Installation Instructions / Warranty
Montreux
16513XX1
Montreux
16514XX1
Montreux
16523XX1
Montreux
16524XX1
Download from Www.Somanuals.com. All Manuals Search And Download.
Technical Data
Installation Considerations
Max. flow rate
2.2 gpm
•
For best results, Hansgrohe recom-
mends that this unit be installed by a
licensed, professional plumber.
Please read over these instructions
thoroughly before beginning instal-
lation. Make sure that you have all
tools and supplies needed to complete
the installation.
Max. water pressure
Recommended pressure:
Max. hot water temperature:
Recommended hot water temp.
Hole size in mounting surface
valve
145 psi
14.5 - 72 psi
176° F
120°F - 140°F*
•
1 1/4"
1 3/8"
spout
Maximum mounting surface depth 1 5/8"
Requires 1/2" supply lines and nuts.
•
This faucet may be used with a con-
tinuous flow water heater as long as
the flow pressure is at least 14.5 psi.
Bidet faucet not for use on vertical spray bidets.
*Please know and follow all applicable local codes when setting
the temperature on the water heater.
Installation
Remove the mounting ring with o-ring and stop
ring from the valve body.
Push the valve up through the hole in the mounting
surface.
Install the stop ring on the valve. Install the
mounting ring -- it will stop at the proper mounting
height.
Rest the valve on the mounting surface.
Tighten the mounting nut and the tensioning
screws.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Turn the valve cartridges to the “off” position by
turning the cold stem counter-clockwise and the hot
stem clockwise.
Place the handle over the valve. Thread the flange
to the mounting ring.
Place the spout on the mounting surface.
Install the friction washer, metal washer and
mounting nut.
Tighten the mounting nut by hand.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Tighten the tensioning screws.
Install the connecting hoses on the valves with the
compression fittings (included). Take care that the
hoses do not twist.
Install the pop-up drain.
Cnnect the valves to the supply stops with 1/2”
supply lines and nuts (not included).
Turn on the water and check all connections for
leaks.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Install the pop-up drain
Remove the plunger assembly.
Unscrew the drain outlet flange from the tee.
plunger
Unscrew the tailpiece from the tee. Wrap
the threads with two layers of Teflon tape and
replace.
height adjuster
Install the white, flexible sealing gasket to the
flange. Place it in the sink outlet.
flange
Install the black mack gasket, white friction ring
and retainer nut to the flange. Do not tighten the
nut against the bottom of the sink at this time.
sealing gasket
mack gasket
friction ring
retainer nut
Thread the tee and tailpiece to the flange. The
pivot must face the faucet. If necessary, turn the
drain assembly.
Tighten the retainer nut.
pull rod
Place the plunger assembly in the drain.
Install the horizontal rod so that the end goes
through the loop in the bottom of the height
adjuster.
Install and hand tighten the pivot ball nut.
tee
Attach the swivel connector to the end of the
horizontal rod.
pivot ball nut
Attach the swivel connector to the end of the
pull rod. Position as desired and tighten with a
small, flathead screwdriver.
tailpiece
horizontal rod
swivel connector
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Replacement Parts
17
16
2
5
15
3
2
1
10
18
13
4
6
4
12
7
1
2
3
4
5
6
7
8
9
cross handle
16291XX0
97987000
97991XX0
97988XX0
97990XX0
94009000
88503000
13961000
94071001
97989XX0
88513000
96657000
94008000
88511000
97688XX0
97360XX0
97362XX0
16691XX0
14
8
screw cover
aerator cpl.
flange for handle
spout large model
hot cartridge
valve set
fixation set
connection hose
9
11
10 flange for spout
11 compression ftgs.
12 pull rod
13 cold cartridge
14 valve mounting kit
15 spout for bidet
16 aerator cpl.
17 ball joint
18 lever handle
XX = Colors
00 chrome
82 brushed nickel
83 polished nickel
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Cleaning Recommendation for Hansgrohe Products
Modern lavatory faucets, kitchen faucets, and showers consist of very different materials to comply with the needs of the
market with regard to design and functionality. To avoid damage and returns, it is necessary to consider certain criteria when
cleaning.
Cleaning Materials for Faucets and Showers
Acids are a necessary ingredient of cleaning materials for removing lime, however please pay attention to the following points
when cleaning faucets and showers:
•
•
Only use cleaning materials which are explicitly intended for this type of application.
Never use cleaning materials which contain hydrochloric, formic, phosphoric, or acetic acid, as they cause considerable
damage.
•
•
Never mix one cleaning material with another.
Never use cleaning materials or appliances with an abrasive effect, such as unsuitable cleaning powders, sponge pads,
or micro fiber cloths.
Cleaning Instructions for Faucets and Showers
Please follow the cleaning material manufacturer’s instructions. In addition, pay attention to the following points:
•
•
Clean the faucets and showers as and when required
Use the amount of cleaning product and the amount of time recommended by the manufacturer. Do not leave the cleaner
on the fixture longer than necessary.
•
•
Regular cleaning can prevent calcification.
When using spray cleaners, spray first onto a soft cloth or sponge. Never spray directly onto the faucet as droplets can
enter openings and gaps and cause damage.
•
After cleaning, rinse thoroughly with clean water to remove any cleaner residue.
Important
Residues of liquid soaps, shampoos, and shower foams can also cause damage, so rinse with clean water after using.
Please note: if the surface is already damaged, the effect of cleaning materials will cause further damage.
Components with damaged surfaces must be replaced or injury could result.
Damage caused by improper treatment is not covered under the warranty.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Limited Lifetime Consumer Warranty
This product has been manufactured and tested to the highest quality standards by Hansgrohe, Inc. (“Hansgrohe”). This
warranty is limited to Hansgrohe products which are purchased by a consumer in the United States after March 1, 1996, and
installed in either the United States or Canada.
WHO IS COVERED BY THE WARRANTY
This warranty extends to the original consumer purchaser only. This warranty is non-transferable.
WHAT IS COVERED BY THE WARRANTY
This warranty covers only your Hansgrohe manufactured product. Hansgrohe warrants this product against defects in material
or workmanship as follows: Hansgrohe will repair at no charge for parts only or, at its option, replace any product or part of
the product that proves defective because of improper workmanship and/or material, under normal installation, use, service
and maintenance. If Hansgrohe is unable to provide a replacement and repair is not practical or cannot be timely made,
Hansgrohe may elect to refund the purchase price in exchange for the return of the product.
LENGTH OF WARRANTY
Replacement or repaired parts of products will be covered for the term of this warranty as stated in the following two sentenc-
es. If you are a consumer who purchased the product for use primarily for personal, family, or household purposes, this war-
ranty extends for as long as you own the product and the home in which the product is originally installed. If you purchased
the product for use primarily for any other purpose, including, without limitation, a commercial purpose, this warranty extends
only (i) for 1 year, with respect to Hansgrohe and Commercial products, and (ii) for 5 years, with respect to AXOR products.
THIS WARRANTY DOES NOT COVER, AND HANSGROHE WILL NOT PAY FOR:
A. Conditions, malfunctions or damage not resulting from defects in material or workmanship.
B. Conditions, malfunctions or damage resulting from (1) normal wear and tear, improper installation, improper mainte-
nance, misuse, abuse, negligence, accident or alteration, or (2) the use of abrasive or caustic cleaning agents or “no-
rinse” cleaning products, or the use of the product in any manner contrary to the product instructions. (3) Conditions in the
home such as excessive water pressure or corrosion.
C. Labor or other expenses for the disconnection, deinstallation, or return of the product for warranty service, or for installa-
tion or reinstallation of the product (including but not limited to proper packaging and shipping costs), or for installation or
reinstallation of the product.
D. Accessories, connected materials and products, or related products not manufactured by Hansgrohe.
TO OBTAIN WARRANTY PARTS OR INFORMATION
Contact your Hansgrohe retailer, or contact Technical Service at:
Hansgrohe Inc.
1492 Bluegrass Lakes Parkway
Alpharetta GA 30004
Toll-free (800) 334-0455.
In requesting warranty service, you will need to provide
1. The sales receipt or other evidence of the date and place of purchase.
2. A description of the problem.
3. Delivery of the product or the defective part, postage prepaid and carefully packed and insured, to Hansgrohe Inc. 1492
Bluegrass Lakes Parkway, Alpharetta, Georgia 30004, Attention: Technical Service, if required by Hansgrohe.
When warranty service is completed, any repaired or replacement product or part will be returned to you postage prepaid.
EXCLUSIONS AND LIMITATIONS
REPAIR OR REPLACEMENT (OR, IN LIMITED CIRCUMSTANCES, REFUND OF THE PURCHASE PRICE) AS PROVIDED UNDER
THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER. HANSGROHE NEITHER ASSUMES NOR AUTHORIZES
ANY PERSON TO CREATE FOR IT ANY OBLIGATION OR LIABILITY IN CONNECTION WITH THIS PRODUCT.
HANSGROHE SHALL NOT BE LIABLE TO PURCHASER OR ANY PERSON FOR ANY INCIDENTAL, SPECIAL, OR CONSE-
QUENTIAL DAMAGES, ARISING OUT OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY (INCLUDING
MERCHANTABILITY).
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Some States do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclu-
sion may not apply to you. This warranty gives you specific legal rights, and you may have other rights which vary from State
to State. You may be required by law to give us a reasonable opportunity to correct or cure any failure to comply before you
can bring any action in court against us under the Magnuson-Moss Warranty Act.
PRODUCT INSTRUCTIONS AND QUESTIONS
Upon purchase or prior to installation, please carefully inspect your Hansgrohe product for any damage or visible defect.
Prior to installing, always carefully study the enclosed instructions on the proper installation and the care and maintenance of
the product. If you have questions at any time about the use, installation, or performance of your Hansgrohe product, or this
warranty, please call or write to us or call us toll-free at 800 334 0455.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Hansgrohe, Inc. • 1490 Bluegrass Lakes Parkway • Alpharetta, GA 30004
Tel. 770-360-9880 • Fax 770-360-9887
www.hansgrohe-usa.com
Download from Www.Somanuals.com. All Manuals Search And Download.
|