Whirlpool Europe
Custom er Services
S E R V I C E
ADP 5966 WHM
Service Manual
Dishwasher
ADP 5966 WHM
Model
Version
ADP 5966 WHM
8542 966 10791
Technical data
Spare part list
Exploded view
Circuit diagram
Program diagram
Text/Legend
Page
2 - 4
5 - 6
7 - 8
9
10
11 - 17
Family
VBL - HIGH 6
Sensor 2
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 02.10.2003
Subject to modification
Document-No.: 4812 718 19321
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 3
Doc. No: 4812 718 19321
S E R V I C E
Technical data
Water pressure
Electrical base data
Voltage
230-240
V
Inlet pressure
0.3 - 10 bar
Frequency
Total power
Fuse
50
2.4
13
Hz
kW
A
Spray pump pressure
0.3
bar
Rotations
Spray pum p m otor alternating spray system
Spray pump motor
Drain pump motor
Spray arm lower
Spray arm upper
Fan for drying
2800
3000
30 - 40
30 - 40
2500
RPM
RPM
RPM
RPM
RPM
Voltage
220/ 240 V
Power consumption
HI
HA
Capacitor
125
79
60
4
W
Ω
Ω
µ F
Spray arm s, turning rhythm at alternating spray
system
Drain pum p m otor
Turning starts every time with the upper spray arm
Voltage
220/ 240 V
Power consumption
Resistance
30
146
W
Ω
Pre wash Lower arm ~3min, Upper arm ~1min
Main wash Lower arm ~3min, Upper arm ~5min
Intermediate rinse
Lower arm ~2min, Upper arm ~2min
Final rinse Lower arm ~2min, Upper arm ~2min
Service Test program
Fan for drying
Voltage
Resistance
220 - 240 V
141
Ω
Lower arm ~30sec, Upper arm ~30sec
Heating - 1 Elem ent system
Remark: When switching of the main switch or
interrupt the mains during the Test Program runs,
then the alternating of the spray arms change in
the test program to the rhythm of main wash 5/3
min.
Voltage
Power consumption
Resistance
230-240
V
2.04-2.22 kW
24.5
~ 2.0
~ 115
Ω
˚C/min
˚C
Heating speed
Temperature on surface
Safety thermostat self reset
(Temperature of water)
Fuse
Important: To leaf the Test program is possible by
made a break by customer (pushing the start
button for 1.5 sec.)
After finishing the test program (End LED shines
and/or Start LED goes of) must the appliance be
switched off.
If this will not be done, then the next normal wash
will be made with the frequency of the Service
Test Program ~30/30sec.
~ 85
206
˚C
˚C
Potentiom eter
Points of meassurement: 1(black) to 2 (middle)
Position 0
Position 1
Position 2
Position 3
Position 4
Position 5
Position 6
0.0
0.5
1.0
1.4
1.8
2.3
2.6
kΩ
kΩ
kΩ
kΩ
kΩ
kΩ
kΩ
Flow rates/ Inlet volum e
Flow meter (at 0.3 bar
= quantity 1.1 l/min)
Spray pump
Drain pump
Pump height max.
Inlet valve
Spray arm lower
Sprayarm upper
Ceiling rotor
208
45 - 65
16
1.1
4
~ 33
~ 27
~ 8
lmp/l
l/min
l/min
m
l/min
l/min
l/min
l/min
Fan for drying:
Total
Primary air flow
Secondary air flow
900
210
780
l/min
l/min
l/min
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 4
Doc. No: 4812 718 19321
ADP 5966 WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Technical data
Single electric inlet valve
Regeneration
3
Voltage
220/ 240 V
Volume
300
cm
Frequency
Resistance
50/ 60
3.76
Hz
kΩ
Position 0
after wash cycles
water hardness
12
0 - 5
0 - 0.9
0 - 9
˚dh
mmol/l
˚Fh
Regenerating valve
Voltage
Frequency
Resistance
220/ 240 V
Position 1
after wash cycles
water hardness
50/ 60
3.13
Hz
kΩ
10
6 - 10
1 - 1.8
10 - 18
˚dh
mmol/l
˚Fh
Motor Diverter Valve
Position 2
after wash cycles
water hardness
7
Voltage
Frequency
Resistance
220 - 240 V
11 - 15
1.9 - 2.7 mmol/l
19 - 27
˚dh
50/ 60
6.5
Hz
kΩ
˚Fh
Signal (2x within ~13 sec.) 5.0
V
Position 3
after wash cycles
water hardness
5
Coil of dispenser
16 - 21
˚dh
2.8 - 3.7 mmol/l
Voltage
Frequency
Resistance
220/ 240 V
28.37
˚Fh
50/ 60
1.3
Hz
kΩ
Position 4
after wash cycles
water hardness
3
22 - 28
˚dh
3.8 - 5.0 mmol/l
Reed contacts
38 - 50
˚Fh
Position 5
after wash cycles
water hardness
flow meter
salt control
rinse aid control
2
29 - 35
˚dh
5.1 - 6.3 mmol/l
51 - 63
˚Fh
Optical water indicator (OWI)
Position 6
after wash cycles
water hardness
1
Optical measurement of the water in sump
Combination part of:
36 - 60
6.4 - 10.7 mmol/l
64 - 107 ˚Fh
˚dh
Turbidity sensor
(DON)
Thermostat temp. sensor (notice NTC)
Salt consumption
for regeneration
77
26
g
NTC
20 ˚C
Number of cycles
with 2 kg salt
58.1
47.1
38.2
25.4
17.2
11.8
8.3
6
kΩ
kΩ
kΩ
kΩ
kΩ
kΩ
kΩ
kΩ
kΩ
25 ˚C
30 ˚C
40 ˚C
50 ˚C
60 ˚C
70 ˚C
80 ˚C
85 ˚C
Accesory
If you need spare parts apart from
the spare part list have a look
in the Service Bulletin 4812 718 40084.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP5966WHM
8542 966 10791
02.10.2003 / Page 5
Doc. No: 4812 718 19321
S E R V I C E
Spare part list
Model
Service No.
Version
ADP 5966 WHM
854296610791
854296610791
Pos. No. 12NC Code
Description
Pos. No. 12NC Code
Description
003 0
004 0
004 1
011 0
022 0
4812 440 19594 Traverse
4812 440 18952 Drip tray assy
4812 401 18402 Holder
4812 505 18357 Foot short
4812 440 10755 Side panel left
332 0
332 1
400 0
405 0
405 1
4812 410 29032 Button WH
4812 410 29053 Button WH
4812 361 58336 Motor +SP,50Hz,alt.LP-PNT1
4812 360 18509 Spray pump wo.Mot.alt.LP-50Hz
4819 515 28158 Gasket
022 1
024 0
030 0
034 0
034 1
4812 440 10754 Side panel right
4812 440 10417 Panel, rear
4812 440 10763 Table top WH
4812 404 78237 Spacer
420 0
421 0
430 0
430 1
442 0
4812 121 18132 Capacitor
4812 121 18158 Interf.filter
4812 360 18508 Pump,draining cpl.
4812 466 68689 Gasket
4812 404 78242 Fastener table top
4812 361 18196 Blower cpl.
040 1
040 2
040 3
044 0
047 0
4812 417 18774 Hinge left
450 0
480 0
480 3
490 0
490 1
4812 259 28684 Heating element
4812 321 28405 Cable harness set
4812 401 18418 Protector f.wiring
4819 321 18136 Cable,mains 2m SA
4812 321 28367 Strain relief
4812 417 18773 Hinge right
4812 417 19174 Protector f.door (set)
4812 492 38358 Spring f.door
4812 404 48746 Brake f.door
047 1
047 2
053 0
053 4
065 0
4812 401 18397 Band,brake
4812 404 68023 Hook
4812 440 89032 Plinth WH
4812 440 89034 Plinth rounded WH
4812 466 48051 Insulation
521 0
531 0
531 1
575 0
583 0
4812 214 78704 Control board (CB)
4812 273 18055 Switch waterhardness
4812 273 18056 Wheel,fingertip
4812 281 28361 Regen.valve
4812 271 28459 Switch diaphragm (OWI)
103 0
103 2
120 0
120 1
130 0
4812 440 10762 Door outer WH
4812 440 10766 Corner piece set
4812 440 19456 Door,inner
4812 440 18969 Batten
616 0
616 1
620 0
623 0
633 0
4812 281 18047 Contact,reed salt
4812 271 58161 Contact,reed rinsing agent
4812 310 28066 User board KIT (DUB)
4812 271 38356 Microswitch
4812 417 58361 Tilt lock cpl. wh
4812 271 38355 Microswitch door
131 0
191 0
191 3
192 0
241 0
4812 401 18416 Hook lock
4812 466 68564 Gasket door
4812 466 68533 Gasket
4812 466 68467 Gasket, door lower
4812 458 19026 Basket upper straight
680 0
680 1
681 1
681 2
682 0
4812 418 68155 Combidosage
4812 466 68495 Gasket
4812 466 68497 Gasket
4812 440 18975 Flap
4812 466 68496 Gasket
241 1
241 3
241 4
241 5
241 6
4812 458 18324 Holder cups right wh
4812 528 88068 Wheel,basket upper (set)
4812 458 18984 Holder dishes wh
4812 535 78043 Bearing
691 1
700 0
700 0
700 1
700 2
4812 462 79769 Stopper NTC
4812 530 28804 Hose, inlet aqua stop 4,2m
4812 530 28848 Hose, inlet aqua stop 2m
4812 480 48095 Sieve
4812 310 18757 Holder glasses KIT wh
4812 466 68628 Gasket
241 7
241 8
242 0
242 1
242 4
4812 404 48683 Hoop
701 1
710 0
710 2
710 3
714 0
4812 310 18153 Yoke clamp set
4812 418 68151 Monoblock
4819 310 38536 Threaded ring
4819 466 69562 Gasket set
4812 462 78993 Threaded cap
4812 466 68553 Spacer cap set
4812 458 18974 Basket lower cpl.
4812 528 88069 Wheel,basket lower wh
4812 466 48059 Fixation wh
242 6
242 7
243 0
243 5
243 6
4812 458 18977 Support plate left
4812 458 18978 Support plate right
4812 458 18272 Basket cutlery
4819 310 39859 Cutlery basket KIT
4812 458 18996 Grille wh
716 0
716 1
716 2
717 0
717 2
4812 418 68147 Reg.dosage
4812 466 68475 Gasket
4812 462 78994 Cover
4812 281 28418 Valve motordiverter
4812 528 98011 Valve disk diverter
261 0
261 1
261 2
263 0
263 1
4819 462 38271 Rail telescope, inner
4812 462 79768 Cap rail
4812 462 78995 Cap rail ahead
4819 520 18013 Ball cage cpl.
4812 520 48001 Ball Niro 8 D
717 3
721 1
722 0
722 2
723 0
4812 530 29121 Gasket diverter valve
4812 360 68347 Spray arm lower. cpl.
4812 360 68348 Spray arm upper wh
4812 360 68349 Spray arm 2nd level cpl. wh
4812 360 68351 Douche ceiling
265 0
265 2
303 1
322 0
331 0
4812 404 48637 Basket adjustm. cpl.
4812 404 48638 Grip basket adjustment
4812 460 38134 Plate,handle WH
4812 453 71956 Insert panel
726 1
726 2
743 0
743 1
743 2
4812 530 29118 Tube assembly cpl.
4812 505 18208 Nut
4812 530 48134 Air guide
4812 530 28102 Hose, inlet
4812 440 19526 Air guide lower
4812 413 59143 Knob program cpl. WH
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 6
Doc. No: 4812 718 19321
ADP5966WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Spare part list
Model
ADP 5966 WHM
Service No.
Version
854296610791
854296610791
Pos. No. 12NC Code
Description
743 3
743 4
743 5
743 7
751 0
4812 505 18364 Nut
4812 281 38001 Valve disk
4812 466 98934 Disc
4812 466 68514 Gasket
4812 418 18338 Water collector
755 0
755 2
756 0
761 0
761 2
4812 530 29119 Bend
4812 530 48148 Tray,leak
4812 360 58099 Floater
4812 480 58122 Sieve fine
4812 418 18337 Cover sieve
761 3
761 4
763 0
781 0
781 3
4812 418 18341 Cover
4812 530 58141 O-Ring
4812 480 58123 Sieve coarse
4812 530 29113 Hose,draining
4812 281 28417 Flap non-return
783 6
791 0
791 2
901 0
901 1
4812 530 28796 Hose 10x3x180+10
4812 532 68099 Gasket
4812 530 58093 Gasket
4822 401 10258 Clamp,hose 10-18 mm
4812 401 18424 Strap 050,0
901 2
901 5
904 2
910 1
910 2
4812 401 18157 Strap 32-50/9 C61
4812 401 48573 Strap 028,6
4812 462 79635 Cover WH 3,5x5
4812 502 38152 Screw 4.8x19
4812 502 18363 Screw 4,0x12-H
910 3
910 4
910 5
910 7
910 8
4812 502 18389 Screw 5x20 T20
4812 502 18385 Screw M3,5x8-T15M
4812 502 18393 Screw 3,5x9-1 Tx15
4812 502 18397 Screw INOX A2 M 5X12
4812 502 18527 Screw 4x15 T20
910 9
964 0
964 1
993 0
993 5
4812 502 18446 Screw 3,5x16
4812 466 68536 Gasket housing ri/le
4812 466 68469 Gasket housing upper
4819 530 29028 Bow
4822 532 80216 Funnel salt
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 7
Doc. No: 4812 718 19321
S E R V I C E
Exploded view
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 8
Doc. No: 4812 718 19321
ADP 5966 WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Exploded view
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 9
Doc. No: 4812 718 19321
S E R V I C E
Circuit diagram
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 10
Doc. No: 4812 718 19321
ADP 5966 WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Program diagram
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 11
Doc. No: 4812 718 19321
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 12
Doc. No: 4812 718 19321
ADP 5966 WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 13
Doc. No: 4812 718 19321
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 14
Doc. No: 4812 718 19321
ADP 5966 WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 15
Doc. No: 4812 718 19321
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
02.10.2003 / Page 16
Doc. No: 4812 718 19321
ADP 5966 WHM
8542 966 10791
Whirlpool Europe
Custom er Service
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
Whirlpool Europe
Custom er Service
ADP 5966 WHM
8542 966 10791
02.10.2003 / Page 17
Doc. No: 4812 718 19321
S E R V I C E
Text/ Legend
Download from Www.Somanuals.com. All Manuals Search And Download.
|