OWNER’S MANUAL
All Weather Woven Heater
Model No. GWU9850F / 35554 (A & B)
CARBON MONOXIDE HAZARD
DANGER
s 4HIS APPLIANCE CAN PRODUCE
CARBON MONOXIDE WHICH HAS NO
ODORꢀ
s 5SING IT IN AN ENCLOSED SPACE
CAN KILL YOUꢀ
s .EVER USE THIS APPLIANCE IN
AN ENCLOSED SPACE SUCH AS A
CAMPERꢁ TENTꢁ CAR OR HOMEꢀ
WARNING
&/2 9/52 3!&%49ꢂ
&OR /UTDOOR 5SE /NLY
(outside any enclosure)
WARNING
&/2 9/52 3!&%49ꢂ
ꢃꢀ )MPROPER INSTALLATIONꢁ ADJUSTMENTꢁ ALTERATIONꢁ
SERVICE OR MAINTENANCE CAN CAUSE INJURY OR
PROPERTY DAMAGEꢀ
ꢄꢀ 2EAD THE INSTALLATIONꢁ OPERATIONꢁ AND
MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE
INSTALLING OR SERVICING THIS EQUIPMENTꢀ
ꢅꢀ &AILURE TO FOLLOW THESE INSTRUCTIONS COULD
RESULT IN lRE OR EXPLOSIONꢁ WHICH COULD CAUSE
PROPERTY DAMAGEꢁ PERSONAL INJURYꢁ OR DEATHꢀ
ꢆꢀ 4HIS INSTRUCTION MANUAL CONTAINS IMPORTANT
INFORMATION NECESSARY FOR THE PROPER
ASSEMBLY AND SAFE USE OF THE APPLIANCEꢀ
ꢇꢀ 2EAD AND FOLLOW ALL WARNINGS AND
INSTRUCTIONS BEFORE ASSEMBLING AND USING
THE APPLIANCEꢀ
Made from 75% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
Table of Contents
Important Safeguards ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ Page 2
%XPLODED 6IEW ꢌ (ARDWAREꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 3
Assembly Instructionsꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢊ
Installling LP Gas Tank ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Insert LP Gas Tankꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Secure LP Gas Tankꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Connect LP Gas Tankꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Disconnect LP Gas Tankꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
/PERATING )NSTRUCTIONSꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Checking for Leaks ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Before Lighting ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
Lightingꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 7
7HEN HEATER IS /.ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Re-Lighting ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
3HUTDOWN ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Cleaning and Care ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Cleaning Surfaces ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Maintenance ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Storage ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Product Registration ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢈ
Specificationsꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢋ
Troubleshooting ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ ꢇ 10
ꢈꢀ &OLLOW ALL WARNINGS AND INSTRUCTIONS WHEN
USING THE APPLIANCEꢀ
ꢉꢀ +EEP THIS MANUAL FOR FUTURE REFERENCEꢀ
DANGER
)F YOU SMELL GAS ꢊ
ꢃꢀ 3HUT OFF GAS TO APPLIANCEꢀ
ꢄꢀ %XTINGUISH ANY OPEN FLAMEꢀ
ꢅꢀ /PEN LIDꢀ
ꢆꢀ )F ODOR CONTINUESꢁ KEEP AWAY FROM THE
APPLIANCE AND IMMEDIATELY CALL YOUR GAS
SUPPLIER OR YOUR FIRE DEPARTMENTꢀ
WARNING
&/2 9/52 3!&%49ꢂ
ꢃꢀ $O NOT STORE OR USE GASOLINE OR OTHER
FLAMMABLE LIQUIDS OR VAPORS IN THE VICINITY OF
THIS OR ANY OTHER APPLIANCEꢀ
ꢄꢀ !N ,0 CYLINDER NOT CONNECTED FOR USE SHALL
NOT BE STORED IN THE VICINITY OF THIS OR ANY
OTHER APPLIANCEꢀ
4HE USE AND INSTALLATION OF THIS PRODUCT MUST CONFORM TO LOCAL CODESꢇ )N ABSENCE OF LOCAL CODESꢁ
use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, CAN/CGA-B149.1, Natural Gas and
Propane Installation Code.
#ALIFORNIA 0ROPOSITION ꢉꢆꢍ #OMBUSTION BYꢀPRODUCTS PRODUCED WHEN USING THIS PRODUCT CONTAIN
CHEMICALS KNOWN TO THE 3TATE OF #ALIFORNIA TO CAUSE CANCERꢁ BIRTH DEFECTSꢁ AND OTHER REPRODUC-
TIVE HARMꢇ
DANGER
.EVER OPERATE THIS APPLIANCE UNATTENDEDꢀ
#ALIFORNIA 0ROPOSITION ꢉꢆꢍ 7ASH YOUR HANDS AFTER HANDLING THIS PRODUCTꢇ
3AVE THESE INSTRUCTIONS FOR FUTURE REFERENCEꢇ
If you are assembling this unit for someone else,
GIVE THIS MANUAL TO HIM OR HER TO READ AND SAVE
FOR FUTURE REFERENCEꢇ
Manufactured in China for: Blue Rhino Global Sourcing, Inc
7INSTONꢀ3ALEMꢁ .# ꢂꢃꢄꢅꢆ 53! s ꢄꢇꢈꢅꢅꢇꢃꢉꢂꢇꢄꢄꢊꢂꢁ WWWꢇBLUERHINOꢇCOM
¥ "LUE 2HINO 'LOBAL 3OURCINGꢁ )NCꢇ !LL 2IGHTS 2ESERVEDꢇ
Frontgate® is a Registered Trademark of Frontgate, Incꢇ !LL 2IGHTS 2ESERVED
'75ꢋꢈꢆꢅ&ꢀ/-ꢀꢄꢅꢆ %
Download from Www.Somanuals.com. All Manuals Search And Download.
PAGE NOꢇ
3
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
Parts List
Exploded View
ꢆꢉꢀꢅꢄꢀꢉꢄꢊ
1
2
3
4
5
6
7
ꢎ
9
Upper Dome
1
ꢆꢉꢀꢅꢄꢀꢉꢄꢆ
,OWER $OME
ꢆꢉꢀꢅꢄꢀꢉꢄꢉ
%MITTER 4OPꢑ
2
ꢆꢉꢀꢅꢄꢀꢉꢄꢃ
%MITTER 3CREENꢑ
"URNERꢑ
3
ꢆꢉꢀꢅꢄꢀꢉꢄꢈ
ꢆꢉꢀꢅꢄꢀꢉꢄꢋ
0ILOT (EAT 3HIELDꢑ
Bottom Plate
4
ꢆꢉꢀꢅꢄꢀꢉꢂꢅ
ꢆꢉꢀꢅꢄꢀꢉꢂꢄ
ꢆꢉꢀꢅꢄꢀꢄꢂꢃ
ꢆꢉꢀꢅꢄꢀꢄꢒꢄ
ꢆꢉꢀꢅꢄꢀꢄꢊꢂ
ꢆꢉꢀꢅꢄꢀꢉꢂꢂ
ꢆꢉꢀꢅꢄꢀꢄꢆꢉ
ꢆꢉꢀꢅꢄꢀꢉꢂꢒ
ꢆꢉꢀꢅꢄꢀꢄꢊꢊ
ꢆꢉꢀꢅꢄꢀꢅꢄꢋ
ꢆꢉꢀꢅꢄꢀꢄꢋꢅ
ꢆꢉꢀꢅꢄꢀꢉꢂꢊ
ꢆꢉꢀꢅꢄꢀꢉꢂꢆ
ꢆꢉꢀꢅꢄꢀꢉꢂꢉ
ꢆꢉꢀꢅꢄꢀꢉꢂꢃ
ꢆꢉꢀꢅꢄꢀꢉꢂꢈ
ꢆꢉꢀꢅꢄꢀꢉꢂꢋ
ꢆꢉꢀꢅꢄꢀꢄꢋꢂ
ꢆꢉꢀꢅꢄꢀꢉꢒꢅ
ꢆꢉꢀꢅꢄꢀꢉꢒꢄ
ꢆꢉꢀꢅꢄꢀꢉꢒꢂ
ꢆꢉꢀꢅꢄꢀꢉꢒꢒ
ꢆꢉꢀꢅꢄꢀꢉꢒꢊ
ꢆꢉꢀꢅꢄꢀꢉꢒꢆ
5
6ALVE 3UPPORT "RACKETꢑ
0ILOT !SSEMBLYꢑ
6
ꢃꢍ "URNER /RIFICEꢑ
11 %LECTRONIC )GNITERꢑ
12 )GNITER "UTTONꢑ
13 #ONTROL +NOBꢑ
14 !CCESS 0ANELꢑ
15 6ALVEꢑ
9
7
ꢃꢍ
11
14
ꢎ
12
13
17
16
15
19
16 4IP 3WITCHꢑ
17 Gas Line
ꢃꢎ
ꢄꢍ
ꢃꢎ %NGINE #OVERꢑ
19 #ONTROL 0ANEL $OORꢑ
ꢄꢍ Upper Cap
21
21 Pole
22 ,OWER #AP
22
23 Shroud Cap
24 2EGULATORꢎ(OSE !SSEMBLY
25 Shroud Back
26 Shroud Front
27 Tank Retainer Wire
ꢄꢎ Wheel Assembly
29 Base
23
24
ꢅꢍ Weight Plate
25
ꢑ 0RE !SSEMBLED
26
27
ꢄꢎ
29
ꢅꢍ
Hardware
Tools Required for Assembly (Not Included)
ꢃꢎꢄꢉv 7RENCH
-ꢉXꢂꢆ "LACK :INC 0LATED 0HILIPS 4RUSS (EAD
-ꢉXꢊꢅ "LACK :INC 0LATED 0HILIPS 4RUSS (EAD
Nickel Plated
3CREW
3CREW
Bolt
ꢊ PCS
ꢊ PCS
3 pcs
3 pcs
ꢊ PCS
3 pcs
ꢊ PCS
3 pcs
1 pc
A
B
C
D
%
F
G
(
I
ꢆꢎꢄꢉꢏꢏ 3OCKET AND 3OCKET 7RENCH
7/16"
Nickel Plated
Bolt
ꢐꢂ 0HILLIPS (EAD 3CREWDRIVER
Nickel Plated
Bolt
M5 Stainless Steel
Nut
-ꢉ "LACK :INC 0LATED
’ꢆ :INC 0LATED
Nut
Washer
AA Battery
AA Battery
Download from Www.Somanuals.com. All Manuals Search And Download.
All Weather Woven Heater, Model No. GWU9850F / 35554 (A & B)
Assembly Instructions
!TTACH "ASE
DO NOT RETURN PRODUCT TO STORE.
For assistance call ꢃꢀꢎꢍꢍꢀꢉꢈꢄꢀꢃꢃꢆꢄ TOLL FREEꢇ 0LEASE HAVE
YOUR OWNERꢏS MANUAL AND MODEL NUMBER AVAILABLE FOR
REFERENCEꢇ
1
2
&OR %ASIEST !SSEMBLYꢍ
s 4O AVOID LOSING ANY SMALL COMPONENTS OR HARDWAREꢁ ASSEMBLE
YOUR PRODUCT ON A HARD LEVEL SURFACE THAT DOES NOT HAVE CRACKS
OR OPENINGSꢇ
s #LEAR AN AREA LARGE ENOUGH TO LAYOUT ALL COMPONENTS AND
HARDWAREꢇ
s 7HEN APPLICABLEꢁ TIGHTEN ALL HARDWARE CONNECTIONS BY HAND
FIRSTꢇ /NCE THE STEP IS COMPLETED GO BACK AND FULLY TIGHTEN ALL
HARDWAREꢇ
s &OLLOW ALL STEPS IN ORDER TO PROPERLY ASSEMBLE YOUR PRODUCTꢇ
4O COMPLETE ASSEMBLY YOU WILL NEEDꢍ
s ꢓꢄ ,EAK $ETECTION 3OLUTION ꢓ)NSTRUCTIONS ON HOW TO MAKE
SOLUTION ARE INCLUDED IN THE h/PERATING )NSTRUCTIONSv SECTION OF
this manual)
s ꢓꢄ 0RECISION &ILLED ,0 'AS 'RILL 4ANK WITH !CME 4YPE ꢄ EXTERNAL
THREADED VALVE CONNECTION ꢓꢊꢀꢆ GALLON SIZE
4YPICAL ASSEMBLYꢍ APPROXIMATELY ꢄ ꢓONE HOURꢇ
X ꢆ
G
X ꢆ
B
!TTACH 0OLE
0LACE #APS
3
4
X ꢆ
%
Download from Www.Somanuals.com. All Manuals Search And Download.
PAGE NOꢇ
5
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
!TTACH %NGINE !SSEMBLY
3ECURE 5PPER #AP
Note: 5PPER CAP MUST ALIGN WITH THE NOTCH ON THE ENGINE ASSEMBLY AND LOCK INTO
POSITIONꢇ
5
7
6
X ꢆ
A
!TTACH "OLTS
!TTACH ,OWER $OME
ꢎ
X ꢅ
X ꢅ
D
C
Download from Www.Somanuals.com. All Manuals Search And Download.
All Weather Woven Heater, Model No. GWU9850F / 35554 (A & B)
Assembly Instructions (continued)
!TTACH 5PPER $OME
)NSERT "ATTERY
9
ꢃꢍ
X ꢅ
F
X ꢅ
(
X ꢃ
I
!TTACH 4ANK 2ETAINER 7IRE
!TTACH 3HROUD &RONT
11
12
Download from Www.Somanuals.com. All Manuals Search And Download.
PAGE NOꢇ
7
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
Installing LP Gas Tank
4O OPERATE YOU WILL NEED ꢓꢄ PRECISIONꢀFILLED STANDARD GRILL ,0 GAS
TANK ꢓꢂꢅ LBSꢇ WITH EXTERNAL VALVE THREADSꢇ
Operating Instructions
#HECKING FOR ,EAKS
Note: !N EMPTY STANDARD GRILL ,0 GAS TANK WEIGHS APPROXIMATELY
ꢄꢈ LBSꢇ ! PRECISIONꢀFILLED STANDARD GRILL ,0 GAS TANK SHOULD WEIGH
NO MORE THAN ꢒꢈ LBSꢇ
20 lb
9 Kg
"URNER #ONNECTIONS
ꢄꢇ -AKE SURE THE REGULATOR VALVE AND HOSE CONNECTIONS ARE SECURELY FASTENED TO THE BURNER AND
THE TANKꢇ
#AUTIONꢂ ,0 GAS TANK MUST BE PROPERLY
DISCONNECTED AND REMOVED PRIOR TO MOVING THIS
HEATERꢀ
ꢂꢇ )F YOUR UNIT WAS ASSEMBLED FOR YOUꢁ VISUALLY CHECK THE CONNECTION BETWEEN THE BURNER PIPE
AND ORIFICEꢇ -AKE SURE THE BURNER PIPE FITS OVER THE ORIFICEꢇ
12.2 in. / 31 cm
7!2.).'ꢂ &AILURE TO INSPECT THIS CONNECTION OR FOLLOW THESE
INSTRUCTIONS COULD CAUSE A FIRE OR AN EXPLOSION WHICH CAN CAUSE DEATHꢁ
SERIOUS BODILY INJURYꢁ OR DAMAGE TO PROPERTYꢀ
)NSERT ,0 'AS 4ANK
0LACE PRECISION FILLED ,0 GAS TANK UPRIGHT INTO HOLE IN PATIO HEATER SO IT IS ARRANGED FOR VAPOR
WITHDRAWALꢇ
ꢒꢇ )F THE BURNER PIPE DOES NOT REST FLUSH TO THE ORIFICEꢁ
PLEASE CONTACT ꢄꢇꢈꢅꢅꢇꢃꢉꢂꢇꢄꢄꢊꢂ FOR ASSISTANCEꢇ
Figure 1
4ANKꢋ'AS ,INE #ONNECTION
ꢄꢇ -AKE ꢂꢀꢒ OZꢇ OF LEAK SOLUTION BY MIXING ONE PART LIQUID
DISHWASHING SOAP WITH THREE PARTS WATERꢇ
ꢂꢇ -AKE SURE CONTROL KNOB IS IN h/&&v POSITIONꢇ ꢓ&IGURE ꢒ
ꢒꢇ 4URN ,0 GAS TANK VALVE TO h/0%.vꢇ
X
ꢊꢇ 3POON LEAK CHECK SOLUTION AT ALL h8v LOCATIONSꢇ
(Figures 1 and 2)
Aꢇ )F ANY BUBBLES APPEAR TURN ,0 GAS TANK VALVE TO
h#,/3%$vꢁ RECONNECT AND REꢀTESTꢇ
Figure 2
Bꢇ )F YOU CONTINUE TO SEE BUBBLES AFTER SEVERAL
ATTEMPTSꢁ TURN ,0 GAS TANK VALVE TO h#,/3%$vꢁ
disconnect LP gas tank and contact
ꢄꢇꢈꢅꢅꢇꢃꢉꢂꢇꢄꢄꢊꢂ FOR ASSISTANCEꢇ
Bꢇ )F NO BUBBLES APPEAR AFTER ONE MINUTE TURN ,0 GAS
TANK VALVE TO h#,/3%$vꢁ WIPE AWAY SOLUTION AND
PROCEEDꢇ
3ECURE ,0 'AS 4ANK
3ECURE TANK IN PLACE BY ATTACHING LOOSE END OF TANK RESTRAINT CHAIN TO HOLE IN RIGHT LEGꢇ
"EFORE ,IGHTING
ꢄꢇ (EATER SHOULD BE THOROUGHLY INSPECTED BEFORE EACH USEꢁ
AND BY A QUALIFIED SERVICE PERSON AT LEAST ANNUALLYꢇ
Figure 3
ꢂꢇ )F RELIGHTING A HOT HEATERꢁ ALWAYS WAIT AT LEAST
ꢆ MINUTESꢇ
PILOT / VEILLEUSE
LOW /
BAS
PUSH IN ꢎ PRESSEZ ET MAINTENEZ
ꢒꢇ )NSPECT THE HOSE ASSEMBLY FOR EVIDENCE OF EXCESSIVE
ABRASIONꢁ CUTS OR WEARꢇ 3USPECTED AREAS SHOULD BE
LEAK TESTEDꢇ )F THE HOSE LEAKSꢁ IT MUST BE REPLACED PRIOR
TO OPERATIONꢇ /NLY USE THE REPLACEMENT HOSE ASSEMBLY
SPECIFIED BY MANUFACTURERꢇ
OFF /
ARRÊT
HIGH /
HAUT
,IGHTING
Note: 4HIS HEATER IS EQUIPPED WITH A PILOT LIGHT THAT ALLOWS
FOR SAFER STARTUPS AND SHUTDOWNSꢇ 0ILOT MUST BE LIT BEFORE
MAIN BURNER CAN BE STARTEDꢇ
&IGURE ꢊ
ꢄꢇ #ONTROL KNOB MUST BE IN THE h/&&v POSITIONꢇ ꢓ&IGURE ꢒ
ꢂꢇ 4URN ,0 GAS TANK VALVE TO h/0%.vꢇ
PILOT / VEILLEUSE
LOW /
BAS
PUSH IN ꢎ PRESSEZ ET MAINTENEZ
ꢒꢇ /PEN VIEWING HOLE BY SLIDING COVER TO EITHER SIDEꢇ
ꢓ&IGURE ꢉ
#ONNECT ,0 'AS 4ANK
Before connecting, be sure that there is no debris caught in
THE HEAD OF THE ,0 GAS TANKꢁ HEAD OF THE REGULATOR VALVE OR
IN THE HEAD OF THE BURNER AND BURNER PORTSꢇ
ꢊꢇ 0USH CONTROL KNOB IN AND ROTATE TO h0),/4v POSITIONꢇ
ꢓ&IGURE ꢊ
Note: For initial start or after any tank change, hold control
knob in for 2 minutes to purge air from gas lines before
PROCEEDINGꢇ
OFF /
ARRÊT
HIGH /
HAUT
#ONNECT GAS LINE TO TANK BY TURNING KNOB CLOCKWISE UNTIL IT
STOPSꢇ
ꢆꢇ Push-button Ignition: Immediately push igniter button
A COUPLE OF TIMESꢇ 0ILOT LIGHT FLAME WILL APPEAR AND BE
VISIBLE THROUGH VIEWING HOLEꢇ
Figure 5
Electronic Ignition: Immediately push igniter button for
FIVE ꢓꢆ SECONDSꢇ 0ILOT LIGHT FLAME WILL APPEAR AND BE
VISIBLE THROUGH VIEWING HOLEꢇ
$ISCONNECT ,0 'AS 4ANK
PILOT / VEILLEUSE
LOW /
BAS
PUSH IN ꢎ PRESSEZ ET MAINTENEZ
ꢉꢇ 2ELEASE CONTROL KNOB AFTER ꢒꢅ SECONDSꢇ 0ILOT LIGHT WILL
REMAIN LITꢇ
"EFORE DISCONNECTING MAKE SURE THE ,0 GAS TANK VALVE IS
h#,/3%$vꢇ
Disconnect gas line from LP gas tank by turning knob
COUNTERCLOCKWISE UNTIL IT IS LOOSEꢇ
ꢃꢇ )F IGNITION DOES NOT OCCURꢁ TURN CONTROL KNOB h/&&vꢁ WAIT ꢆ
MINUTES AND REPEAT LIGHTING PROCEDUREꢇ
ꢈꢇ 4URN CONTROL KNOB TO h()'(vꢇ ꢓ&IGURE ꢆ -AIN BURNER WILL
LIGHT IMMEDIATELYꢇ &LAME IS VISIBLE THROUGH VIEWING HOLEꢇ
)F NOTꢁ TURN CONTROL KNOB h/&&vꢁ WAIT ꢆ MINUTESꢁ AND
REPEAT LIGHTING PROCEDUREꢇ
#AUTIONꢂ ,0 GAS TANK MUST BE PROPERLY
DISCONNECTED AND REMOVED PRIOR TO MOVING
THIS HEATERꢀ
OFF /
ARRÊT
HIGH /
HAUT
ꢋꢇ )F FOR SOME REASON YOUR IGNITOR FAILS TO DELIVER A SPARKꢁ
your heater can be started by inserting a lit match
THROUGH THE PILOT VIEW HOLE WHILE PUSHING THE CONTROL
KNOB IN WHILE IN THE h0),/4v POSITIONꢇ
&IGURE ꢉ
6IEW (OLE
.EED A TANK OF GASꢐ 4RY TANK EXCHANGE SERVICEꢇ )TꢏS EASYꢁ
FASTꢁ SAFEꢁ AND AVAILABLE AT TENS OF THOUSANDS OF CONVENIENTLY
LOCATED RETAIL OUTLETS NATIONWIDEꢇ 9OU CAN PURCHASE A NEW FULL
TANK OR EXCHANGE YOUR EMPTY FOR A PRECISION FILLED ONEꢇ
7!2.).'ꢂ "E CAREFUL WHEN ATTEMPTING TO
MANUALLY IGNITE THIS HEATERꢀ (OLDING IN THE
CONTROL KNOB FOR MORE THAN ꢃꢍ SECONDS
BEFORE IGNITING THE GAS WILL CAUSE A BALL OF
FLAME UPON IGNITIONꢀ
(AVE A QUESTION OR ARE HAVING PROBLEMS VISIT
WWWꢇBLUERHINOꢇCOM OR CALL ꢄꢇꢈꢅꢅꢇꢃꢉꢂꢇꢄꢄꢊꢂꢇ
Download from Www.Somanuals.com. All Manuals Search And Download.
All Weather Woven Heater, Model No. GWU9850F / 35554 (A & B)
Operating Instructions (continued)
Cleaning and Care (continued)
Note: 4HE BURNER MAY BE NOISY WHEN INITIALLY TURNED ONꢇ 4O ELIMINATE EXCESSIVE NOISE FROM THE
BURNER TURN THE CONTROL KNOB TO THE PILOT POSITIONꢁ THEN TURN THE KNOB TO THE LEVEL OF HEAT DESIREDꢇ
-AINTENANCE
To enjoy years of outstanding performance from your heater, make sure you perform the
7HEN HEATER IS /.ꢂ
%MITTER SCREEN WILL BECOME BRIGHT RED DUE TO INTENSE HEATꢇ 4HE COLOR IS MORE VISIBLE AT NIGHTꢇ
FOLLOWING MAINTENANCE ACTIVITIES ON A REGULAR BASISꢍ
ꢄꢇ +EEP EXTERIOR SURFACES CLEANꢇ
Figure 7
ꢂꢇ !IR FLOW MUST BE UNOBSTRUCTEDꢇ +EEP CONTROLSꢁ BURNERꢁ AND CIRCULATING AIR PASSAGEWAYS CLEANꢇ
Signs of possible blockage include:
"URNER WILL DISPLAY TONGUES OF BLUE AND YELLOW FLAMEꢇ
4HESE FLAMES SHOULD NOT BE YELLOW OR PRODUCE THICK BLACK
SMOKEꢁ INDICATING AN OBSTRUCTION OF AIRFLOW THROUGH THE
BURNERSꢇ 4HE FLAME SHOULD BE BLUE WITH STRAIGHT YELLOW
TOPSꢇ ꢓ&IGURE ꢃ
'AS ODOR WITH EXTREME YELLOW TIPPING OF FLAMEꢇ
(EATER DOES ./4 REACH THE DESIRED TEMPERATUREꢇ
(EATER GLOW IS EXCESSIVELY UNEVENꢇ
)F EXCESSIVE YELLOW FLAME IS DETECTEDꢁ TURN OFF HEATER AND
VISIT WWWꢇBLUERHINOꢇCOM OR CALL ꢄꢇꢈꢅꢅꢇꢃꢉꢂꢇꢄꢄꢊꢂꢇ
(EATER MAKES POPPING NOISESꢇ
Note: )N A SALTꢀAIR ENVIRONMENT ꢓSUCH AS NEAR AN OCEAN ꢁ CORROSION OCCURS MORE QUICKLY THAN
NORMALꢇ &REQUENTLY CHECK FOR CORRODED AREAS AND REPAIR THEM PROMPTLYꢇ
2EꢊLIGHTING
4)0ꢍ 5SE HIGHꢀQUALITY AUTOMOBILE WAX TO HELP MAINTAIN THE APPEARANCE OF YOUR HEATERꢇ !PPLY TO
EXTERIOR SURFACES FROM THE POLE DOWNꢇ $O NOT APPLY TO EMITTER SCREEN OR DOMESꢇ
Note: &OR YOUR SAFETYꢁ CONTROL KNOB CANNOT BE TURNED h/&&v WITHOUT FIRST DEPRESSING CONTROL
KNOB IN 0),/4 POSITION AND THEN ROTATING IT TO h/&&vꢇ
ꢄꢇ 4URN CONTROL KNOB TO h/&&vꢇ
3TORAGE
ꢂꢇ 7AIT AT LEAST ꢆ MINUTES TO LET GAS DISSIPATEꢇ
ꢒꢇ 2EPEAT THE h,IGHTINGv PROCEDUREꢇ
"ETWEEN USESꢂ
ꢄꢇ 4URN CONTROL KNOB TO h/&&vꢇ
ꢂꢇ 4URN ,0 GAS TANK VALVE TO h#,/3%$vꢇ
ꢒꢇ $ISCONNECT ,0 GAS TANKꢇ
3HUT $OWN
ꢄꢇ 4URN CONTROL KNOB CLOCKWISE TO PILOTꢇ ꢓ.ORMALLYꢁ BURNER WILL MAKE A SLIGHT POPPING SOUND WHEN
EXTINGUISHEDꢇ "URNER WILL EXTINGUISH BUT PILOT WILL REMAIN h/.vꢇ
ꢊꢇ 3TORE HEATER UPRIGHT IN AN AREA SHELTERED FROM DIRECT CONTACT WITH INCLEMENT WEATHER ꢓSUCH AS
RAINꢁ SLEETꢁ HAILꢁ SNOWꢁ DUSTꢁ DEBRIS AND HIGH WINDS ꢇ
ꢂꢇ 4O EXTINGUISH PILOTꢁ DEPRESS CONTROL KNOB AND CONTINUE TO TURN IT CLOCKWISE TO h/&&vꢇ
ꢒꢇ 4URN TANK VALVE TO h#,/3%$v AND DISCONNECT REGULATOR WHEN HEATER IS NOT IN USEꢇ
.OTEꢍ !FTER USEꢁ SOME DISCOLORATION OF THE EMITTER SCREEN IS NORMALꢇ
ꢆꢇ )F DESIREDꢁ COVER HEATER TO PROTECT EXTERIOR SURFACES AND TO HELP PREVENT BUILD UP IN AIR
PASSAGESꢇ
Note: 7AIT UNTIL HEATER IS COOL ꢓAPPROXIMATELY ꢊꢆ MINUTES BEFORE COVERINGꢇ
$URING PERIODS OF EXTENDED INACTIVITY OR WHEN TRANSPORTINGꢂ
Cleaning and Care
ꢄꢇ 4URN CONTROL KNOB TO h/&&vꢇ
#!54)/.ꢂ !LL CLEANING AND MAINTENANCE SHOULD BE DONE WHEN PATIO
HEATER IS COOL AND WITH THE FUEL SUPPLY DISCONNECTEDꢀ
#!54)/.ꢂ $/ ./4 CLEAN ANY PATIO HEATER PART IN A SELF CLEANING OVENꢀ
4HE EXTREME HEAT WILL DAMAGE THE FINISHꢀ
ꢂꢇ 4URN ,0 GAS TANK VALVE TO h#,/3%$vꢇ
ꢒꢇ $ISCONNECT ,0 GAS TANK AND MOVE TO A SECUREꢁ WELLꢀVENTILATED LOCATION OUTDOORSꢇ
ꢊꢇ 3TORE HEATER UPRIGHT IN AN AREA SHELTERED FROM DIRECT CONTACT WITH INCLEMENT WEATHER ꢓSUCH AS
RAINꢁ SLEETꢁ HAILꢁ SNOWꢁ DUSTꢁ DEBRIS AND HIGH WINDS ꢇ
ꢆꢇ )F DESIREDꢁ COVER HEATER TO PROTECT EXTERIOR SURFACES AND TO HELP PREVENT BUILD UP IN AIR
PASSAGESꢇ
.OTICES
ꢉꢇ .EVER LEAVE ,0 TANK EXPOSED TO DIRECT SUNLIGHT OR EXCESSIVE HEATꢇ
ꢃꢀ 4HIS HEATER SHOULD BE THOROUGHLY CLEANED ON A REGULAR BASISꢀ
Note: 7AIT UNTIL HEATER IS COOL ꢓAPPROXIMATELY ꢊꢆ MINUTES BEFORE COVERINGꢇ
ꢄꢀ !BRASIVE CLEANERS WILL DAMAGE THIS PRODUCTꢀ
ꢅꢀ .EVER USE OVEN CLEANER TO CLEAN ANY PART OF HEATERꢀ
ꢆꢀ -ORE FREQUENT CLEANING MAY BE REQUIRED AS NECESSARYꢀ )T IS IMPERATIVE THAT CONTROL
COMPARTMENTꢁ BURNERS AND CIRCULATING AIR PASSAGEWAYS OF THE HEATER BE KEPT CLEANꢀ
Product Registration
ꢇꢀ (AVE HEATER INSPECTED ANNUALLY AND REPAIRS SHOULD BE MADE BY A QUALIFIED SERVICE
PERSONꢀ
&OR FASTER WARRANTY SERVICEꢁ REGISTER YOUR PRODUCT IMMEDIATELY AT WWWꢇBLUERHINOꢇCOM OR CALL
ꢄꢇꢈꢅꢅꢇꢃꢉꢂꢇꢄꢄꢊꢂꢇ
ꢈꢀ )NSPECT HEATER BEFORE EACH USEꢀ
ꢉꢀ 3PIDERS AND INSECTS CAN CREATE A DANGEROUS CONDITION THAT MAY DAMAGE THE HEATER OR
MAKE IT UNSAFEꢀ +EEP BURNER AREA CLEAN OF ALL SPIDERSꢁ WEBS AND INSECTSꢀ #LEAN BURNER
HOLES BY USING A HEAVYꢊDUTY PIPE CLEANERꢀ #OMPRESSED AIR MAY HELP CLEAR AWAY SMALLER
PARTICLESꢀ
Specifications
#ERTIFICATIONSꢂ
ꢎꢀ #HECK HEATER IMMEDIATELY IF ANY OF THE FOLLOWING CONDITIONS EXISTꢂ
Aꢀ 4HE SMELL OF GAS IN CONJUNCTION WITH EXTREME YELLOW TIPPING OF BURNER FLAMESꢀ
Bꢀ (EATER DOES NOT REACH PROPER TEMPERATUREꢀ
!.3 :ꢈꢒꢇꢂꢉAꢀꢂꢅꢅꢈ s #3! ꢂꢇꢒꢃAꢀꢂꢅꢅꢈꢁ 'ASꢀ&IRED /UTDOOR )NFRARED 0ATIO (EATER
2ATINGꢂ
.OTEꢂ !T TEMPERATURES LESS THAN ꢆꢍŽ&ꢁ HEAT OUTPUT WILL BE REDUCEDꢀ
Cꢀ (EATERꢏS GLOW IS EXCESSIVELY UNEVEN
-AXIMUM ꢊꢅꢁꢅꢅꢅ "45ꢎHRꢇ INPUT
(EAT 2ANGEꢂ
Up to 20 foot diameter
Dꢀ "URNER MAKES POPPING NOISES DURING USEꢀ
.OTEꢂ ! SLIGHT POP IS NORMAL WHEN BURNER IS EXTINGUISHEDꢀ
ꢑꢀ #ARBON DEPOSITS MAY CREATE A FIRE HAZARDꢀ +EEP DOME AND EMITTER CLEAN AT ALL TIMESꢀ
ꢃꢍꢀ $O NOT CLEAN HEATER WITH COMBUSTIBLE OR CORROSIVE CLEANERSꢀ 5SE WARMꢁ SOAPY WATERꢀ
ꢃꢃꢀ $O NOT PAINT ENGINEꢁ ENGINE ACCESS PANEL OR DOMEꢀ
&UELꢂ
,IQUID 0ROPANE 'AS ꢓ,0
4ANK 3IZEꢂ
Nominal 20 lb / 5 Gallon
ꢃꢅꢀ !FTER A PERIOD OF STORAGE ANDꢋOR NONUSEꢁ CHECK FOR LEAKSꢁ BURNER OBSTRUCTIONS AND
INSPECT FOR ANY ABRASIONꢁ WEAR OR CUTS TO THE HOSEꢀ
)NLET GAS SUPPLY PRESSUREꢂ
-AXIMUM n ꢄꢆꢅ 03)
-INIMUM n ꢆ 03)
#LEANING 3URFACES
ꢄꢇ 7IPE SURFACES CLEAN WITH MILD DISHWASHING DETERGENT OR BAKING SODAꢇ
ꢂꢇ &OR STUBBORN SURFACES USE A CITRUS BASED DEGREASER AND A NYLON SCRUBBING BRUSHꢇ
ꢒꢇ 2INSE CLEAN WITH WATERꢇ
-ANIFOLD 0RESSUREꢂ
ꢄꢄꢇꢅꢅ INꢇ 7ꢇ#ꢇ
%NGINEꢂ
)00 %ꢄ
Note: While cleaning your unit, be sure to keep the area around the burner and pilot assembly
DRY AT ALL TIMESꢇ $O NOT SUBMERGE THE CONTROL VALVE ASSEMBLYꢇ )F THE GAS CONTROL IS SUBMERGED IN
WATERꢁ DO ./4 USE ITꢇ )T MUST BE REPLACEDꢇ
3AFETY &EATURESꢂ
100% Burner shut-off
4ILT 3WITCH
-ANUFACTURERꢂ
Blue Rhino Global Sourcing, Inc
-ADE )Nꢂ
China
Download from Www.Somanuals.com. All Manuals Search And Download.
PAGE NOꢇ
ꢋ
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
Troubleshooting
0ROBLEM
0OSSIBLE #AUSE
0REVENTIONꢋ#URE
Igniter fails
,IGHT THE HEATER MANUALLY WITH A MATCHꢁ PER THE h,IGHTING
)NSTRUCTIONSvꢇ )F HEATER LIGHTS WITH A MATCHꢁ REPLACE IGNITER
Pilot or orifice
#LEAN THE PILOT ASSEMBLYꢍ $OWNLOAD AND FOLLOW THE CORRECT
CLEANING INSTRUCTIONS FROM WWWꢇBLUERHINOꢇCOM
,0 GAS TANK VALVE IS CLOSED
Air in gas line
Make sure regulator is securely attached to the LP gas tank,
TURN ,0 GAS TANK VALVE TO h/0%.v
0ILOT WONꢏT LIGHT
ꢄꢇ /PEN GAS LINE AND BLEED IT ꢓPRESSING CONTROL KNOB IN FOR NOT
more than 1 - 2 minutes or until you smell gas
ꢂꢇ 4URN CONTROL KNOB TO h/&&v
ꢒꢇ 7AIT AT LEAST ꢆ MINUTES FOR GAS TO DISSIPATE
,OW GAS PRESSURE WITH TANK VALVE FULLY h/0%.v
4URN ,0 GAS TANK VALVE h#,/3%$v AND REPLACE ,0 GAS TANK
Dirt built up around pilot
#LEAN THE PILOT ASSEMBLYꢍ $OWNLOAD AND FOLLOW THE CORRECT
CLEANING INSTRUCTIONS FROM WWWꢇBLUERHINOꢇCOM
0ILOT WONꢏT STAY LIT
ꢌ2ESIDENTIALꢋ#OMMERICAL (EATERS /NLY
#ONNECTION BETWEEN GAS VALVE AND PILOT ASSEMBLY IS LOOSE
Tighten connection and perform leak check
Air in gas line
/PEN GAS LINE AND BLEED IT ꢓPRESSING CONTROL KNOB IN FOR NOT
more than 1 - 2 minutes or until you smell gas
Note: Heater operates at reduced efficiency below
40ºF (5ºC).
Thermocouple is not operating correctly
#LEAN THE HEATERꢍ $OWNLOAD AND FOLLOW THE CORRECT CLEANING
INSTRUCTIONS FROM WWWꢇBLUERHINOꢇCOM
#ONTROL KNOB IS NOT IN h/.v POSITION
,0 GAS PRESSURE IS LOW
2EVIEW h,IGHTING )NSTRUCTIONSv AND TRY AGAIN
4URN ,0 GAS TANK VALVE h#,/3%$v AND REPLACE ,0 GAS TANK
"URNER WONꢏT LIGHT
Blockage in orifice
#LEAR BLOCKAGEꢍ $OWNLOAD AND FOLLOW THE CORRECT CLEANING
INSTRUCTIONS FROM WWWꢇBLUERHINOꢇCOM
Note: Heater operates at reduced efficiency below
40ºF (5ºC).
#ONNECTION BETWEEN GAS VALVE AND BURNER ASSEMBLY IS LOOSE Tighten connection and perform leak check
Air in gas line /PEN GAS LINE AND BLEED IT ꢓPRESSING CONTROL KNOB IN FOR NOT
more than 1 - 2 minutes or until you smell gas
#ONNECTION BETWEEN GAS VALVE AND BURNER ASSEMBLY IS LOOSE Tighten connection and perform leak check
"URNER WONꢏT STAY LIT
"URNER mAME IS LOW
Thermocouple is not operating correctly
#LEAN HEATER IF STILL NOT WORKINGꢁ OBTAIN A NEW THERMOCOUPLE
from the manufacturer
,0 GAS PRESSURE IS LOW
4URN ,0 GAS TANK VALVE h#,/3%$v AND REPLACE ,0 GAS TANK
/UTDOOR TEMPERATURE IS LESS THAN ꢊꢅŽ& AND TANK IS LESS THAN Use a full LP gas tank
ꢄꢎꢊ FULL
Note: Heater operates at reduced efficiency below
40ºF (5ºC).
Supply hose is bent or kinked
3TRAIGHTEN HOSEꢁ IF CRACKED OBTAIN A NEW HOSE FROM THE
manufacturer
,0 GAS PRESSURE IS LOW
"ASE IS NOT ON A LEVEL SURFACE
Blockage in burner
4URN ,0 GAS TANK VALVE h#,/3%$v AND REPLACE ,0 GAS TANK
0LACE HEATER ON A LEVEL SURFACE
%MITTER GLOWS UNEVEN
Note: Bottom 1” of emitter normally does NOT
glow.
#LEAN THE BURNERꢍ $OWNLOAD AND FOLLOW THE CORRECT CLEANING
INSTRUCTIONS FROM WWWꢇBLUERHINOꢇCOM
Blockage in burner
2EMOVE BLOCKAGE AND CLEAN BURNER INSIDE AND OUTSIDEꢍ
$OWNLOAD AND FOLLOW THE CORRECT CLEANING INSTRUCTIONS FROM
WWWꢇBLUERHINOꢇCOM
4HICK BLACK SMOKE
&OR MORE ASSISTANCE PLEASE VISIT US ONLINE AT WWWꢀBLUERHINOꢀCOM OR CALL ꢃꢀꢎꢍꢍꢀꢉꢈꢄꢀꢃꢃꢆꢄ FOR IMMEDIATE ASSISTANCEꢀ
Download from Www.Somanuals.com. All Manuals Search And Download.
All Weather Woven Heater, Model No. GWU9850F / 35554 (A & B)
Download from Www.Somanuals.com. All Manuals Search And Download.
PAGE NOꢇ
11
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
Download from Www.Somanuals.com. All Manuals Search And Download.
All Weather Woven Heater, Model No. GWU9850F / 35554 (A & B)
Download from Www.Somanuals.com. All Manuals Search And Download.
|