XR-C8100/C8100R
SERVICE MANUAL
AEP Model
UK Model
XR-C8100R
E Model
XR-C8100
Photo : XR-C8100R
Model Name Using Similar Mechanism
Tape Transport Mechanism Type
XR-C7200/C7200W
MG-25D-136
SPECIFICATIONS
AM (C8100)
Tuning range
Cassette player section
AM tuning interval:
9 kHz / 10 kHz switchable
531 - 1,602 kHz
(at 9 kHz step)
530 - 1,710 kHz
Tape track
4-track 2-channel stereo
Wow and flutter
Frequency response
0.08 % (WRMS)
30 - 20,000 Hz (C8100)
10 - 20,000 Hz (C8100R)
Signal-to-noise ratio
(at 10 kHz step)
Cassette type
TYPE II, III, IV
TYPE I
Dolby B NR
Dolby NR off
61 dB
Aerial terminal
Intermediate frequency
Sensitivity
External antenna connector
10.71 MHz / 450 kHz
30 µV
67 dB
64 dB
58 dB
Tuner section
FM
Tuning range
MW/LW (C8100R)
Tuning range
MW: 531 - 1,602 kHz
LW: 153 - 281 kHz
External antenna connector
10.71 MHz / 450 kHz
MW: 30 µV
C8100:
FM tuning interval:
50 kHz / 200 kHz
switchable
87.5 - 108.0 MHz
(at 50 kHz step)
87.5 - 107.9 MHz
(at 200 kHz step)
C8100R:
Aerial terminal
Intermediate frequency
Sensitivity
LW: 50 µV
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
4 - 8 ohms
Maximum power output 45 W × 4 (at 4 ohms)
87.5 - 108.0 MHz
External antenna connector
10.7 MHz
Speaker impedance
Aerial terminal
Intermediate frequency
Usable sensitivity
Selectivity
9 dBf
– Continued on next page –
75 dB at 400 kHz
65 dB (stereo),
68 dB (mono)
Signal-to-noise ratio
Harmonic distortion at 1 kHz
0.7% (stereo),
0.4% (mono)
35 dB at 1 kHz
30 - 15,000 Hz
2 dB
Separation
Frequency response
Capture ratio
FM/AM CASSETTE CAR STEREO
XR-C8100
FM/MW/LW CASSETTE CAR STEREO
XR-C8100R
MICROFILM
– 16 –
– 17 –
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. COVER
1 claw
4 cover
3 claws
2 claw
2-2. FRONT PANEL ASSY
3 Push the bearing (L).
2 Push the bearing (R).
4 front panel assy
1 Push the button (open).
– 18 –
2-3. SUB PANEL ASSY
4 claws
7 CN500
3 PTT 2.6x6
6 CN802
5 claw
2 PTT 2.6x6
1 PTT 2.6x6
8 sub panel assy
2-4. MECHANISM DECK
1 screws
(2.6x6) (C TIGHT)
4 mechanism deck
2 CN201
3 CN250
– 19 –
2-5. MAIN BOARD
3 ground point screw
4 ground point screws
2 PTT 2.6x10
5 MAIN board
6 insulated plate
1 PTT 2.6x10
2-6. HEAT SINK
1 CN551
2 J10
9 heat sink
4 cord (with connector) (INVERTER)
3 PTT 2.6x10
7 PTT 2.6x10
8 PTT 2.6x10
6 cord (with connector)
5 PTT 2.6x10
(ANTENNA)
– 20 –
SECTION 3
ASSEMBLY OF MECHANISM DECK
Note : Follow the assembly procedure in the numerical order given.
7 Holder the hanger by bending the claw.
1 Install the catcher to the hanger.
HOUSING
5 Fit projection on C part.
2 Install the hanger onto
two claws of the housing.
hanger
4 Fit claw on B part.
3 Put the housing
6 Fit projection on D part.
under A part.
housing
C part
8 Hold the hanger by
bending the claw.
D part
A part
B part
ARM (SUCTION)
2 Move the arm (suction) in the arrow
direction and fit on projection.
projection
1 Fit the arm (suction) on the shaft.
– 21 –
LEVER (LDG-A) / (LDG-B)
shaft A
shaft A
shaft B
shaft C
shaft B
1 Fit the lever (LDG-A) on
shafts A – C and install it.
3 type-E stop ring 2.0
2 Fit the lever (LDG-B) on
shafts A and B and
install it.
GEAR (LOADING FT)
gear (LDG-D)
5 gear (loading FT)
6 polyethylene washer
hole
hole
lever (LDG-A)
gear (LDG-FB)
4 Align hole in the gear (LDG-D)
with hole the lever (LDG-A).
1
2 tension spring (LD-2)
3 Move the lever (LDG-B)
in the arrow direction.
2 tension spring (LD-1)
– 22 –
GUIDE (C)
2 guide (C)
1 three claws
MOUNTING POSITION OF CAPSTAN/REEL MOTOR (M901)
1 precision screws
+P 2x2
capstan/ reel motor
30˚
– 23 –
SECTION 4
SECTION 5
MECHANICAL ADJUSTMENTS
ELECTRICAL ADJUSTMENTS
PRECAUTION
1. Wipe the following components with an absorbent cotton cloth
See the adjustment location from on page 28 for the adjust-
ment.
moistened with alcohol before adjustment :
PB head
Idler
Pinch roller
Rubber belt
0 dB = 0.775 V
TAPE SECTION
Capstan
Tape Speed Adjustment
Procedure :
1. Put the set into the FWD PB mode.
2. Demagnetize the PB head using a head demagnetizer.
3. Be careful not to use a magnetized screwdriver.
4. After the adjustment is completed, lock the adjustment parts
using screws.
speed checker
or
frequency counter
5. Unless otherwise specified, make adjustments at the specified
voltage (14.4V).
test tape
WS-48A
(3 kHz, 0 dB)
10 k Ω
Torque Measurement
Mode
Torque Meter
Meter Reading
35 – 65 g • cm
set
FWD
(0.49 – 0.90 oz • inch)
0.5 – 5.0 g • cm
LINE OUT REAR
CQ-102C
FWD
Specification : Constant speed
Speed checker
Back Tension
(0.01 – 0.07 oz • inch)
35 – 65 g • cm
Frequency counter
REV
(0.49 – 0.90 oz • inch)
0.5 – 5.0 g • cm
– 1 to + 2 %
2,970 to 3,060 Hz
CQ-102RC
CQ-201B
REV
Adjustment Location : See page 28.
Back Tension
(0.01 – 0.07 oz • inch)
60 – 200 g • cm
DOLBY Level Adjustment
Setting :
FF, REW
(0.83 – 2.78 oz • inch)
SHIFT n 3 (PLAY MODE) (twice) button : NR off
Tape Tension Measurement
test tape
P-4-D400
(400 Hz, 0 dB)
Mode
FWD
REV
Tension Meter
CQ-403A
Meter Reading
more than 60 g
level meter
CQ-403R
(more than 2.12 oz)
set
main board
TP (DOLBY)
TP230 (L-CH)
TP240 (R-CH)
Procedure :
1. Put the set into the FWD PB mode.
2. Adjust RV230 (L-CH) and RV240 (R-CH) so that level meter
reading is – 6 ± 1 dB (0.35 to 0.44 V).
Adjustment Location : See page 28.
– 24 –
FM Auto Scan/Stop Level Adjustment
Setting :
TUNER SECTION
0 dB = 1 µV
SOURCE button
FREQUENCY SELECT switch (C8100) : FM 200K
: FM
Cautions during repair
When the tuner unit is defective, replace it by a new one because
its internal block is difficult to repair.
FM RF signal
generator
antenna
terminal
TEST MODE
This set have the test mode function. In the test mode, FM Auto
Scan/Stop Level and AM (MW) Auto Scan/Stop Level adjustments
can be performed easier than it in ordinary procedure.
0.01 µF
<Set the Test Mode>
1. Set the “OFF” mode.
2. Push the preset 4 button.
3. Push the preset 5 button.
4. Press the preset 1 button for more than two seconds.
5. Then the display indicates all lights, the test mode is set.
Carrier frequency : 97.9 MHz (C8100)
98.00 MHz (C8100R)
Output level
Mode
: 22 dB (12.6 µV)
: mono
Modulation
: 1 kHz, 22.5 kHz deviation (30%)
Procedure :
1. Set to the test mode.
2. Push the SOURCE button and set to FM.
<Release the Test Mode>
1. Push the OFF button.
Display
Note on Adjustment
The adjustments of tuner section, should be performed according
to the following sequence.
1. FM Auto Scan/Stop Level Adjustment
2. FM Stereo Separation Adjustment (WIDE)
3. FM Stereo Separation Adjustment (NARROW)
4. FM RDS S-Meter Adjustment (XR-C8100R only)
5. AM (MW) Auto Scan/Stop Level Adjustment
SHUF
*1
*2
REG
3. Push the preset 3 button.
Display
SHUF
*1
*2
REG
4. Adjust with the volume RV2 on TUX10 so that the “FM”
indication turns to “FM0” indication on the display window.
But, in case of already indicated “FM0”, turn the RV2 so that
put out light “0” indication and adjustment.
Display
SHUF
*1
*2
REG
*1 : XR-C8100R has the “98.00” displayed.
*2 : “REG” is displayed only for XR-C8100R.
Adjustment Location : See page 28.
– 25 –
FM Stereo Separation Adjustment (WIDE)
FM Stereo Separation Adjustment (NARROW)
Setting :
Setting :
SOURCE button
: FM
SOURCE button
: FM
FREQUENCY SELECT switch (C8100) : FM 200K
FREQUENCY SELECT switch (C8100) : FM 200K
FM RF signal
FM RF signal
generator
generator
level meter
level meter
antenna
terminal
antenna
terminal
10 k Ω
10 k Ω
0.01 µF
0.01 µF
set
set
LINE OUT REAR
LINE OUT REAR
Carrier frequency : 97.9 MHz (C8100)
: 98.00 MHz (C8100R)
Carrier frequency : 97.9 MHz (C8100)
: 98.00 MHz (C8100R)
Output level
Mode
: 70 dB (3.2 mV)
: stereo
Output level
Mode
: 70 dB (3.2 mV)
: stereo
Modulation
: main : 1 kHz, 33.75 kHz deviation (45%) (C8100)
1 kHz, 20 kHz deviation (26.5%) (C8100R)
sub : 1 kHz, 33.75 kHz deviation (45%) (C8100)
1 kHz, 20 kHz deviation (26.5%) (C8100R)
19 kHz pilot : 7.5 kHz deviation (10%)
Modulation
: main : 1 kHz, 33.75 kHz deviation (45%) (C8100)
1 kHz, 20 kHz deviation (26.5%) (C8100R)
sub : 1 kHz, 33.75 kHz deviation (45%) (C8100)
1 kHz, 20 kHz deviation (26.5%) (C8100R)
19 kHz pilot : 7.5 kHz deviation (10%)
Procedure :
Procedure :
1. Push the SHIFT button.
2. Push the 4 button three times.
3. Push the 5 button twice and set to NARROW mode.
FM stereo
Level meter
connection
Level meter
reading (dB)
signal generator
output channel
L-CH
FM stereo
Level meter
connection
Level meter
reading (dB)
L-CH
L-CH
R-CH
R-CH
A
signal generator
output channel
L-CH
B
R-CH
R-CH
L-CH
Adjust RV3 on TUX10
for minimum reading.
L-CH
L-CH
R-CH
R-CH
A
B
C
R-CH
R-CH
L-CH
Adjust RV4 on TUX10
for minimum reading.
D
Adjust RV3 on TUX10
for minimum reading.
C
D
L-CH stereo separation : A – B
R-CH stereo separation : C – D
Adjust RV4 on TUX10
for minimum reading.
The separations of both channels should be equal.
Specification : Separation more than 24 dB
Adjustment Location : See page 28.
L-CH stereo separation : A – B
R-CH stereo separation : C – D
The separations of both channels should be equal.
Specification : Separation more than 18 dB
Adjustment Location : See page 28.
– 26 –
FM RDS S-Meter Adjustment (XR-C8100R only)
Setting :
AM (MW) Auto Scan/Stop Level Adjustment
Setting :
SOURCE button : FM
SOURCE n MODE button
: AM (C8100)
MW (C8100R)
FREQUENCY SELECT switch (C8100) : AM 10K
FM RF signal
generator
15 pF
30 Ω
antenna
terminal
0.01 µF
65 pF
set
Carrier frequency : 98.00 MHz
AM RF signal
generator
Output level
Mode
: 35 dB (56.2 µV)
: mono
AM dummy
antenna (50 Ω)
Modulation
: no modulation
set
Procedure :
1. Set to the test mode. (See page 25.)
2. Push the SOURCE button and set to FM.
Display
antenna
terminal
Carrier frequency : 1000 kHz (C8100)
999 kHz (C8100R)
30% amplitude
SHUF
modulation by
1 kHz signal
output level
: 33 dB (44.7 µV)
REG
Procedure :
1. Set to the test mode. (See page 25.)
2. Push the SOURCE button.
3. Push the MODE button and set to AM (C8100) or MW
3. Push the preset 10 button.
4. Adjust RV10 so that the display indication is “13.2”.
Display
(C8100R).
Display
SHUF
*1
SHUF
*2
REG
TP
Specification : Display indication : 13.0 to 13.4
4. Push the preset 3 button.
Display
Adjustment Location : See page 28.
*1
SH*U2F
TP
5. Adjust with the volume RV1 on TUX10 so that the “AM”
(C8100) or “MW” (C8100R) indication turns to “AM0” (C8100)
or “MW” (C8100R) indication on the display window.
But, in case of already indicated “AM0” (C8100) or “MW”
(C8100R), turn the RV1 so that put out light “0” indication and
adjustment.
Display
*1
SH*U2F
TP
*1 : XR-C8100R has the “MW” displayed.
*2 : XR-C8100R has the “999” displayed.
Adjustment Location : See page 28.
– 27 –
Adjustment Location : tuner unit (TUX10)
– set upper view –
TAPE SPEED ADJ
TUX10
RV1
AM (MW) AUTO SCAN/
STOP LEVEL ADJ
RV2
FM AUTO SCAN/
STOP LEVEL ADJ
RV240
(R-CH)
DOLBY
LEVEL
ADJ
RV3
FM STEREO
SEPARATION ADJ
(WIDE)
RV230
(L-CH)
RV4
FM STEREO
SEPARATION ADJ
(NARROW)
RV10
FM RDS
S-METER ADJ
(XR-C8100R only)
– set lower view –
L-CH
R-CH
TP (DOLBY)
DOLBY LEVEL
ADJ
– 28 –
XR-C8100/C8100R
SECTION 6
DIAGRAMS
6-1. BLOCK DIAGRAM — TAPE SECTION —
TUNER
SECTION
TA-L
1
SYSTEM CONTROL
IC600 (3/3)
LCD DRIVER
IC900
TAPE EQ/DOLBY NR
IC250
PON10V LCD10V
FWD/REV
MTL/NRM
NR ON
SEG101
19
18
16
113 N-R
102 MTL
DOLBY
SO 13
CKO 14
CE 16
18
17
19 CE
DATA
CLK
HP901
PLAYBACK HEAD
LCD900
|
SEG165
LIQUID
CRYSTAL
DISPLAY
PANEL
FL
L
34
32
116
COM100
|
COM107
FWD
R
INH 32
14 INH
DOLBY
NR
R-CH
R-CH
EQ
29
GRN
YEL
24
LCD ANGLE
CONTROL
Q508, 509
ANG 41
11
VLCD
COLOR
SELECT
Q900-903
L
REV
R
GREEN
AMBER
1
2
RL
AUTO
MUSIC
SENSOR
MUTE
AMS/PLAY
(METAL DET)
Q250
14
103
AMS
REIN1 36
17
20
RE900
ROTARY
ENCODER
114 AMS ON
R-CH
27
REIN0 37
EJECT
R230
SW500
(NOSE SW)
105
106
107
NOSESW 80
POS0
POS1
POS2
S901
TAPE
OPERATION
DOLBY
LEVEL
(L ch)
FF (NOR)
REW (NOR)
REV
C8100R
LED
LED801
TIR
DRIVER
Q502
108 POS3
31
TIRIND
FWD
M902
LOADING/TAPE
LED
DRIVER
Q501
LED800
(TAPE WINDOW)
LED802
M
PACKIND 59
POWSEL 56
OPERATION MOTOR
(TAPE DET)
MOTOR
ON
7
9
4
2
109
LMEJ
110 LMLOD
DRIVER
S600
IC201
(POWER SELECT)
OFF
M901
CAPSTAN/REEL
MOTOR
MOTOR
DRIVER
M
111 CMON
Q201, 204
T/R
REEL
SENSOR
C8100
REEL
BUFFER
104
FM50k
AM9k
8.5V REG
Q202, 203
DSTSEL2 51
TA8.5V
BATT
S601
FREQUENCY
SELECT
112
76
TAPE ON
KEY ACK
FM100k
AM10k
KEY-ACK
BU5VA
BU5VA
DETECT
Q510
D510
D506
35 AD ON
KEY-ACK
DETECT
Q511
46
I/F+B
KEY IN0
47 KEY IN1
KEY IN
MATRIX
• Signal path
: TAPE
48
72
RC IN0
RC IN1
J500
(REMOTE IN)
04
– 29 –
– 30 –
XR-C8100/C8100R
6-2. BLOCK DIAGRAM — TUNER SECTION —
AMP
IC50
1
FL
FL
24
23
ELECTRONIC VOLUME
IC301
3
FM
AM
40
39
TUNER UNIT
TUX10
C8100
(ANTENNA)
VOL/
TONE
2
MAIN
FADER
RL
R-CH
33
32
26
25
L
C8100R
TAPE
AUX
TAPE
2
FM ANT
18
16
12
OUT
TA-L
41
42
1
SECTION
R
SECTION
RL
R-CH
-1
-2
CN780
OUT
L
16 21 17
22
BUS AUDIO
IN
AM
DET
2
1
6
5
1
8
AM ANT
FM+B
R-CH
R
Q50
Q60
SUBL
7
23
FM 8V
SWITCH
IC51
6
7
Q53
Q52
AMP
IC320
5
7
1
VREF (L)
R-CH
D10
+B
9
3
SYSTEM CONTROL
IC600 (1/3)
VREF (R)
AM+B
AM 8V
D50
10
REF VOLTAGE
IC302
VOL CE 64
TIR
60
SO 66
VOL/
SUB
PLAY
C8100
67
68
CKO
MUTE
TUN
MUTE
SUB CE
CONTROL
Q51
5
VOICE SYNTHESIZER
IC650
RV10
S-METER
17
22
8
15 SD
14
RST
NAR
9
RESET
NAR
ST
A OUT
9
8
7
ADPCM/
DAC
23
117
CE 23
SO 21
BUFFER
Q13
S-METER 19
53
VSM
2
3
XT
XT
EQ
CONTROL
Q360, 362
C8100R
VOL
20
15
X650
4.19MHz
SI
CKO 22
RECEIVE/SEEK
1
20
4
13
20
SEEK OUT
SD IN
ST/MONO
SD
ELECTRONIC
VOLUME
IC350
SD IND 22
SW1 61
SW0 62
WIDE/
SUB
NARROW
CONTROL
Q14, 15
WIDE/NARROW
24
3
WIDE
C8100R
C8100R
AM+B
IC11
TIR CONTROL
IC100
TUNER PLL
IC10
ADPCM/
DAC
VT
CONTROL
Q17
VT
5
18
SEK
PD
7
2
4
5
6
1
CE
CLK
28
27
26
25
CE
A OUT
XT1
4
11
21
6
9
LO/DX
AMIF
FMIF
VCO
LO/DX
IF IN
AM OSC
FM OSC
CKO
SO
SI
18
47
13
15
16
DIN
DOUT
XO
TIR SIGNAL
REGISTER
IC101
X100
4.19MHz
D0-3
D0-3
XT2
D-IN/OUT
RWCK
48
44
50
X10
7.2MHz
95
98
101
96
99
5
BUSY
CE1
RD
WR
RES
BUSY
CE
RD
XI
20
DOUT
56
55
54
15
D-IN
RWCK
11
2
• Signal path
: FM
WR
C8100R
53 RESET
WE 46
CSI 40
16 WE
PDWN 100
97
CS
35
11
17
18
22
23
PDWN
CE
RDS DEMODULATOR
IC150
: AM(MW)
: TAPE
CE0
37
TAS
SAS
SAD
TAS
36
SAS
4
5
2
8
9
52
75
70
71
OSCD
DSCI
MPTH
DAVN
SDA
MTP
DAVN
SIO
39
SADX
X150
4.332MHz
SCL
CKO
10
16
S-METER
(RDS)
04
15
23
20 LVIN
MPX
BUFFER
Q12
FM DET
26
– 31 –
– 32 –
XR-C8100/C8100R
6-3. BLOCK DIAGRAM — MAIN SECTION —
LINE DRIVER
IC310
-1
-2
CN781
FRONT
L
FL
2
7
13
12
R
R-CH
R-CH
LINE OUT
-3
-4
CN780
REAR
RL
L
2
Q330
Q361
Q340
R
TUNER
SECTION
AMP
IC383
-3
-4
1
3
CN781
SUB L
L
SUB OUT
BATT
R
R-CH
BUS INTERFACE
IC602
BATT(H)
CHECK
Q600
SYSTEM CONTROL
IC600(2/3)
MUTE
CONTROL
Q702
BATT(L)
CHECK
BATT
3
10
BUIN
77
POWER AMP
IC700
BU CHECK
IC501
RA MBU
1
2
55
65
73
74
BU5VA
CN700
1
2
4
13
11
8
RESET
SYSRST
MUTE
CK
11
19
17
18
10
BATT
7
MUTE
2
5
CLK
FL+
X601
CN600
(BUS CONTROL IN)
32.768KHz
12
9
2
X1A
10V REG
Q504
PON10V
BATT
3
9
FL–
1
2
3
4
5
6
SI
DT
6
X0A
RL+
9
SO
11
4
10
X600
3.68MHz
POWER
CONTROL
Q505
7
RL–
8
BUS
ON
1
12
BUS ON
X0
X1
92
93
12
Q602
ST-BY
DOOR
DET
D524
4
12
3
FR+
FR–
IR
SIRCS
RST
RECEIVER
IC901
1
24
90
DOOR
DOOR SW
LED ON 118
R-CH
DET
RR+
RR–
RESET
IC500
BU5VA
2
1
Q503
11
SW800
RESET
BEEP
DRIVE
Q601
POWER
CONTROL
Q703,704
5
BZ600
(BUZZER)
BEEP
ACC IN
ILL IN
15
81
78
BATT
AMP-R
ACC
POWER SUPPLY
IC502
ACC
CHECK
Q705
7
FM+B
10 AM+B
COM+B
ANT+B
BATT
FM8V
AM8V
COM8V
ANT+B
11
VCC
7
ILL
CHECK
Q512
14
ILL
Q603
9
8
4
3
2
120 POW ON
STB
MODE1
MODE2
13
15
16
6
FM ON TEL MUTE
6
7
79
58
TEL MUTE
TEST
TU ON
TEST IN
BATT
BATT
DIMMER
ILL ON
30
D532
ANT+B
ANT-R
29
BU5VA
BU5VB
6V REG
IC503
3
1
BATT
DIMMER
CONTROL
IC550
D533
POWER
ON/OFF
DRIVE
Q556,557
EL
EL900
BATT
SWITCH
Q550,551
Q552-555
• Signal path
: FM
10V REG
Q506
LCD10V
BATT
POWER
CONTROL
Q507
04
– 33 –
– 34 –
6-8. IC PIN DESCRIPTION
• IC600 MB90574PFV-G-115-BND (SYSTEM CONTROL) (XR-C8100R)
MB90574PFV-G-116-BND (SYSTEM CONTROL) (XR-C8100)
Pin No.
1
Pin Name
SEKOUT
AF-SEEK
WIDE
I/O
O
O
O
I/O
O
O
O
—
O
O
O
I
Pin Description
SEEK OUT output
2
AF SEEK output
3
WIDE/NARROW select output
4
ST-MONO
TUNMUTE
FM-ON
TU-ON
VCC
Use a thing both as ST-IND display input and force MONO output.
Tuner mute output
5
6
FM ON output
7
Tuner ON output
8
Power supply pin (+5 V)
9
CSV-RST
BUSON
SYSRST
DOORSW
LCDSO
LCDCKO
BEEP
Audio composition IC reset output
Bus ON control output
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36, 37
38
39
40
41
42
43
44
45
46, 47
48
49
50
51
System reset output
Door OPEN/CLOSE detection input
LCD serial data output
O
O
O
O
O
O
I
LCD serial clock output
BEEP output
LCDCE
UNISI
LCD chip enable output
Serial data input
UNISO
UNICKI
SD-IN
Serial data output
Serial clock input
I
Signal detector input
CSV-SO
CSV-CKO
CSV-CE
SIRCS
O
O
O
I
Audio composition serial data output
Audio composition serial clock output
Audio composition chip enable output
Remote commander input
PLL data input
PLLSI
I
PLLSO
PLLCKO
PLLCE
ILL-ON
DIMMER
TIRIND
LCDINH
VSS
O
O
O
O
I/O
O
O
—
—
O
I
PLL data output
PLL clock output
PLL chip enable output
Illumination power control output
Dimmer control input/output
TIR indicator control output (C8100R)
LCD blank display control output
GND
C
Power stabilization capacitor pin
Power control output of A/D conversion.
Rotary encoder input 0, 1
D/A converter VREF input
GND of D/A converter.
AD-ON
RE-IN0, 1
DVCC
—
—
O
O
—
—
—
—
I
DVSS
EL-ON
Not used.
LCDANG
AVCC
LCD view angle alignment output
Analog power supply pin (+5 V)
A/D converter VREF+ input
A/D converter VREF- input
Analog GND
AVRH
AVRL
AVSS
KEYIN0, 1
RC-IN0
DSTSEL0
DSTSEL1
DSTSEL2
Key input 0, 1
I
Rotary commander input 0
Destination select input 0 (Fixed at “L” in this set.)
Destination select input 1 (Fixed at “H” in this set.)
Destination select input 2 (Fixed at “L” in this set.) (C8100R)
Frequency select input (C8100)
I
I
I
– 51 –
Pin No.
52
Pin Name
MTP
I/O
I
Pin Description
Tuner multi-pass input
53
VSM
I
S-Meter voltage detection input
Power supply pin (+5 V)
54
VCC
—
I
55
RAMBU
POWSEL
EQ-SEL
TESTIN
PACK-IND
TIRPLAY
SUB-SW1, 0
VSS
RAM reset detection input
Power select initial setting input
56
I
57
I
Equalizer connection with/without detection initial input
Test mode setting detection input
Door indicator output
58
I
59
O
O
O
—
O
O
O
O
O
I
60
Audio line select control output at TIR playback. (C8100R)
Simple SUB WOOFER control output 1, 0
GND
61, 62
63
64
VOLCE
MUTE
Electric volume serial chip enable output
System mute control output
65
66
VOLSO/SUBSO
VOLCKO/SUBCKO
SUBCE
FLASH-W
I2CSIO
I2CCKO
RC-IN1
X1A
Main/Sub volume serial data output
Main/Sub volume serial clock output
Sub volume serial chip enable output
Flash write in mode detection input
RDS serial data input/output
67
68
69
70
I/O
O
I
71
RDS serial clock output
72
Rotary commander input
73
—
—
I
Low speed oscillation input (32.768 kHz)
Low speed oscillation input (32.768 kHz)
RDS IC data taking in detection input
Key input acknowledge
74
X0A
75
DAVN
76
KEYACK
BU-IN
I
77
I
Back-up power detection input
78
ILLIN
I
Illumination line detection input
Telephone mute detection input
Front panel detachable detection input
Accessory power detection input
TIR IC command input/output 0 – 3 (C8100R)
Connect to power supply pin.
79
TELMUTE
NOSESW
ACCIN
TIR-D0 – D3
(VCC)
I
80
I
81
I
82 – 85
86
I/O
—
—
—
I
87
(VSS)
Connect to GND.
88, 89
90
(VCC)
Connect to power supply pin.
RST
Microcomputer reset input
91
VSS
—
—
—
—
I
GND
92
X0
High speed oscillation input (3.68 MHz)
High speed oscillation input (3.68 MHz)
Power supply pin (+5 V)
93
X1
94
VCC
95
TIR-BUSY
TIR-WR
TIR-CE0, 1
TIR-RES
TIR-PDWN
TIR-RD
MTLIN
AMSTIN
REEL
TIR IC BUSY output monitor pin (C8100R)
TIR IC data write in pulse output (C8100R)
TIR IC chip enable output (C8100R)
TIR IC reset/power down output (C8100R)
TIR IC power down output (C8100R)
TIR IC data read in pulse output (C8100R)
Auto METAL detection input
96
O
O
O
O
O
I
97, 98
99
100
101
102
103
104
105
106
107
108
109
110
I
Tape AMS music detection input
Tape reel table rotation detection input
Tape position detection input 0
I
POS0
I
POS1
I
Tape position detection input 1
POS2
I
Tape position detection input 2
POS3
I
Tape position detection input 3
LM-EJ
O
O
Tape loading motor control output (Eject direction)
Tape loading motor control output (Loading direction)
LM-LOD
– 52 –
Pin No.
111
Pin Name
CM-ON
TAPEON
N-ROUT
AMSON
DOLBC
DOLBY
CSV-NAR
LEDON
VSS
I/O
O
O
O
O
O
O
I
Pin Description
Tape capstan motor control output
Tape power control output
112
113
Tape forward/reverse detection output
Tape AMS control output
114
115
Tape DOLBY B/C select control output
Tape DOLBY control output
116
117
118
Space condition indicate signal input for voice synthesizer IC.
Front panel LED control output
GND
O
—
O
119
120
POWON
System power control output
– 53 –
• IC Block Diagrams
IC10 BU2624FV
IC310, 410 TDA8574
20 XOUT
19
VCCL
INL
1
VSS
2
3
VCCL
BUFFER
PHASE
DET
CL+
16
18 PD
15 CL–
SVRL
LIFT
AMP
REFERENCE
DIVIDER
17
16
VDD
XIN
1
BUFFER
FMIN
MAIN
COUNT
PRESCALER
REFERENCE
VCCL
2
4
5
CE
CK
DA
LGND
14
13
I/O
CTL
SIGNAL
AMP
SHIFT REGISTER LATCH
AMIN
P2
15
14
OUTL
4
5
INML
INMR
CD
6
IF COUNT
CTL
VCCR
P0
7
12
OUTR
SIGNAL
AMP
11 RGND
20BIT COUNT
13 IFIN
9
P1
P3
REFERENCE
VCCR
10
12
11
SD
P4
LIFT
AMP
BUFFER
BUFFER
CR–
CR+
SVRR
INR
6
10
9
7
8
VCCR
IC101 MSM6684
26
25
VCC
TEST
1
TIMING
GENERATOR
RS/A
REFRESH TIMER
RWCK
NC
2
3
4
24 RFSH
IC201 LB1638M
TEST
TEST
5
REFRESH ADDRESS
COUNTER
8,388,608DATA
REGISTER
10
9
1
N.C.
GND
IN1
9
TEST
TEST 10
DIN 11
ROW ADDRESS
COUNTER
COLUMN DECODER
2
OUT1
NC
12
23 SAD
22 SAS
ROW ADDRESS
REGISTER
8
7
VS
COLUMN ADDRESS
COUNTER
VSS 13
VCC
IN2
3
4
18
TAS
OUT2
CS
17
16
5
6
N.C.
GND
WRITE CLOCK
GENERATOR
WE
DOUT
15
14 NC
IC500 BA3918-V3
IC602 BA8270F
BUS ON
SWITCH
14 VCC
BUS ON
1
2
3
REGULATOR
RESET
SWITCH
13
RST
RST
12 BUS ON
11 CLK IN
10 BU IN
BATTERY
SWITCH
BATT
OVER VOLTAGE
PROTECT
–
+
–
+
–
+
–
+
4
5
6
CLK
VREF
DATA
9
8
DATA IN
GND
7
DATA OUT
2
3
4
5
6
7
8
9
10
11
12
1
– 54 –
IC100 MSM6688GS
IC501 RN5VD33A-TU
5
4
56 55 54 53 52
51
50 49 48 47
OSC
46
45 44
43
TIMING
CONTROLLER
DATA
I/O
RESET
2
42 CS3
D0
D1
D2
D3
1
2
3
4
41
40
39
38
37
36
CS2
CS1
MCU I/F
REGISTER
CONTROLLER
3
1
SADX
SADY
TAS
SAS
BUSY
RPM
VPM
5
6
7
35
PDWN
STATUS
REGISTER
34 TEST
33 TEST
ACON
TEST
8
9
ADDRESS
CONTROLLER
RSEL2
RSEL1
32
31
MCUM 10
ADPCM
ANALYZER/
SYNTHESIZER
CE
11
30 DGND
29 AGND
12
TEST
TEST
CIRCUIT
12BIT
DAC
TEST 13
TEST 14
12BIT
ADC
SG
CIRCUIT
LPF
15
16
17 18
19 20 21 22 23 24
25
26
27
28
IC250 CXA2510AQ
IC350 CXA1846N
30
29 28 27 26
25
24
23 22 21
NR
20 19
18 17
16
15
14
13 12 11
120µ/
70µ
–
+
8dB STEP
VOLUME
1dB STEP
VOLUME
T2
+
–
20
MSMODE
19 DRSW
18
+
–
NR BIAS
TAPE/AUX
TAPE EQ
FWD/RVS
VCC
MS
MODE
PBFB1 31
VCT
BUFFER
X1
LATCH
CONTROL
ZC
PBRIN1 32
LATCH
DET
TAPESW
F2
33
34
PBREF1
PBFIN1
17 INSW
NR
MODE
16 NRSW
SHIFT
REGISTER
VCT 35
VCT
15 NC
PBGND
36
MS ON/
OFF
+
LPF
+
–
8dB STEP
VOLUME
1dB STEP
VOLUME
DETECT
+
–
14 MSOUT
13 DGND
37
PBFIN2
F3
F1
PBREF2 38
X1
PBRIN2
PBFB2
39
40
1
2
3
4
5
6
7
8
9
10
12 MSTC
11 FF
–
+
–
+
OFF/B
NR
T1
120µ/
70µ
2
3
4
5
6
7
8
9
10
1
– 55 –
IC150 SAA6588
IC650 MSM6654A-519GS
IIC-BUS
SLAVE
11
10
9
PSWN
MAD
SCL
SDA
24
23
22
21
20
GND
AOUT
NAR
NC
12
TRANSCEIVER
4
4
1
VDD
SIGNAL
QUALITY
DETECTOR
XT
XT
2
3
BUSY
PAUSE
INTERFACE
REGISTER
DETECTOR
AFIN 13
5
TIMMING
BEEP TONE
NC
4
5
6
7
8
OSC
LPF
19
18
NC
NC
CONTROLLER
GENARATOR
CMD
NC
8 DAVN
CLOCKED
COMPARATOR
RDS/RDBS
RDS/RDBS
DECODER
DEMODULATOR
14
15
16
17
7
VDDA
VSSA
MPX
VDDD
MELODY
GENARATOR
12 BIT
DAC
I/O
INTERFACE
NC
ST
17
RESET
6
5
4
VSSD
OSCI
OSC0
POWER SUPPLY
AND RESET
12
OSCILLATOR
AND CLOCK
VREF
PCM
SYNTHSIZER
57kHz
8th ORDER
BAND-PASS
TEST
CONTROL
17 BIT
ADDRESS
COUNTER
18
19
3
TCON
SCOUT
CIN
DATA
CONTROLLER
ADPCM
SYNTHESIZER
2
1
MPTH
MRO
MULTI-PATH
DETECTOR
20
LVIN
1M BIT ROM
EDITING ROM &
ADDRESS ROM
CONTAINS 22KBIT
8
17 BIT
MULTIPLEXER
7
16 CH
9
15 16/SD
10
11
ADDRESS
&
COMMAND
CONTROLLER
15/SI
14
13 14
10
12/PoRT0 11
13/PoRT1
12
IC301 CXA1946BQ
36
35 34
LOUD
33
32
31
30 29 28 27 26
TONE
25
24 FNTO1
23 REO1
VOLUME
8dB STEP
VOLUME
1dB STEP
FADER
GAIN12 37
GAIN11 38
IN14 39
VCTBUFF
VCTBUFF
VCTBUFF
IN13 40
IN12 41
IN11 42
LATCH
CONTROL
22 CE
LATCH
SHIFT
21 CLK
20 DGND
19 GND
ZCDET
45k
45k
REGISTER
18 VCC
IN21 43
IN22 44
17 VCT
VCTBUFF
VCTBUFF
VCTBUFF
16 DATA
15 TIMER
IN23 45
IN24 46
GAIN21 47
GAIN22 48
14 REO2
VOLUME
8dB STEP
VOLUME
1dB STEP
LOUD
TONE
FADER
12
13 FNTO2
1
2
3
4
5
6
7
8
9
10 11
– 56 –
SECTION 7
EXPLODED VIEWS
NOTE:
• Themechanicalpartswithnoreference
numberinthee xplodedvie wsarenotsupplied.
• Items mar ked “*”are not stoc ked since
theyareseldomrequiredf orroutineser vice.
Somedelayshouldbeanticipated
whenorderingtheseitems.
• -XXand-Xmeanstandardizedparts, so
the yma yha vesomediff erencefromthe
original one.
• ColorIndicationofAppear anceP ar ts
Example:
• Accessoriesandpackingmaterialsand
hardware (# mark) list are given in
the last of this parts list.
KNOB, BALANCE (WHITE) ... (RED)
• Abbreviation
G:Germanmodel
Par ts Color Cabinet’ s Color
7-1. CHASSIS SECTION
12
17
#3
#3
1
MG-25D-136
#3
#3
#3
18
B
#3
16#3
13
26
15
#3
8
F701
26
11
14
28
#4
9
2
TUX10
10
19
3
4
26
20
26
5
6
27
#2
#2
#1
LUG1
21
7
29
24
A
B
#2
#1
#2
#1
#2
22
23
25
A
Ref. No.
Part No.
3-022-316-01 COVER
X-3375-092-1 PANEL ASSY, SUB (C8100)
X-3375-093-1 PANEL ASSY, SUB (C8100R)
3-922-165-92 DOOR, CASSETTE
Description
Remark
Ref. No.
Part No.
Description
Remark
* 1
2
2
3
4
17
18
19
* 20
* 21
1-783-495-11 CORD (WITH CONNECTOR) (INVERTER)
1-777-246-11 CORD (WITH CONNECTOR) (ANTENNA)
3-937-282-01 CASE (UPPER)
3-938-138-01 SHEET (E)
A-3313-646-A INVERTER BOARD, COMPLETE
3-935-003-01 SPRING (C DOOR), TORSION
5
* 6
7
8
9
3-022-338-01 BUTTON (EJECT)
1-669-656-11 SUB BOARD
X-3375-068-1 LOCK ASSY
X-3375-066-1 BRACKET (GEAR) ASSY
3-011-170-01 GEAR (HOLDER)
22
23
23
3-937-812-01 CASE (LOWER)
1-776-207-71 CORD (WITH CONNECTOR) (POWER) (C8100)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(C8100R)
3-022-307-01 INSULATED PLATE (C8100R)
3-022-312-01 INSULATED PLATE (C8100)
* 24
* 24
10
11
12
* 13
* 13
3-341-752-11 WASHER, POLYETHYLENE
3-953-235-01 DAMPER, OIL
3-919-171-01 SCREW (2.6X6) (C TIGHT)
A-3313-644-A MAIN BOARD, COMPLETE (AEP,UK)
A-3313-652-A MAIN BOARD, COMPLETE (C8100)
* 25
26
27
* 28
* 29
X-3375-081-1 CHASSIS ASSY
3-915-923-01 SCREW, GROUND POINT
3-015-565-31 SPACER (SW)
3-355-209-01 PLATE (B), GROUND
3-023-774-01 PLATE (LOCK), GROUND
* 13
* 14
* 15
* 16
A-3313-656-A MAIN BOARD, COMPLETE (G)
3-011-078-01 BRACKET (POWER IC)
3-022-317-01 BRACKET (AMP)
F701
* LUG1
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
1-537-738-21 TERMINAL, EARTH
3-022-306-01 HEAT SINK
TUX10 A-3282-045-A TUNER UNIT (TUX-012(E))
– 57 –
7-2. FRONT PANEL SECTION
#5
67
68
#5
not supplied
(KEY board)
70
#5
56
65
58
68
69
EL900
57
66
60
64
52
LCD900
59
63
54
53
62
55
51
61
61
C8100R
C8100
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
51
52
53
54
55
3-022-329-01 BUTTON (SOURCE)
3-022-322-01 KNOB
3-022-323-01 LEVER (SHUTTLE)
3-022-324-01 PLATE (SHUTTLE), LIGHT GUIDE
X-3375-681-1 PANEL SUB ASSY, FRONT (C8100)
62
* 63
64
* 65
* 66
3-022-332-01 BUTTON (10 KEY)
3-022-327-01 PLATE (LCD), GROUND
1-694-414-11 CONDUCTOR BOARD, CONNECTION
3-022-328-01 ILLUMINATOR (LCD)
3-022-326-01 PLATE (LCD), LIGHT GUIDE
55
56
57
58
59
X-3375-682-1 PANEL SUB ASSY, FRONT (C8100R)
3-022-330-01 BUTTON (MODE)
3-022-331-01 BUTTON (SOUND)
3-022-325-01 PLATE (RING), LIGHT GUIDE
3-022-333-01 BUTTON (OPEN)
67
68
69
70
3-010-999-01 BEARING (L)
3-010-998-01 SPRING (BEARING)
3-011-000-01 BEARING (R)
3-022-319-01 PANEL, FRONT BACK
EL900 1-517-766-11 LIGHT, ELECTRO LUMINESCENT
60
61
61
3-932-225-01 SPRING (OPEN)
3-022-308-01 BUTTON (PTY) (C8100R)
3-022-334-01 BUTTON (LIST) (C8100)
LCD900 1-803-107-11 DISPLAY PANEL, LIQUID CRYSTAL
– 58 –
7-3. MECHANISM DECK SECTION
(MG-25D-136)
110
109
113
108
HP901
111
105
104
112
114
107
106
#6
M901
103
102
115
#7
118
118
116
117
101
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
101
102
103
104
105
A-3291-667-A CLUTCH (FR) ASSY
3-019-130-01 LEVER (LDG-A)
3-020-522-03 LEVER (LDG-B)
3-020-539-01 SPRING (LD-1), TENSION
3-020-540-01 SPRING (LD-2), TENSION
111
112
113
114
115
3-933-346-01 CATCHER
3-933-344-01 GUIDE (C)
3-014-798-01 SCREW (HEAD), SPECIAL
3-364-151-01 WASHER
X-3375-625-1 CHASSIS (SV) ASSY (D)
106
107
108
109
110
3-020-542-01 GEAR (LOADING FT)
3-341-753-11 WASHER, POLYETHYLENE
3-020-533-01 HOUSING
3-020-532-01 ARM (SUCTION)
3-020-534-01 HANGER
116
117
118
3-017-302-01 BELT (25)
3-936-853-01 FLYWHEEL (F)
3-701-437-21 WASHER
HP901 1-500-157-21 HEAD, MAGNETIC (PLAYBACK)
M901 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL)
– 59 –
SECTION 8
ELECTRICAL PARTS LIST
INVERTER KEY
NOTE:
• Duetostandardization, replacementsin
the par ts list ma y be different from the
par tsspecifiedinthediag ramsorthe
componentsusedontheset.
• -XXand-Xmeanstandardizedparts, so
the ymayha vesomediff erencefromthe
original one.
• Items mar ked “*”are not stoc ked since
theyareseldomrequiredf orroutineser vice.
Somedelayshouldbeanticipated
whenorderingtheseitems.
• SEMICONDUCT ORS
In each case , u : µ, for e xample:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
Whenindicatingpartsbyreference
number , pleaseincludetheboard.
• Abbreviation
G:Germanmodel
• RESIST ORS
All resistors are in ohms.
METAL:Metal-film resistor .
METAL OXIDE:Metal o xide-film resistor .
F:nonflammable
uF : µF
• COILS
uH : µH
Ref. No.
Part No.
Description
Remark
Ref. No.
R563
Part No.
Description
Remark
1/10W
*
A-3313-646-A INVERTER BOARD, COMPLETE
1-216-097-00 RES,CHIP
< TRANSFORMER >
1-431-831-11 TRANSFORMER, OSCILLATION (EL)
100K
5%
*************************
< CAPACITOR >
T550
C551
C552
C553
C554
C555
1-126-157-11 ELECT
1-164-004-11 CERAMIC CHIP 0.1uF
1-126-923-11 ELECT 220uF
1-164-232-11 CERAMIC CHIP 0.01uF
1-124-257-00 ELECT 2.2uF
10uF
20%
10%
20%
16V
25V
10V
50V
50V
*************************************************************
KEY BOARD
**********
20%
10%
1-694-414-11 CONDUCTOR BOARD, CONNECTION
C556
1-164-004-11 CERAMIC CHIP 0.1uF
< CONNECTOR >
25V
*
*
*
3-022-326-01 PLATE (LCD), LIGHT GUIDE
3-022-327-01 PLATE (LCD), GROUND
3-022-328-01 ILLUMINATOR (LCD)
* CN550 1-564-507-11 PLUG, CONNECTOR 4P
< CAPACITOR >
CN551 1-564-505-11 PLUG, CONNECTOR 2P
C900
C901
C902
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-232-11 CERAMIC CHIP 0.01uF
10%
10%
25V
25V
50V
< DIODE >
D550
D551
D552
D553
D554
8-719-422-49 DIODE MA8056-L
8-719-422-80 DIODE MA8075-H-TX
8-719-404-49 DIODE MA111
8-719-033-43 DIODE RB751H
8-719-422-49 DIODE MA8056-L
< CONNECTOR >
CN900 1-778-183-11 PLUG, CONNECTOR 18P
< DIODE >
< IC >
8-759-495-75 IC NJM317F
< TRANSISTOR >
D901
D903
8-719-420-90 DIODE MA8051-M
8-719-420-90 DIODE MA8051-M
IC550
< ELECTRO LUMINESCENT LIGHT >
Q552
Q553
Q554
Q555
Q556
8-729-421-22 TRANSISTOR UN2211
8-729-026-68 TRANSISTOR 2SD2525(TP)
8-729-421-22 TRANSISTOR UN2211
8-729-903-46 TRANSISTOR 2SB1132-P
8-729-016-11 TRANSISTOR 2SD1507M
EL900 1-517-766-11 LIGHT, ELECTRO LUMINESCENT
< IC >
IC900
IC901
8-759-496-75 IC uPD16432BGC-018-9EU
8-749-012-25 IC RS-170-TU
Q557
8-729-021-94 FET 2SK1657-T1B
< RESISTOR >
< LIQUID CRYSTAL DISPLAY >
LCD900 1-803-107-11 DISPLAY PANEL, LIQUID CRYSTAL
< DIODE >
R552
R553
R555
R556
R557
1-216-198-00 RES,CHIP
1-216-198-00 RES,CHIP
1-216-158-00 RES,CHIP
1-216-158-00 RES,CHIP
1-216-001-00 METAL CHIP
1K
1K
22
22
10
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/10W
LED900 8-719-987-45 LED CL-155Y/PG-CD
LED901 8-719-987-45 LED CL-155Y/PG-CD
LED902 8-719-987-45 LED CL-155Y/PG-CD
LED903 8-719-987-45 LED CL-155Y/PG-CD
LED904 8-719-987-45 LED CL-155Y/PG-CD
R558
R559
R560
R561
R562
1-216-097-00 RES,CHIP
1-216-057-00 METAL CHIP
1-216-063-00 RES,CHIP
1-216-031-00 METAL CHIP
1-216-097-00 RES,CHIP
100K
2.2K
3.9K
180
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
LED905 8-719-987-45 LED CL-155Y/PG-CD
LED906 8-719-033-13 LED CL-170Y-CD-T
100K
– 60 –
KEY
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
LED907 8-719-033-14 LED CL-170PG-CD-T
R932
R933
R935
R936
R937
1-216-037-00 METAL CHIP
1-216-037-00 METAL CHIP
1-216-182-00 RES,CHIP
1-216-182-00 RES,CHIP
1-216-037-00 METAL CHIP
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/8W
1/10W
330
220
220
330
< SWITCH >
LSW900 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (OFF)
LSW901 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MODE)
LSW902 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
LSW903 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SOUND)
LSW904 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
R938
R939
R941
R942
R943
1-216-037-00 METAL CHIP
1-216-190-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-041-00 METAL CHIP
1-216-025-00 RES,CHIP
330
470
100
470
100
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/10W
1/10W
LSW905 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SHIFT)
LSW906 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (1)
LSW907 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (2)
LSW908 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (3)
LSW909 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (PTY/LIST)
R944
R945
R946
R947
R948
1-216-037-00 METAL CHIP
1-216-081-00 METAL CHIP
1-216-089-00 RES,CHIP
1-216-089-00 RES,CHIP
1-216-049-11 RES,CHIP
330
22K
47K
47K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
LSW910 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (AF/TA)
(C8100R)
LSW911 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (TIR)
(C8100R)
LSW912 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (10)
LSW913 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (9)
LSW914 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (8)
R949
R950
R951
R952
R953
1-216-049-11 RES,CHIP
1-216-049-11 RES,CHIP
1-216-049-11 RES,CHIP
1-216-097-00 RES,CHIP
1-216-057-00 METAL CHIP
1K
1K
1K
100K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
LSW915 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (7)
LSW916 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (6)
LSW917 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (5)
LSW918 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (4)
R954
R955
R956
R957
R958
1-216-057-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-057-00 METAL CHIP
2.2K
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< TRANSISTOR >
R960
R961
R962
R963
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
100
100
100
100
5%
5%
5%
5%
1/10W
(C8100)
1/10W
(C8100)
1/10W
(C8100)
1/10W
(C8100)
Q900
Q901
Q902
Q903
8-729-904-66 TRANSISTOR DTD113EK
8-729-904-66 TRANSISTOR DTD113EK
8-729-424-08 TRANSISTOR UN2111
8-729-424-08 TRANSISTOR UN2111
< RESISTOR >
R901
R902
R903
R904
R905
1-216-045-00 METAL CHIP
1-216-045-00 METAL CHIP
1-216-045-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-053-00 METAL CHIP
680
680
680
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< ROTARY ENCODER >
RE900 1-475-014-11 ENCODER, ROTARY
< SWITCH >
1.5K
R906
R907
R908
R909
R910
1-216-053-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-061-00 METAL CHIP
1-216-065-00 RES,CHIP
1-216-069-00 METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
S900
1-771-290-11 SWITCH, SLIDE (SEEK/AMS)
*************************************************************
*
*
*
A-3313-644-A MAIN BOARD, COMPLETE (AEP,UK)
A-3313-652-A MAIN BOARD, COMPLETE (C8100)
A-3313-656-A MAIN BOARD, COMPLETE (G)
*********************
R911
R912
R913
R914
R915
1-216-045-00 METAL CHIP
1-216-045-00 METAL CHIP
1-216-045-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-053-00 METAL CHIP
680
680
680
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
*
*
*
3-011-078-01 BRACKET (POWER IC)
3-022-306-01 HEAT SINK
3-022-317-01 BRACKET (AMP)
7-685-794-09 SCREW +PTT 2.6X10 (S)
1.5K
R916
R917
R918
R919
R920
1-216-053-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-061-00 METAL CHIP
1-216-065-00 RES,CHIP
1-216-069-00 METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< BUZZER >
BZ600 1-504-920-11 BUZZER
R931
1-216-033-00 METAL CHIP
220
5%
1/10W
– 61 –
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
C101
Part No.
Description
Remark
< CAPACITOR >
1-162-970-11 CERAMIC CHIP 0.01uF
10%
20%
20%
5%
25V
(C8100R)
16V
(C8100R)
16V
(C8100R)
50V
(C8100R)
16V
(C8100R)
C10
C11
C12
C13
C14
1-163-235-11 CERAMIC CHIP 22PF
1-126-933-11 ELECT 100uF
1-163-809-11 CERAMIC CHIP 0.047uF 10%
1-126-933-11 ELECT 100uF 20%
1-163-809-11 CERAMIC CHIP 0.047uF 10%
5%
20%
50V
10V
25V
10V
25V
C102
C103
C104
C105
1-126-157-11 ELECT
1-126-157-11 ELECT
10uF
10uF
1-162-957-11 CERAMIC CHIP 220PF
1-107-826-11 CERAMIC CHIP 0.1uF
C15
C16
C17
C18
1-126-933-11 ELECT
1-163-809-11 CERAMIC CHIP 0.047uF 10%
1-164-232-11 CERAMIC CHIP 0.01uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-251-11 CERAMIC CHIP 100PF
1-164-232-11 CERAMIC CHIP 0.01uF
100uF
20%
10V
25V
50V
25V
(C8100R)
50V
10%
10%
C106
C107
C150
C152
C153
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-489-11 CERAMIC CHIP 0.22uF
1-107-826-11 CERAMIC CHIP 0.1uF
1-163-237-11 CERAMIC CHIP 27PF
1-163-237-11 CERAMIC CHIP 27PF
10%
10%
10%
5%
25V
(C8100R)
16V
(C8100R)
16V
(C8100R)
50V
(C8100R)
50V
(C8100R)
C19
5%
C20
C21
C22
C23
C24
50V
50V
50V
25V
16V
1-163-009-11 CERAMIC CHIP 0.001uF 10%
1-163-251-11 CERAMIC CHIP 100PF
1-164-222-11 CERAMIC CHIP 0.22uF
5%
1-126-157-11 ELECT
10uF
20%
20%
5%
C25
C28
1-124-234-00 ELECT
1-164-222-11 CERAMIC CHIP 0.22uF
22uF
16V
25V
(C8100R)
25V
16V
16V
C154
C155
C158
C159
C160
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-251-11 CERAMIC CHIP 100PF
10%
5%
25V
(C8100R)
50V
(C8100R)
100V
(C8100R)
50V
(C8100R)
16V
(C8100R)
C29
C31
C32
1-163-809-11 CERAMIC CHIP 0.047uF 10%
1-124-589-11 ELECT
1-126-157-11 ELECT
47uF
10uF
20%
20%
1-164-161-11 CERAMIC CHIP 0.0022uF 10%
C33
C34
C35
C37
1-163-234-11 CERAMIC CHIP 20PF
1-163-243-11 CERAMIC CHIP 47PF
1-124-234-00 ELECT
5%
5%
20%
10%
50V
50V
16V
1-163-135-00 CERAMIC CHIP 560PF
1-164-505-11 CERAMIC CHIP 2.2uF
5%
22uF
1-164-004-11 CERAMIC CHIP 0.1uF
25V
(C8100R)
100V
C38
C39
C39
1-164-161-11 CERAMIC CHIP 0.0022uF 10%
1-163-989-11 CERAMIC CHIP 0.033uF 10%
1-164-232-11 CERAMIC CHIP 0.01uF
C161
C162
1-163-263-11 CERAMIC CHIP 330PF
1-164-004-11 CERAMIC CHIP 0.1uF
5%
50V
(C8100R)
25V
(C8100R)
16V
16V
25V
(C8100)
50V
(C8100R)
50V
50V
10%
C201
C202
C204
1-126-935-11 ELECT
1-124-234-00 ELECT
470uF
22uF
20%
20%
C40
C41
C50
1-164-232-11 CERAMIC CHIP 0.01uF
1-164-232-11 CERAMIC CHIP 0.01uF
1-163-023-00 CERAMIC CHIP 0.015uF 5%
1-117-370-11 CERAMIC CHIP 10uF
10V
50V
C205
C206
C207
C230
C231
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-222-11 CERAMIC CHIP 0.22uF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
10%
10%
25V
25V
25V
50V
50V
C51
C52
1-164-344-11 CERAMIC CHIP 0.068uF 10%
25V
50V
(C8100R)
16V
16V
25V
1-126-301-11 ELECT
1uF
20%
5%
5%
C53
C54
C60
1-126-157-11 ELECT
1-126-157-11 ELECT
10uF
10uF
20%
20%
C232
C233
C234
C235
C236
1-163-251-11 CERAMIC CHIP 100PF
1-163-263-11 CERAMIC CHIP 330PF
1-163-263-11 CERAMIC CHIP 330PF
1-164-232-11 CERAMIC CHIP 0.01uF
5%
5%
5%
50V
50V
50V
50V
50V
1-163-037-11 CERAMIC CHIP 0.022uF 10%
C61
C62
C63
C64
C80
1-126-163-11 ELECT
1-124-257-00 ELECT
4.7uF
2.2uF
20%
20%
50V
50V
50V
50V
25V
1-126-159-11 ELECT
0.47uF
20%
1-163-275-11 CERAMIC CHIP 0.001uF 5%
1-163-275-11 CERAMIC CHIP 0.001uF 5%
1-163-037-11 CERAMIC CHIP 0.022uF 10%
C237
C240
C241
C242
C243
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
1-163-263-11 CERAMIC CHIP 330PF
10%
5%
5%
5%
5%
25V
50V
50V
50V
50V
C81
C82
C83
C84
C100
1-126-163-11 ELECT
1-124-257-00 ELECT
4.7uF
2.2uF
20%
20%
50V
50V
50V
50V
25V
1-163-275-11 CERAMIC CHIP 0.001uF 5%
1-163-275-11 CERAMIC CHIP 0.001uF 5%
1-163-989-11 CERAMIC CHIP 0.033uF 10%
C244
C245
1-163-263-11 CERAMIC CHIP 330PF
1-164-232-11 CERAMIC CHIP 0.01uF
5%
50V
50V
(C8100R)
– 62 –
MAIN
Ref. No.
Part No.
1-126-159-11 ELECT
1-164-004-11 CERAMIC CHIP 0.1uF
1-124-234-00 ELECT 22uF
1-107-823-11 CERAMIC CHIP 0.47uF
Description
Remark
Ref. No.
Part No.
Description
Remark
C246
C247
C250
C251
C252
0.47uF
20%
10%
20%
10%
50V
25V
16V
16V
50V
C408
C409
C410
C416
C420
1-164-161-11 CERAMIC CHIP 0.0022uF 10%
100V
50V
16V
16V
25V
1-126-159-11 ELECT
1-126-157-11 ELECT
1-124-234-00 ELECT
0.47uF
10uF
22uF
20%
20%
20%
10%
1-163-023-00 CERAMIC CHIP 0.015uF 5%
1-164-004-11 CERAMIC CHIP 0.1uF
C253
C254
C255
C301
C303
1-163-023-00 CERAMIC CHIP 0.015uF 5%
50V
16V
50V
50V
50V
C421
C422
C430
C431
C432
1-163-012-00 CERAMIC CHIP 0.0018uF 10%
50V
25V
16V
16V
16V
1-124-589-11 ELECT
1-163-139-00 CERAMIC CHIP 820PF
47uF
20%
5%
1-164-004-11 CERAMIC CHIP 0.1uF
10%
20%
20%
20%
1-126-157-11 ELECT
1-115-175-11 ELECT
1-126-157-11 ELECT
10uF
100uF
10uF
1-124-257-00 ELECT
1-124-257-00 ELECT
2.2uF
2.2uF
20%
20%
C304
C305
C306
C307
C308
1-124-257-00 ELECT
1-163-809-11 CERAMIC CHIP 0.047uF 10%
1-164-161-11 CERAMIC CHIP 0.0022uF 10%
1-126-157-11 ELECT
1-164-161-11 CERAMIC CHIP 0.0022uF 10%
2.2uF
20%
50V
25V
100V
16V
100V
C433
C440
C441
C442
C443
1-163-141-00 CERAMIC CHIP 0.001uF 5%
50V
16V
16V
16V
50V
1-126-157-11 ELECT
1-115-175-11 ELECT
1-126-157-11 ELECT
10uF
100uF
10uF
20%
20%
20%
10uF
20%
1-163-141-00 CERAMIC CHIP 0.001uF 5%
C309
C310
C316
C320
C321
1-126-159-11 ELECT
1-126-157-11 ELECT
1-124-234-00 ELECT
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-012-00 CERAMIC CHIP 0.0018uF 10%
0.47uF
10uF
22uF
20%
20%
20%
10%
50V
16V
16V
25V
50V
C461
C462
C463
C464
C465
1-124-234-00 ELECT
1-110-501-11 CERAMIC CHIP 0.33uF
1-107-823-11 CERAMIC CHIP 0.47uF
1-126-157-11 ELECT
1-126-157-11 ELECT
22uF
20%
10%
10%
20%
20%
16V
16V
16V
16V
16V
10uF
10uF
C322
C330
C331
C332
C333
1-164-004-11 CERAMIC CHIP 0.1uF
10%
20%
20%
20%
25V
16V
16V
16V
50V
C466
C467
C500
C501
C503
1-126-163-11 ELECT
1-163-243-11 CERAMIC CHIP 47PF
1-163-037-11 CERAMIC CHIP 0.022uF 10%
1-163-037-11 CERAMIC CHIP 0.022uF 10%
1-163-017-00 CERAMIC CHIP 0.0047uF 5%
4.7uF
20%
5%
50V
50V
25V
25V
50V
1-126-157-11 ELECT
1-115-175-11 ELECT
1-126-157-11 ELECT
10uF
100uF
10uF
1-163-141-00 CERAMIC CHIP 0.001uF 5%
C340
C341
C342
C343
C350
1-126-157-11 ELECT
1-115-175-11 ELECT
1-126-157-11 ELECT
1-163-141-00 CERAMIC CHIP 0.001uF 5%
1-164-004-11 CERAMIC CHIP 0.1uF 10%
10uF
100uF
10uF
20%
20%
20%
16V
16V
16V
50V
25V
C504
C505
C506
C507
C510
1-125-701-11 DOUBLE LAYERS 0.047F
5.5V
10V
16V
25V
16V
1-124-584-00 ELECT
100uF
20%
10%
10%
20%
1-164-489-11 CERAMIC CHIP 0.22uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-126-157-11 ELECT
10uF
C351
C352
C353
C354
C355
1-126-154-11 ELECT
1-164-232-11 CERAMIC CHIP 0.01uF
1-124-584-00 ELECT 100uF
47uF
20%
6.3V
50V
10V
50V
16V
C511
C513
C514
C515
C516
1-124-234-00 ELECT
1-126-157-11 ELECT
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
22uF
10uF
20%
20%
10%
10%
10%
16V
16V
25V
25V
25V
20%
1-163-009-11 CERAMIC CHIP 0.001uF 10%
1-126-157-11 ELECT
10uF
20%
C356
C357
C358
C359
C360
1-164-232-11 CERAMIC CHIP 0.01uF
50V
10V
50V
50V
50V
C517
C518
C519
C520
C521
1-164-004-11 CERAMIC CHIP 0.1uF
10%
20%
25V
16V
50V
50V
16V
1-124-584-00 ELECT
1-126-163-11 ELECT
100uF
4.7uF
20%
20%
1-126-157-11 ELECT
10uF
1-163-009-11 CERAMIC CHIP 0.001uF 10%
1-163-009-11 CERAMIC CHIP 0.001uF 10%
1-164-346-11 CERAMIC CHIP 1uF
1-163-009-11 CERAMIC CHIP 0.001uF 10%
1-164-232-11 CERAMIC CHIP 0.01uF
C361
C362
C363
C364
C365
1-124-234-00 ELECT
1-110-501-11 CERAMIC CHIP 0.33uF
1-107-823-11 CERAMIC CHIP 0.47uF
1-126-157-11 ELECT
1-126-157-11 ELECT
22uF
20%
10%
10%
20%
20%
16V
16V
16V
16V
16V
C530
C531
C532
C550
C601
1-164-004-11 CERAMIC CHIP 0.1uF
1-124-584-00 ELECT 100uF
1-164-004-11 CERAMIC CHIP 0.1uF
10%
20%
10%
20%
20%
25V
10V
25V
16V
16V
10uF
10uF
1-126-157-11 ELECT
1-126-157-11 ELECT
10uF
10uF
C366
C367
C401
C403
C404
1-126-163-11 ELECT
1-163-243-11 CERAMIC CHIP 47PF
1-124-257-00 ELECT
1-124-257-00 ELECT
1-124-257-00 ELECT
4.7uF
20%
5%
20%
20%
20%
50V
50V
50V
50V
50V
C602
C603
C604
C605
C606
1-126-154-11 ELECT
47uF
20%
10%
5%
5%
10%
6.3V
25V
50V
50V
16V
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-235-11 CERAMIC CHIP 22PF
1-163-229-11 CERAMIC CHIP 12PF
1-107-826-11 CERAMIC CHIP 0.1uF
2.2uF
2.2uF
2.2uF
C405
C406
C407
1-163-809-11 CERAMIC CHIP 0.047uF 10%
1-164-161-11 CERAMIC CHIP 0.0022uF 10%
25V
100V
16V
C607
C608
C609
1-107-826-11 CERAMIC CHIP 0.1uF
1-164-232-11 CERAMIC CHIP 0.01uF
10%
20%
16V
50V
10V
1-126-157-11 ELECT
10uF
20%
1-124-229-00 ELECT
33uF
– 63 –
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
< DIODE >
Remark
C610
C611
C612
C613
C614
1-107-826-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-009-11 CERAMIC CHIP 0.001uF 10%
1-164-232-11 CERAMIC CHIP 0.01uF
10%
10%
16V
25V
50V
50V
50V
D10
D11
D12
D50
D200
8-719-040-04 DIODE MA721WK-(TX)
8-719-422-49 DIODE MA8056-L
8-719-422-97 DIODE MA8091-M
8-719-422-16 DIODE MA8039-L-TX
8-719-040-04 DIODE MA721WK-(TX)
1-163-009-11 CERAMIC CHIP 0.001uF 10%
C615
C650
C651
C701
C702
1-163-229-11 CERAMIC CHIP 12PF
1-164-004-11 CERAMIC CHIP 0.1uF
1-126-157-11 ELECT
1-111-233-11 ELECT
5%
10%
20%
50V
25V
16V
16V
25V
10uF
D201
D202
D350
D351
D501
8-719-200-82 DIODE 11ES2
5600uF 20%
8-719-422-97 DIODE MA8091-M
8-719-422-16 DIODE MA8039-L-TX
8-719-422-16 DIODE MA8039-L-TX
8-719-423-23 DIODE MA8110-M
1-164-004-11 CERAMIC CHIP 0.1uF
10%
C703
C704
C705
C706
C707
1-115-334-11 FILM
1-124-589-11 ELECT
1-163-251-11 CERAMIC CHIP 100PF
1-136-227-11 MYLAR
1-136-227-11 MYLAR
0.47uF
47uF
5%
20%
5%
50V
16V
50V
50V
50V
D502
D503
D504
D506
D507
8-719-423-23 DIODE MA8110-M
8-719-423-32 DIODE MA8120-M
8-719-423-32 DIODE MA8120-M
8-719-400-20 DIODE MA152WA
8-719-404-49 DIODE MA111
0.001uF 5%
0.001uF 5%
C708
C709
C710
C711
C712
1-163-251-11 CERAMIC CHIP 100PF
5%
5%
20%
20%
20%
50V
50V
50V
16V
50V
1-115-326-11 FILM
1-126-163-11 ELECT
1-126-933-11 ELECT
1-126-301-11 ELECT
0.1uF
4.7uF
100uF
1uF
D508
D509
D510
D512
D513
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-404-49 DIODE MA111
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
C713
C714
C715
C720
C740
1-126-157-11 ELECT
1-126-163-11 ELECT
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
10uF
4.7uF
20%
20%
10%
10%
10%
16V
50V
25V
25V
25V
D514
D515
D516
D517
D518
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
C750
C760
C770
C782
C783
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-164-004-11 CERAMIC CHIP 0.1uF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
10%
10%
10%
5%
25V
25V
25V
50V
50V
D519
D520
D521
D522
D523
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-422-64 DIODE MA8062-M
8-719-404-49 DIODE MA111
5%
C784
C785
C786
C787
C788
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
1-163-251-11 CERAMIC CHIP 100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
D524
D525
D530
D532
D533
8-719-040-04 DIODE MA721WK-(TX)
8-719-404-49 DIODE MA111
8-719-067-56 DIODE MA112-TX
8-719-067-56 DIODE MA112-TX
8-719-404-49 DIODE MA111
C789
1-163-251-11 CERAMIC CHIP 100PF
< CONNECTOR >
5%
50V
D534
D601
D602
D603
D604
8-719-404-49 DIODE MA111
8-719-022-90 DIODE MA8160M
8-719-060-80 DIODE MA8180-L-TX
8-719-060-80 DIODE MA8180-L-TX
8-719-404-49 DIODE MA111
* CN201 1-506-995-11 PIN, CONNECTOR (PC BOARD) 13P
CN250 1-766-260-11 CONNECTOR, FFC/FPC (ZIF) 7P
CN500 1-770-411-11 CONNECTOR, BOARD TO BOARD 20P
CN551 1-564-510-11 PLUG, CONNECTOR 7P
CN600 1-580-907-31 PLUG, CONNECTOR 8P (BUS CONTROL IN)
CN700 1-774-701-11 PIN, CONNECTOR 16P
< JACK >
D605
D606
D608
D701
D702
8-719-422-64 DIODE MA8062-M
8-719-017-62 DIODE MA8068-L-TX
8-719-033-43 DIODE RB751H
8-719-313-73 DIODE SFPB-52
8-719-313-73 DIODE SFPB-52
CN780 1-774-699-12 JACK, PIN 4P (BUS AUDIO IN, LINE OUT REAR)
CN781 1-774-699-12 JACK, PIN 4P (LINE OUT FRONT, SUB OUT)
D703
D704
D705
D706
D707
8-719-313-73 DIODE SFPB-52
8-719-313-73 DIODE SFPB-52
8-719-313-73 DIODE SFPB-52
8-719-313-73 DIODE SFPB-52
8-719-313-73 DIODE SFPB-52
< DISCHARGE GAP >
CP10
1-519-504-11 GAP, DISCHARGE
D708
8-719-313-73 DIODE SFPB-52
– 64 –
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
J500
Part No.
Description
< JACK >
Remark
D709
D710
D711
D712
D713
8-719-422-64 DIODE MA8062-M
8-719-049-38 DIODE 1N5404TU
8-719-404-49 DIODE MA111
8-719-200-82 DIODE 11ES2
8-719-422-76 DIODE MA8075-M
1-566-822-41 JACK (REMOTE IN)
< COIL >
D714
D715
D717
D718
D719
8-719-801-78 DIODE 1SS184
8-719-404-49 DIODE MA111
8-719-404-49 DIODE MA111
8-719-313-73 DIODE SFPB-52
8-719-313-73 DIODE SFPB-52
L10
L11
L12
L13
L14
1-414-146-31 INDUCTOR
1-414-146-31 INDUCTOR
1-410-204-31 INDUCTOR CHIP 10uH
1-410-204-31 INDUCTOR CHIP 10uH
1-410-999-11 INDUCTOR CHIP 3.3uH
2.2uH
2.2uH
< IC LINK >
L100
L150
L500
L550
L650
1-410-204-31 INDUCTOR CHIP 10uH (C8100R)
1-410-204-31 INDUCTOR CHIP 10uH (C8100R)
F550
F701
1-533-674-11 LINK, CHIP IC (ICP-S0.5) 0.5A
< FUSE >
1-410-513-11 INDUCTOR
1-414-712-21 INDUCTOR
22uH
1mH
1-410-204-31 INDUCTOR CHIP 10uH
1-416-712-11 COIL, CHOKE
< EARTH TERMINAL >
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
< FERRITE BEAD >
L700
FB100 1-414-233-21 INDUCTOR, FERRITE BEAD (C8100R)
FB500 1-414-233-21 INDUCTOR, FERRITE BEAD
FB600 1-414-233-21 INDUCTOR, FERRITE BEAD
* LUG1
1-537-738-21 TERMINAL, EARTH
< TRANSISTOR >
< IC >
Q10
Q11
Q12
Q13
Q14
8-729-920-85 TRANSISTOR 2SD1664-QR
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T (C8100R)
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T
8-729-421-22 TRANSISTOR UN2211
IC10
IC11
IC50
IC51
IC100
8-759-448-85 IC BU2624FV-E2
8-759-184-64 IC TC4W66FU (C8100R)
8-759-711-82 IC NJM4580E
8-759-242-66 IC TC4W66F (C8100R)
8-759-374-66 IC MSM6688GS-2K (C8100R)
Q15
Q17
Q50
Q51
Q52
8-729-020-67 TRANSISTOR XN1A312-TX
8-729-021-94 FET 2SK1657-T1B
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-020-67 TRANSISTOR XN1A312-TX
8-729-421-22 TRANSISTOR UN2211 (C8100R)
IC101
IC150
IC201
IC250
IC301
8-759-448-87 IC MSM6684JSDR1 (C8100R)
8-759-492-59 IC SAA6588T-118 (C8100R)
8-759-823-87 IC LB1638M
8-752-079-79 IC CXA2510AQ-T4
8-752-078-67 IC CXA1946BQ-T6
Q53
Q60
Q80
Q201
Q202
8-729-421-22 TRANSISTOR UN2211 (C8100R)
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-421-22 TRANSISTOR UN2211
IC302
IC310
IC320
IC350
IC383
8-759-711-82 IC NJM4580E
8-759-444-50 IC TDA8574(T)
8-759-711-82 IC NJM4580E
8-752-067-30 IC CXA1846N
8-759-711-82 IC NJM4580E
8-729-020-67 TRANSISTOR XN1A312-TX
Q203
Q204
Q250
Q330
Q340
8-729-931-13 TRANSISTOR 2SD1858-P-TV2
8-729-106-60 TRANSISTOR 2SB1115A
8-729-421-22 TRANSISTOR UN2211
8-729-420-68 TRANSISTOR 2SD1328-R-TX
8-729-420-68 TRANSISTOR 2SD1328-R-TX
IC410
IC500
IC501
IC502
IC503
8-759-444-50 IC TDA8574(T)
8-759-443-72 IC RH5VL43AA-T1
8-759-495-76 IC RN5VD33AA-TL
8-759-347-50 IC BA3918-V3
8-759-540-27 IC TA78DL06AS
Q360
Q361
Q362
Q430
Q440
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-420-68 TRANSISTOR 2SD1328-R-TX
8-729-420-68 TRANSISTOR 2SD1328-R-TX
IC600
IC600
IC602
IC650
IC700
8-759-531-90 IC MB90574PFV-G-115-BND (C8100R)
8-759-531-91 IC MB90574PFV-G-116-BND (C8100)
8-759-449-89 IC BA8270F-E2
8-759-530-58 IC MSM6654A-519GS-KR1
8-759-486-44 IC TDA7386
Q460
Q461
Q462
Q501
Q502
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-020-67 TRANSISTOR XN1A312-TX
8-729-020-67 TRANSISTOR XN1A312-TX
< CONNECTOR >
* J10
1-506-984-11 PIN, CONNECTOR (PC BOARD) 2P
– 65 –
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
Q503
Q504
Q505
Q506
Q507
8-729-424-59 TRANSISTOR UN2212
R51
R52
R53
R54
1-216-081-00 METAL CHIP
1-216-045-00 METAL CHIP
1-216-037-00 METAL CHIP
1-216-089-00 RES,CHIP
22K
680
330
47K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
(C8100R)
1/10W
8-729-931-13 TRANSISTOR 2SD1858-P-TV2
8-729-020-67 TRANSISTOR XN1A312-TX
8-729-931-13 TRANSISTOR 2SD1858-P-TV2
8-729-020-67 TRANSISTOR XN1A312-TX
R55
R56
1-216-073-00 METAL CHIP
1-216-057-00 METAL CHIP
10K
5%
Q508
Q509
Q510
Q511
Q512
8-729-216-22 TRANSISTOR 2SA1162-G
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T
8-729-015-74 TRANSISTOR UN5111
8-729-015-74 TRANSISTOR UN5111
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T
(C8100R)
2.2K
5%
5%
1/10W
(C8100R)
1/10W
R57
R58
R60
R61
1-216-001-00 METAL CHIP
1-216-295-00 SHORT
1-216-081-00 METAL CHIP
1-216-089-00 RES,CHIP
10
0 (C8100)
22K
Q550
Q551
Q600
Q601
Q602
8-729-019-03 TRANSISTOR 2SB1202FA-T-TL
8-729-421-22 TRANSISTOR UN2211
8-729-421-22 TRANSISTOR UN2211
8-729-421-22 TRANSISTOR UN2211
8-729-403-35 TRANSISTOR UN5113
5%
5%
1/10W
1/10W
47K
R62
R63
R64
R65
1-216-069-00 METAL CHIP
1-216-069-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-071-00 METAL CHIP
6.8K
6.8K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
(G)
Q603
Q700
Q701
Q702
Q703
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T
8-729-424-56 TRANSISTOR UN211L
8-729-021-94 FET 2SK1657-T1B
8-729-021-94 FET 2SK1657-T1B
8-729-019-03 TRANSISTOR 2SB1202FA-T-TL
8.2K
R65
1-216-077-00 METAL CHIP
15K
5%
1/10W
(EXCEPT G)
R80
R81
R82
R83
R84
1-216-081-00 METAL CHIP
1-216-089-00 RES,CHIP
1-216-069-00 METAL CHIP
1-216-069-00 METAL CHIP
1-216-073-00 METAL CHIP
22K
47K
6.8K
6.8K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q704
Q705
8-729-421-22 TRANSISTOR UN2211
8-729-208-21 TRANSISTOR 2SC2712L-TE85L-T
< RESISTOR >
R9
1-216-049-11 RES,CHIP
1-216-049-11 RES,CHIP
1-216-037-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-097-00 RES,CHIP
1K
1K
330
10K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(C8100R)
R85
1-216-071-00 METAL CHIP
1-216-077-00 METAL CHIP
1-216-097-00 RES,CHIP
1-216-849-11 METAL CHIP
1-216-809-11 METAL CHIP
8.2K
15K
5%
5%
5%
5%
5%
1/10W
(G)
1/10W
(EXCEPT G)
1/10W
(C8100R)
1/16W
(C8100R)
1/16W
(C8100R)
R10
R11
R12
R13
R85
R100
R101
R102
100K
220K
100
R14
1-216-097-00 RES,CHIP
100K
5%
1/10W
(C8100R)
1/10W
R15
R18
1-216-049-11 RES,CHIP
1-216-065-00 RES,CHIP
1K
4.7K
5%
5%
1/10W
(C8100R)
1/10W
1/10W
R103
R104
R105
R106
R107
1-216-825-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-089-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-845-11 METAL CHIP
2.2K
1K
5%
5%
5%
5%
5%
1/16W
(AEP,UK)
1/16W
(C8100R)
1/10W
(C8100R)
1/10W
(C8100R)
1/16W
R19
R20
1-216-049-11 RES,CHIP
1-216-081-00 METAL CHIP
1K
22K
5%
5%
R21
R22
R23
R25
R26
1-216-081-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-089-00 RES,CHIP
1-216-845-11 METAL CHIP
22K
10K
10K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/16W
(C8100)
47K
100K
100K
(C8100R)
R27
1-216-845-11 METAL CHIP
100K
5%
1/16W
(C8100)
1/10W
1/10W
1/10W
(C8100R)
1/10W
(C8100)
R108
R109
R110
R111
R150
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-089-00 RES,CHIP
1-216-845-11 METAL CHIP
1-216-853-11 METAL CHIP
100K
100K
47K
5%
5%
5%
5%
5%
1/16W
(C8100R)
1/16W
(C8100R)
1/10W
(C8100R)
1/16W
(C8100R)
1/16W
(C8100R)
R30
R32
R33
1-216-025-00 RES,CHIP
1-216-073-00 METAL CHIP
1-216-089-00 RES,CHIP
100
10K
47K
5%
5%
5%
R34
R34
1-216-075-00 METAL CHIP
1-216-081-00 METAL CHIP
12K
22K
5%
5%
100K
470K
1/10W
(C8100R)
1/10W
1/10W
1/10W
R35
R36
R50
1-216-057-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-073-00 METAL CHIP
2.2K
1K
10K
5%
5%
5%
R151
1-216-821-11 METAL CHIP
1K
5%
1/16W
(C8100R)
– 66 –
MAIN
Ref. No.
R152
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
1-216-067-00 METAL CHIP
1-216-817-11 METAL CHIP
1-216-814-11 METAL CHIP
1-216-814-11 METAL CHIP
1-216-001-00 METAL CHIP
5.6K
470
270
270
10
5%
5%
5%
5%
5%
1/10W
(C8100R)
1/16W
(C8100R)
1/16W
(C8100R)
1/16W
(C8100R)
1/10W
(C8100R)
R335
R336
R340
R341
R342
1-216-049-11 RES,CHIP
1-216-061-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-082-00 RES,CHIP
1-216-086-00 RES,CHIP
1K
3.3K
1K
24K
36K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R154
R155
R156
R157
R343
R344
R345
R346
R350
1-216-033-00 METAL CHIP
1-216-081-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-061-00 METAL CHIP
1-216-065-00 RES,CHIP
220
22K
1K
3.3K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R158
1-216-001-00 METAL CHIP
10
5%
1/10W
(C8100R)
1/8W
1/8W
1/8W
R351
R352
R353
R355
R356
1-216-065-00 RES,CHIP
1-216-298-00 METAL CHIP
1-216-298-00 METAL CHIP
1-216-001-00 METAL CHIP
1-216-109-00 METAL CHIP
4.7K
2.2
2.2
10
330K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R201
R202
R203
R204
1-216-150-00 RES,CHIP
1-216-150-00 RES,CHIP
1-216-150-00 RES,CHIP
1-216-150-00 RES,CHIP
10
10
10
10
5%
5%
5%
5%
1/8W
R205
R206
R207
R209
R230
1-216-073-00 METAL CHIP
1-216-065-00 RES,CHIP
1-216-049-11 RES,CHIP
1-216-089-00 RES,CHIP
1-216-097-00 RES,CHIP
10K
4.7K
1K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R360
R361
R362
R363
R364
1-216-077-00 METAL CHIP
1-216-085-00 METAL CHIP
1-216-065-00 RES,CHIP
1-216-689-11 METAL CHIP
1-216-033-00 METAL CHIP
15K
33K
4.7K
39K
220
5%
5%
5%
1/10W
1/10W
1/10W
0.5% 1/10W
5%
1/10W
R231
R232
R233
R234
R235
1-216-097-00 RES,CHIP
1-216-027-00 METAL CHIP
1-216-109-00 METAL CHIP
1-216-079-00 METAL CHIP
1-216-075-00 METAL CHIP
100K
120
330K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R365
R366
R367
R368
R369
1-216-081-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
22K
10K
10K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
12K
R240
R241
R242
R243
R244
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-027-00 METAL CHIP
1-216-109-00 METAL CHIP
1-216-079-00 METAL CHIP
100K
100K
120
330K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R401
R402
R403
R404
R405
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-069-00 METAL CHIP
1-216-079-00 METAL CHIP
10K
10K
10K
6.8K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R245
R250
1-216-075-00 METAL CHIP
1-216-681-11 METAL CHIP
12K
18K
5%
1/10W
R406
R407
R420
R421
R422
1-216-077-00 METAL CHIP
1-216-025-00 RES,CHIP
1-216-073-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-073-00 METAL CHIP
15K
100
10K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0.5% 1/10W
(EXCEPT G)
0.50% 1/16W
(G)
R250
1-218-722-11 METAL CHIP
18K
R251
R252
1-216-057-00 METAL CHIP
1-216-065-00 RES,CHIP
2.2K
4.7K
5%
5%
1/10W
1/10W
R423
R430
R431
R432
R433
1-216-073-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-082-00 RES,CHIP
1-216-086-00 RES,CHIP
1-216-033-00 METAL CHIP
10K
1K
24K
36K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R253
R254
R301
R302
R303
1-216-113-00 METAL CHIP
1-216-089-00 RES,CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
470K
47K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R434
R435
R436
R440
R441
1-216-081-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-061-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-082-00 RES,CHIP
22K
1K
3.3K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R304
R305
R306
R307
R320
1-216-069-00 METAL CHIP
1-216-079-00 METAL CHIP
1-216-077-00 METAL CHIP
1-216-809-11 METAL CHIP
1-216-073-00 METAL CHIP
6.8K
18K
15K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/10W
24K
R442
R443
R444
R445
R446
1-216-086-00 RES,CHIP
1-216-033-00 METAL CHIP
1-216-081-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-061-00 METAL CHIP
36K
220
22K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R321
R330
R331
R332
R333
1-216-057-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-082-00 RES,CHIP
1-216-086-00 RES,CHIP
1-216-033-00 METAL CHIP
2.2K
1K
24K
36K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
3.3K
R460
R461
R462
1-216-077-00 METAL CHIP
1-216-085-00 METAL CHIP
1-216-065-00 RES,CHIP
15K
33K
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
R334
1-216-081-00 METAL CHIP
22K
5%
1/10W
– 67 –
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
R463
R464
R465
R466
R467
1-216-689-11 METAL CHIP
1-216-033-00 METAL CHIP
1-216-081-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
39K
220
22K
10K
10K
0.5% 1/10W
R628
R629
R630
R631
R632
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-089-00 RES,CHIP
1-216-049-11 RES,CHIP
1-216-815-11 METAL CHIP
100
100
47K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/16W
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
330
R468
R469
R500
R501
R502
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-053-00 METAL CHIP
1-216-845-11 METAL CHIP
1-216-057-00 METAL CHIP
100K
100K
1.5K
100K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/10W
R633
R634
R635
R636
R637
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-085-00 METAL CHIP
100K
100K
100K
100K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R503
R504
R505
R506
R507
1-216-073-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-057-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-067-00 METAL CHIP
10K
1K
2.2K
10K
5.6K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R638
R639
R640
R641
R651
1-216-073-00 METAL CHIP
1-216-073-00 METAL CHIP
1-216-089-00 RES,CHIP
1-216-295-00 SHORT
10K
10K
47K
0
5%
5%
5%
1/10W
1/10W
1/10W
1-216-097-00 RES,CHIP
100K
5%
1/10W
R508
R509
R510
R511
R512
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-675-11 METAL CHIP
1-216-675-11 METAL CHIP
100K
100K
100K
10K
5%
5%
5%
1/10W
1/10W
1/10W
R652
R655
R656
1-216-845-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-097-00 RES,CHIP
100K
0
100K
5%
5%
5%
1/16W
1/16W
1/10W
(C8100)
1/16W
(C8100R)
1/10W
0.5% 1/10W
0.5% 1/10W
10K
R657
R658
1-216-864-11 METAL CHIP
1-216-097-00 RES,CHIP
0
5%
5%
R514
R515
R516
R517
R518
1-216-089-00 RES,CHIP
1-216-073-00 METAL CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-025-00 RES,CHIP
47K
10K
100K
100K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
100K
R660
R661
R662
R663
R701
1-216-049-11 RES,CHIP
1-216-049-11 RES,CHIP
1-216-049-11 RES,CHIP
1-216-049-11 RES,CHIP
1-216-222-00 RES,CHIP
1K
1K
1K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R519
R520
R530
R531
R532
1-216-025-00 RES,CHIP
1-216-049-11 RES,CHIP
1-216-675-11 METAL CHIP
1-216-675-11 METAL CHIP
1-216-675-11 METAL CHIP
100
1K
10K
10K
10K
5%
5%
1/10W
1/10W
0.5% 1/10W
0.5% 1/10W
0.5% 1/10W
R702
R703
R704
R705
R706
1-216-206-00 RES,CHIP
1-216-049-11 RES,CHIP
1-216-017-00 RES,CHIP
1-216-073-00 METAL CHIP
1-216-089-00 RES,CHIP
2.2K
1K
47
10K
47K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R533
R550
R551
R600
R602
1-216-675-11 METAL CHIP
1-216-089-00 RES,CHIP
1-216-061-00 METAL CHIP
1-216-295-00 SHORT
10K
47K
3.3K
0
0.5% 1/10W
5%
5%
1/10W
1/10W
R707
R708
R709
R710
R711
1-216-073-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-295-00 SHORT
1-216-089-00 RES,CHIP
1-216-206-00 RES,CHIP
10K
2.2K
0
47K
2.2K
5%
5%
1/10W
1/10W
1-216-845-11 METAL CHIP
100K
5%
1/16W
5%
5%
1/10W
1/8W
R603
R607
R608
R609
R613
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-845-11 METAL CHIP
1-216-097-00 RES,CHIP
1-216-049-11 RES,CHIP
100K
100K
100K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
1/10W
R712
R713
R714
R715
R780
1-216-085-00 METAL CHIP
1-216-089-00 RES,CHIP
1-216-089-00 RES,CHIP
1-216-121-00 METAL CHIP
1-216-049-11 RES,CHIP
33K
47K
47K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R614
R615
R616
R617
R618
1-216-057-00 METAL CHIP
1-216-057-00 METAL CHIP
1-216-049-11 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
2.2K
2.2K
1K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1K
R781
1-216-049-11 RES,CHIP
1K
5%
1/10W
< NETWORK RESISTOR >
R619
R620
R621
R622
R623
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-097-00 RES,CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
RB100 1-236-412-11 NETWORK RESISTOR (CHIP) 1.0K (C8100R)
RB601 1-236-412-11 NETWORK RESISTOR (CHIP) 1.0K
RB602 1-236-412-11 NETWORK RESISTOR (CHIP) 1.0K
< VARIABLE RESISTOR >
R624
R625
R626
R627
1-216-097-00 RES,CHIP
1-216-017-00 RES,CHIP
1-216-206-00 RES,CHIP
1-216-073-00 METAL CHIP
100K
47
2.2K
10K
5%
5%
5%
5%
1/10W
1/10W
1/8W
RV10
1-238-095-11 RES, ADJ, CERMET 470K (C8100R)
RV230 1-238-090-11 RES, ADJ, CERMET 10K
RV240 1-238-090-11 RES, ADJ, CERMET 10K
1/10W
– 68 –
MAIN SUB
Ref. No.
Part No.
Description
< SWITCH >
Remark
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
***************
S600
S601
1-571-478-11 SWITCH, SLIDE (POWER SELECT)
1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT) (C8100)
17
18
23
23
1-783-495-11 CORD (WITH CONNECTOR) (INVERTER)
1-777-246-11 CORD (WITH CONNECTOR) (ANTENNA)
1-776-207-71 CORD (WITH CONNECTOR) (POWER) (C8100)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(C8100R)
SW500 1-762-108-31 SWITCH, PUSH (1 KEY) (NOSE DET)
< THERMISTOR (POSITIVE) >
TH600 1-801-792-21 THERMISTOR, POSITIVE 2.2
TH700 1-801-792-21 THERMISTOR, POSITIVE 2.2
F701
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
HP901 1-500-157-21 HEAD, MAGNETIC (PLAYBACK)
M901 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL)
*************************************************************
< TUNER >
TUX10 A-3282-045-A TUNER UNIT (TUX-012(E))
< VIBRATOR >
ACCESSORIES & PACKING MATERIALS
********************************
X10
1-577-126-51 VIBRATOR, CRYSTAL (7.2MHz)
1-467-559-91 REMOTE COMMANDER (RM-X47) (C8100)
9-939-081-01 LID, BATTERY (for RM-X47) (C8100)
1-473-067-71 REMOTE COMMANDER (RM-X4S)
3-012-070-01 LABEL (SOUND) (2) (FOR RM-X4S)
3-862-253-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
CHINESE) (C8100)
X100
X150
X600
X601
1-577-101-11 VIBRATOR, CERAMIC (4.19MHz) (C8100R)
1-760-556-31 VIBRATOR, CRYSTAL (4.332MHz) (C8100R)
1-767-833-21 VIBRATOR, CERAMIC (3.68MHz)
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X650
1-577-101-11 VIBRATOR, CERAMIC (4.19MHz)
*************************************************************
3-862-253-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
SWEDISH,PORTUGUESE) (AEP,UK)
*
1-669-656-11 SUB BOARD
3-862-253-31 MANUAL, INSTRUCTION (FRENCH,GERMAN,
DUTCH,ITALIAN) (AEP)
**********
3-862-253-41 MANUAL, INSTRUCTION (GERMAN) (G)
3-862-255-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH,CHINESE) (C8100)
< CONNECTOR >
CN800 1-779-170-11 SOCKET, CONNECTOR 20P
CN801 1-779-169-11 SOCKET, CONNECTOR 18P
CN802 1-778-330-21 PIN, CONNECTOR (PC BOARD) 2P
3-862-255-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH,SWEDISH,PORTUGUESE) (AEP,UK)
3-862-255-31 MANUAL, INSTRUCTION, INSTALL (FRENCH,
GERMAN,DUTCH,ITALIAN) (AEP,G)
< DIODE >
3-862-619-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH,GERMAN,SPANISH,DUTCH,SWEDISH,
ITALIAN,PORTUGUESE,CHINESE) (RM-X4S)
X-3373-926-1 CASE ASSY (XR)
LED800 8-719-058-14 LED CL-220PG-C-TS (TAPE WINDOW)
LED801 8-719-051-01 LED CL-170HR-CD-T (TIR) (C8100R)
LED802 8-719-038-07 LED CL-190PG-CD-T (6)
*************************************************************
< RESISTOR >
**************
HARDWARE LIST
**************
R800
R801
R802
R803
R804
1-216-049-11 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
100
100
100
100
#1
#2
#3
#4
#5
7-621-772-30 SCREW +B 2X6
7-685-792-09 SCREW +PTT 2.6X6 (S)
7-685-794-09 SCREW +PTT 2.6X10 (S)
7-621-255-15 SCREW +P 2X3
R806
R807
R808
R809
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
100
100
100
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
7-685-105-19 SCREW +P 2X8 TYPE2 NON-SLIT
#6
#7
7-624-104-04 STOP RING 2.0, TYPE -E
7-627-553-17 SCREW, PRECISION +P 2X2 TYPE 3
< SWITCH >
*************************************************************
SW800 1-572-921-11 SWITCH, KEY BOARD (RESET)
SW801 1-771-027-11 SWITCH, KEY BOARD (WITH LED) (6)
*************************************************************
– 69 –
XR-C8100/C8100R
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
151
152
153
154
155
3-009-613-21 FRAME
3-386-828-01 SCREW, FITTING
3-349-410-01 BUSHING
X-3366-405-1 SCREW ASSY (EXP), FITTING
3-934-325-01 SCREW, +K (5X8) TAPPING
156
157
158
159
160
3-022-310-01 COLLAR
7-682-560-04 SCREW +P 4X6
3-934-787-01 SPRING, FITTING
X-3373-432-1 BRACKET ASSY (RM-X4S)
1-776-207-71 CORD (WITH CONNECTOR) (POWER) (C8100)
161
162
163
1-775-543-11 CORD, GROUND
1-465-459-21 ADAPTOR, ANTENNA (C8100R)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(C8100R)
Sony Corporation
Personal & Mobile Communication Company
– 70 –
98B0469-1
Printed in Japan C1998. 2
Published by Quality Assurance Dept.
9-925-904-11
|