Sony XR C440 User Manual

XR-C440/C450

US Model

SERVICE MANUAL

Canadian Model

XR-C450

Ver 1.1 2001.08

E Model

XR-C440/C450

Photo: XR-C450

Refer to RM-X2S/X3S SERVICE MANUAL (9-960-039-∏)

issued previously for information of remote commander

(RM-X2S) supplied with XR-C440.

Dolby noise reduction manufactured under license

from Dolby Laboratories Licensing Corporation.

“DOLBY” and the double-D symbol aare trademarks

of Dolby Laboratories Licensing Corporation.

Model Name Using Similar Mechanism

Tape Transport Mechanism Type

NEW

MG-25C-136

SPECIFICATIONS

AUDIO POWER SPECIFICATIONS (US model)

POWER OUTPUT AND TOTAL HARMONIC DISTORTION

12 watts per channel minimum continuous average power into 4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than 1% total

harmonic distortion.

Antenna terminal

External antenna connector

Cassette player section

Intermediate frequency 10.7 MHz

Tape track

4-track 2-channel stereo

Usable sensitivity

Selectivity

Signal-to-noise ratio 65 dB (stereo),

68 dB (mono)

8 dBf

75 dB at 400 kHz

Wow and flutter

Frequency response

0.08% (WRMS)

30 – 18,000 Hz (C440/C450: US, Canadian)

30 – 20,000 Hz (C450: E, Saudi Arabia)

Signal-to-noise ratio

Harmonic distortion at 1 kHz

0.5% (stereo),

Cassette type

TYPE II, IV

TYPE I

Dolby B NR

67 dB

Dolby NR off

61 dB

0.3% (mono)

Separation

35 dB at 1 kHz

64 dB

58 dB

Frequency response

Capture ratio

30 – 15,000 Hz

2 dB (C450: E, Saudi Arabia)

4 dB (C440/C450: US, Canadian)

Tuner section

Tuning range

US, Canadian model:

87.5 – 107.9 MHz

— Continued on next page —

E, Saudi Arabia model:

50 kHz/200 kHz switchable

87.5 – 108.0 MHz (at 50 kHz step)

87.5 – 107.9 MHz (at 200 kHz step)

XR-C440/C450: US, Canadian Model

FM/AM CASSETTE CAR STEREO

XR-C450: E Model

FM/MW/SW CASSETTE CAR STEREO

9-925-536-12

2001H0500-1

C 2001.8

Sony Corporation

e Vehicle Company

Shinagawa Tec Service Manual Production Group

SECTION 1

GENERAL

This section is extracted

from instruction manual.

(XR-C440)

– 3 –

(XR-C450)

– 4 –

(XR-C450: E, Saudi Arabia)

– 5 –

(XR-C440/XR-C450: E, Saudi Arabia)

– 6 –

(XR-C450: US, Canadian)

– 7 –

– 8 –

(XR-C440)

– 9 –

– 10 –

(XR-C450)

(E, Saudi Arabia model)

– 11 –

(E, Saudi Arabia model)

– 12 –

(US, Canadian model)

(E, Saudi Arabia model)

– 13 –

SECTION 2

DISASSEMBLY

Note: Follow the disassembly procedure in the numerical order given.

FRONT PANEL ASS’Y

1 Push the button

(release).

2 Remove the front panel ass’y

to the direction of the arrow A.

COVER ASS’Y

3 cover ass’y

– 14 –

SUB PANEL, MECHANISM DECK

5 screw

(PTT2.6 × 6)

3 connector

(CN302)

6 mechanism deck

4 flexible flat cable

(CN301)

2 sub panel

1 three screws

(PTT2.6 × 8)

1 three screws

(PTT2.6 × 8)

4 nine screws

MAIN BOARD, HEAT SINK

(PTT2.6 × 10)

2 two ground point

screws

1 screw

(PTT2.6 × 8)

5 heat sink

3 main board

1 two screws

(PTT2.6 × 8)

– 15 –

SECTION 3

ASSEMBLY OF MECHANISM DECK

Note: Follow the assembly procedure in the numerical order given.

HOUSING

7 Holder the hanger by bending the claw.

5 Fit projection on C part.

2 Install the hanger onto

1 Install the catch to the hanger.

two claws of the housing.

4 Fit claw on B part.

hanger

6 Fit projection on D part.

3 Put the housing

under A part.

housing

C part

8 Hold the hanger by

bending the claw.

D part

A part

B part

ARM (SUCTION)

2 Move the arm (suction) in the arrow

direction and fit on projection.

projection

1 Fit the arm (suction) on the shaft.

– 16 –

LEVER (LDG-A) / (LDG-B)

shaft A

shaft B

shaft C

shaft B

1 Fit the lever (LDG-A) on

2 Pull the lever in the

4 type-E stop ring 2.0

shafts A – C and install it.

arrow direction.

3 Fit the lever (LDG-B) on

shafts A and B and

install it.

GEAR (LDG-FT)

5 polyethyene washer

5 gear (LDG-FT)

1 tension spring (lever LDG)

gear (LDG-D)

hole

2 Move the lever (LDG-B)

in the arrow direction.

lever (LDG-A)

gear (LDG-FB)

3 Align hole in the gear (LDG-D)

with hole the lever (LDG-A).

– 17 –

GUIDE (C)

2 guide (C)

1 three claws

– 18 –

SECTION 4

SECTION 5

MECHANICAL ADJUSTMENTS

ELECTRICAL ADJUSTMENTS

1. Clean the following parts with a denatured-alcohol-moistened

swab:

TEST MODE

This set have the test mode function. In the test mode, FM Auto

Scan/Stop Level and AM (MW) Auto Scan/Stop Level adjustments

can be performed easier than it in ordinary procedure.

playback head

rubber belt

idles

pinch roller

capstan

2. Demagnetize the playback head with a head demagnetizer.

3. Do not use a magnetized screwdriver for the adjustments.

4. After the adjustments, apply suitable locking compound to the

parts adjusted.

1. Set the “OFF” mode.

2. Push the preset 4 button.

3. Push the preset 5 button.

5. The adjustments should be performed with the power supply

voltage unless otherwise noted.

4. Press the preset 1 button for more than two seconds.

5. Then the display indicates all lights, the test mode is set.

• Torque Measurement

1. Push the “OFF” button.

Mode

Torqu Meter

Meter Reading

30 - 65 g·cm

(0.42 - 0.90 oz·inch)

Forward

CQ-102C

Forward

Back Tension

0.5 - 4.5g·cm

(0.01 - 0.06 oz·inch)

30 - 65 g·cm

CQ-102C

Reverse

CQ-102RC

(0.42 - 0.90 oz·inch)

Reverse

Back Tension

0.5 - 4.5g·cm

(0.01 - 0.06 oz·inch)

CA-102RC

CQ-201B

60 - 200 g·cm

(0.83 - 2.78 oz·inch)

FF, REW

• Tape Tension Measurement

Mode

Forward

Reverse

Torqu Meter

Meter Reading

more than 90 g

(more than 3.18 oz)

CQ-403A

more than 90 g

(more than 3.18 oz)

CQ-403R

– 19 –

See the adjustment location from on page 22 for the ad-

justment.

TUNER SECTION

(XR-C450: E, Saudi Arabia model only)

0dB=1µV

TAPE DECK SECTION

0 dB=0.775 V

Cautions during repair

Tape Speed Adjustment

When the tuner unit is defective, replace it by a new one because

its internal block is difficult to repair.

Procedure:

1. Put the set into the FWD PB mode.

speed checker

frequency counter

FM Auto Scan/Stop Level Adjustment

Setting:

test tape

SOURCE button

FREQUENCY SELECT switch: 10 k

: FM

WS-48A

(3 kHz, 0 dB)

10 kΩ

FM RF signal

generator

set

–

antenna jack (J1)

0.01 µF

LINE OUT

set

Specification: Constant speed

Carrier frequency : 97.9 MHz

Output level

Mode

: 22 dB (12.6 µV)

Speed checker

Frequency counter

: mono

Modulation

: 1 kHz, 75 kHz deviation

–1.5 to +2.5%

2,955 to 3,075Hz

Procedure:

1. Set to the test mode. (See page 19).

Adjustment Location: See page 22.

2. Push the SOURCE button and set to FM.

DOLBY Level Adjustment

Setting:

Display

Preset 3 (DOLBY) button

SEL (BAS) button

SEL (TRE) button

SEL (BAL) button

SEL (FAD) button

SEL (VOL) button

D-BASS control

: OFF

: Center

: Maximum

: OFF

SHUF1

3. Push the preset 3 button.

Display

L-CH: IC301 7

R-CH: IC301@¢

main board

TP (DOLBY )

test tape

P-4-D400

level meter

(400Hz, 0dB)

SHUF1

–

set

4. Adjust with the volume RV2 on TU1 so that the “FM” indica-

tion turns to “FM0” indication on the display window.

But, in case of already indicated “FM0”, turn the RV2 so that

put out light “0” indication and adjustment.

main board

TP (GND)

Procedure:

1. Put the set into the FWD PB mode.

2. Adjust RV231 (L-CH) and RV131 (R-CH) so that the level meter

reading is –6±0.5 dB (0.37 to 0.41 V).

Display

Adjustment Location: See page 22.

SHUF1

Adjustment Location: See page 22.

– 20 –

FM Noise Focus Adjustment

Setting:

AM (MW) Auto Scan/Stop Level Adjustment

Setting:

SOURCE button

FREQUENCY SELECT switch: 10 k

: FM

SOURCE and MODE button : MW

FREQUENCY SELECT switch: 10 k

FM RF signal

generator

level meter

antenna jack (J1)

0.01 µF

30 Ω

15 pF

65 pF

10 k Ω

–

set

AM RF signal

generator

Carrier frequency : 97.9 MHz

LINE OUT

Output level

Mode

: 60 dB (1 mV)

: mono

: 1 kHz, 75 kHz deviation

AM dummy antenna

Modulation

(50 Ω)

set

Procedure :

1. Tune the 97.9 MHz

2. The then output level is supposing that (A) dB.

3. Adjust with the volume RV3 on TU1 so that the output level is

antenna jack (J1)

Carrier frequency : 1000 kHz

30% amplitude

modulation by

(A) –32 dB then signal generator input set to –20 dB.

400 Hz signal

Output level

: 33 dB (44.7 µV)

Adjustment Location: See page 22.

Procedure:

1. Set to the test mode. (See page 19.)

FM Stereo Separation Adjustment

2. Push the SOURCE button and set to FM.

3. Push the MODE button and set to MW.

Setting:

SOURCE button

: FM

FREQUENCY SELECT switch: 10 k

Display

FM RF signal

generator

level meter

antenna jack (J1)

0.01 µF

10 k Ω

SHUF1

–

set

4. Push the preset 3 button.

Display

Carrier frequency : 97.9 MHz

LINE OUT

Output level

Mode

: 70 dB (3.2 mV)

: stereo

main: 1 kHz, 20 kHz deviation (26%)

sub: 1 kHz, 20 kHz deviation (26%)

19 kHz pilot: 7.5 kHz deviation (10%)

Modulation

SHUF1

FM Stereo

signal generator

output channel

Level meter

connection

Level meter

reading (dB)

5. Adjust with the volume RV1 on TU1 so that the “MW” indica-

tion turns to “MW0” indication on the display window.

But, in case of already indicated “MW0”, turn the RV1 so that

put out light “0” indication and adjustment.

L-CH

R-CH

L-CH

R-CH

Adjust RV4 on TU1

for minimum reading.

Display

Adjust RV4 on TU1

for minimum reading.

SHUF1

3 1

Adjustment Location: See page 22.

Procedure:

L-CH Stereo separation: A-B

R-CH Stereo separation: C-D

The separations of both channels should be equal.

Specification: Separation more than 30 dB

Adjustment Location: See page 22.

– 21 –

Adjustment Location:

– SET UPPER VIEW –

Tape Speed Adjustment

(XR-C450: E, Saudi Arabia model only)

TU1

RV1 AM (MW) Auto Scan/Stop Level Adjustment

RV2 FM Auto Scan/Stop Level Adjustment

RV3 FM Noise Focus Adjustment

RV4 FM Stereo Separation Adjustment

RV131 RV231

(R-CH) (L-CH)

DOLBY Level

Adjustment

– MAIN BOARD (CONDUCTOR SIDE) –

antenna jack

TU1

TP (DOLBY R)

TP (GND)

IC301

TP (DOLBY L)

IC501

– 22 –

• IC Block Diagrams

IC361 MM1322XFBE

IC1 BU2624F-E2

20 VSS

19 PD1

XOUT

XIN

GND

REFERENCE

DIVIDER

OUT2

PHASE

DETECT

IN2

18 VDD

VCC

I/O

CONTROL

IN1

OUT1

GND

FMIN

AMIN

MAIN

COUNT

IC651 RN5VD23AA-TL

SHIFT

LATCH

PRESCALLER

14 IF1

IF COUNT

CONTROL

VREF

–

20BIT COUNT

IF2

PD2

IC161 LC75373ED

31 30 29

28 27 26

25 24

–

22 LFIN

–

21 LFOUT

LSELO

L4 35

L3 36

L2 37

L1 38

–

LROUT

VREF

–

VDD 39

–

SHIFT

DECODER

LATCH

CONTROL

VSS

RROUT

–

R2 41

R3 42

R4 43

–

RSELO 44

–

RFOUT

–

12 RFIN

– 37 –

IC301 CXA2510AQ-T4

IC701 BA8270F-E2

BUS ON

14 VCC

BUS ON

SWITCH

29 28 27 26

23 22 21

RESET

SWITCH

120µ/

70µ

RST

12 BUS ON

11 CLK IN

10 BU IN

–

BATTERY

SWITCH

BATT

MSMODE

19 DRSW

–

NR BIAS

TAPE/AUX

TAPE EQ

FWD/RVS

VCC

PBFB1 31

MODE

PBRIN1 32

CLK

VREF

DATA

TAPESW

PBREF1

PBFIN1

17 INSW

DATA IN

MODE

GND

DATA OUT

16 NRSW

VCT 35

VCT

15 NC

PBGND

MS ON/

OFF

LPF

–

DETECT

14 MSOUT

13 DGND

PBFIN2

PBREF2 38

PBRIN2

PBFB2

12 MSTC

11 FF

–

OFF/B

120µ/

70µ

IC671 BA3918-V2

REGULATOR

OVER VOLTAGE

PROTECT

–

– 38 –

6-7. IC PIN FUNCTION DESCRIPTION

MAIN BOARD IC501 µPD78058GC-913-3B9 (SYSTEM CONTROL)

Pin No. Pin Name

I/O

Function

DSEL

RC_IN0

SD_IN

Destination setting pin

Rotary remote commander input pin (A/D input)

Station detection signal input

GND

AVSS

—

I/O

Stereo detection signal input and forced monaural signal output pin

PLL chip enable output pin

PLLCE

AVREF1

PLLSI

A/D reference voltage input pin

PLL data input pin

PLLSO

PLLCKO

P.ST_IN

LCDSO

LCDCKO

LCDCE

LCDINH

UNISI

PLL data output pin

PLL clock output pin

Polar stereo input pin

LCD data output pin

LCD clock output pin

LCD chip enable output pin

LCD blank indication control pin

Data input pin (for SONY BUS)

Data output pin (for SONY BUS)

Clock input pin (for SONY BUS)

Clock output pin (for SONY BUS)

BUS ON control signal output pin (for SONY BUS)

System reset signal output pin

Power amp power supply control pin

Power amp muting control pin. At muting: “L”

Tape power supply control pin

FM power supply control pin

System power supply control pin

UNISO

UNICKI

UNICKO

BUSON

SYSRST

AMPON

AMP_MUT

TUNON

FM_ON

PW_ON

COLOR

I/O

Illumination color selection input/output pin

At initial mode: valid/invalid selection input of color select function

At normal mode: color selection output

AMSON

REL

Tape AMS control pin. At AMS: “L”

Reel table rotation detection pin

AUTO METAL detection pin. “L”: METAL

Tape position control pin

MTLIN

31, 32 POS3, POS2

33 GND

34, 35 POS0, POS1

—

GND

Tape position control pin

LM_LOD

LM_EJ

Loading motor control pin (loading direction)

Loading motor control pin (eject direction)

Forward/reverse control pin

N/R_OUT

P.ON

Polar stereo detection output pin. At polar stereo on: “H”

Capstan motor control pin

CM_ON

TAPON

COLSEL

RC_IN1

TEST

Tape power supply control pin

Illumination color setting pin. “L”: amber, “H”: green

Rotary remote commander input pin (A/D input)

Test mode setting pin

– 39 –

Pin No. Pin Name

I/O

Function

ILLON

Illumination power supply control pin

At PW SEL on: ACC on: “H”

At PW SEL off: Power on: “H”

BEEP

MUT

Beep sound output pin

System mutig control pin. At muting: “H”

Chip enable output pin to electrical volume

VOLCE

SUBCE

VOLCKO

SUBCKO

VOLSO

TAPMUT

DOLON

Chip enable output pin to sub volume (not used)

Clock output pin to electrical volume

Clock output pin to sub volume (not used)

Data output pin to electrical volume

Tape mutig control pin. At muting: “H”

I/O

DOLBY control input/output pin

At initial mode: valid/invalid selection input of DOLBY function

At normal mode: DOLBY on/off output

DOLBC

I/O

DOLBY B/C selection pin

At initial mode: valid/invalid selection input of DOLBY C function

At normal mode: DOLBY B/C selection output. “L”: DOLBY B, “H”: DOLBY C

AMSIN

Tape music with/without detection pin. “L”: with music

MTLSEL

I/O

METAL control input/output pin

At initial mode: auto/manual serection input of METAL function. “L”: manual

At manual mode: METAL on/off output. “H”: on

At auto mode: input st 30 MTLIN

AD_ON

RAMBU

RESET

SIRCS

Power supply control pin for A/D conversion

Reset detection pin of RAM

Reset input pin

SIRCS signal input pin

BU_IN

Buck up power supply detection pin

Power select switch input pin

PW_SEL

ACCIN

NOSESW

TELMUT

KEYACK

VDD

Accessory voltage detection pin

Front panel removal or attaching detection pin

Telephone muting detection pin. “L”: 20dB audio muting

Key acknowledge signal input pin

Power supply

—

OSCOUT

OSCIN

Main system clock output pin (5MHz)

Main system clock input pin (5MHz)

GND

—

XT_OUT

XT_IN

Sub system clock output pin (32.768kHz)

Sub system clock input pin (32.768kHz)

Power supply

AVDD

—

AVREF0

A/D reference voltage input pin

Key input pin (A/D input)

76, 77 KEYIN0, KEYIN1

D.POSI

VSM

D-BASS switch input pin (A/D input)

FM/AM signal meter voltage detection pin (A/D input)

Key function setting pin

KEYSEL

– 40 –

Ver 1.1

SECTION 7

EXPLODED VIEWS

NOTE:

• -XX and -X mean standardized parts, so they

may have some difference from the original

one.

• Color Indication of Appearance Parts

Example:

• Items marked “*” are not stocked since they

are seldom required for routine service. Some

delay should be anticipated when ordering

these items.

• The mechanical parts with no reference num-

ber in the exploded views are not supplied.

• Accessories and packing materials are given

in the last of the electrical parts list.

KNOB, BALANCE (WHITE) . . . (RED)

↑

Parts Color Cabinet's Color

• Abbreviation

EA: Saudi Arabia

(1) CHASSIS SECTION

MG-25C-136

F901

XR-C440

Front panel ass’y

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

3-009-294-01 PANEL, SUB

3-935-003-01 SPRING, TORSION

3-932-205-31 DOOR, CASSETTE (XR-C450: E, EA)

3-932-205-51 DOOR, CASSETTE

1-776-207-11 CORD (WITH CONNECTOR)

(XR-C440/XR-C450: E, EA)

1-776-207-31 CORD (WITH CONNECTOR)

(XR-C450: US, Canadian)

(XR-C440/XR-C450: US, Canadian) * 10

3-009-809-01 BRACKET (IC)

X-3367-636-1 LOCK ASSY

* 11

3-009-808-01 HEAT SINK (XR-C450)

3-009-808-21 HEAT SINK (XR-C440)

* 5

3-009-306-01 SHEET, INSULATING

* 6

A-3309-720-A MAIN BOARD, COMPLETE

9-911-840-XX CUSHION (U)

3-009-813-01 CHASSIS

(XR-C450: US, Canadian) * 13

* 6

A-3309-723-A MAIN BOARD, COMPLETE (XR-C450: E)

A-3313-122-A MAIN BOARD, COMPLETE (XR-C450: EA)

A-3309-877-A MAIN BOARD, COMPLETE (XR-C440)

* 14

3-012-859-01 CAP, RUBBER

3-360-123-01 PLATE (C), GROUND (XR-C450: E, EA)

3-937-650-01 PLATE (C), GROUND

(XR-C440/XR-C450: US, Canadian)

* 8

3-915-923-01 SCREW, GROUND POINT

X-3373-270-1 COVER ASSY (XR-C440)

X-3373-269-1 COVER ASSY (ISO) (XR-C450)

F901

1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)

– 41 –

(2) FRONT PANEL SECTION

(XR-C440)

not supplied

(KEY board)

LCD901

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

* 61

* 62

* 63

3-010-387-01 BUTTON (PRESET) (6. 1. 2. 3. 4. 5. 6. DSPL)

3-010-390-01 BUTTON (L. L. D) (PTY. AF/ TA. – DISC +)

3-010-375-11 SHEET (REFLECTOR) (XR-C440)

3-010-393-01 PLATE (LCD), LIGHT GUIDE

3-010-396-01 KNOB (D-BASS)

3-010-398-01 BUTTON (RELEASE)

3-013-272-01 SPRING (RELEASE)

X-3373-678-1 PANEL SUB ASSY

3-010-383-01 BUTTON (SOURCE)

3-010-394-01 HOLDER (LCD)

3-010-382-01 PANEL, FRONT BACK

3-010-384-01 BUTTON (M. O. S) ( r. OFF. – = 0.

SEEK AMS. + ) +)

3-010-386-01 BUTTON (B.M.+/–) (–. SEL. +. MUTE. SENS)

LCD901 1-801-587-11 DISPLAY PANEL, LIQUID CRYSTAL

– 42 –

(3) FRONT PANEL SECTION

(XR-C450)

not supplied

(KEY board)

PL903

108

109

107

106

117

118

116

115

105

SONY

110

LCD901

114

111

PL904

112

113

104

103

101

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

101

103

104

105

106

3-009-301-01 BUTTON (BASS)

3-009-299-01 BUTTON (L2) (+.-)

3-009-304-01 BUTTON (RELEASE)

3-932-475-01 SPRING (RELEASE)

3-904-194-01 EMBLEM (NO. 2.5), SONY

111

112

113

* 114

* 115

3-009-308-01 BUTTON (1-3) (6. 1. 2. 3)

3-009-309-11 BUTTON (4-6) (4. 5. 6)

3-009-310-01 BUTTON (R) (L) (PTY. AF/ TA. – DISC +)

3-010-282-01 PLATE (LCD), GROUND

3-009-305-01 SHEET (REFLECTOR)

107

108

109

X-3373-665-1 PANEL SUB ASSY

3-009-300-01 BUTTON (SOURCE)

3-009-297-01 BUTTON (L) (+ + ). SEEK AMS. = 0

–.r. OFF. r. SEL. MUTE)

* 116

* 117

118

3-009-302-11 PLATE (LCD), LIGHT GUIDE

3-009-303-01 HOLDER (LCD)

3-009-295-01 PANEL, FRONT BACK

LCD901 1-801-587-11 DISPLAY PANEL, LIQUID CRYSTAL

110

3-009-311-01 LENS

PL903 1-517-633-11 LAMP, PILOT

PL904 1-517-633-11 LAMP, PILOT

– 43 –

(4) MECHANISM DECK SECTION

(MG-25C-136)

209

210

213

208

HP901

211

205

207

212

206

M901

214

204

203

215

202

216

217

201

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

201

202

* 203

* 204

205

A-3291-667-A CLUTCH (FR) ASSY

3-701-437-21 WASHER

3-008-883-01 LEVER (LDG-A)

3-008-884-01 LEVER (LDG-B)

3-008-890-01 SPRING (LEVER LDG), TENSION

211

212

213

214

215

3-008-874-02 CATCHER

3-933-344-01 GUIDE (C)

3-927-100-01 SCREW (+PS 2X10), SPECIAL

3-364-151-01 WASHER

A-3291-919-A CHASSIS ASSY (A)

206

207

208

* 209

210

3-933-335-01 GEAR (LDG-FT)

3-341-753-11 WASHER, POLYETHYLENE

3-008-861-01 HOUSING

3-008-882-01 ARM (SUCTION)

3-008-860-01 HANGER

216

217

3-928-675-01 BELT (52)

3-936-853-01 FLYWHEEL (F)

HP901 1-500-196-21 HEAD, MAGNETIC (PLAYBACK)

M901 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/ REEL)

– 44 –

SECTION 8

ELECTRICAL PARTS LIST

KEY

NOTE:

• Due to standardization, replacements in the

parts list may be different from the parts speci-

fied in the diagrams or the components used on

the set.

• Items marked “*” are not stocked since they

are seldom required for routine service.

Some delay should be anticipated when order-

ing these items.

When indicating parts by reference

number, please include the board.

• -XX and -X mean standardized parts, so they

may have some difference from the original one.

• SEMICONDUCTORS

In each case, u: µ, for example:

uA. . : µA. .

uPB. . : µPB. . uPC. . : µPC. .

uPD. . : µPD. .

uPA. . : µPA. .

• RESISTORS

All resistors are in ohms.

METAL: Metal-film resistor.

METAL OXIDE: Metal oxide-film resistor.

F: nonflammable

• CAPACITORS

uF: µF

• Abbreviation

EA: Saudi Arabia

• COILS

uH: µH

Ref. No.

Part No.

Description

Remark Ref. No.

Part No.

Description

< CHIP CONDUCTOR >

Remark

KEY BOARD

*********

JC901 1-216-295-00 CONDUCTOR, CHIP

(2012)

3-009-302-01 PLATE (LCD), LIGHT GUIDE (XR-C450)

3-009-303-01 HOLDER (LCD) (XR-C450)

3-009-305-11 SHEET (REFLECTOR) (XR-C450)

3-010-282-01 PLATE (LCD), GROUND (XR-C450)

3-010-375-11 SHEET (REFLECTOR) (XR-C440)

< LIQUID CRYSTAL DISPLAY >

LCD901 1-801-587-11 DISPLAY PANEL, LIQUID CRYSTAL

< SWITCH >

3-010-393-01 PLATE (LCD), LIGHT GUIDE (XR-C440)

3-010-394-01 HOLDER (LCD) (XR-C440)

LSW901 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (OFF)

(XR-C440/XR-C450: US, Canadian)

LSW901 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (OFF)

(XR-C450:E, EA)

< CAPACITOR >

LSW902 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)

C901

C902

C903

C904

C905

1-163-033-91 CERAMIC CHIP

1-163-038-00 CERAMIC CHIP

1-163-251-11 CERAMIC CHIP

1-163-038-00 CERAMIC CHIP

0.022uF

0.1uF

100PF 5%

0.1uF

50V

25V

50V

(XR-C440/XR-C450: US, Canadian)

LSW902 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)

(XR-C450: E, EA)

LSW903 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MODE)

(XR-C440/XR-C450: US, Canadian)

25V

(XR-C450)

LSW903 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MODE)

(XR-C450: E, EA)

< CONNECTOR >

LSW904 1-762-619-11 SWITCH, KEY BOARD (WITH LED)

(+ + ) (SEEK/AMS)) (XR-C440/XR-C450: US, Canadian)

LSW904 1-762-620-11 SWITCH, KEY BOARD (WITH LED)

(+ + ) (SEEK/AMS)) (XR-C450: E, EA)

CNP901 1-764-423-11 PIN, CONNECTOR 12P

< DIODE >

LSW905 1-762-619-11 SWITCH, KEY BOARD (WITH LED)

(– = 0 (SEEK/AMS)) (XR-C440/XR-C450: US, Canadian)

LSW905 1-762-620-11 SWITCH, KEY BOARD (WITH LED)

(– = 0 (SEEK/AMS)) (XR-C450: E, EA)

D901

D902

D903

D904

D905

8-719-976-99 DIODE DTZ5.1B

8-719-105-99 DIODE RD6.2M-B1

LSW906 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (–)

(XR-C440/XR-C450: US, Canadian)

D908

8-719-976-99 DIODE DTZ5.1B (XR-C450)

< IC >

LSW906 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (–)

(XR-C450: E, EA)

LSW907 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (SEL)

(XR-C440/XR-C450: US, Canadian)

IC901

IC902

8-759-365-90 IC LC75824W

8-749-012-25 IC RS-170-TU (XR-C450)

LSW907 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SEL)

(XR-C450: E, EA)

– 45 –

KEY

Ref. No.

Part No.

Description

Remark Ref. No.

Part No.

Description

Remark

LSW908 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (+)

LSW929 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (FILE)

(XR-C440/XR-C450: US, Canadian)

(XR-C450: US, Canadian)

LSW929 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (FILE)

(XR-C450: E, EA)

LSW930 1-762-619-11 SWITCH, KEY BOARD (WITH LED)

(+ (DISC/PRESET)) (XR-C440/XR-C450: US, Canadian)

LSW930 1-762-620-11 SWITCH, KEY BOARD (WITH LED)

(+ (DISC/PRESET)) (XR-C450: E, EA)

LSW931 1-762-619-11 SWITCH, KEY BOARD (WITH LED)

(– (DISC/PRESET)) (XR-C440/XR-C450: US, Canadian)

LSW908 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (+)

(XR-C450: E, EA)

LSW909 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MUTE)

(XR-C440)

LSW909 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (DSPL)

(XR-C450: US, Canadian)

LSW909 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (DSPL)

(XR-C450: E, EA)

LSW910 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (BTM)

(XR-C440)

LSW931 1-762-620-11 SWITCH, KEY BOARD (WITH LED)

(– (DISC/PRESET)) (XR-C450: E, EA)

LSW932 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (DSPL)

(XR-C440)

LSW910 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MUTE)

(XR-C450: US, Canadian)

LSW910 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MUTE)

(XR-C450: E, EA)

LSW921 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (6)

(XR-C440/XR-C450: US, Canadian)

LSW921 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (6)

(XR-C450: E, EA)

< PILOT LAMP >

PL903 1-517-633-11 LAMP, PILOT

PL904 1-517-633-11 LAMP, PILOT

< TRANSISTOR >

LSW922 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (1/INTRO)

(XR-C440/XR-C450: US, Canadian)

Q901

Q902

Q903

Q904

8-729-106-60 TRANSISTOR 2SB1115A (XR-C450: E, EA)

8-729-900-53 TRANSISTOR DTC114EK (XR-C450: E, EA)

LSW922 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (1/INTRO)

(XR-C450: E, EA)

LSW923 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (2/REPEAT)

(XR-C440/XR-C450: US, Canadian)

< RESISTOR >

LSW923 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (2/REPEAT)

(XR-C450: E, EA)

R901

R902

R903

R904

R905

1-216-045-00 METAL CHIP

1-216-049-11 METAL GLAZE

1-216-053-00 METAL CHIP

680

1/10W

LSW924 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (3/SHUF/a)

(XR-C440/XR-C450: US, Canadian)

LSW924 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (3/SHUF/a)

(XR-C450: E, EA)

1.5K

LSW925 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (6/BL.SKIP)

(XR-C440/XR-C450: US, Canadian)

LSW925 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (6/BL.SKIP)

R906

R907

R908

R909

R910

1-216-053-00 METAL CHIP

1-216-057-00 METAL CHIP

1-216-061-00 METAL CHIP

1-216-065-00 METAL CHIP

1-216-069-00 METAL CHIP

1.5K

2.2K

3.3K

4.7K

6.8K

1/10W

(XR-C440)

(XR-C450: E, EA)

LSW926 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (5/ATA)

(XR-C440/XR-C450: US, Canadian)

LSW926 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (5/ATA)

(XR-C450:E, EA)

LSW927 1-762-619-11 SWITCH, KEY BOARD (WITH LED)

R921

R922

R923

R924

R925

1-216-045-00 METAL CHIP

1-216-049-11 METAL GLAZE

1-216-053-00 METAL CHIP

680

1/10W

(4/BANK/MTL) (XR-C440/XR-C450: US, Canadian)

LSW927 1-762-620-11 SWITCH, KEY BOARD (WITH LED)

(4/BANK/MTL) (XR-C450: E, EA)

1.5K

LSW928 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (LCL)

(XR-C440)

LSW928 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (LCL/BTM)

(XR-C450: US, Canadian)

R926

R927

R928

R929

R930

1-216-053-00 METAL CHIP

1-216-057-00 METAL CHIP

1-216-061-00 METAL CHIP

1-216-065-00 METAL CHIP

1-216-069-00 METAL CHIP

1.5K

2.2K

3.3K

4.7K

6.8K

1/10W

LSW928 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (LCL/BTM)

(XR-C450: E, EA)

LSW929 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (LIST)

(XR-C440)

R931

R932

1-216-073-00 METAL CHIP

1-216-077-00 METAL CHIP

10K

15K

1/10W

(XR-C440)

– 46 –

KEY

MAIN

Ref. No.

Part No.

Description

Remark Ref. No.

Part No.

Description

Remark

1/10W

R951

R952

R953

1-216-041-00 METAL CHIP

1-216-109-00 METAL CHIP

1-216-049-11 METAL GLAZE

470

330K

1/10W

R972

1-216-021-00 METAL GLAZE

(XR-C450: E, EA)

1/10W

R981

R982

1-216-053-00 METAL CHIP

1-216-061-00 METAL CHIP

1.5K

3.3K

1/10W

R954

R955

R956

R957

1-216-049-11 METAL GLAZE

1-216-073-00 METAL CHIP

10K

1/10W

R983

R984

R991

1-216-069-00 METAL CHIP

1-216-081-00 METAL CHIP

1-216-025-00 METAL GLAZE

6.8K

22K

100

1/10W

(XR-C450: E, EA)

(XR-C450)

1/10W

(XR-C450)

R958

1-216-065-00 METAL CHIP

4.7K

1/10W

R992

R999

1-216-041-00 METAL CHIP

1-216-308-00 METAL GLAZE

470

4.7

(XR-C450: E, EA)

1/10W

R959

R960

R961

1-216-073-00 METAL CHIP

1-216-065-00 METAL CHIP

1-216-025-00 METAL GLAZE

1-216-033-00 METAL CHIP

1-216-037-00 METAL CHIP

10K

4.7K

100

220

1/10W

(XR-C440/XR-C450: US, Canadian)

(XR-C450: E, EA)

1/10W

< SWITCH >

1/10W

SW951 1-762-937-11 SWITCH, ROTARY (D-BASS)

(XR-C440) ************************************************************

1/10W

(XR-C450: US, Canadian)

5% 1/10W

(XR-C450: E, EA)

A-3309-720-A MAIN BOARD, COMPLETE

330

*********************

(XR-C450: US, Canadian)

R962

R963

R964

1-216-033-00 METAL CHIP

1-216-025-00 METAL GLAZE

1-216-029-00 METAL CHIP

1-216-033-00 METAL CHIP

1-216-025-00 METAL GLAZE

220

100

150

220

100

1/10W

A-3309-723-A MAIN BOARD, COMPLETE (XR-C450: E)

(XR-C450: E, EA)

*********************

1/10W

(XR-C450: US, Canadian)

A-3309-877-A MAIN BOARD, COMPLETE (XR-C440)

1/10W

*********************

(XR-C450: E, EA)

1/10W

(XR-C440)

1/10W

A-3313-122-A MAIN BOARD, COMPLETE (XR-C450: EA)

*********************

(XR-C450: E, EA)

3-009-808-01 HEAT SINK (XR-C450)

3-009-808-21 HEAT SINK (XR-C440)

3-009-809-01 BRACKET (IC)

R965

R966

R967

1-216-033-00 METAL CHIP

1-216-037-00 METAL CHIP

1-216-033-00 METAL CHIP

1-216-021-00 METAL GLAZE

1-216-029-00 METAL CHIP

220

5% 1/10W

(XR-C440/XR-C450: US, Canadian)

7-685-794-09 SCREW +PTT 2.6X10 (S)

330

220

1/10W

(XR-C450: E, EA)

< CAPACITOR >

1/10W

1-163-235-11 CERAMIC CHIP

1-163-133-00 CERAMIC CHIP

1-124-234-00 ELECT

22PF

470PF 5%

22uF

50V

16V

1/10W

(XR-C440/XR-C450: US, Canadian)

20%

150

1/10W

(XR-C450: E, EA)

R968

R969

R970

1-216-021-00 METAL GLAZE

1-216-031-00 METAL CHIP

1-216-037-00 METAL CHIP

1-216-031-00 METAL CHIP

1/10W

C10

1-164-232-11 CERAMIC CHIP

0.01uF

50V

(XR-C450: E, EA)

1/10W

(XR-C440)

1/10W

180

330

180

(XR-C450: E, EA)

50V

(XR-C450: US, Canadian)

5% 1/10W

(XR-C450: E, EA)

C11

1-163-251-11 CERAMIC CHIP

100PF 5%

C12

C13

C14

C15

C16

1-163-251-11 CERAMIC CHIP

1-124-589-11 ELECT

1-164-232-11 CERAMIC CHIP

1-164-489-11 CERAMIC CHIP

100PF 5%

47uF

0.01uF

0.22uF 10%

50V

16V

50V

1/10W

(XR-C450:E, EA)

20%

R971

1-216-021-00 METAL GLAZE

1-216-029-00 METAL CHIP

1/10W

16V

(XR-C440/XR-C450: US, Canadian)

150 5% 1/10W

(XR-C450: E, EA)

C17

C18

1-163-017-00 CERAMIC CHIP

1-124-234-00 ELECT

0.0047uF5%

22uF

50V

16V

20%

– 47 –

MAIN

Ref. No.

Part No.

Description

Remark Ref. No.

C176

Part No.

Description

Remark

50V

C19

C20

C21

1-126-157-11 ELECT

1-164-004-11 CERAMIC CHIP

1-163-237-11 CERAMIC CHIP

10uF

0.1uF

27PF

20%

10%

16V

25V

50V

1-163-251-11 CERAMIC CHIP

100PF 5%

(XR-C450)

C191

C192

C193

C194

C201

1-136-165-00 FILM

1-163-024-00 CERAMIC CHIP

0.1uF

50V

C22

C93

C94

C95

C96

1-163-237-11 CERAMIC CHIP

1-163-251-11 CERAMIC CHIP

1-163-235-11 CERAMIC CHIP

1-163-243-11 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

27PF

100PF 5%

22PF

47PF

50V

0.018uF 10%

(XR-C440/XR-C450: E, EA)

0.01uF

C97

C98

C99

C101

1-164-232-11 CERAMIC CHIP

1-163-024-00 CERAMIC CHIP

0.01uF

50V

C201

1-163-986-00 CERAMIC CHIP

0.027uF 10%

25V

(XR-C450: US, Canadian)

C203

C231

C232

C233

1-126-160-11 ELECT

1uF

20%

50V

0.018uF 10%

1-163-251-11 CERAMIC CHIP

1-126-160-11 ELECT

100PF 5%

(XR-C440/XR-C450: E, EA)

0.027uF 10% 25V

(XR-C450: US, Canadian)

C101

1-163-986-00 CERAMIC CHIP

1uF

20%

C234

C241

C242

C251

C252

1-163-009-11 CERAMIC CHIP

1-163-251-11 CERAMIC CHIP

1-126-157-11 ELECT

1-126-160-11 ELECT

0.001uF 10%

100PF 5%

50V

16V

50V

C103

C121

1-126-160-11 ELECT

1-107-823-11 CERAMIC CHIP

1uF

0.47uF 10%

20%

50V

16V

10uF

1uF

20%

(XR-C450: E, EA)

C121

C122

1-164-489-11 CERAMIC CHIP

1-163-037-11 CERAMIC CHIP

1-164-344-11 CERAMIC CHIP

0.22uF 10%

(XR-C440/XR-C450: US, Canadian)

0.022uF 10%

(XR-C440/XR-C450: US, Canadian)

0.068uF 10% 25V

(XR-C450: E, EA)

16V

25V

C253

C254

C255

C256

C257

1-164-182-11 CERAMIC CHIP

1-163-037-11 CERAMIC CHIP

1-126-157-11 ELECT

1-164-492-11 CERAMIC CHIP

0.0033uF10%

0.022uF 10%

50V

25V

16V

10uF

20%

0.15uF 10%

C123

1-163-037-11 CERAMIC CHIP

0.022uF 10%

(XR-C450: E, EA)

0.22uF 10%

25V

C258

C271

C272

C273

C274

1-126-157-11 ELECT

1-126-163-11 ELECT

1-163-009-11 CERAMIC CHIP

10uF

4.7uF

1000PF 10%

20%

16V

50V

1-164-489-11 CERAMIC CHIP

16V

(XR-C440/XR-C450: US, Canadian)

C131

C132

C133

1-163-251-11 CERAMIC CHIP

1-126-160-11 ELECT

100PF 5%

50V

1-163-009-11 CERAMIC CHIP

1uF

20%

C275

C276

1-163-251-11 CERAMIC CHIP

100PF 5%

50V

(XR-C450)

50V

C134

C141

C142

C151

C152

1-163-009-11 CERAMIC CHIP

1-163-251-11 CERAMIC CHIP

1-126-157-11 ELECT

1-126-160-11 ELECT

0.001uF 10%

100PF 5%

50V

16V

50V

10uF

20%

C291

C292

C293

1-136-165-00 FILM

0.1uF

1uF

50V

C153

C154

C155

C156

C157

1-164-182-11 CERAMIC CHIP

1-163-037-11 CERAMIC CHIP

1-126-157-11 ELECT

1-164-492-11 CERAMIC CHIP

0.0033uF10%

0.022uF 10%

50V

25V

16V

C294

C311

C312

C313

C315

1-136-165-00 FILM

0.1uF

0.01uF

0.22uF 10%

0.01uF

50V

16V

50V

25V

1-164-232-11 CERAMIC CHIP

1-164-489-11 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

1-164-004-11 CERAMIC CHIP

10uF

20%

0.15uF 10%

0.1uF

10%

C158

C161

C162

C163

C171

1-126-157-11 ELECT

1-124-584-00 ELECT

1-164-232-11 CERAMIC CHIP

1-124-234-00 ELECT

1-126-163-11 ELECT

10uF

100uF 20%

0.01uF

22uF

4.7uF

20%

16V

10V

50V

16V

50V

C321

C322

C323

C324

C325

1-164-232-11 CERAMIC CHIP

1-164-489-11 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

1-163-251-11 CERAMIC CHIP

1-164-004-11 CERAMIC CHIP

0.01uF

0.22uF 10%

0.01uF

100PF 5%

0.1uF

50V

16V

50V

25V

20%

10%

C172

C173

C174

C175

1-126-163-11 ELECT

4.7uF

20%

50V

C331

C332

C333

C334

1-124-234-00 ELECT

1-124-584-00 ELECT

1-107-823-11 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

22uF

20%

16V

10V

16V

50V

1-163-009-11 CERAMIC CHIP

1-163-251-11 CERAMIC CHIP

1000PF 10%

100PF 5%

100uF 20%

0.47uF 10%

0.01uF

– 48 –

MAIN

Ref. No.

C335

Part No.

Description

Remark Ref. No.

Part No.

Description

Remark

1-164-232-11 CERAMIC CHIP

0.01uF

50V

CN601 1-774-701-11 PIN, CONNECTOR 16P

C336

C361

C362

C364

C365

1-126-157-11 ELECT

10uF

0.1uF

10uF

20%

16V

25V

16V

CN631 1-764-422-11 PLUG, CONNECTOR 12P

1-163-038-00 CERAMIC CHIP

1-126-157-11 ELECT

CN701 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)

< CONPOSITION CIRCUIT BLOCK >

20%

1-126-157-11 ELECT

CP1

1-519-504-11 GAP, DISCHARGE

< DIODE >

C366

C501

C502

C503

C504

1-126-934-11 ELECT

220uF 20%

16V

50V

16V

1-163-234-11 CERAMIC CHIP

1-163-235-11 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

1-126-157-11 ELECT

20PF

22PF

0.01uF

10uF

D331

D361

8-719-991-65 DIODE SB02W03C

8-719-977-25 DIODE DTZ9.1C

8-719-977-02 DIODE DTZ-TT11-5.6A

8-719-991-33 DIODE 1SS133T-77

8-719-977-25 DIODE DTZ9.1C

20%

C601

C602

C603

C604

1-126-938-51 ELECT

6800uF 20%

100PF 5%

16V

50V

25V

1-163-251-11 CERAMIC CHIP

1-164-004-11 CERAMIC CHIP

0.1uF

10%

D362

D501

D601

D602

D603

8-719-991-33 DIODE 1SS133T-77

8-719-914-44 DIODE DAP202K

8-719-049-38 DIODE 1N5404TU

8-719-977-69 DIODE DTZ24B

(XR-C440/XR-C450: E, EA)

C611

1-126-157-11 ELECT

10uF

20%

16V

C612

C613

C614

C615

C621

1-126-157-11 ELECT

1-163-243-11 CERAMIC CHIP

1-136-165-00 FILM

1-164-506-11 CERAMIC CHIP

1-124-589-11 ELECT

10uF

47PF

0.1uF

4.7uF

47uF

20%

16V

50V

16V

D604

D605

D606

D621

D622

8-719-105-99 DIODE RD6.2M-B1

8-719-105-99 DIODE RD6.2M-B1 (XR-C440/XR-C450: E, EA)

8-719-988-62 DIODE 1SS355 (XR-C440/XR-C450: E, EA)

8-719-976-88 DIODE DTZ3.9B

20%

C622

C631

C651

C652

C653

1-126-161-11 ELECT

2.2uF

0.22uF

0.1uF

50V

25V

8-719-988-62 DIODE 1SS355

1-164-222-11 CERAMIC CHIP

1-164-004-11 CERAMIC CHIP

1-163-038-00 CERAMIC CHIP

10%

D631

D632

D633

D634

D635

8-719-158-49 DIODE RD12SB2

8-719-109-93 DIODE RD6.2ESB2

8-719-110-49 DIODE RD18ES-B2

8-719-109-93 DIODE RD6.2ESB2

C654

C655

C661

C671

C672

1-125-710-11 CAPACITOR

1-124-584-00 ELECT

1-126-163-11 ELECT

1-126-157-11 ELECT

0.1F

100uF 20%

5.5V

10V

50V

16V

4.7uF

10uF

20%

D636

D637

D638

D639

D640

8-719-109-93 DIODE RD6.2ESB2

8-719-105-99 DIODE RD6.2M-B1

C673

C674

C675

C676

C701

1-126-157-11 ELECT

1-164-004-11 CERAMIC CHIP

10uF

0.1uF

20%

10%

16V

25V

D641

D651

D652

D661

D662

8-719-105-99 DIODE RD6.2M-B1 (XR-C450)

8-719-988-62 DIODE 1SS355

8-719-914-43 DIODE DAN202K

8-719-977-17 DIODE DTZ7.5C

C702

C703

C704

C705

1-163-038-00 CERAMIC CHIP

1-163-037-11 CERAMIC CHIP

1-163-077-00 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

0.1uF

0.022uF 10%

25V

50V

0.1uF

10%

D671

D672

D701

D702

D703

8-719-970-02 DIODE 1SR139-400

8-719-056-93 DIODE UDZ-TE-17-18B

8-719-105-99 DIODE RD6.2M-B1

0.01uF

< CONNECTOR >

CN151 1-774-699-12 JACK, PIN 4P (BUS AUDIO IN/LINE OUT)

(XR-C440)

CN151 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN/LINE OUT)

(XR-C450)

D704

D705

D706

8-719-105-99 DIODE RD6.2M-B1

8-719-988-62 DIODE 1SS355 (XR-C450)

CN301 1-766-260-11 CONNECTOR, FFC/FPC (ZIF) 7P

* CN302 1-506-995-11 PIN, CONNECTOR (PC BOARD) 13P

– 49 –

MAIN

Ref. No.

Part No.

Description

< IC >

Remark Ref. No.

Part No.

Description

Remark

JC115 1-216-296-00 CONDUCTOR, CHIP

(3216)

IC1

8-759-448-84 IC BU2624F-E2

8-759-443-67 IC LC75373ED

8-752-079-79 IC CXA2510AQ-T4

8-759-395-97 IC MM1322XFBE

8-759-461-73 IC uPD78058GC-913-3B9

JC116 1-216-296-00 CONDUCTOR, CHIP

JC117 1-216-296-00 CONDUCTOR, CHIP

JC118 1-216-296-00 CONDUCTOR, CHIP

JC119 1-216-296-00 CONDUCTOR, CHIP

JC120 1-216-296-00 CONDUCTOR, CHIP

IC161

IC301

IC361

IC501

(3216) (XR-C450)

(3216)

IC611

IC651

IC652

IC671

IC701

8-759-369-41 IC HA13155

JC121 1-216-296-00 CONDUCTOR, CHIP

JC122 1-216-296-00 CONDUCTOR, CHIP

JC123 1-216-296-00 CONDUCTOR, CHIP

JC124 1-216-296-00 CONDUCTOR, CHIP

JC125 1-216-296-00 CONDUCTOR, CHIP

(3216)

8-759-344-91 IC RN5VD23AA-TL

8-759-363-81 IC XC61AN4002PR

8-759-347-49 IC BA3918-V2

8-759-449-89 IC BA8270F-E2

< JACK >

JC126 1-216-296-00 CONDUCTOR, CHIP

JC131 1-216-296-00 CONDUCTOR, CHIP

JC132 1-216-296-00 CONDUCTOR, CHIP

JC133 1-216-296-00 CONDUCTOR, CHIP

JC134 1-216-296-00 CONDUCTOR, CHIP

(3216)

J501

1-764-808-14 JACK (ANT) (ANT IN)

1-566-822-41 JACK (REMOTE IN)

< CHIP CONDUCTOR >

JC136 1-216-296-00 CONDUCTOR, CHIP

JC137 1-216-296-00 CONDUCTOR, CHIP

JC138 1-216-296-00 CONDUCTOR, CHIP

JC139 1-216-296-00 CONDUCTOR, CHIP

(3216)

JC1

JC2

JC5

JC6

JC7

1-216-295-00 CONDUCTOR, CHIP

(2012)

JC140 1-216-296-00 CONDUCTOR, CHIP

< COIL >

(3216)

JC8

JC9

1-216-295-00 CONDUCTOR, CHIP

(2012)

1-216-057-00 METAL CHIP

2.2K

1/10W

JC10

JC11

JC12

1-216-295-00 CONDUCTOR, CHIP

(2012)

1-410-989-11 INDUCTOR CHIP 0.47uH

(XR-C440/XR-C450: US, Canadian)

1-411-669-12 COIL, CHOKE

L601

JC31

JC33

JC34

JC35

JC36

1-216-295-00 CONDUCTOR, CHIP

(2012)

< TRANSISTOR >

8-729-120-28 TRANSISTOR 2SC1623-L5L6

8-729-021-94 TRANSISTOR 2SK1657-T1B

8-729-106-68 TRANSISTOR 2SD1615A-GP

8-729-120-28 TRANSISTOR 2SC1623-L5L6

8-729-920-21 TRANSISTOR DTC314TKH04

JC37

1-216-295-00 CONDUCTOR, CHIP

(2012)

Q171

(XR-C450: US, Canadian)

(3216)

(XR-C450: E, EA)

(3216)

(XR-C450: E, EA)

(3216)

JC101 1-216-296-00 CONDUCTOR, CHIP

JC102 1-216-296-00 CONDUCTOR, CHIP

Q172

Q271

Q272

Q361

Q362

8-729-920-21 TRANSISTOR DTC314TKH04

8-729-921-48 TRANSISTOR 2SD1760F5-TRPQR

8-729-027-23 TRANSISTOR DTA114EKA-T146

JC103 1-216-296-00 CONDUCTOR, CHIP

JC104 1-216-296-00 CONDUCTOR, CHIP

Q363

Q364

Q365

Q621

Q622

8-729-900-53 TRANSISTOR DTC114EK

8-729-106-60 TRANSISTOR 2SB1115A

8-729-900-53 TRANSISTOR DTC114EK

8-729-027-23 TRANSISTOR DTA114EKA-T146

8-729-900-53 TRANSISTOR DTC114EK

JC105 1-216-296-00 CONDUCTOR, CHIP

JC106 1-216-296-00 CONDUCTOR, CHIP

JC107 1-216-296-00 CONDUCTOR, CHIP

JC108 1-216-296-00 CONDUCTOR, CHIP

JC110 1-216-296-00 CONDUCTOR, CHIP

(3216)

Q631

Q633

Q651

Q661

Q701

8-729-423-99 TRANSISTOR 2SD2137-OP

8-729-020-67 TRANSISTOR XN1A312-TX

8-729-024-31 TRANSISTOR XN1111-TX

8-729-120-28 TRANSISTOR 2SC1623-L5L6

8-729-900-53 TRANSISTOR DTC114EK

JC111 1-216-296-00 CONDUCTOR, CHIP

JC112 1-216-296-00 CONDUCTOR, CHIP

JC113 1-216-296-00 CONDUCTOR, CHIP

JC114 1-216-296-00 CONDUCTOR, CHIP

(3216)

(3216) (XR-C450)

(3216)

– 50 –

MAIN

Ref. No.

Q702

Part No.

Description

Remark Ref. No.

Part No.

Description

Remark

8-729-027-38 TRANSISTOR DTA144EKA-T146 (XR-C450)

< RESISTOR >

R192

R193

R194

1-216-298-00 METAL CHIP

2.2

1/10W

JW15

1-247-767-00 CARBON

1-216-049-11 METAL GLAZE

1-216-037-00 METAL CHIP

2.2

330

1/4W

1/10W

R201

R202

1-216-065-00 METAL CHIP

1-216-089-00 METAL GLAZE

4.7K

47K

1/10W

(XR-C440/XR-C450: US, Canadian)

(XR-C450: E, EA)

R233

R234

R242

1-216-069-00 METAL CHIP

1-216-230-00 METAL GLAZE

1-216-073-00 METAL CHIP

6.8K

22K

10K

1/10W

1/8W

1/10W

1-216-041-00 METAL CHIP

1-216-105-00 METAL GLAZE

1-216-073-00 METAL CHIP

470

220K

10K

1/10W

R251

R271

R272

R273

R274

1-216-061-00 METAL CHIP

1-216-017-00 METAL GLAZE

1-216-073-00 METAL CHIP

3.3K

10K

1/10W

R10

R11

1-216-081-00 METAL CHIP

1-216-073-00 METAL CHIP

1-216-061-00 METAL CHIP

1-216-073-00 METAL CHIP

1-216-057-00 METAL CHIP

22K

10K

3.3K

10K

2.2K

1/10W

R275

R276

R277

R278

R291

1-216-081-00 METAL CHIP

1-216-129-00 METAL CHIP

1-216-298-00 METAL CHIP

22K

2.2M

2.2

1/10W

R12

R13

R14

R15

R17

1-216-049-11 METAL GLAZE

1-216-065-00 METAL CHIP

1-216-206-00 METAL GLAZE

1-216-057-00 METAL CHIP

1-216-073-00 METAL CHIP

1/10W

1/8W

1/10W

4.7K

2.2K

10K

(XR-C450: E, EA)

R292

R293

R294

R311

R312

1-216-298-00 METAL CHIP

1-216-109-00 METAL CHIP

1-216-079-00 METAL CHIP

2.2

330K

18K

1/10W

R18

1-216-073-00 METAL CHIP

1-216-061-00 METAL CHIP

10K

1/10W

(XR-C450: E, EA)

R19

R91

R92

3.3K

1/10W

1-216-295-00 CONDUCTOR, CHIP

(2012)

1-216-049-11 METAL GLAZE

1-216-214-00 METAL GLAZE

1-216-089-00 METAL GLAZE

1-216-057-00 METAL CHIP

1/10W

R313

R314

R321

R322

R323

1-216-079-00 METAL CHIP

1-208-812-11 METAL GLAZE

1-216-109-00 METAL CHIP

1-216-079-00 METAL CHIP

18K

330K

18K

1/10W

(XR-C440/XR-C450: US, Canadian)

R101

R102

R121

R122

R133

4.7K

1/8W

47K

1/10W

(XR-C440/XR-C450: US, Canadian)

2.2K 5% 1/10W

(XR-C450: E, EA)

(2012)

(XR-C440/XR-C450: US, Canadian)

10K 5% 1/10W

(XR-C440/XR-C450: US, Canadian)

R331

R332

R333

R334

R335

1-216-009-00 METAL CHIP

1-216-065-00 METAL CHIP

1-216-077-00 METAL CHIP

1-216-113-00 METAL CHIP

1-216-073-00 METAL CHIP

1/10W

4.7K

15K

470K

10K

1-216-295-00 CONDUCTOR, CHIP

1-216-073-00 METAL CHIP

1-216-069-00 METAL CHIP

6.8K

1/10W

R361

R362

R363

R364

R365

1-216-049-11 METAL GLAZE

1-249-389-11 CARBON

1-216-073-00 METAL CHIP

1-216-065-00 METAL CHIP

4.7

10K

1/10W

1/4W

1/10W

R134

R142

R151

R171

R172

1-216-230-00 METAL GLAZE

1-216-073-00 METAL CHIP

1-216-061-00 METAL CHIP

1-216-017-00 METAL GLAZE

22K

10K

3.3K

1/8W

1/10W

4.7K

R501

R502

R503

R504

R505

1-216-206-00 METAL GLAZE

1-216-057-00 METAL CHIP

2.2K

1/8W

1/10W

R173

R174

R175

R176

R177

1-216-073-00 METAL CHIP

1-216-081-00 METAL CHIP

1-216-129-00 METAL CHIP

10K

22K

2.2M

1/10W

R506

R507

R508

R509

1-216-057-00 METAL CHIP

1-216-246-00 METAL GLAZE

2.2K

100K

1/10W

1/8W

R178

R191

1-216-129-00 METAL CHIP

1-216-298-00 METAL CHIP

2.2M

2.2

1/10W

(XR-C450: E, EA)

– 51 –

MAIN

Ref. No.

Part No.

Description

Remark Ref. No.

Part No.

Description

Remark

1/10W

R510

1-216-097-00 METAL GLAZE

100K

1/10W

R602

1-216-129-00 METAL CHIP

2.2M

(XR-C440/XR-C450: E, EA)

R511

R512

R513

R514

R515

1-216-097-00 METAL GLAZE

100K

1/10W

R611

R612

1-216-073-00 METAL CHIP

1-216-089-00 METAL GLAZE

10K

47K

1/10W

R613

R621

R622

R631

R632

1-216-097-00 METAL GLAZE

1-216-017-00 METAL GLAZE

1-216-057-00 METAL CHIP

1-249-383-11 CARBON

100K

2.2K

1.5

1/10W

1/6W

R516

R517

R518

R519

R520

1-216-097-00 METAL GLAZE

1-216-081-00 METAL CHIP

1-216-190-00 METAL GLAZE

1-216-081-00 METAL CHIP

100K

22K

470

22K

1/10W

1/8W

1-249-383-11 CARBON

1/6W

R633

R634

R636

R638

R639

1-249-383-11 CARBON

1-216-186-00 METAL GLAZE

1-216-025-00 METAL GLAZE

1.5

330

100

1/6W

1/8W

1/10W

R521

R522

R523

R524

R525

1-216-097-00 METAL GLAZE

1-216-246-00 METAL GLAZE

1-216-057-00 METAL CHIP

100K

2.2K

1/10W

1/8W

1/10W

R640

1-216-057-00 METAL CHIP

2.2K

1/10W

(XR-C450)

R641

R642

R651

R652

1-208-806-11 METAL GLAZE

1-216-113-00 METAL CHIP

1-216-097-00 METAL GLAZE

10K

470K

100K

0.50% 1/10W

R526

R527

R528

R529

R530

1-216-057-00 METAL CHIP

1-216-246-00 METAL GLAZE

1-216-097-00 METAL GLAZE

1-216-246-00 METAL GLAZE

2.2K

1/10W

1/8W

1/10W

1/8W

100K

1/10W

R653

R654

R655

R656

R661

1-208-806-11 METAL GLAZE

1-216-025-00 METAL GLAZE

1-216-206-00 METAL GLAZE

10K

100

2.2K

0.50% 1/10W

R531

R532

R533

R534

R535

1-216-097-00 METAL GLAZE

1-216-246-00 METAL GLAZE

1-216-025-00 METAL GLAZE

1-208-806-11 METAL GLAZE

1-216-085-00 METAL CHIP

100K

100

10K

33K

1/10W

1/8W

1/10W

1/8W

0.50% 1/10W

1/10W

(XR-C440)

R662

R663

R664

R665

R701

1-216-073-00 METAL CHIP

1-216-089-00 METAL GLAZE

1-216-085-00 METAL CHIP

1-216-017-00 METAL GLAZE

10K

47K

33K

1/10W

R535

R536

R537

R538

1-216-097-00 METAL GLAZE

1-216-089-00 METAL GLAZE

1-216-097-00 METAL GLAZE

1-216-093-00 METAL CHIP

100K

47K

1/10W

(XR-C450)

1/10W

(XR-C440)

1/10W

(XR-C440)

R702

R703

R704

R705

1-216-073-00 METAL CHIP

1-216-174-00 METAL GLAZE

1-216-025-00 METAL GLAZE

1-216-089-00 METAL GLAZE

10K

100

47K

1/10W

1/8W

1/10W

(XR-C450)

100K

1/10W

(XR-C450: US, Canadian)

5% 1/10W

(XR-C450: US, Canadian)

68K

< VARIABLE RESISTOR >

R538

R539

R540

R541

1-216-097-00 METAL GLAZE

1-216-093-00 METAL CHIP

1-216-097-00 METAL GLAZE

100K

1/10W

RV131 1-223-829-11 RES, ADJ, CARBON 1.0K

RV231 1-223-829-11 RES, ADJ, CARBON 1.0K

(XR-C440/XR-C450: E, EA)

100K

68K

1/10W

(XR-C440)

1/10W

(XR-C440)

1/10W

< SWITCH >

S501

S502

1-571-478-11 SWITCH, SLIDE (POWER SELECT)

1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT)

(XR-C440/XR-C450: E, EA)

100K

(XR-C450: E, EA)

5% 1/10W

100K

S503

1-692-431-21 SWITCH, TACTILE (RESET)

(XR-C440/XR-C450: US, Canadian)

< TUNER >

R542

R601

1-216-198-00 METAL GLAZE

1-216-049-11 METAL GLAZE

1/8W

1/10W

TU1

A-3282-019-A TUNER UNIT TUX-008 (EA) (XR-C450: E, EA)

(XR-C440/XR-C450: E, EA)

– 52 –

MAIN

Ref. No.

TU1

Part No.

Description

Remark Ref. No.

Part No.

Description

Remark

A-3282-034-A TUNER UNIT TUX-010 (E)

3-859-894-11 MANUAL, INSTRUCTION, INSTALL

(XR-C440/XR-C450: US, Canadian)

(ENGLISH, ARABIC) (XR-C450: EA)

3-859-492-21 MANUAL, INSTRUCTION, INSTALL

(ENGLISH, SPANISH, CHINESE) (XR-C440)

9-939-081-01 LID, BATTERY CASE (for RM-X40)

X-3373-371-1 CASE ASSY (for FRONT PANEL)

< VIBRATOR >

X501

X502

1-577-126-51 VIBRATOR, CRYSTAL (7.2MHz)

1-579-233-11 VIBRATOR, CERAMIC (5MHz)

1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)

************************************************************

PARTS FOR INSTALLATION AND CONNECTIONS

**************************************

MISCELLANEOUS

**************

501

502

3-916-161-31 FRAME ASSY

X-3370-077-1 SCREW ASSY (AE.KEY), FITTING

1-776-207-11 CORD (WITH CONNECTOR)

(XR-C440/XR-C450: E, EA)

1-776-207-31 CORD (WITH CONNECTOR)

(XR-C450: US, Canadian)

1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)

(XR-C440/XR-C450: E, EA)

503

504

505

3-386-828-01 SCREW, FITTING (XR-C440/XR-C450: E, EA)

3-349-410-01 BUSHING (XR-C440/XR-C450: E, EA)

3-388-078-01 KEY (XR-C440/XR-C450: E, EA)

F901

HP901 1-500-196-21 HEAD, MAGNETIC (PLAYBACK)

M901 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL)

************************************************************

506

507

3-924-961-01 SUPPORT (ND), FITTING

(XR-C450: US, Canadian)

X-3370-076-1 SCREW ASSY (KEY), FITTING

(XR-C450: US, Canadian)

**************

HARDWARE LIST

**************

508

509

510

7-682-560-04 SCREW +P 4X6 (XR-C450: US, Canadian)

3-926-426-01 KEY (XR-C450: US, Canadian)

X-3371-913-1 SCREW ASSY (J)

7-621-772-10 SCREW +B 2X4

511

512

3-934-325-01 SCREW, +K (5X8) TAPPING

1-776-207-11 CORD (WITH CONNECTOR)

(XR-C440/XR-C450: E, EA)

7-685-793-09 SCREW +PTT 2.6X8 (S)

7-685-792-09 SCREW +PTT 2.6X6 (S)

7-685-794-09 SCREW +PTT 2.6X10 (S)

7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT

512

1-776-207-31 CORD (WITH CONNECTOR)

(XR-C450: US, Canadian)

513

514

X-3373-432-1 BRACKET ASSY (XR-C440)

1-775-543-11 CORD, GROUND

7-624-104-04 STOP RING 2.0, TYPE-E

7-627-553-17 PRECISION SCREW +P 2X2 TYPE3

************************************************************

XR-C440/XR-C450:E, EA

502

501

503

504

505

ACCESSORIES & PACKING MATERIALS

********************************

1-467-559-22 REMOTE COMMANDER (RM-X40)

(XR-C450: E, EA)

XR-C450: US, Canadian

507

1-473-067-31 REMOTE COMMANDER (RM-X2S) (XR-C440)

3-856-246-61 MANUAL, INSTRUCTION, INSTALL (for RM-X2S)

(ENGLISH, FRENCH, GERMAN, DUTCH, SWEDISH,

ITALIAN, PORTUGUESE, CHINESE) (XR-C440)

3-859-489-31 MANUAL, INSTRUCTION (ENGLISH)

(XR-C450: US, Canadian)

506

508

509

510

511

512

3-859-489-41 MANUAL, INSTRUCTION (FRENCH)

(XR-C450: Canadian)

3-859-489-51 MANUAL, INSTRUCTION

XR-C440

513

(ENGLISH, SPANISH, CHINESE) (XR-C450: E)

3-859-490-31 MANUAL, INSTRUCTION, INSTALL

(ENGLISH, FRENCH) (XR-C450: US, Canadian)

3-859-490-41 MANUAL, INSTRUCTION, INSTALL

(ENGLISH, SPANISH, CHINESE) (XR-C450: E)

514

3-859-491-21 MANUAL, INSTRUCTION

(ENGLISH, SPANISH, CHINESE) (XR-C440)

3-859-893-11 MANUAL, INSTRUCTION (ENGLISH, ARABIC)

(XR-C450: EA)

– 53 –

XR-C440/C450

REVISION HISTORY

Clicking the version allows you to jump to the revised page.

Also, clicking the version at the upper right on the revised page allows you to jump to the next revised

page.

Ver.

1.1

Date

Description of Revision

Correction-1 is included

2001.08

1997.05

1997.01

1.0

Correction-1

New

– 54 –

Westcott 1090 User Manual
Weil McLain SERIES 2 LGB 17 User Manual
Vivitar DVR510N User Manual
ToCAD PRO 723P User Manual
Tamron SP A08 User Manual
Sprint Nextel PCS VISION MM A800 User Manual
Sony M2000 Microcassette Transcribing Machine M2000 User Manual
Sony DVX 11A User Manual
Sony Camcorder DSC F1 User Manual
Rockford Fosgate RFX9000 User Manual