Sub Zero 427R User Manual

MODELS 427 and 427R - Door Lock Installation  
PROCEDURE: (Refer to the illustration below)  
1. If possible, install the lock components onto the appliance before pushing the appliance the final six inches  
into the wall. If the top edge of the door panel is less than 81 inches from the floor, it may be affected by the  
lock barrel hole described in Step 3 below.  
2. Remove side and top moldings if they are already installed. Remove the two top cabinet hinge screws on  
the handle side of the appliance. Insert the catch plate and tighten the screws to a sliding fit.  
3. If installing the lock kit on a wood panel, using the drilling template provided, drill an 1/8” diameter pilot hole  
through the wood panel. NOTE: The drilling template must fit flush with the front and side of the wood panel  
and the bottom edge must rest tight on top of the door frame. Take special care not to damage panel when  
using template or drilling holes. Drill a 7/8” diameter hole using a Forstner or suitable drill bit (Drill bits are  
not provided).  
4. Insert the lock through the finish washer, anti-rotation washer, panel hole and install the extension nut.  
NOTE: When positioning the anti-rotation washer, hole flats need to be vertically positioned.  
5. Install the cam onto the lock using the #10 screw so that a clockwise rotation will lock the door.  
6. Adjust the catch plate for a proper fit. Check the lock for proper operation. Tighten the catch plate screws.  
7. Install the special top molding strip. Install side moldings.  
Top Molding (LH)  
#10 Screw  
Catch Plate  
427 / 427R  
Door  
Panel  
Cam  
Anti-Rotation  
Washer  
Drilling  
Template for 1/8"  
Pilot Hole  
Extension  
Nut  
Key  
Door  
Lock  
Finish  
Washer  
Left hand (LH) hinged application shown  
Page 1 of 1  
3756430 / Rev C / May, 2007  

Westcott 4826 User Manual
Tatung Rack Mount Kit TRK 0841C User Manual
Star Manufacturing Peristaltic Heated Condiment Dispenser HPDE2 User Manual
Sony XR C6200 User Manual
Sony HVL 10DC User Manual
Sony DCR PC6E User Manual
Sony CDX GT28 User Manual
Sony Camera Accessories CMA H10 User Manual
Sanyo XACTI VPC GH3TA User Manual
Sanyo VCC 9300 User Manual