INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 1
WARNING
WARNING
TO PREVENT DAMAGE TO
EYESIGHT, NEVER LOOK INTO
SPOTLIGHT WHEN LIGHT IS ON. DO
NOT SHINE LIGHT INTO THE FACE
OF SOMEONE ELSE.
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS
MANUAL TO AVOID PERSONAL
INJURY OR PROPERTY DAMAGE.
OWNER’S MANUAL &
OPERATING INSTRUCTIONS
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 3
OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
Step 1: To activate spotlight, plug the cigarette lighter adapter
into a cigarette lighter receptacle.
Step 2: Depress trigger switch in handle to turn spotlight ON.
Release trigger switch to turn spotlight OFF.
WARNING: Never place spotlight lens face down when light is
on or if it was recently on. Doing so could
burn/ignite surfaces such as seats, carpeting, etc.
and cause serious property damage. Always turn
spotlight off and unplug from power source when
not in use.
Step 3: To lock trigger switch to ON, depress trigger switch and
slide locking button on side of handle to LOCK. To
unlock and turn spotlight OFF, slide locking button up to
UNLOCK.
Locking
ON/OFF
Button
NOTE: The locking button can also be used to lock spotlight in
the OFF position to prevent accidental activation.
Only use a Brinkmann halogen bulb that is designed for the
1 Million CP Spotlight as a replacement. Use of any other bulb
may result in poor performance and may damage your spotlight.
To Replace Bulb
Screws
IMPORTANT: Do not touch the glass part of bulb with fingers as
natural oils affect the life and performance of bulb.
Handle bulb by metal end only.
Step 1: Disconnect spotlight from power source.
Step 2: Pull out rubber cap. Remove screws from right housing.
(see Figure 1).
Step 3: Holding the left housing securely, slowly lift the right
housing off being careful not to pull wire connections
inside. Do not touch the inside of reflector.
FIGURE 1
2
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 4
NOTE: The glass lens is not attached to
either housing. Use care when
disassembling to avoid breaking
lens.
Connector
FIGURE 2
Step 4: Disconnect bulb wire from connector by holding the
connector firmly with fingers then pulling bulb wire
straight out as shown in Figure 2.
Step 5: Squeeze the wire retainer together and lift up as
illustrated in Figure 3.
Step 6: Pull bulb straight out from the reflector mounting plate.
Step 7: To install new bulb, grasp the bulb from the metal end
(DO NOT TOUCH THE GLASS PART) and insert into the
reflector mounting plate. Align the slots in the bulb base
with those in the reflector mounting plate.
FIGURE 3
Step 8: Replace wire retainer by squeezing ends together while
pressing down. Release ends so that they catch on the
reflector mounting plate.
Connector
Step 9: Reconnect the bulb wire to the connector as illustrated
in Figure 4.
Step 10: To reassemble, place the left housing down on a flat
surface. Set the reflector into the left housing. Insert the
right housing onto the left housing of the spotlight.
Step 11: Replace screws that were removed in Step 2. Do not
overtighten screws.
Replacement bulbs and accessories may be purchased from
The Brinkmann Corporation Consumer Sales Department by
calling 800-468-5252.
FIGURE 4
3
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 5
To Replace Cigarette
Lighter Plug Fuse
Step 1: Disconnect spotlight from power source.
Step 2: Unscrew cap of lighter plug and pull straight away from
fuse.
Lighter Plug
Step 3: Pull fuse out of lighter plug. Observe to see if fuse is
burned out.
NOTE: Use a 8A fuse only. Fuse is burned out when fuse
element is missing or broken inside glass tube. Replace
with new 8A fuse if fuse element is missing or broken.
Lighter Cap
Step 4: Pull fuse out of fuse holder. Insert new fuse into holder.
Step 5: Insert fuse holder and fuse into lighter plug.
Step 6: Screw cap onto lighter plug.
Lighter Cap
Fuse
Lighter Plug
Lighter Plug
Lighter Cap
Lighter Cap
4
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 6
ACCESSORIES
Lighter Plug Extension Cord
Features a 15-ft. cord with a cigarette
lighter plug and receptacle.
Model 802-1706-0
Replacement Bulb
12-volt, halogen bulb is an original
replacement for 1 Million CP spotlight.
Model 802-1745-0
Look for these accessories at your local retailer where spotlights
are sold, or order direct by calling 800-468-5252
5
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 7
ACCESSORIES
Rechargeable Battery Pack
With Carrying Case
12-volt rechargeable battery pack
adds total mobility to your spotlight.
Includes cigarette lighter receptacle,
120-volt charging transformer and a
heavy-duty, woven nylon carrying
case with shoulder strap.
Model 802-1724-1 Black
Model 802-1725-1 Green Camo
Pigtail Adapters
Pigtail adapter with battery terminal
clips allow spotlights with cigarette
lighter plug to operate directly from
a 12-volt battery.
(2Ft. Cord) Model 802-1704-0
(10Ft. Cord) Model 802-1705-0
6
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTR_800-2705-0_1MCP.qxd 9/26/05 10:59 AM Page 8
© 2003 The Brinkmann Corporation
Dallas, TX 75244
1-YEAR LIMITED WARRANTY
For 1-year from date of purchase, The Brinkmann Corporation warrants the 1 Million Candlepower 12-Volt
Spotlight against defects due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s
obligations under this warranty are limited to the following guidelines:
•
•
This warranty does not extend to the bulb.
This warranty does not cover spotlights that have been altered or damaged due to: normal wear, abuse,
improper maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an
authorized employee of The Brinkmann Corporation.
•
•
This warranty does not cover surface scratches or weathering as this is considered normal wear.
Warranty service is limited to repair or replacement of spotlights which prove defective under normal use and
which upon examination shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms
the defect and approves the claim, Brinkmann will elect to repair or replace the rechargeable light as covered
by the terms of this warranty.
•
This warranty extends to the original purchaser only and is not transferable or assignable to subsequent
purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you
retain your sales receipt or invoice. To obtain repair or replacement of your 1 Million Candlepower 12-Volt
Spotlight under the terms of this warranty, please call Customer Service Department at 800-527-0717 for a
Return Authorization Number and further instructions. A receipt or proof of purchase will be required. A Return
Authorization Number must be clearly marked on the outside of the box. Spotlights returned to Brinkmann must
include your name, address and telephone number. Please make sure the light is properly packed, postage
prepaid, and insured. Brinkmann will not be responsible for any spotlights forwarded to us without a Return
Authorization Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED
IN DURATION TO 1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON
HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF
THE 1 MILLION CANDLEPOWER 12-VOLT SPOTLIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED
WARRANTY IS EXCLUDED. CUSTOMER ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED
UPON THE LIMITATIONS CONTAINED IN THE WARRANTY SET OUT ABOVE. SOME STATES DO NOT ALLOW THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR
EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY
ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
140-2705-0
Owner’s Manual for Model
800-2705-0
7/03, 4/05, 9/05
Download from Www.Somanuals.com. All Manuals Search And Download.
|