Sony Ericsson CDX CA850 User Manual

CDX-CA850/CA850X/CA860X

SERVICE MANUAL

US Model

Canadian Model

Ver 1.1 2001. 04

CDX-CA850X/CA860X

AEP Model

UK Model

CDX-CA850

Photo: CDX-CA850X

• The tuner and CD sections have no adjustments.

Model Name Using Similar Mechanism CDX-C5000R

CD Drive Mechanism Type

Optical Pick-up Name

MG-383Z-121//Q

KSS-720A

AUDIO POWER SPECIFICATIONS (US Model)

POWER OUTPUT AND TOTAL HARMONIC DISTORTION

23.2 watts per channel minimum continuous average power into

4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more

than 5% total harmonic distortion.

SPECIFICATIONS

CD player section

Power amplifier section

Signal-to-noise ratio

Frequency response

Wow and flutter

90 dB

10 – 20,000 Hz

Below measurable limit

Outputs

Speaker outputs

(sure seal connectors)

4 – 8 ohms

Speaker impedance

Laser Diode Properties (US, Canadian Model)

Maximum power output 52 W × 4 (at 4 ohms)

Material

GaAlAs

Wavelength

Emission Duration

Laser output power

780 nm

Continuous

Less than 44.6 µW*

General

Outputs

Audio outputs (front/rear)

Subwoofer output (mono)

Power Antenna relay control lead

Power amplifier control lead

Telephone ATT control lead

Illumination control lead

* This output is the value measured at a distance

of 200 mm from the objective lens surface on the

Optical Pick-up Block.

Inputs

Bus control input connector

Bus audio input connector

Remote controller input connector

Antenna input connector

Bass ±10 dB at 62 Hz (US, Canadian model)

Bass ±8 dB at 100 Hz (AEP, UK model)

Treble ±10 dB at 16 kHz (US, Canadian model)

Treble ±8 dB at 10 kHz (AEP, UK model)

+8 dB at 100 Hz

Tuner section

Tuning range

87.5 – 107.9 MHz (US, Canadian model)

87.5 – 108.0 MHz (AEP, UK model)

External Antenna connector

Tone controls

Antenna terminal

Intermediate frequency 10.7 MHz/450 kHz

Usable sensitivity

Selectivity

Signal-to-noise ratio

8 dBf

75 dB at 400 kHz

66 dB (stereo),

72 dB (mono)

Loudness

+2 dB at 10 kHz

12 V DC car battery

(negative ground)

Power requirements

Harmonic distortion at 1 kHz

0.6% (stereo),

0.3% (mono)

35 dB at 1 kHz

30 – 15,000 Hz

– Continued on next page –

Separation

Frequency response

AM (US, Canadian model)

Tuning range

Antenna terminal

Intermediate frequency 10.7 MHz/450 kHz

Sensitivity 30 µV

530 – 1,710 kHz (US, Canadian model)

External Antenna connector

FM/MW/LW COMPACT DISC PLAYER

CDX-CA850

MW/LW (AEP, UK model)

Tuning range

MW: 531 – 1,602 kHz

LW: 153 – 279 kHz

External Aerial connector

FM/AM COMPACT DISC PLAYER

Aerial terminal

Intermediate frequency 10.7 MHz/450 kHz

Sensitivity

CDX-CA850X/CA860X

MW: 30 µV

LW: 40 µV

9-870-291-12

2001D0400-1

Sony Corporation

e Vehicle Company

Shinagawa Tec Service Manual Production Group

CDX-CA850/CA850X/CA860X

Ver 1.1 2001. 04

TABLE OF CONTENTS

1. GENERAL ........................................................................... 4

2. DISASSEMBLY

2-1. Sub Panel Assy .................................................................. 10

2-2. CD Mechanism Block ....................................................... 10

2-3. Main Board ....................................................................... 10

2-4. Heat Sink ........................................................................... 11

2-5. Chassis (T) Assy................................................................ 11

2-6. Lever Section..................................................................... 12

2-7. Servo Board ....................................................................... 12

2-8. Arm Roller Assy ................................................................ 13

2-9. Chassis (OP) Assy ............................................................. 13

2-10. Optical Pick-up Block ....................................................... 14

3. DIAGRAMS

3-1. IC Pin Descriptions ........................................................... 15

3-2. Block Diagram –CD Section–........................................... 23

3-3. Block Diagram –Tuner Section– ....................................... 24

3-4. Block Diagram –Display Section– .................................... 25

3-5. Circuit Boards Location .................................................... 26

3-6. Printed Wiring Boards –CD Mechanism Section–............ 28

3-7. Schematic Diagram –CD Mechanism Section (1/2)– ....... 30

3-8. Schematic Diagram –CD Mechanism Section (2/2)– ....... 31

3-9. Printed Wiring Boards –Main Section– ............................ 32

3-10. Schematic Diagram –Main Section (1/4)– ........................ 34

3-11. Schematic Diagram –Main Section (2/4)– ........................ 35

3-12. Schematic Diagram –Main Section (3/4)– ........................ 36

3-13. Schematic Diagram –Main Section (4/4)– ........................ 37

3-14. Printed Wiring Board –Sub (CD) Section– ....................... 38

3-15. Schematic Diagram –Sub (CD) Section–.......................... 39

3-16. Printed Wiring Board –Key Section– ................................ 40

3-17. Schematic Diagram –Key Section–................................... 41

4. EXPLODED VIEWS

4-1. Chassis Section ................................................................. 46

4-2. Front panel Section ........................................................... 47

4-3. CD Mechanism Section (1) ............................................... 48

4-4. CD Mechanism Section (2) ............................................... 49

4-5. CD Mechanism Section (3) ............................................... 50

5. ELECTRICAL PARTS LIST ........................................ 51

CDX-CA850/CA850X/CA860X

SECTION 1

GENERAL

This section is extracted from AEP,

UK model’s instruction manual.

CDX-CA850/CA850X/CA860X

Connection

CDX-CA850/CA850X/CA860X

SECTION 2

DISASSEMBLY

Note : This equipment can be removed using the following procedure.

2-2. CD MECHANISM BLOCK

7 bracket (CD)

Set

Sub Panel Assy

CD Mechanism Block

Main Board

Heat Sink

6 PTT 2.6x4

5 CD mechanism block

Chassis (T) Assy

lever Section

Servo Board

Arm Roller Assy

Chassis (OP) Assy

Optical Pick-up Block

2 PTT 2.6x4

1 PTT 2.6x4

4 CN401

Note : Follow the disassembly procedure in the numerical order given.

2-1. SUB PANEL ASSY

2-3. MAIN BOARD

4 ground point screw

6 MAIN board

(PTT 2.6x6)

4 two claws

5 ground point screws

(PTT 2.6x6)

6 sub panel assy

3 PTT 2.6x4

3 claw

2 PTT 2.6x6

2 PTT 2.6x4

1 PTT 2.6x4

5 CN701

1 PTT 2.6x6

CDX-CA850/CA850X/CA860X

2-4. HEAT SINK

5 heat sink

3 PTT 2.6x10

2 PTT 2.6x16

1 PTT 2.6x10

4 PTT 2.6x4

2-5. CHASSIS (T) ASSY

2 P 2x3

3 P 2x3

1 Unsolder the

lead wires.

4 chassis (T) assy

black

red

white

CDX-CA850/CA850X/CA860X

2-6. LEVER SECTION

5 guide (disc)

6 lever (R) sub assy

3 tension spring (LR)

7 lever (L) sub assy

1 PS 2x4

2 DISC IN board

4 claws

2-7. SERVO BOARD

2 heat sink (CD)

1 PS 2x5

9 PS 2x4

7 PS 2x4

4 CN2

5 Removal the solders.

3 CN3

7 P 2x3

0 SERVO board

6 Removal the solders.

8 loading motor assy

(M903)

CDX-CA850/CA850X/CA860X

2-8. ARM ROLLER ASSY

• When installing, take note of the positions

arm (roller) and washers. (Fig. 1)

bearing (roller)

washer(RA)

retaining ring (roller)

arm

bearing (roller)

arm

washer(RA)

Fig. 1

2 arm roller assy

3 PS 2x3

4 LOAD board

1 tension spring (RA2)

2-9. CHASSIS (OP) ASSY

7 chassis (OP) assy

8 compression spring (FL)

1 tension spring (KF1)

9 compression spring (FL)

2 tension spring (KR1)

5 Fit lever (D) in the

direction of the arrow.

6 Turn loading ring in the

direction of the arrow.

3 damper (T)

4 damper (T)

CDX-CA850/CA850X/CA860X

2-10. OPTICAL PICK-UP BLOCK

1 P 2x3

2 sled motor assy

(M902)

3 optical pick-up block

CDX-CA850/CA850X/CA860X

SECTION 3

DIAGRAMS

3-1. IC PIN DESCRIPTIONS

• IC501 CXD2598Q (DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR) (SERVO BOARD)

Pin No.

Pin Name

DVDD

DVSS

SOUT

SOCK

XOLT

SQSO

SQCK

SCSY

SBSO

EXCK

XRST

STSM

DATA

XLAT

CLOK

SENS

SCLK

ATSK

WFCK

XUGF

XPCK

GFS

I/O

—

Pin Description

Digital power supply pin

Digital ground

Servo brock serial data output (Not used.)

Servo brock serial data read clock output (Not used.)

Servo brock serial data latch output (Not used.)

Sub Q 80 bit, PCM peak and level data output. CD TEXT data output

Clock input from SQSO read output.

Fixed at “L”.

Serial output of sub-P to W. (Not used.)

Clock input from SBSO read output. (Fixed at “L”)

System reset (“L”: Reset)

System mute input (Fixed at “L”)

Serial data input from CPU.

Latch input from CPU. Latch serial data at the falling edge.

Serial data transfer clock input from CPU.

SENS output for CPU.

Clock input from SENS serial data read.

Input/output for anti-shock.

I/O

—

I/O

WFCK (Write Flame Clock) output (Not used.)

XUGF output (Not used.)

XPCK output (Not used.)

GFS output

C2PO

SCOR

C4M

C2PO output (Not used.)

“H” output at either detection, sub code sync S0 or S1.

4.2336 MHz output (Not used.)

Word clock input f=2Fs (Not used.)

Track number count signal input/output (Not used.)

Mirror signal input/output (Not used.)

Digital ground

WDCK

COUT

MIRR

DVSS

DVDD

DFCT

FOK

Digital power supply pin

Diffect signal input/output (Not used.)

Focus OK signal output

PWM1

LOCK

MDP

External control input of spindle motor.

Lock signal input/output

I/O

Servo control output of spindle motor.

Disc most inner track detection signal input

2/3 frequency division output of pins ih and ij. (Not used.)

Sled drive output

SSTP

FSTIO

SFDR

SRDR

TFDR

TRDR

FFDR

FRDR

DVDD

DVSS

TEST

TES1

I/O

—

Sled drive output

Tracking drive output

Focus drive output

Digital power supply pin

Digital ground

Test pin (Fixed at “L”)

XTSL

X’tal select input (“L”: 16.9344 MHz, “H”: 33.8688 MHz)

Center voltage input

Focus error signal input

Sled error signal input

CDX-CA850/CA850X/CA860X

Pin No.

100

Pin Name

I/O

Pin Description

Tracking error signal input

Center servo analog input

RF signal input

RFDC

ADIO

AVSSO

IGEN

—

Test pin (Not used.)

Analog ground

Constant current input from OP amplifier.

Analog ground

AVDDO

ASYO

ASYI

—

EFM full-swing output (“L”: VSS, “H”: VDD)

Asymmetry comparate voltage input

EFM signal input

RFAC

AVSS3

CLTV

FILO

—

Analog ground

VCO control voltage input from master.

Filter output for master PLL (slave=digital PLL)

Filter input from master PLL.

FILI

PCO

—

Charge pump output for master PLL.

Analog power supply pin

AVDD3

BIAS

Asymmetry circuit constant current input

VCO2 control input from wideband EFM PLL. (Not used.)

VCO2 oscillator output for wideband EFM PLL. (Not used.)

Charge pump output for wideband EFM PLL. (Not used.)

Digital ground

VCTL

V16M

VPCO

DVSS

MD2

—

Digital out ON/OFF control input (“L”: OFF, “H”: ON)

Digital out output

DOUT

ASYE

DVDD

LRCK

LRCKI

PCMD

PCMDI

BCK

Asymmetry circuit ON/OFF input (“L”: OFF, “H”: ON)

Digital power supply pin

—

D/A interface LR clock output (f=Fs)

D/A interface LR clock input

D/A interface serial data output (2’s COMP, MSB fast)

D/A interface serial data input (2’s COMP, MSB fast)

D/A interface bit clock output

BCKI

D/A interface bit clock input

EMPH

EMPHI

XVDD

XTAI

Emphasis ON/OFF signal output

Emphasis ON/OFF signal input (“H”: ON, “L”: OFF)

Power supply for master clock.

X’tal oscillator input from master clock (16.9344 MHz).

X’tal oscillator output for master clock (16.9344 MHz).

Ground pin for master clock.

—

XTAO

XVSS

AVDD1

AOUT1

AIN1

—

Analog power supply pin

Lch analog output

Lch OPAMP input

LOUT1

AVSS1

AVSS2

LOUT2

AIN2

—

Lch LINE output

Analog ground

Rch LINE output

Rch OPAMP input

AOUT2

AVDD2

RMUT

LMUT

—

Rch analog output

Analog power supply pin

Rch “0” detect Flug (Not used.)

Lch “0” detect Flug (Not used.)

CDX-CA850/CA850X/CA860X

• IC5 CXP84640-072Q (CD SYSTEM CONTROL) (SERVO BOARD)

Pin No.

Pin Name

ITRPT

—

I/O

—

Pin Description

Not used in this set.

2, 3

4, 5

Not used in this set.

NCO

Not used in this set.

OPEN

Front panel open detection input

Front panel close control output

Bus interface link input

Not used in this set.

LINKOFF

NCO

—

12, 13

14, 15

D SW

Down switch input (SW4)

Limit switch input (SW3)

Not used in this set.

SSTP

NCO

—

Not used in this set.

EMPH O

CDMON

CD ON

A MUT

LD ON

CD RST

HOLD

AGC CONT

—

De-emphasis ON/OFF control output

CD mechanism deck power control output

CD power control output

System attenuate control output

Laser power ON/OFF control output

CD system reset output

Hold switch output

AGC control output

Not used in this set.

PH3

Not used in this set.

TSTIN0

TSTIN1

TST.CLV

NCO

Not used in this set.

—

Not used in this set.

RESET

X IN

System reset input (“L”=Reset)

X’tal oscillator input from system clock. (10 MHz)

X’tal oscillator output for system clock. (10 MHz)

Analog ground

X OUT

GND

—

XT OUT

XT IN

Not used in this set.

AVSS

—

A/D converter ground

AVREF

TEP L

A/D converter reference voltage input

Not used in this set.

TEP H

SLED–

PH2

Not used in this set.

Sled drive input

Not used in this set.

SEK/SMET

GFS/MNT2 SEL

SC-JIG ON/OFF

SCLK

Fixed at “H” in this set.

I/O

—

CD-TEXT data read clock output

Lock signal input/output

Not used in this set.

LOCK

—

SCK2

Sub Q read clock output

SI2

Sub Q 80 bit, PCM peak and level data 16 bit input.

Not used in this set.

—

I/O

BUS CLK

BUS SI

BUS SO

F OK

Bus system serial clock input/output

Bus system serial interface input

Bus system serial interface output

Focus OK signal input

GFS

GFS signal detection input

Fixed at “H” in this set.

TEST MODE

CDX-CA850/CA850X/CA860X

Pin No.

Pin Name

SENS

I/O

Pin Description

SENS signal input

—

Not used in this set.

—

Not used in this set.

BU.IN

BUSON

IN SW

SELF SW

SCOR

CD-CKO

LM LOD

CD DATA

CD-XLAT

LM-EJ

DRV-OE

MD2

Back-up power detection input

Bus on control input

Disc in switch input (SW1)

Self switch input (SW2)

Sub-code sync output

—

CD signal process serial clock input

Loading motor control output

CD signal process serial data output

CD signal process serial data latch output

Loading motor control output

Focus/tracking coil/sled motor control output

Digital out ON/OFF control output (“L”: OFF, “H”: ON)

Power supply pin

VDD

NIH

Fixed at “H” in this set.

V/Z

Fixed at “H” in this set.

PH1

Not used in this set.

—

Not used in this set.

DOUT-SEL

—

Fixed at “H” in this set.

78 – 80

—

Not used in this set.

CDX-CA850/CA850X/CA860X

• IC501 MB90574BPMT-G-323-BND (MAIN SYSTEM CONTROL) (CDX-CA850X/CA860X) (MAIN BOARD)

• IC501 MB90574BPMT-G-324-BND (MAIN SYSTEM CONTROL) (CDX-CA850) (MAIN BOARD)

Pin No.

1 – 4

Pin Name

NCO

I/O

—

I/O

Pin Description

Not used. (Open)

ATT

System mute control signal output

Not used. (Open)

6, 7

NCO

VCC

Power supply pin (+5 V)

Amp mute signal output

EEPROM data signal input/output

EEPROM clock signal output

AMP ATT

E2PSIO

E2PCKO

DOOR SW/FLS SI

FLS SO

BUS ON

BEEP

Door switch signal input (L: close) Flash write data signal input

Flash write data signal output

BUS ON control signal output

Beep signal output

NS MASK

UNISI

Tuner mute signal output

SONY BUS data signal input

SONY BUS data signal output

SONY BUS clock signal output

Not used. (Open)

UNISO

UNICKO

IFWIDTH

SWSHIFT

SYSRST

(NCO)

SIRCS

NCO

Not used. (Open)

System reset signal output

Not used. (Open)

Remote control data signal input

Not used. (open)

25 – 29

—

AMPON

VOLATT

NCO

Amp on signal output (L: OFF/H: ON)

Electronic volume mute signal output (L: Mute on)

Not used. (Open)

VSS

Ground pin

Power stabilized capacitance pin Not used. (open)

Not used. (Open)

35 – 37

NCO

DVCC

DVSS

D/A converter VREF input

D/A converter GND pin

40, 41

(NCO)

AVCC

Not used. (Open)

Analog power supply pin (+5 V)

A/D converter VREF+ input

A/D converter VREF– input

Analog ground pin

AVRH

AVRL

AVSS

KEYIN0

KEYIN1

RCIN0

NCO

Key signal input 0

Key signal input 1

Rotary commander signal input

Not used. (Open)

QUALITY

FM AGC

MPTH

VSM

Quality signal output

Not used in this set. (Open)

MPTH signal output to RDS decoder

S-meter signal input

VCC

—

Power supply pin (+5 V)

55, 56

NCO

Not used. (Open)

BOOT

Display microcomputer write control signal output

Front panel indicator signal output

Not used. (Connect to ground in this set.)

Ground pin

DOORIND

NIL

59 – 62

VSS

—

NIL

Not used. (Connect to ground in this set.)

Not used. (Open)

FSW IN

NCO

66 – 68

Not used. (Open)

CDX-CA850/CA850X/CA860X

Pin No.

Pin Name

FLASH W

I2CSIO

I2CCKO

NCO

I/O

Pin Description

Flash write mode detection signal input

Tuner, electronic volume communication data signal output

Tuner, electronic volume communication clock signal output

Not used. (Open)

X1A

Low speed oscillation signal input (32.768 kHz)

DAVN signal output to RDS decoder

Not used. (Open)

X0A

DAVN

DISCON IN

BUIN

Backup power supply detection signal input

Not used. (Open)

NCO

KEYACK

ADON

KEY ACK detection signal input

A/D conversion power control signal output

Front panel attachment detection signal input

Flash write jig power supply output

System power supply control signal output

Not used. (Open)

NOSESW

FLASH ON

PWON

NCO

RAMBU

HSTX

RAM reset detection signal input

Hardware standby signal input

MD2

Operation mode input (Connect to ground.)

Operation mode input (Connect to VCC.)

Microcomputer reset signal input

Ground pin

88, 89

MD1, 0

RESET

VSS

—

High speed oscillation signal input (3.68 MHz)

Power supply pin (+5 V)

VCC

—

95, 96

97 – 99

100

101

102

103

104

105, 106

107

108

109

110

111, 112

113

114, 115

116

117

118

119

120

REIN0, 1

NCO

Rotary encoder signal input

Not used. (Open)

4V SEL X/O

COLORSEL X/O

MODELSEL0 U/J

DOT/L-CUBE

CD/MD

NCO

4 V/5.5 V preout menu with/without initial setting input

Illumination select with/without initial setting input Not used. (Open)

Destination setting input Not used. (Open)

DOT/L-CUBE judgment initial setting input

CDX/MDX judgment initial setting input Not used. (Open)

Not used. (Open)

RCIN1 (PULL UP)

TESTIN (PULL UP)

TELATT

ILLIN

Rotary commander signal input

Test mode setting detection input

TEL mute detection signal input

Illumination line detection signal input

Not used. (Open)

NCO

TUNON

NCO

Tuner on signal output

Not used. (Open)

EMPH

Not used. (Open)

ACCIN

ACC power supply detection signal input L: ACC ON

Not used. (Open)

NCO

—

VSS

Ground pin

NCO

Not used. (Open)

CDX-CA850/CA850X/CA860X

• IC701 HD6432355A35F (SUB SYSTEM CONTROL)

Pin No.

Pin Name

PG3

I/O

—

Pin Description

Spectrum analyzer clock output

Not used (open)

Ground pin

PG4

VSS

Not used (open)

Power supply pin

Not used (open)

Ground pin

VCC

6 – 9

PC0 – PC3

VSS

11 – 14

15 – 18

PC4 – PC7

PB0 – PB3

VSS

Not used (open)

Ground pin

20 – 23

24 – 27

PB4 – PB7

PA0 – PA3

VSS

Not used (open)

Ground pin

29 – 32

PA4 – PA7

SP LAT(PWON)

BU IN

Not used (open)

Spectrum analyzer latch input

Back-up power detection input

Ground pin

VSS

—

VSS

Ground pin

P65

Not used (open)

Bus on control signal

Power supply pin

Not used (open)

Ground pin

BUS ON

VCC

—

40 – 43

PE0 – PE3

VSS

45 – 48

PE4 – PE7

PD0

Not used (open)

Bus interface link off control signal

Not used (open)

LINK OFF

PD2

ILL-ON

VSS

Illumination on/off switch signal output

Ground pin

54 – 56

PD4 – PD6

BOOT

Not used (open)

Flash write-in mode detection input

Power supply pin

VCC

—

Not used (open)

TX/LCD DATA

SP SI

Flash write-in data/LCD driver data output

Not used (open)

Flash write-in data input

Reset signal for SIRCS inveter

LCD driver clock output

Ground pin

L RST

—

LCD SCK

VSS

LCD CE1

VSS

LCD driver chip enable output

Ground pin

VSS

Ground pin

LCD INH1

LCD CE2

LCD INH2

P27 – P21

P20

Not used (open)

72 – 78

Not used (open)

Flash write-in control signal

Flash write-in enable input

Reset signal

FWE L

RES

NMI

Non maskable interrupt signal

Standby mode signal

Power supply pin

STBY

VCC

—

CDX-CA850/CA850X/CA860X

Pin No.

Pin Name

XTAL

I/O

—

Pin Description

Crystal oscillator (18.432 MHz)

Ground pin

EXTAL

VSS

PF7

Not used (open)

VCC

—

Power supply pin

90 – 96

PF6 – PF0

UNI SO

UNI SI

VSS

Not used (open)

SONY Bus data output

SONY Bus data input

Ground pin

—

100

VSS

Ground pin

101

UNI SCK

P53

SONY Bus clock input

Not used (open)

102

103

AVCC

—

Power supply pin for A/D converter

Reference voltage for A/D converter

Not used (Connecting to ground.)

Spectrum analyzer data input

Ground pin

104

VREF

105 – 111

112

P42 – P46

P47(SA DATA)

AVSS

113

—

114

VSS

Ground pin

115 – 122

123

P17 – P10

MD0

Not used (open)

—

Mode select

124

MD1

Mode select

125

MD2

Mode select

126 – 128

PG0 – PG2

Not used (open)

CDX-CA850/CA850X/CA860X

3-2. BLOCK DIAGRAM — CD SECTION —

RF AMP, LD APC,

ERROR AMP

IC1

DIGITAL SERVO,

DIGITAL SIGNAL PROCESSOR

IC501

(Page 24)

TUNER

ATT

CD SYSTEM CONTROL

IC5

SYSTEM CONTROL

IC501 (1/3)

OPTICAL PICK-UP

KSS-720A

SECTION

(Page 24)

• Signal path

:CD

TUNER

A MUT

ATT

SECTION

LOUT1

LOUT2

RFO

RFAC

RFDC

CD L

EFM

DEM

D/A

I/F

D/A

CONV.

CDMON

CDON

MDON

CDON

DISPLAY

SECTION

(Page 25)

R-CH

I-V

CONV.

BUS CLK

BUS SI

UNI CKO

UNI SI

UNI SO

BUS ON

SYS RST

BU IN

FOCUS

ERROR

DIGITAL

CLV

LOCK

OPEN

BUS ON

RESET

BU IN

(KEY BOARD)

SIRCS

BUFFER

IC903

RESET SIRCS

HSTX

TRACKING

ERROR

SQSO

SQCK

SCOR

SI2

SCK2

SCOR

SUB

CODE

PROCESS

IC502

MD2

XRST

DATA

XLAT

SCLK

CLOK

SENS

GFS

MD2

BU 5V

RESET

LD ON

CD RST

CD DATA

CD XLAT

SCLK

CD CKO

SENS

AMP

S101

RESET

HOLD SW 21

AGC CONT 20

DRIVE

Q101

TRACKING/FOCUS COIL DRIVE

SLED/SPINDLE/LOADING MOTOR DRIVE

IC7

GFS

FOK

BU DET

BATT

FOK

BUS INTERFACE

IC601

Q602

FFDR

FRDR

FOCUS

XIN

FOCUS

COIL

10MHz

BATT (L)

CHECK

DRIVE

BATT

XOUT

TFDR

TRACKING

COIL

DRIVE

SERVO

TRACKING

COIL

TRDR CTL

RESET

SW3

SSTP

(LIMIT)

Q603

M902

SFDR

SRDR

SLED

MOTOR

DRIVE

SW1

(DISC IN)

IN SW

D SW

BUS ON

CONT

SLED

MOTOR

SW4

(DOWN)

M901

SPINDLE

MOTOR

SPINDLE

MOTOR

DRIVE

MDP

SW2

(SELF)

SELF SW

DATA

CLK

M903

MOTOR

DRIVE

LM EJ

CN601

BUS

CONTROL IN

LM LOD

SLED –

DRIVE OE

LD ON

HOLD

AGC CONT

MUTE 1 34

MUTE 2 35

BUS SO 53

SRST

BUS CLK

BUS SI

BUS ON

UNI SO

DISPLAY

SECTION

LINK OFF

(Page 25)

CDX-CA850/CA850X/CA860X

3-3. BLOCK DIAGRAM — TUNER SECTION —

CN302

–1

CA850/CA850X

BUS AUDIO IN

–2

CA860X

CDL

R-CH

ELECTRONIC VOLUME

IC301

SECTION

(Page 23)

–5

AUXL

MDL

OUT FL

ADSO(L-CH)

IC304

AUDIO OUT

FRONT

Q306

Q308

–6

BUFFER

IC308

BUFFER

IC302

AC INL

–3

ACOUTL

OUT RL

AUDIO OUT

REAR

TUNER UNIT

TUX201

–4

CN201

(ANTENNA)

AM ANT

MPX

MPX1

CA850/CA850X

CA860X

SUB WOOFER AMP

IC310

FM ANT

AMDET

CN301

QUAL

MP IN

SDA

SCL

OUTSW

SUB OUT

SA CLK

SA OUT

POWER AMP

IC351

CA850/CA850X

CN101

Q310

MUTE

CA850

SYSTEM CONTROL

IC501 (2/3)

ATT

CONTROL

Q303, 304

FL+

SECTION

(Page 23)

IC202

VOL ATT

QUALITY

RF AMP

Q204

NOISE

DET

SA CLK

SA OUT

PWON

FL–

RL+

DISPLAY

SECTION

Q205

NS MASK

(Page 25)

RL–

BEEP

22 MUTE

BEEP

AMP ATT

RDS DECODER

IC201

POWER

CONT.

BATT

Q104(1/2),105

MPT

MPTH

DAIN

STBY

AMP ON

DAVN

SCA 10

SDA

LVIN 20

TEL ATT 109

110

RDS DET

MPX

FR+

FR–

RR+

RR–

ILL IN

ACC IN 117

Q103

R-CH

ILL

DET

Q102

XIA

ACC

DET

Q101

X501

32.768kHz

TEL MUTE

ILL

ACC

XDA

S METER

SDA IIC

SCL IIC

VSM

I2CSIO

I2CCKO

TEST

TEST 108

AMP REM

PW ON

SDA EEPROM

SCL EEPROM

E2PSIO

E2PCKO

POWER

CONT.

Q104(2/2),106

X502

3.68MHz

CONT

ANT REM

COM 8.5V

BATT

Q801-803

113

TUN ON

• Signal path

POWER

CONT

Q201,202

TU 8V

BATT

COM8.5V

BATT

:CD

:FM

CA860X

+5V

REG

Q207

TU 5V

+10V

:AM/MW/LW

REG

10V

IC801

CDX-CA850/CA850X/CA860X

3-4. BLOCK DIAGRAM — DISPLAY SECTION —

SYSTEM CONTROL

IC501 (3/3)

SUB SYSTEM CONTROL

IC701

BUS SI

UNI SO

98 UNI SI

97 UNI SO

UNI SCK

BUS ON

LINK OFF

BUS CLK

BUS ON

LINK OFF

101

ADON

XTAL

X701

18.432MHz

KEY

ACTIVE

Q701

SECTION

(Page 23)

BUF

IC702

RES

S RST

KEY ACK

EXTAL

CA850

107

RC IN1

RC IN0

PW ON

SA CLK

SA OUT

33 PW ONI

SA CLK

112 SA OUT

J651

(REMOTE IN)

TUNER

SECTION

(Page 24)

KEY IN

MATRIX

KEY IN0

KEY IN1

BOOT

ILL ON

FLASH ON

LCD DRIVER

IC901

POWER

CONT.

Q702,703

LCD+B

BATT

100

LCD DATA

LCD SCK

LCD CE1

DATA

CLK

LCD901

LED851

DIMMER

CONTROL

Q903

LED

DOOR IND

NOSESW

DRIVE

Q705,706

MD ON

CD ON

SECTION

(Page 23)

S102

(NOSE DET)

POWER

CONT.

Q402,403

POWER

CONT.

Q405,407

LSW921

LED910-913

+6V REG

Q401

+5V REG

Q406

BATT

CD 5V

CD 6V

LCD+B

REG

Q501

BATT

BU5V

CDX-CA850/CA850X/CA860X

3-5. CIRCUIT BOARDS LOCATION

SUB board

DISC IN board

SUB (CD) board

LIMIT board

tuner unit

(TUX201)

MAIN board

LOAD board

SERVO board

KEY board

CDX-CA850/CA850X/CA860X

• Waveforms

THIS NOTE IS COMMON FOR PRINTED WIRING

BOARDS AND SCHEMATIC DIAGRAMS.

(In addition to this, the necessary note is

printed in each block.)

— Servo Board —

(MODE: CD PLAY)

— Main Board —

for schematic diagram:

• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolytics

and tantalums.

5Vp-p

• All resistors are in Ω and ¹/⁴W or less unless otherwise

specified.

Approx. 200mVp-p

4.332MHz

(TE)

(OSCD)

IC1

IC201

•

: indicates tolerance.

: internal component.

• C : panel designation.

5.1Vp-p

Note:

Les composants identifiés par

une marque 0 sont critiques

pour la sécurité.

Ne les remplacer que par une

piéce portant le numéro

spécifié.

The components identi-

fied by mark 0 or dotted

line with mark 0 are criti-

cal for safety.

Replace only with part

number specified.

Approx. 620mVp-p

32.768kHz

(FE)

(X0A)

IC1

IC501

2.2Vp-p

• A : B+ Line.

• Power voltage is dc 14.4V and fed with regulated dc power

supply from ACC and BATT cords.

• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-

tion tolerances.

• Waveforms are taken with a oscilloscope.

Voltage variations may be noted due to normal produc-

tion tolerances.

1.2Vp-p

3.68MHz

(RFO)

(XO)

IC1

IC501

1.6Vp-p

1.4Vp-p

• Circled numbers refer to waveforms.

• Signal path.

18.432MHz

16MHz

(EXTAL)

IC701

: FM

: AM/MW/LW

: CD

(XTAI)

IC501

4.2Vp-p

for printed wiring boards:

• X : parts extracted from the component side.

• Y : parts extracted from the conductor side.

10MHz

•

: parts mounted on the conductor side.

: Through hole.

: Pattern from the side which enables seeing.

(X IN)

IC5

(The other layer’s patterns are not indicated.)

Caution:

Pattern face side: Parts on the pattern face side seen from the

(Side B)

Parts face side: Parts on the parts face side seen from the

(Side A) parts face are indicated.

pattern face are indicated.

— Key Board —

4.6Vp-p

4MHz

(XOUT)

IC903

CDX-CA850/CA850X/CA860X

3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION —

CDX-CA850/CA850X/CA860X

• Semiconductor

Location

Ref. No. Location

IC1

IC5

IC7

IC501

C-2

C-6

F-2

F-5

Q101

B-2

(Page 33)

CDX-CA850/CA850X/CA860X

• Refer to page 27 for Waveforms.

3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 42 for IC Block Diagrams.

IC B/D

(Page 31)

(Page 36)

Note:

• Voltage is dc with respect to

ground under no-signal conditions.

no mark : CD PLAY

(Page 31)

CDX-CA850/CA850X/CA860X

• Refer to page 27 for Waveforms.

3-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 42 for IC Block Diagrams.

(Page 30)

IC B/D

(Page 30)

Note:

• Voltage is dc with respect to

ground under no-signal conditions.

no mark : CD PLAY

CDX-CA850/CA850X/CA860X

3-9. PRINTED WIRING BOARDS — MAIN SECTION —

• Semiconductor Location

Ref. No. Location Ref. No. Location

D102

D105

D106

D107

D110

D202

D203

D204

D310

D311

D501

D504

D505

D601

D603

D607

D608

D609

D610

D653

D703

D707

D715

D802

C-5

D-7

C-7

C-5

E-5

G-12

I-11

G-8

H-7

K-5

K-6

K-7

D-4

C-2

E-3

D-3

D-4

K-9

K-13

J-4

IC310

IC502

IC601

IC702

IC801

D-12

K-6

D-3

J-10

H-10

Q101

Q102

Q103

Q104

Q105

Q106

Q201

Q202

Q204

Q205

Q207

Q303

Q304

Q402

Q403

Q405

Q407

Q602

Q603

Q701

Q702

Q703

Q705

Q706

Q802

Q803

C-4

D-5

B-5

C-6

C-5

G-11

G-12

G-11

H-11

H-12

G-8

G-7

H-2

G-3

G-4

C-3

K-8

J-3

CA860X

H-10

IC201

IC202

IC302

IC303

IC305

IC308

IC309

I-13

H-11

D-11

D-10

F-11

E-11

E-10

J-4

K-3

K-4

G-2

F-2

CDX-CA850/CA850X/CA860X

AEP,UK model

US,Canadian model

(Page 29)

• Semiconductor

Location

Ref. No. Location

D101

D301

D302

D303

D304

D305

D306

D307

D308

D401

D402

D503

D604

D605

D606

D708

D801

B-4

B-7

B-6

C-7

B-8

C-8

G-2

H-3

I-2

B-2

K-11

G-2

IC301

IC304

IC351

IC501

IC701

F-9

F-10

B-7

J-7

J-10

Q306

Q307

Q308

Q309

Q310

Q401

Q406

Q501

Q801

C-10

B-10

C-12

C-11

E-12

G-1

G-4

H-2

F-1

(Page 38)

CDX-CA850/CA850X/CA860X

• Refer to page 27 for Waveforms.

3-10. SCHEMATIC DIAGRAM — MAIN SECTION (1/4) — • Refer to page 42 for IC Block Diagrams.

IC B/D

(Page 35)

:CA850/CA850X

:CA860X

IC B/D

(Page 36)

Note:

• Voltage is dc with respect to ground under

no-signal (detuned) condition.

no mark : FM

CDX-CA850/CA850X/CA860X

3-11. SCHEMATIC DIAGRAM — MAIN SECTION (2/4) — • Refer to page 43 for IC Block Diagrams.

IC B/D

US,Canadian model

IC B/D

AEP,UK model

(Page

34)

(Page 37)

Note:

• Voltage is dc with respect to ground under

no-signal (detuned) condition.

no mark : FM

CDX-CA850/CA850X/CA860X

• Refer to page 27 for Waveforms.

3-12. SCHEMATIC DIAGRAM — MAIN SECTION (3/4) — • Refer to page 42 for IC Block Diagrams.

(Page 34)

(Page 30)

(Page 37)

IC B/D

Note:

• Voltage is dc with respect to ground under

no-signal (detuned) condition.

no mark : FM

(

) : AM/MW/LW

> : CD PLAY

CDX-CA850/CA850X/CA860X

3-13. SCHEMATIC DIAGRAM — MAIN SECTION (4/4) — • Refer to page 27 for Waveforms.

(Page 35)

(Page

36)

(Page 39)

Note:

• Voltage is dc with respect to ground under

no-signal (detuned) condition.

no mark : FM

CDX-CA850/CA850X/CA860X

3-14. PRINTED WIRING BOARD — SUB (CD) SECTION —

(Page 33)

(Page 40)

CDX-CA850/CA850X/CA860X

3-15. SCHEMATIC DIAGRAM — SUB (CD) SECTION —

(Page 41)

(Page 37)

CDX-CA850/CA850X/CA860X

3-16. PRINTED WIRING BOARD — KEY SECTION —

• Semiconductor Location

Ref. No. Location

(IC903) B-3

(D900)

(D901)

(D902)

(D910)

D920

A-12

A-11

B-12

B-3

B-13

A-9

(LED900) B-1

(Page 38)

LED910

LED911

LED912

LED913

B-12

B-2

B-12

B-2

(D972)

(D974)

A-9

(IC901)

(IC902)

B-8

B-1

(Q903)

C-11

(

) : SIDE B

CDX-CA850/CA850X/CA860X

• Refer to page 27 for Waveforms.

3-17. SCHEMATIC DIAGRAM — KEY SECTION — • Refer to page 43 for IC Block Diagrams.

IC B/D

(Page 39)

Note:

• Voltage is dc with respect to ground under no-signal

(detuned) condition.

no mark : FM

CDX-CA850/CA850X/CA860X

• IC BLOCK DIAGRAMS

IC1 CXA2596M

IC601 BA8270F

IC7 LA6556L-TE-L

BUS ON

APC PD AMP

14 VCC

BUS ON

GND

SWITCH

VCC

FWD

REV

HOLD

VCC

36 S-GND

–

VCC

INPUT

RESET

SWITCH

VEE

–

RST

CH2-CH4 OUTPUT

ON/OFF

12 BUS ON

11 CLK IN

10 BU IN

MUTE2

MUTE1

VIN4

MUTE2

LC/PD

LD ON

HOLD SW

AGCCONT

RF BOT

RFTC

RF I

AGCVTH

BATTERY

SWITCH

VEE

–

BATT

–

CH1 OUTPUT

ON/OFF

APC LD AMP

VCC2

VL0–

VL0+

VO4+

VO4–

VO3+

VO3–

MUTE1

CLK

VREF

DATA

DATA IN

OUTPUT

VCC

CONTROL

VIN4–

GND

DATA OUT

–

VIN4+

LEVEL

SHIFT

–

VREF-IN

–

VIN1 (VREF)-SW

VREF-OUT (CH1)

–

VIN1/VREF SW

LEVEL

SHIFT

VEE

–

RF SUMMING AMP

RF EQ AMP

5V REG

–

RFO

VEE

ERROR AMP

FOCUS

VO2+

VO2–

REG-OUT

REG-IN

VIN3+

VIN3–

VIN3

VEE

LEVEL

SHIFT

–

RFE

VO1+

–

LEVEL

SHIFT

–

VO1–

–

VC BUFFER

VCC

VEE

VCC1

TRACKING

ERROR AMP

–

VIN1

VIN2+

VIN2–

–

VIN1–A

VIN1+A

VIN1–B

IC201 SAA6588T

AMP-A

–

VIN2

12 11

–

VIN1 +B

POWER SUPPLY

& RESET

PAUSE

DETECTOR

AMP-B

MULTI

PATH

DETECTOR

57kHz

8th ORDER

BAND-PASS FILTER

CLOCKED

COMPARATOR

SIGNAL QUALITY

DECODER

CLOCK

DATA

RDS/RDBS

DEMODULATOR

RDS/RDBS

DECODER

INTERFACE

DATA

TEST

CONTROL

OSCILLATOR

& CLOCK

IIC BUS SLAVE

TRANSCEIVER

CDX-CA850/CA850X/CA860X

IC301 TDA7406T

33 32 31 30 29

28 27

26 25

MIXER

SOFT STEP

FADER

SOFT STEP

FADER

SOFT STEP

FADER

MONO

FADER

CREF

22 VDD

SUPPLY

21 SACLK

SUB

WOOFER

FILTER

SCL

SDA

GND

OUTPUT SELECTOR

SWIN

ACINR

ATT

ACOUTR

SWACOUT

AC OUTL

IIC-BUS

16 QUAL

QUAL.

HIGH PASS

A/D

HIGH OUT

S & H

7BAND

EQUALIZER

DIGITAL

CONTROL

PULSE

FORMER

CREF

SOFT STEP

VOLUME

25kHz

AM/FM

NOISE

BLANKER

SOFT MUTE

LOUDNESS

15 MP OUT

14 MP IN

MULTI

PATH

DETECTOR

DEMODULATOR

+STEREO ADJUST

+STEREO BLEND

SPECTRUM

ANALIZER

BEEP

PILOT

CANCELLATION

IN GAIN

+ AUTO

ZERO

13 LEVEL

PIL, DET

PLL

PAUSE

MAIN SOURCE

SELECTOR

MIXING

SELECTOR

86kHz

CDR 40

CDL 41

MDR 42

MDL 43

TAPEL 44

STD

IN GAIN

INPUT MULTIPLEXER

12 AUX1

10 11

CDX-CA850/CA850X/CA860X

IC302, 303 NJM2160AV

CFL/R+

VCC

VREF

CFL/R-

INFL/R

SVRFL/R

GNDFL/R

13 OUTFL/R

INMFL/R

INMRL/R

OUTRL/R

SVRRL/R

INRR/L

11 GNDRL/R

10 CRL/R-

VREF

VCC

CRL/R+

IC902 RRX9000-0601

GND

12 11 10

L IN GND A

V IN

V AGC

LNS

VCO NC

INPUT

SLAGE

320kHz

/500kHz

NOISE

SUPPRESSION

320kHz

PULSE

COUNTER

AGC

PULSE

FORMER

BANDGAP

REFERENCE

L IN GND V STBY

VCC

NC NC

VPO

CDX-CA850/CA850X/CA860X

Ver 1.1 2001. 04

SECTION 4

EXPLODED VIEWS

NOTE:

The components identified by

mark 0 or dotted line with mark

0 are critical for safety.

Replace only with part number

specified.

• The mechanical parts with no reference

number in the exploded views are not supplied.

• Items marked “*” are not stocked since

they are seldom required for routine service.

Some delay should be anticipated

when ordering these items.

• -XX and -X mean standardized parts, so

they may have some difference from the

original one.

• Color Indication of Appearance Parts

Example :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinet’s Color

• Accessories and packing materials and

hardware (# mark) list are given in

the last of this parts list.

Les composants identifiés par une

marque 0 sont critiques pour

la sécurité.

Ne les remplacer que par une piéce

portant le numéro spécifié.

CDX-CA850/CA850X/CA860X

Ver 1.1 2001. 04

4-1. CHASSIS SECTION

MG-383Z-121//Q

#13

TUX201

F901

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

* 3

X-3378-512-1 PANEL ASSY, SUB

3-040-990-01 BUTTON (EJECT)

1-680-868-11 SUB (CD) BOARD

X-3376-699-1 GEAR ASSY

* 15

* 16

3-040-998-01 BRACKET (IC)

A-3283-144-A MAIN BOARD, COMPLETE (CA850)

A-3283-145-A MAIN BOARD, COMPLETE (CA860X)

A-3283-146-A MAIN BOARD, COMPLETE (CA850X)

3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT

3-030-909-01 DAMPER, OIL

* 8

3-713-786-51 SCREW +P 2X3

X-3377-621-1 LOCK ASSY

3-223-782-01 COVER

* 18

3-045-878-01 PLATE (TU), GROUND

1-790-355-51 CORD (WITH CONNECTOR) (RCA)

(SUB OUT (MONO))

1-776-207-72 CORD (WITH CONNECTOR) (POWER)

* 20

3-224-755-01 SHEET, INSULATING

3-223-781-01 CHASSIS

(CA850X/CA860X) * 21

1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)

(CA850)

3-047-812-01 SCREW (LOCK)

* 23

3-045-857-01 HEAT SINK (CD)

1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE)

3-046-626-01 SHEET, RADIATION

* 10

* 11

* 12

* 13

3-041-012-01 BRACKET (CD)

3-227-287-01 SHEET, DUST PROTECTION

3-223-783-21 CHASSIS (BACK)

3-223-780-01 HEAT SINK (CA850)

3-223-780-21 HEAT SINK (CA850X/CA860X)

F901

1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A

TUX201 A-3220-812-A TUNER UNIT (TUX-020)

* 14

3-223-785-01 HEAT SINK (REG/D)

CDX-CA850/CA850X/CA860X

4-2. FRONT PANEL SECTION

not

supplied

not

supplied

not supplied

(KEY board)

LCD901

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

* 52

* 53

* 54

* 55

X-3380-575-1 PANEL ASSY, FRONT

3-227-279-01 PLATE (LCD), GROUND

3-230-625-01 SHEET

3-227-283-01 SHEET (ILLUMINATOR)

3-227-278-01 PLATE (LCD), LIGHT GUIDE

3-031-319-01 SPRING (BEARING)

X-3380-118-1 PANEL ASSY, FRONT BACK

3-227-286-01 PLATE (FBP), ORNAMENTAL (CA850)

3-227-286-11 PLATE (FBP), ORNAMENTAL (CA850X)

3-227-286-21 PLATE (FBP), ORNAMENTAL (CA860X)

* 57

1-694-780-11 CONDUCTIVE BOARD, CONNECTION

3-227-284-01 SHEET (REFLECTOR)

* 62

3-227-280-01 CASE (IR-T), SHIELD

LCD901 1-804-308-11 DISPLAY PANEL, LIQUID CRYSTAL

CDX-CA850/CA850X/CA860X

4-3. CD MECHANISM SECTION (1)

(MG-383Z-121//Q)

102

103

not supplied

109

not supplied

101

#11

105

106

107

104

M903

110

#10

108

#11

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

* 101

* 102

103

1-659-836-11 DISC IN BOARD

A-3315-034-E CHASSIS (T) ASSY

3-931-909-01 SPRING (LR), TENSION

107

* 108

109

3-047-477-01 SPRING (RA2), TENSION COIL

3-039-629-01 BRACKET (MOTOR)

3-931-908-13 GUIDE (DISC)

* 104

105

A-3326-231-A SERVO BOARD, COMPLETE

3-338-737-01 SCREW (2X3), +PS

110

M903

A-3315-040-A ROLLER ASSY, ARM

A-3315-039-A MOTOR SUB ASSY, LD (LOADING)

* 106

1-659-837-11 LOAD BOARD

CDX-CA850/CA850X/CA860X

4-4. CD MECHANISM SECTION (2)

(MG-383Z-121//Q)

154

151

156

157

158

166

160

167

162

155

153

165

164

155

163

161

159

152

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

151

152

153

154

155

X-3378-956-1 ARM ASSY, CHUCKING

3-931-897-61 DAMPER (T)

3-039-627-01 LEVER (D)

3-040-165-01 RETAINER (DISC)

3-018-272-01 WASHER

160

161

162

163

164

3-220-180-01 SPRING (TR2), TENSION

3-931-881-01 LEVER (LOCK)

3-931-882-02 GEAR (MDL)

3-007-537-11 WHEEL (U), WORM

3-032-484-01 SPRING (KR1), TENSION

156

157

158

159

3-931-895-01 SPRING (CH), TENSION

3-931-898-01 SPRING (FL), COMPRESSION

3-032-483-01 SPRING (KF1), TENSION

A-3307-471-C OVERALL ASSY, CHASSIS (M)

165

166

167

3-014-727-01 WHEEL (LW), WORM

3-039-626-01 LEVER (TR)

3-025-418-22 RING, LOADING

CDX-CA850/CA850X/CA860X

4-5. CD MECHANISM SECTION (3)

(MG-383Z-121//Q)

201

M901

207

202

M902

203

208

205

#12

206

209

210

204

213

212

211

The components identified by Les composants identifiés par une

mark 0 or dotted line with mark marque 0 sont critiques pour

0 are critical for safety.

Replace only with part number Ne les remplacer que par une piéce

specified. portant le numéro spécifié.

la sécurité.

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

201

202

203

X-3378-598-1 CHASSIS (OP) ASSY (including M901)

3-043-494-01 SPRING (SL), TORSION

3-040-170-01 BASE (DRIVING)

* 208

209

0210

211

1-659-834-11 SUB BOARD

3-909-607-01 SCREW

8-820-103-03 PICK-UP, OPTICAL KSS-720A/K1RP

3-025-743-01 SPRING (FEED), LEAF

204

3-040-419-01 GEAR (MIDWAY)

* 205

1-659-835-11 LIMIT BOARD

212

1-676-707-21 PICK-UP FLEXIBLE BOARD

206

207

3-338-737-01 SCREW (2X3), +PS

1-659-880-11 MOTOR FLEXIBLE BOARD

213

M902

A-3315-306-A SHAFT (FEED) ASSY

A-3291-674-A MOTOR ASSY, SLED (SLED)

CDX-CA850/CA850X/CA860X

DISC IN KEY

SECTION 5

ELECTRICAL PARTS LIST

NOTE:

The components identified by

mark 0 or dotted line with mark

0 are critical for safety.

Replace only with part number

specified.

• Due to standardization, replacements in

the parts list may be different from the

parts specified in the diagrams or the

components used on the set.

• -XX and -X mean standardized parts, so

they may have some difference from the

original one.

• RESISTORS

All resistors are in ohms.

METAL:Metal-film resistor.

METAL OXIDE: Metal oxide-film resistor.

F:nonflammable

• Items marked “*” are not stocked since

they are seldom required for routine service.

Some delay should be anticipated

when ordering these items.

• SEMICONDUCTORS

In each case, u : µ, for example:

uA.. : µA.. uPA.. : µPA..

uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..

• CAPACITORS

Les composants identifiés par une

marque 0 sont critiques pour

la sécurité.

Ne les remplacer que par une piéce

portant le numéro spécifié.

uF : µF

• COILS

uH : µH

When indicating parts by reference

number, please include the board.

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

1-659-836-11 DISC IN BOARD

D901

D902

D910

D920

D972

8-719-018-01 DIODE MA8220-TX

8-719-017-58 DIODE MA8068-TX

8-719-073-01 DIODE MA111-(K8).S0

8-719-420-90 DIODE MA8051-M-TX

8-719-977-03 DIODE MA8056-M-TX

*************

< SWITCH >

SW1

SW2

1-572-288-21 SWITCH, PUSH (DISC IN)

1-572-288-21 SWITCH, PUSH (SELF)

D974

8-719-422-94 DIODE MA8091-L-TX

< FERRITE BEAD >

*************************************************************

KEY BOARD

**********

FB901 1-414-235-22 INDUCTOR, FERRITE BEAD

FB902 1-414-235-22 INDUCTOR, FERRITE BEAD

1-694-780-11 CONDUCTIVE BOARD, CONNECTION

3-227-278-01 PLATE (LCD), LIGHT GUIDE

3-227-279-01 PLATE (LCD), GROUND

3-227-280-01 CASE (IR-T), SHIELD

3-227-283-01 SHEET (ILLUMINATOR)

< IC >

IC901

IC902

IC903

8-759-653-26 IC LC75878W

8-759-830-18 IC RRX9000-0601#1

8-759-830-17 IC RRX9000-0401R#01

3-227-284-01 SHEET (REFLECTOR)

3-230-625-01 SHEET

< LIQUID CRYSTAL DISPLAY >

< CAPACITOR >

LCD901 1-804-308-11 DISPLAY PANEL, LIQUID CRYSTAL

< DIODE >

C900

C901

C902

C903

C904

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-974-11 CERAMIC CHIP 0.01uF

1-126-205-11 ELECT CHIP

1-135-852-21 ELECT CHIP

25V

50V

6.3V

25V

47uF

22uF

20%

LED900 8-719-083-14 LED RRX9000-0501 (IR RECEIVE)

LED910 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)

LED911 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)

LED912 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)

LED913 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)

1-164-156-11 CERAMIC CHIP 0.1uF

C905

C906

C907

C908

C910

1-135-852-21 ELECT CHIP 22uF

20%

6.3V

50V

10V

25V

1-162-974-11 CERAMIC CHIP 0.01uF

1-164-388-11 CERAMIC CHIP 270PF

1-115-156-11 CERAMIC CHIP 1uF

1-164-156-11 CERAMIC CHIP 0.1uF

< SWITCH >

LSW921 1-762-619-21 SWITCH, KEYBOARD (WITH LED) (ON/OFF)

< TRANSISTOR >

C911

C912

C982

C983

C986

1-164-156-11 CERAMIC CHIP 0.1uF

1-164-227-11 CERAMIC CHIP 0.022uF 10%

1-115-412-11 CERAMIC CHIP 680PF

1-164-489-11 CERAMIC CHIP 0.22uF

25V

16V

Q903

8-729-904-75 TRANSISTOR DTD114EK-T-146

< RESISTOR >

10%

C990

C991

C992

C993

1-164-227-11 CERAMIC CHIP 0.022uF 10%

25V

16V

R900

R901

R902

R903

R904

1-216-819-11 METAL CHIP

1-216-037-00 METAL CHIP

1-216-846-11 METAL CHIP

1-216-851-11 METAL CHIP

1-216-037-00 METAL CHIP

680

330

120K

330K

330

1/16W

1/10W

1/16W

1/10W

1-107-826-11 CERAMIC CHIP 0.1uF

10%

< CONNECTOR >

R905

R910

R911

R912

R913

1-216-295-11 SHORT

470

100K

CN901 1-794-065-22 PLUG, CONNECTOR 14P

< DIODE >

1-216-821-11 METAL CHIP

1-216-857-11 METAL CHIP

1-216-817-11 METAL CHIP

1-216-845-11 METAL CHIP

1/16W

D900

8-719-078-81 DIODE DF5A6.8FU(TE85R)

CDX-CA850/CA850X/CA860X

KEY LIMIT LOAD

MAIN

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

R914

R915

R916

R917

R918

1-216-845-11 METAL CHIP

100K

1/16W

A-3283-144-A MAIN BOARD, COMPLETE (CA850)

A-3283-145-A MAIN BOARD, COMPLETE (CA860X)

A-3283-146-A MAIN BOARD, COMPLETE (CA850X)

*********************

1-790-355-53 CORD (WITH CONNECTOR) (RCA)

R919

R921

R922

R923

R924

1-216-797-11 METAL CHIP

1-216-029-00 METAL CHIP

1/16W

1/10W

(SUB OUT (MONO))

150

3-040-998-01 BRACKET (IC)

3-223-780-01 HEAT SINK (CA850)

3-223-780-21 HEAT SINK (CA850X/CA860X)

3-223-783-21 CHASSIS (BACK)

R971

R972

R973

R974

R979

1-216-029-00 METAL CHIP

1-216-027-00 METAL CHIP

1-216-029-00 METAL CHIP

1-216-027-00 METAL CHIP

1-216-041-00 METAL CHIP

150

120

150

120

470

1/10W

3-223-785-01 HEAT SINK (REG/D)

7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S

7-685-790-01 SCREW +PTT 2.6X4 (S)

7-685-793-09 SCREW +PTT 2.6X8 (S)

7-685-794-09 SCREW +PTT 2.6X10 (S)

R980

R981

R982

R983

R984

1-216-029-00 METAL CHIP

1-216-857-11 METAL CHIP

1-216-821-11 METAL CHIP

150

1/10W

1/16W

7-685-797-09 SCREW +PTT 2.6X16 (S)

< CAPACITOR >

C102

C103

C106

C107

C108

1-127-573-11 CERAMIC CHIP 1uF

10%

20%

16V

25V

16V

1-124-259-11 ELECT

4.7uF

R985

R986

R987

R988

R990

1-216-821-11 METAL CHIP

1-216-841-11 METAL CHIP

1-216-029-00 METAL CHIP

1-216-041-00 METAL CHIP

47K

150

470

1/16W

1/10W

1-164-156-11 CERAMIC CHIP 0.1uF

1-126-936-11 ELECT

3300uF

20%

C201

C202

C203

C204

C205

1-162-918-11 CERAMIC CHIP 18PF

1-162-968-11 CERAMIC CHIP 0.0047uF 10%

50V

16V

25V

6.3V

R991

R992

R993

R994

1-216-829-11 METAL CHIP

4.7K

1/16W

1-124-589-11 ELECT

1-164-156-11 CERAMIC CHIP 0.1uF

1-126-154-11 ELECT 47uF

47uF

20%

C206

C207

C208

C209

C210

1-162-964-11 CERAMIC CHIP 0.001uF 10%

1-164-156-11 CERAMIC CHIP 0.1uF

50V

(CA850)

25V

(CA850)

50V

(CA850)

50V

(CA850)

50V

< VIBRATOR >

X910

1-781-646-21 VIBRATOR, CERAMIC (4MHz)

*************************************************************

1-162-920-11 CERAMIC CHIP 27PF

1-164-315-11 CERAMIC CHIP 470PF

1-659-835-11 LIMIT BOARD

***********

< SWITCH >

(CA850)

SW3

1-572-688-11 SWITCH, PUSH (1 KEY) (LIMIT)

C211

C212

C213

C214

C215

1-107-826-11 CERAMIC CHIP 0.1uF

10%

16V

(CA850)

50V

(CA850)

50V

(CA850)

6.3V

(CA850)

50V

*************************************************************

1-162-966-11 CERAMIC CHIP 0.0022uF 10%

1-659-837-11 LOAD BOARD

*********

1-164-739-11 CERAMIC CHIP 560PF

1-135-834-11 CERAMIC CHIP 2.2uF

1-162-959-11 CERAMIC CHIP 330PF

< SWITCH >

SW4

1-572-288-21 SWITCH, PUSH (DOWN)

*************************************************************

(CA850)

C216

C217

C218

1-164-156-11 CERAMIC CHIP 0.1uF

25V

(CA850)

50V

(CA850)

50V

1-162-964-11 CERAMIC CHIP 0.001uF 10%

(CA850)

CDX-CA850/CA850X/CA860X

MAIN

Ref. No.

C219

Part No.

Description

Remark

Ref. No.

C332

Part No.

Description

Remark

1-162-964-11 CERAMIC CHIP 0.001uF 10%

50V

1-164-156-11 CERAMIC CHIP 0.1uF

25V

(CA850)

16V

(CA850)

50V

(CA850)

(CA860X)

50V

(CA860X)

10V

(CA860X)

16V

C220

C221

C222

C223

1-107-826-11 CERAMIC CHIP 0.1uF

1-164-315-11 CERAMIC CHIP 470PF

1-162-915-11 CERAMIC CHIP 10PF

1-125-891-11 CERAMIC CHIP 0.47uF

10%

C333

C334

1-162-919-11 CERAMIC CHIP 22PF

1-124-584-00 ELECT

100uF

10uF

20%

0.5PF 50V

(CA850)

10V

C335

C336

1-124-779-00 ELECT CHIP

20%

1-162-927-11 CERAMIC CHIP 100PF

50V

10%

(CA850)

C337

C338

C339

C340

C341

1-124-779-00 ELECT CHIP

1-162-927-11 CERAMIC CHIP 100PF

1-124-779-00 ELECT CHIP 10uF

1-162-927-11 CERAMIC CHIP 100PF

1-124-779-00 ELECT CHIP 10uF

10uF

20%

16V

50V

16V

50V

16V

C224

C225

1-165-176-11 CERAMIC CHIP 0.047uF 10%

16V

(CA850)

10V

1-126-785-11 ELECT

47uF

20%

(CA850)

25V

(CA850)

C226

C227

C228

1-164-156-11 CERAMIC CHIP 0.1uF

C342

C343

C344

C345

C346

1-162-927-11 CERAMIC CHIP 100PF

50V

16V

50V

1-126-157-11 ELECT

1-104-942-11 ELECT

10uF

1uF

20%

1-162-927-11 CERAMIC CHIP 100PF

C229

C302

C303

C304

C305

1-125-837-11 CERAMIC CHIP 1uF

1-162-970-11 CERAMIC CHIP 0.01uF

1-125-891-11 CERAMIC CHIP 0.47uF

1-162-968-11 CERAMIC CHIP 0.0047uF 10%

1-125-837-11 CERAMIC CHIP 1uF 10%

10%

6.3V

25V

10V

50V

6.3V

C347

C349

1-124-589-11 ELECT

1-126-157-11 ELECT

47uF

10uF

20%

16V

(CA860X)

10V

(CA860X)

10V

C350

C351

1-115-467-11 CERAMIC CHIP 0.22uF

1-125-891-11 CERAMIC CHIP 0.47uF

1-115-467-11 CERAMIC CHIP 0.22uF

10%

C306

C307

C308

C309

C310

1-165-176-11 CERAMIC CHIP 0.047uF 10%

1-162-970-11 CERAMIC CHIP 0.01uF

16V

25V

50V

10%

(CA850/CA850X)

10%

20%

1-126-193-11 ELECT CHIP

1uF

10V

(CA860X)

C351

C352

C353

1-125-891-11 CERAMIC CHIP 0.47uF

1-115-467-11 CERAMIC CHIP 0.22uF

1-125-891-11 CERAMIC CHIP 0.47uF

1-115-467-11 CERAMIC CHIP 0.22uF

1-125-891-11 CERAMIC CHIP 0.47uF

10%

(CA850/CA850X)

10%

10V

C311

C312

C313

C314

C315

1-104-942-11 ELECT

1-136-154-00 FILM

1-162-965-11 CERAMIC CHIP 0.0015uF 10%

1-136-154-00 FILM 0.012uF 5%

1-162-965-11 CERAMIC CHIP 0.0015uF 10%

1uF

20%

50V

0.012uF 5%

10V

(CA860X)

10V

10%

(CA850/CA850X)

10%

10V

(CA860X)

10V

C316

C317

1-126-157-11 ELECT

1-127-573-11 CERAMIC CHIP 1uF

10uF

20%

10%

16V

10%

(CA860X)

25V

(CA860X)

16V

(CA860X)

10V

(CA850/CA850X)

C318

C319

C320

1-164-156-11 CERAMIC CHIP 0.1uF

C354

1-165-176-11 CERAMIC CHIP 0.047uF 10%

16V

1-126-157-11 ELECT

1-124-584-00 ELECT

10uF

20%

(CA860X)

50V

C356

C357

C358

1-162-927-11 CERAMIC CHIP 100PF

100uF

50V

(CA860X)

1-124-589-11 ELECT

47uF

20%

16V

(CA860X)

16V

(CA850/CA850X)

C321

C322

C323

C324

C325

1-162-919-11 CERAMIC CHIP 22PF

1-127-573-11 CERAMIC CHIP 1uF

1-164-156-11 CERAMIC CHIP 0.1uF

50V

(CA860X)

16V

(CA860X)

25V

(CA860X)

10V

(CA860X)

50V

C358

1-126-157-11 ELECT

10uF

20%

10%

C359

C360

C364

C365

1-164-156-11 CERAMIC CHIP 0.1uF

1-125-837-11 CERAMIC CHIP 1uF

25V

6.3V

(CA860X)

50V

1-124-584-00 ELECT

100uF

20%

10%

1-162-919-11 CERAMIC CHIP 22PF

1-127-573-11 CERAMIC CHIP 1uF

C365

1-162-964-11 CERAMIC CHIP 0.001uF 10%

(CA860X)

(CA850/CA850X)

C326

10%

16V

(CA860X)

10V

16V

(CA860X)

10V

(CA860X)

50V

(CA860X)

C368

C373

C374

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-927-11 CERAMIC CHIP 100PF

1-162-966-11 CERAMIC CHIP 0.0022uF 10%

25V

(CA860X)

50V

(CA860X)

50V

C327

C328

1-126-785-11 ELECT

1-126-157-11 ELECT

47uF

10uF

20%

C329

C330

1-124-584-00 ELECT

100uF

20%

(CA850/CA850X)

1-162-927-11 CERAMIC CHIP 100PF

50V

(CA860X)

50V

1-162-919-11 CERAMIC CHIP 22PF

1-162-966-11 CERAMIC CHIP 0.0022uF 10%

(CA850/CA850X)

C331

1-127-573-11 CERAMIC CHIP 1uF

10%

16V

(CA860X)

C375

1-162-927-11 CERAMIC CHIP 100PF

50V

(CA860X)

CDX-CA850/CA850X/CA860X

MAIN

Ref. No.

C375

Part No.

Description

Remark

50V

(CA850/CA850X)

Ref. No.

Part No.

Description

Remark

1-162-966-11 CERAMIC CHIP 0.0022uF 10%

C416

C501

C503

C504

C505

1-162-964-11 CERAMIC CHIP 0.001uF 10%

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-968-11 CERAMIC CHIP 0.0047uF 10%

50V

25V

50V

(CA850)

C376

C377

1-162-927-11 CERAMIC CHIP 100PF

50V

(CA860X)

50V

1-162-966-11 CERAMIC CHIP 0.0022uF 10%

(CA850/CA850X)

1-162-927-11 CERAMIC CHIP 100PF

50V

(CA860X)

50V

C505

1-165-176-11 CERAMIC CHIP 0.047uF 10%

16V

1-162-966-11 CERAMIC CHIP 0.0022uF 10%

(CA850X/CA860X)

25V

(CA850/CA850X)

C506

C507

C508

C509

1-164-156-11 CERAMIC CHIP 0.1uF

1-164-315-11 CERAMIC CHIP 470PF

1-164-230-11 CERAMIC CHIP 220PF

1-162-921-11 CERAMIC CHIP 33PF

50V

C378

C379

1-164-227-11 CERAMIC CHIP 0.022uF 10%

25V

6.3V

(CA860X)

6.3V

(CA860X)

6.3V

(CA860X)

6.3V

1-125-837-11 CERAMIC CHIP 1uF

10%

C380

C381

C382

C510

C511

C512

C513

C514

1-162-917-11 CERAMIC CHIP 15PF

50V

6.3V

25V

50V

1-162-964-11 CERAMIC CHIP 0.001uF 10%

1-135-834-11 CERAMIC CHIP 2.2uF

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-927-11 CERAMIC CHIP 100PF

(CA860X)

(CA850)

C383

C384

1-164-156-11 CERAMIC CHIP 0.1uF

25V

(CA860X)

25V

(CA860X)

10V

50V

(CA860X)

50V

C515

C516

C518

C519

C520

1-162-974-11 CERAMIC CHIP 0.01uF

1-164-156-11 CERAMIC CHIP 0.1uF

50V

25V

10V

5.5V

1-107-877-11 ELECT

1000uF

20%

C385

C386

1-125-889-11 CERAMIC CHIP 2.2uF

1-162-919-11 CERAMIC CHIP 22PF

10%

1-125-701-11 DOUBLE LAYERS 0.047F

C521

C522

C601

C602

C603

1-124-584-00 ELECT

100uF

10V

25V

50V

6.3V

50V

C386

1-162-964-11 CERAMIC CHIP 0.001uF 10%

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-974-11 CERAMIC CHIP 0.01uF

1-125-837-11 CERAMIC CHIP 1uF

1-162-927-11 CERAMIC CHIP 100PF

(CA850/CA850X)

10%

C387

C388

C389

1-162-919-11 CERAMIC CHIP 22PF

50V

(CA860X)

50V

1-162-964-11 CERAMIC CHIP 0.001uF 10%

C604

C701

C702

C703

C704

1-104-653-11 ELECT

220uF

20%

16V

50V

25V

(CA850/CA850X)

1-162-964-11 CERAMIC CHIP 0.001uF 10%

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-919-11 CERAMIC CHIP 22PF

50V

(CA860X)

50V

1-162-964-11 CERAMIC CHIP 0.001uF 10%

(CA850/CA850X)

1-162-919-11 CERAMIC CHIP 22PF

50V

(CA860X)

C705

C706

C707

C708

C709

1-164-156-11 CERAMIC CHIP 0.1uF

1-107-826-11 CERAMIC CHIP 0.1uF

1-126-205-11 ELECT CHIP 47uF

25V

16V

6.3V

16V

10%

20%

10%

C389

C390

C391

C392

C393

1-162-964-11 CERAMIC CHIP 0.001uF 10%

50V

(CA850/CA850X)

1-107-826-11 CERAMIC CHIP 0.1uF

1-162-964-11 CERAMIC CHIP 0.001uF 10%

50V

(CA850)

6.3V

(CA860X)

25V

C710

C711

C712

C713

C714

1-162-974-11 CERAMIC CHIP 0.01uF

1-162-970-11 CERAMIC CHIP 0.01uF

50V

25V

50V

25V

50V

1-125-837-11 CERAMIC CHIP 1uF

1-164-156-11 CERAMIC CHIP 0.1uF

1-127-715-11 CERAMIC CHIP 0.22uF

10%

20%

10%

1-126-401-21 ELECT CHIP

1uF

1-162-970-11 CERAMIC CHIP 0.01uF

1-162-964-11 CERAMIC CHIP 0.001uF 10%

(CA860X)

16V

10%

C715

C716

C717

C718

C722

1-164-156-11 CERAMIC CHIP 0.1uF

1-162-927-11 CERAMIC CHIP 100PF

1-162-974-11 CERAMIC CHIP 0.01uF

25V

50V

C394

C401

C402

C403

C404

1-127-715-11 CERAMIC CHIP 0.22uF

1-107-826-11 CERAMIC CHIP 0.1uF

1-162-961-11 CERAMIC CHIP 330PF

10%

20%

16V

50V

6.3V

16V

1-126-154-11 ELECT

47uF

1-165-128-11 CERAMIC CHIP 0.22uF

C723

C801

C802

C803

C804

1-162-974-11 CERAMIC CHIP 0.01uF

50V

10V

C405

C406

C407

C408

C410

1-126-154-11 ELECT

1-126-176-11 ELECT

1-128-057-11 ELECT

1-107-826-11 CERAMIC CHIP 0.1uF

1-162-923-11 CERAMIC CHIP 47PF

47uF

220uF

330uF

20%

10%

6.3V

10V

6.3V

16V

1-128-526-11 ELECT

100uF

20%

10%

1-125-891-11 CERAMIC CHIP 0.47uF

C805

C806

1-124-589-11 ELECT

1-126-154-11 ELECT

47uF

20%

16V

(CA860X)

6.3V

C411

C412

50V

(CA850)

50V

(CA860X)

(CA850)

50V

C413

C414

C415

1-162-964-11 CERAMIC CHIP 0.001uF 10%

< CONNECTOR >

50V

CN101 1-774-701-11 PIN, CONNECTOR 16P

* CN301 1-564-506-11 PLUG, CONNECTOR 3P

CDX-CA850/CA850X/CA860X

MAIN

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

CN401 1-764-617-12 PIN, CONNECTOR (PC BOARD) 30P

CN601 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)

CN701 1-784-456-11 CONNECTOR, FFC/FPC 14P

FB403 1-414-235-22 INDUCTOR, FERRITE BEAD (CA850)

FB501 1-414-235-22 INDUCTOR, FERRITE BEAD

FB701 1-414-235-22 INDUCTOR, FERRITE BEAD

< JACK >

< IC >

CN201 1-815-185-11 JACK (ANTENNA)

CN302 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,AUDIO OUT)

8-759-492-59 IC SAA6588T/V2-118 (CA850)

8-759-909-71 IC BA4558F-E2 (CA850)

8-759-827-13 IC TDA7406T

8-759-826-90 IC NJM2160AV-TE2 (CA860X)

< DIODE >

D101

D102

D105

D106

D107

8-719-049-38 DIODE 1N5404TU

8-719-017-58 DIODE MA8068

8-719-073-01 DIODE MA111-(K8).S0

8-719-053-18 DIODE 1SR154-400TE-25

8-759-832-29 IC NJM4580M-(TE2)

8-759-100-96 IC uPC4558G2 (CA860X)

8-759-198-34 IC TA75S558F(TE85R) (CA860X)

D110

D202

D203

D204

D301

8-719-975-40 DIODE RB411D-T146 (CA860X)

8-719-073-01 DIODE MA111-(K8).S0

8-719-422-41 DIODE MA8051-L-TX

8-719-800-76 DIODE 1SS226 (CA850)

8-719-200-82 DIODE 11ES2

IC351

IC501

8-759-660-96 IC TDA7560 (CA860X)

8-759-827-14 IC TA8268AH (CA850/CA850X)

6-800-243-01 IC MB90574BPMT-G-335-BND (CA850)

8-759-837-48 IC MB90574BPMT-G-323-BND

(CA850X/CA860X)

D302

D303

D304

D305

D306

8-719-200-82 DIODE 11ES2

8-719-053-18 DIODE 1SR154-400TE-25

8-719-200-82 DIODE 11ES2

IC502

8-759-828-22 IC XC61CN4102MR

8-759-449-89 IC BA8270F-E2

6-800-141-01 IC HD6432355A37F

8-759-277-63 IC TC7W14FU(TE12R)

8-759-460-80 IC BA10FP-E2 (CA860X)

D307

D308

D310

D311

D401

8-719-200-82 DIODE 11ES2

8-719-801-78 DIODE 1SS184

8-719-073-01 DIODE MA111-(K8).S0

8-719-017-67 DIODE MA8068-H

< JACK >

1-566-822-41 JACK (REMOTE IN) (CA850)

< COIL >

J651

D402

D501

D503

D504

D505

8-719-422-64 DIODE MA8062-M

8-719-801-78 DIODE 1SS184

8-719-977-03 DIODE DTZ5.6B

8-719-073-01 DIODE MA111-(K8).S0

8-719-422-41 DIODE MA8051-L-TX (CA850)

L101

L201

L202

1-419-476-11 COIL, CHOKE

1-216-864-11 SHORT

1-216-296-11 SHORT

250uH

< TRANSISTOR >

D601

D603

D604

D605

D606

8-719-073-01 DIODE MA111-(K8).S0

8-719-017-94 DIODE MA8180

8-719-420-51 DIODE MA729

8-719-018-01 DIODE MA8220-TX

Q101

Q102

Q103

Q104

Q105

8-729-120-28 TRANSISTOR 2SC1623-L5L6

8-729-049-13 TRANSISTOR UPA1853GR-9JG-E1

8-729-421-22 TRANSISTOR UN2211

D607

D608

D609

D610

D653

8-719-801-78 DIODE 1SS184

8-719-073-01 DIODE MA111-(K8).S0

8-719-422-64 DIODE MA8062-M

8-719-073-01 DIODE MA111-(K8).S0

8-719-820-05 DIODE 1SS181

Q106

Q201

Q202

Q204

Q205

8-729-421-22 TRANSISTOR UN2211

8-729-106-60 TRANSISTOR 2SB1115A-YQ

8-729-421-22 TRANSISTOR UN2211

8-729-120-28 TRANSISTOR 2SC1623-L5L6 (CA850)

8-729-421-22 TRANSISTOR UN2211 (CA850)

D703

D707

D708

D715

D801

8-719-018-01 DIODE MA8220-TX

8-719-017-58 DIODE MA8068

8-719-018-01 DIODE MA8220-TX

8-719-801-78 DIODE 1SS184

8-719-420-14 DIODE MA8082-M

Q207

Q303

Q304

Q306

8-729-920-85 TRANSISTOR 2SD1664-QR

8-729-421-22 TRANSISTOR UN2211

8-729-424-08 TRANSISTOR UN2111

8-729-021-95 TRANSISTOR RN1441-A(TE85L) (CA860X)

8-729-920-21 TRANSISTOR DTC314TKH04 (CA850/CA850X)

D802

8-719-420-92 DIODE MA8051-M-TX

< FERRITE BEAD >

Q307

Q308

Q309

8-729-021-95 TRANSISTOR RN1441-A(TE85L) (CA860X)

8-729-920-21 TRANSISTOR DTC314TKH04 (CA850/CA850X)

8-729-021-95 TRANSISTOR RN1441-A(TE85L) (CA860X)

8-729-920-21 TRANSISTOR DTC314TKH04 (CA850/CA850X)

8-729-021-95 TRANSISTOR RN1441-A(TE85L) (CA860X)

FB201 1-414-235-22 INDUCTOR, FERRITE BEAD (CA850)

FB301 1-414-235-22 INDUCTOR, FERRITE BEAD

FB401 1-414-235-22 INDUCTOR, FERRITE BEAD

FB402 1-414-235-22 INDUCTOR, FERRITE BEAD

Q309

8-729-920-21 TRANSISTOR DTC314TKH04 (CA850/CA850X)

FB403 1-414-234-22 INDUCTOR, FERRITE BEAD (CA850X/CA860X)

CDX-CA850/CA850X/CA860X

MAIN

Ref. No.

Part No.

Description

Remark

Ref. No.

R210

Part No.

Description

Remark

Q310

Q401

Q402

Q403

Q405

8-729-920-21 TRANSISTOR DTC314TKH04

8-729-021-82 TRANSISTOR 2SD2396K

8-729-421-22 TRANSISTOR UN2211

8-729-424-08 TRANSISTOR UN2111

8-729-421-22 TRANSISTOR UN2211

1-216-853-11 METAL CHIP

1-216-797-11 METAL CHIP

1-216-825-11 METAL CHIP

1-216-857-11 METAL CHIP

470K

1/16W

(CA850)

1/16W

(CA850)

1/16W

(CA850)

1/16W

(CA850)

1/16W

R211

R212

R213

R214

2.2K

Q406

Q407

Q501

Q602

Q603

8-729-920-85 TRANSISTOR 2SD1664-QR

8-729-424-08 TRANSISTOR UN2111-TX

8-729-040-17 TRANSISTOR 2SD2164-K

8-729-421-22 TRANSISTOR UN2211

8-729-424-18 TRANSISTOR UN2113

(CA850)

R215

R216

R217

R218

R219

1-216-809-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-809-11 METAL CHIP

1-216-845-11 METAL CHIP

100

10K

100

100K

1/16W

(CA850)

1/16W

(CA850)

1/16W

(CA850)

1/16W

(CA850)

1/16W

(CA850)

Q701

Q702

Q703

Q705

Q706

8-729-424-08 TRANSISTOR UN2111

8-729-106-60 TRANSISTOR 2SB1115A-YQ

8-729-120-28 TRANSISTOR 2SC1623-L5L6

8-729-026-49 TRANSISTOR 2SA1037AK-T146-R

8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q801

Q802

Q803

8-729-024-95 TRANSISTOR 2SB1565EF

8-729-120-28 TRANSISTOR 2SC1623-L5L6

< RESISTOR >

R220

1-216-825-11 METAL CHIP

2.2K

1/16W

(CA850)

1/16W

R101

R102

R103

R104

R105

1-216-821-11 METAL CHIP

1-216-073-00 METAL CHIP

1-216-821-11 METAL CHIP

1-216-841-11 METAL CHIP

1/16W

1/10W

1/16W

R221

R222

1-216-841-11 METAL CHIP

1-216-809-11 METAL CHIP

47K

100

10K

(CA850)

(CA850X/CA860X)

R222

R223

1-216-864-11 SHORT

1-216-809-11 METAL CHIP

100

47K

1/16W

(CA850)

R106

R107

R108

R109

R110

1-216-829-11 METAL CHIP

1-216-841-11 METAL CHIP

1-216-829-11 METAL CHIP

1-216-845-11 METAL CHIP

4.7K

47K

4.7K

100K

1/16W

R223

R301

R302

R303

R304

1-216-864-11 SHORT

(CA850X/CA860X)

1-216-841-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-833-11 METAL CHIP

47K

100K

10K

1/16W

R111

R113

R114

R115

R116

1-216-837-11 METAL CHIP

1-216-833-11 METAL CHIP

22K

10K

1/16W

R305

R306

R307

R308

R309

1-216-833-11 METAL CHIP

10K

1/16W

R117

R118

R125

R130

R131

1-216-833-11 METAL CHIP

1-216-841-11 METAL CHIP

1-216-073-00 METAL CHIP

10K

47K

10K

1/16W

1/10W

R310

R311

1-216-833-11 METAL CHIP

1-216-845-11 METAL CHIP

10K

100K

1/16W

(CA860X)

R312

R313

R314

1-216-833-11 METAL CHIP

1-216-864-11 SHORT

1-216-833-11 METAL CHIP

10K

1/16W

(CA850/CA850X)

R201

R202

R203

R204

R205

1-216-797-11 METAL CHIP

1-216-831-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-829-11 METAL CHIP

1-216-817-11 METAL CHIP

1/16W

6.8K

10K

4.7K

470

R315

R316

R317

R318

R319

1-216-797-11 METAL CHIP

1-216-817-11 METAL CHIP

1-216-839-11 METAL CHIP

1-216-837-11 METAL CHIP

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

470

33K

22K

R206

R207

R208

R209

1-216-817-11 METAL CHIP

1-216-797-11 METAL CHIP

1-216-832-11 METAL CHIP

1-216-821-11 METAL CHIP

470

1/16W

(CA850)

1/16W

(CA850)

1/16W

8.2K

(CA850)

1/16W

(CA850)

R320

1-216-817-11 METAL CHIP

470

1/16W

(CA860X)

CDX-CA850/CA850X/CA860X

MAIN

Ref. No.

R321

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

1-216-797-11 METAL CHIP

1-216-839-11 METAL CHIP

1-216-797-11 METAL CHIP

1-216-817-11 METAL CHIP

1-216-839-11 METAL CHIP

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

R368

R369

R370

1-216-805-11 METAL CHIP

1-216-821-11 METAL CHIP

1-216-833-11 METAL CHIP

10K

1/16W

(CA860X)

1/16W

R322

R323

R324

R325

33K

R370

R372

1-216-841-11 METAL CHIP

1-216-801-11 METAL CHIP

47K

(CA850/CA850X)

470

33K

1/16W

(CA860X)

R372

1-216-831-11 METAL CHIP

6.8K

1/16W

(CA850/CA850X)

R326

R327

R328

R329

R330

1-216-837-11 METAL CHIP

1-216-817-11 METAL CHIP

1-216-797-11 METAL CHIP

1-216-839-11 METAL CHIP

22K

470

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

R373

R375

R376

R377

1-216-833-11 METAL CHIP

1-216-813-11 METAL CHIP

10K

220

1/16W

R378

R379

R380

R381

R382

1-216-813-11 METAL CHIP

1-216-864-11 SHORT

220

1/16W

33K

R331

R332

R333

R334

R335

1-216-821-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-821-11 METAL CHIP

1-216-813-11 METAL CHIP

1/16W

(CA860X)

R383

1-216-835-11 METAL CHIP

15K

1/16W

(CA860X)

10K

R383

R384

1-216-864-11 SHORT

1-216-835-11 METAL CHIP

15K

(CA850/CA850X)

1/16W

(CA860X)

220

R384

R385

1-216-864-11 SHORT

1-216-835-11 METAL CHIP

15K

(CA850/CA850X)

1/16W

R335

R336

1-216-864-11 SHORT

1-216-841-11 METAL CHIP

47K

(CA850/CA850X)

(CA860X)

1/16W

(CA850/CA850X)

R385

R386

1-216-864-11 SHORT

1-216-835-11 METAL CHIP

15K

(CA850/CA850X)

R337

1-216-813-11 METAL CHIP

220

1/16W

(CA860X)

1/16W

(CA860X)

R337

R338

1-216-864-11 SHORT

1-216-841-11 METAL CHIP

47K

(CA850/CA850X)

R386

R387

1-216-864-11 SHORT

1-216-833-11 METAL CHIP

10K

(CA850/CA850X)

1/16W

(CA850/CA850X)

(CA860X)

R388

1-216-825-11 METAL CHIP

2.2K

1/16W

R339

1-216-813-11 METAL CHIP

220

1/16W

(CA860X)

R339

R340

1-216-864-11 SHORT

1-216-841-11 METAL CHIP

47K

(CA850/CA850X)

R389

R390

R391

R392

R393

1-216-833-11 METAL CHIP

1-216-825-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-825-11 METAL CHIP

1-216-833-11 METAL CHIP

10K

2.2K

10K

2.2K

10K

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA850/CA850X)

R341

R342

1-216-813-11 METAL CHIP

1-216-864-11 SHORT

220

1/16W

(CA860X)

(CA850/CA850X)

1-216-841-11 METAL CHIP

47K

1/16W

(CA850/CA850X)

R343

R344

R345

R346

1-216-864-11 SHORT

1-216-841-11 METAL CHIP

1-216-864-11 SHORT

47K

(CA860X)

1/16W

(CA850/CA850X)

R394

R395

R396

R397

R398

1-216-825-11 METAL CHIP

1-216-845-11 METAL CHIP

2.2K

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

100K

R347

R348

R357

R358

R359

1-216-864-11 SHORT

(CA850/CA850X)

R360

R364

R365

1-216-864-11 SHORT

1-216-829-11 METAL CHIP

1-216-864-11 SHORT

4.7K

(CA850/CA850X)

(CA860X)

1/16W

(CA850/CA850X)

CDX-CA850/CA850X/CA860X

MAIN

Ref. No.

R399

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

1/16W

1-216-837-11 METAL CHIP

22K

10K

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

R533

R534

R535

R536

R539

1-216-864-11 SHORT

1-216-845-11 METAL CHIP

R400

1-216-833-11 METAL CHIP

R401

R402

R403

1-216-825-11 METAL CHIP

2.2K

100K

1/16W

R540

R541

R601

R604

R605

1-216-864-11 SHORT

1-216-821-11 METAL CHIP

1-216-809-11 METAL CHIP

1-216-821-11 METAL CHIP

1-216-809-11 METAL CHIP

100

1/16W

R405

R406

R407

R408

R410

1-216-864-11 SHORT

1-216-793-11 RES-CHIP

1-216-805-11 METAL CHIP

1-216-797-11 METAL CHIP

1-216-801-11 METAL CHIP

4.7

1/16W

R607

R652

R653

R654

1-216-835-11 METAL CHIP

1-218-871-11 METAL CHIP

1-216-809-11 METAL CHIP

15K

10K

100

1/16W

0.5% 1/16W

R417

R422

1-216-825-11 METAL CHIP

1-216-839-11 METAL CHIP

2.2K

33K

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA860X)

1/16W

(CA850)

1/16W

R423

R424

R425

1-216-839-11 METAL CHIP

33K

R702

1-216-809-11 METAL CHIP

100

R703

R704

R705

R706

R707

1-216-845-11 METAL CHIP

1-216-864-11 SHORT

1-216-809-11 METAL CHIP

1-216-845-11 METAL CHIP

100K

100

100K

1/16W

R426

R427

R428

R429

R430

1-216-821-11 METAL CHIP

1-216-864-11 SHORT

1/16W

R708

R709

R711

R712

R713

1-216-845-11 METAL CHIP

1-216-037-00 METAL CHIP

1-216-829-11 METAL CHIP

1-216-825-11 METAL CHIP

100K

330

4.7K

2.2K

1/16W

1/10W

1/16W

R501

R503

1-216-845-11 METAL CHIP

100K

1/16W

(CA860X)

1/16W

(CA850)

1/16W

R714

R715

R716

R717

R718

1-216-813-11 METAL CHIP

1-216-809-11 METAL CHIP

220

100

1/16W

R504

R505

R506

1-216-845-11 METAL CHIP

1-216-864-11 SHORT

1-216-837-11 METAL CHIP

100K

22K

R507

R508

R509

R510

R511

1-216-845-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-841-11 METAL CHIP

1-216-809-11 METAL CHIP

100K

10K

47K

100

1/16W

R719

R720

R721

R724

R728

1-216-821-11 METAL CHIP

1-218-871-11 METAL CHIP

1-216-845-11 METAL CHIP

1/16W

10K

100K

0.5% 1/16W

1/16W

R512

R513

R514

R515

R516

1-216-845-11 METAL CHIP

1-216-829-11 METAL CHIP

1-216-813-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-864-11 SHORT

100K

4.7K

220

100K

1/16W

R729

R731

R732

R733

R734

1-216-821-11 METAL CHIP

1-216-813-11 METAL CHIP

1-216-821-11 METAL CHIP

1-216-037-00 METAL CHIP

1-216-821-11 METAL CHIP

220

330

1/16W

1/10W

1/16W

R517

R520

R521

R522

R523

1-216-864-11 SHORT

1-216-809-11 METAL CHIP

1-216-845-11 METAL CHIP

(CA860X)

R735

R736

R737

R738

R739

1-216-821-11 METAL CHIP

1-216-829-11 METAL CHIP

4.7K

1/16W

100

100K

1/16W

R524

R525

R526

R527

R530

1-216-845-11 METAL CHIP

1-216-853-11 METAL CHIP

1-216-835-11 METAL CHIP

1-216-793-11 RES-CHIP

1-216-821-11 METAL CHIP

100K

470K

15K

4.7

1/16W

R740

R741

R742

R743

R744

1-216-829-11 METAL CHIP

1-216-037-00 METAL CHIP

1-216-833-11 METAL CHIP

1-216-821-11 METAL CHIP

4.7K

330

10K

1/16W

1/10W

1/16W

R531

R532

1-216-821-11 METAL CHIP

1-216-864-11 SHORT

1/16W

R745

1-216-005-00 METAL CHIP

1/10W

CDX-CA850/CA850X/CA860X

SERVO

MAIN

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

R746

R747

R748

R749

R750

1-216-005-00 METAL CHIP

1/10W

C304

C305

C306

C307

C308

1-164-227-11 CERAMIC CHIP 0.022uF 10%

1-162-965-11 CERAMIC CHIP 0.0015uF 10%

25V

50V

1-162-962-11 CERAMIC CHIP 470PF

10%

1-162-962-11 CERAMIC CHIP 470PF

10%

R801

R802

R803

R804

R805

1-216-829-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-821-11 METAL CHIP

1-216-817-11 METAL CHIP

1-216-825-11 METAL CHIP

4.7K

10K

470

2.2K

1/16W

C309

C310

C311

C312

C501

1-164-227-11 CERAMIC CHIP 0.022uF 10%

1-125-838-11 CERAMIC CHIP 2.2uF 10%

1-164-677-11 CERAMIC CHIP 0.033uF 10%

1-164-360-11 CERAMIC CHIP 0.1uF

25V

6.3V

16V

6.3V

1-126-391-11 ELECT CHIP

47uF

20%

R806

R813

1-216-864-11 SHORT

1-216-815-11 METAL CHIP

330

C502

C504

C505

C506

C507

1-162-965-11 CERAMIC CHIP 0.0015uF 10%

1-162-967-11 CERAMIC CHIP 0.0033uF 10%

1-165-176-11 CERAMIC CHIP 0.047uF 10%

50V

16V

1/16W

(CA860X)

1-107-823-11 CERAMIC CHIP 0.47uF

10%

< SWITCH >

1-107-826-11 CERAMIC CHIP 0.1uF

10%

S101

S102

1-692-431-21 SWITCH, TACTILE (RESET)

1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DET)

C508

C509

C510

C511

C512

1-164-230-11 CERAMIC CHIP 220PF

1-164-360-11 CERAMIC CHIP 0.1uF

1-164-217-11 CERAMIC CHIP 150PF

1-162-963-11 CERAMIC CHIP 680PF

50V

16V

50V

10%

< THERMISTOR (POSITIVE) >

TH101 1-810-940-11 THERMISTOR, POSITIVE

TH102 1-810-940-11 THERMISTOR, POSITIVE

TH601 1-801-792-21 THERMISTOR, POSITIVE

C513

C514

C515

C516

C517

1-162-963-11 CERAMIC CHIP 680PF

10%

20%

50V

6.3V

16V

50V

16V

1-126-391-11 ELECT CHIP

47uF

1-164-360-11 CERAMIC CHIP 0.1uF

1-162-974-11 CERAMIC CHIP 0.01uF

1-164-360-11 CERAMIC CHIP 0.1uF

< TUNER >

TUX201 A-3220-812-A TUNER UNIT (TUX-020)

< VIBRATOR >

C518

C519

C520

C521

C522

1-164-360-11 CERAMIC CHIP 0.1uF

16V

X201

X501

X502

X701

1-767-853-21 VIBRATOR, CRYSTAL (4.332MHz) (CA850)

1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)

1-767-833-21 VIBRATOR, CERAMIC (3.68MHz)

1-781-822-21 VIBRATOR, CERAMIC (18.432MHz)

C550

C553

C554

1-164-360-11 CERAMIC CHIP 0.1uF

16V

*************************************************************

A-3326-231-A SERVO BOARD, COMPLETE

**********************

< CONNECTOR >

< CAPACITOR >

CN1

CN2

CN3

1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P

1-794-153-21 CONNECTOR, FPC (ZIF) 16P

1-770-347-21 CONNECTOR, FPC 6P

C101

C103

C104

C106

C107

1-115-156-11 CERAMIC CHIP 1uF

1-104-609-11 ELECT CHIP

10V

100uF

20%

1-115-156-11 CERAMIC CHIP 1uF

1-107-826-11 CERAMIC CHIP 0.1uF

1-125-837-11 CERAMIC CHIP 1uF

10V

16V

6.3V

< JUMPER RESISTOR >

10%

FB101 1-216-295-11 SHORT

FB102 1-216-295-11 SHORT

FB503 1-216-295-11 SHORT

C108

C109

C111

C115

C116

1-162-974-11 CERAMIC CHIP 0.01uF

1-162-917-11 CERAMIC CHIP 15PF

1-115-156-11 CERAMIC CHIP 1uF

1-164-733-11 CERAMIC CHIP 820PF

1-165-128-11 CERAMIC CHIP 0.22uF

50V

10V

50V

16V

< IC >

10%

IC1

8-752-095-36 IC CXA2596M-T6

IC5

IC7

IC501

8-752-914-87 IC CXP84640-072Q

8-759-832-99 IC LA6576L-TE-L

8-752-392-04 IC CXD2598Q

C117

C118

C127

C301

C302

1-164-733-11 CERAMIC CHIP 820PF

1-164-360-11 CERAMIC CHIP 0.1uF

10%

50V

16V

10V

16V

1-104-851-11 TANTAL. CHIP

1-126-393-11 ELECT CHIP

10uF

33uF

20%

< JUMPER RESISTOR >

1-164-360-11 CERAMIC CHIP 0.1uF

JR501 1-216-295-11 SHORT

JR505 1-216-864-11 SHORT

C303

1-164-227-11 CERAMIC CHIP 0.022uF 10%

25V

CDX-CA850/CA850X/CA860X

SERVO SUB SUB (CD)

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

JR506 1-216-864-11 SHORT

R517

R518

R519

R520

R521

1-216-837-11 METAL CHIP

1-216-834-11 METAL CHIP

22K

12K

1/16W

< TRANSISTOR >

Q101

8-729-904-87 TRANSISTOR 2SB1197K-T-146-R

< RESISTOR >

R522

R523

R524

R526

R527

1-216-834-11 METAL CHIP

1-216-845-11 METAL CHIP

12K

100K

1/16W

R101

R102

R103

R104

R105

1-216-847-11 METAL CHIP

1-216-801-11 METAL CHIP

1-216-857-11 METAL CHIP

1-216-833-11 METAL CHIP

150K

10K

1/16W

R531

R532

R533

R535

R551

1-216-809-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-841-11 METAL CHIP

100

1/16W

100K

47K

R106

R107

R108

R109

R110

1-216-857-11 METAL CHIP

1-216-835-11 METAL CHIP

1-216-838-11 METAL CHIP

1-216-801-11 METAL CHIP

1-216-843-11 METAL CHIP

15K

27K

1/16W

68K

R552

R553

R554

R555

R558

1-216-841-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-864-11 SHORT

47K

100K

1/16W

R111

R113

R122

R123

R127

1-216-842-11 METAL CHIP

1-216-839-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-839-11 METAL CHIP

1-216-821-11 METAL CHIP

56K

33K

100K

33K

1/16W

R560

R563

R564

R568

R569

1-216-809-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-837-11 METAL CHIP

1-216-809-11 METAL CHIP

100

100K

22K

100

1/16W

R213

R301

R302

R303

R304

1-216-821-11 METAL CHIP

1-216-843-11 METAL CHIP

1-216-839-11 METAL CHIP

1-216-821-11 METAL CHIP

1-216-839-11 METAL CHIP

1/16W

68K

33K

R570

R572

R590

R594

R595

1-216-821-11 METAL CHIP

1-216-809-11 METAL CHIP

1-216-845-11 METAL CHIP

100

100K

1/16W

R306

R307

R308

R309

R310

1-216-833-11 METAL CHIP

10K

1/16W

R599

1-216-821-11 METAL CHIP

< VIBRATOR >

1/16W

R311

R312

R313

R314

R315

1-216-833-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-842-11 METAL CHIP

10K

100K

56K

1/16W

1-781-758-21 VIBRATOR, CERAMIC (CHIP TYPE) (10MHz)

1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16MHz)

*************************************************************

R316

R317

R318

R319

R320

1-216-842-11 METAL CHIP

1-216-838-11 METAL CHIP

1-216-842-11 METAL CHIP

1-216-833-11 METAL CHIP

56K

27K

56K

10K

1/16W

1-659-834-11 SUB BOARD

**********

< CONNECTOR >

CN1

1-770-347-21 CONNECTOR, FPC 6P

R321

R322

R501

R503

R504

1-216-846-11 METAL CHIP

1-216-835-11 METAL CHIP

1-216-833-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-857-11 METAL CHIP

120K

15K

10K

100K

1/16W

*************************************************************

1-680-868-11 SUB (CD) BOARD

**************

1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE)

3-039-443-11 SHEET (CONNECTOR)

R505

R506

R507

R511

R513

1-216-839-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-827-11 METAL CHIP

1-216-845-11 METAL CHIP

1-216-827-11 METAL CHIP

33K

1/16W

100K

3.3K

100K

3.3K

< CAPACITOR >

C852

C853

1-162-960-11 CERAMIC CHIP 220PF

10%

50V

R516

1-216-845-11 METAL CHIP

100K

1/16W

CDX-CA850/CA850X/CA860X

SUB (CD)

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

< CONNECTOR >

**************

HARDWARE LIST

**************

CN852 1-794-064-12 SOCKET, CONNECTOR 14P

< DIODE >

7-685-790-01 SCREW +PTT 2.6X4 (S)

7-685-792-09 SCREW +PTT 2.6X6 (S)

7-621-772-20 SCREW +B 2X5

7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S

7-685-794-09 SCREW +PTT 2.6X10 (S)

D851

D852

8-719-078-81 DIODE DF5A6.8FU(TE85R)

LED851 8-719-082-38 LED CL-270SR-C-TS (INSERT MARK)

< SWITCH >

LSW851 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z)

< RESISTOR >

#10

7-685-793-09 SCREW +PTT 2.6X8 (S)

7-685-797-09 SCREW +PTT 2.6X16 (S)

7-685-105-19 SCREW +P 2X8 TYPE2 NON-SLIT

7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3

7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3

R855

R856

1-219-286-11 METAL CHIP

680

1/16W

#11

#12

#13

7-628-253-00 SCREW +PS 2X4

7-627-850-28 SCREW, PRECISION +P 1.4X3

7-628-253-15 SCREW +PS 2X5

*************************************************************

MISCELLANEOUS

***************

PARTS FOR INSTALLATION AND CONNECTIONS

***************************************

1-776-207-72 CORD (WITH CONNECTOR) (POWER)

(CA850X/CA860X)

1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)

(CA850)

1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE)

X-3378-598-1 CHASSIS (OP) ASSY (including M901)

1-659-880-11 MOTOR FLEXIBLE BOARD

251

252

253

254

255

X-3373-602-1 FRAME ASSY

3-386-828-01 SCREW, FITTING (CA850)

3-349-410-01 BUSHING (CA850)

X-3366-405-1 SCREW ASSY (EXP), FITTING (CA850)

3-924-961-01 SUPPORT (ND), FITTING (CA850X/CA860X)

201

207

256

257

258

259

260

7-682-160-01 SCREW +P 4X6 (CA850X/CA860X)

X-3368-725-1 SCREW ASSY, FITTING (CA850X/CA860X)

3-040-979-01 COLLAR

3-934-325-01 SCREW, +K (5X8) TAPPING

1-465-459-21 ADAPTOR, ANTENNA (CA850)

0210

212

F901

M902

M903

8-820-103-03 PICK-UP, OPTICAL KSS-720A/K1RP

1-676-707-21 PICK-UP FLEXIBLE BOARD

1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A

A-3291-674-A MOTOR ASSY, SLED (SLED)

A-3315-039-A MOTOR SUB ASSY, LD (LOADING)

*************************************************************

261

262

3-041-000-01 SPRING, FITTING

1-776-207-72 CORD (WITH CONNECTOR) (POWER)

(CA850X/CA860X)

ACCESSORIES & PACKING MATERIALS

********************************

263

1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)

(CA850)

1-476-546-31 REMOTE COMMANDER (RM-X113) (CA850)

1-476-546-41 REMOTE COMMANDER (RM-X112)

(CA850X/CA860X)

264

265

7-685-248-14 SCREW +KTP 3X12 TYPE4 (for RM-X5S)

3-231-381-01 STRAP (ROTARY COMMANDER) (for RM-X5S)

1-476-589-11 REMOTE COMMANDER (RM-X5S)

3-020-953-01 LABEL (MODE) (for RM-X5S)

3-229-196-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,

DUTCH,ITALIAN,GERMAN) (CA850)

* 266

267

3-671-893-00 CLAMP (LOW TYPE) (for RM-X5S)

X-3373-432-1 BRACKET ASSY (for RM-X5S)

251

254

252

255

259

263

253

3-229-196-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH,

SWEDISH,PORTUGUESE,GREEK,RUSSIAN)

3-229-198-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,

SPANISH) (CA850X/CA860X)

3-229-199-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,

FRENCH,SPANISH) (CA850X/CA860X)

257

258

256

3-229-200-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,

FRENCH,DUTCH,ITALIAN,GERMAN)

(CA850)

260

261

262

3-229-200-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH,

SPANISH,SWEDISH,PORTUGUESE,

GREEK,RUSSIAN)

267

264

3-230-549-01 LID, BATTERY CASE (for RM-X112/X113)

X-3378-490-1 CASE (PANEL) ASSY (for FRONT PANEL)

*************************************************************

265

266

The components identified by Les composants identifiés par une

mark 0 or dotted line with mark marque 0 sont critiques pour

0 are critical for safety.

Replace only with part number Ne les remplacer que par une piéce

specified. portant le numéro spécifié.

la sécurité.

CDX-CA850/CA850X/CA860X

REVISION HISTORY

Clicking the version allows you to jump to the revised page.

Also, clicking the version at the upper right on the revised page allows you to jump to the next revised

page.

Ver.

1.1

1.0

Date

2001. 04

2001. 02

Description of Revision

Change the page of exploded views.

New

Toshiba MK2555GSX User Manual
Telex Scholar User Manual
Sony USM4GJX User Manual
Sony Cell Phone ST27A User Manual
Seagate Barracuda 72009 User Manual
Samsung SGH P100 User Manual
Samsung GH68 23213A User Manual
Philips AZ3708 User Manual
Panasonic Versio EB TX320 User Manual
Nokia Cell Phone 3120 User Manual