Once the ice is more than 5mm thick, the freezer should be defrosted.
• First remove the freezer drawers.
• To speed up the process, place a bowl of warm water in the base of the freezer compartment.
Once defrosting is complete, dry the inside of the freezer compartment with a sponge or clean cloth.
The freezer should be cleaned using a solution of bicarbonate of soda and lukewarm water. Do not use abrasive products or
detergents. After washing, rinse and dry thoroughly.
Clean the drawers separately by hand with soap and water. Do not put them in the dishwasher.
Once cleaning is complete, then reconnect the power.
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting
If you have any problems with your appliance, you should check the troubleshooting prior to calling CDA Customer Care to
prevent unnecessary service calls and potential cost.
If the appliance is not working
•
•
•
•
•
Check there is power to the appliance:
The house fuses are intact and the fuse in the plug has not blown.
The thermostat is not set to 0 (off position).
The plug socket is functioning fine. To check this, plug another electrical appliance in to see if the socket is working.
The temperature of the room is adequate (10oC or above).
The appliance is working, but not very well
•
•
•
•
•
•
The appliance is not overloaded.
The thermostat is set to an appropriate temperature.
The door is closing properly.
The cooling system at the rear of the appliance is clean and free of dust, and not touching the rear wall.
There is enough ventilation at the side and rear walls.
The temperature of the room is adequate (10oC or above).
The appliance is noisy
•
•
•
The appliance is level and stable.
The side and rear walls are clear, and there is nothing resting on the appliance.
The cooling gas in the refrigerator will make a slight bubbling noise, even when the compressor is not running.
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
This appliance must never be installed close to heat sources i.e. heating elements, radiators, cookers or in
damp places
The appliance should be mounted on a piece of wood (for example a section of worktop or kitchen carcass) if
a raised floor is to be fitted, if the kitchen floor is to be tiled after installation, or if the installation height of
the appliance is greater than 850 mm.
Contents and Tools Required
Fig. 1 - Installation kit contents
2
1
1. Wood screw (17 pcs)
3
2. Decor door fixing bracket
4
3. Decor door base fixings (2 pcs)
6
5
4. Decorative cover
5. Screw
KIT
6. Top bracket
fig. 1
Fig. 2 - Tools required
7. Spirit level
7
8
8. Spanner
9. Setsquare
10. Flathead screwdriver
10
10
9
9
fig. 2
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 3 - Dimensions of the appliance
600
min
550
548
595
820-
890
819-
889
100- 170
min 25
fig. 3
Fig. 4 - Fitting the worktop bracket
5
Remove the screw (5) on the top of the appliance, locate the
top bracket(6) and fix the bracket with screw(5).
6
fig. 4
Fig. 5 - Fitting the spacer piece
Take out the spacer piece (11) located on the side panel and
remove the protective tape. Stick the spacer piece on the
opposite side to the door hinges of the appliance.
11
11
11
fig. 5
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 6 - Adjusting the appliance height
The height of the appliance can be adjusted by the help of
adjustable feet to fit the furniture height. Use a spirit level to
ensure the appliance is level.
7
7
8
fig. 6
Fig. 7 - Aligning the appliance
Slide the appliance into the kitchen unit and align the hinge
surface with front surface of the kitchen unit.
9
9
fig. 7
Fig. 8 - Fixing the appliance
1
Screw the hinges and metal bracket to the kitchen unit using
screws (1)
1
fig. 8
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 9 - Fitting the decor door bracket
C
Unscrew and remove the nuts and washers from the appliance
door. Place fixing bracket on the appliance door by inserting
the holes to adjustment bolts.
B
Dimension B= Measure from the underside surface of kitchen
unit to the bottom of fixing bracket.
fig. 9
Dimension C= Measure from the underside surface of kitchen
unit to the top of next unit door.
Fig. 10 - Fitting the decor door bracket
Substract C from B and put the fixing bracket (2) in place using
this measurement for vertical position and place to the centre
for horizontal position. Secure the fixing bracket (2) using
screws(1).
1
B-C
2
fig. 10
Fig. 11 - Fitting the decor door
Place the decor door onto the appliance door by inserting
adjustment bolts into the slots on the fixing bracket. Locate the
washers and screw the nuts onto the adjustment bolts.
fig. 11
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 12 - Aligning the decor door
Close the door and check the alignment with the other unit
doors. Adjust the decor door by screwing or unscrewing the
adjustment bolts for vertical adjustment and by the help of the
slots on the fixing bracket for other directions. Lock the screws
into place as shown in 10.2.
10
10
8
fig. 12
Fig. 13 - Fitting the decor door base fixings
With the appliance door open, remove the screws at the
bottom of the appliance door. Locate the decor door base
fixings (3) and screw the fixings to the appliance door and the
decor door.
3
1
fig. 13
Fig. 14 - Fitting the decorative cover
Fit the decorative cover (4) on the decor door fixing bracket.
4
fig. 14
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Fig. 17 - Fitting the plinth
Fit the plinth section, providing minimum 25 mm gap between
the cabinet door and fix it.
Never cover over the ventilation slots.
Once installed the plinth must not block the
ventilation slots in the appliance.
This may require cutting the plinth down. Failure
to ensure adequate ventilation may invalidate
the warranty.
25mm
min
fig. 17
Download from Www.Somanuals.com. All Manuals Search And Download.
Reversing the door
It is possible to reverse the door on this appliance, if
required. To do so, follow the steps below:
1. Open the door.
2. Loosen the hinge fixing screws (1) and remove the door.
3. Remove the door fixing screws (2).
4. Remove the cover caps (3).
5. Relocate the hinges as shown.
6. Refit the door to the hinges.
Do not turn the door upside down
7. Insert the cover caps (3) on the opposite side in the exposed
holes.
fig. 18
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical information
Warning! This appliance must be earthed.
The mains lead of this appliance has been fitted with a BS 1363A 13 amp fused plug. To change a fuse in this type of plug, follow
the steps below:
1. Remove the fuse cover and fuse.
2. Fit replacement 13A fuse, ASTA approved to BS 1362 type, into the fuse cover.
3. Replace fuse cover.
Important: Do not use the appliance without the fuse cover in position.
How to connect an alternative plug
If the fitted plug is not suitable for your socket outlet, then it should be cut off and disposed of safely to prevent the risk of electric
shock. A suitable alternative plug of at least 13 Amp rating to BS 1363 should be used.
As the colours of the wires in the mains lead of this appliance may not correspond with the
coloured markings identifying the terminals in your plug, proceed as follows:-
•
•
•
The wire which is coloured GREEN and YELLOW must be connected to the terminal which is marked with letter (E) or
by the Earth symbol or coloured GREEN and YELLOW.
The wire which is coloured BLUE must be connected to the terminal which is marked with the letter (N), or
coloured BLACK.
The wire which is coloured BROWN must be connected to the terminal which is marked with the letter (L) or
coloured RED.
If in doubt regarding the electrical connection of this appliance, consult a qualified electrician. Do not shorten the
supply cable, the appliance may require removing for servicing.
N.B. Ensure that the plug socket is situated in an easily accessible place.
Download from Www.Somanuals.com. All Manuals Search And Download.
To contact our Customer Care Department, or for Service,
please contact us on the details below.
Customer Care Department • The
Group Ltd. • Harby Road • Langar • Nottinghamshire • NG13 9HY
Download from Www.Somanuals.com. All Manuals Search And Download.
|