INSTRUCTION BOOKLET
TUMBLE DRYER
TC470
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNINGS
It is most important that this instruction book
should be retained with the appliance for future
reference. Should the appliance be sold or trans-
ferred to another owner, or should you move
house and leave the appliance, always ensure
that the book is supplied with the appliance in
order that the new owner can get to know the
functioning of the appliance and the relevant
warnings.
SERVICE/REPAIR
■
Under no circumstances should you attempt to
repair the machine yourself. Repairs carried out by
inexperienced persons may cause injury or seri-
ous malfunctioning. Refer to your local Zanussi
Service Centre. Always insist on genuine Zanussi
spare parts.
GENERAL SAFETY
These warnings have been provided in the inter-
est of safety. You MUST read them carefully
before installing or using the appliance.
■
It is dangerous to modify or try to modify the speci-
fications of this appliance in any way.
■
This appliance is designed to be used by adults.
Children should not be allowed to touch the con-
trols or play with the product.
INSTALLATION
■
Any electrical work required to install this appli-
ance should be carried out by a qualified electri-
cian or competent person.
■
Pets and small children may climb into tumble dry-
ers. Check your appliance each time before use.
■
■
Make sure that the appliance does not stand on its
electrical supply cable.
ENVIRONMENT PROTECTION
The materials used on this appliance marked with
■
If the machine is situated on a carpeted floor,
please adjust the feet in order to allow air to
circulate freely.
the symbol are recyclable.
This means that they can be recycled by disposing
of them properly in appropriate collection contain-
ers.
USE
■
If you take your appliance to a refuse disposal
site, cut off the power cable flush with the appli-
ance to avoid the danger of the appliance being
re-used, and disable the door catch to prevent
children becoming trapped inside.
■
Always unplug the appliance after use.
■
Clothes which are dripping wet should not be
placed in the dryer.
Always load well spun laundry. The higher the
spin speed, the lower the electricity consumption
and the shorter the drying times.
■
■
Never tumble dry items that have been in contact
with chemicals such as dry cleaning fluid. These
are of a volatile nature and could cause an explo-
sion.
As some bulky items such as duvets and eider-
downs should be dried in large commercial
machines because of their bulk, check with the
manufacturer of the item if it is suitable for drying
in a domestic machine, even if the dry weight of
the item is within the limit advised.
■
■
Always check that no cigarette lighters have been
left in pockets.
Leave the door slightly ajar when not in use to pre-
serve the door seal.
■
■
The fluff filter must be cleaned after every use.
Do not operate the appliance with a damaged filter
or with no filter at all, as this may cause a fire.
■
■
Do not overload the appliance.
Do not allow fluff to accumulate around the dryer.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
YOUR APPLIANCE
4 5
1
2 3
6
7
8
13
10 11
9
12
1 Worktop
2 Reservoir Full Indicator Light
3 Door Open Button
4 Mains On Light
5 On/Off Dial - Time Selector Dial
6 Programme Chart
7 Fluff Filter
8 Door Catch
9 Rating Plate
10 Ventilation Grille
11 Condenser Unit
12 Water Reservoir
13 Height - Adjustable Feet
4
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION
Positioning
Door Reversal Instructions
The appliance may be placed on any type of flat floor.
It must be perfectly level (use a spirit level if neces-
sary). Adjust the feet to compensate for any uneven-
ness in the floor.
To ensure correct operation, the surrounding area
must be kept clean, free of dust and fluff.
The appliance is supplied with the door opening from
right to left. If you wish to change the opening direc-
tion, proceed as follows (see picture A):
1. Unhook door stopper «A» from its seat «a» and
loosen from hole «b» by a 90° rotation.
2. Remove the plastic plug from hole «c» by a 90°
rotation and re-fix in hole «b».
Air must be able to circulate freely all round the appli-
ance. Do not obstruct the front ventilation grille or the
air intake grilles in the back of the machine.
3. Unscrew hinge «B» (loosen the 2 screws, holding
the door securely) and lower the door from the top
pivot.
Do not remove the feet.
Do not reduce the clearance between the appliance
and the floor by placing it on deep pile carpet or rugs,
as this could lead to a build-up of heat which would
adversely affect operation of the machine.
4. Re-insert pin «F» from the door above and below
on opposite sides respectively.
5. Loosen door catch «C» by pressing both lugs
together (see small illustration).
6. Loosen opposite plastic part «D» as in step 5 (you
may need to use a screwdriver to assist in both steps
5 and 6 ).
Important:
The hot air emitted by the tumble dryer can reach
temperatures of up to 60°C. The appliance must
therefore not be installed on floors which are not resis-
tant to high temperatures.
The ambient temperature must not exceed 35°C, even
when the appliance is working. If it does, open the
door or window.
7. Interchange and insert parts «C» and «D».
8. Remove screws «E» and refit on the opposite side.
Fix hinge «B» on the right handside.
Do not fully tighten the screws.
F
c
d
D
A
B
C
b
a
E
C
1
2
1
A
P0866
5
Download from Www.Somanuals.com. All Manuals Search And Download.
9. To mount door, see picture B:
Levelling
Level the tumble dryer
into place by screwing or
unscrewing the feet as
required.
■
First locate into upper right hand hole with upper
pin «F».
■
Then place lower pin into the hinge «B» at the bot-
tom of the door.
■
■
Align door before tightening hinge.
Tighten hinge.
Accurate levelling will
keep vibration and
noise to a minimum
when the dryer is in
use.
10. Remove the plug from hole «d» and refix in
hole«a» (Fig. A).
P0046
11. Fix door stopper «A» in hole «c» by 90° rotation.
12. Hook door stopper «A» into hole «d».
c
F
d
A
B
C
B
P0865
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Avoid connecting the tumble dryer to the same socket
as your washing machine (or any other appliance) by
means of an adapter. Have an extra socket installed if
necessary, by a qualified electrician.
Electrical Connections
WARNING: THIS APPLIANCE MUST BE EARTHED.
The manufacturer declines any liability should this
safety measure not be observed.
This appliance complies with the following E.E.C.
Directives:
- 73/23 EEC of 19.2.73 (Low Voltage Directive) and
subsequent modifications;
- 89/336 EEC of 3.5.89 (Electromagnetic Compatibility
Directive) and subsequent modifications.
If the plug that is fitted to your appliance is not suitable
for your socket outlet, it must be cut off, and the
appropriate plug fitted.
Remove the fuse from the cut off plug. The cut off plug
should then be disposed of to prevent the hazard of
electric shocks, in case it should be plugged into a 13
Amp socket in another part of your home.
Please ensure that when the appliance is installed
it is easily accessible for the engineer in the event
of a breakdown.
IMPORTANT
The wires in the mains lead are coloured in accor-
dance with the following code:
Green and Yellow - Earth
Blue - Neutral
Brown - Live
If you fit your own plug, the colours of the wires in the
mains lead of your appliance may not correspond with
the markings identifying the terminals in your plug.
To fit the plug, proceed as follows:
GREEN & YELLOW
13 AMP FUSE
BROWN
BLUE
CORD CLAMP
P0329
Connect the green and yellow (earth) wire to the termi-
nal in the plug which is marked with the letter «E» or
the earth symbol
, or coloured green and yellow.
Connect the blue (neutral) wire to the terminal in the
plug which is marked with the letter «N» or coloured
black.
Connect the brown (live) wire to the terminal in the
plug which is marked with the letter «L» or coloured
red.
The plug moulded on to the lead incorporates a fuse.
For replacement, use a 13 Amp BS1362 fuse. Only
ASTA or BSI approved fuses should be used.
The plug must not be used if the fuse cover/carrier is
lost. The cover/carrier is indicated by the coloured
insert at the base of the plug.
A replacement cover/carrier must be obtained from
your local ZANUSSI Service Centre whose address is
listed in the Customer Care Booklet which accompa-
nies your instruction manual.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
GETTING TO KNOW YOUR MACHINE
Control panel
ZANUSSI
DRYING TIME
DOOR
OPEN
1
2
3
4
5
1 Programme chart
4 Mains On Light (green)
The pilot light indicates operating status.
2 Water Full Indicator Light (red)
This light illuminates when the reservoir is full or
improperly fitted.
The programme will be interrupted.
5 On/OffDial - Time Selector Dial
Turn the dial clockwise (to the right) to select the time
for drying (see Chart page 9). At the same time the
machine is switched on and the programme starts.
3 Door Open Button
This dryer has two drying cycles of up to 120 and 80
minutes, giving a high or low heat temperature accord-
ing to the fabric type.
Depress this button to open the door.
The door of the machine can be opened at any time
during the programme if you want to feel the dryness
of the fabrics.
When selecting the drying time you should remember
that it includes a 12 minute cooling phase (position
on the dial).
This phase should not be shortened, stopped or avoid-
ed, as this could cause skin burns or damages to the
laundry.
Additional drying
If, at the end of the programme, the laundry is still too
damp, set the dial for a further period of drying
(remembering to take into account the cooling period).
8
Download from Www.Somanuals.com. All Manuals Search And Download.
DRYING TIMES
Cotton and Linen (blue section)
Selector dial: up to 120 minutes (high temperature section)
Degree of drying required
and labels on articles
Degree of spin given
rpm
Quantity
kg (1)
Drying times
mins
5
90-100
55-65
75-90
45-55
65-80
45-55
60-75
35-45
800
2.5
5
Store dry
1000-1200
800
2.5
5
2.5
5
Iron dry
1000-1200
2.5
high temperature
Synthetics (green section)
Selector dial: up to 80 minutes (low temperature section)
Degree of drying required
and labels on articles
Degree of spin given
Quantity
kg
Drying times
mins
2
40-50
30-40
20-25
Store dry
Short spin
1
0.5
reduced temperature
(1) Never overfill the drum (do not load large quilts, for example).
The laundry must be suitably spin dried in your washing machine before being placed in the tumble dryer (500rpm
minimum).
Drying times vary according to:
- The type of laundry
- The size of the load
- The degree of spinning prior to drying
Drying times are given as a guide only. Experience will soon enable you to estimate the drying time needed for your
usual laundry loads.
Do not start by selecting a long drying time. It is better to determine the required degree of dryness by gradually
increasing the drying time.
For a mixed load (cotton and resistant synthetics, for example) select the time for the most delicate fibres and
increase it by 10 mins.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Drying
Useful hints
■
Try to load to the maximum capacity of the
machine as small loads are uneconomical.
For information, here is a list of the average
weights of some common laundry items.
1. Load the laundry
Open the door by press-
ing button
.
Load the items one at a
time, shaking them out
loosely and close the
door.
Check the laundry does
not get caught between
the door and filter.
Sheet
Tablecloth
700 - 1000 g
400 - 500 g
70 - 120 g
Kitchen towel
Table napkin
Hand towel
Bathrobe
Man’s shirt
Pillowcase
50 - 100 g
150 - 250 g
1000 - 1500 g
200 - 300 g
100 - 200 g
400 - 500 g
200 - 250 g
P0871
Man’s pyjamas
Ladies’ nightdress
2. Select the drying time
■
Never tumble dry the following:
Particularly delicate items such as net curtains,
woollen, silk, fabrics with metal trim, nylon tights,
bulky materials such as anoraks, blankets, eider-
downs, sleeping bags, feather quilts and any items
containing rubber foam or materials similar to rub-
ber foam.
Turn the selector dial
clockwise to the required
minute setting (in the
high or low temperature
range, according to the
fabric).
40
The mains-on light will il-
luminate and the dryer
will start to work.
■
Always follow the instructions on garment labels.
Tumble dry normal (high temperature)
Tumble dry delicate (low temperature)
Do not tumble dry
P0627
■
Close pillowcases and covers with fasteners to
prevent small laundry items getting tangled inside
them. Close press studs, zips and hooks and tie
belts and apron strings.
3. When drying is completed
The machine stops automatically and the mains-on
light goes out.
If the laundry is still too damp, select a further brief
drying time, bearing in mind that during the last 12 mi-
nutes the dryer carries out the cooling and anticrease
treatment phase.
■
■
Sort laundry according to type and degree of dry-
ing required.
Do not over-dry laundry, this avoids creasing and
saves energy.
Remove the clothes from the machine.
■
■
■
Avoid drying dark clothes with light coloured fluffy
items such as towels as they could attract the fluff.
Clean the filter after every drying programme. A
clean filter ensures correct functioning of the
appliance.
Remove the laundry when the dryer has finished
drying.
To avoid a static charge when drying is completed,
use either a fabric softener when you are washing
the laundry or a fabric conditioner specifically for
tumble dryers.
Laundry Shrinkage
Certain fabrics such as woollens and silks are gener-
ally not suitable for tumble drying. Due to the struc-
ture of some woollen garments which are recom-
mended for tumble drying, shrinking could still occur,
but once the garment is worn again, it should regain
its shape.
Starched Laundry
Starched laundry can also be dried in the tumble
dryer. Make sure that the time selected is for iron dry.
After completion of the programme wipe out the drum
with a damp cloth and dry to remove any traces of
starch.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
MAINTENANCE AND CLEANING
Important:
Emptying the water reservoir
You must disconnect the appliance from the elec-
tricity supply, before carrying out any cleaning or
maintenance work.
Water extracted from the laundry condenses inside
the machine and is collected in a reservoir.
The reservoir must be emptied after each drying cycle
to ensure efficient operation when the machine is
next used.
If this is not done a safety device trips: pilot light
on the control panel comes on and the programme
stops, leaving the laundry damp.
External cleaning
Use only soap and water. Rinse and dry thoroughly.
Important:
The reservoir can be emptied even in the middle of a
programme.
Never use abrasive or caustic products.
Cleaning the filter
The tumble dryer cannot
operate efficiently with a
clogged filter. The filter
collects all the fluff which
forms during drying and it
is therefore essential to
remove and clean this fil-
ter after each drying pro-
P0637
gramme.
P0638
The reservoir must be re-inserted correctly.
You should not be alarmed by the amount of fluff
which collects on the filter; this is due to normal wear-
ing of the fabrics dried and not to incorrect operation
of your machine. Rubbing of the fibres during normal
wear and washing forms fluff. If laundry is dried on a
line, this fluff simply flies away, whereas inside the
tumble dryer it collects together and swells consider-
ably as a result of the drying action.
Handy tip: The condensed water may be used in a
steam iron or to top up a battery, etc. In this case it
must be filtered (e.g. through a coffee filter).
Cleaning the condenser unit
Clean the air condenser periodically, 3 or 4 times a
year depending on how frequently the dryer is used.
Pull out the condenser, holding it at the top, and
remove all fluff. Clean it with a brush and rinse it
under the shower if necessary.
P0639
P0636
Also clean the outside, removing all fluff.
Clean the rubber seal round the porthole door and the
seal of the condenser in the inner door with a damp
cloth.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
SERVICING
Before contacting your local Zanussi Service
Centre, please make the following checks:
If, after the above checks, there is still a fault, call
your local Zanussi Service Centre, whose address
can be found in the accompanying Customer Care
Booklet, and can also be found in your local tele-
phone directory under «Z». Please make sure you
give the model and serial number of the appliance.
The tumble dryer will not start
■
■
■
■
■
■
door not closed properly
appliance not plugged in
blown fuse
This information can be found on the rating plate or
on the guarantee certificate.
power cut
selector dial incorrectly positioned
water reservoir full or not properly inserted. In this
Original spare parts can be purchased from Zanussi
Service Centres.
case, pilot light
comes on.
In-guarantee customers should ensure that the
above checks have been made as the engineer
will make a charge if the fault is not a mechanical
or electrical breakdown.
Poor drying results
■
■
■
■
has the correct time been selected?
do the filter and air condenser need cleaning?
is the drum over-loaded?
Please note that proof of purchase is required for
any in-guarantee service calls.
is the water reservoir empty and properly insert-
ed?
Service details - adhesive label
When you return your guarantee card to Zanussi Ltd.,
you will receive a «Appliance Guarantee And
Maintenance Record» together with an adhesive label
containing the telephone number of your local
Zanussi Service Centre. The label can be adhered to
the machine or adjacent furniture.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
PEACE OF MIND FOR TWELVE MONTHS
Zanussi standard guarantee conditions
Exclusions
This guarantee is in addition to your statutory and
other legal rights which will not be excluded or in any
way diminished by the return of this guarantee card.
We, Zanussi Ltd., undertake that if, within twelve
months of the date of the purchase, this ZANUSSI
appliance or any part thereof is proved to be defective
by reason only of faulty workmanship or materials, we
will, at our option, repair or replace the same FREE
OF ANY CHARGE for labour, materials or carriage on
condition that:
This guarantee does not cover:
■
■
■
Damage or calls resulting from transportation,
improper use or neglect, the replacement of any
light bulbs or removable parts of glass or plastic.
Costs incurred for calls to put right machines
improperly installed or calls to machines outside the
United Kingdom.
Appliances found to be in use within a commercial
or similar environment, plus those which are subject
to rental agreements.
■
■
■
The appliance has been correctly installed and used
only on the electricity supply stated on the rating
plate.
■
■
Products of Zanussi manufacture which are NOT
marketed by Zanussi Ltd.
EEC Countries - The standard guarantee is applica-
ble but subject to the owner’s responsibility and cost
to ensure the appliance meets the standards set by
the country to which the product is taken. The
Zanussi company in the country concerned will be
pleased to advise further. Sight of your purchase
receipt will be required by them.
The appliance has been used for normal domestic
purposes only, and in accordance with the manufac-
turer’s operating and maintenance instructions.
The appliance has not been serviced, maintained,
repaired, taken apart or tampered with by any per-
son not authorised by us.
All service work under this guarantee must be under-
taken by a Zanussi Service Force Centre.
Home visits are made between 8.30am and 5.30pm
Monday to Friday. Visits may be available outside
these hours in which case a premium will be charged.
Any appliance or defective part replaced shall become
our property.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
125997261
Z
Download from Www.Somanuals.com. All Manuals Search And Download.
|