User Manual
TREK-305R
5.7” Display Solution for Vehicle
Application
Download from Www.Somanuals.com. All Manuals Search And Download.
Packing List
Before you begin installing your device, please make sure that the following materials
have been shipped:
ꢀ
TREK-305 device
ꢀ
Display cable (Advantech P/N: 1700009873) to connect with VITA-350P
If any of these items are missing or damaged, contact your distributor or sales repre-
sentative immediately.
iii
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Ordering information
Part Number
Description
TREK-305R-FLA0E
5.7" color TFT LCD with touch screen, 2 Watt speaker, and Power
button
VITA-350P-GA0E
MDT with GPS, GPRS, DI/O, RS232, LVDS (TREK is design com-
patible with VITA)
TREK-305R User Manual
iv
Download from Www.Somanuals.com. All Manuals Search And Download.
Declaration of Conformity
根據交通部低功率管理辦法規定：
第十二條
經型式認證合格之低功率射頻電機，非經許可，公司、商號或使用者均不得擅自變更
頻率、加大功率或變更原設計之特性及功能。
第十四條
低功率射頻電機之使用不得影響飛航安全及干擾合法通信；經發現有干擾現象時，應
立即停用，並改善至無干擾時方得繼續使用。前項合法通信，指依電信規定作業之無
線電信。低功率射頻電機須忍受合法通信或工業、科學及醫療用電波輻射性電機設備
之干擾。
FCC
This device complies with the requirements in part 15 of the FCC rules: Operation is
subject to the following two conditions:
1. This device may not cause harmful interference, and
2. This device must accept any interference received, including interference that
may cause undesired operation This equipment has been tested and found to
comply with the limits for a Class A digital device, pursuant to Part 15 of the
FCC Rules. These limits are designed to provide reasonable protection against
harmful interference when the equipment is operated in a commercial environ-
ment. This equipment generates, uses, and can radiate radio frequency energy
and, if not installed and used in accordance with the instruction manual, may
cause harmful interference to radio communications. Operation of this device in
a residential area is likely to cause harmful interference in which case the user
will be required to correct the interference at his/her own expense. The user is
advised that any equipment changes or modifications not expressly approved
by the party responsible for compliance would void the compliance to FCC regu-
lations and therefore, the user's authority to operate the equipment.
Caution! There is a danger of a new battery exploding if it is incorrectly installed.
Do not attempt to recharge, force open, or heat the battery. Replace the
battery only with the same or equivalent type recommended by the man-
ufacturer. Discard used batteries according to the manufacturer°Øs
instructions.
Additional Information and Assistance
est information about the product.
2. Contact your distributor, sales representative, or Advantech's customer service
center for technical support if you need additional assistance. Please have the
following information ready before you call:
ꢀ Product name and serial number
ꢀ Description of your peripheral attachments
ꢀ A complete description of the problem
ꢀ The exact wording of any error message
v
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
TREK-305R User Manual
vi
Download from Www.Somanuals.com. All Manuals Search And Download.
Contents
Features.................................................................................................... 3
LCD Optical Specification ....................................................................... 11
Enviroment Specification......................................................................... 14
vii
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
TREK-305R User Manual
viii
Download from Www.Somanuals.com. All Manuals Search And Download.
1.1 Introduction
Advantech TREK-305R uses a Toshiba 5.7” LCD panel with touch (Toshiba model
no: LTA057A344F-12), which is the perfect size to fit into tight spaces for fleet man-
agement and dispatching purposes. TREK-305R of 5.7" touch screen panel provides
excellent capabilities and features with industrial standard VESA mounting holes,
light-weight housing, and convenient mounting accessories. The TREK-305 design is
compatible with VITA-350P-GA0E.
Figure 1.1 VITA-350P and TREK-305R total solution
TREK-305R User Manual
2
Download from Www.Somanuals.com. All Manuals Search And Download.
1.2 Features
Type
QVGA TFT LCD (Toshiba LT057A344F)
18 bits (256 k)
Colors
Resolution
320 x 240
Size (disgonal)
Pixel Pitch
5.7” (4:3)
0.36 (W) x 0.36 (W)
H: 140°, V: 120°
320 nits by LED backlight
4-wire resistive
500
Display
View Angle (H°, V°)
Brightness
Touchscreen
Contrast Ratio
Backlight Life Time (hrs)
LVDS
20000
1 x 26 pin connector
2 Watt speaker out
3.3 V and 5 V
I/O
Audio
DC Input
Power
LCD power button
Power Consumption
Mounting
Push button
1.3 W
VESA mount (30 x 38 mm, 75 x 75 mm)
PC
Material
Mechanical
Enviroment
Weight
400 (g)
Dimension W x H x D (mm)
Operating Temperature
Storage Temperature
Vibration
168.55 x 128.05 x 35.6
-10 ~ 70°C
-30 ~ 80°C
MIL-STD-810F 514.5C-3
FCC 47 CFR part 15B
ICES-003 issue 4
EN55022/55024
ECE-R10 (v.03)
CNS 13438
FCC
IC
Certification
CE
E13
BSMI
3
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
1.3 Quick Installation Guide
1. Connect 26pin connector to 5.7” panel.
36pin (S2)
connect to
VITA series
26 pin (S1)
connect to
TREK-305R
DI/O (default: 4 Digital output)
Figure 1.2 - 2 m cable connecting VITA and TREK
2. Connect 36pin connector to VITA-350P.
2 types of VESA mount:
30 x 38mm and 75 x 75mm
Speaker
Warranty void if sticker is removed.
Please refer to Advantech RMA policy
Figure 1.3 Backside of TREK-305R
TREK-305R User Manual
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Power button to control LCD backlight On/Off
When LCD backlight is on, red LED light is on
Figure 1.4 Front side of TREK-305R
Pin definition (on TREK)
Connector vendor: 3M Touch systems, p/n: 10226-55G3PC
Figure 1.5 26-pin connector
Pin definition (on VITA)
Connector vendor: 3M Touch systems, p/n: 10236-55G3PC
Figure 1.6 36-pin connector
5
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
36 pin
CITA-350P Side
26 pin
TREK-305R Side
1
LVDS Data0+
LVDS Data0-
LVDS Data1+
LVDS Data1-
GND
1
LVDS Data0+
LVDS Data0-
LVDS Data1+
LVDS Data1-
GND
2
2
3
3
4
4
5
5
6
T/S signal X+
T/S signal Y+
T/S signal X-
T/S signal Y-
GND
6
T/S signal X+
T/S signal Y+
T/S signal X-
T/S signal Y-
GND
7
7
8
8
9
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
GPIO
GPIO
DC +5 V
DC +5 V
DC +5 V
DC +5 V
LVDS Data2+
LVDS Data2-
LVDS Data3+
LVDS Data3-
LVDS Clock+
LVDS Clock-
GND
LVDS Data2+
LVDS Data2-
LVDS Data3+
LVDS Data3-
LVDS Clock+
LVDS Clock-
GND
Line in
Line in
GPIO
GPIO
GPIO
GPIO
GPIO
GPIO
DC +3.3 V
DC +3.3 V
DC +3.3 V
DC +3.3 V
5 pin
DI/DO Side
27
28
29
30
31
32
33
34
35
36
GPIO1
1
2
3
4
5
GPIO1
GPIO2
GPIO3
GPIO4
GND
GPIO2
GPIO3
GPIO4
GND
X (empty PIN)
X (empty PIN)
X (empty PIN)
X (empty PIN)
X (empty PIN)
TREK-305R User Manual
6
Download from Www.Somanuals.com. All Manuals Search And Download.
TREK-305R User Manual
8
Download from Www.Somanuals.com. All Manuals Search And Download.
A.1 LCD General Specification
Item
Specifications
Display Mode1)
VIewing Direction
Driving Method
TN colors (64 gray scales, 256 k colors)
6 o’clock (in direction of maximum contrast)
TFT active matrix
CLK (clock), DE (Data Enable signal)
H-sync, V-sync (Synchronization signal)
R5, R4, R3, R2, R1, R0 (Red display data)
G5, G4, G3, G2, G1, G0 (Green display data)
B5, B4, B3, B2, B1, B0 (Blue display data)
R/L, U/D (Reverse Scan Control)
Input Signals
Dimensional Outline2)
Active Area
144.0 (W) x 104.6 (H) x 10.0 max. (D) (mm)
115.2 (W) x 86.4 (H) (mm)
115.4 (W) x 86.6 (H) (mm)
320 (W) x 240 (H) (mm)
Viewing Area
Number of Pixels3)
Pixel Pitch3
Pixel Arrangement3
Surface treatment
Backlight
0.36 (W) x 0.36 (H) (mm)
RGB vertical stripes
Anti-glare and hard cost 3H on LCD surface
18 LEDs (3 rows) for sidelighting
Note!
1. k=1024.
2. Excluding backlight cables.
3. Display area address is as follows.
TREK-305R User Manual
10
Download from Www.Somanuals.com. All Manuals Search And Download.
A.2 LCD Optical Specification
Specifications
Item
Symbol Conditions
Unit Remark
Min. Typ. Max.
30
40
40
40
50
70
70
70
-
-
-
-
°
°
°
°
-
=180°
=0°
Viewing Angle
CR >=10
=90°
=190°
Contrast Ratio
Response Time
CR
350 500 -
=0°,
=0°
tON
-
-
15 25
25 35
ms
ms
=0°,
tOFF
=0°
cd/m2
/F=12 mA
Luminance
L
255 320 -
=0°,
=0°
Gray Scale Level=163
(White)
Luminance Uniformity LUNF
XR
60
70
-
%
Gray Scale Level: L63
0.52 0.59 0.66 -
0.27 0.34 0.41 -
Red
YR
=0°,
Ditto
=0°
XG
0.29 0.36 0.43 -
0.48 0.55 0.62 -
0.08 0.15 0.22 -
0.05 0.12 0.19 -
0.25 0.32 0.39 -
0.27 0.34 0.41 -
Green
YG
Chromaticity
XB
Blue
Ditto
Ditto
YB
XW
White
YW
Note!
1. Refer to “11. Measuring Method“.
2. The above test limit must be applied for initial use. Characteristics
will be shifted by long period operation, but it is not irregular phe-
nomena. Theoretically brightness characteristics will be decreased
due to color shift.
11
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
TREK-305R User Manual
12
Download from Www.Somanuals.com. All Manuals Search And Download.
B.1 Enviroment Specification
Chemical Resistance
(top surface)
Toluene, Acetone, Methanol, Alcohol, Ethylacetate, Artificial sweat,
Petroleum ether
Condition: Tested after leaving the chemical on the surface for 3 minutes being wiped
off by cloth.
Judgment: Must be no effect in appearance.
B.2 Mechanical Characteristics
Operating Life
Input (finger)
10,000,000 hits (Note 1)
Character Input (pen)
100,000 characters (Note 2)
Note!
1. Testing rod (Figure 1), Load 250 g, Cycle 2hit/sec;
2. Testing rod (Figure 2), load 250 g, Input size 10 x 10 mm, Input
character A to Z / minute.
These (finger and pen) are tested at same point of the panel surface,
and all point will become dis-functin after test.
Silicon Rubber
(Hardness: 60°)
Tip: R = 4.0
Polyacetal resin
Tip: R = 0.8
Figure 1 Testing rod 1
Figure 2 Testing rod 2
B.3 Mechanical Characteristics
Pressing Force
Activation Force
Surface Hardness
Max 100N (Note 3)
0.05N to 1.0N
Over 3H (by JIS pencil hardness) (Note 4)
Note!
3. Testing with rubber rod. (Ø 16 mm, Hardness 60°), Time: 5 s, Center
of LCD surface. If you apply pressure over 100N, white spots and
dark spots will be occured.
4. Testing pressure is 750 g. If you use 3H hardness pencil with under
750 g pressure, the surface will not be damaged. But using a 4H
hard pencil, the surface may be damaged. Please use a 3H pencil
or under with under 750 g pressure.
TREK-305R User Manual
14
Download from Www.Somanuals.com. All Manuals Search And Download.
15
TREK-305R User Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Please verify specifications before quoting. This guide is intended for reference
purposes only.
All product specifications are subject to change without notice.
No part of this publication may be reproduced in any form or by any means,
electronic, photocopying, recording or otherwise, without prior written permis-
sion of the publisher.
All brand and product names are trademarks or registered trademarks of their
respective companies.
© Advantech Co., Ltd. 2008
Download from Www.Somanuals.com. All Manuals Search And Download.
|