PLCD46
INSTRUCTION MANUAL
EJECT
OPEN
Detachable Front Panel CAR Radio & CD Player
CDP
POP
TRACK
LOC
LOUD MUTE DISC
FLAT CLASS ROCK
RPT
RDM INT
+
+
CH
BND
SEL
DSP
COMPACT
-
-
DIGITAL AUDIO
POWER
LUD
LOC
M5
M2/RPT
M6
M1/TOP
APS
M3/INT
M4/RDM
CLK
160WATTS
ANTI-THEFT DETACHABLE SYSTEM
AUTO-LOADING COMPACT DISC PLAYER
AM/FM STEREO WITH DIGITAL TUNING RADIO
DISC PLAY:
INSTALLATION
Cleaning discs
Before playing, clean the disc with a clean, lint-free.
Flip the disc in the direction of the arrow.
DASH BOARD
METAL MOUNTING STRAP
HEX NUT
SPRING WASHER
CONSOLE
PLAIN WASHER
PLAIN WASHER
NOTE:
. Do not use so solvents such as benzine, thinners. Commercially available
cleaners or anti static spray damage the unit.
SLIDE BRACKET HOUSING
TAPPING SCREW
HEX BOLT
Insert a disc with the label surface down. Doing so may damage the unit.
Label
surface up
NOTE:
. Do not try to insert another disc when one has been already inserted.
Doing so may damage the unit.
.Handle the disc by its edge. And to keep the disc clean, do not touch
the surface.
KEY PLATE
PLASTIC TRIM OUT
KEY PLATE
.Do not stick paper or tape on the disc.
.Do not expose the disc to direct sunlight or heat sources such as hot air
ducts. Or leave it in a car parked in direct sunlight where there can be a
considerable rise in temperature.
9
2
LOCATION AND FUNCTION OF CONTROLS
SPECIFICATION
GENERAL
1
2
3
4
5
6
7
Power requirement..............................................................................................DC 13.8V.
Current consumption..............................................................................................7A MAX.
Power output.........................................................................................................40W X 4
EJECT
OPEN
Detachable Front Panel CAR Radio & CD Player
CDP
POP
TRACK
LOC
LOUD MUTE DISC
FLAT CLASS ROCK
RPT
RDM INT
+
+
FM SECTION
CH
BND
SEL
Frequency range.....................................................................87.5MHz -108.0MHz(EUROPE).
Frequency range...........................................................................87.5MHz -107.9MHz(USA).
DSP
COMPACT
-
-
DIGITAL AUDIO
POWER
LUD
LOC
Usable sensitivity.........................................................................................................3uV.
I.F Frequency........................................................................................................10.7MHz.
M5
M2/RPT
M6
M1/TOP
APS
M3/INT
M4/RDM
CLK
AM(MW) SECTION
Frequency range........................................................................522KHz - 1620KHz(EUROPE).
Frequency range............................................................................. 530KHz - 1710KHz(USA).
8
9
10 11 12 13
14
15
16 17 18 19
20
LINE - OUT [OPTION]
Output...............................................................................1000mV @ FM 10% THD POWER.
Impedance............................................................................................................600 ohm.
CD PLAYER
1. SEL( AUDIO MODE SELECT)/VOLUME +/- BUTTON
Press SEL button to change the mode in the sequence of
BAS
TRE
BAL
FAD
VOL
System........................................................................................compact disc audio system.
Usable disc......................................................................................................compact disc.
Signal format.............................................................................sampling frequency 44.1KHz.
No of quantization bits 1bit.
1). The volume level can be adjusted at any time by pressing the audio level+ or
- button as select mode has been initially defaulted at volume mode.
2). The volume level is also obtained by stepping through the SEL button until
the function VOL is displayed and then press + or - button to adjust the
sound level.
Frequency characteristics...............................................................................5-40Hz < 5dB
10K-20KHz < 5dB.
3). Press and hold the + or - button to adjust the sound level.
Signal to noise radio................................................................70dB [1KHz] [IEC - A net work].
Number of channels..............................................................................................2 STEREO.
Chassis dimensions.......................................................................183[W] X 53[H] X 165[D].
BASS CONTROL
1). Press the SEL button to select the bass mode until BAS appears on the display.
2). Press + or - to adjust the bass effect.
TREBLE CONTROL
1). Press the SEL button to select the treble mode until TRE appears on the display.
2). Press + or - to adjust the treble effect.
3
8
BALANCE CONTROL
TROUBLE SHOOTING
1). Press the SEL button to select the balance mode until BAL appears on the display.
2). Press the + button or - button to increase or decrease the sound level of
left or right speaker.
Before going through the check list, wiring connection, should any of the
problem persist after check list has been made, consult your nearest service
dealer.
FADER CONTROL
1). Press the SEL button to select the fader mode until FAD appears on the display.
2). Press the + button or - button to increase or decrease the sound level of
front or rear speaker.
Symptom
No power
Cause
Solution
The car ignition is not on.
If the power supply is properly
connected to the car accessory
switch the ignition key to " ACC "
2. OPEN BUTTON
Press it to eject the front panel when you want to take away.
The fuse is blown
Replace the fuse
Presence of CD disc inside
the player
Remove the disc in the player
then put a new upward
Disc cannot
be loaded or
ejected
3. BAND BUTTON
Press it to select your desired radio band and word which band is selected
will be displayed on LCD.
Inserting the disc in upside
down
Insert the compact disc with
the label facing upward
Compact disc is extremely
dirty or defective
Clean the disc or try to play a
new one
4. LCD ( LIQUID CRYSTAL DISPLAY)
Temperature inside the
car is too high
Cool off until the ambient
temperature returns to normal
5. CD
( CD PLAY, PAUSE) BUTTON
button to switch to CD mode. At CD mode,
Condensation
Leave the player off for an
hour or so, then try again
At tuner mode, press
press it to pause the CD program and press it again to resume CD
playback.
Volume is in minimum
Adjust volume to a desired level
No sound
Wiring is not properly
connected
Check wiring connection
The operation
keys do not
work
The built-in microcomputer
is not operating properly
due to noise
Press the RESET button
front panel is not properly
fix into its place
6. EJECT BUTTON
Press it to eject the disc from the slot.
The installation angle
is more than 30 degrees
Adjust the installation angle
to less than 30 degrees
Sound skips
7. DSP( DISPLAY) BUTTON
Press it to apply those functions, press it continually to switch between 4
preset equalizer curves: FLAT, POP, CLAS, ROCK. The sound quality will
be changed. Press it again to resume initial default mode.
The disc is extremely
dirty or defective
Clean the compact disc/try to
play a new one
The radio does
not work
the radio
8. MUTE BUTTON
Press this button to eliminate the sound temporarily, press it again to
resume normal play state.
Insert the antenna cable firmly
select a station manually
The antenna cable is not
connected
the signals are too weak
station
automatic
selection does
not work
7
4
19. LOCAL/DISTANCE BUTTON
9. CLOCK ADJUSTMENT BUTTON
Press it for distance reception when you are located at weak signal location,
depress it for stronger signal.
During TUNING or CD state, press the button to change to clock function.
To adjust hour:
with time on display, push the tune
completed, release the button.
To adjust minute:
with time on display, push the tune
completed, release the button.
button adjust hour, when adjustment is
button adjust minute. When adjustment is
20. [TUNE/SEEK UP] BUTTON and TRACK UP BUTTON
1). The frequency scans up by one step when pressing
button once(50k for Europe,200k for USA).
Hold it for more than 2 seconds to seek for a station of higher frequency.
2). During CD mode, press
button allow you to track forwards.
Hold the button allow you to skip forwards.
10.11.12.15.16.17,PRESET STATION [ 1-6 ] / TOP, RPT, INT,RDM.
A]. To memorize the current frequency, press and any one of the six preset
buttons for more than 2 seconds.
[TUNE/SEEK DOWN] BUTTON and TRACK DOWN BUTTON
1). The frequency scans down by one step when pressing
button once(50k for Europe,200k for USA).
Hold it for more than 2 seconds to seek for a station of lower frequency.
B]. To recall the preset memory, press one of the preset button [1-6].
C]. TOP BUTTON
Press the button during playback to return to the first track of CD.
D]. INT: Preview all tracks
2). During CD mode, press
Hold the
button allow you to track backwards.
button allow you to skip backwards.
Press INT to play first ten seconds of each track on current CD. Press again
to stop scan and listen to track.
E]. REPEAT BUTTON
Press the button to continuously repeat same track. Press again to
stop repeating.
F]. Random button: play all tracks
Press it to play all tracks on CD in random order. Press again to stop
random play
13. POWER BUTTON
Press the button to turn on or off the unit.
14. LOUD( LOUDNESS) BUTTON
Press this button to enhance the bass sound while reduce half volume
level.
18. AS/PS BUTTON
Select 6 strong stations and store them in current band.
Select a band( if needed)
Hold AS/PS button for more than 3 seconds. The news stations replace
the stations already stored in that band.
Scan stations in current band
Select a band( if needed).
Press AS/PS button for less than 3 seconds. Radio pauses for 5 seconds
at each station. Press AS/PS again to stop scanning when desired
stations is reached.
5
6
|