FREEZER
ZF 67
INSTRUCTION BOOKLET
2222 090-48
Download from Www.Somanuals.com. All Manuals Search And Download.
CONTENTS
Instructions for the user
Instructions for the
installer
2
4
5
Important Safety Information
Description of the appliance
12
13
Technical specification
Installation
Positioning
Operation
13
13
Before use
5
5
5
5
5
6
6
6
6
Rear Spacers
Control panel
Start your appliance
Temperature control
Freezing fresh food
Frozen food storage
Thawing
14
15
Electrical Connection
Door Reversal
Making ice cubes
Normal operating sounds
7
8
Hints and tips
Maintenance and Cleaning
Internal cleaning
8
8
8
8
External cleaning
When the appliance is not in use
Defrosting
9
Something not working
Service and Spare Parts
Customer Care Department
Guarantee Conditions
10
10
11
2222 090-48
3
Download from Www.Somanuals.com. All Manuals Search And Download.
DESCRIPTION OF THE APPLIANCE
A
B
N
S
6
5
4
S
1
2
3
3
6
9
12
D
C
A - Freezer controls
B - Freezer calender (recommended storage times for frozen foods)
C - Frozen food storage
D - Freezing fresh foods
4
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION
Control Panel
N
S
6
5
4
S
1
2
3
A
B C D E
Pilot light
A -
B -
Thermostat control
Fast freeze knob
C -
D -
E -
Fast freeze light
Alarm light
Before using
Temperature control
Remove all securing tapes. Wash inside the
appliance with lukewarm water and bicarbonate of
soda (5 ml to 0.5 litre of water).
The temperature within the freezer is controlled by
the thermostat situated at the top of the cabinet.
To operate the freezer proceed as follows:
Do not use soap or detergent as the smell may
linger. Dry thoroughly.
Turn the thermostat control beyond the ÇOÈ position.
When you first start the freezer, we suggest that you
turn the thermostat control to a medium setting,
between 3 and 4. For easier turning of this control,
use a small coin.The internal temperature of the
freezer is automatically adjusted by the thermostat to
ensure safe food storage.
Control Panel
A. Thermostat control
Turn the thermostat control clockwise to required
setting, which is normally between 3-4.
However, if the appliance is working in unfavourable
room conditions such as
B. Fast freeze knob
-
-
-
poor ventilation,
When you place fresh food in the appliance, turn the
fast freeze knob to ÒSÓ.
high temperature,
frequent door openings,
C. Pilot light
it may be necessary to select a more suitable
setting.
The operation light is illuminated continuously, to
show that the appliance is on.
To obtain a colder temperature, turn the thermostat
control to the higher number; to obtain a warmer
temperature turn the control to the lower number.
D. Fast freeze light
The fast freeze light is illuminated, to show that the
fast freeze function is working.
Freezing fresh food
E. Alarm light
In any 24 hour period you can freeze up to 20 kg of
fresh food.
If the alarm light (E) lights up, it indicates that the
temperature within the freezer has reached a level
where the safe food storage is no longer ensured.
When you first start the freezer or after a period of
non-use, turn the fast freeze knob to ÇSÈ 24 hours
before you want to freeze your food (the yellow light
(D) lights up).
When the freezer is first switched on, the alarm light
will stay on until the temperature has dropped to a
safe level for the storage of frozen food.
If the freezer is already in operation, the fast-freeze
knob should be activated about 2-3 hours before
freezing fresh food.
Start your appliance
This time can be shortened, depending on the
quantity of food to be frozen. After the time has
elapsed place the food to be frozen in the two top
compartments of the freezer as these are the coldest
parts.
Insert the plug into the wall socket. The pilot light (C)
will light up to show that the appliance is on.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Once the food is completely frozen (which could take
up to 24 hours) return the fast freeze switch to the
ÇNÈ position; the yellow light (D) goes off.
Thawing
Deep frozen or frozen food, prior to being used, can
be thawed in the fridge or at room temperature
depending on the time available. Small food items
may even be cooked from frozen; in this case
cooking will take longer.
Distribute the frozen food packages in the other
compartments, so that the top compartments can be
used for a further freezing operation.
-
-
-
The food to be frozen must be fresh and of the
best quality.
Any frozen food which is allowed to thaw
accidentally should either be eaten as soon as
possible or thrown away. Alternatively, if the food is
uncooked and has not been completely defrosted it
can be cooked and then refrozen.
Do not allow fresh food to touch food which is
already frozen.
During the freezing process, ensure that the
freezer door remains closed.
Meat, fish and fruit should be thawed in the
refrigerator compartment and small pieces of meat
can even be cooked while still frozen, but you must
ensure that it is thoroughly cooked through.
Frozen food storage
When you first start the freezer or if the freezer has
been out of use for some time, we advise you to run
your appliance for at least two hours in the Çfast
freezeÈ mode before storing frozen food.
Vegetables should be directly immersed in boiling
water; ready-cooked dishes can be placed directly in
the oven in their aluminium wrapping.
A microwave oven is particularly suitable for thawing
any type of frozen or deep-frozen food: follow the
oven instructions, particularly regarding the
placement of aluminium wrapping or containers in
the oven.
Do not exceed the storage period indicated by the
manufacturer.
Finally, do not open the door frequently or leave it
open longer than is absolutely necessary.
Defrosted cooked food must never be refrozen.
Important
Do not put carbonated liquids, (fizzy drinks etc.), in
the freezer compartment.
Making ice cubes
The appliance is provided with one or more trays for
the production of ice-cubes.
Ice Iollies, if consumed immediately after removal
from the freezer, can possibly result in a low
temperature skin burn.
Fill the trays 3/4 full to allow the ice to expand and
place them in one of the freezer compartment.
Do not remove items from the freezer if your hands
are damp/wet, as this could cause skin abrasions or
Òfrost/freezer burnsÓ.
Do not use sharp instruments to remove the trays
from the freezer.
To remove the cubes twist the tray slightly or hold it
under running water for a few seconds.
Important
In the event of a power cut do not open the door.
The food in the freezer will not be affected if the
power cut is short and if the freezer is full. Should
the food begin to thaw, it must be consumed quickly
and must not be re-frozen.
Normal Operating Sounds
¥
You may hear faint gurgling or bubbling sounds
when the refrigerant is pumped through the coils
or tubing at the rear, to the cooling
plate/evaporator or to the fixed freezer shelves.
¥
¥
When the compressor is on, the refrigerant is
being pumped round, and you will hear a whirring
sound or pulsating noise from the compressor.
A thermostat controls the compressor, and you
will hear a faint ÕclickÕ when the thermostat cuts in
and out.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
HINTS AND TIPS
¥
¥
¥
Avoid unnecessary frosting in the cabinet by
packing all foodstuffs into airtight pakages before
placing them in the freezer.
Food Storage
To obtain the best performance from your freezer
Food which is to be frozen (when cool) should be
placed in the fridge before being transferred to
the freezer.
¥
¥
Do not store warm food or evaporating liquids.
Avoid buying frozen food if you cannot store it
straight away. The use of an insulated container
is advisable. When you arrive home place the
frozen food in the frezeer immediately.
Try to avoid keeping the door open for long
periods or opening the door too frequently as
warm air will enter the cabinet and cause the
compressor to switch on unnecessarily often.
¥
Do not push food together too much, try to allow
air to circulate around each item.
¥
Ensure there are no obstructions preventing the
door from closing properly.
¥
¥
Do not store food uncovered.
Ensure that food placed in the freezer is dated
and labelled and used in date order to ensure
that food is consumed at its best.
In the Event of a Power Failure
If there is a power failure during the storage of frozen
foods, keep the door closed. If the temperature
within your freezer should rise, do not refreeze the
food without checking its condition. The following
guidelines should assist you:
¥
¥
Lean food keeps better and longer than fatty
food, salt reduces the storage time.
Wrap the food in polythene or aluminium freezing
bags or foil so that they adhere to the food and
provide an airlight seal .
Ice-cream: Once thawed should be discarded.
Fruits & Vegetables: If soft should be cooked and
used up.
¥
Packaging which is swollen or has traces of
refrozen water droplets on the pack could
indicate that the product has not been kept at a
suitable temperature and that it may have lost its
original quality. Partially thawed food must not be
refrozen, it must be consumed within 24 hours.
Never exceed the storage times indicated by the
manufacturer.
Breads & Cakes: Can be refrozen without danger.
Shellfish: Should be refrigerated and used up
quickly.
Cooked Dishes: i. e. casseroles should be
refrigerated and used up.
Large Pieces of Meat: Can be refrozen providing
there are still ice crystals remaining within them.
Energy Saving Advice
Small Joints: Should be cooked and can then be
refrozen as cooked dishes.
¥
Do not install the appliance close to sources of
heat, such as a boiler or radiator.
Chicken: Should also be cooked and refrozen as a
fresh dish.
¥
Locate the appliance in a cool well ventilated
room and make sure that the air openings of the
appliance are not obstructed.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
MAINTENANCE AND CLEANING
Defrosting
Before any maintenance or cleaning work is
carried out, DISCONNECT the appliance from the
ELECTRICITY supply.
When the frost has reached a thickness of up to
4mm it can be removed using the ice scraper
provided with the appliance. During this operation it
is not necessary to disconnect the appliance from
the mains and remove the food. Never use metal
tools for this operation.
Internal cleaning
Clean the inside and accessories with warm water
and bicarbonate of soda (5ml to 0.5 litre of water).
Rinse and dry thoroughly.
For complete defrosting (once or twice a year)
proceed as follows:
-
turn the thermostat dial to the ÇOFFÈ position
(O) or disconnect the appliance from the mains.
NEVER USE DETERGENTS, ABRASIVE
POWDERS, HIGHLY PERFUMED CLEANING
PRODUCTS OR WAX POLISHES, TO CLEAN THE
INTERIOR AS THESE WILL DAMAGE THE
SURFACE AND LEAVE A STRONG ODOUR.
-
Remove any food from inside the freezer , wrap it
in several sheets of newspaper and store in a
cool,dry place.
-
Leave the door open and insert the ice scraper
under the channel in the centre of the lower part
of the appliance; place a low-sided container
beneath the scraper to collect the water (see fig.).
External cleaning
Wash the outer cabinet with warm soapy water. Do
NOT use abrasive products.
Once or twice a year dust the condenser (black grill)
and the compressor at the back of the appliance,
with a brush or vacuum cleaner, see figure, as an
accumulation of dust will affect the performance of
the appliance and cause excessive electricity
consumption.
D068
-
-
-
Clean and dry thoroughly.
Replace the scraper in one of the drawers .
CONDENSER
Reconnect the appliance to the mains or reset
the thermostat to the normal operating position.
-
After letting the appliance run for at least two
hours in fast freeze mode, replace the previously
removed food into the compartment.
COMPRESSOR
D273/1
Important
A temperature rise of the frozen food packs, during
defrosting, may shorten their safe storage life.
When the appliance is not in use
When the appliance is not in use for long periods,
disconnect from the electricity supply, empty all
foods and clean the appliance, leaving the doors ajar
to prevent unpleasant smells.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
SOMETHING NOT WORKING
If the appliance is not working correctly, please carry out the following checks before contacting your local
Zanussi Service Force Centre
Symptom
Solution
No power to the appliance
Check there is power at the socket.
Check there is not a power cut by checking the
household lights.
Check the fuse has not blown.
The temperature in the freezer is too high
Check the temperature in the freezer is turned to the
correct setting relative to ambient conditions.
Check the ambient temperature is within the
applianceÕs operating limits of 10¡C to 32¡C.
Relocate the appliance if necessary.
The freezer door will not open
Has door just been opened? If so leave for a few
minutes to allow the air pressure to equalise.
The compressor runs continously
Adjust the thermostat to give correct temperature
control. See ÒSetting the temperatureÓ.
Check that the door is closed.
Large quantities of food have recently been placed in
the cabinet/and or door is frequently opened.
Check that air ventilation is not obstructed.
Ensure the door is not left open.
Excessive frost and ice has built up
Check that nothing is preventing the door from
closing.
Is the door gasket intact and clean.
Has advised periodic defrosting been carried out.
Noise
Refer to normal operating sounds.
In-guarantee customers should ensure that the
above checks have been made, as the engineer
will make a charge if the fault is not a mechanical
or electrical breakdown.
If after the above checks your appliance still does
not operate correctly, contact your local Zanussi
Service Force Centre.
Please note that it will be necessary to provide proof
of purchase for any in-guarantee service calls.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
SERVICE AND SPARE PARTS
In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your
local Zanussi Service Force Centre by telephoning:-
0870 5 929929
Your telephone call will be automatically routed to the Service Force Centre covering your post code area. The
addresses are listed on the following pages.
Before calling out an engineer, please ensure you have read the details under the heading ÔSomething Not
Working.Õ
When you contact the Service Force Centre you will need to give the following details:
1.
2.
3.
4.
5.
Your name, address and post code
Your telephone number
Clear and concise details of the fault
The model and serial number of the appliance (found on the rating plate)
The purchase date
CUSTOMER CARE DEPARTMENT
For general enquiries concerning your Zanussi appliance or for further information on Zanussi products, please
contact our Customer Care Department by letter or telephone as follows:-
Customer Care Department
Zanussi
55-77 High Street
Slough
Berkshire
SL1 1DZ
Tel: 08705 727 727
10
Download from Www.Somanuals.com. All Manuals Search And Download.
GUARANTEE CONDITIONS
Standard guarantee conditions
We, Zanussi, undertake that if within 12 months of the date of the purchase this Zanussi appliance or any part
thereof is proved to be defective by reason only of faulty workmanship or materials, we will, at our option repair
or replace the same FREE OF CHARGE for labour, materials or carriage on condition that:
The appliance has been correctly installed and used only on the electricity supply stated on the rating plate.
The appliance has been used for normal domestic purposes only, and in accordance with the manufacturerÕs
instructions.
The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any person not
authorised by us.
All service work under this guarantee must be undertaken by a Zanussi Service Force Centre. Any appliance or
defective part replaced shall become the CompanyÕs property.
This guarantee is in addition to your statutory and other legal rights.
Home visits are made between 8.30am and 5.30pm Monday to Friday. Visits may be available outside these
hours in which case a premium will be charged.
Exclusions
This guarantee does not cover:
Damage or calls resulting from transportation, improper use or neglect, the replacement of any light bulbs or
removable parts of glass or plastic.
Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside the
European Community (EC) or European Free Trade Area.
Appliances found to be in use within a commercial environment, plus those which are subject to rental
agreements.
Products of Zanussi manufacture which are not marketed by Zanussi.
European Guarantee
If you should move to another country within Europe then your guarantee moves with you to your new home
subject to the following qualifications:
The guarantee starts from the date you first purchased your product.
The guarantee is for the same period and to the same extent for labour and parts as exists in the new country
of use for this brand or range of products.
This guarantee relates to you and cannot be transferred to another user.
Your new home is within the European Community (EC) or European Free Trade Area.
The product is installed and used in accordance with our instructions and is only used domestically, i.e. a
normal household.
The product is installed taking into account regulations in your new country.
Before you move please contact your nearest Customer Care centre, listed below, to give them details of your
new home. They will then ensure that the local Service Organisation is aware of your move and able to look
after you and your appliances.
France
Germany
Italy
Senlis
+33 (0)3 44 62 29 99
+49 (0)911 323 2600
+39 (0)1678 47053
+46 (0)8 738 79 50
+44 (0)1753 219 897
NŸrnberg
Pordenone
Stockholm
Slough
Sweden
UK
11
Download from Www.Somanuals.com. All Manuals Search And Download.
TECHNICAL SPECIFICATIONS
DIMENSIONS
Height
124
cm
Width
Depth
54
57
cm
cm
POWER SUPPLY VOLTAGE AND FREQUENCY
TOTAL POWER ABSORBED
220-240 V / 50 Hz
150 W
AVERAGE DAILY UNITS ELECTRICITY *
1.05 kWh
GROSS CAPACITY
Freezer
186 l
150 l
NET CAPACITY
Freezer
STAR RATING
* This figure is based on standard test results in accordance with European Standard EN 153.
Actual consumption will depend on how the appliance is used and where it is located.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION
Important
IF YOU ARE DISCARDING AN OLD APPLIANCE
THAT HAS A LOCK OR CATCH ON THE DOOR,
YOU MUST ENSURE THAT IT IS MADE
UNUSABLE TO PREVENT YOUNG CHILDREN
BEING TRAPPED INSIDE.
Depending upon the position which you choose for
your appliance, you may wish to reverse the way in
which the door opens. To do this, refer to instructions
on ÒDoor reversal directionsÓ paragraph.
Positioning
This appliance is designed to operate in ambient
temperatures between 10¡C (50¡F) and 32¡C (90¡F).
It should be located in a dry atmosphere, out of
direct sunlight and away from extreme temperature
e.g. not next to a boiler or radiator, or in a very cold
room e.g. an outhouse, where the temperatures may
fall below 10¡C (50¡F). If these temperatures are
exceeded i.e. colder or warmer, then the appliance
may not operate correctly.
A
B
You should also ensure that air can circulate freely
around the back and the top of the cabinet. There
must also be at least 100 mm (4Ó) distance between
the top of the cabinet and any overhanging kitchen
furniture (A). Ideally, the appliance should not be
positioned beneath overhanging furniture (B).
NP006
There should also be a gap of 25 mm either side of
the appliance. Do not obstruct the space
underneath. The back of the cabinet may be placed
close to the wall but must not touch it. DO NOT
install in places with restricted ventilation.
Adjust the level of the appliance by screwing out the
adjustable foot, or feet, at the bottom of the cabinet
using your fingers (see figure).
D200
Rear spacers
The plastic bag containing all relevant
documentation also contains two spacers to be fitted
into special holes in the back of the appliance. Fit the
spacers into the holes, taking care to ensure that the
arrow (A) is positioned as shown in Fig. Then turn
them through 45¡ (arrow (A) vertical) until they lock
into place.
A
45°
PR60
13
Download from Www.Somanuals.com. All Manuals Search And Download.
For replacement, use a 13amp BSI362 fuse. Only
ASTA or BSI approved fuses should be used.
Electrical connections
The plug must not be used if the fuse cover/carrier is
lost. The cover/carrier is indicated by the coloured
insert at the base of the plug.
Any electrical work required to install this appliance
should be carried out by a qualified electrician or
competent person.
A replacement cover/carrier must be obtained from
your local Zanussi Service Force Centre whose
address is listed in the Customer Care Booklet which
accompanies your instruction manual.
WARNING: THIS APPLIANCE MUST BE
EARTHED.
The manufacturer declines any liability should
this safety measure not be observed.
This appliance complies with the E.E.C. Directive
No. 87/308 of 2.6.87 relative to radio interference
suppression.
If the plug that is fitted to your appliance is not
suitable for your socket outlet, it must be cut off and
the appropriate plug fitted.
This appliance complies with the following
E.E.C. Directives:
Remove the fuse from the cut off plug.
The cut off plug should then be disposed of to
prevent the hazard of shocks in case it should be
plugged into a 13amp socket in another part of your
home.
-
-
73/23 EEC of 19.2.73 (Low Voltage Directive)
and subsequent modifications;
89/336 EEC of 3.5.89 (Electromagnetic
Compatibility Directive) and subsequent
modifications.
Important
Please ensure that when the appliance is
installed it is easily accessible for the engineer in
the event of a breakdown.
The wires in the mains lead are coloured in
accordance with the following code:
Green and Yellow
Blue
- Earth
- Neutral
- Live
Brown
If you fit your own plug, the colours of the wires in
the mains lead of your appliance may not
correspond with the markings identifying the
terminals in your plug, proceed as follows:
GREEN & YELLOW
13 AMP. FUSE
BROWN
BLUE
CORD CLAMP
D207
Connect the Green and Yellow (earth) wire to the
terminal in the plug which is marked with the letter
ÇEÈ or the earth symbol
yellow.
or coloured green and
Connect the blue (neutral) wire to the terminal in the
plug which is marked with the letter ÇNÈ or coloured
black.
Connect the brown (live) wire to the terminal in the
plug which is marked with the letter ÇLÈ or coloured
red.
The plug moulded onto the lead incorporates a fuse.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Door reversal directions
1. Disconnect from the electricity supply.
1
3
2. Remove all loose items, including food, store food
in a cool place.
2
3. dismantle the lower hinge (3), pin (1) and the
screw (2);
2
4. Slide out the door from pin (D), unscrew the pin
and reposition on the opposite side.
5. unscrew the left front foot and reposition on the
opposite side;
D299
D590
D336
6. unscrew the two screws which mask the holes for
fixing the hinge from the left front side;
7. reassemble the door;
8. reassemble the lower hinge (turning it 180¡), the
pin and the screw on the opposite side, as shown
in the figure;
D
9. dismantle the handle (6) and reassemble it on the
opposite side.
Important
After completion of the door reversiing operation,
check that the door gasket adheres to the cabinet. If
the ambient temperature is cold (i.e. in Winter), the
gasket may not fit perfectly to the cabinet. In that
case, wait for the natural fitting of the gasket or
accelerate this process by heating up the part
involved with a normal hairdrier on a low setting.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
|